SAFETY PRECAUTIONS

SERVICE WARNING
Only qualified service technicians who are familiar with safety checks and guidelines should perform service work. Before replacing parts, disconnect power source to protect electrostatically sensitive parts. Do not attempt to modify any circuit unless so recommended by the manufacturer. When servicing the receiver, use an isolation transformer between the line cord and power receptacle.

SAFETY CHECKS - FIRE AND SHOCK HAZARD

Cold Leakage Checks for Receivers with Isolated Ground
Unplug the AC cord, connect a jumper across the plug prongs, and turn the power switch on (if applicable). Use an ohmmeter to measure the resistance between the jumped AC plug and any exposed metal cabinet parts such as antenna screw heads, control shafts, or handle brackets. Exposed metal parts with a return path should measure between 1M ohms and 5.2M ohms. Parts without a return path must measure infinity.

H ··TOFACr Technical Service Da~!74

INDEX Error Codes Chart High Voltage Shutdown Test IC Functions Important Parts Information Miscellaneous Adjustments Parts List Placement Chart Safety Precautions Schematic Component Location Schematic Notes Schematics Audio Audio Output Main Tuner PIP/IF Power Supply System Control Television Video Switching / PIP Test Equipment Tuner Voltage Chart Main PIP 1 1 6 7 1 7, 8 3 1 7 4 6 6 4 5 3 4 2 5 2 4 4

RCA
Model F32730SBFM1 (Chassis CTC179CM)

SERVICING THE HIGH VOLTAGE AND CRT

Use EXTREME CAUTION when servicing the high voltage circuits. To discharge static high voltage, connect a 10K ohms resistor in series with a test lead between the receiver ground and CRT anode lead. DO NOT lift the CRT by the neck. Always wear shatterproof goggles when handling the CRT to protect eyes in case of implosion.

Hot Leakage Current Check

Plug the AC cord directly into an AC outlet. DO NOT use an isolation transformer. Use a 1500 ohms, lOW resistor in parallel with a .l5J!F capacitor to connect between any exposed metal parts on the receiver and a good earth ground. (See figure below.) Use an AC voltmeter with at least 5000 ohms per volt sensitivity to measure the voltage across the resistor. Check all exposed metal parts and measure voltage at each point. Voltage measurements should not exceed .75VAC, 500J!A. Any value exceeding this limit constitutes a potential shock hazard and must be corrected. If the AC plug is not polarized, reverse the AC plug and repeat exposed metal part voltage measurement at each point.

X·RAY RADIATION AND HIGH VOLTAGE LIMITS

Be aware of the instructions and procedures covering X-ray radiation. In solid-state receivers and monitors, the CRT is the only potential source of X-rays. Keep an accurate high voltage meter available at all times. Check meter calibration periodically. Whenever servicing a receiver, check the high voltage at various brightness levels to be sure it is regulating properly. Keep high voltage at rated value, NO HIGHER. Excessive high voltage may cause X-ray radiation or failure of associated components. DO NOT depend on protection circuits to keep voltage at rated value. When troubleshooting a receiver with excessive high voltage, avoid close contact with the CRT. DO NOT operate the receiver longer than necessary. To locate the cause of excessive high voltage, use a variable AC transformer to regulate voltage. In present receivers, many electrical and mechanical components have safety related characteristics which are not detectable by visual inspection. Such components are identified by a # on both the schematic and the parts list. For SAFETY, use only equivalent replacement parts when replacing these components.

~AC WSCALE

GENERAL GUIDELINES
Perform a final SAFETY CHECK before returning receiver to customer. Check repaired area for poorly soldered connections, and check entire circuit board for solder splashes. Check board wiring for pinched wires or wires contacting any high wattage resistors. Check that all control knobs, shields, covers, grounds, and mounting hardware have been replaced. Be sure to replace all insulators and restore proper lead dress. CONNECT TO EARTH GROUND

EXPOSED METAL PARTS

::E
u,

Essential coverage for servicing a television receiver ... • Schematics • Component locations • Parts list
Coverage includes these additional models and chassis:

en Q

M l"N M LI-

HIGH VOLTAGE SHUTDOWN TEST

Momentarily short a 1000 ohms resistor across the base of Q4902 and ground. The receiver should lose raster and sound. If the receiver does not lose raster and sound, the shutdown circuit should be repaired. To resume normal operation, remove AC power for approximately 30 seconds and then turn the receiver on. Enter the Service Mode and reset the error code parameters for X-Ray Shutdown to 00.

W C

..J

o
::E

Models
F32730SBJX1 F35755MBFM2 F35755MBJX2 G35831ATLM1

Chassis
CTC179CM CTC179CK CTC179CK CTC179CK

The listing of any available replacement part herein in no case constitutes a recommendation, warranty, or guarantee by SAMS Technical Publishing as to the quality and suitability of such replacement part. The numbers of the listed parts have been compiled from information furnished to SAMS Technical Publishing by the manufacturers of the specific type of replacement part listed. Reproduction or use, without express permission, of editorial or pictorial content, in any manner, is prohibited. No patent liability is assumed with respect to the use of the information contained herein.

© 2001 ~AH5,]Technical
5436 West 78th Street Indianapolis, IN 46268-4149

Publishing

For Supplier Address, See PHOTOFACT Annual Index

54321

Technical Publishing
AUGUST 2001 SET 4474

Printed in the United States of America

OlPFOl825

Page 1

SET 4474

Page 1

SET 4474

ERROR CODES CHART

Error Code Error
No error code Bus Fault Detected by U3102 DC Detect Run Supply Momentary Dropout Run Supply Shutdown System Stack Overflow PIP Module Error User Stack Overflow Watchdog Timeout XRP Shutdown Bus Expander Fault U2502 Bus Expander Fault U2502 Stereo decoder U1600 TVB Fault Ul503 TVB Fault Ul504 Video matrix switch U6501 Audio matrix switch U1402 T2 Chip U2001 Tuner PLL U501

MISCELLANEOUS ADJUSTMENTS
B+CHECK
NOTE: R4113 is factory sealed. DO NOT ADJUST. Refer to replacement for kit information. parts

Condition Indicated
U3102 standby IIC clock or data held low. Power supply shutdown. Run supply momentary dropped and recovered. Run supply shutdown. Software error. PIP fails to acknowledge. Software error. Software error. X - ray overvoltage detected by U2001. U2502 fails to acknowledge. U2502 fails to acknowledge. Stereo decoder U1600 fails to acknowledge. Tone/ Volume/ Balance U1503 fails to acknowledge. Tone/ Volume/ Balance U1504 fails to acknowledge. Video matrix switch U6501 fails to acknowledge. Audio matrix switch U1402 fails to acknowledge. U2001 fails to acknowledge. Tuner U501 PLL IC fails to acknowledge.

o
17

STEREO ADJUSTMENTS
All adjustments were made using a MTS TV I stereo generator. controls to normal listening levels and select stereo mode. Set the customer

18
22 23 24 25 26

Connect a digital DC voltmeter to pin 8 ofT4401 and use pin 3 as ground point. Set brightness and picture to minimum. With AC line voltage set to l20V AC, the B+ should read 135V ±.l V.

STEREOVCO
Unsolder the end of R1609 connected to JW244, disconnect the RF source from the antenna terminal. Enter service mode, and select parameter (1 19). Connect a frequency counter to pin 28 of U1600. Adjust the value to obtain a reading of 62.936 kHz. Resolder R 1609 for normal operation.

HIGH VOLTAGE CHECK

Tune in a picture. Set brightness, contrast, and color to minimum. Connect a high voltage probe to the CRT anode. High voltage should measure 31kV to 33kV.

28
30 72 73

SAPVCO
Remove power, and unsolder the end ofRI609 connected to JW244. Apply 1kHz audio frequency and L-R modulating signal with SAP on. Connect an audio generator (78.67 kHz sine) to the loose end of R 1609 and set signal level to 255 mVrms. Apply AC power, enter service mode, and select parameter (l 20), and set value to minimum. Increment the value slowly until an astrisk (*) appears next to the value, record this value as VI. Reset the value of parameter (l 20) to maximum. Decrement the value slowly until an astrisk (*) appears next to the value, record this value as V2. Set the value of parameter (1 20) to half the value of (V2 - VI). Resolder R1609 for normal operation.

128
136 138 150 154

BLANKING RESERVE
Tune in a color bar signal, short pin 49 of U2001 to ground to eliminate color. Enter service mode, and select parameters (1 13), (1 14), and (1 15). Adjust the value of each parameter to maximum. Select parameters (1 16), (1 17), and (1 18). Adjust the value of each parameter to minimum. Connect an oscilloscope to pin 8 of the CRT socket. Adjust the value of parameter (1 16) to obtain 5.0V ± 2.0V between the sync tip and the peak point of the red output waveform. If that can not be attained by adjusting value of parameter (I 16), then decrement the value of parameter (1 13) by one step and repeat the adjustment. Connect an oscilloscope to pin 6 of the CRT socket. Adjust the value of parameter (1 17) to obtain 5.0V ± 2.0V between the sync tip and the peak point of the green output waveform. If that can not be attained by adjusting the value of parameter (1 17), then decrement the value of parameter (1 14) by one step, and repeat the adjustment. Connect an oscilloscope to pin 11 of the CRT socket. Adjust the value of parameter (1 18) to obtain 5.0V ± 2.0V between the sync tip and the peak point of the blue output waveform. If that can not be attained by adjusting the value of parameter (1 18), then decrement the value of parameter (1 15) by one step, and repeat the adjustment.

186
194

STEREO LOWPASS FILTER

Remove power and unsolder the end of R 1609 connected to JW244. Apply 1kHz audio frequency and L+R modulating signal with pilot on. Connect an audio generator (9.4 kHz sine) to the loose end of R1609 and set signal level to I.04Vrms. Apply AC power, enter service mode, and select parameter (1 21), and set value to minimum. Increment the value slowly until an astrisk (*) appears next to the value, record this value as VI. Reset the value of parameter (1 21) to maximum. Decrement the value slowly until an astrisk (*) appears next to the value, record this value as V2. Set the value of parameter (1 21) to half the value of (V2 - VI). Resolder R1609 for normal operation.

SAP FILTER
Remove power and unsolder the end ofR1609 connected to JW244. Apply 1kHz audio frequency and L-R modulating signal with SAP on. Connect an audio generator (88 kHz sine) to the loose end of R1609 and set signal level to 206m Vrms. Apply AC power, enter service mode, and select parameter (1 22), and set value to minimum. Increment the value slowly until an astrisk (*) appears next to the value, record this value as VI. Reset the value of parameter (l 22) to maximum. Decrement the value slowly until an astrisk (*) appears next to the value, record this value as V2. Set the value of parameter (1 22) to half the value of (V2 - VI). Resolder R1609 for normal operation.

COLOR TEMPERATURE
Tune in a color bar signal, short pin 49 of U2001 to ground to eliminate color. Enter service mode, and select parameters (0 14), (0 15), and (0 16). Adjust the value of each parameter to obtain a low-level white balance on the screen. Notice that the far right bar on the screen must remain black. In case one or more of these bias parameters can not be set, increment the value of the corresponding parameter (0 20), (0 21), or (0 22) by one step at a time. These parameters have a very large effect on the display, adjust only if absolutely necessary. Select parameters (0 17), (0 18), and (0 19). Adjust the value of each parameter to obtain a high-level white balnce on the screen. Notice that the far left bar on the screen must remain white. Tune in a crosshatch signal, select parameter (0 14), and check for stable display. If the display is blinking or blanking, adjust the screen control. There is a narrow range of the screen control in which a stable display will appear. Repeat color temperature adjustment if necessary. Check for best black and white picture. Check tracking at low and high brightness.

SEPARATION
Select pilot, 300Hz audio frequency, and left modulating signal. Connect an oscilloscope to pin 28 of UI600, enter service mode, and select parameter (1 23), set value for minimum amplitude. Change audio frequency to 3kHz, and select parameter (1 24). Set value for minimum amplitude. Repeat process until no further decrease in the waveform amplitude is obtained. Do not use any modulation frequency other than specfied. If the specified frequency is not available set the value of parameter (1 23) to 31 and set the value of parameter (1 24) to 35.

SET 4474

Page 1

MISCELLANEOUS ADJUSTMENTS
SERVICE MENU
The following adjustment procedures are accessed thru a service menu. To access the service menu, tum the receiver on, press the menu button and hold it down while pressing the power button. While holding down the menu button, release the power button and press the volume + button. The screen will display a one line menu, on the left the parameter PO, and on the right the value of that parameter YO. Release buttons. Adjustments are made by selecting the proper parameter and changing the value of that parameter. To change the parameter number use channel up and down buttons. To adjust the current value of that parameter use volume + and - buttons. To access and change any of the adjustments, the proper parameter pass number must be entered. This information is listed at the beginning of the alignment. When these parameters are modified, the T-Chip U2001 and the corresponding EEPROM U3102, and U8302 are updated. All service adjustments are bus controlled, except focus and screen. Parameters are grouped in 4 groups. Group 0 is Instrument Parameters; Group 1 is Chassis Parameters; Group 2 is Tuner Parameters; and Group 3 is PIP Tuner Parameters. A security code must be entered to access the parameters of each group.

continued
ELECTRONIC PIP TUNER ALIGNMENT
Monitor IF AGC at pin 4 ofU8101, and adjust for minimum voltage at parameters 58, and 59. The entire Electronic Tuner Alignment procedure, once started, must be completed in its entirety.

ELECTRONIC MAIN TUNER ALIGNMENT

Use tuner alignment generator, RCA stock no. TAGOOl, and a VCR for signal source. Monitor IF AGC at pin 11 of U2001, and adjust for minimum voltage at parameters 59 and 58. The entire Electronic Tuner Alignment procedure, once started, must be completed in its entirety.

Parameter No.
2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59

Parameter Name
Pass number for Main tuner alignment parameters Ch. 2 secondary Ch. 2 single Ch. 2 primary Ch. 3 secondary Ch.3 single Ch. 3 primary Ch. 6 secondary Ch. 6 single Ch. 6 primary Ch. 99 secondary Ch. 99 single Ch. 99 primary Ch. 17 secondary Ch. 17 single Ch. 17 primary Ch. 18 secondary Ch. 18 single Ch. 18 primary Ch. 13 secondary Ch. 13 single Ch. 13 primary Ch. 29 secondary Ch. 29 single Ch. 29 primary Ch.41 secondary Ch.41 single Ch. 41 primary Ch. 47 secondary Ch. 47 single Ch. 47 primary Ch. 50 secondary Ch. 50 single Ch. 50 primary Ch. 51 secondary Ch. 51 single Ch. 51 primary Ch. 57 secondary Ch. 57 single Ch. 57 primary Ch. 68 secondary Ch. 68 single Ch. 68 primary Ch. 76 secondary Ch. 76 single Ch. 76 primary Ch. 93 secondary Ch. 93 single Ch. 93 primary Ch. 110 secondary Ch. 110 single Ch. 110 primary Ch. 120 secondary Ch. 120 single Ch. 120 primary Ch. 125 secondary Ch. 125 single Ch. 125 primary Main IF Filter 1 Main IF Filter 2

Value Range
Must set to 78 00 - 62 00 - 62 00-62 00-62 00 - 62 00 - 62 00-62 00 -62 00 - 62 00 - 62 00-62 00-62 00 - 62 00 - 62 00 - 62 00-62 00-62 00 - 62 00- 62 00-62 00 -62 00 - 62 00- 62 00-62 00 -62 00 - 62 00 - 62 00 - 62 00-62 00-62 00 - 62 00- 62 00-62 00-62 00-62 00 - 62 00- 62 00 -62 00-62 00 - 62 00 - 62 00-62 00 -62 00 - 62 00 - 62 00- 62 00 -62 00 -62 00- 62 00 -62 00-62 00- 62 00-62 00 -62 00 - 62 00- 62 00 -62 00 -62 00 - 62

OnSet Value
00 25 20 17 26 27 25 49 37 52 49 43 37 57 56 41 30 27 25 49 40 45 35 30 37 42 47 46 49 50 55 49 37 17 25 20 17 49 37 25 49 20 25 25 20 17 49 37 25 49 20 25 49 20 25 25 20 17 49 37

Parameter No.
3 00 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 01 02 03 04 05 06 07 08 09

Parameter Name
Pass number for PIP tuner alignment parameters Ch. 2 single Ch. 2 secondary Ch. 2 primary Ch. 3 single Ch. 3 secondary Ch. 3 primary Ch. 6 single Ch. 6 secondary Ch. 6 primary Ch. 99 single Ch. 99 secondary Ch. 99 primary Ch.17single Ch. 17 secondary Ch. 17 primary Ch. 18 single Ch. 18 secondary Ch. 18 primary Ch. 13 single Ch. 13 secondary Ch. 13 primary Ch. 29 single Ch. 29 secondary Ch. 29 primary Ch. 41 single Ch. 41 secondary Ch. 41 primary Ch. 47 single Ch. 47 secondary Ch. 47 primary Ch. 50 single Ch. 50 secondary Ch. 50 primary Ch. 51 single Ch. 51 secondary Ch. 51 primary Ch. 57 single Ch. 57 secondary Ch. 57 primary Ch. 68 single Ch. 68 secondary Ch. 68 primary Ch. 76 single Ch. 76 secondary Ch. 76 primary Ch. 93 single Ch. 93 secondary Ch. 93 primary Ch. 110 single Ch. 110 secondary Ch. 110 primary Ch. 120 single Ch. 120 secondary Ch. 120 primary Ch. 125 single Ch. 125 secondary Ch. 125 primary PIP IF Filter 1 PIP IF Filter 2

Value Range
Must set to 79 00 - 62 00 - 62 00-62 00 - 62 00- 62 00-62 00 - 62 00 -62 00 - 62 00 - 62 00 - 62 00 - 62 00 - 62 00- 62 00 - 62 00 - 62 00-62 00-62 00 - 62 00- 62 00 - 62 00 - 62 00 - 62 00 - 62 00-62 00 - 62 00 - 62 00 - 62 00-62 00 - 62 00-62 00- 62 00-62 00 - 62 00-62 00-62 00 - 62 00 - 62 00-62 00-62 00 - 62 00 - 62 00 - 62 00 - 62 00-62 00 - 62 00-62 00 - 62 00 - 62 00 - 62 00-62 00 - 62 00 - 62 00 - 62 00 - 62 00-62 00 - 62 00 - 62 00 - 62

OnSet Value
00 25 20 17 49 37 25 49 20 17 49 37 17 25 20 17 49 37 25 49 20 25 25 20 17 49 37 25 49 20 25 49 37 17 25 20 17 49 37 25 49 20 25 25 20 17 49 37 25 49 20 25 49 20 25 25 20 17 49 37

SERVICE ADJUSTMENT PARAMETERS

Parameter No.
0 0

Parameter Name
Pass number for service adjustment parameters for group O. Error Code 1 Error Code 2 Error Code 3 Horizontal Phase Vertical Centering Horizontal Size Pincushion Amplitude Pincushion Tilt Vertical Size Vertical Linearity Vertical S-Correction Bottom Comer Pin Correct Top Comer Pin Correction Red Bias Green Bias Blue Bias Red Drive Green Drive Blue Drive Red Sub Bias Green Sub Bias Blue Sub Bias Pass number for service adjustment parameters for group 1. IF VCO Free Run 4.5MHzTrap IF APC Offset Video Level FMLevel RFAGCDelay D2PIP Brightness D2PIP Contrast D2PIP Chroma Level D2PIPTint Factory Tint Factory Contrast Red Blanking (Sub-Bias) Green Blanking (Sub-Bias) Blue Blanking (Sub-Bias) Red Blanking (Bias) Green Blanking (Bias) Blue Blanking (Bias) Stereo VCO SAPVCO Stereo Lowpass Filter SAP Filter Wideband DBX Spectral DBX

On Set Value
00 00 00 00 05 32 20 08 08 110 08 00 03 03 27 20 37 32 27 25 00 00 00 00 87 07 16 05 19 30 19 50 67 60 65 55 00 00 00 00 00 00 31 07 32 07 31 35

Value Range
Must set to 76 00 - 255 00 - 255 00 - 255 00 - 15 00 - 63 00 - 31 00 - 15 00 - 15 00 - 127 00 - 15 00 - 15 00-7 00 -7 00 - 127 00 - 127 00 - 127 00- 63 00- 63 00 - 63 00 - 3 00 - 3 00 - 3 Must set to 77 00 - 127 00 -7 00 - 31 00 -7 00 - 31 0000 00 00 00 00 00 00 00 00 00 00 00 00 00 0000 00 0063 31 63 127 127 127 127 3 3 3 127 127 127 63 15 63 15 63 63

Comment
May not advance until value is set to 76. Displays the first error detected. Set to 00 before exiting. See Error Codes Chart. Displays the second error detected. Set to 00 before exiting. See Error Codes Chart. Displays the last error detected. Set to 00 before exiting. See Error Codes Chart. Set value to 05. Adjust to center vertically. Adjust for slight horizontal overscan. Set value to 08. Set value to 08. Adjust for slight vertical overscan. Adjust to center vertically. Set value to 00. Set value to 03. Set value to 03. Adjust for proper low-level white balance see color temperature adjustment. Adjust for proper low-level white balance see color temperature adjustment. Adjust for proper low-level white balance see color temperature adjustment. Adjust for proper high-level white balance see color temperature adjustment. Adjust for proper high-level white balance see color temperature adjustment. Adjust for proper high-level white balance see color temperature adjustment. See color temperature adjustment. See color temperature adjustment. See color temperature adjustment. May not advance until value is set to 77. Disconnect RF source, short +side of C2309 to ground. Set the generator for 45.75MHz marker, 450m Vrrns. Adjust for 3.8V at pin12 of U2001. Set value to 07. Short pin 11 of U2001 to ground, adjust for 3.8V at pin 14 of U2001. Short pin 49 of U2001 to ground, adjust for a waveform of 1.6V ±.15Vp-p at pin 56 of U2001. Apply 1kHz, L+R signal. Adjust for a 333mVp-p waveform at pin 5 ofU2001 (carrier portion is not included). Set to the value when snow disappears from picture. Adjust so that the brightness of the PIP picture matches the brightness of the main picture. Adjust so that the brightness of the PIP picture matches the brightness of the main picture. Adjust so that color level of the PIP picture matches color level of the main picture. Adjust so that the tint of the PIP picture matches the tint of the main picture. Set value to 65. Set value to 55. See Blanking Reserve adjustment. See Blanking Reserve adjustment. See Blanking Reserve adjustment. See Blanking Reserve adjustment. See Blanking Reserve adjustment. See Blanking Reserve adjustment. See Stereo Adjustments. See Stereo Adjustments. See Stereo Adjustments. See Stereo Adjustments. See Stereo Adjustments. See Stereo Adjustments.

01 02 03 04 05 06 07 08 09 0 10 0 11 0 12 0 13 0 14 0 15 0 16 0 17 0 18 0 19 0 20 0 21 0 22 0

10
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

MISCELLANEOUS ADJUSTMENTS
MAIN TUNER ALIGNMENT (GROUP 2)
The tuner coil alignment is preset at the time of manufacture and should require no further adjustment. The following recommended procedure should be performed only in event a complete tuner alignment is necessary, which is unlikely. Use plastic or wooden tool to adjust coils. This procedure is performed with top tuner cover removed and bottom tuner cover in place and soldered.

continued
6. Select parameter (3 14) and record the value. Adjust parameter (3 14) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust Ll l l and repeat this step. If the null voltage appears, set parameter (3 14) to recorded value and continue to the next step. 7. Select parameter (3 15) and record the value. Adjust parameter (3 15) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L1 OS and repeat this step. If the null voltage appears, set parameter (3 15) to recorded value.

6. Select parameter (2 13) and record the value. Adjust parameter (2 13) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust Ll l l and repeat this step. If the null voltage appears, set parameter (2 13) to recorded value and continue to the next step. 7. Select parameter (2 15) and record the value. Adjust parameter (2 15) thru the value range and check for a null AGC voltage. Ifthe null voltage does not appear, adjust LIOS arid repeat this step. If the null voltage appears, set parameter (2 15) to recorded value.

PIP TUNER ALIGNMENT (GROUP 3)

The tuner coil alignment is preset at the time of manufacture and should require no further adjustment. The following recommended procedure should be performed only in event a complete tuner alignment is necessary, which is unlikely. Use plastic or wooden tool to adjust coils. This procedure is performed with top tuner cover removed and bottom tuner cover in place and soldered.

IF Alignment
1. Use tuner alignment generator, RCA stock no. TAGOOl, and
tune in a color bar signal on main tuner. Connect DC voltmeter to pin 11 of U200 1. Connect ground to tuner shield. 2. Select parameter (2 59), and adjust value to have minimum voltage at pin 11 of U200 1. 3. Select parameter (2 5S), and adjust value to have minimum voltage at pin 11 of U2001. 4. Repeat steps 2 and 3 until no reduction in voltage reading at pin 11 ofU2001 can be achieved.

IF Alignment
1. Use tuner alignment generator, RCA stock no. TAGOOl, and
tune in a color bar signal on PIP tuner. Connect DC voltmeter to pin 4 of US 101. Connect ground to tuner shield. 2. Select parameter (3 59) PIP IF Filter 2 and adjust value to have minimum voltage at pin 4 of USI01. 3. Select parameter (3 5S) PIP IF Filter 1 and adjust value to have minimum voltage at pin 4 of US 101. 4. Repeat steps 2 and 3 until no reduction in voltage reading pin 4 ofUS101 can be achieved. at

Band 3 Manual Alignment

1. Use tuner alignment generator, RCA stock no. TAGOO1.
Connect DC voltmeter to the junction of R509 and R51 O. Connect ground to tuner shield .. 2. Set the tuner alignment generator for channel 125 output and tune to receive channel 125 on main tuner. 3. Adjust L701 for4.SV ±.lV.

Band 3 Manual Alignment

1. Use tuner alignment generator, RCA stock no. TAGOO1. Connect DC voltmeter to the junction of R509 and R51 O. Connect ground to tuner shield. 2. Set the tuner alignment generator for channel 125 output and tune to receive channel 125 on PIP tuner. 3. Adjust L701 for 4.SV ±.l V. 4. Connect voltmeter across CS117. 5. Select parameter (3 55) and record the value. Adjust parameter (3 55) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L302 and repeat this step. If the null voltage appears, set parameter (3 55) to recorded value and continue to the next step. 6. Select parameter (3 56) and record the value. Adjust parameter (3 56) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L305 and repeat this step. If the null voltage appears, set parameter (3 56) to recorded value and continue to the next step. 7. Select parameter (3 57) and record the value. Adjust parameter (3 57) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L304 and repeat this step. If the null voltage appears, set parameter (3 57) to recorded value.

Band 2 Manual Alignment

1. Use tuner alignment generator, RCA stock no. TAGOOl.
Connect DC voltmeter to the junction of R509 and R51 O. Connect ground to tuner shield. 2. Set the tuner alignment generator for channel 50 output and tune to receive channel 50 on main tuner. 3. Adjust L 703 for 4.9V ±.l V. 4. Connect voltmeter across C2309. 5. Select parameter (2 31) and record the value. Adjust parameter (2 31) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust LI04 and repeat this step. If the null voltage appears, set parameter (2 31) to recorded value and continue to the next step. 6. Select parameter (2 32) and record the value. Adjust parameter (2 32) thru the value range and check for a null AGC voltage. Ifthe null voltage does not appear, adjust LI09 and repeat this step. If the null voltage appears, set parameter (2 32) to recorded value and continue to the next step. 7. Select parameter (2 33) and record the value. Adjust parameter (2 33) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L 107 and repeat this step. If the null voltage appears, set parameter (2 33) to recorded value.

4. Connect voltmeter across C2309. 5. Select parameter (2 56) and record the value. Adjust parameter (2 56) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L302 and repeat this step. If the null voltage appears, set parameter (2 56) to recorded value and continue to the next step. 6. Select parameter (2 55) and record the value. Adjust parameter (2 55) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L305 and repeat this step. If the null voltage appears, set parameter (2 55) to recorded value and continue to the next step. 7. Select parameter (2 57) and record the value. Adjust parameter (2 57) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust L304 and repeat this step. If the null voltage appears, set parameter (2 57) to recorded value.

Band 2 Manual Alignment

1. Use tuner alignment generator, RCA stock no. TAGOO1. Connect DC voltmeter to the junction ofR509 and R510. Connect ground to tuner shield. 2. Set the tuner alignment generator for channel 50 output and tune to receive channel 50 on PIP tuner. 3. Adjust L 703 for 4.9V ±.l V. 4. Connect voltmeter across. CS117. 5. Select parameter (3 31) and record the value. Adjust parameter (3 31) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust LI 04 and repeat this step. If the null voltage appears, set parameter (3 31) to recorded value and continue to the next step. 6. Select parameter (3 32) and record the value. Adjust parameter (3 32) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust LI 09 and repeat this step. If the null voltage appears, set parameter (3 32) to recorded value and continue to the next step. 7. Select parameter (3 33) and record the value. Adjust parameter (3 33) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust LI07 and repeat this step. If the null voltage appears, set parameter (3 33) to recorded value.

o c
m

3:

rW
Q

-n w N .......

en

m
-n

3: .......

-0

::J:

~ en
-I

en
.......
CQ

RF AGC Alignment
1. Use tuner alignment generator, RCA stock no. TAGOO1. Connect DC voltmeter to the junction of R509 and R51 O. Connect ground to tuner shield. 2. Connect voltmeter across C2309. 3. Set the tuner alignment generator for channel 2 output and tune to receive channel 2 on main tuner. 4. Select parameter (2 voltage. 5. Select parameter (2 voltage. 6. Select parameter (2 voltage. 1) and adjust value to have minimum DC 2) and adjust value to have minimum DC 3) and adjust value to have minimum DC

RF AGC Alignment
1. Use tuner alignment generator, RCA stock no. TAGOO1.
Connect DC voltmeter to the junction ofR509 and R510. Connect ground to tuner shield. 2. Connect voltmeter across CSl17. 3. Set the tuner alignment generator for channel 2 output and tune to receive channel 2 on PIP tuner. 4. Select parameter (3 voltage. 5. Select parameter (3 voltage. 6. Select parameter (3 voltage. 1) and adjust value to have minimum DC 2) and adjust value to have minimum DC 3) and adjust value to have minimum DC

o ....... o
3:

Band 1 Manual Alignment

1. Use tuner alignment generator, RCA stock no. TAGOO1. Connect DC voltmeter to the junction of R509 and R51 O. Connect ground to tuner shield. 2. Set the tuner alignment generator for channel 17 output and tune to receive channel 17 on main tuner. 3. Adjust L704 for 4.6V ±.l V. 4. Connect voltmeter across C2309. 5. Select parameter (2 14) and record the value. Adjust parameter (2 14) thru the value range and check for a null AGC voltage. Ifthe null voltage does not appear, adjust LI05 and repeat this step. If the null voltage appears, set parameter (2 14) to recorded value and continue to the next step.

Band 1 Manual Alignment

1. Use tuner alignment generator, RCA stock no. TAGOO1. Connect DC voltmeter to the junction of R509 and R51 O. Connect ground to tuner shield. 2. Set the tuner alignment generator for channel 17 output and tune to receive channel 17 on PIP tuner. 3. Adjust L704 for 4.6V ±.l V. 4. Connect voltmeter across CS117. 5. Select parameter (3 13) and record the value. Adjust parameter (3 13) thru the value range and check for a null AGC voltage. If the null voltage does not appear, adjust LI 05 and repeat this step. If the null voltage appears, set parameter (3 13) to recorded value and continue to the next step.

7. The adjustments for each channel must be repeated to assure correct alignment. 8. Repeat the process with parameters (2 4) thru (2 57), and repeat the adjustments for each channel must be repeated to assure correct alignment.

7. The adjustments for each channel must be repeated to assure correct alignment. 8. Repeat the process with parameters (3 4) thru (3 57) and repeat the adjustments for each channel must be repeated to assure correct alignment.

SET 4474

Page 1

Page 2 SET 4474 --,

B TELEVISION SCHEMATIC

A·
SEE U3103 PIN 11 PAGE 4C SEE U3103 PIN B PAGE 4C

--l

SEE U3103 PIN 4 PAGE 4C

c......._--..,

B
SEE Q601 COLLECTOR ON MAIN TUNER PAGE 4G

INPUT

12.ov SEE 02602 PAGE 5E

--l

+-------BASE
SEE 08102

~~r~~ ~--~~---~-ir--~

10.3V

C.

A PHOTOFACT STANDARD

WITH
©2001 ~

';m$idtfifG
Technlcol

NOTATION

SCHEMATIC

ADDITIONAL SCHEMATIC NOTES, SEE PAGE 4G

publrshlng

--l
U4501
VERT OUT

o·
C4353

.022

--l

c
~i~

D TELEVISION SCHEMA TIC

continued

SET 4474

Page 2

~~501---<

__

..:w__

---::!"-!.!+-r

PAGE 5H

R2601 1600

2"
R2632 4700

R2602

SEE U2601 PIN 1 PAGE 5E

2000 211:
C261S 5.6pF

NPO R2603 620

2%
[2607

NPO

~;5J 4J~~ 2%
12.0V

C2602

2"

CR2751

7.6V

2%

C2715 .0016 (100pF) (NPO)

7.6V

E4401 AODITIONAl SCHEMATIC NOTES, SEE PAGE 4G A PHOTOFACT STANDARD WITH @2QQl ~ NOTATION SCHEMATIC T4401 BOnOM VIEW

012 011
0

20
•

Gl@llilft!Wl
TechnIcal

HV ANODE 31kV TO 33kV

10

Publ1shlng

68

P4501 OUT

NC

SEE 04720 COLLECTOR PAGE 5G A6 A2 A3 A7 AS Nil

~ 9

10

11

12

13

dd
14 15

\~~

16

E
TELEVISION SCHEMA TIC
C5018 .0015

~~jTI9rt01_'----~r----~~~~~~ 10.3V
PAGE 4A

-I

C5D23
5~~~

-I
.3-----,

c·

10.3V

-I

o·

250V

-I
SVM CR4802 18.OV 26.0V
A PHOTOFACT STANDARO WITH ©.2001 ~

';MYiJid1fi4

NOTATION

SCHEMATIC ADDITIONAL SCHEMATIC NOTES. SEE PAGE 4G

C4408 101'f"

Technical Publishing

A4

-f
Page 2 SET 4474

17

18

19

20

21

22

23

24

G
TELEVISION SCHEMATIC continued TEST EQUIPMENT

Test equipment listed by participating manufacturer illustrates typicalor equivalent equipment used by Sams engineers to obtain measurements. This equipment is compatible with most types used by field service technicians.

Equipment
Oscilloscope Generators RGB Multiburst Signal Color Bar TV Stereo Digital YOM Frequency Meter Hi-Voltage Probe Accessory Probes Isolation Transformer Capacitance Analyzer CRT Analyzer AC Leakage Tester Inductance Analyzer Flyback Yoke Tester Field Strength Meter Transistor Tester Horizontal Analyzer Video Analyzer

Sencore No.
SC3100 CM2125 VG91 V091 VG91 SC3100 SC3100 HP200 TP212 PR570 LCI02 CR7000 PR570 LCI02 TVA92 SL753 TF46 HA-2500 VG91, TVA92

250V

o
r."

s::: c

W
W

N ...... o en

Dl
."

'0
::J:
E5009

s::: ..... en

» en
o
Cii

ADDITIONAL SCHEMATIC NOTES. SEE PAGE 4G A PHOTOFACT STANDARD NOTATION SCHEMATIC

WITH
@200t

'Mfliti

o s:::
CR6201
E5007 EKS5007

o ..... ......
CoO

.....

~Techntcol

Pubi10hinQ

STRENGTH

SW6201

U3101 CR6203

.r{~
NC

P6201/J5101

P620~J5101 ~ 41 P6201,J5101 NC~ 23

NC NC Al A

25

26

27

28

l SET 4474 Page 2

Page 3 SET 4474 -,

A POWER SUPPLY SCHEMATIC

135V SOURCE

A·
C41$ 470 160V

135V SOURCE

26.0V SOURCE C4507 .1

-l

C4120 660#

SEE U3101 PIN 4 PAGE 4B C4134 1500# ~~----------------------~--~~~O~RCE C4202

.001
~~i---~--------------~--IffiI~O~RCE

C8245

.1

-l

c·

-l

o·
135V

-l

SEE Q3106 EMITTER PAGE 4B

E
ADDITIONAL SCHEMATIC NOTES. SEE PAGE 4G A PHOTOFACT STANDARD NOTATION SCHEMATIC C4603 .001 CR4603 CR4604 C4604 .001 C4601 .001 CR4601 CR4602 C4602 .001

29

30

31

32

33

34

35

36

C POWER SUPPLY SCHEMA TIC

continued

SET 4474

Page 3

33.7V SOURCE 12,4V SOURCE SEE Q3312 BASE PAGE 4A 5.3V SOURCE 5.0V SOURCE 5.0V SOURCE 5.3V SOURCE 33.7V SOURCE SEE T4401 PIN 5 PAGE 20 33.7V SOURCE 33.7V SOURCE

NC

12.0V SOURCE 12.0V SOURCE 12.0V SOURCE 12.0V SOURCE 12.0V SOURCE 12.0V SOURCE C1709 47# 10.6V SOURCE

E+120Y, E+12V 12.4V SOURCE 7.6V SOURCE 7.6V SOURCE 7.6V SOURCE 5.7V SOURCE CR4129 7.6V SOURCE SEE O410S COLLECTOR PAGE 48 -1S.0V SOURCE CR4126 12.0V SOURCE -12.0V SOURCE 12.0V SOURCE 12.0V SOURCE 12.0V SOURCE 12.0V SOURCE -12.0V SOURCE -12.0V SOURCE 12.0V SOURCE 135V 10.3V SOURCE 10.3V SOURCE 10.3V SOURCE 250V SOURCE B.OV SOURCE 7.6V SOURCE

6.BV SOURCE

U4102

-12

REG

-12.0V SOURCE

C4702 471" 315V

-12.0V SOURCE

250V SOURCE

250V SOURCE

10.3V SOURCE 10.3V SOURCE 9.0V SOURCE 9.0V SOURCE

-10.3V SOURCE C1476 .01

C5010 1SOp' C5007 1801"

SEE Ul406 PIN 7 PAGE 6E

20.OV SOURCE

12.0V SOURCE 12.0V SOURCE 12.0V SOURCE

IN 19.3V

U4601

+12V

REG OUT 3

4.BV SOURCE

CR4611

SEE U3101 PIN 1 PAGE 4A

4.SV SOURCE

C3505

.1

ADDITIONAL SCHEMATIC NOTES. SEE PAGE 4G A PHOTO,ACT STANDARD

WITH
©2001 ~

i;M4iJid£fifG
44

NOTATION

SCHEMATIC

Technleol Publfshfng

37

38

39

40

41

42

43

PLACEMENT CHART
9.0V 5.OV

MAIN BOARD - TOP VIEW

9.5V

MAIN BOARD - BOTTOM VIEW

02515 02514 ~ 002511 Q2 50B 0 ~~ 0 0251 0 02501 003302 02509 02509i 513 003303 03301 02 510 002507 0 02517 002518 Q2503 02505 02502 0

10.3V

003107 UN U3103 B07 16UD160015 14 L23'03 1 ~ 1 4.BV P3101 7 CR3110 -M0410B 002504

Il

02302

002905 002701 02803 02902 002908 002907 Q2906 0 002913 02912 002909

30 ~~3 1

1
L2201

~~

L23'04

DYNAMIC FOCUS BOARD - TOP VIEW

03310

ill
MAIN TUNER

03105

003102

Q2914

B07

02301

02B02 02~0029040 0 0 02801 029100

U3'BOI

003109

0 03201 003304

0601 U701 10 1
B

14 1 L4102

250V OQ310B 04707

0 O 03200 03306 03106

0 03101 503 Q3~01 0 03502 Q3103

03311 0

03B02 03BOI

o o

110
1:01

002901

0 0101

20 05030502 00 Q5010

0301

Q2512

00504 U5017

c=J
3

U4601

04603

B U4701 7

03312

03104

0 00Q508 05050506 0507

QB02

T4101

CR4115

......... ......... CR4111

DYNAMIC FOCUS BOARD - BOTTOM VIEW

U4101 lOB 04110 4 5

004103 004102

D
K4201 J4701 2(01

04201

R4732A

D~

R4113 REG B+ 04705 04706 004703

lW

HORIZ CENTERING SW4401 HORIZ CENTERING R4402

{]

04402

04720

0 04702

04701

04721

004723 04722

250V

FOCUS & SCREEN

Page 3

SET 4474

SET 4474

Page 3

PLACEMENT CHART
FRONT PANEL BOARD

continued

D
-12_OV

IR3401

P3~00: :\

LJ LJ LJ
SW3430 SW3420 SW3410 MENU CH ON CH UP

SW3431 SW3421 SW3411 VOLON VOLUP POWER

LJ LJ LJ

5.0V

PIP BOARD - TOP VIEW

12.DV 9.OV

12.0V 5.3V -12.0V

IN/OUT BOARD - TOP VEW

26.3V
R260B

135V

CRT BOARD - TOP VIEW

~
2 J5001 1 J5101 05006

PIP TUNER

U8350 7 80 14 1

U8301

COMB DEPTH

[Q]

12.OV J8006 J8003 1 P8004 ~ 3

~1
o

I
J~pl J6506 20 [gil

10

FB8201

ITIl

U19131 1 11

41 U1910D 58

05007

::a

rr:::::rl
05002 250V

»
05206

12 U1702 U1700 7 1 30 16 U1503 1 15

~3

~82Dog
16 1

U8201

52 lUD820228

[;]4

[;]4

c=J 1

11 U6501

64

D 8 14

I
SW6201 SC1900 STRENGTH P6201 1000011 4 05004 J5002 1

10

J6501 J1404 J1405,i, 26 14 27 15 J1406 J1407

[Q] [Q] I2l [Q][Q][Q]

~ ~ I2l H J1410

85 J1415 DUl404 J61Ql504Jl1Ql414,i,O 4 1

U [Q] [Q]

D~~1J~x~D
D
SW1904 SPKR 06202

r.l

0 r.l

J6502

J1417

U POlARITY

SW6202

ill

05008

~
05207

05005

0
05009

:s:::

o c
m rW "T1 W N

rr:::::rl
05001 281

rr:::::rl
05003

~
J5201 281

L5005 E5002 o J5003

.....
o
D:J

en
"T1

5.OV

5.6V

5.6V

12.OV

12.OV

-12.0V

6.0V

10.3V

:s::: ......

'0
CRT BOARD - BOTTOM VIEW

:J:

PIP BOARD - BOTTOM YEW

0508 0507 0506 00000505

10.6V -1O.3V

» en
en

en
..... co

05205 01411

o o 08350
08105

08351 0301

80700501 14

0504 0

10 0101

10
U501

0503 0~20 20 02604

01410 01412 014130 01416 01415

11 U701 0601

Cf

01414

05204 01417

05202 0 05201

o -t o ...... o :s:::

02605 026010

02602 0

01704 01706

00

05029

05016

005021 05014

01703 01705

08204

o 08401
08201

08205

08106

02603 06504 12.0V

21U20 01910

006503

0
06502 01907

05~8

05013 05018 1 2 U5DOl 005015 05024

o 08202

01912

01911

082080 082070 082090 082060 081020 081040 081010 0 08103

lD.3V

SET 4474

Page 3

Page 4

-,

SET 4474

SYSTEM CONTROL SCHEMATIC

IR3401
IR RECEIVER C3205 .001 R OSD all CR31 07 SEE Q3303 PAGE 2C SEE Q3503 COLLECTOR PAGE 3D

A-

CR3306

R3357 10K R3368 lOOK

4 all

rr-;>;+

P300D

P/J3001

CR31 05

Q3301

R3356 15K C3109 B20pF SEE 04201 BASE PAGE 3A 71V R4134 lOOK

4.BV

4.BV

CR31 06

SEE 04105 BASE PAGE 3C

12.aII 5 KDl 4.7V IF VCl 1.6V 12.aII 12.0V

B
8 KS3 4.7V IF VC2 1.6V DATA 4.7V TUNER 15

KS2 4.7V

5.3V

-1
6 KSI 4.7V

U3101
SYSTEM CONTROL

C.
SEE Q6503 EMITTER PAGE 2B SEE Q2507 BASE PAGE 5H SEE U2001 PIN 39 PAGE 20 SEE T4101 PIN 8 PAGE 3B SEE Q2503 BASE PAGE 5G C3107 3~~

-1

r
4.BV DET RESET 4.7V 29

o·
SEE T4401 PIN 5 PAGE 20

NC 1M CLK 4.7V

16

-1

SEE U4501 PIN .'5 PAGE 2B

SEE U1910 PIN 7 PAGE 6F

4.BV

26.aII SEE Q3104 COLLECTOR PAGE 3C 2 IRQ 4.BV SEE U2001 PIN 56 PAGE 2A

E
ADDITIONAL SCHEMATIC NOTES, SEE PAGE 4G A PHOTOFACT STANDARD NOTATION SCHEMATIC

4.BV 4.BV

RESET all 9

SYS

WITH

G'@IIIi&#W

©2001 ~

Technfcal PUblIshIng

45

46

4.BV

47

48

49

50

51

52

C
SYSTEM CONTROL SCHEMATIC continued
Pin
No.
C3104 .1 NC

SET 4474

Page 4

PIP TUNER VOLTAGE

VHF Low VHF High UHF

CHART
Pin
No. Q101 VHF Low VHF High UHF

Band

Band

Band

Band

Band

Band

----7

J3104

SERVICE 1 TEST SERVICE TEST

NC

----7

J3104 2

U501
1 2 3 4 5 6 7 8 9 10 11 12 1.8V 1.8V 1.8V 3.3V 3.3V 3.3V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7V 12.2V .IV 12.0V OV OV OV 12.0V 11.8V OV 12.2V 12.2V 12.2V 5.0V 5.0V 5.0V 1.9V 1.9V 1.9V 1.9V 1.9V 1.9V OV OV OV DO NQT MEASURE DC VOLTAGE

nTEST

J3104SERVICE

G1 G2 D S

1.7V 2.3V 10.7V OV

1.7V 2.3V 10.7V OV

OV 2.3V OV OV

Q301
G1 G2 D S OV .5V OV OV OV .5V OV OV 4.0V .5V 10.3V 4.9V

Q501
E B C 12.0V 12.2V ·11.9V 12.0V .IV 11.9V 12.0V l2.0V ·11.9V

13
14

U701
1 2 3 4 5 6 7 8 9 8.1V 8.IV OV 4.0V 4.0V 3.7V 3.7V 11.9V 11.9V 11.9V OV 2.7V 4.7V 4.7V 2.7V 2.9V 8.0V 8.0V 2.9V OV 8.IV 8.1V OV 4.0V 4.0V 3.7V 3.7V 11.9V 11.9V 11.9V OV 2.7V 4.7V 4.7V 2.7V 2.9V 8.0V 8.0V 2.9V OV 8.IV 8.IV OV 3.5V 3.5V 3.9V 3.9V llAV 11.4V 11.4V 4.1V 2.7V 7.9V 7.9V 2.7V 2.9V 4.3V 4.7V 2.9V OV

Q506
E B C 12.0V -4.3V 11.9V l2.0V -4.3V 11.8V 12.0V -4.3V llAV

SEE U2001 PIN 54 PAGE 2A

R3343

SEE USOI PIN 4 PAGE 4E SEE UI600 PIN 1 PAGE 6A SEE U2502 PIN 3 PAGE 5H SEE U1402 PIN 24 PAGE 6A SEE U6501 PIN 2 PAGE 28 SEE U1503 PIN 29 PAGE 6E

Q507
E B C 11.9V 12.0V -2AV 11.8V 11.8V -2.5V llAV OV 11.2V

C3121 .001

10
11 12

Q508
E B C 11.9V -2AV 11.9V 11.8V -2.5V 11.8V llAV 11.2V -11.7V

13
14 15 16

17
18 19 20

NOTE:

VHF Low Band voltages taken on channel 2. VHF High Band voltages taken on channel 7. UHF Band voltages taken on channel 14.

F====;:__-------~iij~2502
PAGE 5H

9.5V SEE U8201 PIN 22 PAGE 5F

ADDITIONAl. SCHEMATIC NOTES. SEE PAGE 4G A PHOTOfACT STANDARD NOTATION SCHEMATIC

WITH
@.2001 ~

';';Si"&fjQ

Technical Publishing

53

54

55

56

.l

E
MAIN TUNER SCHEMATIC r--------------..J

-E702 1

E706

RF OUT,:::.. Rt-

SEE 0301 Gl0N PIP TUNER PAGE5B

-'1
J802 Q802 BUffER l~vfJr~t) CRB03(~ ANT Bf

J801

~! ?- "& ~ fTi":'~
'I
SW801 , TOOl

I-----------------~ : ,----1:

SEE 02512 -<--"'---H~ ~~~~~~OR

c~~

I •.
12.0V OSOS~

~~~t c~;1~~~
R~ga R503 1~ ~ 12.~

~~!

1 :

141

L
"

::~:

"EE 0230 1 ~ ~~~ --C2-02-:

Rl11 100

~ lin _

1 1

kr ~ -7

CB09 6BpF L---fl'__--l~r--r------lNP~PO NPO LBOl (~'CRll1

=rr
'----;2

L02 1.9V LO 1 1.9V

P7 b---------,1.fH.· 6 12.2V~LO~ .IVHI 12.OV( HF PI t;;---t-l.~ )-4.3V 12.3V 9 ., US01 PLL .•. 12.OV R513 4700

0501 SWITCH ~r_~171.~~~(L~0')-----' ) 12.0V(HI) -ll.9V(UHF)

C401 C302 C~1 L301 .01 CR307 C306 27pF 10rPf-F_r--bl "ilJr: "'_,.__ji'ii'iirmCL_r-----.,--fr.::-¥'r-_r-~-12~PI'-F...,.._t----0"'V""f::.F"TG""1 ~ .~ ~ L302Z~t*J NPO ~3OB CR303 (, ::: ~ R303 \; R316 R~~ 3000 47K 3 3 R304.--R319 1000 C305 47K R311

:!:-_;.,;~-C-1o:-:1-~.., k

"

R30B lOOK

.SV(VHF) 7,4V(UHF)

~~~1 ;!; NPO R306 82K 2"

/.
\

0301
G2 ~

UHF AMP D OV(VHF)

R4~1 !~

.7!:?pF

C310 NPO

K ~~----~~ L3041} ~

~.:.!;;;i~r-lI'J 0.6V(UHF) L303 1

'\. -S OV(VHF) 4.1V(UHF) 5.1V(UHF) R309 ~ 2" C309 2~~~ R3~;

+-------------,p__--_.
C71~:!:

~r
r
:!:

SOURCE

I':.!
R315 47K R402 47K C201k .0047 r-

~~~

1 Rm

100

Rl03 47K Rl0l

R104 47K

'--

R31B .001 470 2_".. R126 lOOK

J C30B
120pF NPO

+-

-_1::2=.OV.:__

-.. __ C424:!: lI)~PF PO

OS06

SWITCH 12.0\i(Ht) 11.7V(UHF) C6~ .001

..-_-..

-IIlJI. _

SOURCE

C407:!: C411:!: 3~~OF 3~~ 1

c·

~12.0V(LOl

'*I +'

r----------r---.,.C~,Ol.

_ SOURCE __ SOURCE __ -II!'. _ _SOURCE

Cl01 150pF NPO

2"

tc"1o:41 330pF 1
NPO CR102(~ L103 Cl0B .001

2"

I:: L305

C313 L306 470pF ~-~f-------C31~; lBpF

N220

NPO

~tg
CR304~B

C~5

\it(320 47K

L307

C314 470pF NPO

I R314 R312 C311;!: lOOK 47K 27pF N750 CR306(~ R113 47K C114 CR105 (~ ClIO 39pF NPO R302 47K R40B 47K .001

I
::h

1,1,---Rl0S Q101 VHF AMP 39 3.3V G2 ~ 0 10.7V(VHF) 1 7V VHF) Gl .14lI OV (UHF) OV (UHF) -

R313 R409 R204 47K 47K 47K

Rl07 470K

Rl15 47K R116 47K

, 0507 .. VCC P2b-------+-I 12.1":~LO( 12.1'()HI~ •1v( HF

r_,",

C316 RS17 .001 7600

C30~ .001 T "

11

,
1 1

-FL101

1 ,3

~._J 1
1

.Ji!M_~
C117 Cl02 1~~ .001 CR101(P

Cl05 .001

2"

C204 •00471

!!
C3B04 .0221 R123 33 C119

R3B1B 91K

_o. \.::

5.ov

f13

-12.0V 12.0V ~ 'USWITCH OS08 SWITCH -2.6V(LO) 11.~(LO) )-2.5V(HI) '_~---i\.-l '·l1.~(H(I) ) II,6V(UHF) R514 1-l1.8V UHF 12.OV(VHF) 6800 R515 11.7V(UHF) 2" 220K

I?

::!: C510 .001 T C504 •0011 " COil .001

+ _...

L104
t_---,

,~ L106?

.~~
Rl09 150

'*'

_SOURCE

L_

--

J R3B24 91K

CR1(j3

1~
,~

L105

GND -12.0V RS16 6BOO

2"
-12.OV 0502 CURRENT SOURCE +-.:w. __ -_p-C125 ' 100P NPO

o·

C50~ 3~~O

r f

Y501 4MHz
IU~

~~1J'

_...

R3B23~ l00K~C~~~ SOURcE R3B22 27K

Rl02 1200

Cl07 ::h .001

r
C41~~ 5pF

2"

Rl05 1800

Cl06 .001

__

2"

47K R124 33

'DL-- XTAL1
3.3V

'--_---:;;-1 XTAL 2 3 4.7V

5.OV PO 1-;---,--:wv:--,-----,-,1 1.BY 1

~m

2"

. -_:r~. .<..:...7Vt-{ ~

r7')

33.7V RS12 20K_ C50B .0047

Cl13 •0011

F'*'r

2"

Cl03 .001

r
R3804

C203k .0047

+
.001

Rl14 1200

2"

C121 .001

R506 C507 QS03 CURRENT 4700 ,1 SOURCE +-~i;;-.,_-I1--1p-------__;;2~"~---..,.... -Ir;I-f~{7V 63V L NC7 RS02 1000 CAU OV R~~ ~ 2"

'*'

,-tGl_1 SOURCE
BUFFER R3B25 PARTOF U3801 2200~1 5~ BUFFER PARTOF U3801

R3821 R112P 91K 12~

J
C116 .001

-l

CLK 5 4.7V

Q r
10pF (.01 NP

DATA 4.7V ..... -~.;....-__, 4 R501 1000

UOi-;-;"""'IIL------------------------tr'{_ r' 'f 14 ~ ..

L--_._

-12.OV ~:::.:___J

0504 SWITCH 2.8V(CH.3)

~~1~

1"

'.:::I

DO NOT MEASURE DC VOLTAGE

R50B C509 4700 R511 RS09 001 R507 37'1~ 1M' 1 4700 .•

~f1I
:L
J"
33~

>-H 11,gsVJ!.._._R~rg;;,.;~;...6_;--I ...2!':)V:t~-, .

11

I
SEE U31 PIN 361~ PAGE 4A R3B14 15.BK Rrg~~ 1"

10K
j~

BUFFER PARTOF U3801

1"

~9V~;C>-Ir.~.2=V..--...,----1
4 C3B03 .033

2L...._--I

I
R3B12 15.SK

1 3V 12

t%>

R119 100 R3B20

~~2.~BY~~---~-~--10~0~K__+ ..... b~021 033

II
SEE U3101 ~l~E~A -

~1~ ~ ..... --

TR3S1~l 10~~t

R3Bl~! C3B05 27K! .0221

SEE U3101 PIN 35 PAGE4A

-....J

.~ 33.7V ADOITIONAL SCHEMATIC NOTES. SEE PAGE4G

3~.7V

1"

R3B02 10K 1" R3Bl0 IS.BK 1"

BUFFER PARTOF U3801 1 5 1.3V 6 2.8V 7 GND C3BOI .033 R3Bl1 lOOK 1"

R3B17 lOOK

SEE U3103 PIN 4 PAGE 4C SEE U3103 PIN 2 PAGE4C

03801R)~7V03802lBU~t)I~.I~~-3B-0-~!--------~~--------------------------------------~nr_r~~~2J R3B07 t.tv 14.3K R3BOB 1" 820 2"

A PHOTOFACT TANDARD S NOTATION SCHEMATIC WITH

©2001 ~

IlL

R3B16 27K

';'i,II'Mb

1 L

Technical Publishing

4~i

~~. ~ 33.7V
61

....

57

58

59

60

62

63

64

Page 4

SET 4474

G
MAIN TUNER SCHEMATIC continued
Pin No. US01
1

MAIN TUNER VOLTAGE CHART

-)

VHF Low Band

VHF High Band

UHF Band

Pin No. Q101

VHF Low Band

VHF High Band

UHF Band

2 3
U701
VHF/UHF MIXER

5 6
7

8 9
10

11
12 13 14

SEE U3101 PIN 33 PAGE 4A

1.8V 1.8V 1.8V 3.3V 3.3V 3.3V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7V 4.7Y 4.7V 12.2V .IV I2.0V OV OV OV 12.1V 12.IV .IV 12.3V 12.3V I2.3V 5.0V 5.0V 5.0V 1.9V 1.9V 1.9V 1.9V 1.9V 1.9V OV OV OV DO NOT MEASURE DC VOLTAOE

G1 02 D S

1.7V 3.3V 10.7V OV

1.7V 3.3V 10.7V OV

OV 3.3V OV OV

Q301
01 02 D S OV .5V OV OV OV .5V OV OV 4.1V 7.4V 10.6V 5.1V

QS01
E B C 12.0V 12.2V -11.9V l2.0V .IV 12.0V 12.0V 12.0V -11.9V

U701
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 8.IV 8.IV OV 4.1 V 4.IV 3.7V 3.7V 12.0V 12.0V 12.0V OV 2.8V 4.8V 4.9V 2.8V 2.8V 8.0V 8.0V 2.8V OV 8.1V 8.IV OV 4.1 V 4.1 V 3.7V 3.7V l2.0V 12.0V 12.0V OV 2.8V 4.8V 4.9V 2.8V 2.8V 8.0V 8.0V 2.8V OV 8.1V 8.1V OV 3.6V 3.6V 4.0V 4.0V I1.7V 11.7V 11.7V 4.2V 2.8V 7.9V 7.9V 2.8V 2.8V 4.2V 4.7V 2.8V OV

QS06
E B C 12.0V -4.3V 12.0V 12.0V -4.3V 12.0V 12.0V -4.3V 11.7V

QS07
E B C 12.0V 12.1V -2.5V l2.0V 12.IV -2.5V 11.7V .IV 11.5V

o c
r"TI N

s:::

m
W

QS08
E B C I2.0V -2.5V I1.9V l2.0V -2.5V 11.9V 11.7V 11.5V -11.8V

.......
W
Q

SCHEMATIC NOTES
~
..

en
"TI

s::: ....... '0

Circuitry not used in some versions.

Circuitry Ground Chonia Common Token ground tIe poInt common tie point Voltage source tle used in some versions.

17
18 19 20
pornL
lines.

nJn V

NOTE: VHF Low Band voltages taken on channel 2. VHF High Band voltages taken on channel 7. UHF Band voltages taken on channel14.

1:;
en en
(') (')

:::J:

II
A"'--"-----"1.,-11 ~(VHF) 4.2V(UHF)

l::.

from

Schematlc CablIng:

;;M4'''ffl!#i\.i
Heovy lines reduce

-I

use of multrpla

Waveforms and voltages are token from ground~ unless otharwlse noted. Woyeforma taken with triggered scope and colorbar signal. Woveform voltage is peak to peak. T1mebose Is per division. Wovelorma shown at 10 divisIons. Supply voltages maintaIned as seen at Input. Voltages measured with digital meter and a 1000pV RF signal. with colorbar pottern applIed to antenna termInal, Controls adjusted for normal operation. Capocitors are 50 volts or Ie... 5" or greater unl.... noted. ElectrolytIc capocltars are 50 Yolts or less. 20" or gneater unless noted. ResIstors are 1j2W or le.s. 5" or greater unl.... noted.

....... .......

s::: -

CD (')

Value in ( ) used in some versions.

Measurements Rated voltage

with switchIng as shown shown an zener dIodes.

unless

neted,

A PHOTOFACT STANDARD NOTATION SCHEMATIC

WITH
@mll ~

';;@i)iffl!#i\.i

Technical Pubnshlng

65

66

67

68

1
SET 4474 Page 4

Page 5 SET 4474 -,

A PIP TUNER/IF SCHEMATIC

~i~ ~B01~---R-l-06~~ir-------------------------------------------------------------------------------. PAGE4E

A·
1500

-I
L301 L302

C202~ •011 C112rr .001 CR307

100

R30B lOOK C307 C306 12pF NPO R307 51K 2% R311 100 2~~6 r

b
ov
R306 82K 2%

0301 UHF AMP

Rf.~1

C310 .75pF NPO

B
C124 470pF NPO R121 1500

W
R316 47K R319 47K

5V G2 L.'i"'\. D OV{VHF) I~ HF Gl .14ll 10.3V{UHF) L303 \, -S OV{VHF) 4.0V{UHF) 4.9V{UHF) ~1~ R309 91 2%

L3041

i~
A •

L305 C312 lBpF N220

C~

"'L--_1f-----------NPO

C313 470pF

CR304(~ ~20 ~~~~ 11 NPO R312 C311 47K 27pF 1 N750 CR306,=~ \:~ 47K R314 lOOK L307 C314 470pF NPO

.VCC
-I
5.0V

c.

C505 39pF NPO '--_--:,.JXTAL 2 3 4.7V R501 r-r-__ ~10",0 ... 0 --:-I OATA 4 4.7V

r~'-f
Y501 4MHz
ur-:

f13 GND
2 3.3V

-12.OV R516 6BOO 2% -12.0V C113 001 • 1

R51B 100 C125 10~~6

XTAL 1

*
I

~~8ri .OV 5 PD~--~--~~~----1~.8~V4·~~~

1.8'1 1

Q502 Cr-iURRENT SO.URCE

\..:::=

.-f )

r-

GpCRl13

fi
r---11 FL101 1 13

Rl03 47K

R104 47K

R318 470 2% '-----R-12-6~

.001l C30B 120pF NPO

R317 91 2%

lOOK Cl0B :h .0011 Rl07 470K Cl0S 2%. .001 Cl17 Cl02 1~~ .001 CR101~~ L104

•. 1
-

R113 47K C114 .0011 K Ll07 L109 4-------, PARTOF l~A~Rl07 Ll0B Ll10 ~DCR106 PARTOF Ll0B Rl22 [ K • C115 ~ 150pF L111 NPO CllB 18~~6 R115 47K R116 47K

R313 R409 R204 47K 47K 47K C204 .0047

RB364 300K

Rl08 0101 VHF AMP 39 2.3V G2 ~ L7VO~~U;F; ~

CR105 (~

_SOURCE

D 10.7V{VHF)

'p

I
9

I (91K) ::!: C8352

.022 22

ClIO NPO R302

R12{ C119 .001

.: 33.7V R50S C507 R512

0503 '--

~g~~~~ 4-_;4¥70~O~_1. f-~------------...:~¥~&-K------..,... I

+tor
R510 0504 SWITCH 191K 1:1:

~ 01.
-12.OV

C508± .0047

=. r
T-B

I I I L __
2

S OV (UHF) ;t-~--3-9IP!-F---E----------<l-....;~,.--...,r-----------~lE-!;L112

L1,13

I I I
J R8374 300K (91K)

F +----,

Ll06

SOURCE

Rl02 1200 2%

CR103(D

L10S...

Cl07 .001

:hI

CRl12~'

47K R408 47K R203 47K

(~

(~CR108

,p
I--

Ub~

R502 r-l.",O"'OO

-I

-=-I CLK 5 4.7V .... UO~-,~--------------------------1r{ ... 14 """'--;;;;.NOT MEASURE DC VOLTAGE

o 6.2V{CH.6) R508
4700 R507 4700

R509 COO9 1M 1% •0011

1
R8356 2000

R8373~ 68K 1CB~~~:!: (27K) .022 r

37AK R51~i

Rl05 1BOO

Cl0S .001

b
r

Rl09 150 2%

r=«

1%

RB372 27K

!.~
BUFFER PARTOF U8350

Cl03 .001

L1
...

B.2

L-

R124 ._~~_~1I1,,14~---~1I1,,15'----~22~~~~ R114 1200 2%

C203["" .0047 ~ R8369 Rl12~ 300K 1200 (91K) 2% BUFFER PARTOF U8350 1.3V~ 12 + RB368 >~2~8<!.V--~--__,.----..,..._;6~B~K.,_; 14 ... CB353 +'R836~f R836~1 C8354 lOOK 27K (27K) .003_3--+ ..:.1 __ __ %::.J .022 r R119 100 .001 T ....

1~
~

C121 .001

U8302 EEPROM

R118 1800

o·

VOO 4.BV B

SDA 4.7V 5 RB317 100

SCL 4.7V A2

Al

A2

VSS

TEST

C502

W~6~

J:

-I

CB304 .1~

::!:

r---

RB316 10K ••
p---~:

C503 1~~6l

SEE Q3102 COLLECTOR PAGE4B

SEE Q310B EMITTER PAGE4C

SEE U3103 PIN 2 PAGE 4C

r...____.

RB353 10K 1%

[iE»-E~..,,5!!.V-1~R~'Y:l~&~-5-1 RB371 lOOK 1%

I,.
RB351 \~ ~~~ 1%

Cl16 .001

+R8370 15.8K

~ 13 ..

08302 SWITCH
4.1V_f? RB332 4700 R833~! 4700L

C8309 .001 ~ 5.0V RB320 2000 R8315 1000 RB318 1000

R8328 100

C8307 1~~6 ~

RB326 100

CB308 1~~6 ~

R8327 100

ADDITIONALCHEMATIC S NOTES,SEE PAGE 4G A PHOTOFACTTANDARD OTATION S N SCHEMATIC WITH

©.2001 ~

i;M4i"lMiid

08351 REF 08350 ::FFER

l____t;::oIl7V ~.' R8357 R8354 26.1K 1%

Technical Publishing

E
18 OV mrl'WR

(~:ti~f
'. 5.OV

ti
73

RB365 15.8K 1%

BUFFER PARTOF U8350 11~ ~>-~~C'B,,"V 6 GND 11.1 ~

R8363 (2_~_~K-i) R8362 27K

~~~::~-----t----_'----------------------------------------------1I__;~F-~,~~v~~~J
l1V ). R8g~~ ~ 1 CB35 .0033

~1
.

RB361 lOOK 1:1:

R8307 1000 1

RB304 1000 16 4.6V SCK

R8305 1000 15 4.7V SOlO

mrms
PARTOF

19 4.8'1

10 4.7V PAl

11 4.7V PAl

PM P~

PC3

PC5

PA7 PAS

DAD

32 IN 0A3

1.0V 14.3K R84535B31 I%~.· 1% .: 33.7V

!I. 33.7V

r:'I

R8352 26.1K 1% 34 .BV

RB303 --, 22K: CI!:!IQ~:!:: 2% •00681 27 VCO 26 Rl

R8350 26.1K 1:1: 33 .8'1

.J..

O~

OM

U8301 PIP MICRO

69

70

71

72

74

75

76

77

78

79

80

81

82

83

84

E
VIDEO SWITCHING/PIP SCHEMATIC

A·

SEE 06503 EMITTER PAGE 28

-_-::-tIN

3.BV PIP Y 2.1V

-l

-l
4 2.2'1
....---E---::-IIN 2 3 3.6V COMP VI02

5.6V

U8202
SRAM

U8201
PIP PROCESSOR

c·
C CONTROL 3.7V 1B

PIP 2.1V CB223 .01

1-

~6~~i8~--._-------~~--~~-~~-~
PAGE 48 ~~j~~OB POR 5.3V ~~ ~ __ ~~ __ ~ PAGE

PWR BUS 5.6V

39
5.6V R8215

I
e-

-l

4C

CLElCK 4.6V DATA 4.7V

SEE U3103 PIN 2 PAGE 4C

C820B .1

D'

y CONTROL 4.1v SEE 03109 EMmER PAGE 48 INSERT OV

cv

-l

SEE 03311 EMITTER ----------PAGE 4A

SEE U2001 PIN 29 PAGE 2A

SEE 04501 EMITTER PAGE 4A

CB20S 100pF NPO

E
AOOITIONAL SCHEMATIC NOTES. SEE PAGE 4G

A PHOTOFACT STANDARD

NOTATION SCHEMATIC

WITH
©2001 ~

';hl§'i11@!f#@
Tochnlcal publrshlng

PART

U8301

OF

PIP

MICRO

85

86

87

88

89

90

91

92

l Page 5

Page 5

SET 4474

SET 4474

G
VIDEO SWITCHING/PIP SCHEMATIC
P8oo4/J2004

H
continued

H>;-+

SEE 04501

~~~r~------i~~~r-~~~

02514

TEMP COMP

02516

GROUND SEP

02506

DELAY EO

02513

AMP

U2501
PROCESSOR

LUMA

:s::: o c
9.OV C2809 680pf

02801
2.9V

m -n w
02803
BUffER

.ORIVER 4.9V 2.3V R2807 1000 2" R2806 1200 2"

02802

DRIVER

NPO

;--""'\.-.,---11---

R2B08 3.3

C802 .001

..., ......
TO U2001 PIN 51 PAGE 2C

w o en aI -n

5.6V

5.6V

7.6V

7.6V C2BOl 15pf NPO R2801 1200 2" R2809 390 2"

7.6V

n :J:
~ en

:s::: ......

en
02510
SVt,1 LEVEL CQ

(')

..... (')
(')

7.6V ~~jnO{;07_---"AIVPAGE 2f __

-"-'--H

:s:::

...... ......

SEE U5001

7 ~l~E

CR4721

2E

--------""Wi-----I4-_,.------_;_;-;;;71
CR4723

12.4V

SEE U3103 PIN 2 PAGE 4C SEE U3103 PIN 4 PACE 4C SEE 03102 COLLECTOR PAGE 48 SEE 0802 BASE PAGE 4E

A PHOTOfACT STANDARD NOTATION SCHEMATIC WITH ©2001 ~

Gfifitli'lffi#G
Techn;"o'

Pub,tsh1ng

02518

SVM

LEVEL

SEE 04402 ~2!;kE~10R

---o---"'M

__ ~-""'-'--jH"

93

94

95

96

97

98

99

100

l SET 4474 PageS

Page 6

-,

SET 4474

Hh
A·
SEE U2001 PIN 5 PAGE 2B Cl602

J2oo3/P

1003

AUDIO SCHEMATIC
L IN1 4.BY

U1402

SEE U1503 PIN 14 PAGE 6E

SEE U3103 PIN 4 PAGE 4C NC

SEE U1503 PIN 10 PAGE 6E

--I

SEE U3103 PIN 2 PAGE 4C

--I
GND

1-:4

---,

U1504

c.

TONE/VOL/BAL

--I

~nJ1 ~HEADPHONE

SEE U6501

o·

~~E 12B

------1

...... N.----7)--_;;;;w;.--1---r-;F--4--;=i

Jl404 AUOIO 1L IN

--I

J1406 AUDIO 2L IN

J1407 AUDIO 2R IN

E
ADDITIONAL SCHEMATIC NOTES, SEE PAGE 4G A PHOTOFACT STANDARD NOTATION SCHEMATIC

SEE U3103 ~~E4~ SEE U3103 PIN 2 PAGE ~

--~------~------4r----~~--------~--~~~~
SOA 4.7V

SCL OV TREBLE 4.4V

6 C1555

WITH
©2001 ~

Gi§iI&4&

.0022

Technteol Publ10htng

101

102

103

104

105

106

107

108

C
AUDIO SCHEMATIC
continued

SET 4474

Page 6

C1723

__________________

~~L

IN
6.3V

__________________ -=1 R IN
56 S.3V

C1715 .01

U1702
SRS AUDIO

>==+.:,...+---_:.w.;.'------41---------------------------

~i~ 503 ~~
PAGE 6E

6.011

12.011 C1747 .47# l00V

6.011 R1746 4 6.011 LPI S.3V 6.0V

A PHOTOfACT STANDARD

PH

DETI 6.4V

;>~i7--~-------------------------------------------------------------------------------------~i~ ~1503
PAGE SE AODlTIONAL SCHEMATIC NOTES. SEE PAGE 4G NOTATION SCHEMATIC

WITH

'AifuMldb
116

© 2001 ~

Techn'icol Publishing

109

110

111

112

113

114

115

-,

E
U1503
TONE/VOL/BAL

AUDIO OUTPUT SCHEMATIC

Rl C1963 .33

F
SW1900

SEE U1402

A-

~l~El~

Ir,
o
1_4_NC 1 1

I'ffiXT SP ERS

. SEE U1402 PIN 11 . PAGE 6A

SEE U1700 PIN 1 PAGE 60

--I

SEE U1700 PIN 7 PAGE 60 1 SEE U1700 PIN 14 PAGE 60 NC~NC 1 #,tNC ~NC 114 NC

SEE U1700 PIN PAGE 60

NC

i_~NC

SEE U1700 PIN 7 PAGE 60

--I

SEE U1700 PIN 1 PAGE 60

100V

R3 11 4.5V

CR1900

c.

SEE

PAGE 3C

BASE

Q1411

Q1418
CR1420 CR1419

DRIVER

o·

SEE U3103 ~l~E 44C

__.--.:w'_--,-_;'W;'--;;;;i

E
ADDITIONAL SCHEMATIC NOTES. SEE PAGE 4G A PHOTOFACT STANDARD NOTATION SCHEMATIC

WITH
©2001 ~

';;.&'i1w.u
Technical

Publishing

117

118

119

120

121

122

123

124

Page 6

SET 4474

U2001

IC FUNCTIONS
U1503

a:

U1504 U2501 U501

U5001

15

..

U1702

.. ..
62 57

(')

;:a

.,
55

U4101

3:

f2 f.

o c
m

eo

..
6
L-

rL-__

-+
-+

.-

112

+-

~----._~.,

"TI

~f2

w N ~
W
C)

27

26 20

en
"TI

III

21
22

I.
1a

..
..
3D

3: .....

21

20

f.

2.

..
17

U2601 U1600

U6501

I. f. I.

.... .... _OCI'I.

lICe

..
1a

f. f7

U701

U8101 U8203

f2

11 f7

,.
•

LIN! RIN! LI .. RI .. L 1116 • 1116 ..... IX

Loun R ourl Lour. L 1M2 R 1M2 • our.

10

,.
ff f2 f• 1.

U2602

a:

U2603

LINt
R lH1 LI .. RI .. L 1N2 .1N2

21 7 f. 20
24

....
REF
lICe

2.

~L-

.....

22

SET 4474

Page 6

Page 7

SET 4474

SCHEMATIC COMPONENT LOCATION GUIDE

CI01 CI02 CI02 CI03 CI03 C104 C104 CI05 CI05 C106 C106 CI07 CI07 CI08 CI08 CliO ClIO C111 C1ll Cl12 C1l2 C1l3 Cl13 Cl14 Cl14 C1l5 Cl15 Cl16 Cl16 C1l7 C1l7 C1l8 C1l8 C1l9 C1l9 C120 C120 C121 Cl2l C122 C122 C124 C124 C125 C125 C201 C201 C202 C202 C203 C203 C204 C204 C205 C205A C206 C206A C207 C207A C208 C208A C301 C301 C302 C302 C304 C304 C305 C305 C306 C306 C307 C307 C308 C308 C309 COO C61 C73 061 073 C61 C73 C62 C74 C73 061 C62 C74 C62 C74 C63 C75 063 075 B61 B73 C7l 059 C63 C75 C76 064 064 076 C61 C73 C64 C76 C64 C76 C65 C77 064 076 065 077 BOO B72 C71 059 COO C73 B61 B73 063 075 C64 C76 A41 C36 C41 C41 A44 A44 C38 C38 B7l C59 B60 B72 B74 C62 B61 B73 B62 B74 B62 B74 B74 C62 B63 C309 C310 C310 C311 C3ll C312 C312 C313 C313 C314 C314 C316 C316 C401 C401 C407 C407 C410 C4ll C4ll C424 C424 C501 C501 C501A C502 C502 C503 C504 C504 C505 C505 C506 C506 C507 C507 C508 C508 C509 C509 C510 C510 C5ll C5ll C601 C601 C602 C602 C603 C603 C604 C604 C605 C605 C606 C606 C607 C607 C610 C610A C612 C612 C614 C614 C701 C701 C702 C702 C703 C703 C704 C704 C705 C705 C707 C707 B75 B63 B75 B75 C63 B64 B76 B64 B76 B64 B76 B71 C59 BOO B72 B71 C59 063 B71 C59 B71 C59 A41 E57 C36 069 E57 070 B71 C59 C69 057 C70 058 C70 058 C71 059 071 E59 B71 C59 B7l C59 B66 B78 A66 A78 B66 B79 B70 C58 B67 B79 B67 B79 A67 A79 C41 C41 A68 A80 B68 B80 B78 C66 C66 C78 B66 B78 B78 C66 B78 C66 C78 066 C708 C708 C709 C709 C710 C7!O C711 C7ll C712 C712 C713 C713 C714 C714 C715 C715 C716 C716 C717 C717 C719 C802 C803 C805 C806 C807 C808 C809 CI145 C1l46 CI400 CI401 CI404 CI405 CI406 CI407 CI408 CI412 CI428 CI429 CI430 CI431 CI432 CI433 CI434 C1436 CI437 CI440 CI441 CI442 CI443 CI444 CI445 CI446 C1464 CI465 CI470 CI471 C1472 CI473 CI474 CI475 CI476 CI477 C1478 CI479 CI480 CI522 CI523 CI525 CI529 CI530 CI531 CI532 CI533 CI534 C66 C78 066 078 066 078 066 078 C78 066 C66 C78 C78 066 B71 C59 A65 A77 A65 A77 0112 C95 B58 B57 C41 B58 B59 B59 A1l9 A1l9 AI03 AI03 0103 0103 EI03 EI03 0103 CI03 EI03 EI03 0103 0103 EI03 EI03 0103 AI03 AI03 AI13 AI13 BI13 BI13 A1l2 A1l4 B1l4 E1l8 EI18 0120 C43 0119 037 041 EI23 038 C44 BI03 CI03 CI03 0119 BII9 0107 0118 B1l9 B1l9 0106 0106 0107 CI535 CI536 CI537 CI538 CI541 CI543 CI544 CI550 CI551 CI552 CI553 CI554 CI555 CI556 CI557 CI558 CI559 CI560 CI561 CI562 CI563 CI601 CI602 CI603 CI604 CI605 CI606 CI607 CI608 CI609 CI610 CI6ll CI612 CI613 CI614 CI615 CI616 CI619 CI620 CI621 CI622 CI701 CI702 CI703 CI704 C1705 CI706 CI707 C1708 CI709 CI710 CI7ll CI712 CI713 CI714 CI7I5 CI7I6 CI7I7 CI7I8 CI720 CI721 CI722 CI723 CI724 CI733 C1736' C1737 CI739 C1740 CI742 CI743 C1744 CI745 C1746 CI747 CI748 0107 CI19 Cl19 0118 0106 0107 0107 0105 0105 EI05 EI05 EI06 EI06 CI05 CI06 EI05 EI05 CI06 0106 CI04 0104 BIOI AIOI CI02 CI02 CI02 CI02 CIOI BIOI 0102 0101 CIOI CI01 CIOI CI01 BI02 CIOI BI02 BI02 BIOI AIOI BI08 BI08 BllO CI09 Bill 0109 CI09 0109 B44 BllO CI09 BllO BllO BllO BI09 B109 ClIO ClIO 0109 Bill Clli Blli BllO C44 EI13 0113 E1l2 E110 0112 CllO C1l2 OlIO EI09 0110 0111 C1749 CI750 CI751 CI752 CI755 CI756 CI757 Cl758 CI759 CI760 CI761 CI762 CI763 C1764 CI765 CI766 CI770 CI771 CI773 CI774 Cl775 CI776 CI777 Cl779 CI780 CI781 Cl784 Cl785 CI907 CI908 CI917 CI918 CI923 C1933 CI960 CI961 CI962 CI963 CI964 CI965 CI966 C1967 CI968 CI969 CI970 CI980 CI981 C2201 C2202 C2203 C2302 C2303 C2304 C2305 C2306 C2307 C2308 C2309 C2310 C2311 C2312 C2313 C2314 C2315 C2316 C2317 C2501 C2502 C2503 C2504 C2505 C2506 C2507 C2508 C2509 C2510 Ell 1 0112 0111 0111 EI09 0109 Ell 1 BllO E110 EIlO CIl3 Cl13 C112 0113 0113 0112 BIl5 CIl5 AIl8 0118 0119 0115 A1l8 CIl6 0115 EIl3 BIl8 CIl8 036 036 CI22 0124 C123 0123 BI22 036 036 AI21 A121 A121 BI22 AI22 BI22 AI22 B122 AI21 BI21 B5 AS A4 C3 C3 C3 C3 B2 C3 C3 C2 C4 B1 B2 A4 C2 A2 B41 B41 041 041 B96 B96 B96 C94 B94 C99 E99 B95 C251l C2512 C2513 C2514 C2515 C2516 C2517 C2518 C2519 C2520 C2521 C2522 C2523 C2524 C2525 C2527 C2528 C2529 C2530 C2532 C2533 C2534 C2535 C2536 C2538 C2539 C2541 C2542 C2544 C2601 C2602 C2603 C2604 C2605 C2606 C2607 C2609 C2610 C2611 C2612 C2613 C2614 C2615 C2616 C2617 C2618 C2701 C2702 C2703 C2704 C2706 C2707 C2709 C2711 C2713 C2714 C2715 C2716 C2717 C2751 C2753 C2754 C2755 C2756 C2801 C2803 C2804 C2805 C2807 C2808 C2809 C2901 C2902 C2903 C2904 C2905 B96 098 A97 098 B99 C96 C99 096 096 096 B99 A98 B99 C99 C98 C99 A94 DlOO B99 B41 E97 C98 E97 E97 098 B98 ElOO BlOO CI5 B9 C9 B85 B85 B86 B44 B44 B41 C87 A87 B87 B41 A88 A86 A86 B86 C9 C4 BII BIO CI3 B41 B41 CI2 CIO B41 BII CIO B2 B2 CI4 CI2 CI2 Cll CI4 094 Bll CII CII CI3 CI3 C94 A15 AI4 CI5 CI4 BI5 C2906 C2907 C3100 C3101 C3102 C3103 C3104 C3106 C3107 C3108 C3109 C3110 C31l1 C3112 C3ll3 C3114 C3ll7 C3ll9 C3120 C3121 C3122 C3201 C3202 C3203 C3204 C3205 C3301 C3302 C3303 C3304 C3305 C3306 C3307 C3309 C3311 C3312 C3314 C3315 C3317 C3321 C3322 C3323 C3324 C3325 C3326 C3401 C3502 C3505 C3506 C3801 C3802 C3803 C3804 C3805 C3806 C3807 C3808 C3809 C4002 C4003 C4004 C4006 C4007 C4008 C4009 C4011 C4101 C4102 C4103 C4104 C4105 C4106 C4107 C4108 C4109 C4ll0 BI4 041 050 B53 051 C53 AS3 B51 C49 050 ASO A50 E44 E44 C4 E51 051 E50 E47 C53 E51 B47 C47 B47 B47 A47 A48 AI2 B48 A13 A48 BI2 049 C47 C48 B55 B48 B48 A51 047 046 A48 B48 A48 048 A45 E41 E41 E44 E64 E62 E61 C64 E63 061 A44 B49 B49 A29 A31 A31 A31 C32 A31 A31 ;\30 032 032 E32 032 E34 034 034 E32 E33 035 C4ll1 C4112 C4113 C4114 C4115 C4116 C4117 C4118 C4ll9 C4120 C4121 C4123 C4124 C4125 C4126 C4127 C4128 C4129 C4130 C4131 C4132 C4133 C4134 C4135 C4136 C4137 C4138 C4139 C4140 C4141 C4142 C4143 C4145 C4146 C4147 C4148 C4190 C4191 C4!93 C4194 C4195 C4196 C4197 C4198 C4199 C4201 C4202 C4301 C4302 C4303 C4304 C4305 C4306 C4307 C4308 C4309 C4310 C4352 C4353 C4354 C4402 C4403 C4405 C4406 C4407 C4408 C4409 C4410 C44ll C4412 C4413 C4414 C4415 C4416 C4418 C4419 035 C38 C34 B32 A42 A38 A38 B34 B33 B36 A36 B31 033 A34 A32 B32 B33 A41 A41 B40 A34 B34 B36 039 041 A42 A42 A43 A44 C38 B34 C41 A35 A34 A32 E32 B41 B41 C41 A44 C38 A41 C41 032 032 B29 B29 EI E5 E5 E5 E6 E6 E4 E6 E7 EI8 04 01 01 08 012 Dl2 013 013 EI9 EI9 013 012 011 011 010 012 012 E20 E20 C4502 C4504 C4505 C4506 C4507 C4551 C4552 C4601 C4602 C4603 C4604 C4606 C4607 C461l C4612 C4613 C4701 C4702 C4720 C4720A C4721 C472IA C4722 C4722A C4724 C4725 C4726 C4727 C4728 C4729 C4730 C4732 C4759 C4802 C4803 C4805 C4806 C4807 C4808 C4809 C4810 C48ll C4812 C4901 C4902 C4904 C4906 C5001 C5002 C5003 C5004 C5005 C5006 C5007 C5008 C5009 C5010 C5011 C5012 C5013 C5014 C5015 C5016 C5017 C5018 C5019 C5021 C5022 C5023 C5024 C5202 C5203 C5204 C5205 C5206 C5207 07 08 08 A36 A36 05 05 E36 E36 E36 E36 038 E44 E43 044 E44 C43 C44 E94 E8 E96 E7 E94 EI2 B38 B38 B38 EI3 EIO B38 Ell E93 014 EI7 E4 017 EI9 EI9 E2 E4 E3 E3 EI7 E2 E3 03 02 C44 B27 C27 A23 A22 A23 044 A20 A23 044 A25 C20 B23 AI9 B24 C20 C19 AI9 C21 B24 CI8 B21 019 E23 E21 E22 022 E22 E22 C5208 C5209 C5210 C521l C5212 C6201 C6203 C6501 C6502 C6503 C6504 C6505 C6507 C6508 C6511 C6512 C6513 C6514 C6515 C6516 C6517 C6518 C6519 C6520 C652I C6522 C8101 C8102 C8103 C8104 C8105 C8106 C8107 C8108 C8110 C8ll1 C8ll2 C8ll3 C8ll4 C8ll5 C8116 C8117 C8118 C8121 C8122 C8123 C8124 C8201 C8202 C8203 C8205 C8206 C8207 C8208 C8209 C8210 C821l C8212 C8213 C8214 C8215 C8216 C8220 C8221 C8222 C8223 C8224 C8225 C8226 C8227 C8229 C8230 C8231 C8232 C8233 C8234 E24 024 E23 E23 E24 E28 E27 A7 B7 A7 B5 C7 C86 C86 C7 B6 C6 A8 B44 C6 C6 C86 B5 B6 C6 C45 041 041 C36 C36 C80 C81 082 C82 081 E81 E82 E83 084 A82 A83 A81 A81 C41 C81 C81 C81 088 088 088 089 E92 B90 089 090 090 089 E89 E90 C89 C88 B87 A92 B91 090 C90 B91 B91 B91 B92 B92 B91 C88 B92 A92 C36 C8235 C8237 C8238 C8239 C8240 C8241 C8242 C8243 C8244 C8245 C8246 C8247 C8248 C8249 C8301 C8302 C8303 C8304 C8305 C8306 C8307 C8308 C8309 C8310 C8350 C8351 C8352 C8353 C8354 C8355 C8356 C8360 C8361 C8363 C8364 CF2201 CF8101 CF8102 CRIOI CRIOI CR102 CRI02 CRI03 CRI03 CRI04 CRI04 CRI05 CR105 CRI06 CRI06 CRI07 CRI07 CRI08 CRI08 CRI09 CR109 CRIIO CRIIO CRill CRill CRI12 CRI12 CRI13 CRI13 CR301 CR301 CR303 CR303 CR304 CR304 CR305 CR305 CR306 CR306 CR307 CR307 C36 C36 B90 B89 C92 092 C36 B91 C35 B36 B34 B35 C88 C88 E77 E77 E74 069 E88 E88 E70 E71 E70 E87 A44 E76 C76 074 075 073 C73 E79 E79 079 079 B3 B83 081 C61 C73 C61 C73 C61 C73 C61 C73 C63 C75 C75 063 C64 C76 C64 C76 C64 C76 064 076 B60 B72 C62 C74 COO C72 BOO B72 B61 B73 'B63 B75 B64 B76 B75 C63 B61 B73 CR501 CR501 CR601 CR601 CR602 CR602 CR701 CR701 CR702 CR702 CR703 CR703 CR803 CRI412 CRI413 CRI414 CRI415 CRI416 CRI417 CRI418 CRI419 CRI420 CRI601 CRI850 CRl900 CR1901 CRI903 CRI906 CRI907 CRI908 CRI909 CRI910 CR2201 CR2501 CR275I CR3101 CR3102 CR3103 CR3104 CR3105 CR3106 CR3107 CR3301 CR3302 CR3306 CR3307 CR3308 CR3401 CR3501 CR4001 CR4101 CR4102 CR4103 CR4105 CR4106 CR4107 CR4108 CR4109 CR4110 CR41l1 CR4112 CR4113 CR4114 CR41l5 CR41l6 CR4ll7 CR4118 CR4ll9 CR4120 CR4121 CR4126 CR4128 CR4129 CR4130 CR4131 CR4132 B71 C59 B66 B78 B67 B79 B78 C66 C78 066 C66 C78 B58 C43 0120 0119 038 040 029 029 0121 0121 BI02 CI20 CI23 CI23 0124 CI20 Cl2l BI21 Cl2l Cl2l B4 040 CI4 E37 052 E52 E37 A49 B49 A49 045 E47 AS2 045 045 A45 E40 A31 032 A35 034 E32 E31 035 C35 B34 A34 B33 A38 B38 B40 B33 A32 039 A42 A42 A43 A43 C37 A34 B39 C39 B30 032 CR4133 CR4201 CR4303 CR435I CR4401 CR4402 CR4403 CR4404 CR4405 CR4406 CR4408 CR4501 CR4502 CR4601 CR4602 CR4603 CR4604 CR4605 CR4611 CR4612 CR4701 CR4703 CR4704 CR4720 CR4720A CR4721 CR472IA CR4722 CR4723 CR4726 CR4727 CR4801 CR4802 CR4803 CR4804 CR4901 CR4902 CR5001 CR5002 CR5003 CR5004 CR5005 CR5006 CR5007 CR5008 CRSOO9 CR6201 CR6203 CR6204 CR6501 CR6502 CR6503 CR6504 CR6505 CR8203 CR8204 CR8205 CR8301 CR8302 OL2501 OL2601 OYI E702 E706 F4001 FB4101 FB4102 FB4103 FB4104 FB4105 FB4106 FB4107 FB4108 FB4109 FB4110 FB4lli 034 B29 E5 EI 012 012 Oil 011 EI9 E7 013 07 06 E36 E36 E36 E36 E43 E39 E43 C43 Ell Ell EI6 E9 E93 EIO E93 E93 B38 Ell E3 EI8 EI7 E4 E2 E2 E29 E29 A23 B25 C20 C23 A25 C21 B23 028 E26 E27 B7 B7 B7 C86 A8 C35 C35 C35 E86 087 A98 B85 09 A59 A60 A29 A32 A32 B32 035 035 C34 C35 B34 B34 B33 B34 FB41l2 FB4113 FB4114 FB41l5 FB4ll6 FB4401 FB4501 FB4701 FB4702 FB5201 FB5202 FB5203 FB8201 FB8202 FB8203 FB8204 FB8205 FB8206 FLIOI FLiOI IR3401 Jl J2 J801 J802 Jl404 Jl405 Jl406 Jl407 Jl410 Jl414 Jl415 Jl417 J6501 J6502 J6504 JC301 JC357 JW301 JW327 K4201 K4201 LIOI LlO2 Ll02 Ll03 LI03 LlO4 LI04 LI05 LI05 LI06 Ll06 LI07 Ll07 LlO8 LlO8 Ll08 Ll08 LlO9 LI09 LlIO LlIO Llli LIlI LlI2 Ll12 Ll13 LI13 L1l4 Ll14 LlI5 Ll15 LJOI L301 L302 A33 A34 B33 B34 032 E8 05 C43 C43 E23 E23 E24 B35 C36 C35 C88 B91 B91 COO C72 A45 0108 A6 B58 B58 0102 0102 EI02 EI02 0124 EI20 EI20 Dl24 A6 A6 A8 E78 E78 E83 C4 'A30 B29 C60 C61 C73 C61 C73 C61 C73 C61 C73 C62 C74 C63 C75 C63 C75 C75 063 C63 C75 C63 C75 C75 063 C64 C76 C64 C76 064 076 064 076 B61 B73 B61 L302 L303 L303 L304 L304 L305 L305 L306 L306 L307 L307 L308 L308 L601 L601 L602 L602 L603 L603 L604 L604 L701 L701 L702 L702 L703 L703 L704 L704 L801 Ll401 Ll402 LI701 LI702 LI703 L2201 L2301 L2302 L2303 L2304 L2305 L2501 L2502 L2503 L2504 L2505 L2506 L2507 L2601 L2602 L2603 L2604 L2605 L2606 L2607 L2608 L2609 L2701 L2702 L2705 L2901 L2902 L2903 L2904 L3101 L3301 L3302 L3303 L3304 L4OO1 L4002 L4101 L4102 L4103 L4104 L4105 B73 B63 B75 B63 B75 B63 B75 B64 B76 B64 B76 BOO B72 B66 B78 A67 A79 A67 A79 A68 A80 B78 C66 B78 C66 066 078 C78 066 BOO 040 C38 B42 B43 B42 B5 C3 B3 BI A2 B40 041 B96 B98 096 B98 C93 B96 B9 B85 C85 B42 B86 A86 C9 A88 B40 B40 B40 CIO AI4 CI4 BI4 040 E44 A48 B48 A48 048 A29 A29 A40 A43 C38 C40 C39 L4201 L4202 L4401 L4402 L4403 L4404 L4405 L5001 L5002 L5003 L5004 L5005 L5006 L5007 L5008 L6501 L6502 L8101 L8102 L8103 L8104 L8105 L8106 L8201 L8202 L8203 L8204 P4001 QIOI QIOI Q301 Q301 Q501 Q501 Q502 Q502 Q503 Q503 Q504 Q504 Q505 Q505 Q506 Q506 Q507 Q507 Q508 Q508 Q601 Q601 Q802 QI410 QI41l QI412 Q1413 QI414 QI415 QI416 QI417 QI418 QI419 Q1500 QI703 QI704 Q1705 Q1706 QI907 QI910 Q19ll QI912 Q2301 Q2302 Q2501 Q2502 Q2503 Q2504 A30 E27 E7 012 EI2 E20 012 B26 C21 C23 043 043 B25 020 C23 B42 C6 B80 A80 B83 B81 C35 C35 B91 B34 B91 C88 A29 C62 C74 B62 B74 B70 C58 C70 058 C70 058 070 E58 B70 C58 B70 C58 B70 C58 B70 C58 A67 A79 B58 0119 038 C43 038 EI20 0123 EI23 EI20 0121 0122 0106 CIl2 0112 Bill Bill BI21 CI20 CI20 BI21 C2 B4 C94 B96 C96 B100 Q2505 Q2506 Q2507 Q2508 Q2509 Q2510 Q2511 Q2512 Q2513 Q2514 Q2515 Q2516 Q2517 Q2518 Q2601 Q2602 Q2603 Q2604 Q2605 Q2701 Q2801 Q2802 Q2803 Q2901 Q2902 Q2903 Q2904 Q2905 Q2906 Q2907 Q2908 Q2909 Q2910 Q2912 Q2913 Q2914 Q3101 Q3102 Q3103 Q3104 Q3105 Q3106 Q3107 Q3108 Q3109 Q3200 Q3201 Q3301 Q3302 Q3303 Q3304 Q3306 Q3310 Q3311 Q3312 Q3501 Q3502 Q3503 Q3801 Q3802 Q4101 Q4102 Q4103 Q4104 Q4105 Q4106 Q4107 Q4108 Q4109 Q4110 Q4201 Q4301 Q4302 Q4401 Q4402 Q4501 A9 B93 E99 A98 B98 0100 B95 E98 B94 B94 A94 B93 B97 E100 A86 086 B88 A87 A88 CI2 C94 C94 C95 CI6 A15 AI6 BI6 CI5 CI6 C16 BI5 B16 BI6 AI7 C17 BI7 E49 E52 E46 E37 A52 052 049 053 E52 B47 B46 AI2 A13 Bll 046 C46 A51 046 045 E42 E41 E42 E61 E61 B31 E31 E31 A38 B40 A40 039 B52 B31 032 B29 E5 E5 E7 E20 E45 Q4502 Q4603 Q4701 Q4702 Q4703 Q4704 Q4705 Q4706 Q4707 Q4720 Q4721 Q4722 Q4723 Q4801 Q4802 Q4902 Q5001 Q5002 Q5003 Q5004 Q5005 Q5006 Q5007 Q5008 Q5009 Q5013 Q5014 Q5015 Q5016 Q5018 Q5021 Q5024 Q5028 Q5029 Q5030 Q5201 Q5202 Q5204 Q5205 Q5206 Q5207 Q6202 Q6502 Q6503 Q6504 Q8101 Q8102 Q8103 Q8104 Q8105 Q8106 Q8201 Q8202 Q8204 Q8205 Q8206 Q8207 Q8208 Q8209 Q8302 Q8350 Q8351 Q8401 R1 R2 RI01 RI01 RI02 RI02 RI03 RI03 R104 RI04 R105 R105 RI06 06 E43 EIO EIO Ell Ell EI2 EI2 Ell E94 E94 E95 E96 EI9 E3 02 A25 C20 B23 B25 A25 020 C20 C23 B23 B24 019 C21 018 B24 CI9 B21 A24 C20 B22 E21 E21 022 E22 023 E23 E26 A7 B8 C7 E83 083 A83 A83 E81 A80 088 088 B88 C88 B91 C93 A93 B91 E69 E73 E73 E85 016 E16 COO C73 C73 061 B73 C61 B73 C61 C73 061 A69

SET 4474 SCHEMATIC COMPONENT LOCATION GUIDE continued

RI07 RI07 RI08 RI08 RI09 RI09 RIll RIll R1l2 R1l2 RI13 RI13 R1l4 R114 RI15 RI15 R1l6 R116 RI17 Rll7 R1l8 R1l8 R1l9 RI19 RI20 RI20 RI21 RI21 RI22 RI22 RI23 RI23 RI24 RI24 RI26 RI26 R203 R203 R204 R204 R301 R30l R302 R302 R303 R303 R304 R304 R305 R305 R306 R306 R307 R307 R308 R308 R309 R309 R310 R310 R3ll R3ll R312 R312 R313 R313 R314 R314 R315 R315 R316 R316 R317 R317 R318 R318 C62 C74 C62 C74 C64 C76 B61 B73 063 075 B75 C63 064 076 C64 C76 C64 C76 C64 C76 064 076 063 075 B60 B72 B72 C60 063 075 C64 C76 064 076 C62 C74 C75 063 C64 C76 B63 B75 C63 C75 B60 B72 B60 B72 B61 B73 B62 B74 B62 B74 B62 B74 B62 B74 B63 B75 B62 B74 B75 C63 C64 C76 B75 C63 B72 C60 B61 B73 B62 B74 B74 C62 R319 R319 R320 R320 R402 R402 R408 R408 R409 R409 R501 R501 R502 R502 R503 R503 R504 R504 R505 R505 R506 R506 R507 R507 R508 R508 R509 R509 R510 R510 R5ll R5ll R512 R512 R513 R513 R514 R514 R515 R515 R516 R516 R517 R517 R518 R518 R60l R601 R602 R602 R603 R603 R604 R604 R605 R605 R606 R606 R609 R609 R610 R610 R701 R701 R702 R702 R704 R704 R705 R705 R706 R706 R707 R707 R708 R708 B61 B73 B64 B76 C60 C72 C63 C75 C64 C76 C69 E57 C69 E57 B70 C58 C70 058 C70 058 C70 058 071 E59 071 E59 071 E59 059 071 071 E59 C71 059 B70 C58 B70 C58 C71 059 C70 058 B71 C59 C71 059 A78 B66 B67 B79 B67 B79 A67 A79 A67 A79 B68 B80 B67 B79 A79 B67 065 077 065 077 C66 C78 B78 C66 C78 066 C78 066 C66 R709 R709 R807 R808 R821 R822 RI130 RI131 RI136 RI400 RI401 RI402 RI403 RI404 RI405 RI406 RI407 RI408 RI409 RI410 RI411 RI412 R1413 RI414 RI415 RI416 RI420 RI421 RI422 RI423 RI429 RI431 RI432 RI440 RI441 RI442 RI443 RI444 RI445 RI446 RI447 RI448 RI451 RI452 RI453 RI454 RI455 RI456 RI457 RI459 RI460 RI461 RI462 RI463 RI464 RI465 RI466 RI467 RI468 RI469 RI470 RI471 R1472 RI473 RI474 RI475 RI476 RI477 RI478 RI479 RI480 RI481 RI483 RI484 RI485 RI486 066 078 B58 B58 B58 B58 AI20 AI21 C38 AI03 0103 A103 EI03 AI03 EI03 0103 AI03 0103 0103 0103 0103 CI03 EI03 C43 EI03 038 A1l7 AI17 BI03 EI03 EI20 EI20 EI03 A1l2 AI13 AI13 A1l4 AI13 B113 AI12 AI12 B114 E1l8 EI18 0118 EI18 EI18 EI19 EI19 0119 0119 0120 0120 0120 038 038 E38 C43 038 038 E119 0121 EI23 EI23 0123 E119 EI19 0123 0123 EI19 EI03 EI03 0121 0121 EI23 0123 RI487 RI488 RI489 RI490 RI491 RI493 RI494 RI495 RI496 RI497 RI498 RI499 RI512 RI513 RI514 RI515 RI521 RI522 RI523 RI528 RI531 RI532 RI533 RI534 RI535 RI536 RI538 RI539 R1540 RI541 RI542 RI543 RI550 RI551 RI552 RI553 RI554 RI555 RI556 RI557 RI558 RI559 RI601 RI602 RI603 RI605 RI606 RI607 RI608 RI609 RI610 R1611 RI612 RI613 RI614 RI615 RI616 RI617 RI6l8 RI701 R1705 R1706 RI708 R1709 RI710 R1711 RI713 RI714 RI715 RI716 RI717 RI718 RI719 RI720 RI721 RI722 0119 0123 0121 EI23 C38 0123 0123 0121 0121 0121 0122 CI03 CI06 0106 0106 0106 0107 0107 0106 0106 0118 0118 0118 0118 0107 0107 CI19 0107 0107 0106 0106 BI19 CI04 0104 0106 EI06 EI05 EI05 EI04 EI04 CI05 CI05 0102 CI02 CI02 0101 CIOI CIOI CIOI AS AIOI AI02 AI02 BI02 BIOI BIOI AIOI AIOI 0102 BIll B110 B110 CI09 CI09 0109 RI724 RI726 RI728 RI729 RI730 RI732 RI733 RI734 RI735 R1736 RI738 R1739 R1740 RI741 RI742 RI743 R1744 RI745 RI746 RI747 RI748 RI749 RI755 RI757 RI758 RI759 RI760 RI761 RI762 RI763 RI764 RI767 RI768 RI769 R1770 RI771 R1772 RI773 R1774 RI775 RI776 RI777 RI778 RI779 RI780 RI781 RI782 RI783 RI784 RI785 RI786 R1787 RI788 RI789 RI790 RI791 RI792 RI875 RI902 RI904 RI909 RI910 RI911 RI912 RI913 RI914 RI915 RI916 RI942 RI947 RI948 RI949 RI950 RI951 RI952 RI953 EI13 0112 0113 CI13 B1l5 EI12 E1l2 C44 C44 RI954 RI955 RI956 RI957 RI958 RI959 RI979 RI980 RI981 RI982 RI983 RI984 RI986 RI987 RI992 RI993 RI994 RI995 RI996 R2201 R2202 R2203 R2204 R2301 R2302 R2304 R2305 R2307 R2308 R2309 R2310 R2311 R2312 R2313 R2314 R2315 R2316 R2317 R2318 R2319 R2320 R2321 R2S01 R2S02 R2S03 R2504 R2505 R2506 R2S07 R2S08 R2509 R2510 R25ll R2512 R2513 R2514 R2515 R2516 R2517 R2518 R2519 R2520 R252I R2522 R2523 R2524 R2525 R2526 R2527 R2528 R2529 R2530 R253I R2532 R2533 R2534 AI22 AI22 0123 BI22 BI22 BI22 BI21 BI21 BI21 CI24 BI21 CI24 AI21 BI22 CI20 CI20 Cl21 CI20 CI20 A3 A5 B5 A4 C3 A2 C3 C2 C2 C4 CI B4 B4 B5 B4 BI B2 B2 C4 C2 A68 CI B2 C94 B94 B96 A96 A96 B96 C97 C97 CIOO C99 B95 C% B99 B99 A98 A98 A98 R2535 R2536 R2537 R2538 R2539 R2540 R2541 R2542 R2543 R2544 R2545 R2546 R2547 R2548 R2549 R2550 R2551 R2552 R2553 R2554 R2555 R2556 R2557 R2558 R2559 R2560 R2561 R2562 R2563 R2564 R2565 R2566 R2567 R2568 R2569 R2570 R257I R2572 R2573 R2574 R2575 R2576 R2577 R2578 R2579 R2580 R2581 R2582 R2583 R2584 R2585 R2586 R2587 R2588 R2589 R2590 R259I R2592 R2593 R2595 R2596 R2597 . R2598 R2599 R2601 R2602 R2603 R2604 R2605 R2606 R2607 R2608 R2609 R2610 R2611 R2612 A94 A93 A94 C93 B94 R2613 R2614 R2615 R2616 R2617 R2618 R2619 R2620 R2622 R2623 R2624 R2626 R2627 R2628 R2629 R2630 R2631 R2632 R2701 R2702 R2703 R2705 R2706 R2707 R2708 R2712 R2713 R2714 R2715 R2716 R2717 R2718 R275I R2752 R2753 R2754 R2755 R2756 R2801 R2802 R2803 R2804 R2805 R2806 R2807 R2808 R2809 R2810 R28ll R2812 R2813 R2814 R2815 R2816 R2817 R2818 R2901 R2902 R2904 R2905 R2906 R2907 R2908 R2909 R29ll R2912 R2913 R2914 R2915 R2916 R2918 R2919 R2920 R2921 R2922 R2926 C86 C86 086 A86 A86 A87 A88 A88 B86 B86 C7 A87 A86 B86 C7 A88 C9 B9 CI2 CI3 C13 03 CIO CI2 C13 B2 B3 CIO CIO CIO B2 B3 CI4 CI3 04 CI2 CI2 CI2 094 Cll Cll CIO CIO C94 C94 C95 094 Cll CI3 C93 C94 C94 C95 C95 C95 C13 CI5 AI4 AI5 AI5 AI6 AI5 AI6 CI4 CI5 CI5 CI5 CI5 CI6 BI4 BI5 BI5 BI5 BI5 BI6 AI6 R2927 R2928 R2929 R2930 R293I R2932 R2933 R2934 R3101 R3102 R3103 R3104 R3105 R3106 R3107 R3108 R3109 R3110 R3ll1 R3ll2 R3ll3 R3ll4 R3ll5 R3ll6 R3ll8 R3ll9 R3120 R3121 R3122 R3123 R3124 R3125 R3126 R3127 R3128 R3129 R3130 R3131 R3132 R3135 R3137 R3138 R3138A R3140 R3141 R3143 R3144 R3145 R3146 R3147 R3148 R3149 R3150 R3151 R3201 R3202 R3203 R3204 R3205 R3206 R3207 R3208 R3210 R32ll R3212 R3213 R3301 R3302 R3303 R3304 R3305 R3306 R3307 R3308 R3309 R3310 AI7 AI7 CI6 CI7 Cl7 BI6 BI7 BI7 B53 B54 CSO A53 051 051 051 AS3 AS3 C53 AS2 E37 B51 050 C50 ASO C4 E50 E50 E47 E47 E47 E37 E37 C54 051 E51 E51 E51 E51 E52 C53 051 052 E50 E38 E38 052 051 E51 C51 C53 048 048 049 049 B47 C47 C47 B47 B47 B47 B47 A47 B47 B47 B46 A46 A48 All AI2 AI2 B48 AI3 AI3 AI4 A48 Bll R33ll R3312 R3313 R3315 R3316 R3317 R3318 R3319 R3320 R3321 R3322 R3323 R3324 R3325 R3326 R3327 R3328 R3329 R3330 R3331 R3332 R3333 R3334 R3335 R3336 R3338 R3341 R3342 R3343 R3344 R3353 R3354 R3355 R3356 R3357 R3358 R3359 R3360 R3361 R3362 R3364 R3365 R3366 R3367 R3368 R3369 R3370 R337I R3372 R3373 R3374 R3375 R3376 R3377 R3401 R3402 R3403 R3S01 R3502 R3S03 R3504 R3S05 R3506 R3S07 R3508 R3509 R3801 R3802 R3803 R3804 R3805 R3806 R3807 R3808 R3809 R3810 BII AI2 048 B13 045 047 047 047 E47 C46 047 C46 C53 048 048 B53 C54 054 C48 B54 C54 C55 055 B55 C55 054 B48 B48 C56 E55 ASI A51 A51 A52 AS2 B55 C54 C53 053 E52 052 053 E52 E52 AS2 047 047 045 045 045 046 046 046 047 A45. A46 A45 E40 E40 E42 E42 E42 E42 E40 A50 E42 E48 E63 E48 061 E48 E60 E61 E61 E61 E63 R3811 R3812 R3813 R3814 R3815 R3816 R3817 R3818 R3819 R3820 R3821 R3822 R3823 R3824 R3825 R3826 R3827 R3828 R3829 R3832 R3833 R4001 R4002 R4003 R4100 R4101 R4102 R4103 R4104 R4105 R4106 R4107 R4108 R4109 R4110 R4ll1 R4ll2 R4113 R4ll4 R4ll6 R4ll7 R4ll8 R4ll9 R4120 R4121 R4122 R4123 R4124 R4126 R4127 R4128 R4129 R4130 R4131 R4132 R4133 R4134 R4137 R4138 R4140 R4141 R4145 R4150 R4190 R4192 R4193 R4195 R4196 R4197 R4198 R4199 R4201 R4202 R4203 R4304 R4305 E64 E62 E62 E61 E61 E64 E64 C64 E63 E63 063 060 D60 C60 059 B48 B49 B48 B49 B48 B48 A30 A29 A31 B31 B31 B31 B30 032 D32 E34 E34 E34 034 034 034 D34 D34 . D34 E31 E31 E31 E31 E31 A38 C39 C41 B52 B40 B40 B40 A32 039 A43 C37 034 B52 A39 A40 A42 B32 C40 033 A43 D3 D2 B30 032 D33 033 C40 B29 B51 B51 E4 E5 R4306 R4307 R4308 R4309 R435I R4352 R4353 R4355 R4356 R4357 R4358 R4359 R4360 R4401 R4402 R4403 R4404 R4407 R4409 R4410 R44ll R4412 R4413 R4414 R4415 R4416 R4501 R4502 R4503 R4504 R4S05 R4507 R4508 R4509 R4510 R45ll R4512 R4516 R4518 R4519 R459I R4609 R4610 R4700 R4703 R4712 R4715 R4716 R4717 R4718 R4719 R4720 R4720A R4721 R472IA R4722 R4722A R4723 R4723A R4724 R4724A R4725 R4725A R4726 R4726A R4727 R4727A R4728 R4729 R4729A R4730 R4730A R473I R4731A R4732 R4732A E5 E6 E6 E5 EI EI EI 04 E4 05 01 EI 01 E7 011 012 E7 013 E21 E21 E20 E20 E20 E20 E20 E20 08 06 E45 E45 E45 08 06 06 05 A35 05 06 06 06 03 E43 E44 016 E28 E8 E7 E7 E9 E8 E9 E94 E9 E93 EIO E94 EIO E94 EIO E94 Ell E94 Ell E94 Ell E95 EI2 E95 E95 EI2 E95 011 E95 B38 E96 B38 R4733 R4733A R4734 R4735 R4736 R4737 R4738 R4739 R4740 R4741 R4742 R4785 R4790 R479I R4792 R4793 R4795 R4803 R4805 R4806 R4807 R4810 R48ll R4812 R4813 R4814 R4815 R4816 R4817 R4851 R4901 R4903 R4904 R4905 R4906 R4907 R4908 R4909 R4910 R4912 R5OO1 R5OO2 R5OO3 R5004 R5OO5 R5OO6 R5OO7 R5OO8 R5009 R5010 R50ll RSOl2 R5013 RSOl4 R5015 R5016 R5017 R5018 R50l9 R5020 R5021 R5022 R5023 R5024 R5025 R5026 R5027 R5029 R5031 R5032 R5033 R5034 R5035 R5036 R5037 R5038 E96 B38 EI3 E93 E93 E94 EI3 E8 EI2 Ell EI2 015 E4 CI4 CI3 E4 E4 04 EI7 EI7 EI7 EI9 EI7 EI9 EI8 017 E3 E3 E3 04 E2 E2 02 E2 02 E2 03 E2 02 E2 AI9 A20 AI9 B25 C21 C23 B25 D20 C23 A25 C20 B23 A24 B24 CI9 CI9 B22 B22 AI9 A22 A22 A20 A23 AI9 B25 C20 C20 C23 A24 C20 B22 C44 B27 B27 C27 A24 R5039 R5040 R5041 R5042 R5043 R5044 R5045 R5046 R5047 R5048 R5049 R5050 R5051 R5052 R5053 R5054 R5055 R5056 R5058 R5060 R5063 R5068 R5069 R5070 RS072 R5073 R5079 R5083 R5084 R5085 R5086 R5087 R5088 R5089 R5201 R5202 R5203 R5204 R5205 R5207 R5208 R5210 R5211 R5213 R5214 R5215 R5216 R5217 R5218 R5219 R5220 R5221 R5222 R5224 RS225 R56ll R5613 R5636 R6204 R6205 R6206 R6207 R6208 R6209 R6301 R6302 R6303 R6304 R6309 R6501 R6S02 R6503 R6504 R6505 R6S06 R6S07 CI9 B22 B25 C20 C23 A25 C21 B23 B20 018 018 B24 A20 019 B24 B24 CI9 018 B21 CI8 CI9 C21 019 B21 B24 B21 044 A24 A24 CI9 B20 B22 B22 B27 E21 E21 E21 E21 E22 E21 E22 E22 022 023 E23 024 024 E24 E22 E22 E22 E23 E23 023 E23 C85 C85 B6 £26 E26 026 E25 E25 027 0107 0107 0102 A6 A6 A6 A7 B7 A6 B7 B7 A7 R6S08 R6509 R6510 R6515 R6516 R652I R6522 R6523 R6524 R6525 R6526 R6527 R6528 R6529 R653I R6532 R6533 R6535 R6536 R6537 R6539 R6540 R654I R6543 R6544 R6545 R6546 R6548 R8101 R8102 R8103 R8104 R8105 R8106 R8107 R8108 R8109 R8110 R8111 R8112 R8113 R8114 R8ll5 R8116 R8117 R8118 R8119 R8120 R8121 R8122 R8123 R8124 R8125 R8126 R8127 R8128 R8129 R8130 R8131 R8132 R8133 R8134 R8135 R8136 R8137 R8138 R8139 R8140 R8201 R8202 R8203 R8204 R8205 R8206 R8207 R8208 A7 B7 B5 C86 C85 B8 A8 B8 B8 B8 A8 A8 C7 B7 C8 B8 C7 C7 C7 C6 B6 C6 B6 B6 B6 C6 C6 C45 C81 C81 B81 082 E82 E82 C40 C82 A80 D83 083 E81 082 C82 E81 E81 E81 E82 E83 E83 083 083 A83 A83 A83 A83 A84 A84 A81 083 A81 081 C40 A80 A80 081 D82 A80 C81 040 D87 E88 E88 E88 B34 C89 C88 B91 R8209 R8210 R82ll R8212 R8213 R8214 R8215 R8216 R8217 R8218 R8219 R8220 R8224 R8225 R8226 R8227 R8229 R8230 R8231 R8232 R8233 R8234 R8235 R8236 R8237 R8238 R8239 R8240 R8241 R8244 R8245 R8246 R8247 R8249 R8250 R8251 R8252 R8253 R8254 R8256 R8257 R8258 R8262 R8301 R8302 R8303 R8304 R8305 R8306 R8307 R8308 R8309 R8310 R8315 R8316 R8317 R8318 R8319 R8320 R8321 R8323 R8324 R8325 R8326 R8327 R8328 R8329 R8331 R8332 R8350 R8351 R8352 R8353 R8354 R8355 R8356 089 C88 088 C89 089 D89 090 090 089 E90 090 B87 B88 B88 B88 B91 B91 C88 C88 C88 C88 B92 B92 C93 C93 C93 B91 C87 B88 C93 A93 A92 A92 A93 Cll E89 E92 B92 088 C89 B90 091 A91 E77 E75 E74 E70 E71 E86 E70 E78 E89 E86 E69 069 069 E70 070 E69 E87 E70 E86 E86 E70 E71 E70 087 E69 E69 E75 E75 E74 073 E72 072 071 R8357 R8358 R8359 R8360 R8361 R8362 R8363 R8364 R8365 R8366 R8367 R8368 R8369 R8370 R8371 R8372 R8373 R8374 R8375 R8376 R8377 R8378 R8381 R8382 R8384 R8385 R8401 R8402 RN4501 RT4201 SF2301 SF2302 SF8101 SF8102 SPI SP2 SW801 SWI900 SW3410 SW3411 SW3420 SW3421 SW3430 SW343I SW4401 SW6201 SW6202 T801 T4101 T4102 T4103 T4301 T4401 T4401 T4601 T4701 U501 U501 U701 U701 UI402 Ul403 Ul404 Ul405 Ul406 UI503 U1504 UI505 UI505 Ul600 UI700 UI700 Ul700 UI700 UI702 UI710 E73 E73 E73 E75 E76 E76 E76 C76 074 074 075 D75 D75 E73 073 072 C72 C72 E79 079 E79 079 E79 E79 079 079 E85 E86 06 A30 BI Al A80 B80 AI24 AI24 B59 AI23 C46 B45 B46 B46 B46 B46 011 E26 E26 B59 A33 C31 031 E6 C42 014 E35 EI3 B69 C57 A77 B65 AI04 AI13 E1l8 0122 0120 AI18 CI05 CI06 0106 A102 B1l4 CI14 C1l5 0114 ClIO EI13 UI910 Ul913 U2OO1 U2OO1 U2OO1 U2OO1 U2501 U2502 U2601 U2602 U2603 U3101 U3102 U3103 U3801 U3801 U3801 U3801 U4101 U4102 U4501 U4601 U4701 U4701 U4701 U4701 U4801

Page 7

sioo
B99 B94 E98 098 098 E99 E99 E98 E99 E99

cuo

cno

eva

EI09 C111 BIIO C1l3 CI12 C112 CI12 0112 B1l4 B115

BIll EllO EllO EllO EllO EI09 0109 B1l5 E111 0110 ClIO E1l2 E1l2 BI08 EI09 0111 EIll 0111 BI08 C116 B1l8 C1l8 0113 0112 C1l4 C1l4 C1l5 C1l5 0118 CI14 C1l4 C1l5 Cll3 0115 0115 B1l4 B1l4 B114 B114 C1l3 C1l3 E1l2 E1l2 C1l4 C1l3 C1l3 E1l3 CI20 CI23 051 CI24 CI24 0124 0124 CI22 CI22 CI23 CI23 0123 Cl23 BI23 AI23 CI23 AI21 AI21 AI22

sioo sioo
B96 B96 A40 E96 E96 B95 B98 040 098 098 E97 E97 0100 0100 097 097 098 D98 C97 C97 E96 E96 E96 E96 E97 E98 A97 A97 E98 E97 B94 C94 B94 A94 A94 B97 B97 B98 B98

usooi

moo

U6501 U8101 U8201 U8202 U8203 U8204 U8301 U8301 U8302 U8350 U8350 U8350 U8350 VIOl Y501 Y501 Y2801 Y3101 Y4190 Y8101 Y8201 Y8301

CI23 AI21 A4 Bll B2 02 C98 E97 A85 B87 A87 C49 AS3 B54 059 060 062 E64 033 C37 07 E39 010 E7 E8 E9 EI7 A20 B6 A82 C90 C91 A92 B35 E69 E86 069 071 072 074 E76 B28 C69 057 Bll C50 03 B81 090 E77

moo

sroo
D96

C95 C98 C98 C98 096 096 096 B93 B93 A99 A98 A98 C99 A9 AIO 097

sioo
C96 C96

sroo
B9 B9 C9 B85 B85 B85 B85 B86 C86 B86 A86 B87

Important Parts Information

• The parts listed here are those not usually available from a well-stocked supply cabinet or bin. • Where items may be replaced with equivalent parts, several alternates are shown from participating vendors. • On the parts lists, safety items are marked with a # to remind you that only exact replacements are recommended for these items. • When ordering parts, state the model number, part number, and description.

Obtaining Parts
Many of these parts are available from your local sams authorized distributor or the manufacturer of the equipment. Sams for the name of your nearest distributor: Call

800-428-7267
Or consult the Sams Annual Index for the address of the original equipment manufacturer.

Participating Vendors
Information on test equipment and replacement parts is listed in these pages for the following participating vendors. Consult the Sams Annual Index for their current address. • NTE Electronics, Inc. (NTE) • Sencore, Inc.

Page 7

SET 4474

SET 4474

Page 7

PARTS LIST
Item No.
CRI0l CRI02 CRI03 CRI04 CRI05 CRI06,07 CRI08 CRI09 CR110 Thru CRIB CR301 CR303, 04, 05 CR306 CR307 CR501 CR601,02 CR701 CR702 CR703 CR1412 Thru CR1418 CR1419,20 CR1601 CR1850 CR1900,01 CR1903 CR1906 Thru CR1910 CR2201 CR2501 CR2752 CR3101 CR3102,03 CR3104 CR3105, 06, 07 CR3301, 02, 06 CR3307 CR3308 CR3401 CR3501 # CR4001 CR4101 CR4102 CR4103, 05, 06 CR4107,08 CR4109 CR4110 CR4111 CR4112 CR4113 CR4114 CR4115 CR4116 CR4117 CR4118,19 CR4120 CR4121, 26 CR4128 CR4129,30 CR4131 CR4132 CR4133 CR4201 CR4303,51 CR4401 CR4402 # CR4403,04 CR4405,06 CR4408 CR4501 CR4502 CR4601 Thru CR4604 CR4605,11 CR4612

Type No.

Mfr. Part No.

215493 211863 215493 227051 211863 215493 211863 215493 215493 215493 215492 215493 227082 215493 227051 215492 211863 215493 147015 223659 164717 227362 223659 227355 223659 227051 164717 229644 164717 223659 226783 215493 223659 226782 223659 198602 223659 214649 223338 227066 164717 164590 223339 164589 164590 218514 226504 164717 164590 214653 226782 176296 217306 164717 164590 147015 223651 176296 164717 164717 164717 227291 164589 176296 176296 140971 147015 164717 147015 164717 215488

Item No.
CR4701 CR4703 # CR4704 CR4720 CR4720A CR4721 (1) CR4721 (2) CR4721 A CR4722,23 CR4726 CR4727 CR4801 CR4802 CR4803,04 # CR4901 # CR4902 CRSOOl,02 CR5003 CRS004, 05, 06 CR5007, 08, 09 CR6201,03 CR6204 CR6501 Thru CR6504 CR6505 CR8203, 04, 05 CR8301,02 QI0l Q301 Q501 Q502 Q503 Q504 Q505 Thru Q508 Q601 Q1410 QI411, 12 Q1413 Thru Q1418 Q1419 Q1500 Q1703 Thru Q1706 Q1907, 10, 11, 12 Q2301 Q2302 Q2501 Q2502, 03, 04 Q2505 Q2506 Q2507 Q2508, 09, 10 Q2511 Q2512, 13 Q2514 Q2515 Q2516 Q2517 Q2518 Q2601 Q2602 Q2603 Q2604,05 Q2701 Q2801 Q2802 Q2803 Q2901 Q2902 Q2903,04 Q2905 Q2906, 07 Q2908 Q2909,10

Type No.

Mfr. Part No.

164589 164874 227379 176296 164874 176296 164717 164874 164717 215487 164874 164717 164717 157301 159429 140971 164717 139706 215487 176296 223694 215487 227362 164874 164874 226973 227008 219028 215495 215496 215495 219028 226981 215495 215496 215495 215496 177788 227814 215495 215495 215496 215496 215495 215496 215495 215496 215495 215496 215495 215496 215495 215496 215495 215496 215495 215496 215495 215496 215496 215495 215496 215495 215496 215495 215496 215495 215496 215495 215496

Item No.
Q2912, 13, 14 Q3101 Q3102,03 Q3104,05 Q3106 Thru Q3109 Q3200 Q3201 Q3301 Thru Q3304 Q3306 Q3310, 11 Q3312 Q3501 Q3502,03 Q4101 Q4102 Q4103 Q4104 Q4105 Q4106,07 Q4108 Q4109 Q4110 Q4201 Q4301 Q4302 Q4401 Q4402 Q4501 Q4502 Q4603 Q4701 Q4702,03 Q4704 Q4705, 06 Q4707,20 Q4721,22 Q4723 Q4801 Q4802 # Q4902 Q5001, 02, 03 Q5004 Q5005 Q5006 Q5007 Q5008 Q5009 Q5013, 14, 15 Q5016, 18 Q5021,24 Q5028, 29, 30 Q5201,02 Q5204 Q5205 Q5206 Q5207 Q6202 Q6502,03 Q6504 Q8101,02 Q8103 Thru Q8106 Q8201, 02, 04 Q8205 Thru Q8209 Q8302 Q8350,51 Q8401 USOI U701 U1402 UI403,04,05 U1406

Type No.

Mfr. Part No.

215496 215496 215495 215496 215495 215495 215496 215496 215496 215495 215496 215496 215495 214640 177789 223704 226975 157627 226975 215496 226971 226972 223704 223704 190482 227010 215495 215495 177788 223704 215496 215495 226453 215495 226453 215496 215495 214641 145395 147665 208434 226453 227406 226453 227406 226453 227406 215496 215495 215495 214644 215495 177788 177789 227405 227404 223704 215496 215495 215496 215495 215495 215496 215496 215495 215495 215533 227007 227345 223806 227357

;;0
(")

3: 0
C
W
N 0 ."

rW

......
."

»
3:
(")

en
OJ

:::t:

(")

3:
(")

(")

en
-I

en en

...... CQ

SET 4474

Page 7

PageS

SET 4474

PARTS LIST continued

Item No.
U1503,04 U1505 U1600 Ul700 U1702 U1710 U1910 Ul913 # mOO1 U2501 U2502 U2601 U2602,03 U3101 (3) U3102 (3) U3103 U4101 U4102 U4501 U4601 U4701 U4801 U5001 U6501 U8101 U8201 U8202 U8203 U8204 U8301 U8302 U8350

Type No.

Mfr. Part No.

227344 227342 225700 207827 227815 223806 227341 210911 226967 226968 226969 182321 227354

Item No.
C124 C125 C302 C305 C306 C307 C308 C309 C310 C311 C312 C313, 14 C401 C407, 11 C424 C502,03 C505 C602 C605 C607 C701 C702 C703 C704 C705 C707 C708 C709 C710 C711 C712 C1428,29 CI445,46 C1529,38 C1558,59 C1560,61 C1562,63 C1601,08 C161O, 14 C1621,22 C1713 CI724 C1736,37 C1773,77 C1965,66 C2306 C2310 C2314 C2503 C2506 C2507 C2516 C2519,20 C2522 C2528 C2530 C2535,36 C2539 C2541 C2601 C2602 C2604 C2614 C2615 C2616 C2617 C2618 C2714 C2715 C2716, 17 C2801 C2804

Function/RatingMfr.
470pF 5% 50V NPO 100pF 2% 50V NPO IOpF 2% 50V NPO 27pF 5% 50V N750 12pF 5% 50VNPO 27pF 5% 50V NPO 120pF 5% 50V NPO 27pF 5% 50V NPO .75pF ±.lpF 50V NPO 27pF 5% 50V N750 18pF 2% 50V N220 470pF 5% 50V NPO 27pF 5% 50V NPO 33pF 5% 50V NPO 100pF 5% 50V NPO IOpF 2% 50VNPO 39pF 5% 50V NPO 100pF 5% 50V NPO 330pF 5% 50V NPO 22pF 5% 50V NPO IpF ±.lpF 50V NPO 2pF ±.lpF 50V NPO 2pF ±.lpF 50V N750 IpF ±.lpF 50V NPO 27pF 5% 50V N750 IpF ±.lpF 50V NPO 3pF ±.lpF 50V NPO 68pF 10% 50V NPO 3pF ±.lpF 50V NPO IpF ±.lpF 50V NPO 3pF ±.lpF 50V NPO IOpF 5% 50V NPO IIlF 20% 100V NP IOpF 5% 50V NPO IOpF 5% 50V NPO IOIlF 20% 16V NP 4.71lF 20% 35V NP 4.71lF 20% 35V NP 4.71lF 20% 16V NP IOpF 5% 50V NPO 180pF 5% 50V NPO 220pF 5% 50V NPO 47pF 5% 50V NPO IOIlF 20% 16V NP 471lF 20% 10V NP .01 10% 50V 150pF 5% 50V NPO 470pF 5% 50V NPO .015% 50V 150pF 5% 50V 220pF 5% 50V NPO 18pF 2% 50V NPO 6pF ±.25pF 50V NPO 27pF 5% 50V NPO IOpF 5% 50V NPO 220pF 5% 50V NPO IOIlF 20% 16V NP 330pF 5% 50V NPO 10pF 5% 50V NPO 12pF 5% 50V NPO 300pF 5% 50V NPO 82pF 5% 50V NPO 43pF 5% 50V NPO 33pF 5% 50V NPO 200pF 5% 50V NPO 22pF 5% 50V NPO 8.2pF 2% 50V NPO 36pF 5% 50V NPO 5.6pF .25pF NPO 56pF 5% 50V NPO .0015 10% 50V 100pF 5% 50V NPO IOpF 5% 50VNPO 15pF 5% 50V NPO 18pF 2% 50V NPO

Part No.
214732 227089 214740 214760 214027 197604 194902 197604 227269 214760 227077 214732 197604 194911 193340 214740 202905 193340 205227 174406 227084 227074 226965 227084 214760 227084 227088 193339 227088 227084 227088 214740 218513 214740 214740 227017 224269 224269 228341 214740 190543 205551 210689 227017 227350 215555 181091 214732 215555 181091 205551 227075 227250 197604 214740 205551 227017 205227 214740 214027 220154 192049 214029 194911 218986 194903 227360 194911 227352 190542 197609 193340 214740 202907 227075

Notes

Item No.
C2809 C2901 C2902 C2903 C2904 C2905 C2906 C3101, 02, 03 C3107,08 C3114 C3119 C3301, 03, 05 C3307 C3311 C3323 Thru C3326 C3401 C3506 C4002 C4003,04 C4006 C4007 C4008,09 C4011 C4110, 13, 18 C4123 C4126 C4127 C4128,33 C4142,46 C4147 C4199 C4301 C4306 C4307 C4310 C4352 C4402 C4403 C440S

Function/RatingMfr.
680pF 5% 50V NPO 18pF 2% 50V NPO 5pF ±.5pF 50V NPO 18pF 2% 50V NPO 5pF ±.5pF 50V NPO 18pF 5% 50V NPO 5pF ±.5pF 50V NPO 22pF 5% 50V NPO 33pF 5% 50V NPO 22pF 5% 50V NPO 100pF 2% 50V NPO 7pF ±.5pF 50V NPO 15pF 5% 50VNPO 100pF 2% 50V NPO IOpF 1% 50V NPO .01 100v IOpF 1% 50V NPO 220pF 5% 50V NPO 470pF 10% l20VAC 680pF 20% lkV 820llF 10% 200V .00520% 120V 680pF 10% lkV .2220% 250VAC .1 20% 125VAC 470pF 10% 500V NPO 220pF 5% 50V NPO 470pF 10% 500V .0082 5% 600V 470pF 10% 500V NPO 470pF 10% 500V NPO 470pF 10% 500V 470pF 10% 500VNPO IOpF 5% 50VNPO 470pF 10% 500V NPO 100pF 5% 50V NPO 470pF 5% 50V NPO 47pF 5% 50V NPO 470pF 5% 2kV .0186 1.6kV .0565% 600V .0565%400V .0745% 250V IOIlF 50VNP .05610% 250V 680pF 5% 2kV 470pF 10% 500V .00281.6kV 180pF 5% 2kV .0022 20% 2kV 470pF 5% 50V NPO 100pF 2% 50V NPO IOOpF 2% 50V NPO 220pF 2% 50V NPO .0033 10% 3kV 68pF 5% 50V NPO 150pF 5% 50V NPO 56pF 5% 50V NPO 330pF 10% 50V NPO 100pF 5% 500V NPO 39pF 5% 50V NPO IOpF 5% 50V NPO 82pF 5% 50V NPO 220pF 5% 50V NPO IIlF 20% 100V NP IOpF 5% 50V NPO IOpF 5% 50V NPO IOpF 5% 50V NPO 100pF 5% 50V NPO 39pF 5% 50V NPO 15pF 5% 50V NPO 33pF 5% 50V NPO 27pF 5% 50V NPO IOpF 5% 50V NPO

Part No.
220344 227075 193917 227075 193917 174405 193917 194903 194911 194903 227089 192045 202907 227089 214740 214740 205551 250102 190538 190561 195697 190538 214067 229322 227050 205551 102230 214070 227050 227050 102230 227050 174402 227050 193340 214732 210689 227068 227021 200149 227080 227053 146158 227069 102230 227378 227375 227078 214732 227089 227089 205551 226300 145676 214032 214741 195922 227407 202905 214740 192049 205551 218513 174402 214740 174402 193340 202905 202907 194911 197604 214740

Notes

226976 226974 227012 215531 162394 223807 200420 227396 227343 227416 227426 204280 227425 215528 227415 227843 215534 215493 211863 215493 227051 211863 215493 211863 215493 215493 215492 215493 227082 215493 227051 215492 211863 215493 215493 226973 227008 219028 215495 215496 215495 219028 226981 219028 215495 227007 215533 215534

# # # #

# # #

MAINTUNER
CRI0l CRI02 CRI03 CRI04 CRI05 CRI06,07 CRI08 CRI09 Thru CRI13 CR301 CR303,04,05 CR306 CR307 CRSOI CR601,02 CR701 CR702 CR703 CR803 QI01 Q301 Q501 Q502 Q503 Q504 Q505 Thru Q508 Q601 Q802 Q3801, 02 U701 U501 U3801

# # #

# C4407
C4408 C4411, 12 C441S C4416 C4722A,27 C4730 # C47S9 C4808 C4811 C4812

# # # #

Item No.
CI04 ClIO C1l5 C117 C118

Function/RatingMfr.
330pF 5% 50V NPO 39pF 5% 50V NPO 150pF 5% 50V NPO 1.5pF ±.l pF 50V NPO 180pF 5% 50V NPO

Part No.
205227 181090 214032 223146 211039

Notes

C5003 C5011, 12, 13 C5015, 17, 19 C5021, 22, 23 C5204, 06 C5208 C6505 C6519,20 C6522 C8112 C8115 C8201 C8202 C8203 C8206 C8209 C8210 C8221 C8224 C8225

SET 4474

PageS

PARTS LIST continued

Item No.
C8226 C8227 C8230 C8231 C8238,42 C8243 C8248 C8249 C8301,02 C8307, 08, 10 CF2201 CF8101 CF8102 DL2501 DL2601 DYI (4) E706 F4001 FB4101,02 FB4103 FB4104 Thru FB4115 FB4116 FB4401 FB4501 FB4701,02 FB5201,02 FB5203 FB8201 Thru FB8206 FLlOI IR3401 11 J2 11404 11405 11406 11407 11410 11414 11415 11417 J6501 J6502 J6503 J6504 K4201 KS5001 LI02 LI03 LI04 LI05 LI06 LI07 LI08 LI09 L110 L111 L112 LI13 LI14 L115 L301 L302 L303 L304 L305 L306 L307 L308 L601,02 L603 L604 L701,02 L703

Function/RatingMfr.
56pF 5% 50V NPO 560pF 5% 50V NPO 27pF 5% 50V NPO IOpF 5% 50VNPO 100pF 5% 50V NPO 56pF 5% 50V NPO 470pF 5% 50V NPO 220pF 5% 50V NPO 56pF 5% 50V NPO IOpF 5% 50V NPO Filter Filter Filter Delay Line Delay Line Yoke Jack Fuse Ferrite Bead Ferrite Bead Ferrite Ferrite Ferrite Ferrite Ferrite Ferrite Ferrite Bead Bead Bead Bead Bead Bead Bead

Part No.
214741 200139 197604 214740 193340 214741 214732 178188 190542 214740 195702 181125 195702 227063 223169 RF Input 175425 154042 227067 154042 152103 229324 154042 226467 227410 226467 181470 218379 227334 227334 227816 227817 227816 227817 227816 227816 227817 227817 227818 227818 214607 227818 190490 228946 227003 227005 226992 227006 200559 226987 226998 226993 226994 226998 226995 227000 226996 227000 227427 226988 227005 226983 226984 226990 226991 226985 226999 227002 227001 226986 226989

Notes

Item No.
L704 L1401,02 LI701 LI702 LI703 L2201 L2301 L2302 L2303,04 L2305 L2501 L2502 L2503 L2504 L2505,06 L2507 L2601 L2602 L2603 L2604 L2605,06 L2607 L2608 L2609 L2701,02 L2705 L2901,02,03 L2904 L3101 L3301, 02, 03 L3304 L4001 L4002 L4101, 02, 03 L4104,05 L4201 (5) L4201 (6) L4202 L4401 L4402 L4403 L4404 L4405 LSOOl,02,03 L5004,05 L5006, 07, 08 L6501,02 L8101,02 L8103 L8104 L8105 L8106 L8201 L8202 L8203 L8204 P4001 R102 RI07 RI09 R112,14 R303 R306 R307 R309,17 R318 RS05 RS09 RSI0 RS11 RS12 R514 RS15 RS16 R605

Function/RatingMfr.
100J1H 100J1H 120J1H 100J1H 2.2J1H VCO IJlH 10J1H 100J1H 82JlH 12J1H 82J1H 10J1H 68J1H 33J1H 10J1H 18J1H 100J1H 56J1H 68J1H 10J1H 100J1H 10J1H 47J1H 10J1H 10J1H 10J1H 82J1H 56J1H Line Filter Line Filter 2.2J1H 27J1H Degaussing Degaussing Field Neutralization 2.2J1H 17.5J1H 320J1H 140J1H 17.5J1H 22JlH 10J1H 22J1H 100J1H IJlH 15JlH 1.8J1H 27J1H 100J1H 22J1H 47JlH 15J1H 68J1H Line Cord 12002% 1I10W 470K 2% 1I10W 1502% 1I10W 12002% 1I10W 30002% lIlOW 82K2% 1/l0W 51K2% 1/l0W 912% lIlOW 4702% 1I1OW 51K2% 1I10W 1M 1% 1I10W 191K 1% 1I10W 37.4K 1% 1/10W 20K2% 1I10W 68002% 1/l0W 220K 2% 1I10W 68002% lIlOW 4702% 1/l0W

Part No.
226996 160186 160186 227813 160186 227052 197616 227070 195709 175409 160186 215503 210687 215503 161243 149167 200161 161243 223800 161243 196107 149167 161243 160186 175409 195713 161243 175409 161243 227095 227093 227014 227283 143893 190017 214078 214167 225821 190480 210895 227059 227044 226458 195712 175409 195712 160186 195709 197613 227422 190017 160186 195712 190729 197613 149167 227065 194920 205381 205334 194920 194917 197906 ?05365 205330 194926 205365 215216 215214 215215 197904 194916 192093 194916 194926

Notes

Item No.
R609 R701 R704, 06 R708 R1403,05 R1406, 08, 10 R1422 R1429,31 R1441 R1493,94 R1558 R1601 R1602 RI605 R1606 R1607 R1610 R1611, 12 R1613 R1780 R1911 R1912 R1947 R1955,58 R2301 R2304 R2310, 11 R2315, 16 R2318 R2319 R2320 R2321 R2501,02 R2504 R2505 R2506 R2509,10 R2515 R2516 R2517 R2520 R2521 R2523 R2524 R2525 R2526 R2527 R2528 R2534 R2535 R2536 R2538 R2539 R2541 R2542 R2543 R2544

Function/RatingMfr.

Part No.

Notes

# # # # # # #

# #

Horiz .95rnH, Vert 25Mb 227055 5A,125V

# # # #

# #

Ferrite Bead Filter Receiver Jack Jack Jack Jack Jack Jack Jack Jack Jack Jack Jack Jack Jack Jack Relay Socket

High Pass IR Headphone AIV Input Audio 1 Left Input Audio 1 Right Input Audio 2 Left Input Audio 2 Right Input ID-FI Left Output Selected Left Output Selected Right Output ID-FJ Right Output Video Input 1 Video Input 2 S-Video Input Select Video Output Degaussing CRT

# #

# # # # # #

3.9J1H

AC, Polarized

R2545 R2546 R2547 R2548 R2549 R2550 R2552 # R2555 R2559 # R2560 R2561 R2562 R2563 R2567 R2568

51K 2% 1/10W 205365 75002% 1I10W 205348 51K 2% 1I10W 205365 1200 2% I/IOW 194920 2200 2% 1/4W Nonflammable 2200 2% 1I4W Nonflammable 1005% 1/4W 829110 10005% 1/4W 108865 1005% 1/4W 829110 10005% 1/4W 108865 1005% 1/4W 829110 43.2K 1% 1I1OW 225704 61.9K 1% I/IOW 225705 102% 1I10W 205308 33002% 1I10W 195938 30002% 1I10W 194917 22K2% 1/10W 205357 4702% 1I1OW 194926 13 5% 1/4W 829013 1005% 1/4W 829110 6800 2% 1I10W 194916 10K 2% 1110W 195937 335% 3W 227358 4.75% 1I4W 200197 8202% 1I10W 192088 1502% 1I10W 205334 10002% 1I10W 197638 lOOK 2% 1I10W 192094 15K 2% 1/8W 192835 2202% 1/10W 192089 4702% 1I10W 194926 4702% 1I8W 182628 4702% 1I10W 194926 2202% 1/10W 192089 6200 2% 1I10W 205347 18002% 1I10W 197903 51002% lIlOW 205345 6802% 1/4W 175312 10002% lIlOW 197638 1202%1I10W 205332 75002% lIlOW 205348 39002% 1I10W 197907 5602% lIlOW 205338 2702% 1I10W 197623 6802% 1I10W 195939 2702% 1I1OW 197623 4702% 1I1OW 194926 68002% 1I10W 194916 68002% 1I10W 194916 8200 2% 1I1OW 205349 68002% 1I10W 194916 8202% 1I1OW 192088 6202% 1I1OW 205339 82002% 1I10W 205349 102% 1I10W 205308 51K2% 1I8W 181062 75002% 1I10W 192097 47002% 1/10W 82002% 1I4W 175366 27K2% 1/8W 193061 22K2% 1/10W 205357 75002% 1I10W 205348 33K2% 1/8W 176813 10K 2% 1/10W 195937 15K 2% I/IOW 205354 1005% 1I4W 829110 10002% 1I10W 197638 25% 1I4W 181419 27K2% 1/10W 205245 36K2% 1/10W 205361 20K2% 1/10W 10002% 1I8W 190462 62002% 1I10W 205347 82005% 1/4W 175366 62002% 1/4W 179316

829222 829222

PARTS LIST
Item No.
R2569 R2570 R2571,72 R2573 R2576 R2580 R2584 R2586 R2587 R2588 R2589 R2590 R2591 R2592 R2595 R2596 R2601 R2602 R2603 R2608 R2610 R2611 R2631 R2632 R2714 R2715 R2716 R2752 R2755 R2756 R2801 R2802 R2803 R2804 R2805 R2806 R2807 R2809 R2810 R2811 R2813 R2815 R2817 R2901 R2904 R2905 R2906 R2907 R2908 R2911 R2912 R2913 R2914 R2915 R2918 R2919 R2920 R2921 R2922 R2926 R2927 R2929 R2930 R2932 R2933 R3I03

continued
Notes Item No.
R4723 (1) R4723 (2) R4723A R4724 R4726A R4726 R4727 R4728 R4729 R4730 R4731 (I) R4731 (2) R4732A R4733A R4734 R4738 R4739 R4740 R4785 R4790 R479 I R4805 R4806 R4807 R4811 R4814 R4901 R4903 R4905 (I) R4905 (2) R4907 R4909 R4912 RS004, OS, 06 RS007, 08, 09 RS025, 27, 29 RS034 RS037 RS038, 39, 40 RS044, 45, 46 R5048 R5049 R5054, 55, 58 RS089 R5201 R5202 R5203 R5204 R5205 R5208 RS213 R5214 RS215 RS216 RS217 R5219 R5220 RS221 R5222 RS224,25 R6206 R6208 R6209 R6502, OS, 08 R6526 R6528 R6529 R8101 R8102 R8103 R8107 R8108 R8109 R8110 R8111

Function/RatingMfr.
51002% 1I10W 51002% 1/10W 43002% lIlOW 51002% 1I10W 36002% I/IOW 3000 2% 1I1OW 27K2% I/IOW 3302% 1I10W 510 2% 1I10W 2702% I1IOW 510 2% 1I10W 2200 2% 1I1OW 3302% IIIOW 4702% 1I8W 8202% 1I10W 10002% 1I10W 15K 2% lIlOW 16002% 1I4W 20002% 1I10W 8202% I/IOW Comb Depth 7321% I/10W 9102% 1I10W 62002% 1I4W 47002% 1/4W 3002% IIIOW 1l0K 2% lIlOW lOOK 2% 1I10W 3002% 1I10W 625% lIlOW 4702% 1I10W 470K 2% I/IOW 240K 2% 1I10W 12002% 1I10W 4702% I/IOW 1000 2% 1I10W 16K 2% I/I0W 2202% l/lOW 12002% 1I10W 1000 2% III OW 3902% 1I10W 11002% l/lOW 62002% 1I10W 75002% 1I10W 3902% 1/10W 10002% l/lOW 15002% 1I10W 3602% 114W 15002% 1I10W 2402% 1I10W 1502% I1IOW 1102% 1I10W 2202% 118W 1802% 1/8W 3602% 1I10W 15002% 1/8W 2402% l/lOW 1502% 1I10W 1102% I/IOW 2202% 1/8W 1802% 1/8W 3602% 1I10W 15002% 1I10W 2402% 1I10W 1502% 1I10W 1102% IIIOW 2202% 1I10W 1802% 1I10W 9102% 1I10W 15002% IIIOW 9102% 1I10W 15002% 118W 9102% IIIOW 15002% 1I10W 20K2% 1/10W

Part No.
205345 205344 205345 205345 205343 194917 205245 195929 202585 197623 202585 192096 195929 182628 192088 197638 205354 175311 205341 192088 181106 227361 197627 179316 175413 205336 205369 192094 205336 194919 194926 205381 205374 194920 194926 197638 205355 192089 194920 197638 192102 202586 205347 205348 192102 197638 197628 175567 197628 197624 205334 205331 181492 181491 205337 181482 197624 205334 205331 181492 181491 205337 197628 197624 205334 205331 192089 194918 197627 197628 197627 181482 197627 197628 197904

Notes

Item No.
R3105 R3120 R3121 R3122 R3143 R3201 R3212 R3302,06, 10 R3312 R3316 R3328,29 R3330 R3331,33 R3338,53 R3358 R3359 R3365,67 R3369 R3372 R3501 R3503 R3509 R3801 R3803 R3805 R4001 R4002 R4003 R4103 R4105 R4110 R4112 R4113 R4114 R4119 R4121 R4122 R4127 R4129 R4131 R4132 R4133 R4137 R4140 R4141 R4197 R4305 R4306 R4307 R4358 R4359 R4402 R4403 R4407 R4409 R4410 R4412 R4413 R4414 R4416 R4503 R4504 R4507 R4508,09 R4510 R4511 R4512 R4700 (1) R4700 (2) R4703 (I) R4703 (2) R4717 R4718, 19 R4720A

Function/RatingMfr.
10002% 1I8W 24K2% lIlOW 10002% 1I8W 100 2% lIlOW 4702% lIlOW 10002% 1/8W 10002% 1I8W 33K2% 1I8W 3602% lIlOW 15002% I1IOW 51002% I1IOW 102% I1IOW 1000 2% 1I10W 102% lIlOW 10002% 1I8W 102% 1I10W 10002% 1I8W 1502% 1I10W 10002% 1I8W 4702% lIlOW 470K 2% 1I1OW 20K2% 1I10W 470K 2% 1I10W 26.IK 1% 1I8W 26.IK 1% 1I8W 26.IK 1% 1I8W 1.8 10% 15W Wirewound 2.7M 10% 112W 68K5% IW 1.85%2W 4702% lIlOW 10002% 1/8W 17401% 114W 300 Regulator B+ 45.3K 1% 114W 20K2% lIlOW 565% lW 3.9 5% 7W Wirewound 8.25% 1I2W 330 5% 7W Wirewound 2205% 1W 225%2W 53.6K 1% 114W 2.75%2W 15% 1W 105% 1W 2202% 1I10W 2202% 1I4W 822% 1I10W 75 5% 3W Wirewound 15002% 1I10W 10002% 1I8W 1000 Horizontal Centering 8205% IW 22005% 3W 10K 2% 114W 33002% 1I4W 56K2% lIlOW 3900 2% 1I10W 22002% 1I10W 47K2% 114W 15K 2% I1IOW 51002% I1IOW 1.55% lW 1805% 3W 16002% 1I2W 1 5% 2W Wirewound 20002% 112W Focus/Screen Focus/Screen 2.2 5% 3W Wirewound 2.7 5% 3W Wirewound 1005% 1/4W 10002% IIIOW 10002% 1I10W

Part No.
190462 205358 190462 218508 194926 190462 190462 176813 205337 197628 205345 205308 197638 205308 190462 205308 190462 205334 190462 194926 205381 197904 205381 215218 215218 215218 200444 217662 179784 227086 194926 190462 227037 190525 176506 197904 176910 179813 120595 200185 190555 179786 200189 227821 183140 175781 192089 175324 205329 227090 197628 190462 227011 175349 190559 175317 175352 192095 197907 192096 175322 205354 205345 178619 227094 179253 145384 227252 228910 229881 227091 229882 829110 197638 197638

Function/RatingMfr.
lOOK 2% 1/10W 120K 2% 1/10W 20K2% 1I4W 150K 2% 1I10W 68002% 1/2W 9105% 1/2W 51002% 1I10W 10K 2% IIIOW 51002% 1I10W 51002% 1/4W 5102% I1IOW 7502% 1I10W 12002% 1I10W 62002% lIlOW 10K 10% 1I2W 30 5% 3W Wirewound 3900 2% 111OW 9105% 1/4W lOOK 5% 1I2W 18K 5% 1I2W 10001% 1I4W 39.2K 1% 1/4W 49.9K 1% 1/4W 22K2% I/IOW 240K 2% 1I10W 1005% 1/2W 22002% 1I2W 222% 114W 38.3K 1% 114W 40.2K 1% 1/4W 26.7K 1% 1/4W 1500 2% 1I1OW 150K XRP Level 1000 10% 112W 12K5%3W 1005% 114W 1005% lW 2200 20% 112W 1005% 1/4W 475% 1/4W 91002% 1I10W 9102% 1I10W 2402% 1I10W 1000 10% 1/2W 3302% 1/8W 1500 2% 1I10W 2702% 1/8W 3302% 1/8W 682% IIIOW 10002% 1/8W 10002% 1/2W lOOK 2% 112W 4305% 1W 275% 1I4W 2205%2W lOOK 2% 112W 10002% IIIOW 275% IW 15002% 1I10W 5.65% 112W 2202% 112W 8202% 1/2W 472% 1I2W 515% 1I4W 685% 114W 15002% 1I10W 6202% 1I10W 5602% 1/10W 1502% 1/10W 10002% 1/8W 15% 114W 3302% I110W 10002% 1I10W 10001% 1/8W 10001% 1I1OW

Part No.
192094 205370 175351 195931 223353 830191 205345 195937 205345 175417 202585 202914 194920 205347 227374 227376 197907 829191 227079 8303.18 179753 190469 227085 205357 205374 176796 227267 175357 220197 219026 196081 197628 207883 502210 227393 829110 176673 502222 829110 829047 205350 197627 197624 502210 181488 197628 181481 181488 205328 190462 829210 227408 831143 829027 175310 227408 197638 210480 197628 227403 830122 830182 830047 175414 829068 197628 205339 205338 205334 190462 829AI0 195929 197638 220317 214143

Notes

# # # # #

# # # #

# # # #
# #

# # # # # # # #
# #

# # # # # # # #

# # # #
#

# # # # # # # # # #

# # # #
#

# #
#

PageS

SET 4474

PARTS LIST
Item No.
R8114 R8125 R8126 R8132 R8139 R8201 R8202 R8205 R8231 R8232 R8240 R8262 R8303 R8350 R8351 R8352 R8353 R8354 R8355 R8357 R8358 R8360 R8361 R8365 R8366 R8370 R8371 RN4501 RT420l SCl900 SCl904 SF2301 SF2302 SF8101 SF8102 SPl, 2 (7) SPl, 2 (8) SYM SW1900 SW3410 SW3411 SW3420 SW3421 SW3430 SW3431 SW4401 SW6201 SW6202 T4l0l T4l02 T4l03 T430l T440l (2)(4) T440l (3)(4) T460l T470l VlOl (1) VlOl (2) Y501 Y2801 Y3101 Y4190 Y8101 Y8201 Y830l

continued
Notes
Power For F4001 (2 Used) NY Input CRT Dynamic Focus Front Panel Headphone IN/OUT PIP Remote, CRK70Al

FunctionlRatingMfr.
lOOK 2% 1I10W 16002% 1I10W 13002% 1I10W 3302% l/lOW 1502% l/lOW 15K 2% I/IOW 56002% 1I10W 2.4 5% IW 3302% 1/8W 10002% 1I10W 2202% 1/10W 18002% 1/10W 22K2% 1I8W 26.1K 1% 1I8W 10K 1% l/IOW 26.lK 1% 1/8W 10K 1% 1I8W 26.lK 1% 1/8W 10K 1% 1I8W 14.3K 1% 1I10W 4531% 1I10W 15.8K 1% 1I10W lOOK 1% 1IIOW 15.8K 1% 1I10W lOOK 1% 1I10W 15.8K 1% 1I10W lOOK 1% 1IIOW Resistor Network PTC Thermistor Connector Connector Filter Filter Filter Filter Speaker Speaker Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch SMT Current Sense Horizontal Horizontal Horizontal Standby CRT CRT Crystal Crystal Crystal Resonator Resonator Resonator Crystal Crystal Adapter Button (8) Button (9) Button (10) Button (8) Button (9) Button (10) Button (8) Button (9) Drive Output Output

Part No.
192094 197625 205340 195929 205334 205354 205346 176887 181488 197638 192089 197903 174367 215218 215217 215218 220130 215218 220130 215219 217317 215199 215221 215199 215221 215199 215221 215499 207768 227346 227346 227024 227023 227024 227023 226332 229647 228459 227353 207842 205258 207842 207842 207842 207842 190488 205225 211982 227272 227016 227013 227018 227271 229880 225708 210878 A80AEJl59 A89AEJl59 182839 161235 21731.2 227064 227417 197652 182839 AH055 225801 229639 226005 229306 229641 228451 225802 229640

Notes

Item No.

FunctionlRatingMfr.
Button (10) Fuse Holder PC Board PC Board PC Board PC Board PC Board PC Board PC Board Trausmitter

Part No.
228450 176642 228452 228908 226787 226784 227333 227809 226788 221115 214032 205227 181090 214032 223146 211039 192060 193339 227089 214740 214760 214027 197604 194902 197604 227269 214760 227077 214732 197604 194911 193340 214740 215555 214740 202905 193340 205227 174406 227084 227074 226965 227084 214760 227084 227088 193339 227088 227084 227088 174410 181470

Item No.
L303 L304 L305 L306 L307 L308 L601,02 L603 L604 L701,02 L703 L704 L801 RI0l RI02 RI07 RI09 R112,14 R303 R306 R307 R309, 17 R318 R505 R509 R510 R511 R512 R514 R515 R516 R605 R609 R701 R704,06 R708 R808 R3802 R3804 R3806 R3807 R3808 R3809 R3810 R3811 R3812 R3813 R3814 R3815 SW801 T801 Y501

Function/RatingMfr.

Part No.
227005 226983 226984 226990 226991 226985 226999 227002 227001 226986 226989 226996 226999 205336 194920 205381 205334 194920 194917 197906 205365 205330 194926 205365 215216 215214 215215 197904 194916 192093 194916 194926 205365 205348 205365 194920 205308 215217 215217 215217 215219 217317 192088 215199 215221 215199 215221 215199 215221 227020 227015 182839

Notes

MAIN TUNER
CI0l CI04 ClIO C1l5 C1l7 C118 # C122 C124 C125 C302 C305 C306 C307 C308 C309 C310 C311 C312 C313, 14 C401 C407,11 C424 C501 C502 C505 C602 C605 C607 C701 C702 C703 C704 C705 C707 C708 C709 C710 C711 C712 C809 E702 FLI0l J801 J802 LIOI LI02 LI03 LI04 LI05 LI06 LI07 LI08 LI09 LllO Lll1 LI12 LI13 L1l4 LI15 L301 L302 150pF 5% 50V NPO 330pF 5% 50V NPO 39pF 5% 50V NPO 150pF 5% 50V NPO 1.5pF ±.lpF 50V NPO 180pF 5% 50V NPO .00110% 50V 47pF 5% 50V NPO 68pF 5% 50V NPO 100pF 2% 50V NPO IOpF 5% 50V NPO 27pF 5% 50V N750 12pF 5% 50V NPO 27pF 5% 50V NPO 120pF 5% 50V NPO 27pF 5% 50V NPO .75pF ±.lpF 50V NPO 27pF 5% 50V N750 18pF 2% 50V N220 470pF 5% 50V NPO 27pF 5% 50V NPO 33pF 5% 50V NPO 100pF 5% 50V NPO IOpF 5% 50V NPO .01 10% 50V IOpF 5% 50V NPO 39pF 5% 50V NPO 100pF 5% 50V NPO 330pF 5% 50V NPO 22pF 5% 50V NPO IpF ±.lpF 50V NPO 2pF ±.l pF 50V NPO 2pF ±.lpF 50V N750 1pF ±.l pF 50V NPO 27pF 5% 50V N750 1pF ±.l pF 50V NPO 3pF ±.1 pF 50V NPO 68pF 10% 50V NPO 3pF ±.lpF 50V NPO IpF ±.lpF 50V NPO 3pF ±.lpF 50V NPO 68pF 5% 50V NPO Jack Filter Jack Jack

# # #

Rear External Speakers Front External Speakers SAW SAW SAW SAW 3 112", 8 Ohms, 5W 3 118" X 6 114" 8 Ohms, 15W InternallExternal Speakers Channel Up Power Channel Down Volume Up Menu Volume Down Horizontal Centering Strength Polarity

# # # # # # # # # #

3002% l/lOW 12002% 1I10W 470K 2% 1I10W 1502% 1I10W 12002% 1I10W 30002% 1I8W 82K2% 1/10W 51K 2% l/IOW 912% 1I10W 4702% 1I10W 51K2% 1I10W 1M 1% 1I10W 191K 1% 1I10W 37.4K 1% 11l0W 20K2% 1/10W 68002% 1I10W 220K 2% 111OW 6800 2% l/l OW 4702% l/lOW 51K 2% 1I10W 75002% 1I10W 51K 2% 1I10W 12002% 1I10W 102% l/lOW 10K 1% 1I10W 10K 1% l/lOW 10K 1% 1I10W 14.3K 1% 1I10W 4531% 1I10W 8202% l/lOW 15.8K 1% 1/i0W lOOK 1% 1/i0W 15.8K 1% I/IOW lOOK 1% I/I0W 15.8K 1% 1IIOW lOOK 1% 1I10W Relay RF Splitter Crystal

:::0

3:
0
C
."

rw
Q

w ..., ......

en

m
."

3: ......
::::t:

'0
en en

en

Antenna AlB 4MHz

.!5

n -I n ...... ...... CQ n

A80AEJl5X09 A89AEJl5X09 4MHz 3.58MHz 8MHz 507kHz 507.5kHz 5.71MHz 14.318MHz 4MHz Antenna 75 To 300 Ohms Cap Cap Cap Cluster Cluster Cluster Power Power

RF Output High Pass Antenna A Antenna B

# For SAFETY use only equivalent

3.9J.lH

226982 227003 227005 226992 227006 200559 226987 226998 226993 226994 226998 226995 227000 226996 227000 227427 226988

replacement part. configuration may vary from original. % Use insulating hardware supplied with replacement. (1) Used in chassis CTCI79CK. (2) Used in chassis CTCI79CM. (3) Part of EPROM kit Part No. 229781 (Marked -97H or before) or Part No. 229782 (Marked -971 or later). (4) Screen and focus controls are part ofT4401. (5) Used in 32" models. (6) Used in 35" models. (7) Used in models F32730SBFMI, F32730SBJXI, F35755MBFM2, and F35755MBJX2. (8) Used in model G35831ATLMI. (9) Used in models F32730SBFMI and F32730SBJXl. (10) Used in models F35755MBFM2 and F35755MBJX2.

* Lead

SeT 4474

PageS