Modular Sony HCD-GB3
Uploaded by
ppstoneModular Sony HCD-GB3
Uploaded by
ppstoneHCD-GB3
SERVICE MANUAL
E Model
Ver. 1.0 2006.05
HCD-GB3 is the Amplifier, CD player, Tape
Deck and Tuner section in CMT-GB3.
Model Name Using Similar Mechanism
CD
HCD-EC50
Base Unit Name
BU-K6BD83S2-WOD
Optical Pick-up Name
KSM-213DCP
TAPE
Model Name Using Similar Mechanism
HCD-EC50
Section
Tape Transport Mechanism Type
Section
SPECIFICATIONS
Amplifier section
Tuner section
The following measured at AC 127 V, 60 Hz (Mexican model), AC 220 V,
60 Hz (Argentine model), AC 120, 220 or 240 V, 60 Hz (Other models)
DIN power output (rated): 40 + 40 W (6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference): 50 + 50 W (6 ohms at 1 kHz,
10% THD)
Inputs
AUDIO IN (stereo mini jack): Sensitivity 700 mV, impedance 47 kilohms
Outputs
PHONES (stereo mini jack): Accepts headphones with an impedance of 8
ohms or more
SPEAKER: Accepts impedance of 6 ohms
FM stereo, FM/AM superheterodyne tuner
Antenna:
FM lead antenna
AM loop antenna
CD player section
General
System: Compact disc and digital audio system
Laser Diode Properties
Emission duration: continuous
Laser Output*: Less than 44.6W
* This output is the value measurement at a distance of 200mm from the
objective lens surface on the Optical Pick-up Block with 7mm aperture.
Frequency response: 20 Hz 20 kHz
Signal-to-noise ratio: More than 90 dB
Dynamic range: More than 90 dB
Tape deck section
FM tuner section:
Tuning range: 87.5 108.0 MHz (50 kHz step)
Intermediate frequency: 10.7 MHz
AM tuner section:
Tuning range: 530 1,710 kHz (with 10 kHz tuning interval)
531 1,710 kHz (with 9 kHz tuning interval)
Intermediate frequency: 450 kHz
Power requirements
Mexican model: AC 127 V, 60 Hz
Argentine model: AC 220 V, 50/60 Hz
Other models: AC 120, 220 or 230 240 V, 50/60 Hz
Adjustable with voltage selector
Power consumption: 80 W
Dimensions (w/h/d) (excl. speakers): Approx. 200 281.5 390.5 mm
Mass (excl. speakers): Approx. 5.1 kg
Design and specifications are subject to change without notice.
Recording system: 4-track 2-channel, stereo
COMPACT DISC DECK RECEIVER
9-887-236-01
2006E1678-1
2006.05
Sony Corporation
Home Audio Division
Published by Sony Techno Create Corporation
HCD-GB3
TABLE OF CONTENTS
1.
SERVICING NOTES ................................................ 3
2.
GENERAL ................................................................... 4
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
3-12.
3-13.
3-14.
Disassembly Flow ...........................................................
Side Panel (R), Side Panel (L) .........................................
Top Panel Section ............................................................
Mechanical Deck .............................................................
Belt (MAIN), Belt (R/F) ..................................................
Front Panel Section .........................................................
PANEL Board ..................................................................
JACK Board .....................................................................
MAIN Board, REG Board ...............................................
CD Mechanism Deck Section (BU-K6BD83S2) ............
Optical Pick-up (KSM-213DCP), BD83S Board ............
Belt (DLM3A) .................................................................
DC Fan, Chassis (MAIN MOLD) ...................................
POWER Board, AMP Board ...........................................
4.
TEST MODE ............................................................... 15
5.
MECHANICAL ADJUSTMENTS ......................... 16
6.
ELECTRICAL ADJUSTMENTS .......................... 16
7.
DIAGRAMS
6
7
7
8
8
9
9
10
10
11
12
13
13
14
7-1. Block Diagram BD/DRIVER Section .................. 22
7-2. Block Diagram TUNER Section .......................... 23
7-3. Block Diagram MAIN Section ............................. 24
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
7-4. Printed Wiring Board BD83S Board ....................
7-5. Schematic Diagram BD83S Board .......................
7-6. Printed Wiring Boards
MAIN Board, REG Board .....................................
7-7. Schematic Diagram
MAIN Board (1/3), REG Board ............................
7-8. Schematic Diagram MAIN Board (2/3) ...............
7-9. Schematic Diagram MAIN Board (3/3) ...............
7-10. Printed Wiring Board AMP Board .......................
7-11. Schematic Diagram AMP Board ..........................
7-12. Printed Wiring Board PANEL Board ...................
7-13. Schematic Diagram PANEL Board ......................
7-14. Printed Wiring Boards
POWER Board, JACK Board ................................
7-15. Schematic Diagram
POWER Board, JACK Board ................................
25
26
27
28
29
30
31
32
33
34
35
36
8.
EXPLODED VIEWS
8-1.
8-2.
8-3.
8-4.
8-5.
Overall Section ................................................................
Front Panel Section .........................................................
Chassis Section ................................................................
Top Panel Section ............................................................
CD Mechanism Deck Section (BU-K6BD83S2-WOD) .
9.
ELECTRICAL PARTS LIST .................................. 50
45
46
47
48
49
HCD-GB3
SECTION 1
SERVICING NOTES
Notes on chip component replacement
Never reuse a disconnected chip component.
Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
Keep the temperature of the soldering iron around 270 C
during repairing.
Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
Be careful not to apply force on the conductor when soldering
or unsoldering.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
Unleaded solder melts at a temperature about 40 C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
This appliance is classified as a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT MARKING is located on
the rear exterior.
Laser component in this product is capable of emitting radiation
exceeding the limit for Class 1.
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
Carry out the S curve check in CD section adjustment and check
that the S curve waveforms is output three times.
CAUTION
When carrying this system
1 Remove all discs to protect the CD mechanism.
2 Hold down CD u (play/pause) on the unit, and press
?/1 until STANDBY appears.
3 After LOCK appears, unplug the power cord.
HCD-GB3
SECTION 2
GENERAL
This section is extracted
from instruction manual.
"ASIC /PERATIONS
!DJUSTING THE SOUND
4O ADJUST THE VOLUME
0RESS 6/,5-% n ON THE REMOTE OR TURN THE
6/,5-% CONTROL ON THE UNIT
4O ADD A SOUND EFFECT
XT
XB
X
4O
0RESS
'ENERATE A MORE DYNAMIC
SOUND $YNAMIC 3OUND
'ENERATOR 8
TRA
$3'8 ON THE UNIT
3ET THE SOUND EFFECT
%1
s 4HE MAXIMUM NUMBER OF
n FOLDERS IS INCLUDING THE ROOT FOLDER
n -0 lLES IS
n -0 lLES AND FOLDERS THAT CAN BE CONTAINED ON A SINGLE DISC IS
n FOLDER LEVELS THE TREE STRUCTURE OF lLES IS EIGHT
s #OMPATIBILITY WITH ALL -0 ENCODINGWRITING SOFTWARE RECORDING
DEVICE AND RECORDING MEDIA CANNOT BE GUARANTEED )NCOMPATIBLE
-0 DISCS MAY PRODUCE NOISE OR INTERRUPTED AUDIO OR MAY NOT PLAY
AT ALL
.OTES ON PLAYING MULTISESSION DISCS
s )F THE DISC BEGINS WITH A #$
$! OR -0 SESSION IT IS RECOGNIZED
AS A #$
$! OR -0 DISC AND PLAYBACK CONTINUES UNTIL ANOTHER
SESSION IS ENCOUNTERED
s ! DISC WITH A MIXED #$ FORMAT IS RECOGNIZED AS A #$
$! AUDIO
DISC
RM
0LAYING A #$-0 DISC
3ELECT THE #$ FUNCTION
0RESS #$ ON THE REMOTE OR &5.#4)/. ON THE
REMOTE REPEATEDLY
,ISTENING TO THE RADIO
3ELECT h&-v OR h!-v
0RESS 45.%2"!.$ REPEATEDLY
3ELECT THE TUNING MODE
0RESS 45.).' -/$% REPEATEDLY UNTIL h!54/v
APPEARS
0LACE A DISC
0RESS OPENCLOSE ON THE UNIT AND PLACE A DISC
WITH THE LABEL SIDE UP ON THE DISC TRAY
4UNE IN THE DESIRED STATION
0RESS n ON THE REMOTE OR 45.).' OR n ON THE
UNIT OR TURN THE JOG DIAL ON THE UNIT 3CANNING
STOPS AUTOMATICALLY WHEN A STATION IS TUNED IN AND
THEN h45.%$v AND h34%2%/v FOR STEREO PROGRAMS
APPEAR
XL
XB
XK
XE
XG
4HE SYSTEM OFFERS THE FOLLOWING DISPLAY MODES
$ISPLAY MODE
7HEN THE SYSTEM IS OFF
$EMONSTRATION
4HE CLOCK DISPLAY IS REPLACED BY
LIGHTING AND mASHING OF THE DISPLAY
WINDOW
4HE CLOCK IS DISPLAYED
4HE DISPLAY IS TURNED OFF TO CONSERVE
POWER 4HE TIMER AND CLOCK CONTINUE
TO OPERATE
#LOCK
0OWER 3AVING
-ODE
4HE 34!.$"9 INDICATOR LIGHTS UP WHEN THE SYSTEM IS OFF
7HEN THE SYSTEM IS IN 0OWER 3AVING -ODE THE FOLLOWING FUNCTIONS
ARE UNAVAILABLE
n SETTING THE CLOCK
n CHANGING THE !- TUNING INTERVAL
n CHANGING THE #$ POWER MANAGE FUNCTION
.OTES ON THE DISPLAY INFORMATION
s 4HE FOLLOWING ARE NOT DISPLAYED
n TOTAL PLAYING TIME FOR A #$
$! DISC DEPENDING ON THE PLAY MODE
n TOTAL PLAYING TIME FOR AN -0 DISC
n REMAINING PLAYING TIME FOR A TRACK AND AN -0 lLE
s 4HE FOLLOWING ARE NOT DISPLAYED CORRECTLY
n ELAPSED PLAYING TIME OF AN -0 lLE ENCODED USING A 6"2
VARIABLE BIT RATE
n FOLDER AND lLE NAMES THAT DO NOT FOLLOW EITHER THE )3/ ,EVEL
,EVEL OR *OLIET IN THE EXPANSION FORMAT
s 4HE FOLLOWING ARE DISPLAYED
n )$ TAG INFORMATION FOR -0 lLES WHEN )$ VERSION AND VERSION
TAGS ARE USED
n UP TO CHARACTERS OF )$ TAG INFORMATION USING UPPERCASE LETTERS
! TO : NUMBERS TO AND SYMBOLS
n
; < = ? { [ \ ] >
5SING OPTIONAL AUDIO
COMPONENTS
XI
RB
RL
R
R
XH
RE
4O INSERT ADDITIONAL DISCS SLIDE THE DISC TRAY WITH YOUR
lNGER AS SHOWN BELOW
4O STOP AUTOMATIC SCANNING
4O CONNECT AN OPTIONAL HEADPHONES
0RESS STOP
#ONNECT HEADPHONES TO THE 0(/.%3 JACK ON THE
UNIT
4O TUNE IN A STATION WITH A WEAK SIGNAL
)F h45.%$v DOES NOT APPEAR AND THE SCANNING DOES
NOT STOP PRESS 45.).' -/$% REPEATEDLY UNTIL
h-!.5!,v APPEARS AND THEN PRESS n ON THE REMOTE
REPEATEDLY OR 45.).' OR n ON THE UNIT OR TURN
THE JOG DIAL ON THE UNIT TO TUNE IN THE DESIRED STATION
4O REDUCE STATIC NOISE ON A WEAK &- STEREO
STATION
4O CLOSE THE DISC TRAY PRESS OPENCLOSE ON THE
UNIT
$O NOT FORCE THE DISC TRAY CLOSED WITH YOUR lNGER AS
THIS MAY DAMAGE THE UNIT
"EFORE USING THE SYSTEM
3TART PLAYBACK
4O USE THE REMOTE
0RESS PLAY ON THE REMOTE OR #$ PLAY
PAUSE ON THE UNIT
3LIDE AND REMOVE THE BATTERY COMPARTMENT LID AND
INSERT THE TWO SUPPLIED 2 SIZE !! BATTERIES SIDE
lRST MATCHING THE POLARITIES SHOWN BELOW
4O
0RESS
0AUSE PLAYBACK
PAUSE ON THE REMOTE OR
#$ PLAYPAUSE ON THE
UNIT 4O RESUME PLAY PRESS IT
AGAIN
3TOP PLAYBACK
3ELECT A FOLDER ON AN
-0 DISC
3ELECT A TRACK OR lLE
.OTES ON USING THE REMOTE
s 7ITH NORMAL USE THE BATTERIES SHOULD LAST FOR ABOUT SIX MONTHS
s $O NOT MIX AN OLD BATTERY WITH A NEW ONE OR MIX DIFFERENT TYPES OF
BATTERIES
s )F YOU DO NOT USE THE REMOTE FOR A LONG PERIOD OF TIME REMOVE THE
BATTERIES TO AVOID DAMAGE FROM BATTERY LEAKAGE AND CORROSION
4O SET THE CLOCK
4URN ON THE SYSTEM
0RESS #,/#+4)-%2 3%4 ON THE REMOTE )F THE
CURRENT MODE APPEARS ON THE DISPLAY PRESS
ON THE REMOTE REPEATEDLY TO SELECT h#,/#+ v AND
THEN PRESS %.4%2 ON THE REMOTE
3ET THE TIME
0RESS ON THE REMOTE REPEATEDLY TO SET
THE HOUR AND THEN PRESS %.4%2 ON THE REMOTE
5SE THE SAME PROCEDURE TO SET THE MINUTES
7HEN YOU TURN OFF THE SYSTEM AFTER SETTING THE CLOCK
THE CLOCK DISPLAY APPEARS INSTEAD OF THE DEMONSTRATION
DISPLAY
4HE CLOCK SETTINGS ARE LOST WHEN YOU DISCONNECT THE
POWER CORD OR IF A POWER FAILURE OCCURS
3ELECTING A MUSIC SOURCE
0RESS THE FOLLOWING BUTTONS OR PRESS &5.#4)/. ON
THE REMOTE REPEATEDLY
n
3ELECT A TAPE FUNCTION
0RESS &5.#4)/. ON THE REMOTE REPEATEDLY OR
4!0%
)NSERT A TAPE
0RESS STOPEJECT ON THE UNIT AND INSERT THE
TAPE INTO THE CASSETTE HOLDER -AKE SURE THERE IS NO
SLACK IN THE TAPE TO AVOID DAMAGING THE TAPE OR THE
TAPE DECK
3TART PLAYBACK
0RESS PLAY ON THE UNIT
GO BACKGO FORWARD
ON THE REMOTE ON THE
UNIT OR TURN THE JOG DIAL
ON THE UNIT
4O
0RESS
0AUSE PLAYBACK
PAUSE ON THE UNIT 4O RESUME
PLAY PRESS IT AGAIN
(OLD DOWN REWINDFAST
FORWARD DURING PLAYBACK AND
RELEASE IT AT THE DESIRED POINT
3ELECT 2EPEAT 0LAY
2%0%!4 ON THE REMOTE
REPEATEDLY UNTIL h2%0v OR h2%0v
APPEARS
3ELECT A DISC
$)3# 3+)0 ON THE REMOTE OR
$)3# n OR $)3# 3+)0
IN STOP MODE ON THE UNIT
3WITCH TO #$
FUNCTION FROM
ANOTHER SOURCE
%XCHANGE OTHER
DISCS WHILE PLAYING
$)3# n ON THE UNIT
!UTOMATIC 3OURCE 3ELECTION
#HANGING THE DISPLAY
%8 #(!.'% ON THE UNIT
4O CHANGE
0RESS
)LLUMINATION
PATTERN AROUND
THE 6/,5-%
CONTROL
),,5- ON THE UNIT REPEATEDLY
UNTIL h),,5-v APPEARS AND THEN
PRESS n ON THE REMOTE OR 45.).'
OR n ON THE UNIT REPEATEDLY OR
TURN THE JOG DIAL ON THE UNIT TO
CHANGE THE ILLUMINATION PATTERN
4O CHANGE THE PLAY MODE
0RESS 0,!9 -/$% REPEATEDLY WHILE THE PLAYER IS
STOPPED 9OU CAN SELECT NORMAL PLAY NO DISPLAY FOR ALL
DISCS OR h $)3#v FOR A DISC OR h v FOR ALL -0 lLES
IN THE FOLDER ON THE DISC SHUFmE PLAY h3(5&v FOR
ALL DISCS SHUFmE h $)3# 3(5&v FOR ONE DISC SHUFmE
OR h 3(5&
v FOR FOLDER SHUFmE OR PROGRAM PLAY
h0'-v
7HEN PLAYING A #$
$! DISC
3(5& 0LAY PERFORMS THE SAME
OPERATION AS $)3# 3(5& 0LAY
.OTES ON 2EPEAT 0LAY
#$
4UNER
45.%2"!.$
s !LL TRACKS OR lLES ON A DISC ARE PLAYED REPEATEDLY UP TO lVE TIMES
s 9OU CANNOT SELECT h2%0v AND h3(5&v ALL DISCS SHUFmE AT THE SAME
TIME
s h2%0v INDICATES THAT A SINGLE TRACK OR lLE IS REPEATED UNTIL YOU STOP
IT
4APE
4!0%
.OTES ON PLAYING -0 DISCS
#OMPONENT CONNECTED
USING AN AUDIO CORD
!5$)/ ). ON THE
UNIT
5SE BUTTONS ON THE UNIT FOR THE OPERATION
STOP
0RESS
#$ ON THE REMOTE
4O SELECT
0LAYING A TAPE
&IND A POINT IN A
TRACK OR lLE
0RESS POWER
3ELECT THE CLOCK SET MODE
0RESS &- -/$% ON THE REMOTE REPEATEDLY UNTIL
h-/./v APPEARS TO TURN OFF STEREO RECEPTION
s $O NOT SAVE OTHER TYPES OF TRACKS OR lLES OR UNNECESSARY FOLDERS ON A
DISC THAT HAS -0 lLES
s &OLDERS THAT HAVE NO -0 lLES ARE SKIPPED
s -0 lLES ARE PLAYED BACK IN THE ORDER THAT THEY ARE RECORDED ONTO
THE DISC
s 4HE SYSTEM CAN ONLY PLAY -0 lLES THAT HAVE A lLE EXTENSION OF
h-0v
s )F THERE ARE lLES ON THE DISC THAT HAVE THE h-0v lLE EXTENSION
BUT THAT ARE NOT -0 lLES THE UNIT MAY PRODUCE NOISE OR MAY
MALFUNCTION
3TOP PLAYBACK
STOPEJECT ON THE UNIT
2EWIND OR FAST
FORWARD
ON THE UNIT
"E SURE TO PRESS STOPEJECT ON THE UNIT AFTER THE TAPE HAS
BEEN WOUND OR REWOUND TO THE END
.OTE
$O NOT TURN OFF THE SYSTEM DURING PLAYBACK OR RECORDING
"RIGHTNESS OF THE $)--%2 ON THE UNIT REPEATEDLY
UNTIL h$)--%2v APPEARS AND THEN
DISPLAY
PRESS n ON THE REMOTE OR 45.).'
OR n ON THE UNIT REPEATEDLY OR
TURN THE JOG DIAL ON THE UNIT TO
CHANGE THE BRIGHTNESS
)NFORMATION ON
THE DISPLAY
$)30,!9 REPEATEDLY WHEN THE
SYSTEM IS ON
$ISPLAY MODE
3EE BELOW
$)30,!9 REPEATEDLY WHEN THE
SYSTEM IS OFF
&OR EXAMPLE YOU CAN VIEW #$-0 DISC INFORMATION SUCH AS THE
TRACK OR lLE NUMBER OR FOLDER NAME DURING NORMAL PLAY OR THE TOTAL
PLAY TIME WHILE THE PLAYER IS STOPPED
4O CONNECT AN OPTIONAL COMPONENT
#ONNECT ADDITIONAL AUDIO SOURCE COMPONENTS TO THE
!5$)/ ). JACK ON THE UNIT USING AN AUDIO ANALOG
CORD NOT SUPPLIED 4URN DOWN THE VOLUME ON THE
SYSTEM AND THEN PRESS !5$)/ ). ON THE UNIT TO
SELECT THE !5$)/ ). FUNCTION
HCD-GB3
/THER /PERATIONS
#REATING YOUR OWN #$ PROGRAM
2ECORDING ONTO A TAPE
0ROGRAM 0LAY
5SE A 490% ) NORMAL TAPE ONLY
5SE BUTTONS ON THE REMOTE TO CREATE YOUR OWN PROGRAM
9OU CAN RECORD JUST THE PORTIONS YOU LIKE FROM A SOUND
SOURCE INCLUDING CONNECTED AUDIO COMPONENTS
0RESS #$ TO SELECT THE #$ FUNCTION
0RESS 0,!9 -/$% REPEATEDLY UNTIL h0'-v
APPEARS WHILE THE PLAYER IS STOPPED
0RESS $)3# 3+)0 TO SELECT A DISC
0RESS OR ON THE UNIT
REPEATEDLY UNTIL THE DESIRED TRACK NUMBER
APPEARS
7HEN PROGRAMING -0 lLES PRESS n
REPEATEDLY TO SELECT THE DESIRED FOLDER AND THEN SELECT
THE DESIRED lLE
3ELECTED TRACK OR lLE NUMBER
5SE BUTTONS ON THE UNIT TO CONTROL TAPE RECORDING
)NSERT A RECORDABLE TAPE INTO THE CASSETTE HOLDER
WITH THE SIDE YOU WANT TO RECORD FACING UP
0REPARE THE RECORDING SOURCE
3ELECT THE DESIRED SOURCE TO RECORD
0LACE THE DISC YOU WANT TO RECORD AND PRESS $)3#
3+)0 TO SELECT A DISC
7HEN RECORDING A FOLDER FROM AN -0 DISC PRESS
0,!9 -/$% REPEATEDLY TO SELECT h v AND
THEN PRESS n REPEATEDLY TO SELECT THE DESIRED
FOLDER
4O RECORD ONLY YOUR FAVORITE #$ TRACKS OR -0 lLES IN
YOUR DESIRED ORDER PERFORM STEPS TO OF h#REATING
YOUR OWN #$ PROGRAMv
3TART RECORDING
0RESS %.4%2 TO ADD THE TRACK OR lLE TO THE
PROGRAM
2EPEAT STEPS THROUGH TO PROGRAM ADDITIONAL
TRACKS OR lLES UP TO A TOTAL OF TRACKS OR lLES
4O PLAY YOUR PROGRAM OF TRACKS OR lLES PRESS
OR #$ ON THE UNIT
4HE PROGRAM REMAINS AVAILABLE UNTIL YOU OPEN THE
DISC TRAY 4O PLAY IT AGAIN SELECT THE #$ FUNCTION AND
PRESS OR #$ ON THE UNIT
4O CANCEL 0ROGRAM 0LAY
0RESS RECORD AND THEN START PLAYING THE
DESIRED RECORDING SOURCE
4HE #$ STARTS PLAYING AUTOMATICALLY
)F THERE IS NOISE WHILE RECORDING FROM THE TUNER
REPOSITION THE APPROPRIATE ANTENNA TO REDUCE THE NOISE
7HILE RECORDING YOU CANNOT LISTEN TO OTHER SOURCES
4O STOP RECORDING
0RESS
4IP
7E RECOMMEND THAT YOU PRESS lRST AND THEN PRESS TO
AVOID NOISE BEING RECORDED WHEN YOU STOP RECORDING
0RESS 0,!9 -/$% REPEATEDLY UNTIL h0'-v
DISAPPEARS WHILE THE PLAYER IS STOPPED
4O DELETE THE LAST TRACK OR lLE OF THE PROGRAM
5SING THE TIMERS
0RESS #,%!2 ON THE REMOTE WHILE THE PLAYER IS
STOPPED
4HE SYSTEM OFFERS TWO TIMER FUNCTIONS )F YOU USE BOTH
TIMERS THE 3LEEP 4IMER HAS PRIORITY
4O VIEW PROGRAM INFORMATION SUCH AS TOTAL
TRACK NUMBER OF THE PROGRAM
3LEEP 4IMER
0RESS $)30,!9 REPEATEDLY
0RESETTING RADIO STATIONS
9OU CAN PRESET YOUR FAVORITE RADIO STATIONS AND TUNE
THEM IN INSTANTLY BY SELECTING THE CORRESPONDING PRESET
NUMBER
5SE BUTTONS ON THE REMOTE TO PRESET STATIONS
4UNE IN THE DESIRED STATION SEE h,ISTENING TO THE
RADIOv
0RESS 45.%2 -%-/29 ON THE REMOTE
0RESET NUMBER
0RESS n OR 45.).' OR n ON THE UNIT
REPEATEDLY TO SELECT YOUR DESIRED PRESET NUMBER
)F ANOTHER STATION IS ALREADY ASSIGNED TO THE SELECTED
PRESET NUMBER THE STATION IS REPLACED BY THE NEW
STATIONS
0RESS %.4%2
2EPEAT STEPS THROUGH TO STORE OTHER STATIONS
9OU CAN PRESET UP TO &- AND !- STATIONS 4HE
PRESET STATIONS ARE RETAINED FOR ABOUT A DAY EVEN IF
YOU DISCONNECT THE POWER CORD OR IF A POWER FAILURE
OCCURS
4O CALL UP A PRESET RADIO STATION PRESS 45.).'
-/$% REPEATEDLY UNTIL h02%3%4v APPEARS
AND THEN PRESS n OR 45.).' OR n ON THE
UNIT REPEATEDLY TO SELECT THE DESIRED PRESET
NUMBER
9OU CAN FALL ASLEEP TO MUSIC 4HIS FUNCTION WORKS EVEN IF
THE CLOCK IS NOT SET
0RESS 3,%%0 ON THE REMOTE REPEATEDLY )F YOU SELECT
h!54/ v THE SYSTEM AUTOMATICALLY TURNS OFF AFTER THE
CURRENT DISC OR TAPE STOPS OR IN MINUTES
)F THE TAPE DECK IS STILL PLAYING OR RECORDING AT THE SET
TIME THE SYSTEM TURNS OFF AFTER THE TAPE DECK STOPS
0LAY 4IMER
9OU CAN WAKE UP TO #$ OR TUNER AT A PRESET TIME
5SE BUTTONS ON THE REMOTE TO CONTROL THE 0LAY 4IMER
-AKE SURE YOU HAVE SET THE CLOCK
0REPARE THE SOUND SOURCE
0REPARE THE SOUND SOURCE AND THEN PRESS 6/,5-%
n OR TURN THE 6/,5-% CONTROL ON THE UNIT TO
ADJUST THE VOLUME
4O START FROM A SPECIlC #$ TRACK OR -0 lLE CREATE
YOUR OWN #$ PROGRAM
0RESS #,/#+4)-%2 3%4
0RESS REPEATEDLY TO SELECT h0,!9
3%4 v AND THEN PRESS %.4%2
h/. 4)-%v APPEARS AND THE HOUR INDICATION mASHES
3ET THE TIME TO START PLAYING
0RESS REPEATEDLY TO SET THE HOUR
AND THEN PRESS %.4%2
4HE MINUTE INDICATION mASHES 5SE THE PROCEDURE
ABOVE TO SET THE MINUTE
5SE THE SAME PROCEDURE AS IN STEP TO SET THE
TIME TO STOP PLAYING
3ELECT THE SOUND SOURCE
0RESS REPEATEDLY UNTIL THE DESIRED
SOUND SOURCE APPEARS AND THEN PRESS %.4%2 4HE
DISPLAY SHOWS THE TIMER SETTINGS
0RESS TO TURN OFF THE SYSTEM
)F THE SYSTEM IS ON AT THE PRESET TIME THE 0LAY 4IMER
WILL NOT PLAY
4O ACTIVATE OR CHECK THE TIMER AGAIN
0RESS #,/#+4)-%2 3%,%#4 PRESS
REPEATEDLY UNTIL h0,!9 3%,v APPEARS AND THEN PRESS
%.4%2
4O CANCEL A TIMER
2EPEAT THE SAME PROCEDURE AS ABOVE UNTIL h/&&v
APPEARS AND THEN PRESS %.4%2
4O CHANGE THE SETTING
3TART OVER FROM STEP
4IP
4HE 0LAY 4IMER SETTING REMAINS AS LONG AS THE SETTING IS NOT CANCELED
MANUALLY
HCD-GB3
SECTION 3
DISASSEMBLY
This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW
SET
3-2. SIDE PANEL (R),
SIDE PANEL (L)
(Page 7)
3-3. TOP PANEL SECTION
(Page 7)
3-6. FRONT PANEL SECTION
(Page 9)
3-4. MECHANICAL DECK
(Page 8)
3-9. MAIN BOARD,
REG BOARD
(Page 10)
3-5. BELT (MAIN), BELT (R/F)
(Page 8)
3-7. PANEL BOARD
(Page 9)
3-8. JACK BOARD
(Page 10)
3-10. CD MECHANISM DECK SECTION
(BU-K6BD83S2)
(Page 11)
3-11. OPTICAL PICK-UP (KSM-213DCP),
BD83S BOARD
(Page 12)
3-12. BELT (DLM3A)
(Page 13)
3-13. DC FAN, CHASSIS (MAIN MOLD)
(Page 13)
3-14. POWER BOARD, AMP BOARD
(Page 14)
HCD-GB3
Note: Follow the disassembly procedure in the numerical order given.
3-2. SIDE PANEL (R), SIDE PANEL (L)
5 two screws
(+BV3 10)
4 four screws
(case 3 TP2)
2 two screws
(+BV3 10)
6 side panel (L)
3 side panel (R)
1 four screws
(case 3 TP2)
3-3. TOP PANEL SECTION
5 two dowels
4 two screws
(+BV3 10)
6 two claws
8 connector
(CNP501)
3 three screws
(+BV3 10)
9 Remove the top panel section
in the direction of the arrow.
7 connector
(CNP502)
2 screw
(+KTP3 10)
1 screw
(+KTP3 10)
HCD-GB3
3-4. MECHANICAL DECK
2 Slide the lever in the
direction of the arrow.
3 mechanical deck
When re-assembling, solder each lead according to the color
(Red, White, Black) as shown in the figure.
White
Red
Red
White
White
Black
3-5. BELT (MAIN), BELT (R/F)
1 belt (main)
2 belt (R/F)
1 four screws
(+BVTP 2.6 8)
HCD-GB3
3-6. FRONT PANEL SECTION
4 screw
(+BV3 10)
2 wire (flat type)
29core (CNS111)
8 front panel section
1 connector
(CNP171)
6 screw
(+KTP3 10)
3 wire (flat type)
13core (CNS671)
5 screw
(+KTP3 10)
7 two screws
(+BV3 10)
3-7. PANEL BOARD
two claws
6 PANEL board
1 knob (volume)
3 fifteen screws
(+BVTP2.6 8)
2 knob (jog)
5 wire (flat type)
29core (CNS701)
HCD-GB3
3-8. JACK BOARD
1 clamp
5 JACK HLDR 2 board
3 clip coathing
2 two screws
(+BVTP2.6 8)
6 JACK board
4 JACK HLDR 1 board
3-9. MAIN BOARD, REG BOARD
qs MAIN board
8 screw
(+BV3 10)
9 REG board
5 connector
(CNP202)
6 connector
(CNP201)
qa two screws
(+BV3 10)
q; screw
(+BV3 10)
1 wire (flat type)
29core (CNS111)
4 connector
(CNP901)
7 wire (flat type)
23core (CNS104)
2 connector
(CNP171)
3 connector
(CNP151)
10
HCD-GB3
3-10. CD MECHANISM DECK SECTION (BU-K6BD83S2)
1 wire (flat type)
23core (CNS104)
2 four screws
(+BV3 10)
3 Remove the CD section and base unit
(BU-K6BD83S2) section in the
direction of the arrow.
4 door (CD) assy
qa CD mechanism deck section
(BU-K6BD83S2)
q; wire (flat type)
23core
6 wire (flat type)
13core
7 two screws (+BV2.6)
5 tape
9 cover (CD mecha)
8 two screws
(+BVWH)
11
HCD-GB3
3-11. OPTICAL PICK-UP (KSM-213DCP), BD83S BOARD
1 two screws (+PTPWHM 2.6)
2 two coil springs (insulator)
3 two insulators
4 two screws (+PTPWHM 2.6)
5 two coil springs (insulator)
6 two insulators
9 optical pick-up
(KSM-213DCP)
7 wire (flat type) (16 core)
(CN301)
q; BD83S board
8 Remove soldering from
the four points.
12
HCD-GB3
3-12. BELT (DLM3A)
1 two screws
(+BVTP2.6 8)
2 two screws
(+BVTP2.6 8)
3 cover
4 belt (DLM3A)
5 belt (DLM3A)
3-13. DC FAN, CHASSIS (MAIN MOLD)
7 four screws
(+BVTP4 12)
4 two screws
(+BV3 10)
5 DC fan
3 back panel
6 Remove soldering from
the two points.
1 connecter
(CNP902)
2 six screws
(+BV3 10)
8 screw
(+BV3 10)
9 AC HOLD board
qa chassis (main mold)
0 power cord
13
HCD-GB3
3-14. POWER BOARD, AMP BOARD
8 screw
(+BV3 10)
2 three screws
(+BV3 10)
9 AMP board
3 plate (pt shield)
4 four screws
7 two transister screws
5
6 POWER board
1 screw
(+BV3 10)
14
HCD-GB3
SECTION 4
TEST MODE
[MC COLD RESET]
[CD SLOT LOCK]
The cold reset clears all data including preset data stored in the
memory to initial conditions. Execute this mode when returning
the set to the customer.
Procedure:
1. In the standby status, press the @/1 button to turn the power
on.
2. Press three buttons of [DSGX], s , and at last @/1 simultaneously.
3. When RESET appears, the machine enters standby status.
This mode is for the antitheft of CD disc in shop. (not for transport)
Procedure:
1. Press the @/1 button to turn the power on.
2. Press the CD 7 button to select CD function.
3. Insert a disc.
4. While pressing the s button, press the Z button for more 5
seconds.
5. The message LOCKED is displayed and the disc slot is
locked. (Even if exiting from this mode, the disc slot is still
locked)
6. If press the Z button to eject the disc, the message
LOCKED is displayed and can not eject the disc.
7. To release this lock, while pressing the s button, press the
Z button for 5 seconds again.
8. The message UNLOCKED is displayed and the disc slot is
unlocked.
[PANEL TEST MODE]
Enter The Panel Test Mode
Procedure:
1. In the standby status, press the @/1 button to turn the power
on.
2. Press three buttons of [DISPLAY], s , and [DSGX] simultaneously.
3. When the panel test mode is activated, LEDs and segments of
LCD are all turned on.
Version Check
Procedure:
1. In the panel test mode (all LEDs and segments of LCD are
turned on), press the [AUDIO IN] button.
2. On the LCD, date and version are displayed xxxxxxxx.
For example, 1227V002.
3. From this status, press the [TUNER/BAND] button, and the
destination is displayed. For example, GB3LATIN
4. To release from this mode, press three buttons of [DISPLAY],
s , and [DSGX] simultaneously.
[CD REPEAT 5 LIMIT CANCEL MODE]
Number of repeats for CD playback is 5 times when the repeat mode
is REPEAT. This mode enables CD to repeat playback for limitless
times.
Procedure:
1. Press the @/1 button to turn the power on.
2. Press the CD 7 button to select CD function.
3. Press three buttons of CD 7 , [EQ], and [DISC SKIP] simultaneously.
4. It enters the CD repeat 5 limit cancel mode and displays NO
LIMIT
5. To release this mode, press the @/1 button to turn the power
off.
[CD POWER MANAGE]
This mode is for switch the CD power supply on/off. Even if this
state pulls out AC plug, it is held.
Procedure:
1. Press the @/1 button to turn the power on.
2. Press the CD 7 button to select CD function.
3. Press the @/1 button again to turn the power off (standby).
4. While pressing the s button, press the @/1 button.
5. It turns power on and display CD POWER, then display
ON or OFF.
[CHANGE-OVER THE AM TUNING INTERVAL]
The AM tuning interval can be changed over 9 kHz or 10 kHz.
Procedure:
1. Press the @/1 button to turn the power on.
2. Press the [TUNER/BAND] button to select TUNER (AM)
function.
3. Press the @/1 button again to turn the power off (standby).
4. While pressing the TUNING+ JL button, press the
@/1 button.
5. It turns power on and display 9k STEP or 10k STEP, and
thus the tuning interval is changed over.
[CD SHIP MODE]
This mode can run the CD sled motor optionally. Use this mode, for
instance, when cleaning the optical pick-up.
Procedure:
1. Press the @/1 button to turn the power on.
2. Press the CD 7 button to select CD function.
3. Press two buttons of CD 7 and @/1 simultaneously. *1
4. Set to the CD ship mode. (chucking on)
5. After blink STANDBY, LOCK is displayed, disconnect
the AC plug.
*1) If press three buttons of [DISC 3], s and @/1 simultaneously, activate the CD ship mode and MC cold reset.
15
HCD-GB3
SECTION 5
MECHANICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured-alcohol-moistened
swab :
record/playback head
pinch roller
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head
demagnetizer. (Do not bring the head magnetizer close to the
erase head.)
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, appiy suitable locking compound to
the parts adjusted.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
Torque Measurement
Mode
FWD
FWD
back tension
FF
Torque meter
CQ-102AS
CQ-102C
CQ-201AS
REW
CQ-201B
Meter reading
2.0 8.0 mN m
(20 to 80 g cm)
(0.28 1.12 oz inch)
0.15 0.6 mN m
(1.5 to 6 g cm)
(0.021 0.083 oz inch)
5 17.7 mN m
(50 to 177 g cm)
(0.7 2.48 oz inch)
5 17.7 mN m
(50 to 177 g cm)
(0.7 2.48 oz inch)
SECTION 6
ELECTRICAL ADJUSTMENTS
DECK SECTION
0 dB=0.775 V
1. Demagnetize the record/playback head with a head
demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
Test Tape
Tape
P-4-A063
Signal
6.3 kHz, 10 dB
Used for
Azimuth Adjustment
RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENT
Procedure:
1. Mode: Playback
test tape
P-4-A063
(6.3 kHz, 10 dB)
JACK board
PHONES jack
(J102)
level meter
set
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
Tape Tension Measurement
Mode
FWD
Tension Meter
CQ-403A
Meter Reading
more than 80 g
(more than 2.82 oz)
within
1dB
L-CH
peak
within
1dB
Output
level
Screw
position
R-CH
peak
L-CH
peak
Screw
position
R-CH
peak
3. Mode: Playback
test tape
JACK board
P-4-A063
(6.3 kHz, 10 dB) PHONES jack oscilloscope
(J102)
V
set
waveform of oscilloscope
in phase 45
good
90 135 180
wrong
4. After the adjustments, apply suitable locking compound to
the pats adjusted.
16
HCD-GB3
Adjustment Location: Record/Playback/Erase Head
CD SECTION
Note:
1. CD Block is basically constructed to operate without adjustment.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10 M impedance.
4. Clean the object lens by an applicator with neutral detergent when the
signal level is low than specified value with the following checks.
5. Check the focus bias check when optical pick-up block is replaced.
FOCUS BIAS CHECK
oscilloscope
(DC range)
BD83S board
TP (RFACI)
TP (VC)
Procedure :
1. Connect oscilloscope to TP (RFACI) and TP (VC) on the
BD83S board.
2. Press the I/1 button to turn the power ON, and press
the Z (CD) button to open the CD disc tray.
3. Set disc (YEDS-18) on the tray and press the CD 7 button
to playback.
4. Confirm that oscilloscope waveform is as shown in the figure
below. (eye pattern)
A good eye pattern means that the diamond shape () in the
center of the waveform can be clearly distinguished.
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
level:
0.9 0.4 Vp-p
Checking Location:
BD83S Board (SIDE B)
TP
(VC)
IC201
TP
(RFACI)
17
HCD-GB3
TUNER SECTION
0 dB=1 V
AM FREQUENCY COVERAGE ADJUSTMENT
Adjustment Part
L852
Confirmation
[AM]
Setting:
FUNCTION: TUNER
TUNER/BAND button: AM
AM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter
L851
530 kHz
60 cm
loop antenna A loop antenna B
AM RF signal
generator
level meter
32
+
set
30% amplitude
modulation by
400 Hz signal
Output level: 54 dBuV
JACK board
PHONES jack (J102)
[FM]
Setting:
FUNCTION: TUNER
TUNER/BAND button: FM
FM RF signal
generator
0.01 F
Frequency Display Reading on Digital Voltmeter
530 kHz
1.5 0.1 V
1,710 kHz
8 0.5 V
FM FREQUENCY COVERAGE ADJUSTMENT
Adjustment Part Frequency Display Reading on Digital Voltmeter
L805
87.5 MHz
1.75 0.1 V
Confirmation
108 MHz
6.2 0.5 V
FM TRACKING ADJUSTMENT
Adjust for a maximum reading on level meter
L804
98 MHz
Adjustment Location: MAIN board (See page 19).
MAIN board
ANTENNA
CNP802 pin 1
level meter
32
[FM DETECTOR ADJUSTMENT]
Setting:
FUNCTION: TUNER
TUNER/BAND button: FM
set
JACK board
MAIN board
75kHz frequency
ANTENNA
PHONES jack (J102)
deviation by 1K Hz
CNP802 pin 2
signal
Output level: as low as possible
(8dBuV)
FM RF signal
generator
MAIN board
IC801 pin qs
MAIN board
(TUNER OUT L-ch)
ANTENNA
CNP802 pin 1
level meter
set
digital voltmeter
MAIN board
TP (TUNER VT)
18
100 k
Repeat the procedures in each adjustment several times.
Carrier frequency: 98MHz
Modulation:
deviation by FM 75 kHz
Output level: 60 dBuV
MAIN board
MAIN board
ANTENNA
TP (TUNER GND)
CNP802 pin 2
1. Tune the set to 98 MHz.
2. Adjust L806 so that modulation distortion may become the
best in the vicinity of the maximum value where the tuner out
level becomes 15dBuV or more.
HCD-GB3
Adjustment Location and Connecting Points
AM TRACKING
ADJUSTMENT
MAIN BOARD (Component side)
(TUNER VT)
CNP802
3
1
L851
L805
L852
L804
FM FREQUENCY
COVERRANGE
ADUJUSTMENT
AM FREQUENCY
COVERRANGE
ADUJUSTMENT
FM DETECTOR
ADUJUSTMENT
L806
FM TRACKING
ADJUSTMENT
(TUNER GND)
MAIN BOARD (Condutor side)
TP (TUNER VT)
IC801 pin qs
(TUNER OUT L-ch)
TP (TUNER GND)
19
HCD-GB3
SECTION 7
DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
Note on Schematic Diagram:
All capacitors are in F unless otherwise noted. (p: pF)
50 WV or less are not indicated except for electrolytics and
tantalums.
All resistors are in and 1/4 W or less unless otherwise
specified.
f : internal component.
2 : nonflammable resistor.
5 : fusible resistor.
C : panel designation.
Note: The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
20
H : adjustment for repair.
A : B+ Line.
B : B Line.
Voltages are taken with a VOM (Input impedance 10 M).
Voltage variations may be noted due to normal production
tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
BD83S BOARD
No mark: CD PLAY
Other Section
No mark: FM
Circled numbers refer to waveforms.
Signal path.
F
: TUNER (FM)
f
: TUNER (AM)
J
: CD
d
: AUX
E
: PB (TAPE)
a
: REC (TAPE)
Abbreviation
AR
: Argentine model
E2
: 120V AC area in E model
MX
: Mexican model
Note on Printed Wiring Boards:
X : parts extracted from the component side.
Y : parts extracted from the conductor side.
f
: internal component.
: Pattern from the side which enables seeing.
Indication of transistor.
C
Q
These are omitted.
B E
Q
B
These are omitted.
HCD-GB3
Circuit Boards Location
Waveforms
MAIN Board
PANEL Board
IC801 w; (XOUT)
BD83S Board
4 IC201 u; (RFACO)
IC701 qd (X0A/P90)
(CD PLAY mode)
MAIN board
AMP board
13.3 s
REG board
500m V/DIV, 4 s/DIV
1.5 Vp-p
30.5 s
0.5 to 1.3 Vp-p
2.2 Vp-p
0.5 V/DIV, 10 s/DIV
200 mV/DIV, 500 ns/DIV
5 IC201 <z/,
(XTAO)
(CD PLAY mode)
IC701 od (X0)
POWER board
PANEL board
239 ns
1 V/DIV, 100 ns/DIV
3.3 Vp-p
3.3 Vp-p
59.1 ns
1 V/DIV, 20 ns/DIV
6 IC201 1 (LRCK)
(CD PLAY mode)
3.3 Vp-p
22.7 s
1 V/DIV, 10 s/DIV
7 IC201 5 (BCK)
BD83S board
(CD PLAY mode)
JACK board
3.4 Vp-p
472 ns
1 V/DIV, 200 ns/DIV
HCD-GB3
21
21
HCD-GB3
7-1. BLOCK DIAGRAM BD/DRIVER SECTION
SYSTEM CONTROLLER
IC701
(1/2)
OPTICAL PICK-UP
BLOCK
(KSM-213DCP/C2NP)
CD MECHANISM DECK
BLOCK
DETECTOR
VCC
+1.7V
+3.3V
VC
IC201
RF AMP,DSP,MP3
57 A
58 B
59 C
60 D
50 E
51 F
AOUT1 112
AOUT2 117
66 LD
CLK2 90
XLAT-MP3 13
REQ-MP3 14
GND
108 XTAO
X201
16.9344MHz
IREQ-MP3 10
ACK-MP3 15
DATA-MP3
F+
FOCUS
COIL
F
T+
TRACKING
COIL
SP+
12 CH2OUTF
REQ-MP3
SL
M402
(SLED)
S201
(LIMIT)
44 TRDR
M1-
8 P33/TMCK
CLOCK
30 P55/SC0
SENS
29 P54/SI0
SCOR
43 P67/AN7/INT2
MAIN
SECTION
(Page 24)
CH2RIN 7
46 FRDR
CH3FIN 23
41 SFDR
CH3RIN 22
42 SRDR
M1
M2
Q665,668
M2+
MOTOR
DRIVE
Q666,667
MOTOR
DRIVE
14 CH1OUTF
16 CH4OUTF
M245 FFDR
MOTOR
DRIVE
31 P56/SO0
13 CH1OUTR
CH2FIN 6
MOTOR
DRIVE
Q669,672
3 P26
XLAT
SENS 20
CH1RIN 5
34 P76
DATA
CLOCK 11
M1+
50 P75/SCL/SO2
XRST
XLAT 16
Q670,671
49 P74/SDA/SC2
XTACN
SCOR 26
43 TFDR
SW5(STOCK)
SW8(OPEN)
11 CH2OUTR
Q661-664
CD
MOTOR
CONTROL
15 CH4OUTR
VM9V
18 CH3OUTR
OPIN+ 2
SL+
39 SSTP
SW6(CLOSE)
12 P37/OCU1
ACK-MP3
DATA 89
CH1FIN 4
M401
M
(SPINDLE)
SP
67 PD
SW7(CHACK)
10 P35/IC1
IREQ-MP3
109 XTAI
+3.3V
P50/TINO 25
P51/TIN1 26
6 P31/SC3
XLAT-MP3
XRST 8
IC402
SL/SP MOTOR
DRIVER
FOCUS/TRUCKING
COIL DRIVER
VR
SW2
5 P30/SO3
CLK-MP3
XTACN 7
PD
SW1
P43/LED3 20
P53/PPG1 28
DATA2 12
AUTOMATIC
POWER
CONTROL
CD-R
MAIN
SECTION
(Page 24)
SW3
P42/LED2 19
P52/TIN2/PPGO 27
Q321
LD
CD-L
P41/LED1 18
38 MPD
17 CH3OUTF
MUTE 20
Signal Path
: CD
M-MUTE
11 P36/OCU0
IC203
+1.8V
+1.8
REG
3.3V
HCD-GB3
22
22
HCD-GB3
7-2. BLOCK DIAGRAM TUNER SECTION
AM TRACKING
L851
IC801
AM/FM IF AMP,
MIX, MPX, DET, OSC
FM/AM PLL
2 REG
1 AM RF-IN
L803
D851
ANTENNA
CF803
450kHz
AM-MIX 5
CNP802
L852
AM OSC
L-OUT 12
TUNER
L-CH
L-CH
TUNER
R-CH
R-CH
FM DETECTOR
7 AM IF-IN
AM FREQUENCY
COVERAGE
L806
R-OUT 13
FM-DET 11
31 AM-OSC
FM/AM
CF801
10.7MHz
36 FM RF-IN
FM-MIX 3
Q803
FM MIX
AMP
CF802
10.7MHz
8 FM IF-IN
34 FM RF-OUT
L804
FM RF
D802
FM TRACKING
Q801
32 FM-OSC
+3V
D803
AGC 25
L805
FM OSC
Q802
+5V
27 LP-IN
XOUT
28 LP-OUT
XIN
VT
19
20
DO
DI
CL
CE
18
16
17
15
C
MAIN
SECTION
(Page 24)
VM9V
TU-ANSD
FM FREQUENCY
COVERAGE
26 PD
+3V
REG
TU-DO
TU-DI
TU-CLK
TU-CE
+5V
REG
VM9V
VM+9V
TU-ANSD
TU-DO
TU-CE
TU-DI
X801
75kHz
TU-CLK
Signal Path
: TUNER(FM)
: TUNER(AM)
HCD-GB3
23
23
HCD-GB3
7-3. BLOCK DIAGRAM MAIN SECTION
J105
PB/REC EQ AMP,
FUNCTION CONTROLLER
IC401
R-CH
IC202
OUT 1 18
19 A1
AUDIO IN
1
SYSTEM CONTROLLER
IC701(2/2)
2 PB1P
23 C1
VM+9V
VM+9V
SEL OUT 1
21 B1
SD 13
C
TUNER
SECTION
(Page 23)
6
L
4 P27
R-CH
Q135
VOLTAGE
SHIFT
REC 10 28
33 P57/SI1
TU-DI
TU-CLK
57 V2/P82
TU-CE
55 V0/P80
P25
R
D901
AMP
CONTROL
56 V1/P81
TU-ANSD
R-CH
39 P63/AN3
LCD702
46 P71/AN9/SC1
IC402
LEVEL
DET
TAPE MECHANISM DECK
BLOCK
J102
PHONES
Q131-134,
Q138
D510
HP
MUTE
LIQUID CRYSTAL
DISPLAY
R-CH
Q901-Q903
63
.
64
.
SEG0 67
SEG31 89
.
94
SW501(1/2)
(REC/PB)
VM+9V
FAN
CONTROL
M901
FAN MOTOR
100
L-CH
Q201
REC/PB
HEAD
X701
32.768kHz
SW501(2/2)
(REC/PB)
R-CH
+4V
Q507,508
ERASE
COM0 59
COM3 62
14 X1A
OVERLOAD
DET
13 X0A
R-CH
X702
4.19MHz
BIAS
OSC
93 X0
R-CH
92 X1
Q707,709,710
L501
BIAS OSC
P47/LED7/TOT2 24
P-SW
IC702
DECODER
LED701,709
(BACK LIGHT)
Q243
LED
DRIVE
AMP
PROTECT
40 P64/AN4
P44/LED4 21
Q501,502
SW
3 DATA
P45/LED5/TOT0 22
4 CLK
P46/LED6/TOT1 23
5 LCK
VM9V
M2- 13
SW703,704,706,709,710,719,721
FUCTION
KEY
THERMAL
DET
LED1 6
LED5 10
M1- 12
M-SW
Q242
LED703-707
(VOLUME)
DIM0 15
DIM1 16
M1+ 11
AMP-ON
M2+ 14
37 P61/AN1
TH241
M1+
M1M2-
D154
B
Q151-154
M2+
BD/DRIVER
SECTION
(Page 22)
PROTECT
DET
SW711-716,SW708,720
FUCTION
KEY
38 P62/AN2
Q193
D156
SW701,702,705,722-724
FUCTION
KEY
RY131
RELAY
CONTROL
Q241
AMP-ON
R-CH
TU-DO
J101
SPEAKER
R-CH
Q244
L-CH
R-CH
POWER
AMP
DETECTION
LED702
(STANDBY)
41 P65/AN5/INT0
Q192
CD-L
CD-R
P40/LED0 17
R-CH
BD/DRIVER
SECTION
(Page 22)
DVDD
( +3.3V)
SW699
ENCODER
ENCODER
+3.3V
REG
Q191
45 P70/AN8/INT3
AVDD
( +3.3V)
PT001
POWER
TRANSFORMER
(MAIN)
D107-110
E2
S001
VOLTAGE
SELECTOR
+VP
-VP
+3.3V
REG
D111,113
D191,192
R-CH is omitted due to same as L-CH.
+7V
SW700
IC101
Signal Path
VOLUME
VOLUME
48 P73/AN11/SI2
VM+9V
: TUNER(FM)
+9V
REG
Q121,122
: TUNER(AM)
IC703
: CD
REMOTE
CONTROL 1
RECEIVER
: AUX
P60/ANO 36
POWER
MONITOR
P24
RELAY
DRIVE
P34/IC0
Q102
1
RY002
PT002
POWER
TRANSFORMER
(SUB)
42 P66/AN6/INT1
: PB (TAPE)
: REC (TAPE)
Q705,706
Q704
RESET
RESET
SWITCH
54 RSTX
D702
CON AVCC
CON VCC
HCD-GB3
24
24
Q701-703
+3.6V
REG
L001
D051,052
LINE
FILTER
AC
IN
HCD-GB3
7-4. PRINTED WIRING BOARD BD83S BOARD
See page 21 for Circuit Boards Location.
:Uses unleaded solder.
10
11
12
BD83S BOARD (SIDE A)
BD83S BOARD (SIDE B)
B
M
(SPINDLE MOTOR)
S201
(LIMIT)
(SLED MOTOR)
IC402
TP(VC)
IC201
MAIN BOARD
CNS104
(Page 27)
TP(RFACI)
F
E
IC203
12
1-868-067-
OPTICAL PICK-UP
BLOCK
KSM-213DCP
(12)
12
1-868-067-
(12)
Semiconductor
Location
HCD-GB3
25
25
Ref. No.
Location
IC201
IC203
IC402
E-8
G-3
C-10
Q321
F-5
HCD-GB3
See page 21 for Waveforms.
7-5. SCHEMATIC DIAGRAM BD83S BOARD
See page 37 for IC Block Diagrams. See page 40 for IC Pin Function Description.
BD83S BOARD
0.47
0.01
C208
0.1
C230
100p
C260
C261
R260 0
C264
C273
470p
0.001p
C210
0.1
TP
(RFACI)
R256
22k
C257
0.1
R265 4.7k
R250 1M
R258 220k
C265 0.1
R268 10k
C274
0.1
CN301
16P
VC
R324
100k
C258
R267
4.7k
220p
VCC
R266
1k
R257
100k
C221
0.1
C323
100
10V
R321
2.2
C322
1
C301
0.1
C304
1
C303
10
E
D
R322
2.2
A
B
Q321
2SA2119K
R323
0
TP1
(APC)
OPTICAL
AUTOMATIC
F
POWER
C321
0.001p
PICK-UP
BLOCK
GND
CONTROL
KSM-213DCP
C256
0.1
LD
VR
PD
F+
TP
(VC)
T+
JTAGTCK
RFDCO
AVDD4
PDSENS
LD
AC_SUM
PD
EG_IN
RFC
RFACI
AVSS4
RFACO
AVDD3
BIAS
ASYI
VCTL
VPCO
ASYO
AVSS3
FILI
CLTV
PCO
FILO
SVSS
VSS
VDD
SVDD
SVDD
0.1
SSTB-MP3
C222
DATA
SVSS
TEST1
TCLK2
FD
(SPINDLE)
SP+
C
SPB
SL+
JTAGTDI
A
SL-
C207 100 10V
JTAGTDO
VC
R255 1k
JTAGTMS
C254 0.0047p
R254
TP4
TRST
10k
DOUT
R252
10k
R451
22k
TES1
FRDR
FFDR
PLLVSS
FFDR
XVSS
TRDR
XTAO
TFDR
XTAI
SRDR
C276 1
C291
470p
VREFL
MDP
AVSS1
LOCK
AVSS2
VSS
VREFR
VDD
AOUT2
VSS
C277 1
R292 100
OPIN+
OPIN-
CH1FIN
CH4CAPA
PREVCC
CH1RIN
CH4IN
GAIN-SW
CH2FIN
OPOUT
CH2RIN
CH3FIN
GND
CH3RIN
CNF4
POWVCC
GND
COIL DRIVER,
CH2OUTR
FOCUS/TRACKING
MUTE
SVDD
POWVCC
SVSS
COUT
VDD
SCOR
C2PO
GFS
XPCK
XUGF
SVDD
WFCK
SENS
SVSS
VDD
XLAT
REQ-MP3
DATA2
CLOK
IREQ-MP3
VSS
XRST
XTACN
BCK
BCKI
PCMD
CH3OUTR
CH1PUTF
CH2OUTF
FOK
DFCT
MIRR
CH1OUTR
LRCK
IC203
BH18LB1WG-TR
+1.8V REGULATOR
LRCKI
IC203
CN102
23P
DATA
IOVSS0
IOVDD0
PCMDI
AVDD2
C219
0.1
ACK-MP3
C292
470p
R421
0
SSTP
AOUT1
R291
100
C217
0.1
CH3OUTF
C202
0.1
XLAT-MP3
C218
0.1
C201
100
10V
R423
10k
IOVSS1
AVDD1
R111 100
C424
0.1
C404
0.1
SFDR
XVDD
R112 100
C232
0.1
FRDR
TFDR
R271
1M
R203
R113 100
C205
0.1
IOVDD1
TP2
(SPI)
TRDR
R270
1k
X201
16.9344MHz
C215
0.1
IC201
CXD3014A-201R
CH4OUTF
C268
10p
C275
5p
C266
10p
RF AMP,DSP,MP3
CH4OUTR
C267
5p
AVDD0
IOVSS2
PLLVDD
R452 10k
C206 0.1
C451 0.047
AVSS0
TEST
C223
0.1
C251 470p
FFDR
TP3
F
TFDR
TEI
IOVDD2
FRDR
TEO
VDD
C252 0.0047p
TRDR
VSS
0.1
C214
0.1
C253 470p
FEI
R253 1k
C213
(SLED)
FEO
SLED/SPINDLE
CLK-MP3
IC402
BA5947FM-E2
C224
0.1
M-MUTE
DVDD(3.3V)
R207
0
D-OUT
C227
1
C226
1
C220
0.1
VREF
MOTOR DRIVER
D-GND
C204
0.1
A-GND
R-CH
R201
0
R275
100
AVDD(3.3V)
(2/3)
CNS104
(Page 29)
R276
47k
XTACN
C271
0.1
R278 100
C203
100
10V
R202
0
L-CH
C272
0.1
R277 100
XRST
R110 100
R280
0
IREQ-MP3
R103 100
CLK
R105 100
DATA-MP3
R104 100
C405
0.1
XLAT-MP3
R109 100
C406
0.1
R107 100
XLAT
SL-
SP-
ACK-MP3
SP+
R108 100
SL+
REQ-MP3
R102 100
SENS
R101 100
SCOR
220p
220p
C109
C107
100p
220p
100p
C105
C103
C104
22p
220p
220p
220p
100p
22p
C101
C108
C102
C110
C111
C112
C113
M+7V
100p
M-GND
R401
0
C401
220
10V
S201
(LIMIT)
No mark:CD PLAY
HCD-GB3
26
26
HCD-GB3
See page 21 for Circuit Boards Location.
7-6. PRINTED WIRING BOARDS MAIN BOARD, REG BOARD
:Uses unleaded solder.
TAPE MECHANISM
DECK
ANTENNA
A
FM/AM
E
E
A
A
4
8
A
K
11
Semiconductor
Location
AMP
BOARD
CNP202
(Page 31)
10
IC401
IC801
F
JACK
BOARD
WH171
(Page 35)
IC402
+
L
PANEL
BOARD
CNS701
(Page 33)
E
E
AMP
BOARD
CNP201
(Page 31)
K
A
SPEAKER
IMPEDANCE:
USE 6
A
E
22
23
A
K
BD83S
BOARD
CN102
(Page 25)
AMP
BOARD
CNP901
(Page 31)
H
(CHASSIS)
HCD-GB3
27
27
POWER
BOARD
WH151
(Page 35)
3
1
3
1
IC101
Ref. No.
Location
D107
D108
D109
D110
D111
D113
D131
D132
D154
D156
D191
D192
D193
D501
D502
D503
D504
D505
D506
D508
D510
D511
D802
D803
D812
D813
D814
D851
D901
E-7
E-7
E-7
E-7
E-7
E-7
D-8
D-8
F-6
F-5
F-5
F-5
F-3
C-10
C-9
C-9
C-9
D-9
C-9
D-9
D-9
D-8
B-3
B-4
B-2
B-2
B-4
B-4
G-3
IC101
IC401
IC402
IC801
G-11
B-8
C-10
C-4
Q102
Q121
Q122
Q131
Q132
Q133
Q134
Q135
Q137
Q138
Q151
Q152
Q153
Q154
Q191
Q192
Q193
Q501
Q502
Q507
Q508
Q801
Q802
Q803
E-8
E-8
D-8
E-3
E-3
E-4
E-4
E-3
E-4
E-4
F-6
F-6
F-6
F-6
F-3
F-3
F-5
C-8
D-8
B-10
B-10
B-5
B-5
D-3
HCD-GB3
7-7. SCHEMATIC DIAGRAM MAIN BOARD (1/3), REG BOARD
L101
C183
0.1
R181
10
J101
C181
0.1
D901
MC2838-T112-1
R901
4.7k
R183
10
C187
0.01
CLP101
LEAD PIN
R902 4.7k
R129
47
C188
0.01
C182
0.1
C184
0.1
R182
10
C132
0.1
R184 10
R127
47
C131 0.022
R133
4.7k
Q135
2SC3052F-TLF
RELAY
CONTROL
L102
R128
47
C403
0.1
D192
1N4002B
R406
1k
C130
220
10V
R197
47
R131
47k
WH102
5P
D191
1N4002B
Q192
KTC3203Y-AT
RY131
RELAY
R194
47
C515
47p
C193
0.1
R198
47
32
C192
0.1
Q191
KTC3203Y-AT
R191
1k
Q193
2SA1235TP-1EF
R410
100k
D193
UDZW-TE173.9B
R195
R196 100
100
R192
100k
R411
1k
R404
220
R412
220
C191
220 10V
R403
1k
C418
0.1 50V
R193 100k
C417 0.1
R188 22k
32
WH101
5P
R154
220k
50V
R189 22k
R153
220k
C402
100 16V
C413
100 16V
C412
470 10V
R402 100
30
29
Q133
RT1P441C-TP-1
R132 4.7k
R142
100k
R130 4.7k
Q134
RT1N441C-TP-1
32
WH901
4P
R172
10k
R156
10k
R163
10k
R162
100
Q154
2SA1235TP-1EF
Q151
2SC3052F-T1-LF
R116
100
C134
470p
R174
100
R186
100
Q153
2SC3052F-T1-LF
D156
MC2836
D154
MC2838-T112-1
Q132
2SC5938-T112-1B
C153 0.47
C152 0.47
CNP151
8P
R177
4.7k
R179 R178
0 4.7k
R180
0
R165
10k
R169 R167
10k 10k
R171
10k
R164
22k
R168R166
10k 22k
R170
10k
R157
2.2k
R115
100
C105
0.1
Q137
2SC5938-T112-1B
R101
2.2k
C115 0.1
D110
1N5402-F46
C106
0.1
R113
100
R117
100
R159 10k
R123
470k
C101
2200
50V
D108
1N5402-F46
C156 0.1
CLP201
LEAD PIN
D132
MC2836
R105
47k
C116
0.022
R103
47k
D131
1N4002B
Q122
2SC3052F-T1-LF
Q121
2SC3052F-T1-LF
R107
22k
Q102
2SC3052F-T1-LF
R104
47k
R108
2.2k
R110
2.2
R109
2.2
IC101
KIA7809API
C111
100
16V
C119
0.1
R125
22k
D111 1N4002B
C155 0.1
R121
220k
C102
2200
50V
D107
1N5402-F46
D109
1N5402-F46
36
R199
100
R114
100
Q131
2SC5938-T112-1B
R158 10k
R155 47k
C151
100
16V
R112
100
R111
100
R185
100
Q138
2SC5938-T112-1B
R200
100
Q152
2SA1235TP-1EF
R161
2.2k
R160 2.2k
R118
100
C133
0.01
R124
100
C121
0.47
D113
1N4002B
C114
0.1
R106
22k
WH203
3P
WH103
3P
C112
2200
25V
C113
1000
25V
: Impossible to measure
No mark : FM
EP102
EARTH,PLATE
HCD-GB3
28
28
C118
0.1
HCD-GB3
7-8. SCHEMATIC DIAGRAM MAIN BOARD (2/3)
See page 39 for IC Block Diagram.
30
C574
1
D502
MC2840-T112-1
CNS104
23P
C195
0.1
C194
0.1
IC402
BA4558F-E2
C573
1
R140 470
R574
100
R566
100
R570
1k
D510
1SS355WTE-17
R144 470
D504
MC2840-T112-1
R145 470
C568
1
R575
22k
R571
220k
R577
100k
R579
10k
R146 470
C544
0.001
C504
470p
R508 C506
R504 4.7k 2.2k 0.047
C508 0.01
R506 10k
R149 470
C503
470p
R507 C505
R503 4.7k 2.2k 0.047
R516 47
R505 10k
R150 470
R511 2.2M
R139 470
R510 470k
R509 470k
R567
220k
CNP501
6P
R518 100k
6P-(PH)
TAPE_HEAD
TPR1
C510
100 16V
C543
0.001
R513
100
C507 0.01
R512 2.2M
C577
1
D508
1SS355WTE-17
R578 10k
R514 100
C571
0.1
R148 470
26
C570
1
R572 100k
R147 470
D505
MC2840-T112-1
R576
10k
R568
22k
R573
10k
C198 0.1
D503
MC2840-T112-1
D506
MC2840-T112-1
R584
220k
D501
MC2840-T112-1
R517
100k
R515
47
C509
100 16V
R520 100k
R138 470
C531 0.001
R137 470
C502 47p
R136 470
C421 0.1
R134 470
W501
W502
C404
1
C501
47p
C406
1
C197
470
10V
CNP502
3P
C514 0.001
C532
0.001
C408
0.0047
C407
0.0047
R135 470
C512 470p
R502
100
R501
100
R519 100k
C511 470p
CNA502
3P-PH
TAPE_MECHA
C551
22
50V
C513 0.001
SW501
PB/REC EQ AMP,
FUNCTION CONTROLLER
C158
0.1
IC401
BD3881FV
C159
0.1
R530
2.2k
CNS111
29P
D511
1SS355WTE-17
C528
0.001
Q501
KTA1273-Y-AT
R532 R534
4.7k 10k
C529
100p
R528
4.7k
C524
0.01
C527
0.001
R521 R529
22k 2.2k
R527
4.7k
R524
4.7k
Q502
2SC3052F-T-1-LF
C526
0.01
C523
0.01
R523 R525
4.7k 10k
R583
47k
R536 47
C525
0.01
C561
0.0022
R560 0
R535 47
Q507
2SC1740S-RT
R545
4.7k
C564
0.01
R564
10k
R542
10k
C566
0.0022
C567
0.0047
100V
R561
4.7
R565
10k
28
C431 0.22
R581
47k
C562
0.0022
R419 22k
R541 22k
R439 4.7k
R440 4.7k
C433 470p
C434 470p
R441
47k
R442
47k
R526 10k
R429 4.7k
R430 4.7k
C437 470p
C438 470p
R426 10k
R433
22k
R427
100k
R405
220
C522
100p
R522
22k
R434
22k
C415 0.1
R425
8.2k
R423 10k
R424
8.2k
C416 0.1
C409
0.1
R428
100k
C405
0.1 50V
C410
0.1
C401
0.1 50V
R582
4.7k
R531 R533
4.7k 10k
Q508
2SC1740S-RT
C565
1
34
L501
C530
0.1
R543
4.7k
R544
4.7k
C432 0.22
R420 22k
C196
0.1
36
CNP171
8P
HCD-GB3
29
29
HCD-GB3
See page 21 for Waveform. See page 38 for IC Block Diagram.
7-9. SCHEMATIC DIAGRAM MAIN BOARD (3/3)
D814
1PS226-115
JW851
0
R812
470
R814
100
R839
100
R811
4.7k
C818
0.001
C834
220
10V
JW803
0
C819
0.001
L852
L851
L805
D851
SVC347A-TL
R801
2.2k
JW802
0
Q801
2SC3052F-T1-LF
R843
470k
R855
470k
X801
75KHz
R850
2.2k
R816
10k
R818 47k
C822 470p
R863
22k
R817 10k
R804 0
R805 100k
C840
0.47
R849 22k
R813 10k
R809 1k
C802 0.1
D813
1PS226-115
C804
0.1
C821
0.047
C809
0.1
R802
10
C815 100p
R808
10k
C803
0.01
R815 4.7k
R807
100k
C841
22 50V
C816 C817
0.22 0.1
R806
0
L804
CNP802
3P
C820
0.001
R803
10
C807
0.0022
C806
0.001
D802
SV230-TB-E
C856 5p
C854 10p
C851
0.047
R853 100k
C852 10p
R851 22k
C853
0.022
C855
470p
R827
100
C823
18p
C838
0.1
C824
18p
JR801
0
D812
1PS226-115
R842
47k
D803
SV230-TB-E
IC801
JW806
0
LV23003VA
R830
47k
R829
100k
Q802
2SC3052F-T1-LF
C811
0.1
CF802
CF803
Q803
2SC5477
R835 4.7k
C801 100 16V
R834
22k
C831 0.47
R848 1k
R819
10k
L806
Fm-DET
R836 23003
10k
R820
1k
JW804 0
R840
22k
R825
470
29
L803
JW805
0
R828
47
C829
0.01
C830
0.01
C848
0.0022
C847
0.0022
C812
0.1
R831
220
C826
100p
C827
100p
R833
10k
R824
2.2k
R846
2.2k
R841
100
C828 100p
R822 2.2k
C814
0.1
C833 0.47
R823
100
CF801
C873
2p
C813
220 10V
R821
220
C825
1
6.3V
C832 0.47
R810
1M
R826
100
C839 0.1
C810
0.22
R844 R845 R852
10
22
22
C835
0.22
R837
10k
C836
0.22
R838
10k
R859
10k
R860
10k
No mark : FM
HCD-GB3
30
30
28
HCD-GB3
See page 21 for Circuit Boards Location.
7-10. PRINTED WIRING BOARD AMP BOARD
:Uses unleaded solder.
5
Semiconductor
Location
AMP BOARD
A
D
MAIN
BOARD
WH901
(Page 27)
MAIN
BOARD
WH102
(Page 27)
4
E
MAIN
BOARD
WH101
(Page 27)
-VP
R-OUT
E
E
E
FAN
IC202
HCD-GB3
31
31
Ref. No.
Location
D241
B-4
IC202
C-3
Q201
Q202
Q241
Q242
Q243
Q244
Q901
Q902
Q903
B-3
B-4
B-2
B-2
B-3
B-3
B-1
B-2
B-1
HCD-GB3
7-11. SCHEMATIC DIAGRAM AMP BOARD
See page 39 for IC Block Diagram.
FAN
IC202
STK432-070
R907
4.7k
C251
0.1
C212
0.0022
R232
220
R238
0.22
2W
R236
0.22
2W
R224
10k
R251
100
C206
220p
R202
0
R222
22k
R922
47
R921
10
C921
4.7
50V
R924
2.2k
R906
470
C902
47
50V
C901
4.7
50V
C210 10p
R218 R204
47k
1k
Q202
2SA2026
R216
1k
R214
10k
R212
33k
C202
220p
R220 R206
10k
1k
C204
4.7
50V
C254
0.0022
C203
4.7
50V
C253
0.0022
R231
220
R233
10k
R227
2.2k
Q201
2SA2026
R235
R223 0.22
10k 2W
R237
0.22
2W
R215
1k
R213
10k
R211
33k
R205
R219 10k
1k
C201
220p
R217
1k
R234 10k
R225
22k
C211
0.0022
R228
2.2k
C209 10p
C205
220p
R203
47k
R201 R221
22k
0
R207
100
D241
MC2838-T112-1
CNP202
5P
Q244
2SA1235TP-1EF
Q241
2SC3052F-T1-LF
R241
10k
28
R245
2.2k
R243
1k
R246
10k
R249
4.7k
R244
100k
C244
0.01
Q242
2SA1235TP-1EF
R242
10k
R248
10k
CNP201
5P
R247
470k
Q243
2SC3052F-T1-LF
HCD-GB3
32
CNP901
4P
R905
47k
Q903
2SC3052F-T1-LF
R923
220k
R253
10k
R208
100
R910
47
Q901
2SC3052F-T1-LF
R252
100
C252
0.1
TH241
R911
47
R909
10k
R908
4.7k
C903
47
50V
R226
22k
CNP902
3P
Q902
2SA1235TP-1EF
32
28
R904
10k
28
HCD-GB3
See page 21 for Circuit Boards Location.
7-12. PRINTED WIRING BOARD PANEL BOARD
:Uses unleaded solder.
9
Semiconductor
Location
Ref. No.
Location
D509
D701
D702
C-6
C-4
C-4
IC701
IC702
IC703
C-5
E-4
C-3
LED701
LED702
LED703
LED704
LED705
LED706
LED707
LED709
B-3
D-8
G-6
F-6
E-5
F-4
G-4
B-7
Q661
Q662
Q663
Q664
Q665
Q666
Q667
Q668
Q669
Q670
Q671
Q672
Q701
Q702
Q703
Q704
Q705
Q706
Q707
Q709
Q710
H-4
H-6
H-5
H-5
H-3
H-3
H-4
H-4
G-4
G-4
G-3
G-3
C-4
C-4
C-4
C-3
C-4
C-4
E-2
F-2
F-2
(LIQUID CRYSTAL DISPLAY)
36
E
E
E
E
IC701
IC703
TUNING+
M>
(STANDBY)
DIMMER
ILLUM
CD
TUNING-
M>
PLAY MODE/
TUNING MODE
DISPLAY
EQ
?/1
IC702
+
ENTER
TUNER/
BAND
(VOLUME)
(VOLUME)
VOLUME
AUDIO IN
+
TAPE
(VOLUME)
(VOLUME)
CD MECHANISM
DECK
DSGX
3
DISC
2
DISC
1
DISC
HCD-GB3
33
33
DISC SKIP/
EX-CHANGER
MAIN
BOARD
CNS111
(Page 27)
HCD-GB3
7-13. SCHEMATIC DIAGRAM PANEL BOARD See page 21 for Waveforms. See page 39 for IC Block Diagram. See page 43 for IC Pin Function Description.
LCD702
Q701
2SA1235TP-1EF
D702
MC2836
R719
1k
R722
220k
R713
10k
R721
470
R785
10k
C701
0.1
Q702
2SC3052F
-T1-LF
C703
100
10V
705
2SC3052F
-T1-LF
Q703
2SC3052F
-T1-LF
R718
1k
CNS701
29P
X702
4.19MHz
Q704
RT1N441C-TP-1
Q706
2SC3052F
-T1-LF
C705
0.01
R788
0
R767
220k
L701 0
R728
10k
C702
0.01
C711
0.1
C704
470
6.3V
C721
470
10V
C731 0.1
R711
22k
D701
UDZW-TE173.6B
R723 2.2k
R787 47
R784
100k
C750
4.7 50V
R854 1k
C736
0.1
R704 1k
R706 1k
R731
10k
R705 1k
R789
1k
R703 4.7k
R756 1k
R709 1k
R790
1k
R724 1k
R791
1k
R730 10k
R779 100
C724 47p
R778 1k
R776 1k
C707 0.001
R771 1k
R772 470
R734
470
R717 1k
C732
22p
R758 1k
R707 1k
LED702
SLR-342VRT
32
R735 1k
R716 1k
R708 1k
R755 0
IC701
MB90802PF-G -113E1
C706 0.1
C716 0.1
IC702
BU2099FV
R749 1k
29
X701 32768Hz
C733
22p
C737 0.001
R715 1k
C738 0.001
R710 4.7k
C739 0.001
R701 1k
R678
100
R786
100
R668
100
R759
100
R660
100
R753
100
LED701
1L0341Y23E
0CA602
R725 1k
R702 1k
LED709
1L0341Y23E
0CA602
R757
100k
C730 0.001
R712 4.7k
C729 0.001
LED707
1L4345V22D
OTDT02
R699 1k
R751 100k
R659
47k
Q666
2SC3440-T112-1EF
C725 0.1
R655
47k R669
47k
Q668
2SC3440-T112
-1EF
Q670
2SC3440-T112
-1EF
R656
47k
C717
0.001
C718
0.001
C742 220p
C743 220p
C735
0.001
R783 22k
C747 0.001
C734 0.001
C715 0.001
C714 0.001
R698
470
C709 0.001
R695
470
D509
1SS355WTE-17
R768
10k
C722
0.0047
C746
0.0047
C710
0.22
Q672
2SC3440-T112
-1EF
R748
47k
C726 0.1
R770
47k
R733
47k
R754
10k
R739 10k
Q661
RT1N441C-TP-1
C727 0.1
R689
10k
R667
470
R800
220k
R782 22k
Q710
2SC3052F-T1-LF
IC703
RPM7240-H18
C741 220p
R693
47k
R861
220
Q709
2SC3052F-T1-LF
R700
1k
R694 470
R692 470
R666 470
R691
47k
R857
220
R866
1k
Q671
2SA1365-T112
-1EF
C708 47p
R671
470
C671
22 50V
Q707
2SC3052F-T1-LF
R714
4.7k
Q663
2SC3052F
-T-LF
Q664
2SA1235TP-1EF
R856
10k
R726 100k
R740 1k
R697 1k
LED706
1L4345V22D
OTDT02
R795 1k
R696 1k
LED705
1L4345V22D
OTDT02
R794 1k
R690 1k
R658
47k
R657
470k
R681
22k
R683
47k
R682
220k
R796
10k
C719
0.047
C713 47p
C712 0.1
R685
22k
C672
0.1
C723 0.001
Q669
2SA1365-T112
-1EF
R665 47k
Q662
KTA1273-Y-AT
R670 470
R687
4.7k
LED704
1L4345V22D
OTDT02
Q665
Q667
2SA1365-T112
-1EF
2SA1365-T112
-EF
R688 2.2
R686
4.7k
R793 1k
R792 1k
R684 2.2
R680 1k
LED703
1L4345V22D
OTDT02
C728 0.001
JW700
0
R742
1k
R744
2.2k
R777
470
R746
2.2k
R765
4.7k
R762
10k
R766
22k
R775
47k
R652 47k
R743
1k
R653 47k
JR704 0
R661 47k
R651 47k
R662 47k
R764
22k
R738
10k
R763
22k
R675 22k
R677 22k
R673 22k
R674 22k
R679 22k
R676 22k
R864
2.2k
R865
4.7k
R745
2.2k
R747
2.2k
R769
4.7k
R773
10k
R774
22k
R780
10k
R760 100k
R664 47k
R672 22k
R862
2.2k
JR717 0
R663 47k
CNS671
13P
R750
1k
SW701 SW702 SW705 SW722 SW723 SW724
R732
22k
R761 47k
R799
22k
R797 47k
SW700
SW699
HCD-GB3
34
34
R798 100k
SW703 SW704
SW706 SW709 SW710 SW719
SW721 SW711 SW712 SW713 SW714 SW715 SW716 SW708 SW720
HCD-GB3
7-14. PRINTED WIRING BOARDS POWER BOARD, JACK BOARD
See page 21 for Circuit Boards Location.
:Uses unleaded solder.
POWER BOARD
AC
IN
E2
S001
AR
230-240V
VOLTAGE
SELECTOR
MX
220V
PT001
120V
1
16
15
MX
14
3
8
13
JACK BOARD
MAIN
BOARD
CNP151
(Page 27)
12
PT002
1
5
11
10
9
7
8
* NOT REPLACEABLE
BUILT IN TRANSFORMER
E
J105
AUDIO IN
HCD-GB3
35
35
J102
PHONES
MAIN
BOARD
CNP171
(Page 27)
HCD-GB3
7-15. SCHEMATIC DIAGRAM POWER BOARD, JACK BOARD
D052
MC2838-T112-1
PT002
S001
D051
MC2836-T112-1
JW001
JW005
R051
4.7k
JW002
R052
4.7k
C51
0.1
JW003
RY002
G5PA-2
C055 0.47
T3.15A/250V
F051
C054 0.47
FH002
T002
1P TERMINAL
T001
1P TERMINAL
FH001
WH151
8P
28
PT001
L001
LINE FILTOR
*: Not Replaceable Built in Transformer
C053
0.47
W052
WARE
R151
4.7k
J105
R175
47k
R152
4.7k
L106 0
L104
C139
0.1
R176
47k
JR111
0
J102
L105 0
WH171
8P
29
R119
47
R120
47
L103
C140
0.1
C141
0.01
C142
0.01
W172
WIRE-EARTH
HP
HCD-GB3
36
36
HCD-GB3
IC Block Diagrams
BD83S Board
IC203 BH18LB1WG-TR
VIN 1
VOLTAGE
REFERENCE
GND 2
VOUT
NC
THERMAL
PROTECTION
OVER CURRENT
PROTECTION
CONTROL
BLOCK
STBY 3
PREVCC
OPOUT
OUTVREF
CH4CAPA
CH4IN
CH3FIN
CH3RIN
GND
MUTE
POWVCC
CH3OUTR
CH3OUTF
CH4OUTF
CH4OUTR
IC402 BA5947FM-E2
28
27
26
25
24
23
22
21
20
19
18
17
16
15
MUTING
+
INTERFACE
LEVEL SHIFT
INTERFACE
INTERFACE
+
1 2
10
11
12
13
14
CH2FIN
CH2RIN
GND
VREFIN
POWVCC
CH2OUTR
CH2OUTF
CH1OUTR
CH1OUTF
CH1RIN
CH1FIN
SW
OPIN
OPIN+
VREF
37
HCD-GB3
MAIN Board
IC801 LV23003VA
AM
RF
AM RF-IN 1
FM
RF
36 FM RF-IN
35 GND2
34 FMRF-OUT
REG 2
FM
MIX
FM-MIX 3
33 VCC2
FM
OSC
GND1 4
32 FM-OSC
AM
MIX
AM-MIX 5
AM
OSC
VCC1 6
OSC
BUFFER
LOW-PASS
FILTER
AGC
31
30
29
28
27
26
25
AM-OSC
BO2
BO1
A-OUT
A-IN
PD
AGC
AMIF-IN 7
AM
IF
AM
DET
24 AM DET-OUT
FMIF-IN 8
FM
IF
FM
DET
23 FM DET-OUT
FM
S-METER
SD
IF
BUFFER
ST
PIROT
DET
P-DET 9
TRIG
STSW
FF
FF
FF
PHASE
COMPARATOR
P-COMP 10
FM-DET 11
L-OUT 12
R-OUT 13
VCO
DECODER
22 MPX-IN
MUTE
VSS 14
POWER ON
RESET
UNIVERSAL
COUNTER
CE
DI
CL
DO
15
16
17
18
CCB
I/F
DATA SHIFT
REGISTER
LATCH
21 VDD
PROGRAMMABLE
DIVIDER
SWALLOW
COUNTER
UNLOCK
DETECTOR
PHASE
DETECTOE
CHARGE
PUMP
REFERENCE
DIVIDER
38
20 XOUT
19 XIN
HCD-GB3
MAIN Board
REC1O
REC1N
REC2N
REC2O
INC2
INC1
INB2
INB1
INA2
INA1
OUT1
BAS1
OUT2
BAS2
IC401 BD3881FV
28
27
26
25
24
23
22
21
20
19
18
17
16
15
BASS
VOLUME
BASS
TREBLE
PB1P
PB2P
PB2N
PB2O
PB1O
VOLIN1
IC202 STK432-070
12
11
13
14
LED5
LED4
LED3
LED2
LED1
LCK
CLK
DATA
NC
VSS
LPF
11
12
13
14
15
16
17
18
19
20
OE
Shift
Register
VDD
Write
Buffer
SO
Controller
NC
Latch
DIM1
RI+
DIM0
15
M2-
14
M2+
13
M1-
12
10
M1+
11
RI-
+VP
10
SUB
LO-
RO-
-VCC
-VP
RO+
5
ICC
+
ch.2
LO+
NC
LI-
+VCC
LI+
10
IC702 BU2099FV
+
ch.1
PANEL Board
AMP Board
VEE
CONT
VDD
TRE2
TRE1
GND
LOGIC
CONTROL
TREBLE
VOLIN2
PB1N
VOLUME
39
HCD-GB3
IC Pin Function Description
BD83S BOARD IC201 CXD3014A-201R (RF AMP, DSP, MP3)
Pin No.
Pin Name
I/O
LRCK
L/R sampling clock signal output terminal
LRCKI
L/R sampling clock signal input terminal
PCMD
Serial data output terminal
PCMDI
Serial data input terminal
BCK
Bit clock signal output terminal
BCKI
Bit clock signal input terminal
XTACN
XRST
VSS
Ground terminal
10
IREQ-MP3
MP3 data request signal output to the system controller
11
CLOK
CD serial data transfer clock signal input from the system controller
12
DATA2
MP3 serial data input from the system controller
13
XLAT-MP3
MP3 serial data latch pulse signal input from the system controller
14
REQ-MP3
MP3 data request signal input from the system controller
15
ACK-MP3
MP3 acknowledge signal output to the system controller
16
XLAT
CD serial data latch pulse signal input from the system controller
17
VDD
40
Description
Oscillation circuit on/off switch control signal input from the system controller
L: oscillation stop, H: self-oscillation
System reset signal input from the system controller L: reset
Power supply terminal (+1.8V)
18
SVSS
Ground terminal
19
SVDD
Power supply terminal (+1.8V)
20
SENS
Internal status (SENSE) signal output to the system controller
21
WFCK
WFCK output (Not used)
22
XUGF
XUGF output (Not used)
23
XPCK
XPCK output (Not used)
24
GFS
GFP output (Not used)
25
C2PO
C2PO output (Not used)
26
SCOR
Subcode sync (S0+S1) detection signal output to the system controller
27
VDD
Power supply terminal (+1.8V)
28
COUT
I/O
Track number count signal input/output (Not used)
29
SVSS
Ground terminal
30
SVDD
Power supply terminal (+1.8V)
31
MIRR
I/O
Mirror signal input/output (Not used)
32
DFCT
I/O
Defect signal input/output (Not used)
33
FOK
I/O
Focus OK signal input/output (Not used)
34
VSS
Ground terminal
35
VDD
Power supply terminal (+1.8V)
36
VSS
Ground terminal
37
LOCK
I/O
Not used
38
MDP
Spindle motor servo control signal output terminal
Disc inner position detection signal input terminal
39
SSTP
40
IOVSS1
Ground terminal
41
SFDR
Sled servo drive signal (+) output to the coil/motor driver
42
SRDR
Sled servo drive signal () output to the coil/motor driver
43
TFDR
Tracking servo drive signal (+) output to the coil/motor driver
44
TRDR
Tracking servo drive signal () output to the coil/motor driver
45
FFDR
Focus servo drive signal (+) output to the coil/motor driver
46
FRDR
Focus servo drive signal () output to the coil/motor driver
HCD-GB3
Pin No.
Pin Name
I/O
Description
47
IOVDD1
Power supply terminal (+3.3V)
48
AVDD0
Power supply terminal (+3.3V)
49
AVSS0
Ground terminal
50
E signal input from the optical pick-up block
51
F signal input from the optical pick-up block
52
TEI
Tracking error signal input terminal
53
TEO
Tracking error signal output terminal
54
FEI
Focus error signal input terminal
55
FEO
Focus error signal output terminal
56
VC
Middle point voltage output terminal
57
A signal input from the optical pick-up block
58
B signal input from the optical pick-up block
59
C signal input from the optical pick-up block
60
D signal input from the optical pick-up block
61
AVDD4
Power supply terminal (+3.3V)
62
RFDCO
RFDC signal output (Not used)
63
PDSENS
Reference voltage pin (Connected to ground)
64
AC_SUM
RFAC summing amplifier signal output terminal
65
EQ_IN
RF equalizer circuit input terminal
66
LD
67
PD
Light amount monitor input from the optical pick-up block laser diode
Equalizer cut off frequency adjustment terminal
Laser diode on/off control signal output to the automatic power control circuit
L: laser off, H: laser on
68
RFC
69
AVSS4
Ground terminal
70
RFACO
EFM signal output terminal
71
RFACI
EFM signal input terminal
72
AVDD3
73
BIAS
Asymmetry circuit constant current input terminal
74
ASYI
Playback EFM asymmetry comparator voltage input terminal
75
ASYO
Playback EFM full-swing output terminal
76
VPCO
Charge pump output terminal for broad-band EFM PLL (Not used)
VCO2 control voltage input terminal for broad-band EFM PLL
Power supply terminal (+3.3V)
77
VCTL
78
AVSS3
79
CLTV
VCO1 control voltage input terminal for multiplier
80
FILO
Filter output terminal for master PLL
81
FILI
Filter input terminal for master PLL
Ground terminal
82
PCO
Charge pump output terminal for master PLL
83
SVSS
Ground terminal
84
SVDD
85
SSTB-MP3
86
VDD
Power supply terminal (+1.8V)
87
VSS
Ground terminal
88
TEST1
Test terminal (Connected to ground)
89
DATA
CD serial data input from the system controller
90
CLK2
MP3 serial data transfer clock signal input from the system controller
91
SVSS
Ground terminal
92
SVDD
Power supply terminal (+1.8V)
93
JTAGTCK
Connected to ground
94
JTAGTDI
Connected to ground
Power supply terminal (+1.8V)
MP3 standby control signal input terminal L: standby (Connected to ground)
41
HCD-GB3
Pin No.
Pin Name
I/O
95
JTAGTDO
Not used
96
JTAGTMS
Connected to ground
97
TRST
Connected to ground
42
Description
98
VSS
Ground terminal
99
VDD
Power supply terminal (+1.8V)
100
IOVDD2
Power supply terminal (+3.3V)
101
DOUT
Digital audio signal output terminal (Not used)
102
TEST
Test terminal (Connected to ground)
Test terminal (Connected to ground)
103
TES1
104
IOVSS2
105
PLLVDD
Power supply terminal (+1.8V)
106
PLLVSS
Ground terminal
107
XVSS
Ground terminal
108
XTAO
System clock output terminal (16.9344 MHz)
109
XTAI
System clock input terminal (16.9344 MHz)
Ground terminal
110
XVDD
Power supply terminal (+1.8V)
111
AVDD1
Power supply terminal (+3.3V)
112
AOUT1
L-ch analog audio signal output terminal
113
VREFL
L-ch reference voltage output terminal
114
AVSS1
Ground terminal
115
AVSS2
Ground terminal
116
VREFR
R-ch reference voltage output terminal
117
AOUT2
R-ch analog audio signal output terminal
118
AVDD2
Power supply terminal (+3.3V)
119
IOVDD0
Power supply terminal (+3.3V)
120
IOVSS0
Ground terminal
HCD-GB3
PANEL BOARD IC701 MB90802-108 (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
P24
Power relay control signal output
Description
P25
Amp control signal output
P26
System reset signal output to the RF AMP
P27
Control signal output to the PB/REC EQ AMP/FUNCTION CONTROLLER
P30/SO3
Serial data output to the MP3 decoder
P31/SC3
Serial data transfer clock signal output to the MP3 decoder
P32/SI3
Serial data input
P33/TMCK
Latch pulse signal output to the RF AMP
P34/IC0
Remote sensor signal input
10
P35/IC1
Serial data latch pulse output to the MP3 decoder
11
P36/OCU0
M-MUTE signal output to the MP3 decoder
12
P37/OCU1
Data transfer request signal output to the MP3 decoder
13
X0A/P90
Resonator output terminal (32.768kHz)
14
X1A/P91
Resonator input terminal (32.768kHz)
15
VCC
Power supply terminal (+3.3V)
16
VSS
Ground terminal
17
P40/LED0
STANDBY LED control signal output
18
P41/LED1
CD switch (SW3) input terminal
19
P42/LED2
CD switch (SW1) input terminal
20
P43/LED3
CD switch (SW2) input terminal
21
P44/LED4
Serial data output to the decoder
22
P45/LED5/TOT0
Serial data transfer clock signal output to the decoder
23
P46/LED6/TOT1
Latch pulse signal output to the decoder
24
P47/LED7/TOT2
Back light LED control signal output
25
P50/TIN0
CD chuck switch (SW7) input terminal
26
P51/TIN1
CD close switch (SW6) input terminal
27
P52/TIN2/PPG0
CD stock switch (SW5) input terminal
28
P53/PPG1
CD open switch (SW8) input terminal
29
P54/SI0
Internal status (SENSE) input from the CD DSP
30
P55/SC0
Serial data transfer clock signal output to the CD DSP
31
P56/SO0
Serial data output to the CD DSP
32
AVCC
Power supply terminal (+3.3V)
33
P57/SI1
Data input from the the tuner
34
P76
Oscillator control signal output to the CD DSP
35
AVSS
Ground terminal
36
P60/AN0
Power detection signal input
37
P61/AN1
Key AD input1
38
P62/AN2
Key AD input2
39
P63/AN3
Tuner tuned status signal input
40
P64/AN4
Tape mecha status signal input
41
P65/AN5/INT0
Key AD input3
42
P66/AN6/INT1
Power down detection signal input
43
P67/AN7/INT2
Subcode data request signal input terminal
44
VSS
45
P70/AN8/INT3
Signal input from the encoder
46
P71/AN9/SC1
Audio level signal input
47
P72/AN10/SO1
SUFFIX signal input (Connected to +3.3V)
48
P73/AN11/SI2
Signal input from the volume encoder
Ground terminal
43
HCD-GB3
Pin No.
Pin Name
I/O
Description
49
P74/SDA/SC2
Data transfer request signal input from the MP3 decoder
50
P75/SCL/SO2
Acknowledge signal input from the MP3 decoder
51
MD2
Input pin for selecting operation mode (Connected to ground)
52
MD1
Input pin for selecting operation mode (Connected to +3.3V)
53
MD0
Input pin for selecting operation mode (Connected to +3.3V)
54
RSTX
System reset signal input terminal
55
V0/P80
Tuner chip enable signal output to the tuner
56
V1/P81
Clock signal output to the tuner
57
V2/P82
Data output to the tuner
58
V3
Reference power terminal of LCD controller/driver
59, 60
COM0, COM1
Common signal output to the LCD
61, 62
P83/COM2, P84/COM3
Common signal output to the LCD
63, 64
SEG0, SEG1
Segment signal output to the LCD
65
VCC
Power supply terminal (+3.3V)
66
VSS
Ground terminal
67 to 84
SEG2 to SEG19
85 to 89 SEG20/P10 to SEG24/P14
Segment signal output to the LCD
Segment signal output to the LCD
90
VCC
Power supply terminal (+3.3V)
91
VSS
Ground terminal
92
X1
Resonator input terminal (4.19MHz)
93
X0
Resonator output terminal (4.19MHz)
94 to 96 SEG25/P15 to SEG27/P17
Segment signal output to the LCD
97 to 100 SEG28/P20 to SEG31/P23
Segment signal output to the LCD
44
HCD-GB3
SECTION 8
EXPLODED VIEWS
NOTE:
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
8-1.
The mechanical parts with no reference
number in the exploded views are not supplied.
Abbreviation
AR
: Argentine model
E2
: 120V AC area in E model
MX
: Mexican model
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
OVERALL SECTION
top panel section
4
4
B
4
4
6
4
4
4
1
2
4
#1
A
chassis section
#1
front panel section
Ref. No.
1
2
2
3
4
Part No.
Description
2-669-681-02
2-669-683-01
2-669-683-11
2-669-682-02
3-254-143-11
PANEL (L), SIDE
PANEL, BACK (E2)
PANEL, BACK (AR, MX)
PANEL (R), SIDE
SCREW (B3), (+) BV TAPPING
Remark
Ref. No.
5
6
#1
Part No.
Description
Remark
3-363-099-32 SCREW (CASE 3 TP2)
1-787-319-12 FAN, DC
7-685-247-14 SCREW +KTP 3X10 TYPE2 NON-SLIT
45
HCD-GB3
8-2.
FRONT PANEL SECTION
56
58
51
52
57
70
53
54
59
67
55
68
62
61
60
65
63
66
71
69
65
not
supplied
64
not
supplied
Ref. No.
Part No.
Description
51
52
53
54
55
2-669-695-01
2-669-699-01
2-669-698-01
2-679-198-01
2-669-696-01
KNOB (VOLUME)
RING (VOLUME)
LENS (VOLUME)
SHEET (VOLUME)
KNOB (JOG)
56
57
58
59
60
2-669-702-01
2-672-558-01
X-2109-154-1
2-669-689-01
2-669-692-01
WINDOW (DISPLAY)
RING (DSGX)
BUTTON (PLAY) ASSY
KEY (DISPLAY)
KEY (POWER)
61
62
2-669-691-01 KEY (DSGX)
2-669-690-01 KEY (EQ)
46
Remark
Ref. No.
not
supplied
Part No.
68
Description
63
64
65
2-669-693-01 KEY (ENTER)
2-672-557-01 KEY (EJECT)
4-225-252-01 CUSHION (FOOT)
66
67
67
67
68
2-669-680-01
A-1177-458-A
A-1177-460-A
A-1177-461-A
4-951-620-01
69
70
71
1-832-657-21 CABLE, FLEXIBLE FLAT (29 CORE)
2-669-697-01 LENS (STANDBY)
3-701-748-00 CLAMP
PANEL, FRONT
PANEL BOARD, COMPLETE (E2)
PANEL BOARD, COMPLETE (MX)
PANEL BOARD, COMPLETE (AR)
SCREW (2.6X8), +BVTP
Remark
HCD-GB3
8-3.
CHASSIS SECTION
103
CD mechanism deck section
(BU-K6BD83S2-WOD)
not
supplied
103
103
112
110
103
113
114
109
116
103
103
not
supplied
not
supplied
#2
#2
PT001
F051
103
not
supplied
108
111
115
103
105
not
supplied
not
supplied
106
not
supplied
103
103
105
107
103
not
supplied
not
supplied
104
101
102
103
Ref. No.
Part No.
Description
101
102
103
104
105
2-649-153-41
4-225-252-01
3-254-143-11
3-229-336-11
2-633-134-01
CHASSIS (MAIN MOLD)
CUSHION (FOOT)
SCREW (B3), (+) BV TAPPING
SCREW, +BVWH TAPPING
SCREW (B2.6), (+) BV TAPPING
106
107
108
109
110
2-681-036-01
1-832-837-21
X-2109-155-1
1-831-612-21
A-1177-468-A
COVER (CD MECHA)
CABLE, FLEXIBLE FLAT (13 CORE)
DOOR (CD) ASSY
CABLE, FLEXIBLE FLAT (23 CORE)
MAIN BOARD, COMPLETE
111
112
3-701-748-00 CLAMP
A-1177-469-A AMP BOARD, COMPLETE
Remark
Ref. No.
Part No.
113
0 114
0 114
3-905-609-31 SCREW (TRANSISTOR)
1-831-370-11 CORD, POWER (E2)
1-832-228-11 CORD, POWER (AR)
Description
0 114
115
115
115
116
1-832-377-11
A-1177-464-A
A-1177-466-A
A-1177-467-A
4-900-386-01
CORD, POWER (MX)
POWER BOARD, COMPLETE (E2)
POWER BOARD, COMPLETE (MX)
POWER BOARD, COMPLETE (AR)
SCREW
0 F051
0 PT001
0 PT001
#2
1-532-237-00
1-443-911-11
1-443-995-21
7-685-661-14
FUSE (T3.15AL/250V)
TRANSFORMER, POWER (E2, AR)
TRANSFORMER, POWER (MX)
SCREW +BVTP 4X12 TYPE2 IT-3
Remark
47
HCD-GB3
8-4.
TOP PANEL SECTION
157
156
158
155
154
not
supplied
153
162
159
not
supplied
151
152
#3
160
161
151
Ref. No.
Part No.
Description
151
152
153
154
155
4-951-620-01
2-649-154-01
2-649-132-11
3-921-725-01
3-047-468-01
SCREW (2.6X8), +BVTP
LEVER (REC)
BUTTON (CASS)
SCREW (2.6X10), +PWH
DAMPER
156
157
2-649-131-11 BOX, CASSETTE
2-649-152-02 SPRING (CASS)
48
Remark
Ref. No.
Part No.
Description
158
159
160
2-649-128-61 PANEL, TOP
1-797-575-11 DECK, MECHANICAL
2-688-622-01 BELT (MAIN)
161
162
#3
2-688-621-01 BELT (R/F)
3-701-748-00 CLAMP
7-685-850-04 SCREW +BVTT 2X3 (S)
Remark
HCD-GB3
8-5.
CD MECHANISM DECK SECTION (BU-K6BD83S2-WOD)
206
206
not
supplied
207
203
not
supplied
205
208
204
202
209
205
205
204
204
202
202
205
204
202
S201
201
Ref. No.
201
202
203
204
205
Part No.
Description
A-1179-506-A
4-985-672-01
2-632-062-01
4-227-045-11
4-227-549-11
BD83S BOARD, COMPLETE
SCREW (+PTPWHM2.6), FLOATING
BELT (DLM3A)
SPRING (INSULATOR), COIL
INSULATOR
Remark
Ref. No.
Part No.
Description
206
207
208
0 209
S201
4-951-620-01
1-797-193-12
1-832-404-21
A-4735-357-A
1-771-853-11
SCREW (2.6X8), +BVTP
MECHANICAL, CD (DLM3A23-11)
CABLE, FLEXIBLE FLAT (16 CORE)
OP BASE ASSY (KSM-213DHAP/ZRP1)
SWITCH, DETECTION (LIMIT)
Remark
49
HCD-GB3
SECTION 9
ELECTRICAL PARTS LIST
AMP
NOTE:
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
Ref. No.
Part No.
CAPACITORS
uF: F
COILS
uH: H
Items marked * are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
SEMICONDUCTORS
In each case, u: , for example:
uA. . : A. .
uPA. . : PA. .
uPB. . : PB. .
uPC. . : PC. .
uPD. . : PD. .
Description
Remark
Ref. No.
Part No.
A-1177-469-A AMP BOARD, COMPLETE
********************
C201
C202
C203
C204
C205
1-162-960-11
1-162-960-11
1-126-963-11
1-126-963-11
1-162-960-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
220PF
220PF
4.7uF
4.7uF
220PF
10%
10%
20%
20%
10%
50V
50V
50V
50V
50V
C206
C209
C210
C211
C212
1-162-960-11
1-162-915-11
1-162-915-11
1-162-966-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
10PF
10PF
0.0022uF
0.0022uF
10%
0.5PF
0.5PF
10%
10%
50V
50V
50V
50V
50V
C244
C251
C252
C253
C254
1-162-970-11
1-165-621-91
1-165-621-91
1-162-966-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
10%
0.1uF
0.1uF
0.0022uF 10%
0.0022uF 10%
25V
50V
50V
50V
50V
C901
C902
C903
C921
1-126-963-11
1-126-967-11
1-126-967-11
1-126-963-11
ELECT
ELECT
ELECT
ELECT
4.7uF
47uF
47uF
4.7uF
50V
50V
50V
50V
20%
20%
20%
20%
< CONNECTOR >
1-819-133-11
1-815-446-11
1-815-445-11
1-819-131-11
PIN, CONNECTOR
PIN, CONNECTOR (PWB) 5P
PIN, CONNECTOR (PWB) 4P
PIN, CONNECTOR 3P
< DIODE >
D241
Abbreviation
AR
: Argentine model
E2
: 120V AC area in E model
MX
: Mexican model
Description
Remark
R201
R202
R203
R204
R205
1-216-864-11
1-216-864-11
1-216-841-11
1-216-841-11
1-216-833-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
47K
47K
10K
5%
5%
5%
1/10W
1/10W
1/10W
R206
R207
R208
R211
R212
1-216-833-11
1-216-809-11
1-216-809-11
1-216-839-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
100
33K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R213
R214
R215
R216
R217
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R218
R219
R220
R221
R222
1-216-821-11
1-216-821-11
1-216-821-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R223
R224
R225
R226
R227
1-216-833-11
1-216-833-11
1-216-837-11
1-216-837-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
22K
22K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R228
R231
R232
R233
R234
1-216-825-11
1-216-813-11
1-216-813-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
220
220
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0 R235
0 R236
0 R237
0 R238
R241
1-216-361-31
1-216-361-31
1-216-361-31
1-216-361-31
1-216-833-11
METAL OXIDE
METAL OXIDE
METAL OXIDE
METAL OXIDE
METAL CHIP
0.22
0.22
0.22
0.22
10K
5%
5%
5%
5%
5%
2W
2W
2W
2W
1/10W
R242
R243
R244
R245
R246
1-216-833-11
1-216-821-11
1-216-845-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
100K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R247
R248
R249
R251
R252
1-216-853-11
1-216-833-11
1-216-829-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
10K
4.7K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
6-500-335-01 DIODE MC2838-T112-1
< IC >
IC202
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
< RESISTOR >
< CAPACITOR >
CNP201
CNP202
CNP901
CNP902
When indicating parts by reference number,
please include the board name.
6-709-529-01 IC STK432-070
< TRANSISTOR >
Q201
Q202
Q241
Q242
Q243
6-551-270-01
6-551-270-01
8-729-120-28
8-729-600-22
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA2026
2SA2026
2SC3052F-T1-LF
2SA1235TP-1EF
2SC3052F-T1-LF
Q244
Q901
Q902
Q903
8-729-600-22
8-729-120-28
8-729-600-22
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1235TP-1EF
2SC3052F-T1-LF
2SA1235TP-1EF
2SC3052F-T1-LF
50
HCD-GB3
AMP
Ref. No.
Part No.
Description
Remark
R253
R904
R905
R906
R907
1-216-833-11
1-216-833-11
1-216-841-11
1-216-817-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
47K
470
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R908
R909
R910
R911
R921
1-216-829-11
1-216-833-11
1-216-805-11
1-216-805-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
47
47
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R922
R923
R924
1-216-805-11 METAL CHIP
1-216-849-11 METAL CHIP
1-216-825-11 METAL CHIP
47
220K
2.2K
5%
5%
5%
1/10W
1/10W
1/10W
Ref. No.
BD83S
Part No.
Description
C232
C251
C252
C253
C254
1-164-360-11
1-164-315-11
1-162-968-11
1-164-315-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
470PF
0.0047uF
470PF
0.0047uF
Remark
5%
10%
5%
10%
16V
50V
50V
50V
50V
C256
C257
C258
C260
C261
1-107-826-11
1-107-826-11
1-164-230-11
1-117-863-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
220PF
0.47uF
0.01uF
10%
10%
5%
10%
10%
16V
16V
50V
6.3V
25V
C264
C265
C266
C267
C268
1-162-964-11
1-107-826-11
1-162-915-11
1-162-910-11
1-162-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
10PF
5PF
10PF
10%
10%
0.5PF
0.25PF
0.5PF
50V
16V
50V
50V
50V
C271
C272
C273
C274
C275
1-107-826-11
1-164-360-11
1-164-315-11
1-107-826-11
1-162-910-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
470PF
0.1uF
5PF
10%
16V
16V
5%
50V
10%
16V
0.25PF 50V
C276
C277
C291
C292
C301
1-165-908-11
1-165-908-11
1-164-315-11
1-164-315-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
470PF
470PF
0.1uF
10%
10%
5%
5%
10V
10V
50V
50V
16V
C303
C304
C321
C322
C323
1-137-710-11
1-165-908-11
1-162-964-11
1-165-908-11
1-128-995-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
10uF
1uF
0.001uF
1uF
100uF
20%
10%
10%
10%
20%
6.3V
10V
50V
10V
10V
C401
C404
C405
C406
C424
1-128-394-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
10V
16V
16V
16V
16V
C451
1-165-176-11 CERAMIC CHIP
0.047uF
10%
16V
< THERMISTOR >
TH241 1-805-217-21 THERMISTOR (1012)
*************************************************************
A-1179-506-A BD83S BOARD, COMPLETE
**********************
< CAPACITOR >
C101
C102
C103
C104
C105
1-162-919-11
1-162-919-11
1-162-927-11
1-164-230-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
100PF
220PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C107
C108
C109
C110
C111
1-164-230-11
1-164-230-11
1-164-230-11
1-164-230-11
1-164-230-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
220PF
220PF
220PF
220PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C112
C113
C201
C202
C203
1-162-927-11
1-162-927-11
1-128-995-21
1-164-360-11
1-128-995-21
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
100PF
100PF
100uF
0.1uF
100uF
5%
5%
20%
50V
50V
10V
16V
10V
C204
C205
C206
C207
C208
1-164-360-11
1-164-360-11
1-164-360-11
1-128-995-21
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
100uF
0.1uF
C210
C213
C214
C215
C217
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
IC201
IC203
IC402
C218
C219
C220
C221
C222
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
Q321
C223
C224
C226
C227
C230
1-164-360-11
1-164-360-11
1-165-908-11
1-165-908-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
1uF
1uF
100PF
16V
16V
10V
10V
50V
20%
< CONNECTOR >
20%
10%
10%
5%
16V
16V
16V
10V
16V
CN102
CN301
1-770-706-21 CONNECTOR, FFC/FPC 23P
1-770-425-51 CONNECTOR, FFC/FPC 16P
< IC >
8-753-246-30 IC CXD3014A-201R
6-709-050-01 IC BH18LB1WG-TR
6-705-808-01 IC BA5947FM-E2
< TRANSISTOR >
6-551-120-01 TRANSISTOR
2SA2119K
< RESISTOR >
R101
R102
R103
R104
R105
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R107
R108
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/10W
1/10W
51
HCD-GB3
BD83S
Ref. No.
JACK
Part No.
MAIN
Description
R109
R110
R111
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
R112
R113
R201
R202
R203
Remark
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
1-216-809-11
1-216-809-11
1-216-295-91
1-216-295-91
1-500-445-21
METAL CHIP
100
5%
METAL CHIP
100
5%
SHORT CHIP
0
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
1/10W
1/10W
R207
R250
R252
R253
R254
1-216-295-91
1-216-857-11
1-216-833-11
1-216-821-11
1-216-833-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
1M
10K
1K
10K
R255
R256
R257
R258
R260
1-216-821-11
1-216-837-11
1-216-845-11
1-216-849-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
R265
R266
R267
R268
R270
1-216-829-11
1-216-821-11
1-216-829-11
1-216-833-11
1-216-821-11
R271
R275
R276
R277
R278
Ref. No.
1/10W
1/10W
1/10W
1/10W
1K
22K
100K
220K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
4.7K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-216-857-11
1-216-809-11
1-216-841-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
100
47K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R280
R291
R292
R321
R322
1-216-864-11
1-216-809-11
1-216-809-11
1-216-789-11
1-216-789-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
100
2.2
2.2
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R323
R324
R401
R421
R423
1-216-864-11
1-216-845-11
1-216-295-91
1-216-864-11
1-216-833-11
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
100K
0
0
10K
5%
1/10W
5%
1/10W
R451
R452
1-216-837-11 METAL CHIP
1-216-833-11 METAL CHIP
22K
10K
5%
5%
1/10W
1/10W
Description
Remark
< JUMPER RESISTOR >
JR111
1-216-864-11 SHORT CHIP
< COIL >
L103
L104
L105
L106
5%
5%
5%
5%
Part No.
1-469-152-11
1-469-152-11
1-216-295-91
1-216-295-91
FERRITE, EMI (SMD) (2012)
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
SHORT CHIP
0
< RESISTOR >
R119
R120
R151
R152
R175
1-216-805-11
1-216-805-11
1-216-829-11
1-216-829-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
47
4.7K
4.7K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R176
1-216-841-11 METAL CHIP
47K
5%
1/10W
< CABLE HOLDER >
< VIBRATOR >
X201
1-795-101-21 VIBRATOR, CERAMIC (16.9344MHz)
*************************************************************
A-1177-470-A JACK BOARD
***********
< CAPACITOR >
C139
C140
C141
C142
1-164-156-11
1-164-156-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
< JACK >
J102
J105
52
1-815-629-11 JACK (PHONES)
1-566-822-51 JACK (AUDIO IN)
0.1uF
0.1uF
0.01uF
0.01uF
10%
10%
25V
25V
25V
25V
WH171 1-819-972-11 HOLDER, CABLE 8P
*************************************************************
A-1177-468-A MAIN BOARD, COMPLETE
*********************
< CAPACITOR >
C101
C102
C105
C106
C111
1-128-550-11
1-128-550-11
1-165-621-91
1-165-621-91
1-126-933-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
2200uF
2200uF
0.1uF
0.1uF
100uF
20%
20%
20%
50V
50V
50V
50V
16V
C112
C113
C114
C115
C116
1-126-943-11
1-126-942-61
1-100-566-91
1-100-566-91
1-164-227-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2200uF
1000uF
0.1uF
0.1uF
0.022uF
20%
20%
10%
10%
10%
25V
25V
25V
25V
25V
C121
C130
C131
C132
C133
1-117-863-11
1-126-923-91
1-164-227-11
1-165-621-91
1-162-970-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
220uF
0.022uF
0.1uF
0.01uF
10%
20%
10%
6.3V
10V
25V
50V
25V
C134
C151
C152
C153
C155
1-162-962-11
1-126-933-11
1-125-891-11
1-125-891-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
100uF
0.47uF
0.47uF
0.1uF
10%
20%
10%
10%
C156
C158
C159
C181
C182
1-164-156-11
1-165-621-91
1-165-621-91
1-100-566-91
1-100-566-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
C183
C184
C187
C188
C191
1-100-566-91
1-100-566-91
1-162-974-11
1-162-974-11
1-126-923-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.01uF
0.01uF
220uF
20%
25V
25V
50V
50V
10V
C192
C193
1-100-566-91 CERAMIC CHIP
1-100-566-91 CERAMIC CHIP
0.1uF
0.1uF
10%
10%
25V
25V
10%
10%
10%
10%
10%
50V
16V
10V
10V
25V
25V
50V
50V
25V
25V
HCD-GB3
MAIN
Ref. No.
Part No.
Description
Remark
C194
C195
C196
1-100-566-91 CERAMIC CHIP
1-100-566-91 CERAMIC CHIP
1-100-566-91 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
10%
10%
10%
25V
25V
25V
C197
C198
C401
C402
C403
1-126-925-91
1-100-566-91
1-126-956-91
1-126-933-11
1-100-566-91
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
470uF
0.1uF
0.1uF
100uF
0.1uF
20%
10%
20%
20%
10%
10V
25V
50V
16V
25V
C404
C405
C406
C407
C408
1-125-837-91
1-126-956-91
1-125-837-91
1-162-968-11
1-162-968-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
1uF
0.0047uF
0.0047uF
10%
20%
10%
10%
10%
6.3V
50V
6.3V
50V
50V
C409
C410
C412
C413
C415
1-100-566-91
1-100-566-91
1-126-925-91
1-126-933-11
1-100-566-91
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.1uF
0.1uF
470uF
100uF
0.1uF
10%
10%
20%
20%
10%
25V
25V
10V
16V
25V
C416
C417
C418
C421
C431
1-100-566-91
1-126-956-91
1-126-956-91
1-100-566-91
1-115-467-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.22uF
10%
20%
20%
10%
10%
25V
50V
50V
25V
10V
C432
C433
C434
C437
C438
1-115-467-11
1-162-962-11
1-162-962-11
1-162-962-11
1-162-962-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
470PF
470PF
470PF
470PF
10%
10%
10%
10%
10%
10V
50V
50V
50V
50V
C501
C502
C503
C504
C505
1-162-923-11
1-162-923-11
1-162-962-11
1-162-962-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
47PF
470PF
470PF
0.047uF
5%
5%
10%
10%
10%
50V
50V
50V
50V
16V
C506
C507
C508
C509
C510
1-165-176-11
1-162-970-11
1-162-970-11
1-126-933-11
1-126-933-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.047uF
0.01uF
0.01uF
100uF
100uF
10%
10%
10%
20%
20%
16V
25V
25V
16V
16V
C511
C512
C513
C514
C515
1-162-962-11
1-162-962-11
1-162-964-11
1-162-964-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
470PF
0.001uF
0.001uF
47PF
10%
10%
10%
10%
5%
50V
50V
50V
50V
50V
C522
C523
C524
C525
C526
1-162-927-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.01uF
0.01uF
0.01uF
0.01uF
5%
10%
10%
10%
10%
50V
25V
25V
25V
25V
C527
C528
C529
C530
C531
1-162-964-11
1-162-964-11
1-162-927-11
1-100-566-91
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
100PF
0.1uF
0.001uF
10%
10%
5%
10%
10%
50V
50V
50V
25V
50V
C532
C543
C544
C551
C561
1-162-964-11
1-162-964-11
1-162-964-11
1-126-965-91
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
22uF
0.0022uF
10%
10%
10%
20%
10%
50V
50V
50V
50V
50V
Ref. No.
Part No.
Description
Remark
C562
C564
C565
C566
C567
1-162-966-11
1-162-970-11
1-115-156-11
1-162-966-11
1-137-391-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
0.0022uF
0.01uF
1uF
0.0022uF
0.0047uF
10%
10%
10%
5%
50V
25V
10V
50V
100V
C568
C570
C571
C573
C574
1-125-837-91
1-125-837-91
1-100-566-91
1-125-837-91
1-125-837-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.1uF
1uF
1uF
10%
10%
10%
10%
10%
6.3V
6.3V
25V
6.3V
6.3V
C577
C801
C802
C803
C804
1-125-837-91
1-126-933-11
1-100-566-91
1-162-970-11
1-100-566-91
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
100uF
0.1uF
0.01uF
0.1uF
10%
20%
10%
10%
10%
6.3V
16V
25V
25V
25V
C806
C807
C809
C810
C811
1-162-964-11
1-162-966-11
1-100-566-91
1-115-467-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.0022uF
0.1uF
0.22uF
0.1uF
10%
10%
10%
10%
50V
50V
25V
10V
25V
C812
C813
C814
C815
C816
1-164-156-11
1-126-923-91
1-164-156-11
1-162-927-11
1-115-467-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220uF
0.1uF
100PF
0.22uF
5%
10%
25V
10V
25V
50V
10V
C817
C818
C819
C820
C821
1-100-566-91
1-162-964-11
1-162-964-11
1-162-964-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.001uF
0.001uF
0.001uF
0.047uF
10%
10%
10%
10%
10%
25V
50V
50V
50V
16V
C822
C823
C824
C825
C826
1-162-962-11
1-162-918-11
1-162-918-11
1-125-837-91
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
18PF
18PF
1uF
100PF
10%
5%
5%
10%
5%
50V
50V
50V
6.3V
50V
C827
C828
C829
C830
C831
1-162-927-11
1-162-927-11
1-162-970-11
1-162-970-11
1-117-863-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.01uF
0.01uF
0.47uF
5%
5%
10%
10%
10%
50V
50V
25V
25V
6.3V
C832
C833
C834
C835
C836
1-117-863-11
1-117-863-11
1-126-923-91
1-115-467-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.47uF
0.47uF
220uF
0.22uF
0.22uF
10%
10%
20%
10%
10%
6.3V
6.3V
10V
10V
10V
C838
C839
C840
C841
C847
1-100-566-91
1-100-566-91
1-117-863-11
1-126-965-91
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
0.47uF
22uF
0.0022uF
10%
10%
10%
20%
10%
25V
25V
6.3V
50V
50V
C848
C851
C852
C853
C854
1-162-966-11
1-165-176-11
1-162-915-11
1-164-227-11
1-162-915-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.047uF
10PF
0.022uF
10PF
10%
10%
0.5PF
10%
0.5PF
50V
16V
50V
25V
50V
C855
C856
1-162-962-11 CERAMIC CHIP
1-162-910-11 CERAMIC CHIP
470PF
5PF
10%
50V
0.25PF 50V
20%
53
HCD-GB3
MAIN
Ref. No.
C873
Part No.
Description
1-162-907-11 CERAMIC CHIP
Remark
2PF
< FILTER >
CF801
CF802
CF803
1-795-426-11 FILTER, CERAMIC (107MHz)
1-579-554-21 FILTER, CERAMIC (107MHz)
1-781-962-21 FILTER, CERAMIC (450kHz)
< CONNECTOR >
CNP151
CNP171
CNP501
CNP502
* CNP802
1-819-136-11
1-815-449-11
1-815-447-11
1-815-444-11
1-506-680-11
Ref. No.
Part No.
PIN, CONNECTOR 8P
PIN, CONNECTOR (PWB) 8P
PIN, CONNECTOR (PWB) 6P
PIN, CONNECTOR (PWB) 3P
PLUG, CONNECTOR (2.5MM) 3P
(ANTENNA FM/AM)
D107
D108
D109
D110
D111
6-501-046-01
6-501-046-01
6-501-046-01
6-501-046-01
8-719-063-79
DIODE
DIODE
DIODE
DIODE
DIODE
1N5402-F46
1N5402-F46
1N5402-F46
1N5402-F46
1N4002B
D113
D131
D132
D154
D156
8-719-063-79
8-719-063-79
8-719-000-07
6-500-335-01
8-719-000-07
DIODE
DIODE
DIODE
DIODE
DIODE
1N4002B
1N4002B
MC2836
MC2838-T112-1
MC2836
D191
D192
D193
D501
D502
8-719-063-79
8-719-063-79
6-501-164-01
6-500-848-01
6-500-848-01
DIODE
DIODE
DIODE
DIODE
DIODE
1N4002B
1N4002B
UDZW-TE17-3.9B
MC2840-T112-1
MC2840-T112-1
D503
D504
D505
D506
D508
6-500-848-01
6-500-848-01
6-500-848-01
6-500-848-01
6-501-193-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2840-T112-1
MC2840-T112-1
MC2840-T112-1
MC2840-T112-1
1SS355WTE-17
D510
D511
D802
D803
D812
6-501-193-01
6-501-193-01
6-501-369-01
6-501-369-01
8-719-062-51
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
1SS355WTE-17
SV230-TB-E
SV230-TB-E
1PS226-115
D813
D814
D851
D901
8-719-062-51
8-719-062-51
6-501-142-01
6-500-335-01
DIODE
DIODE
DIODE
DIODE
1PS226-115
1PS226-115
SVC347A-TL-E
MC2838-T112-1
< IC >
IC401
IC402
IC801
6-702-895-01 IC BD3881FV
8-759-909-71 IC BA4558F-E2
6-708-840-01 IC LV23003VA
Remark
JR101
JR102
JR103
JR104
JR105
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR106
JR107
JR108
JR109
JR110
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR801
JR802
JR803
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
0
0
0
CNS104 1-779-291-11 CONNECTOR, FFC (LIF (NON-ZIF)) 23P
CNS111 1-779-297-11 CONNECTOR, FFC (LIF (NON-ZIF)) 29P
< DIODE >
Description
< JUMPER RESISTOR >
0.25PF 50V
< COIL >
L101
L102
L501
L803
L804
1-456-107-11
1-456-107-11
1-456-094-11
1-433-741-11
1-457-163-11
COIL, AIR-CORE
COIL, AIR-CORE
TRANSFORMER, BIAS OSCILLATION
TRANSFORMER, IF
COIL, AIR-CORE
L805
L806
L851
L852
1-457-162-11
1-457-168-11
1-457-161-11
1-456-596-11
COIL, AIR-CORE
COIL, DET
COIL, AM ANTENNA
COIL, MW OSC
< TRANSISTOR >
Q102
Q121
Q122
Q131
Q132
8-729-120-28
8-729-120-28
8-729-120-28
6-550-889-01
6-550-889-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC5938-T112-1B
2SC5938-T112-1B
Q133
Q134
Q135
Q137
Q138
8-729-027-38
1-801-806-11
8-729-120-28
6-550-889-01
6-550-889-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1P441C-TP-1
RT1N441C-TP-1
2SC3052F-T1-LF
2SC5938-T112-1B
2SC5938-T112-1B
Q151
Q152
Q153
Q154
Q191
8-729-120-28
8-729-600-22
8-729-120-28
8-729-600-22
8-729-036-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
2SA1235TP-1EF
2SC3052F-T1-LF
2SA1235TP-1EF
KTC3203Y-AT
Q192
Q193
Q501
Q502
Q507
8-729-036-86
8-729-600-22
8-729-040-76
8-729-120-28
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KTC3203Y-AT
2SA1235TP-1EF
KTA1273-Y-AT
2SC3052F-T1-LF
2SC1740S-RT
Q508
Q801
Q802
Q803
8-729-119-78
8-729-120-28
8-729-120-28
6-550-304-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1740S-RT
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC5477-T122-1
< RESISTOR >
< JACK >
J101
54
1-536-708-81 TERMINAL BOARD, PUSH (4P)
(SPEAKER IMPEDANCE 6)
R101
R103
R104
R105
R106
1-216-825-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
47K
47K
47K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
HCD-GB3
MAIN
Ref. No.
Part No.
Description
Remark
R107
R108
R109
R110
R111
1-216-837-11
1-216-825-11
1-216-789-11
1-216-789-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
2.2K
2.2
2.2
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R112
R113
R114
R115
R116
1-216-809-11
1-216-809-11
1-216-809-11
1-247-807-31
1-247-807-31
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
CARBON
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/4W
R117
R118
R121
R123
R124
1-247-807-31
1-247-807-31
1-216-849-11
1-216-853-11
1-216-809-11
CARBON
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
100
100
220K
470K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/10W
1/10W
1/10W
R125
R127
R128
R129
R130
1-216-837-11
1-249-401-11
1-249-401-11
1-249-401-11
1-216-829-11
METAL CHIP
CARBON
CARBON
CARBON
METAL CHIP
22K
47
47
47
4.7K
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/4W
1/10W
R131
R132
R133
R134
R135
1-216-841-11
1-216-829-11
1-216-829-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
4.7K
4.7K
470
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R136
R137
R138
R139
R140
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
470
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R142
R144
R145
R146
R147
1-216-845-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
470
470
470
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R148
R149
R150
R153
R154
1-216-817-11
1-216-817-11
1-216-817-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
220K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R155
R156
R157
R158
R159
1-216-841-11
1-216-833-11
1-216-825-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
2.2K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R160
R161
R162
R163
R164
1-216-825-11
1-216-825-11
1-216-809-11
1-216-833-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
100
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R165
R166
R167
R168
R169
1-216-833-11
1-216-837-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R170
R171
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
10K
10K
5%
5%
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
R172
R174
R177
1-216-833-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-829-11 METAL CHIP
10K
100
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
R178
R179
R180
R181
R182
1-216-829-11
1-216-864-11
1-216-864-11
1-216-797-11
1-216-797-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
4.7K
0
0
10
10
5%
1/10W
5%
5%
1/10W
1/10W
R183
R184
R185
R186
R188
1-216-797-11
1-216-797-11
1-247-807-31
1-247-807-31
1-216-837-11
METAL CHIP
METAL CHIP
CARBON
CARBON
METAL CHIP
10
10
100
100
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/4W
1/10W
R189
R191
R192
R193
R194
1-216-837-11
1-216-821-11
1-216-845-11
1-216-845-11
1-249-401-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
22K
1K
100K
100K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/4W
R195
R196
R197
R198
R199
1-216-809-11
1-216-809-11
1-249-401-11
1-249-401-11
1-247-807-31
METAL CHIP
METAL CHIP
CARBON
CARBON
CARBON
100
100
47
47
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/4W
1/4W
R200
R402
R403
R404
R405
1-247-807-31
1-216-809-11
1-216-821-11
1-216-813-11
1-216-813-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
1K
220
220
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R406
R410
R411
R412
R419
1-216-821-11
1-216-845-11
1-216-821-11
1-216-813-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
1K
220
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R420
R423
R424
R425
R426
1-216-837-11
1-216-833-11
1-216-832-11
1-216-832-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
8.2K
8.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R427
R428
R429
R430
R433
1-216-845-11
1-216-845-11
1-216-829-11
1-216-829-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
4.7K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R434
R439
R440
R441
R442
1-216-837-11
1-216-829-11
1-216-829-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
4.7K
4.7K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R501
R502
R503
R504
R505
1-216-809-11
1-216-809-11
1-216-829-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
4.7K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R506
R507
R508
R509
R510
1-216-833-11
1-216-825-11
1-216-825-11
1-216-853-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
2.2K
470K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
55
HCD-GB3
MAIN
Ref. No.
Part No.
Description
Remark
R511
R512
R513
R514
R515
1-216-861-11
1-216-861-11
1-216-809-11
1-216-809-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2M
2.2M
100
100
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R516
R517
R518
R519
R520
1-216-805-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R521
R522
R523
R524
R525
1-216-837-11
1-216-837-11
1-216-829-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
4.7K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R526
R527
R528
R529
R530
1-216-833-11
1-216-829-11
1-216-829-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
4.7K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R531
R532
R533
R534
R535
1-216-829-11
1-216-829-11
1-216-833-11
1-216-833-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
10K
10K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R536
R541
R542
R543
R544
1-216-805-11
1-216-837-11
1-216-833-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
22K
10K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R545
R560
R561
R564
R565
1-216-829-11
1-216-864-11
1-216-793-11
1-216-833-11
1-216-833-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
0
4.7
10K
10K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R566
R567
R568
R570
R571
1-216-809-11
1-216-849-11
1-216-837-11
1-216-821-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
220K
22K
1K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R572
R573
R574
R575
R576
1-216-845-11
1-216-833-11
1-216-809-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
100
22K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R577
R578
R579
R581
R582
1-216-845-11
1-216-833-11
1-216-833-11
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
10K
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R583
R584
R801
R802
R803
1-216-841-11
1-216-849-11
1-216-825-11
1-216-797-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
220K
2.2K
10
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R804
R805
1-216-864-11 SHORT CHIP
1-216-845-11 METAL CHIP
0
100K
5%
1/10W
56
Ref. No.
Part No.
Description
Remark
R806
R807
R808
1-216-864-11 SHORT CHIP
1-216-845-11 METAL CHIP
1-216-833-11 METAL CHIP
0
100K
10K
5%
5%
1/10W
1/10W
R809
R810
R811
R812
R813
1-216-821-11
1-216-857-11
1-216-829-11
1-216-817-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1M
4.7K
470
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R814
R815
R816
R817
R818
1-216-809-11
1-216-829-11
1-216-833-11
1-216-833-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
4.7K
10K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R819
R820
R821
R822
R823
1-216-833-11
1-216-821-11
1-216-813-11
1-216-825-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
220
2.2K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R824
R825
R826
R827
R828
1-216-825-11
1-216-817-11
1-216-809-11
1-216-809-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
470
100
100
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R829
R830
R831
R833
R834
1-216-845-11
1-216-841-11
1-216-813-11
1-216-833-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
47K
220
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R835
R836
R837
R838
R839
1-216-829-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
10K
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R840
R841
R842
R843
R844
1-216-837-11
1-216-809-11
1-216-841-11
1-216-853-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
100
47K
470K
10
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R845
R846
R848
R849
R850
1-216-801-11
1-216-825-11
1-216-821-11
1-216-837-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
2.2K
1K
22K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R851
R852
R853
R855
R859
1-216-837-11
1-216-801-11
1-216-845-11
1-216-853-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22
100K
470K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R860
R863
R901
R902
1-216-833-11
1-216-837-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
4.7K
4.7K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< RELAY >
RY131
1-755-307-11 RELAY
HCD-GB3
MAIN
Ref. No.
Part No.
Description
Remark
< SWITCH >
SW501
1-762-369-11 SWITCH, SLIDE (a/H)
< CABLE HOLDER >
WH101
WH102
WH203
WH901
1-824-030-21
1-824-030-21
1-824-027-21
1-824-029-21
HOLDER, CABLE 5P
HOLDER, CABLE 5P
HOLDER, CABLE 3P
HOLDER, CABLE 4P
Ref. No.
Part No.
PANEL
Description
Remark
C737
C738
C739
1-162-964-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
0.001uF
0.001uF
0.001uF
10%
10%
10%
50V
50V
50V
C741
C742
C743
C746
C747
1-162-960-11
1-162-960-11
1-162-960-11
1-162-968-11
1-162-964-11
220PF
220PF
220PF
0.0047uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C750
1-126-963-11 ELECT
4.7uF
20%
50V
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
< VIBRATOR >
< CONNECTOR >
X801
1-767-388-21 VIBRATOR, CRYSTAL (75kHz)
*************************************************************
A-1177-458-A PANEL BOARD, COMPLETE (E2)
A-1177-460-A PANEL BOARD, COMPLETE (MX)
A-1177-461-A PANEL BOARD, COMPLETE (AR)
**********************
CNS671 1-784-735-11 CONNECTOR, FFC 13P
CNS701 1-779-297-11 CONNECTOR, FFC (LIF (NON-ZIF)) 29P
< DIODE >
D509
D701
D702
2-669-704-01 GUIDE, LCD
6-501-193-01 DIODE 1SS355WTE-17
6-501-163-01 DIODE UDZW-TE17-3.6B
8-719-000-07 DIODE MC2836
< IC >
< CAPACITOR >
50V
25V
25V
25V
10V
IC701
IC702
IC703
6.3V
25V
25V
50V
50V
JR701
JR702
JR703
JR704
JR705
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
50V
10V
25V
25V
50V
JR706
JR707
JR708
JR709
JR710
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
10%
10%
50V
50V
25V
50V
50V
JR711
JR712
JR713
JR714
JR715
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
10%
20%
10%
10%
5%
16V
10V
50V
50V
50V
JR716
JR717
JR718
JR719
JR720
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
10%
10%
25V
25V
25V
50V
50V
C671
C672
C701
C702
C703
1-126-965-91
1-100-566-91
1-164-156-11
1-162-970-11
1-124-584-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
22uF
0.1uF
0.1uF
0.01uF
100uF
20%
10%
C704
C705
C706
C707
C708
1-119-941-91
1-162-970-11
1-164-156-11
1-162-964-11
1-162-923-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470uF
0.01uF
0.1uF
0.001uF
47PF
20%
10%
C709
C710
C711
C712
C713
1-162-964-11
1-115-467-11
1-164-156-11
1-164-156-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.22uF
0.1uF
0.1uF
47PF
10%
10%
C714
C715
C716
C717
C718
1-162-964-11
1-162-964-11
1-164-156-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.1uF
0.001uF
0.001uF
10%
10%
C719
C721
C722
C723
C724
1-165-176-11
1-126-925-91
1-162-968-11
1-162-964-11
1-162-923-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
470uF
0.0047uF
0.001uF
47PF
C725
C726
C727
C728
C729
1-164-156-11
1-164-156-11
1-164-156-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.001uF
0.001uF
C730
C731
C732
C733
C734
1-162-964-11
1-164-156-11
1-162-919-11
1-162-919-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
22PF
22PF
0.001uF
C735
C736
1-162-964-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.001uF
0.1uF
10%
20%
10%
5%
5%
10%
5%
5%
10%
10%
50V
25V
50V
50V
50V
50V
25V
6-806-467-01 IC MB90802PF-G-113E1
6-704-046-01 IC BU2099FV
6-600-446-01 IC RPM7240-H18
< JUMPER RESISTOR >
< COIL >
L701
1-216-864-11 SHORT CHIP
< LIQUID CRYSTAL DISPLAY >
LCD702 1-805-973-21 DISPLAY PANEL, LIQUID CRYSTAL
< LED >
LED701
LED702
LED703
LED704
6-501-479-01
8-719-060-44
6-501-452-01
6-501-452-01
DIODE
DIODE
DIODE
DIODE
1L0341Y23E0CA602 (BACKLIGHT)
SLR-342VRT32 (STANDBY)
1L4345V22DOTDT02 (VOLUME)
1L4345V22DOTDT02 (VOLUME)
57
HCD-GB3
PANEL
Ref. No.
Part No.
Description
Remark
LED705 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)
LED706 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)
LED707 6-501-452-01 DIODE 1L4345V22DOTDT02 (VOLUME)
LED709 6-501-479-01 DIODE 1L0341Y23E0CA602 (BACKLIGHT)
< TRANSISTOR >
Q661
Q662
Q663
Q664
Q665
1-801-806-11
8-729-040-76
8-729-120-28
8-729-600-22
8-729-024-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1N441C-TP-1
KTA1273-Y-AT
2SC3052F-T1-LF
2SA1235TP-1EF
2SA1365-T112-1EF
Q666
Q667
Q668
Q669
Q670
8-729-047-62
8-729-024-43
8-729-047-62
8-729-024-43
8-729-047-62
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3440-T12-1F
2SA1365-T112-1EF
2SC3440-T12-1F
2SA1365-T112-1EF
2SC3440-T12-1F
Q671
Q672
Q701
Q702
Q703
8-729-024-43
8-729-047-62
8-729-600-22
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1365-T112-1EF
2SC3440-T12-1F
2SA1235TP-1EF
2SC3052F-T1-LF
2SC3052F-T1-LF
Q704
Q705
Q706
Q707
Q709
1-801-806-11
8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1N441C-TP-1
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
Q710
8-729-120-28 TRANSISTOR
2SC3052F-T1-LF
< RESISTOR >
R651
R652
R653
R655
R656
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R657
R658
R659
R660
R661
1-216-853-11
1-216-841-11
1-216-841-11
1-216-809-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
47K
47K
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R662
R663
R664
R665
R666
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R667
R668
R669
R670
R671
1-216-817-11
1-216-809-11
1-216-841-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
100
47K
470
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R672
R673
R674
R675
R676
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R677
R678
R679
1-216-837-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-837-11 METAL CHIP
22K
100
22K
5%
5%
5%
1/10W
1/10W
1/10W
58
Ref. No.
Part No.
Description
Remark
R680
R681
1-216-821-11 METAL CHIP
1-216-837-11 METAL CHIP
1K
22K
5%
5%
1/10W
1/10W
R682
R683
R684
R685
R686
1-216-849-11
1-216-841-11
1-216-789-11
1-216-837-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
47K
2.2
22K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R687
R688
R689
R690
R691
1-216-829-11
1-216-789-11
1-216-833-11
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
2.2
10K
1K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R692
R693
R694
R695
R696
1-216-817-11
1-216-841-11
1-216-817-11
1-216-817-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
47K
470
470
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R697
R698
R699
R700
R701
1-216-821-11
1-216-817-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
470
1K
1K
1K
5%
5%
54%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R702
R703
R704
R705
R706
1-216-821-11
1-216-829-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
4.7K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R707
R708
R709
R710
R711
1-216-821-11
1-216-821-11
1-216-821-11
1-216-829-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R712
R713
R714
R715
R716
1-216-829-11
1-216-833-11
1-216-829-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
4.7K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R717
R718
R719
R721
R722
1-216-821-11
1-216-821-11
1-216-821-11
1-216-817-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
470
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R723
R724
R725
R726
R728
1-216-825-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
1K
1K
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R730
R731
R732
R733
R734
1-216-833-11
1-216-833-11
1-216-837-11
1-216-841-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
22K
47K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R735
R738
R739
R740
R742
1-216-821-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
10K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
HCD-GB3
PANEL
Ref. No.
Part No.
Description
R743
R744
R745
R746
R747
1-216-821-11
1-216-825-11
1-216-825-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R748
R749
R750
R751
R753
1-216-841-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
1K
100K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R754
R755
R756
R757
R758
1-216-833-11
1-216-864-11
1-216-821-11
1-216-845-11
1-216-821-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
0
1K
100K
1K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R759
R760
R761
R762
R763
1-216-809-11
1-216-845-11
1-216-841-11
1-216-833-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
47K
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R764
R765
R766
R767
R768
1-216-837-11
1-216-829-11
1-216-837-11
1-216-849-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
4.7K
22K
220K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R769
R770
R771
R772
R773
1-216-829-11
1-216-841-11
1-216-821-11
1-216-817-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
1K
470
10K
5%
5%
5%
5%
5%
R774
R775
R776
R777
R778
1-216-837-11
1-216-841-11
1-216-821-11
1-216-817-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47K
1K
470
1K
R779
R780
R781
R782
R783
1-216-809-11
1-216-833-11
1-216-829-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R784
R785
R786
R787
R788
1-216-845-11
1-216-833-11
1-216-809-11
1-216-805-11
1-216-864-11
R789
R790
R791
R792
R793
Ref. No.
Part No.
POWER
Description
Remark
R856
R857
1-216-833-11 METAL CHIP
1-216-813-11 METAL CHIP
10K
220
5%
5%
1/10W
1/10W
R861
R862
R864
R865
R866
1-216-813-11
1-216-825-11
1-216-825-11
1-216-829-11
1-216-821-11
220
2.2K
2.2K
4.7K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
< SWITCH >
SW699
SW700
SW701
SW702
SW703
1-418-859-21
1-786-417-11
1-762-875-21
1-762-875-21
1-762-875-21
ENCODER, ROTARY (
+)
ENCODER, ROTARY (
VOLUME
)
SWITCH, KEYBOARD (?/1)
SWITCH, KEYBOARD (DISPLAY)
SWITCH, KEYBOARD (TUNING /lj)
SW704
SW705
SW706
SW708
SW709
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (CD7)
SWITCH, KEYBOARD (TUNER/BAND)
SWITCH, KEYBOARD (DSGX)
SWITCH, KEYBOARD (/ )
SWITCH, KEYBOARD (1 DISC)
SW710
SW711
SW712
SW713
SW714
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (2 DISC)
SWITCH, KEYBOARD (s)
SWITCH, KEYBOARD (TUNING+/JL)
SWITCH, KEYBOARD (EQ)
SWITCH, KEYBOARD
(PLAY MODE/TUNING MODE)
1/10W
1/10W
1/10W
1/10W
1/10W
SW715
SW716
SW719
SW720
SW721
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (DIMMER/ILLUM)
SWITCH, KEYBOARD (+/ )
SWITCH, KEYBOARD (3 DISC)
SWITCH, KEYBOARD (ENTER)
SWITCH, KEYBOARD(Z)
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
SW722
SW723
SW724
1-762-875-21 SWITCH, KEYBOARD (AUDIO IN)
1-762-875-21 SWITCH, KEYBOARD (TAPE)
1-762-875-21 SWITCH, KEYBOARD (DISC SKIP/EX-CHANGE)
100
10K
4.7K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
100K
10K
100
47
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R794
R795
R796
R797
R798
1-216-821-11
1-216-821-11
1-216-833-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R799
R800
R854
1-216-837-11 METAL CHIP
1-216-849-11 METAL CHIP
1-216-821-11 METAL CHIP
22K
220K
1K
5%
5%
5%
1/10W
1/10W
1/10W
< VIBRATOR >
X701
1-760-252-12 VIBRATOR, CRYSTAL (32768Hz)
X702
1-795-054-51 VIBRATOR, CERAMIC (4.19MHz)
*************************************************************
A-1177-464-A POWER BOARD, COMPLETE (E2)
A-1177-466-A POWER BOARD, COMPLETE (MX)
A-1177-467-A POWER BOARD, COMPLETE (AR)
**********************
< CAPACITOR >
0 C051
C053
C054
C055
1-165-621-91
1-100-385-91
1-100-385-91
1-100-385-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.47uF
0.47uF
0.47uF
50V
25V
25V
25V
< DIODE >
D051
D052
6-500-334-01 DIODE MC2836-T112-1
6-500-335-01 DIODE MC2838-T112-1
< FUSE HOLDER>
FH001
FH002
1-533-233-31 FUSE HOLDER
1-533-233-31 FUSE HOLDER
59
HCD-GB3
POWER
Ref. No.
REG
Part No.
Description
Remark
< COIL >
0 L001
1-402-663-11 TRANSFORMER, LINE FILTER (LFT)
< TRANSFORMER >
0 PT002
1-443-913-11 TRANSFORMER, POWER
< RESISTOR >
R051
R052
1-216-829-11 METAL CHIP
1-216-829-11 METAL CHIP
4.7K
4.7K
5%
5%
1/10W
1/10W
< RELAY >
0 RY002
1-755-496-11 RELAY
< SWITCH >
0 S001
1-786-408-11 SELECTOR, VOLTAGE (SWS-2301)
(VOLTAGE SELECTOR)(E2)
< CABLE HOLDER >
WH151 1-819-972-11 HOLDER, CABLE 8P
*************************************************************
A-1177-471-A REG BOARD
**********
< CAPACITOR >
C118
C119
1-164-156-11 CERAMIC CHIP
1-100-566-91 CERAMIC CHIP
0.1uF
0.1uF
10%
25V
25V
< IC >
IC101
6-700-830-01 IC KIA7809API
< CABLE HOLDER >
WH103 1-824-027-21 HOLDER, CABLE 3P
*************************************************************
MISCELLANEOUS
**************
6
69
107
109
0 114
1-787-319-12
1-832-657-21
1-832-837-21
1-831-612-21
1-831-370-11
FAN, DC
CABLE, FLEXIBLE FLAT (29 CORE)
CABLE, FLEXIBLE FLAT (13 CORE)
CABLE, FLEXIBLE FLAT (23 CORE)
CORD, POWER (E2)
0 114
0 114
159
207
208
1-832-228-11
1-832-377-11
1-797-575-11
1-797-193-12
1-832-404-21
CORD, POWER (AR)
CORD, POWER (MX)
DECK, MECHANICAL
MECHANICAL, CD (DLM3A23-11)
CABLE, FLEXIBLE FLAT (16 CORE)
0 209
0 F051
0 PT001
0 PT001
S201
A-4735-357-A
1-532-237-00
1-443-911-11
1-443-995-21
1-771-853-11
OP BASE ASSY (KSM-213DHAP/ZRP1)
FUSE (T3.15AL/250V)
TRANSFORMER, POWER (E2, AR)
TRANSFORMER, POWER (MX)
SWITCH, DETECTION (LIMIT)
60
HCD-GB3
MEMO
61
HCD-GB3
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
Date
1.0
2006.05
Description of Revision
New
You might also like
- How To Take The GRRRR Out of Anger (Como Quitar El GRRRR de La Ira)98% (46)How To Take The GRRRR Out of Anger (Como Quitar El GRRRR de La Ira)129 pages
- Sony HCD-EP313 Service Manual (P.N. - 987723704)No ratings yetSony HCD-EP313 Service Manual (P.N. - 987723704)44 pages
- Service Manual: Compact Disc Deck ReceiverNo ratings yetService Manual: Compact Disc Deck Receiver54 pages
- Manual Servicio Micro HI-FI Sony Hcdgp7No ratings yetManual Servicio Micro HI-FI Sony Hcdgp762 pages
- Service Manual: Component Hi-Fi Stereo SystemNo ratings yetService Manual: Component Hi-Fi Stereo System96 pages
- HCD-GZR5D - (MHC-GZR5D) (v.1.0) (sm-9-889-161-01)100% (2)HCD-GZR5D - (MHC-GZR5D) (v.1.0) (sm-9-889-161-01)102 pages
- Sony Hcd-gnz77d Hcd-gnz88d Ver.1.3 FullNo ratings yetSony Hcd-gnz77d Hcd-gnz88d Ver.1.3 Full116 pages
- Sony - CFD s03cp s03cpl - Ver 1 93346.7 - SMNo ratings yetSony - CFD s03cp s03cpl - Ver 1 93346.7 - SM98 pages
- Service Manual: DVD Deck Receiver DVD Receiver100% (1)Service Manual: DVD Deck Receiver DVD Receiver110 pages
- Automated Optical Inspection: Advancements in Computer Vision TechnologyFrom EverandAutomated Optical Inspection: Advancements in Computer Vision TechnologyNo ratings yet
- Radio Shack TRS-80 Expansion Interface: Operator's Manual Catalog Numbers: 26-1140, 26-1141, 26-1142From EverandRadio Shack TRS-80 Expansion Interface: Operator's Manual Catalog Numbers: 26-1140, 26-1141, 26-1142No ratings yet
- A Guide to Vintage Audio Equipment for the Hobbyist and AudiophileFrom EverandA Guide to Vintage Audio Equipment for the Hobbyist and AudiophileNo ratings yet
- The Unofficial WG K7000 Repair Guide: Arcade Monitor Troubleshooting Guides, #1From EverandThe Unofficial WG K7000 Repair Guide: Arcade Monitor Troubleshooting Guides, #1No ratings yet
- Panasonic Lumix Dmc-Fx01 Series Service Manual Repair GuideNo ratings yetPanasonic Lumix Dmc-Fx01 Series Service Manual Repair Guide56 pages
- Receptor Kenwood krf-V7070-V8070 - X9070-VR-7060 - 7070 - 7080 - SMNo ratings yetReceptor Kenwood krf-V7070-V8070 - X9070-VR-7060 - 7070 - 7080 - SM32 pages
- Service Manual - LG Monitor - 500E-G - Chassis CA-133100% (1)Service Manual - LG Monitor - 500E-G - Chassis CA-13332 pages
- Language Leader Upper Intermediate Unit Test 1A: A Add The Missing Words To The Following Idioms100% (1)Language Leader Upper Intermediate Unit Test 1A: A Add The Missing Words To The Following Idioms2 pages
- A Clockwork Orange-Ultra-Violence RewrittenNo ratings yetA Clockwork Orange-Ultra-Violence Rewritten15 pages
- SAMSUNG LCD Service Manual (Internal) - ES15UNo ratings yetSAMSUNG LCD Service Manual (Internal) - ES15U81 pages
- 8.33 KHZ ABOVE FL195 User Guide: European Organisation For The Safety of Air NavigationNo ratings yet8.33 KHZ ABOVE FL195 User Guide: European Organisation For The Safety of Air Navigation72 pages
- Singh Exp22 Excel Ch09 Cumulative Theatre (AutoRecovered)No ratings yetSingh Exp22 Excel Ch09 Cumulative Theatre (AutoRecovered)8 pages
- Eimac Cermaic/Metal Tetrode VHF/TV Linear Amplifier 4CX25-000ANo ratings yetEimac Cermaic/Metal Tetrode VHF/TV Linear Amplifier 4CX25-000A1 page
- Windows Movie Maker: Adriano A. Diaz JRNo ratings yetWindows Movie Maker: Adriano A. Diaz JR15 pages
- Cultural Capital and School Success: The Impact of Status Culture Participation On The Grades of U.S. High School StudentsNo ratings yetCultural Capital and School Success: The Impact of Status Culture Participation On The Grades of U.S. High School Students14 pages
- Solfeggio 111 HZ Mandala, Angelic Frequency, Healing Art For The New Earth50% (2)Solfeggio 111 HZ Mandala, Angelic Frequency, Healing Art For The New Earth1 page
