ld w ide

Wo r LCD TV

Welcome to

LCD TV
(PAL & NTSC Chassis with LCD screen !)

CIS
Europe
N.America
China
Middle-East
Asia
Africa
S.America
Oceania

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  1 LG DID ENGINEERING DEPT.

 ld w ide
CONTENTS Wo r LCD TV

LCD TV CHASSIS APPLICATION NOTE

1. TV COLOR SYSTEM
2. TV SOUND SYSTEM
3. Special feature
-SCART
-V-CHIP
-CAPTION
-TELETEXT
-Etc..
4. ADJUSTMENT & OPTION TABLE
5. MODEL NAME DONATION
6. GENERAL SPEC.
7. Chassis SPEC.
8. BLOCK DIAGRAM

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  2 LG DID ENGINEERING DEPT.

 ld w ide
TV Color System Wo r LCD TV

NTSC(National Television System Committee)

`Developed in USA, on 1953
` Video signal(R,G,B) from Camera is converted to Y,I,Q signal.
` Y Signal : Luminance signal Video R Y
Y=0.30R+0.59G+0.11B signals
` I Signal: Chrominance Signal(I=0.60R-0.28G-0.32B) from G Matrix I
`Q Signal: 90º (Phase difference) compare with I Signal. camera B Q
(Q=0.21R-0.52G+0.31B)
` Color sub-carrier 3.58MHz
` Frame rate : 30/sec (60 Field)
` Horizontal line : 525 Line
` Nation : USA.Canada,Mexico,Korea,Japan etc..

PAL(phase alternation by line)

` Developed in Germany ,on 1967
` In every other line the R-Y signal is transmitted by inverting phase(180 degree).
` By combining two horizontal lines, using a delay line in the TV set,
two lines can be combined and any phase error can be cancelled.

Phase(Chroma) distortion is reduced. (Automatic hue control)
` Color sub-carrier 4.43MHz
` Frame rate : 25/sec (50 Field)
` Horizontal line : 625 Line
` Nation : West Europe (except France),China,Brazil etc..

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  3 LG DID ENGINEERING DEPT.

 ld w ide
TV Color System Wo r LCD TV

SECAM(sequential chrominance and memory)

`Developed in France, on 1967
`One color signal at a time, transmitting chrominance signal (the R-Y signal and the B-Y signal)
alternately by delay one line.
`FM modulation for color which is not effected by phase shift removes the problem
during transmission that will effect the color hue nor saturation.
` Color sub-carrier 4.4MHz and 4.25MHz is used for R-Y and B-Y
` Frame rate : 25/sec (50 Field)
` Horizontal line : 625 Line
` Nation : France,CIS,East Europe etc..

ә Comparison of Feature

   
    


 
  



    



   
  


 

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  4 LG DID ENGINEERING DEPT.

 ld w ide
TV Color System Wo r LCD TV

) 

       
 

             

        
 !"#$
        
%# !"#$                 
""&#  
 !"#$             
%'(             
"          

TV Broadcasting System Specifications

 $%!   
      
 
  


 &'
  
    
    
 
#
#


  

        


!"#$  %  & ' ( )

 *+,-.+/'  %  &   )
 0 !1"#$  %  &% ' 2 )
 0 /  2#3  &## ' # 
 0 *+,-.+/'  2#3  &  ( 


!"$  %  & ' 2 )


!"$  %  & ' 2 )
 /   %  &% ' 2 )
 0 !1"$  %  &% ' 2 )
 0 !1"$  %  &% ' 2 )
 /  %  &%  2 )
 4/56 "33($  7  & ' % )
! 6/'  % 7  & ' % )
#


  

"  68 68 9##: &% ' )

"  68 68 9: &%  )

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  5 LG DID ENGINEERING DEPT.

 ld w ide
TV Sound System Wo r LCD TV

Summary
1) Image is transmitted by AM modulation, Sound is FM modulation.
2) Separation & detection of Vision,Sound signal in TV system.

z–œ•‹ z–œ•‹Gpm mt kŒT z–œ•‹

šŒ—ˆ™ˆ›–• h”— ‹Œ›ŒŠ›–• Œ”—ˆšš vœ›—œ›

}š–• }š–•
pmGh”— kŒ›ŒŠ›–•
 1. Separation of Vision & Sound

3) De-emphasis Circuit (For improving S/N ratio)

; Noise sensitivity of high frequency is poor
To compensate this problem, transmitter amplifies high frequency part with high-pass AMP (Pre-emphasis)
 Receiver needs De-emphasis circuit(low pass filter) for decreasing high frequency.

4) To avoid interference with color signal, use FM modulation & transmit by decreasing amplitude.
5) Mono : same sound pressure in two speaker.
Stereo : different sound pressure in two speker. sound form is moved.
Surround : different sound pressure & Phase. user can feel the sound form in the outside of speaker .

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  6 LG DID ENGINEERING DEPT.

 ld w ide
TV Sound System Wo r LCD TV

Sound system of broadcasting

}j hjX hjY
W‹i TXZ‹i TYW‹i
[U\WW [U^Y[Y
TWU^\

zj h‹‘U
TX]‹i Šˆ••Œ“
TXUY\

TX W X Y Z [ [U\ \
]to¡

Fig 2. M(NTSC) System

ʰ Sound Frequency & Stereo carrier frequency of Broadcasting System

TV Position of Sound Carrier

Sound Modulation Color System Country
system /MHz
B/G 5.5/5.7421875 FM-Stereo PAL Germany

B/G 5.5/5.85 FM-Mono /NICAM PAL Scandinavia,Spain

L 6.5/5.85 FM-Mono /NICAM SECAM-L France

I 6.0/6.552 FM-Mono /NICAM PAL UK

6.5/6.2578125 D/K1
USSR
D/K 6.5/6.7421875 D/K2 FM-Mono /NICAM SECAM-East
Hungary
6.5/5.85 D/K-NICAM
M 4.5 USA
NTSC
M-Korea 4.5/4.724212 Korea

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  7 LG DID ENGINEERING DEPT.

 ld w ide
TV Sound System Wo r LCD TV

Sound system of broadcasting

ʰ Major parameter of broadcasting system when transmit sound signal

Sound Carriers Carrier FM1 Carrier FM2

TV-Sound Standard B/G D/K M B/G D/K M
5.5 6.5 4.5 5.74218 6.257812 4.724212
Carrier frequency in
75 6.742187
MHz
5.742187
Vision/sound power
13dB
ratio
Sound bandwidth 40Hz to 15kHz
Preemphasis 50us 75us 50us 75us
A17 /
Frequency
A27 / A 50kHz A25kH A25 /A50kHz A25kHz
deviation(nom/max)
z
Sound Signal Components
Mono tramsmission mono Mono
Stereo transmission (L+R)/2 (L+R)/2 R (L - R)/2
Dual-sound
Language A Language B
transmission

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  8 LG DID ENGINEERING DEPT.

 ld w ide
TV Sound System Wo r LCD TV

MTS(Multi-channel Television Sound, proposed by Zenith)

pilot
mono

L+R L-R L-R SAP

PRO

H 2H 5H 6.5H

` SAP(Second Audio Program) - for second-language

` PRO(Professional Channel) - used primarily by television stations for program coordination purposes

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  9 LG DID ENGINEERING DEPT.

 ld w ide
TV Sound System Wo r LCD TV

Multi Carrier sound broadcasting

1) KOREA : transmit L+R, L-R signal only (2 carrier method)
2 Language broadcasting: L+R(A Language),L-R(B Language)

2) USA ; transmit L+R,L-R, Pilot, SAP carrier individually .

Aural BTSC – MPX - Components

Carrier (L + R) Pilot (L – R) SAP
Carrier frequency
Base-
(fhNTSC = 15.734kHz) 4.5MHz fh 2fh 5fh
band
(fhPAL = 15.625kHz)
0.05 0.05
Sound bandwidth in kHz 0.05 ~15
~15kHz ~12kHz
Max. deviation to Aural Carrier 73kHz 25kHz 5kHz 50kHz 15kHz
Max. Freq. Deviation of 10kHz
AM
Sub-carrier Modulation Type FM

3) JAPAN : transmit L+R, L-R, pilot carrier ( 3 carrier method)

Main sound : R+L, Sub sound : R-L, control carrier( 3.5fh).
2 Language broadcasting: main sound(A Language),Sub sound(B Language)

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  10 LG DID ENGINEERING DEPT.

 ld w ide
TV Sound System Wo r LCD TV

NICAM 728
1) NICAM (Near-Instantaneous Companding Audio Multiplex)
; Transmit Digital Sound .
A high frequency sub-carrier (5.85MHz or 6.552MHz ) is digitally modulated
with a 728Kbits/sec data-stream.
The data-stream consists of 728bit NICAM packets transmitted continuously,
one packet every millisecond.
OupjhtTt–•–SGupjhtTz›Œ™Œ–SGupjhtTkœˆ“P z–œ•‹GŠˆ™™Œ™
}š–•GŠˆ™™Œ™ kŽ›ˆ“
š–œ•‹GŠˆ™™Œ™

W X Y Z [ \ ] ^
XUY\ \U_\to¡OwhsGinP
to¡ ]U\\Yto¡OwhsGpP
_to¡GXjo

* QPSK(Qudrature Phase Shift Keying) Modulation

; Phase of carrier is shifted 90 degree every 2-bit period from original point.
0O 90O 180O 270O
00 10 11 01

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  11 LG DID ENGINEERING DEPT.

EXTERNAL CONNECTIONS ld w ide
Wo r LCD TV

Standard of External (Rear) Connections


  
 

 






 

 

Y PB PR Audio(L) (R)
AV1 Component






 




 !

Y Audio(L) (R) Y Audio(L) (R)

AV2 S-Video Headphone AV2 S-Video Headphone

 
   
 

D-SUB(21P) PC Audio(L,R) D-SUB(21P) PC Audio(L,R)

PC INPUT PC INPUT

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  12 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

XUGzŠˆ™›G
XUGzŠˆ™›GqˆŠ’GO
zŠˆ™›GqˆŠ’GOwŒ™G
qˆŠ’GOwŒ™G{}Gj–••ŒŠ›–™P
wŒ™G{}Gj–••ŒŠ›–™P


 

w• uhtl kpzjypw{pvu }hs|l

% 5+   + &*#/ 3*2: ;

( +  
  &*#/

4 5    &*#/ 3*2: + ;

  
  &*#/


   

 
&#3*6 /


  

!"
 #$ 0 &7&8(#3 0%72*8#3 0%7.*8%(#

%& 
 
 
 
 95


%% '
'
 
 
&#3*6 /


%( ) 


9-  
 


+

%* +  

 
&#3*6 /


%
),)' +'  - !"

 / &8&2# 3+' %84#

%. # / 0  1  %#3*6 /


#

(& / 0  1 

 %#3*6 /


23*3.3%43%23 ')$
')$ - 

%3%3(%

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  13 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

XUGzŠˆ™›G
XUGzŠˆ™›GqˆŠ’GO
zŠˆ™›GqˆŠ’GOwŒ™G
qˆŠ’GOwŒ™G{}Gj–••ŒŠ›–™P
wŒ™G{}Gj–••ŒŠ›–™P


 










   !"#$%
#&
& 
'()* !()!*
!"# 
'()(+, !)-


  


   ./0
1$ &$%$
 $ $
1
2
/%
&3
2#
4/#$%/ /%
&1
·5/67$2/67+
·8$&$%+
·0
19&951
9:$&1+
; &
&
./#$'4%
//+
·
 
 $/+
·.//%/+
#
3  % 11 # % 11 
 
 % 11 


 
  $%$42$

4/ 0
1$/%+  1 $
< 16 %8$$1  
% 1%

$
=

3
 6
1

$%3
1+

< 
&
&5&
&

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  14 LG DID ENGINEERING DEPT.

 ld w ide
}Tjopw Wo r LCD TV

XUG}
XUG}Tjopw

To protect from Sexual,violent screen or words of AIR and CABLE broadcast,

All TV in USA must provide V-CHIP(protecting equipment according to rating)

All broadcaster(AIR,Cable) and Video manufacture must include Rating grade in signal.
V-Chip built-in TV is operating as follow method .If improper signal is inserted by rating.
1)Screen BLOCKING, 2) AUDIO MUTING 3) CAPTION OFF





    

2 "3 /2
'!3 4565  #
- /2
'!3 
0 " "0"
""jhw{pvuG›ŒŠ•–“–Ž 
jhw{pvuG›ŒŠ•–“–Ž 

j}izGOYG}——
j}izGOYG}——PSG
}——PSG.
"6   0 "
6  
PSG
 63 ! "3!"# 
7!-'
 !!4
!( 89"$ "% '5 :)





    

- ./%% ./%%0 "
%%1


   *+(  $,

%% )

!"
 #$%&  '(!" jhw{pvuGš›ˆ•‹ˆ™‹)
jhw{pvuGš›ˆ•‹ˆ™‹

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  15 LG DID ENGINEERING DEPT.

 ld w ide
}TjopwGyˆ›•Ž Wo r LCD TV




 !"#


%$2$
1$1>4
/56?@?
&@7” & @
&@7+

$ %
!

!&
'
#&@?&' A07@'0?@ <3#&&&0?

.; 6 
"  6 !

.;< 6 #<!

"  566
   
"

. 6 ! .- 566 3- !

"

. 566

   
"  1-<!2 " !3

.-* 566

   3-*!
"
.-< 566 3-<!

. #-<!:3 , :3

 
    
 
$ %
 
&
'
5

 
%$2#&@?&' A07@'0?@

.;
.;<
.
.
.-*
.
zl|hs
T T T zvtl pu{luzl lwspjp{
zp{|h{pvu
hk|s{G pumylx|lu{ z{yvun
T T T T
shun|hnl jvhyzl jvhyzl
}pvslujl T mhu{hz€ T tvklyh{l pu{luzl nyhwopj
zl|hs
T T T zvtl pu{luzl jy|kl
kphsvn

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  16 LG DID ENGINEERING DEPT.

 ld w ide
v—Œ™ˆ›–•G‰ G}T
v—Œ™ˆ›–•G‰ G}TjopwG™ˆ›•Ž Wo r LCD TV

()*+ , 
()*+ , 

=>+'

!63  !6
 =>+'
1%>
=>+'

= %

B'65C0?  %

3#&&&0? D B'65C0?  %
 A07@'0?@D
 !'3 !  !'3 !
  .-  .-< ,
.;
.;<
.
.
.-*
.

.;
 &-
. ! //
.;< &-
. ! //
yˆ›•Ž

yˆ›•Ž
zŽ•ˆ“

zŽ•ˆ“
.-
.

.
.-< &-
. !
.-* &-
. !
,
.

'65C0?  %

56?@?
&@7

0&-
.
0&-
. ! //
!+5/%//%
07@6
*+./
%$ $

%$/%/ 
/$%
% '65C0? 6
5

-+./ 
%$% % 1$

 E$+
,+%
4
/
&0? +

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  17 LG DID ENGINEERING DEPT.

 ld w ide
}TjopwGkˆ›ˆGš›™œŠ›œ™Œ Wo r LCD TV

1
1
'2
2
%  = < = ? = 9 = * =  =  = - = 8
 !  - . . 8  - 8
#(  - - 8 -  - 8

3 3
45 *)6768 *%%3
333 ?&
33 !”
“!
33 ”
“
3 !:”
!:
“!: ;+ ;#

# 
 !
93
33 ”
“
3 “


1”
1
3 <”
“<
 ?6&@7
33  6
3 
3
3 9 ;+ ; - --
 :
33 86
3 
3
3 9 ;+ ;<2
---
 :
33 46
3 -
3
3 -9 ;+ ;
' "--
 -:
iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  18 LG DID ENGINEERING DEPT.
 ld w ide
j“–šŒ‹Gjˆ—›–• Wo r LCD TV

YUGj“–šŒ‹Gjˆ—›–•
YUGj“–šŒ‹Gjˆ—›–•

 )

 )

•
*4
 = $


*4
 = 11 2

4/$ 4
$
$2 
$  
/$ 2 +
• 
 =$1
    $
 


/$ +

 =

$42$$24/$ 4
$ 
+

9. 4;6 

9. 4;6 

 +
 =$4$

 +
 = 
:$/4 $
$ 2
 6
 =
$$  1 
 
6
 = 
A
% 2 $

15
+
 

 = * -
$$2

/$1
1
% 2 $7 1 3$+

:67>);6 
:67>);6 
3
1
/
3
1
/$&3&1
1
 
0
/

:% 
0
  %$4
/F(0@+

0
 $
7

0
/0
  
 $
!(G*!*F-G*,+

$1$$
2
$*2
+

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  19 LG DID ENGINEERING DEPT.

 ld w ide
Wo r
j“–šŒ‹Gjˆ—›–•G{”•Ž LCD TV

*4
 ' + >

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  20 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

Teletext (Character multiplex broadcasting)

-Summary of Teletext
- transmit latest information(real time)
- consisted with character and figure.
vision information is multiplexed in TV signal with digital data format.
receiver reproduce with TV Vision signal form by using Teletext decoder.
Teletext Signal
·Field fly-back mode :transmit text data in the VBI(vertical blanking interval) of Video signal) interval.
use horizon. Line 6~22, 318~335 . (transmit data of 45byte in every Line)
- Page format
·every Page is consist with Packet. 1 Page have 32 Packet .
·possible total Page : 800Page(100 Page ~ 899 Page)
- Teletext form
·TOP : TXT contents is consisted with table form of total page,in designated pages.
(Germany,sweden,swiss etc..)
·FLOF : use 3 Page no. and 5 additional key of Remocon.(Red, Green, Yellow, Blue, Index)
( UK,france, etc.. )

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  21 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

[2] Structure

TOP FLOF

BLOCK InitialPage
Initial Page
BLOCK

GROUP GROUP GROUP 1 2 3

PAGE
PAGE PAGE
PAGE PAGE
PAGE PAGE
PAGE PAGE
PAGE PAGE
PAGE 1 2 3 4 5 1 2 3 4 5

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  22 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV
{}Gmœ•Š›–•G–™ {Œ“Œ›ŒŸ›
XUG{Œ“Œ›ŒŸ›
XUG {Œ“Œ›ŒŸ› yŒ“ˆ›Œ‹Gmœ•Š›–•G•G{}U

  

{l{ {Œ“Œ›ŒŸ› v•Vv

zpl k–œ‰“ŒGoŒŽ›G–™G{Œ“Œ›ŒŸ› kˆ›ˆ

ovsk tˆ•›ˆ••ŽGŠœ™™Œ•›Gkš—“ˆ GwˆŽŒGŠ–•›Œ•›šGŒŒ•GG›ŒGwˆŽŒGŠ–•›Œ•›šGšGŠˆ•ŽŒ‹G

|wkh{l p•–™”GœšŒ™GžŒ•GGŠœ™™Œ•›Gkš—“ˆ GGwˆŽŒGŠ–•›Œ•›šGˆ™ŒG|—‹ˆ›Œ‹G

tp tŸ•ŽGŠœ™™Œ› kš—“ˆ GwˆŽŒG›–Gš–žGœ—Gž›G}‹Œ–Gˆ›G›ŒGšˆ”ŒG›”Œ

{ptl ~Œ•G{{GvmmSG‹š—“ˆ GŠœ™™Œ•›G›”ŒG•–™”ˆ›–•Gˆ•‹GžŒ•G{{GvuGSšŒ“ŒŠ›Gzœ‰T—ˆŽŒGt–‹Œ

yl}lhs ? sŒ›G›ŒG›ŒŸ›GžŠGšGŠ–•ŠŒˆ“Œ‹G•Gjœ™™Œ•›Gkš—“ˆ GwˆŽŒG›–G‰ŒGš–ž•

tvkl M tŒ”–™¡ŒG[G—ˆŽŒšG›ˆ›GœšŒ™Gžˆ•›šG—Œ™G—™–Ž™ˆ”Gˆ›GŠœ™™Œ•›G—™–Ž™ˆ”

ylk jˆ•ŽŒG›–G›ŒG—ˆŽŒG“•’Œ‹G›–G{{GylkG’Œ 

nyllu jˆ•ŽŒG›–G›ŒG—ˆŽŒG“•’Œ‹G›–G{{GnylluG’Œ 

€lssv~ jˆ•ŽŒG›–G›ŒG—ˆŽŒG“•’Œ‹G›–G{{G€lssv~G’Œ 

j€hu jˆ•ŽŒG›–G›ŒG—ˆŽŒG“•’Œ‹G›–G{{Gj€huG’Œ 

pukl i jˆ•ŽŒGGŠœ™™Œ•›G—ˆŽŒG›–G•‹ŒŸG—ˆŽŒ

hjtz TTT h›Œ™Ghœ›–GšŒˆ™ŠSGG‹Œ›ŒŠ›G‰™–ˆ‹Šˆ›•ŽG•ˆ”ŒG—Œ™GŠ–œ•›™ Gˆ•‹G”Œ”–™¡ŒGŠˆ••Œ“Gˆœ›–”ˆ›Šˆ““ GˆšGžˆ•›Œ‹

~zz hyj ~›Gœš•ŽG~zzGšŽ•ˆ“G™–”G›Œ“Œ›ŒŸ› šŽ•ˆ“GSGŠˆ•ŽŒG›–Gž‹ŒG—Š›œ™ŒG™ˆ›–

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  23 LG DID ENGINEERING DEPT.

 d w ide
SPECIAL Features Wo r l LCD TV

Progressive Scan for High Picture Quality Without Flicker

Progressive Scan double the number of scan lines for high density, high quality images.
Therefore, flicker was eliminated for long time viewing without eye fatigue.





 
  
   
-Progressive Scanning :
- Interlaced Scanning :
From 1st scan line to last scan line,
First one- half of the image is scanned
each lines is progressively scanned.
in odd-numbered line,
So,Reduce line-flicker.
and then followed by even-numbered line.
And,providing higher resolution
image(vertically) .

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  24 LG DID ENGINEERING DEPT.

 d w ide
SPECIAL Features Wo r l LCD TV

` High Definition Digital Broadcast <Digital Broadcast Screen Comparison>

Reception (HD grade)
In response to digital broadcasting, it is possible to receive
digital signals through the separate digital terminal
so viewers can enjoy high quality digitalized images.
HD grade D-TV(480P,720P,1080I) compatible.
(When digital receiver is connected.)

<Conventional TV> <Digital TV Compatible>

 
 


 

  

(V. Lines x H. Pixels) 
60I
30P Interlace camera vision
1080 x 1920 16 / 9
24P Hi definition movie film
HDTV
60P Sports, Graphic ,Advertisement ,
720 x 1280 16 / 9 30P
24P
Animation movie(35mm)
60P
16/9 60I Multimedia vision(DVD,LDP)
480 x 704 or 30P Data interface
SDTV 4/3 24P
60P
480 x 640 4/3 60I VGA grade vision data Interface
30P
24P

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  25 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

` Wireless

 Transmission and Reception
/
The TV and other AV devices can be connected without connecting wires for
picture and sound signals can be received more freely.

<Wireless Receiver> <Wireless Reception Demonstration>

` Multi-Use
Desktop, wall-hanging, floor standing, and wireless reception and
transmission allow a variety of installation possible.

Desktop Wall-hanging

Floor stand
Usage Environments

Wireless Reception and

Transmission

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  26 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

PSM (Picture Status Memory)

PSM for PAL Model has 5mode(STANDARD, DYNAMIC, MILD, GAME and USER ).
STANDARD, DYNAMIC, MILD and GAME are programmed at the factory for good picture
reproduction appropriate to each program character and cannot be changed.
USER status controls the picture status.(contrast,brightness,color, sharpness and tint)

PSM for NTSC Model has 5mode (CLEAR,OPTIMUM,SOFT,USER).

CLEAR,OPTIMUM,SOFT are programmed at the condition of surroundings in mode.
USER status controls the picture status.(contrast,brightness,color, sharpness and tint)

SSM(Sound Status Memory)

SSM for PAL Model has 5 mode(FLAT, MUSIC, MOVIE, SPEECH and USER)
You can always obtain the best sound conditions, for movies, music and speech,
as you prefer.
Also you can adjust the sound frequency to the levels you prefer in user mode.
SSM for NTSC Model has 5 mode (FLAT, MOVE, MUSIC, SPORTS, USER).
You can always obtain best sound conditions, for movies, music, sports and speech, as you prefer.
Also you can adjust the sound frequency to the levels you prefer in USER mode.

Favorite Program
After you memorize the channels desired,
you can easily watch your favorite programs.
(MAX. 5 program)

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  27 LG DID ENGINEERING DEPT.

 SPECIAL Features ld w ide
Wo r LCD TV

DCF(Digital Comb Filter)

The Comb filter separates the color information from luminance
signal to avoid cross color on the
luminance(Y) signal and to eliminates edge crawls.
Adaptive Digital 2-H comb filter is compatible with
PAL and NTSC systems.

ACMS plus Existing Comb Filter Digital Comb Filter ( 4H )

ACMS plus(Auto Channel Memory System and Station Labeling) function makes a TV set automatically
search all the active channels and to store the names of broadcasting stations by VPS and PDC information.
This makes it possible to display a station name on the screen and to edit programs.

Digital Comb Filter

The Comb filter separates the color information from luminance signal to avoid cross color on the luminance(Y)
signal and eliminate edge crawls.
Adaptive intra-field comb filter is compatible with PAL and NTSC systems.

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  28 LG DID ENGINEERING DEPT.

 d w ide
SPECIAL Features Wo r l LCD TV

DCTI

Before
DCTI

After
DCTI

DCTI(Digital Color Transient Improvement) is implemented to improve horizontal transitions

of the chrominance signals resulting in a better picture sharpness.
( Refer to page 53. )

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  29 LG DID ENGINEERING DEPT.

 d w ide
SPECIAL Features Wo r l LCD TV

AVL (Automatic Volume Leveler)

Audio out -14dB
AVL off
This function is automatic gain control on the AVL on
volume which regulates the audio level to +6dB

constant sound level with non-standard

15
(NTSC)
signals 30
(PAL)

Deemphasis(FM swing)

Most of broadcasting station has different modulation ratio. AVL characteristic

Especially, in case of CATV or BSTV broadcast system,
the difference of modulation ratio is more serious than normal system.
Whenever customer change the channel, volume level should be also adjusted again.
AVL function makes uniform sound-output level, independently of various modulation ratio.
AVL function can solve upper inconvenience of customer’s needless operation.
So, it’s very powerful and useful function for customer.
AVL function of applied to LCD TV chassis can make uniform
sound-output level( 60% modulation ratio)
from 30% under-modulation to 300% over-modulation ratio.
AVL modulation ratio is 60%, it’s base on 60% modulation ratio.

Auto Demonstration Mode

Press “OK” in control(local) key(TV Set) Automatic demonstration Press any key to exit
for 10 sec . (guide all function of TV) (Only front control key in TV set)

In this time ,cannot operate TX(remote control)

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  30 LG DID ENGINEERING DEPT.

 d w ide
SPECIAL Features Wo r l LCD TV

DBS (Dynamic Bass System)

The DBS extends the frequency range of loudspeakers or headphones.

After the adaptation of DBS to the loudspeakers and the cabinet, further customizing of
DBS allows individual fine tuning of the sound.
Dynamic Bass System combines two effects: dynamic amplification and adding harmonics.

- Dynamic amplification : If the amplitude comes close to the definable limit, the gain is reduced
automatically in dynamic volume mode. Therefore, Clipping effects are avoided.
- Adding Harmonics : Adding harmonics of the frequency components below the cutoff frequency
gives the impression of actually hearing the low frequency fundamental.
In other words, the listener has the impression that a loudspeaker system seems to reproduce
frequencies although physically not possible.

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  31 LG DID ENGINEERING DEPT.

 ADJUSTMENT ld w ide
Wo r LCD TV

AUTO INSERT MANUAL INSERT SOL. ADJ. LINE ASSEMBLE LINE

USE
SVC
OPTION SELECT ADJ. Autogray REMOCON ADJ. YPbPr
- ADJUST IN SVC MODE - ADJUST in SVC MODE. IN-START - ADJUST in SVC MODE.
(REFER TO OPTION DATA TABLE) ADJUST in PC MODE. ADJUST in PC MODE.
KEY Refer to ADJ. Manual
Refer to ADJ. Manual

Ӑ THE OPTION DATA OF ANY MODEL REFER

TO THE COMMENTS OF CHASSIS ASSY IN BOM

3141VMN_ _ _ _ OP [138,160,44.100 ]

OPTION 1 OPTION 2 OPTION 3 OPTION 4

FOR PAL Model

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  32 LG DID ENGINEERING DEPT.

 ADJUSTMENT in SVC MODE [ OPTION 1,2,3,4 ] ld w ide
Wo r LCD TV

Adjustment EEPROM Data

“EXIT” Key or
“TV/AV”KEY

“IN-START” OPTION 1 “IN-START”

“OK” Key OPTION 2
before page or “Red” or “Green”
mode (SAVE) mode
key key

200PR 0 PIP TXT 0

TEXT 1 ACMS 1 “OK” Key “EXIT” Key or

SAVE 0 VOL 0 (SAVE) “TV/AV”KEY
TOP 1 HIDEV 0
A2STER 1 OSDLAN 1
SYS 1 “IN-START”
50hz PC or “Yellow”
OPTOPN 2 97 IIC AFT 1 key
50hz PC
MD SAVE 0
OPTOPN 1 93
MONO 0
CH+AUS 0
TXT-LAN 0 OPTION 3
mode
50hz PC
OPTOPN 3 12

“OK” Key “EXIT” Key or

(SAVE) “TV/AV”KEY

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  33 LG DID ENGINEERING DEPT.

 ADJUSTMENT in SVC MODE ld w ide
Wo r LCD TV

Test The Sound Condition

“IN-START” key, or VOL 0 VOL 50 VOL 100 VOL 30

SVC 1 “CHECK-S”
“OK”(TX) +”OK”(SET) BAL 30 BAL 30 BAL 30 BAL 0 =>5 0 => 100 => 30
mode key
-Press for 5 sec-
SND TEST SND TEST SND TEST SND TEST

Press “CHECK-S” Key Continuously

Test The Picture Condition

“IN-START” key, or CON 25 CON CON

SVC 1 “P-CHECK” 75 75
“OK”(TX) +”OK”(SET) BRI 65 BRI 65 BRI 65
mode key
-Press for 5 sec- COL 70 COL 70 COL 70
SHA 60 SHA 60 SHA 75
TNT 50 TNT 50 TNT 50

PIC TEST PIC TEST PIC TEST

Press “P-SHCECK” Key Continuously

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  34 LG DID ENGINEERING DEPT.

 ADJUSMENT TABLE in SERVICE 4 ld w ide
Wo r LCD TV

SERVICE - 4

FIX FP 19 ә List of Pre-scaler DATA for MSP34xy

FIX NP 73
FIX SP 19 Service-4 Function DATA REMARKS
FIX S1VOL 112 FIX FP FM PRE-SCALER 19 Don’t adjust data (Fixed data)
FIX S2VOL 105
FIX NP NICAM PRE-SCALER 73
FIX
FIX SP SCART PRE-SCALER 19
FIX S1 VOL SCART 1 VOLUME 112
50HZ PC FIX S2 VOL SCART 2 VOLUME 105

This data can be used to adjust picture alignment by memorized EEPROM of the default value.

SVC-4 data is no need of adjustment.

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  35 LG DID ENGINEERING DEPT.

OPTION TABLE in OPTION 1,2,3 ld w ide
Wo r LCD TV

: Recommended Item
OPTION-1 ә OPTION-1
200PR
Code
0
Function Remarks

200PR 0 1

TEXT 1 TOP 0 Disable TOP ( FLOF BASIC) Only applied “some EU nation” with
TOP TEXT Option.

SAVE 0 1 Enable TOP TEXT
TOP 1 ACMS 0 Disable ACMS plus (Australia Only) Auto Channel Memory with
Broadcasting Station Labeling
A2STER 1 1 Enable ACMS plus
SYS 1 TOP 0 Disable TOP ( FLOF BASIC) Only applied “some EU nation” with
TOP TEXT Option.
1 Enable TOP TEXT
A2-ST 0 NICAM check only All model is applied “1”

50HZ PC 1 NICAM Check & FM Stereo available

93
SYS
0 BG / I / DK / M RT – Model
OPTION 1 1 BG / I / DK / L RZ – Model
2 Reserved
After Key in New Data 3 Reserved
(According to BOM)
Press “OK” Key  THE OPTION 1 & 2 DATA OF ANY MODEL REFER TO THE COMMENTS OF CHASSIS
CHASSIS ASSY IN BOM
OPTION-2 Code Function Remarks
PIP TXT 0 Disable TXT in PIP

ә
1 Enable TXT in PIP
OPTION-2 ACMS 0 Disable ACMS plus (Australia Only) Auto Channel Memory with
1 Enable ACMS plus Broadcasting Station Labeling
PIP TXT 0
VOL 0 Standard Sound Volume Curve Low Step = Slow, High Step = Rush
ACMS 1
1 Rushed Sound Volume Curve at Low Low Step = Rush, High Step = Slow
VOL 0
HIDEV 0
HIDEV 0
1 RT-(China) model Only
OSDLAN 1
OSD LAN 0 ENGLISH Only
1 EU-5 EA
2 6 COUNTRY
3 5 COUNTRY
50HZ PC 4 4 COUNTRY
5 3 COUNTRY
OPTION 2 97

6 2 COUNTRY
7 Reserved

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  36 LG DID ENGINEERING DEPT.

OPTION TABLE in OPTION 1,2,3 ld w ide
Wo r LCD TV

OPTION-3  THE OPTION 3 DATA OF ANY MODEL REFER TO THE COMMENTS OF CHASSIS ASSY IN BOM

IIC AFT
MD SAVE
1
0
ә OPTION-3
IIC AFT
Code
0
Function
Enable IIC Tunning
Remarks
RZ – Model
MONO 0 1 Enable AFT Tunning RT – Model
CH+AUS 0 MD SAVE 0 Not Save DUAL I/II Sound Condition EU model
TXT-LAN 0 1 Save DUAL I/II Sound Condition Non EU model
MONO 0 Normal (RF-ST Model must be fixed “0”)
1 Forced Mono (AV-ST Model must be fixed “1”)
CH+AU 0 Exception China & Australia Model Frequency (RF) Table Setting
50HZ PC
1 China & Australia Model Only
OPTION 3 12 TXT-LAN 0 West EU (E, France, Sweden, Czech, German, Spain, Italy) “Western EU”
1 East EU ( Poland, France, Sweden, Czech, German, Slovenia, Italy,
Romania)
2 Turkey (E, France, Sweden, Turkey, German, Spain, Italy) “TURKEY”
6 Cyrillic3 (E, Russia, Estonia, Czech, German, Ukraine, Lettish)
7 Greek (E/France/Sweden/Turkey/German/Spain/Italy/Greece) “GREECE”

: Recommended Data

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  37 LG DID ENGINEERING DEPT.

SPECIAL SPEC. LIST ld w ide
Wo r LCD TV

VIDEO AUDIO
• High Luminance ( 430cd/m²) • A2 / Nicam Stereo
• PSM(Picture Status Memory) • DBS (Dynamic Bass System)
• DCF (Digital Comb Filter ; IC ) • AVL (Auto Volume Leveler)
• CTI (Color Transient Improvement) • SSM (Sound Status Memory) : DASP
• Graphic Equalizer

MONITOR

• XGA 1024X768 75Hz (Except 13” 14” 20”)

ML-024
Tunning
• Full Multi System
• FVS/FS
• ACMS Plus with VPS & TXT
• Auto Sleep & Sleep Timer • Program List & Edit
• Real Timer (On Off Time)
• Favorite CH Memory : 5
• Closed Caption (RU/RN/RJ-MODEL only)
•Front or Side
• Stand-By Power Consumption 3W
AV-IN
S-Vide / Head Phone
•Rear Side
ETC AV-IN, DVD-IN (Option)
User Interface
iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  38 LG DID ENGINEERING DEPT.
 d w ide
COMPARE SPEC. LIST (1) Wo r l LCD TV

ʅ : Basic Function,  : Option Function
ML-012C ML-024A ML-027B Remarks
Items Sub Items (15LA60) (15LA54) (17LZ20)
RT- RU- RT- RU- RT- RU-
Receiving PAL-B/G,D/K,I/I



System SECAM-B/G, D/K,



NTSC AV 3.58 / 4.43



NTSC RF 3.58






Aspect Ratio 4:3 4:3 16:9
Tuning System FVS FS FVS FS FVS FS
Memory type ACMS + ACMS + ACMS +
No. of Program 100 (200) 125 100 (200) 125 100 (200) 125 W/O TXT :
200Pr.(China)
Pr. Edit ,Station



Labeling (AMS+)
Quick View

CATV / Hyper Band
/

/

/

Favorite CH Memory



Picture DCDI
-

DCF



CTI -
-

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  39 LG DID ENGINEERING DEPT.

 COMPARE SPEC. LIST (2) ld w ide
Wo r LCD TV

ʅ : Basic Function,  : Option Function
ML-012C ML-024A ML-027B Remarks
Items Sub Items (15LA60) (15LA54) (17LZ20)
RT- RU- RT- RU- RT- RU-
Picture Luminance 450nit 430nit 450nit
Blue Back -
-

Sound Stereo (A2 /Nicam)
/

/-
/

/-
/

/-

AVL



Surround



Graphic Equalizer



DBS -


SSM
(5 mode)
(5 mode)
(5 mode)
Sound Output (Max) 3W  2 1W  2 3W  2
PIP PIP (PC Mode)
-

Double Window - -

Multi Window - - 4/9/13 windows
TXT/ TXT / CAPTION
/- -/

/- -/

/- -/

Caption No. of pages (TXT) 10 - 10 - 10 -
OSD Type WINDOW MENU WINDOW
Character Graphic RGB font Graphic
Language Multi Lang. Multi Lang. Multi Lang.

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  40 LG DID ENGINEERING DEPT.

 COMPARE SPEC. LIST (3) ld w ide
Wo r LCD TV

ʅ : Basic Function,  : Option Function
ML-012C ML-024A ML-027B Remarks
Items Sub Items
RU/T-15LA60 RU/T-15LA54 RU/RT-17LZ20

Other Picture Status 5 mode 5 mode 5 mode

Function Memory
clock




ARC(Zoom, 16:9, 4:3) - -

Auto Demo



DPM



Digital TV(W/ STB)
(HD)
(HD)
(HD)
Child Lock



On/Off Timer -


Sleep Timer



Recall / Mute
/

/

/

AV(PC) AV-in (RCA)



Terminals S-Video in



Component-In
-


Head Phone



PC-in (D-SUB)



PC Audio-in

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  41 LG DID ENGINEERING DEPT.

 ld w ide
Model Name Definition Wo r LCD TV

1 2 - 4 5 6 7 8 9

R T - 2 0 L A 6 0

SCREEN SIZE TOOL CHANGE

13”/14”/15”/17/20”/ Using 1-digit number
23”/30”/42”/54”

SYSTEM Giving Serial No

PRODUCT according to modified
CODE Z-
Z- :: EU
EU -Multi
-Multi
chassis & tool as to Initial
PAL/SECAM-BG,DK,I
PAL/SECAM-BG,DK,I
R : Analog/ Tool
SECAM-,L/L’
SECAM-,L/L’
Digital (0,1,2,3…9,A,B,C,…Z)
T-
T- :: Non
Non EU
EU Full
Full Multi
Multi
Ready
PAL/SECAM-BG,DK,I
PAL/SECAM-BG,DK,I NTSC- NTSC-
M
M
M :Monitor TOOL
U-
U- :: USA
USA
Products
NTSC-M
NTSC-M
K :Analog Old
Old Tool
Tool (( using
using 1-digit
1-digit alphabet)
alphabet)
P-
P- :: LATIN
LATIN AMERICA
AMERICA
Complex A
A :: LCD
LCD
PAL-N/M
PAL-N/M ,, NTSC-M
NTSC-M
Products New
New Tool
Tool (using
(using 2-digit
2-digit alphabet)
alphabet)
N-
N- :: KOREA
KOREA
NTSC-M L

L
:: LCD
LCD TV TV
NTSC-M
J-
J- :: JAPAN
JAPAN
NTSC-M
NTSC-M

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  42 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV
5. Main Functions/Spec.
ML-024 SPEC. (PAL)

SPECIFICATIONS REMARKS SPECIFICATIONS REMARKS

Halftone OSD
PAL/SECAM-B/G,D/K, I, SECAM-L/L’ RZ-Model Ez Menu
SYSTEM OSD
PAL/SECAM- B/G,D/K,I, NTSC-M RT-Model
Multi-language *
Program List & Edit Mode
100-240V , 50/60Hz
Adapter Free
POWER Power Consumption : Rear
13”(35W) , 14”15”(55W) .Scart In RZ-Model
17”(60W) , 20”(65W) .Video In
Stand by : 3W Below EXTERNAL
CONNECTIONS .S-VHS In
.DVD In /DTV In RZ-Model
FVS, 100Program(200 Optional) (480i,480p,720P,1080i Compatible
TUNING Auto/Manual programming Input)
ACMS+ With VPS & TXT .Headphone Out
Quick View
.XGA-IN (D-SUB Jack)
.PC-Audio In
PSM
VIDEO (Dynamic, Standard, Mild, Game)
Digital comb filter TELETEXT FLOF/LIST/TOP* TOP - Optional
CTI
Progressive Scan USER
CONVENIENT Auto A/V RZ-Model
SOUND FEATURES DPM (Display Power Management)
RF Stereo (A2, NICAM) Child Lock
DASP(4mode) Easy Picture Control (PSM)
AVL, Balance (Stereo) Auto Sleep
Graphic Equalizer Any Key Power On
Sound output: 3W + 3W (rms)

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  43 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV
5. Main Functions/Spec.

ML-024 SPEC. (NTSC)

SPECIFICATIONS REMARKS SPECIFICATIONS REMARKS

Halftone OSD
SYSTEM NTSC M, PAL- M, PAL-N OSD Ez Menu
Multilanguage (English, French,
Spanish)
100-240V , 50/60Hz
Adapter Free
Power consumption : Rear part
13”(35W) , 14”15”(55W) .Video in
POWER
17”(60W) , 20”(65W) .S-VHS in
Stand by : 3W Below EXTERNAL .Component(DVD/DTV) Input
CONNECTIONS (480i,480p,720P,1080i Compatible
TUNING FS 181Ch Input)
Auto/Manual Programming
.Headphone Out
.XGA-IN ( D-SUB Jack)
.PC-Audio In
APC (PSM)
(Clear,Soft, Optimum, User ) Caption/V-Chip Standard
VIDEO Digital comb filter
CTI
Progressive Scan DPM (Display Power Management)
USER Auto Picture Control(APC)
CONVENIENT Auto Sleep
SOUND RF Stereo (Zenith Stereo/SAP)
FEATURES Any Key Power On
Bass, Treble, Balance
Sound output : 3W + 3W

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  44 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV
5. Main Functions/Spec. Description (15.1”)

ML-024 15” SPEC. (LCD Module)

SPECIFICATIONS REMARKS

MONITOR XGA 1024 X 768 85Hz

Type Color Active Matrix TFT

Size 15” ( 38cm)
Pixel Format 1024 X 768 Pixel
LCD
Display Type R / G / B Stripe
Panel
Pixel Pitch 0.297 X 0.297mm
Color Depth 8 bits
Active Video Area 304 X 228mm
Surface Anti Glare, Hard Coating
Back Light 6CCFL
Lamp Life cycle 50,000 Hours(min)

Viewing Angle Left / Right: 176
Contrast ratio10

Optical
Upward /Downward: 176

Luminance 450Cd/m²
Contrast Ratio
400 : 1

Input Signal Volt. Low = 0 ~ 0.8V,High= 2.1 ~ 5.5V

PC Input Separator Sync
Sync Input Sync. type
Signal Polarity Positive & Negative

PC Input Signal Type R, G, B Analog

Color Input Signal Volt. 0 ~ 0.741V p-p
Signal 75
Input Impedance

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  45 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV
5. Main Functions/Spec. Description (17.1”)
ML-024(17.1”) LCD TV Features

SPECIFICATIONS REMARKS

MONITOR XGA 1280 X 768 75Hz

Type Color Active Matrix TFT

Size 17.1” ( 43.438cm)
Pixel Format 1280 X 768 Pixel
LCD
Display Type R / G / B Stripe
Panel
Pixel Pitch 0.291 X 0.291mm
Color Depth 16,194,277 color
Active Video Area 372.48 X 223.488mm
Surface Anti Glare, Hard Coating
Back Light 6CCFL
Lamp Life cycle 50,000 Hours(min)

Viewing Angle Left / Right: 176
Contrast ratio5

Optical
Upward /Downward: 176

Luminance 450Cd/m²
Contrast Ratio
400 : 1

Input Signal Volt. Low = 0 ~ 0.8V,High= 2.1 ~ 5.5V

PC Input Separator Sync
Sync Input Sync. type
Signal Polarity Positive & Negative

PC Input Signal Type R. G. B Analog

Color Input Signal Volt. 0 ~ 0.741V p-p
Signal Input impedance 75

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  46 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV
5. Main Functions/Spec. Spec.(20.1”)

ML-024 20.1” SPEC. (LCD Module)

SPECIFICATIONS REMARKS

MONITOR VGA 640 X 480 60Hz

Type Color Active Matrix TFT

Size 20.1” ( 510.54cm)
Pixel Format 640 X 480 Pixel

LCD Display Type R / G / B Stripe

Panel Pixel Pitch 0.6375 X 0.6375mm
Color Depth 16Mil. Color, 8 bits
Active Video Area 408 X 306mm
Surface Anti Glare, Hard Coating
Back Light
6CCFL
Lamp Life Cycle
50,000 Hours (Minimum)

Optical Viewing Angle Left / Right: 176
Contrast ratio10

Upward /Downward: 176

Luminance 450Cd/m²
Contrast Ratio 400 : 1

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  47 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV
3.3V TO
TO MODULE(400Nit)
MODULE(400Nit)
ML-024A CHASSIS BLOCK DIAGRAM EEP
EEP
ROM
ROM
TCLK+/- TA+/- TB+/- TC+/- TD+/-
ST-BY
3.3V/2.5V SCL1/SDA1 3.3V LVDS TRANSMITTER
POWER
DC to AC THC63LVDM83R
(SMPS)
INVEERTER 12V
MICOM / TXT
4-LAMP OUT H/V Sync
6.0MHz Enable,CLK R(8) G(8) B(8)
(7mA/EA) FROM MICOM 5.0V
BRI -Adj SCL/SDA
R/G/B/FB
FROM MICOM SCALER(Format Converter)
INV-On/Off
CVBS LG8801 OSD
NTSC/PAL/SECAM Decoder with Analog
RGB/YUV SW
OSD/TXT YPbPr/RGB Input and Digital YCbCr/Digital
R/G/B/FB RGB Input
RF V.
===============================

SCART R/G/B/FB A/V V.

Video Video
12V S/W
12V CXA2040
INVERTER,LM1881 8.0V 5.0V S-V.
MSP34** SCL/SDA
SCART V.
MULTISTANDARD RESET 4.2V
33V SOUND PROCESSOR SIF
COAST
TUNER MSP-34XX AUDIO MONO R/Y(8) G/U(8) B/V(8) RF V.
POWER Dual Audio AMP
SIF : 2, SCART : 4 A/V L,R
MONO : 1 AFT
LA4282 I2S : 2 PC L,R
SCL/SDA
5V ------18.432MHz--- S L,R AD Converter SIF
L-SPK / WOOFER 3.3V AD9883 AUDIO
MICOM, TUNER H/P, I2S
SCART OUT : 2 SW2
8.0V
R/G/B H/V
SW1
or YUV
3.3V S L,R H/P L,R B+ TUNER
LG8801, MODULE,
THC63LVDM83R
RGB/YUV IF-0UT
100~220V(AC) AD9883 S/W
ADC
M52758FP
33V
YUV
S L/R S L/R RGB/YUV SW SDA
H/P L,R
SCART V. RF V. S-V. A/V V. A/V L,R From Micom
SCL

.... R/G/B V/H

CTR

AGC
PC L,R

R/G/B/FB L/R in DVD/DTV Input PC Input ANT (RF) Input

AC In TV L/R out H/P S-Input VIDEO Input PC A. In
(480I/480P
CVBS in D-4 720P/1080I) (L/R)

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  48 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV

ML-024B CHASSIS BLOCK DIAGRAM

5V TO
TO MODULE(50P)
MODULE(50P)
POWER H/V Sync
R(8) G(8) B(8)
Enable,CLK
(SMPS)
INVEERTER 5.0V
15V
EEP SCL1/SDA1 H/V R/G/B/FB
6-LAMP OUT
(7mA/EA)
Assay EEP
ROM
ROM IC100 SCL/SDA IC502
INV-On/Off MICOM / TXT IC501
OSD
(FROM MICOM) 6.0MHz CVBS(From IC352) SCALER(Format Converter)
ST-BY
3.3V/2.5V LG8801
RF V.
NTSC/PAL/SECAM Decoder with Analog
CAP./TXT YPbPr/RGB Input and Digital YCbCr/Digital
(R/G/B/FB) RGB Input A/V V.
=============================== IC352
Video Video
S/W S-Y/C
SCART R/G/B/FB CXA2040
15V SCART V.
15V
INVERTER 8.0V 5.0V
MSP34** SCL/SDA
CVBS(To MJ201)
IC601 RESET 4.2V
33V MULTISTANDARD SIF
CVBS(To Micom)
3W SOUND PROCESSOR
TUNER MSP-34XX
AUDIO MONO R/Y(8) G/U(8) B/V(8) RF V.
POWER IC602 SIF : 2, SCART : 4 A/V L,R
AFT
LA4282 MONO : 1 DVD L/R
DC-DC Converter I2S : 2 SCL/SDA IC701 SIF
S-T 5V/5V ------18.432MHz---
S. L/R
AD Converter
3W 3.3V AUDIO
MICOM, TUNER L-SPK / WOOFER AD9883
H/P, I2S
SW2
SCART OUT : 2
SW1

S-T 5V/3.3V S. L/R H/P L,R

Y/U/V
B+ TUNER
LG8801, MODULE,
AD9883,MICOM IF-0UT
12V(DC)
ADC

S. L/R(In/Out) 33V
YUV
MJ201
SDA
SCART V. RF V. H/P L,R
S-V. A/V V. A/V L,R V. OUT A/V L,R OUT
DVD L/R
SCL

.... CTR

AGC

R/G/B/FB L/R in DVD(Audio) DVD/DTV Input H/P S-Input VIDEO Input VIDEO Output ANT (RF) Input
DC In TV L/R out (480I/480P)
CVBS in D-2

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  49 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV

ML-024C CHASSIS BLOCK DIAGRAM EEP

EEP
ROM
ROM

ST-BY
3.3V TO
TO MODULE(450Nit)
MODULE(450Nit)
3.3V/2.5V SCL1/SDA1
POWER
DC to AC
(SMPS)
INVEERTER 12V MICOM / TXT
H/V Sync
Enable,CLK
R(8) G(8) B(8)
4-LAMP OUT 6.0MHz
(7mA/EA) FROM MICOM 5.0V
INV-On/Off SCL/SDA
R/G/B/FB
SCALER(Format Converter)
CVBS(From CXA2040) LG8801 OSD
NTSC/PAL/SECAM Decoder with Analog
RGB/YUV SW OSD/TXT YPbPr/RGB Input and Digital YCbCr/Digital
R/G/B/FB RGB Input
RF V.
===============================

SCART R/G/B/FB A/V V.

Video Video
12V S/W
12V
INVERTER,LM1881 8.0V 5.0V
CXA2040 S-V.
MSP34** SCL/SDA

CVBS SCART V.
MULTISTANDARD RESET 4.2V
33V SOUND PROCESSOR SIF

TUNER
MSP-34XX AUDIO MONO RF V.
POWER Dual Audio AMP
SIF : 2, SCART : 4 A/V L,R YUV(480i)
MONO : 1 AFT
LA4282 I2S : 2
PC L,R
------18.432MHz--- SIF
5V S L,R
L-SPK / WOOFER
AUDIO
MICOM, TUNER H/P, I2S
SCART OUT : 2 SW2

SW1
3.3V S L,R H/P L,R
B+ TUNER
LG8801, MODULE,
100~220V(AC) IF-0UT

ADC

33V
YUV
S L/R S L/R
H/P L,R SDA
SCART V. RF V. S-V. A/V V. A/V L,R

SCL

.... CTR

AGC

AC In R/G/B/FB L/R in DVD/DTV Input H/P S-Input VIDEO Input ANT (RF) Input
TV L/R out (480I)
CVBS in D-1

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  50 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV

ML-024D CHASSIS BLOCK DIAGRAM EEP

EEP
ROM
ROM

ST-BY
3.3V/2.5V SCL1/SDA1
5V TO
TO MODULE(450Nit)
MODULE(450Nit)
POWER
DC to AC
(SMPS)
INVEERTER 15V
MICOM / TXT
6-LAMP OUT H/V Sync
6.0MHz Enable,CLK R(8) G(8) B(8)
(6mA/EA) 5.0V
SCL/SDA
FROM MICOM R/G/B/FB
INV-On/Off
SCALER(Format Converter)
CVBS LG8801 OSD
NTSC/PAL/SECAM Decoder with Analog
RGB/YUV SW OSD/TXT YPbPr/RGB Input and Digital YCbCr/Digital
R/G/B/FB RGB Input RF V.
15V ===============================
INVERTER, OZ960S A/V V.
MSP34** SCART R/G/B/FB Video Video
S/W
CXA2040
15V
S-V.
ST-BY3.3/3.3V 8.0V 5.0V
SCL/SDA
SCART V.
DC-DC LG8801, MODULE,
MICOM,
(MP1583) AD9883 MULTISTANDARD RESET 4.2V
CVBS(To Micom)
SOUND PROCESSOR SIF COAST
ST-BY5/5V 3W
MSP-34XX RF V.
AUDIO MONO R/Y(8) G/U(8) B/V(8)
MICOM, TUNER, ETC D-Class SIF : 2, SCART : 4 A/V L,R
Audio AMP MONO : 1 AFT
TPA3004D2 I2S : 2 SCL/SDA
------18.432MHz--- S L,R AD Converter SIF
3W L-SPK / WOOFER 3.3V AD9883 AUDIO
H/P, I2S
15V SCART OUT : 2 SW2

SW1
POWER 33V
TUNER
YUV
S L,R B+
(480I/480P)
(STR-W6853P) TUNER
IF-0UT
110~240V(AC)
ADC

33V
YUV
S L/R S L/R SDA
H/P L,R
SCART V. RF V. S-V. A/V V. A/V L,R
SCL

.... CTR

AGC

AC In R/G/B/FB L/R in DVD/DTV Input H/P S-Input VIDEO Input ANT (RF) Input
TV L/R out (480I/480P)
CVBS in D-2

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  51 LG DID ENGINEERING DEPT.

 ld w ide
Wo r LCD TV

ML-024E CHASSIS BLOCK DIAGRAM EEP

3.3V TO
TO MODULE(400Nit)
MODULE(400Nit)
EEP
ROM
ROM TCLK+/- TA+/- TB+/- TC+/- TD+/-
ST-BY
3.3V/2.5V SCL1/SDA1 3.3V LVDS TRANSMITTER
POWER
DC to AC THC63LVDM83R
(SMPS)
INVEERTER 15V MICOM / TXT
6-LAMP OUT H/V Sync
6.0MHz Enable,CLK R(8) G(8) B(8)
(6mA/EA) FROM MICOM 5.0V
INV-On/Off SCL/SDA
R/G/B/FB
SCALER(Format Converter)
CVBS LG8801 OSD
NTSC/PAL/SECAM Decoder with Analog
RGB/YUV SW OSD/TXT YPbPr/RGB Input and Digital YCbCr/Digital RF V.
15V R/G/B/FB RGB Input
===============================
INVERTER, OZ960S A/V V.
Video Video
MSP34** SCART R/G/B/FB S/W
CXA2040 S-V.
ST-BY3.3/3.3V 8.0V 5.0V

DC-DC LG8801, MODULE, SCL/SDA SCART V.

MICOM,
(MP1583) AD9883
MULTISTANDARD RESET 4.2V CVBS(To Micom)
SOUND PROCESSOR
ST-BY5/5V 3W SIF COAST
D-Class
MSP-34XX AUDIO MONO R/Y(8) G/U(8) B/V(8) RF V.
MICOM, TUNER, ETC SIF : 2, SCART : 4
Audio
Dual AMP AMP
Audio A/V L,R
MONO : 1 AFT
TPA3004D2
LA4282 PC L,R
I2S : 2 SCL/SDA
------18.432MHz--- S L,R AD Converter SIF
3W
L-SPK / WOOFER 3.3V AD9883 AUDIO
15V H/P, I2S
SCART OUT : 2 SW2
8.0V
R/G/B H/V
POWER 33V or YUV SW1

(STR-W6853P) TUNER
S L,R H/P L,R
B+ TUNER
110~240V(AC) RGB/YUV
IF-0UT
S/W
M52758FP ADC

33V
YUV
S L/R S L/R RGB/YUV SW
H/P L,R SDA
SCART V. RF V. S-V. A/V V. A/V L,R From Micom
SCL

.... R/G/B V/H

CTR

AGC
PC L,R

AC In R/G/B/FB L/R in DVD/DTV Input H/P S-Input VIDEO Input ANT (RF) Input PC A. In
PC Input (L/R)
TV L/R out (480I/480P
CVBS in D-4 720P/1080I)

iŒš›GsnGž›GiŒš›G{ŒŠ•–“–Ž  52 LG DID ENGINEERING DEPT.