Mooney M20 (Pre-201)

Known for strength, economy, speed and a sports-car fit, the basic Mooney airframe
endures.
The thoughts and dreams of airplane owners on a budget, whove had
enough bobbling along at 110 knots, may turn to the pre-201 Mooney
M20 series. These distinctive airplanes dont cost a fortune and they fly
fast (140 knots or so), sipping only a gallon or two more per hour than
a 172. If you find an older
Mooney that has been well
maintained, has a low-time
engine (watch out for those
Lycoming 360 ADs) and the most
popular mods, whats not to love?
Age is one concern. The last pre-J
M20 dates to 1978 and the
biggest numbers were produced
in the 1960s, before one of
Mooneys serial bankruptcies,
Although the J-model put Mooneys on the
which itself is a worry for owners. map, the older M20s, photo above, have
The earliest had wooden wings.
all the basics that make Mooneys fast:
Some of the rest had corrosion
simple folding gear, low drag and a light
airframe.
problems and fuel tanks with
sealant trouble. A bladder mod
has an AD. Resale value is
another issue. The 3700-plus 1977 J and later models, from the 201
onward, keep a lid on the prices of earlier M20s, no matter what their
mods and panel improvements. For the rare owner who doesnt care
the one with a budget who wants an airplane to use and love forever
a pre-J Mooney can be a beautiful thing.
MODEL HISTORY

The M20 series evolved in 1955 from Al Mooneys "Wee Scotsman," the
Mooney Mite M-18, a single-seat, low-wing, speedy little airplane with
manually retractable gear cushioned by rubber "donuts." Mooney
designed it in the 1940s for simplicity, speed and efficiency. In addition
to the donut cushions and the "Johnson bar" for operating the gear,
which would remain an M20 model feature until 1969, the Mite
introduced the famous "backwards" vertical stabilizer that supposedly
improved spin recovery and remains the Mooneys trademark.

The pre-201 Mooneys, launched as a four-seat version of the Mite, are

those that came before the Roy LoPresti aerodynamic redesign with
the J model in 1977, which boosted cruise speeds about 10 to 15
knots. The first M20, the four-seat Mark 20, built from 1955 through
1958, had a wooden wing and tail. Powered by a 150-HP Lycoming O320 with a constant speed prop, it gave way in 1958 to the metaltailed M20A, powered by a 180-HP Lycoming O-360 A1A. It still had
the wooden wing. These two models, of which nearly 700 were built
through 1960, had the worst in-flight break-up record of any small
airplane and ADs that required inspections of the wing and tail for rot.
You can buy one for less than $25,000, though, and cruise at better
than 140 knots.
The B-model Mark 21, made only in 1961, got rid of the wood and
boosted the standard fuel capacity from 35 to 52 gallons. Its metal
wing design, with few changes, is still in production. The B quickly
gave way to the most ubiquitous of all M20 models, the C, in 1962. It
had an engine change to the O-360-A1D, more rudder travel, a handpumped hydraulic flap actuator instead of a mechanical linkage,
increased flap deflection and a 125-pound increase in useful load. The
C remained in production until 1977. More than a third of the 6200
pre-J M20s were C models.
Mooneys success inspired it to try an economy version: the Model D
Master with fixed gear, which cost the design 20 knots or so. Only 60
were made from 1964 through 1966 and its rare to find one that
hasnt been converted to retractable gear. The same year saw Mooney
try a pricier package, too. The Model E Super 21 Chaparral introduced
the 200-HP Lycoming IO-360-A1A, making it the first of the Mooneys
without a carburetor heat control.
In 1965, Mooney introduced its Brittain-made wing-leveler as a
standard feature on all models, calling it "Positive Control" because it
was always on unless the pilot pressed a release button on the yolk.
Either loved, hated or put up with, it probably prevented some
graveyard spirals and remained a feature until the 201 came along.
Known for its tight fit as well as speed, the M20 fuselage got a footlong stretch with the Model F Executive in 1966. Three were made as
that year ended and 536 in 1967, more in one year than any model
before or since. Like the C and E, the F remained in production until
the paradigm shift of LoPrestis 201. In 1969, they all got one-piece
windshields, a popular mod now for earlier models.

The M20G in 1968 matched the C models 180-HP engine with the
longer fuselage and lasted two production years. A more notable and
costly loser was the M22 pressurized Mustang. Introduced in 1968, it
looked like a tank and helped tank the company, which went bankrupt
in 1969. Butler Aviation bought Mooney and stopped production in
1972. Republic Steel bought in and started making Mooneys again in
1974. Republic spun off the design for a Mooney 301, which Socata
built as the TMB700, and merged the company with a French firm in
1984.
There was another bankruptcy in 2001 and another in 2004. One of
the players, the Mooney Aerospace Group Ltd., has been rebuilding the
Mooney Airplane Company since then under a court-approved
reorganization plan. It introduced the M20TN Acclaim at Sun N Fun
this spring. Powered by a 280-HP Teledyne Continental TSIO-550G
with twin turbochargers and dual intercoolers, it goes fast and costs a
lot. If youre looking into pre-J M20s, try not to think about it too
much.
MARKET SCAN

Its been a buyers market for a while, as The Mooney Owners of

America magazine, Mooney Pilot, described it last fall. The Spring 2006
Bluebook average price range for pre-J M20s went from $20,000 for a
1955-1957 M20, $39,000 for a 1961 M20B, $45,000 for a 1965 Model
C into the $50,000-and-up range from 1969 to 1971 and in the
$60,000 range after 1974. The Bluebook put a 1978 Model C at
$67,000 and a 1977 Model F at $72,000. Nothing quite compares to a
Mooney for speed and efficiency but other step-up airplanes are
generally priced higher. A 1967 Cardinal RG is Bluebooked at $67,000.
A 1978 Piper Arrow comes in at $76,000. Forget a 1977 182Q, which
the Bluebook puts at $99,000. Accept lesser airplanes and the prices
get closer. A 1978 Sierra is listed at $61,000 and so is a 1978 fixedgear Cardinal. A 1980 172 RG Cutlass is listed at $65,000.
PERFORMANCE

Mooneys are all about getting speed without spending a lot of money.
Most older models have a 180-HP engine; some the 200-HP fuelinjected Lycoming. A 172 owner who steps up to a mid-1960s Model C
is going to be thrilled watching the world slip under the leading edge at
a noticeably higher pace while flight planning for 10 or so gallons per
hour.
The pre-1977 Model-C Ranger, for example, cruises at 150 knots, the
Bluebook says somewhat optimistically. It has a sea level rate of climb

of 860 FPM. Takeoff over a 50-foot obstacle is listed as about 1400 feet
and landing over one requires 1550 feet.
Mooneys perform well on 180 HP by having low drag, which requires
sacrificing space. It feels like you wear a Mooney and, to some, thats
part of its pleasure. Theres a sports-car slouch required to slip behind
the controls and the pilot sits low with his legs stretched under the
panel a possible problem for short pilots. Those used to sitting up
high and having a good view out and below will feel a bit
claustrophobic. Because the cowling may not be in the pilots field of
view, different sight cues are needed during landings.
These airplanes are famous for being hard to land. That may have
more to do with poor basic training and bad habits that slower singles
let pilots get away with. The Mooney, with its rubber-donut gear, is
easy to grease on if the approach is stable, speed on short final no
more than 75 knots, the roundout is not made too high and the nose is
held off. At higher speeds, its slippery design will float in ground effect.
Thats where pilots get in trouble, over-controlling or dropping it on,
inducing a bounce, then letting the nose fall through and hit the
runway. Thats how pilot-induced oscillations start and woe to the
transitioning Mooney flier who dumps the nose on the runway.
In crosswinds, there is also a legend that Mooneys are tricky. Again,
good speed control, cross-control technique and judgment make up for
any quirks, especially in C and later models, which have more rudder
travel than the early M20s.
Short-field operations can be a challenge. Pilots used to Cessna flaps,
for example, will find the Mooneys almost absent and, as noted, the
airplane will float if approach speeds are too high. Speed brakes are a
popular mod in later models. The problem with them is a tendency to
sink in the pattern and have to drag it in on final. Just carry more
power than you used to once those brakes are deflected.
Mooniacs, as the devoted call themselves, love the older models with
the Johnson bar for operating the manual gear. The gear has low
operational speeds, however, so it cant serve as a speed brake for en
route descents. It also takes a lot of muscle to retract if the pilot lets
the speed build too high on departure.
Theres not a lot of room in a Mooney, but load-carrying ability is not
bad. Squash four people into the airplane, fill the tanks and youre in
trouble in most four-seat airplanes. The useful load of a Mark 21 Model

C is 1050 pounds not counting any mods and new equipment, which
are common on these older models. That leaves, at most, 738 pounds
for people and baggage. Pilots have commented that these airplanes
are perfect cross-country machines for one or two people and their
bags.
Roll response is often called "truck-like." The Mooney is controlled with
pushrods, not cables, and some pilots like their solid feel. Its heavy
aileron feel makes it a good IFR airplane and the Positive Control
feature, on those models that have not had autopilot upgrades, is
simple and helpful when theres work to do in the cockpit.
Good rudder control to prevent yaw is crucial when practicing stalls in
a Mooney. The airflow over that clean wing breaks abruptly and one
wing often will drop. Lower the nose, pick it up with aggressive rudder
and all will be well. Spins are not for the faint-hearted (or legalminded). Youll need at least 1000 feet to recover.
MAINTENANCE

Pre-J shoppers should study up on a number of issues involving these

models and check logbooks carefully. For the pre-buy, use a mechanic
who really knows Mooneys. Problem number one is the old wood wing
and tail. Dont go there. Problem number two is corrosion in the
fuselage tubing. The Mooney is known as a very well built and very
strong airplane. It has a very low break-up rate and a virtual "roll
cage" around the cabin. Rust doesnt care. The older models seem less
prone to it, in part because there was less sound insulation to trap
moisture. Watch out especially for models built in the late 1960s and
early 1970s, before Republic bought the company. Cost-cutting as
bankruptcy loomed included less rust-proofing. Be familiar with
Mooney Service Bulletin M20-208B from August 1989, which calls for
corrosion inspections.
Another common problem is deteriorating fuel-tank sealant that
contaminates fuel and causes engine failure. A 1985 AD covers the
tanks. Other ADs include one in 2004 for airplanes with the popular O
& N bladder fuel cell mod, the result of reports that rainwater was
entering the fuel bladders.
Over the years, there also have been ADs involving cracked aileron
control links, the original Dukes fuel pump, the electric gear, the
control wheel shaft, ingestion of air filter screens and gaskets and
corrosion in the control rigging and landing gear. There have been very

few recent ADs, however. Good logbooks or a good mechanic (and

perhaps a big check for catch-up work) should be vital to any buyer.
Watch out for nose
gear damage as a
result of line
personnel exceeding
the turn limits while
towing the airplane,
which requires a wide
radius. There were 57
Service Difficulty
Reports filed by
mechanics (who
famously complain
about all the screws
they need to remove
to get inside a
Publicity shot of a new M20E from Mooneys files.
Mooney) for pre-J
M20 models from
January 2000 to May 2006.
Thats way down from the last time we checked more than a decade
ago. (J and later models had about 135.) The most, 11, involved
various landing gear problems. Nine had to do with the engine, either
internal components (4), the oil system (3) or accessory gearboxes
(3). Two engine problems could not be specified.
Four reports had to do with the fuel distribution or storage systems
and four involved the prop, spinner or hub. (We recently saw a quart
of water pour out of the spinner when the new owner of an
unhangared M20 pulled his prop through. Not a pretty sight.) The rest
of the SDRs were typical with no discernible patterns. Parts availability
is never mentioned as a problem for older Mooneys. With so many
airplanes out there, it seems unlikely it will become a problem any
time soon.
MODS, OWNER GROUP

Lots of help for Mooney buyers and owners is available on line. The
Mooney Owners of America (MOA) claims to be member owned and
managed, publishes Mooney Pilot magazine and can be visited at
www.mooneyowners.com/. Theres also the Mooney Aircraft Pilots
Association, which is partly sponsored by Mooney and Falcon Insurance
Company. Visit it at www.mooneypilots.com/.

The mods for older Mooneys to make them look and behave just like J
and later models are almost countless. Speed mods, one-piece
windshields, new wingtips, an alternator to replace the old generator
on early models, fuel bladders, larger fuel tanks, speed brakes, new
panels to replace the awful old ones, soundproofing and new engines
are just some of the improvements available.
Lake Aero (www.lakeaero.biz/, 509-682-4109) offers a 201 windshield
and 201-style wingtips. O&N Aircraft Modifications
(www.onaircraft.com/, 570-945-3769) sells six interconnected fuel
bladders to replace the tanks. LoPresti Speed Merchants in Vero Beach
is in the game, of course, with a new cowling, gap seals and other
fixes (www.speedmods.com/, 877-565-1731).
Coy Jacobs Mod Squad in Venice, Florida has a dizzying pile of
information about mods on its site (www.mooneymart.com/, 841-4840801). Precise Flight offers speed brakes; see www.preciseflight.com/,
800-547-2558.
OWNER FEEDBACK
I purchased N128PB, a 1967 M20E, in April 1996 and couldnt have
made a better purchase. I believe this plane offers a lot of bang for the
buck. I have made a few modifications, which include fabricating a
complete new panel containing a Garmin GX60, GEM analyzer, S-Tec
50 and a WX-900 Stormscope. The previous owner installed a cowl
closure mod.
I had Triad Aviation in Burlington, North Carolina, rebuild the engine
about 750 hours ago and couldnt be happier. I had chrome cylinders
installed and burn one quart per four hours. The fuel tanks have been
resealed by Wetwingologists after many attempts at patching.
I can run lean of peak and burn about 8 GPH and 10 GPH running 50
degrees rich of peak. I usually see 140-143 knots true running rich of
peak. I usually fly between 6000 and 10,000 feet and see about 700 to
800 FPM climb. I almost never have more than one passenger aboard
and believe this is a great two-people-with-luggage plane.
Tommy Craig
Conover, North Carolina
In 1996, I bought a 1975 M20E with 2300 TTIS my first ever

airplane after building most of my hours on Grumman Cheetahs and

Tigers. My target was a fast, economical single engine IFR retractable.
I consistently achieved 145 knots on 9.5 GPH and my only gripe would
be the limited range, which in a big country like Australia can be
important. With all Mooneys, the approach speed is important and I
quickly learnt that good landings came from getting the speed right.
Until the M20E, I was apprehensive about crosswind landings in any
aircraft but I found it handled fine in a crosswind and could be landed
well above its demonstrated limit.
The M20E is a strong reliable airframe with sturdy landing gear and is
fast and economical. For those considering an M20E (or any aircraft for
that matter), a thorough independent pre-purchase inspection is
mandatory and walk away if the SBs and ADs have not been done or
are suspect.
Gary McKernan
Adelaide, South Australia
I acquired my 1967 Mooney M20F with 1950 hours on it in February
2003 and have put about 600 hours on it. Some of the interior
appointments are nicer than in the early years of the 201. Most
obvious is that each of the rear seats recline separately where, in
many 201 Mooneys, the rear seat is a bench seat.
The more significant modifications include 201 windshield, gap seals,
wing root flaring, reversed brake calipers, alternator and oil filter. I
added Precise Flight standby vacuum as my first mod and my last was
a RayJay turbocharger. There are few "original" pre-201 Mooneys and I
would avoid those that are stock and unmodified, as it would make
one think the previous owner(s) did not "invest" in the airplane.
To be honest, my two favorite singles are the Bonanza and the
Saratoga/Lance. The reality is both of these types run from $70,000 to
$100,000 and more for good examples than what my Mooney cost. In
my buying search, I looked at other 200 HP planes such as the Cessna
Cardinal RG and the Piper Arrow before selecting a Mooney. The
Cardinal RG, although a quick, roomy plane for 200 HP, is a bit slower
then the Mooney and I feel has a bouncer ride and lower build quality.
The Piper Arrow is slow. The Beechcraft Sierra, although big on the
inside, is underpowered and slower then the Piper.

I have the electric landing gear option and was not interested in the
manual system. The electric gear cycles very fast, only a few seconds
up or down. If youre a medium to tall person the Mooney is
comfortable with lots of legroom. If youre short or wide, you will need
to think about whether or not the airplane is what you really want.
John Murray
Albany, New York
I owned one of these gems, a 1964 M20C, for 16 years. It provided a
good combination of speed, range and low operating costs. The small
cabin coupled with the inability to store outsized luggage led me to sell
the airplane once I started a family.
The Lycoming O-360 engine gave little trouble except when the old
fuel pump went and once when the mag coil split. Other than that, it
was bulletproof. The plane had a big aircraft feel in smooth air but in
turbulence it would transfer the bumps through the yoke. Noise levels
are high and earplugs became standard equipment for passengers.
Ventilation is good with gasper vents on top and full venting on the
bottom. The heater really means business and its possible to get a
nasty burn on your fingers from the blast deflectors. (Hint use the
fingernails.)
The standard instrument lighting is mediocre; I ended up modifying
with post lightsbig improvement. As far as IFR flying goes, it handles
about average but low gear and flap extension speeds require you to
get creative in the pattern. Although far from ideal in unpaved
operations, I sometimes flew into grass and even select gravel fields
(made a trip to Alaska). With the 180-HP engine, it is just an average
climber, but once at altitude I usually cruise between 8000 and
10,000 feet I could get 140 knots on 8.6 gallons an hour. This would
give me nearly six hours
endurance before dry
tanks.
Now for the bad part. The
airplane is a bear to work
on. Im an A&P/IA so I do
my own annuals. There are
just over a thousand
The original 1963 panel of 6562U with some later
exterior screws in this
additions.
aircraft. Fortunately, not all

of them have to come out at annual time. There are several little
mechanisms that need attention (like the empennage trim) and there
is little extra room in the engine compartment. Pay close attention to
leaks: The avionics cover can leak and especially critical are the wing
roots. This can cause corrosion on the frame tubes near the lower spar
attach point. The fuel quantity sending units attach straight from the
cabin, so if a gasket goes bad, it will stink up the whole cabin.
Having said that much, the airplane has good dispatch reliability, which
is to say it doesnt break much. The nose gear can bend if towed by a
tug so I installed the factory limit indicator and made signs reminding
the tug driver to observe tow limits. The baggage door is on the top
level so you dont have to pass excess baggage over the seat.
As far as a structural basis goes, it is built like a tank. If you ever see
one being parted out in a salvage yard, youll see what I mean.
Properly maintained, the manual gear is remarkably easy to use and
youll wonder why it was abandoned. There are few aircraft that offer
such value for the serious cross-country pilot.
Nathan Kimble
Lawrenceville, Georgia
Ive been a cartoonist for 40 years, a pilot for 25 and for the last 15,
Ive owned and flown N213EJ, a 1966 M20E Ive logged over 1500
hours in it and enjoyed every one of them. Ive also logged many
hours drawing the Looney Tunes characters in animation, comic strip
and comic book format, so I couldnt resist the enclosed. Hard to say
which is the most fun.
I added spoilers to the wings and it made descents much easier to
manage. Its a manual-gear Mooney, which I like, plus a few minor
mods. Its an honest 150-knot, 10-gallon-an-hour cross country flyer
or is just plain fun to dink around in locally. If theres a more efficient
airplane around for the money, I havent heard of it.
Lee Holley
Aptos, California
I have owned N7883V, a 1965 M20C, since 1998. In 1993, it was
upgraded with a full IFR package. The instruments were upgraded to a

T panel versus the original random instrument panel. This airplane is

an excellent instrument platform and I use it IFR frequently.
The engine has given me very few problems except for the
replacement of one of the Bendix magnetos and a starter change.
Annuals have run approximately $1500-$2000 but since I use this time
to upgrade or perform preventive maintenance (like installing new
bladders recently), the annual can run me quite a bit more by choice.
The airplane was upgraded from a generator to Airnav alternator
system and starts are now a breeze since I changed to a Skytech
starter.
Externally there are no mods, with the stock fuselage and "guppy"
mouth. Ive often thought of upgrading to a cowl closure but have not
justified the cost.
The airplane consistently gives 144 knots below 9000 feet at 75
percent using 9.8 GPH, which is not bad for a 180-HP airplane. The
nosegear truss has been replaced twice due to FBOs failing to observe
the turning limits during towing. I hope I have cured this with the new
design truss that limits the travel before the truss tubes strike each
other. I love the manual gear; it is a great design that should have
been kept.
Lloyd Stearns
via email