Design of Over Head Water Tank
Design of Over Head Water Tank
products and similar liquids. The force analysis of the reservoirs or tanks is about the same
irrespective of the chemical nature of the product. All tanks are designed as crack-free
structures to eliminate any leakage. Water or raw petroleum retaining slab and walls can be of
reinforced concrete with adequate cover to the reinforcement. Water and petroleum do not
react with concrete and, therefore, no special treatment to the surface is required. Industrial
wastes can also be collected and processed in concrete tanks with few exceptions. The
petroleum products such as petrol, diesel oil, etc. are likely to leak through the concrete walls;
therefore such tanks need special membranes to prevent leakage. The present chapter deals
with the design of water tanks. Reservoirs below ground level are built normally to store
large quantities of water whereas those of overhead type are built for direct distribution by
gravity flow and are usually of smaller capacity.
The reservoirs can be made with a minimum of M20 concrete so to provide not only strength
but also higher density to prevent leakage. A well-graded aggregate with water cement ratio is
less than 0.5 is desired for making impervious concrete. As the head of water increases, there
is a tendency of seepage; however, water heads upto 15m should not present any problem of
seepage provided crack-free design method is applied. Mild or high yield strength steel
reinforcement bars can be used in storage tanks. The permissible stress in the reinforcement is
controlled by the strain and the crack widths rather than the strengths. Plain concrete may
fracture at about 0.0002 tension but when it is strengthened by reinforcement, the level of the
cracking strain is decreased by one-third to one-fifth, depending on the nature of the bond
between the concrete and the reinforcement. Deformed bars or ribbed steel improve the level
of cracking capacity in the concrete. A crack width of 0.1 mm has been accepted as a
permissible value in water retaining structures. This crack width is not a real crack width but
is an imaginary value which really does not cause apparent cracking. In view of the
complexities and uncertainties associated with the crack widths, a simplified approach
through allowable stresses is presented. The fracture strength of the concrete is given by
Where
The allowable direct and bending tensile stresses in concrete can be expressed as
where
Stress
Direct tension
Bending tension
M15
1.1
1.5
M20
1.2
1.7
Grade of concrete
M25
M30
1.3
1.5
1.8
2
M35
1.6
2.2
M15
1.1
1.5
Grade of concrete
M20
M25
M30
1.2
1.3
1.5
1.7
1.8
2
M35
1.6
2.2
The face of the concrete away from the water face can be designed as a cracked section,
provided a minimum of 115 mm uncracked section is available on the water face for a head
of 5m. The allowable stresses in the reinforced bars are listed in table xx.
Table xx allowable stresses in reinforcement (MPa)
Nature of stress
High yield
deformed
100
120
120
150
190
190
It should be stated that all the tensile force either due to hoop tension or bending tension must
be resisted by the reinforcement with the allowable stresses listed in table xx. The allowable
tensile stresses in the reinforced concrete correspond to the uncracked composite section. The
minimum recommended covers to the reinforcement are
Percentage
0.12
0.24
0.16
0.12
0.24
A minimum reinforcement in the concrete is must since the allowed stresses exceed the
normal limits of plain concrete, to minimise cracking due to shrinkage and temperature.
Concrete submerged under water or under soil is less sensitive to shrinkage and temperature
effects when compared with that exposed to alternative drying and wetting.
Roof dome
Top ring beam
Vertical wall
Middle ring beam
Conical dome
Lower dome
Bottom ring beam
minor edge perturbations can be accepted in some of the elements even if R/t is in the
range 20
2. The boundary membrane forces of different components must be properly balanced
by ring beams so as to minimize the transverse shear forces on the shell elements. The
ring beams must be placed properly at the correct locations with no eccentricities. The
eccentricity of the radial or meridional forces with respect to the centroid of the ring
beam will cause end moments on the shell.
3. The reinforcement details play an important role. As far as possible small diameter
bars be provided at closer intervals. Proper anchor lengths, minimization of
congestion of reinforcement and overlaps be maintained. Proper bending of the bars
be applied so as to have smooth transmission of forces.
The membrane theory is an equilibrium method; therefore, improper geometrical alignments
and poor detailing though structurally strong, can lead to cracking and leakage. The notations
used in the design are given below
Notations
t = thickness of shell or wall, h = height
r = radius in plan, R = radius of curvature of the shell
b = width of the beam, D = depth of the beam
= density of water, c = density of concrete.
The subscripts refer to
1 or t = top dome or top ring beam, w = wall
m = middle ring beam,
b = bottom dome or bottom ring beam
Geometric properties and capacity calculations: Let
r1 = radius of the inside face of the cylindrical wall at top
h1 = rise of the top or roof dome
t = semicentral angle of the top dome
Rt = radius of curvature of the top dome
t1 = thickness of the top dome
Usually the radius r and the rise h1 are selected a priori. The rise of the top dome can be
selected in the range of r1/6 to r1/3 depending on the size of the tank. The relation between the
radius of the dome and that of the cylindrical shell is:
Therefore ,
Volume of the liquid in the cylindrical portion of the tank (excluding the free board)
Where h6 = free board, r2 = radius at the base of the wall. Volume of a frustum of a cone is.
= t1
=t
= 0.12 m
Rise of dome
= h1
= 1.5 m
Chord radius
= r1
= 5m
Surface radius
= 0.5(5.12/1.44 + 1.44)
= 9.75 m
= 32.22
Let the density of concrete be 25 kN/m2
Live load = w1 = 0.75 kN/m2
Dead load = wd = 0.12(25) = 3 kN/m2
Total load = w = 3.75 kN/m2
Total live load on the shell is
1.5
Self weight of the dome
Meridional thrust
Compressive stress
The hoop stress is compressive over the entire domain and it is less than meridional stress.
The actual compressive stress is far less than the allowable compressive stress therefore,
provide a nominal reinforcement.
Minimum reinforcement in the either direction is
h = 5m
= t2 = 100 mm
T(kN)
0 to 1
1 to 2
2 to 3
3 to 4
4 to 5
50
75
125
175
225
Reinforcement
Required mm2
Number of 12
333.33
3
500
5
833.33
8
1166.67
11
1500
14
= 75 mm
= 940 N/m
= 750 N/m
= 235 Nm/m
= 320 Nm/m
= 188 Nm/m
= 425 Nm/m
= 75mm
= 45mm
= 105 mm2
Provide 8 mm radial bars at 200 mm c/c and anchored into the ring beam.
As(provided) = 250 mm2/m
Distribution reinforcement =
W1 = 344.45
W2 = 275.56
W3 = 43.24
W4 = 558
W5 = 33.56
LL on the gallery
W6 = 53.69
W7 = 26.85
The load transferred to the conical wall is equal to the weight of the components of the tank
up to the top of the cone plus the live loads etc., and it is
= 250 mm
= 45
= 1.5 m
= 6.25 kN/m2
= 2.12 m
This stress is much smaller than the allowable compressive stress; however, the actual
thickness of the slab is governed by the hoop tension rather than the meridional compression.
The hoop tension is computed at a height (y) from the base = rx = (4+y) m
Height of the water at this level
Hoop tension in the slab at depth y=0, y = 0.75 and y =1.5 m are computed and are given
below.
The maximum hoop tension in the slab occurs at the intersection of the middle ring beam.
The total hoop tension in the slab
Provide 12mm dia bars, 21 at the inner face and 22 at the outer face of the slab
Total area of steel provided is
As = 4860.72 mm2
The area of the concrete required is governed by the allowable tensile stresses in the concrete.
The hoop tension in the concrete is
Minimum reinforcement in the radial direction is 0.24% for 100 mm thick and 0.16 mm for
450 mm thick.
Percentage of reinforcement required
=4m
= 1.5 m
= 0.2 m
Semicentral angle
Meridional thrust
Compressive stress
The compressive stress is only nominal, therefore, provide minimum reinforcement. The
hoop compression is also in the same range. The minimum reinforcement is
The horizontal component of the meridional thrust from the bottom dome at the beam level is
DESIGN OF COLUMNS
Total load of the overhead tank
= 2965.34 kN
= 494.2 kN
= 90 kN
= 660.2 kN
= 660.2 kN
= 1125.015 kN
= 1785.2 kN
= 4.5 m
= 2512 mm2
Use beam section of 0.3 by 0.6 with 2 numbers of 20 mm main bars at top and bottom faces.
Provide stirrups of 8mm bars at 400 mm spacing.
DESIGN OF FOUNDATION
DL + LL on each column
= 494.2 kN
= 292.5 kN
= 519 kN
Load at base
= 1305.7
= (5.85.80.5(25-17)) = 134.56 kN
= 1440.26 kN
= 1125.015 kN
Design load
= 2565.275 kN
= 34 m2
=34 m2
= 75.4 kN/m2
= 71.44 kN/m
Cantilever span
= 2.6 m
Use 100 mm thick slab at the face of the column with 10 numbers of 20 mm bars