Pioneer Avh-X5500 Avh-X5550 Avh-X5590 SM PDF
Uploaded by
Carlos Alonso Gonzalez VazquesPioneer Avh-X5500 Avh-X5550 Avh-X5590 SM PDF
Uploaded by
Carlos Alonso Gonzalez VazquesORDER NO.
CRT5255
AVH-X5500BHS/XNUC
DVD RDS AV RECEIVER
AVH-X5500BHS /XNUC
AVH-X5500BT/XNEW5
AVH-X5550BT/XNRC
AVH-X5550BT/XNRD
AVH-X5550BT/XNRI
AVH-X5590BT/XNID
This service manual should be used together with the following manual(s):
Model No. Order No. Mech.Module Remarks
CX-3283 CRT4843 LS2 DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2012
K-ZZZ OCT. 2012 Printed in Japan
1 2 3 4
SAFETY INFORMATION
A CAUTION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive
B harm.
Health & Safety Code Section 25249.6 - Proposition 65
Where in a manufacturer’s service documentation, for example in circuit diagrams or lists
of components, a symbol is used to indicate that a specific component shall be replaced only
by the component specified in that documentation for safety reasons, the following symbol shall
be used:
- Safety Precautions for those who Service this Unit.
When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable
C results.
Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
D CAUTION
This product is a class 1 laser product classi-
fied under the Safety of laser products, IEC
60825-1:2007, and contains a class 1M laser
module. To ensure continued safety, do not re-
move any covers or attempt to gain access to
the inside of the product. Refer all servicing to
qualified personnel.
E CAUTION—CLASS 1M INVISIBLE LASER
RADIATION WHEN OPEN, DO NOT VIEW
DIRECTLY WITH OPTICAL INSTRUMENTS.
WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
F
AVH-X5500BHS/XNUC
2
1 2 3 4
5 6 7 8
A
Laser diode characteristics
Wave length:
DVD:660 nm to 670 nm
CD:780 nm to 800 nm
Focus lens on Maximum output:
CD:6.26 mW(Emitting period :9 sec.)
DVD:1.27 mW (Emitting period : unlimited)
Additional Laser Caution
B
Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD
respectively. When Q1103 or Q1104 is shorted between their terminals,
the laser diodes for DVD or CD will radiate beam. If the top cover is removed
with no disc loaded while such short-circuit is continued, the naked eyes may
be exposed to the laser beam.
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacturer. C
Discord used batteries according to the manufacturer's instructions.
AVH-X5500BHS/XNUC
5 6 7 8
3
1 2 3 4
CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
A
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 7
2. SPECIFICATIONS ............................................................................................................................................ 8
2.1 SPECIFICATIONS ..................................................................................................................................... 8
2.2 DISC/CONTENT FORMAT ...................................................................................................................... 19
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 20
3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 20
3.2 PCB LOCATIONS .................................................................................................................................... 21
3.3 JIGS LIST ................................................................................................................................................ 22
3.4 CLEANING............................................................................................................................................... 22
4. BLOCK DIAGRAM.......................................................................................................................................... 24
4.1 OVERALL CONNECTION DIAGRAM...................................................................................................... 24
B 4.2 BLOCK DIAGRAM ................................................................................................................................... 26
5. DIAGNOSIS.................................................................................................................................................... 37
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 37
5.2 INSPECTION METHOD OF PICKUP UNIT............................................................................................. 38
5.3 DIAGNOSIS FLOWCHART ..................................................................................................................... 41
5.4 ERROR CODE LIST ................................................................................................................................ 61
5.5 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 64
6. SERVICE MODE ............................................................................................................................................ 65
6.1 MONITOR TEST MODE .......................................................................................................................... 65
6.2 DVD TEST MODE ................................................................................................................................... 83
7. DISASSEMBLY .............................................................................................................................................. 88
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 95
C
8.1 DVD ADJUSTMENT ................................................................................................................................ 95
8.2 PCL OUTPUT CONFIRMATION............................................................................................................ 100
9. EXPLODED VIEWS AND PARTS LIST........................................................................................................ 102
9.1 PACKING ............................................................................................................................................... 102
9.2 EXTERIOR (1) ....................................................................................................................................... 106
9.3 EXTERIOR (2) ....................................................................................................................................... 108
9.4 EXTERIOR (3) ........................................................................................................................................110
9.5 DVD MECHANISM MODULE (1)............................................................................................................112
9.6 DVD MECHANISM MODULE (2)............................................................................................................114
10. SCHEMATIC DIAGRAM..............................................................................................................................116
10.1 MOTHER PCB (ANALOG BLOCK).......................................................................................................116
D 10.2 MOTHER PCB (SYSTEM BLOCK) (GUIDE PAGE) .............................................................................118
10.3 MOTHER PCB (SH BLOCK) (GUIDE PAGE) ...................................................................................... 124
10.4 MOTHER PCB (POWER SUPPLY BLOCK) ........................................................................................ 130
10.5 MOTHER PCB (IN/OUT BLOCK) (GUIDE PAGE)............................................................................... 132
10.6 MOTHER PCB (TUNER BLOCK) ........................................................................................................ 138
10.7 INTERFACE PCB ................................................................................................................................ 140
10.8 DVD CORE UNIT (GUIDE PAGE) ....................................................................................................... 142
10.9 SERVICE UNIT(MONITOR) (GUIDE PAGE) ....................................................................................... 148
10.10 SERVICE UNIT (KEY) ....................................................................................................................... 154
10.11 PCB UNIT (SERVICE) ....................................................................................................................... 156
10.12 WAVEFORMS .................................................................................................................................... 158
11. PCB CONNECTION DIAGRAM.................................................................................................................. 160
E 11.1 MOTHER PCB ..................................................................................................................................... 160
11.2 INTERFACE PCB................................................................................................................................. 164
11.3 DVD CORE UNIT ................................................................................................................................. 166
11.4 SERVICE UNIT (MONITOR) ................................................................................................................ 168
11.5 PCB UNIT (SERVICE) ......................................................................................................................... 172
11.6 SERVICE UNIT (KEY).......................................................................................................................... 174
12. ELECTRICAL PARTS LIST ........................................................................................................................ 175
AVH-X5500BHS/XNUC
4
1 2 3 4
5 6 7 8
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and
should keep the safety during servicing by following the safety instructions described in this manual.
2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic
induction.
3. Please be sure to conduct line process to original status if you make assembling after repair.
4. Please be careful of not to imply static charge onto integrated circuits, etc, when you conduct repair work.
Especially, please use soldering iron with its tip grounded.
Also, please use a pair of tweezers with static charge protection capability if there is the possibility of contacting to
device terminals, and avoid the use of metal-made tweezers.
5. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on B
mode may damage the ICs inside the unit.
6. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder)
by referring to "the DISASSEMBLY".
7. Please keep the distance of more than 13 cm from focus lens for safety when you check pickup and make adjustment,
and do not look straight at Laser Beam for more than 10 seconds.
8. Please power adjustment when you replaced mechanical area of DVD Mecha Module or DVD core unit.
9. Graphically-illustrated areas become hot . Be careful not to burn yourself.
Drive
IC
IC1251 Main IC
IC1501
10. On this mechanism, Pickup and Spindle Motor can not be replaced at the service site, because a special facility is
required for the adjustment after replacing them.
So, if Pickup or Spindle Motor is defective, replace the Mechanism Unit.
11. EJECT LOCK MODE for DVD mechanism
In order to change the EJECT LOCK status of the mechanism, please perform following procedure.
[FORWARD] + [EJECT] -> ACC ON
AVH-X5500BHS/XNUC
5 6 7 8
5
1 2 3 4
A 12. area and a heat sink becomes hot areas. Be careful not to burn yourself.
MOTHER PCB
C801
IC341
IC1821 C2172
L2101
C1979
IC501
B IC1302
MOTHER PCB
IC2161 IC251
IC2101
IC1051
C IC1951
IC1901
IC1911
IC1921
1F & 2F Rear Holder
LS2 DVD Mechanism Module Top Case
AVH-X5500BHS/XNUC
6
1 2 3 4
5 6 7 8
1.2 NOTES ON SOLDERING
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
B
The following lead-free solders are available as service parts:
Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.
AVH-X5500BHS/XNUC
5 6 7 8
7
1 2 3 4
2. SPECIFICATIONS
2.1 SPECIFICATIONS
A • UC Type
General Continuous power output
Power source ................... 14.4 V DC (10.8 V to 15.1 V al- ................................... 22 W × 4 (50 Hz to 15 000 Hz,
lowable) 5 % THD, 4 Ωload, both chan-
Grounding system ............ Negative type nels driven)
Maximum current consumption Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch)
................................... 10.0 A allowable)
Backup current .................... 5 mA or less Preout maximum output level
Dimensions (W × H × D): ................................... 4.0 V
D Equalizer (8-Band Graphic Equalizer):
Chassis .............. 178 mm × 100 mm × Frequency ................. 40 Hz/80 Hz/200 Hz/400 Hz/
165 mm 1 kHz/2.5 kHz/8 kHz/10 kHz
B (7 in. × 3-7/8 in. × 6-1/2 in.) Gain ......................... ±12 dB
Nose .................. 171 mm × 97 mm × HPF:
18 mm Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
(6-3/4 in. × 3-7/8 in. × 3/4 in.) 125 Hz
Weight ............................. 2.0 kg (4.4 lbs) Slope ........................ –12 dB/oct
Subwoofer (mono):
Display Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
Screen size/aspect ratio ... 6.95 inch wide/16:9 125 Hz
(effective display area: Slope ........................ –18 dB/oct
156.6 mm × 81.6 mm) Gain ......................... +6 dB to –24 dB
Pixels ............................... 1 152 000 (2 400 × 480) Phase ....................... Normal/Reverse
Display method ................ TFT active matrix, driving type Bass boost:
C Color system .................... NTSC/PAL/PAL-M/PAL-N/ Gain ......................... +12 dB to 0 dB
SECAM compatible
Durable temperature range (power off)
DVD Player
................................... –4 °F to +176 °F
System ............................ DVD video, Video CD, CD,
WMA, MP3, AAC, DivX, JPEG,
Audio MPEG player
Maximum power output ... 50 W × 4 Usable discs .................... DVD video, Video CD, CD, CD-
70 W × 1/2 Ω (for subwoofer) R/RW, DVD-R/RW/R DL
Region number ................ 1
Frequency response......... 5 Hz to 44 000 Hz (with DVD,
at sampling frequency 96 kHz)
Signal-to-noise ratio ......... 96 dB (1 kHz) (IHF-A network)
D (RCA level)
Output level:
Video ........................ 1.0 Vp -p/75Ω(±0.2 V)
Number of channels ........ 2 (stereo)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
AVH-X5500BHS/XNUC
8
1 2 3 4
5 6 7 8
• UC Type A
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6
audio) (Except ultra and HD) (.avi,
(Windows Media Player) .divx)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded MPEG video decoding format
only) (.m4a) ................................... MPEG1, MPEG2, MPEG4
(Ver. 10.6 and earlier)
JPEG:
JPEG decoding format FM tuner
............................ .jpeg, .jpg, .jpe Frequency range .............. 87.9 MHz to 107.9 MHz
Pixel Sampling .......... 4:2:2, 4:2:0 Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
Decode Size.............. MAX:8 192(H) x 7 680(W), 30 dB)
MIN:32(H) x 32(W) Signal-to-noise ratio ......... 80 dB (digital broadcasting)
B
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6 (IHF-A network)
(Except ultra and HD) (.avi,
AM tuner
.divx)
Frequency range .............. 530 kHz to 1 710 kHz (10 kHz)
MPEG video decoding format
Usable sensitivity ............. 25 µV (S/N: 20 dB)
................................... MPEG1, MPEG2, MPEG4
Signal-to-noise ratio ......... 80 dB (digital broadcasting)
(IHF-A network)
USB
USB standard specification Bluetooth
................................... USB 1.1, USB 2.0 full speed Version ............................ Bluetooth 3.0 certified
(For video files) Output power ................... +4 dBm Maximum
USB 2.0 high speed (For (Power class 2)
audio files) C
Maximum current supply
CEA2006 Specifications
................................... 1.0 A
USB Class ....................... MSC (Mass Storage Class)
File system....................... FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
Power output ................... 14 W RMS × 4 Channels (4 Ω
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
and 1 % THD+N)
only)
S/N ratio .......................... 91 dBA (reference: 1 W into
(Ver. 10.6 and earlier)
4 Ω)
WAV: D
WAV signal format .... Linear PCM, MS ADPCM Note
(.wav)
Sampling Frequency
Specifications and the design are subject to
............................ Linear PCM:16 kHz, modifications without notice.
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0
E
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
AVH-X5500BHS/XNUC
5 6 7 8
9
1 2 3 4
A • EW5 Type
General Continuous power output ... 22 W × 4 (50 Hz to
Rated power source............... 14.4 V DC 15 000 Hz, 5 % THD,
(allowable voltage range: 4 Ω load, both channels dri-
10.8 V to 15.1 V DC) ven)
Grounding system................... Negative type Load impedance ...................... 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch)
Maximum current consumption allowable)
..................................................... 10.0 A Preout maximum output level
Backup current .......................... 5 mA or less ..................................................... 4.0 V
Dimensions (W × H × D):
DIN Equalizer (8-Band Graphic Equalizer):
Chassis ..................... 178 mm × 100 mm × Frequency.......................... 40 Hz/80 Hz/200 Hz/400 Hz/
B 157 mm 1 kHz/2.5 kHz/8 kHz/10 kHz
Nose ........................... 188 mm × 118 mm × Gain ...................................... ±12 dB
26 mm HPF:
D Frequency.......................... 50 Hz/63 Hz/80 Hz/100 Hz/
Chassis ..................... 178 mm × 100 mm × 125 Hz
165 mm Slope.................................... –12 dB/oct
Nose ........................... 171 mm × 97 mm × 18 mm Subwoofer (mono):
Frequency.......................... 50 Hz/63 Hz/80 Hz/100 Hz/
Weight .......................................... 2.0 kg 125 Hz
Slope.................................... –18 dB/oct
Display Gain ...................................... +6 dB to –24 dB
Screen size/aspect ratio.......6.95 inch wide/16:9 Phase .................................. Normal/Reverse
C (effective display area: Bass boost:
156.6 mm × 81.6 mm) Gain ...................................... +12 dB to 0 dB
Pixels ............................................. 1 152 000 (2 400 × 480) DVD Player
Display method ........................ TFT active matrix, driving
System .......................................... DVD video, Video CD, CD,
type
WMA, MP3, AAC, DivX,
Color system.............................. NTSC/PAL/PAL-M/PAL-N/
JPEG, MPEG player
SECAM compatible
Usable discs .............................. DVD video, Video CD, CD,
Durable temperature range (power off)
CD-R/RW, DVD-R/RW/R DL
..................................................... –20 °C to +80 °C
Region number ........................ 2
Frequency response............... 5 Hz to 44 000 Hz (with DVD,
Audio at sampling frequency
Maximum power output ....... 50 W × 4
96 kHz)
D 70 W × 1/2 Ω (for subwoo-
Signal-to-noise ratio............... 96 dB (1 kHz) (IEC-A net-
fer)
work) (RCA level)
Output level:
Video.................................... 1.0 Vp-p/75 Ω (±0.2 V)
Number of channels .............. 2 (stereo)
MP3 decoding format ........... MPEG-1 & 2 Audio Layer 3
WMA decoding format ......... Ver. 7, 7.1, 8, 9, 10, 11, 12
(2 ch audio)
(Windows Media Player)
AAC decoding format............ MPEG-4 AAC (iTunes en-
coded only) (.m4a)
(Ver. 10.6 and earlier)
E JPEG:
JPEG decoding format
........................................... .jpeg, .jpg, .jpe
AVH-X5500BHS/XNUC
10
1 2 3 4
5 6 7 8
• EW5 Type A
Pixel Sampling ................ 4:2:2, 4:2:0 Signal-to-noise ratio............... 62 dB (IEC-A network)
Decode Size..................... MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W) LW tuner
DivX decoding format............ Home Theater Ver. 3, 4, 5.2, Frequency range...................... 153 kHz to 281 kHz
6 (Except ultra and HD) Usable sensitivity..................... 28 µV (S/N: 20 dB)
(.avi, .divx) Signal-to-noise ratio............... 62 dB (IEC-A network)
MPEG video decoding format
..................................................... MPEG1, MPEG2, MPEG4 Bluetooth
USB Version .......................................... Bluetooth 3.0 certified
USB standard specification Output power ............................ +4 dBm Maximum
B
..................................................... USB 1.1, USB 2.0 full speed (Power class 2)
(For video files)
USB 2.0 high speed (For Note
audio files) Specifications and the design are subject to mod-
Maximum current supply .... 1.0 A ifications without notice.
USB Class................................... MSC (Mass Storage Class)
File system.................................. FAT16, FAT32
MP3 decoding format ........... MPEG-1 & 2 Audio Layer 3
WMA decoding format ......... Ver. 7, 7.1, 8, 9, 10, 11, 12
(2 ch audio)
(Windows Media Player)
AAC decoding format............ MPEG-4 AAC (iTunes en-
coded only) C
(Ver. 10.6 and earlier)
WAV:
WAV signal format ........ Linear PCM, MS ADPCM
(.wav)
Sampling Frequency.... Linear PCM:16 kHz,
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG:
JPEG decoding format
........................................... .jpeg, .jpg, .jpe D
Pixel Sampling ................ 4:2:2, 4:2:0
Decode Size..................... MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
DivX decoding format............ Home Theater Ver. 3, 4, 5.2,
6 (Except ultra and HD)
(.avi, .divx)
MPEG video decoding format
..................................................... MPEG1, MPEG2, MPEG4
FM tuner
Frequency range...................... 87.5 MHz to 108.0 MHz
Usable sensitivity..................... 9 dBf (0.8 µV/75 Ω, mono,
S/N: 30 dB) E
Signal-to-noise ratio............... 72 dB (IEC-A network)
MW tuner
Frequency range...................... 531 kHz to 1 602 kHz (9 kHz)
Usable sensitivity..................... 25 µV (S/N: 20 dB)
AVH-X5500BHS/XNUC
5 6 7 8
11
1 2 3 4
A • RC Type
General Preout maximum output level
Power source ...................14.4 V DC (12.0 V to 14.4 V al- ................................... 4.0 V
lowable) Equalizer (8-Band Graphic Equalizer):
Grounding system ............ Negative type Frequency ................. 40 Hz/80 Hz/200 Hz/400 Hz/
Maximum current consumption 1 kHz/2.5 kHz/8 kHz/10 kHz
...................................10.0 A Gain ......................... ±12 dB
Backup current .................... 5 mA or less HPF:
Dimensions (W × H × D): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
D 125 Hz
Chassis .............. 178 mm × 100 mm × Slope ........................ –12 dB/oct
165 mm Subwoofer (mono):
B Nose .................. 171 mm × 97 mm × Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
18 mm 125 Hz
Weight ............................. 2.0 kg Slope ........................ –18 dB/oct
Gain ......................... +6 dB to –24 dB
Display Phase ....................... Normal/Reverse
Screen size/aspect ratio ... 6.95 inch wide/16:9 Bass boost:
(effective display area: Gain ......................... +12 dB to 0 dB
156.6 mm × 81.6 mm)
Pixels ............................... 1 152 000 (2 400 × 480)
DVD Player
Display method ................ TFTactive matrix, driving type
System ............................ DVD video, Video CD, CD,
Color system .................... NTSC/PAL/PAL-M/PAL-N/
WMA, MP3, AAC, DivX, JPEG,
SECAM compatible
C
MPEG player
Durable temperature range (power off)
Usable discs .................... DVD video, Video CD, CD, CD-
................................... –20 °C to +80 °C
R/RW, DVD-R/RW/R DL
Region number ................ 3
Audio Frequency response......... 5 Hz to 44 000 Hz (with DVD,
Maximum power output ... 50 W × 4 at sampling frequency 96 kHz)
70 W × 1/2 Ω (for subwoofer) Signal-to-noise ratio ......... 96 dB (1 kHz) (IEC-A network)
Continuous power output (RCA level)
................................... 22 W × 4 (50 Hz to 15 000 Hz, Output level:
5 % THD, 4 Ω load, both chan- Video ........................ 1.0 Vp-p/75 Ω (±0.2 V)
nels driven) Number of channels ........ 2 (stereo)
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
allowable) WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
D audio)
(Windows Media Player)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
only) (.m4a)
(Ver. 10.6 and earlier)
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
AVH-X5500BHS/XNUC
12
1 2 3 4
5 6 7 8
• RC Type A
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6 AM tuner
(Except ultra and HD) (.avi, Frequency range .............. 530 kHz to 1 640 kHz (10 kHz)
.divx) 531 kHz to 1 602 kHz (9 kHz)
MPEG video decoding format Usable sensitivity ............. 25 µV (S/N: 20 dB)
................................... MPEG1, MPEG2, MPEG4 Signal-to-noise ratio ......... 62 dB (IEC-A network)
USB Bluetooth
USB standard specification
................................... USB 1.1, USB 2.0 full speed Version ............................ Bluetooth 3.0 certified
(For video files) Output power ................... +4 dBm Maximum
USB 2.0 high speed (For (Power class 2) B
audio files)
Maximum current supply Note
................................... 1.0 A Specifications and the design are subject to
USB Class ....................... MSC (Mass Storage Class)
modifications without notice.
File system....................... FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
only)
(Ver. 10.6 and earlier)
C
WAV:
WAV signal format .... Linear PCM, MS ADPCM
(.wav)
Sampling Frequency
............................ Linear PCM:16 kHz,
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0 D
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx)
MPEG video decoding format
................................... MPEG1, MPEG2, MPEG4
FM tuner
Frequency range .............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
E
30 dB)
Signal-to-noise ratio ......... 72 dB (IEC-A network)
AVH-X5500BHS/XNUC
5 6 7 8
13
1 2 3 4
A • RD Type
General Preout maximum output level
Power source ................... 14.4 V DC (12.0 V to 14.4 V al- ................................... 4.0 V
lowable) Equalizer (8-Band Graphic Equalizer):
Grounding system ............ Negative type Frequency ................. 40 Hz/80 Hz/200 Hz/400 Hz/
Maximum current consumption 1 kHz/2.5 kHz/8 kHz/10 kHz
................................... 10.0 A Gain ......................... ±12 dB
Backup current .................... 5 mA or less HPF:
Dimensions (W × H × D): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
D 125 Hz
Chassis .............. 178 mm × 100 mm × Slope ........................ –12 dB/oct
165 mm Subwoofer (mono):
B Nose .................. 171 mm × 97 mm × Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
18 mm 125 Hz
Weight ............................. 2.0 kg Slope ........................ –18 dB/oct
Gain ......................... +6 dB to –24 dB
Phase ....................... Normal/Reverse
Display Bass boost:
Screen size/aspect ratio ... 6.95 inch wide/16:9 Gain ......................... +12 dB to 0 dB
(effective display area:
156.6 mm × 81.6 mm)
Pixels ............................... 1 152 000 (2 400 × 480) DVD Player
Display method ................ TFT active matrix, driving type System ............................ DVD video, Video CD, CD,
Color system ....................NTSC/PAL/PAL-M/PAL-N/ WMA, MP3, AAC, DivX, JPEG,
C SECAM compatible MPEG player
Durable temperature range (power off) Usable discs .................... DVD video, Video CD, CD, CD-
................................... –20 °C to +80 °C R/RW, DVD-R/RW/R DL
Region number ................ 4
Frequency response......... 5 Hz to 44 000 Hz (with DVD,
Audio at sampling frequency 96 kHz)
Maximum power output ... 50 W × 4 Signal-to-noise ratio ......... 96 dB (1 kHz) (IEC-A network)
70 W × 1/2 Ω (for subwoofer) (RCA level)
Continuous power output Output level:
................................... 22 W × 4 (50 Hz to 15 000 Hz, Video ........................ 1.0 Vp-p/75Ω(±0.2 V)
5 % THD, 4 Ω load, both chan- Number of channels ........ 2 (stereo)
nels driven) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
D
allowable) audio)
(Windows Media Player)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
only) (.m4a)
(Ver. 10.6 and earlier)
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
AVH-X5500BHS/XNUC
14
1 2 3 4
5 6 7 8
• RD Type A
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6 AM tuner
(Except ultra and HD) (.avi, Frequency range .............. 530 kHz to 1 640 kHz (10 kHz)
.divx) 531 kHz to 1 602 kHz (9 kHz)
MPEG video decoding format Usable sensitivity ............. 25 µV (S/N: 20 dB)
................................... MPEG1, MPEG2, MPEG4 Signal-to-noise ratio ......... 62 dB (IEC-A network)
USB Bluetooth
USB standard specification
................................... USB 1.1, USB 2.0 full speed Version ............................ Bluetooth 3.0 certified
(For video files) Output power ................... +4 dBm Maximum
USB 2.0 high speed (For (Power class 2) B
audio files)
Maximum current supply Note
................................... 1.0 A Specifications and the design are subject to
USB Class ....................... MSC (Mass Storage Class)
modifications without notice.
File system....................... FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
only)
(Ver. 10.6 and earlier)
C
WAV:
WAV signal format .... Linear PCM, MS ADPCM
(.wav)
Sampling Frequency
............................ Linear PCM:16 kHz,
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling ..........4:2:2, 4:2:0 D
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx)
MPEG video decoding format
................................... MPEG1, MPEG2, MPEG4
FM tuner
Frequency range .............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
E
30 dB)
Signal-to-noise ratio ......... 72 dB (IEC-A network)
AVH-X5500BHS/XNUC
5 6 7 8
15
1 2 3 4
A • RI Type
General Audio
Power source ................... 14.4 V DC (12.0 V to 14.4 V al- Maximum power output ... 50 W × 4
lowable) 70 W × 1/2 Ω (for subwoofer)
Grounding system ............ Negative type Continuous power output
Maximum current consumption ................................... 22 W × 4 (50 Hz to 15 000 Hz,
................................... 10.0 A 5 % THD, 4 Ω load, both chan-
Backup current .................... 5 mA or less nels driven)
Dimensions (W × H × D): Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch)
DIN allowable)
Chassis .............. 178 mm × 100 mm × Preout maximum output level
157 mm ................................... 4.0 V
B Nose .................. 188 mm × 118 mm × Equalizer (8-Band Graphic Equalizer):
26 mm Frequency ................. 40 Hz/80 Hz/200 Hz/400 Hz/
D
Chassis .............. 178 mm × 100 mm × 1 kHz/2.5 kHz/8 kHz/10 kHz
165 mm Gain ......................... ±12 dB
HPF:
Nose .................. 171 mm × 97 mm ×
18 mm Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
125 Hz
Weight ............................. 2.0 kg Slope ........................ –12 dB/oct
Subwoofer (mono):
Display
Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
Screen size/aspect ratio ... 6.95 inch wide/16:9
125 Hz
(effective display area:
Slope ........................ –18 dB/oct
156.6 mm × 81.6 mm)
C Gain ......................... +6 dB to –24 dB
Pixels ............................... 1 152 000 (2 400 × 480) Phase ....................... Normal/Reverse
Display method ................ TFT active matrix, driving type Bass boost:
Color system ....................NTSC/PAL/PAL-M/PAL-N/ Gain ......................... +12 dB to 0 dB
SECAM compatible
Durable temperature range (power off)
................................... –20 °C to + 80 °C DVD Player
System ............................ DVD video, Video CD, CD,
WMA, MP3, AAC, DivX, JPEG,
MPEG player
Usable discs .................... DVD video, Video CD, CD, CD-
R/RW, DVD-R/RW/R DL
Region number ................ 2
D
Frequency response......... 5 Hz to 44 000 Hz (with DVD,
at sampling frequency 96 kHz)
Signal-to-noise ratio ......... 96 dB (1 kHz) (IEC-A network)
(RCA level)
Output level:
Video ........................ 1.0 Vp-p/75 Ω (±0.2 V)
Number of channels ........ 2 (stereo)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
AVH-X5500BHS/XNUC
16
1 2 3 4
5 6 7 8
• RI Type A
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6
audio) (Except ultra and HD) (.avi,
(Windows Media Player) .divx)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded MPEG video decoding format
only) (.m4a) ................................... MPEG1, MPEG2, MPEG4
(Ver. 10.6 and earlier)
JPEG:
JPEG decoding format FM tuner
............................ .jpeg, .jpg, .jpe Frequency range .............. 87.5 MHz to 108.0 MHz
Pixel Sampling .......... 4:2:2, 4:2:0 Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
Decode Size.............. MAX:8 192(H) x 7 680(W), 30 dB)
MIN:32(H) x 32(W) Signal-to-noise ratio ......... 72 dB (IEC-A network) B
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6
(Except ultra and HD) (.avi,
AM tuner
.divx)
Frequency range .............. 530 kHz to 1 640 kHz (10 kHz)
MPEG video decoding format
531 kHz to 1 602 kHz (9 kHz)
................................... MPEG1, MPEG2, MPEG4
Usable sensitivity ............. 25 µV (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)
USB
USB standard specification
Bluetooth
................................... USB 1.1, USB 2.0 full speed
(For video files)
Version ............................ Bluetooth 3.0 certified
USB 2.0 high speed (For
Output power ................... +4 dBm Maximum C
audio files)
(Power class 2)
Maximum current supply
................................... 1.0 A Note
USB Class ....................... MSC (Mass Storage Class)
File system....................... FAT16, FAT32 Specifications and the design are subject to
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 modifications without notice.
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
only)
(Ver. 10.6 and earlier)
WAV: D
WAV signal format .... Linear PCM, MS ADPCM
(.wav)
Sampling Frequency
............................ Linear PCM:16 kHz,
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0 E
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
AVH-X5500BHS/XNUC
5 6 7 8
17
1 2 3 4
A • ID Type
General Preout maximum output level
Power source ................... 14.4 V DC (12.0 V to 14.4 V al- ................................... 4.0 V
lowable)
Equalizer (8-Band Graphic Equalizer):
Grounding system ............ Negative type
Frequency ................. 40 Hz/80 Hz/200 Hz/400 Hz/
Maximum current consumption
1 kHz/2.5 kHz/8 kHz/10 kHz
................................... 10.0 A
Backup current .................. 5 mA or less Gain ......................... ±12 dB
HPF:
Dimensions (W × H × D):
Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
D
125 Hz
Chassis .............. 178 mm × 100 mm ×
Slope ........................ –12 dB/oct
B 165 mm
Subwoofer (mono):
Nose .................. 171 mm × 97 mm ×
Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
18 mm
125 Hz
Weight ............................. 2.0 kg Slope ........................ –18 dB/oct
Gain ......................... +6 dB to –24 dB
Display Phase ....................... Normal/Reverse
Screen size/aspect ratio ... 176.5 mm wide/16:9 Bass boost:
(effective display area: Gain ......................... +12 dB to 0 dB
156.6 mm × 81.6 mm)
Pixels ............................... 1 152 000 (2 400 × 480)
Display method ................ TFT active matrix, driving type DVD Player
Color system .................... NTSC/PAL/PAL-M/PAL-N/ System ............................ DVD video, Video CD, CD,
SECAM compatible WMA, MP3, AAC, DivX, JPEG,
C
Durable temperature range (power off) MPEG player
................................... –20 °C to +80 °C Usable discs .................... DVD video, Video CD, CD, CD-
R/RW, DVD-R/RW/R DL
Region number ................ 5
Audio Frequency response......... 5 Hz to 44 000 Hz (with DVD,
Maximum power output ... 50 W × 4 at sampling frequency 96 kHz)
70 W × 1/2 Ω (for subwoofer) Signal-to-noise ratio ......... 96 dB (1 kHz) (IEC-A network)
Continuous power output (RCA level)
................................... 22 W × 4 (50 Hz to 15 000 Hz, Output level:
5 % THD, 4 Ωload, both chan- Video ........................ 1.0 Vp-p/75 Ω (±0.2 V)
nels driven) Number of channels ........ 2 (stereo)
Load impedance .............. 4 Ω (4 Ω to 8 Ω (2 Ω for 1 ch) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
D allowable) WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
AAC decoding format ....... MPEG-4 AAC (iTunes encoded
only) (.m4a)
(Ver. 10.6 and earlier)
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
E
AVH-X5500BHS/XNUC
18
1 2 3 4
5 6 7 8
• ID Type A
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6 FM tuner
(Except ultra and HD) (.avi, Frequency range .............. 87.5 MHz to 108.0 MHz
.divx) Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N:
MPEG video decoding format 30 dB)
................................... MPEG1, MPEG2, MPEG4 Signal-to-noise ratio ......... 72 dB (IEC-A network)
USB AM tuner
USB standard specification Frequency range .............. 530 kHz to 1 640 kHz (10 kHz)
................................... USB 1.1, USB 2.0 full speed 531 kHz to 1 602 kHz (9 kHz)
(For video files) Usable sensitivity ............. 25 µV (S/N: 20 dB)
USB 2.0 high speed (For Signal-to-noise ratio ......... 62 dB (IEC-A network) B
audio files)
Maximum current supply
................................... 1.0 A Bluetooth
USB Class ....................... MSC (Mass Storage Class)
File system....................... FAT16, FAT32 Version ............................ Bluetooth 3.0 certified
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 Output power ................... +4 dBm Maximum
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch (Power class 2)
audio)
(Windows Media Player) Note
AAC decoding format ....... MPEG-4 AAC (iTunes encoded Specifications and the design are subject to
only) modifications without notice.
(Ver. 10.6 and earlier)
C
WAV:
WAV signal format .... Linear PCM, MS ADPCM
(.wav)
Sampling Frequency
............................ Linear PCM:16 kHz,
22.05 kHz, 24 kHz, 32 kHz,
44.1 kHz, 48 kHz
MS ADPCM:22.05 kHz,
44.1 kHz
JPEG:
JPEG decoding format
............................ .jpeg, .jpg, .jpe
Pixel Sampling .......... 4:2:2, 4:2:0 D
Decode Size.............. MAX:8 192(H) x 7 680(W),
MIN:32(H) x 32(W)
DivX decoding format ....... Home Theater Ver. 3, 4, 5.2, 6
(Except ultra and HD) (.avi,
.divx)
MPEG video decoding format
................................... MPEG1, MPEG2, MPEG4
2.2 DISC/CONTENT FORMAT
E
The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc.
and any use of such marks by Pioneer Corporation is under license.
Other trademarks and trade names are those of their respective owners.
F
is a trademark of DVD Format/Logo Licensing Corporation.
AVH-X5500BHS/XNUC
5 6 7 8
19
1 2 3 4
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING
A
To keep the product quality after servicing, please confirm following check points.
No. Procedures Item to be confirmed
1 Confirm whether the customer complain has The customer complain must not be
been solved. reappeared.
If the customer complain occurs with the Display, video, audio and operations must be
normal.
specific media, use it for the operation check.
2 Flap-mecha Check the operation of the flap mechanism. The flap mechanism operation must be
smooth without making the noise and
scratches.
3 DVD Measure playback error rates at the Deterioration of mecha-drive can be
B innermost and outermost tracks by using the checked.
test mode with the following disc. The error rate must be less than the
DVD test disc (TDV-582) threshold value.
(Refer to the chapter of DIAGNOSIS for the
threshold value.)
4 DVD Play back a DVD. Display, video, audio and operations must be
(Menu operation; Title/chapter search) normal.
5 CD Play back a CD. Display, audio and operations must be
(Track search) normal.
6 FM/AM tuner Check FM/AM tuner action. Display, audio and operations must be
C (Seek, Preset) normal. * If the reception sensitivity is poorer
Switch band to check both FM and AM. than normal, the gasket on the FM/AM tuner
unit may be damaged or lost.
7 Check whether no disc is inside the product. The media used for the operating check must
be ejected.
8 Appearance check No scratches or dirt on its appearance after
receiving it for service.
For check items concerning image and voice, please refer to the followings:
Check items concerning image Check items concerning voice
D Block-noise Distortion
Crosscut noise Noise
Dot noise Low volume
Distorted image (Image skip) High volume
Low brightness Changes in level
Too bright Pause of sound
Color fading
Partial discoloration
AVH-X5500BHS/XNUC
20
1 2 3 4
5 6 7 8
3.2 PCB LOCATIONS
A Mother PCB A
C DVD Core Unit
D Service Unit (Monitor)
E Service Unit (Key) B Interface PCB
B
F PCB Unit (Service)
A:AVH-X5500BHS/XNUC
B:AVH-X5500BT/XNEW5
C:AVH-X5550BT/XNRC
D:AVH-X5550BT/XNRD
E:AVH-X5550BT/XNRI
F:AVH-X5590BT/XNID
Service Unit(Mother I/F) C
Consists of
Mother PCB
Interface PCB
Unit Number : CXX4970(A)
Unit Number : CXX4969(B)
Unit Number : CXX4972(C)
Unit Number : CXX4973(D)
Unit Number : CXX4974(E)
Unit Number : CXX4975(F)
Unit Name : Service Unit(Mother I/F)
Unit Number : YWX5032 D
Unit Name : DVD Core Unit
Unit Number : CXX4997
Unit Name : Service Unit(Monitor)
Unit Number : CXX5005
Unit Name : Service Unit(Key)
Unit Number : EXX2001
Unit Name : PCB Unit(Service)
AVH-X5500BHS/XNUC
5 6 7 8
21
1 2 3 4
3.3 JIGS LIST
DVD Mechanism Module
A
Interface PCB
GGD1222
B
Mother PCB
GGD1188
Service Unit (Monitor)
Drive Unit
C
PCB Unit(Service)
- Jigs List
Name Jig No. Remarks
D Disc TDV-582 Skew adjustment, Check points after servicing,
Inspection method of Pickup Unit
Disc TCD-782 Inspection method of Pickup Unit
30P FFC GGD1222 DVD CORE UNIT <–> MOTHER PCB
10P FFC GGD1188 PCB UNIT (SERVICE) <–> MOTHER PCB
- Grease List
Name Jig No. Remarks
Grease GEM1024 DVD Mechanism Module, Drive Unit
Grease GEM1038 DVD Mechanism Module
Grease GEM1045 DVD Mechanism Module
E Grease GEM1043 Drive Unit
3.4 CLEANING
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools:
Portions to be cleaned Cleaning tools
F DVD pickup lenses Cleaning liquid : GEM1004
Cleaning paper : GED-008
AVH-X5500BHS/XNUC
22
1 2 3 4
5 6 7 8
AVH-X5500BHS/XNUC
5 6 7 8
23
F
E
B
A
D
C
24
1
1
C
"ELECTRICAL PARTS LIST".
DVD CORE UNIT
4. BLOCK DIAGRAM
CN1952
CKS6025-A
1
2
3
4
5
6
7
8
9
2
2
22
23
24
25
26
27
28
29
30
10
11
12
13
14
15
16
17
18
19
20
21
AVH-X5590BT/XNID
E AVH-X5550BT/XNRI
D AVH-X5550BT/XNRD
C AVH-X5550BT/XNRC
B AVH-X5500BT/XNEW5
A AVH-X5500BHS/XNUC
D-
D+
SCL
VD5
VD8
VD8
VD8
SDA
AGND
AGND
AGND
PGND
PGND
PGND
DGND
DGND
CPRST
CPRDY
AMUTE
MOVBS
IECOUT
SLVSTS
STANBY
XRESET
IRQPWR
HSTCMD
WAKEUP
ANA_L_OUT
VIDEO_GND
ANA_R_OUT
9
8
7
6
5
4
3
2
1
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
YEK5001-A
B.UP
CN751
CKS6025-A GND
16 1 2
15
ACC
14
BGSENS
13
YT ILM
1 12
4.1 OVERALL CONNECTION DIAGRAM
XR B.REM
2 11
YB MUTE
3 10
XL P.B.
4 9
CSX1194
CKS6327-A
RL+
8
CN5301
FL+
7
CKM1376-A
RL-
JA801
TOUCH PANEL
6
AVH-X5500BHS/XNUC
FL-
5
RR+
4
FR+
3
RR-
2
POWER SUPPLY
FR-
1
GND
3
3
60
DIO1 59 WIREDAD 2
NC 58 WIRED 3
VR1 GNDD 1
57
CKS6437-A
VR2 56
JA3731
VR3 8 GNDA
55 GNDA
VR4 7
WIRED REMOTE
54 RLOUT
VR5 53 6
VR6 5 RROUT
52 FLOUT
VR7 51 4
VR8 3 FROUT
XKB7001-B
50 SWLOUT
JA1631
VR9 49 2 BTMICP 2
SWROUT NC 3
VR10 48 1 BTMICN 1
PRE OUT
B0 47
CKN1040-A
B1
JA3691
46
BT MIC
B2 45
B3 44
60 COMDC 1
B4 43
59 POL 2
B5 42
58 VCLK 3
G0 41
57 OEV 4
G1 40 SXL 1
56 STV2 5
G2 WIREDAD SXTX 2
39 LCDGND 1 50
G3 55 6 WIRED XC 3
38 HCLK 2 49
G4 54 7 GNDSX SXR 4
37 LCDGND 3 48
G5 53 8 GNDSX GNDA 5
36 LD 4 47
R0 52 9 SXEN SXRX 6
SXi
35 R5 5 46
CKS3806-A
R1 51 10 SXPWR NC 7
34 R4 6 45
4
JA3701
4
R2 50 11 SXPWR GNDSX 8
33 R3 7 44
R3 49 12 NC SXPWR 9
8 43
D
32 R2
R4 48 13 SXL PWEN 10
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
31 R1 9 42
R5 47 14 GNDA
30 R0 10 41
only A
LOAD 46 15 GNDA
29 G5 11 40
L/R 45 16 SXR
B
28 G4 12 39
AVDD 44 17 ASENBO
27 G3 13 38
A
AVDD 43 18 GND
26 G2 14 37
GND 42 19 STOSX
25 G1 15 36
GND 41 20 SXTOS
24 G0 16 35
HCLK 40 21 GNDD
CKS6536-A
23 B5 17 34 VIDEO
DVDD 39 22 GNDD 1
18 33
CN5001
22 B4 AUXR
DIO2 38 23 GNDD 3
21 B3 19 32
GND 37 24 BTMICP AUXL 4
20 B2 20 31
AKN1073-A
GND
CWX4182
GND 36 25 BTMICN 2
19 B1 21 30
JA3641
GND 35 26 GND
TFT LCD
AUX IN
18 B0 22 29
STV2 34 27 NTOSYS
17 LCDGND 23 28
33 28
A 2/6 SYSTEM
UD SYSTON
A 1/6 ANALOG
CN
C
C
C
CKS
16 24 27
A 5/6 IN/OUT B
DIO
CK
A 6/6 TUNER B
A 3/6 SH BLOC
INTERFAC
C
MOTHER
SERVICE UNIT
A 4/6 POWER S
27 G3 13 38
A
AVDD 43 18 GND
26 G2 14 37
GND 42 19 STOSX
25 G1 15 36
GND 41 20 SXTOS
24 G0 16 35
HCLK 40 21 GNDD
CKS6536-A
23 B5 17 34 VIDEO
DVDD 39 22 GNDD 1
18 33
CN5001
22 B4 AUXR
DIO2 38 23 GNDD 3
21 B3 19 32
GND 37 24 BTMICP AUXL 4
20 B2 20 31
AKN1073-A
GND
CWX4182
GND 36 25 BTMICN 2
19 B1 21 30
JA3641
GND 35 26 GND
TFT LCD
AUX IN
18 B0 22 29
STV2 34 27 NTOSYS
17 LCDGND 23 28
UD 33 28 SYSTON
16 DIO 24 27
OEV 32 29 GND
15 LCDGND 25 26
VCLK 31 30 ONSEI-
6 SH BLOCK
14 LCDPW 26 25
CKS6535-A
GND 30 31 ONSEI+
13 LPSYNC 27 24
CKS6429-A
CN1701
GND 29 32 GUIDEON NAVI_TO_SYS 26
CKS6536-A
CKS6536-A
12 V18HI 28 23
28 33 SYS_TO_NAVI 25
CN5401
POL TVON
CN1751
CN3601
11 LCDGND 29 22
34 VSW5 24
MOTHER PCB
XON 27 DTVR
10 30 21
6 IN/OUT BLOCK
PWRVI
6 TUNER BLOCK
NC 26 35 DTVAG MONON 23
INTERFACE PCB
9 TEMPSENS 31 20
VEEG-6V 25 36 GUIDEON 22
6 SYSTEM BLOCK
DTVL
6 ANALOG BLOCK
5
32 19
5
8 PWM_G
NC 24 37 GND TVON 21
7 PWM_R 33 18
VDDG+18V 23 38 CSYNC DSEN 20
6 PWM_B 34 17
NC 22 39 APPPUP CCREM 19
5 KDT1 35 16
STV1 21 40 ANB GNDRAU 18
4 KDT0 36 15
NC 20 41 GNDSIG REAUL 17
RVICE UNIT(MONITOR)
3 RST 37 14
VCOM 19 42 ANG REAUR 16
2 REMIN 38 13
VCOM 18 43 GNDSIG OMSEI- 15
1 LCDGND 39 12
17 44 ANR ONSEI+ 14
MTCHCL 40 11
6 POWER SUPPLY BLOCK
16 45 GNDSIG GNDD 13
41 10
CKS4497-A
15 MTCHDA 46 AUXV GNDAU 12
CN3661
ANODE TPIRQN 42 9
1 14 47 AUXVGND CCAUR 11
ANODE KEYGND 43 8
2 13 48 AUXL CCAUL 10
ANODE TOUCHGND 44 7
3 12 49 AUXAGND ASENBO 9
NC DDC33 45 6
4 11 50 AUXR 8
K1 BLSYNC 46 5 YS
5 10 51 AUXAGND 7
K2 BLEN 47 4 GNDDVD
6 9 52 BEEP 6
K3 DIMMER 48 3 DVDVBS
7 8 53 5
CKS6523-A
49 BCAMIN 2 GNDSIG
NAVI/DTV INTERFACE
K4 8 BLERR 54 4
CN5201
7 BCAMGND
NC BLGND 50 1 CSYNC
9 6 55 3
NC BLGND CCB
10 5 56 2
BLGND CCG
BACK LIGHT
4 57 1
ILMB CCR
3 58
2 ILMB 59
6 SHIELD2
1 ILMB 60
5 SHIELD1
4 USBGND
3 USB_D+
6
6
CN5403 2 USB_D- BCAMIN
2
CKS6524-A
CKN1091-A
USB5V
USB IN
1
INPUT
JA1601 BCAMGND 1
9
8
7
6
5
4
3
2
1
11
10
CKB1106-A
JA3621
RST
ILMB
KDT1
KDT0
LEDB
REM
1 VCR_RG
LEDR
LEDG
DDC33
KEYGND
KEYGND
REAR CAMERA
2 VCR_RIN
3 VOUT_G
4 VOUT
9
8
7
6
5
4
3
2
1
11
10
5 VCR_LG
6 VCR_LIN
CKB1102-A
VSS
BT33V
BT18V
BT18V
BT18 EN
LINEOUT L
nRESET
UART AT TX
LINEOUT R
CN3801 7 VCR_VG
JA1621
UART AT RX
UART DBG TX
UART DBG RX
CKS6291-A 8 VCR_VIN
RCA V IN OUT
12 13
11 14
10 15
9 16
8 17
7 18
6 19
5 20
4 21
3 22
2 23
1 24
CKS6346-A
CN1671
VSS
I2S IN
MIC1 P
MIC2 P
MIC1 N
MIC2 N
BOOTS
I2S CLK
I2S OUT
MIC BIAS
I2S SYNC
I2S MCLK
BT MODULE
22
1
1
ANT
AVH-X5500BHS/XNUC
YKS5041-A
JA451
FM/AM
Consists of
E
CN1651
CKS6437-A
7
7
CKS6095-A
9
8
7
6
5
4
3
2
1
10
MOTHER PCB
MICIN
GNDA
INTERFACE PCB
JA1661 MICSENSR
2
3
1
POS
MOT1
MOT0
MOTV
MOTV
GNDD
GNDD
GNDD
VDD33
HOSW
SERVICE UNIT(KEY)
9
8
7
6
5
4
3
2
1
10
CN101
SERVICE UNIT(MOTHER)
CKS4997-A
AEQ MIC
F
PCB UNIT
(SERVICE)
8
8
25
E
A
D
C
F
B
1 2 3 4
4.2 BLOCK DIAGRAM
A
RCA V
A MOTHER PCB (1/3)
IN/OUT
8
6
4
JA1621
VCR_VIN
VCR_LIN
VOUT
CN751 AV SELECT
IC101
1 VD8 AK4223V
2
RCA_V 13
3 VOUT2
7 VD5
VCR_L 33
TUN_L LIN4
TUN_L 27
ANA_L_OUT
G LS_L 36
LIN6
17 LIN3
AUX_L 30
LIN5
iTV_L 40
LIN2
SH_L SH_L 43
TO 2/3 H LIN1
B iCOMP iCOMP
C I VCR_V
11
9
VIN1
VIN2
CN1952 19
MOVBS LS_V 5
VIN4
BCAMIN 3
VIN5
AMUTE AUX_V 7
8 VIN3
XRESET XRST
9
IRQPWR IRQPW
10
HSTCMD SYSTOLS
11
SLVSTS LSTOSYS
12
STANBY STANBY Q751
13 Q752
D- D- SYS+B
22 105 AVSCL 46
D+ D+ L TO 2/3 AVSCK SCL
23 103 AVSDA 45
AMUTE AVSDATA SDA
104 AVSRST 17 V
AVSRST RSTN
CN1701
AUXL
44
C BCAMIN
49
AUXV
42
35
EVSEL
IC1721 EVSDA
33
NJM4558V 34
EVSCK
DTVL 2 17 36 EVSACLK
32 1 iTV_L AMUTE SACLK
DTVAG 3 9 120 EVSAOUT
31 XRST SAIN
16
IRQPW
SYSTOLS 7 6
IC1731 (1/2) TXDVD MICSEN
NJM4558V IC1731 (2/2) LSTOSYS 8
RXDVD AEQAUXSW
62
ONSEI+
NJM4558V STANBY 29
STB SYSMUTE
38
6
27 7 2 1 OFFSET
ONSEI- 5 1 iNAVI offset
26 3
SYSTEM uCOM
Q1721 IC601 (1/3)
SYS+B A :PDB091A8
IC1741 B C D :PDB094A8
TC7SH126FU
E F
D SXTOS 2 4 53
16 RXSXI/NC
IC1751
TC7SET08FUS1
STOSX 4 2 52
15 TXSXI/NC
A
SXL BUSL+ 68
9 AMPPW
B 10
GNDA BUSL-
TELMUTEIN
74
75
TELMUTE
CN3601 ANR PBSENS
40
ANG
K TO 2/3 ISENS
77
38 76 BGSENS0
ANB BGSENS
36 111
CSYNC ASENS
34 Q601 110
BSENS
TVON 3
29 RGBARI
GUIDEON 2
28 GUIDEON 57
SYSTON 4 BTRST
E 24
NTOSYS 5
TXNAVI 56
23 RXNAVI BTRX
55
Q1701 BTTX
ASENBO
13 BUP_1
APPPUP
35 SOC33_1 100
ASENBO
SXPWR
7 DABSX12
6 A :AVH-X5500BHS/X
5
SXEN 54
SXIPWREN/NC
B :AVH-X5500BT/XNE
C :AVH-X5550BT/XNR
D :AVH-X5550BT/XNR
E :AVH-X5550BT/XNR
WIREDAD 118
1
WIRED 117
WIREDAD F :AVH-X5590BT/XNI
2 WIRED
BEEP 67
48 BEEP
F
BTMICN
21
BTMICP
20
AVH-X5500BHS/XNUC
26
1 2 3 4
5 6 7 8
JA1661
AV SELECTOR E.VOL AEQMICIN 2
EQ MIC
IC101 IC251 MICSEN MICSENSR 3
AK4223VQ PML020A GNDA 1
13
VOUT2
18
MIC SENS
MIC_IN Q1662
33 SYS+B
LIN4
27 22 AV_LOUT1 8
LIN6 LOUT2 IN2L
36 AEQAUXSW
LIN3
30
LIN5
40 BTANAL 9
LIN2 IN3L JA1631
43
LIN1 61 RCA_FL FLOUT
PREOUT
FRONT_L 4
11 60 RCA_RL RLOUT B
VIN1 REAR_L 6
9 BUSL+ 11
VIN2 IN4L+ 59 RCA_SWL SWLOUT
5 BUSL- 12 PRE_SWL 2
VIN4 IN4L-
3
VIN5 A
7 Q1633(1/2) Q1633(2/2) Q1631
VIN3
iNAVI 14
IN5L
RCAMUTE
Q311
54
EV12 VP BUP_1
46
SCL SYSMUTE
45
SDA 14 MONVBS
17 VOUT1 J TO 2/3
RSTN AMP
IC341
EVSEL 32 PA2030A JA801
STB
EVSDA 31 11 9 FL+
DATA FLIN RL+ 7
EVSCK 30 7 FL- C
CLK 15 RL- 5
EVSACLK 28 RLIN
SACLK
EVSAOUT 27 4 17 RL+
SAOUT STBY FL+ 8
19 RL-
FL- 6
OFFSET
Q302
OFFSET 25
offset
MUTE
AMPMUTE 22
Q331 Q321
SYS+B SYSMUTE
POWER SUPPLY
FUSE B.UP
BUP_1 16
B.REM 10A
AMPPW IC301
TPD1052F
3 8 B.REM
IN OUT 11
TEL MUTE
TELMUTE Q854 (1/2) MUTE D
10
PBSENS
PBSENS Q854(2/2) P.B.
9
ISENS
Q841
ISENS ILM
12
BGSENS AVH
Q831
BGSENS0 BGSENS
13
ASENS
ASENS Q871(2/2) ACC
14
BSENS
Q871(1/2)
BSENS
BUP_1
CN1671
nRESET
7
UART_AT_TX E
11
UART_AT_RX
12
BT18V
BT18 5
DAC 6
IC1671 BT33
BT33V
8
WM8761BGED
-X5500BHS/XNUC 2
BT MODULE
I2S_OUT
DIN 13
-X5500BT/XNEW5 BTANAL 9 BCKIN
3
1
I2S_CLK
I2S_SYNC
15
VOUTL
-X5550BT/XNRC LRCIN
MCLK
14 I2S_MCLK
16
17
-X5550BT/XNRD
BTMICN MIC1_N
-X5550BT/XNRI BTMICP MIC1_P
20
-X5590BT/XNID MIC_BIAS
21
22
BT1.8V REG.
IC2061
NJM2856DL3-18 F
2
4 VIN DD5
BT18 VO 1 BT18_EN
CONTROL 4
AVH-X5500BHS/XNUC
5 6 7 8
27
1 2 3 4
A MOTHER PCB (2/3)
A
VIDEO DECODER
IC1051
ML86V7675TBZ03A
MONVBS 59
TO 1/3 J CVBS1
RGB VIDEO ISOLATOR
IC1002
BH7673G
Q1002
ANR 4 1 12
+IN OUT RIN1
IC1004
BH7673G
B Q1004
ANG 4 1 1
+IN OUT GIN1
TO 1/3 K
iCOMP
IC1003 I TO 1/3
BH7673G
Q1001
ANB 4 1 5
+IN OUT BIN1
IC1001
BH7673G SDA
51 V_SDA0
Q1003 52 V_SCL0
CSYNC 4 1 16 SCL
+IN OUT CSYNC_A
RF FRONT END IC iPod CP
IC501 IC1202
TDA7706 337S3959
ANTENNA
JA451 VCC
1 5
FMMIXIN1 8
16 57 TUN_L Q1201
18
PINDIN DACOUTL G TO 1/3 76
LNAIN PE6
SD RAM
SYSTEM uCOM IC1101
IC601(2/3) M12L128168A-5TG2N
A :PDB091A8
D BB_DIQ/REF_CLK 44
31 GPIO1 B C D E F :PDB094A8
BB_DII 43
32 GPIO2
BB_WS 42
33 GPIO3 33 42
BB_CLK 41 TUNDATA
34 GPIO4 I2CSDA
A_DO 40 34 44
38 GPIO5 I2CSCL TUNCLK
A_DI 39
39
A_WS 38
GPIO6 FLASH ROM
40
A_CLK 37
GPIO7 IC1251
41 GPIO8 A C :CXX4926
B D E F :CXX4927
RESET
3
U401
31
RSTN
93
SOCXRST
WWR C-TUN UNIT
37 68
E SOCSTB PJ3
TX 40 95 77
18 RXHD/NC SOCAMUTE1 PE7
RX 39 30 202
19 TXHD/NC TXSOC PF7
RESET 43 31 203
20 TUNRST RXSOC PF8
94 216
SOCIRQPW PF1
SCS 38
23 PJ2
SSCK 232
24 PJ2
SDO 237
25 PJ2
SDI 238
26 PJ2
DVCC11_1
17
30
DVCC11_2
TUN12
A :AVH-X5500BHS/XNUC
DVCC33_1 B :AVH-X5500BT/XNEW5
21 TUN33
F 35
DVCC33_2 C :AVH-X5550BT/XNRC
A
D :AVH-X5550BT/XNRD
E :AVH-X5550BT/XNRI
F :AVH-X5590BT/XNID
AVH-X5500BHS/XNUC
28
1 2 3 4
5 6 7 8
CN1751 (1/2)
10
SH PART uCOM R[0-5] l
IC1302 15
R5S72690RW266FP 16
G[0-5] l
21
22
B[0-5] l
27
191 POL
PG26/LCD_TCON1 2
190 VCLK
PG25/LCD_TCON0 3
44 OEV
PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1 4
43 STV2
PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1 5
189 HCLK B
PG24/LCD_CLK 7
185 LD
PG21/DV_DATA7/LCD_DATA21/LCD_TCON4/TxD4/AUDATA2 9
183 DIO
PG20/DV_DATA6/LCD_DATA20/LCD_TCON3/RxD4 29
66 LPSYNC
PJ28/SSISCK5/TIOC1B/RTS7 32
PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2
42
239
TPIRQN
BLSYNC
47 D
PJ27/SGOUT_3/TIOC1A/CTS7 51 CN5401
223 BLEN
PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0 52
22 DIMMER
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK 53
118 BLERR
PH0/AN0/PINT0 54
0
0 70 MTCHCK
PE0/SCL0/TCLKA/LCD_EXTCLK 45
71 MTCHDA
PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK 46
V_SDA0
V_SCL0
V18HI 33
PWRVI 35 C
TPN33 50
TAGGING ILMB 58
IC1301 59
MX25L8006EM2I-12G 60
Q1201
76
PE6/SCL3/RxD6
DAC
IC1151
WM8761BGED D
9 SH_L
VOUTL H TO 1/3
16 USBFLG
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
24 USBCNT
M TO 3/3
PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD
68
PJ30/SSIDATA5/TIOC2B/IETxD E
77
PE7/SDA3/RxD7
202
PF7/SSIRxD0/RxD0/SGOUT_3/CTS1
203
PF8/A23/TxD0
USB SW
216
PF16/SD_CD_0/FCE/IRQ4/MMC_CD
IC751
TC7USB221FT
DP
94 12 JA1601
5 USB_D+
38 3
PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2
232 10
PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7
237 93 14
PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7 DM
238
PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7 4 USB_D-
2 USB IF
11
221 3
PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
USB5V
USB5 1
D+ F
TO 1/3 L D-
AVH-X5500BHS/XNUC
5 6 7 8
29
1 2 3 4
A MOTHER PCB (3/3)
A
DC/DC CONVERTER
IC1951
DD8 AN33012UA
P2151 Q1951
3 1
VD8 RS1 VCC BUP_1
2
P2152 VCC_S1
ILMB 24
VCC_S2
4
HSD1
7
FB1
8
EN1
P2071 Q1952 12
23 FLAG
VD5 RS2
P2081
PWRVI
B 22 13
HSD2 SYNC
DD5 18 9
FB2 EN2
USB5V REG.
IC2161
AN33014UA
24 4
USB5 LX PVCC1 BUP_1
2 5
RSO PVCC2
12 6
FB VCC
19 USBFLG
FLAG
EN
16 USBCNT M TO 2/3
17
SYNC
DDC3.3V REG.
IC2101
C BD9876EFJ
1 8
DDC33 LX VCC BUP_1
4
FB
SOC33 5
SYNC
6
SOC33_1 EN
VDEC33
TPN33 SOC1.25V REG.
IC2011
BT33 BD00IA5WEFJ
1 8
SOC12 VO VCC SOC33
2 5
FB EN
VDD3.3V REG.
IC1801
NJW4181U3-33B
TUN3.3V REG.
VDD33
1
VOUT VIN
3
BUP_1
IC1911
NJM2886DL3-33
2
D 4 VIN DD5
TUN33 VOUT 1
CONT
VDEC1.5V REG.
IC2031
NJM2878F3-15
5
TUN1.2V REG.
4 VIN VDEC33 IC1921
VDEC15 VOUT
CONT
1 S-1172B12-E6
1 6
TUN12 VOUT VIN DDC33
ON/OFF
TUN5V REG. 3
IC1901 A
NJM2886DL3-05 P1951
2
4 VIN DD8
TUN5 VOUT 1
CONT
E
SYS+B
IC1821
DD5V REG. Q1853 NJM2387ADL3
V18HI
EV12.3V REG. 3 VIN
1
BUP_1
Q1856 SYS+B VOUT 2
Q1851 Q1852 CONT
EV12 DD5
MOTV
Q2131 P2131
MOTV DD8
Q2132
F
AVH-X5500BHS/XNUC
30
1 2 3 4
5 6 7 8
SYSTEM uCOM
IC601 (3/3)
A :PDB091A8
B C D :PDB094A8
E F
70
VDCNT8
64
DDCERR
B
CN1751 (2/2)
119 COMDC
COMDC 1
73 LCDPW
LCDPW 31
124 TMPSENS
TEMPSEN 36
92 PWM_G
G_PWM 37
R_PWM
90
88
PWM_R
PWM_B
38 D
B_PWM 39 CN5401
126 KDT1
KDT1 40
127 KDT0
KDT0 41
112 REMIN
REMIN 43
28 RST
65 ATRST 42
DDCCLK 26
NRST
69
VDCNT5
CN1651
10 H&OSW
H&OSW 10
121 POS
POS 7
SOC33 89 MOT1
MOT1 6
MOT0
87 MOT0
5 F
VDD33 8 CN101
MOTV 2
1
DD5 D
49
HDPWR33/NC
A :AVH-X5500BHS/XNUC
B :AVH-X5500BT/XNEW5
C :AVH-X5550BT/XNRC
DDC33
D :AVH-X5550BT/XNRD
E :AVH-X5550BT/XNRI
A F :AVH-X5590BT/XNID
48
HDPWR11/NC A
B C D E F
E
DABSX12
Q1901 Q1903 P1901
BUP_1 DABSX12 BUP_1
122
SXISENS/ANTSENS
66 Q1902
SYSPW
50
SXIPW/ANTPW
DD8
F
91
MOTPWR2
AVH-X5500BHS/XNUC
5 6 7 8
31
1 2 3 4
B INTERFACE PCB C DVD CORE UNIT
A
CN3601 FLASH ROM (16M x 2)
BEEP 1 BUZZER
3 BZ3631
IC1401
JA3731 CWW5043
WIREDAD WIREDAD 2
50
49
WIRED WIRED 3 WIRED
GNDD 1 REMOTE
IC1402
CWW5044
JA3701 RESET
12
SXTOS SXTX
35 2
STOSX SXRX
36 6
GNDA GNDA
41 5 SDRAM
SXL SXL
42 1 SXi IC1480
B 44
SXPWR SXPWR
9 M12L64164A-5TG2M
45
SXEN PWEN
46 10
A MOTOR DRIVER
IC1251
BA5839FP
CN3661 LECRGM 17 24
WHITE VO4+ OPINSL
ASENBO ASENBO LECRGP 18 23
38 9 GREEN VO4- OPOUTSL
NTOSYS NAVI_TO_SYS SPDLM 15 22
28 25 BLK VO3+ LDIN
SYSTON SYS_TO_NAVI SPDLP 16 21
27 24 RED VO3- CNT
9
MUTE
ONSEI- ONSEI- 7
25 14 OPOUT1
ONSEI+ ONSEI+ 6
24 13 OPIN1-
CN1701
GUIDEON GUIDEON 4
23 21
TVON TVON OPOUT2
22 20 3
DTVAG GNDAU
12
NAVI/DTV I/F OPIN2-
25
20
DTVL CCAUL OPOUT3
19 10 26
CN1101 OPIN3-
A
T+ 14 1
C 17
CSYNC CCSYNC
4 1
F- 12
VO2+ VR
2
APPPUP MONON 2 VO1+ OPIN2+
16 22 F+ 11 5
ANB CCB 3 VO1- OPIN1+
15 3 T- 13 27
ANG CCG 4 VO2- OPIN3+
13 2
ANR CCR
11 1
Q1104 Q1102
78LD
13
JA3641
GND 2 Q1103 Q1101
AUXL AUXL 4 65LD
7 14
AUXR 3 AUX IN
AUXV AUXV 1
9
TEMP
6
F+H/G+H
10
E+G/E+F
JA3621 11
B
BCAMIN BCAMIN 2 16
D 2 A
BACK CAMERA 17
C
BCAMGND 1 INPUT 18
D
PU (DP11)
19
FE1
20
FE2
21
JA3691
BTMICP BTMICP 2
31 IMON VR1101
3
BT MIC 22
BTMICN BTMICN 1
30
VR1102
A :AVH-X5500BHS/XNUC 23
RF
B :AVH-X5500BT/XNEW5
C :AVH-X5550BT/XNRC
D :AVH-X5550BT/XNRD
E
E :AVH-X5550BT/XNRI
F :AVH-X5590BT/XNID
Vref
8
VCC
9 VCC5
AVH-X5500BHS/XNUC
32
1 2 3 4
5 6 7 8
IT
A
ROM (16M x 2) SYSTEM uCOM ADAC
IC1501 IC1801
MN2DS0018MA PCM1753DBQ
IC1401 151 2
WW5043 ADOUT DATA
150 3
LRCK LRCK
SRCK
149 1
BCK
CN1952
148 16 7 ANALOG LOUT
DACCK SCK VOUTL 14
57 13
IC1402 SDODAC
58 14
MD
WW5044 SCKDAC MC
56 15
LTDAC ML
12
RESET
75 AMUTE
EXTRG1 23
SDRAM NRES
70 XRESET
22
IC1480 IRQPWR
48 IRQPWR
21
4164A-5TG2M 53 HSTCMD B
CMDCOMN 20
54 SLVSTS
STSCOMN 19
191 STANBY
CN751
STANDBY 18
TOR DRIVER 138 COMPOSITE
12
COMPOSITE
IC1251 144 D-
9
LOUT
A5839FP 146 D+
8
ROUT
A
24 67 152 IECOUT
IECOUT 6
OPINSL CRGDRV 47 SCL
23 I2C_SCL 4
OPOUTSL 46 SDA
22 62 I2C_SDA 3
LDIN LDIN 61 RESET
21 63 CP_Reset 2
CNT CONT1
9 64
MUTE CONT2
7 127
OPOUT1 FD
6
OPIN1-
4 126
VCC5 REG. VD8 30
OPOUT2
3
TD IC1002 29
OPIN2- S-1133B50-U5
25 66
OPOUT3 MD 4 VD8
26 5 VIN 28
OPIN3- VCC5 VOUT 3
1 110 ON/OFF
VR
2
VHALF VD5 24 C
OPIN2+
5 VCC5-AU REG.
OPIN1+
27 IC1003
OPIN3+ S-1200B50-M5
1
5 VIN
VCC5_AU VOUT 3
ON/OFF
Q1104 Q1102
106
LPCO2 VCC33 REG.
IC1004
NJM2855DL1-33
Q1103 Q1101
104 3 1
LPCO1 VCC33 Vout Vin
122
TEMP
112
F+H_G+H VCC12 REG.
111
E+G_E+F IC1953
100
VIN3RF S-1135D12-A6
99 6
D
VIN4RF 1 VIN
98 VCC12 VOUT 4
VIN2RF ON/OFF
97
VIN1RF
115
VIN7
116
VIN8
VR1101 105
CDMPD
VR1102 103
DVDMPD
S1
HOME
96 65
RFINP HOME
IC1951
TC7SZU04FU S3
55
2 4 50 12EJ
USB_CLOCK
E
X1950
121
VDSENS VD8
48MHz
109
VREFH
113
VIN5
114
VIN6
117
VIN3
118
VIN4
119
VIN2
120
VIN1
AVH-X5500BHS/XNUC
5 6 7 8
33
1 2 3 4
D SERVICE UNIT(MONITOR)
A
CN5401
51
| R[0-5]
46
45
| G[0-5]
40
39
| B[0-5]
34
DIO
32
LD
52
HCLK
54
STV2
56
OEV
57
VCLK
58
POL
B 59
COMDC
Q5103
COMDC
60
LCD33
TEMPSENS
25
4 23
TH5201 VIN LX1
THERMISTOR 6 24
CE LX2
7
VFB
LCD3.3V REG. AMPOUT
12
IC5102
S-1155B33-U5 CPVCC
20
4
PWRVI VIN 5
LCDPW 1 VOUT LCD33 22
30 ON/OFF CPPSW Q5106
C
LCD POWER 21
1 ILMB
IC5101 CPP
R1290K103A
2
3
11 TPN33
26 PWRVI
A CN1751 CPPFB
17
Q5101
LPSYNC 13 5
29 RT VREF
DTC 10
15
CPNFB
ILMB
19
CPN
D V18HI
28
BLSYSC
10
BLEN
9
DIMMER
8
BLERR
7
MTCHCK
16
MTCHDA
15
TPIRQN
14
REMIN
18
RST
19
KDT0
20
KDT1
21
Q5402
PWM_B
22
23 PWM_R
PWM_G
24
AVH-X5500BHS/XNUC
34
1 2 3 4
5 6 7 8
LCD PANEL
A
CN5001
30
|
35
36
|
41
42
|
47
DIO1 LCD
59
LOAD
29
HCLK(33.3MHz)
23
STV2
17
OEV(Low)
15
VCLK
14
POL
11 B
Vcom
2
1
GRADATION VOLTAGE AVDD
27
26
48
VR[1-10] |
57
VDDG +18V
6
06
VEEG-6V
C
8
DVDD_3.3V
LCD33 22
L/R (Hi)
28
XON (Hi)
10
CN5201
Anode 1
ILMB |
3
LCD BACKLIGHT DRIVER
IC5201
BD81A04EFV-M D
1
28
VCC OUTL
20
17
BACKLIGHT
CS OVP
5 13 K1
SYNC LED1 5
27 14 K2
EN LED2 6
8 15 K3
PMW LED3 7
9 16 K4
FAIL1 LED4 8
10
FAIL2
TOCH PANEL CONTROLLER
IC5301 CN5301
AK4187VN
1 8 XL
SCL XN 4
2
4
SDA YN
13
9
YB
XR
3 TOUCH
PENIRQN XP
YP
12 YT
2
1
PANEL
E
CN5403
REM
2
RST
10
KDT0
3
KDT1
5
LEDB
8
Q5401 E CN3801
LEDR
6
LEDG
7
TPN33 9
ILMB 4 F
AVH-X5500BHS/XNUC
5 6 7 8
35
1 2 3 4
E SERVICE UNIT(KEY)
A REMOTE CONTROL SENSOR
U3801
CN3801 RS-470
REM 4
2
TPN33 2
9
KEY MATRIX D3801 D3802
KDT0 S3801, S3802, S3803,
3
KDT1 S3804, S3805, S3806,
5 S3807, S3808, S3809
RST
D CN5403 10 S3810
LEDB
8
LEDG
7
LEDR
6
ILMB
4
B
F PCB UNIT(SERVICE)
MOTOR DRIVER
IC101 DRIVE MECHANISM
CN101 BA6288FS
MOT0 6 14 GN
5 FIN OUT2
MOTOR UNIT
M EXA4003
MOT1 11 3 PL
6 RIN OUT1
MOTV 4
1 VM
C
5
2 VCC
12
VREF
A CN1651
POS VR101
7 POSITION
8 VDD
HOME
S101
H/O
10
HOME
S102
AVH-X5500BHS/XNUC
36
1 2 3 4
5 6 7 8
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
RESET
VDD50 : pin 24 VDD50=3.3V?
bsens : pin 110 bsens=L?
B
asens : pin 111 asens=L?
socstb : pin 37
socstb=H? C
Standby
ASENBO : pin 100
ASENBO←H
DDCCLK←Clock Out D
DDCCLK : pin 65 (Frequency of 413.9 kHz)
VDCNT5 : pin 69
VD5, 8←H
VDCNT8 : pin 70
Starts
Communication
with Display microcomputer
E
Source keys operate
↓
Source ON
SYSPW : pin 66 SYSPW←H
AVH-X5500BHS/XNUC
5 6 7 8
37
1 2 3 4
5.2 INSPECTION METHOD OF PICKUP UNIT
A
Disc to be used
CD-DA : TCD-782
DVD-Video : TDV-582(GGV1025)
Exact judgment cannot be performed if the disk to be used has a crack and dirt.
Be careful of handling of a disk enough.
Execution method
Refer to the following page for the details of the check 1 and the check 2.
B
Replace the
START
CRG chassis
Please perform the
PU Lighting?
No usual diagnosis.
RF level check
Check1 Yes
LD current check
C
Check2
Replace the Error rate check
Is it OK?
No CRG chassis
Yes
Is it OK?
No
Yes
RF level check PICK UP Perform lens
D No cleaned? No cleaning
Yes Yes
Replace the
Check2 CRG chassis
Error rate check
Is it OK? PICK UP Perform lens
No cleaned? cleaning
No
Yes Yes
E Replace the
CRG chassis
Ckeck parts
other than PICK UP Finished
AVH-X5500BHS/XNUC
38
1 2 3 4
5 6 7 8
A
Check1 : LD current check
<Check>
Status: [Foucs closed] of TEST MODE
No. Disc Check Point Threshold Remarks: LD current
1 GGV1025 DVDLD1 - VCC5_PU 120 - 780 (mV) 10 - 65 (mA)
DVDLD1 B
C
VCC5_PU
No. Disc Check Point Threshold Remarks: LD current
2 TCD-782 CDLD1 - VCC5_PU 150 - 900 (mV) 10 - 60 (mA)
D
CDLD1
VCC5_PU
Notes: Please pay attention to the laser diode damage by static electricity.
AVH-X5500BHS/XNUC
5 6 7 8
39
1 2 3 4
A
Check : RF level
<Check>
ASMAX value shows the value of RF level.
Status: [Foucs closed] of TEST MODE
No. Disc Check Point Threshold Remarks
1 GGV1025 8 digits value of more than
ASMAX on display 0000 0B00
8 digits value of more than
2 TCD-782 0000 0E00
ASMAX on display
B
Check2 : Error rate check
<Check>
Status: [Tracking Closed] of TEST MODE
D
No. Disc Check Point Threshold Remarks
1 ID:40000 less than
GGV1025
1.000E-3
2 GGV1025 less than
ID:200000
1.000E-3
less than
3 TCD-782 ID:HOME Position 2.500E-3
AVH-X5500BHS/XNUC
40
1 2 3 4
LS2 BACK END section flow
Is VDD5
START (VCC33, VCC12)
power supply voltage OK?
Execute check 2.
Standby
Can the NO OK? NO
5
playback
5
Execute
start? check 1.
YES YES YES
Does the Is the Reset OK?
NO NO Is the image NO Is the iPod play NO USB play NO Is the sound
operation Execute
take time? in error? in error? in error? in error?
check 3.
YES YES YES YES YES YES
Is the
life of flash Is AVCC5 Is the iPod Is 48 MHz Is AVCC5 Is SDRAM Is VSENS
NO NO NO circuit OK? NO NO voltage OK? NO NO
memory OK? voltage OK? OK? IF OK? OK?
Conduct check Execute Execute Execute Execute Execute Execute
item 12. check 8. check 14. check 13. check 8. check 6. check 4.
YES YES YES YES YES YES YES
Go to FE Go to the Is VD8,
Is the video Is DACCLK VCC5 power Is 27 MHz
section check. NO circuit OK? product check. NO NO NO OK?
NO Is the USB normal? supply voltage OK?
Execute circuit OK? Execute Execute Execute
check 11. Execute check 9. check 7. check 5.
6
6
check 14.
5.3 DIAGNOSIS FLOWCHART
YES NO The product YES YES YES
is normal?(iPod YES
attestation IC) Is the audio Go to FE Replace the unit.
NO circuit OK? section check.
Replace the unit.
Execute
YES check 10.
Replace the unit. YES
Product repair
Go to FE
section check.
AVH-X5500BHS/XNUC
Repair the
defective part.
7
7
*1)Note *1) With service, even when exchange of a flash ROM
is required, please replace core unit .
(Since the key etc. are not written in in case of the
flash simple substance)
Normal?
YES Go to FE
section check.
END NO
Is FE section NO Go to FE related
normal? repair process.
YES
Replace the unit.
YES
Normal?
8
8
YES
END
41
E
A
D
C
F
B
1 2 3 4
Check 1: Standby OK?
A
<Check> Check the voltage at the “STANBY” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 STANBY - DGND1 ALL VCC33 - 0.6 V or more V
Side A
B
D
GNDD1
STANBY
Fig 1.1: STANBY check point
AVH-X5500BHS/XNUC
42
1 2 3 4
5 6 7 8
Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK?
A
IC1401 FLASH power supply (Data)
IC1402 FLASH power supply (Program)
VDD5 IC1004 VCC33 (= 3.3V ) IC1480 SDRAM power supply
3.3 V output regulator IC1501 DV5 power supply
IC1953 VCC12 (= 1.2V ) IC1501 DV5 power supply
1.2 V output Regulator
Fig 2.1: Power supply configuration
B
<Check> Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 VDD5_1 - DGND1 ALL 5.0 ± 0.4 V
2 VCC33_1 - DGND1 ALL 3.3 ± 0.033 V
3 VCC12_1 - DGND1 ALL 1.2 ± 0.015 V
Side A C
VCC12
VCC33
VD5-1
DGND1
Fig 2.2: VDD5, VCC33, VCC12 voltage check points
AVH-X5500BHS/XNUC
5 6 7 8
43
1 2 3 4
Check 3: Reset OK?
A
<Check> Check the voltage at the “XRES” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 NRES - DGND1 ALL VCC33 × 0.7 or more V
B
Side A
NRES
DGND1
Fig 3.1: RESET check point
E
AVH-X5500BHS/XNUC
44
1 2 3 4
5 6 7 8
Check 4: Is VSENS OK?
A
CN1952
HOST I/F
IC1501
VD8 R1004 VSENS DV5
R1007
VDD5 IC1004 VCC33
Regulator
B
IC1953 VCC12
1.2 V output
Regulator
STANBY
NRES
Fig 4.1: Power supply configuration and VSENS
C
<Check> Check the voltage at the “VSENS” test point while the power is on.
Use the “DGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 VSENS - DGND1 ALL 0.95 - 1.07 V
VD8 = 8.0 ± 0.4 V
Side A
VSENS
F
DGND1
Fig 4.2: VSENS check point
AVH-X5500BHS/XNUC
5 6 7 8
45
1 2 3 4
Check 5: 27 MHz Normal?
A
<Outline> Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501).
IC1501
DVD-LSI
X1501 OSCO
27 MHz
crystal OSCI
VCC33 VCC12
B
Fig 5.1: Clock configuration
<Check method> Turn the power on, and check with DGND being the reference.
In case of NG, check the applicable line, periphery of IC1501,
soldering of the peripheral components and defective components.
No. Check point Module No. Specification value Unit
2 IC1501 156pin - DGND1 ALL 27 MHz ± 50 ppm ppm
Specification
value
GND
Fig 5.2: Clock specification value
Side A
D
DGND1
F IC1501 156pin
Fig 5.3: 27 MHz check point
AVH-X5500BHS/XNUC
46
1 2 3 4
5 6 7 8
Check 6: Is SDRAM I/F OK?
<Outline> In order to secure the MPEG stream data as the buffer, A
the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit.
Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501,
namely NCSM, NWE, NCAS, NRAS.
IC1480 MA0 - 11 IC1501
MDQ0 - 15 DV5
SDRAM MCK
XWE(NWE)
XCAS(NCAS)
XRAS(NRAS)
XCSM(NCSM)
DQM0 B
DQM1
BA0
BA1
Fig 6.1: SDRAM I/F
<Check> Check the conductivity at “check point 1” and “check point 2” without power.
In case of NG, check the soldering and defective components throughout the
“output t input” of the applicable section.
C
No. Signal name Check point 1 Check point 2 Specification value
1 MA0 IC1480 23pin IC1501 201pin 56 ohm ± 5%
2 MA1 IC1480 24pin IC1501 203pin 56 ohm ± 5%
3 MA2 IC1480 25pin IC1501 207pin 56 ohm ± 5%
4 MA3 IC1480 26pin IC1501 209pin 56 ohm ± 5%
5 MA4 IC1480 29pin IC1501 208pin 56 ohm ± 5%
6 MA5 IC1480 30pin IC1501 206pin 56 ohm ± 5%
7 MA6 IC1480 31pin IC1501 202pin 56 ohm ± 5%
8 MA7 IC1480 32pin IC1501 200pin 56 ohm ± 5%
9 MA8 IC1480 33pin IC1501 198pin 56 ohm ± 5%
10 MA9 IC1480 34pin IC1501 194pin 56 ohm ± 5%
11 MA10 IC1480 22pin IC1501 199pin 56 ohm ± 5% D
12 MA11 IC1480 35pin IC1501 192pin 56 ohm ± 5%
13 MDQ0 IC1480 2pin IC1501 160pin 56 ohm ± 5%
14 MDQ1 IC1480 4pin IC1501 162pin 56 ohm ± 5%
15 MDQ2 IC1480 5pin IC1501 164pin 56 ohm ± 5%
16 MDQ3 IC1480 7pin IC1501 168pin 56 ohm ± 5%
17 MDQ4 IC1480 8pin IC1501 170pin 56 ohm ± 5%
18 MDQ5 IC1480 10pin IC1501 172pin 56 ohm ± 5%
19 MDQ6 IC1480 11pin IC1501 176pin 56 ohm ± 5%
20 MDQ7 IC1480 13pin IC1501 178pin 56 ohm ± 5%
21 MDQ8 IC1480 42pin IC1501 177pin 56 ohm ± 5%
22 MDQ9 IC1480 44pin IC1501 175pin 56 ohm ± 5%
23 MDQ10 IC1480 45pin IC1501 171pin 56 ohm ± 5% E
24 MDQ11 IC1480 47pin IC1501 169pin 56 ohm ± 5%
25 MDQ12 IC1480 48pin IC1501 167pin 56 ohm ± 5%
26 MDQ13 IC1480 50pin IC1501 163pin 56 ohm ± 5%
27 MDQ14 IC1480 51pin IC1501 161pin 56 ohm ± 5%
28 MDQ15 IC1480 53pin IC1501 159pin 56 ohm ± 5%
29 MCK IC1480 38pin IC1501 183pin 47 ohm ± 5%
30 XWE IC1480 16pin IC1501 181pin 56 ohm ± 5%
31 XCAS IC1480 17pin IC1501 188pin 56 ohm ± 5%
32 XRAS IC1480 18pin IC1501 189pin 56 ohm ± 5%
33 XCSM IC1480 19pin IC1501 190pin 56 ohm ± 5%
34 DQM0 IC1480 15pin IC1501 179pin 56 ohm ± 5%
35 DQM1 IC1480 39pin IC1501 180pin 56 ohm ± 5% F
36 BA0 IC1480 20pin IC1501 193pin 56 ohm ± 5%
37 BA1 IC1480 21pin IC1501 197pin 56 ohm ± 5%
AVH-X5500BHS/XNUC
5 6 7 8
47
1 2 3 4
Side A
A
Check point 1 (IC1480)
C
Check point 2 (IC1501)
Fig 6.2: SDRAM I/F check point
AVH-X5500BHS/XNUC
48
1 2 3 4
5 6 7 8
Check 7: Is VD8, VCC5 power supply voltage OK?
A
VD8_1 F.E. driver
system
VD8_2 VCC5 (= 5.0 V ) Power supply
REG IC
for PU
for VCC 5 V.
Fig 7.1: Power supply configuration
B
<Check> Check the voltage at the “VD8_P, VD8_A and VCC5_1” test point while the power is on.
Use the “PGND1 and AGND1” test point at the reference.
No. Check point Module No. Specification value Unit
1 VD8_P - PGND1 ALL 8.0 ± 0.4 V
2 VD8_A - AGND1 ALL 8.0 ± 0.4 V
3 VCC5_1 - AGND1 ALL 5.0 ± 0.05 V C
Side A
AGND1
VCC5_1
PGND1
VD8_A VD8_P
Fig 7.2: VD8, VCC5 voltage check points
AVH-X5500BHS/XNUC
5 6 7 8
49
1 2 3 4
Check 8: Is AVCC5 voltage OK?
A
IC1003 IC1801
VD8 AVCC5 (= 5.0 V )
REG IC
Audio-DAC
for AVCC 5 V.
Fig 8.1: Power supply configuration
<Check> Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus.
B
Check with PGND_3 and GNDAU1 being the reference.
No. Check point Module No. Specification value Unit
1 VD8_A - PGND_3 ALL 8.0 ± 0.4 V
2 AVCC5 - GNDAU1 ALL 5.0 ± 0.05 V
Side A
D PGND3
GNDAU1
AVCC5
VD8_A
E
Fig 8.2: VD8, AVCC5 voltage check points
AVH-X5500BHS/XNUC
50
1 2 3 4
5 6 7 8
Check 9: Is DACCLK normal?
<Outline> DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501). A
IC1501
X1501 DVD-LSI IC1801
DACCLK
27MHz Audio-DAC
crystal
VCC33 VCC12
Fig 9.1: Clock configuration
<Check method>
DVD: DVD-REF-A1 TITLE 1
CD: Playback a normal CDDA.
B
Common to all DVD-V compatible modules.
Check with DGND being the reference.
In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and
defective components.
No. Check point 1 (stylus) Media Specification value 1 Specification value 2 Specification value 3
1 DACCK DVD 2.0 V - VCC33V DGND - 0.8 V 36.8640 MHz ± 300 ppm
2 DACCK CD 2.0 V - VCC33V DGND - 0.8 V 33.8688 MHz ± 300 ppm
Specification
value 1
Specification C
value 2 Specification
value 3
GND
Fig 9.2: Clock specification value
Side A
DGND4 F
Check point 2 (IC1501 148 pin)
Fig 9.3: DACCLK check point
AVH-X5500BHS/XNUC
5 6 7 8
51
1 2 3 4
Check 10: Is the audio circuit OK?
A <Outline> The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio
signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1952).
Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F.
The digital audio signal (IECOUT), output from DVD-LSI (IC1501).
CN1952
HOST I/F
IC1501 IECOUT
DVD-LSI LRCK LO
ADOUT IC1801
SRCK Audio-DAC RO
B GNDAU
Fig 10.1: Audio circuit
<Check method> Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB),
and check with DGND1 being the reference.
In case of NG, check the applicable line, periphery of major components as described in the above drawing,
soldering of the peripheral components and defective components.
No. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform
1 ADOUT VCC33V - 0.6 V or higher 0.4 V or lower Waveform 1
2 SRCK VCC33V - 0.6 V or higher 0.4 V or lower Waveform 2
C 3 LRCK VCC33V - 0.6 V or higher 0.4 V or lower Waveform 3
Specification
Specification value 2
value 1
GND
Fig 10.2: Serial 3 lines specification value
Side A
D
DGND1
151pin ADOUT signal
F 150pin LRCK signal
149pin SRCK signal
Fig 10.3: Serial 3 lines check points
AVH-X5500BHS/XNUC
52
1 2 3 4
5 6 7 8
The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference.
47 kohm 47 kohm
LO GNDAU1 RO
No. Check point 1 (stylus) Specification value (rms) Reference waveform
4 LO 1400 ± 150 mV Waveform 4 B
5 RO 1400 ± 150 mV Waveform 4
Specification value is the root-mean-square value (rms).
Fig 10.4: Analog audio out (LO, RO) specification value.
C
Side A
GNDAU3 RO LO
Fig 10.5: Analog audio out check point
AVH-X5500BHS/XNUC
5 6 7 8
53
1 2 3 4
Check with DGND1 being the reference.
A
No. Check point 1 (stylus) Specification value 1 Specification value 2 Reference waveform
6 IEC VCC33V - 0.6 V or higher 0.4 V or lower Waveform 5
Specification
value 2
Specification
value 1
10.6: Digital audio signal (IECOUT) specification value
Side A
IEC DGND1
Fig 10.7: Digital audio signal (IECOUT) check point
AVH-X5500BHS/XNUC
54
1 2 3 4
5 6 7 8
Check 11: Is the video circuit OK?
A
<Outline> Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the
HOST I/F (CN1952) via a buffer circuit.
CN1952
HOST I/F
IC1501
DVD_LSI
Video Composite COMPOSITE
DAC
section
Fig 11.1: Video circuit B
<Checking method> Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with
an oscilloscope with GNDV (stylus) being the reference. Set the trigger mode to “TV trigger” and
the trigger line to “150 line”.
No. Check point 1 (stylus) Specification value Reference waveform
1 COMPOSITE 1000 mVpp ± 5% Waveform 6
In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the
peripheral components and defective components.
PEAK C
COMPOSITE signal Reference
value
Color burst
Pedestal level
BOTTOM
Horizontal sync signal
Fig 11.2: Waveform for the case of composite white 100% output
Side A
D
F
GNDV2 COMPOSITE
Fig 11.3: VIDEO signal check point
AVH-X5500BHS/XNUC
5 6 7 8
55
1 2 3 4
Check 12:How to judge whether the flash memory has reached its life or not.
A
If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory
has reached its life.
Make judgment regarding the flash memory life by looking at the display of the LD power on time mode.
1. Let the LD energizing time displayed.
(Refer to the LD power on time mode for the method of displaying the LD energizing time.)
2. If the second digit from the left of the energizing time display is showing E,
such as “ E ”, it means that the flash memory has reached its life.
Example:
B
0E000BB8
AVH-X5500BHS/XNUC
56
1 2 3 4
5 6 7 8
Check 13: 48 MHz Normal?
<Outline> CLOCK of a USB circuit is made using the 48 MHz master crystal oscillator (X1950). A
IC1501
DVD-LSI
X1950
48MHz
crystal USB_CLOCK
VCC33 VCC12
Fig 13.1: Clock configuration
<Check method> Turn the power on, and check with DGND1 being the reference.
In case of NG, check the applicable line, periphery of IC1501,
soldering of the peripheral components and defective components.
No. Check point Module No. Specification value Unit
2 IC1501 50pin - DGND1 ALL 48 MHz ± 200 ppm ppm
Specification
value
GND
Fig 13.2: Clock specification value
Side A D
48 MHz
DGND1
F
Fig 13.3: 48 MHz check point
AVH-X5500BHS/XNUC
5 6 7 8
57
1 2 3 4
Check 14: Is USB Circuit OK?
A <Outline>
The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD.
USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK) in addition to D+ and D-.
CN1952
HOST I/F
IC1501 CP_RESET
DVD-LSI I2C_SDA
I2C_SCL
D+
D-
B
DGND
Fig. 14-1: USB Circuit
<Check Method>
1. USB Memory: Play a song from USB memory and check D+ and D- with the DGND1 standards.
2. iPod: Connect iPod and check CP_RESET, SDATA and SCLOCK with the DGND1 standards until the Pioneer log
appears. When iPod Touch or iPhone is connected, the logo is not displayed but only a check mark is displayed.
Play a song from iPod and check D+/D- with the DGND1 standards.
When it does not conform to the standards, check appropriate line, main parts shown in the above figure,soldering of
peripheral parts and malfunctions in parts.
C No. Checking spot (stylus) Standard value 1 Standard value 2
1 CP_RESET VCC33*0.7 or more
2 SDATA VCC33*0.7 or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod
3 SCLOCK VCC33*0.7 or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod
4 D+ VCC33*0.7 or more VCC33*0.3 or less
5 D- VCC33*0.7 or more VCC33*0.3 or less
Standard
Standard value 2
value 1
D Fig.14.2: USB Circuit Communication Wave
Side A
SDATA
CP_RESET
D- D+ SCLOCK DGND1
AVH-X5500BHS/XNUC
58
1 2 3 4
5 6 7 8
AUDIO
CH1 : LO A
CH1 : ADOUT3 CH2 : RO
Reference voltage:DGND2 1 V/div. 5 μsec/div Reference voltage:GNDAU2 2 V/div. 500 μsec/div
Gt
Gt
Gt
B
Waveform 1 Waveform 4
CH1 : SRCK CH1 : IECOUT
Reference voltage:DGND2 1 V/div. 1 μsec/div Reference voltage:DGND2 1 V/div. 500 nsec/div
Gt
Gt C
Waveform 2 Waveform 5
CH1 : LRCK
Reference voltage:DGND2 1 V/div. 5 μsec/div
Gt
Waveform 3
VIDEO
[WHITE 100IRE] E
CH1 : COMPO
Reference voltage:GNDV1 200 mV/div. 10 μsec/div
GNDV
F
Waveform 6
AVH-X5500BHS/XNUC
5 6 7 8
59
1 2 3 4
USB, IPOD
USB memory USB memory
A D+/D- communication waveform D+/D- communication waveform
It checks with an oscilloscope. It checks with an oscilloscope.
Reference voltage : DGND 1 ms/div 2 V/div Reference voltage : DGND 200 ns/div 2 V/div
D- D-
DGND DGND
DGND
DGND
D+ D+
B
Waveform 7 Waveform 8
IPOD IPOD
D+/D- communication waveform D+/D- communication waveform
It checks with an oscilloscope. It checks with an oscilloscope.
Reference voltage : DGND 1 ms/div 2 V/div Reference voltage : DGND 200 ns/div 2 V/div
D- D-
DGND DGND
C DGND DGND
D+ D+
Waveform 9 Waveform 10
IPOD
CP_RESET signal IPOD
A relation with NRES, At the time of RESET release SDA signal
(It checks with an oscilloscope. ) It checks by LECORY.
Reference voltage : DGND 20 ms/div 1 V/div Reference voltage : DGND 2 ms/div 1 V/div
CP_RESET
DGND SDA
NRES
DGND
DGND
Waveform 11 Waveform 12
IPOD
E
SCL signal
It checks by LECORY.
Reference voltage : DGND 500 μs/div 1 V/div
SCL
DGND
Waveform 13
AVH-X5500BHS/XNUC
60
1 2 3 4
5 6 7 8
5.4 ERROR CODE LIST
Generation source Method of reset
UART
Error status OSD *1 Meaning USB USB ACC Source Eject/
*2 Disc Play Key
(MSC) (iPod) Off/On Off/On With no device
Media Error UNPLAYABLE DISC 00h A disc containing the unplayable format only X - - X X X - A
INCOMPATIBLE DEVICE 00h USB device that doesn't correspond - X X X X X -
UNPLAYABLE FILE 00h USB device of format alone that cannot be reproduced - X - X X X -
Open (No display) 10h Door open error X - - * * * *
Read Error ERROR-02-99 20h Transfer start error X - - X X X X
Focus Error(Focus Error in
ERROR-02-90 21h Focus error X - - X X X X
mechanism set up)
Focus error during set up
Surface Error ERROR-02-9E 22h (A focus has never been achieved with that disc.) X - - - - X -
Address not found
(Invalid Track) ERROR-02-80 23h Address not found. X - - X X X X
Spindle Lock ERROR-02-91 24h Spindle lock NG(the disc cannot rotate) X - - X X X X
Carriage home NG
Carriage HOME ERROR-02-92 25h (The pick up tries to return to carriage home, X - - X X X X
but it cannot go back and stopped.)
ID/SUBCODE Read Error ID/SUBCODE Read Error (ID/SUBCODE cannot
ERROR-02-94 26h be read due to scratch or stain.) X - - X X X X
AV CHIP decode Error ERROR-02-9A 2Ah AV CHIP decode NG(AV chip cannot be decoded.) X X X X X X X B
AV CHIP Recovery NG ERROR-02-9B 2Bh AV CHIP recovery NG X X - X X X X
Error of PLAY BACK Playback state error
ERROR-02-9C 2Ch (An error due to software bug.) X X - X X X X
Mode Status
Disc Data Error ERROR-02-9D 2Dh Disc Data NG X - - X X X X
Temp Error(In Case of High temperature(Playback is stopped because the pick
THERMAL PROTECTION IN MOTION 30h up temperature is 89 C or higher.) X - - X - - -
High Temperature)
No Disc
(including Disc loading (No display) Disc has not been inserted.
40h (Including Load in process or Eject in process.) X - - * * * *
and ejecting)
(No display) Loading mechanism error
Loading_Mecha Error 50h (The disc cannot be clamped.) X X *11 X *11 X - X *12 -
Communication fault attesting iPod ERROR-02-60 60h Communication fault attesting iPod X *13 - X X - X *14 -
iPod authentication data is abnormal ERROR-02-61 61h iPod authentication data is abnormal X *13 - X X - X *14 -
iPod attestation retrying failure ERROR-02-62 62h iPod attestation retrying failure X *13 - X X - X *14 -
iPod attestation time out ERROR-02-63 63h iPod attestation time out X *13 - X X - X *14 -
Error when iPod is connected/ Error when iPod is connected/
It is generated STALL by the USB ERROR-02-64 64h It is generated STALL by the USB communication - - X X - X -
communication
Error setting iPod ERROR-02-65 65h Error setting iPod - - X X - X -
Demand timeout when Demand timeout when
initial is communicated ERROR-02-66 66h initial is communicated - - X X - X -
C
Protocol version Protocol version non-correspondence
non-correspondence ERROR-02-67 67h (It is necessary to Version Up the iPod by iTunes.) - - X X - X -
Timeout when protocol Timeout when protocol
version is judged ERROR-02-68 68h version is judged - - X X - X -
iPod does not have music.
No songs error (No display) 69h (It is necessary to put music into iPod by iTunes) - - X X - X -
iPod control forwarding/
Intarapta forwarding error ERROR-02-6A 6Ah iPod control forwarding / Intarapta forwarding error - - X X - X -
Demand timeout Demand timeout iPod's reproducing
iPod's reproducing ERROR-02-6B 6Bh - - X X - X -
Remote switch error ERROR-02-6C 6Ch Remote switch error - - X X - X -
Remote switch demand Remote switch demand timeout
timeout ERROR-02-6D 6Dh - - X X - X -
Demand timeout to an Demand timeout to an iPodApl(Pandora)
iPodApl(Pandora) ERROR-02-6E 6Eh - - X X - X -
DRM Error DRM error (All music cannot be played back due
PROTECTED DISC 70h to DRM.) X - - X X X -
NO ACCESSIBLE DATA AVAILABLE 70h DRM error (All music cannot be played back due
to DRM.) - X - X X X -
Region code NG (Unable to be played back due
Region code Error DIFFERENT REGION DISC 90h X - - X X X -
to incorrect mechanism region.)
D
CPRM*7 Key Error *8 UNPLAYABLE DISC 93h Key Error for playback X - - X - X -
REQUEST Error ERROR-02-A0 A0h REQUEST_error X - - X X X X
Failure in issuing read
command (chip dependent) ERROR-02-A1 A1h Failure in issuing the read command X - - X X X X
Adjustment of L0 is NG. ERROR-02-A2 A2h L0 adjustment is NG. X - - X X X X
Adjustment of L1 is NG. ERROR-02-A3 A3h L1 adjustment is NG. X - - X X X X
LD system NG ERROR-02-A4 A4h LD system NG X - - X X X X
Gain adjustment system NG. ERROR-02-A5 A5h Gain adjustment system NG. X - - X X X X
Gain determining system NG. ERROR-02-A6 A6h Gain determining system NG. X - - X X X X
Servo initial setting related items NG. ERROR-02-A7 A7h Servo initial setting related items NG. X - - X X X X
Disc is not clamped yet. ERROR-02-A8 A8h Disc is not clamped yet. X - - X X X X
Tracking system NG. ERROR-02-A9 A9h Tracking system NG X - - X X X X
Media setting system NG. ERROR-02-AA AAh Media setting system NG X - - X X X X
Focus Error ERROR-02-AB ABh JUMP over layers NG X - - X X X X
Error of PLAY BACK
ERROR-02-B0 B0h Navigation command error X - - X X X X
Mode Status
Error of PLAY BACK
ERROR-02-B1 B1h Retry over X - - X X X X
Mode Status
DivX DRM Inofrmation ERROR-02-C1 C1h DivX DRM inofrmation update error X - - X - - - E
Update Error *10
Error when MCS is connected/ Error when MCS is connected / It is generated
It is generated STALL by the USB ERROR-02-D0 D0h - X - - - X -
communication STALL by the USB communication
CBW and CSW forwarding error ERROR-02-D1 D1h CBW and CSW forwarding error - X - - - X -
Audio class band securing failure ERROR-02-D8 D8h Audio class band securing failure - - X X - X -
Audio class FS setting failure ERROR-02-D9 D9h Audio class FS setting failure - - X X - X -
Undefined Error ERROR-FF-FF FFh Undefined error X - - X X X X
X : Cancel the error by operation. - : Error is not cancelled by operation. * : No setting
*1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower
row is for the Touch Panel model and Full GUI (English version).
*2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits.
*7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card.
*8 DVD-VR model only.
*10 This occurs when the DRM information update notice is sent from the DVD mecha but no DRM information update response is returned.
*11 Although it is USB source, it notifies as an error of DISC source.
*12 Although it is USB source, iIt cancels only by Disc eject. F
*13 Although it is DISC source, it notifies as an error of USB source.
*14 Although it is DISC source, It cancels only without Device.
AVH-X5500BHS/XNUC
5 6 7 8
61
1 2 3 4
A External storage device (USB)
Message Cause Action Message Cause Action Message Cause Action
Unplayable This type of file Select a file that Format Read Sometimes Wait until the Check USB The USB con- Check that the
File cannot be can be played. there is a delay message disap- nector or USB USB connector or
played on this between the pears and you cable has short- USB cable is not
unit. start of playback hear sound. circuited. caught in some-
There are no Transfer the audio and when you thing or dam-
songs. files to the USB start to hear any aged.
portable audio sound. The connected Disconnect the
player/USB mem- Skipped The connected Play an audio file USB storage de- USB portable
ory and connect. USB portable not embedded vice consumes audio player/USB
Security for the Follow the USB audio player/ with Windows more than maxi- memory and do
connected USB memory instruc- USB memory Media™ DRM 9/ mum allowable not use it. Turn
memory is en- tions to disable contains WMA 10. current. the ignition
abled. security. files that are switch to OFF,
protected by then to ACC or
B Windows Me- ON and then con-
dia™ DRM 9/10. nect a compliant
Protect All the files on Transfer audio USB portable
the connected files not protected audio player/USB
USB portable by Windows memory.
audio player/ Media DRM 9/10 Error-02-9X/- Communication Perform one of
USB memory to the USB port- DX failed. the following op-
are protected by able audio player/ erations.
Windows Media USB memory and –Turn the ignition
DRM 9/10. connect. switch OFF and
Incompatible The USB device Connect a USB back ON.
USB connected to is portable audio –Disconnect the
not supported player or USB USB portable
by this unit. memory that is audio player/USB
USB Mass Stor- memory.
age Class compli- –Change to a dif-
ant. ferent source.
C Then, return to
The USB device The connected the USB portable
is not formatted USB device audio player/USB
with FAT12, should be format- memory.
FAT16 or FAT32. ted with FAT12,
FAT16 or FAT32. This DivX The inserted ex- Select a file that
rental has ternal storage can be played.
expired. device contains
expired DivX
VOD content.
iPod iTunes tagging
D Message Cause Action
Message Cause Action Message Cause Action
Video resolu- The inserted ex- Select a file that
tion not sup- ternal storage can be played. Format Read Sometimes Wait until the iPod full. Memory used Sync the iPod
ported device contains there is a delay message disap- Tags not for tag informa- with iTunes and
a high definition between the pears and you transferred. tion on the iPod clean up the
DivX/MPEG-1/ start of playback hear sound. is full. tagged playlist.
MPEG-2/ and when you Memory full. This unit’s flash The tag informa-
MPEG-4 file. start to hear any Tags not memory used tion on this unit is
It is not pos- This unit’s flash Select a file that sound. stored. Con- as the tempo- transferred to the
sible to write memory used can be played. Error-02-6X/- Communication Disconnect the nect iPod. rary storage iPod automati-
it in the as the tempo- 9X/-DX failed. cable from the area is full. cally when an
flash. rary storage iPod. Once the iPod is con-
area is full. iPod’s main nected.
Your device This unit’s DivX Register this unit menu is dis- Tag transfer This unit’s tag Check the iPod
is not au- registration to the DivX VOD played, reconnect failed. Re- information and try again.
thorized to code has not contents provider. the iPod and reset connect your cannot transfer
E play this been authorized it. iPod. to the iPod.
DivX pro- by the DivX iPod failure. Disconnect the Tag store Tag information Try again.
tected video. VOD contents cable from the failed. cannot be
provider. iPod. Once the stored in this
Format Read Sometimes Wait until the iPod’s main unit.
there is a delay message disap- menu is dis-
played, reconnect Error-8D Built-in FLASH Turn the ignition
between the pears and you ROM encoun- OFF or ON.
start of playback hear sound. the iPod and reset
it. tered an error
and when you
start to hear any Error-02-67 The iPod firm- Update the iPod Already This tag infor- Tag information
sound. ware version is version. stored mation is al- can only be saved
old. ready stored in once for any
Video frame DivX file’s frame Select a file that memory. given song. Tag
rate not sup- rate is more can be played. Stop There are no Transfer songs to information can-
ported than 30 fps. songs. the iPod. not be saved for
Audio For- This type of file Select a file that There are no Select a list that the same song
mat not sup- is not supported can be played. songs in the contains songs. more than once.
F ported on this unit. current list.
Not Found No related Transfer songs to
songs. the iPod.
AVH-X5500BHS/XNUC
62
1 2 3 4
5 6 7 8
Bluetooth A
Message Cause Action Message Cause Action Message Cause Action
Error-10 The power failed Turn the ignition Pandora sys- Pandora system Try again later. Communica- If there is no Please reconnect
for the switch OFF and tem mainte- is undergoing tion error oc- ACK after 10 at- your iPhone and
Bluetooth mod- then to ACC or nance. Try maintenance. cured. Please tempted retries try again.
ule of this unit. ON. again later. reconnect at 750 ms, the
If the error mes- Skip limit Skip limit Do not exceed the your device. accessory
sage is still dis- reached. reached. skip limit. should assume
played after that communi-
performing the This version This version of Connect an cation is inter-
above action, of the the Pandora ap- iPhone that has a rupted and
please contact Pandora Ap- plication is not compatible ver- disconnect
your dealer or an plication is supported. sion of the from
authorized not sup- Pandora applica- PandoraLink.
Pioneer Service ported. tion installed.
Device has No Bluetooth Follow the in-
Station. Check Device Device error Please check your not been device found. structions that ap-
message dis- iPhone. registered. pear on the B
played in the Go to screen.
Pandora ® Pandora appli- Bluetooth
cation. Connection
Message Cause Action
Pandora is Unable to play Please check your Menu to
Error-19 Communication Disconnect the
unable to music from iPhone. register.
failed. cable from the
play music. Pandora. BT error. Bluetooth con- Follow the in-
iPod. Once the
Please see Press BAND nection failed. structions that ap-
iPod’s main
your Device. key to retry. pear on the
menu is dis-
played, reconnect Create sta- No station Create a station screen.
the iPod and reset tion within found. in the Pandora Start up Connection to Follow the in-
it. the Pandora application on Pandora. the Pandora ap- structions that ap-
Application your iPhone. Press BAND plication failed. pear on the
Start up the The Pandora ap- Start up the
on Device. key to retry. screen.
Pandora Ap- plication has Pandora applica-
plication not started run- tion from your No Active No station se- Select a station. Check Connection to Follow the in-
from your ning yet. iPhone. Station lected. Pandora. the Pandora ap- structions that ap-
Device. Press BAND plication failed. pear on the C
Unable to Unable to save Try again later. key to retry. screen.
save thumb thumb rating. Disconnect- Bluetooth con- Follow the in-
rating. Try ed.Press nection lost. structions that ap-
again later. BAND key to pear on the
Unable to Unable to save Try again later. retry. screen.
save Book- Bookmark.
mark. Try
again later.
SiriusXM Satellite Radio Understanding auto EQ error
Message Cause Action messages
Check An- The antenna Check the antenna When correct measurement of the car’s interior Message Cause Action
tenna connection is connection. acoustic characteristics is not possible using
incorrect. auto EQ, an error message may appear on the
display. In such cases, refer to the table below to Error. Please Power is not Connect the
Check Tuner The SiriusXM Check the tuner
Connect Vehicle connection. see what the problem is and how it may be cor- check bat- being supplied battery correctly. D
rected. After checking, try again. tery. from the battery Check the bat-
Tuner connec-
tion is incorrect. to this unit. tery voltage.
No Signal The SiriusXM Verify that your Message Cause Action
Connect Vehicle vehicle is outdoors
Please con- The microphone Plug the optional
Understanding messages
Tuner is having with a clear
difficulty receiving view of the southern nect the mi- is not con- microphone se-
the sky. crophone for nected. curely into the Messages Translation
SiriusXM satellite Verify that the measure- jack. Pioneer recommends
signal. SiriusXM magnetic ment. When
mount antenna the use of a camera
finished, which outputs mirror-
is mounted Screen image may
please push reversed images. Oth-
on a metal surface
HOME key. appear reversed.
on the outside erwise, the screen
the vehicle. Error. Please The microphone Confirm that image will appear re-
Move the versed.
check xxxx cannot pick up the speakers are
SiriusXM antenna
away from any ob- speaker. the measuring connected cor-
structions. tone of a speak- rectly. E
er. Correct the
Subscription This unit has de- Press any keys to input level setting
Updated tected a change clear the message. of the power amp
in your
connected to the
SiriusXM sub-
scription status. speakers.
Plug the micro-
Not Avail- The channel Check the phone securely
able that you have SiriusXM channel into the jack.
requested is not lineup.
Error. Please The surround- Stop your car in
a valid SiriusXM
channel. check noise. ing noise level a place that is
is too high. quiet, and switch
Not Sub- The channel Check the content off the engine, air
scribed that you have of your conditioner and
requested is not SiriusXM sub-
heater.
included in your scription pack-
Set the micro-
SiriusXM sub- age.
scription pack- phone correctly.
age. F
Channel Locked by the Release the channel
Locked radio Parental lock.
Control feature.
AVH-X5500BHS/XNUC
5 6 7 8
63
1 2 3 4
5.5 CONNECTOR FUNCTION DESCRIPTION
A ANTENNA INPUT AUDIO INPUT USB IF
REARVIEW FRONT AUX INPUT BT MIC REAR VIDEO WIRED
CAMERA INPUT REAR MONITOR INPUT REMOTE
SUBWOOFER VIDEO CONTROL
PRE-OUT OUTPUT SXI-BUS INPUT
(AVH-X5500BHS/XNUC)
D POWER SUPPLY NAVI INTERFACE
2 26
16 14 12 10 8 6 4 2
15 13 11 9 7 5 3 1 1 25
1 : CCR 10 : CCAUL 19 : GNDD (DSEN)
1. FR- 9. P. BRAKE 2 : CCG 11 : CCAUR 20 : TVON
2. RR- 10. MUTE 3 : CCB 12 : GNDAU 21 : GUIDE ON
3. FR+ 11. B.REM 4 : CSYNC 13 : ONSEI+ 22 : MONON
4. RR+ 12. ILM 5 : GNDSIG 14 : ONSEI- 23 : NC (VSW5)
5. FL- 13. BGSENS 6 : NC (DVDVBS) 15 : NC (REAUR) 24 : SYS_TO_NAVI
E 7 : NC (GNDDVD) 16 : NC (REAUL) 25 : NAVI_TO SYS
6. RL- 14. ACC
7. FL+ 15. GND 8 : NC (YS) 17 : NC (GNDRAU) 26 : GNDD
8. RL+ 16. B.UP 9 : ASENBO 18 : NC (CCREM)
SXI-BUS INPUT
1 SXiL 6 SXiRX
2 SXiTX 7 NC
F 3 NC 8 GND
4 SXiR 9 SXi PW
5 SXiG 10 SXiPW
AVH-X5500BHS/XNUC
64
1 2 3 4
5 6 7 8
6. SERVICE MODE
6.1 MONITOR TEST MODE
MONITOR TEST MODE MENU SCREEN A
Method for Mode IN
While pressing [Mute] + [Reverse] key, restart the system.
Display specification
Operational description Remote controller key
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
AVH-X5500BHS/XNUC
5 6 7 8
65
1 2 3 4
1. Version Information
Method for Mode IN
A
While pressing [Mute] + [Reverse] key, restart the system.
Choose “1. Version Information” among the Monitor Test Menu screen.
Display specification
Page: 1
<Navi>
When Navi is connected : Connect
When Navi is not connected : -
<EEPRM>
C
When set value initialization is performed normally : Init OK
When set value initialization is not performed normally : -
<Eject Lock>
When Eject Lock is on : ON
When Eject Lock is canceled : OFF
Operational description Remote controller key
Return to test mode menu RETURN
Page up NEXT
Page down PREV
Page: 2 Page: 3
D
Page: 4 Page: 5
AVH-X5500BHS/XNUC
66
1 2 3 4
5 6 7 8
2. Touch Panel Test
Method for Mode IN A
While pressing [Mute] + [Reverse] key, restart the system.
Choose “2. Touch Panel Test” among the Monitor Test Menu screen.
Display specification
Top menu
Condition that the mark meaning adjustment is completed, (*) is lit
(the mark is lit when any of one condition is satisfied)
Outermost circle check -1 C
When “Outermost circle check of line calibration-1” is finished normally
When “Outermost circle check of line calibration-2” is finished normally
-> Since “Outermost circle check of line calibration-2” includes “Outermost circle check of line calibration-1.”
Outermost circle check -2
When “Outermost circle check of line calibration-2” is finished normally
Calibration check
When “Calibration check of line calibration” is finished normally
Condition that the mark meaning adjustment is completed, (*) is extinguished
(the mark is extinguished when any of one condition is satisfied)
Outermost circle check -1
When “conditions that the mark is lit” are not satisfied D
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Outermost circle check -2
When “conditions that the mark is lit” are not satisfied
When “Outermost circle check of line calibration-1” is finished abnormally
-> Since “Outermost circle check of line calibration-2” includes “Outermost circle check of line calibration-1.”
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Calibration check
When “conditions that the mark is lit” are not satisfied
When “Data Initialize is executed”
E
When “EEPROM initialize is executed”
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
AVH-X5500BHS/XNUC
5 6 7 8
67
1 2 3 4
1. Effective Area Calibration - 1
A Outermost circle check screen
First point Second point
Operational description Remote controller key
Check is interrupted Band
Outermost circle check result screen
Finished normally Finished abnormally
Operational description Remote controller key
D Check is finished Band
2. Effective Area Calibration - 2
Outermost circle check screen
First point Second point
AVH-X5500BHS/XNUC
68
1 2 3 4
5 6 7 8
3rd point 4th point
Operational description Remote controller key B
Check is interrupted Band
Outermost circle check result screen
Finished normally Finished abnormally
Operational description Remote controller key
Check is finished Band
3. 16 Point Calibration D
Calibration check screen
Touch the cursor [+] displayed on the screen. By touching it correctly, it disappears and another cursor appears.
By repeating this action 16 times, obtain calibration value of each [+].
When touching the last 17th cursor, calibration values at 16 points and information of normal finish in 17 bytes
are written in EEPROM and the screen returns to TOP menu by pressing a key.
AVH-X5500BHS/XNUC
5 6 7 8
69
1 2 3 4
Operational description Remote controller key
B Return to top menu Band
Calibration check result screen
Operational description Remote controller key
Return to top menu Band
4. Touch Panel Coordinates Test
D
[+] is displayed at a touched place.
(Two [+] are displayed by touching two places.)
Operational description Remote controller key
Return to top menu RETURN
AVH-X5500BHS/XNUC
70
1 2 3 4
5 6 7 8
5. Calibration Test
Calibration confirmation screen A
Touch the cursor [+] displayed on the screen. By touching it correctly, it disappears and another cursor appears.
Otherwise, the cursor is displayed in red.
Repeating this action for 4 points and by pressing the last 4th point, “O.K.” is displayed.
Operational description Remote controller key
Return to top menu RETURN
Calibration confirmation result screen
D
Operational description Remote controller key
Return to top menu RETURN
AVH-X5500BHS/XNUC
5 6 7 8
71
1 2 3 4
6. Data Initialize
B
Condition that the mark meaning adjustment is completed, (*) is lit
(the mark is lit when any of one condition is satisfied)
Outermost circle check
When “Outermost circle check of line calibration-1” is finished normally
When “Outermost circle check of line calibration-2” is finished normally
Calibration check
When “Calibration check of line calibration” is finished normally
Outermost circle check of user calibration
When “Outermost circle check of user calibration” is finished normally
User calibration check
When “Calibration check of user calibration” is finished normally
C
Condition that the mark meaning adjustment is completed, (*) is extinguished
(the mark is extinguished when any of one condition is satisfied)
Outermost circle check
When “conditions that the mark is lit” are not satisfied
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Calibration check
When “conditions that the mark is lit” are not satisfied
When “Data Initialize is executed”
When “EEPROM initialize is executed”
Outermost circle check of user calibration
D When “conditions that the mark is lit” are not satisfied
When “Data initialize is executed”
When “EEPROM initialize is executed”
When Outermost circle check of line calibration or 16-point adjustment is finished
normally after Outermost circle check of user calibration is finished normally
User calibration check
When “conditions that the mark is lit” are not satisfied
When “Data initialize is executed”
When “EEPROM initialize is executed”
When Outermost circle check of line calibration or 16-point adjustment is finished
normally after 16-point adjustment of user calibration is finished normally
E
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
AVH-X5500BHS/XNUC
72
1 2 3 4
5 6 7 8
3. EEPROM Adjustment
Method for Mode IN A
Choose “3. EEPROM Adjustment” among the Monitor Test Menu screen.
Display specification
Top menu
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
C
1. Flicker Adjustment
1 dot stripe image of black and gray (50% white) will appear.
Adjust the number to minimize the flicker.
< Flicker Adjustment >
Flicker adjustment image (lattice)
D
COM DC
Operational description Remote controller key
Return to top menu RETURN
-1 REV
+1 FF
Following items in EEPROM Adjustment menu are not used on service.
AVH-X5500BHS/XNUC
5 6 7 8
73
1 2 3 4
4. EEPROM Initialize
Method for Mode IN
A
Choose “4. EEPROM Initialize” among the Monitor Test Menu screen.
Display specification
Confirmation screen
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor left movement REV
Selection cursor right movement FF
Menu enter Band
C
AVH-X5500BHS/XNUC
74
1 2 3 4
5 6 7 8
5. Display Test
Method for Mode IN A
Choose “5. Display Test” among the Monitor Test Menu screen.
Display specification
Top menu
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down
Menu enter Band
C
1. RGB
RGB is plotted in the following pattern:
R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Magenta:100% -> Magenta:50% -> Cyan:100% ->
Cyan:50% -> Yellow:100% -> Yellow:50% -> Black -> Gray -> White -> Green & Magenta dot signal
(The display of the screen will be changed in 1 second.)
R: 100%
E
Operational description Remote controller key
Return to test mode menu RETURN
Stop / restart of auto display Band
AVH-X5500BHS/XNUC
5 6 7 8
75
1 2 3 4
2. Monochrome Stripe
Display of monochrome stripe signals.
A
Monochrome stripe (Vertical)
Operational description Remote controller key
Return to test mode menu RETURN
Pattern change Band
3. Color Bar
C Display of color bar signals.
Color bar (Vertical)
Operational description Remote controller key
Return to test mode menu RETURN
Pattern change Band
AVH-X5500BHS/XNUC
76
1 2 3 4
5 6 7 8
4. Ramp & 10step
Display of step signals and signals for alpha blend check. A
Right-white 64step
Alpha blend set value
(in hexadecimal)
Operational description Remote controller key
Return to test mode menu RETURN
Alpha blend Up (+0x10) Up
Alpha blend Down (-0x10) Down
Alpha blend Up (+0x01) FF
Alpha blend Down (-0x01) REV
Pattern change Band
5. Raster Signal
Display of signals for step confirmation.
White 0%
Operational description Remote controller key
Return to test mode menu RETURN
Pattern change Band
E
AVH-X5500BHS/XNUC
5 6 7 8
77
1 2 3 4
6. Contrast
Display of Black / White signals.
A
Black
Operational description Remote controller key
Return to test mode menu RETURN
Pattern change Band
7. Center Marker
C Display of signal for screen central location setting.
Center marker
Operational description Remote controller key
Return to test mode menu RETURN
AVH-X5500BHS/XNUC
78
1 2 3 4
5 6 7 8
6. Rear Video Output Test
Method for Mode IN A
Choose “6. Rear Video Output Test” among the Monitor Test Menu screen.
Display specification
On this Rear Video Output Test mode, test signals appear only on the rear video output terminal.
Top menu
Operational description Remote controller key
Return to test mode menu RETURN
Selection cursor up movement Up
Selection cursor down movement Down C
Menu enter Band
1. RGB
RGB is plotted in the following pattern:
R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Black -> Gray -> White signal
(The display of the screen will be changed in 5 seconds.)
R: 100%
D
Operational description Remote controller key
Return to test mode menu RETURN
Stop / restart of auto display Band
AVH-X5500BHS/XNUC
5 6 7 8
79
1 2 3 4
2. Color bar
Display of color bar signals.
A
Color bar (Vertical)
Operational description Remote controller key
Return to test mode menu RETURN
3. Ramp & 10step
C
Display of step signals and signals for alpha blend check.
Right-white 64step
Operational description Remote controller key
Return to test mode menu RETURN
Alpha blend Up (+0x10) Up
Alpha blend Down (-0x10) Down
Alpha blend Up (+0x01) FF
Alpha blend Down (-0x01) REV
E
Pattern change Band
AVH-X5500BHS/XNUC
80
1 2 3 4
5 6 7 8
4. Raster Signal
Display of signals for step confirmation. A
White 0%
Operational description Remote controller key
Return to test mode menu RETURN
Pattern change Band
5. Center Marker
C
Display of signal for screen central location setting.
Center marker
Operational description Remote controller key
Return to test mode menu RETURN
AVH-X5500BHS/XNUC
5 6 7 8
81
1 2 3 4
6. Multiburst
Display of multiburst signal.
A
Multiburst
White Gray Stripe Gray Stripe Gray Stripe Gray Stripe Gray Stripe Gray
94dot 30dot 9dot width 30dot 4dot width 30dot 3dot width 30dot 2dot width 30dot 1dot width 30dot
Operational description Remote controller key
Return to test mode menu RETURN
AVH-X5500BHS/XNUC
82
1 2 3 4
5 6 7 8
6.2 DVD TEST MODE
The service test mode is used to check functions in fault diagnosis by a serviceman in case of any defect found in the A
DVD mecha.
This mode is enabled only when the test mode is activated. At this time, no normal operation is executed.
1. Outline
The service test mode is used to check functions in fault diagnosis by a serviceman in case of any defect found in the
DVD mecha. No general user goes into this mode.
The mode is implemented mainly to check the FE part. It is originally the test mode at the FE part implemented in the
PC communication, which is modified to allow implementation in the HOST communication.
The command for the test mode received in the HOST communication is interpreted by the application part, converted
to the PC communication command and transferred to the OS.
The OS transfers this command to the PC task as if it received the command in the PC communication.
The execution result is noticed to the application part by an e-mail instead of the PC communication. B
The application part then transmits the result in the HOST communication to display OSD.
2. Conditions for operation
(1) This service test mode is enabled only when the test mode is activated. At this time, no normal operation is executed.
3. To enter the test mode.
(1) [MUTE] key + [FORWARD] key -> Turn on BUP and ACC.
(2) DVD SOURCE -> ON
(3) Execute the test mode using each key.
Operation Key C
Display on function flow
(1) +
(2) MUTE
(3) MENU
(4) TOP MENU
(5) AUDIO
(6) SUB TITLE
(7) ANGLE
(8) RETURN
EJECT EJECT
D
AVH-X5500BHS/XNUC
5 6 7 8
83
1 2 3 4
Image of the test mode.
Legend: … Key operation
A … Operation state
Start of the test mode. … The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.
TEST [Note] Higher level 4 characters only. Lower level 4 characters are spaces.
(1) (2) (3) (4) (5)
LD power on time Simple FE
FE test selection EDC1 test selection EDC2 test selection mode selection test mode
Hereafter, to FE test Hereafter, to EDC1 Hereafter, to EDC2 Hereafter, to LD power on Hereafter, to simple
mode image. test mode image. test mode image. time mode image. FE test mode.
[Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode.
Image of the front end test mode. Legend: … Key operation
… Operation state
… The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.
FE test mode
0X00 0000
(1) (2) (3) (4) (5) EJECT
Power on Disc type DVD1 Disc type DVD2
FE offset coefficient Disc type CD Disc type CD-RW EJECT
TE offset coefficient layer layer
0FFF 0000
AS offset coefficient
ENV offset coefficient
TG offset coefficient 0000 0000 0100 0000 0200 0000 0300 0000
DBAL coefficient
C VIN1 offset cancel value
VIN2 offset cancel value
VIN3 offset cancel value
VIN4 offset cancel value
VIN5 offset cancel value
VIN6 offset cancel value
VIN7 offset cancel value
VIN8 offset cancel value
VIN9 offset cancel value
1X00 0000
(1) (2) (3),(4) (5) (6) (7) (8)
F search CRG+/- LD-ON/OFF CRG_HOME CRG_OUTSIDER Power_OFF
F close
S curve
measurement
1FFF 0000 Activates while the key When LO-ON : 1100 0000 1D00 0000 1E00 0000
1A00 0000 When LD-OFF : 1000 0000
is being pressed.
(2) 1B00 0000 : CRG+
1C00 0000 : CRG-
F search STOP
[Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically.
D If F close is selected during LD-OFF, it will become an error.
1100 0000 During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected
within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds.
In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again
Focus close state before F close.
FEMAX level
FEMIN level
ASMAX level
ENVMAX level
FE normalization coefficient
Spindle gain coefficient
TEMAX level indication
TEMIN level indication
(2)
2x00 0000
(1) (2) (3),(4) (8)
Tracking balance Focus Jump CRG+/- Power_OFF
When L0 layer : 2000 0000 It operates while the key
2FFF 0000 When L1 layer : 2100 0000 is being pressed.
E 2B00 0000 : CRG+
TBAL coefficient (layer 0) 2C00 0000 : CRG-
TBAL coefficient (layer 1)
TE normalization coefficient (layer 0)
TE normalization coefficient (layer 1)
Off track adjustment result
3000 0000
(1) (3),(4) (5) (8)
Tracking close CRG+/- RF level value Power_OFF
3FFF 0000 It operates while the key 3FFF 0000
is being pressed.
3B00 0000 : CRG+
3C00 0000 : CRG- Tracking close state FBAL coefficient (layer 0)
FBAL coefficient (layer 1)
Focus gain coefficient (layer 0)
Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
AS normalization adjustment value (layer 0)
F
A B C
AVH-X5500BHS/XNUC
84
1 2 3 4
5 6 7 8
A B C
A
5000 0000
(1) (2) (7) (8)
RF level value Error rate
indication start measurement T.OPEN Power_OFF
Error rate
RF level is informed Focus gain coefficient (layer 0) To (2)
every 500msec. Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
(1) AS normalization adjustment value (layer 0)
RF level value AS normalization adjustment value (layer 1)
indication end
FBAL coefficient (layer 0)
Tracking close state FBAL coefficient (layer 1)
Focus gain coefficient (layer 0)
Focus gain coefficient (layer 1)
Tracking gain coefficient (layer 0)
Tracking gain coefficient (layer 1)
AS normalization adjustment value (layer 0) B
4000 0000
4x00 0000
(1) (2) (5) (6) (3),(4) (7) (8)
Error rate Playback speed T.Jump+/- Power_OFF
measurement switching Focus Jump ID Search T.OPEN
Error rate Jump+ : 4B00 0000
Focus gain coefficient (layer 0) When L0 layer : 4x00 0000 4A00 0000 Jump- : 4C00 0000 To (2)
DVDX1.3 -
Focus gain coefficient (layer 1) When L1 layer : 4x00 0000
Tracking gain coefficient (layer 0) 1.6CAV (3)
(1)-(4)
Tracking gain coefficient (layer 1) CDX4CLV: ID Track number
AS normalization adjustment value (layer 0) 4x00 0000 designation designation
AS normalization adjustment value (layer 1)
ID display Track number
indication The higher 2 digits of the designated ID are the value showing the test state.
(5) (5) The lower 6 digits show the ID.
Search Jump Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000.
L0 layer DVD X CAV,CD X 2CLV :4000 0000 start start
L0 layer DVD X 1CLV,CD X 1CLV :4200 0000 C
Error occurrence L1 layer DVD X CAV :4100 0000
L1 layer DVD X 1CLV :4300 0000
V Change The number for designation of the track number shall be selected from the track numbers previously prepared.
V Switch to cyclic by (3). Fix by (4).
L0 layer DVD X 1.3 - 1.6CAV, CD X 4CLV :4000 0000 For CD: Tracks 1, 4, 10, 11 and 32
Error display
L0 layer DVD X 1CLV :4200 0000 For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100
L1 layer DVD X 1.3 - 1.6CAV :4100 0000
(8) L1 layer DVD X 1CLV :4300 0000 Change the method for ID address designation.
Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5).
Power_OFF
Error occurrence at Power_OFF
[Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again.
Error display
AVH-X5500BHS/XNUC
5 6 7 8
85
1 2 3 4
EDC. Image of the test mode Legend: … Key operation
… Operational state
A … The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.
EDC1/2 test mode [Note] Image is the same for both EDC1 and EDC2.
0000 0000
(1) (2) [Note] Eject can be effected any time during the
EJECT operation
EDC test mode.
Layer 0 selection Layer 1 selection
Eject
0000 0000 0100 0000 Test mode Eject
B 1003 0000 1103 0000
After completion of EJECT operation
(1)-(4)
ID designation
Layer 0:10** ****
Layer 1:11** ****
[Note] ** **** is the ID designation value
(5)
EDC1/2 start
Layer 0:20** ****
Layer 1:21** ****
[Note] ** **** is the present ID designation value
C
**** ****
[Note] **** **** is the present ID designation value
[Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected.
Image of the LD power on time mode.
Legend: … Key operation
… Operational state
D LD power on time mode
… The content displayed on the DVD mechanism (video only)
8 characters data is sent to the product side (HOST) by UART communication.
0000 0000
(1) (2) (5) (6)
CD LD power on DVD LD power on CD LD power on DVD LD power on
time indication time indication time setting time setting
10** **** 20** ****
[Note] ** **** is the CD LD [Note] ** **** is the DVD LD 30** **** 40** ****
power on time. power on time. [Note] ** **** is the setting time. [Note] ** **** is the setting time.
(1)-(4) (1)-(4)
Setting time (8) Setting time (8)
designation designation
(5)
(5)
E
Setting time Setting time
registration registration
10** **** 20** ****
[Note] ** **** is the CD LD
[Note] ** **** is the DVD LD
power on time.
power on time.
[Method of setting time designation]
Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4).
Fix by command (5). Cancel by command (8).
[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours.
[Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory.
AVH-X5500BHS/XNUC
86
1 2 3 4
5 6 7 8
Simple test mode
The selection of the figure of each screen can be selected by "Key command for the test".
A
<Flow chart>
TEST MODE
1: LD ON
2: ASMAX
3: Skew Adjustment
4: Error Rate
5: CRG Move Outer
6: Eject
Please Input Number
LD ON LD ON LD ON
1 select B
1: DVD Single Layer LD ON 1: Power OFF
2: DVD Dual Layer select Completion select
5 Return 3: CD
select 4: CD-RW
5: Return
Please Input Number Now Running Please Input Number
2 select ASMAX ASMAX ASMAX
1: DVD Single Layer ASMAX 1: Power OFF
2: DVD Dual Layer select value set select
5 Return 3: CD
select 4: CD-RW
5: Return ASMAX Level : 000000 ASMAX
Level display
Please Input Number Now Running Please Input Number
Skew Adjustment Skew Adjustment Skew Adjustment
3 select
1: DVD Single Layer
select
value set
RF Level
1: Power OFF C
select
5 Return
select RF Level
5: Return RF Level : 000000 display
Update 500 msec.
Search ID
Please Input Number Now Running 0x00100000 Please Input Number
*1 *1
4 select Error Rate Error Rate Error Rate - Inner Error Rate - Inner
1: DVD Single Layer DVD 1: Inner Measurement Error Rate 1: Power OFF
select 2: Outer Measurement select set select
5 Return 3: CD 3: Middle Measurement
select
5: Return 5: Return Error Rate : 000000
5 Return
select
Please Input Number Please Input Number Search ID Now Running Please Input Number
inner :
0x00040000 *1 : The position in which Error Rate
outer :
0x00200000 select was done is display
*1
Error Rate - CD displayed.
Error Rate -CD
DVD Inner
CD select DVD Outer D
DVD Middle
CD CD
Now Running
Search CRG
home position
5 select CRG Move Outer CRG Move Outer CRG Move Outer
1: DVD Single Layer CRG Move 1: Power OFF
2: DVD Dual Layer select Completion select
5 Return 3: CD
select 4: CD-RW
5: Return CRG moves
to the most
Please Input Number Now Running Please Input Number
outer
<Error>
ERROR
1: Power OFF select E
Code : 00000000
Please Input Number
<Error : Power OFF>
ERROR
Code : 00000000
Please Reset
AVH-X5500BHS/XNUC
5 6 7 8
87
1 2 3 4
7. DISASSEMBLY
While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.
A
Removing the Monitor Assy (Fig.1)
Method for opening the flap manually
Insert a tip of screwdriver whose diameter is
approximately 2mm into the slit at the bottom surface
of the product and slide the flame part to the direction
indicated by an arrow.
B
1 Pull out the Monitor Assy in the direction 3
indicated by an arrow.
2 Remove the two screws.
2 2
3 Disconnect the connector and then remove
the Monitor Assy. 1
Monitor Assy
C
Collar
Attention at assembly:
Mount the Collar for preventing Monitor Assy
backlash on the red circle section.
D Fig.1
Removing the Panel (Fig.2)
Panel Cover
3 3
1 Push the two tabs and then remove the Cover.
2 Remove the four screws. 2 2
3 3
3 Release the six latches and then remove
E the Panel. 1 1
2 2
3 3
Fig.2
AVH-X5500BHS/XNUC
88
1 2 3 4
5 6 7 8
Removing the Case Unit (Fig.3) A
Case Unit
Remove the Case Unit according to the following
procedures, as it is difficult to release the latches on
the lower side of the Grille Assy.
1 Remove the two screws. 2 2
2 Remove the two screws.
1 1 B
(Upper side of the Case Unit)
Push the Case Unit downward with your
finger other than the thumb.
3 Push upward/downward the Grille Assy with
your right thumb and the Case Unit with C
your finger other than the thumb.
(Lower side of the Case Unit)
Case Unit
(Upper side of the Case Unit)
3
Grille Assy D
Push the Grille Assy
upward with your thumb.
Case Unit
(Upper side of the Case Unit)
4 Release the three latches on the upper side
of the Grille Assy with your left hand.
4 4 4 E
Grille Assy
5 Release the four latches on the lower side
5 5 5 5
of the Grille Assy and then remove the
Case Unit.
(Lower side of the Case Unit) F
Fig.3
AVH-X5500BHS/XNUC
5 6 7 8
89
1 2 3 4
- Removing the Service Unit (Monitor) (Fig.4)
A
Service Unit (Monitor)
1 Disconnect the four connectors.
2 2
2 Remove the four screws and then remove
the Service Unit (Monitor).
1
1
2 1 1
B
2
Holder
Attention at assembly:
Be careful of not pinching FPC and FFC from Service
Unit (Monitor) when you mount the Case Unit.
Fig.4
- Removing the Service Unit (Key) (Fig.4)
Remove the Holder, LCD and the Touch
Panel.
1 Release the five latches and then remove
the Holder.
D
Remove the Service Unit (Key). Holder Service Unit (Key)
After the Service Unit (Key) is replaced,
check the following items.
Check whether all LED's light up
Check the operation of all switches
Check the operation of light receiving part
of the remote controller 1 1 1 1 1
E
Fig.5
AVH-X5500BHS/XNUC
90
1 2 3 4
5 6 7 8
Removing the DVD Mechanism Module (Fig.6) A
1 Remove the four screws.
DVD Mechanism Module
2 Disconnect the connector and then remove
1
the DVD Mechanism Module.
DVD Mechanism Module 1
1
1
Bracket
2
Attention at assembly)
When installing the DVD Mechanism Module,
pulling the side Bracket to the DVD
Mechanism Module, tighten the screws. C
Put the dowels of the DVD Mechanism
Module in the slits of the side Bracket
securely.
Attention of removing
Don’t remove this screws excluding the
dismantlement of the DVD Mechanism
Module.
Fig.6 D
Removing the Heat Sink and the Holder (Fig.7)
Heat Sink Holder
1 Remove the three screws and then remove
the Heat Sink.
1
2 Remove the two screws and then remove 2 2
the Holder.
E
1 1
Fig.7
AVH-X5500BHS/XNUC
5 6 7 8
91
1 2 3 4
Removing the Service Unit (Mother I/F) (Fig.8)
A
Service Unit (Mother I/F)
1 Remove the two screws.
2 Disconnect the connector.
1 1
B
Service Unit (Mother I/F)
3 Remove the seven screws and then remove
the Service Unit (Mother I/F).
C
3 3 3
3 3 3 3
D
Service Unit Holder Service Unit Holder
Note)
Remove the Service Unit Holder with tweezers.
If forcefully removed, it may be deformed.
E
Attention at assembly)
When you assemble the Service Unit Holder and the Bracket,
the Claw enters the hole.
They are hardly separated, so pay attention to the deformation.
F
The Service Unit Holder should contact the Bracket.
Fig.8
AVH-X5500BHS/XNUC
92
1 2 3 4
5 6 7 8
Removing the Interface PCB and the Mother PCB (Fig.9) A
Interface PCB
1 Disconnect the connector.
2 Remove the three screws and then remove 2
the Interface PCB. 2
2
1
3 Straighten the tab at location indicated.
4
4
4 Remove the three screws and then remove
the Mother PCB. B
3
4
Mother PCB
Fig.9
Removing the PCB Unit (Service) (Fig.10) C
Washer Gear
1 Remove the two solders and then remove
the two cords.
2 Remove the Washer and then remove the Gear.
3 Remove the screw and then remove the
PCB Unit (Service).
2 D
3
1
PCB Unit (Service)
Motor Unit E
Precautions on attachment of Motor Unit.
While withdrawing a Motor Unit to the direction
indicated by an arrow and tighten the screw to
fix it. If you tighten the screw after withdrawing
it to the opposite direction of the arrow, the
pitch between Worm Gear and Worm Wheel
opens up and the gear jumps due to drop of
package and abnormal sound may be
generated.
Fig.10
AVH-X5500BHS/XNUC
5 6 7 8
93
1 2 3 4
A
<<Drive Unit Gear set position>>
The cutting lack of the Gear (ENV1635) is put between signs of the PCB.
The point of the Frame (ENC2001) is set to
the position of the mark of the Gear (ENV1630).
AVH-X5500BHS/XNUC
94
1 2 3 4
5 6 7 8
8. EACH SETTING AND ADJUSTMENT
8.1 DVD ADJUSTMENT
A
This product uses 5 V and 3.3 V as standard voltages.
The electrical potential that is the reference for signals, is not GND, but VREF (approximately 2.2 V) and VHALF
(approximately 1.65 V) .
During product adjustments, if the reference voltage is mistakenly taken as GND, and a grounding contact is made,
not only would it be impossible to measure the accurate electrical potential, but also the servo motor
would malfunction, resulting in the application of a strong impact on the pick up.
The following precautionary measures should be strictly adhered to, in order to avoid such problems.
The reference voltage and GND should not be confused when using the minus probe of a measurement device.
B
When an oscilloscope is being used special care should be taken to make sure that the reference voltage is not
connected to the probe of ch1 (on the minus side), while the probe of ch2 (on the minus side), is connected to GND.
Further, since the body frame of most measurement devices have the same electrical potential as the minus side of
the probe, the body frame of the measurement device should be set to floating ground.
If the reference voltage is connected to GND by mistake, turn the regulator OFF immediately, or turn the power OFF.
Remove the filters and wires used for measurements only after the regulator has been turned OFF.
After the power supply is turned on, regulator ON the following adjustment and measurement are promptly done.
Whenever the product is in the test mode, the software will not take any protective action. For this reason, special
care should be taken to make sure that no mechanical or electrical shock could be applied to the product when
taking measurements in the test mode.
Whenever the EJECT key is pressed to eject the disk, no other keys, other than the EJECT key, should be pressed C
until the disk eject action has been completed.
Press the EJECT key only after the disk has stopped completely.
If the product hangs up turn the power OFF immediately.
Don't touch the volume for laser power adjustment other than the time of POWER adjustment.
(Laser diode may be damaged.)
AVH-X5500BHS/XNUC
5 6 7 8
95
1 2 3 4
- Power Adjustment
A Power Adjustment
To turn VR of the circuit for Power adjustment and adjust the optical output level of PU laser diode to make the level
of signal (RF signal) read from the media appropriate level during the reproduction of media, CD and DVD.
It has been decided that Power adjustment circuit (circuit from IMON to CDMP, DVDMP) which adjusts the optical
output level of PU laser diode should be installed on DVD Core Unit in the DVD mecha module.
Therefore, in the replacement of CRG mecha (with PU unit) and DVD Core Unit, Power adjustment should be
implemented.
The Power adjustment method of mecha module is shown below.
Items to be Prepared
Measuring instrument: Oscilloscope (digital or analog)
B
Frequency band of oscilloscope in DVD whose frequency is higher than CD Adjustable 10 MHz
and higher (enough to check the level)
(In LS2, DVD (x 1.5CLV) MAX RF 6.55 MHz / DVD (x 1.5CLV) MIN RF 1.40 MHz)
DISC: DVD TEST DISC (TDV-582 or TDV-520) Almedio
CD TEST DISC (TCD-782 or TCD-792) Almedio
Adjustment screwdriver : crosshead, No.0, nonmetal (ceramic screwdriver for adjustment)
Line Locating
The following line locating is required.
1 RF Power adjustment
C
2 VREF1 Power adjustment
Connection Diagram
: Checking terminal for oscilloscope
The figure in parentheses of resistor / capacitor is constant. Universal board
RF VREF1
Enlarged
E
For CDt
For DVDt
AVH-X5500BHS/XNUC
96
1 2 3 4
5 6 7 8
Method of Power Adjustment
1. Monitor RF by using the analog oscilloscope. (line locating of RF and VREF1) A
2. Turn VR1101 and VR1102 to set the PP value of RF at the value shown in the right lower table.
RF waveform after F-ON / before T-ON (waveform measured by analog oscilloscope)
Adjust VR in order that this
width is within the range of
target RF level adjustment value.
Power adjustment standard
RF level adjustment value
(F-ON STEP 10, 24)
B
DVD 200 mV to 1200 mV
CD 200 mV to 1200 mV
RF waveform after the completion of all adjustment (waveform measured by analog oscilloscope)
Adjust VR in order that this
width is within the range of C
target FR level adjustment value.
Power adjustment standard
RF level adjustment value
(The setup is completed. STEP 12, 26)
DVD 848 mV to 892 mV
CD 658 mV to 702 mV
AVH-X5500BHS/XNUC
5 6 7 8
97
1 2 3 4
Procedure of Power Adjustment
Flow
A 1. DVD Power adjustment in the state where F is ON
2. DVD Power adjustment in the state where the setup is completed
3. CD Power adjustment in the state where F is ON
4. CD Power adjustment in the state where the setup is completed
Procedure of Adjustment
STEP No.
1. Set the mecha to clockwise.
2. Turn on power.
3. Test Mode In Refer to FE test mode function flow.
B
4. Insert DVD TDV-582 (or TDV-520).
5. Set the mecha to counterclockwise.
6. Adjustment of the initial position of VR for Power adjustment Adjust the angle at the D cut position to the initial position
(initial position shown in Fig.1).
1st 2nd 3rd
CD (VR1101) -30°
DVD (VR1102) -30° -45° -90° 0° CD VR (VR1101)
Adjustment of the initial position
-30° - 1st, 2nd, 3rd is the same, too
3rd - -90°
2nd - -45°
DVD VR (VR1102)
Adjustment of the initial 0°
position
1st - -30°
7. Set DISC TYPE to DVD single layer. Fig.1
8. Power on. Refer to FE test mode function flow.
9. LD-ON Refer to FE test mode function flow.
D
Refer to FE test mode function flow.
10. Execute until Focus close state is reached.
If the waveform is similar to RF waveform after F-ON and before T-ON (waveform measured by analog oscilloscope), Focus Close is reached.
Go to STEP 9.
If the RF waveform does not appear, Focus Close is not reached.
Return to STEP 7 and change the angle of initial position of DVD VR (VR 1102). If Focus Close is not reached after the 3rd VR adjustment,
replace the whole CRG mecha (including PU unit) and start again from STEP 1.
DVD 200 mV to 1200 mV
11. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.)
DVD 848 mV to 892 mV
12. Execute until Tracking Close is reached.
E
13. Conduct Power adjustment. (Conduct the adjustment in the state of Tracking Close.)
DVD 2.0E – 4 and under
14. Check the ERR rate after Power adjustment.
DVD 820 mV to 917 mV
DVD 2.0E – 4 and under
15. Power off.
16. Return the state of mecha to clockwise.
17. Set up again (state of mecha to clockwise / setting of DVD single layer) and conduct the final check of RF level and ERR rate.
F
(Check in the state of Tracking Close)
18. Eject.
AVH-X5500BHS/XNUC
98
1 2 3 4
5 6 7 8
19. Take out DVD TDV-582 (or TDV-520).
Insert CD TCD-782 (or TCD-792).
A
20. Set the mecha counterclockwise.
21. Adjustment of the initial position of VR for Power adjustment Adjust the angle at the D cut position to the initial position
(initial position shown in Fig.2).
1st 2nd 3rd
-45° -90° CD VR (VR1101)
CD (VR1101) -30° Adjustment of the initial position
0°
DVD (VR1102) As the adjustment is 1st - 30°
completed, never change. 2nd - -45°
3rd - -90°
B
DVD VR (VR1102)
As the adjustment is
completed, never change. 0°
Fig.2
22. Set DISC TYPE to CD. Refer to FE test mode function flow.
23. Power on. Refer to FE test mode function flow.
24. Execute until Focus Close 1 is reached. Refer to FE test mode function flow.
If the waveform is similar to RF waveform after F-ON and before T-ON (waveform measured by analog oscilloscope), Focus Close is reached.
Go to STEP 20.
If the RF waveform does not appear, Focus Close is not reached. Return to STEP 21 and change the angle of initial position of CD VR (VR1101).
If Focus Close is not reached after the 3rd VR adjustment, replace the whole CRG mecha (including PU unit) and start again from STEP 1. C
25. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.)
CD 200 mV to 1200 mV
26. Execute until Tracking Close is reached. Refer to FE test mode function flow.
27. Conduct Power adjustment. (Conduct the adjustment in the state of Focus Close.)
CD 658 mV to 702 mV
28. Check ERR rate.
CD 1.0E – 2 and under Refer to FE test mode function flow. D
29. Power off. Refer to FE test mode function flow.
30. Return the state of mecha to clockwise.
31. Set up again (state of mecha to clockwise / setting of CD layer), and conduct the final check of RF level and ERR rate.
(Check in the state of Tracking Close)
CD 528 mV to 832 mV Refer to FE test mode function flow.
CD 1.0E – 2 and under
32. Eject. Refer to FE test mode function flow.
E
33. Take out CD TCD-782 (or TCD-792).
34. Power off.
AVH-X5500BHS/XNUC
5 6 7 8
99
1 2 3 4
8.2 PCL OUTPUT CONFIRMATION
- PCL Output
With the TESTIN (72 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started.
The clock signal is output from the CLKOUT terminal IC601 (Pin 78).
The frequency of the clock signal is 9.375 MHz.
If the clock signal out of the range, the X’tal (X601) should be replaced with new one.
AVH-X5500BHS/XNUC
100
1 2 3 4
5 6 7 8
AVH-X5500BHS/XNUC
5 6 7 8
101
1 2 3 4
9. EXPLODED VIEWS AND PARTS LIST
NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
A
Therefore, when replacing, be sure to use parts of identical designation.
"
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
9.1 PACKING
RC, RD, RI, ID
EW5
UC, RC, RD
RI, ID
UC, RC, RD
F RI, ID
EW5, RI
UC, EW5 EW5
AVH-X5500BHS/XNUC
102
1 2 3 4
5 6 7 8
(1) PACKING SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Cord Assy See Contrast table (2) 13 Card Remote Control Unit See Contrast table (2)
2 USB Extended Cable CDP1585 14 Handle See Contrast table (2)
A
3 Polyethylene Bag CEG1160 15 Panel See Contrast table (2)
4 Screw See Contrast table (2)
5 Screw TRZ50P080FTC 16 IM CD-ROM See Contrast table (2)
17-1 Owner's Manual See Contrast table (2)
6 Cover See Contrast table (2) * 17-2 Warranty Card See Contrast table (2)
7 Unit Box See Contrast table (2) 17-3 Installation Manual See Contrast table (2)
8 Contain Box See Contrast table (2) 17-4 Installation Manual See Contrast table (2)
9 Protector See Contrast table (2)
10 Microphone Assy CPM1083 * 17-5 Caution Card See Contrast table (2)
* 17-6 Caution Card See Contrast table (2)
11 Holder CZN7192 * 17-7 Service Network See Contrast table (2) B
12 Cushion CZN7193
(2) CONTRAST TABLE
AVH-X5500BHS/XNUC, AVH-X5500BT/XNEW5, AVH-X5550BT/XNRC, AVH-X5550BT/XNRD, AVH-X5550BT/
XNRI and AVH-X5590BT/XNID are constructed the same except for the following:
Mark No. Description AVH-X5500BHS/XNUC AVH-X5500BT/XNEW5 AVH-X5550BT/XNRC
1 Cord Assy CDP1435 CDP1436 CDP1435
4 Screw CRZ50P090FTC CRZ50P090FTC Not used
6 Cover CEG1359 CEG1356 CEG1356
7 Unit Box CHG8154 CHG8162 CHG8155
C
8 Contain Box CHL8154 CHL8162 CHL8155
9 Protector CHP4598 CHP4599 CHP4598
13 Card Remote Control CXE5116 Not used CXE5116
Unit
14 Handle Not used CND6289 Not used
15 Panel Not used Not used CNS9475
16 IM CD-ROM Not used CPJ1446 Not used
17-1 Owner's Manual CRD4703 Not used CRD4704
* 17-2 Warranty Card QRY3001 CRY1376 Not used
D
17-3 Installation Manual Not used CRD4652 Not used
17-4 Installation Manual Not used CRD4653 Not used
* 17-5 Caution Card Not used CRP1436 Not used
* 17-6 Caution Card Not used CRP1441 Not used
* 17-7 Service Network Not used Not used Not used
Mark No. Description AVH-X5550BT/XNRD AVH-X5550BT/XNRI AVH-X5590BT/XNID
1 Cord Assy CDP1435 CDP1435 CDP1435
4 Screw Not used Not used Not used
6 Cover CEG1356 CEG1356 CEG1356
E
7 Unit Box CHG8156 CHG8163 CHG8157
8 Contain Box CHL8156 CHL8163 CHL8157
9 Protector CHP4598 CHP4599 CHP4598
13 Card Remote Control CXE5116 CXE5116 CXE5116
Unit
14 Handle Not used CND6289 Not used
15 Panel CNS9475 CNS9475 CNS9475
16 IM CD-ROM Not used Not used Not used
17-1 Owner's Manual CRD4706 CRD4705 CRB4065
F
* 17-2 Warranty Card Not used Not used CRY1304
17-3 Installation Manual Not used Not used Not used
17-4 Installation Manual Not used Not used Not used
AVH-X5500BHS/XNUC
5 6 7 8
103
1 2 3 4
Mark No. Description AVH-X5550BT/XNRD AVH-X5550BT/XNRI AVH-X5590BT/XNID
* 17-5 Caution Card Not used Not used Not used
* 17-6 Caution Card Not used Not used Not used
A * 17-7 Service Network Not used Not used CRY1305
Owner's Manual,Installation Manual
Part No. Language
CRD4703 English, French, Spanish(Espanol)
CRD4704 English, Traditional Chinese
CRD4705 English, Arabic, Persian
CRD4706 English, Spanish(Espanol), Portuguese(B)
B CRD4652 English, French, Italian, Spanish(Espanol), German, Dutch
CRD4653 English, French, Italian, Spanish(Espanol), German, Dutch
CRB4065 English
CONTENTS OF CD-ROM (Operation Manual), CPJ1446
Part No. Language
* CRB4082 English
* CRB4083 French
* CRB4084 Italian
C
* CRB4085 Spanish(Espanol)
* CRB4086 German
* CRB4087 Dutch
* CRB4088 Swedish
* CRB4089 Norwegian
* CRB4090 Finnish
* CRB4091 Danish
* CRB4092 Portuguese
D
* CRB4093 Greek
* CRB4094 Turkish
All operation manuals are supplied in PDF files by the CD-ROM.
Regarding the availability of paper manual, contact Pioneer Service representative in your region.
AVH-X5500BHS/XNUC
104
1 2 3 4
5 6 7 8
AVH-X5500BHS/XNUC
5 6 7 8
105
1 2 3 4
9.2 EXTERIOR (1)
A
EW5, RI
C
B
B
C A
EW5, RI
B
A
EW5, RI, ID
UC, RD
C
E
EW5, RI
AVH-X5500BHS/XNUC
106
1 2 3 4
5 6 7 8
(1) EXTERIOR (1) SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Screw BSZ26P050FTC 11 Cover CNW2316
2 Screw BSZ26P120FTC 12 Cushion CNN3206
A
3 Screw CBA1735 13 Panel See Contrast table (2)
4 Screw (M2 x 3) CBA1877 14 Cover QNM3029
5 FFC CDE9765 15 DVD Mechanism Module (LS2) CXK8002
6 FFC CDE9769 16 Holder See Contrast table (2)
7 Holder CND6246 17 Panel See Contrast table (2)
8 Sheet CNN4247 18 Label See Contrast table (2)
9 Heat Sink CNR2147 19 Cushion See Contrast table (2)
10 Collar CNW2038 20 Screw BSZ26P060FTC
B
(2) CONTRAST TABLE
AVH-X5500BHS/XNUC, AVH-X5500BT/XNEW5, AVH-X5550BT/XNRC, AVH-X5550BT/XNRD, AVH-X5550BT/
XNRI and AVH-X5590BT/XNID are constructed the same except for the following:
Mark No. Description AVH-X5500BHS/XNUC AVH-X5500BT/XNEW5 AVH-X5550BT/XNRC
13 Panel CNU2048 CNU2047 CNU2049
16 Holder Not used CND6288 Not used
17 Panel Not used CNS9952 Not used
18 Label Not used CNN3533 Not used
19 Cushion CNN3206 Not used Not used
Mark No. Description AVH-X5550BT/XNRD AVH-X5550BT/XNRI AVH-X5590BT/XNID C
13 Panel CNU2049 CNU2049 CNU2049
16 Holder Not used CND6288 Not used
17 Panel Not used CNS9952 Not used
18 Label Not used CNN3533 CNN3533
19 Cushion CNN3206 Not used Not used
AVH-X5500BHS/XNUC
5 6 7 8
107
1 2 3 4
9.3 EXTERIOR (2)
UC, RC, RD, RI, ID
B
UC, RC, RD, RI, ID EW5
C
C
D UC, RD
D
B
C UC, RD
E
F
UC, RD
AVH-X5500BHS/XNUC
108
1 2 3 4
5 6 7 8
(1) EXTERIOR (2) SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Cord Assy See Contrast table (2) 16 Lighting Conductor CNW2312
2 Card Remote Control Unit See Contrast table (2) 17 Touch Panel CSX1194
A
3 Battery Cover See Contrast table (2) 18 TFT LCD CWX4182
4 Screw AMZ26P040FTC 19 Case Unit CXE4761
5 Button (HOME) CAI3846 20 Grille Assy See Contrast table (2)
6 Screw (M2 x 3) CBA1877 21 Button (SRC, VOL+/-, MUTE) CAI3613
7 FFC CDE9393 22 Button (MODE, TRK UP/DOWN, EJECT) CAI3690
8 Holder CND6526 23 Plate See Contrast table (2)
9 Sheet CNN3991 24 Grille CNU2015
10 Sheet CNN4033 25 Lighting Conductor CNW2313
11 Sheet CNN4196 26 Screw IMS20P030FTC B
12 Sheet CNN4232 27 Service Unit (Monitor) CXX4997
13 Cushion CNN4271 28 Service Unit (Key) CXX5005
14 Cushion CNN4272 29 Gasket See Contrast table (2)
15 Holder CNU1756 30 Sheet See Contrast table (2)
(2) CONTRAST TABLE
AVH-X5500BHS/XNUC, AVH-X5500BT/XNEW5, AVH-X5550BT/XNRC, AVH-X5550BT/XNRD, AVH-X5550BT/
XNRI and AVH-X5590BT/XNID are constructed the same except for the following:
Mark No. Description AVH-X5500BHS/XNUC AVH-X5500BT/XNEW5 AVH-X5550BT/XNRC
C
1 Cord Assy CDP1435 CDP1436 CDP1435
2 Card Remote Control CXE5116 Not used CXE5116
Unit
3 Battery Cover CNU1624 Not used CNU1624
20 Grille Assy CXE5621 CXE5620 CXE5622
23 Plate CNN4177 CNN4176 CNN4178
29 Gasket CNN4360 Not used Not used
30 Sheet CNN3881 Not used Not used
Mark No. Description AVH-X5550BT/XNRD AVH-X5550BT/XNRI AVH-X5590BT/XNID
1 Cord Assy CDP1435 CDP1435 CDP1435 D
2 Card Remote Control CXE5116 CXE5116 CXE5116
Unit
3 Battery Cover CNU1624 CNU1624 CNU1624
20 Grille Assy CXE5622 CXE5622 CXE5623
23 Plate CNN4178 CNN4178 CNN4179
29 Gasket CNN4360 Not used Not used
30 Sheet CNN3881 Not used Not used
AVH-X5500BHS/XNUC
5 6 7 8
109
1 2 3 4
9.4 EXTERIOR (3)
UC
-1
B
A
B
-2
B
C
UC
F
Spreads grease
on tip of gear.
(A)
Spreads grease on
(B) the entire gear.
E (B)
(A) : GEM1024
(B) : GEM1043
A
(B) (B)
(B)
F (A)
(B)
AVH-X5500BHS/XNUC
110
1 2 3 4
5 6 7 8
(1) EXTERIOR (3) SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Drive Mechanism Unit CXE3878 20 Screw ASZ26P050FTC
2 Screw AMZ26P030FTC A
3 Washer CBF1039 21 Screw BSZ26P050FTC
4 Washer CBF1064 22 FFC CDE9554
5 Spring EBL1034 23 Bracket CND6335
24 Holder CND6530
6 Frame ENC2001 25 Bracket CND6636
7 Gear ENV1630
8 Gear ENV1631 26 Screw ASZ26P050FTC
9 Gear ENV1632 27 Screw BPZ26P080FTC
10 Gear ENV1635 28 FFC CDE9766
29 Holder See Contrast table (2)
11 Guide ENV3001 30 BT Module (U1671) CWX4306 B
12 Chassis Unit EXA4001
13 Motor Unit EXA4003 > 31 Fuse (10A) YEK5001
14 PCB Unit (Service) EXX2001 32 Service Unit (Mother I/F) See Contrast table (2)
* 15 Cord (Green) CDC1056 33 WWR Core TUN Umit (U401) See Contrast table (2)
34 Holder See Contrast table (2)
* 16 Cord (White) CDC1057 35 Sheet See Contrast table (2)
17 Screw IMS26P060FTC
18 Screw JFZ20P025FTC 36 Screw BSZ26P060FTC
19 Screw EBA2002
(2) CONTRAST TABLE C
AVH-X5500BHS/XNUC, AVH-X5500BT/XNEW5, AVH-X5550BT/XNRC, AVH-X5550BT/XNRD, AVH-X5550BT/
XNRI and AVH-X5590BT/XNID are constructed the same except for the following:
Mark No. Description AVH-X5500BHS/XNUC AVH-X5500BT/XNEW5 AVH-X5550BT/XNRC
29 Holder CND6554 CND6531 CND6531
32 Service Unit (Mother I/F) CXX4970 CXX4969 CXX4972
33 WWR Core TUN Umit CWE2364 Not used Not used
(U401)
34 Holder CND6449 Not used Not used
35 Sheet CNN4314 Not used Not used
Mark No. Description AVH-X5550BT/XNRD AVH-X5550BT/XNRI AVH-X5590BT/XNID D
29 Holder CND6531 CND6531 CND6531
32 Service Unit (Mother I/F) CXX4973 CXX4974 CXX4975
33 WWR Core TUN Umit Not used Not used Not used
(U401)
34 Holder Not used Not used Not used
35 Sheet Not used Not used Not used
AVH-X5500BHS/XNUC
5 6 7 8
111
1 2 3 4
9.5 DVD MECHANISM MODULE (1)
B
B A
(C)
(A)
C
(C)
D
(A)
C (NOTE)
D
(C)
(C)
D
(NOTE) (A)
(A)
(C)
(A) (B)
(A)
(NOTE)
(A) (A)(NOTE)
E E
C
E
B
A
(C) (C)
(A) : GEM1045
F
(B) : GEM1038
(C) : GEM1024 (NOTE) Apply grease to the whole part.
AVH-X5500BHS/XNUC
112
1 2 3 4
5 6 7 8
DVD MECHANISM MODULE (1) SECTION PARTS LIST
Mark No. Description Part No. Mark No. Description Part No.
1 Screw BSZ20P040FTC 35 Gear CNW1186
2 Screw BSZ26P060FTC A
3 Screw (M2 x 4) CBA1835 36 Gear CNW1187
4 Washer CBF1038 37 Clamper CNW1190
5 Spring CBH2855 38 Arm CNW1192
39 Holder CNW1193
6 Spring CBH2860 40 Holder CNW1194
7 Spring CBH3010
8 Spring CBH3011 41 Damper CNW2439
9 Spring CBH3014 42 Damper CNW2440
10 Spring CBH3015 43 Arm CNW1726
44 Guide CNW2240
11 Spring CBH3016 45 Arm CNW2241 B
12 Spring CBH3017
13 Spring CBH3019 46 Rack CNW2265
14 Spring CBH3086 47 Gear CNW2287
15 Spring CBH3095 48 Motor Unit(M1)(CRG(L/E)) CXC4026
49 Screw Unit CXC8894
16 Spring CBH3096 * 50 Chassis Unit CXE6044
17 Plate Spring CBL1824
18 ••••• 51 •••••
19 Case CNB3762 * 52 Support Wheel CNW2052
20 Bracket CND4553 * 53 Spindle Motor(M2)(SPINDLE) EXM2002
54 Arm Assy CXE6232 C
21 Lever CND5398 55 Washer CBF1037
22 Bracket CND5710
23 Bracket CND6127 56 Washer CBF1038
24 Arm CND6406 57 Arm CND6242
25 Sheet CNN3678 58 Roller CNW2500
59 Collar CNW2444
26 Roller CNW1172 60 Gear Unit CXE6225
27 Roller CNW1175
28 Arm CNW1177 61 Washer YE15FTC
29 Arm CNW1178 62 Screw JFZ20P025FTC
D
30 Gear CNW1180 63 Screw JGZ17P020FTC
64 Screw (M2 x 5) EBA1028
31 Gear CNW1181 65 DVD Core Unit YWX5032
32 Gear CNW1183
33 Rack CNW1184 66 Mechanism Unit(Service) CXX4549
34 Gear CNW1185
On this mechanism, Pickup and Spindle Motor can not be replaced at the service site, because a special facility is
required for the adjustment after replacing them. E
So, if Pickup or Spindle Motor is defective, replace the Mechanism Unit.
AVH-X5500BHS/XNUC
5 6 7 8
113
1 2 3 4
9.6 DVD MECHANISM MODULE (2)
(C)
(C)
(C)
(A)
(B)
(A) : GEM1045
(B) : GEM1038
(C) : GEM1024
AVH-X5500BHS/XNUC
114
1 2 3 4
5 6 7 8
AVH-X5500BHS/XNUC
5 6 7 8
115
1 2 3 4
10. SCHEMATIC DIAGRAM
10.1 MOTHER PCB (ANALOG BLOCK)
A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".
INNER BUS
A 2/6 ANA-SYS BUS
A
B
AV
AV
C AV
RR
FR
RL
FL
AV_LOUT1
D AV
ANA-I/O BUS
A 5/6 E
F
AV
AV
RCA_SWR
RCA_SWL
RCA_RR
BTANAR
RCA_FR
RCA_RL
BUSL+
BTANAL
AUX_L
RCA_FL
BUSL-
AEQMICIN
iNAVI
RCAMUTE
A 6/6 ANA-TUN BUS
C280 CCG1236-A-T
EV12 SYS+B
B E.VOL
AMPPW
10u/35
C281 100p/50
R258 R260
R256 2.7k 1.8k 1.8k
R264
R265
NM
1000p/50
0
R257 2.7k R259 R261 FL
C278 1000p/50
C284 NM
E. VOL IC INPUT 1.8k 1.8k FR
1 - GNDA
0.1u/16
100p/50
C286
C252
R262
R263
C282
C285
10u/35
2 AV SEL
2.7k
2.7k
RR
NM
C283
1u/10
C279
3 BT TEL AUDIO RL
4 SXI
5 NAVI/app GUIDE
64
63
62
FRONT_L 61
REAR_L 60
PRE_SWL 59
NC13 58
PGND 57
NC12 56
PREF 55
VP 54
NC11 53
PRE_SWR 52
REAR_R 51
FRONT_R 50
NC10 49
GNDA
6 - C253 1 SVIN_RL 48
M - C269 SYSMUTE
1u/10 2 TOUT_RL 47
10p/50
C251
3 NC1 46 1u/10
E. VOL Input 4 APF_2 SVIN_FR TOUT_RR 45 C270
S
TOUT_FR
FM/AM(30%) (A,C~F): -15.0 dBs C254 NC14 1u/10
TOUT_FL
5 APF_1 SVIN_PRE 44 9.0
SVIN_FL
SVIN_RR
FM/AM(30%) (B): -11.0 dBs C255 6 NC2 TOUT_PRE 43 C271
SXi (A):+2.2 dBs 0.22u/50
7 IN1L NC9 42 1u/10
TV:+2.2 dBs GNDA
AUX:+2.2 dBs C256 1u/10 8 IN2L IN1R 41
IC251
VCR:+2.2 dBs C257 1u/10 9 IN3L IN2R 40 C272
DC_FILTER
TEST_OUT
PML020A AV_ROUT1
USB(LS2 Decode):+5.1 dBs 10 NC3 IN3R 39 1u/10
C268
MIC_IN
USB(SH Decode):+2.2 dBs
C275
10p/50
C DVD/CD(LS2):+5.1 dBs C258 1u/10 11 IN4L+ NC8 38 1u/10 OFFSET
C273 PCHANG
Navi Guide:+8.6 dBs C259 1u/10 12 IN4L- IN4R+ 37 1u/10 BUSR+
BT-Audio:+2.2 dBs GNDA
BT-HF:+2.2 dBs only A 13 NC4 IN4R- 36 C274 BUSR-
20 MIC_AMP_OUT
26 SA_TEST_OUT
1u/10
R201
C260 1u/10
NM
14 IN5L NC7 35
C261 1u/10 15 IN5G DVCC 34 only A SYS+B
27 SAOUT
28 SACLK
29 DGND
16 IN5R MUTE 33
10u 24 CREF
31 DATA
25 GND
GNDA
23 VCC
21 NC5
22 NC6
30 CLK
32 STB
CCG1192-A
SPEED
E. VOL Output
0.1u/10
C277
C276
17
18
19
FM/AM(30%) (A,C~F): -1.9 dBs
10u
R202 C203 MAO
FM/AM(30%) (B):+2.1 dBs EVMUTE
C265 10u 0.47u/10
C264
SXi (A):+14.3 dBs CCG1218-A-T
R255
1.8k C266
CCG1192-A
SYS+B
47k
1000p/50 R253
3300p/50
2.2u/10
NM
TV:+14.3 dBs
C201
100p/50
C267
AUX:+14.3 dBs (Rb
C287
VCR:+14.3 dBs GNDA
CCG1192-A
USB(LS2 Decode):+14.2 dBs EVSEL
1000p/50
C288
C263
C289
C262
100p/50
0.1u/16
NM
USB(SH Decode):+14.3 dBs EVSDA
DVD/CD(LS2):+14.2 dBs GNDA
Navi Guide: -7.5 dBs EVSCK
BT-Audio:+14.3 dBs GNDA C113
CCG1192-A 10u
BT-HF:+19.3 dBs EVSACLK TELMUTE
GNDA
C114 EVSAOUT
GNDA
0.1u/10
AVSCL
D
AVSDA
AV SELECTOR C129 1u/10 R112 100
SH_L PBSENS
C137 1u/10 R116 100
AUDIO CH VIDEO CH
CH1 SH CH1 iCOMP C128 1u/10 R113 100
SH_R
CH2 iTV CH2 VCR C132 1u/10 R114 100
iTV_L
C138 R117 100
CH3 LS-2 CH3 AUX 1u/10
C133 1u/10 R115 100 GNDA
CH4 VCR CH4 LS-2
A 3/6 CH5 AUX CH5 BC
GNDV
iTV_R
BSENS
48
47
46
SDA 45
VCOM 44
43
GND1 42
41
40
GND2 39
RIN2 38
37
CH6 TUN CH6 -
VSS1
1 VIN6 LIN3 36 C134 1u/10 R108 56
RIN1
LIN1
LIN2
LS_L
R101 100 C101 C135 1u/10 R119 56
BC_VGND 1 8 0.1u/10 2 VGND5 GND3 35
C102 0.1u/10 C136 1u/10 R120 56 GNDA
BCAM_IN 2 7 3 VIN5 RIN3 34 LS_R
VGND6
SCL
VSS2
LS2_VGND 6 C103 0.1u/10 4 VGND4 LIN4 33 C119 1u/10 R121 56 VCR_L
3
LS_V 5 C104 0.1u/10 5 VIN4 GND4 32 C120 1u/10 R109 1 8 100 VCR_GND ASENS
4
AUX_VGND 8 C105 0.1u/10 6 VGND3 RIN4 31 C121 1u/10 7 VCR_R
1 2
IC101
ANA-SH BUS
AUX_V 7 C106 0.1u/10 7 VIN3 LIN5 30 C122 1u/10 6 AUX_L
2 3
AK4223VQ
E
GNDV ISENS
VCR_VGND 6 C107 0.1u/10 8 VGND2 GND5 29 C123 1u/10 5 AUX_AGND
3 4
VCR_V 5 C108 0.1u/10 9 VIN2 RIN5 28 C124 1u/10 8 AUX_R
4 1
R102 100 C131 0.1u/10 10 VGND1 LIN6 27 C125 7 TUN_L
1u/10 2
iCOMP GNDV 11 VIN1 GND6 26 C126 6 (TUN AGND)
C130 0.1u/10 1u/10 3
21 ROUT2
23 ROUT1
14 VOUT2
VOUT1
TUNAG
22 LOUT2
LOUT1
NM C127 1u/10
16 REGV
20 RVDD
12 VR2 RIN6
18 VVDD
19 AVDD
R111 25
17 RSTN
4 5 TUN_R
15 VR1
C109 R110 100
0.1u/10
R118
NM
R107 NM AV SELECTOR Input BGSENS0
13
24
SYS+B
SYS+B FM/AM(30%) (A,C~F): -15.0 dBs
GNDV
FM/AM(30%) (B): -11.0 dBs
R103 R106 NM GNDA TV:+2.2 dBs
10u
C116 10u
CCG1192-A
AUX:+2.2 dBs
C111 0.1u/10
CCG1192-A
NM
0.1u/16
1000p/50
75
75
CCG1192-A
C117
C118
C139
VCR:+2.2 dBs
0.1u/16
0.1u/10
D101
C110
C112
C115
USB(LS2 Decode):+5.1 dBs
BGSENS1
NM USB(SH Decode):+2.2 dBs
RCA_V R104
R105
10u
NM DVD/CD(LS2):+5.1 dBs
AV_ROUT1
AV_LOUT1
D102
GNDA
GNDA GNDV ANA-I/O BUS NOTE
INNER BUS
MONVBS
AVSRST
F
ANA-SH BUS
ANA-SYS BUS
A 1/6
AVH-X5500BHS/XNUC
116
1 2 3 4
5 6 7 8
BUP_1
YS BUS
A AVH-X5500BHS/XNUC CHIP SIZE LEGEND
A 1/6 MOTHER PCB
R312
B AVH-X5500BT/XNEW5 1608
1k
C AVH-X5550BT/XNRC
2125 (ANALOG BLOCK)
DA2J101
3216
D312
D AVH-X5550BT/XNRD Q311
IC341
PA2030A
SYS+B
C2 3 4 E2
E AVH-X5550BT/XNRI 1 TAB
B1 2 5 B2
101 - : AV.SEL AMP 2 PW.GND2
100u/16
F AVH-X5590BT/XNID
C311
R331
10k
E1 1 6 C1
105
RN4987 FR- 3 RR-
201 - : AEQ Q331
4 STBY
251 - : E.VOL E2 4 3 C2 5 RR+
FR+
R332
301 - : PWAMP B2 5 2 B1
47k
GNDA 6 VCC1/2
C1 6 1 E1
801 - : SENS RN4982
C351 FL- 7 RL-
NM
8 PW.GND1
AMPPW GNDA C350 FL+ 9 RL+
B
CCH1998-A 10 SVR
C341
CCG1313-A 0.22u 10u/16V 11 FLIN
C342 12 FRIN
CCG1313-A 0.22u 13 S-GND
C343 14 RRIN
CCG1313-A 0.22u 15 RLIN
C340 NM
C345 NM
C346 NM
C347 NM
C344 0.22u C349 1u 16 ACGND
CCG1313-A
CCG1325-A RL+ 17 FL+
D311
R311
NM
NM
18 PW.GND3
AMPMUTE C348
SYSMUTE NM GNDA RL- 19 FL-
GNDA
Q321 R321 R323 14.1V 20 VCC3/4
OFFMUTE
1 6 NM 10k VDD33 RR+ 21 FR+
R301
NM
SYS+B AMMUTE
5 R322 22 MUTE
9.0V D301 R302
220 23 FR-
C321
RR-
1u/16
2
R306
NM NM
10k
R303 D302
24 PW.GND4
C301
NM
Q301 3 4
NM NM NM R305 25 offset
R304
NM
RN1903 10k
10p/50
C352
C307
C308
GNDA
100p/50
0.1u/16
OFFSET
GNDA GNDD
Q302 C
PCHANG LTC014YEB
DD5
C886 B.REM
R886
R884
NM
NM
GNDD
NM
R882
C887
R893
NM
NM
NM
SPEED-App
R896 R891 NM
IC301
R885
NM
IC881 VCC IC881 6 R889 NM
NM NM 2 R892 7 C885 R883 D881 R881 1 VDD 8
GNDD OUT
Q882 1 8 2 NC1 7
NM NM NM NM NM NM NM NM NC2
EVMUTE 5 R890
D883
NM
4 3 IN 6
C884
C304
0.1u/16
NM
R888 NM
0.1u/16
3
D882
C882
C881
NM
NM
NM
R895 GND DIAG
NM
C883
C302
C303
NM
4 GND 5
NM PCNG MASK
(Rb=10K,Rbe=10k)
R894
R887
NM
NM
Q881
NM TPD1052F
EVSEL GNDD
(Rb=Rbe=10k)
EVSDA GNDD VDD33
PBSENS
EVSCK
GNDD
R864
R867
47k
EVSACLK TELMUTE
HN1A01FU(YGR)
D853 (BTH1101) D304
1k R866 L852 CRG03
EVSAOUT
C1
B2
E2
R861
6
5
4
CRG03
NM
D303
C305
47k
10k
AVSCL
D
0.1u/16
Q854
DAN202UM C306
0.1u/50
C860
NM
C861
C862
NM
NM
AVSDA
C2
1
2
3
E1
B1
_L PBSENS R868 GNDD R865
GNDA
1k 47k
GNDD
TELMUTE GNDD
JA801
CKM1376-A
R863 GNDD D821 FR-
_R R821 L821 FR-
1 FR-
22k RR- RR-
NM 2 RR-
C821
15k
0.1u/50
(BTH1101) FR+ FR+
DAN202UM 3 FR+
POWER SUPPLY
ASENS RR+ RR+
4 RR+
FL- FL-
HZU7L(A1) GNDD 5 FL-
R872 R873 D871 R880 RL-
BSENS RL-
6 RL-
FL+
HN1C01FU(YGR)
NM 10k 1k FL+
7 FL+
BSENS
C1
B2
E2
RL+
6
5
4
LS_L 100k D873 RL+
8 RL+
R874
R875
C871
NM
47k
Q871
4.7k
PBK
BSN2 R878 HZU7L(C3) 9 P.B.
R876 D872
R879
Q872 MUTE
47k
LS_R
C2
1
2
3
10 MUTE
E1
B1
NM NM NM BREM
R877
NM
11 B.REM
R871 ILM
ASENS GNDD 12 ILM
GNDD
BGSN
NM 13 BGSENS
GNDD ACC
GND2 GND3
14 ACC
ISENS
ISENS
R842
GND1
15 GND E
R841 D841 BGSENS-AVH FUSE
Q841 16 B.UP
LTC014EEB BUP_1
C841
C842
10k DA2J101 1k YEK5001
105
1u/10
GNDD
NM
600uH 10 A
BUP2
BUP1
VDD33
3.4V 14.4V >
C801
3300u/16
L801
D801
D802
SPOUT
CTH1221-A
R832
1SR154-400
1SR154-400
100k
R834
GNDD FM/AM(30%) (A,C~F):+19.7 dBs
1k
BGSENS0 Q831
LTC014EEB R833 FM/AM(30%) (B):+23.7 dBs
D831 10k L831 SXi (A):+35.9 dBs
SOC33_1
BGSENS-App RKZ5.6KG(B2) NM TV:+35.9 dBs
R831
3.4V AUX:+35.9 dBs
NM
(CTF1547)
0.1u/50
R801
C831
C832
VCR:+35.9 dBs
NM
NM
USB(LS2 Decode):+35.8 dBs
BGSENS1 USB(SH Decode):+35.9 dBs
Q801
NM DVD/CD(LS2):+35.8 dBs
R802
NM
Navi Guide:+14.1 dBs
GNDD BT-Audio:+35.9 dBs
BT-HF:+40.9 dBs
NOTE :
Symbol indicates a resistor. GNDD
SERVICE UNIT(MOTHER I/F)
No differentiation is made between chip resistors and Consists of
discrete resistors. MOTHER PCB F
Symbol indicates a capacitor. NM : No Mount INTERFACE PCB
No differentiation is made between chip capacitors and
US
discrete capacitors. : The power supply is shown with the marked box.
A 1/6
AVH-X5500BHS/XNUC
5 6 7 8
117
1 2 3 4
10.2 MOTHER PCB (SYSTEM BLOCK) (GUIDE PAGE)
A-a A-b
Large size
SCH diagram
A-a 2/6
SYS+B
9.0V
LS2
R759
1k
SYS-TUN BUS
CCG1192-A
VD8
10u 10V
A-a A-b Guide page CN751
6
5
4
CKS6025-A
8.0V
VD8 1
RN4982
Q752
SYS-I/O BUS
0.1u/10
VD8 2
C751
C753
C757
NM
VD8 3 PGD
PGND
PGND 4
Detailed page
1
3
2
A-a A-b PGND VD5
PGND 5
10u 10V
C752
C754
C755
NM
NM
SYS-POWER BUS
CCG1192-A
DGND GND
PGND 6
INNER BUS
GNDD
VD5 7
AMTE R752 470
AMUTE AMUTE
AMUTE 8
R753 1k /XRST XRST
XRESET 9
LSIRQ SYS-SH BUS
B
1 8 IRQPW IRQPW
IRQPWR 10
S LS2TX 2 7 SYSTOLS
HSTCMD 11
LS2 SRX 3 6 LSTOSYS
SLVSTS 12
4 5 STNBY STANBY
STANBY 13 SYS-ANA BUS
R751 220
AGND 14
LS_ROUT LS_R
ANA_R_OUT 15
*
C AGND
ANA_L_OUT
16
17
LS_LOUT
R754
LS_L
A
R601 R602 R603 R604 R605 R60
NM NM NM NM NM NM
USB(LS2 Decode):+5.1 dBs
CN1952 AGND 18
GNDA 0 DVD/CD(LS2):+5.1 dBs LS_V
B 100k NM 100k NM 100k NM
MOVBS 19 C 100k NM NM 100k 100k NM
LSVG
VIDEO_GND 20 D 100k NM NM 100k NM 100k
GNDV E NM 100k 100k NM 100k NM
WAKEUP 21
F NM 100k 100k NM NM 100k
HN1C01FU(YGR)
C2
D- 22
E1
B1
R757
1
2
3
4.7k
D+ 23
Q751
DGND 24 R758
6
5
4
C1
B2
E2
IECOUT 25 4.7k
DGND 26
SCL 27
SDA 28 GNDA
CPRST 29 LSDG
CPRDY 30
DGND
GNDD
USB SW
C SOC33
DM R707
R750
100k
0
IC751 DP
1 VCC 14
1D+ ASENBO
2 NC1 13
NC4
3 S 12
1D-
4 D+ 11
2D+ AVSDA R700
5 D- 10
220 R692
2D- AVSRST 100k
6 NC2 9
NC3 S CH MEDIA CONNECTED DEVICE AVSCL R612
7 OE 8
220 R601 R602
GND L 1D Audio TO SH Hi SPEED
0.1u/10
100k 100k
C756
R603 R604
TC7USB221FT H 2D Video TO LS2 FULL SPEED 100k 100k
R605 R606
* 100k 100k
R608
R607 NM 100k
GNDD BSENS
USB_SW ASENS
REMIN R622
100
D- R609 R610
D+ 100k NM
D601
WIRED NM
D602
WIREDAD NM
COMDC
EVSAOUT R626
D 0 C603
POS
330p/50
ANTSENS
only A
TEMPSENS
C605
NM
R613
KDT1 4.7k
R615
KDT0 4.7k
CN601 VDD33
NM
VDD 1
NC 2
GND 3
RESET
NRST 4
OSMD
NDMOD 5
E GND 6
OSCK
SCL 7
GND 8
OSDA
SDA 9
GND 10
GNDD
SYS-ANA BUS
SYS-SH BUS
SYS-POWER BUS
SYS-I/O BUS
SERVICE UNIT(MOTHER I/F) SYS-TUN BUS
Consists of
MOTHER PCB
F INTERFACE PCB
INNER BUS
A 2/6
AVH-X5500BHS/XNUC
118
1 2 3 4
5 6 7 8
A-b 2/6
A 2/6 MOTHER PCB
(SYSTEM BLOCK)
SYS-TUN BUS
A 6/6
SYS-I/O BUS
A 5/6
G_PWM
R_PWM
B_PWM
LCDPW
MOT1
MOT0
BEEP
SYS-POWER BUS
A 4/6
SYSPW
MOTPW2
DDCCLK
HIOUTCLK
VDCNT8
VDCNT5
SYS-SH BUS A AVH-X5500BHS/XNUC
A 3/6 B AVH-X5500BT/XNEW5 B
SHMUTE
SHRST
SHIRQ
C AVH-X5550BT/XNRC
D AVH-X5550BT/XNRD
SYS-ANA BUS
A 1/6 E
F
AVH-X5550BT/XNRI
AVH-X5590BT/XNID
AMPPW
PBSENS
BGSENS0
TELMUTE
ISENS
C690
NM
601 R602 R603 R604 R605 R606 R608
NM NM NM NM NM NM NM
R705
00k NM 100k NM 100k NM 100k
8.2k
NM
00k NM NM 100k 100k NM 100k
R694
R690
R691
NM
2.7k
00k NM NM 100k NM 100k 100k
1k
R697
NM 100k 100k NM 100k NM 100k
R681
R682
R683
220
220
220
NM 100k 100k NM NM 100k 100k CHIP SIZE LEGEND
1608
R695
NM
2125
3216
R625
R699
R689
R693
NM
NM
100k
47k
VDD33
R687
GNDD
100k
NM
NM
NM
R698
C617
C616
C618
47k
R688
47k
L601
NM
1000p/50
CCG1321-A
50V
TELMUTE
0.01u/16
C621
C615
C614
R684
R685
R686
601 - : SYSTEM
220
220
220
0.1u
701 - : LS2
0.1u/10
CLKOUT
SYPW
C613
AMPP
PBSN
DCLK
VC5
GNDD
C
72
71
70
69
68
67
66
65
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
TESTIN
R707 97 64
NC
NC
NC
NC
NC
G_PWM
AMPPW
R_PWM
B_PWM
DDCERR
LCDPW
SYSPW
VSS
MOT1
MOT0
MOTPWR2
BEEP
DDCCLK
CLKOUT
PBSENS
VDD50
VDCNT8
VDCNT5
NC
/BGSENS
TESTIN
HIOUTCLK
FLAPLESS
TELMUTEIN
/ISENS
100k 98 63
NC
99 62 AEQAUXSW
NC
100 ASENBO 61
101
SOCIRQPW
60 R704
SOCAMUTE1
TXIE/NC FAN_PWM FAN_PWM
/SOCXRST
SOCTESTIN
/DDCERR
102 RXIE/NC VSS BTTESTMD 59 BTMD NM
AEQAUXSW
00 R620 NC R678 47k
10k 103 AVSDATA BTTESTIN 58
0 R692 BTRT R677
104 /AVSRST /BTRST 57 R676 BTRST
100k 47k
12 R611 R673 NM
10k 105 AVSCK BTRX 56 R675 NM 47k BTTOSYS
0 R601 R602
100k 100k 106 MODEL0/NC BTTX 55 R674 NM SYSTOBT
R603 R604
100k 100k 107 MODEL1/NC SXIPWREN/NC 54 SXIPWEN
R605 R606 R672
* 100k 100k
R608
108 MODEL2/NC RXSXI/NC 53 47k R702 SXTOS
109 52 0 STOSX
R607 100k MODEL3/NC TXSXI/NC R669
NM 470
R617 R706
100k 110 /BSENS BLEND 51 BLEND
R618 NM R680
100k 111 /ASENS IC601 SXIPW/ANTPW 50 ANTPW
22 112 REMIN HDPWR33/NC 49 0 only A TU3VON
00 113 NC
A PDB091A8 HDPWR11/NC 48 TU1VON
R609 R610
114 MODEL4/NC B ~ F PDB094A8 NC 47
100k NM
115 NC NC 46
116 NC AUTOANT 45 AUTOANT
R623 R667 10k
D601 117 44 R668
NM 100k WIRED TUNCLK TUNCLK
D602 R624 R619 R666 1k
NM 10k 118 WIREDAD /TUNRST 43 100k TUNRST
R664 10k
119 COMDC TUNDATA 42 1k R665 TUNDATA
26 120 41 0
SAIN NC R703 NM
D
0 C603
121 POS RXHD/NC 40 DTUNtoSYS
330p/50 STDT
R679 122 SXISENS/ANTSENS TXHD/NC 39 SYStoDTUN
R663 47k
only A 0 123 AVSS SYSMUTE 38 SMTE
C604 SYSMUTE
/GUIDEON
EVLMUTE
R627 R638
124 37
/RGBARI
TEMPSEN /SOCSTB SHSTBY
RXNAVI
47k
TXNAVI
RXSOC
TXSOC
C605 C601 0.1u/10 0.1u/16
offset
1k
/STB
125 SACLK 36 R662 0 EVSACLK
NM AVDD
R613
4.7k R616 126 KDT1 EVSEL 35 R661 0 EVSEL
(OCD_SDA)
(OCD_SCL)
NOCDMOD
R615 470
127 34
/H&OSW
4.7k R614 R660 0 EVSCK
MICSEN
VOUT18
KDT0 EVSCK
RXDVD
AMUTE
TXDVD
IRQPW
ATRST
VDD50
/XRST
OSCO
470
NRST
OSCI
128 33
TSO
R659
TCK
VSS
VSS
VREFH EVSDA 0 EVSDA
TSI
XO
XI
R628 NM
C602
1
2
3
4
6
7
8
9
5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
0.1u/10
1u/6.3
TSO
UGD
OSMD
1000p/50
OSDA
OSCK
R651
R653
R654
R633
NM
C612
470
470
1k
0.1u/10
TSI TCK
C619
R656
R629
C608
R701
680
47k
0
R621
47k
R645
1k
STL
LTS
VDD33
NM
R649
1k
47k
27k
R630
R631
R655
R635
R636
R637
R644
100k
4.7k
4.7k
4.7k
C607
NM
LSCR523UB
10p/50
R650
RST
NM
R647
100k
R658
D603
IC602
100k
C606
Q601
1 5
0.1u/10
8p/50
1u/6.3
47k
R642
47k
47k
R632
R634
OUT NC2
2
NM
VDD
3 4
C609
NM
C620
C610
R652 VSS NC1
C611
E
47k
NM
X601
SYS-ANA BUS
4 GNDD
GND2 X2 3
NM
120
120
R646
R648
R657
1 2
X1 GND1
EVMUTE
OFFSET
CSS1839-A
RESET
SYS-SH BUS
12.500MHz
SYS-POWER BUS
SYStoSH
SHtoSYS
SYS-I/O BUS
MICSENSR
GUIDEON
S_TO_N
N_TO_S
RGBARI
H/OSW
RESET
SYS-TUN BUS
SYSTOLS
LSTOSYS
F
STANBY
AMUTE
IRQPW
RESET
OSMD
OSDA
OSCK
XRST
A 2/6
AVH-X5500BHS/XNUC
5 6 7 8
119
F
E
B
A
D
C
120
A-a A-b
A-b 2/6
PCB
1
1
A 2/6 MOTHER
(SYSTEM BLOCK)
SYS-TUN BUS
A 6/6
SYS-I/O BUS
A 5/6
MOT1
MOT0
BEEP
G_PWM
R_PWM
B_PWM
LCDPW
SYS-POWER BUS
A 4/6
SYSPW
MOTPW2
VDCNT8
VDCNT5
DDCCLK
A AVH-X5500BHS/XNUC
HIOUTCLK
SYS-SH BUS
A 3/6 B AVH-X5500BT/XNEW5
2
2
C AVH-X5550BT/XNRC
SHIRQ
SHRST
D AVH-X5550BT/XNRD
SHMUTE
SYS-ANA BUS
E AVH-X5550BT/XNRI
A 1/6 F AVH-X5590BT/XNID
C690
NM
ISENS
AMPPW
PBSENS
R604 R605 R606 R608
BGSENS0
TELMUTE
NM NM NM NM
R705
NM 100k NM 100k
00k 100k NM 100k 8.2k
NM
00k NM 100k 100k
NM
1k
R694
2.7k
R690
R691
NM 100k NM 100k
R697
CHIP SIZE LEGEND
220
220
220
NM NM 100k 100k
R681
R682
R683
1608
NM
R695
2125
3216
AVH-X5500BHS/XNUC
NM
NM
47k
R625
R699
100k
R689
R693
VDD33
GNDD
NM
R687
100k
NM
NM
47k
R698
C617
C616
C618
3
3
L601
R688
47k
NM
50V
C621
C615
C614
601 - : SYSTEM
1000p/50
0.01u/16
220
220
220
R684
R685
R686
TELMUTE
CCG1321-A
0.1u
701 - : LS2
C613
VC5
PBSN
AMPP
SYPW
DCLK
0.1u/10
GNDD
CLKOUT
72
71
70
69
68
67
66
65
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
TESTIN
97 64 DDCERR
NC
NC
NC
NC
NC
NC
VSS
98 63
MOT1
MOT0
BEEP
NC
G_PWM
R_PWM
B_PWM
VDD50
LCDPW
AMPPW
SYSPW
CLKOUT
/ISENS
PBSENS
TESTIN
VDCNT8
VDCNT5
99 DDCCLK 62
NC AEQAUXSW
MOTPWR2
/BGSENS
HIOUTCLK
FLAPLESS
100 61
TELMUTEIN
ASENBO
101 TXIE/NC FAN_PWM 60 R704 FAN_PWM
/DDCERR
102 RXIE/NC VSS BTTESTMD 59 BTMD NM
AEQAUXSW
R620 NC R678 47k
10k 103 AVSDATA BTTESTIN 58
SOCIRQPW
/SOCXRST
R677
SOCTESTIN
SOCAMUTE1
104 57 BTRT R676 BTRST
/AVSRST /BTRST 47k
R611 R673 NM
10k 105 AVSCK BTRX 56 R675 NM 47k BTTOSYS
R602
4
106 55
4
100k MODEL0/NC BTTX R674 NM SYSTOBT
R604
100k 107 MODEL1/NC SXIPWREN/NC 54 SXIPWEN
R606 R672 R702
100k 108 MODEL2/NC RXSXI/NC 53 47k SXTOS
R608 0
100k 109 MODEL3/NC TXSXI/NC 52 R669 STOSX
R617 470
100k 110 /BSENS BLEND 51 R706 BLEND
R618 NM R680
100k 111 /ASENS IC601 SXIPW/ANTPW 50 ANTPW
112 49 0 only A TU3VON
REMIN HDPWR33/NC
113 NC
A PDB091A8 HDPWR11/NC 48 TU1VON
R610
114 MODEL4/NC B ~ F PDB094A8 NC 47
NM
115 NC NC 46
116 NC AUTOANT 45 AUTOANT
R623 R667 10k
100k 117 WIRED TUNCLK 44 R668 TUNCLK
R608 0
100k 109 MODEL3/NC TXSXI/NC 52 R669 STOSX
R617 470
100k 110 /BSENS BLEND 51 R706 BLEND
R618 NM R680
100k 111 /ASENS IC601 SXIPW/ANTPW 50 ANTPW
112 49 0 only A TU3VON
REMIN HDPWR33/NC
113 NC
A PDB091A8 HDPWR11/NC 48 TU1VON
R610
114 MODEL4/NC B ~ F PDB094A8 NC 47
NM
115 NC NC 46
116 NC AUTOANT 45 AUTOANT
R623 R667 10k
100k 117 WIRED TUNCLK 44 R668 TUNCLK
2 R624 R619 R666 1k
10k 118 WIREDAD /TUNRST 43 100k TUNRST
R664 10k
119 COMDC TUNDATA 42 1k R665 TUNDATA
120 41 0
SAIN NC R703 NM
5
5
121 POS RXHD/NC 40 DTUNtoSYS
122 39 STDT SYStoDTUN
R679 SXISENS/ANTSENS TXHD/NC
0 R663 47k SMTE
only A 123 AVSS SYSMUTE 38 C604 SYSMUTE
R627 R638
47k 124 TEMPSEN /SOCSTB 37 SHSTBY
C601 0.1u/10 0.1u/16 1k
125 SACLK 36 R662 0 EVSACLK
AVDD
offset
/GUIDEON
/RGBARI
TXNAVI
RXNAVI
/STB
TXSOC
RXSOC
EVLMUTE
R613
4.7k R616 126 KDT1 EVSEL 35 R661 0 EVSEL
R615 470
4.7k R614 127 EVSCK 34 R660 0 EVSCK
KDT0
470
128 33 R659 0 EVSDA
VREFH EVSDA
MICSEN
TXDVD
RXDVD
/XRST
/H&OSW
TSO
TSI
TCK
(OCD_SDA)
(OCD_SCL)
IRQPW
AMUTE
NOCDMOD
OSCO
OSCI
VSS
XI
XO
VDD50
VOUT18
NRST
VSS
ATRST
R628 NM
C602
1
2
3
4
6
7
8
9
5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
0.1u/10
1u/6.3
TSO
UGD
NM
R651
OSDA
OSCK
OSMD
R653
R654
R633
470
470
1k
C612
TSI TCK
1000p/50
680
47k
C619
R656
R629
C608
R701
0.1u/10
47k
R621
1k
R645
STL
LTS
1k
NM
6
6
47k
27k
R649
VDD33
R630
R631
100k
R655
4.7k
R635
R636
4.7k
R637
4.7k
R644
C607
NM
10p/50
NM
RST
IC602
R650
100k
R647
C606
R658
100k
D603
8p/50 1 5
Q601
LSCR523UB
OUT NC2
47k
47k
47k
2
R642
R632
R634
1u/6.3
0.1u/10
VDD
NM
3 4
R652 VSS NC1
NM
C609
C620
C610
47k
C611
NM
X601
4 GNDD
GND2 X2 3
NM
120
120
R646
R648
R657
1 2
X1 GND1
CSS1839-A
AVH-X5500BHS/XNUC
SYS-ANA BUS
12.500MHz
RESET
OFFSET
EVMUTE
7
7
SYS-SH BUS
SYStoSH
SHtoSYS
SYS-POWER BUS
SYS-I/O BUS
GUIDEON
RGBARI
S_TO_N
N_TO_S
MICSENSR
H/OSW
RESET
SYS-TUN BUS
8
8
SYSTOLS
LSTOSYS
XRST
OSDA
OSCK
IRQPW
AMUTE
OSMD
STANBY
RESET
A-a A-b
A-b 2/6
121
E
A
D
C
F
B
F
E
B
A
D
C
122
A-a A-b
A-b 2/6
A-a 2/6
1
1
SYS+B
9.0V
LS2
1k
VD8 SYS-TUN BUS
R759
CN751
6
5
4
CKS6025-A
10u 10V
CCG1192-A
8.0V
VD8 1
VD8 2 SYS-I/O BUS
Q752
NM
RN4982
C751
C753
C757
VD8 3 PGD
0.1u/10
PGND
PGND 4
3
2
PGND VD5
PGND 5
DGND GND SYS-POWER BUS
NM
NM
PGND 6
C752
C754
C755
GNDD
10u 10V
VD5 7
AMTE R752 470
AMUTE AMUTE
CCG1192-A
AMUTE 8
R753 1k /XRST XRST
XRESET 9
LSIRQ IRQPW IRQPW SYS-SH BUS
1 8
INNER BUS
IRQPWR 10
S LS2TX 2 7 SYSTOLS
HSTCMD 11
2
2
LS2 SRX 3 6 LSTOSYS
SLVSTS 12
4 5 STNBY STANBY
STANBY 13 SYS-ANA BUS
R751 220
AGND 14
LS_ROUT LS_R
ANA_R_OUT 15
AGND 16
*
C LS_LOUT LS_L
R601 R602 R603 R604 R605 R606 R608
ANA_L_OUT 17 NM NM NM NM NM NM NM
R754 A
AGND 18 USB(LS2 Decode):+5.1 dBs B 100k NM 100k NM 100k NM 100k
CN1952 GNDA 0 DVD/CD(LS2):+5.1 dBs LS_V
MOVBS 19 C 100k NM NM 100k 100k NM 100k
LSVG
VIDEO_GND 20 D 100k NM NM 100k NM 100k 100k
GNDV E NM 100k 100k NM 100k NM 100k
WAKEUP 21
F NM 100k 100k NM NM 100k 100k
D- 22
1
E1
2
B1
3
C2
R757
4.7k
D+ 23
Q751
DGND 24
AVH-X5500BHS/XNUC
6
5
4
C1
B2
E2
IECOUT 25
HN1C01FU(YGR)
R758
4.7k
DGND 26
SCL 27
GNDA
3
3
SDA 28
CPRST 29 LSDG
CPRDY 30
DGND
GNDD
USB SW
SOC33
DM R707
100k
0
IC751 DP
R750
1 VCC 14
1D+ ASENBO
2 NC1 13
NC4
3 S 12
1D-
4 D+ 11
R700 R620
2D+ AVSDA 10k
5 D- 10
220 R692
2D- AVSRST 100k
6 NC2 9
S CH MEDIA CONNECTED DEVICE R612 R611
NC3 AVSCL
7 OE 8 10k
220 R601 R602
4
GND
4
L 1D Audio TO SH Hi SPEED 100k 100k
R603 R604
C756
TC7USB221FT H 2D Video TO LS2 FULL SPEED 100k 100k
0.1u/10
R605 R606
* 100k 100k
R608
R607 NM 100k
R617
GNDD BSENS 100k
USB_SW R618
ASENS 100k
REMIN R622
100
D- R609 R610
D+ 100k NM
D601 R623
WIRED NM 100k
R608
R607 NM 100k
R617
GNDD BSENS 100k
USB_SW R618
ASENS 100k
REMIN R622
100
D- R609 R610
D+ 100k NM
D601 R623
WIRED NM 100k
D602 R624
WIREDAD NM 10k
COMDC
EVSAOUT R626
5
C603
5
POS 0
330p/50
ANTSENS R679
0
only A
R627
TEMPSENS 47k
C605 C601
NM
R613
KDT1 4.7k
R615
KDT0 4.7k
R628 N
C
0.
6
6
CN601 VDD33
NM
VDD 1
NC 2
GND 3
RESET
NRST 4
OSMD
NDMOD 5
GND 6
OSCK
SCL 7
GND 8
OSDA
SDA 9
GND 10
AVH-X5500BHS/XNUC
GNDD
SYS-ANA BUS
7
7
SYS-SH BUS
SYS-POWER BUS
SYS-I/O BUS
SERVICE UNIT(MOTHER I/F) SYS-TUN BUS
Consists of
MOTHER PCB
8
8
INTERFACE PCB
INNER BUS
A-a A-b
A-a 2/6
A-b 2/6
123
E
A
D
C
F
B
1 2 3 4
10.3 MOTHER PCB (SH BLOCK) (GUIDE PAGE)
A-a 3/6
RGB VIDEO ISOLATOR
DD5
INNER BUS
DEEM
VDCRST
VDEC_D7
VDEC_D6
VDEC_D5
L1005
10u
SH-I/O BUS
GPSON
POL
LOAD
B0
B1
B2
B3
B4
CLK
Q1003
VCLK
CCG1192-A
PLSEN
DIO
10u 10V
PLSDATA
L1001 LSCR523UB
C1006
R1011
CTF1545-A 15p/50
100
SH-SYS BUS C1382
C1001
R1381
GNDV
C1363
C1364
C1365
C1366
56p/50
56p/50
56p/50
0.1u/10
0
GNDD
SH-POWER BUS
IC1001
56p/50
C1383
C1362
6p/50
1 5 C1010 GNDSIG
GNDV
Q1002 2 1u/10 SH-TUN BUS
L1004 GNDV GND
LSCR523UB R1012 L1006 C1011
3 4 CSYNC
R1378
C1378
CTF1545-A
L1378
NM
NM
B
VCC
0
100 NM C1005 N_CSYNC 1u/10
0.1u/10
BH7673G
SH-ANA BUS GNDD
NM
C1002
0.1u/10
VTL1126-A
VTL1126-A
100 VTL1126-A
VTL1126-A
VTL1126-A
L1413
L1411
L1409
L1407
IC1002
VTL1127-A
L1415
C1381
L1306
C1012
VTL1126-A
L1377
1 5 GNDSIG
2 1u/10
0
R1426 0
R1362
GNDV
NM
GND
R1427
330 R1425
GNDV L1007 3 4 C1013 ANR
100
100
0
NM
NM
Q1001 VCC
R1364
R1363
L1002 NM C1007
R1416
R1414
LSCR523UB N_R 1u/10
100
R1010 0.1u/10 R1013
0
CTF1545-A BH7673G C1014 iCOMP
R1379
47p/50
C1360
100
R1412
R1410
R1408
R1406
100 iPodVideo
0
1u/10
R1365
R1376
IC1003 26pim
1 5 C1015 GNDSIG
C1003
0.1u/10
2 1u/10
GNDV GND
L1008 C1016
C1342
C1343
C1344
C1345
3 4
C1390
R1393
ANB
10p/50
0.1u/16
0.1u/16
0.1u/16
0.1u/16
100
C1008 VCC
NM N_B
GNDV
Q1004
0.1u/10
BH7673G
1u/10
only A, D
L1003 LSCR523UB IC1004
R1009 1 5 C1017 GNDSIG
CTF1545-A
100 2 1u/10
GNDV GND
L1009 3 4 C1018 ANG
VCC PG18
C1004
NM C1009 N_G
0.1u/10
0.1u/10 1u/10 PG19
BH7673G
PG20/DV_DATA6/LCD_DATA20 181
191
184
Vss16 182
189
192
190
187
186
185
PG21/DV_DATA7/LCD_DATA21 183
PVcc14 180
179
178
PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5 177
176
175
174
PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G 173
PVcc13 172
171
170
169
168
167
188
PG26/LCD_TCON1
PG25/LCD_TCON0
PG22/LCD_DATA22/LCD_TCON5
PG23/LCD_DATA23/LCD_TCON6
PG27/LCD_TCON2
PG24/LCD_CLK
PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5
MONVBS
Vcc14
PG18/DV_DATA4/LCD_DATA18/SPDIF_IN/SCK4
PG19/DV_DATA5/LCD_DATA19
PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F
PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H
Vcc13
Vss15
PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0
PG15/D31/LCD_DATA15/PINT7
PG14/D30/LCD_DATA14/PINT6
PG13/D29/LCD_DATA13/PINT5
PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1
/LCD_TCON4/TxD4/AUDATA2
GNDV
/LCD_EXTCLK
FLCLK_1 193
C1301
/LCD_TCON3/RxD4
194
/SPDIF_OUT/SCK5
FCS1
/RxD5/AUDSYNC
VIDEO DECODER 0.1u/16
/TxD5/AUDATA3
FLCS_1 195
196 PF0/BREQ/QSPCLK_1/RSPCK1
/TIOC4A/DREQ0/AUDCK
FIO0_1 197 PVcc15
56p/50 PF1/BACK/QSSL_1/SSL10
FIO1_1 198
C
C1361 /TIOC4B/DACK0
R1390 R1308 199 Vss17
L1052 BCK NM PF2/WAIT/QMO_1/QIO0_1/MOSI1
VDEC15 VDEC33 /TIOC4C/TEND0/SPBMO_1/SPBIO0_1
LRCK NM R1309 200
NM
NM
NM
NM PF3/CS2/QMI_1/QIO1_1/MISO1/TIOC4D
0
C1077
201 /AUDIO_XOUT/SPBMI_1/SPBIO1_1
0.1u/10
DATA R1310
0.1u/10
NM
C1065
C1067
R1076
R1077
100 PF4/CS5/CE1A/SSISCK0/SGOUT_0
R1080
202
R1079
R1087
SYStoSH
PF5/SSIWS0/SGOUT_1
R1302
GNDD SHtoSYS 27k 203 PF6/CE2A/SSITxD0/SGOUT_2
GNDV
PF9 PF7/SSIRxD0/RxD0/SGOUT_3/CTS1
R1397 NM 204
C1084 R1078 BCLK
Q1051
PF8/A23/TxD0
NM
C1302
CCG1192-A
CCG1192-A
205 PF9/BS/DV_DATA0/SCK0/MMC_D4/RTS1
NM NM R1394
10u
NM
10u
LRCLK
R1086
C1072
C1076
PF10 PVcc16
NM
0.1u/16 206
R1074
R1075
2.2k
2.2k
DATA_BT R1399 NM PF10/CS1/SSISCK1/DV_DATA1/SCK1/MMC_D5
207
Vss18
VDEC15 GPStoSH R1366 208 PF11/SSIWS1/DV_DATA2/RxD1/MMC_D6
V_SCL0
VDEC33 NM R1373
GNDV 32.000MHz V_SDA0 SHtoGPS R1367 NM 209 PF12/SSIDATA1/DV_DATA3/TxD1/MMC_D7
C1071 NM
5p/50 VDEC_FLD 210
R1051
C1062
R1052
PF13/A24/SSISCK2/SCK2
R1083
1u/10
75
R1377
211
1
BTTOSH R1368 NM
R1059
PF14/A25/SSIWS2/RxD2
0
X1051
470
NM
CSS1818-A
SHTOBT R1421 212 PF15/A0/SSIDATA2/WDTOVF/TxD2/UBCTRG
C1063 10u
NM C1303 213
CCG1192-A
PVcc17
CCG1192-A
0.1u/10
C1057
C1058
C1060
C1064
R1053
1000p/50
0.01u/16
R1369 0.1u/16
4.7k
10u
PLSCLK 214 PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5
NM
1M
215
R1058
Vss19
100
100
3
R1055
R1056
R1071
2
5p/50 3
SHIRQ 216 PF16/SD_CD_0/FCE/IRQ4/MMC_CD
C1070
47k SYS P.DW R1374 NM
BGSENS1 217 PF17/SD_WP_0/FRB/IRQ5
C1075
64
63
AVDD4 62
61
60
59
58
57
56
55
54
53
52
51
XOSCO 50
49
0.01u/16 PCHANG R1375 NM 218
100 PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1
C1083 R1072 PJ11
DGND5
SDA
AGND4
SAS
PGND_A
SCL
1
CVBS4
CVBS3
CVBS2
PVDD_A
CVBS1
48
DVDD_C5
GNDD 219
XOSCI
C1085 VDCRST
DVDD_IO4
PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6
R1088
1u/10 R1073 L1051 R1304
R1085
2 47 VDECCLK MTCHRST 220
NM
PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7
75
GIN1 5p/50
C1054 0.01u/16 3 GIN2 46 CTF1740-A NM R1305 120
100 USB_SW 221 PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
C1055
4
AVDD1 RESETN
CLKO 45 C1073 0.1u/10 only A, D C1304 222 PVcc18
1000p/50 AGND1 DVDD_IO3 R1306
5 C1074 0.1u/10 100k 0.1u/16
C1082 DGND4 44 BLEN 223 PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0
BIN1 R1345
1u/10 DVDD_C4 43
R1084
R1089
6 R1060 390 VDEC_D7 47k 224
NM
Vss20
75
BIN2
C1056 7 DO7 42 R1061 PF20
390 VDEC_D6 225 PF20/SD_CLK_0/SSIDATA3/MMC_CLK
REF
D
DO6
C1051 0.01u/25 8 41 R1062 VDEC_D5 C1305 226
IC1051 390 Vcc15
REFP DO5
C1053
0.47u/6.3
0.47u/6.3 9 ML86V7675TBZ03A 40 R1063 VDEC_D4 ADCCL R1370 0.1u/16 227
C1052 390 PF21/SD_CMD_0/SCK3/MMC_CMD
REFN DO4 NM
10 39 R1064 390 VDEC_D3 ADCDA R1371 228 PF22/SD_D3_0/RxD3/MMC_D3
0.47u/6.3 AGND2 DO3 NM
11 TAOUT DO2 38 R1065 390 VDEC_D2 ADCON R1372 229 PF23/SD_D2_0/TxD3/MMC_D2
C1078 DO1 NM
GNDV 1u/10 12 RIN1 37 R1066 230
DO0 390 VDEC_D1 D0 PD0/D0/PWM1A
RIN2
13 AVDD3 VSYNC_L 36 R1067 390 VDEC_D0 C1306 231
HSYNC_L PVcc19
R1082
R1090
C1081 AGND3
NM
SSCK
75
14 CSYNC_A FID 35 R1068 220 VDEC_VD SSCK 0.1u/16 232
1000p/50 PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7
DVDD_IO1
DVDD_IO2
DVDD_C1
DVDD_C2
DVDD_C3
C1080 15 34 R1069 220 VDEC_HD 233 Vss21
STATUS
DGND1
DGND2
DGND3
SLEEP
TEST1
TEST2
TEST3
0.01u/16 16 33 R1070 234
CHSI
560 VDEC_FLD D1 PD1/D1/PWM1B
VSI
DE
C1079 D2 235 PD2/D2/PWM1C
R1081
R1091
NM
1u/10
75
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
D3 236 PD3/D3/PWM1D
R1057 SDI
VDECSTUS SDI 237 PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7
560 SDO
SDO 238 PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7
BLSYNC R1423 239
GNDV GNDD PJ27/SGOUT_3/TIOC1A/CTS7
2.2k C1307 240 PVcc20
R1430
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10
R1054
C1059
C1061
C1066
C1068
C1069
0.1u/16 241
47k
NM Vss22
D4 242 PD4/D4/FRE/PWM1E
D5 243 PD5/D5/FCLE/PWM1F
D6 244 PD6/D6/FALE/PWM1G
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK
245 PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC
PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD
D7 PD7/D7/FWE/PWM1H
GNDD
246
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7
D8 PD8/D8/NAF0/PWM2A
D9 247 PD9/D9/NAF1/PWM2B
D10 248
SOC33 SDRAM PD10/D10/NAF2/PWM2C
PD11/D11/NAF3/PWM2D
D11 249
PC6/CAS/SCK7/CTx0/CTx0&CTx1&CTx2
PC5/RAS/CRx0/CRx0/CRx1/CRx2/IRQ0
PC7/CKE/RxD7/CRx1/CRx0/CRx1/IRQ1
CTF1786-A
C1308 PVcc21
250
L1101
PD12/D12/NAF4/PWM2E
D12 0.1u/16 251 Vss23
PC8/CS3/TxD7/CTx1/CTx0&CTx1
252 PD13/D13/NAF5/PWM2F
E
PC4/WE1/WE/DQMLU/TxD6
PD14/D14/NAF6/PWM2G
IC1101 D13 253
PD15/D15/NAF7/PWM2H
PC3/WE0/DQMLL/RxD6
C1101 1 54
D14 254 MD_CLK0
0.1u/10 VDD1 VSS3
2 53
PC2/RD/WR/SCK6
DQ0 DQ15 D15 255
R1101 R1108
PB3/A3/TIOC0C
PB4/A4/TIOC0D
PB1/A1/TIOC0A
PB2/A2/TIOC0B
PB5/A5/TIOC1A
PB6/A6/TIOC1B
D0 C1102 3 52 D15 R1301 MDCLK
VDDQ1 VSSQ4 256
5 4 0.1u/10 5 4
R5S7269*
D1 4 51 D14 NM
DQ1 DQ14
PC1/RD
6 3 6 3
R1307
5 50
PVcc1
PVcc2
PVcc3
D2 D13
PVcc
47k
Vss1
Vcc1
Vss2
Vcc2
DQ2 DQ13
7 2 6 49 C1106 7 2
D3 D12
VSSQ1 VDDQ4
8 1 7 48 0.1u/10 8 1
1
2
3
4
6
7
8
9
5
220 220
10
11
VTL1127-A 12
13
14
15
16
17
DAMT18
19
20
21
22
23
24
25
26
DQ3 DQ12
8 47
R1102 DQ4 DQ11 R1109
L1313
D4 C1103 9 46 D11
VDDQ2 VSSQ3
5 4 0.1u/10 10 45 5 4
D5 D10
VTL1127-A
VTL1127-A
L1315
0.1u/16
VTL1126-A
DQ5 DQ10
C1310
R1346
R1311
R1313
R1315
R1316
R1317
R1318
L1311
L1312
R1418
3 3
L1305
6 6
100k
4.7k
4.7k
4.7k
4.7k
D6 11 44 D9
NM
NM
DQ6 DQ9
7 2 12 43 C1107 7 2
D7 D8
VSSQ2 VDDQ3
8 1 13 42 0.1u/10 8 1
220 DQ7 DQ8 220
0.1u/16
0.1u/16
C1311
C1312
C1313
C1314
R1420
C1104
0.1u/16
0.1u/16
NM
14 41 R1106 470 UDQM
R1103 VDD2 VSS2
470 0.1u/10 15 40
LDQM L1107 SDCK
LDQM NC2
5 4 16 39 CTF1645-A
WE
WE UDQM C1108
R1312
R1314
6 3
R1319
17 38
4.7k
4.7k
CAS
100k
CAS CLK 47p/50 R1112
R1361
CKE
NM
7 2 18 37
RAS 470
RAS CKE R1110
1 470
SDCS R1104 8 470 19 36 R1113 A12 SH-TUN BUS
CS NC1
5 4 5 4 NM
USBFLG
USBCNT
BA0 20 35 A11
BA0 A11
6 3 21 34 6 3
BA1 A9
7 2 22
BA1 A9
33 7 2 SH-POWER BUS
A10 A8
A10_AP A8
8 1 23 32 8 1
A0 A7
A0 A7
5 4 5 4
A1 24
A1 A6
31 A6 SH-SYS BUS
6 3 25 30 6 3
A2 A5
A2 A5
CPLDRST
7 2 7 2
GPSRST
DIMMER
A3 26 29 A4
A3 A4
F
8 1 C1105 27 28 8 1
R1105 470 VDD3 VSS1 R1111 470
0.1u/10 SH-I/O BUS
M12L128168A-5TG2N
DACMUTE
UDQM
LDQM
SDCS
RAS
CAS
CKE
GNDD
WE
A0
A1
A2
A3
A4
A5
INNER BUS
A 3/6
AVH-X5500BHS/XNUC
124
1 2 3 4
A2 15 178 NM VDCRST
PB3/A3/TIOC0C PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5
R1317
USBFLG NM 16 PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6 PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5 177 VDEC_D7
C1313 L1305 C1344
17 PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H 176
PVcc3
0.1u/16 VTL1126-A DAMT18 Vcc13 175 0.1u/16 R1414 L1415
DACMUTE PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7 B0
R1318 PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1
100k 19 174 100 VTL1126-A
Vss2 Vss15
C1362
GNDD
A3 20 PB4/A4/TIOC0D PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G 173 56p/50 VDEC_D6
R1319 C1314 21 C1345
Vcc2 PVcc13 172
DIMMER 100k 0.1u/16 R1418 22 171 0.1u/16 VDEC_D5
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F
R1420 L1413
GPSRST 0 23 170 R1412 VTL1126-A C1363 B1
PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0
100 L1411 56p/50
USBCNT NM 24 169 R1410 VTL1126-A C1364 B2
PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD PG15/D31/LCD_DATA15/PINT7
L1409 56p/50
A4 25 PB5/A5/TIOC1A PG14/D30/LCD_DATA14/PINT6 168 R1408
100 VTL1126-A
C1365 B3
100 L1407 56p/50
A5 26 PB6/A6/TIOC1B PG13/D29/LCD_DATA13/PINT5 167 R1406 VTL1126-A B4
C1315 L1315 C1346 100 C1366
27 PVcc4 Vcc12 166
L1405 56p/50
A6 0.1u/16 VTL1127-A 28 0.1u/16 R1404 VTL1126-A B5
PB7/A7/TIOC2A PG12/D28/LCD_DATA12/PINT4 165
100 C1367
29 Vss3 Vss14 164 L1403 56p/50
A7 30 R1402 VTL1126-A G0
PB8/A8/TIOC2B PG11/D27/LCD_DATA11/PINT3/TIOC3D 163
C1316 L1316 C1347 100 C1368
31 Vcc3 PVcc12 162 56p/50
L1401
A8 0.1u/16 VTL1127-A 32 161 0.1u/16 R1400 VTL1126-A C1369 G1
PB9/A9/TIOC3A PG10/D26/LCD_DATA10/PINT2/TIOC3C
100 L1399 56p/50
A9 33 PB10/A10/TIOC3B PG9/D25/LCD_DATA9/PINT1/TIOC3B 160 R1398 G2
C1370
IC1302
34 159 100 VTL1126-A
A10 PB11/A11/TIOC3C PJ4/DV_DATA4/LCD_DATA4/SD_CLK_1/PWM1E 56p/50 VDEC_D4
5
5
A11 35 PB12/A12/TIOC3D PJ3/DV_DATA3/LCD_DATA3/SD_D0_1/PWM1D 158 VDEC_D3
R5S72690RW266FP
MCK R1303 L1301 36 157 VDEC_D2
PJ19/DV_DATA19/LCD_DATA19/MISO0/TIOC0D/SIOFRxD/AUDIO_XOUT PJ2/DV_DATA2/LCD_DATA2/SD_D1_1/PWM1C
0 C1309 CTF1786-A C1317 L1317 C1348
37 PVcc5 Vcc11 156
47p/50 0.1u/16 VTL1127-A SCS 38 0.1u/16 R1396 L1397
SCS PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2 PG8/D24/LCD_DATA8/PINT0/TIOC3A 155 G3
BA0 R1353 39 100 VTL1126-A C1371
0 Vss4 Vss13 154 56p/50
A12 R1354 40 PB13/A13/QIO2_1/SPBIO2_1 PJ1/DV_DATA1/LCD_DATA1/SD_WP_1/PWM1B 153 VDEC_D1
NM C1318 L1318 C1349
41 Vcc4 PVcc11 152
BA1 R1355
TPIRQN 0 0.1u/16 VTL1127-A 42 151 0.1u/16 VDEC_D0
PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2 PJ0/DV_DATA0/LCD_DATA0/SD_CD_1/PWM1A
0 0 R1341
STV2 R1428 R1347 100k TPIRQ 43 PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1 PG7/D23/LCD_DATA7/IRQ7/TIOC2B 150 R1395 100 VTL1126-A L1394 C1372 G4
R1429 0 56p/50
OEV R1356 0 44 PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1 PG6/D22/LCD_DATA6/IRQ6/TIOC2A 149 R1392 100 VTL1126-A L1393 C1373 G5
56p/50
BA0 R1357 NM 45 PB14/A14/QIO3_1/SPBIO3_1 PG5/D21/LCD_DATA5/IRQ5/TIOC1B 148 R1389 100 VTL1126-A L1391 R0
R1388 100 L1390 VTL1126-A R1
BA1 R1358 NM 46 PB15/A15/QIO2_0/SPBIO2_0 PG4/D20/LCD_DATA4/IRQ4/TIOC1A 147 R1386 100 L1387 VTL1126-A R2
C1319 L1319 C1350 C1374
FLSIO2 R1359 0 47 PVcc6 Vcc10 146 56p/50
C1351
0.1u/16 VTL1127-A MT10 48 145 0.1u/16 C1375
FLSIO3 R1360 0 PB16/A16/QIO3_0/SPBIO3_0 PG3/D19/LCD_DATA3/IRQ3/TIOC0D 56p/50
2
12p/50
C1376
49 Vss5 Vss12 144 56p/50
3 X2
FLCK 50
GND1
PB17/A17/QSPCLK_0/RSPCK0/SPBCLK AUDIO_X1 143
C1320 51 142 R1350
X1303
Vcc5 AUDIO_X2
CSS1794-A
FLCS 0.1u/16 52 1.5k C1352
PB18/A18/QSSL_0/SSL00/SPBSSL PVcc10 141
X1
GND2
R1322
16.9344MHz
FLSIO0 47k 53 0.1u/16 C1353
4
1
PB19/A19/QMO_0/QIO0_0/MOSI0/SPBMO_0/SPBIO0_0 PG2/D18/LCD_DATA2/IRQ2/TIOC0C 140 12p/50
FLSIO1 54 PB20/A20/QMI_0/QIO1_0/MISO0/SPBMI_0/SPBIO1_0 Vss11 139 C1377
L1384 56p/50 R3
55 Vss6 PG1/D17/LCD_DATA1/IRQ1/TIOC0B 138 R1385 100 VTL1126-A
C1354 R1382 R4
56 PB21/A21/CRx2/IERxD Vcc9 137 100 L1383 C1379
PB21
C1321 0.1u/16 VTL1126-A 56p/50
57 Vcc6 PG0/D16/LCD_DATA0/IRQ0/TIOC0A 136 R1380 L1381 R5
0.1u/16 100 VTL1126-A C1380
58 PB22/A22/CTx2/IETxD/CS4 Vss10 135
56p/50
R1320
PB22
100k 59 TCK 134 TCKJ
PC0/CS0/MD_BOOT2
C1322 L1322 TMS
60 PVcc7 133 TMSJ
TDI
R1344 15 0.1u/16 VTL1127-A 61 TDO 132
SDCK CKIO TDIJ
ASEBRKAK/ASEBRK
C1359 62 131 TDOJ
Vss7 TRST
R1321
6
6
NM 100k 63 130 ASEBRKJ
PA0/MD_BOOT0
C1323 L1323 64 R1351
Vcc7 129
0.1u/16 VTL1127-A 1k TRSTJ
INNER BUS
R1352
PLLVss1
PLLVss2
PJ31/DV_CLK
PLLVcc
VIDEO_X1
VIDEO_X2
PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK
PVcc8
PVcc9
USBAPVss
USBAPVcc
Vss9
USBAVcc
USBAVss
USBDPVcc
USBDPVss
PE4/SCL2/RxD4/DV_VSYNC
PJ30/SSIDATA5/TIOC2B/IETxD
REFRIN
USBDVcc
USBDVss
USBUVcc
USBUVss
VDAVcc
VDAVss
PE6/SCL3/RxD6
1 8
RTC_X1
RTC_X2
USB_X1
USB_X2
PE7/SDA3/RxD7
PE5/SDA2/RxD5/DV_HSYNC
EXTAL
PE0/SCL0/TCLKA/LCD_EXTCLK
XTAL
PE3/SDA1/TCLKD/ADTRG/DV_HSYNC
AVref
NMI
PE2/SCL1/TCLKC/IOIS16/DV_VSYNC
VIN1
VIN2
PJ28/SSISCK5/TIOC1B/RTS7
PH5/AN5/PINT5/LCD_EXTCLK
PH7/AN7/PINT7
PA1/MD_BOOT1
PJ29/SSIWS5/TIOC2A/IERxD
2 7
65
66
67
69
72
73
74
75
76
77
78
79
Vss8 80
ASEMD 81
Vcc8 82
83
84
85
86
87
RES 88
89
90
91
92
DM 93
DP 94
VBUS 95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
VRT 115
VRB 116
BIAS 117
PH0/AN0/PINT0 118
PH1/AN1/PINT1 119
PH2/AN2/PINT2 120
PH3/AN3/PINT3 121
PH4/AN4/PINT4 122
123
AVss 124
PH6/AN6/PINT6 125
AVcc 126
127
128
3 6
4 5
68 R1384
SH-I/O BUS
NMI
1k
SH-SYS BUS
L1302
SH-TUN BUS
47k
TP1301
C1334
CPPW
0.1u/16
1k
70 R1323 100
71 R1383 100
R1391
CTF1545-A
BLR 100k
NM
100k
NM
R1407
R1405
R1403
R1431
R1432
R1433
R1411
R1436
R1409
R1401
R1434
R1435
SH-POWER BUS
100k
100k
3216
2125
1608
NM
NM
NM
NM
100k
100k
C1385
C1384
C1332
R1338
R1326
100k
R1335
2.2k
R1333
R1324
C1333
R1328
C1331
R1327
C1330
C1328
C1327
C1326
R1325
R1336
C1325
C1324
C1391
0.1u/16
C1335
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
24k F%
NM
680
0
5.6k F%
47k
NM
NM
100k
C1388
1u/6.3
0.1u/16
C1329 0.1u/16
330p/50
GNDD
C1386
CHIP SIZE LEGEND
C1341
47k
47k
47k
100k
1000p/50
R1334
R1340
R1330
R1329
SC33
X1301
R1342
R1343
0.1u/10 R1331
IC1301 X1302 4 X2 3 C1356
0
A 6/6
A 4/6
A 2/6
A 5/6
4 GND2 C1389 0.01u/16
X2 3
R1424
GND2 10k
NM
NM
1000p/50
27k
NM
FLCS_1 1 CS 8
GNDUSB
VCC
GNDUSB
C1358
GNDD
C1387
R1339
R1422
SH-ANA BUS
R1419 2 SO/SIO1 7 R1349 C1336 1 2
FIO1_1 1 2 GND1 330p/50
SOC33_1
C1392
HOLD 1u/6.3 X1
GND1 CCG1192-A
R1387 4.7k
0 3 WP 6 0 X1 C1355
CSS1760-A 10u
100
NM
A-b 3/6
SCLK 0.01u/16
R1332
CSS1840-A SH_L
TAGGING
4 GND 5 R1256 48.00MHz
10p/50
10p/50
C1339
C1338
C1337
12p/50
C1340
SI/SIO0
12p/50
13.3333MHz C1357
GNDD
F
E
B
A
D
C
0 SH_R
L1304
R1253
CCG1192-A
VTL1129-A
MX25L8006EM2I-12G
0 10u
USB5
SH-SYS BUS
SHSTBY
SHRST
SHMUTE
L1303
DP
DM
AVH-X5500BHS/XNUC
Consists of
VTL1129-A
SOC33
SH-I/O BUS
SHRST
100
100
MOTHER PCB
R1337
R1348
SOC12
7
7
AVH-X5590BT/XNID
AVH-X5550BT/XNRI
AVH-X5550BT/XNRD
AVH-X5550BT/XNRC
MTCH_SCL0
MTCH_SDA0
INTERFACE PCB
AVH-X5500BT/XNEW5
LPSYNC
AVH-X5500BHS/XNUC
BLERR
GPSSHT
GPSOPN
A 1/6
INNER BUS
FIO0_1
FLCLK_1
V_SCL0
V_SDA0
CP_SCL
VDECSTUS
VDECCLK
VDEC_VD
CP_SDA
VDEC_HD
ASEMDJ
CPRST
CPPW
SERVICE UNIT(MOTHER I/F)
*
BCK
TDIJ
MCK
TCKJ
FLCS
FLCK
TMSJ
TDOJ
DATA
LRCK
DEEM
CPPW
TRSTJ
FLSIO1
FLSIO3
FLSIO2
FLSIO0
NM
CP_SCL
R1288
CP_SDA
ASEMDJ
ASEBRKJ
A, C
DACMUTE
IC1151
WM8761BGED
220
47
47
47
47
47
22
CPRST R1209
SOC33
14
R1252
R1259
R1260
R1258
R1257
R1251
1 LRCIN
C1287 MCLK
2 DIN 13
R1287
R1286
R1285
R1284
R1283
R1282
R1281
NM
NM
NM
NM
NM
NM
NM
FORMAT
1301 -
1281 -
1251 -
1201 -
1151 -
1101 -
1051 -
1001 -
NM
GNDD
ipod CP
R1262 NM 3 BCKIN 12
R1206
R1205
100
100
C1151 NM DEEMPH
11
DAC
R1261 NM
B, D~F CXX4927
CXX4926
4 NC1
C1152 NC2
5 CAP 10
USB(SH Decode):+2.2 dBs
: DAC
IC1202 MUTE
: JTAG
CCG1192-A 9 R1152
GNDD
6 VOUTR
SOC33_1
LSAR523UB
: FLASH
Q1201
10u
GNDD
10
11
12
13
14
15
16
VOUTL
: SDRAM
9
NC3 NC2 8 820
: IPOD CP
7 GND
: SH PART
SI
5 4 VDD
SCL PAD NC1
WP
C1156
GNDA
VIO
VSS
SCK
1800p/50
DNU2
DNU4
DNU3
6 3 C1153
A 3/6 MOTHER
RST SDA
9
8
7
6
5
4
3
2
1
12
11
10
FLASH
9
to JTAG JIG
IC1251
7 2 0.1u/10
GNDA
CXX4926
VCC GND
: RGB VIDEO ISO
NM
TDI
L1201
8 1
: VIDEO DECODER
TCK
C1154
2.2k
TMS
TDO
(SH BLOCK)
GND
GND
TRST
R1203
C1155
MDMP
CCG1192-A
A_RST
SOC33
1800p/50
337S3959
SO 8
CS 7
RFU 6
NC 5
DNU1 4
RESET 3
VCC 2
HOLD 1
C1202
R1201 2.2k
1000p/50
10u
ASEBRE
SOCRST
NM
PCB
C1252 R1151
L1251
R1254 820
CN1281
NM GND4 R1202 18k
CTF1786-A SOC33
L1151
NM C1201
GNDD
VD5
C1251
CTF1786-A
0.1u/10
GNDD
0.1u/10
8
8
A 3/6
125
E
A
D
C
F
B
4 3 2 1
126
AVH-X5500BHS/XNUC
178 NM VDCRST
PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5
PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5 177 VDEC_D7
PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H 176 C1344
Vcc13 175 0.1u/16 R1414 L1415 B0
PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1
100 VTL1126-A
Vss15 174
C1362
GNDD
PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G 173 56p/50 VDEC_D6
C1345
PVcc13 172
F
171 0.1u/16 VDEC_D5
PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F
L1413
170 C1363
A-b 3/6
PG16/WE2/ICIORD/DQMUL/LCD_DATA16/AUDATA0 R1412 VTL1126-A B1
100 L1411 56p/50
PG15/D31/LCD_DATA15/PINT7 169 R1410 VTL1126-A C1364 B2
L1409 56p/50
PG14/D30/LCD_DATA14/PINT6 168 R1408
100 VTL1126-A
C1365 B3
100 L1407 56p/50
PG13/D29/LCD_DATA13/PINT5 167 R1406 VTL1126-A B4
C1346 100 C1366
Vcc12 166 L1405 56p/50
0.1u/16 R1404 VTL1126-A B5
PG12/D28/LCD_DATA12/PINT4 165
100 C1367
Vss14 164 L1403 56p/50
R1402 VTL1126-A G0
PG11/D27/LCD_DATA11/PINT3/TIOC3D 163
C1347 100 C1368
PVcc12 162 L1401 56p/50
161 0.1u/16 R1400 VTL1126-A C1369 G1
PG10/D26/LCD_DATA10/PINT2/TIOC3C
100 L1399 56p/50
PG9/D25/LCD_DATA9/PINT1/TIOC3B 160 R1398 G2
C1370
IC1302
159 100 VTL1126-A
PJ4/DV_DATA4/LCD_DATA4/SD_CLK_1/PWM1E 56p/50 VDEC_D4
PJ3/DV_DATA3/LCD_DATA3/SD_D0_1/PWM1D 158 VDEC_D3
PJ2/DV_DATA2/LCD_DATA2/SD_D1_1/PWM1C 157 VDEC_D2
C1348
Vcc11 156
155 0.1u/16 R1396 L1397
PG8/D24/LCD_DATA8/PINT0/TIOC3A G3
100 VTL1126-A C1371
Vss13 154 56p/50
VDEC_D1
E
PJ1/DV_DATA1/LCD_DATA1/SD_WP_1/PWM1B 153
C1349
PVcc11 152
151 0.1u/16 VDEC_D0
PJ0/DV_DATA0/LCD_DATA0/SD_CD_1/PWM1A
PG7/D23/LCD_DATA7/IRQ7/TIOC2B 150 R1395 100 VTL1126-A L1394 C1372 G4
56p/50
PG6/D22/LCD_DATA6/IRQ6/TIOC2A 149 R1392 100 VTL1126-A L1393 C1373 G5
56p/50
PG5/D21/LCD_DATA5/IRQ5/TIOC1B 148 R1389 100 VTL1126-A L1391 R0
R1388 100 L1390 VTL1126-A R1
PG4/D20/LCD_DATA4/IRQ4/TIOC1A 147 R1386 100 L1387 VTL1126-A R2
C1350 C1374
Vcc10 146 56p/50
C1351
145 0.1u/16 C1375
PG3/D19/LCD_DATA3/IRQ3/TIOC0D 56p/50
2
12p/50
144 C1376
Vss12 56p/50
3 X2
143
GND1
AUDIO_X1
142 R1350
X1303
AUDIO_X2
CSS1794-A
1.5k C1352
PVcc10 141
X1
GND2
16.9344MHz
0.1u/16 C1353
4
1
PG2/D18/LCD_DATA2/IRQ2/TIOC0C 140 12p/50
Vss11 139 C1377
L1384 56p/50 R3
PG1/D17/LCD_DATA1/IRQ1/TIOC0B 138 R1385 100 VTL1126-A
C1354 R1382 R4
Vcc9 137 100 L1383 C1379
0.1u/16 VTL1126-A 56p/50
PG0/D16/LCD_DATA0/IRQ0/TIOC0A 136 R1380 L1381 R5
100 VTL1126-A C1380
Vss10 135
56p/50
D
TCK 134 TCKJ
TMS
133 TMSJ
TDI
TDO 132 TDIJ
ASEBRKAK/ASEBRK
131 TDOJ
TRST
130 ASEBRKJ
129 R1351
1k TRSTJ
INNER BUS
R1352
VIDEO_X1
VIDEO_X2
PVcc9
USBAPVss
USBAPVcc
Vss9
USBAVcc
USBAVss
REFRIN
VDAVcc
VDAVss
USBUVcc
USBUVss
1 8
USB_X1
USB_X2
AVref
VIN1
VIN2
PH7/AN7/PINT7
2 7
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
VRT 115
VRB 116
BIAS 117
PH0/AN0/PINT0 118
PH1/AN1/PINT1 119
PH2/AN2/PINT2 120
PH3/AN3/PINT3 121
PH4/AN4/PINT4 122
PH5/AN5/PINT5/LCD_EXTCLK 123
AVss 124
PH6/AN6/PINT6 125
AVcc 126
127
128
3 6
4 5
SH-I/O BUS
SH-SYS BUS
SH-TUN BUS
47k
A-a A-b
BLR 100k
NM
100k
NM
R1431
R1432
R1433
R1407
R1405
R1403
R1411
R1436
R1409
R1401
R1434
R1435
SH-POWER BUS
100k
100k
3216
2125
1608
NM
NM
NM
NM
100k
100k
R1327
C1330
C1328
C1327
C1326
R1325
R1336
C1325
C1324
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
24k F%
R1326 680
5 6k F%
NM
C1388
C1329 0.1u/16
330p/50
C1386
CHIP SIZE LEGEND
C
1000p/50
SC33
X1301
R1342
R1343
4 X2 3 C1356
A 6/6
A 4/6
A 2/6
A 5/6
GND2 C1389 0.01u/16
NM
NM
1000p/50
NM
GNDUSB
C1358
GNDD
C1387
R1422
SH-ANA BUS
1 2
GND1 330p/50
SOC33_1
X1
C1355 CCG1192-A
CSS1760-A 0.01u/16 10u
SH_L
48.00MHz
10p/50
10p/50
C1338
C1337
C1357
GNDD
F
E
B
A
SH_R
L1304
CCG1192-A
VTL1129-A
10u
L1303
Consists of
VTL1129-A
SOC33
MOTHER PCB
SOC12
AVH-X5590BT/XNID
AVH-X5550BT/XNRI
D AVH-X5550BT/XNRD
C AVH-X5550BT/XNRC
INTERFACE PCB
AVH-X5500BT/XNEW5
AVH-X5500BHS/XNUC
BLERR
GPSSHT
GPSOPN
A 1/6 B
VDECSTUS
SERVICE UNIT(MOTHER I/F)
BCK
MCK
DATA
LRCK
DEEM
DACMUTE
IC1151
WM8761BGED
220
CPRST R1209
SOC33
1 LRCIN 14
MCLK
2 DIN 13
FORMAT
1301 -
1281 -
1251 -
1201 -
1151 -
1101 -
1051 -
1001 -
ipod CP
3 BCKIN 12
C1151 NM DEEMPH
4 11
DAC
NC1
C1152 NC2
5 CAP 10
USB(SH Decode):+2.2 dBs
: DAC
IC1202 MUTE
: JTAG
CCG1192-A 6 9 R1152
VOUTR
LSAR523UB
: FLASH
Q1201
10u VOUTL
: SDRAM
NC3 NC2 7 8 820
: IPOD CP
GND
: SH PART
5 4 VDD
SCL PAD NC1
C1156
GNDA
1800p/50
6 3 C1153
A 3/6 MOTHER
RST SDA
7 9 2 0.1u/10
GNDA
VCC GND
: RGB VIDEO ISO
L1201
8 1
: VIDEO DECODER
C1154
(SH BLOCK)
C1155
CCG1192-A
1800p/50
337S3959
C1202
1000p/50
10u
R1151 PCB
820
A
L1151
GNDD
VD5
CTF1786-A
4 3 2 1
8 7 6 5
127
AVH-X5500BHS/XNUC
A2 15 PB3/A3/TIOC0C
R1317
USBFLG NM 16 PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
C1313 L1305
17 PVcc3
0.1u/16 VTL1126-A DAMT18
DACMUTE PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7
R1318
100k 19 Vss2
A3 20 PB4/A4/TIOC0D
R1319 C1314 21 Vcc2
F
DIMMER 100k 0.1u/16 R1418 22 PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK
R1420 0 23
A-b 3/6
GPSRST PJ17/DV_DATA17/LCD_DATA17/SSL00/TIOC0B/SIOFSYNC
USBCNT NM 24 PJ18/DV_DATA18/LCD_DATA18/MOSI0/TIOC0C/SIOFTxD
A4 25 PB5/A5/TIOC1A
A5 26 PB6/A6/TIOC1B
C1315 L1315
27 PVcc4
A6 0.1u/16 VTL1127-A 28 PB7/A7/TIOC2A
29 Vss3
A7 30 PB8/A8/TIOC2B
C1316 L1316 31
Vcc3
A8 0.1u/16 VTL1127-A 32
PB9/A9/TIOC3A
A9 33 PB10/A10/TIOC3B
IC1302
A10 34 PB11/A11/TIOC3C
A11 35 PB12/A12/TIOC3D
R5S72690RW266FP
MCK R1303 L1301 36 PJ19/DV_DATA19/LCD_DATA19/MISO0/TIOC0D/SIOFRxD/AUDIO_XOUT
0 C1309 CTF1786-A C1317 L1317 37 PVcc5
47p/50 0.1u/16 VTL1127-A SCS 38
SCS PJ20/DV_DATA20/LCD_DATA20/LCD_TCON3/IRQ0/CRx2/CRx0/CRx1/CRx2
BA0 R1353 39
0 Vss4
A12 R1354 40
E
PB13/A13/QIO2_1/SPBIO2_1
NM C1318 L1318
41 Vcc4
BA1 R1355
TPIRQN 0 0.1u/16 VTL1127-A 42
PJ21/DV_DATA21/LCD_DATA21/LCD_TCON4/IRQ1/CTx2/CTx0&CTx1&CTx2
0 0 R1341
STV2 R1428 R1347 100k TPIRQ 43 PJ22/DV_DATA22/LCD_DATA22/LCD_TCON5/IRQ2/CRx1/CRx0/CRx1
OEV R1429 0 R1356 0 44 PJ23/DV_DATA23/LCD_DATA23/LCD_TCON6/IRQ3/CTx1/CTx0&CTx1
BA0 R1357 NM 45 PB14/A14/QIO3_1/SPBIO3_1
BA1 R1358 NM 46 PB15/A15/QIO2_0/SPBIO2_0
C1319 L1319 47
FLSIO2 R1359 0 PVcc6
0 0.1u/16 VTL1127-A MT10 48
FLSIO3 R1360 PB16/A16/QIO3_0/SPBIO3_0
49 Vss5
FLCK 50 PB17/A17/QSPCLK_0/RSPCK0/SPBCLK
C1320 51 Vcc5
FLCS 0.1u/16 52 PB18/A18/QSSL_0/SSL00/SPBSSL
R1322
FLSIO0 47k 53 PB19/A19/QMO_0/QIO0_0/MOSI0/SPBMO_0/SPBIO0_0
FLSIO1 54 PB20/A20/QMI_0/QIO1_0/MISO0/SPBMI_0/SPBIO1_0
55 Vss6
56 PB21/A21/CRx2/IERxD
PB21
C1321 57 Vcc6
0.1u/16 58 PB22/A22/CTx2/IETxD/CS4
R1320
PB22
D
100k 59 PC0/CS0/MD_BOOT2
C1322 L1322 60 PVcc7
R1344 15 0.1u/16 VTL1127-A 61
SDCK CKIO
C1359 62
Vss7
NM R1321 63
100k PA0/MD_BOOT0
C1323 L1323 64 Vcc7
0.1u/16 VTL1127-A
PLLVss1
PLLVss2
PJ31/DV_CLK
PLLVcc
PE1/SDA0/TCLKB/AUDIO_CLK/DV_CLK
PVcc8
PVcc9
USBAPVss
USBAPVcc
Vcc8
USBAVcc
USBAVss
USBDPVcc
PE4/SCL2/RxD4/DV_VSYNC
PJ30/SSIDATA5/TIOC2B/IETxD
REFRIN
USBDVcc
USBDVss
USBUVcc
USBUVss
PE6/SCL3/RxD6
RTC_X1
RTC_X2
USB_X1
USB_X2
PE7/SDA3/RxD7
PE5/SDA2/RxD5/DV_HSYNC
EXTAL
PE0/SCL0/TCLKA/LCD_EXTCLK
XTAL
PE3/SDA1/TCLKD/ADTRG/DV_HSYNC
NMI
PE2/SCL1/TCLKC/IOIS16/DV_VSYNC
PJ28/SSISCK5/TIOC1B/RTS7
PA1/MD_BOOT1
PJ29/SSIWS5/TIOC2A/IERxD
65
66
67
69
72
73
74
75
76
77
78
79
Vss8 80
ASEMD 81
83
84
85
86
87
RES 88
89
90
91
USBDPVss 92
DM 93
DP 94
VBUS 95
96
97
98
99
100
101
102
103
104
105
106
68 R1384
NMI
1k
L1302
TP1301
C1334
CPPW
0.1u/16
1k
70 R1323 100
71 R1383 100
R1391
A-a A-b
82 CTF1545-A
C1385
C1384
C1332
100k
R1335
2.2k
R1333
R1324
C1333
R1328
C1331
R1327
C1330
C1328
C1391
0.1u/16
C1335
0.1u/16
0.1u/16
0.1u/16
0.1u/16
0.1u/16
NM
R1326 680
0
5.6k F%
47k
NM
R1338 100k
1u/6.3
0.1u/16
C1329 0.1u/16
GNDD
C1341
47k
47k
47k
C
100k
R1334
R1340
R1330
R1329
0.1u/10 R1331
IC1301 X1302 4
0
4 GND
X2 3
R1424
27k GND2 10k
FLCS_1 1 CS 8
GNDUSB
VCC
GNDUSB
R1339
R1419 2 SO/SIO1 7 R1349 C1336 1
FIO1_1 1 2
C1392
HOLD 1u/6.3 X1
GND1
R1387 4.7k
0 3 WP 6 0 X1 CS
100
NM
SCLK
R1332
CSS1840-A
TAGGING
4 GND 5 R1256 48
10p/50
C1339
C1338
12p/50
C1340
SI/SIO0
12p/50
13.3333MHz
0
R1253
MX25L8006EM2I-12G
0
USB5
SH-SYS BUS
SHSTBY
SHRST
SHMUTE
DP
DM
SH-I/O BUS
SHRST
100
100
R1337
R1348
MTCH_SCL0
MTCH_SDA0
LPSYNC
INNER BUS
B
FIO0_1
FLCLK_1
V_SCL0
V_SDA0
CP_SCL
VDECCLK
VDEC_VD
CP_SDA
VDEC_HD
ASEMDJ
CPRST
CPPW
*
TDIJ
TCKJ
FLCS
FLCK
TMSJ
TDOJ
CPPW
TRSTJ
FLSIO1
FLSIO3
FLSIO2
FLSIO0
NM
CP_SCL
R1288
CP_SDA
ASEMDJ
ASEBRKJ
A, C
220
47
47
47
47
47
22
CPRST R1209
SOC33
R1252
R1259
R1260
R1258
R1257
R1251
C1287
R1287
R1286
R1285
R1284
R1283
R1282
R1281
NM
NM
NM
NM
NM
NM
NM
NM
GNDD
R1262 NM
R1206
R1205
100
100
R1261 NM
B, D~F CXX4927
CXX4926
IC1
GNDD
SOC33_1
LSAR523UB
Q1201
GNDD
10
11
12
13
14
15
16
9
NC3
SI
5
SCL P
WP
VIO
VSS
SCK
DNU2
DNU4
DNU3
6
RST
9
8
7
6
5
4
3
2
1
12
11
10
FLASH
to JTAG JIG
IC1251
7
CXX4926
VCC
NM
TDI
L1201
8
TCK
2.2k
TMS
TDO
GND
GND
TRST
R1203
MDMP
A_RST
SOC33
337S3
SO 8
CS 7
RFU 6
NC 5
DNU1 4
RESET 3
VCC 2
HOLD 1
C1202
R1201 2.2k
1000p/50
ASEBRE
SOCRST
NM
C1252
L1251
R1254
CN1281
NM GND4 R1202 18k
A
CTF1786-A
SOC33
NM C1201
GNDD
C1251
0.1u/10
GNDD
0.1u/10
8 7 6 5
F
E
B
A
D
C
128
A-a A-b
A-b 3/6
A-a 3/6
1
1
RGB VIDEO ISOLATOR
DD5
INNER BUS
DEEM
VDCRST
10u
VDEC_D7
VDEC_D6
VDEC_D5
L1005
SH-I/O BUS
Q1003
B0
B1
L1001 LSCR523UB
POL
CLK
DIO
R1011
VCLK
LOAD
CTF1545-A 15p/50 PLSEN
GPSON
C1006
10u 10V
100
PLSDATA
SH-SYS BUS C1382
CCG1192-A
GNDV
0
GNDD
C1001
R1381
SH-POWER BUS
C1363
0.1u/10
IC1001
1 5 C1010 GNDSIG
GNDV
6p/50
C1383
C1362
56p/50
Q1002 2 1u/10 SH-TUN BUS
L1004 GNDV GND
LSCR523UB R1012 L1006 C1011
3 4 CSYNC
CTF1545-A VCC
0
NM
NM
100 NM C1005 N_CSYNC 1u/10
R1378
C1378
L1378
0.1u/10 SH-ANA BUS GNDD
BH7673G
NM
2
2
IC1002
C1381
C1002
1 5 C1012 GNDSIG
0.1u/10
L1413
L1415
L1306
0
L1377
2 1u/10
VTL1126-A
VTL1126-A
GNDV
VTL1127-A
GND
NM
L1007 3 4 C1013
0
GNDV
VTL1126-A
ANR
R1362
Q1001 VCC
R1427
NM
NM
NM C1007
R1426 0
L1002 LSCR523UB N_R 1u/10
0
R1010 0.1u/10 R1013
BH7673G C1014
0
100
CTF1545-A
R1364
R1363
iCOMP
330 R1425
R1416
R1414
100
0
100 iPodVideo 1u/10
IC1003 26pim
R1379
47p/50
C1360
R1412
1 5 C1015 GNDSIG
R1365
R1376
2 1u/10
C1003
GNDV GND
0.1u/10
L1008 3 4 C1016 ANB
C1008 VCC
100
NM N_B 1u/10
C1342
C1343
C1344
C1345
0.1u/10
R1393
C1390
10p/50
0.1u/16
0.1u/16
0.1u/16
0.1u/16
GNDV BH7673G only A, D
Q1004 IC1004
L1003 LSCR523UB
R1009 1 5 C1017 GNDSIG
CTF1545-A
100 2 1u/10
GNDV GND
L1009 3 4 C1018 ANG
VCC PG18
AVH-X5500BHS/XNUC
NM C1009 N_G
0.1u/10 1u/10 PG19
BH7673G
C1004
0.1u/10
191
184
182
189
192
190
187
186
185
183
179
178
176
172
171
170
188
MONVBS
GNDV
Vcc14
Vss16
Vcc13 175
Vss15 174
3
3
PVcc14 180
PVcc13
FLCLK_1 193
C1301 194
PG24/LCD_CLK
0.1u/16 FCS1
PG26/LCD_TCON1
PG25/LCD_TCON0
195
PG27/LCD_TCON2
/LCD_EXTCLK
VIDEO DECODER FLCS_1
196 PF0/BREQ/QSPCLK_1/RSPCK1
/TIOC4A/DREQ0/AUDCK
FIO0_1 197 PVcc15
56p/50 PF1/BACK/QSSL_1/SSL10
FIO1_1 198
PG21/DV_DATA7/LCD_DATA21
/LCD_TCON4/TxD4/AUDATA2
C1361 /TIOC4B/DACK0
PG20/DV_DATA6/LCD_DATA20 181
/LCD_TCON3/RxD4
PG19/DV_DATA5/LCD_DATA19
/SPDIF_OUT/SCK5
PG22/LCD_DATA22/LCD_TCON5
/RxD5/AUDSYNC
PG23/LCD_DATA23/LCD_TCON6
/TxD5/AUDATA3
R1390 R1308 199 Vss17
L1052 BCK NM PF2/WAIT/QMO_1/QIO0_1/MOSI1
VDEC15 VDEC33 /TIOC4C/TEND0/SPBMO_1/SPBIO0_1
LRCK NM R1309 200
NM
PF3/CS2/QMI_1/QIO1_1/MISO1/TIOC4D
0
NM
NM
NM
DATA R1310 201 /AUDIO_XOUT/SPBMI_1/SPBIO1_1
NM
100
0
0
202 PF4/CS5/CE1A/SSISCK0/SGOUT_0
C1077
SYStoSH
PJ6/DV_DATA6/LCD_DATA6/SD_D3_1/PWM1G 173
PJ7/DV_DATA7/LCD_DATA7/SD_D2_1/PWM1H
C1065
C1067
0.1u/10
PG18/DV_DATA4/LCD_DATA18/SPDIF_IN/SCK4
0.1u/10
PF5/SSIWS0/SGOUT_1
R1076
R1077
PJ5/DV_DATA5/LCD_DATA5/SD_CMD_1/PWM1F
R1302
PJ9/DV_DATA9/LCD_DATA9/PINT1/PWM2B/RTS5
PJ8/DV_DATA8/LCD_DATA8/PINT0/PWM2A/CTS5 177
R1080
GNDD SHtoSYS 27k 203 PF6/CE2A/SSITxD0/SGOUT_2
R1079
R1087
GNDV
PG16/WE2/ICIORD/DQMUL/LCD DATA16/AUDATA0
PF9 PF7/SSIRxD0/RxD0/SGOUT_3/CTS1
R1397 NM 204
C1084 R1078 BCLK PF8/A23/TxD0
PG17/WE3/ICIOWR/AH/DQMUU/LCD_DATA17/AUDATA1
C1302
NM
205 PF9/BS/DV_DATA0/SCK0/MMC_D4/RTS1
NM NM R1394
Q1051
LRCLK NM PF10 PVcc16
10u
0.1u/16
10u
206
NM
R1399 NM PF10/CS1/SSISCK1/DV_DATA1/SCK1/MMC_D5
R1086
C1072
C1076
DATA_BT
2.2k
2.2k
207
R1074
R1075
Vss18
CCG1192-A
CCG1192-A
VDEC15 GPStoSH R1366 208 PF11/SSIWS1/DV_DATA2/RxD1/MMC_D6
V_SCL0
VDEC33 NM R1373
GNDV 32.000MHz V_SDA0 SHtoGPS R1367 NM 209 PF12/SSIDATA1/DV_DATA3/TxD1/MMC_D7
C1071 NM
5p/50 VDEC_FLD 210 PF13/A24/SSISCK2/SCK2
75
R1377
1
4
4
211
0
BTTOSH R1368
4
NM PF14/A25/SSIWS2/RxD2
R1051
C1062
1u/10
R1052
1
4
R1083
NM
470
SHTOBT R1421 212 PF15/A0/SSIDATA2/WDTOVF/TxD2/UBCTRG
R1059
X1051
NM C1303 213 PVcc17
PLSCLK R1369 0.1u/16 214 PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5
CSS1818-A
10u
4.7k
C1057
C1058
C1060
C1063 10u
C1064
R1053
0.1u/10
NM 215
2
3
1M
Vss19
0.01u/16
1000p/50
CCG1192-A
2
100
100
CCG1192-A
R1071
SHIRQ 216 PF16/SD_CD_0/FCE/IRQ4/MMC_CD
R1058
R1055
R1056
47k SYS P.DW R1374 NM
BGSENS1 217 PF17/SD_WP_0/FRB/IRQ5
5p/50 3
C1075
C1070
0.01u/16 NM
64
63
61
60
59
58
57
56
55
54
53
52
51
49 R1375 218
100 PCHANG PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1
C1083 1 48 R1072 PJ11
GNDD C1085 VDCRST 219 PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6
SAS
SCL
SDA
1u/10 2 47 R1073 L1051 VDECCLK MTCHRST R1304 220 PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7
AGND4
AVDD4 62
CVBS4
CVBS3
CVBS2
CVBS1
DGND5
XOSCO 50
XOSCI
GIN1
75
NM
5p/50
PGND_A
PVDD_A
C1054 0.01u/16
R1088
3 GIN2 46 CTF1740-A NM R1305 120 221
DVDD_C5
R1085
100 USB_SW PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
DVDD_IO4
C1055 AVDD1 RESETN
4 CLKO 45 C1073 0.1u/10 only A, D C1304 222 PVcc18
1000p/50 AGND1 DVDD_IO3 R1306
5 C1074 0.1u/10 100k 0.1u/16 223
C1082 DGND4 44 BLEN PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0
BIN1 R1345
4
9
1 /10 6 DVDD C4 43 R1060
PLSCLK 214 PJ10/DV_DATA10/LCD_DATA10/PINT2/PWM2C/SCK5
CS
10
4.7
C10
C10
C10
C10
C10
R10
0.1u
NM 215
2
3
1M
Vss19
0.01u/
1000p/
CCG11
2
100
100
CCG11
R1071
SHIRQ 216 PF16/SD_CD_0/FCE/IRQ4/MMC_CD
R1058
R1055
R1056
47k SYS P.DW R1374 NM
BGSENS1 217 PF17/SD_WP_0/FRB/IRQ5
5p/50 3
C1075
C1070
0.01u/16 NM
64
63
61
60
59
58
57
56
55
54
53
52
51
49
PCHANG R1375 218 PF18/SD_D1_0/SSISCK3/IRQ6/MMC_D1
100
C1083 1 48 R1072 PJ11
GNDD C1085 VDCRST 219 PJ11/DV_DATA11/LCD_DATA11/PINT3/PWM2D/SCK6
SAS
SCL
SDA
1u/10 2 47 R1073 L1051 VDECCLK MTCHRST R1304 220 PJ12/DV_DATA12/LCD_DATA12/PINT4/PWM2E/SCK7
AGND4
AVDD4 62
CVBS4
CVBS3
CVBS2
CVBS1
DGND5
XOSCO 50
XOSCI
GIN1
75
NM
5p/50
PGND_A
PVDD_A
C1054 0.01u/16
R1088
3 GIN2 46 CTF1740-A NM R1305 120 221
DVDD_C5
R1085
100 USB_SW PJ13/DV_DATA13/LCD_DATA13/PINT5/PWM2F/TxD5
DVDD_IO4
C1055 AVDD1 RESETN
4 CLKO 45 C1073 0.1u/10 only A, D C1304 222 PVcc18
1000p/50 AGND1 DVDD_IO3 R1306
5 C1074 0.1u/10 100k 0.1u/16 223
C1082 DGND4 44 BLEN PF19/SD_D0_0/SSIWS3/IRQ7/MMC_D0
BIN1 R1345
1u/10 6 DVDD_C4 43 R1060 390 VDEC_D7 47k 224
BIN2 Vss20
75
NM
C1056 7 DO7 42 PF20
225
R1084
R1089
REF
R1061 390 VDEC_D6 PF20/SD_CLK_0/SSIDATA3/MMC_CLK
DO6
C1051 0.01u/25 8 41 R1062 390 VDEC_D5 C1305 226
REFP IC1051 DO5 Vcc15
0.47u/6.3 9 ML86V7675TBZ03A 40 R1063 390 VDEC_D4 ADCCL R1370 0.1u/16 227
C1052 REFN DO4 PF21/SD_CMD_0/SCK3/MMC_CMD
5
C1053
NM
5
10 39 R1064 390 VDEC_D3 ADCDA R1371 228 PF22/SD_D3_0/RxD3/MMC_D3
0.47u/6.3
0.47u/6.3 AGND2 DO3 NM
11 TAOUT DO2 38 R1065 390 VDEC_D2 ADCON R1372 229 PF23/SD_D2_0/TxD3/MMC_D2
C1078 DO1 NM
GNDV 1u/10 12 RIN1 37 230
DO0
R1066 390 VDEC_D1 D0 PD0/D0/PWM1A
RIN2
13 AVDD3 VSYNC_L 36 R1067 390 VDEC_D0 C1306 231
C1081 HSYNC_L PVcc19
AGND3 SSCK
0.1u/16
75
NM
14 CSYNC_A FID 35 R1068 220 VDEC_VD SSCK 232 PJ24/SGOUT_0/SSISCK4/LCD_TCON3/SPDIF_IN/SCK7
1000p/50
R1082
R1090
C1080 15 34 R1069 220 VDEC_HD 233 Vss21
0.01u/16 16 33 R1070 560 VDEC_FLD D1 234 PD1/D1/PWM1B
DVDD_C1
DGND1
DVDD_IO1
CHSI
VSI
TEST1
TEST2
TEST3
DVDD_C2
DGND2
SLEEP
STATUS
DVDD_C3
DGND3
DVDD_IO2
DE
C1079 D2 235 PD2/D2/PWM1C
1u/10
75
NM
236
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
D3 PD3/D3/PWM1D
R1081
R1091
R1057 SDI
VDECSTUS SDI 237 PJ25/SGOUT_1/SSIWS4/LCD_TCON4/SPDIF_OUT/RxD7
560 SDO
SDO 238 PJ26/SGOUT_2/SSIDATA4/LCD_TCON5/TxD7
BLSYNC R1423 239
GNDV GNDD PJ27/SGOUT_3/TIOC1A/CTS7
2.2k C1307 240 PVcc20
R1430
0.1u/16 241 Vss22
47k
NM
R1054
C1059
C1061
C1066
C1068
C1069
242
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10
D4 PD4/D4/FRE/PWM1E
D5 243 PD5/D5/FCLE/PWM1F
D6 244 PD6/D6/FALE/PWM1G
D7 245 PD7/D7/FWE/PWM1H
GNDD
D8 246 PD8/D8/NAF0/PWM2A
6
6
D9 247 PD9/D9/NAF1/PWM2B
SOC33 D10 248 PD10/D10/NAF2/PWM2C
SDRAM PD11/D11/NAF3/PWM2D
D11 249
C1308 PVcc21
250
PD12/D12/NAF4/PWM2E
D12 0.1u/16 251 Vss23
L1101
252 PD13/D13/NAF5/PWM2F
CTF1786-A
PD14/D14/NAF6/PWM2G
IC1101 D13 253
PD15/D15/NAF7/PWM2H
C1101 1 54
D14 254 MD_CLK0
0.1u/10 VDD1 VSS3
2 53 255
R1101 DQ0 DQ15 R1108 D15
D0 C1102 3 52 D15 R1301 MDCLK
VDDQ1 VSSQ4 256
5 4 0.1u/10 4 51 5 4
D1 D14 NM
DQ1 DQ14
6 3 5 50 6 3
D2 D13
DQ2 DQ13
47k
7 2 C1106 7 2
R5S7269*
6 49
PVcc
R1307
D3 D12
PC1/RD
PVcc1
PC2/RD/WR/SCK6
PC3/WE0/DQMLL/RxD6
PC4/WE1/WE/DQMLU/TxD6
PC5/RAS/CRx0/CRx0/CRx1/CRx2/IRQ0
PVcc2
PC6/CAS/SCK7/CTx0/CTx0&CTx1&CTx2
Vss1
PC7/CKE/RxD7/CRx1/CRx0/CRx1/IRQ1
Vcc1
PC8/CS3/TxD7/CTx1/CTx0&CTx1
PB1/A1/TIOC0A
PB2/A2/TIOC0B
PB3/A3/TIOC0C
PJ14/DV_DATA14/LCD_DATA14/PINT6/PWM2G/TxD6
PVcc3
PJ15/DV_DATA15/LCD_DATA15/PINT7/PWM2H/TxD7
Vss2
PB4/A4/TIOC0D
Vcc2
PJ16/DV_DATA16/LCD_DATA16/RSPCK0/TIOC0A/SIOFSCK
PJ17/DV DATA17/LCD DATA17/SSL00/TIOC0B/SIOFSYNC
VSSQ1 VDDQ4
8 1 0.1u/10 8 1
1
2
3
4
6
7
8
9
7 48
5
220 220
10
11
13
14
15
16
17
19
20
21
22
23
DQ3 DQ12
8 47
R1102 DQ4 DQ11 R1109
C1103
DAMT 18
D4 9 46 D11
VDDQ2 VSSQ3
L1313
5 4 0.1u/10 10 45 5 4
D5 D10
AVH-X5500BHS/XNUC
VTL1127-A 12
DQ5 DQ10
6 3 11 44 6 3
0
D6 D9
DQ6 DQ9
NM
NM
4.7k
4.7k
4.7k
4.7k
C1310
R1346
L1311
R1311
R1313
L1312
R1315
R1316
R1317
R1318
100k
0.1u/16
R1418
L1305
7 2 12 43 C1107 7 2
D7 D8
VTL1127-A
VTL1127-A
VSSQ2 VDDQ3
VTL1126-A
7
7
8 1 13 42 0.1u/10 8 1
220 DQ7 DQ8 220
C1104 14 41 R1106 470 UDQM
R1103 VDD2 VSS2
470
C1311
C1312
C1313
C1314
R1420
0.1u/16
0.1u/16
LDQM 0.1u/10 15 40 L1107 SDCK
0.1u/16
0.1u/16
LDQM NC2
5 4 16 39 CTF1645-A
WE
WE UDQM C1108
6 3 17 38
CAS 47p/50 R1112
CAS CLK CKE
4.7k
4.7k
R1312
R1314
7 2
100k
18 37
NM
R1319
RAS 470
RAS CKE
R1361
1 R1110 470
SDCS R1104 8 470 19 36 R1113 A12 SH-TUN BUS
CS NC1
5 4 20 35 5 4 NM
BA0 A11
BA0 A11
6 3 21 34 6 3
BA1 A9
BA1 A9
USBFLG
7 2 22 33 7 2 SH-POWER BUS
A10 A8
A10_AP A8
8 1 23 32 8 1
A0 A7
A0 A7
5 4 24 31 5 4
A1 A6 SH-SYS BUS
A1 A6
6 3 25 30 6 3
A2 A5
A2 A5
7 2 26 29 7 2
A3 A4
A3 A4
8 1 C1105 27 28 8 1
R1105 470 VDD3 VSS1 R1111 470
CPLDRST
DIMMER
GPSRST
0.1u/10 SH-I/O BUS
M12L128168A-5TG2N
GNDD
WE
LDQM
UDQM
RAS
CAS
CKE
SDCS
A0
A1
A2
DACMUTE
A3
8
8
INNER BUS
A-a A-b
A-a 3/6
A-b 3/6
129
E
A
D
C
F
B
1 2 3 4
10.4 MOTHER PCB (POWER SUPPLY BLOCK)
1
2
A LSCR523UB
18.0V
V18HI CN1831
12.3V Q1853
R1853 270k V18 NM
EV12
Q1851
3 4 D1852
EV12 Q1852 L1851
NM
R1856 2 14.1V R1864 FAN
3 4 5 NM NM
CCG1244-A-T
0
R1858
47u
NM
R1851
R1865
R1857
NM
680
R1852 22k
68k
2 1 6
NM
10u/6.3
RN4982
C1855
C1856
5 Q1854 IC1851
NM
R1854
NM (D)
NM C1858
27k
1 6 D 8 1
4.7u 25V
Q1855
C1853
FB EaIn
NM (D)
NM
NM
NM
NM
NM
R1859
NM
HN1B04FU(YGR) NM 7 2
NM
GNDA G
C1860
R1863
C1861
OSC SCP
HZU13(B1)
NM
NM
C1851
D1851
C1852
C1854
0.1u/16
NM
6 3
GND Vcc
C1831
C1832
C1833
R1831
R1836
S 5 4
Out BR/CTL
NM (D)
R1866
10
R1860
C1857
R1861
R1862
C1859
NM
NM
NM
NM
4.7u
NM
GNDA
GNDA 12.3V GNDFAN
Q1856
RN1907
DD5 1 6 GNDHI
5
R1868 GNDA
2
10k 3 4
B GNDA only A
1.2V 3.3V
IC1922 IC1911 IC1901
NJM2886DL3-33 NJM2886DL3-05
TUN12 NM
TUN33 TUN5
5.0V
CONT
CONT
VOUT
VOUT
2 GND
GND
GND
3 Vout
VIN
VIN
TUN5
1 Vin
NC
NC
TUN12 TUN33
TU11 IC1921 TUPW TU33 TU5
5
4
3
2
1
5
4
3
2
1
1 6 D1921 D1911 D1901 D1902 L1901
CCG1192-A
VOUT VIN
CCG1218-A-T
CCG1201-A
2 5 CRG03 NM NM CRG03 NM
10V
C1912
C1902
CCG1201-A
C1921
C1911
2.2u/10
C1922
C1923
C1924
D1922
C1901
CCG1218-A-T
VSS1 VSS2
4.7u 10V
1u/10
NM
NM
1u/10
NM
3 4
10u
ON/OFF NC
4.7u
S-1172B12-E6
R1903 GNDD
R1902 0 except A
GNDRF
GNDD 0 R1901 0
only A
DAB33 RFVCC33
IC1931
RFVCC33 L1902 P1911
3.3V 1 6 D1904
VOUT VIN 1 2
R1904 NM
2 5 NM CRG03
CCG1201-A
CCG1201-A
NM
2
4.7u
4.7u
C1904
CEK1381-A
VSS1 VSS2
C1905
>
(2.5A)
P1951
3 4
(1A)
1.25V 3.3V
C
ON/OFF NC
SOC12 SOC33
1
NM 0
IC2011 R2003
SOC12 SOC33
BD00IA5WEFJ IC2001
R1905
1k
NM GNDRF
SC12
1
VO VCC
8 1
VOUT VIN
6
FIN
R2011 R2012
2 7 2 5
R2001 NM
9
22k
FB NC
C2003
C2001
VSS1 VSS2
C2002
NM
NM
NM
C2012
C2011
1u/10
3 6 3 4
1u/10
IC2061 GND NC ON/OFF NC
IC2051 R2052 4 5
NJM2856DL3-18
4.7k
1.8V NC EN
3.3V NM NM
0
CONTROL
BT18 BT33 R2013
CONT
VOUT
GND
GND
47k
VIN
VIN
NC
VO
NC
BT18
R2002
BT33
NM
BT18 BT33 GNDD
5
4
3
2
1
5
4
3
2
1
GNDD
D2051 P2051 8.1V
1 2
NM NM DD8
1000p/50
C2052
22u/16
CCG1201-A
C2051
0 1u/10
NM
(0.5A)
4.7u
C2061
C2062
R2024
TPN33
R2051
1u/10
NM
3.3V
1.5V
D2052 GNDD TPN33
R2022 0
P2052 VDEC15
C1957
C1958
GNDD NM NM
D 1
NM
2
VDEC15 VDEC33 4
VOUT NC
3
IC2031 VDC33 GND
R2021 NM
5.2V 5.18V 5 1 R2031 2
VIN CONT VIN CONT
C2021
1k
R2023
2 5 1
NM
NM
VDC15
CCG1192-A
For LS2 Mecha
PWRVI VD5 GND
C2023
4 3 IC2021
10u
VOUT NC
PWRVI
> VD5
C2022
>
C2031
C2032
1u/10
1u/10
NM
NJM2878F3-15
PVI VD5
P2081 L2071 P2071
1 2 1 2
CEK1380-A NM CEK1382-A
C2081
C2082
C2083
C2071
NM
NM
0.1u/10
0.1u/10
(0.75A) Fast acting
GNDD GNDD
Fuse
(1.25A)
GNDD
GNDD
D2162
5.0V RSX201L-30
R2179
USB5
USB5
NM L2161
USB5
R2171 CTH1524-A
VD8 For LS2 Mecha
CTF1793-A
10u
2SD1760F5(QR)
C2175 R2175
ACN7160-A 6.4V
L2162
DCH1256-A
NM
1k
1k
1k
1k
E 0.056 ohm
C2163
C2185
C2186
100u/16
0.1u/16
8.1V
> MOTV
105
VD8
R2162
R2161
R2170
R2163
DB2X41400L
NM
22u
Q2131
M8V P2151 MOTV
MTV
1 2
D2161
IC2161 D2132
CEK1385-A
GNDD 1 NC1 24 (2.5A) NM
LX
2 RSO 23 Fast acting fuse R2132
PGND
RKZ6.2KG(B2)
3 NC2 22 C2161 120
D2131
BT
4 PVCC1 21 GNDD 0.1u/16 ILMB
C2131
C2132
R2131
100u/16
BTVCC
1u/10
47k
5 PVCC2 20 C2167 R2133
ILMB
>
C2162
C2172
TL 8.1V
10u/35
47u/16
R2172 6 VCC 19 0.1u/16 22
105
FLAG ILL8 Q2132
P2152 LTC014EEB
C2133
0 7 NC3 18 R2176 R2165
0.1u/10
C2173
0.1u/16
RADJ 1 2
8 RSIN 17 NM 47k (D) 365.8/413.9kHz CEK1383-A
C2151
GNDD SYNC
0.1u/16
C2170 9 VREG 16 (1.5A)
33k (D)
C2168 R2166
R2178 R2167
27p/50 EN
1.5k
C2165 Fast acting fuse
10 SGND 15
CT
R2169 C2169 11 COMP 14 1000p/50
RT
470p/50
R2164 220k GNDD
7.5k 2200p/50 GNDD12 FB 13
0
SS C2166
4700p/25
AN33014UA R2174 R2173 GNDD
R2177
only A, D
0
200k 390k
C2164
F
1u/10
8.2k (D)
C2152
R2168
1000p/50
GNDD
GNDD
A 4/6
AVH-X5500BHS/XNUC
130
1 2 3 4
5 6 7 8
CN1831 A
NM
FAN Q1831
NM
(1.0A)
P1831
8.1V
DD8
CHIP SIZE LEGEND
1608
2125
1801 -
1821 -
: VDD33
: SYS+B
2001 -
2051 -
: SOC
: BT
A 4/6 MOTHER PCB
(POWER SUPPLY BLOCK)
4 3
4 3 1 2 1851 - : EV12 2101 - : DDC33
5 2 3216
5 2 R1832 1901 - : TUN 2161 - : USB5
6 1
6
NM
1 NM 1951 - : DDC 5/8
NM
NM
NM
NM
NM
BUP_1
only A > SYS+B VDD33
C1831
C1832
C1833
R1831
IC1821
R1836
IC1801
2
PWR-I/O BUS
CEK1380-A
(0.75A)
NJM2387ADL3 NJW4181U3-33B
A 5/6
2SD1664(QR)
2SB1132(QR)
P1901
BUP_1 9.0V 3.3V
CONT
VOUT
1 VOUT
VADJ
DABSX12 SYS+B VDD33
GND
2 GND
BUP_1
BT18ON
VIN
3 VIN
1
Q1901
Q1903
GNDFAN VD33 VDIN
PWR-SH BUS
1
2
3
4
5
D1801
SYB
1SR154-400 A 3/6
USBCNT
USBFLG
R1906
R1911
910
10k
0.01u/25
R1823
1000u/16
0.1u/10
R1909
C1805
C1801
C1802
C1803
C1804
PWR-SYS BUS
(F) 100k
47u/16
0.1u/50
NM
10k
A 2/6
105
105
RKZ16KG(B2)
MOTPW2
ANTPW
SYSPW
FAN_PWM
DDCERR
DDCCLK
R1907
TU1VON
TU3VON
ANTSENS
VDCNT8
VDCNT5
B
C1821
C1822
HIOUTCLK
D1903
C1903
100u/16
1/4W
1u/16
R1822
0.1u/16
470
82k
105
C1906
R1910
C1907
NM
(D) 18k
1/4W
470
R1908
R1824
15k
GNDD
Q1902
LTC014EEB
R1821
GNDA
NM
GNDD
DDIN L1953
P1952 CTH1486-A D1953
2
CEK1381-A
1 2
> 10uH
P1951
NM RSX201L-30
(1A)
C1977
C
C1975
C1982
1000p/50
NM
3300u/16
C1979
10u/35
Slow Blow Fuse D1954
DDC 5/8 (4.5A)
1
105
RSX201L-30
GNDD
0.047u/50
1000p/50
C1962
C1963
C1964
C1965
C1967
C1968
10u/35
10u/35
10u/35
NM
C1973
NM
IC1951
CCN1321-A
0.012 ohm
R1962
AN33012UA
CCN1341-A
47u 10V
0.011 ohm
1 VCC 24
R1959
10u/35
10u/35
10u/35
10u/35
VCC_S2 Q1952 3 S
Q1951 2 VCC_S1 23 SFT1342
RS2
S 3 SFT1342 3 RS1 22
HSD1 HSD2 1
CCG1229-A-T
CCG1236-A-T
CCG1236-A-T
CCG1236-A-T
CCG1236-A-T
8.1V 4 HSD1 21 C1970 0.1u/16 G
1 SS2
DD8 G C1969 5 SS1 20 D 5.2V
1000p/50
GNDD PGND
0.1u/10
2
0.1u/10
D R1964 C1955 0.1u/16 6 COMP1 19 C1952 R1956 DD5
L1951 2 COMP2
CTH1446-A 4.7k 0.01u/16 7 FB1 18 0.01u/16 12k L1952
R1968 FB2
510 C1956 C1951 R1952 CTH1519-A
10uH 8 EN1
VREG
17
15u
8p/50
C1953
C1954
1000p/50 470p/50 560
C1972
8p/50
9 EN2 16
1u/10
SGND R1953
RB056L-40
1000p/50
CCG1229-A-T
RB056L-40
3225size
47u 10V
C1957
C1958
C1959
C1960
C1961
D1951
D1952
C1974
C1976
C1978
C1980
C1981
R1967 10 CT 15
R1955 R1954
R1965
3225size
10k RT 33k
D
4.3k
300 1.1k
(D)
(D) 11 TL_CTRL 14 (D)
R1957 10k
(D)
TL
12 FLAG 13
0.1u/10
0.1u/10
C1971
R1963
C1966
R1958
SYNC
220k
R1966
NM
3.6k
(D)
(D)
R1969
NM
R1951 R1960 200k GNDD GNDD
NM R1961
390k 365.8/413.9kHz
3.3V
DDC33
DDC33 IC2101
DDC33 L2101
CTH1524-A R2105
2SD1760F5(QR)
1 8
10u LX
2 7
VCC C2106
E
RB056L-40
C2102
0
>
0.01u/16
9
47u/16
C2109
C2101
D2101
10u/35
GND BST 0.01u/16
C2107
C2108
0.01u/25
3 6
10u/35
Q2131
VC FIN EN
2
4 5
CEK1384-A
FB SYNC
P2131
C2104 NM
D2132
(2A)
6800p/25
C2103 BD9876EFJ
C2105
NM GNDD
1
R2132 NM GNDD
120 R2101 R2102
22k (D)
D2131
R2103
R2104
3.6k 47k
2.2k
1000p/50
C2134
R2133 (D) (D)
365.8/413.9kHz
22
Q2132
LTC014EEB GNDD
0.1u/10
GNDD
A AVH-X5500BHS/XNUC
B AVH-X5500BT/XNEW5
SERVICE UNIT(MOTHER I/F) C AVH-X5550BT/XNRC The > mark found on some component parts indicates
Consists of D AVH-X5550BT/XNRD the importance of the safety factor of the part. F
MOTHER PCB E AVH-X5550BT/XNRI Therefore, when replacing, be sure to use parts of
INTERFACE PCB F AVH-X5590BT/XNID identical designation.
A 4/6
AVH-X5500BHS/XNUC
5 6 7 8
131
F
E
B
A
D
C
132
A 5/6
1
1
BT18
BT33
A 4/6
A 3/6
A 2/6
A 1/6
RT1 RT1
NM
R1673
C1672
10u
U1671
RT2 RT2
NM
DUMMY
CWX4306-A
CCG1192-A
R1672
GNDD
GNDD
C1680 NM
C1681 0.1u/16
C1673 10u
CCG1192-A
INNER BUS
BT18ON
I/O-POWER BUS
R1682
I/O-SH BUS
C1677 NM R1674 BTRST
I/O-ANA BUS
I/O-SYS BUS
0.01u/16 100
R1676 R1671 R1686 BTTOSYS
NM 0
CKN1091-A
R1675 R1677
JA1601
NM R1687 SYSTOBT
USB5
DBGT
DBGR
NM 100 0
R1688 NM BTTOSH C1601
CTF1713-A
C1689 C1684 R1601 NM 1 USB5V
0.1u/10 NM 0.1u/50
GNDD
R1689 NM SHTOBT D+ 44 3 3
2 USB_D-
R1694 NM DATA_BT
GNDD
C1688 C1687 D- 3 USB_D+
R1695 NM BCLK R1602 NM
100p/50 CCG1192-A D1602
GNDD
R1685 BTANAR 11 2 2 4 USBGND
10u L1601
GNDD
USB IF
820 R1696 NM LRCLK EZAEG2A50AX RT1 Shield1
LINEOUT_L
LINEOUT_R
RT2 Shield2
UART_AT_TX
UART_AT_RX
BT33V
BT18_EN
D1601
UART_DBG_TX
BT18V
UART_DBG_RX
BT18V
7
6
5
4
3
2
1
VSS
nRESET
C1683
1800p/50
GNDD
EZAEG2A50AX
DIN
NC1
CAP
GND
LRCIN
BCKIN
VOUTR
GNDA
1 24
2 23
3 22
4 21
5 20
6 19
7 18
8 17
9 16
10 15
11 14
12 13
CKS6346-A
IC1671
CN1671
NM
R1691
VOUTL
WM8761BGED
NC2
FORMAT
MCLK
R1678
DEEMPH
MUTE
VDD
VSS
1k
I2S_IN
MIC1_P
MIC1_N
8
9
BOOTS
10
11
12
13
14
MIC2_P
I2S_CLK
MIC2_N
BT MODULE
I2S_OUT
R1679
I2S_MCLK
I2S_SYNC
MIC_BIAS
GNDA
1k
2
2
C1685
C1674
BT-HF:+2.2 dBs
BT-Audio:+2.2 dBs
0
0
0
NM 0.1u/10
C1682 L1672
C1678
C1679
R1692
R1693
R1690
C1675
VD5
BBOT
NM CTF1786-A
GNDA
L1671 CCG1192-A
C1676
NM
10u
1u/10
220u/4 CTF1786-A
C1686
1800p/50
C1671
GNDD
100p/50 R1684 BTANAL
NM
C1690
820
1k
R1680
R1683
BTMICN
BTMICP
BT IF
R1681
BT33
NM
AUX_AGND
AEQMICIN
DD5
AEQMIN
SOC33_1
IF
BUP_1
1.5k
NM
GNDA
R1662 D1661
10k
R1704 NM
NM
NM
SPEED
R1756
R1762
R1763
RKZ3.9KG(B2) R1663
10k
SYS+B
R1664 GNDA
Q1661
1.2k
BCG
BC_VGND
AVH-X5500BHS/XNUC
50 BCAMGND
E1 1
B1 2
C2 3
BCI
2SD2114K(VW)
BCAM_IN
49 BCAMIN
BEEP
Q1662
RN4984
48 BEEP
47 AUXAGND
AUR
5 B2
4 E2
6 C1
AUX_R
(3.9V)
46 AUXR
AUAG
A-a 5/6
C1661 R1710 NM AUX_AGND
PLSCLK 45 AUXAGND
AUL
GNDA
AUX_L
3
3
470p/50
AX_R
Q1663 44 AUXL
MIC SENS
AUVG R1764
PLSDATA R1713 NM AUX_VGND
C2 3 4 E2 43 AUXVGND
0 AUV
AUX_V
B1 2 5 B2 42 AUXV
GNDSIG
E1 1 6 C1 41 GNDSIG
GNDA
RN4984 ANR
AEQSW 40 ANR
AEQAUXSW
10.5 MOTHER PCB (IN/OUT BLOCK) (GUIDE PAGE)
39 GNDSIG
ANG
38 ANG
37 GNDSIG
ANB
36 ANB
35 APPPUP
CSYNC
34 CSYNC
CPLDRST R1708 NM
33 GND
GNDD
32 DTVL
GNDD
31 DTVAG
CKS6536-A
CN1751
30 DTVR
RGBARI
COMDC 29 TVON
COMDC 1 GUIDEON
POL 28 GUIDEON
POL 2 R1706 NM
B
PLSEN
VCLK 27 ONSEI+
VCLK 3 ADCON R1718 NM
OEV 26 ONSEI-
OEV 4
STV2 25 GND
STV2 5
GNDD
S_TO_N
24 SYSTON
LCDGND 6 N_TO_S
CLK R1714 NM 23 NTOSYS
HCLK 7 ADCDA
22 GND
CN3601
ADCCL R1716 NM
LCDGND 8 BTMICN
LOAD 21 BTMICN
LD 9 BTMICP
R5 20 BTMICP
R5 10 P1701
R4 FSMD075-24R 19 GNDD
R4 11 1 2
R3 18 GNDD
GNDD
R3 12 GPSOPN R1748 NM
R2 17 GNDD
4
R2 13 R1701
4
5.1V
R1 Q1701 16 SXTOS
R1 14 R1702 2.2k
E2 C2 15 STOSX
R0
R0 15 4 3 5.6k R1703
GNDD
ASENBO
14.4V
B2 B1 14 GND
G5 R1749
BUP_1
GPSSHT NM 5 2 3.3k ASBO
G5 16
GNDD
G4 C1 E1 13 ASENBO
G4 17 6 1 BUSRP
BUSR+
G3 12 SXR
G3 18 UMF23N BUSRM
BUSR-
G2 11 GNDA
G2 19 BUSL-
G1 10 GNDA
G1 20 GPSRST R1753 NM BUSL+
G0 9 SXL
G0 21
B5 8 NC
B5 22 GPStoSH R1750 NM
B4 0 R1711 7 SXPWR
R1754 NM
2
3
B4 23 SHtoGPS
6 SXPWR
GNDD
B3
DABSX12
B3 24 SXIPWEN R1712
B2 5 SXEN
B2 25 470
4 GNDSX
NM
B1
Q1711
B1 26
B0 3 GNDSX
B0 27
GNDSX
2 WIRED
4
5
6
DD5
LCDGND 28 R1752
1
only A
DIO GPSON NM WIREDAD
DIO 29
D
WIRED
LCDGND 30 LCDPW
LCDPW WIREDAD
LCDPW 31
CKS
LPSNC
CN
CN
5 6 7 8
A-b 5/6
WIREDAD
SXPWR
SXPWR
GNDSX
GNDSX
WIRED
A 5/6 MOTHER
SXEN
CN1701 PCB
SXL
NC
CKS6535-A-TBB
9
8
7
6
5
4
3
2
1
SYS+B (IN/OUT BLOCK)
DABSX12
GNDSX
DD5
RCA V IN OUT PREOUT
VCR_RIN
VCR_VIN
VCR_LIN
VCR_RG
VCR_VG
VOUT_G
IC1751
VCR_LG
NM
1 SWROUT
2 SWLOUT
R1751
VOUT
RROUT
3 FROUT
RLOUT
4 FLOUT
1 5
7 GNDA
8 GNDA
Q1721
LSCR523UB 2
INB Vcc
JA1621 JA1631
INA CKB1102-A XKB7001-B
3 4
8
7
6
5
4
3
2
1
5
6
GND OUTY
1u/10
4.7k
R1729 GNDA1
C1752
only A
R1712
470
NM
1k
TC7SET08FUS1
C1751
VOVG
VCRG
VCVG
VCVO
0.1u/10
VCLG
VCRI
D1721
VCVI
VCLI
C1723
1u/10
DD5
SWRO
RRO
FRO
SWLO
RKZ4.7KG(B2)
RLO
R1711
FLO
R1730
C1722
R1731
R1724
FSMD075-24R
15k
15k
2
15k
VCR:+8.2 dBs
15k
15k
15k
15k
C1721 100p/50
C1637
C1638
P1631
NM
NM
R1728
NM
NM
0
GNDA GNDD
3 4 SOC33_1 VDD33
R1723
1
R1727
R1725
R1722
R1721
IC1721
2
1 8
5 OUT1 VCC
2 7 C1607 C1608 C1609 C1610 C1611 C1612 GNDRF GNDA GNDA
1 6 IN-1 OUT2
Q1711 3 6
27p/50 27p/50 27p/50 27p/50 27p/50
R1741
27p/50
15k
IN+1 IN-2
R1765
NM
NM
4
VEE IN+2
5
only A, D
C1725
0.1u/10
IC1741 GNDA GNDA GNDA
R1726
0.1u/10
R1632 R1634 R1638 R1641 R1644 R1647
NJM4558V 1 5
GNDD G VCC D1621 22k 22k 22k 22k 22k 22k
2 NM
100p/50
C1724
IN_A D1622
3 4 DZ2S068C Q1631 Q1632 Q1633
C1736
GND OUT_Y
R1740 C1735 2.2u/10 GNDA D1623 2C 2E 2C 2E 2C 2E
15k DZ2S068C 3 4 3 4 3 4
2.2u/10 TC7SH126FU 1B 2B 1B 2B 1B 2B
R1733
27k
C1732
GNDD
only A D1624
DZ2S068C 2
1E
5
1C
2
1E
5
1C
2
1E
5
1C
R1734 C1731 2.2u/10 C1622 1 6 1 6 1 6
27k 0.1u/50 HN1C03FU(AB) HN1C03FU(AB) HN1C03FU(AB)
R1732 C1623 R1633 R1635 R1639 R1640 R1645 R1646
R1649
R1650
NM
NM
NM
15k 4.7k 4.7k 4.7k 4.7k 4.7k 4.7k
C1621
FSMD075-24R
2
FOR SERVICE 0.1u/50
C1734 100p/50
P1623
IC1731 P1621 C1624
R1631
R1636
R1637
R1642
R1643
R1648
0.1u/50
39
39
39
39
39
39
75
R1621
1 8 R1739 1 2
OUT1 VCC NM
2 7 15k P1622 1
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
IN-1 OUT2
C1631
C1632
C1633
C1634
C1635
C1636
R1736 3 6 R1737 15k 1 2 GNDD
IN+1 IN-2 NM R1622 R1623
4.7u
4.7u
4.7u
4.7u
4.7u
47k 4 5 R1738 15k
4.7u
VEE IN+2 GNDV 22k 22k
NJM4558V
C1733 0.1u/10
R1735
15k
GNDA
C
VCR_VGND
RCA_SWR
RCAMUTE
VCR_GND
RCA_SWL
RCA_RR
RCA_FR
RCA_RL
RCA_FL
VCR_R
VCR_V
RCA_V
VCR_L
BUSL+
iTV_R
iTV_L
iNAVI
AEQMICIN
RCA Output
FM/AM(30%) (A,C~F): -1.9 dBs
FM/AM(30%) (B):+2.1 dBs
SXi (A):+14.3 dBs
TV:+14.3 dBs
AUX:+14.3 dBs
VCR:+14.3 dBs
WIREDAD
SXIPWEN
USB(LS2 Decode):+14.2 dBs
STOSX
SXTOS
WIRED
USB(SH Decode):+14.3 dBs
DVD/CD(LS2):+14.2 dBs
Navi Guide: -7.5 dBs
BT-Audio:+14.3 dBs
G_PWM
R_PWM
B_PWM
LCDPW
POS
MOT1
MOT0
H/OSW
RESET
KDT1
KDT0
TEMPSENS
REMIN
BT-HF:+19.3 dBs
MICSENSR
NM
NM
NM
NM
R1752
R1753
R1750
R1754
GPStoSH
SHtoGPS
GPSRST
GPSON
G0
B5
B4
B3
B2
B1
B0
MTCHRST
BLEN
DIO
LPSYNC
BLSYNC
DIMMER
TPIRQN
BLERR
MTCH_SDA0
MTCH_SCL0
C1651
CHIP SIZE LEGEND 0.1u/10
R1653
680
1608
R1651
2125 D1662
3216 DZ2S068C
D1663 R1652 47k MOTV
DZ2S068C 47k
VDD33
C1602 NM
C1604 0.1u/16 C1652
GNDD
C1603 NM NM
C1605 0.1u/16
C1606 0.1u/16
D1603 NM
GNDD
GNDD
GNDA
1
3
2
10
GNDD 9
8
POS 7
MOT1 6
MOT0 5
GNDD 4
GNDD 3
MOTV 2
MOTV 1
CN1651
VDD33
H/O SW
JA1661 CKS6095-A
CKS6437-A
Auto EQ MIC F CN101
E
DZ2S068C
DZ2S068C
MTCK
MTDA
LCDPW
TIRQ
LPSNC
TEMP
1601 - : USB IF
V18HI
1611 - : OPT
D1781
D1782
1621 - : VCR IN/OUT
A AVH-X5500BHS/XNUC
0
PWRVI
1631 - : PREOUT
B AVH-X5500BT/XNEW5
R1781
SERVICE UNIT(MOTHER I/F)
0
GNDD 1651 - : AUTO FLAP
C AVH-X5550BT/XNRC
TPN33 1661 - : MIC SENS, Auto EQ MIC Consists of
D AVH-X5550BT/XNRD
R1782
ILMB 1671 - : BT
MOTHER PCB
C1701
C1702
470p/50
0.1u/10
C1704
0.1u/10
0.1u/16 1701 - : TO IF E AVH-X5550BT/XNRI
BLGND C1703 1781 - : TO MONITOR F AVH-X5590BT/XNID
INTERFACE PCB
F
G1 20
G0 21
22
23
24
25
26
27
LCDGND 28
29
LCDGND 30
LCDPW 31
32
33
LCDGND 34
35
TMPSENS 36
PWM_G 37
PWM_R 38
PWM_B 39
40
41
RST 42
43
LCDGND 44
MTCHCK 45
MTCHDA 46
47
KEYGND 48
TOUCHGND 49
50
51
BLEN 52
53
BLERR 54
BLGND 55
BLGND 56
BLGND 57
58
59
60
KDT1
KDT0
DIMMER
B5
B4
B3
B2
B1
B0
DIO
PWRVI
LPSYNC
BLSYNC
REMIN
TPN33
ILMB
ILMB
ILMB
TPIRQN
V18HI
D CN5401
A 5/6
AVH-X5500BHS/XNUC
5 6 7 8
133
F
E
B
A
D
C
134
A-a A-b
A-b 5/6
1
1
NC
CN1701
SXPWR
SXPWR
GNDSX
GNDSX
WIRED
WIREDAD
SXEN
CKS6535-A-TBB
PCB
8
7
6
5
4
3
2
1
SYS+B
A 5/6 MOTHER
(IN/OUT BLOCK)
DABSX12
GNDSX
DD5
RCA V IN OUT PREOUT
IC1751
NM
1 5
Q1721 INB Vcc
R1751
VCR_VIN
VCR_VG
VCR_LIN
VCR_LG
VOUT
VOUT_G
VCR_RIN
VCR_RG
LSCR523UB 2 JA1621 JA1631
RROUT
RLOUT
INA CKB1102-A XKB7001-B
8
7
6
5
4
3
2
1
3 4
1 SWROUT
2 SWLOUT
3 FROUT
4 FLOUT
5
6
7 GNDA
8 GNDA
R1729 GND OUTY
GNDA1
4.7k
only A
1u/10
470
1k
C1752
NM
R1712
TC7SET08FUS1
DD5
C1751
VCVI
VCVG
VCLI
VCLG
VCVO
VOVG
VCRI
VCRG
D1721
0.1u/10
C1723
1u/10
FRO
FLO
RRO
RLO
2
SWRO
SWLO
R1711
R1730
C1722
R1731
R1724
15k
15k
VCR:+8.2 dBs
15k
2
2
15k
15k
15k
15k
NM
NM
NM
0
NM
GNDA GNDD
RKZ4.7KG(B2)
C1637
C1638
P1631
R1728
3 4
1
SOC33_1 VDD33
FSMD075-24R
IC1721
2
R1723
C1721 100p/50
R1727
R1725
R1722
R1721
1 8
5 OUT1 VCC
2 7 C1607 C1608 C1609 C1610 C1611 C1612 GNDRF GNDA GNDA
1 6 IN-1 OUT2
Q1711 3 6
IN+1 IN-2 27p/50 27p/50 27p/50 27p/50 27p/50 27p/50
15k
4 5
NM
NM
VEE IN+2
R1741
only A, D
R1765
IC1741 GNDA GNDA GNDA
R1632 R1634 R1638 R1641 R1644 R1647
C1725
1 5
R1726
0.1u/10
GNDD NJM4558V G VCC D1621 22k 22k 22k 22k 22k 22k
0.1u/10
2 NM
IN_A D1622
3 4 DZ2S068C Q1631 Q1632 Q1633
C1724
GND OUT_Y
100p/50
R1740 C1735 2.2u/10 GNDA D1623 2C 2E 2C 2E 2C 2E
C1736
15k DZ2S068C 3 4 3 4 3 4
C1732 2.2u/10 TC7SH126FU 1B 2B 1B 2B 1B 2B
R1733 D1624
27k only A DZ2S068C 2 5 2 5 2 5
GNDD 1E 1C 1E 1C 1E 1C
R1734 C1731 2.2u/10 C1622 1 6 1 6 1 6
27k 0.1u/50 HN1C03FU(AB) HN1C03FU(AB) HN1C03FU(AB)
R1732
AVH-X5500BHS/XNUC
C1623 R1633 R1635 R1639 R1640 R1645 R1646
NM
15k
NM
NM
4.7k 4.7k 4.7k 4.7k 4.7k 4.7k
C1621
2
R1649
R1650
FOR SERVICE 0.1u/50
C1734 100p/50
IC1731 P1621 C1624
0.1u/50
39
39
39
39
39
39
75
P1623
1 8 R1739 1 2
R1631
R1636
R1637
R1642
R1643
R1648
NM
3
3
1
OUT1 VCC
R1621
15k
FSMD075-24R
2 7 P1622
IN-1 OUT2
R1736 3 6 R1737 15k 1 2 GNDD
IN+1 IN-2 NM R1622 R1623
C1631
C1632
C1633
C1634
C1635
C1636
47k 4 5 R1738 15k
4.7u
4.7u
4.7u
4.7u
4.7u
VEE IN+2 GNDV 22k 22k
CCG1201-A
4.7u
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
NJM4558V
C1733 0.1u/10
GNDA
15k
R1735
iNAVI
iTV_L
iTV_R
VCR_V
VCR_VGND
VCR_L
RCA_V
VCR_R
VCR_GND
RCA_SWR
RCA_SWL
RCA_FR
RCAMUTE
RCA_FL
RCA_RR
RCA_RL
RCA Output
FM/AM(30%) (A,C~F): -1.9 dBs
AEQMICIN
FM/AM(30%) (B):+2.1 dBs
SXi (A):+14.3 dBs
TV:+14.3 dBs
AUX:+14.3 dBs
VCR:+14.3 dBs
4
4
USB(LS2 Decode):+14.2 dBs
USB(SH Decode):+14.3 dBs
DVD/CD(LS2):+14.2 dBs
SXIPWEN
WIRED
WIREDAD
STOSX
SXTOS
Navi Guide: -7.5 dBs
BT-Audio:+14.3 dBs
BT-HF:+19.3 dBs
POS
KDT1
KDT0
MOT1
MOT0
LCDPW
G_PWM
R_PWM
B_PWM
RESET
REMIN
H/OSW
TEMPSENS
MICSENSR
NM
NM
NM
R1752
R1750
R1754
GPStoSH
SHtoGPS
GPSON
8 7 6 5
135
AVH-X5500BHS/XNUC
G0 21
B5 R1750
B5 22 GPStoSH NM
B4 R1754
B4 23 SHtoGPS NM
B3
B3 24
B2
B2 25
B1
B1 26
B0
B0 27
F
LCDGND 28 R1752
DIO GPSON NM
A-b 5/6
DIO 29
D
LCDGND 30 LCDPW
LCDPW
LCDPW 31 LPSNC
LPSYNC
LPSYNC 32
C1701 R1781 0
V18HI 33
470p/50
V18HI
LCDGND 34
CN5401
PWRVI 35 PWRVI TEMP
TEMPSENS
TMPSENS 36 C1702
0.1u/10 G_PWM
PWM_G 37
R_PWM
PWM_R 38
B_PWM
PWM_B 39
KDT1
KDT1 40
KDT0
KDT0 41
RESET
RST 42
REMIN
REMIN 43 R1782 0
MTCHRST
LCDGND 44
MTCK
MTCH_SCL0
MTCHCK 45
MTDA
MTCH_SDA0
E
MTCHDA 46
TIRQ
TPIRQN
TPIRQN 47
KEYGND 48 0.1u/10 D1781
C1704 DZ2S068C
TOUCHGND 49
TPN33
DZ2S068C
TPN33 50
GNDD
D1782 BLSYNC
BLSYNC 51
BLEN
BLEN 52
DIMMER
DIMMER 53
BLERR
BLERR 54
BLGND 55
BLGND 56
BLGND
BLGND 57
ILMB 58
0.1u/16
C1703
ILMB 59
ILMB
ILMB 60
3216
2125
1608
D
CHIP SIZE LEGEND
1781 -
1701 -
1671 -
1661 -
1651 -
1631 -
1621 -
1611 -
1601 -
GNDA
: BT
MICSENSR
: OPT
: TO IF
A-a A-b
1
: USB IF
3
2
: PREOUT
: AUTO FLAP
: VCR IN/OUT
: TO MONITOR
CKS6437-A
Auto EQ MIC
JA1661
C
D1663
D1662
: MIC SENS, Auto EQ MIC
DZ2S068C
DZ2S068C
GNDD
D1603
C1606
C1605
C1603
C1604
C1602
NM
NM
NM
0.1u/16
0.1u/16
0.1u/16
F
E
B
A
GNDD
R1652
R1651
0.1u/10
NM
C1652
C1651
47k
47k
H/OSW
H/O SW 10
AVH-X5590BT/XNID
AVH-X5550BT/XNRI
GNDD 9
D AVH-X5550BT/XNRD
C AVH-X5550BT/XNRC
VDD33
AVH-X5500BT/XNEW5
AVH-X5500BHS/XNUC
VDD33 8
R1653 POS
POS 7
F
680 MOT1
MOT1 6
MOT0
B MOT0 5
GNDD 4
GNDD 3
CN101
MOTV 2
GNDD
MOTV 1
MOTV
Consists of
CKS6095-A
MOTHER PCB
CN1651
INTERFACE PCB
SERVICE UNIT(MOTHER I/F)
BT-HF:+19.3 dBs
BT Audio:+14.3 dBs
A
8 7 6 5
4 3 2 1
136
AVH-X5500BHS/XNUC
A-a 5/6
F
A 3/6
A 2/6
A 1/6
INNER BUS
I/O-SH BUS
BTRST
I/O-ANA BUS
I/O-SYS BUS
R1686 BTTOSYS
0
CKN1091-A
JA1601
R1687 SYSTOBT
USB5
0
C1601
CTF1713-A
R1601 NM 1 USB5V
0.1u/50
GNDD
D+ 44 3 3
2 USB_D-
D- 3 USB_D+
R1602 NM
D1602 4 USBGND
BTANAR 11
L1601 2 2
GNDD
USB IF
EZAEG2A50AX RT1 Shield1
E
RT2 Shield2
D1601
GNDD
EZAEG2A50AX
BTANAL
BTMICN
BTMICP
D
AUX_AGND
AEQMICIN
DD5
SOC33_1
IF
A-a A-b
BUP_1
10k
R1704 NM
NM
NM
SPEED
R1756
R1762
R1763
BCG
BC_VGND
50 BCAMGND
BCI
BCAM_IN
49 BCAMIN
BEEP
48 BEEP
47 AUXAGND
AUR
AUX_R
46 AUXR
AUAG
PLSCLK R1710 NM AUX_AGND
45 AUXAGND
AUL
AUX_L
44 AUXL
AUVG R1764
PLSDATA R1713 NM AUX_VGND
43 AUXVGND
0 AUV
AUX_V
C
42 AUXV
GNDSIG
41 GNDSIG
ANR
40 ANR
AEQAUXSW
39 GNDSIG
ANG
38 ANG
37 GNDSIG
ANB
36 ANB
35 APPPUP
CSYNC
34 CSYNC
CPLDRST R1708 NM
33 GND
GNDD
32 DTVL
31 DTVAG
30 DTVR
RGBARI
COMDC 29 TVON
GUIDEON
28 GUIDEON
R1706 NM
B
PLSEN
27 ONSEI+
ADCON R1718 NM
26 ONSEI-
25 GND
GNDD
S_TO_N
24 SYSTON
B
N_TO_S
R1714 NM 23 NTOSYS
ADCDA
22 GND
CN3601
ADCCL R1716 NM
BTMICN
21 BTMICN
BTMICP
20 BTMICP
P1701
FSMD075-24R 19 GNDD
1 2
18 GNDD
GNDD
GPSOPN R1748 NM
17 GNDD
5.1V R1701
Q1701 16 SXTOS
R1702 2.2k
E2 C2 15 STOSX
4 3 5.6k R1703
GNDD
ASENBO
14.4V
B2 B1 14 GND
R1749
BUP_1
GPSSHT NM 5 2 3.3k ASBO
GNDD
C1 E1 13 ASENBO
6 1 BUSRP
BUSR+
12 SXR
UMF23N BUSRM
BUSR-
11 GNDA
BUSL-
10 GNDA
GPSRST R1753 NM BUSL+
9 SXL
8 NC
GPStoSH R1750 NM
0 R1711 7 SXPWR
R1754 NM
2
3
1
SHtoGPS
6 SXPWR
GNDD
DABSX12
SXIPWEN R1712
A
5 SXEN
470
4 GNDSX
NM
Q1711
3 GNDSX
GNDSX
2 WIRED
5
6
DD5
R1752
1
only A
GPSON NM WIREDAD A-b 5/6
4 3 2 1
8 7 6 5
137
AVH-X5500BHS/XNUC
A-a 5/6
BT18
F
BT33
A 4/6
A 3/6
A 2/6
RT1 RT1
NM
R1673
C1672
10u
U1671
RT2 RT2
NM
DUMMY
CWX4306-A
CCG1192-A
R1672
GNDD
GNDD
C1680 NM
C1681 0.1u/16
C1673 10u
CCG1192-A
BT18ON
I/O-POWER BUS
R1682
I/O-SH BUS
C1677 NM R1674 BTRST
0.01u/16 100
R1676 R1671 R1686 BTTOSYS
NM 0
R1675 R1677 NM R1687 SYSTOBT
DBGT
DBGR
NM 100 0
R1688 NM BTTOSH
C1689 C1684
0.1u/10 NM R1689 NM SHTOBT
R1694 NM DATA_BT
GNDD
C1688 C1687
R1695 NM BCLK
100p/50 CCG1192-A
GNDD
R1685
10u
820 R1696 NM LRCLK
E
LINEOUT_L
LINEOUT_R
UART_AT_TX
UART_AT_RX
BT33V
BT18_EN
UART_DBG_TX
BT18V
UART_DBG_RX
BT18V
VSS
nRESET
C1683
1800p/50
2 DIN
4 NC1
5 CAP
7 GND
1 LRCIN
3 BCKIN
6 VOUTR
GNDA
1 24
2 23
3 22
4 21
5 20
6 19
7 18
8 17
9 16
10 15
11 14
12 13
CKS6346-A
IC1671
CN1671
NM
R1691
VOUTL
WM8761BGED
NC2
FORMAT
MCLK
R1678
DEEMPH
MUTE
VDD
VSS
1k
I2S_IN
MIC1_P
MIC1_N
8
9
BOOTS
10
11
12
13
14
MIC2_P
I2S_CLK
MIC2_N
BT MODULE
I2S_OUT
R1679
I2S_MCLK
I2S_SYNC
MIC_BIAS
GNDA
1k
C1685
C1674
BT-HF:+2.2 dBs
BT-Audio:+2.2 dBs
0
0
0
NM 0.1u/10
C1682 L1672
C1678
C1679
R1692
R1693
R1690
C1675
VD5
BBOT
NM CTF1786-A
GNDA
L1671 CCG1192-A
C1676
NM
10u
1u/10
220u/4 CTF1786-A
C1686
1800p/50
C1671
GNDD
100p/50 R1684
NM
C1690
820
0
1k
R1680
R1683
BT IF
R1681
BT33
D
NM
AEQMIN
A-a A-b
1.5k
NM
GNDA
R1662 D1661
RKZ3.9KG(B2) R1663
10k
SYS+B
R1664 GNDA
Q1661
1.2k
E1 1
B1 2
C2 3
2SD2114K(VW)
Q1662
RN4984
5 B2
4 E2
6 C1
(3.9V)
C1661 R1710 NM
PLSCLK
GNDA
470p/50
AX_R
Q1663
MIC SENS
C2 3 PLSDATA R1713 NM
C 4 E2
B1 2 5 B2
GNDSIG
E1 1 6 C1
GNDA
RN4984 ANR
AEQSW
AEQAUXSW
ANG
ANB
CSYNC
CPLDRST R1708 NM
GNDD
CKS6536-A
CN1751
COMDC
COMDC 1
POL R1706
POL 2 PLSEN NM
VCLK
VCLK 3 ADCON R1718 NM
OEV
OEV 4
STV2
B STV2 5
LCDGND 6
CLK ADCDA R1714 NM
HCLK 7
ADCCL R1716 NM
LCDGND 8
LOAD
LD 9
R5
R5 10
R4
R4 11
R3 R1748
R3 12 GPSOPN NM
R2
R2 13
R1
R1 14
R0
R0 15
G5 GPSSHT R1749 NM
G5 16
G4
G4 17
G3
G3 18
G2
G2 19
G1 R1753
G1 20 GPSRST NM
G0
G0 21
B5 R1750
B5 22 GPStoSH NM
B4 R1754
B4 23 SHtoGPS NM
B3
B3 24
A
B2
B2 25
B1
B1 26
B0
B0 27
LCDGND 28 R1752
DIO GPSON NM
A-b 5/6
DIO 29
D
8 7 6 5
1 2 3 4
10.6 MOTHER PCB (TUNER BLOCK)
TUN-SH BUS
A 3/6
only A
FM/AM ANTENNA
B
WWR C-TUN UNIT X-2056_2 only A JA451
YKS5041-A
RFG2
CWE2364 2 1
C455
D452
NM
TUN33
3p/50
R401 U401
ACLK 1 8 A_CLK RFG1
41 DGND5 27 R403
AWS 2 7 A_WS SDO
L401
NM
40 SDI 26 P451
ADI
3 6 A_DI
5 4
SDI IMSA-6803-01Y900-T only A, D
ADO 39 SDO 25 6 3 GNDRF
4 5 A_DO SSCK
CCG1192-A
38 SSCK 24 7 2
10u
C401
0 BLEND/SCK SCS
R410
C404
NM
1k
SCS 23
37
DGND6
8
0
1 only A,
36 DGND4 22 C556
DVCC33_2
R402 35 DVCC33_1 21 GNDD
BBCLK1 8 BB_CLK R407 TUNRST 22p/50
34 RESET 20 0
BBWS 2 7 R405
C BB_WS
RX 19 0
SYStoDTUN
33
BBD0 3 6 BB_DII R406 DTUNtoSYS
R519
R521
1
220
750
32 TX 18 0
BBD1 4 5 BB_DIQ/REF_CLK TUN12
GPIO 17 L402 2
31
0 DVCC11_2
DVCC11_1 3
RN731VN
RN731VN
CCG1192-A
10u
30 16
only A, D
D501
D502
NM C526
I2C1_SCL
C402
C405
NM
GNDRF NM 4
29 DGND3 15 L502
TUCLK
L506
I2C1_SDA C509 0.27u CTF1794-A C527
DGND2 14 5
28
TUDAT
33p/50 0.01u/16 6
C454
2p/50
0.01u/16
0.01u/16
0.01u/16
6p/50
C525
C510
C513
C516
C517
C518
NM
L501 7
0.15u
I2C0_SCL 13 GNDD
I2C0_SDA 12 CN401 TUNAG
1u/10 8
R404
TUN33 NM orRFGND C528 9
DGND1 11 GNDRF
8 1 ACLK
NM 10
RDSINT 10 GNDD GNDRF
7 2 AWS
1 L503 11
LCH 9 R409 NM
C529 10u
RFVCC33
6 3 ADI
CCG1192-A
2 CTF1786-A C519 C521
0.1u/10
12
D AGND 8
5 4 R408 NM ADO
C514
3 0.1u/10 0.01u/16 13
RCH 7
NM TUNAG C522
RFGND3 L403 4 0.01u/16 14
6 L504
5 CTF1806-A GNDRF C523 15
RFVCC5 5 10u
NM
6 GNDRF CCG1192-A 16
0.1u/10
FMAMANT 4
C511
C515
NM
GNDRF
C403
C406
NM
NM
RFGND2 7
3 C524
0.022u/16
DABANT 8
2 except A, D
9 TUNAG R522 1.5k R524
RFGND1 1
10 C512 L505 L519 L507
GNDRF 0.01u/50 CTF1389-A 10n 22u L508
only A, D
R520
1M
only A D
GNDD
D503
C520
R523
NM
DABSX12
1M
3p/50
E 2 JA452
NM L451
3 1
NM
NM
4
only A
D451
NM
C453
C462
NM
NM
VA451
R455
0
C458
GNDRF
R456
5p/50
GNDRF
C459
0
C457
NM
4p/50
only A except A C460 R451 R452
C456 R457 R454
4p/50 NM 0
5p/50 0 0 C461
GNDRF GNDD
F GNDRF
GNDD GNDRF GNDRF GNDRF 4p/50
TUNAG TUNAG only A, D
A 6/6
AVH-X5500BHS/XNUC
138
1 2 3 4
5 6 7 8
A
A 6/6 MOTHER PCB
(TUNER BLOCK)
FM/AM(30%) (A,C~F): -15.0 dBs
FM/AM(30%) (B): -11.0 dBs
TUN-ANA BUS
A 1/6
TUN_R
TUN_L
TUN-SYS BUS
C560 10p/50
A 2/6
BLEND
TUNRST
TUNCLK
TUNDATA
only A, D C561 10p/50
C562 A AVH-X5500BHS/XNUC
4700p/25
B AVH-X5500BT/XNEW5 B
C563 TUNER TUN5
C AVH-X5550BT/XNRC
4700p/25 36.48MHz D AVH-X5550BT/XNRD
TUNAG E AVH-X5550BT/XNRI
NM
F AVH-X5590BT/XNID
C566 only A, D
C564
10p/50
10p/50 TUNAG
X501
CTF1786-A
CTF1786-A
4 3
X2 NM
0.22u/6.3
GND2
L512
L513
CCG1218
0.1u/10
22p/50
D
2.2u/10
GNDD
22p/50
C568
C569
C574
C570
C567
1 2
GND1 L517
C559
X1
0.22u/16
1u/10
C558
CSS1805-A CTF1786-A
only A, D L515 NM
C556
R540
0.1u/10
0
C557
C565
22p/50 L516 NM
R541 NM
C
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
L514
CTF1786-A
TCFM
C571
OSCOUT
TVDAC
DACOUTR
1 48
DACOUTL
VREFDEC
OSCIN
GND-REF
VCC-REF
PLLTEST
GND-PLL
CCG1218-A-T
VCC-PLL
GND-ADC_DAC
VDDIO1V2
VDDPLL1V2
VCC-ADC_DAC
2 47 C573 2.2u/10
3 46 0.1u/10
C526 only A
NDRF NM 4 FMMIXIN2 45 R501 220
6
94-A C527 5 FMMIXIN1 TEST GPIO1 44 R531 0
VDD_CORE BBD1
0.01u/16 6 GNDRF FMPINDRV GND1V2 GPIO2 43 R532 0
FMPINDDEC GPIO0 BBD0
C525 7 TCAM FMMIXDEC GPIO3 42 R533 0 BBWS
1u/10 8 VCCRF GPIO4 41 R534 0 BBCLK
TUNAG IC501
FGND C528 9 CK_SEL GPIO5 40 R535 0
TDA7706 ADO
NM 10 GNDVCO GPIO6 39 R536 0 ADI
11 LFREF GPIO7 38 R537 0 AWS
VDD3V3
C521 12 LF1 I2CSCL GPIO8 37 R538 0
TCAM2 I2CSDA
ACLK D
0 0.01u/16 13 VCCVCO PINDDEC GND3V3 36
PINDIN TUN33
C522 0.01u/16 14 35 0.1u/10
VCCREG1V2
C523 C555
GNDSLINK
15 34 GNDD
AMMIXIN1
AMMIXIN2
VREG3V3
LNAOUT2
LNADEC2
10u
GNDLNA
LNADEC
LNAOUT
REG1V2
RDSINT
except A
LNAIN2
CCG1192-A 16 33
LNAIN
RSTN
VDIG
GNDRF L518 CTF1786-A
C524
2u/16
30
31
32
17
18
10u 19
20
21
22
23
24
25
26
27
28
29
except A, D L511 CTF1786-A
522 1.5k R524 0 only A
CCG1192-A
0.1u/10
C538
R539 1k
C540
L507
0.1u/10
1/4W
C530
GNDRF
22u L508 68n
NM
0.1u/10
only A, D
0.1u/10
1000p/50
0.1u/10
22p/50
C549
C548
82p/50
C553
C554
C547
680
R526
C546
470
33
L509
47u
C531
3p/50
only A, D
R523
1M
3p/50
R528 R529 R530 GNDD
100p/50
R527
C542
R525
E
C541
C539
5.6 5.6 5.6 only A, D
0.01u/16
L510
100p/50
2.2u/10
CTF1786-A
CCG1218
0.1u/10
C544
C545
C550
C543
0.1u/10
GNDRF
only A, D GNDD GNDRF
CHIP SIZE LEGEND SERVICE UNIT(MOTHER I/F)
401 - : HD TUNER UNIT
1608 Consists of
R452 451 - : ANT PART 2125 MOTHER PCB
0 501 - : HIT2 PART 3216 INTERFACE PCB
NDD
GNDRF GNDRF F
A 6/6
AVH-X5500BHS/XNUC
5 6 7 8
139
1 2 3 4
10.7 INTERFACE PCB
BZ3631
CPV1062-A
A BZ
I/F
1
1
JA3621
CKB1106-A
R3621 1
2 75
2 2
CN3601
C3621
GND
CKS6429-A
AUX
D3621
R3644
NM
NM
BCAMGND 1
NM
BCAMIN 2 JA3641
AUX:+2.2 dBs AKN1073-A
BEEP 3
R3641 R3645 NM 2
AUXAGND 4 22k GND
GND
R3642 R3646 NM 4
AUXR 5 22k AUXL
R3647 NM 3
AUXAGND 6 75 AUXR
R3643 NM 1
AUXL 7
VIDEO
B AUXVGND 8
R3648
DZ2S068C
DZ2S068C
DZ2S068C
0.1u/50
0.1u/50
C3641
D3641
D3642
D3643
C3642
AUXV 9
R3661
GNDSIG 10
ANR 11
GND
GNDSIG 12
D3665
ANG 13 NM
GND
GNDSIG 14
APPPUP
ANB 15
1000p/50
APPPUP 16
C3722
CSYNC 17
GND 18
C3601 2.2u/10
DTVL 19
C3602 2.2u/10
DTVAG 20
C C3603 2.2u/10
DTVR 21
C3723 C3724
TVON 22 1000p/50 1000p/50
GUIDEON 23
C3604 2.2u/10
ONSEI+ 24
A 5/6 ONSEI- 25
C3605 2.2u/10
GND 26 C3725
CN1701 18p/50
SYSTON 27 C3726
18p/50
NTOSYS 28
GND 29
GND
BTMICN 30
BTMICP 31
GNDD 32
D GNDD 33
GNDD 34
GNDD
SXTOS 35
STOSX 36
C3721 1000p/50
GND 37
GND
ASENBO 38
SXR 39
GNDA 40
GNDA 41
SXL 42
SXPWR
NC 43
C3606
SXPWR 44
NM
SXPWR 45
GND
E SXEN 46
GNDSX 47
R3691
GNDSX 48
BT MIC
NM
WIRED 49 GNDSX
WIREDAD 50
R3692
JA3691
NM CKN1040-A 1
WIRED REMOTE R3693 3
2
NM
VA3691
R3694
VA3692
0.1u/10
NM C3691
C3692
NM
NM
NM
R3731 1k
R3732 1k 2 WIREDAD
3 WIRED
NM
NM
GND
NM
NM
1
JA3731 GND
C3731
C3732
D3731
CKS6437-A
D3732
GND GNDD
B
AVH-X5500BHS/XNUC
140
1 2 3 4
5 6 7 8
JA3621
CKB1106-A
B INTERFACE PCB
1
B.CAMERA INPUT
2
NM
CN3661
CKS4497-A
GND
R3670 NM IF-Mother Connector part 3601~3620
1 CCR
R3671 NM
Back Camera part 3621~3630
2 CCG
R3672 NM
Buzzer part 3631~3640
3 CCB
AUX part 3641~3660
R3673 NM
4 CCSYNC B
NAVI part 3661~3690
8
5
R3661
5 GNDSIG
BT mic part 3691~3700
75
6 DVDVBS
SXi part 3701~3730
2
4
1
7 GNDDVD
Wired remote part 3731~3740
8 YS
D3665
NM ASENBO
GND to GND 3741~
GND 9
R3674 NM
R3662 22k 10 CCAUL
R3675 NM
11 CCAUR CHIP SIZE LEGEND
22k R3676 NM 1608
R3663 12 GNDAU
R3677
13 ONSEI+
R3664
5.6k R3678 2.7k
2.7k 14 ONSEI-
NAVI I/F 2125
3216
TV:+2.2 dBs
15 REAUR
Navi Guide:+14.5 dBs
16 REAUL
C
17 GNDRAU
18 CCREM
R3665 1k
19 DSEN A AVH-X5500BHS/XNUC
20 TVON
R3666 1k B AVH-X5500BT/XNEW5
21 GUIDEON
APPPUP C AVH-X5550BT/XNRC
22 MONON
VSW5
D AVH-X5550BT/XNRD
23
R3668 470
24 SYS_TO_NAVI E AVH-X5550BT/XNRI
R3669 470
25 NAVI_TO_SYS F AVH-X5590BT/XNID
NM
NM
NM
NM
26 GNDD
D3661
D3662
D3663
D3664
GNDD
GND D
R3706 8.2k
SXPWR JA3701 only A
R3707 470 CKS3806-A
R3712
D3705 NM
D3706 NM
NM
100k
10 PWEN
NM
9 SXPWR
R3711
D3704
NM
R3713
8 GNDSX
0.1u/25
C3702
7
GND
SXi
6 SXRX
R3704 R3708 NM
5 GNDA
R3702 180 GND
4 SXR
R3701 22k
R3709 NM
3
470 R3703
2 SXTX
22k R3705 R3710 NM E
1 SXL
180
NM
NM
NM
SXi (A):+2.2 dBs
C3701
D3701
D3702
D3703
GNDSX
NM
GND
KN3602
KN3601 TP3741
C3741
NM
SERVICE UNIT(MOTHER I/F)
1 1 GND
Consists of
M2R6TP_GND MOTHER PCB
INTERFACE PCB F
B
AVH-X5500BHS/XNUC
5 6 7 8
141
1 2 3 4
10.8 DVD CORE UNIT (GUIDE PAGE)
C-a
SDODAC
TEMP
FD
TD
D+
SCKDAC
LTDAC
FE2
FE1
D-
COMPOSITE
IECOUT
C1806
C1801 CCG1192-A
CCG1201-A R1803 10u
ROUT
4.7u 820 (2125)
1800p/50
R1801
C1803
(2125)
100k
VCOM 10
11
12
MD 13
MC 14
ML 15
SCK 16
AGND 9
ADAC
PCM1753DBQ
IC1801
GNDAU1
VOUTR
VOUTL
DGND
LRCK
DATA
VCC
BCK
NC
1800p/50
R1802
C1804
100k
8
7
6
5
4
3
2
1
C1802
CCG1201-A R1804
LOUT
200 (D)
R1672
4.7u 820 X1501 27.000 MHz
(2125) CSS1823-A
4 C1604
NC2 X2 3 GNDV
R1601
68p/50
12k
VCC5_AU D1901
1 2 RKZ6.8TKJ C1602
C1805
C1809
NC1
0.1u/10
0.1u/10
X1 100p/50
C1510 C1512
10p/50 10p/50 RKZ6.8TKJ C1605
D1902
R1602
68p/50
12k
R1501
1.2k
IEC
GNDD R1955 15k C1603
GNDAU GNDD
B R1503 R1954 15k R1670 R1983 100p/50
24 (F) (1608)
10k 100 R1671
1M
R1504
120
VCC33 GNDD (D) (D) 24k
(1608)
220
C1674 (D)
24 (F)
R1950
R1951
MDQ15
GNDD5
R1508
0.1u/10
MDQ0
R1603
0.1u/10
1u/10
10k (D)
100
TEMP
0
30k (D)
VTL1126-A
100
100
MDQ14
L1511
0.1u/10
0.1u/10
0.1u/10
C1673
(1608)
C1511
R1674
C1606
C1515
GNDA
0.1u/10
0.1u/10
C1601
C1514
MDQ1
C1671
C1676
R1506
R1507
R1987
R1505
VCC12 0.01u/16
AD2
CCG1192-A
CCG1192-A
C1502
C1501
(2125)
MDQ14 160
MDQ0 159
158
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
162
161
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
10u
10u
(2125)
AVDDG
COMP2
COMP1
OSCO
AVDDH
MDQ1
TEMP
AVSSG
AVDDE
ROUT
FD
TD
VDSENS
AVDDF
DAC1OUT
DAC2OUT
DAC3OUT
AVSSH
ADOUT
DACCK
DAC5OUT
SRCK
LOUT
VREF
MDQ15
AVSSE
AD4
AD2
AVSSF
LRCK
COMPOSITE
163
OSCI
VSS_9
MDQ13
IECOUT
AVDDI
VIN7
VIN1
VIN2
VIN4
VIN3
VIN8
VSS_10
AVSSI
IREF1
VDD12_4
VDD33_6
MDQ2 164
165 MDQ13
MDQ2
C1504 166 VSS_11
VDD33_7
MDQ12 0.1u/10 167
MDQ12
MDQ3 168
MDQ3
MDQ11 169
MDQ11
MDQ4 170
MDQ4
MDQ10 171
MDQ10
MDQ5 172
MDQ5
173
VSS_12
C1505 174
VDD33_8
MDQ9 0.1u/10 175
MDQ9
MDQ6 176
MDQ6
MDQ8 177
MDQ8
MDQ7 178
MDQ7
DQM0 179
DQM0
C DQM1
XWE
180
181
DQM1
NWE
182
L1501 VSS_13
MCK R1512 183
MCK
47 CTF1743-A C1506 184
VDD33_9
0.1u/10 185
MCKI
186
VSS_14
C1503
R1538
187
100k
VDD12_5
XCAS 0.1u/10 188
NCAS
XRAS 189 IC1501
NRAS MN2DS0018MA
XCSM 190
NCSM
STANDBY 191
STANDBY
MA11 192
DQM3
BA0 193
BA0
MA9 194
MA9
195
VSS_15
C1507 196
VDD33_10
BA1 0.1u/10 197
BA1
MA8 198
MA8
MA10 199
MA10
MA7 200
MA7
MA0 201
MA0
MA6 202
MA6
MA1 203
MA1
204
VSS_16
C1508 205
VDD33_11
MA5 0.1u/10 206
MA5
MA2 207
MA2
D MA4
MA3
208
209
MA4
MA3
210
VSS_17
C1509 211
VDD12_6
0.1u/10 212
EXADT0
213
NEXCE
214 NEXOE
EXDT0
EXADR16
EXADR19
EXADR18
EXADR17
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
I2C_SCL
VDD33_1
VDD33_2
VDD12_1
VDD33_3
VDD12_2
I2C_SDA
215
IRQPWR
EXADT9
EXADT8
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
EXDT8
EXDT10
EXDT11
EXDT12
EXDT13
EXDT14
EXDT15
NEXWE
3 EXDT1
EXDT9
4 EXDT2
EXDT3
EXDT4
EXDT5
EXDT6
EXDT7
VSS_1
VSS_2
VSS_3
VSS_4
VSS_5
216
A20
1
2
6
7
8
9
5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
VCC33
DEBUG
GNDD
GNDD4
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10
C1513
C1516
C1517
C1518
C1519
1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
10 11
CN1951 R1517 10k R1539
NM 100k
R1529 10k R1533
GNDD
R1971 NM
R1972 NM
R1973 NM
R1974 NM
R1975 NM
R1976 NM
R1977 NM
R1978 NM
R1979 NM
R1531 10k NM
R1547
NM
R1518 10k
R1528 10k
R1530 10k R1542
10k
R1527 6.8k
TRCDATA3
TRCDATA2
TRCDATA1
TRCDATA0
SCLOCK
TRCCLK
EXTRG0
R1546 6.8k
TRCST
SDATA
XCSF2
XWR1
XRD
D10
D11
D12
D13
D14
D15
A16
A15
A14
A13
A12
A11
A10
A19
A18
A17
A20
D0
D8
D1
D9
D2
D3
D4
D5
D6
D7
A0
A9
A8
A7
A6
A5
A4
A3
A2
A1
VCC33
L1904
E CTF1528-A
CCG1192-A
FLASH 16M FLASH 16M
1000p/50
C1490
C1489
10u
(2125)
IC1401 VCC33 IC1402 VCC33
C1480 IC1480
1 54 A15 1 48 C1404 A16 A15 1 48 C1409 A16
A15 A16 A15 A16
MDQ0 R1490 0.1u/10 2 VDD1 GND3 53
R1485 A14 2 47 CCG1201-A A14 2 47 CCG1201-A
DQ0 DQ15 56 A14 BYTE A14 BYTE
56 C1481 3 52 3 46 4.7u (2125) 3 46 4.7u (2125)
MDQ15 A13 A13
VDDQ1 GNDQ4 A13 VSS2 A13 VSS2
0.1u/10 4 51 5 4 4 A12 45 4 A12 45
MDQ1 MDQ14 A12 D15 A12 D15
DQ1 DQ14 DQ15/A-1 DQ15/A-1
5 4 5 50 6 3 5 44 5 44
MDQ2 MDQ13 A11 D7 A11 D7
DQ2 DQ13 A11 DQ7 A11 DQ7 VHALF
6 3 R1480 6 49 C1488 7 2 6 43 6 43
MDQ3 56 MDQ12 A10 D14 A10 D14
GNDQ1 VDDQ4 A10 DQ14 A10 DQ14
7 2 7 48 0.1u/10 8 1 7 42 7 42
MDQ4 A9 D6 A9 D6 VHALF
DQ3 DQ12 A9 DQ6 A9 DQ6
8 1 8 47 8 41 8 41 IC1251
R1486 A8 D13 A8 D13
DQ4 DQ11 A8 DQ13 A8 DQ13
2
56
C1482 9 46 MDQ11 A19 9 40 D5 A19 9 40 D5 1 VR 28
VDDQ2 GNDQ3 XWR1 10 A19 DQ5 A19 DQ5 PreVcc
5 4 0.1u/10 10 45 5 4 39 10 39 2 OPIN2+ 27 C1524
MDQ5 MDQ10 XWR1 D12 A20 D12 TD2 0.047u/16
DQ5 DQ10 NC1 DQ12 NC1 DQ12
6 3 R1481 11 44 6 3 11 38 11 38 TD1 R1251 3 OPIN2-OPIN3+ 26 MD1 MD2
MDQ6 56 MDQ9 FRES D4 XWR1 D4 TD M
DQ6 DQ9 WE DQ4 WE DQ4
4
7 2 12 43 C1487 7 2 12 %RESET 37 C1403 12 %RESET 37 C1408 33k R1252 OPIN3-
4 OPOUT2 25 R1255
MDQ7 MDQ8 FRES
R1401
C1401
GNDQ2 VDDQ3
220
VCC VCC OPOUT3
0.1u/16
8 1 13 42 0.1u/10 8 1 13 36 0.1u/10 13 36 0.1u/10 47k 5 OPIN1+ 24 18k
D11 D11 FD2 CRGDR
DQ7 DQ8 NC2 DQ11 NC2 DQ11 OPINSL CRGDRV
C1484 14 41 C1410 14 35 D3 14 35 D3 FD FD1 R1253 6 OPIN1- 23 R1256 7.5k
VDD2 GND2 WP DQ3 WP DQ3 LDIN
0.1u/10 15 40 15 RY/BY 34 15 RY/BY 34 R1254 OPOUTSL
7 OPOUT1 22
DQM0 0.1u/16 D10 D10 33k LDIN
LDQM NC2 NRES DQ10 DQ10 LDIN
5 4 16 39 R1489 C1523
XWE DQM1 A18 GNDD 16 33 D2 A18 16 33 D2 47k 0.22u/6.3
WE UDQM A18 DQ2 A18 DQ2
6 3 R1482 17 38 56 17 32 17 32 29 30
XCAS 56 MCK A17 D9 A17 D9
CAS CLK A17 DQ9 A17 DQ9 FIN1 FIN2
7 2 18 37 18 31 18 31
XRAS A7 D1 A7 D1 CNT1
RAS CKE A7 DQ1 A7 DQ1
8 1 19 36 19 30 19 30 8 GND1 21 R1258 220
XCSM MA11 A6 D8 A6 D8 CONT
CS NC1 A6 DQ8 A6 DQ8 CNT
5 4 20 35 5 4 20 29 20 29 CNT2 R1257 220 9 MUTE 20
BA0 MA9 A5 D0 A5 D0 CONT2
BA0 A11 A5 DQ0 A5 DQ0 GND2
6 3 R1483 21 34 R1487 6 3 21 28 21 28 C1254 10 19 C1255
BA1 56 56 A4 DGND1 XRD A4 DGND2 XRD PowVcc1
BA1 A9 A4 OE A4 OE
7 2 22 33 7 2 22 27 22 27 FOP2 0.1u/16 11 PowVcc2 18 0.1u/16
MA10 MA8 A3 A3 FOP LECRG
A10 A8 A3 VSS1 A3 VSS1 VO1- VO4-
8 1 23 32 8 1 23 26 23 26 FOM2 12 17
MA0 MA7 A2 XCSF1 A2 XCSF2 FOM LECRGM
A0 A7 R1488 5 A2 CE A2 CE VO1+ VO4+
5 4 24 31 4 24 25 100k 24 25 R1405 TOM2 13 16
MA1 56 MA6 A1 A1 TOM SPDLP
A1 A6 A1 A0 A1 A0 VO2- VO3-
6 3 R1484 25 30 6 3 R1402 100k TOP2 14 15
MA2 56 MA5 A0 A0 TOP SPDLM
F
A2 A5 VO2+ VO3+
7 2 26 29 7 2 CWW5043 GNDD R1406
MA3 MA4 CWW5044 VD8
A3 A4
8 1 C1485 27 28 8 1 4.7k BA5839FP
CCG1222-A
4.7u (2125)
VDD3 GND1
C1253
C1252
C1251
100u/16
0.1u/10
0.1u/16
M12L64164A-5TG2M
GNDD3 GNDP5 GNDP4
GNDD
SDRAM MOTOR DRIVER
GNDD GNDP
C
AVH-X5500BHS/XNUC
142
1 2 3 4
5 6 7 8
C-b
TEMP
TD
FE2
FE1
F+H_G+H
E+G_E+F
C DVD CORE UNIT
1000->1049 :POWER SUPPLY
1100->1199 :PU
1200->1299 :ACT+SPDL
1400->1449 :FLASH
1480->1499 :SDRAM
1500->1599 :DV5(SYS)
1600->1669 :DV5(FE)
1670->1699 :DV5(BE)
1700->1749 :VIDEO
1800->1849 :AUDIO (ANALOG)
1850->1899 :AUDIO (DIGITAL)
12k
IC1004
1900->1950 :OUTSIDE I/F NJM2855DL1-33
1950->1999 :USB
2 GND
3 Vout
1 Vin
R1602
12k
VDSENS VCC33
VCC33 VD5
B
2.2u/10
C1010
C1011
1u/10
VHALF
IC1953
S-1135D12-A6
R1603 VCC12 GNDD
C1608 (2125) VCC33 1 6
GNDA3
10k (D) CCG1201-A
TEMP
VREF1 VCC12 VOUT VIN
2 7 5
C1953
1u/10
C1601 4.7u C1607 VSS NC2
VREF CCG1192-A 3 4
C1954
10u
1u/10
0.01u/16 VREF2 C1623 NC1 ON/OFF
AD2
1u/10 (1608) (2125)
GND
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
E+G_E+F 111
VHALF 110
109
C1609
1M
R1605 1M
0.1u/10
GNDD
TEMP
FD
TD
VDSENS
AVSSH
VREFH
AD4
AD2
R1604
108
F+H_G+H
VIN7
VIN1
VIN2
VIN4
VIN3
VIN6
VIN5
VIN8
107
AVSSB 106
AVDDB LPCO2
LPCO2 105
CDMPD
CDMPD
104 LPCO1
LPCO1
103 DVDMPD
DVDMPD
102
VREFL5 F1001
101 DTF1106-A
VREFH5
100 C1612 L1902
0.1u/10 B VD8 1 3
VIN3RF
99 C1613 A CTF1487-A
VIN4RF 0.1u/10
98 C1614 2
0.1u/10 C
VIN2RF
97 C1615 0.1u/10 D
VIN1RF IC1003
96 C1616 0.1u/10 RF VCC5_AU
RFINP 5 1 GNDP
95 C1617 VOUT VIN C1040
RFINN 0.1u/10 VCC5_AU
(1608)
2
94 VSS 820p/50
ANAMONI2 ANAMONI2
C1001
C1005
4 3
(1608)
1u/10
93 NC ON/OFF R1043
ANAMONI1 ANAMONI1
C1625
1u/16
92 0.1u/10 NM
AVDDC (3216)
C
S-1200B50-M5
91 C1618 100p/50 GNDAU GNDV
CDATA
90 C1619 5600p/25 IC1002 C1041
CCAPA S-1133B50-U5
89 0.1u/16 VIN 4 270p/50
3 ON/OFF
GNDP3
AVSSC R1045
88 C1620 C1002
VREFL7 0.22u/6.3 VCC5 2 VSS NM
87 GNDAU (3216)
VCC5 VOUT5 1 NC
AVSSD
86 C1621 0.22u/6.3 GNDP GNDD
CCG1201-A
GNDA
GNDP2
VREFH7
C1004
85 C1622
(2125)
0.1u/16
0.033u/16 4.7u GNDA1
C1003
PLFIL1 GNDA2
84 C1624 0.1u/10
AVDDD
83 C1521 CN1952
CKS6025-A
GNDP1
VDD12_3 VD8_P2 VD8_P1
82 0.1u/10
VSS_8 GNDA 30 VD8
81 C1015
TRCST TRCST 1000p/50 VD8
TRCST 29
80 TRCDATA3 VD8_A VD8
TRCDATA3 28
79 TRCDATA2 VD5 1 3 PGND
TRCDATA2 27
78 TRCDATA1 F1002 GNDD1 GNDD2 PGND
TRCDATA1 2 26
77 TRCDATA0 DTL1106-A VD5_2 VD5_1
TRCDATA0 25 DGND
76 TRCCLK L1903 CTF1558-A
TRCCLK 24 VD5
75 AMUTE AMUTE R1019 AMUTE AMUTE
EXTRG1 23
74 EXTRG0 NRES 100 NRES XRESET
EXTRG0 22
73 SDATA SDATA IRQPWR IRQPWR IRQPWR
SDATA 21
72 SCLOCK SCLOCK CMDCOMN CMDCOMN HSTCMD
SCLOCK 20
71 STSCOMN STSCOMN
FG 19 SLVSTS
70 R1523 NRES STANDBY R1025 STANBY
NRES 18 STANBY
100k
C1522
4.7k
100k
69 220 100
1k
1k
AGND
0.01u/16
VDD33_5 17
RO
A 2/6
C1526
R1522
R1516
R1510
R1509
R1524
68 0.1u/10 ROUT ANALOG ROUT
VSS_7 16
67 R1513 CRGDRV
CRGDRV 10k 15 AGND
66 R1514 LO
MD
65
18k
HOME
MD LOUT
14 ANALOG LOUT
CN751
HOME 13 AGND
64 CONT2 COMPOSITE R1027 COMPOSITE
CONT2 12 COMPOSIT
CONT1
63
62
CONT1
LDIN
100
11 VIDEO GND
D
LDIN 10 DGND
61 CP_RESET R1532 CP_RST D- D-
CP_Reset 9 D-
P13 60 100 D+ D+ D+
XCSSR 59 8
XCSF1 DGND
SCKDAC 7
SDODAC 58 SCKDAC IECOUT
LTDAC 6 IECOUT
12EJ 57
USB_CLOCK
SDODAC
CMDCOMN
5 DGND
STSCOMN
I2C_SCL
VDD12_2
VDD33_4
I2C_SDA
56 SCL
IRQPWR
LTDAC I2C_SCL
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
4
VSS_5
VSS_6
55 SDA SCL
08EJ
12EJ I2C_SDA
A20
3 SDA
CP_RST CP_RST
2 RESET
100k
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
100k
GNDAU2
10k
VD8
1k
10k
1 DGND
GNDV1 GNDV2
R1004
47k
R1537
R1525
R1519
R1535
R1526
VSENS
R1540 STSCOMN VDSENS
GNDAU3
220
0.1u/10
0.1u/10
C1520
C1519
R1541
1000p/50
220 CMDCOMN
0.1u/10
R1007
C1018
C1016
6.8k
R1539 R1534 IRQPWR
100k 220
R1533 C1528 470p/50
NM R1536 100k GNDD GNDAU GNDV CN1101
CKS6331-A
R1547
NM
TOP TOP1
1 T+
FOM
R1542 2 F-
10k 08EJ FOP FOP1
3 F+
R1527 6.8k R1544 180 I2C_SDA TOM
4 T-
R1546 6.8k R1543 180 I2C_SCL VCC5 VREF
5 GND
TEMP
A20
A6
A5
A4
A3
A2
A1
X1950 6 TEMP
C1950 4 X2 3
R1952
GND2 C1108 7
0.01u/16 TEMP GND
0.1u/10
C1952
10p/50
1M
8 Vref
5 1 1 2 VCC5_PU
VCC NC GND1 9
E
X1 VCC
R1953
2 F+H_G+H F+H_G+H C1110 0.01u/16
820
IN_A CSS1760-A 10 F+H/G+H
4 3 48.000 MHz E+G_E+F E+G_E+F
OUT_Y GND 11 E+G/E+F
PU UNIT (DP11)
48MHz
C1951
10p/50
12 SW
IC1951 CDLD0
CDLDO 78LD
13
TC7SZU04FU DVDLD0
DVDLDO 65LD
14
GNDD LD GND
15
B B
HOME
CSN1080-A A A
16 B
HOME S1 17 A
4 31
HOME R1223 C C
2
18 C
560 C1223 D D
19 D
NM S2 NM FE1 FE1
20 FE1
4 31
28 08EJ R1224 08EJ FE2 FE2
2
c VR1101 21 FE2
27 C1524 NM C1224 IMON
0.047u/16 CCP1447-A 22
+ 26 CDMPD CDMPD 2 IMON
MD1 MD2 MD NM
S3 CSN1081-A R1982 23 RF
- 25
4 31
R1255 12EJ R1225 12EJ DVDMPD DVDMPD 2
R1113 R1118 3 1 8.2k
2
VCC5
T3 24
1
18k CRGDRV 470 6.8k(B)
C1225 R1110 3.9 3.9
CDLD1
CDLD2
L 23 CRGDRV 3 1
R1256 7.5k VR1102
(2125)
3.3
L 22
LDIN
SWITCHES: 12EJ GNDD NM (1608*4) CCP1449-A
C1105
10u (2125)
R1105
0.1u/10
RF 15k(B)
DCH1256-A
LDIN RF
430
CCG1192-A
R1114 R1117
(F)
C1112
N C1523
0.22u/6.3
DVD CORE UNIT
C1101
3.3 3.9
22u
30
S1:HOME SWITCH.........ON-OFF
C1109
C1111
0.22u/16
0.22u/16
(1608)
(1608)
CNT1 Q1104
LPCO2 Q1102 2SB1132(QR) CDLDO
21 R1258
T
220 CONT1
S3:12EJ SWITCH............ON-OFF LSC4081UB(QRS)
R1102
R1106
20
100k
C1107
560
2
The underlined indicates the switch position.
(F)
19 C1255 0.01u/16
GNDA
3
2 18 0.1u/16 R1112 R1115
LECRGP
17 3.3 2.7
DVDLD1
DVDLD2
LECRGM R1109
(2125)
+ (1608*4)
16 WHITE 3.3
DCH1256-A
SPDLP LECRGM LECRGM
M
0.1u/10
M1 CXC4026
C1104
C1113
3
R1103
1
15 R1111 R1116
430
SPDLM
(F)
0.1u/16
C1955
F
+
22u
CRG(L/E) MOTOR 3.3 2.7
VD8 Q1103
LECRGP GREEN 2SB1132(QR)
LECRGP DVDLDO
CCG1222-A
4.7u (2125)
LPCO1 Q1101
1
LSC4081UB(QRS)
C1253
C1252
C1251
100u/16
SPDLM BLK
0.1u/16
SPDLM
M
1
M2 EXM2002
R1101
R1104
DP4
100k
0.1u/16
510
C1210
(F)
SPINDLE MOTOR GNDA4 C1106
SPDLP SPDLP RED 0.01u/16
GNDP
C
1
GNDA
AVH-X5500BHS/XNUC
5 6 7 8
143
F
E
B
A
D
C
144
C-a C-b
C-b
FE2
FE1
TEMP
DVD CORE UNIT
F+H_G+H
E+G_E+F
1
1
C
1000->1049 :POWER SUPPLY
1100->1199 :PU
1200->1299 :ACT+SPDL
1400->1449 :FLASH
1480->1499 :SDRAM
1500->1599 :DV5(SYS)
1600->1669 :DV5(FE)
1670->1699 :DV5(BE)
1700->1749 :VIDEO
1800->1849 :AUDIO (ANALOG)
1850->1899 :AUDIO (DIGITAL)
IC1004
1900->1950 :OUTSIDE I/F NJM2855DL1-33
1950->1999 :USB
3 Vout
2 GND
1 Vin
VDSENS VCC33
VCC33 VD5
VHALF
1u/10
2.2u/10
2
2
C1010
C1011
IC1953
S-1135D12-A6
03 VCC12 GNDD
C1608 (2125) VCC33 1 6
k (D) VREF1 CCG1201-A VCC12 VOUT VIN
2 7 5
01 4.7u C1607
TEMP
VSS NC2
GNDA3
CCG1192-A 3 4
1u/10
VREF
C1953
u/16 VREF2 C1623 10u NC1 ON/OFF
AD2
1u/10
C1954
1u/10 (1608) (2125)
GND
C1609
123
122
121
120
119
118
117
116
115
114
113
112
109
0.1u/10
1M
GNDD
108
AD2
VIN7
TEMP
VIN1
VIN2
VIN4
VIN3
VIN6
VIN5
VIN8
107
R1604
R1605 1M
VHALF
VREFH 110
VDSENS
AVSSB 106
F+H_G+H
E+G_E+F 111
AVDDB LPCO2
LPCO2 105
CDMPD
CDMPD
104 LPCO1
LPCO1
103 DVDMPD
DVDMPD
AVH-X5500BHS/XNUC
102
VREFL5 F1001
101 DTF1106-A
VREFH5
100 C1612 L1902
0.1u/10 B VD8 1 3
VIN3RF
99 C1613 A CTF1487-A
VIN4RF 0.1u/10
98 C1614 2
3
3
0.1u/10 C
VIN2RF
97 C1615 0.1u/10 D
VIN1RF IC1003
96 C1616 0.1u/10 RF VCC5_AU
RFINP 5 1 GNDP
95 C1617 VOUT VIN C1040
RFINN 0.1u/10 VCC5_AU
2
94 VSS 820p/50
ANAMONI2 ANAMONI2
(1608)
4 3
93 NC ON/OFF R1043
ANAMONI1 ANAMONI1
C1001
1u/10
C1005
C1625
(1608)
92 0.1u/10 NM
AVDDC S-1200B50-M5 (3216)
1u/16
91 C1618 100p/50 GNDAU GNDV
CDATA
90 C1619 5600p/25 IC1002 C1041
CCAPA S-1133B50-U5
89 0.1u/16 VIN 4 270p/50
AVSSC 3 ON/OFF
R1045
88 C1620 0.22u/6.3 VCC5 C1002
VREFL7 2 VSS NM
GNDAU
GNDP3
87 VOUT5 (3216)
AVSSD VCC5 1 NC
86 C1621 0.22u/6.3 GNDP GNDD
VREFH7 GNDA
85 C1622 0.033u/16 GNDA1
PLFIL1 GNDA2
4.7u
GNDP2
84 C1624
C1004
(2125)
0.1u/10
C1003
0.1u/16
AVDDD CN1952
CCG1201-A
83 C1521
VDD12_3 VD8_P2 VD8_P1 CKS6025-A
82 0.1u/10
VSS_8 GNDA 30 VD8
C1015
GNDP1
81 TRCST TRCST 1000p/50
TRCST 29 VD8
80 TRCDATA3 VD8_A VD8
TRCDATA3 28
79 TRCDATA2 VD5 1 3 PGND
TRCDATA2 27
4
4
78 TRCDATA1 F1002 GNDD1 GNDD2 PGND
TRCDATA1 2 26
77 TRCDATA0 DTL1106-A VD5_2 VD5_1
TRCDATA0 25 DGND
76 TRCCLK L1903 CTF1558-A
VD5
TRCCLK 24
75 AMUTE AMUTE R1019 AMUTE AMUTE
EXTRG1 23
74 EXTRG0 NRES 100 NRES XRESET
EXTRG0 22
73 SDATA SDATA IRQPWR IRQPWR IRQPWR
SDATA 21
72 SCLOCK SCLOCK CMDCOMN CMDCOMN HSTCMD
SCLOCK 20
71 STSCOMN STSCOMN
FG 19 SLVSTS
70 R1523 NRES STANDBY R1025 STANBY
NRES 18 STANBY
69 C1522 220 100
1k
1k AGND
4.7k
100k
VDD33_5 17
100k
68 0.1u/10 ROUT RO
VSS_7 16 ANALOG ROUT
67 R1513
C1526
R1522
R1516
R1510
R1509
R1524
0.01u/16
CRGDRV
CRGDRV
R1514
10k
LO 15 AGND
A 2/6
66 18k MD LOUT ANALOG LOUT
MD 14 CN751
75 AMUTE AMUTE R1019 AMUTE AMUTE
EXTRG1 23
74 EXTRG0 NRES 100 NRES XRESET
EXTRG0 22
73 SDATA SDATA IRQPWR IRQPWR IRQPWR
SDATA 21
72 SCLOCK SCLOCK CMDCOMN CMDCOMN HSTCMD
SCLOCK 20
71 STSCOMN STSCOMN
FG 19 SLVSTS
70 R1523 NRES STANDBY R1025 STANBY
NRES 18 STANBY
69 C1522 220 100
1k
1k
AGND
4.7k
100k
VDD33_5 17
100k
68 0.1u/10 ROUT RO
VSS_7 16 ANALOG ROUT
67 R1513
C1526
R1522
R1516
R1510
R1509
R1524
0.01u/16
CRGDRV
CRGDRV
R1514
10k
LO 15 AGND
A 2/6
66 18k MD LOUT ANALOG LOUT
MD 14 CN751
65 HOME
HOME 13 AGND
64 CONT2 COMPOSITE R1027 COMPOSITE
CONT2 12 COMPOSIT
63 CONT1 100 VIDEO GND
CONT1 11
62 LDIN
LDIN 10 DGND
5
5
61 CP_RESET R1532 CP_RST D- D-
CP_Reset 9 D-
P13 60 100 D+ D+
8 D+
XCSSR 59 XCSF1 DGND
SCKDAC 7
SDODAC 58 SCKDAC IECOUT
LTDAC 6 IECOUT
12EJ 57 SDODAC
5 DGND
56 LTDAC I2C_SCL SCL
4 SCL
55 12EJ I2C_SDA SDA
3 SDA
I2C_SCL
I2C_SDA
08EJ
EXADT3
EXADT2
EXADT1
VSS_5
VDD12_2
IRQPWR
USB_CLOCK
VSS_6
VDD33_4
CMDCOMN
STSCOMN
A20
CP_RST CP_RST
2 RESET
41
42
43
45
46
47
40
44
48
49
50
51
52
53
54
VD8
1k
1 DGND
10k
100k
10k
100k
GNDAU2
47k
VSENS
R1004
R1540
R1537
R1525
R1519
R1535
R1526
220 STSCOMN VDSENS
R1541 CMDCOMN
220
C1520
GNDV1 GNDV2
0.1u/10
GNDAU3
0.1u/10
C1519
6.8k
R1007
C1018
C1016
0.1u/10
1000p/50
R1539 IRQPWR
100k R1534 220
R1533 C1528 470p/50
NM R1536 100k GNDD GNDAU GNDV CN1101
CKS6331-A
TOP1
NM
TOP
1
R1547
T+
FOM
R1542 2 F-
10k 08EJ FOP FOP1
6
6
3 F+
R1527 6.8k R1544 180 I2C_SDA TOM
4 T-
R1546 6.8k R1543 180 I2C_SCL VCC5 VREF
5 GND
TEMP
6 TEMP
A3
A2
A1
A20
C1950 4 X1950
GND2 X2 3 C1108 7
0.01u/16 TEMP GND
0.1u/10
R1952
8 Vref
1M
5 1 1 2 VCC5_PU
C1952
10p/50
VCC NC X1 GND1 9 VCC
2 F+H_G+H F+H_G+H C1110 0.01u/16
IN_A CSS1760-A 10 F+H/G+H
820
4 3
R1953
48.000 MHz E+G_E+F E+G_E+F
OUT_Y GND 11 E+G/E+F
12 SW
PU UNIT (DP11)
IC1951 CDLD0
48MHz
CDLDO
C1951
13 78LD
10p/50
TC7SZU04FU DVDLD0
DVDLDO 65LD
14
GNDD LD GND
15
B B
16 B
HOME
CSN1080-A A A
HOME S1 17 A
R1223
2
HOME C C C
18
4 31
560 C1223 D D
19 D
NM S2 FE1 FE1
AVH-X5500BHS/XNUC
NM 20 FE1
R1224 08EJ FE2
2
08EJ FE2
21 FE2
4 31
C1524 NM C1224 VR1101 IMON
0.047u/16 CCP1447-A 22
CDMPD CDMPD 2 IMON
7
7
D1 MD2 MD NM
S3 CSN1081-A R1982 23 RF
R1255 R1225 12EJ DVDMPD
2
12EJ VCC5 R1113 R1118 DVDMPD 2 3 1 8.2k
4 31
18k CRGDRV 470 6.8k(B)
C1225 R1110 3.9 3.9
RGDRV 1 3 1
R1256 7.5k VR1102
LDIN NM 3.3 (1608*4) CCP1449-A
CDLD1
CDLD2
LDIN 12EJ GNDD RF RF 15k(B)
SWITCHES: R1114 R1117
(2125)
430
(F)
C1523
C1105
R1105
0.22u/6.3 0.1u/10 3.3 3.9
C1112
DVD CORE UNIT
22u
10u (2125)
C1101
DCH1256-A
CCG1192-A
CNT1 S1:HOME SWITCH.........ON-OFF Q1104
LPCO2 Q1102 2SB1132(QR) CDLDO
C1109
C1111
(1608)
(1608)
R1258 220 CONT1 LSC4081UB(QRS)
0.22u/16
0.22u/16
S3:12EJ SWITCH............ON-OFF
C1107
560
(F)
C1255 0.01u/16
100k
The underlined indicates the switch position.
R1102
R1106
GNDA
0.1u/16 LECRGP R1112 R1115
LECRGM
3 R1109 3.3 2.7
LECRGM WHITE 3.3 (1608*4)
SPDLP LECRGM
(2125)
1
M
DVDLD1
DVDLD2
M1 CXC4026 R1111 R1116
SPDLM
430
(F)
C1104
C1113
3 CRG(L/E) MOTOR
0.1u/10
R1103
3.3 2.7
22u
VD8 Q1103
DCH1256-A
C1955
0.1u/16
LECRGP GREEN 2SB1132(QR)
LECRGP LPCO1 Q1101 DVDLDO
1
SPDLM SPDLM BLK LSC4081UB(QRS)
1
M M2 EXM2002
C1253
C1252
C1251
0.1u/16
100u/16
510
(F)
CCG1222-A
4.7u (2125)
100k
SPINDLE MOTOR GNDA4 C1106
R1101
R1104
8
8
C1210
0.1u/16
SPDLP SPDLP RED 0.01u/16
1
GNDA
C-a C-b
C-b
145
E
A
D
C
F
B
F
E
B
A
D
C
146
C-a C-b
C-b
C-a
D+
D-
FD
TD
FE2
FE1
TEMP
LTDAC
SDODAC
SCKDAC
IECOUT
C1806
1
1
COMPOSITE
C1801 CCG1192-A
CCG1201-A R1803 10u
ROUT
4.7u 820 (2125)
(2125)
11
12
100k
R1801
C1803
ADAC
1800p/50
MD 13
MC 14
ML 15
SCK 16
AGND 9
VCOM 10
GNDAU1
IC1801
VOUTR
VOUTL
VCC
NC
DGND
LRCK
DATA
BCK
PCM1753DBQ
8
7
6
5
4
3
2
1
C1802
100k
R1802
C1804
CCG1201-A
1800p/50
LOUT R1804
4.7u 820 X1501 27.000 MHz
(2125)
R1672
200 (D)
CSS1823-A C1604
4 X2 3
NC2 GNDV
68p/50
VCC5_AU D1901
12k
1 2 RKZ6.8TKJ C1602
R1601
X1 NC1
C1512 100p/50
C1510
C1805
C1809
C1605
0.1u/10
0.1u/10
10p/50 10p/50 RKZ6.8TKJ
D1902
68p/50
12k
GNDD R1955 15k C1603
R1602
IEC
1.2k
GNDAU GNDD
R1501
R1503 R1954 15k R1670 R1983 100p/50
10k 100 R1671
1M
VCC33 GNDD (D) (D) 24k
2
2
120
C1674 (D)
220
R1504
MDQ15
(1608)
0.1u/10
24 (F) (1608)
24 (F)
MDQ0
R1950
R1951
R1508
GNDD5
R1603
0
MDQ14 10k (D)
100
100
100
1u/10
0.1u/10
GNDA C1601
TEMP
MDQ1
30k (D)
L1511
(1608)
C1673
C1511
R1674
C1606
0.1u/10
C1515
0.1u/10
0.1u/10
0.01u/16
C1514
0.1u/10
0.1u/10
VCC12
VTL1126-A
AD2
C1671
C1676
R1506
R1507
R1987
R1505
162
161
158
157
156
155
154
153
152
151
150
149
148
147
140
133
132
131
130
129
128
127
126
125
124
123
120
119
146
145
144
143
142
141
139
138
137
136
135
134
122
121
118
117
116
115
10u
10u
C1502
C1501
(2125)
(2125)
CCG1192-A
163
CCG1192-A
FD
TD
MDQ13
AD4
AD2
VIN7
LOUT
VREF
TEMP
VIN1
VIN2
VIN4
VIN3
VIN8
MDQ1
MDQ0 159
OSCO
OSCI
LRCK
SRCK
ROUT
MDQ2 164
AVSSG
AVDDG
AVDDE
AVSSE
AVSSF
COMP2
IREF1
COMP1
AVDDF
AVDDH
AVSSH
MDQ14 160
MDQ15
VSS_9
ADOUT
DACCK
AVDDI
AVSSI
VDSENS
VSS_10
IECOUT
165 MDQ13
DAC1OUT
DAC5OUT
DAC2OUT
DAC3OUT
VDD12_4
VDD33_6
MDQ2
VSS_11
COMPOSITE
C1504 166
VDD33_7
MDQ12 0.1u/10 167
MDQ12
MDQ3 168
MDQ3
AVH-X5500BHS/XNUC
MDQ11 169
MDQ11
MDQ4 170
MDQ4
MDQ10 171
MDQ10
MDQ5 172
MDQ5
173
3
3
VSS_12
C1505 174
VDD33_8
MDQ9 0.1u/10 175
MDQ9
MDQ6 176
MDQ6
MDQ8 177
MDQ8
MDQ7 178
MDQ7
DQM0 179
DQM0
DQM1 180
DQM1
XWE 181
NWE
182
L1501 VSS_13
MCK R1512 183
MCK
47 CTF1743-A C1506 184
VDD33_9
0.1u/10 185
MCKI
186
VSS_14
C1503 187
VDD12_5
100k
0.1u/10 188
R1538
XCAS
NCAS
XRAS 189 IC1501
NRAS MN2DS0018MA
XCSM 190
NCSM
STANDBY 191
STANDBY
MA11 192
DQM3
4
4
BA0 193
BA0
MA9 194
MA9
195
VSS_15
C1507 196
VDD33_10
BA1 0.1u/10 197
BA1
MA8 198
MA8
MA10 199
MA10
MA7 200
MA7
MA0 201
MA0
MA6 202
MA6
MA1 203
MA1
204
VSS_16
C1508 205
VDD33_11
0 1 /10
C1507 196
VDD33_10
BA1 0.1u/10 197
BA1
MA8 198
MA8
MA10 199
MA10
MA7 200
MA7
MA0 201
MA0
MA6 202
MA6
MA1 203
MA1
204
VSS_16
C1508 205
VDD33_11
MA5 0.1u/10 206
MA5
MA2 207
MA2
MA4 208
MA4
MA3 209
MA3
5
5
210
VSS_17
C1509 211
VDD12_6
0.1u/10 212
EXADT0
213
NEXCE
214 NEXOE
215 EXDT0
EXDT8
216
I2C_SCL
I2C_SDA
EXDT1
EXDT10
VSS_1
VDD33_1
EXDT3
EXDT11
EXDT4
EXDT12
EXDT5
EXDT13
EXDT6
EXDT14
VSS_2
VDD33_2
EXDT7
EXDT15
VSS_3
VDD12_1
EXADR16
EXADT15
EXADT14
EXADT13
EXADT12
EXADT11
EXADT10
EXADT9
EXADT8
EXADR19
NEXWE
VSS_4
VDD33_3
EXADR18
EXADR17
EXADT7
EXADT6
EXADT5
EXADT4
EXADT3
EXADT2
EXADT1
VSS_5
VDD12_2
IRQPWR
A20
1
2
3 EXDT9
4 EXDT2
6
7
8
9
5
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
VCC33
DEBUG
GNDD
GNDD4
0.1u/10
0.1u/10
0.1u/10
0.1u/10
0.1u/10
C1513
C1516
C1517
C1518
C1519
CN1951
1 20
2 19
3 18
4 17
5 16
6 15
7 14
8 13
9 12
R1539
10 11
NM R1517 10k 100k
R1529 10k R1533
GNDD R1531 10k NM
NM
R1518 10k
R1547
R1971 NM
R1972 NM
R1973 NM
R1974 NM
R1975 NM
R1976 NM
R1977 NM
R1978 NM
R1979 NM
R1528 10k
R1530 10k R1542
10k
6
6
R1527 6.8k
R1546 6.8k
TRCST
TRCDATA3
TRCDATA2
TRCDATA1
TRCDATA0
TRCCLK
EXTRG0
SDATA
SCLOCK
A0
XCSF2
XRD
D0
D8
D1
D9
D2
D10
D3
D11
D4
D12
D5
D13
D6
D14
D7
D15
A16
A15
A14
A13
A12
A11
A10
A9
A8
A19
XWR1
A18
A17
A7
A6
A5
A4
A3
A2
A1
A20
VCC33
L1904
CTF1528-A
FLASH 16M FLASH 16M
IC1401 IC1402 VCC33
10u
VCC33
C1490
C1489
C1480 IC1480
(2125)
1000p/50
1 54 A15 1 48 A16 A15 1 48 C1409 A16
CCG1192-A
A15 A16 C1404 A15 A16
MDQ0 R1490 0.1u/10 2 VDD1 GND3 53
A14 2 47 CCG1201-A A14 2 47 CCG1201-A
DQ0 DQ15 R1485 A14 BYTE A14 BYTE
C1481 56 4.7u (2125) 4.7u (2125)
56 3 52 MDQ15 A13 3 46 A13 3 46
VDDQ1 GNDQ4 A13 VSS2 A13 VSS2
0.1u/10 4 51 5 4 45 45
MDQ1 MDQ14 A12 4 A12 D15 A12 4 A12 D15
DQ1 DQ14 DQ15/A-1 DQ15/A-1
5 4 5 50 6 3 5 44 5 44
MDQ2 MDQ13 A11 D7 A11 D7
DQ2 DQ13 A11 DQ7 A11 DQ7 VHALF
6 3 R1480 6 49 C1488 7 2 6 43 6 43
MDQ3 56 MDQ12 A10 D14 A10 D14
GNDQ1 VDDQ4 A10 DQ14 A10 DQ14
7 2 7 48 0.1u/10 8 1 7 42 7 42
MDQ4 A9 D6 A9 D6 VHALF
DQ3 DQ12 A9 DQ6 A9 DQ6
8 1 8 47 8 41 8 41 IC1251
R1486 A8 D13 A8 D13
AVH-X5500BHS/XNUC
DQ4 DQ11 56 A8 DQ13 A8 DQ13
C1482 9 46 MDQ11 A19 9 40 D5 A19 9 40 D5 1 VR 28
VDDQ2 GNDQ3 DQ5 A19 DQ5 PreVcc
4 4
MDQ5 5 0.1u/10 10 45 5 MDQ10
XWR1 10 A19 39 D12 A20 10 39 D12
2 2 OPIN2+ 27 C1524
DQ5 DQ10 XWR1 NC1 DQ12 NC1 DQ12 TD2 0.047u/16
OPIN3+
7
7
6 3 R1481 11 44 6 3 11 38 11 38 TD1 R1251 26 MD1 MD2
MDQ6 56 MDQ9 FRES D4 XWR1 D4 TD 3 OPIN2- M
DQ6 DQ9 WE DQ4 WE DQ4 OPIN3-
7 2 12 43 C1487 7 2 37 C1403 37 C1408 33k R1252 25 R1255
MDQ7 MDQ8 12 %RESET FRES 12 %RESET 4 OPOUT2
GNDQ2 VDDQ3 VCC VCC OPOUT3
8 1 8 1 0.1u/10
4 18k
220
13 42 0.1u/10 13 36 D11 13 36 0.1u/10 D11 47k 5 OPIN1+ 24 CRGDR
FD2
R1401
C1401
DQ7 DQ8 NC2 DQ11 NC2 DQ11 OPINSL CRGDRV
C1484 14 41 C1410 14 35 14 35 FD1 R1253 23 R1256 7.5k
0.1u/16
D3 D3 FD 6 OPIN1-
LDIN
VDD2 GND2 WP DQ3 WP DQ3 OPOUTSL
DQM0 0.1u/10 15 40 0.1u/16 15 RY/BY 34 D10 15 RY/BY 34 D10 33k R1254 7 OPOUT1 22 LDIN
LDQM NC2 NRES DQ10 DQ10 LDIN
5 4 16 39 R1489 33 16 33 47k C1523
XWE DQM1 A18 GNDD 16 D2 A18 D2 0.22u/6.3
WE UDQM A18 DQ2 A18 DQ2
6 3 R1482 17 38 56 17 32 17 32 29 30
XCAS 56 MCK A17 D9 A17 D9
CAS CLK A17 DQ9 A17 DQ9 FIN1 FIN2
7 2 18 37 18 31 18 31
XRAS A7 D1 A7 D1 CNT1
RAS CKE A7 DQ1 A7 DQ1
8 1 19 36 19 30 19 30 21 R1258 220
XCSM MA11 A6 D8 A6 D8 8 GND1 CONT
CS NC1 A6 DQ8 A6 DQ8 CNT
5 4 20 35 5 4 20 29 20 29 CNT2 R1257 220 20
BA0 MA9 A5 D0 A5 D0 CONT2 9 MUTE
BA0 A11 A5 DQ0 A5 DQ0 GND2
6 3 R1483 21 34 R1487 6 3 21 28 21 28 C1254 10 19 C1255
BA1 56 56 A4 DGND1 XRD A4 DGND2 XRD PowVcc1
BA1 A9 A4 OE A4 OE
7 2 22 33 7 2 22 27 22 27 FOP2 0.1u/16 11 PowVcc2 18 0.1u/16
MA10 MA8 A3 A3 FOP LECRG
A10 A8 A3 VSS1 A3 VSS1 VO1- VO4-
8 1 23 32 8 1 23 26 23 26 FOM2 12 17
MA0 MA7 A2 XCSF1 A2 XCSF2 FOM LECRG
A0 A7 A2 CE A2 CE VO1+ VO4+
5 4 24 31 R1488 5 4 24 25 100k 24 25 R1405 TOM2 13 16
MA1 56 MA6 A1 A1 TOM SPDL
A1 A6 A1 A0 A1 A0 VO2- VO3-
6 3 R1484 25 30 6 3 R1402 100k TOP2 14 15
MA2 56 MA5 A0 A0 TOP SPDL
A2 A5 VO2+ VO3+
7 2 26 29 7 2 CWW5043 GNDD R1406
MA3 MA4 CWW5044 VD8
A3 A4
8 1 C1485 27 28 8 1 4.7k BA5839FP
VDD3 GND1
0.1u/10
M12L64164A-5TG2M
C1253
C1252
C1251
GNDD3 GNDP5 GNDP4
0.1u/16
100u/16
GNDD
CCG1222-A
4.7u (2125)
SDRAM
8
MOTOR DRIVER
8
GNDD GNDP
C-a C-b
C-a
C-b
147
E
A
D
C
F
B
1 2 3 4
10.9 SERVICE UNIT(MONITOR) (GUIDE PAGE)
D-a TFT LCD
23 HCLK 33.3MHz
22 DVDD 3.3V
VDDG+18V
9.2V
15 OEV(Low)
VEEG-6V
16 UD(Low)
10 XON(Hi)
28 L/R (Hi)
TO LCD
27 AVDD
26 AVDD
CN5001
29 LOAD
Vcom
Vcom
14 VCLK
STV1
48 VR10
17 STV2
59 DIO1
21 DIO2
13 GND
12 GND
60 GND
25 GND
24 GND
20 GND
19 GND
18 GND
11 POL
57 VR1
56 VR2
55 VR3
54 VR4
53 VR5
52 VR6
51 VR7
50 VR8
49 VR9
NC
NC
NC
NC
58 NC
41 G0
40 G1
39 G2
38 G3
37 G4
36 G5
35 R0
34 R1
33 R2
32 R3
31 R4
30 R5
47 B0
46 B1
45 B2
44 B3
43 B4
42 B5
CKS6536-A
9
8
7
6
5
4
3
2
1
R5028
47k
R5029
47k
R5026
47k
LCDGND
HCLK
R5024
LOAD
VCLK
OEV
POL
STV
DIO
47k
G0
G1
G2
G3
G4
G5
R0
R1
R2
R3
R4
R5
B0
B1
B2
B3
B4
B5
POL
VCL
OEV
B C5021
1000p/50
C5028 STV
C5033 NM C5038 HCL
C5022 NM
R5003 R5005 R5007 R5009 R5011 R5013 R5015 R5017 R5019 R5021 C5029 NM C5042 LOA
NM C5034 0.1u/16
C5023 1000p/50 C5039 0.1u/16 R5
180 47 39 100 130 100 39 47 180 33 C5035
D% D% D% D% D% D% D% D% D% D% C5030 0.1u/50
0.1u/16 R4
4.7u/16V
C5024 0.1u/10 C5040
DTL1096-A
L5003
R5001 R5002 R5004 R5006 R5008 R5010 R5012 R5014 R5016 R5018 R5020 R5022 NM C5031 0.33u/50
R5108 CCG1192-A-T
4.7 56 D% 2.2 0 4.7 8.2 0 8.2 4.7 0 2.2 2.4 C5025
BTX1042-A
10k 10u/10V C5036
Q5106
DTL1096-A
CTF1635-A
10u/25V
L5004
R5139
2SA1577(QR)
L5002
L5001
NM
NM
1000p/50
1000p/50
0.1u/16
0.1u/16
C5001
C5003
C5005
C5017
C5019
C5020
C5015
C5002
C5004
C5006
C5007
C5008
C5009
C5010
C5011
C5012
C5013
C5014
C5016
C5018
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
NM
C5026 C5032 C5037 C5041
C5119
1000p/50 NM 2.2u/16 NM
NM
C5027
R3
D5103 C5124 NM R2
0.47u/25
C5120
LCDGND R1
4.7u/16
9.2V
C5127
LCDGND
C5126
NM
1u/25 RB548W V92 R0
G5
D5104 G4
C5125
0.47u/25 -6V
C5121 G3
VM6
G2
1u/25 RB548W 18V
V18 R5023
0
470p/50
C5051
100k D%
560p/50
91k D%
R5142
R5140
C5140
C5122
CPGND
1u/10
C5123
C D5105
9.1k D%
18k D%
R5141
RB548W
R5143
0.1u/50
G1
G0
9.2V
22uH D5101
CPGND L5101 R5107 RB162M-40 B5
CTH1426-A B4
0
R5134
IC5101 B3
10u/35
10u/35
C5108 R5113
C5111
0
C5112
R1290K103A
NM
UVLO 2.8V
24
LX2 23
EP CPPSW 22
CPVCC 21
20
19
B2
R5101
CPN
LX1
CPP
1 18 B1
10k
PGND1
NM
2 CPGND 17 B0
PGND2 CPPFB
3
R5136
CPPDLY 16
R5135
AGND
4.7k
120k
D%
CPNFB 15
25
4 CPPGND
VIN CPNDLY
5
4.7u/6.3
1000p/50
14
C5101
C5102
AMPOUT
VREF
LCD POWER BLOCK
DELAY
1000p/50
6 CE RT 13
R5116
C5113
DTC
D%
7 VFB
TST
3k
SS
12
10
11
9
8
R5106 C5107 COMDC
CPPGND L5102
LCTAW101J2520-T
R5102
4.7k 1000p/50 DIO
NM
R5110
8.2k
D%
R5125
R5123
R5103
6.8k
NM
10u/35
20k R5121 R5126 C5115
C5109
R5122
1200p/50
NM 0
100p/50
R5117
C5110
D%
C5103
15k
1u/6.3
4.7k
Q5103
R5111
0.012u/16
0.1u/10
R5109
1u/10
C5106
R5104
LSAR523UB
C5104
C5105
100k
D%
D%
15k
15k
Q5104
KN5004 NM
C5114
0.1u/16
R5129
R5124
1M
Q5101 M2R6TP_GND R5128
LTC014EEB
KN5001 KN5003 100
R5127
NM
M2R6TP_GND M2R6TP_GND
1
D
1 1 LCDGND
GND R5112 0
R5105
NM
BLGND GND
3.3V
LC
LCD33
R5130
NM
5
ON/OFF VOUT
CCG1201-A
10V
C5116
IC5102
476.6/514.8kHz
TFT LCD (BACK LIGHT)
4.7u
Anode
Anode
Anode
1
NC
NC
10 NC
K1
K2
K3
K4
ILMB CN5201
1
2
3
4
5
6
7
8
9
CKS6523-A
LC
R5201
BACK LIGHT
NM
2 Anode
3 Anode
1 Anode
L5202
D5201
CN5202
4 NC
10 NC
CTH1526-A
9 NC
K1
K2
K3
8 K4
L5203 6.8u DB2X41400L
TH5201 CN5
NM
5
6
7
NM CKS6
C5211
C5207
C5208
10u/35
10u/35
100p/50
CCX1058-A
0.1u/16
C5212
C5205
C5213
C5202
C5210
NM
NM
NM
XL
You might also like
- Pioneer Avh-P3400bh p2400bt 2450bt 2490bt PDF0% (1)Pioneer Avh-P3400bh p2400bt 2450bt 2490bt PDF152 pages
- Pioneer AVH-2550NEX - Z5200BT - Z5200DAB - Z5250BT - Z5290BT ERT0066No ratings yetPioneer AVH-2550NEX - Z5200BT - Z5200DAB - Z5250BT - Z5290BT ERT0066131 pages
- Pioneer - Avh-X5800bhs - Avh-X5800dab - Service Manual100% (1)Pioneer - Avh-X5800bhs - Avh-X5800dab - Service Manual109 pages
- Samsung Bn41-02079a Bn41-02295a Ua32f4088ar Ua32f4088aj Power Pus SCHNo ratings yetSamsung Bn41-02079a Bn41-02295a Ua32f4088ar Ua32f4088aj Power Pus SCH1 page
- Mitsubishi Service Manual For DLP Projection HDTV Model WD-57833No ratings yetMitsubishi Service Manual For DLP Projection HDTV Model WD-5783387 pages
- Pioneer Avh-X2600bt x2650bt x2690bt Crt5435 Car DVD ReceiverNo ratings yetPioneer Avh-X2600bt x2650bt x2690bt Crt5435 Car DVD Receiver183 pages
- Pioneer Avh-X7800bt Avh-X7850bt Avh-X7850tv crt5826 PDFNo ratings yetPioneer Avh-X7800bt Avh-X7850bt Avh-X7850tv crt5826 PDF124 pages
- Brother WORD PROCESSOR dp525cj - Service - ManualNo ratings yetBrother WORD PROCESSOR dp525cj - Service - Manual194 pages
- LOOP-H3310S Multi Rate G.SHDSL Data Transport Stand Alone User'S ManualNo ratings yetLOOP-H3310S Multi Rate G.SHDSL Data Transport Stand Alone User'S Manual155 pages
- AVH-X 8500 - 8550 - 8580 BT Manual Servico CRT 5284 PDF100% (1)AVH-X 8500 - 8550 - 8580 BT Manual Servico CRT 5284 PDF242 pages
- Pioneer Avh-280bt Avh-285bt Avh-289bt crt5859No ratings yetPioneer Avh-280bt Avh-285bt Avh-289bt crt585994 pages
- Service Manual: HR-S3902U, HR-S3912U, HR-S3912U, HR-S5902U, HR-S5912U, HR-S5912U0% (1)Service Manual: HR-S3902U, HR-S3912U, HR-S3912U, HR-S5902U, HR-S5912U, HR-S5912U20 pages
- Service Manual: Better Service Better Reputation Better ProfitNo ratings yetService Manual: Better Service Better Reputation Better Profit294 pages
- A2051-90003 PA RISC 9x8LX 800 Ex5 Class CE100% (1)A2051-90003 PA RISC 9x8LX 800 Ex5 Class CE280 pages
- DATAMAX I Class Parts List, Service ManualNo ratings yetDATAMAX I Class Parts List, Service Manual177 pages
- Sony Video Printer UP-890 - Service Manual PDFNo ratings yetSony Video Printer UP-890 - Service Manual PDF76 pages
- Service Manual Acer Aspire 5050 3050 Series100% (1)Service Manual Acer Aspire 5050 3050 Series153 pages
- Fujitsu Klima Uredjaj Kanalski Inverter Aryg24lmla Aoyg24lala Design Technical ManualNo ratings yetFujitsu Klima Uredjaj Kanalski Inverter Aryg24lmla Aoyg24lala Design Technical Manual54 pages
- Avh-X4500bt x4500dvd x4550dvd x4590dvd crt5254No ratings yetAvh-X4500bt x4500dvd x4550dvd x4590dvd crt5254189 pages
- Pioneer Avh-X1800s Avh-X1800dvd Avh-X1850dvd Avh-X1890dvd crt5820No ratings yetPioneer Avh-X1800s Avh-X1800dvd Avh-X1850dvd Avh-X1890dvd crt582095 pages
- Pioneer - AVH-X 3700bhs - X3700dab - Crt5619-Service ManualNo ratings yetPioneer - AVH-X 3700bhs - X3700dab - Crt5619-Service Manual152 pages
- Pioneer Avh-100dvd 160dvd 165dvd 169dvd Crt5438 Car DVD ReceiverNo ratings yetPioneer Avh-100dvd 160dvd 165dvd 169dvd Crt5438 Car DVD Receiver174 pages
- Pioneer Avh-X270bt Avh-X275bt Avh-X279bt SMNo ratings yetPioneer Avh-X270bt Avh-X275bt Avh-X279bt SM124 pages
- Pioneer Avh-X1700s Avh-X1750dvd Avh-X1790dvd SMNo ratings yetPioneer Avh-X1700s Avh-X1750dvd Avh-X1790dvd SM148 pages
- Avh-2300nex: Avh-Z5000bt Avh-Z5050bt Avh-Z5050bt Avh-Z5050bt Avh-Z5090btNo ratings yetAvh-2300nex: Avh-Z5000bt Avh-Z5050bt Avh-Z5050bt Avh-Z5050bt Avh-Z5090bt135 pages
- 128Mb Synchronous DRAM Specification: A3V28S40JTPNo ratings yet128Mb Synchronous DRAM Specification: A3V28S40JTP40 pages
- Videomate U880 Usb 2.0 TV Tuner Box Start Up Guide: Compro Technology, IncNo ratings yetVideomate U880 Usb 2.0 TV Tuner Box Start Up Guide: Compro Technology, Inc16 pages
- Intelligent Monitoring Software: Installation Guide Realshot Manager AdvancedNo ratings yetIntelligent Monitoring Software: Installation Guide Realshot Manager Advanced32 pages
- LG Commercial LS55A LS53A Owners ManualNo ratings yetLG Commercial LS55A LS53A Owners Manual72 pages
- Operational Manual For Alphenix 2b308-307enNo ratings yetOperational Manual For Alphenix 2b308-307en536 pages
- Massachusetts Institute of Technology v. Funai Electric Company Et. Al.No ratings yetMassachusetts Institute of Technology v. Funai Electric Company Et. Al.23 pages
