ROCK PROOF X2P

Powder integral waterproofing additive for mortar and

concrete

PROPERTIES FIELD OF APPLICATION X2P

• Concrete containing ROCK PROOF X2P • ROCK PROOF X2P should be used in all structural
is resistant to water penetration either under concrete that is constantly or intermittently in
contact with water such as sea walls tunnels,
conditions of hydrostatic Pressure or capillary
absorption stuctural and pre-cast concrete in exposed
superstructures.

• Durability is increased due to a significant • ROCKPROOF X2P is used to waterproof cement:

Reduction in w/c ratio sand renders for walls facades , floor toppings and
jointing mortars.
• Sulphate attack is reduced due to the
Sulphate bearing ground water being
Resisted

• The cohesive properties of the concrete are

Improved thus reducing segregation and
Bleeding

• Concrete of similar workability to a control

mix produced with ROCK PROOF ® X2P
is easier to place

• Pump ability of concrete is greatly

Improved

• The surface finish of the concrete is

improved

• It disrupts the cellular network within the concrete

and mortar mass (capillaries), which are normally,
inter-connected thereby reducing permeability.

SPECIAL SURFACE WATER

ADMIXTURE SHOTCRETE GROUTS
ADMIXTURE IMPROVEMENT PROOFING
CRACK
FLOORING COATING JOINT SEALANT REPAIR TILING
INJECTION
Powder integral waterproofing additive for mortar and concrete

TECHNICAL DATA DIRECTION OF USE

X2P
TYPE X-2P MIXING:
Color Off white
powder ROCK PROOF X2P should be pre-mixed dry with
chloride content to
The cement or alternatively , it can be poured into
The mixer at the time the cement is added to the
BS5075 :1982 Nil aggregate.
nitrate content Nil
WATCH POINT:
consumption with
100kg cement 2-4Kg • Ensure specified water / cement ratio is not
specific gravity N/A exceeded; work within the range of 0.4 to 0.6.
air contents 2 ± 1% according to • Keep water content as low as possible
Grading of sand and compatible with achieving full compaction.
Water content
• Place concrete quickly and ensure it is thoroughly
freezing point 0°C. can be reconstituted, compacted.
if stirred after thawing
flash point None
• Protect new concrete against rapid drying out
and ensure adequate and complete curing with
PAGEL's ROCK CURE curing compounds.

CAUTION:

PACKAGING: ROCK PROOF X2P is not a fire or health

hazard. Spillages should be washed down
Supplied in: 1Kg or 15Kg bag immediately with cold water. For further information
refer to the material safety data sheet.
Storage: Dry; Frost free, out of direct sunlight

Shelf life: 12 months, when stores as above

Hazard class: No dangerous goods, Observe

Material Safety datasheet

The information provided in this leaflet, is supplied by our consulting service and is the end result of exhaustive research work and extensive experience. They are, however, without
liability on our part, in particular with regard to third parties proprietary rights, and do not relieve the user of the responsibility for verifying that theproducts and processes are suitable
for the intended application. The data presented was derived from tests under normal climate conditions according to DIN 50014 and mean average values and analysis. Deviations
are possible when delivery takes place. Given that recommendations may differ from those shown in this leaflet written confirmation should be sought. It is the responsibility of the
purchaser to ensure they have the latest leaflet issue and that its contents are current. Our customer service staff will be glad to provide assistance at any time. We appreciate the
interest you have shown in our products. This technical data sheet supercedes pre viously issued information.

PAGEL PAKISTAN (PVT.) LTD.

1-A, MISC. ZONE, VALUE ADDITION CITY Phone: +92-41-850-7212-13

SAHIANWALA ROAD, KHURRIANWALA. Fax: +92-41-850-7214
FAISALABAD Email: [email protected] Technical Ref. Sheet 2.02 PK
Website: www.pagelpakistan.com QS-Formblatt 01/14 Rev. 02

SPECIAL SURFACE WATER

ADMIXTURE SHOTCRETE GROUTS
ADMIXTURE IMPROVEMENT PROOFING
CRACK
FLOORING COATING JOINT SEALANT REPAIR TILING
INJECTION