Cat Electronic Technician 2021B v1.
0
Product Status Report
20-07-2021 14:03
Product Status Report
Parameter Value
Engine Serial Number MBD08641
Equipment ID NOT PROGRAMMED
Comments
C9 IND (MBD08641)
Parameter Value
Equipment ID NOT PROGRAMMED
Engine Serial Number MBD08641
ECM Serial Number 02286321JM
Personality Module Part Number 3112459-00
Software Group Release Date JAN2009
Calibration Identification Number Unavailable
Logged Diagnostic Codes [Diagnostic Clock = 11729 hours] - C9 IND (MBD08641)
Code Description Occ. First Last
3- 5 Cylinder #3 Injector : Current Below Normal 127 11722 11729
6- 5 Cylinder #6 Injector : Current Below Normal 4 11728 11729
110- 4 Engine Coolant Temperature Sensor : Voltage 1 11729 11729
Below Normal
100- 3 Engine Oil Pressure Sensor : Voltage Above 91 11590 11726
Normal
274- 4 Atmospheric Pressure Sensor : Voltage Below 2 11676 11676
Normal
100-10 Engine Oil Pressure Sensor : Abnormal Rate of 2 11628 11633
Change
Logged Event Codes [Diagnostic Clock = 11729 hours] - C9 IND (MBD08641)
Code Description Occ. First Last
E198 (1) Low Fuel Pressure 26 11429 11729
E361 (1) High Engine Coolant Temperature 113 11663 11729
E361 (2) High Engine Coolant Temperature 59 11663 11729
E194 (2) High Exhaust Temperature 1 11727 11727
E198 (2) Low Fuel Pressure 127 11627 11712
Active Diagnostic Codes - C9 IND (MBD08641)
Code Description
No Active
Diagnostic
Codes
Current Totals - C9 IND (MBD08641)
Description Value Unit
Total Operating Hours 11730 hours
Total Idle Time 4504:09 hours
Total Fuel 264525 L
Total Idle Fuel 51222 L
Total Max Fuel 593832 L
Average Load Factor 39 %
Engine Starts 12701
Lifetime Total Engine 1101224232 rev
Revolutions
Percentage Idle Time 38,40 %
Average RPM 1564,82 rpm
Average Fuel Rate 22,55 L/h
Overall Load Factor 44 %
Configuration - C9 IND (MBD08641)
Description Value Unit
Equipment ID NOT PROGRAMMED
Engine Serial Number MBD08641
ECM Serial Number 02286321JM
Personality Module Part Number 3112459-00
Software Group Release Date JAN2009
Rating Number 1
Rated Power 205 kW at 2200 rpm
Rated Peak Torque 1257 N-m at 1400 rpm
Top Engine Speed Range 1800 - 2420 rpm
Test Spec 0K4891 0K4892
Top Engine Limit Unavailable rpm
Low Idle Speed 1200 rpm
High Idle Speed 2100 rpm
Maximum Engine Torque Limit 1371 N-m
Engine Acceleration Rate 500 rpm/s
PTO Mode Set/Resume
Engine Governor Mode Override Switch Unavailable
Installation Status
Transmission Default Torque Limit Reset Unavailable
Intermediate Engine Speed 1202,0 rpm
Ether Control Disabled
Ether Solenoid Configuration Not Installed
Air Inlet Heater Installation Status Installed
Air Shutoff Disabled
Throttle Position Sensor Installed
Coolant Level Sensor Not Installed
Exhaust Valve Actuation System Not Installed
Installation Status
Auxiliary Temperature Sensor Installation Not Installed
Status
Auxiliary Pressure Sensor Installation Not Installed
Status
Throttle Input Low Idle Duty Cycle Setpoint 18,0 %
Throttle Input High Idle Duty Cycle Setpoint 83,0 %
Engine Governor Primary Mode Speed Control
Configuration
Engine Location Unavailable
Engine Governor Gain Map Part Number Unavailable
Configuration
Maintenance Indicator Mode Off
PM1 Interval 0 L
FLS -73
FTS 49
Customer Password #1 ****************
Customer Password #2 ****************
Last Tool to Change Customer Parameters
Last Tool to Change System Parameters NEVER S
Total Tattletale 27
Run Out Control Off
Runout Spd Droop Off
EX OFFSET SPD 150 rpm
EX OVR SPD TRIP 3100 rpm
Injector Trim Calibration - C9 IND (MBD08641)
Injector Serial Number File Version Tattletale
Injector1 00000000B311007918 0 1
D5
Injector2 000000003B11865982 0 0
02
Injector3 00000000B310750156 0 2
75
Injector4 000000003B11865847 0 0
8E
Injector5 00000000B311033025 0 1
0D
Injector6 000000003B11865734 0 1
AB
Monitoring System - C9 IND (MBD08641)
Description State Trip Point Delay Time
Engine Overspeed
Least Severe (1) On 2600 rpm 1 sec
Most Severe (3) On 2800 rpm 1 sec
High Auxiliary Pressure
Least Severe (1) On 1500 kPa 4 sec
Moderate Severity (2) Off 1500 kPa 3 sec
Most Severe (3) Off 1500 kPa 3 sec
High Auxiliary
Temperature
Least Severe (1) On 105 Deg C 4 sec
Moderate Severity (2) Off 106 Deg C 4 sec
Most Severe (3) Off 107 Deg C 4 sec
High Engine Coolant
Temperature
Least Severe (1) On 104 Deg C 10 sec
Moderate Severity (2) On 109 Deg C 10 sec
Most Severe (3) Off 111 Deg C 10 sec
High Engine Inlet Air
Temperature
Least Severe (1) On 75,0 Deg C 8 sec
Moderate Severity (2) On 79,0 Deg C 8 sec
High Fuel Pressure
Least Severe (1) On 758,0 kPa 8 sec
Low Coolant Level
Least Severe (1) On None 10 sec
Moderate Severity (2) On None 10 sec
Most Severe (3) On None 10 sec
Low Engine Oil
Pressure
Least Severe (1) On None 8 sec
Moderate Severity (2) On None 8 sec
Most Severe (3) On None 4 sec
Job Segment - C9 IND (MBD08641)
Description Value Unit
Time 11729:50 hours
Fuel 264525,1 L
Idle Time 4504:08 hours
Idle Fuel 51221,8 L
% Idle Time Unavailable hours
Total Fuel / Total Rated Fuel Unavailable %
Start Time 0:00 hours
End Time 11729:50 hours
Maintenance Indicator - C9 IND (MBD08641)
Description Service Status Value Unit
PM1 --- Unavailable
