KHAIRAT AL-EMAR

FOR ‫ﺷﺮﻛﺔ ﺧﯿﺮات اﻷﻋﻤﺎر‬

GENERAL CONTRACTING
COMPANY
‫ﻟﻠﻤﻘﺎوﻻت اﻟﻌﺎﻣﺔ‬

MATERIAL SAFETY DATA SHEET

NUT PLUG (ALL GRADES)

1) IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING

PRODUCT NAME NUT PLUG (ALL GRADES)

APPLICATION Lost circulation material..

SUPPLIER KHAIRAT AL-EMAR.

Iraq-Basra
Tweisa-Engineering union street-Block 42
T = +9647813676902
F = N/A
E-mail [email protected]@yahoo.com

EMERGENCY TELEPHONE (24 Hours) +9647813676902,,+9647706888957

2 )HAZARDS IDENTIFICATION
Not regarded as a health or environmental hazard under current legislation.
HUMAN HEALTH
IARC Monographs, Vol 68, 1997, concludes that there is sufficient evidence that inhaled crystalline Sillica in the form of
quartz or crystobalite from occupational sources cause cancer in humans. IARC classification Group 1. Because of
quantity and composition, the health hazard is small.

3) COMPOSITION/INFORMATION ON INGREDIENTS

NAME EC. NO. CAS NO. CONTENT CLASSIFICATION

CELLULOSE - - 60-100% -

QUARTZ,
238-878-4 14808-60-7 <1% Xn;R20.
CRYSTALLINE SILICA

The Full Text for all R-Phrases are Displayed in Section 16

COMPOSITION COMMENTS
The data shown is in accordance with the latest EC Directives. Barite is a naturally occurring mineral. This product contains
a small quantity of quartz, crystalline silica. Prolonged and repeated exposure to concentrations of crystalline silica
exceeding the workplace exposure limit (WEL) may lead to chronic lung disease such as silicosis. Because of quantity and
composition, the health hazard is small.

4) FIRST-AID MEASURES INHALATION

Move the exposed person to fresh air at once. If respiratory problems, artificial respiration/oxygen. Get medical attention if
any discomfort continues.
INGESTION
Immediately give a couple of glasses of water or milk, provided the victim is fully conscious. Get medical attention if any
discomfort continues.
SKIN CONTACT
Remove contaminated clothing immediately and wash skin with soap and water. Get medical attention promptly if
symptoms occur after washing.
 KHAIRAT AL-EMAR
FOR ‫ﺷﺮﻛﺔ ﺧﯿﺮات اﻷﻋﻤﺎر‬
GENERAL CONTRACTING
COMPANY
‫ﻟﻠﻤﻘﺎوﻻت اﻟﻌﺎﻣﺔ‬
EYE CONTACT
Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes with plenty of water while lifting
the eye lids Continue to rinse for at least 15 minutes. Get medical attention if any discomfort continues.

5 )FIRE-FIGHTING MEASURES EXTINGUISHING MEDIA

Use fire-extinguishing media appropriate for surrounding materials

Water spray, foam, dry powder or carbon dioxide.
SPECIAL FIRE FIGHTING PROCEDURES
Containers close to fire should be removed immediately or cooled with water.
PROTECTIVE MEASURES IN FIRE
Self contained breathing apparatus and full protective clothing must be worn in case of fire.

6 )ACCIDENTAL RELEASE MEASURES

PERSONAL PRECAUTIONS
Wear protective clothing as described in Section 8 of this safety data sheet.
ENVIRONMENTAL PRECAUTIONS
Do not allow to enter drains, sewers or watercourses.
SPILL CLEAN UP METHODS
Avoid generation and spreading of dust. Shovel into dry containers. Cover and move the containers. Flush the area with
water.

7 )HANDLING AND STORAGE USAGE PRECAUTIONS

Avoid inhalation of dust and contact with skin and eyes.

STORAGE PRECAUTIONS
Store in tightly closed original container in a dry, cool and well-ventilated place.

8) EXPOSURE CONTROLS/PERSONAL PROTECTION

NAME STD LT-PPM LT-MG/M3 ST-PPM ST-MG/M3

4 mg/m3
CELLULOSE WEL _ _
resp.dust

QUARTZ 0.1 mg/m3

WEL _
CRYSTALLINE SILICA resp.dust

INGREDIENT COMMENTS
WEL = Workplace Exposure Limits
PROTECTIVE EQUIPMENT
 KHAIRAT AL-EMAR
FOR ‫ﺷﺮﻛﺔ ﺧﯿﺮات اﻷﻋﻤﺎر‬
GENERAL CONTRACTING
COMPANY
‫ﻟﻠﻤﻘﺎوﻻت اﻟﻌﺎﻣﺔ‬

ENGINEERING MEASURES
Provide adequate general and local exhaust ventilation.
RESPIRATORY EQUIPMENT
Respiratory protection must be used if air contamination exceeds acceptable level. Dust filter P3 (for especially fine
dust/powder).
HAND PROTECTION
For prolonged or repeated skin contact use suitable protective gloves. Rubber or plastic.
EYE PROTECTION
Wear approved chemical safety goggles where eye exposure is reasonably probable.
OTHER PROTECTION
Wear appropriate clothing to prevent any possibility of skin contact. Provide eyewash station.

9 PHYSICAL AND CHEMICAL PROPERTIES

APPEARANCE Powder, dust

COLOUR Brown

ODOUR Odourless

SOLUBILITY Insoluble in water

RELATIVE DENSITY ~1.35 @ 20°C

10 )STABILITY AND REACTIVITY

STABILITY
Stable under normal temperature conditions and recommended use.
CONDITIONS TO AVOID
Avoid wet and humid conditions.

11 )TOXICOLOGICAL INFORMATION

INHALATION
Dust in high concentrations may irritate the respiratory system.
INGESTION
May cause discomfort if swallowed.
SKIN CONTACT
Powder may cause mechanical irritation to skin.
EYE CONTACT
Particles in the eyes may cause irritation and smarting.

12) ECOLOGICAL INFORMATION

ECOTOXICITY
Contact Khairat Al-emar’s QH&SE Department for Eco. information.

13 )DISPOSAL CONSIDERATIONS

DISPOSAL METHODS
Recover and reclaim or recycle, if practical. Dispose of waste and residues in accordance with local authority requirements.
 KHAIRAT AL-EMAR
FOR ‫ﺷﺮﻛﺔ ﺧﯿﺮات اﻷﻋﻤﺎر‬
GENERAL CONTRACTING
COMPANY
‫ﻟﻠﻤﻘﺎوﻻت اﻟﻌﺎﻣﺔ‬

14 )TRANSPORT INFORMATION

GENERAL
The product is not covered by international regulation on the transport of dangerous goods (IMDG, IATA,ADR/RID).

15 )REGULATORY INFORMATION

RISK PHRASES
NC Not classified.

SAFETY PHRASES
NC Not classified.

UK REGULATORY REFERENCES
Chemicals (Hazard Information & Packaging) Regulations. The Control of Substances Hazardous to Health Regulations
IARC
Monographs, Vol.68, 1997.

EU DIRECTIVES
Dangerous Substance Directive 67/548/EEC. Dangerous Preparations Directive 1999/45/EC.
GUIDANCE NOTES
Workplace Exposure Limits EH40.

16) OTHER INFORMATION

GENERAL INFORMATION
HMIS Health - 1 HMIS Flammability - 0 HMIS Physical Hazard - 0 E - Safety glasses, Gloves, Dust Respirator

INFORMATION SOURCES
Product information provided by the commercial vendor(s). Material Safety Data Sheet, Misc. manufacturers. Micromedex.
European Chemicals Bureau - ESIS (European Chemical Substances Information).

REVISION COMMENTS
General revision. Compiled or revised by Gorge H. Meckwire
 KHAIRAT AL-EMAR
FOR ‫ﺷﺮﻛﺔ ﺧﯿﺮات اﻷﻋﻤﺎر‬
GENERAL CONTRACTING
COMPANY
‫ﻟﻠﻤﻘﺎوﻻت اﻟﻌﺎﻣﺔ‬
NUT PLUG (ALL GRADES)

ISSUED BY Sa’eed E. Doghan

REV. NO./REPL. SDS GENERATED 7

SDS NO. 90308

RISK PHRASES IN FULL

NC Not classified.

R20 Harmful by inhalation.

DISCLAIMER

MSDS furnished independent of product sale. While every effort has been made to accurately describe this product, some
of the data are obtained from sources beyond our direct supervision. We cannot make any assertions as to its reliability or
completeness; therefore, user may rely only at user's risk. We have made no effort to censor or conceal deleterious
aspects of this product. Since we cannot anticipate or control the conditions under which this information and product may
be used, we make no guarantee that the precautions we have suggested will be adequate for all individuals and/or
situations. It is the obligation of each user of this product to comply with the requirements of all applicable laws regarding
use and disposal of this product. Additional information will be furnished upon request to assist the user; however, no
warranty, either expressed or implied, nor liability of any nature with respect to this product or to the data herein is made or
incurred hereunder.