Handling a complex world.

relax
Marine
Catalogue
Supplement
2003/04

www.siemensvdo.com.au
 Cockpit Vision Pitot Speedometer
Cockpit - Pitot Speedometer 85mm
Part No. Description Voltage
260.111 50mph gauge black 12V
260.101 80mph gauge black 12V
170.701 Cockpit white - Pitot Speedo 75mph 12V
170.702 Pitot tube assembly black

Cockpit Vision Tachometer

Ignition or Alternator Signal 85mm
Part No. Description Voltage
333015033 7,000 rpm tacho black 12V
333.255 7,000 rpm Cockpit white tacho 12V
Suitable for 4, 6 or 8 cylinder four stroke inboard petrol engines with coil pickup.
Also suitable for all diesel and outboard engines using alternator signal pickup.

Cockpit Vision Tachourmeter

Ignition / Alternator / Generator or Inductive 85mm
Part No. Description Specifications Voltage
333015035 7,000 rpm tachourmeter 1 to 12 cyl. 12/24V
Adjustment of settings through digital readout & reset button.
• 4 stroke - 1 to 12 cylinders • 2 stroke - 1 to 6 cylinders
• Operating hours 99,999.9 • Pulses range 0.50 - 200 pulses per revolution.

Works from alternator, inductive generator or coil pickups.

Cockpit Vision Pressure Gauge

Cockpit Vision Pressure Gauge 52mm
Part No. Description Specifications Voltage
350010003 100 PSI 10-180 ohms 12V
350010001 400 PSI 10-180 ohms 12V
350010016 500 kPa 10-180 ohms 12V
350.240 80 PSI Cockpit white 10-180 ohms 12V
350010017 1000 kPa 10-180 ohms 12V
Note: 500 kPa = 80 PSI, 100 PSI = 700 kPa, 1000 kPa = 150 PSI, 400 PSI = 2800 kPa.

Senders - Single Terminal

360.086 100 PSI sender 10-180 ohms 1/8”-27 NPTF
360.406 400 PSI sender 10-180 ohms 1/8”-27 NPTF
360.001 500 kPa sender 10-180 ohms 1/8”-27 NPTF
360.002 1000 kPa sender 10-180 ohms 1/8”-27 NPTF

Pressure sender 230.031 T-piece brass 1/8”-27 NPTF

360.001 240.030 Wiring kit 3 wires 3mm

2
Cockpit Temperature Gauge-Water
Electric 52mm
Part No. Description Specifications Voltage
310010014 40-120°C black 287-23 ohms 12V
310.239 100- 250°F white 287-23 ohms 12V
Senders
320.002 40-120°C sender 287-23 ohms 1/8”-27 NPTF
320.004 40-120°C sender 287-23 ohms M16 x 1.5
320.022 40-120°C sender 287-23 ohms 1/2”-14 NPTF
320.035 40-120°C sender 287-23 ohms M14 x 1.5
320.031 40-120°C sender/switch 287-23 ohms 5/8”-18 UNF
98°C normally open
240.030 Wiring kit 3 wires 3mm

Cockpit Vision Temperature Gauge-Oil

Cockpit Vision Oil Temperature Gauge 52mm
Part No. Description Specifications Voltage
310010015 50-150°C 323-18 ohms 12V

Senders
320.007 50-150°C sender 323-18 ohms M14 X 1.5
320.016 50-150°C sender 323-18 ohms 1/2-20 W/W
320.018 50-150°C dipstick sender 323-18 ohms 500mm
320.021 50-150°C sender 323-18 ohms 1/8”-27 NPTF
320.023 50-150°C sender 323-18 ohms 3/8” UNF
320.028 50-150°C sender 323-18 ohms 1/8”-27NPTF

Cockpit Voltmeter Gauge

Cockpit Voltmeter Gauge 52mm
Part No. Description Voltage
332.241 White Voltmeter 8-16V
332010004 Black Voltmeter 8-16V

Cockpit Vision Ammeter

Internal Shunt 52mm
Part No. Description Specifications Voltage
190077006 30-0-30 amp gauge use 6mm wire 12V
190077007 60-0-60 amp gauge use 6mm wire 12V

External Shunt 52mm

Part No. Description Specifications Voltage
190.504 150-0-150 ammeter kit 50mV=150A 12V
Kit includes: 150amp shunt.

Kit Components
190.079 Shunt - 150 amps 50mV=150A
190.888 5m loom 3
240.701 Dropping resistor for 24V use

www.siemensvdo.com.au
 Cockpit Fuel Gauge
Cockpit Vision Black Fuel Gauge 52mm
Part No. Description Specifications Voltage
301010011 Fuel gauge - petrol 10-180 ohms 12V
301010010 Fuel gauge - LPG 0-90 ohms 12V
301010009 Fuel gauge - tubular 12V

Cockpit White Fuel Gauge 52mm

301.216 Fuel gauge 10-180 ohms 12V

Fuel Senders
Float Arm Senders-Metal Body
Part No. Description Resistance Length
220.003 Fuel sender - petrol 0-180 ohms 150-525mm
220.004 Fuel sender - petrol 0-90 ohms 150-525mm
Float Arm sender - 220.005 Fuel sender - USA 240-20 ohms 150-525mm
metal body
220.003 Tubular Type Senders - refer to main Marine catalogue for part numbers

Cockpit Vision Clock

Cockpit Vision Clock 52mm
Part No. Description Specifications Voltage
370012001 Clock analogue 12V

Hourmeter, Electronic
Suitable for all vehicles and machines.
Available with 360º minute hand sweep or as counters only. Illumination
12V included where applicable. 24V globe #240.055 optional.
Hourmeter 52mm
Part No. Range Installation Ø Voltage
With 360º minute hand sweep – non-illuminated – black bezel
331 032 004 0-99999.9hrs 52mm 12/24V
331.302 0-99999.9hrs 60mm 12/24V
331 032 004

Sender Counter type – non-illuminated with operation Indicator – black bezel

230.043
331 032 001 0-99999.9hrs 52mm 12/24V
331 810 012 004 0-99999.9hrs 52mm illuminated 12/24V

Accessories
240.031 Wiring kit
230.043 Pressure switch - 1 terminal 1/8”-27 NPTF
Sender
230.050 70 kPa - 5 watts - N/O 6-24V
230.050 Pressure switch - 2 terminal 1/8”-27 NPTF
331 810 012 004
48 kPa - 5 watts - N/O 6-24V

Hourmeter, Electronic – rectangular type

Suitable for all vehicles and machines. Overall Dimension 53 X 32mm.
Note - Connections not polarity specific.
Hourmeter
4 Part No. Range Installation Ø Voltage
331.534 0-99999.9hrs 37mm x 25mm 12/24V
331.534
Cockpit Vision Pyrometer
Electric 52mm
Part No. Description Voltage
310.159 900°C pyrometer kit black 12V
310.240 250- 1600°F pyrometer kit white 12V
Kit includes: Loom and thermocouple sender.

Components
240.701 Dropping resistor for 24V use (only for 310.159 kit)
320.714 Thermocouple sender non bonded 1/4” NPTF
junction Male
240.035 Loom 5m
320.059 Weld boss adaptor 1/4” NPTF
Female
Thermocouple sender
310 015 009 Instrument black 320.714

Note: 900°C gauge has a 12V connection.

Ocean Line Gauge Kits

Ocean Line gauge kits are the ideal way to purchase gauge sets during
fit out of your new vessel or if simply upgrading an older set of
gauges.

Ocean Line Gauge Kits

Part No. Description Voltage
240.820 White Gauge Kit - Diesel 12V
240.821 White Gauge Kit - Diesel 24V
240.822 Black Gauge Kit - Diesel 12V
240.823 Black Gauge Kit - Diesel 24V
Kit includes: 4000 rpm tachourmeter, voltmeter, engine oil pressure
gauge(10 bar), gearbox oil pressure gauge (25 bar), engine
temperature (1200C ). Senders sold separately.

Cockpit Vision Speed Boat Gauge Kit

Cockpit Vision gauge kits are the ideal way to purchase gauge sets
during fit out of your new boat or if simply upgrading an older set of
gauges.

Cockpit -Speed Boat Gauge Kit

Part No. Description
240.819 Black Cockpit Vision Speed Boat Kit-50mph
240.824 Black Cockpit Vision Speed Boat Kit-80mph
240.817 Cockpit White Speed Boat Kit-75mph
has a seperate tacho and hourmeter, total 7 gauges
Kit includes: Pitot speedo, tachourmeter, oil pressure, engine
temperature, voltmeter, fuel gauge, pressure sender, temperature
sender and fuel tank sender.

www.siemensvdo.com.au
 Cockpit Vision Accessories
Cockpit Vision Accessories
Part No. Description Specifications
800.005.015 52mm clamp ring suits 52mm gauges
800.005.006 85mm clamp ring suits 85mm gauges
12V Light 600.402 52mm stud kit suits 52mm gauges
800005002
800.005.001 80/85mm stud kit suits 80/85mm gauges
800005002 12V light assembly-2W globe holder and globe
800005003 24V light assembly globe holder and globe

Adaptors
These adaptors are used for temperature and pressure senders with
1/8”27NPTF thread to adapt to a different thread engine mounting hole.

Temperature & Pressure Sender Adaptors

A
A B Length Part No.
1/4”-18NPT 1/8”-27NPTF 20mm 320.050
3/8”-18NPT 1/8”-27NPTF 20mm 320.051
5/8”-18UNF 1/8”-27NPTF 20mm 320.052
B
1/2”-14NPT 1/8”-27NPTF 20mm 320.053
M14x1.5 1/8”-27NPTF 20mm 320.054
M16x1.5 1/8”-27NPTF 20mm 320.055
M18x1.5 1/8”-27NPTF 20mm 320.056
1/2”-14NPT 1/8”-27NPTF 25mm 320.058

Adaptors T-Type
Used for oil pressure senders when an existing oil warning light is to
be retained. Refer to the diagram for the location of dimension “A-C”.
The following adaptors are all 66mm long.

B
Temperature & Pressure Sender Adaptors - T-Type
A B C Part No.
1/8”-27NPTF 1/8”-27NPTF 1/8”-27NPTF 230.031
1/4”NPT 1/4”NPT 1/8”-27NPTF 230.032
C M10x1.0 M10x1.0 1/8”-27NPTF 230.033
A M12x1.5 M12x1.5 1/8”-27NPTF 230.034
M14x1.5 M14x1.5 1/8”-27NPTF 230.035
1/8”-28BSP 1/8”-28BSP 1/8”-27NPTF 230.036

BATTMAN II Battery Monitor

It’s like a fuel gauge for your battery. The Battman II lets you know
everything that is essential to know about your battery.
• battery voltage 8-30 volts • battery capacity used in amphours
• battery capacity regained in amphours • charging and discharging
current in amps

Battery Monitor
Complete Kit 52mm
Part No. Description Specifications Voltage
190.725 Battman including liquid crystal 8-30V
gauge, loom shunt, readout
push button switch
190.727 Shunt
• measuring range, current : +0.1 -200A • accuracy, voltage : better than
1% • accuracy, current : +5% • measuring range : amphours 0-999AH
6 • measuring range voltage : 8-30V • accuracy : +0.5%
Sumlog and Logic Spares
Wind System Components
Part No. Description
N01 340 402 Logic wind mast head unit complete
N05 800 306
N05 800 356 Mast head vane - new style N05 800 308
N05 801 448 Mast head wind cups - new style
N05 800 308 Mast head vane - old style
N05 800 306 Mast head wind cups - old style N05 800 356
N05 800 236 Logic wind mast head cable 30m
N05 801 448

Spares for Sumlog - Electronic

Transducers 12/24V
Part No. Description Specifications Size
270 023 001 002 8/12/18 kn – SL markings - 270/23/1/1/2 128mm long
270 023 004 002 30 kn – SL & markings - 270/23/4/1/2 120mm long Transducer
12-50 kn – Logic 270 023 001 002

270 023 005 002 50 kn range – SL markings - 270/23/5/1 120mm long

or 5/2
Wide Paddle Wheel
270 023 005 003
Paddle Wheels & Axles
Part No. Description
270 023 005 003 8/12/18 kn, wide wheel, 6 blades
270 023 005 004 30 kn, narrow wheel, 6 blades Narrow Paddle Wheel
270 023 005 005
270 023 005 005 50 kn, narrow wheel, 4 blades
Narrow Paddle Wheel
270 023 005 004

Spares for Sumlog - Mechanical

Through Hall Assembly
Through Hull Assembly 270 021 007 001

Part No. Description

270 021 007 001 0-30 knot range, white impeller

Drive Cables
Part No. Description Size
200.701 Inner & Outer 3m long
200.702 Inner & Outer 4m long
200.703 Inner & Outer 5m long
200.704 Inner & Outer 6m long
200.711 Inner only 3.36m long
200.712 Inner only 4.36m long
200.713 Inner only 5.36m long
Inner Cable 200.714 Inner Cable 200.714
200.714 Inner only 6.36m long

Spares for Sumlog - Mechanical

Components Impeller Spanner
270.717
Part No. Description
N05 800 284 White impeller 0-30kn
200.730 Swaging kit
270.717 Impeller spanner
210.701 Angle Drive Impeller N05 800 284

7
Angle Drive 210.701

www.siemensvdo.com.au
 Water Level Alarms
The electronic module monitors current continuity while the level probe
is submerged in water. The location of the level probe in the radiator or
header tank determines the critical water level. Warning occurs within
a few seconds of the water going below this level. The flashing warning
Warning Light light and continuously activated buzzer can only be cancelled by
170.708 switching off the engine. The probe is made of stainless steel.
For above ground applications, two probes are required.
Water level probe For further details please contact VDO.
230.059

Ocean Line Water Level Alarms

Part No. Description Voltage
410.007 Low water alarm kit 12V
410.008 Low water alarm kit 24V
Buzzer 240.021
410.006 Electronic module, 110x67x35
230.056 Ceramic Probe M14x1.5
230.058 Water level probe, 30mm long
230.059 Water level probe, 90mm long
Electronic Module
240.021 Buzzer, 40 dia, 34mm deep 12V
410.006
240.022 Buzzer, 40 dia, 34mm deep 24V
Kit includes: Warning Light, electronic module, water level probe 30mm,
buzzer, adaptor, soldering bush and all wiring plugs and sockets.

Multifunction Switch Boxes

and Alarm Modules
Designed to activate a buzzer or warning light when the reading on a
gauge passes a predetermined level. Switches on either a falling or rising
level for any gauge which uses a variable resistance type sensor. The
Ocean Line Makepoint switch plugs directly in line with Ocean Line
Gauges only, while the 170 series will operate all VDO gauges.

Multifunction Switch Boxes

Multifunction Part No. Description Voltage

Switch Box 170.12V X10719002037 Ocean Line Makepoint Switch 12/24V
170.12V Multifunction Switch Box 12V
(operates one warning light)
170.24V Multifunction Switch Box 24V
(operates one warning light)
170.12V3 Multifunction Switch Box 12V
(operates three warning lights)
170.24V3 Multifunction Switch Box 24V
(operates three warning lights)
Ocean Line Makepoint Switch Tacho Amplifier
X10719002037
411.095 Tachometer Amplifier 12/24V

Splashcam
Components
Part No. Description
850.054 Connects directly with Map 7CC or Map 11
Chartplotters
850.054 RCA Splashcam with RCA socket and cigarette lighter
adaptor. Suits stand alone T.V, Camcorder, etc.

8
Accessories
Round Bezels
Part No. Description Specifications Size
N05 801 110 Black 62.5mm OD round 52mm
*N05 800 378 Black 85mm OD round 85mm
*Does not fit current Ocean Line.

Square Bezels
Part No. Description Specifications Size
N05 800 495 Bezel Logic 62.5mm OD square 52mm
*N05 800 498 Bezel Logic 125mm OD square 85mm
N05 800 222 Bezel standard 62.5mm OD square 52mm
*Does not fit current Ocean Line. N05 800 495 N05 800 222

Drop Resistor- Reduces 24V to run one 12V Gauge

Part No. Description
N05 801 180 Drop resistor

Warning Buzzers
Part No. Specification Current Draw
240.021 12V 75dB 50mA
240.022 24V 75dB 50mA

Instrument Panels
Part No. Description Colour
850.012 Diesel 5 gauge panel (starboard) Woodgrain
850.013 Diesel 5 gauge panel (starboard) Kevlar
850.017 Diesel 5 gauge panel (port) Kevlar
850.018 Diesel 5 gauge panel (port) Woodgrain
850.014 2 gauge panel Kevlar
850.015 2 gauge panel Woodgrain
850.026 2 gauge surround (85mm holes) Woodgrain
suits Smartcraft or Yamaha gauges
850.026C 2 gauge surround (85mm holes) Carbon 850.014 850.012
suits Smartcraft or Yamaha gauges

Instrument Panels
Part No. Description Colour
230.005 Single gauge panel 52mm Black metal
230.006 Twin gauge panel 52mm Black metal

850.017

850.026

www.siemensvdo.com.au
 Accessories continued
Hole Blank
Part No. Description
230.038 52mm plastic hole plug

Reduction Rings
Part No. Description
230.004 60-52mm black metal
230.019 85-80mm black metal

Wiring Plugs
Part No. Description
X39 000 000 002 Suits VDO 3 pin gauges

Push Button
Part No. Description Specifications Size
170.713 Push button - Start 10 amp 15mm hole
170.714 Push button - Stop 10 amp 15mm hole

Keyswitches
Part No. Description
170.706 Brass keyswitch
850.009 Plastic marine keyswitch with rubber boot

Brass marine switch Plastic marine switch

170.706 850.009

10
 FLOSCAN
CruiseMaster Series
The Series 5500/5600 CruiseMaster fits virtually all inboard, I/O, and
outboard engines from 50hp-1000hp including EFI, TBI, and DFI engines
with closed loop return fuel systems. Fits all carbureted engines.

The Series 6500/6600 CruiseMaster is available for most diesel engines

rated from 50hp-2000hp. A system typically consists of two fuel flow
sensors to measure feed and return flows, pulsation dampers for
engines that need them, and a microprocessor based instrument which
calculates and displays net flow rate and total fuel consumption.

Litres per hour models sold in Australia.

Only petrol engines can use 1 display and 2 sensors.

Multifunction Series 7000

Our Multifunction Meter combines a digital LCD Engine Hour Meter,
Tachometer, Fuel Flowmeter, and Fuel Totalizer in a single 3-3/8” diameter
instrument which fits the panel space of a standard tach. Instrument also
incorporates an Engine Synch Indicator (twin gas models only). External
switches are required for resetting the Fuel Totalizer and Port/Stbd GPH
selection (gas only) and Engine Hours/Engine Synch (gas only).

GPS Interface Series 9000

Our GPS Interface Model provides the same functions as the series 7000
instruments PLUS the important addition of litres used per kilometre. The
boat speed over ground data required to calculate the LPKm reading is
obtained from a GPS with NMEA 0183 output. The direct display of LPKm
over the ground gives the skipper a powerful new tool to set optimum
fuel efficiency under all conditions and to determine precisely how far he
can go with his remaining fuel.

TwinScan Tach & GPH Meters

Petrol Engines Only
Monitor your engine’s performance at a glance. A TwinScan Tach and
LPH Meter are easy to install by simply replacing your existing tachs. LPH
meter displays individual burn rates for each engine and total litres
consumed. Tachometer displays individual RPM rates for each engine and
engine Synchronization. When combined with a TwinScan LPH meter, the
Tachometer also displays nautical Kilometres-Per-Litre when connected to
GPS (NMEA 0183 data) for boat speed over ground. SPST (ON/OFF)
switches required for resetting totalizer and accessing Kilometres-Per-Litre
data.

All quotes are done on application. Contact VDO or

11
your dealer with engine make, model and horsepower
and we will individually quote each system.

www.siemensvdo.com.au
 Australian to German Part No
Cross Reference
Previous VDO Aust Part New VDO German Part Previous VDO Aust Part New VDO German Part

170.701 170.701 320.709 325 805 003 003

170.705 333.255 320.710 325 805 003 002
170.710 350.240 320.711 325 805 003 001
170.715 310.239 320.715 323 805 001 004 K
170.720 332.241 320.716 323 805 001 015 N
170.725 301.216 320.718 323 805 001 001 K
170.730 170.730 320.719 323 805 001 007 N
190.708 N03330116 320.720 323 805 001 005 N
220.723 224 802 008 021 R 320.721 323 805 001 002 C
220.724 224 082 007 022 R 320.722 323 805 003 001 N
220.725 224 082 007 009 R 320.723 323 805 003 003 N
220.726 224 082 007 004 R 320.725 323 803 001 006 D
220.728 224 082 005 123 R 320.726 323 805 003 002 N
220.729 224 082 005 130 R 320.727 323 803 002 007 D
220.730 X10224009019 340.704 340 808 001 004 G
220.731 X10224009026 340.721 440 102 001 001 D
220.732 X10224009039 340.722 440 102 002 001 D
220.733 224 082 005 098 R 360.710 362 081 001 001 K
220.735 226 801 015 001C 360.711 362 081 001 002 K
220.736 N02240106 360.712 362 081 002 001 K
240.701 N05801180 360.713 360.081 039 002 C
240.702 N05801110 360.720 360 081 032 001 C
240.703 N05800378 360.721 360 081 032 014 C
240.708 N05800308 360.722 360 081 038 003 C
240.709 N05800306 360.723 360 081 032 025 C
240.728 N05800222 360.730 360 081 038 003 C
240.729 NLA 360.733 362 081 002 001 K
240.735 N05800356 402.715 N01340402
240.736 N05801448 402.720 N03320112
270.275 270 023 005 010 402.721 N05800236
270.711 270 021 007 001 850.040 X11719000023
270.714 N05800284 850.041 X11719000022
270.724 N05800258 850.042 X11719000030
270.735 270 023 005 004 850.043 X11719000031
270.737 270 023 001 002 850.044 X11719000041
270.738 270 023 004 002 850.045 X11719000046
270.739 270 023 005 003 850.048 X11719000028
270.746 270 023 005 002 850.049 X11719000029
270.747 270 023 005 005

Available from

For your nearest dealer

Contact: 1800 335 282

Siemens VDO Automotive Pty Ltd

115 Northern Road,
Heidelberg Heights, VIC 3081
Phone: (03) 9450 3251
Email: [email protected]
Web: www.siemensvdo.com.au
12

www.siemensvdo.com.au