Diagnostic Code Conversion Wire Description SENR6777

Component Location
Code
Flashed CID - FMI Description Component
Schematic Machine
Component
Schematic Machine
Wire
Number
Wire
Color
Description
Wire
Number
Wire
Color
Description March1995 Electrical Schematic Symbols And Definitions
Location Location Location Location
No ACTIVE Power Circuits Accessory Circuits
11 Alarm - Action F-5 A Sensor - Engine Speed D-15 13
Faults Not applicable. 101 RD BAT 500 BR WIPER - FRONT (PARK)
Alarm - Backup B-14 1 Sensor - Transmission Speed C-13 17
No INACTIVE 102 BU HD LMP 501 GN WIPER - FRONT (LO)
12 Alternator E-15 2 Service Meter F-6 A
Faults Not applicable. 104 YL AUX CKT 502 OR WIPER - FRONT (Hi)
Batteries B-15 B Solenoid - Air Conditioner Clutch F-15 10
31 390 - 05 Forward Pump Solenoid Open Circuit 105 BR KEY START SW 503 BR WIPER - REAR (PARK)
Breaker - Alternator B-14 B Solenoid - Auxiliary A-8 C
32 391 - 05 Reverse Pump Solenoid Open Circuit 108 BU AUX CKT 504 YL WIPER - REAR (LO) T
Breaker - Auxiliary B-14 B Solenoid - Float Detent A-8 C
33 417 - 05 GND Interrupt Relay Open Circuit 109 OR ALT OUTPUT (+) TERM 505 BU WIPER - REAR (HI)
Breaker - Lamp B-11 C Solenoid - Forward/Reverse Valve C-15 12 Pressure Temperature Level Flow
34 418 - 05 Primary Steering Flow Lamp Open Circuit
Breaker - Main Power A-14 B Solenoid - Fuel Shutdown E-15 10
112 PU MAIN POWER RELAY OUTPUT 506 PU WASHER - FRONT Symbol Symbol Symbol Symbol
35 419 - 05 Reverse Motor Relay Open Circuit 113 OR OPR MON PANEL 507 WH WASHER - REAR
Control¹ - Electronic Transmission H-8 3 Solenoid - Lift Positioner A-8 C
36 420 - 05 Supplemental Steering Relay Open Circuit 114 GN WARNING HORN (FORWARD) 508 PU RADIO SPEAKER - LEFT
Control - Shift Handle F-5 A Solenoid - Reverse Motor Valve C-13 17
37 346 - 05 Ride Control Relay Open Circuit 116 BR AUX CKT 509 WH RADIO SPEAKER - LEFT (COMMON)
Diode Assembly C-3 A Solenoid - Ride Control Valve (914G) H-4 18
38 421 - 05 Load Check Relay Open Circuit 118 GY AUX CKT 511 BR RADIO SPEAKER - RIGHT
Flasher C-5 A Solenoid - Ride Control Valve (IT14G) H-4 18
39 347 - 05 Motor Displacement Sol Open Circuit 120 YL AUX CKT 512 GN RADIO SPEAKER - RIGHT (COMMON)
Fuses C-11 C Solenoid - Speed Motor Valve C-13 17
41 390 - 06 Forward Pump Solenoid Short to Ground
Gauge - Engine Coolant Temperature F-3 A Solenoid - Tilt Positioner A-8 C 121 YL BACKUP ALARM TO LAMP 513 OR A/C COMPRESSOR/REFRIGERANT PRESS SW Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
42 391 - 06 Reverse Pump Solenoid Short to Ground
Gauge - Fuel Level E-3 A Speedometer E-3 A 124 GN A/C 515 GY BLOWER MOTOR (HI)
43 417 - 06 GND Interrupt Relay Short to Ground
Gauge - Hydraulic Temperature F-4 A Switch - A/C Compressor D-7 C 126 PK XMSN CONT 516 GN BLOWER MOTOR (MEDIUM)
44 418 - 06 Primary Steering Flow Lamp Short to Ground Normally open switch that is closed due to an applied condition, and will open again with a
Gauge - Voltmeter E-4 A Switch - Air Conditioner Refrigerant F-15 10 127 OR AUX CKT 517 BU BLOWER MOTOR (LO)
45 419 - 06 Reverse Motor Relay Short to Ground
Horn - Forward E-2 4 Switch - Beacon D-7 A 128 PK AUX CKT 521 YL A/C SW TO REFRIGERANT SW specific decrease in that condition.
46 420 - 06 Supplemental Steering Relay Short to Ground
Lamp - Alternator B-7 A Switch - Blower Motor C-8 C 129 BU AUX CKT 522 WH A/C CLUTCH TO THERMOSTAT SW
47 346 - 06 Ride Control Relay Short to Ground
Lamp - Brake Oil level F-6 A Switch - Brake Oil Level H-13 11 130 GN AUX CKT 537 GN TURN SIGNAL SW TO FLASHER
48 421 - 06 Load Check Relay Short to Ground
49 347 - 06
Lamp - Engine Coolant Temperature F-6 A Switch - Bucket Positioner E-1, H-1 14 135 BU AUX CKT 538 BR HAZARD INDICATOR Normally closed switch that will open with an increase of a specific condition.
Motor Displacement Sol Short to Ground
144 GN AUX CKT Lighting Circuits

914G Wheel Loader And

Lamp - Engine Oil Pressure F-6 A Switch - Bucket/Fork Select C-7 C
51 390 - 03 Forward Pump Solenoid Short to Battery
Lamp - Filter Bypass F-6 A Switch - Creeper C-9 C 160 PU AUX CKT 603 PK ROTARY BEACON
52 391 - 03 Reverse Pump Solenoid Short to Battery
Lamp - Hydraulic Oil Temperature F-6 A Switch - Defrost D-7 C 164 WH XMSN CONT TO DATA LINK 604 OR STOP LAMP
Normally closed switch that is open due to an applied condition, and will close again
IT14G Intergrated Toolcarrier
53 417 - 03 GND Interrupt Relay Short to Battery
Lamp - Park Brake C-7 A Switch - Dimmer B-5 A 193 PU AUX CKT 605 YL TURN LAMP - LEFT
54 418 - 03 Primary Steering Flow Lamp Short to Battery with a specific decrease in that condition.
Lamp - Primary Steer C-7 A Switch - Disconnect B-15 15 Ground Circuits 606 GY TURN LAMP - RIGHT

Electrical System
55 419 - 03 Reverse Motor Relay Short to Battery
Lamp - Supplemental Steer C-7 A Switch - Engine Coolant Temperature E-15 10 200 BK MAIN CHASSIS 608 GN FLOOD LAMP - REAR
56 420 - 03 Supplemental Steering Relay Short to Battery
201 BK OPR MON PANEL 610 OR HEAD LAMP BASIC
Motor - Front Washer G-13 5 Switch/Sender - Engine Coolant Temperature F-15 10
57 346 - 03 Ride Control Relay Short to Battery
202 BK XMSN CONT 611 PU HEAD LAMP HI
The circle indicates that the component has screw terminals and a wire can be disconnected
58 421 - 03 Load Check Relay Short to Battery Motor - Front Wiper D-3 A Switch - Engine Oil Pressure D-15 10 from it.
59 347 - 03 Motor Displacement Sol Short to Battery Motor - Rear Washer G-13 5 Switch - Filter Bypass G-l 4 11
206 BK BAT SIDE OF DISCONNECT 614 PU PARK/TAIL/DASH LAMP 914G: IT914G:
276 BK XMSN CONT IDENT CODE 0 615 YL CAB FLOOD LAMP/ROPS
61 190 - 02 Engine Speed Sensor Signal Not Correct Motor - Rear Wiper D-12 6 Switch - Fork Positioner (IT14G) H-1 14
277 BK XMSN CONT IDENT CODE 1 617 BR TAIL/POSITION LAMP - LEFT (ROAD PKG)/WIDTH
7ZM1-UP 8ZM1-UP
62
63
422 - 02
623 - 02
Drive Shaft Speed Sensor Signal Not Correct
Invalid Direction Switch Input
Motor - Starter
Motor - Supplement Steer
C-14
G-13
7
8
Switch - Forward Horn
Switch - Front Wiper
D-5
C-6
A
A 278 BK XMSN CONT DENT CODE 2 619 GN HEAD LAMP LO 9WM1-UP 1WN1-UP No circle indicates that the wire cannot be disconnected from the component.
64 168 - 00 279 BK XMSN CONT IDENT CODE 3 Control Circuits
Battery Voltage Above Normal Motors - Blower F-14 8 Switch/Sender - Hydraulic Oil Temperature B-13 17
65 168 - 01 280 BK XMSN CONT IDENT CODE 4 710 GN XMSN SPEED PICKUP SIGNAL
Battery Voltage Below Normal
Relay - Alarm Disarm E-10 C Switch - Hydraulic Lock Override B-8 C
66 650 - 02 281 BK XMSN CONT IDENT CODE 5 720 PU XMSN BRAKE SW
Invalid Harness Code Input
Relay - Backup Alarm E-11 C Switch - Key Start D-5 A
67 687 - 02 Basic Machine Circuits 751 GN XMSN SHIFT SOL NO. 1 OR 3
Invalid Option Code Input
Relay - Blower Motor F-14 8 Switch - Kickout On/Off C-7 C
301 BU STARTER NO. 1 SOL 752 YL XMSN SHIFT SOL NO. 2
This indicates that the component has a wire connected to it that is connected to ground.
68 367 - 02 Invalid Ride Control Switch Input
Relay - Ground Interrupt E-10 C Switch - Lamp Test E-7 A
304 WH STARTER RELAY NO. 1 OUTPUT 754 BU XMSN SHIFT SOL NO. 3 OR 1
Relay - Main Power B-11 C Switch - Lift Positioner E-1 H-1 4
306 GN STARTER RELAY COIL TO XMSN SHIFTER 755 OR XMSN SHIFT SOL NO. 4 OR 5
Relay - Neutral Start E-11 C Switch - Parking Brake F-10 16
307 OR KEY START SW TO XMSN SHIFTER 761 GY LIFT KICKOUT SOL SW
Relay - Park Brake E-11 C Switch - Rear Wiper B-6 C
308 YL MAIN POWER RELAY COIL 762 YL BUCKET POSITIONER SOL SW This indicates that the component does not have a wire connected to ground. It is grounded
Relay - Reverse Motor Solenoid E-12 C Switch - Ride Control/Load Check B-7 C
309 GY ALTERNATOR REGULATOR TERM 900 PU XMSN SHIFT SOL NO. 5 OR 4 by being fastened to the machine.
Relay - Ride Control (IT14G) I-4 C Switch - Running Lamp F-7 A
310 PU START AID SW TO START AID SOL 901 WH XMSN SHIFT SOL NO. 6
Relay - Ride Control/Load Check E-11 C Switch - Service Brake B-3 A
ACTIVATION OF DIAGNOSTIC INDICATOR 311 WH START AID SOL TO TEMP SW 910 YL XMSN NEUTIZER OVERRIDE INDICATOR
Relay - Start B-14 B Switch - Speed Select F-6 A
OPERATIONS 321 BR BCKP ALARM LAMP TRAVEL ALARM 921 WH XMSN SOL NO 1 OR 3 RETURN
Resistor - Blower Motor Speed F-8 9 Switch - Start Aid E-7 A
(Quick Reference) 322 GY WARNING HORN (FORWARD) 922 BR XMSN SOL NO 2 RETURN
Resistor - Fuel Solenoid B-14 B Switch - Supplemental Steer Motor C-6 A
Operation Contact 1¹ Contact 3¹ Contact 5¹ 326 PU KEY START SW “C” TERM 923 GY XMSN SOL NO 3 OR 1 RETURN
Resistor - Thermal Start B-14 B Switch - Thermostat F-8 8
To Scroll ACTIVE Faults Ground² Open Open 373 GN AIH TIMER 924 GN XMSN SOL NO 4 OR 5 RETURN
To Scroll INACTIVE Faults Open Open Ground² Sender/Switch - Engine Coolant Temperature F-15 10 Switch - Turn signal C-5 A Monitoring Circuits 925 YL XMSN SOL NO 5 OR 4 RETURN
To Clear³ Faults Open Ground Open Sender-Fuel Level G-13 11 403 GN ALTERNATOR (R) TERM 926 BU XMSN SOL NO 6 RETURN
¹ These contacts are located in the harness code connector. Sender/Switch - Hydraulic Oil Temperature B-13 17 405 GY OPR MON OIL PRESS (LO SETTING) 944 OR CAT DATA LINK +
² Remove the connection to ground to place the desired 406 PU OPR MON COOLANT TEM 945 BR CAT DATA LINK
¹ Transmission control (if equipped) and associated connectors are located under the operators compartment on right side of the machine.
information shown during scrolling on-hold.
³A fault is cleared only while it is on-hold. A fault that is active Machine locations are repeated for components located close together. 409 OR POPR MON NEUT 963 GN BUCKET/FORK POSITION DETENT COIL © 1995 Caterpillar Printed in U.S.A.
cannot be cleared. A = Components located in operators compartment, dash area. 410 WH OPR MON ACTION ALARM 964 BU FORK POSITION SELECT All Rights Reserved
B = Components located on or near the relay panel. 411 PK OPR MON ACTION LAMP 965 WH TRANS SOL 1 SW TO GND

C = Components located on or in operators compartment, right-side console. 413 BR OPR MON FUEL PRESS 966 GY TRANS SOL 3 SW TO GND
415 GN OPR MON TEST SW 967 BU TRANS SOL 1 & SOL 3 SW TO B+ (CST ONLY)
416 OR SUPPL STER SW 968 BR TRANS SOL 2 SW TO GND
417 GY PRIMARY STER SW 969 YL TRANS SOL 3 SW TO B+
419 YL OPR MON PARKING BRAKE 970 GN TRANS SOL 4 SW TO GND
Connector Location 428 OR OPR MON XMSN OIL TEMP 971 YL TRANSSOL5SWTOGND Harness And Wire Electrical Schematic Symbols
Machine Harness And/Or Schematic Machine Harness And/Or Schematic 432 PK OPR MON BRAKE PRESS (OIL) 972 BU TRANS SOL 6 SW TO GND
Connectors Connectors
Location Components Location Location Components Location 441 OR ENG COOLANT TEMP GAGE 973 BR XMSN CONTROL - AUTO/MANUAL SW 2
442 GY HYD SYSTEM TEMP GAGE 974 PU XMSN CONTROL - SLOW MODE SW
A AA 1 1
K - 111-7877 A - 1083261
40 Contacts * H-9 12 A-11 1 2 2
Transmission Control W - 107-6139 443 YL POWER TRAIN TEMP GAGE 975 WH XMSN CONTROL - SOL RETURN Related Electrical Service Manuals
A - 108-3261 E- 111-3787 447 PK FUEL LEVEL GAGE 976 OR RIDE CONT SOL Title Form Number Typical representation of a Typical representation of a
11 D-13 214
4 B-12
C - 114-5344 X- 108-3260 449 BU SPDOM SENDER (SIGNAL NO. 1) 977 YL XMSN CONTROL - AUTO/MANUAL SW 1 Starting Motor (100-6929) Series R4.5 KW SENR3828 Deutsch connector. The Sure-Seal connector. The
Plug Receptacle plug contains all sockets plugand receptacle contain
A - 108-3261 E 111-3787 450 YL TACH SENDER (+) 978 GN XMSN CONTROL - SLOW MODE SW 1 Transmission Control (Hydrostatic) SENR6767
212 B-11 214
4 A-11 and the receptacle contains both pins and sockets.
W - 107-6139 X - 111-3788 (Hi Speed) 987 WH DIVERTER SOL
2 all pins.
E - 111-3787 E - 111-3787 B757 WH XMSN CONTROL
212 A-9 11 D-13
W - 107-6139 WW - 121-2487
B758 GN XMSN CONTROL

33
H - 111-0159
C-4
H - 111-0159
B766 WH KICKOUTS / DETENT DISABLE SW Pin or Socket
1 W - 107-6139 213
3 W - 107-6139
B-5 TO KICKOUTS Number
C920 GY XMSN CONTROL - DIAGNOSTIC LAMP
H - 111-0159 K - 111-7877
33
2 B-4 212
2 G-8 Wire, Cable, or Harness
1 W - 107-6139 W - 107-6139 Component
6 Contacts Assembly Identification Part Number
K - 111-7877 L - 108-5587
12 Contacts 22
2 H-8 15 E-1 Single Wire
1 W - 111-0159 N - 112-7292
Resistor, Sender and Solenoid Specifications Connector
K - 111-7877 L - 108-5587 Part No. Component Description Resistance (Ohms)¹ A AA 9X-1123
22
1 G-8 216
6 F-1 C A
W - 111-0159 N - 112-7292 Overall 2.00 ± .10
9G-1950 Resistor - Blower Speed 325-PK-14 1 325-PK-14
W - 107-6139 W - 107-6139 Tap 1.00 ± .05
212
2 B-6 217
7 E-9
HH - 114-9280 SS - 120-4762 7T-4003 Resistor - Fuel Solenoid 10.0 ± 0.5
Pin Socket Wire
7W-1251 Resistor - Thermal Start 0.85 Color
W - 107-6139 W - 111-0159
212
2 A-6 212 B-6
102-0347 Solenoid - A/C Clutch 14.4 ± 0.6
JJ - 114-9282 Not Used

H - 111-0159 H - 111-0159 5 111-0305 Solenoid - Ride Control (IT14G) 18.0 ± 1.0

133 C-3 * D-3 5 9X-3267 Solenoid - Ride Control (914G) 18.0 ± 1.0
2 200-BK-14
Diode Assembly Front Wiper Motor
8 14
11 16 7 ¹ At room temperature unless otherwise noted.
W - 107-6139 G - 111-0158 10
* F-5 * D-11 2 Circuit Number Wire
Shift Handle Rear Wiper Motor
8 6 9 18 Identification Gauge
A
2122 K - 111-7877 A - 108-3261
10 Contacts I-9 2
212 A-11 1
Transmission Option Code W - 107-6139
13 7 1 4 17
9 Contacts 22
21 K - 111-7877
I-8 C
F - 111-0157
D-11 15
C
3
4
Electrical Schematic Symbols And Definitions
Transmission Data Link G - 111-0158 3
12 6
E - 111-3787 H - 111-0159 B 2
122 A-9 17 D-4 FUSE - A component in an electrical circuit that will open the circuit if too much current flows
W-107-6i39 VV - 101-9161
through it.
H - 111-0159 J - 107-6077
33
21 C-4 213
3 B-5
W - 107-6139 W - 107-6139 REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the
4 Contacts
J - 107-6077 L - 108-5587
Off Machine Switch Specification contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
23
13 C-5 218
8 E-1
Part No. Function Actuate Deactuate Contact Position
W - 107-6139 Y - 112-9599
76.0±21.0kPa -
L - 108-5587 W - 107-6139 7W-1238 Engine Oil Pressure Normally Closed
122 W - 107-6 139
E-2 *
Key Start Switch
D-5 (11.0 ± 3.0 psi) - SENDER - A component that is used with a temperature or pressure gauge. The sender
102 ±3°C 90°Cmin measures the temperature or pressure. Its resistance changes to give an indication to the
L - 108-5587 X - 108-3260 (standard) 104-3008 Hydraulic Oil Temperature Normally Open ¹ T gauge of the temperature or pressure.
22 F-2 14
4 C-13 (216 ± 5.4°F) (194°F Min)
21 W - 107-6139 Motor Valve Group
8 Contacts 107 ±3°C 97°C Min
114-9253 Engine Coolant Temperature Normally Open ¹
H - 111-0159 X - 111-3788 (hi speed) (225 ± 6°F) (216°F Min)
* C-6 214 C-13 RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
Front Wiper Switch Motor Valve Group 275to1750kPa² -
114-5333 Refrigerant Pressure (A/C) Normally Open ³ It has a coil that makes an electromagnet when current flows through it. The electromagnet
(40 to 255 psi) -
H - 111-0159
* B-6 50±3°C 40±3°C can open or close the switch part of the relay.
Rear Wiper Switch 8 120-9848 Engine Coolant Temperature Normally Open
6 A (122 ± 5.4°F) (104 ± 5.4°F)
H - 111-0159
* F-8 C 4 ¹ To check contact position of switch measure from contact 2 to machine ground. CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too
Running Lamp Switch 1 11 8
9 7 3 ² A hysteresis band exists: with increasing pressure the closed condition can be maintained up to 2800 kPa (405 psi), with decreasing pressure much current flows through it. This does not destroy the circuit breaker and it can be reset to
16 5 6 14
K - 111-7877 1 10 5 the closed condition can be maintained down to 170 kPa (25 psi). become part of the circuit again.
2122 I-9 2
Harness Code Plug 3 ³Contact position at the contacts of the harness connector.
B 2 18
W - 107-6139
15 13 SOLENOID - A solenoid is an electrical component that is activated by electricity. It has a coil
C A-7 7 17
Valve Group 4 that makes an electromagnet when current flows through it. The electromagnet can open or
Machine locations are repeated for connectors located close together 12 close a valve or move a piece of metal that can do work.
* = Connector is located at the component.
C = Operators compartment right side console. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
activated by electricity and held latch by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
D28893

Machine Harness Connector and Component Locations

 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

L N N
619-GN-14 6 GN-14 FLOOD
665-BR 665-BR 5 BK-14 LAMP
A F V 611-PU-14 4 BK-18 109-7041
N
TURN LAMP RD-18 2 200-BK X 2 200-BK-14 E 614-PU-14 3
N LEFT
107-4402 BK-18 1 605-YL 2 975-WH-18 1 603-PK 755-OR-18 1 605-YL 605-YL 1 GY
1 710-GN-18 4 615-YL-14 975-WH-18 2 200-BK-14 2 BK-18 TURN
N LAMP
TRANSMISSION 3 608-GN
LEFT SIDE PROP (MOTOR) NOTE U 5C-9029
SPEED L
A VALVE GP LL

975-WH-18
SENSOR

710-GN-18
T WH-18 C 614-PU (35 KM/H ONLY) 976-OR-18 1 BK-18 144-GN 144-GN 1
3E-8848
S RD-18 A 604-OR 114-2679 A520-BU-18 2 200-BK-18 2
I BK-18 B 200-BK 202-BK-18 BK-18
I
L
STOP/TAIL/PARK LAMP X 665-BR 5
202-BK-18 DATA 102-RD-14 + BATTERY
611-PU-14 4 BU-18

2
3
4
5
1
6
107-4401 HIGH SPEED VERSION LINK 538-BR OUT (LAMP) L LL RIDE CONTROL L
E 619-GN-14 6 RD-18 INTERRUPT-TILT
202-BK-18 PLUG 200-BK GROUND 976-OR-18 1 976-OR-18 4 605-YL 976-OR-18 976-OR-18 1
614-PU-14 3 WH-18 PRESSURE SW NOTE Z
975-WH-18 2 200-BK-18 1 665-BR 975-WH-18 975-WH-18 2
CODE PLUG OPTIONS PLUG FLASHER 605-YL 1 YL-18 114-8726 5 619-GN-14
4Y-9844 200-BK-18 2 BK-18

8
7
6
5
4
3
1
2

G
H
C
D
116-4927

B
2
1
3
4
5
6
7
8

J
7 144-GN
A 914G - 116-4232 6 F766-WH-18
HIGH SPEED VERSION

A261-BK-18
A263-BK-18
A264-BK-18
A265-BK-18

A260-BK-18
202-BK-18
276-BK-18
277-BK-18
278-BK-18
279-BK-18
280-BK-18
281-BK-18
RIDE

202-BK-18
IT14G - 8Y-7961

202-BK-18
308-YL-18

944-OR-18
945-BR-18
T WH-18 C 614-PU LH HEAD/POSITION/ 3 606-GY

202-BK-18
202-BK-18
(REF LOC B-12) CONTROL
S RD-18 A 604-OR TURN LAMP 2 200-BK-14

200-BK-14
JAPANESE ROADING

615-YL-14
BK-18 B 200-BK RELAY 8 975-WH-18
(REF LOC C-5) NOTE U:

608-GN
603-PK
3E-5239
WIRES THAT HAVE BATTERY VOLTAGE W L
STOP/TAIL/PARK LAMP 200-BK-18 A520-BU-18
107-4401 WHEN THE KEY SWITCH IS OFF. W 85 86
RIGHT SIDE V RIDE CTRL
1 144-GN 87 5 976-OR-18
WIRES THAT HAVE BATTERY VOLTAGE VALVE GP - SOL

11

10
12
Z

1
3
4
6
7
8
9
2
2 200-BK A519-GN-18 976-OR-18 3 761-GY-18
A BK-18 1 W WHEN THE KEY SWITCH IS ON. 30 111-0350
1 964-BU-18
PRIMARY 87a

A538-OR
118-GY
105-RD
608-GN
603-PK
615-YL-14
503-BR
504-YL
505-BU

200-BK-14
108-RD-18
135-BU
TURN LAMP RD-18 2 200-BK BK-18 2 HEATER OPERATOR HYSTAT TRANSMISSION LL 2 762-YL-18
107-4402 BK-18 1 606-GY
STEERING STARTING CIRCUIT. SEAT CONTROL
L A519-GN-18 1 4 614-PU-14 200-BK-14 200-BK-18 A BK-18 GROUND
SWITCH NOTE F W 614-PU-14 5
116-4480 200-BK-18 200-BK-18 2 8 611-PU-14 F766-WH-18 B OR-18 + BATTERY
3E-7810 GAUGE CIRCUIT. A 720-PK-18 ACTION 611-PU-14 4 BU-18
6 322-GY-18 761-GY-18 761-GY-18 C BU-18 SOLENOID

202-BK-18
202-BK-18
202-BK-18
202-BK-18
LAMP + 619-GN-14 6 RD-18 LL
B E800-GN-18 HARNESS CODE 0 20 276-BK-18 HAZARD C2 538-BR-18 7 114-RD-18 L
COSA REAR ROADING
SUPPLEMENTAL STEERING PANEL LAMP CIRCUIT. C 200-BK-18 HARNESS CODE 1 21 277-BK-18 3E-8679 GROUND 31 200-BK-18
614-PU-14 3 WH-18 A519-GN-18 1 LIFT POSITIONER
(REF LOC A-14) 606-GY 1 YL-18 W L
ALARM HARNESS CODE 2 22 278-BK-18 HEAD LAMP 49A 537-GN-14 200-BK-18 2 3E-7844
OPEN ROPS CAB (SHELL) WIPER/WASHER CIRCUIT. HARNESS CODE 3 23 279-BK-18 C920-GY-18 + BATTERY 49 102-RD-14
200-BK-18 2 BK-18 L T
(REF LOC D-13) ARC SUPPRESSOR
HARNESS CODE 4 24 280-BK-18 TURN C F766-WH-18 F766-WH-18 1 F766-WH-18 A OR-18 + BATTERY
HEATER AND AIR CONDITIONER CIRCUIT. HARNESS CODE 5 25 281-BK-18 30B IT14G RIDE CONTROL ONLY 106-8704 762-YL-18 762-YL-18 3 762-YL-18 B BU-18 SOLENOID
OPTIONS CODE 0 3 A260-BK-18 (REF LOC I-1) 2 C BK-18
RH HEAD/POSITION/ 200-BK-18 200-BK-18 GROUND
GROUND CIRCUIT. HEATED SEAT OPTION OPTIONS CODE 1 4 A261-BK-18 GERMAN ROADING FLASHER NOTE Z 964-BU-18 964-BU-18 4
TURN LAMP T
UNUSED 26 8V-2514 BUCKET POSITIONER
ENGINE SHUTDOWN CIRCUIT. (REF LOC D-9) NOTE U:
OPTIONS CODE 3 27 A263-BK-18 116-2025
NOTE N OPTIONS CODE 4 28 A264-BK-18 F766-WH-18 A OR-18 + BATTERY
TURN SIGNAL CIRCUIT. OPTIONS CODE 5 29 A265-BK-18
COSA OPTION
964-BU-18 B BU-18 SOLENOID
(REF LOC C-5)
H START AID CIRCUIT.
ACTION LAMP 30 C920-GY-18 200-BK-18 C BK-18 GROUND H
DATA LINK + 8 944-OR-18 NOTES C, F, J COSA FRONT LIGHTING T
DATA LINK - 9 945-BR-18 K W IT14G AND 914G FORK POSITIONER
UNUSED 10 202-BK-18 12 (REF LOC I-1/F-1) 116-2025
ALL DASHED LINES ARE ATTACHMENTS. W NN GROUND 2 202-BK-18 308-YL-18 1 L N RIGHT
N
1 + BATTERY 1 308-YL-18 710-GN-18 6 200-BK-14 2 BK-18 TURN
3 TRANSMISSION SPEED INPUT 5 710-GN-18 449-BU-18 7 L LL 606-GY 606-GY 1 GY LAMP
LL RIDE CTRL
4 SPEEDOMETER DRIVER 7 449-BU-18 922-BR-18 4 976-OR-18 619-GN-14 619-GN-14 6 N 5C-8960
1 976-OR-18 976-OR-18 1 VALVE GP - SOL
2 REVERSE RETURN SWITCH 16 922-BR-18 923-GY-18 2 975-WH-18 2 200-BK-18 200-BK-18 2 9X-3267 614-PU-14 5
N FLOOD
BRAKE LEVEL 6 FORWARD RETURN SWITCH 17 923-GY-18 754-BU-18 5 611-PU-14 4 GN-14
5 FORWARD SWITCH 18 754-BU-18 752-YL-18 3 614-PU-14 614-PU-14 3 BK-18 LAMP
5G-8107
E REVERSE SWITCH 19 752-YL-18 E801-OR-18 8 LL 611-PU-14 BK-14 109-7041
N
200-BK 2 200-BK-18 FORWARD (PUMP) SOLENOID 31 E801-OR-18 E802-YL-18 10 976-OR-18 1
483-BR 1 483-BR-18 24V RADIO REVERSE (PUMP) SOLENOID 32 E802-YL-18 F762-GY-18 9 NOTE U
L34 L34 200-BK-18 2 L
UNUSED 11 F762-GY-18 11 8 UNUSED 114-RD-18 FORWARD
(W/O DC/DC CONVERTER) UNUSED 40 7 BR WASH ARC SUPPRESSOR 322-GY-18 HORN
483-BR-18 RIDE CONTROL/LOAD CHECK SOL 37 571-OR-18 6 BU PARK UU 106-8704 L 7T-0969
(REF LOC C-9) IT14G
506-PU-18 506-PU-18 REV (MOTOR) SOL RELAY 35 A575-BU-18 K W 5 YL LOW ARC SUPPRESSOR 1 976-OR-18 914G RIDE CONTROL ONLY
NOTE L (REF LOC E-2
507-WH-18 507-WH-18 MOTOR DISPLACEMENT ACTUATOR 38 755-OR-18 F762-GY-18 6 4 WH HIGH 106-8704 2 975-WH-18 (REF LOC F-1)
158-BR-14 158-BR-14 SUPPL STEER GND INTERUPT RELAY CONTACT 33 C903-BU-18 571-OR-18 3 3 BK GROUND NOTE Y
L29 L29
521-YL 521-YL MOTOR SPEED/CREEPER SWITCH 15 F747-OR-18 A575-BU-18 4 2 RD WASHER B+
447-PK-18 8X-9701 RIDE CTRL SW2/LOAD CHECK SW 14 F748-WH-18 755-OR-18 5 1 RD WIPER B+
614-PU-18 SOLENOID RETURN 39 975-WH-18 C903-BU-18 7 H
A SECONDARY STEER PILOT RELAY 36 C905-OR-18 F747-OR-18 8 L UU UU
TT GG LOAD CHECK
T WH-18 C 614-PU MOTOR W PRIMARY STEERING FLOW LAMP 34 484-YL-18 F748-WH-18 10 INTERMITTENT 976-OR-18 1 976-OR-18 976-OR-18 1 VALVE GP - SOL
S RD-18 A 604-OR 200-BK-18 3 GROUND RIDE CONTROL SW1 13 E701-PK-18 975-WH-18 11 WIPER SW 975-WH-18 2 975-WH-18 975-WH-18 2 122-1134
BK-18 B 200-BK FUEL LVL SENDER 200-BK-18 6 GROUND PRIMARY STEERING FLOW SWITCH 12 417-GY-18 1 110-7886
110-4738

BK-0
122-RD-18 1 +24 V BATTERY IN ENGINE SPEED INPUT 6 450-YL-18 9

RD-0
STOP/TAIL/PARK LAMP 120-YL 2 +24 V SWITCHED IN 202-BK-18 2 UU
- + WIPER SWITCH OPTION LOAD CHECK
3E-6467 200-BK-18 447-PK-18 108-RD-18 4 +12 V MEMORY OUT 202-BK-18 12 976-OR-18 1
E E (REF LOC B-6) VALVE GP - SOL
E 135-BU 5 +12 V SWITCHED OUT 975-WH-18 2 122-1134
A C446-PK-18
T WH-18 C 614-PU TT DC/DC CONVERTER LOAD CHECK (IT14G)
L34 GG 119-1733
S RD-18 A 604-OR 200-BK-18 453-PK K W (REF LOC I-1)
30 WW
BK-18 B 200-BK 85 12V RADIO C905-OR-18 1 NOTE Z
G FILTER BYPASS SW SUPPL STEER 484-YL-18 2 G
WW (REF LOC C-9)
STOP/TAIL/PARK LAMP 7X-8549 RELAY E701-PK-18 3
3E-6467 3E-0154 87 86 453-PK NOTE L 417-GY-18 4
A NOTE F WW 200-BK-18 450-YL-18 5
EE L36

ARC SUPPRESSOR
TURN 2 200-BK 727-GN-18 6

RD-0
E E

727-GN-18
LAMP 605-YL MOTOR

507-WH-18
1 200-BK-18 506-PU-18 C905-OR-18

506-PU-18

158-BR-14
FRONT 975-WH-18 HYDROSTATIC TRANSMISSION ELECTRONIC CONTROL

101-RD-14
521-YL
A 85 86 ANTENNA
WASHER

118-5597
BACKUP 2 200-BK SUPPL STEER 8E-1118
7T-8891 87 WW
NOTE W LAMP 1 321-BR 727-GN-14 PILOT RELAY
WW 30 3E-5239
RR RR E 87a NOTE F
LICENSE E E
1 614-PU-18 1 614-PU-18 200-BK-18 MOTOR 507-WH-18 101-RD-14
L77

LAMP 2 200-BK-18 2 200-BK-18 REAR L36 L36

WASHER
7T-8891

200-BK-18 200-BK-14
L39 L39
200-BK-18 200-BK-14
L35 L76 L76
200-BK-18 G 200-BK-14
200-BK-18 122-RD DOME LAMP LAMP SW W 200-BK-14
W
200-BK-18 135-BU AUX 12V 200-BK 107-6032 108-3320 FWD SOL (PUMP) 754-BU-18 12 754-BU-18 615-YL-14
L29 POWER SOCKET G
200-BK FWD SOL RTN (PUMP) 923-GY-18 11 923-GY-18 F
RADIO - 12V 117-2311 L76 L76 FLOOD LAMP
REV SOL (PUMP) 752-YL-18 10 752-YL-18 615-YL 200-BK-14
L36 3E-7140 1 L76 L76 109-7041
GY-14 B1 REV SOL RTN (PUMP) 922-BR-18 9 922-BR-18 615-YL 615-YL
NOTE B L73 F
BR-14 428-OR-18 PUMP SOL POWER 720-PU-18 7 A514-YL-18 615-YL LH SPEAKER
NOTE H
158-BR-14 E ANTENNA 123-WH-18 GND 202-BK-18 2 200-BK-18 615-YL 103-8527
C 30 A 158-BR-14 511-BR-18 8 GY,VI RIGHT SPKR + H AUX FWD SOURCE A916-GN-18 6 615-YL
T 85 L77 L77 2
BK 1 441-OR-18 521-YL-14 B 521-YL 512-GN-18 7 GY/BK,VI/BK RIGHT SPKR - BK-14 PK-14 NEUTRAL START RELAY 330-YL-18 5 330-YL-18 615-YL M L N
L74 N
BK 2 406-PU-18 MOTOR MOTOR 200-BK-14 C 200-BK-14 200-BK 3 BK GROUND WH/RD-14 MOTOR BACKUP ALARM RELAY 331-OR-18 3 331-OR-18 200-BK-14 508-PU-18 619-GN-14 6 GN-14 FLOOD
H
87 86 508-PU-18 2 WH,GN LEFT SPKR + 483-BR-18 ACC POWER 308-YL-18 4 308-YL-18 200-BK-14 509-WH-18 665-BR 665-BR 5 BK-14 LAMP
T COOLANT SERVICE 109-7041
509-WH-18 1 WH/BK,GN/BK LEFT SPKR - 123-WH-18 PARK BK RELAY COIL A514-YL-18 8 720-PU-18 511-BR-18 F 611-PU-14 4 BK-18 N
SW/SENDER BLOWER 3 METER

2
1
RELAY 108-RD-18 5 YL +B MEMORY SS 665-BR 5 GY-14 PU-14 BRAKE OIL LEVEL PARK BK RELAY CONTACT 720-PU-18 1 720-PU-18 512-GN-18 200-BK-14 200-BK 614-PU-14 3
B2 L75 L74 N
F 114-9235 3E-5239 112-9565 3E-9359 LEFT
BLOWER BLOWER 135-BU 6 RD + BATTERY (12V) 610-OR-14 6 PK-14 BU-14 115-1748 SHIFT HANDLE L73 615-YL 615-YL 605-YL 605-YL 1 GY F
CONDENSER GROUP 103-9527

THERMOSTAT SW

200-BK-14
OPTIONAL TURN

515-GY-14
MOTOR 135-BU 4 NC 614-PU-14 8 PU-14 F 200-BK-14 2 BK-18
WH/RD-14

WH/RD-14

MOTOR 3E-6454 4 H W W 106-8984 L74

BEACON M 419-YL-18 615-YL-14 4 YL-14 YL-14 404-YL-18 1 2 L74 N LAMP
593-GN-14
593-GN-14

106-2721 106-2721 ACTION FLOOD LAMP

108-1029 L62 W L73 L73 NOTE U 3E-6466
BK-14

BK-14

SS W NC C SS 608-GN 7 GN-14 B3 123-WH-18 3 ALARM 123-WH-18 117-3468

BK SS L
3 1 521-YL 419-YL-18 308-YL-18 522-WH-14 200-BK-14 122-RD 3 BR-14 OR-14 HYDRAULIC OIL TEMP 200-BK-18 3E-6329 123-WH-18
2 NO W L75 L75
BK 2 513-OR F765-BR-18 SS SS 102-RD-14 2 BU-14 115-1748 403-GN-18 614-PU-18 144-GN 144-GN 1
1 W ROADING
517-BU-14 515-GY-14 127-OR-14 1 OR-14 H 122-RD-18 2 BK LAMP 200-BK-18 2
F 5 PARK WORK1 J J
2
1

2
1

200-BK PARKING GN-14 405-GY-18 C742-OR-18 1 RD

SS RESISTOR H 115-1748
603-PK BRAKE SW 516-GN-14 123-WH-18 F747-OR-18 H BAT BAT
9G-1950 L62 L62 OFF WORK2 J J J
REFRIGERANT SW 200-BK-14 OPTIONAL 200-BK-18 6G-4195 ENGINE OIL PRESS 442-GY-18 SEND 441-OR-18 SEND 614-PU-18
F LAMP
114-5333 BEACON LL

L75
603-PK 200-BK-18 515-GY-14 115-1748 115-1748 4 605-YL L
NOTE A SOCKETS L75 L76 L76 HYDRAULIC COOLANT TEMP

L76
200-BK-14 200-BK 200-BK-18 200-BK-14 H GRD GRD 1 665-BR 976-OR-18 976-OR-18 1
SS 9R-7941 614-PU-18 H BACKLIGHT-1 406-PU-18 TEMP 110-4731 5 619-GN-14 975-WH-18 975-WH-18 2 NOTE Y
J

123-WH-18

C742-OR-18
A/C CLUTCH 115-1748 110-4732

F747-OR-18

C470-BR-18
C445-BU-18
GN 1 513-OR 200-BK-18 123-WH-18 J 7 144-GN

614-PU-18
614-PU-18
122-RD-18
200-BK-18
SOLENOID FLOOD H BACKLIGHT-4

522-WH-14
GN 2

516-GN-14
522-WH 200-BK-18 COOLANT TEMP 200-BK-18 6 F766-WH-18

517-BU-14
200-BK-14
515-GY-14
102-0347 LAMP 115-1748 1 W
614-PU-18 115-1748 F747-OR-18 200-BK-18 3 606-GY
(FOR HIGH SPEED VERSION 109-7041 L62 W 2 LIFT POSITIONER
E F765-BR-18 667-OR-18 H 2 200-BK-14

200-BK-18
200-BK-18
614-PU-18
3

200-BK-18
200-BK-18
200-BK-18
200-BK-18
SEE REF LOC I-12) SPEED L74 3E-7844
1 975-WH-18 975-WH-18 200-BK-18 C446-PK-18 200-BK-18 200-BK-18 8 975-WH-18
C SELECT SW L73
2 975-WH-18 975-WH-18 200-BK-18 123-WH-18 441-OR-18 W L 200-BK-14 200-BK-18 A BK-18 GROUND
F LAMP TEST W 7 107-6035 L2
522-WH 2 975-WH-18 975-WH-18 200-BK FILTER BYPASS 200-BK-18 F766-WH-18 B OR-18 + BATTERY
H 2 107-6065 L76
521-YL 1 975-WH-18 115-1748 761-GY-18 761-GY-18 C BU-18 SOLENOID
3 H W 8 NOTE K
200-BK 614-PU-18 123-WH-18 5 976-OR-18
975-WH-18
L

975-WH-18
200-BK-18

200-BK-18

200-BK-18
720-PU-18
SS
200-BK-14 C446-PK-18 3 761-GY-18
975-WH-18
755-OR-18

J
200-BK-14

HEATER GP H 7 107-3317 L76

2
3
6
5
4
1
ARC SUPPRESSOR 200-BK-18 406-PU-18 605-YL LEFT TURN 1 964-BU-18 BUCKET POSITIONER
608-GN

AIR CONDITIONER GP 107-3318

200-BK
603-PK
200-BK

106-8704 W 405-GY-18 200-BK-18 107-1983 2 762-YL-18 L Y 116-2025

200-BK-18

200-BK-18
200-BK-18
200-BK-18
200-BK-18
H 8 L65 L65

200-BK-14
515-GY
522-WH
517-BU
516-GN
441-OR-18 614-PU-18 404-YL-18 4 614-PU-14 F766-WH F766-WH 1 F766-WH-18 A OR-18 + BATTERY
85 W 86 85 W 86 W 86 85 W 86 85 W 86 W 86 85 W 86

200-BK

200-BK
FUEL SHUTDOWN 406-PU-18 85 85 483-BR-18 123-WH-18 8 611-PU-14 762-YL-18 762-YL-18 3 762-YL-18 B BU-18 SOLENOID

200-BK-14

200-BK-18
200-BK-14
SOLENOID SS C J J
87 W 87 W 87 W 87 W 87 W 87 W 87 W 123-WH-18 538-BR HAZARD 6 322-GY-18 200-BK-18 2 200-BK-18 C BK-18 GROUND

200-BK
101-3897 1 521-YL 521-YL 720-PU-18 200-BK-18 428-OR-18 200-BK-18 107-1983 BAT 7 114-RD-18 964-BU-18 964-BU-18 4
W W W W W W W J J Y
2 522-WH 522-WH 30 30 30 30 30 30 30 188-WH 667-OR-18 200-BK-18 GRD 614-PU-18 W L
L30

C L64 L64
396-PK-18 308-YL-18 308-YL-18 87a 87a 87a 87a 87a 87a 87a
L62 L62 J LAMP
200-BK-18 C444-YL-18 C444-YL-18 START 611-PU HIGH BEAM SPEEDOMETER L N RIGHT
L63 SIG 115-1748 N
REV MOTOR NEUTRAL BACKUP PARK RIDE CONT/ GROUND ALARM AID SW 110-7034 TURN

C471-GN-18
C903-BU-18

C470-BR-18
A575-BU-18

403-GN-18 403-GN-18 200-BK-18 107-1983 200-BK-14 2 BK-18

C444-YL-18

E800-GN-18

A576-GN-14
A514-YL-18

F762-GY-18
307-OR-18

331-OR-18

975-WH-18
975-WH-18
975-WH-18
571-OR-18
306-GN-18

136-GN-18
751-GN-18

976-OR-18
321-BR-18
H L61

122-RD-18

136-GN-18
122-RD-18

128-PK-18
330-YL-18

720-PU-18
720-PU-18
200-BK-14
308-YL-18
419-YL-18
SOLENOID START ALARM BRAKE LOAD CHECK INTERRUPT DISARM 107-6036 J LAMP

L56
449-BU-18 606-GY 606-GY 1 GY

200-BK-18
200-BK-18
396-PK-18

L56 3
308-YL-18

H L57
200-BK

RELAY RELAY RELAY RELAY RELAY RELAY RELAY N 3E-6466

122-RD
E 373-GN 619-GN-14 619-GN-14 6 E

614-PU-14
614-PU-18
614-PU-18
200-BK-18

200-BK-18
200-BK-18

200-BK-18
112-9309 112-9309 112-9309 112-9309 112-9309 112-9309 112-9309 H 6 L60 J
C 310-PU 310-PU 606-GY RIGHT TURN 614-PU-14 5

200-BK

200-BK
2 1 3 NOTE R H 7 N FLOOD
200-BK-18 200-BK-18 107-1983 611-PU-14 4 GN-14
200-BK-18 614-PU-14 614-PU-14 3 BK-18 LAMP
I L P ALTERNATOR H 8
614-PU-18 449-BU-18 611-PU-14 BK-14 109-7041
3E-7772 N

L63
L60

L57

L61

L62

L64

L65
C 200-BK

102-RD-14
200-BK-18
605-YL-18
B 109-RD-6 109-RD-6 200-BK-18 NOTE U
L

606-GY
L62 L62

538-BR
200-BK-18 114-RD-18 FORWARD
NOTE: 126-PK-18 322-GY-18 HORN

614-PU-18
614-PU-18
614-PU-18
ALTERNATOR GROUND 123-WH-18 123-WH-18 L 7T-0969

C471-GN-18

C742-OR-18
C471-GN-18
A576-GN-14

C470-BR-18
F747-OR-18
C903-BU-18

C445-BU-18
C470-BR-18

E800-GN-18

C446-PK-18
A575-BU-18
C444-YL-18
L63

A514-YL-18
F762-GY-18

975-WH-18
975-WH-18
975-WH-18

123-WH-18
610-OR-14

127-OR-14
CONNECTION IS THROUGH

102-RD-14
751-GN-18
306-GN-18

136-GN-18
136-GN-18

571-OR-18
976-OR-18

307-OR-18

331-OR-18

727-GN-18

136-GN-18

428-OR-18
667-OR-18
720-PU-18
102-RD-14

122-RD-18
126-PK-18
720-PU-18
720-PU-18

321-BR-18

614-PU-14

483-BR-18

406-PU-18
122-RD-18
122-RD-18
128-PK-18

200-BK-14

453-PK-18

200-BK-18
615-YL-14

405-GY-18
123-WH-18 614-PU-18 614-PU-18

308-YL-18

419-YL-18

330-YL-18

419-YL-18

484-YL-18

404-YL-18
ALTERNATOR MOUNTING LUG

188-WH
608-GN
122-RD
144-GN

373-GN
665-BR
200-BK

310-PU
129-BU
122-RD

200-BK
200-BK

603-PK
615-YL
H 2 J J
W

614-PU-18

614-PU-14

614-PU-18
614-PU-18
C

L68
3 H NOTE H BAT BAT
399-OR 188-WH 188-WH 1 A576-GN-14 720-PU-18 J J

614-PU
C NOTE P J J
T 109-RD-10 2 200-BK-14 443-YL-18 447-PK-18 SEND 614-PU-18
H 7
373-GN L37 310-PU L36 200-BK-18 200-BK-18 200-BK-18
COOLANT SW 304-WH-10 NOTE H VOLTMETER LAMP FUEL LEVEL LAMP
H 8 GRD GRD
120-9848 110-4730 110-4734 115-1748 ABBREV COLOR
L35

L36

200-BK-18 614-PU-18 115-1748

L20

L44

L41

L71
L J

200-BK-18
200-BK-18

200-BK-18
200-BK-18
200-BK-18

200-BK-18
200-BK-18
200-BK-18
399-OR

614-PU
J
373-GN

306-GN-18 118-GY FORWARD HORN SW 200-BK-18

GND L41

200-BK
200-BK

200-BK

200-BK
405-GY-18 H GN 4 504-YL 144-GN 118-GY 118-GY 2T-3360 200-BK-18 RD RED
MOTOR WH WHITE
450-YL-18 1 614-PU-14 118-GY
WW T W OR ORANGE
C BK 2 200-BK 144-GN 118-GY 118-GY 322-GY-18
C L42 L44
2
5
4
1
3
6

GY 6 118-GY 504-YL 614-PU-18 503-BR 503-BR YL YELLOW

P
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-14

E B+ L20 W L59 L61 L70 FRONT WIPER PK PINK

COLD HEATER BR 3 503-BR 118-GY 614-PU-18 504-YL 504-YL
L40 L40 BEACON SW KEY START SW 118-6291 BK BLACK

L57

L58
START 035-8059 OR 5 505-BU 503-BR 1 144-GN 614-PU-18 505-BU 505-BU L
L58 H 2 107-6033 110-7887 R H VV H GY GRAY
ADVANCE G 505-BU 2 200-BK 144-GN 506-PU-18 506-PU-18

403-GN-18

441-OR-18
102-RD-14

449-BU-18
200-BK-14

447-PK-18
322-GY-18

442-GY-18
3 H L66 GND

443-YL-18
REAR WIPER A538-OR M G 521-YL 603-PK 507-WH-18 507-WH-18 1 YL 200-BK 2 NOTE G 501-GN 4 GN MOTOR H PU PURPLE
MOTOR

123-WH

606-GY
611-PU

614-PU
C OFF
304-WH-10

605-YL
C905-OR-18

118-6290 BR BROWN
200-BK-18
C444-YL-18

603-PK C 135-BU 200-BK 2 PU 188-WH 1 1

975-WH-18
306-GN-18

441-OR-18

403-GN-18

727-GN-18
109-RD-10

406-PU-18

200-BK-18
405-GY-18
450-YL-18

308-YL-18

7X-8549 L49 L49 H 7 S ON

A576-GN-14
NOTE N A/C COMP SW T GN GREEN
109-RD-6

C444-YL-18
396-PK-18 615-YL-14 A 108-RD-18 200-BK-18 500-BR 3 OR 373-GN 3 BK-18 200-BK 2 BK
188-WH

522-WH

B ST

308-YL-18
L69 L69
310-PU

453-PK
521-YL

308-YL-18 608-GN B 200-BK W 107-6070 501-GN 4 BR 310-PU 4 118-GY 6 GY BU BLUE

W 2 H 8 B+ P
G A538-OR 105-RD A 720-PU-18 567-WH 614-PU-18 502-OR 500-BR 3 BR
L78 3 W W

L31
118-GY B E800-GN-18 118-GY 105-RD 502-OR 5 OR SYMBOL DESCRIPTION
C REAR WINDOW

L1
122-RD C 200-BK-18 L59 307-OR-18 L2
200-BK-14

W 7 L2
1
2
3
4
5
6
7
8
9
10
11
12

DEFROSTER GLASS 200-BK-18 308-YL BLADE, SPADE, RING,

608-GN

A L55 L57
603-PK
200-BK
200-BK

112-5228 OR SCREW TERMINAL

L37

L28

200-BK 200-BK W 8 200-BK

D L1 L1 D
C444-YL-18
188-WH
405-GY-18

522-WH
521-YL
441-OR-18
406-PU-18

403-GN-18
308-YL-18

G 200-BK 200-BK 200-BK 614-PU-18 200-BK

L60 L69 L69 CIRCUIT CONNECTED
200-BK-14 200-BK-14

614-PU-18
614-PU-14
614-PU-14

614-PU-14
614-PU-18
614-PU-18
200-BK-14

L57
200-BK-18

200-BK-14

L31
200-BK-18

L31 L57 L73

135-BU

614-PU
L78 L78 L20 L71 CIRCUIT NOT CONNECTED
200-BK-14
L44 L70 L70

L68
L58

L59

L60
200-BK
L45 L45 L66 ELECTRICAL CONNECTION

L71
405-GY-18 200-BK 200-BK-14
L67 L67

L31
200-BK-18 DEFROST SW TO VEHICLE STRUCTURE
L31 L46 107-6034
C A 200-BK-18 W 2 INTERNAL ELECTRICAL
L33

L46

L45

L68
1 450-YL-18 200-BK-18 200-BK-18 14 140-BU 3 W CONNECTION TO SURFACE

C471-GN-18
2 200-BK-18 200-BK-14 200-BK-18 200-BK-18 CIGAR LIGHTER OF COMPONENT

727-GN-18

136-GN-18
614-PU-18
614-PU-18
614-PU-18
200-BK-18

200-BK-18
200-BK-18

200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18

453-PK-18
L42

419-YL-18

484-YL-18
L42 L54 9W-0335
NOTE X 200-BK-14 200-BK-18 200-BK-18 CONNECTOR

188-WH

373-GN

373-GN
W 7

129-BU
200-BK

200-BK

310-PU

310-PU
615-YL

615-YL
ENGINE OIL ENGINE 200-BK-14 F G 122-RD 200-BK-18 200-BK-18 NOTE V H
200-BK-18
200-BK-18
200-BK-14

PRESSURE SW SPEED SENSOR L39 ATCH WIRE, CABLE &

963-GN-18

976-OR-18
614-PU-18
614-PU-18
614-PU-18
614-PU-18
614-PU-18
614-PU-18
614-PU-18
964-BU-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-14 200-BK-14 2 200-BK-14 122-RD-18 200-BK-14 129-BU

762-YL-18

F766-WH
W 8

A538-OR
308-YL-18
308-YL-18
308-YL-18
308-YL-18

7W-1238 116-6680 COMPONENT

A576-GN-14

615-YL-14 615-YL-14 4 122-RD-18 614-PU-18 200-BK

140-BU
128-PK

102-RD-14
308-YL

3054 ENGINE 603-PK 1 122-RD-18 TURN CIRCUIT GROUPING

606-GY
L37

538-BR
200-BK
L37

605-YL
RD-0 608-GN 3 122-RD-18 L#
SIGNAL SW DESIGNATION
9G-5589
L45 BUCKET/FORK
RD-0
L30 L30

E800-GN-18

C445-BU-18
SELECT SW

C446-PK-18
IDENT PART NO. CHG LOC NOTE
L38

428-OR-18

667-OR-18
406-PU-18
483-BR-18

405-GY-18
404-YL-18
AIR SEAT 107-6037 NOTE F

L67

L70
1 H 2
L47

L28 BREAKER NOTE M W J 3 HARNESS AS.

136-GN-18 136-GN-18
122-RD-18

VALVE GP (PUMP) L47 L38 3T-2662 W 2 3 H J 2 A 108-3261 04 A-11 MAIN FRAME

963-GN-18 727-GN-18
F766-WH-18

F766-WH-18

567-WH
3 W
122-RD

122-RD
122-RD

521-YL
111-6126 A H C 114-5344 02 D-14 3054 ENGINE

963-GN-18
976-OR-18
964-BU-18

200-BK-18
200-BK-18
200-BK-18
200-BK-18
128-PK-18

762-YL-18
F766-WH
W H 7 SUPPL STEER E 111-3787 05 A-9 TANK
GN 1 E801-OR-18 X 112-PU-14 200-BK-18 200-BK-18
140-BU

15 W 7 6

C471-GN-18

C742-OR-18
FORWARD SOL W MOTOR SW F 111-0157 01 D-11 ROOF

E800-GN-18

9
7
6
5
4
3
2
10
11
12
1
8
976-OR-18

963-GN-18

C470-BR-18

F747-OR-18

C446-PK-18
614-PU-18
614-PU-18

614-PU-18

614-PU-18

614-PU-18

614-PU-18

614-PU-18
964-BU-18
200-BK-18
200-BK-18

200-BK-18

200-BK-18

200-BK-18

200-BK-18

200-BK-18
GN 2 F760-PU-18 975-WH-18 15 127-OR-14 FLOODS 124-GN 200-BK-18

762-YL-18
2

507-WH-18

123-WH-18
610-OR-14

127-OR-14
102-RD-14
610-OR-14

307-OR-18

441-OR-18

727-GN-18

136-GN-18

428-OR-18
L27

102-RD-14

122-RD-18
F766-WH
H 8

614-PU-18

611-PU-14

506-PU-18

614-PU-14
720-PU-18

483-BR-18
406-PU-18
449-BU-18
200-BK-14

200-BK-18

200-BK-14

447-PK-18

200-BK-18

126-PK-18

453-PK-18
442-GY-18

405-GY-18
L53 5

443-YL-18

615-YL-14

419-YL-18

484-YL-18

404-YL-18
GN 3 E802-YL-18 1 710-GN-18 10 129-BU CIGAR LIGHTER 158-BR-14 614-PU-18 614-PU-18 115-1560 G 111-0158 01 B-9 SHELL

140-BU
128-PK

123-WH

188-WH

608-GN
122-RD
608-GN

144-GN
W 8

665-BR
105-RD

118-GY

606-GY
503-BR

611-PU

614-PU

310-PU
505-BU

129-BU
200-BK
200-BK

603-PK
308-YL

504-YL

605-YL
REVERSE SOL GN 4 F761-BR-18 10 118-GY WIPERS 614-PU-18 H 111-0159 01 C-4 DUCT
TRANSMISSION W
J 107-6077 01 C-5 GAGE
L43

SPEED SENSOR 15 SPARE 122-RD 200-BK-18 3 727-GN-18

STARTER K 111-7877 01 H-8 HTC
3E-8848 10 136-GN SEC STEERING 140-BU 200-BK-18 6 964-BU-18 129-BU 4 1
100-6929 L 108-5587 02 E-2 FRONT FRAME
L13
10 120-YL DC/DC CONVERTER 128-PK 122-RD-18 1 762-YL-18 200-BK
112-PU-10

NOTE S J
15 188-WH START AID 120-YL 120-YL 2 NOTE L M 111-7870 00 F-11 RADIO
MM MM C L48 H
304-WH-10 15 SPARE 108-RD-18 4 453-PK-18 614-PU-18 BACKLIGHT-3 N 112-7292 01 E-1 NACD FRNT

L50

L51

L52

L53

L54

L55
G S W 115-1748 T 112-7745 02 H-1 IT14 KICKOUT
CC GN 10 123-WH GAGES/IND LIGHTS 124-GN 135-BU 5 200-BK-18 200-BK-18
C KICKOUT H L66 L66 U 108-3894 00 I-4 IT14 TILT VLV C
GN 15 140-BU REAR WINDOW DEFROST 158-BR-14 SUPPL STEER MOTOR
112-PU-10

EE L78 W L53
MTR BAT 10 144-GN BEACON/HEATED SEAT 105-RD ON/OFF SW 115-1748 V 111-7873 01 I-13 O'ROPS SHELL
SPEED (MOTOR) X L13 L52 107-6031 W 107-6139 02 B-4 MAIN CAB
10 SPARE 118-GY 614-PU-18
VALVE GP L43 L51 W 2 FRONT WIPER SW X 108-3260 00 B-12 AXLE - 20KPH

L74
MOTOR FF 3 755-OR-18 15 158-BR-14 CONDENSOR MOTORS 136-GN 158-BR-14 128-PK 3 200-BK-18
W L44 L21 L21 L50 W H

F747-OR-18
C742-OR-18

188-WH
310-PU
428-OR-18
603-PK
129-BU

406-PU-18
483-BR-18

506-PU-18
E800-GN-18

484-YL-18
537-GN-14

614-PU-18
610-OR-14
122-RD-18
200-BK-18
200-BK-18
105-RD
307-OR-18
308-YL
611-PU-14
443-YL-18
200-BK-14
605-YL
606-GY

441-OR-18
442-GY-18
447-PK-18
102-RD-14
123-WH
611-PU
614-PU
449-BU-18

503-BR
200-BK
504-YL
505-BU
720-PU-18
608-GN
615-YL-14
136-GN-18

610-OR-14
665-BR

453-PK-18
C446-PK-18
405-GY-18

C470-BR-18
507-WH-18

102-RD-14
122-RD
118-GY
127-OR-14

727-GN-18
144-GN
123-WH-18
614-PU-14

126-PK-18
419-YL-18
200-BK
117-3144 112-6174 B B X 111-3788 00 I-14 AXLE - 35KPH

C471-GN-18
404-YL-18
4 975-WH-18 10 128-PK KICKOUT/RIDE CONTROL 144-GN 521-YL 484-YL-18 H
112-PU-10

1 751-GN-18 15 124-GN BLOWERS 130-RD 522-WH 200-BK-18 118-GY 1 RD Y 112-9599 00 E-1 914 KICKOUT
W 7 H LL 125-8232 00 E-1 Y 914 RIDE CONT
144-GN
144-GN

GN 2 200-BK-18 10 SPARE 114-RD-18 G 200-BK-18 PRIM STEER FLOW 118-GY 2 RD

G728-YL
DD AUX 12V BLOWER SW L52 LL 125-8244 00 H-4 Z IT14 RIDE CONT

200-BK-14
615-YL
512-GN-18
511-BR-18
200-BK-14
615-YL
200-BK-18 GN 10 130-RD STOP LAMPS 127-OR-14 135-BU 1 115-1748 200-BK 3
L42

W W W 110-7890 W 8
FF 10 122-RD MISC POWER 129-BU 200-BK 2 POWER F747-OR-18 C742-OR-18 614-PU-18 502-OR 4 WH DIODE BLOCK AS RR 108-2983 00 G-15 LICENSE LAMP
112-PU-10

L10 L

200-BK
REVERSE (MOTOR) 10 SPARE 123-WH CONNECTOR W 501-GN 5 YL 112-4735 SS 120-4762 02 F-14 A/C CLUTCH
PW
VALVE GP CREEPER SW UU 118-2230 00 G-5 Z IT14 LOAD CK
101-RD-6

10 114-RD-18 FORWARD HORN 188-WH 6 419-YL-18 500-BR 6 BU

BK-00

L43 1 J J H H

538-BR
START 117-3145 10 105-RD KEY SWITCH 200-BK 8C-5492 NOTE K 124-GN 1 GN F766-WH 200-BK-18 506-PU-18 7 BR WW 121-2487 00 D-13 SUPPL STEER
2

1
2
3
4
5
6
7
8
L

1
2
3
4
5
6
7
8
9
10
11
12
RECEPTACLE H

1
2
3
4
5
6
7
8
12V BATTERIES 10 SPARE 200-BK-18 567-WH 2 BR PARK BRAKE 8 E B W
(FOR HIGH SPEED VERSION SEE L46 L46 5 J J W W L73 WIRE AS.
3T-5760 STD BK-00 102-RD-14 200-BK-18 515-GY 5 GY 115-1748
LOC I-14, LOC E-15) 113-8490 10A FUSE L48 L48 4 L66 J FLASHER MM 114-8652 00 C-14
9X-3404 ATT RD-00 308-YL-18 200-BK-18 516-GN 4 GN
200-BK-18

113-8491 15A FUSE L49 3 REAR WIPER SW 3Y-9287 NN 117-3274 00 H-11 24V RADIO
RD-0 20 KM/H ARRANGEMENT 308-YL 200-BK-18 517-BU 3 BU
FF
136-GN

TO ENGINE L56 H
L30

DD RIDE CONTROL/ 112-6174 H B B ATCH FLASHER PP 2G-5298 00 NOTE D,M

L47

E 136-GN-18 200-BK-18 615-YL

604-OR

130-RD
CC BB BB YY END FRAME T L40 IT14 LOAD CHECK NOTE E J H H VV 101-9161 01 D-4 G
BK 1 442-GY-18 144-GN 200-BK-14 522-WH 200-BK-18 118-GY 1 RD
L41

L49
NOTE J H

1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4

1
2
3
4
5
6
POS NEG POS NEG

L67
BK 2 404-YL-18 144-GN FLOOD LAMP 118-GY 2 RD

102-RD-14
L44 1 W W W CABLE AS.
L43

L40
115-1748 200-BK 3
BK-00

T 136-GN-18 W 2 W NC C
L27 W AA 102-7950 00 B-15
C907-WH-18 505-BU 4 WH
975-WH-18

975-WH-18

136-GN-18
710-GN-18
751-GN-18

755-OR-18

755-OR-18
200-BK-18

200-BK-18
200-BK-14

BACKUP ALARM L50 L50 3 L NO W BB 112-7291 00 B-15

L41

HYDRAULIC 115-RD-14 504-YL 5 YL F

G728-YL
W L20 W 6 W PW
3T-1815 SW/SENDER 115-RD-14 F766-WH 976-OR-18 C471-GN-18 503-BR 6 BU SERVICE 615-YL 615-YL CC 111-3760 02 B-15

108-RD-18
200-BK-14
YY E 15 L31 W W 7

615-YL-14

A538-OR
200-BK-18 104-3008 W 200-BK-18 BACKLIGHT-5 200-BK-18 200-BK-18 507-WH-18 7 BR BRAKE SW 200-BK DD 8R-1461 00 C-14

610-OR-14
200-BK-14

611-PU-14
614-PU-18
200-BK-18
608-GN
118-GY
122-RD

135-BU
L51

503-BR

505-BU
W

603-PK
W

504-YL
115-1748 H 6G-4195 EE 108-8758 00 C-14 F

L73
L31

321-BR-18 LAMP BREAKER 614-PU-18 ALTERNATOR 8 F

122-RD-18

DISCONNECT X W L50 W BACKLIGHT-6 W 8 FLOOD LAMP FF 9X-3052 00 C-14

L73
3T-2662 614-PU-18 614-PU-18 115-1748 200-BK 511-BR-18
122-RD
122-RD
105-RD
118-GY

F748-WH-18
SWITCH 115-1748 117-3468 GG 108-8872 00 G-13 F
2
3
4
5
1
6

E701-PK-18
200-BK-18 200-BK 512-GN-18
C742-OR-18

C742-OR-18
F747-OR-18

F747-OR-18

A575-BU-18
A514-YL-18

7N-0718 ZZ E G HYDRAULIC LOCK BACKLIGHT-2 TT 8R-1460 01 G-13 F

976-OR-18
571-OR-18

331-OR-18

307-OR-18

A538-OR
112-PU-14
200-BK-18

614-PU-18 614-PU-18
330-YL-18

CC C 1 W
200-BK-14

L24
5
11
1
3
4
6
7
8
9
2
10
12
NOTE T 101-RD-6 109-RD-6 115-RD-10 DETENT OVERRIDE SW 200-BK-18 200-BK-18 115-1748 YY 122-8097 00 B-15
BK-00

W 2 RH SPEAKER
608-GN

60 W 7X-1886 H ZZ 116-5283 01 B-15

C742-OR-18

C471-GN-18
117-RD-6

E800-GN-18
MAIN POWER

F474-OR-18

C470-BR-18
103-8527

C446-PK-18
614-PU-14
614-PU-18

614-PU-14
614-PU-14
614-PU-18

3 W

507-WH-18

123-WH-18
619-GN-14

610-OR-14

307-OR-18

441-OR-18

136-GN-18

610-OR-14

127-OR-14

727-GN-18

A514-YL-18
122-RD-18

102-RD-14

102-RD-14
614-PU-18

611-PU-14

406-PU-18
483-BR-18

506-PU-18

614-PU-14
449-BU-18
200-BK-18
200-BK-18

200-BK-14

447-PK-18

453-PK-18
442-GY-18

405-GY-18

331-OR-18

331-OR-18
ALT BKR M

615-YL-14

404-YL-18

484-YL-18

419-YL-18

922-BR-18
720-PU-18

720-PU-18
754-BU-18

200-BK-18
923-GY-18
752-YL-18

330-YL-18

308-YL-18
RELAY 1 308-YL-18 C907-WH-18 611-PU-14
ZZ L18 F
614-PU

123-WH

188-WH

608-GN

144-GN
105-RD

606-GY

122-RD
118-GY
9S-0174 PLUG AS

611-PU
614-PU

310-PU

503-BR

655-BR
129-BU

505-BU
603-PK

200-BK

200-BK
L48

308-YL

605-YL

504-YL
101-7740 2 200-BK-18 F748-WH-18 615-YL FLOOD LAMP
TO ENGINE W L11 L11 W7 HH 114-9280 00 B-6 C
109-RD-10 F E701-PK-18 DIMMER SW 200-BK-14 109-7041
END FRAME A F JJ 114-9282 00 B-6 C
L37

L17

308-YL-18 A538-OR C905-OR-18 1 111-7897

W 8
B B
L11

1
L38

BK-18 306-GN-18 308-YL-18 200-BK-14 484-YL-18 2

START FLOOD L38 W W NOTE D
101-RD-6

BAT DISC OPTION BK-18 2 200-BK-18 308-YL 200-BK-14 200-BK-14 E701-PK-18 3

RELAY LAMP W CAB
308-YL-18 200-BK-14 C907-WH-18 417-GY-18 4
L5
RD-0

118-3534 L29 109-7041 W GROUND

308-YL-18 200-BK-14 E701-PK-18 450-YL-18 5
L18 L18 NOTE C
C C F748-WH-18 6
L17 L17
RD-0 109-RD-10 304-WH-10 F747-OR-18
THIS SCHEMATIC IS FOR THE 914G / IT14G
L29

L28

310-PU A W C742-OR-18 W HH
975-WH-18

CC BB BB AA E L16 L16 (101-9160 CHG 00)

12V BATTERY AUX BKR 308-YL-18 12 200-BK-14 STRAP AS. 7G-1060 308-YL-18 308-YL-18 1
POS NEG POS NEG 3T-5760 STD 5H-6565 522-WH 6 450-YL-18 923-GY-18 2
L22 FRAME THIS SCHEMATIC IS DRAWN FOR ALL NACD VERSION 914G

C471-GN-18
C470-BR-18
521-YL 7 C905-OR-18 F762-GY-18 752-YL-18 3

C742-OR-18

E800-GN-18
9X-3404 ATT

F747-OR-18

C446-PK-18
A514-YL-18
BK-0

CC A

123-WH-18
GROUND

507-WH-18
136-GN-18
610-OR-14
610-OR-14

331-OR-18

307-OR-18

619-GN-14

127-OR-14

727-GN-18
102-RD-14
102-RD-14
122-RD-18

611-PU-14

720-PU-18
720-PU-18

506-PU-18

483-BR-18

614-PU-14
614-PU-18
614-PU-14
449-BU-18

406-PU-18
200-BK-18

447-PK-18
453-PK-18

200-BK-18

200-BK-14
200-BK-18
442-GY-18
308-YL-18

405-GY-18
441-0R-18
WITH THE 3054 ENGINE AND FOR THE STANDARD POWERTRAIN.

330-YL-18

615-YL-14

419-YL-18

404-YL-18
101-RD-10 115-RD-10 C444-YL-18 10 308-YL-18 F762-GY-18 C903-BU-18 922-BR-18 4
507-WH-18

975-WH-18

975-WH-18
C905-OR-18
710-GN-18
751-GN-18
755-OR-18

727-GN-18
C446-PK-18

321-BR-18

158-BR-14

506-PU-18
483-BR-18

614-PU-18
417-GY-18

442-GY-18

447-PK-18

200-BK-14

30 L16 L16
404-YL-18

188-WH
123-WH

144-GN
608-GN
105-RD
122-RD

118-GY
12V BATTERY DIFFERENCES TO ACCOMMODATE THE IT14G, HIGH SPEED

606-GY
503-BR

611-PU

614-PU
505-BU

129-BU

310-PU

665-BR
603-PK

200-BK

200-BK
308-YL
504-YL

605-YL
450-YL-18 4 450-YL-18 450-YL-18 C903-BU-18 C905-OR-18 754-BU-18 5
A
453-PK

3T-5760 STD
521-YL

AA POWERTRAIN AND ATTACHMENTS ARE ALSO SHOWN

A575-BU-18
200-BK-14 188-WH 2 188-WH F748-WH-18 F748-WH-18 710-GN-18 6
C A

331-OR-18
571-OR-18

571-OR-18
L25 L20 L20

922-BR-18
754-BU-18
TO ENGINE

923-GY-18

A575-BU-18
9X-3404 ATT

484-YL-18
752-YL-18
373-GN 310-PU 405-GY-18 3 975-WH-18 449-BU-18 7
END FRAME L10 L10 COMPONENTS ARE SHOWN INSTALLED ON A FULLY
THERMAL START 441-0R-18 8 975-WH-18 975-WH-18 975-WH-18 E801-OR-18 8
L13 L13 NOTE OPERABLE MACHINE WITH THE KEY AND ENGINE OFF,
L42
L34

976-OR-18
RESISTOR 406-PU-18 9 975-WH-18 975-WH-18 752-YL-18 F761-BR-18 9
L42 LOC XMSN SHIFTER IN NEUTRAL AND WITH PARK BRAKE
7W-1251 5 419-YL-18 L9 922-BR-18 E802-YL-18 10
L21 L21 L9 AND HYDRAULIC LOCK SET

L9

L8

L6

L5
L23

C C 403-GN-18 11 720-PU-18 754-BU-18 F760-PU-18 11 130-RD

L5 L5 L12 C-9,F-5 NOTE K: EITHER THE CREEPER SWITCH (LOC C-9) OR THE
200-BK-18 308-YL-18 396-PK-18 310-PU 1 720-PU-18 923-GY-18 C742-OR-18 12 114-RD-18
L7 SPEED SELECT SWITCH (LOC F-5) IS INSTALLED,
109-RD-6

396-PK-18 E800-GN-18 331-OR-18 W JJ 144-GN THE DATA LINK WIRES (944-OR & 945-BR) MUST BE TWISTED
604-OR

A W
604-OR

FUEL SOLENOID
321-BR

614-PU
614-PU

200-BK
200-BK
605-YL

976-OR-18
L19 NEVER BOTH. NOTE TOGETHER AT LEAST 1 TURN PER INCH
200-BK 200-BK-18 RESISTOR 604-OR 1 C470-BR-18 A575-BU-18 128-PK-18 1

L12
L14 L15 C-9,G-11, NOTE L: LOCATION FOR 24V TO 12V CONVERTER OR JUMPER LOC
7T-4003 665-BR 3 C471-GN-18 484-YL-18 200-BK-18 2
L26 L14 G-12 PLUG FOR 24V RADIO (LOC G-9) UNLESS OTHERWISE SPECIFIED: ALL WIRE IS 16 GAGE
200-BK 200-BK-14 606-GY 4 321-BR-18 751-GN-18 571-OR-18 571-OR-18 3 130-RD

L11
C L19

L3
200-BK 109-RD-6 117-RD-6 109-RD-6 605-YL 5 306-GN-18 128-PK-18 A575-BU-18 4 604-OR C-8 NOTE M: STANDARD IT14G BUCKET/FORK SELECT SWITCH F-15 NOTE A: NORMALLY OPEN BEFORE REFRIGERANT CHARGE

136-GN-18

114-RD-18
127-OR-14
L1

102-RD-14
60

308-YL-18
A L10 L10 L11 SHOWN. FOR 914G, JUMPER WIRE, 2G-5298, F-11 NOTE B: RADIO TO BE INSTALLED BY DEALER
200-BK MAIN BKR 109-RD-6 614-PU-14 6 200-BK-14 321-BR-18 755-OR-18 331-OR-18 9 403-GN-18

188-WH
123-WH

144-GN
144-GN

130-RD
L15 L1

129-BU

308-YL
109-RD-10 321-BR 2 C905-OR-18 11 C905-OR-18 710-GN-18 F748-WH-18 10 322-GY-18 CONNECTS TERMINALS 1 AND 2. B-6,H-8 NOTE C: STANDARD PLUG ASSEMBLIES SHOWN. SEE LOCATION
L32

9S-0174 L19
306-GN-18 321-BR-18 9 321-BR-18 417-GY-18 975-WH-18 11 200-BK-18 D-9,H-11 NOTE N: LOCATION FOR ATTACHMENT HEATED SEAT WITH H-8 FOR TRANSMISSION CONTROL, WHICH IS STANDARD FOR
AUXILLARY
PRIMARY E 188-WH A 975-WH-18 2 SOLENOID E802-YL-18 C907-WH-18 12 200-BK-14 200-BK PARKING BRAKE ALARM. (LOC H-11) HIGH SPEED AND ATTACHMENT FOR STANDARD
W TILT

403-GN-18
L6

406-PU-18
L14

405-GY-18
441-0R-18
STEER E-9 NOTE P: CONNECTION FOR AIR SUSPENSION SEAT. B-5 NOTE D: OPTIONAL DIMMER SWITCH SHOWN. STANDARD
200-BK
200-BK

1 417-GY-18 310-PU 2 158-BR-14 1 POSITIONER E801-OR-18 F747-OR-18 8 200-BK-18 200-BK-14

L19 L14

604-OR
606-GY
310-PU

665-BR
NOTE F E-12 NOTE R: NOT REQUIRED FOR HIGH SPEED MACHINE. MACHINE HAS JUMPER WIRE 2G-5298 CONNECTING

605-YL
2 200-BK-18 406-PU-18 306-GN-18 1 521-YL 5 SOLENOID F761-BR-18 F762-GY-18 6 200-BK-14 200-BK-18
L27 L27 LIFT
A C-13 NOTE S: REQUIRED FOR OPTIONAL SPEEDOMETER OR TERMINALS 1 AND 2
L21

441-OR-18 12 F760-PU-18 C903-BU-18 7 200-BK

L10
L33 L33 POSITIONER
BACKUP 2 200-BK 521-YL 751-GN-18 727-GN-18 8 RD 5 200-BK-18 449-BU-18 755-OR-18 5 TRANSMISSION CONTROL OPTION. B-5,C-5 NOTE E: CONNECTIONS TO ATTACH GERMAN ROADING
SOLENOID
LAMP 1 321-BR 522-WH E801-OR-18 1 C446-PK-18 10 RD 4 F766-WH-18 200-BK-18 B-15 NOTE T: ATTACH DISCONNECT SWITCH BETWEEN BATTERY FLASHER 8V-2514 ARE SHOWN AT H-7
L25 L25 L27 L14 L14 FLOAT
308-YL-18 F760-PU-18 2 507-WH-18 4 SOLENOID RD 3 963-GN-18 614-PU-14 AND GROUND. CONNECTIONS FOR JAPANESE ROADING FLASHER
158-BR-14

A L12 H-1,I-1 NOTE U: FOR COSA LEFT HAND TRAFFIC ROADING USE: 4Y-9844 ARE SHOWN AT I-7
A 403-GN-18 E802-YL-18 3 483-BR-18 6 RD 6 200-BK-18 322-GY-18 A
522-WH
521-YL

TURN L10 3E-7587 A-14,C-6, NOTE F: ATTACHMENT SUPPLEMENTAL STEERING SYSTEM

L7
2 200-BK C444-YL-18 F761-BR-18 4 453-PK 7 RD 7 200-BK-18 114-RD-18
LAMP L8 L9 L9 FOR COSA RIGHT HAND TRAFFIC ROADING USE: G-13,H-8, INCLUDES: ROCKER SW (LOC C-6), RELAY AND
1 606-GY 606-GY 405-GY-18 A W 506-PU-18 3 RD 2 761-GY-18 144-GN
450-YL-18 RD 1 F766-WH-18 449-BU-18 605-YL 3E-7586 G-12,H-14 MOTOR (LOC G-13), RELAY (LOC G-12), AND FLOW
L23 E W
A FOR ITALY ROADING USE: LEFT MOUNT-105-4849 SW (LOC H-14), REQUIRES TRANSMISSION CONTROL
L24

665-BR 115-RD-10 1 RD 8 200-BK-18 606-GY

L24 RIGHT MOUNT-105-4850 OPTION ON STANDARD MACHINES
S RD-18 A 604-OR 604-OR A W 404-YL-18 1 (TYP) W 975-WH-18 665-BR
T WH-18 665-BR VALVE GP 115-3370 L3 D-6 NOTE V: 9V-7204 FLUORESCENT SERVICE LAMP IS D-4 NOTE G: LOCATION FOR OPTIONAL START AID
C 442-GY-18 2 619-GN-14
L6 L6 L3 AVAILABLE AND IS POWERED FROM THE CIGAR TIMER (4Y-7948)
BK-18 B 200-BK 117-RD-6 1 447-PK-18 3 128-PK-18 611-PU-14
L22

L13 L2 L2
A W 710-GN-18 6 F766-WH 964-BU-18 964-BU-18 LIGHTER SOCKET D-4,D-7 NOTE H: CONNECTIONS FOR FUTURE MODEL WARNING LAMP,
STOP/TAIL/PARK LAMP L26 L15 L15 L4 L4 L4
321-BR 755-OR-18 4 964-BU-18 762-YL-18 762-YL-18 G-15 NOTE W: CONNECTION FOR BACHUP LAMP (SCM ONLY) F-6 ROCKER SWITCH AND GAGE.
3E-6467
417-GY-18 8 762-YL-18 F766-WH F766-WH D-13 NOTE X: CONNECTION FOR ELECTRIC FUEL PRIMING B-8,H-8 NOTE J: AUTO RIDE CONTROL SWITCH, 107-6030 IS SHOWN.
A L23 L23 PUMP 4Y-7035 (SCM ONLY) (REQUIRES TRANSMISSION CONTROL OPTION ON
604-OR 751-GN-18 5 976-OR-18 976-OR-18 975-WH-18
L27 L27 L13 L13 F-1,G-4 NOTE Y: FOR MACHINES WITH RIDE CONTROL, STANDARD MACHINES.)
S RD-18 A 604-OR 604-OR 614-PU-18 7 976-OR-18
L26 L26 ATTACH HARNESS AS. LL
T WH-18 C 665-BR 321-BR E W 761-GY-18
L32 L4 L4 I-1,G-6, NOTE Z: FOR MACHINES WITH RIDE CONTROL, THIS IS ALSO LOCATION FOR 118-7237 MANUAL
BK-18 B 200-BK 605-YL 605-YL 614-PU-18 200-BK-14 200-BK-14
L22 L5 L5 H-4 ATTACH HARNESS AS. LL RIDE CONTROL SWITCH, OR FOR 107-6067 LOAD
STOP/TAIL/PARK LAMP 614-PU 614-PU-14 L5
L8 L8 FOR MACHINES WITH LOAD CHECK, CHECK/BUCKET LOWER SWITCH (IT14G OPTION ONLY).
3E-6467 614-PU 751-GN-18 L8
L32 L7 L7 ATTACH HARNESS AS. UU ONLY ONE OPTION CAN BE INSTALLED.
L7

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1