Scribd
Upload
29 views

Check For Intermittent Problems

Uploaded by

Yomar Negron
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
29 views

Check For Intermittent Problems

Uploaded by

Yomar Negron
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
You are on page 1/ 2

Print-Toyota Service Information 11/3/17, 9(22 pm

Print Exit

BRAKE CONTROL / DYNAMIC CONTROL SYSTEMS ANTI-LOCK BRAKE SYSTEM CHECK FOR
INTERMITTENT PROBLEMS

CHECK FOR INTERMITTENT PROBLEMS

HINT:
A momentary interruption (open circuit) in the connectors and/or wire harnesses between the sensors and ECUs
can be detected using the ECU Data List function of the GTS.

a. Turn the ignition switch off.

b. Connect the GTS to the DLC3.

c. Turn the ignition switch to ON.

d. Turn the GTS on.

e. Follow the directions on the GTS to display the Data List and select areas where momentary interruptions
should be monitored.
HINT:
· A momentary interruption (open circuit) cannot be detected for 3 seconds after the ignition switch
is turned to ON (initial check).
· If the Error display remains displayed, measure the resistance between the ECUs and sensors, or
between ECUs.
· The Error display on the GTS will remain displayed for 1 second after the harness signal changes
from momentary interruption (open circuit) to the normal condition.

Chassis > ABS/VSC/TRC > Data List


Measurement Normal
Tester Display Range Diagnostic Note
Item Condition
Front speed sensor Error: Momentary
FR Speed Open Error or Normal Normal
RH open detection interruption
Front speed sensor Error: Momentary
FL Speed Open Error or Normal Normal
LH open detection interruption
Rear speed sensor Error: Momentary
RR Speed Open Error or Normal Normal
RH open detection interruption
Rear speed sensor Error: Momentary
RL Speed Open Error or Normal Normal
LH open detection interruption
EFI ECM
Error: Momentary
Communication communication Error or Normal Normal
interruption
Open open detection
Error: Momentary
Deceleration
interruption
Deceleration Open sensor open Error or Normal Normal
for 4WD and Pre-
detection
Runner
IG Voltage Value IG voltage value
Error or Normal Normal Error: Voltage low
Decreased decrease detection
IG Voltage Value IG voltage value Error: Voltage
Error or Normal Normal
Increased increase detection high
Front speed sensor
FR Speed Sensor Error: Momentary
RH voltage open Error or Normal Normal
Voltage Open interruption
detection
Front speed sensor
FL Speed Sensor Error: Momentary
LH voltage open Error or Normal Normal
Voltage Open interruption
detection
RR Speed Sensor Rear speed sensor Error: Momentary
Voltage Open RH voltage open Error or Normal Normal interruption

https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000L250.html?PUB_TYPE=RM&MODE=1 Page 1 of 2
Print-Toyota Service Information 11/3/17, 9(22 pm

detection
Rear speed sensor
RL Speed Sensor Error: Momentary
LH voltage open Error or Normal Normal
Voltage Open interruption
detection
EFI ECM
Communication communication Error or Normal Normal Error: Invalid
Invalid invalid detection

f. While observing the screen, gently jiggle the connector or wire harness between the ECU and sensors, or
between ECUs.
OK:
Normal is displayed.

HINT:
If the display changes, the connector and/or the wire harness has caused a momentary interruption of
the circuit. Repair or replace the connector and/or wire harness as one of them is faulty.

© 2012 TOYOTA MOTOR CORPORATION. All Rights Reserved.

https://toyotamanuals.com.au/docs/hilux-service-repair-manual-j…manual/repair/contents/RM100000000L250.html?PUB_TYPE=RM&MODE=1 Page 2 of 2

You might also like