Courtesy of Bomar Flying Service

www.bomar.biz
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Published by
Technical Publications

Piper Aircraft Corporation

2926 Piper Drive
Vero Beach, Florida 32960
U.S.A.

Member of GAMA
General Aviation
Manufacturers Association

Added: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

AEROFICHE EXPLANATION AND REVISION STATUS

The Parts Catalog information in this set of Aerofiche cards is arranged in accordance with general specifications of Aerofiche adopted
by the General Aviation Manufacturer's Association.

Conversion of Aerofiche alpha/numeric code numbers:

First number is the Aerofiche card identifier.
Letter is the horizontal line reference per card.
Second number is the vertical line reference per card.
Example: 2J16 = Aerofiche card number two of given set, Grid location J16.

REVISIONS

The information compiled in this Aerofiche Parts Catalog is kept current by revisions distributed periodically. Each revision is a complete
Aerofiche card replacement and supersedes Aerofiche cards of the same number in the set.

Revisions to this PA-28-1511161 Parts Catalog (761 538) issued June 11, 1979 are as follows:

Aerof iche
Effectivity Publication Date Card Effectivity

December 1, 1989 1 and 2

July 30, 1994 1 and 2

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
AIRPLANE PARTS CATALOG

INTRODUCTION
This illustrated Parts Catalog provides simple, positive identification of replacement parts for the Piper Model PA-28-151/161 manufactured
by the Piper Aircraft Corporation of Vero Beach, Florida.

NOTE: DO NOT USE THIS CATALOG FOR RIGGING AND INSTALLATIONPURPOSES,

1. The catalog is divided into thirteen major sections as follows:

a. Section I to XI1 inclusive contains all replacement parts for the complete airplane. Each section is subdivided and each
division includes an illustration and a parts listing.
b. Section Xlll is the Miscellaneous Group. This group includes an illustration and parts list for the Placards and Exterior
Stencils, a listing of the Optional Equipment Kits, Repair kits and Special Tools, and a listing of Miscellaneous Hardware and
Consumables.

2. The following is a brief explanation of the columns in the parts lists: (Refer to EXAMPLE below).
a. The FIGURE AND INDEX NUMBER column indicates the illustration figure number and its part index number.
EXAMPLE: (2-I), the 2 is the figure number and the 1 is the index number. The figure number appears only at the top of each
parts list page.
b. The PART NUMBER column contains the identifying number of the replacement part and this number must be shown on all
parts orders.
c. The CODE column is for the purpose of indicating special uses of the part. An explanation of the letter code used is shown on
the grid (page) preceding each parts listing and pertains to that listing only.
d. The NOMENCLATURE column indicates the part name. This name must be shown on all parts orders.
e. The NO. REQ. (Number Required) column represents the total quantity of parts used per figure when the part is not indented
and the quantity of parts used per assembly when the part is indented. The symbol AR listed in this column means As
Required.
f. The SERIAL NUMBERS AFFECTED column indicates the part application by airplane serial number. Unless otherwise noted,
serial numbers listed with the model year and up (ex. 28-7716001 and up) are intended to include the new style of serial
numbers that do not reference the model year (ex. 2816001 and up).

EXAMPLE
Figure
and Part No. SERIAL NUMBERS
Index Number Code NOMENCLATURE Req. AFFECTED
Number

XXXXX-XX DOOR ASSEMBLY - Baggage compartment

XXXM-XX -
TUBE ASSEMBLY Baggage door latch
Xxxxx-XX '' CLEVIS - Door latch tube assembly
Xxxxx-XX -
' * CLIP Door latch tube assembly
In the nomenclature column, the next higher assembly relationship of items covered is shown by the degree of indention of each
item and is indicated by an asterisk (*). One asterisk signifies one indention, two signifies two indentions, etc. The example listing
above is interpreted as follows:

If the DOOR ASSEMBLY (not indented) is ordered, it will include the three items indented under the DOOR ASSEMBLY.

If the TUBE ASSEMBLY (indented one space) is ordered, it will include the two items indented under the TUBE ASSEMBLY.

If you want only a CLEVIS or CLIP, you order only that item.

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
3. Piper Aircraft will supply all attaching parts to its customers in any quantity. When purchasingthe attaching parts such as nuts, bolts,
washers, cotter pins, etc. from Piper Aircraft, the customer or service center need only order the part(s) needed.
4. All items of Optional Equipment are contained in the parts list in their proper sequence and sections. These items were not marked
optional, since they are fully identified by their descriptions.

HOW TO IDENTIFY A PART

IF YOU KNOW WHAT IT LOOKS UKE
AND KNOW WHERE IT IS LOCATED

1. Refer to Figure 1 to determine the section number in which the part is used.

2. Refer to the Table of Contents and locate the section. Note the figure numbers that illustrate the various subgroups of this main section.
Select the figure title you think might contain the part you wish to identify and proceed to the grid (page) specified. If you don't find the
part on this illustration, try another figure in this group.

3. Refer to Figure and Index Number in the parts listing for description of the part.

HOW TO ORDER PARTS

When ordering parts for your Piper airplanes, please observe the following instructions:
1. Place your order with your local distributor or service center.
2. Specify the model and serial number of your airplane.
3. Specify Part Number, Name, Type and Quantity Required.
4. Specify the method of shipment freight, express, parcel post, air express, air freight or air parcel post. Where the nature of the
shipment requires it or when no instructions are given, we reserve the right to ship the most suitable way.
5. Request price and delivery information prior to order placement.

GENERAL INFORMATION

1. Shortages
All orders are checked before leaving our Shipping Department. A packing slip is enclosed with the shipment. Claims for errors or
shortages must be made within three days after receipt of orders.

2. Returned Goods
No material should be returned without first securing written permission. Material sent in without notice will be held at the owner's risk
for thirty days and will then be disposed of as we see fit.

Transportation charges must be prepaid on returned goods or the shipment will be refused.

3. Transportation Liabilities
The Piper Aircraft Corporation cannot be held liable for damages to parts in transit from the factory. If a shipment is received in a
damaged condition, have the delivery man or transportation company make a notation of the damage and file your claim with the carrier.
In case of concealed damage, do not attempt to remove the part from the shipping container, or try to repair the damage, call the carrier
and have their claim agent inspect the damage before filing your claim with the carrier.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

MODEL SERIAL NUMBER INFORMATION

The serial numbers of the aircraft covered by this Parts Catalog are as follows:

Serial Numbers of the 1974 PA-28-151 WARRIOR Models are 28-7415001 thru 28-7415703.
Serial Numbers of the 1975 PA-28-151 WARRIOR Models are 28-7515001 thru 28-7515449.
Serial Numbers of the 1976 PA-28-151 WARRIOR Models are 28-7615002 thru 28-7615435.
Serial Numbers of the 1977 PA-28-151 WARRIOR Models are 28-7715001 thru 28-7715314.
Serial Numbers of the 1977 PA-28-161 WARRIOR 1
I Models are 28-7716002 thru 28-7716323.
Serial Numbers of the 1978 PA-28-161WARRIOR 1I Models are 28-7816001 thru 28-7816680.
Serial Numbers of the 1979 PA-28-161 WARRIOR 1
I Models are 28-7916001 thru 28-7916598.
Serial Numbers of the 1980 PA-28-161 WARRIOR II Models are 28-8016001 thru 28-8016373.
Serial Numbers of the 1981 PA-28-161 WARRIOR II Models are 28-8116001 thru 28-8116322..
Serial Numbers of the 1982 PA-28-161 WARRIOR I1Models are 28-8216001 thru 28-8216226.
Serial Numbers of the 1983 PA-28-161 WARRIOR 1
I Models are 28-8316001 thru 28-8316112.
Serial Numbers of the 1984 PA-28-161 WARRIOR 1
I Models are 28-8416001 thru 28-8416131.
Serial Numbers of the 1985 PA-28-161 WARRIOR II Models are 28-8516001 thru 28-8516099.
Serial Numbers of the 1986 PA-28-161 WARRIOR II Models are 28-8616001 thru 28-8616057.
2816001 thru 2816010 (less 2816002).
Serial Numbers of the 1987 PA-28-161 WARRIOR II Models are 2816002, 2816011 thru 2816036
(less 2816029 thru 2816033).
Serial Numbers of the 1988 PA-28-161WARRIOR 1 I Models are 2816029 thrh 2816033,
2816037 thm 2816075 (less 2816066).
Serial Numbers of the 1989 PA-28-161 WARRIOR 11 Models are 2816076 thru 2816094.
Serial Numbers of the 1990 PA-28-161WARRIOR II Models are 2816095 thru 2816099.
Serial Numbers of the 1992 PA-28-161 WARRIOR 1I Models are 2816100 thru 2816103.
Serial Numbers of the 1993 PA-28-161 WARRIOR II Models are 2816106 thm 2816109.
Serial Numbers of the 1994 PA-28-161 WARRIOR I1 Models are 2816104 and2816105.
Serial Numbers of the 1994 PA-28-161 WARRIOR Ill Models are 2816110 and up.

SERIAL NUMBER EXPLANATION

The Serial Number on the Manufacturer's Identification Plate is based on either a 3- or 4-set numbering system. In the 4-set system, the
first set defines the Type Certificate Designation, the second set is the Model Year, the third set is the Model Code, while the fourth set is the
Model Sequence Number (within a model year).

The 3-set system omits the model yea? and begins a new sequence with 2816001. This new sequence continues without renumbering for
a new year.

EXAMPLE
28 74 16 001

TYPE CERTIFICATE DESIGNATION 1 MODEL SEQUENCE NUMBER

(Within a Model Year)

'MODEL YEAR MODEL CODE

(1974 and subsequent) 16 = PA-28-161 WARRIOR

EXAMPLE
(late 1986 and subsequent)

TYPE CERTIFICATE DESIGNATION

(Without regard for Model Year)

MODEL CODE
16 = PA 28-161 WARRIOR

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-I51/161 WARRIOR
AIRPLANE PARTS CATALOG

STANDARD PAINT CHART

MFG. PIPER PART NUMBER

NO. QUART GALLON
EXTERIOR

POLYURETHANE ENAMEL (Dupont Imron)

Baja Yellow
Juneau White
Ocala Orange
Madrid Red
Baharna Blue
Alvocado
Las Vegas Gold
Dakota Black
Denver Brown
Matador Red
Royal Blue
Hickory Brown
Silver
time Green
Sage Green
Firethorn
Buckskin
Dark Blue
Platinum Gray
Sandalwood Tan
Dark Claret
Burnished Gold
tight Blue
Dark Saddle
Dark Green
Saffron
tight Sandalwood
tight Platinum

Catalyst (Activator)
Reducer
Retarder
Accelerator

POLYURETHANE PRIMER (Dupont Imron)

Wash Primer
Wash Primer Thinner
Acid Thinner

INTERIOR

INSTRUMENT PANEL
Cadet Dark Grey
Grey II (Flat Tan)

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

TABLE OF CONTENTS
FIGURE NUMBER FIGURE TITLE GRID NUMBER

1 View of Complete Airplane................................................................................................................. A 2A13

SECTION I
WING GROUP

Wing Installation.................................................................................................................................. lA15

Wing Leading Edge Assembly ............................................................................................................ 1A20
Wing Trailing Edge Assembly ......................................................................................................... A 2 4
Aileron Assembly (28-7415001 thm 28-7515459) ..............................................................................185
Aileron Assembly (28-7615001 and up. and 28-7716001 and up) .................................................... l B 9
Flap Assembly ....................................................................................................................................1812

SECTION ll
FUSELAGE GROUP

Fuselage Assembly Complete ............................................................................................................ B 1 5

Fuselage Upper Forward Cockpit Assembly ....................................................................................... B 1 9
Fuselage Upper Center Cockpit Assembly.........................................................................................1823
Fuselage Lower Forward Cockpit Assembly .......................................................................................C 4
Fuselage Lower Aft Cockpit Assembly ............................................................................................... 1C8
Fuselage Aft Section ...........................................................................................................................C 1 1
Fuselage Baggage Door Assembly .................................................................................................... lC15
Fuselage Cabin Door Assembly (28-7415001 thm 28-7615001) .......................................................C 1 8
Fuselage Cabin Door Assembly (28-7615002 and up, and 28-7716001 and up)...............................1C22
Fuselage Enclosure Installation.... ..,...................................................................................................I D 3

SECTlON Ill
TAIL SURFACES GROUP

Tail Surfaces Installation..................................................................................................................... ID9

Stabilator Assembly ...................................................................................................................... D l 3
Fin Assembly ...................................................................................................................................... ID16
Rudder Assembly .............................................................................................................................. ID19

SECTION IV
LANDING GEAR GROUP

Nose Gear Installation ................................................................................................................... ID23

Nose Gear Strut Assembly.................................................................................................................. l E 3
Nose Wheel Assembly (Cleveland) .................................................................................................... l E 7
Nose Wheel Assembly (McCauley) ................................................................................................... E l 0
Main Gear Installation...................................................................................................................... E l 3
Main Wheel Assembly ....................................................................................................................... E l 7
Brake Assembly ................................................................................................................................. E 2 0
Main and Nose Wheel Fairing Installation (28-7415001 and up. and 28-7716001 thw 7716323) .....1E23
Main and Nose Wheel Fairing Installation (28-7816001 and up) ........................................................ I F 2
Main Landing Gear Strut Fairing Installation....................................................................................... I F 6
Hand Brake Installation....................................................................................................................... IF9
Toe Brake Installation.......................................................................................................................... IF12
Toe Brake Master Cylinder Assembly ................................................................................................. IF15

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

TABLE OF CONTENTS
FIGURE NUMBER FIGURE TITLE GRID NUMBER

SECTION V
CABIN EQUIPMENT GROUP

35 Cockpit Finishing Installation ........................................................................................................... IF19

36 Window Curtains Installation (sln 28-8016001 and up) ..............................................................1 G3
37 Carpet Installation .............................................................................................................................lG6
38 Seats Installation.................................................................................................................................
lG13
39 Vertically Adjustable Front Seat Assembly .........................................................................................1G I 8

SECTION VI
INSTRUMENTS GROUP

40 Instrument Panel Installation (sln 28-7415001 and up. and 28-7716001 thru 2816109).................... 1H1
40A Instrument Panel Installation (sln 2816110 and up) ............................................................................ lH7
41 Vacuum System Installation (sln 28-7415001 and up. and 28-7716001 thru 2816109) .....................1H10
41A Vacuum System Installation (sln 2816110 and up) .............................................................................H I 3
418 Auxiliary Vacuum System Installation ................................................................................................. 1H I 6
42 Pitot Static System Installation............................................................................................................
H20

SECTION VII
POWER PLANT GROUP

43 Power Plant Installation ...................................................................................................................... 111

44 Engine Exhaust System Installation.................................................................................................... 115
45 Engine Baffle Installation..................................................................................................................... 118
46 Oil Cooler Installation.......................................................................................................................... I l l
47 Engine Cowl Installation...................................................................................................................... 1114
48 Engine Controls Installation ................................................................................................................ 1117

SECTION Vlll
FUEL SYSTEM GROUP

49 Forward Fuel System Installation........................................................................................................ 1121

50 Aft Fuel System Installation (sln 28-7415001 t h 28-7515459) ~ ........................................................ 1J1
51 Aft Fuel System Installation (sln 28-7615001 and up. and 28-7716001 and up) ................................ 1J4
52 Fuel Tank Assembly ............................................................................................................................ lJ7

SECTION IX
CONTROL SYSTEM GROUP

53 Control System Installation................................................................................................................. 1J l l

54 Flap Control Installation ...................................................................................................................... lJ15
55 Stabilator Trim Installation................................................................................................................... lJl9
56 Rudder Trim Mechanism Installation................................................................................................... J23
57 Control Wheel Installation ................................................................................................................... lK2
58 Rudder Pedal Installation.................................................................................................................. lK6

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

TABLE OF CONTENTS
FIGURE NUMBER FIGURE TITLE GRID NUMBER

SECTION X
ENVIRONMENTAL GROUP

Cabin Heat and Defroster Installation................................................................................................. 1Kg

Cabin Overhead Air Vent Installation.................................................................................................. K 1 3
Air Conditioning Compressor. Refrigerant tines and Alternator Installation(28-7816001 and up) ....1K17
Air Conditioning Duct and Evaporator Installation (sln 28-7816001 and up) ......................................1K21
Air Conditioning Condenser Installation (dn 28-7816001 and up) ..................................................... K 2 4

SECnON XI
ELECTRICAL SYSTEM GROUP

Electrical System Installation.............................................................................................................. 2A15

Instrument Panel Electrical Installation(sln 28-7415001 and up. 28-7716001 thru 2816109) ...........2A20
Instrument Panel Electrical Installation (sln 2816110 and up) ............................................................ 2A24
Air Conditioning Electrical Installation (dn 28-7816001 and up) ........................................................264
Battery Box Installation .......................................................................................................................2B7
Extemal Power Supply Installation (sln 28-7415001 and up, 28-7716001 thru 28-8216236) ............2B12
External Power Supply Installation (s/n 28-8316001 thru 2816109) ................................................... 2515
Auxiliary Power Receptacle Installation ( d n 2816110 and up) ........................................................... 2818
Alternator Assembly (Prestolite) .........................................................................................................2521
Alternator Installation(Chrysler) .........................................................................................................2824
Strobe tight Installation......................................................................................................................2C4

SECTION Xll
ELECTRONICS GROUP

Electric Trim Installation......................................................................................................................2C11

AutoFlite I1 Installation.........................................................................................................................2C14
Autocontrol Ill and lllB Installation (sln 28-7415001 and up. 28-7716001 thru 28-8216236) ............2C17
Century 21 Autopilot Installation (sln 28-8116019 and up) .................................................................2 C m
King KAP 1001150 Autopilot Installation (sln 28-8316001 and up) .....................................................2C23
Piper Automatic Locator (ELT) Installation (Garret Mfg. Ltd.) ............................................................. 2D2
Piper Automatic Locator-(ELT) Installation (Communications Components Corp.) ............................2D5
Piper Automatic Locator (ELT 10) Installation (Narco Avionics) ......................................................... 2D8
Piper Automatic Locator (ELT 910) Installation (Narco Avionics) ....................................................... 2D11
Radar Altimeter Installation................................................................................................................. 2D14
Encoder Installation (Narco .AR 500 and United .5125-P3) ............................................................. 2D17
Piper PM-1 Marker Beacon Installation (sln 28-7415001 thru 28-7415713)....................................... 2D20
Radio. Antenna System and Static Wicks Installation ........................................................................ 2D23
Audio Selector Assembly .................................................................................................................... 2E3
Avionics Cooling Installation............................................................................................................... 2E6
Avionics Installation Drawings............................................................................................................. 2E9

SECTION XI11
MISCELLANEOUS GROUP

Placards and Exterior Stencils ............................................................................................................ 2E13

Optional Equipment Kits and Repair Kits ............................................................................................ 2E19
Miscellaneous Hardware and Consumables....................................................................................... 2 E Z

NUMERICAL INDEX

All Part Numbers................................................................................................................................. 2Fl

Revised: July 30. 1994

1All
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

MISCELLANEOUS
Xlll

ELECTRONICS
XI1

CONTROLS
IX

INSTRUMENTS
VI

ELECTRICAL
\
WING
FUEL SYSTEM
Vlll
\
CABIN EQUIPMENT
LANDING GEAR
IV

XI I v

Figure 1. Complete Airplane

Revised: July 30, 1994

1A13
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Revised: Juiy 30.1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 2.Wing Installation

Reissued: December 1, 1989

1A15
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 2

See Figure 3 for component parts.

See Figure 4 for component parts.
See Figure 52 for component parts.
See Figure 5 for component parts.
See Figure 7 for component parts.
Used if navigation or strobe lights are installed.
Used if navigation or strobe lights are not installed.
See Figure 6 for component parts.

Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7715254 and up, and PA-28-161.
This assembly includes brake lines, fuel lines, pitot static lines (in left wing only) and inspection cover plates.
Complete kit required if replacing safety walk compound painted on wing.

Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8116240.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with seriabnumbers 28-7716001 thru 28-8116010.
Used i f recognition lights are installed.
Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8016075.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Wing Installation 28-7415001 thru 28-7515459

K DRAWING - Wing Installation
DRAWING - Wing Assembly (Complete) 28-7415001 thw 28-7515459

WlNG ASSEMBLY - Left

WlNG ASSEMBLY Left -
WlNG ASSEMBLY Left -
WlNG ASSEMBLY - Right
WlNG ASSEMBLY Right -
WlNG ASSEMBLY Right -
-
' LEADING EDGE ASSEMBLY Wing inboard, left
-
LEADING EDGE ASSEMBLY Wing inboard, left
-
' LEADING EDGE ASSEMBLY Wing inboard, left
LEADING EDGE ASSEMBLY - Wing inboard, right
-
LEADING EDGE ASSEMBLY Wing inboard, right
-
' LEADING EDGE ASSEMBLY Wing inboard, right
LEADING EDGE ASSEMBLY - Wing outboard, left
LEADING EDGE ASSEMBLY - Wing outboard, left
LEADING EDGE ASSEMBLY - Wing outboard, right
* LEADING EDGE ASSEMBLY - Wing outboard, right
-
TRAILING EDGE ASSEMBLY Wing aft section, left
TRAILING EDGE ASSEMBLY -Wing aft section, left
' TRAILING EDGE ASSEMBLY - Wing aft section, left
' TRAILING EDGE ASSEMBLY -Wing aft section, right
' TRAILING EDGE ASSEMBLY -Wing aft section, right
-
* TRAILING EDGE ASSEMBLY Wing aft section, right
RING -Tie down
' PAD -Jack
CHANNEL -Wing skin stiffener
SCREW - (MS24694-S56)
-
STRAP Spar splice, top and bottom (11.50 L.)
' STRAP - Spar splice, top and bottom (24.50 L.)
TANK ASSEMBLY - Fuel, left
TANK ASSEMBLY - Fuel, right
TANK ASSEMBLY - Fuel, left
-
TANK ASSEMBLY Fuel, right
AILERON ASSEMBLY Left -
AILERON ASSEMBLY Right -
AILERON ASSEMBLY - Left
AILERON ASSEMBLY - Right
FLAP ASSEMBLY Left -
FLAP ASSEMBLY - Right
-
TIP ASSEMBLY Wing, left
TIP ASSEMBLY - Wing, left
-
TIP ASSEMBLY Wing, left
-
TIP ASSEMBLY Wing, left
TIP ASSEMBLY - Wing, left 28-8 11624 1 and up
-
TIP ASSEMBLY Wing, left 28-8116241 and up
TIP ASSEMBLY -Wing, left 28-8516001 and up
TIP ASSEMBLY -Wing, left 2816110 and up
TIP ASSEMBLY -Wing, right 28-7415001 t h 28-751
~ 5459
-
TIP ASSEMBLY Wing, right 28-7415001 t h 28-751
~ 5459
TIP ASSEMBLY -Wing, right
TIP ASSEMBLY -Wing, right
TIP ASSEMBLY - Wing, right 28-8 116241 and up
TIP ASSEMBLY - Wing, right 28-8116241 and up
-
TIP ASSEMBLY Wing, right 28-8516001 and up
TIP ASSEMBLY -Wing, right 2816110 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1A17
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Flgure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

2-14a STIFFENER -Wing tip, upper, left 1

STIFFENER -Wing tip, upper, left 1
STIFFENER -Wing tip, upper, right 1
STIFFENER -Wing tip, upper, right 1
' STIFFENER - Wing tip, lower, left 1
STIFFENER -Wing tip, lower, left 1
^ STIFFENER -Wing tip, lower, right 1
' STIFFENER -Wing tip, lower, right 1
LENS -Wing tip, left 1 28-8516001 and up
LENS -Wing tip, right 1 28-8516001 and up
-
SHIELD Recognition light, wing tip, left 1 28-8516001 and up
-
' SHIELD Recognition light, wing tip, right 1 28-8516001 and up
KIT - Pressure sensitive wing walk installation 1
-
' WING WALK Safety, wing 1
' WING WALK - Safety, flap 1
RETAINER -Wing walk 1
-
SAFETY WALK COMPOUND Black (one quairt can) AR
MOULDING -Wing root 2
PLATE ASSEMBLY - Aft wing access, left 1
PLATE ASSEMBLY - Aftwing access, right 1
BUSHING - Flap hinge, center and outboard 8
BUSHING - Flap hinge, inboard 4
BUSHING - Aileron hinge, center 2
CHANNEL - Gang 6
-
CHANNEL Gang (PS10062-2-7) 6
-
CHANNEL Gang (PS10062-2-2) 4
BOLT - (AN3-7A) 4
-
WASHER (AN960-10) 12
-
NUT (MS20365-1032C) 4
BOLT - (AN3-11A) 4
WASHER - (AN960-10) 4
NUT - (MS20365-1032C) 4
-
BOLT (AN3-13A) 2
-
WASHER (AN960-10) 10
-
NUT (MS20365-1032C) 2
BOLT - (AN3-13A) 2
-
WASHER (AN960-10) 2
-
NUT (MS20365-1032C) 2
BOLT - (AN4-14A) 2
BOLT - (NAS1104-17) 2
WASHER - (AN960-416) AR
-
WASHER (AN960-416L) AR
-
NUT (MS20365-428C) 2
-
NUT (MS2 1045-4) 2
-
NUT (MS2 1042-4) 2 28-8016076 and up
-
BOLT (AN5-6A) 2
-
BOLT (NAS464P6LA6) 2 28-8116011 and up
WASHER - (AN960-516) AR
WASHER - (AN960-616L) (under head) 2 28-8116011 and up
-
WASHER (AN960-616) AR 28-8116011 and up
-
WASHER (AN960-616L) AR 28-8116011 and up
-
NUT (MS20365-524C) 2
-
NUT (MS21042-6) 2 28-8116011 and up
BOLT- (AN176-12A) 6
-
WASHER (AN960416) 12
WASHER 6
NUT - (MS21042-6) 6

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1A18
 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
BOLT (AN176-13A)
WASH ER (AN960-616) -
WASHER
NUT - (MS20365-624C)
-
NUT (MS21042-6)
-
BOLT (AN176-13A)
WASHER - (AN960-616)
NUT - (MS21042-6)
-
BOLT (AN176-13A)
WASHER
-
NUT (MS21042-6)
-
BOLT (AN176-14A)
WASHER (AN960-616)-
-
NUT (MS21042-6)
SCREW - (MS35206-245)
WASHER (AN960-8L) -
K NUT - (PSI 0062-5-3)
-
SCREW (MS27039-0809)
SCREW --(MS27039-0812)
SCREW - (MS35206-243)
SCREW - (8 x 112 L ) Type B
NUT - (A1789-82-3)
SCREW - (8 x 112 L ) Type B
NUT - (NAS395-18-3)
K SCREW - (MS27039-1-10)
K WASHER - (AN960-10)
K NUT - (MS20365-1032C)
CHANNEL ASSEMBLY - Gang, bottom, forward
CHANNEL ASSEMBLY - Gang, bottom, rear
PLACARD - Flap warning
COVER - Leading edge
K -
COVER Leading edge
-
COVER Inspection
COVER -Wing bolt, left
COVER -Wing bolt, right
-
BUTTON Plug (HS48172X2215)
SCREW - (MS27039-0812)
-
SCREW (MS27039-0809)
PLACARD No step -
SHIM -Wing attachment
-
BUTTON ASSEMBLY Plug, gear service access
(with retaining ring) 2
STALL STRIP 2 28-8016363 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1A19
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 3. Wing Leading Edge Assembly

Reissued: December 1, 1989

1A20
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 3

A - Used on PA-28-151 with serial numbers 28-7415531,27-7415535,27-7415536,28-7415539 thru 28-7515459. Also used on
PA-28-151 with serial numbers 28-7415001 to 28-7415530,28-7415332 to 28-7415534,28-7415537 and 28-7415538 if Wing
Reinforcement Modification Kit 760 878 has been installed per Service Bulletin 424.
B -
C - Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161.
D - Used if the forward spar fitting assembly incorporates an aluminum attaching plate.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature R4. Affected
Number

LEADING EDGE ASSEMBLY -Wing inboard; left

LEADING EDGE ASSEMBLY -Wing inboard, left
LEADING EDGE ASSEMBLY Wing inboard, left-
LEADING EDGE ASSEMBLY -Wing inboard, right
LEADING EDGE ASSEMBLY -Wing inboard, right
LEADING EDGE ASSEMBLY -Wing inboard,right
RIB ASSEMBLY -Wing nose, Sta. 49.25, left
-
" RIB ASSEMBLY Wing nose, Sta. 49.25, left
RIB ASSEMBLY -Wing nose. Sta. 49.25. left
RIB ASSEMBLY -Wing nose, Sta. 49 25, right
RIB ASSEMBLY -Wing nose, Sta. 49 25, right
" RIB ASSEMBLY -Wing nose, Sta. 49 25, right
-
' RIB Wing walk, right
RIB - Wing nose, Sta. 57.00, left
RIB - Wing nose, Sta. 57 00, left
RIB - Wing nose, Sta. 57.00, left
' RIB -Wing nose, Sta. 57.00, right
RIB - Wing nose, Sta. 57.00, right
-
RIB Wing nose, Sta. 57.00, right
RIB - Wing nose, root, left
-
^ RIB Wing nose, root, right
STRAP - Fuel tank attachment
* STRAP - Fuel tank attachment
* SKIN ASSEMBLY - lnboard wing, left
-
SKIN ASSEMBLY lnboard wing, right
SKlN ASSEMBLY - lnboard wing
' ' DOUBLER ASSEMBLY - Leading edge wing
' DOUBLER ASSEMBLY - Leading edge wing
SKIN ASSEMBLY - Leading edge. left
SKIN ASSEMBLY - Leading edge, right
' DOUBLER - Air inlet
-
* SKlN ASSEMBLY Bottom inboard root, left
SKlN ASSEMBLY - Bottom inboard root, left
-
SKlN ASSEMBLY Bottom inboard root, left
SKlN ASSEMBLY - Bottom inboard root, right
SKlN ASSEMBLY - Bottom inboard root, right
-
SKlN ASSEMBLY Bottom inboard root, right
-
'STIFFENER Bottom inboard skin, left, forward
STIFFENER - Bottom inboard skin, left, rear
STIFFENER - Bottom inboard skin, right, rear
STIFFENER - Bottom inboard skin, right, forward
' WING WALK - Forward, right
SPAR - Leading edge, inboard, left
-
SPAR Leading edge, inboard, right
* FITTING ASSEMBLY - Forward spar, left
FITTING ASSEMBLY - Forward spar, right
-
* BUSHING Forward spar attachment
-
'SKIN ASSEMBLY Top, inboard root, left
' DOUBLER - Forward spar
TUBE ASSEMBLY - Fresh air vent
-
LEADING EDGE ASSEMBLY Wing outboard, left
-
LEADING EDGE ASSEMBLY Wing outboard, left
-
LEADING EDGE ASSEMBLY Wing outboard, right
LEADING EDGE ASSEMBLY - Wing outboard, right
STRAP - Fuel tank attachment, Sta. 88.75
-
* GASKET Air duct
'SKIN - Middle section, left
SKlN - Middle section, right

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Nombers
Index Number Code Nomenclature Req. Affected
Number
SKIN - Aft, top, left 1
' SKIN - Aft, top, left 1
' SKIN - Aft, top, right 1 28-7415001 t h 28-751
~ 5459
-
SKIN Aft, top, right 1
SKIN -Aft, bottom, left 1 28-7415001 t h 28-751
~ 5459
' SKIN ASSEMBLY - Aft, bottom, left 1
-
SKIN ASSEMBLY Aft, bottom, right 1 28-7415001 t h 28-751
~ 5459
-
'SKIN Aft, bottom, right 1
-
' ' DOUBLER Cover plate attachment 2
-
SKIN Forward, left 1
' SKIN - Forward, right 1
' RIB - W~ngnose, Sta. 88.75, left 1
RIB - Wing nose, Sta. 88.75, right 1
* RIB - Wing nose, Sta. 140.09, left 1 28-7415001 t h 28-7515459
~
* RIB - Wing nose, Sta. 131.60, left 1
-
RIB Wing nose, Sta. 140.09, right 1 28-7415001 thru 28-7515459
RIB - Wing nose, Sta. 131.60, right 1
RIB - Wing nose, Sta. 174.00, left 1
* RIB - Wing nose, Sta. 174.00, right 1
* RIB ASSEMBLY -Wing nose, Sta. 106.19, left 1
RIB ASSEMBLY -Wing nose, Sta. 106.19, right 1
SKIN - Forward, left 1 28-7415001 t h 28-751
~ 5459
SKIN - Forward, left 1
' SKIN - Forward, right 1 28-7415001 t h 28-7515459
~
SKIN - Forward, right 1
' RIB - Wing nose, upper, left, Sta. 117.50 1
* RIB - Wing nose, upper, right, Sia. 117.50 1
-
* RIB Wing nose, lower, left, Sta. 117.50 1
RIB -Wing nose. lower, right. Sta. 117.50 1
-
' CHANNEL Leading edge rib 1
-
' CHANNEL Leading edge rib 1
CHANNEL - Leading edge rib 1
RIB - Wing nose, Sta. 148.60, left 1
' RIB - Wing nose, Sta. 148.60, right 1
-
RIB Wing nose, Sta. 206.70, left 1
* RIB - Wing nose, Sta. 206.70, right 1
-
STRAP Skin attachment, Sta. 206.70, left 1
-
" STRAP Skin attachment, Sta. 206.70, right 1
-
RIB Wing nose, Sta. 117.50, left 1
-
RIB Wing nose, Sta. 117.50, right 1
-
STRINGER Skin. leading edge 1
-
STRINGER Skin, leading edge 1
SPACER -Wing 2 28-8216165 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

1A23
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 4. Wing Trailing Edge Assembly

Reissued: December 1, 1989

1 A24
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 4

A -
B - Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161.
C - Used on PA-28-151 with serial numbers 28-7715254 and up, and PA-28-161.
D - Used on PA-28-151with serial numbers 28-7615001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916029.
E - Used on PA-28-151 with serial numbers 28-7715254 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916029.
F -
G - Used on PA-28-151 with serial numbers 28-7715254 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8016271.
H - Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8016271.

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number
-
TRAILING EDGE ASSEMBLY Wing aft section, left
TRAILING EDGE ASSEMBLY - Wlng aft section, left
TRAILING EDGE ASSEMBLY - Wing aft section, left
TRAILING EDGE ASSEMBLY - Wing aft section, right
TRAILING EDGE ASSEMBLY -Wing aft section, right
TRAILING EDGE ASSEMBLY - Wing aft section, right
-
SPAR ASSEMBLY Wing main, left
-
SPAR ASSEMBLY Wing main, left
* SPAR ASSEMBLY - Wing main, right
* SPAR ASSEMBLY - Wing main, right
-
' ' SPAR ASSEMBLY Main inboard, left
' SPAR ASSEMBLY - Main inboard, left
' SPAR ASSEMBLY - Main inboard, right
-
'* SPAR ASSEMBLY Main inboard, right
" DOUBLER ASSEMBLY - Forward, left

-
' ' DOUBLER ASSEMBLY Forward, right
* DOUBLER ASSEMBLY - Aft, left
' DOUBLER ASSEMBLY Aft, right -
' TEE - Landing gear attachment
' SPAR ASSEMBLY - Main, outboard, left
" SPAR ASSEMBLY - Main, outboard, left

' SPAR ASSEMBLY - Main, outboard, right

' SPAR ASSEMBLY - Main, outboard, right
' SPAR ASSEMBLY -Wing aft, inboard, left
SPAR ASSEMBLY - Wing aft, inboard, left
-
' SPAR ASSEMBLY Wing aft, inboard, right
' SPAR ASSEMBLY - Wing aft, inboard, right
-
' PLATE Aft spar
-
SPAR ASSEMBLY Wing aft, outboard, left
SPAR ASSEMBLY - Wing aft, outboard, left
-
SPAR ASSEMBLY Wing aft, outboard. right
-
* SPAR ASSEMBLY Wing aft, outboard, right
-
' ' DOUBLER Aft spar, rear, left
-
' ' DOUBLER Aft spar, rear, right
" CAP - Rear spar, upper, left, Sta. 106.19
' CAP - Rear spar, upper, right, Sta. 106.19
' ' CAP - Rear spar, lower, left, Sta. 106.19
* CAP - Rear spar, lower, right, Sta. 106.19
-
* DOUBLER Aft spar, rear
' DOUBLER -Aft spar, rear
' SKIN ASSEMBLY -Top, inboard, left
' SKIN ASSEMBLY -Top, inboard, left
' SKIN ASSEMBLY -Top, inboard, right
' SKIN ASSEMBLY -Top, inboard, right
-
SKlN ASSEMBLY Bottom, inboard, left
-
SKlN ASSEMBLY Bottom, inboard, left
-
' SKIN ASSEMBLY Bottom, inboard, right
-
' SKIN ASSEMBLY Bottom, inboard, right
' ' DOUBLER -Wing skin, Sta. 42.72
* ' DOUBLER ASSEMBLY - Main gear strut fairing
attachment
-
' ' DOUBLER Fairing plate, left
-
* ' DOUBLER Fairing plate, right
' SKIN - Top, outboard, left
' SKIN ASSEMBLY -Top, outboard, left
' SKIN - Top, outboard, right
SKIN ASSEMBLY -Top, outboard, right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

1B2
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

' SKIN ASSEMBLY - Bottom, outboard, left

' SKIN ASSEMBLY - Bottom, outboard, left
' SKIN ASSEMBLY - Bottom, outboard, left
' SKIN ASSEMBLY - Bottom, outboard, right
' SKIN ASSEMBLY - Bottom, outboard, right
* SKIN ASSEMBLY - Bottom, outboard, right
-
' DOUBLER ASSEMBLY Pitot head, left
SKIN ASSEMBLY -Wing walk, right
' RIB - Sta. 106.19, left
-
' RIB Sta. 106.19, left
'RIB - Sta. 106.19, right
-
RIB Sta. 106.19, right
-
' RIB Sta. 207.65, left
' RIB - Sta. 207.65, left
' RIB - Sta. 207.65, right
' RIB - Sta. 207.65, right
' RIB - Sta. 123.15, left
RIB - Sta. 123.15, left
-
RIB Sta. 123.15, right
RIB - Sta. 123.15, right
* RIB - Sta. 140.09, left
RIB - Sta. 140 09, left
* RIB - Sta. 140.09, right
' RIB - Sta. 140.09, right
-
^ RIB ASSEMBLY Sta. 157.00, left
-
RIB ASSEMBLY Sta. 157.00, left
-
RIB ASSEMBLY Sta. 157.00, left
RIB ASSEMBLY - Sta. 157.00, right
-
RIB ASSEMBLY Sta. 157.00, right
RIB ASSEMBLY - Sta. 157.00, right
-
RIB Sta. 174.00, left
-
' RIB Sta. 174.00. left
-
' RIB Sta. 174.00, right
-
RIB Sta. 174.00, right
' RIB - Sta. 190.00, left
-
' RIB Sta. 190.00, left
' RIB - Sta. 190.00, right
-
RIB Sta. 190.00, right
-
' RIB Sta. 106.19, aft, left
-
RIB Sta. 106.19, aft, right
* RIB - Sta. 101.39, aft, left
RIB - Sta. 101.39, aft, right
-
RIB ASSEMBLY Sta. 49.25, left
-
RIB ASSEMBLY Sta. 49.25, right
' RIB - Sta. 36.22, left
-
RIB Sta. 36.22, right
-
* RIB Sta. 86.03, left
' RIB - Sta. 86.03. right
-
* RIB Sta. 64.59, left
^ RIB - Sta. 64.59, right
' RIB - Sta. 24.24, left
' RIB - Sta. 24.24, right
' STIFFENER -Outboard, left
-
' STIFFENER Outboard, right
STIFFENER - Inboard, left
' STIFFENER - Inboard, right
SUPPORT ASSEMBLY - Flap, inboard, left
* SUPPORT ASSEMBLY - Flap, inboard, right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1B3
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
4 BEARING (KPBA)
-
* SUPPORT ASSEMBLY Flap, center
BEARING - (KP3A)
SUPPORT ASSEMBLY - Flap, outboard
B -
* SUPPORT ASSEMBLY flap, outboard
-
BEARING (KP3A)
-
* SUPPORT Aileron, Sta. 123.15, left
-
SUPPORT Aileron, Sta. 123.15, right
SUPPORT - Aileron, Sta. 157.00, left
' SUPPORT - Aileron, Sta. 157.00, right
-
BEARING (MS20201-KP3A)
-
' SUPPORT Aileron, Sta. 206.70
-
* SUPPORT Aileron, Sta. 206.70
B * DOUBLER - Aft spar, rear, left
B DOUBLER - Aft spar, rear, right
B * HINGE ASSEMBLY - Aileron
B ' HINGE ASSEMBLY - Atleron
E -
* CHANNEL ASSEMBLY Bellcrank support, upper, left
E -
CHANNEL ASSEMBLY Bellcrank support, upper, right
' SKIN - Top, outboard, left 28-7916030 and up
' SKIN - Top, outboard, right 28-7916030 and up
* * STRINGER - Support 28-7916030 and up
' SKIN -Top, center, left 28-7916030 and up
-
SKIN Top, center, right 28-7916030 and up
CHANNEL ASSEMBLY - Bellcrank support, left 28-7916030 and up
" CHANNEL ASSEMBLY - Bellcrank support, right 28-7916030 and up
' SKIN ASSEMBLY - Bottom, center, left 28-8016272 and up
-
' SKIN ASSEMBLY Bottom, center, right 28-8016272 and up
' DOUBLER ASSEMBLY - Pitot head, left 28-8016272 and up
-
* SKIN Bottom, outboard, left 28-8016272 and up
* SKIN - Bottom, outboard, right 28-8016272 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1B4
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 5. Aileron Assembly

(28-7415001 t h 28-751
~ 5459)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 5

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

AILERON ASSEMBLY Left -

AILERON ASSEMBLY Right -
' SPAR - Aileron, inboard, left
' SPAR - Aileron, inboard, right
SPAR - Aileron, outboard, left
' SPAR -Aileron, outboard, right
-
RIB Aileron, Sta. 107.10, left
-
RIB Aileron, Sta. 107.10, left
' RIB - Aileron nose, Sta. 130.50, left
RIB - Aileron nose, Sta. 130.50, right
* RIB - Aileron nose, Sta. 182.97, left
' RIB - Aileron nose, Sta. 182.97, right
-
RIB Aileron nose, Sta. 206.95, left
-
RIB Aileron nose, Sta. 206.95, right
-
' RIB Aileron nose, Sta. 154.43, left
RIB - Aileron nose, Sta. 154.43, right
RIB - Aileron nose, Sta. 157.50, left
RIB - Aileron nose, Sta. 157.50, right
' RIB - Aileron, Sta. 123.24, left
-
* RIB Aileron, Sta. 123.24, right
* RIB - Aileron, Sta. 133.58, left
' RIB - Aileron, Sta. 133.58, right
' RIB - Aileron, Sta. 144.00, left
' RIB - Aileron, Sta. 144.00, right
' RIB - Aileron, Sta. 169.62, left
RIB - Aileron, Sta. 169.62, right
RIB - Aileron, Sta. 182.97, left
' RIB - Aileron, Sta. 182.97, right
' RIB - Aileron, Sta. 194.97, left
' RIB - Aileron, Sta. 194.97, right
-
RIB Aileron, Sta. 206 95, left
RIB - Aileron, Sta. 206 95, dght
-
RIB Aileron, Sta. 156 56, left
RIB - Aileron, Sta. 156 56, right
-
' SKIN Aileron, inboard, left
' SKIN -Aileron, inboard, right
-
SKIN Aileron, outboard, left
-
SKIN Aileron, outboard, right
-
* SKIN Aileron nose, inboard, left
-
SKIN Aileron nose, inboard, right
-
SKIN Aileron nose, outboard, left
-
' SKIN Aileron nose, outboard, right
-
' DOUBLER Aileron, left
' DOUBLER -Aileron, right
' DOUBLER -Aileron, left
-
' DOUBLER Aileron, right
HINGE ASSEMBLY - Aileron, left
HINGE ASSEMBLY -Aileron, right
BEARING - (PS10020-7-3)
-
' FITTING Aileron actuator, left
-
' FITTING Aileron actuator, right
-
FITTING Aileron center hinge, left
-
FllTlNG Aileron center hinge, right
-
WEIGHT Aileron balance
' RETAINER -Aileron balance weight
' BOLT - (AN3-5A)
-
WASHER (AN960-10L)
* NUT - (MS20365-1032C)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1B7
 PIPER AIRCRAFT
PA-28-151M 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

SCREW - (MS24694451)
* WASHER - (AN960-10L)
-
NUT (MS20365-1032C)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1B8
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figurw 6. Aileron Assembly

(28-7615001 thm 28-7716001 and up)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-2&151/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 6

A - Used on PA-28-151 with seral numbers 28-7615001 and up, and PA-28-161.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

AILERON ASSEMBLY - Left

AILERON ASSEMBLY Right -
SKlN - Aileron, left inboard
SKlN - Aileron, right inboard
SKlN - Aileron, left outboard
-
* SKlN Aileron, right outboard
-
' SPAR Aileron, left
' SPAR -Aileron, right
* RIB - Aileron, left inboard
* RIB - Aileron, right inboard
RIB - Aileron, left center
* RIB - Aileron, right center
^ RIB - Aileron, left outboard
-
RIB Aileron, right outboard
-
DOUBLER Aileron, left inboard
-
DOUBLER Aileron, right inboard
DOUBLER - Aileron, left outboard
DOUBLER - Aileron, right outboard
^ DOUBLER - Aileron, left center
DOUBLER -Aileron, right center
' FILLER - Aileron
' FILLER -Aileron
' FITTING - Aileron
SCREW - (MS24694-S53)
-
' WASHER (AN960-10)
NUT - (MS20365-1032C)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1B11
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 7. Flap Assembly

Reissued: December 1, 1989

1B12
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 7

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

FLAP ASSEMBLY Left -

FLAP ASSEMBLY - Right
' SKIN - Flap, bottom, left, inboard
-
' SKIN Flap, bottom, right, inboard
SKIN - Flap, bottom, left and right, outboard
-
SKIN Flap, top, left and right, outboard
-
HINGE Flap, inboard, left
-
HINGE Flap, inboard, right
-
BRACKET Flap hinge center and outboard
-
' SPAR Flap
-
RIB Left flap
RIB - Right flap
-
RIB Left flap
RIB - Right flap
-
' RIB Flap, left, wing, Sta. 49.00
-
' RIB Flap, right, wing, Sta. 49.00
-
' RIB Flap, left
-
' RIB Flap, right
RIB - Flap, left, inboard
' RIB - Flap, right, inboard
STRIP - Flap rear edge
-
' SKIN Flap, left, nose
-
'SKIN Flap, right, nose
-
' SKIN Flap, top, left, inboard
'SKIN - Flap, top, right, inboard
' CORRUGATION - Flap, top, right, inboard
DOUBLER ASSEMBLY - Left
DOUBLER ASSEMBLY Right -
' ZEE - Flap inboard, right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1814
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 8. Fuselage Assembly Complete

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 8

See Figure 13 for component parts.

See Figure 11 for balance of component parts.
See Figure 12 for balance of component parts.
See Figure 9 for balance of component parts.
See Figure 10 for balance of component parts.
Used if cabin overhead fresh air ventilation system is installed.
Used on PA-28-151 with serial numbers 28-7415001 to 28-7415386,28-7415388 thru 28-7415713.
Used on PA-28-151with serial numbers 28-7415387,28-7515001 thru 28-7615001.
Used on PA-28-151 with serial numbers 28-7415387,28-7515001 and up.
Used on PA-28-151 with serial numbers 28-7415387.28-7515001 thru 28-7615001.

Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7515414 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.

When ordering for 1978 and 1979 models, specify with or without provisions for air conditioning. When ordering for 1980 models and
up, specify if air conditioning or fresh air ventilation system is installed.
Used on PA-28-161 if air conditioning is installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affeeted
Number

76254 -
DRAWING Fuselage Assembly
76469 M -
DRAWING Fuselage Assembly

FUSELAGE ASSEMBLY
FUSELAGE ASSEMBLY
FUSELAGE ASSEMBLY
FUSELAGE ASSEMBLY 28-7816001 t h 2816109
~
FUSELAGE ASSEMBLY 2816110 and up
' AFT SECTION - Fuselage 28-7415001 t h 28-761
~ 5001
AFT SECTION Fuselage -
' AFT SECTION - Fuselage
AFT SECTION Fuselage -
-
' SKIN Cockpit, top, rear
' SKIN - Cockpit, top, rear
-
' SKIN Cockpit, left, rear
-
'SKIN Cockpit, left, rear
SKIN - Cockpit, left side
-
SKlN Cockpit, left side
-
STUD Fastener (XX16362 x 318 L)
COCKPIT ASSEMBLY Fuselage -
COCKPIT ASSEMBLY Fuselage -
' COCKPIT ASSEMBLY - Fuselage
-
* * SKlN Cockpit, left side
SKlN - Cockpit, left side
-
' ' SKlN Cockpit, right side
' SKlN -Cockpit, right side
* ' LOWER COCKPIT ASSEMBLY Fuselage -
LOWER COCKPIT ASSEMBLY Fuselage -
'' COVER PLATE Doubler assembly -
-
' SKlN Cockpit, center rear, bottorn
-
* ' SKlN Cockpit, center rear, bottom
-
'' ' SKlN Cockpit. center front, bottorn
' SKIN - Cockpit, center front, bottom
* -
SKIN Cockpit, front, bottom
'' ' SKIN - Cockpit, front, bottom
' " DOUBLER - Cockpit, left
' '' DOUBLER - Cockpit, right
'' 'DOUBLER Lower cockpit -
' ' DOUBLER - Lower cockpit air scoop (with 4 hole)
-
' '' DOUBLER Lower cockpit air scoop (less 4 hole) 28-7816001 and up
' ' ' DOUBLER ASSEMBLY Lower cockpit -
' ' DOUBLER ASSEMBLY Lower cockpit, left -
* ' ' DOUBLER ASSEMBLY Lower cockpit, right -
'' 'SCOOP - Cabin air exhaust
-
'SCOOP Cabin air exhaust
' ' LOWER COCKPIT ASSEMBLY Aft -
* * LOWER COCKPIT ASSEMBLY Aft
* * . * SKlN ASSEMBLY - Bottom center
-
* * . * SKIN ASSEMBLY Bottom center -
...
*.at*
-
SKlN Bottom center
-
SKIN Rear left, bottom
t*..
-
SKIN Rear left, bottom
*.a*
-
SKlN Rear right, bottom
-
*.*' SKIN Rear right, bottom
' ' ' GASKET Cover plate -

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

8-24 76299-05 G ' UPPER COCKPIT ASSEMBLY - Fuselage 1

76299-12 H ' ' UPPER COCKPIT ASSEMBLY - Fuselage 1
79803-684 M ' ' UPPER COCKPIT ASSEMBLY - Fuselage 1
-25 79573-02 '' ' SKIN - Upper cockpit, top, center 1 28-7415001 thru 28-7615001
79573-901 M * ' SKIN - Upper cockpit, top, center 1
-26 76255-00 SKIN - Windshield, left side, trim 1
62420-11 ' ' ' SKIN -Windshield, right side, trim 1 28-7415001 thru 28-7615001
79561-03 M -
' ' ' SKIN Windshield, right side, trim 1
-27 76297-00 ' SKIN ASSEMBLY - Upper cockpit, left side,
rear window 1
76297-01 -
' ' ' SKIN ASSEMBLY Upper cockpit, right side,
rear window 1
-28 62507-00 -
' FILLER Forward upper cockpit, top 1
-29 68817-50 -
' ' DOUBLER Forward upper cockpit, top 1
-30 76299-06 D,G ' ' UPPER COCKPIT ASSEMBLY Forward - 1
76299-11 D,H ' ' UPPER COCKPIT ASSEMBLY - Forward 1
79803-338 D,M " ' UPPER COCKPIT ASSEMBLY - Forward 1
t*..
-3 1 78112-03 G COVER -Cowl deck 1
7811245 J .*a*
COVER Cowl deck - 1
-32 99390-07 G -
* * ' SKIN Forward upper cockpit, top 1
79569-00 K ^ SKIN - Forward upper cockpit, top 1
79569-901 M * ' ' SKIN - Forward upper cockpit, top 1
-33 76130-15 E ' UPPER COCKPIT ASSEMBLY Center - 1 28-7415001 thru 28-7615001
79803-138 E,M * ' * UPPER COCKPIT ASSEMBLY Center - 1
-34 76256-00
.
.
.t
-
* * * . SKIN Window trim, left side, center
1
76257-00 SKIN -Window trim, right side, center 1
-35 76130-08
79576-901 M *...
.tt.
SKIN - Upper cockpit, top, front
-
SKIN Upper cockpit, top, front
1
1
28-7415001 thw 28-7615001

-36 65611-07 - ' ' ' SKIN - Cockpit, left front

. * * . SKIN - Cockpit, left front
1 28-7415001 thw 28-7615001
79563-905 M 1
65611-06 *.*. SKIN - Cockpit, right front 1 28-7415001 thm 28-7615001
79563-901 M tt..
SKIN - Cockpit, right front 1
-37 761 077 -
' * KIT Cabin assist handle replacement 1 28 7415001 thw 28-7515413
481 772 N * * HANDLE (11286) - 1
-38 65384-00 STEP ASSEMBLY Fuselage - 1
-39 65431-00 ' STRIP - Safety 1
-40 79427-02 -
COVER ADF antenna closeout 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1818
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 9. Fuselage Upper Forward Cockpit Assembly

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 9

Used on PA-28-151 with serial numbers 28-7415001 thru 28-7415386,28-7415388 thru 28-7415713.
Used on PA-28-151 with serial numbers 28-7415387,28-7515001 thru 28-7615001.
Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
Used on PA-28-161 28 volt system.
Used on PA-28-151 with serial numbers 28-7715214 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8016382.
Used on PA-28-151 with serial numbers 28-7515002 and up, and PA-28-161.
Used on PA-,28-151 with serial numbers 28-7415387,28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 thru
28-8116018.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716249.
Used on PA-28-161 with serial numbers 28-7716250 and up.
See Figure 40A for Instrument Panel on serial numbers 2816110 and up.
Used if Century 21 Autopilot is installed.
Used if King KAPl00/150 AutoPilot is installed.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

UPPER COCKPIT ASSEMBLY Forward -

UPPER COCKPIT ASSEMBLY - Forward
UPPER COCKPIT ASSEMBLY - Forward
FRAME ASSEMBLY - Firewall
-
* CHANNEL Upper cockpit assembly, firewall
'' CHANNEL - Upper cockpit, firewall, left
-
' CHANNEL Upper cockpit, firewall, right
' ' BEAM - Upper cockpit, firewall
-
' CHANNEL ASSEMBLY Toe brake reinforcement
PANEL ASSEMBLY lnstrument -
PANEL ASSEMBLY lnstrument -
PANEL ASSEMBLY - lnstrument
' PLATE - Control wheel
* ' PLATE - Control wheel
' ' PLATE - Control wheel
^ ' BUSHING - Control wheel
' O-RING - Control wheel (MS28775-218)
' * CHANNEL - Hand brake
' CONTROL ASSEMBLY - Heat and defroster
-
FITTING Engine mount center, left
-
FITTING Engine mount center, right
FITTING - Engine mount center, left
FITTING - Engine mount center, right
' LONGERON - Upper, left
' LONGERON - Upper, right, front
' LONGERON - Upper, right, front
' CHANNEL - Left
* CHANNEL Right -
-
WEB Fuselage, left side
' WEB ASSEMBLY - Fuselage, right side
* FRAME ASSEMBLY - Upper forward cockpit, left
* ZEE - Upper forward cockpit, left
-
ZEE Upper forward cockpit, right
* FITTING - Upper forward cockpit, Sta. 73.00
FITTING - Upper forward cockpit, Sta. 73.00, left
-
FITTING Upper forward cockpit, Sta. 73.00, right
* PLATE ASSEMBLY -Voltage regulator support, left
* PLATE ASSEMBLY -Voltage regulator support, left
-
* PLATE ASSEMBLY Voltage regulator support, left
PLATE ASSEMBLY - Voltage regulator support, left 28-8116001 thru 2816011
* PLATE ASSEMBLY - Voltage regulator support, left 2816012 and up
' CHANNEL Sta. 73.04 -
-
FLANGE Nose cowl attaching, left
FLANGE - Nose cowl attaching, left
-
FLANGE Nose cowl attaching, right
FLANGE - Nose cowl attaching, right
-
* FLANGE Nose cowl attaching, top
-
FLANGE Nose cowl attaching, top
ANGLE - Stiffener, upper forward cockpit
-
ANGLE Stiffener, upper forward cockpit 2816012 and up
-
ANGLE Stiffener. upper forward cockpit
-
PANEL Instrument, upper left
PANEL - Instrument, upper left
-
FLANGE Nose cowl attaching, bottom, right
-
FLANGE Nose cowl attaching, bottom, left
BUMPER - Tee bar

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

BUSHING - Tee bar bumper

-
BOLT (AN3-13A)
WASHER - (AN960-10)
-
NUT (MS20365-1032C)
CHANNEL ASSEMBLY - Brake support, left
' RATCHET - Brake handle
-
CHANNEL ASSEMBLY Brake support, right
-
CHANNEL Brake support, forward
-
CHANNEL ASSEMBLY Brake support, aft
VENTASSEMBLY - Battery 28-8316001 and up
-
ANGLE ASSEMBLY Battery support, left 28-8316001 and up
-
ANGLE ASSEMBLY Battery support, right 28-8316001 and up
N DOUBLER - Instrument panel, upper left 28-8316001 and up
D SHELF ASSEMBLY - Battery support
-
BRACKET ASSEMBLY Instrument panel, left 2816110 and up
BRACKET ASSEMBLY - lnstrument panel, right 2816110 and up
BRACKET ASSEMBLY - lnstrument panel, left 2816110 and up
BRACKET ASSEMBLY - lnstrument panel, right 2816110andup
SUPPORT ASSEMBLY T-BAR - Instrument panel 2816110 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 10. Fuselage Upper Center Cockpit Assembly

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
- ---

CODE EXPLANATIONS FOR FIGURE 10

A - Used if .250 thick windshield is installed.

0 - Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

UPPER COCKPIT ASSEMBLY - Center

UPPER COCKPIT ASSEMBLY Center -
* PAN ASSEMBLY - Upper center
PAN ASSEMBLY - Upper center
' ' PAN - Outer
-
'' PAN Outer
-
' ' PAN lnner
-
' PAN lnner
CHANNEL - Left front window, top
CHANNEL - Left front window, top
-
FRAME ASSEMBLY Fuselage, SIa. 108.16
FRAME ASSEMBLY - Fuselage, Sta. 108.16
' CHANNEL - Fuselage frame, left
* ' CHANNEL - Fuselage frame, right
-
CHANNEL Splice plate
' PAN ASSEMBLY - Side
' PAN ASSEMBLY - Side
-
' ' PAN lnner
-
' * PAN lnner
' ' PAN - Outer
' ' PAN -Outer
' CHANNEL Support-
CHANNEL - Upper center cockpit, left
-
CHANNEL Upper center cockpit, left
-
CHANNEL Upper center cockpit, right
CHANNEL - Upper center cockpit, right
CHANNEL ASSEMBLY - Upper center fuselage, left
CHANNEL ASSEMBLY - Upper center fuselage, left
CHANNEL ASSEMBLY - Upper center fuselage, right
* CHANNEL ASSEMBLY - Upper center fuselage, right
' DOUBLER -Antenna
FRAME ASSEMBLY - Canted, fuselage, SIa. 85.60
-
FRAME ASSEMBLY Canted, fuselage, Sta. 85.60
' ' CHANNEL ASSEMBLY - Left
' ' CHANNEL ASSEMBLY Left -
' ' CHANNEL ASSEMBLY Right -
' ' CHANNEL ASSEMBLY Right -
PLATE ASSEMBLY - Door latch
CHANNEL - Upper cockpit
-
PLATE Door latch
CHANNEL - Door latch
' CHANNEL - Door latch
-
' PLATE Door latch
LOOP ASSEMBLY Door latch-
' JAMB - Door, forward

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1C1
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

RETAINER -Windshield, left

RETAINER - Windshield, left
RETAINER - Windshield, left, upper
RETAINER - Windshield, left, upper
-
RETAINER Windshield, left, upper
RETAINER - Windshield, left, upper
-
RETAINER Windshield, left, lower
-
RETAINER Windshield, left, lower
RETAINER - Windshield, left, lower
-
RETAINER Windshield, left, lower
RETAINER - Windshield, right
RETAINER - Wtndshield, right
-
RETAINER Windshield, right, upper
RETAINER - Windshield, right, upper
RETAINER - Windshield, right, upper
-
RETAINER Windshield, right, upper
RETAINER - Windshield, right, lower
RETAINER - Windshield, right, lower
RETAINER - Windshield, right, lower
RETAINER - Windshield, right, lower
FRAME ASSEMBLY - Fuselage, Sta. 128.737, upper
CHANNEL - Upper frame, left
CHANNEL - Upper frame, right
* CHANNEL - Splice plate
-
LONGERON Upper center cockpit, left
LONGERON - Upper center cockpit, right
CHANNEL - Upper center cockpit, left
-
CHANNEL Upper center cockpit, right
CHANNEL - Upper center cockpit, left
-
CHANNEL Upper center cockpit, right
HAT ASSEMBLY Windshield -
HAT ASSEMBLY - Windshield
HAT ASSEMBLY Windshield -
BRACKET -Windshield
-
FITTING Upper engine mount
-
PLATE Striker
CHANNEL - Upper center cockpit, left
CHANNEL - Upper center cockpit, right
-
GUSSET Upper center cockpit, left
GUSSET - Upper center cockpit, right
-
PAN ASSEMBLY Lower, upper cockpit
PAN ASSEMBLY - Lower, upper cockpit
-
' PAN lnboard
-
' PAN lnboard
-
* PAN Outboard
' PAN - Outboard
* PAN ASSEMBLY - lnboard and outboard, front
PAN ASSEMBLY - lnboard and outboard, rear
ANGLE ASSEMBLY Door holder -
* CHANNEL - Door frame splice
* CHANNEL - Door frame splice
CHANNEL - Pan upper cockpit
CATCH ASSEMBLY - Cabin door

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1C2
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomencfature Req. Affected
Number

-
CHANNEL ASSEMBLY Right door, front, Sta. 72.60
B CHANNEL ASSEMBLY - Right door, front
-
CHANNEL Upper cockpit, left
CHANNEL - Upper cockpit, right
-
DOUBLER Shoulder harness, left
DOUBLER - Shoulder harness, right
GUSSET - Headliner attachment, left
GUSSET - Headliner attachment, right
CHANNEL - Upper center cockpit, left
CHANNEL - Upper center cockpit, right
-
STRINGER Upper center cockpit, left
STRINGER - Upper center cockpit, right
STIFFENER Left side, rear-
SUPPORT- Left
-
WEB Upper center fuselage, left
CHANNEL - Fuselage rear, left
CHANNEL - Baggage door frame, front
CHANNEL - Baggage door frame, top, inner
CHANNEL - Baggage door frame, top, outer
-
GUSSET Baggage door frame, bottom, rear
CHANNEL - Support, left
CHANNEL - Support, right
HINGE HALF Baggage door -
CHANNEL - Upper cockpit, rear, left
CHANNEL - Upper cockpit, rear, right
DOUBLER - Shoulder harness, rear
-
ANGLE Support, left
ANGLE - Support. right
ANGLE - Support, left
-
GUSSET Baggage door frame, top, rear
-
GUSSET Baggage door frame, top, front
-
GUSSET Baggage door frame, bottom, front
-
ANGLE Window, left
BOLT - (AN23-31A)
WASHER - (AN960-10L)
NUT - (M520365-1032C)
BUSHING
-
BOLT (AN44-17A)
-
WASHER (AN960-516L)
-
NUT (M520364-524C)
BUSHING
BOLT - (AN44-17A)
WASHER - (AN960-51 6L)
NUT - (M520364-524C)
BUSHING
-
PLATE Striker, upper door latch
PLATE - Striker, lower door latch

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1C3
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 11. Fuselage Lower Forward Cockpit Assembly

Revised: July 30, 1994

IC4
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CO.DE EXPLANATIONS FOR FIGURE 11

A - See Figure 12 for component parts.

B - Used PA-28-161 with serial numbers 2816094 and up.
C - Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
D - Used on PA-28-161 if air conditioning is installed.
E - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers28-7716001 thm 28-8216236.

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

11- 82235 DRAWING - Fire Extinguisher Installation

LOWER COCKPIT ASSEMBLY Fuselage - 1 28-7415001 th N 28-7615001

LOWER COCKPIT ASSEMBLY - Fuselage 1
HAT ASSEMBLY lnboard - 2 28-7415001 thN 28-7615001
HAT ASSEMBLY lnboard - 2
" HAT 1
' ' FAIRING Front - 1
' ' FAIRING Front - 1 28-7816001 and up
' ' FAIRING - Aft 1
HAT ASSEMBLY Outboard, left - 1 28-7415001 t h 28-7615001
~
HAT ASSEMBLY Outboard, left - 1
HAT ASSEMBLY Outboard, right - 1 28-7415001 @IN28-7615001
* HAT ASSEMBLY - Outboard, right 1
-
* ' HAT Front, left 1
-
HAT Front, right 1
' HAT - Rear, left 1
-
' HAT Rear, right 1
' FAIRING Front, left - 1
' ^ FAIRING - Front, right 1
' FAIRING Center, left - 1
* ' FAIRING - Center, right 1
" FAIRING Rear - 1
-
HAT ASSEMBLY Battery box support, front 1
-
* HAT ASSEMBLY Battery box support. rear 1
ATTACHMENT - Seat belt 1
FRAME ASSEMBLY - Fuselage. Sta. 73.04 1
FITTING - Engine lower, left 1
-
FITTING Engine lower, right 1
STRINGER - Rear of spar box, left 1
-
STRINGER Rear of spar box, right 1
CHANNEL - Lower cockpit, left 1
-
CHANNEL Lower cockpit, right 1
-
CHANNEL Lower cockpit 2
-
' CHANNEL Sta. 67.68, left 1
-
CHANNEL Sta. 67.68, right 1
LONGERON Lower cockpit, left- 1
-
LONGERON Lower cockpit, right 1
BOX ASSEMBLY - Spar lower cockpit 1
' CHANNEL - Spar box, top 1
-
' CHANNEL Spar box, bottom 1
' CHANNEL -Spar box, left 1
-
CHANNEL Spar box, right 1
* ' CHANNEL Spar box, right- 1
' CHANNEL Spar box, left- 1
-
' ' WEB Spar box, rear 1
^ WEB - Spar box, front 1
-
' BRACKET flap retum spring 1
' PLATE - Tunnel, top, front 1
CHANNEL - Tunnel, side extension, left 1
' CHANNEL -Tunnel, side extension, right 1
' CHANNEL -Tunnel, side, left 1
' CHANNEL -Tunnel, side, right 1
ANGLE -Tunnel heat duct, left 1
ANGLE - Tunnel heat duct. right 1
-
ANGLE Tunnel heat duct 4
BRACKET - Pulley 2
' PLATE ASSEMBLY - Tunnel 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1C6
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
BRACKET Seat belt attachment, left
BRACKET - Seat belt attachment, right
SUPPORT - Rear seat bottom, left
SUPPORT - Rear seat bottom, right
SUPPORT - Rear seat bottom, left
-
SUPPORT Rear seat bottom, right
-
FITTING Flap torque tube assembly, left
-
FllTlNG Flap torque tube assembly, right
BOLT - (AN3-5A)
WASHER (AN960-10) -
WASHER - (AN960-10L)
NUT - (MS20365-1032C)

.
' BOLT- (AN3-1OA)
WASHER (AN960-10)
' NUT - (MS20365-1032C)
-
-
BRACKET Lower cockpit, left
BRACKET - Lower cockpit, right
* BRACKET ASSEMBLY - Pulley mounting
-
HAT ASSEMBLY Seat belt attachment, left
* HAT ASSEMBLY - Seat belt attachment, right
SUPPORT - Toque shaft center
E VENT ASSEMBLY Battery -
GUSSET - Lower cockpit, left
GUSSET - Lower cockpit, right
A LOWER COCKPIT ASSEMBLY -Aft
A,C * LOWER COCKPIT ASSEMBLY - Aft
' ' COVER - Inspection access
BLOCK - Rear seat support
BUSHING - Rear seat support
-
BOLT (AN3-20A)
WASHER (AN960-10) -
-
NUT (MS20365-1032C)
-
PLATE Flap toque tube support, left
PLATE - Flap toque tube support, right
* FLOORBOARD Front, left -
FLOORBOARD Front, right -
' FLOORBOARD - Rear
BOLT - (MS27039-1-12)
WASHER - (AN960-D-1)
-
NUT (MS20365-1032C)
-
' BOLT (MS27039-1-13)
. WASHER (AN960-D10)
-
NUT (MS20365-1032C)
-
C * DOUBLER ASSEMBLY - Transponder antenna access
C -
PLATE Transponder antenna access
'ZEE ASSEMBLY -Tunnel
PLATE -Tunnel, top, center front
PLATE - Tunnel, top, rear
PLATE -Tunnel, top, center rear
BRACKET ASSEMBLY - Rudder pedal stop, left
BRACKET ASSEMBLY Rudder pedal stop, right -

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1C7
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 12. Fuselage Lower Aft Cockpit Assembly

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 12

A - Used on PA-28-151 with serial numbers 28-7615002 and up and PA28-161.

B - Used if access covers are installed.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

LOWER COCKPIT ASSEMBLY -Aft 1 28-7415001 t h 28-761

~ 5001
LOWER COCKPIT ASSEMBLY - Aft 1
* CHANNEL ASSEMBLY - Right 1
'STRINGER ASSEMBLY Left - 1 28-7415001 thnt 28-7615001
' STRINGER ASSEMBLY - Left 1
CHANNEL ASSEMBLY - Right 1 28-7415001 t h 28-7615001
~
CHANNEL ASSEMBLY Right - 1
-
FLOOR ASSEMBLY Baggage compartment 1
-
' FLOOR Baggage compartment 1
-
* HAT Baggage floor, outboard 2 28-7415001 thnt 28-7615001
' HAT - Baggage floor, outboard 2
-
' HAT Baggage floor, center 1 28-7415001 t h 28-7615001
~
-
HAT Baggage floor, center 1
CHANNEL - Seat belt attachment 1
BRACKET - Baggage compartment, left 1
' BRACKET - Baggage compartment, right 1
' BRACKET - Baggage compartment, left 1
BRACKET - Baggage compartment, right 1
' DOUBLER ASSEMBLY Step - a
1
' BLOCK - Rear seat support 1
FRAME ASSEMBLY - Lower, Sta. 128.737 1
^ ' CHANNEL - Lower cockpit 1
' FITTING - Lower cockpit, left 1
' ' FITTING - Lower cockpit, right
' BRACKET - Lower cockpit, left1
^ BRACKET - Lower cockpit, right
' BRACKET - Rear seat belt support, left
' BRACKET - Rear seat belt support, right1
ANGLE - Lower cockpit

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure '13. Fuselage Aft Section

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 13

A -
B - Used on PA-28-151with serial numbers 28-7615002 and up, and PA-28-161with serial numbers 28-7716001 t h 28-7716323.
~
C -
D - Used on PA-28-151with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 t h 28-7716323.~
E - When ordering for 1978 and 1979 models, specify with or without provisions for air conditioning. When ordering for 1980 models and
up, specify if air conditioning or fresh air ventilation system is installed.
F - Used when air conditioning is installed.
G - Used when fresh air ventilation system is installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

FUSELAGE ASSEMBLY - Aft section

FUSELAGE ASSEMBLY - Aft section
FUSELAGE ASSEMBLY - Aft section
FUSELAGE ASSEMBLY - Aft section
' SKIN - Upper
SKIN - Upper 28-7816001 and up
-
' SKIN ASSEMBLY Side, left
-
SKlN ASSEMBLY Side, left 28-7816001 and up
-
' SKIN ASSEMBLY Side, left 28-8016001 and up
SKIN ASSEMBLY - Side, left 28-7816001 and up
SKlN ASSEMBLY -Side, right
SKIN ASSEMBLY - Side, right 28-7816001 and up
SKIN ASSEMBLY - Side, right 28-7816001 and up
' LOUVER - Air conditioning exhaust, left 28-7816001 and up
' LOUVER - Air conditioning exhaust, right 28-7816001 and up
* SKlN - Lower side, left
* SKlN - Lower side, left 28-7816001 and up
-
^ SKlN Lower side, right
-
SKlN Lower side, right 28-7816001 and up
SKlN ASSEMBLY - Lower center
SKlN ASSEMBLY - Lower center 28-7816001 t h 2816109
~
SKlN ASSEMBLY - Lower center 2816110 and up
BULKHEAD ASSEMBLY - Fuselage, Sta. 156.00
' PULLEY
^ * FAIRLEAD
" ' BUSHING - Pulley
' BUSHING - Pulley
" BOLT - (AN3-16A)
- WASHER - (AN960-416L)
' ' NUT - (MS20365-1032C)
CHANNEL - Baggage door, right
' FITTING ASSEMBLY - Upper, left
-
' FITTING ASSEMBLY Upper, right
' FITTING ASSEMBLY - Lower, left
' FITTING ASSEMBLY - Lower, right
BULKHEAD ASSEMBLY - Fuselage, Sta. 191.00
' ' FAIRLEAD
* BULKHEAD ASSEMBLY - Fuselage, Sta. 228.30
-
BRACKET Stabilator trim
' BRACKET - Stabilator trim indicator pulley
-
'' FITTING Frame, Sta. 228.30
-
' ' DOUBLER Frame, top, Sta. 228.30
BULKHEAD ASSEMBLY - Fuselage, Sta. 255.125
STRINGER ASSEMBLY - Hat section
' ' BRACKET - Stabilator pulley, left
'' BRACKET - Stabilator pulley, right
' STRINGER ASSEMBLY - Hat section
-
BRACKET Stabilator pulley. left
-
' BRACKET Stabilator pulley, right
-
STIFFENER Condenser door frame 28-7816001 and up
-
ZEE ASSEMBLY Condenser door frame 28-7816001 and up
-
BRACKET ASSEMBLY Condenser door bellcrank, left 28-7816001 and up
' BRACKET ASSEMBLY - Condenser door bellcrank, right 28-7816001 and up
-
BRACKET Motor mount, condenser actuator 28-7816001 and up
-
BRACKET ASSEMBLY Motor support 28-7816001 and up
' SPACER - Tail skid
DOUBLER -Antenna mount, forward
^ DOUBLER - Antenna mount, aft
' SKID ASSEMBLY -Tail
* STRINGER -Top, Sta. 191.00 to Sta. 228.30
^ STRINGER - Top, Sta. 156.00 to Sta. 191.00

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
FITTING ASSEMBLY Stabilator attachment
'' BOLT - Elevator stop (NKN428-3-7)
NUT - (AN315-3R)
BEARING - (DW4K2)
-
BOLT (NA5464P3A5)
WASHER (AN960-lo) -
WASHER (AN960-10L) -
NUT - (M521045 L3)
-
* BOLT (NA5464P3A4)
WASHER (AN960 10) -
'WASHER - (AN960-10L)
NUT - (M52104543)
BRACE - Condenser frame, left 28-7816001 and up
BRACE - Condenser frame, right 28-7816001 and up
GUSSET - Condenser frame, forward 28-7816001 and up
' VENT ASSEMBLY - Evaporator 28-7816001 and up
PANEL ASSEMBLY - Fairiead 28-7816001 and up
-
SCOOP Evaporator vent 28-7816001 and up
-
GUSSET Condenser frame, aft, left 28-7816001 and up
GUSSET - Condenser frame, aft, right 28-7816001 and up
' BRACKET - Brace 28-7816001 and up
-
BRACKET ASSEMBLY Condenser door actuation 287816001andup
-
' BEARING ASSEMBLY Condenser door actuation 28-7816001 and up
CHANNEL - Condenser door frame 28-7816001 and up
SHELF ASSEMBLY Battery -
SHELF ASSEMBLY Battery -
^ WEB - Battery shelf
WEB - Battery shelf
-
CHANNEL Battery shelf, inboard
CHANNEL - Battery shelf, inboard 2816110 and up
' CHANNEL - Battery shelf, outboard
-
' CHANNEL Battery shelf, outboard 2816110 and up
' CHANNEL - Battery shelf, front
-
" CHANNEL Battery shelf, front 2816110 and up
FILTER - Air conditioning exhaust 28-7816001 and up
COVER - Air conditioningexhaust louver, left 28-7816001 and up
-
COVER Air conditioningexhaust louver, right 28-7816001 and up
-
DISC Closeout
-
PLATE ASSEMBLY Aft fuselage closeout
BOLT - (AN3-4A)
WASHER - (AN960-D10)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

1C14
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 14. Fuselage Baggage Door Assembly

Reissued: December 1. 1989

1C15
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 14

A - If matching cabin door lock, baggage door lock, and ignition switch are desired, order Kit 470 728 for PA-28-151 with.serial numbers
28-7415001 t h 28-7615001.
~ Order Kit 87329-03 for PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
B - Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 and up.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

14-1 66793-18 -
DOOR ASSEMBLY Baggage (bonded) (less lock assembly) 1
-2 19063-02 -
MOULDING Baggage door (quarter-roundtype) 9
189 139 -
MOULDING Baggage door (bulb type) 9
-3 65440-80 1 -
STRAP ASSEMBLY Baggage door (11 L) 1
65440-07 -
' STRAP ASSEMBLY Baggage door (11.75 L) 1
-4 12761-02 COVER ASSEMBLY - Lock access (4.75 dia.) 1
79452-00 COVER - Lock access (5.75 dia.) 1
-5 472 010 -
* LATCH (H38-.064-.460) 1
-6 87329-08 A LOCK ASSEMBLY - Baggage door 1
-7 62400-02 PIN - Hinge 1
-8 65530-00 PLACARD - Baggage compartment 1 28-7415001 t h 28-7615445
~
69669-171 B PLACARD - Baggage compartment 1
-9 8734 1-05 -
PLACARD Max. Baggage 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1C17
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 15. Fuselage Cabin Door Assembly

(28-7415001 V ~ N28-7615001)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 15

A - Complete door assembly not available. Order component parts.

B - If matching cabin door lock, baggage door lock, and ignition switch are desired, order Kit 470 728.
C - When ordering specify color red, bluelgreen, gold, black or green.
D - Complete door assembly does not include lock assembly.

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

A,D DOOR ASSEMBLY - Cabin (complete) (with 080 thick window)

A,D DOOR ASSEMBLY - Cabin (complete) (with 125 thick window)
* DOOR ASSEMBLY Cabin -
' HINGE - Cabin door, top
' HINGE - Cabin door, bottom
BRACKET ASSEMBLY Upper door latch -
' ' ACTUATOR ASSEMBLY - Lower door latch
-
* CLAMP (PS10017-1-3)
-
" WINDOW Cabin door, tinted (.080 thick)
WINDOW - Cabin door, clear (.080 thick)
' WINDOW - Cabin door, clear (.I25 thick)
' WINDOW - Cabin door, tinted (.I25 thick)
' HOUSING ASSEMBLY Armrest -
-
' BOX ASSEMBLY Ash tray (S-25-AR-C)
C ' PAD - Armrest
-
PAD Armrest, white
COVER ASSEMBLY - Door trim, upper
* PANEL ASSEMBLY - Door trim, red
PANEL ASSEMBLY Door trim, blue -
PANEL ASSEMBLY Door trim, gold -
* PANEL ASSEMBLY - Door trim, black
PANEL ASSEMBLY - Door trim, white
PANEL ASSEMBLY - Door trim, green
LATCH ASSEMBLY - Door
' ' PIN - Door latch
' ' TONGUE ASSEMBLY Door latch -
SPRING
' ' HOUSING ASSEMBLY - Door latch
" PLATE ASSEMBLY
PLATE
' ' LINK
' ' SPRING
* WASHER (AN960-6) -
-
PIN (MS20392-IC53)
* GOITER PIN - (MS24665-132)
* ROLL PIN - (59 028-125-05625)
PIN - (MS20392-1C49)
" COTTER PIN (MS24665-132) -
* * WASHER (AN960-6) -
' BUSHING
-
' PLATE Door latch stop
' * PLATE - Seal support
" SEAL
* LATCH ASSEMBLY Door, auxiliary -
"WASHER
-
PAN Door latch
' * HOOK ASSEMBLY Door latch -
' PLATE Door latch -
-
' * PLATE Door latch
-
' CAM Door latch
' SPRING - Door latch
BUSHING
-
SCREW (AN507-832R14)
-
NUT (MS20364-832C)
WASHER - (AN960-816)
' ' HANDLE - Door, auxiliary, white

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

1C20
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
SCREW (AN526C-832R8)
' WASHER - Door handle (AN960-51-6L)
' ' ROD ASSEMBLY - Door latch
'' PIN - Door latch
* NUT - (AN315-3R)
-
HANDLE Door, auxiliary, white
-
HANDLE ASSEMBLY Door (113-837-020)
-
ANGLE Door trim, forward
-
ANGLE Door trim, upper center
ANGLE - Door trim, lower center
-
ANGLE Door trim, rear
ESCUTCHEON - (113-837-2399)
'TRIM PLATE - Black (311-837-247)
. SCREW - (AN530-10R36)
' ROD - Door latch
MOULDING - Cabin door (quarter-roundtype)
MOULDING - Cabin door (bulb type)
' EXTRUSION - Vinyl
RETAINER Side panel -
PLATE - Door latch trim
* BUTTON - PIUCJ (207-200201-00-0103)
SPACER - Door lock
' PLACARD - Door lock, white
'SPRING - (113-837-199)
' WASHER - Neoprene
WASHER - (AN960C-816)
CLAMP - Lower door latch
' SCREW - (P510012-3)
WASHER - (P510016-4)
SCREW - (N00-014-2161)
' WASHER - (N00-012-1131)
SCREW - (M551957-45)
WASHER - (AN960C-51-6L)
' SCREW - (P510012-4)
* WASHER - (P510016-4)
SCREW - (4 x 318L Type A)
* SCREW - (4 x 112L Type A)
-
PIN (M520392-3C13)
WASHER (AN960-416L) -
COTTER PIN - (M524665-132)
-
' SCREW (M524693-C28)
BOLT - (AN3-5A)
* WASHER (AN960-10) -
-
NUT (M520365-1032C)
B LOCK ASSEMBLY Cabin door -
DOOR HOLDER ASSEMBLY
-
BUMPER (SJ-5003) White
BOLT - (AN23-10A)
-
WASHER Door holder (neoprene)
-
BUSHING Door holder
PLACARD - Door release

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1C21
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 16. Fuselage Cabin Door Assembly

(28-7615002 and up, and 28-7716001 and up)

Reissued: December 1, 1989

1C22
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 16

Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161 .
Complete door assembly not available. Order component parts.
When ordering, specify color red, bluetgreen, gold, black, green or bark Specify color bark 1 when ordering for PA-28-151 with serial
numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thnr 28-7716075. Specify color bark I1 or black for
PA-28-161 with serial numbers 28-7716076 and up.
When ordering, specify color red, bluelgreen, gold, black or green.
Cabin door lock unlocks in a counterclockwise direction. If matching cabin door lock, baggage door lock and ignition switch are
desired, order Kit 470 728.
Cabin door lock unlocks in a clockwise direction. If matching cabin door lock, baggage door lock and ignition switch are desired, order
Kit 87329-03.

Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 264216236.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161with serial numbers 28-7716001 thm 28-7716323.

Used with door latch hook assembly that has a 318 O.D. welded stud.
Used with door latch hook assembly that has a 114 O.D. welded stud and 318 O.D. removable roller.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thnr 28-8116213.
Used on serial numbers 28-8116214 and up. Also used on serial numbers 28-8016001 t h 28-8116213
~ if luxurious lnterior is
installed.
Used on serial numbers.28-81162l-4 and up. Also used on serial numbers 28-8116001 thru 28-8116213 if luxurious lnterior is
installed.
Used on PA-28-161 with serial numbers 28-8116214 t h 28-8216242.
~ Also used on PA-28-161 with serial numbers 28-8116001 thm
28-8116213 if luxurious lnterior is installed.
Used on PA-28-161 with serial numbers 28-8116214 thnr 28-8216236. Also used on PA-28-161 with serial numbers 28-8016001 thm
28-8116213 if luxurious lnterior is installed.
Used if Luxurious lnterior is not installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 51f161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
lndex Number Code Nomenclature Req. Affected
Number
--

-
DRAWING Doors Installation
DRAWING - Door Snubber Installation 28-7716001 and up

-
DOOR ASSEMBLY Complete (less lock assembly)
-
' MOULDING Cabin door (bulb type)
* HOUSING ASSEMBLY -Armrest
-
'* BOX ASSEMBLY Ash tray (S-25-AR-C)
-
' PAD Armrest
* PAD - Armrest, mushroom
' PAD -Armrest, camel
' PAD -Armrest, firethorn red (vinyl) 28-8116001 t h 28-8216236
~
' PAD -Armrest, firethom red (fabric) 28-8016001 and up
-
' PAD Armrest, firethom red (leather) 28-8316001 and up
-
PAD Armrest, red (vinyl) 28-8316001 and up
' PAD -Armrest, buckskin (velour) 28-8016001 thtU 28-8216236
PAD -Armrest, light buckskin (vinyl) 28-8316001 and up
PAD -Armrest, light buckskin (leather) 28-8316001 and up
PAD -Armrest, dark blue (vinyl) 28-8116001 t h 28-8216236
~
PAD -Armrest, dark blue (fabric) 28-8016001 and up
PAD -Armrest, dark blue (leather) 28-8316001 and up
PAD - Armrest, blue (vinyl) 28-8316001 and up
-
PAD Armrest, dark cedar (knit) 28-8116001 and up
-
PAD Armrest, dark cedar (velour) 28-8216001 thtU 28-8216236
-
PAD Armrest, dark cedar (leather) 28-8316001 and up
-
PAD Armrest, dark carmine (velour) 28-8216001 t h 28-821
~ 6236
' PAD -Armrest, sandalwood (fabric) 28-8216001 and up
-
PAD Armrest, patrician sandalwood (fabric) 28-8316001 and up
-
PAD Armrest, dark saddle (knit) 28-8316001 and up
PAD - Armrest, dark saddle (leather) 28-8316001 and up
-
COVER Cabin door, upper, white
* PANEL ASSEMBLY - Cabin door trim, red
-
PANEL ASSEMBLY Cabin door trim, bluehreen
-
PANEL ASSEMBLY Cabin door trim, gold
PANEL ASSEMBLY - Cabin door trim, black
-
PANEL ASSEMBLY Cabin door trim, green
PANEL ASSEMBLY - Cabin door trim, mushroom/black
-
PANEL ASSEMBLY Cabin door trim, camellblack
-
PANEL ASSEMBLY Cabin door trim, white/camel/black
-
* PANEL ASSEMBLY Cabin door trim, firethorn red
-
PANEL ASSEMBLY Cabin door trim, firethom red (vinyl)
-
PANEL ASSEMBLY Cabin door trim, firethorn red (velour)
-
* PANEL ASSEMBLY Cabin door trim, red (vinyl) 28-8316001 and up
-
PANEL ASSEMBLY Cabin door trim, buckskin (velour)
* PANEL ASSEMBLY - Cabin door trim, light buckskin (vinyl) 28-8316001 and up
-
PANEL ASSEMBLY Cabin door trim, dark blue 28-8116001 thN 28-8116213
-
* PANEL ASSEMBLY Cabin door trim, dark blue (vinyl)
-
PANEL ASSEMBLY Cabin door trim, dark blue (velour)
-
PANEL ASSEMBLY Cabin door trim, light blue (velour) 28-8316001 and up
-
PANEL ASSEMBLY Cabin door trim, blue (vinyl) 28-8316001 and up
PANEL ASSEMBLY - Cabin door trim, dark cedar (knit)
-
PANEL ASSEMBLY Cabin door trim, dark cedar (velour) 28-8216001 and up
PANEL ASSEMBLY - Cabin door trim, dark carmine (velour) 28-8216001 and up
-
PANEL ASSEMBLY Cabin door trim, sandalwood (fabric) 28-8216001 and up
-
PANEL ASSEMBLY Cabin door trim, dark saddle (fabric) 28-8316001 and up
RETAINER - Side panel

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1C24
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Nwnbers
Index Number Code Nomenclature Req. Affected
Number

79475-20 -
* WINDOW Cabin door (.080 thick), clear
79475-59 -
* WINDOW Cabin door (.I25 thick), clear
79475-58 * WINDOW - Cabin door (.080 thick), tinted
79475-60 'WINDOW - Cabin door (.I25 thick), tinted
79475-16 DOOR ASSEMBLY - Cabin (less window and lock
assembly)
79475-07 ' HINGE - Cabin door, upper
79475-08 ' ^ HINGE - Cabin door, lower
79475-22 * ' RETAINER Window -
419 967 ' SCREW - Set (114-28 x 114 L.)
486 145 ' ' SCREW - Set (P70FS420-4C) (114-20 x 114 L.)
79515-35 -
' ' COVER Cabin door latch
79515-13 -
' ^ HANDLE Cabin door
79647-02 ' ' KNOB - Door handle
795 15-04 " ' LATCH ASSEMBLY - Door
79515-06 ' ^ ' TUBE ASSEMBLY - Door latch
..**
65 146-00 SPRING - Door latch tube (2.00 L.)
587 398 ..*a
SPRING - Door latch tube (1.50 L.)
400 113 *.a
-
BOLT (AN4-20)
*.*. WASHER - (AN960-416)
407 565
404 101 * . a *
NUT - (AN310-4)
424 05 1 a*..
COlTER PIN - (MS24665-132)
79515-07 ' ' BOX ASSEMBLY - Door latch
79515-08 ' ' ' LINK - Door latch mechanism
79515-15 -
' ' ' BUSHING Door latch mechanism
79530-02 ' ' HANDLE - Door latch mechanism
587 381 * * SPRING - (E0240-037-1750s)
62833-105 * ' WASHER - Door latch mechanism
79532-02 * ' LATCH - Cabin door
400 665 ' ' BOLT - (AN21-31)
407 562 WASHER - (AN960-6)
404 391 ' ' NUT - (AN320-1)
424 041 -
COTTER PIN (MS24665-5)
424 178 -
' ' ' PIN (MS20392-2C-19)
424 041 -
COTTER PIN (MS24665-5)
480 800 ' ' PIN - Spring (MS9048-111)
407 582 * ' WASHER - (AN960-6L)
99997-00 ' EXTRUSION Vinyl -
519 853 SCREW - (MS24622-43)
62833-107 -
WASHER Teflon
407 680 -
WASHER (AN960-C816)
36598-02 -
LATCH ASSEMBLY Door, auxiliary
407 680 -
WASHER (AN960-C816)
79475-34 ' ' PAN - Door latch, white
62833-06 " WASHER
63045-00 ' SPRING - Door latch
36590-02 * ' HANDLE - Door, auxiliary
63042-03 -
' CAM Door latch
63036-03 '' HOOK ASSEMBLY - Door latch (with 318 O.D. welded
stud)
63036-04 " HOOK ASSEMBLY - Door latch (with 114 O.D. welded

stud)
63900-50 ' ' BUSHING
68179-00 L ' ' PLATE - Door latch
68 179-07 M ' PLATE - Door latch
68 179-02 L '' PLATE - Door latch
68179-08 M ' PLATE - Door latch

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1D l
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number
--

-
SCREW (MS24622-43) 1
-
* * WASHER (AN960-516L) 1
' WASHER Teflon - 1
-
ROLLER Door latch (318 O.D.) 1
-
^ HANDLE Door, auxiliarv latch 1
'WASHER - Neoprene 1
-
HANDLE Door assist (PS10091-1) 1
-
* SCREW (AN530-1OR36) 2
C -
' PAN Door latch 1
E -
' ' LOCK ASSEMBLY Cabin door 1
F ' LOCK ASSEMBLY - Cabin door 1
-
PLACARD Door lock 1
DOOR HOLDER ASSEMBLY 1
BOLT - (AN23-10A) 2
K -
SEAL Door snubber (150 long) 1 28-8016305 and up
BUMPER - (SJ-5003) 2
WASHER - Door holder (neoprene) 1
-
BUSHING Door holder 1
-
PLACARD Door release 1
PIN - (MS20392-3C13) 2
-
WASHER (AN960-416L) 4
NUT - (MS24665-132) 2
PLACARD - Open 1
PLACARD - Latch 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1D2
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 17. Fuselage Enclosure Installation

Reissued: December 1,1989

1D3
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 17

Used if .I25 thick windshield is installed.

Used if .250 thick windshield is installed.
Used if latch assembly attachment screw is bonded to window assembly.
Used if latch assembly attachment screw requires a .I91 hole drilled in window assembly.

Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Windshield Installation

-
DRAWING Window Installation
DRAWING - Window Frame Installation

-
WINDSHIELD Left, clear (.I25thick) 1
-
WINDSHIELD Left, tinted (.I25thick) 1
WINDSHIELD - Left, clear (.250thick) 1
-
WINDSHIELD Left, tinted (.250thick) 1
-
WINDSHIELD Right. clear (.I25thick) 1
WINDSHIELD - Right, tinted (.I25thick) 1
WINDSHIELD - Right, clear (.250thick) 1
WINDSHIELD - Right, tinted (.250thick) 1
WINDOW ASSEMBLY - Front, left, clear 1
WINDOW ASSEMBLY - Front, left, tinted 1
-
WINDOW Front, left, clear 1
WINDOW - Front, left, tinted 1
WINDOW ASSEMBLY Storm, clear - 1
WINDOW ASSEMBLY - Storm, tinted 1
HINGE - Half 1
LATCH ASSEMBLY - Storm window 1
SPACER - Storm window, latch 1
HINGE - Half 1
PIN - Hinge 1
BUSHING - Storm window latch 1
SCREW - (MS35206-232) 1
-
WASHER Shake proof (3502-10-71) 1
WASHER - Lock (MS35338-41) 1
-
NUT (8061-NP) 1
-
SCREW Storm window attachment 1
-
WASHER Shake proof (3502-10-71) 1
WASHER - (MS35338-41) 1
NUT - Dome (8061-NP) 1
WINDOW - Center, left, clear (.080thick) 1
-
WINDOW Center, left, tinted (.080thick) 1
-
WINDOW Center, left, clear (. 125 thick) 1
-
WINDOW Center, left, tinted (.I25thick) 1
-
WINDOW Center, right, clear (.080thick) 1
WINDOW -Center, right, tinted (.Of30thick) 1
WINDOW -Center, right, clear (.I25thick) 1
WINDOW -Center, right, tinted (.I25thick) 1
WINDOW - Rear, left, clear (.080thick) 1
-
WINDOW Rear, left, tinted (.080thick) 1
WINDOW - Rear, left, clear (. 125 thick) 1
WINDOW - Rear, left, tinted (.I25thick) 1
-
WINDOW Rear, right, clear (.080thick) 1
-
WINDOW Rear, right, tinted (.080thick) 1
-
WINDOW Rear, right, clear (.I25thick) 1
WINDOW - Rear, right, tinted (.I25thick) 1
COVER -Window, right 1 28-7415001 t h 28-7615001
~
COVER -Window, right 1
COVER -Window, right 1 2816110 and u p
-
COVER ASSEMBLY Window frame, center, left 1
-
COVER ASSEMBLY Window frame, center, left 1 2816110 and up
-
COVER ASSEMBLY Window frame, center, right 1
-
COVER ASSEMBLY Window frame, center, right 1 2816110 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30,1994

1 D5
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

COVER ASSEMBLY -Window frame, front, left 1

-
COVER ASSEMBLY Window frame, front, left 1
COVER ASSEMBLY - Window frame, front, left 1 2816110 and up
COVER ASSEMBLY - Window frame, rear, left 1
-
COVER ASSEMBLY Window frame, rear, left 1 2816110 and up
-
COVER ASSEMBLY Window frame, rear, right 1
COVER ASSEMBLY -Window frame, rear, right 1 2816110 and up
COVER ASSEMBLY - Window sill, red 1 28-7415001 t h 28-7615445
~
-
COVER ASSEMBLY Window sill, bluelgreen 1 28 7415001 t h 28-7615445
~
COVER ASSEMBLY - Window sill, gold 1 28-7415001 t h 28-7615445
~
COVER ASSEMBLY - Window sill, black 1 28-7415001 t h 28-7615445
~
-
COVER ASSEMBLY Window sill, white 1 28-7415001 t h 28-7615445
~
COVER ASSEMBLY - Window sill, green 1 28-7415001 t h 28-7615445
~
COVER ASSEMBLY - Window sill, mushroom 1
-
COVER ASSEMBLY Window sill, white 1
COVER ASSEMBLY - Window sill, camel 1
COVER ASSEMBLY - Window sill, firethorn red (vinyl) 1 28-8116001 thN 28-8216236
COVER ASSEMBLY - Window sill, firethorn red (velour) 1 28-8016001 and up
-
COVER ASSEMBLY Window sill, firethom red (leather) 1 28-8316001 and up
-
COVER ASSEMBLY Window sill, red (vinyl) 1 28-8316001 and UP
COVER ASSEMBLY -Window sill, buckskin (velour) 1 28-8016001 t h 28-8216236
~
COVER ASSEMBLY - Window sill, light buckskin (vinyl) 1 28-8316001 and up
COVER ASSEMBLY - Window sill, light buckskin (leather) 1 28-8316001 and Up
-
COVER ASSEMBLY Window sill, dark blue (vinyl) 1 28-8116001 t h 28-821
~ 6236
COVER ASSEMBLY - Window sill, dark blue (velour) 1 28 8016001 and up
COVER ASSEMBLY - Window sill, dark blue (leather) 1 28-8316001 and up
-
COVER ASSEMBLY Window sill, blue (vinyl) 1 28-8316001 and up
COVER ASSEMBLY - Window sill, dark cedar (knit) 1 28-8116001 and up
COVER ASSEMBLY - Window sill, dark cedar (velour) 1 28-8216001 and Up
-
COVER ASSEMBLY Window sill, dark cedar (leather) 1 28-8316001 and up
-
COVER ASSEMBLY Window sill, dark carmine (velour) 1 28-8216001 and up
-
COVER ASSEMBLY Window sill, sandalwood (fabric) 1 28-8216001 and UP
COVER ASSEMBLY - Window sill, dark saddle (fabric) 1 28-8316001 and UP
-
COVER ASSEMBLY Window sill, dark saddle (leather) 1 28-8316001 and up
COVER - Windshield bow, upper, left 1 28-7415001 thN 28-7615001
COVER - Windshield bow, upper, left 1
COVER - Windshield bow, upper, left 1 2816110 and up
-
COVER Windshield bow, upper, right 1 28-7615001
28-7415001 t h r ~
COVER -Windshield bow, upper, right 1
COVER -Windshield bow, upper, right 1 2816110 and up
-
COLLAR Inside, left 1
-
COLLAR Inside, right 1
COLLAR - Outside, left 1
COLLAR - Outside, right 1
TRIM -Windshield 1
TRIM -Windshield 1
BUTTON - Plug (207-200201-00-0103) 10
TRIM STRIP - Windshield, center 1
-
TRIM STRIP Windshield, center 1
-
RETAINER Front window, front, left 1
RETAINER - Front window, front, left 1
-
RETAINER Front window, top, left 1
RETAINER - Fmnt window, bottom, left 1
RETAINER - Front window, rear, left 1
-
RETAINER Center window, front, left 1
-
RETAINER Center window, front, right 1
RETAINER - Center window, top, left 1
RETAINER - Center window, top. right 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

17-32 76268-00 RETAINER - Center window, bottom, left 1

76269-00 -
RETAINER Center window, bottom, right 1
-33 76267-00 -
RETAINER Center window, rear, left 1
76267-01 -
RETAINER Center window, rear, right 1
-34 76270-00 -
RETAINER Rear window, front, left 1
76270-01 -
RETAINER Rear window, front, right 1
-35 76271-00 -
RETAINER Rear window, top 1
-36 76273-00 RETAINER - Rear window, bottom, left 1
76274-00 RETAINER - Rear window, bottom, right 1
-37 76272-00 -
RETAINER Rear window, rear, left 1
76272-01 -
RETAINER Rear window, rear, right 2
-38 78086-00 RETAINER - Side panel 2
-39 99943-00 RETAINER - Side panel 9
-40 79154-00 -
RETAINER W~ndshieldattachment, left 1
79155-00 RETAINER - Windshield attachment, right 1
-41 99943-00 RETAINER - Side panel 2
-42 69219-00 PLATE - Windshield collar, outside, center 1
-43 99997-00 EXTRUSION -Vinyl 30
-44 78057-00 RETAINER - Window frame extrusion 12
-45 415 535 B SCREW - (MS35M6-245) 1
415 544 A SCREW - (MS35206-244) 1
-46 415537 B SCREW - (MS35206-247) 8
415 536 A SCREW - (M535206-246) 8
-47 419929 SCREW - (4 x 318 L.) Type A 12
-48 419641 -
SCREW (4 x 112 L.) Type A 90
-49 419681 -
SCREW (PS10012-4) 6
494 001 WASHER - (PSl0015-4) 6
-50 415 495 -
SCREW (M535206-230) 2
-51 415 495 SCREW - (MS35206-230) 24
406 823 -
ANCHOR NUT (NAS686A06K) 24

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1.1989

1D7
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 18. Tail Surfaces Installation

Reissued: December 1.1989

1 D9
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 18

See Figure 19 for component parts.

See Figure 20 for component parts.
See Figure 21 for component parts.
Used if rotating beacon is installed. Also used if neither strobe light nor rotating beacon is installed.
Used if strobe lights are installed.
Used on PA-28-151, and PA-28-161 with serial numbers 28-7716001 thm 28-7816175.
Used on PA-28-161 only.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916617.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216023
Also used on PA-28-161 with serial numbers 28-8216024 and up if aircraft complies with United Kingdom requirements.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

18- 62002 DRAWING - Tail Surfaces Installation

STABILATOR ASSEMBLY 1
FIN ASSEMBLY 1
FIN ASSEMBLY 1 28-8016001 and up
RUDDER ASSEMBLY 1
TAB ASSEMBLY Stabilator, left - 1
TAB ASSEMBLY - Stabilator, right 1
SKIN - Stabilator trim tab, left 2
-
SKIN Stabilator trim tab, right 2
-
RIB Outboard 1
RIB - Inboard 1
DOUBLER -Tab assembly 3
-
HINGE Half, stabilator tab 3
FAIRING - Tail cone, bottom 1
-
FAIRING Tail cone, top 1
FAIRING - Dorsal fin, aft 1
-
FAIRING Dorsal fin, forward 1
TIP ASSEMBLY Fin - 1
TIP ASSEMBLY Fin - 1
TIP ASSEMBLY - Stabilator 2
-
TIP ASSEMBLY Rudder (with provisions for tail light) 1
-
TIP ASSEMBLY Rudder (without provisions for tail light) 1
BALANCE WEIGHT ASSEMBLY Stabilator - 1
'TUBE ASSEMBLY - Stabilator 1
MOULDING Extruded - 2
MOULDING - Extruded 2
PIN - Hinge 2
PIN - Hinge 2
-
PIN Hinge 1
PLATE - Stabilator balance AR
-
WASHER (AN960-10) AR
-
WASHER (AN960-10L) AR
-
BOLT (AN3-11) 1
-
WASHER (AN960-10) 6
WASHER - (AN960-10L) 2
-
NUT (AN310-3) 1
COlTER PIN (MS24665-132) - 1
-
BOLT (AN3-17A) 2
WASHER (AN960-10) - 6
-
NUT (MS20365-1032C) 2
BOLT (AN46A)- 4
WASHER (AN960-416) - 8
-
NUT (MS20365-428C) 4
-
BOLT (AN4-6A) 1
WASHER (AN960-416L) - 1
WASHER (AN960-416) - 2 28-7816176 and up
-
BOLT (NAS1104-17) 2
WASHER (AN960-416) - 4
-
NUT (H-10-4) 2
WASHER (AN960-416L) - AR
WASHER (AN960-416) - AR
-
BOLT (NKN428-3-7) 2
-
NUT (AN315-3R) 2
SCREW (MS24694-C5) - 44
WASHER - (PS10092-1-2C) 44
-
NUT (PS10062-5-3) 44

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

ID11
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number
-

-
SCREW (MS51957-45)
-
NUT (PS10062-5-3)
-
SCREW (MS24694-65)
-
WASHER (P510092-1-2C)
-
SCREW (M5246945-6)
-
WASHER (P5 10092-1-2C)
-
NUT (P5 10062 5 3)
-
SCREW (M524694-65)
-
WASHER (P510092-1-2C)
-
NUT (P510062-5-3)
BOLT - (AN3-IOA)
-
WASHER (AN960-10)
-
NUT (M520365-1032C)
COVER - Fin tip
-
ANGLE Dorsal fin fitting, left
ANGLE - Dorsal fin fitting, right
PLACARD - Do not push

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

ID12
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 19. Stabitator Assembly

Reissued: December 1,1989

ID13
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 19

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

STABILATOR ASSEMBLY
SKlN - Stabilator, aft top, left
SKlN - Stabilator, aft top, right
-
'SKIN Stabilator, aft bottom, left
SKlN - Stabitator, aft bottom, right
-
SKlN Stabilator, leading edge, left
-
' SKIN Stabilator, leading edge, right
' SKIN - Stabilator, center, top
-
SKIN Stabilator, center, bottom
'SKIN - Stabilator, leading edge, left
SKlN - Stabilator, leading edge, right
-
SKlN Stabilator, top and bottom, left
SKlN - Stabilator, top and bottom, right
-
SKIN Stabilator, top, left, bottom, right
SKIN - Stabilator, top, right, bottom, left
' SPAR - Stabilator, rear
-
SPAR Stabilator, outboard, forward
* SPAR - Stabilator, outboard, aft
SPAR - Stabilator, main
' CAP - Stabitator, spar
' RIB - Stabilator, nose
* RIB - Stabilator, aft
-
' RIB Stabilator, tip
' STIFFENER - Stabilator, top, left
STIFFENER - Stabilator, top, right
-
STIFFENER Stabilator, bottom, left
-
' STIFFENER Stabilator. bottom, right
-
F l T l N G Balance weight attachment
-
FITTING Stabitator hinge
ANGLE Stabilator -
' CLOSURE
-
HINGE Extruded, outboard
HINGE - Extruded, inboard and center
BOLT - (AN4-6A)
WASHER - (AN960-416)
NUT - (MS20365-428)
-
* BOLT (AN4-7A)
WASHER (AN960-416) -
-
NUT (MS20365-428)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

ID15
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 20. Fin Assembly

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 20

A - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thtu 28-7916617.

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
lndex Number Code Nomenclature Req. Affected
Number

A FIN ASSEMBLY 1
FIN ASSEMBLY 1 28-8016001 and up
A SKIN ASSEMBLY Fin nose - 1
* SKlN ASSEMBLY - Fin nose 1 28-8016001 and up
A -
COVER Air vent 1
* SKIN - Fin, left 1
-
' SKIN Fin, right 1
-
FITTING Fin root 1
HINGE ASSEMBLY Fin - 1
BEARING (KP3A) - 1
RIB ASSEMBLY Fin top - 1
* RIB ASSEMBLY Fin bottom - 1
' SPAR Fin rear - 1
STIFFENER - Fin spar, left 1
-
' STIFFENER Fin spar, right 1
* DOUBLER ASSEMBLY - Fin 1
BRACKET - Fin antenna 1
-
CLIP Fin 1
' RIB - Fin nose 1
* NUT - (MU-832-38 025 x 050-L-F-10) 10
BOLT - (AN3-5A) 4
-
' WASHER (AN960-10L) 4

When ordering, always specify Part Number, Description, and Serial h m b e r of Aircraft

Reissued: December 1, 1989

ID18
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 21. Rudder Assembly

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 21

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number
- --

RUDDER ASSEMBLY
-
'SKIN Rudder
-
'Rib Rudder, top
-
'RIB Rudder, bottom
-
'SPAR Rudder
'HORN ASSEMBLY - Rudder
"'BEARING (KP3A) -
-
*DOUBLER Rudder, top
*DOUBLER ASSEMBLY - Rudder
-
'FITTING Rudder, hinge
*BOLT - (AN3-4A)
'WASHER - (AN960-10L)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1 D21
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 22. Nose Gear Installation

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 22

A - See Figure 23 for component parts.

B -
C - Used on PA-28-151 with serial numbers 28-7415598 and up, and PA-28-161.
D - See Figure 30 for PA-28-161 with serial numbers 28-7816001 and up if nose wheel fairing is installed.
E - Used i f shockabsorber is stamped with Monroe part number 18756.
F - Used with 114 female threaded rod end bearing.
G - Used on PA-28-151. Also used on PA-28-161 with serial numbers 28-7816001 t h 28-8416095.
~

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Nose Landing Gear Installation

STRUTASSEMBLY - Nose (less tire, tube and wheel

assembly)
BUNGEE ASSEMBLY - Nose wheel
ROD ASSEMBLY - Nose wheel steering 2 28-8416096 and up
' BEARING - (PS10020-2-1RX) (114 female threads) 1
-
' BEARING (NAS659-3-5) (5116 male threads)
' NUT - (AN316-5R)
' BEARING - (PSI 0020-9-3)
-
SCREW Bungee adjusting
-
PLACARD Oleo service instruction
BUSHING
BUSHING
BUSHING
WASHER Nose gear strut -
HORN ASSEMBLY - Nose wheel steering
MOUNTASSEMBLY - Engine
BEARING - Nose gear, upper (15266-00)
BEARING - Nose gear, lower (KP33B)
DAMPENER ASSEMBLY Shimmy (PS50152-5) -
BEARING (PSl0020-1-6RX) -
* NUT - (AN315-4R)
WASHER - (AN936-A416)
CLAMP ASSEMBLY - Shimmy dampener
BOOT - Nose wheel bungee
PLATE Bungee seal-
PLATE Bungee seal-
RING - Bungee seal
RING - Bungee seal
PACKING - Seal
HOUSING Bungee seal -
HOUSING - Bungee seal
HOUSING - Seal ring retainer
-
DISC Firewall seal
BOLT - (AN3-13A)
WASHER (.56 O.D.) -
WASHER (AN960-10) -
-
NUT (MS20365-1032C)
BOLT - (AN3-36A)
BOLT - (AN3-37A)
WASHER - ( 5 6 O.D.)
WASHER - (AN960-10L)
-
NUT (MS20365-1032C)
-
PIN (MS20392-3C59)
WASHER (AN960-416L) -
COlTER PIN (MS24665-132) -
-
BOLT (AN174-25A)
WASHER (AN960-416L) -
-
NUT (MS20364-428C)
-
BOLT (NAS4-12)
NUT - (AN316-4R)
BOLT (AN3-13)-
WASHER (AN960-10L) -
-
NUT (AN310-3)
COTTER PIN - (MS24665-132)
BOLT - (AN3-6A)
-
NUT (MS20365-1032C)
When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1E l
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

BOLT - (AN6-25A)
-
BOLT (AN6-26A) 2816001 andup
-
WASHER (AN960-616L) 2816001 and up
-
WASHER (AN960-616)
NUT - (PS10062-8-624C)
-
BOLT (AN6-35A)
BOLT - (AN6-36A) 2816001 and up
-
WASHER (AN960-616L) 2816001 andup
-
WASHER (AN960616)
-
NUT (PS10062-8-624C)
-
BOLT (AN74A-3)
-
WASHER (AN960-416L)
PLACARD - Turn limit
-
PLACARD Turn limit center mark
NUT - Nose gear
-
STOP ASSEMBLY Nose wheel
-
BOLT (AN4-5A)
WASHER - (AN960-416)
WASHER - (AN960-41 6L)
NUT - (MS20365-428C)
BOLT - (AN3-14)
WASHER - (AN960-10)
WASHER - (AN960-10L)
BUSHING
-
NUT (AN310-3)
COTTER PIN - (MS24665-132)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1E2
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 23. Nose Gear Stmt Assembly

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 23

A - See Figure 24 for component parts.

B - See Figure 25 for component parts.
C - Used with McCauley nose wheel assembly only.
D - Before ordering tube assembly, ascertain if the top of the nose wheel piston bearing (item no. 14) incorporates a 20 inch long by .028
inch deep chamfer in the outer diameter. If the chamfer does not exist, also order a new piston bearing P N 66843-02.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Nose Landing Gear Installation

-
STRUT ASSEMBLY Nose (less tire, tube and wheel
assembly)
FORK ASSEMBLY Nose wheel -
BEARING - Block assembly (P32-4)
-
' ' LlNK Tow bar
BOLT - (AN5-17A)
WASHER (AN960-516L) -
-
' NUT (MS20365-524C)
* BOLT - (AN5-22A)
* WASHER (AN960-516L) -
-
* ' NUT (MS20365-524C)
' SPACER - Toe bar link
GASKET - Air valve (AN901-5A)
LlNK ASSEMBLY - Nose wheel, lower
^ BRACKET ASSEMBLY Bumper block -
-
BLOCK Bumper, ~ b b e r
D ' TUBE ASSEMBLY Outer -
* BEARING - (P32-4)
-
TUBE Landinq gear strut, inner
-
PLUG Nose wheel oleo piston tube
BEARING - Nose wheel piston
' RING - 0 piston tube (15207-00)
RING - Retaining (5000-200)
+ SNAP RING - (3478)

-
' RING Piston (R19046)
' STRIP -Wiper (10W0) (5-114 L)
PACKING - Quad ring (4222)
PACKING - 0 ring (AN6230-2)
-
WASHER Back up (AN6246-27)
-
CORE (AN809-1 ) Air valve
* VALVE - (AN812-1) Air valve
'CAP - (AN813-18) A i ~ d v e
-
LlNK ASSEMBLY Nose wheel, upper
BEARING (P32-4) -
-
BOLT (AN3-14A)
WASHER (AN960-10) -
-
NUT (MS20365-1032C)
-
* BOLT (AN4-32A)
WASHER (AN960-416) -
NUT - (MS20365-428C)
-
BOLT (AN3-4A)
' WASHER (AN960-10) -
-
NUT (MS20365-1032C)
-
BOLT (AN17531A)
WASHER (AN960-516) -
-
NUT (MS20365-524C)
-
* BOLT (AN5-20A)
* WASHER (AN960-516) -
-
* NUT (MS20365-524C)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1E5
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

23-33 407 567 -

WASHER (AN960-616) 2
404 890 -
NUT (MS20364-624C) 2
-34 551 792 A WHEEL ASSEMBLY - Nose (40-778) Cleveland 1
551 772 B -
WHEEL ASSEMBLY Nose (D-30500) McCauley 1
-34a 758 397 C -
BUSHING Valve stem (A-30653) 1
-35 451 728 TIRE - (5.00 x 5, 4 ply) McCreary 1
761 974 TIRE - (5.00 x 5, 4 ply) B. F. Goodrich 1
-36 451 739 -
TUBE (5.00 x 5) 1
-37 35156-00 AXLE- Nosewheel 1
-38 35157-00 SPACER ASSEMBLY Axle - 2
-39 35158-00 PLUG Axle- 2
-40 401 450 BOLT - Axle (AN6-70A) 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 24. Nose Wheel Assembly (Cleveland)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 24

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

24-1 551 792 -

WHEEL ASSEMBLY Nose (40-778) 1
-2 756 667 WHEEL HALF ASSEMBLY - Outer (162-53)
(with valve hole) 1
CUP - Bearing (08231)
-3
-4
-5
757 831
755 048
756 568
'. -
GROMMET (217-00100)
WHEEL HALF ASSEMBLY - Inner (161-55)
1
1
1
-6 757 831 -
' ' CUP Bearing (08231) 1
-7 756 007 -
RING Grease seal (153-8) 4
-8 754 804 -
FELT Grease seal (154-6) 2
-9 756 008 RING - Snap (155-2) 2
-10 750 063 ' BEARING -Cone (08125) 2
-11 407 565 ' WASHER -Wheel bolt (AN960-416) 6
-12 404 888 NUT - Wheel bolt (AN365-428) 3
-13 400015 -
BOLT Wheel (AN4-22A) 3

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1E9
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 25. Nose Wheel Assembly (McCauley)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 25

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
WHEEL ASSEMBLY Nose (D-30500)
' WHEEL - Half (C-30598)
* CUP - Bearing (A-30078-1)
-
BEARING Cone (A-30078-2)
RETAINER - (A-30048)
-
* FELT (A-30047)
-
RING Retaining (A-1636-23)
BOLT - (A-2513-73)
' WASHER - (A-1638-1 )
' NUT - (A-1639-1)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1E12
 PIPER AIRCRAFT
PA-28-1 51f161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 26. Main Gear Installation

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FlGURE 26

A - See Figure 27 for component parts.

B - See Figure 28 for component parts.
C - Used on PA-28-151, and PA-28-161with serial numbers 28-7716001 thru 28-7816253. Order Greaser Bolt Replacement Kit 760 910
if shoulder bolt is installed.
D - Used on PA-28-151, and PA-28-161 with serial numbers 28-7716001 thru 28-7716150.
E - Used on PA-28-151, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.
F -
G - Used on PA-28-151, and PA-28-161with serial numbers 28-7716001 thru 28-7816253.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Main Gear Installation

-
GEAR ASSEMBLY Main, left (less tire, tube, wheel
and brake assembly)
-
GEAR ASSEMBLY Main, right (less tire, tube, wheel
and brake assembly) 1
* STUB AXLE AND OLEO PISTON ASSEMBLY - Left 1
STUB AXLE AND OLEO PISTON ASSEMBLY Right - 1
WASHER - Torque link bolt 2
LINK ASSEMBLY - Toque 2
' ' FITTING - Lubricator (AN944-101) 2
' CYLINDER 1
' RING - Piston spacer 1
' RETAINING RING - Piston 1
' RING - Scraper (AN6231-18) 1
PACKING - Quad ring (4326) 1
-
GASKET Air valve (AN901-5A) 1
D PACKING - 0 Ring (MS28775-218) 1
^ ORIFICE ASSEMBLY 1
'CAP - (AN813-18) Air valve 1
VALVE - (AN812-I) Air 1
-
CORE (AN809-1) Air valve 1
'WASHER - Bearing (.063 thick) 4
* WASHER - Bearing (.005 thick) AR
' CYLINDER HEAD 1
SPACER - Torque link 2
G -
FITTING Lubricator (AN944-101) 1
' WASHER - (AN960-516) 3
WASHER - (AN960-516L) AR
* WASHER -Torque link spacer 1
* WASHER - Toque link bolt 2
BOLT - (AN74-A3) 6
C * BOLT - Main gear toque 1
BOLT - Main gear toque (AN8-21) 1 28-7816254 and up
NUT - (AN310-8) 1
WASHER - (AN960-816L) 2
' WASHER (AN960-816) - 1
COTTER PIN (MS24665-283) - 1
-
BOLT (AN5-22) 1
* WASHER - (AN960-516) 3
* WASHER (AN960-516L) - 3
-
NUT (AN310-CS) 1
-
' PIN Cotter (MS24665-151) 1
-
* BOLT (AN5-23) 1
* WASHER - (AN960-516) AR
* WASHER (AN960-516L) - AR
* NUT - (AN310-C5) 1
-
' PIN Cotter (MS24665-151) 1
SPACER Wheel (SO wide)- 1
WASHER (MS15795-804) - 2
PIN - Cotter (MS24665-132) 2
BOLT - (AN4-11A) 4
WASHER - (AN960-416) 4
NUT - (MS20365-428C) 4
SCREW - (AN525-416-20) 4
WASHER (AN960-416) - 4
NUT - (MS20365-428C) 4

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

1E15
 PIPER AIHGHAt I
PA-28-15111 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

SCREW - (MS35206-228) 3
WASHER (AN960-6)- 6
-
NUT (MS20365-632C) 3
A -
WHEEL ASSEMBLY (6.00 x 6) (40-868) 2
B BRAKE ASSEMBLY - (30-55) 2
TIRE - (6.00 x 6, 4 ply) B. F. Goodrich 2
TIRE - (6 00 x 6, 4 ply) McCreary Airhawk 2
-
TUBE (6.00 x 6) 2
-
HOSE Brake line 1
E -
BRACKET ASSEMBLY Wheel fairing. left 1
E -
BRACKET ASSEMBLY Wheel fairing, right 1
-
BRACKET ASSEMBLY Wheel fairing, left 1 28-7816001 and up
-
BRACKET ASSEMBLY Wheel fairing, right 1 28-7816001 and up
CLIP - Hose, top and bottom 2
CLIP - Hose, center 1
-
NUT Wheel retainer 1
SPACER - Main gear axle (153 wide) 1
-
PIN Clevis (AN392-53) 2
BOLT - (AN4-6A) 6
WASHER - (AN960-416) 9
NUT - (H10-4) 6
BOLT - (AN4-6A) 2
WASHER - (AN960-416) 2
NUT - (MS20365-428C) 2
ELBOW - (AN822-4D) 2
-
BOLT (AN4-6A) 6
WASHER - (AN960 416) 9
E NUT - (MS20364-428C) 6
-
NUT (HIO-4) 6 28-7816001 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1E16
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 27. Main Wheel Assembly

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-151M 61 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 27

ReissuedDecember 1, 1989
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affecdd
Number

-
WHEEL ASSEMBLY Main (40-868) 2
WHEEL HALF ASSEMBLY - Inner (161-47) 1
CUP - Bearing (13836) 1
' WASHER -Wheel bolt (AN960-516) 3
WHEEL HALF ASSEMBLY -Outer (162-45) 1
-
* * CUP Bearing (13836) 1
-
* BEARING Cone, tirnken (13889) 2
DISC ASSEMBLY - Brake (164-20) 1
RING - Grease seal (153-4) 2
' FELT - Grease seal (3021) 1
' RING - Snap (3023) 2
' RING - Grsase seal (153-4) 1
FELT - Grease seal (3021) 1
-
RING Grease seal (153-4) 1
-
' NUT Wheel bolt (AN365-524) 3
-
' BOLT Wheel (AN5-35A) 3
SHIELD - Dust, wheel cover 2 28-7716001 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1E19
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 28. Brake Assembly

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 28

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

BRAKE ASSEMBLY (30-55) -

-
CYLINDER Brake (61-21)
PISTON - (62-15)
-
O-RING (AN6227-27)
-
BOLT Anchor (69-4)
NUT - Anchor bolt (MS20364-428C)
WASHER -Anchor bolt (AN960-416L)
SCREW - Bleeder (FC6446)
SEAT - Bleeder (37-206)
-
CAP Bleeder (183-1)
TORQUE PLATE ASSEMBLY - (75-16)
-
PLATE ASSEMBLY Pressure (73-11)
-
PLATE Pressure (63-12)
LINING - (66-30)
RIVET - (561)
PLATE ASSEMBLY - Back (74-10)
PLATE - Back (64-15)
LINING - (66-30)
RIVET - (561)
-
BOLT Through (LP4-17AM)
WASHER - Through bolt (AN960-416L)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1E22
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 29. Main and Nose Wheel Fairing Installation

(28-7415001 and up, and 28-7716001 thru 28-7716323)

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 29

A - Used on PA-28-151 with serial numbers 28-7415041 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Re% Affected
Number

DRAWING Nose Wheel Fairing Installation

DRAWING Main Wheel Fairing Installation

FAIRING ASSEMBLY - Nose wheel

-
COVER Nose wheel fairing
BOLT - (AN4-11A)
-
WASHER (AN960-416)
SCREW - (AN526 832-Re)
NUT - (P510062-5-4)
FAIRING ASSEMBLY - Main wheel, left
FAIRING ASSEMBLY - Main wheel, right
SUPPORT ASSEMBLY - Wheel fairing, main
BOLT - (AN4-6A)
WASHER - (AN960-416)
BRACKET ASSEMBLY -Wheel fairing, left
BRACKET ASSEMBLY - Wheel fairing, right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1F1
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 30. Main and Nose Wheel Fairing Installation

(28-7816001 and up)

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 30

A - Ascertain if main landing gear fiberglass wheel and strut fairing replacement kit 763 918 has been installed on serial numbers
28-7816001 thru 28-7916228per Service Letter 862.(New fiberglass fairings are identified by camloc fasteners attaching inner and
outer fairing halves together. Obsolete cycolac fairings are identified by screws, washers and nuts attaching inner and outer fairing
halves together). If Kit 763 918 has been installed per Service Letter 862,order individual items listed for serial numbers 28-7916229
and up as desired. If Kit 763 918 has not been installed on serial numbers 28-7816001thru 28-7916228,and individual items are
desired for a particular wheel, one of the following Main Landing Gear Fiberglass Wheel and Strut Fairing Kits must be ordered as a
replacement: 763 956 for left wheel or 763 957 for right wheel After above listed KiUKits have been installed on aircraft, order individual
fiberglass items listed for serial numbers 28-7916229and up, as desired.
B - Used with cycolac fairing assemblies only.
C - Used with fiberglass fairing assemblies only.
D - Used if nose gear fairing incorporates a door assembly in side of wheel fairing.
E - Used if nose gear fairing does not incorporate a door assembly in side of wheel fairing.
F - Ascertain material thickness of fairing currently installed on aircraft If existing fairing measures .093thick, a complete new fairing
assembly PIN 37893-02must be ordered and installed. If existing fairing measures .l25thick, order individual fairing as desired.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Main Wheel Fairing Installation (Fiberglass)

DRAWING - Nose Wheel Fairing Installation

FAIRING ASSEMBLY - Nose wheel (fiberglass) 1

DOOR ASSEMBLY -Wheel fairing 1
' HINGE ASSEMBLY - Door 1
-
' ' LATCH Door (KM610-32) 1
-
FAIRING ASSEMBLY Nose gear strut 1
-
FAIRING Nose gear strut, forward 1
FAIRING - Nose gear strut, aft 1
SCREW - (MS24693-S51) 6
WASHER - (PS10092-1-2C) 6
-
NUT (PSI 0062-5-3) 6
COVER - Nose wheel fairing. forward 1
-
COVER Nose wheel fairing, forward 1
COVER - Nose wheel fairing, aft I
COVER - Nose wheel fairing, aft 1
FAIRING ASSEMBLY - Main wheel, left, complete (fiberglass) 1 28-7916229 and up
FAIRING ASSEMBLY - Main wheel, right, complete (fiberglass) 1 28-7916229 and up
SHELL ASSEMBLY - Main wheel, outboard, left (fiberglass) 1 28-7916229 and up
SHELL ASSEMBLY - Main wheel, outboard, right (fiberglass) 1 28-7916229 and up
ACCESS ASSEMBLY - Main wheel, inboard, left (fiberglass) 1 28-7916229 and up
' ACCESS ASSEMBLY - Main wheel, inboard, right (fiberglass) 1 28-7916229 and up
PLACARD - 3 r e pressure 1
' DOOR ASSEMBLY - Wheel fairing 1
* ' HINGE ASSEMBLY - Door 1
* ' LATCH - Door (KM610-32) I
* SCREW - (MS24693-S50) 26
* WASH ER - (PS10092-1-2C) 26
NUT - (PSI 0062-5-3) 26
STUD - (PSl0077-I -9) 15
' SEAL - Washer (85-43-201-38) 15
RETAINER - (PS10077-1-66) 15
RECEPTACLE - (PS10017-1-63) 15
FAlRlNG ASSEMBLY - Main gear strut, left, complete
(fiberglass) 1 28-7916229 and up
FAIRING ASSEMBLY - Main gear strut, right, complete
(fiberglass) 1 28-7916229 and u p
FAIRING ASSEMBLY - Main gear strut, forward, left
(fiberglass) 1 28-7916229 and up
' FAIRING ASSEMBLY - Main gear, strut, forward, right
(fiberglass) 1 28-7916229 and up
-
FAIRING ASSEMBLY Main gear strut, aft, lefl (fiberglass) 1 28-791 6229 and up
* FAlRlNG ASSEMBLY - Main gear strut, aft, right (fiberglass) 1 28-7916229 and up
-
SCREW (PSlOOl5-F8-16BL) 8
-
WASHER (PSlOO92-1-3C) 8
-
NUT (PS10062-5-9) 8
STUD - (PS10077-1-8) 8
' SEAL - Washer (85-43-201-38) 8
' RETAINER - (PS10077-1-66) 8
RECEPTACLE - (PS10077-1-63) 8
PLACARD - Gear 1
-
SUPPORT ASSEMBLY Wheel fairing. main (1.44 long) 2
-
SUPPORT ASSEMBLY Wheel fairing, main (1.62 long) 2
SPRING - Nose gear 2
ANGLE - Nose gear spring attachment 2
-
BUSHING Nose gear spring 2
-
SCREW (MS24693-5273) 4
-
WASHER (PS10092-1-3C) 4
BOLT - (AN4-7A) 2
WASHER - (AN960-416) 2

When ordering, always specify Part Number, Description. and Serial Number of Aircraft

Reissued: December 1,1989

1 F4
 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

B -
BOLT Main wheel fairing attachment (3.96 long)
C BOLT - Main wheel fairing attachment (4 22 long)
WASHER (AN960-416)-
-
NUT (MS20365-428C)
WASHER (AN970-4) -
-
NUT (MS20365-428C)
-
SCREW (MS24693-S51)
-
WASHER (PS10092-12C)
-
BOLT (AN4-11A)
WASHER - (AN960-41-6L)
-
BOLT (AN3-4 1A)
WASHER - (AN960-10L)
-
NUT (MS20365-1032C)
WASHER - Nose gear spring
-
SCREW (MS35206-245)
WASHER - (AN960-8)
-
NUT (MS20365-832C)
C PLACARD -Oleo service instructions
BRACKET ASSEMBLY - Wheel fairing, left
BRACKET ASSEMBLY - Wheel fairing, right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1F5
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 31. Main Landing Gear Strut Fairing Installation

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 31

A - See Figure 30 for main gear strut fairings on the PA-28-161 with serial numbers 28-7816001 and up when main wheel fairings are
installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

31- 65693 DRAWING - Strut Fairing Installation, Main Landing Gear

FAIRING ASSEMBLY - Main gear

' MOULDING - Extruded
-
PLATE ASSEMBLY Fairing, left
-
PLATE ASSEMBLY Fairing, right
-
' PLATE Fairing, left
-
' PLATE Fairing, right
' MOULDING - Extruded
-
CLIP Fairing
PLACARD - Oleo service instructions
CLIP - Fairing
SCREW - (AN526-832R8)
SCREW - (8 x 112)
-
NUT (NAS395-17-1)
SCREW - (AN526C-632-5)
WASHER - (AN960-6)
NUT - (MS20365-632C)

When ordering, always specify Part Number, Description, and Setial Number of Aircraft

Reissued: December 1,1989

1 F8
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 32. Hand Brake installation

Reissued: December 1. 1989

1 F9
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 32

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Hand Brake Installation

CYLINDER ASSEMBLY Master (10-22) -

'HYDRAULIC CYLINDER ASSEMBLY - (189-9)
'PISTON HOD ASSEMBLY (182-7) -
"ROD - Piston (142 9)
"RING - Snap (155-10)
"GLAND - Packing (141-10)
"PACKING - 0-Ring (AN6227-7)
"PACKING - 0-Ring (AN6227-12)
'"WASHER - Dyna-seal(ll0 x 3/16)
**PISTON ASSEMBLY - (92-19)
"'PISTON - (48-10)
'**PACKING - 0-Ring (AN6227-11)
^'BUSHING (145-15) -
"SPRING - (82-8)
"RING - Snap (155-5)
**SPRING - (82-9)
"'WASHER - (ANg60-616)
"ROLL PIN (223-1) -
RESERVOIR ASSEMBLY - Brake cylinder
LINE ASSEMBLY
LlNE ASSEMBLY - Right
LlNE ASSEMBLY
LlNE ASSEMBLY
HOSE ASSEMBLY - Flexible
HOSE - Flexible
NUT - (AN924-4D)
SPRING - Brake handle
HANDLE ASSEMBLY - Brake
KNOB ASSEMBLY Parking brake -
LATCH ASSEMBLY Brake handle -
-
GRIP Brake handle
BUSHING
DISC - Firewall seal
CLAMP - (SAE NF-4)
ELBOW - (AN821-4D)
ELBOW - (AN822-4D)
ELBOW (AN837-4D) Left-
-
UNION (AN832-4D) Right
UNION (AN815-4D) -
ELBOW - (AN837-4D)
PIN - (AN393-19)
WASHER - (AN960-10L)
PIN - Cotter (MS24665-132)
BOLT (AN4 20)-
WASHER (AN960-416) -
-
NUT (AN310-4)
-
PIN Cotter (MS24665-132)
-
BOLT (AN23-24A)
NUT - (MS20365-1032C)
SCREW - (AN526-1032R6)
WASHER (AN935-10L) -
SCREW (AN520-10R8) -
WASHER - (AN960-10L)
WASHER - (AN960-10)

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1,1989

1 F11
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 33. Toe Brake installation

Reissued: December 1, 1989

1 F12
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 33

A - See Figure 34 forcomponent parts.

B - No longer available. Order Master Cylinder Assembly part number 455 968 (Cleveland 10-30) or 455 944 (Gar-Kenyon 17000) as a
replacement.

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Control System Installation

-
DRAWING Dual Toe Brake Line Installation

A,B CYLINDER ASSEMBLY - Master (10-27) Cleveland

A CYLINDER ASSEMBLY - Master (10-30) Cleveland
A CYLINDER ASSEMBLY - Master (17000) Gar-Kenyon
HOSE ASSEMBLY - Flexible
-
HOSE ASSEMBLY Flexible
-
HOSE ASSEMBLY Flexible
UNION - (AN815-4D)
-
PEDAL ASSEMBLY Toe brake, left
PEDAL ASSEMBLY - Toe brake, right
PAD ASSEMBLY - Brake pedal
BRACE ASSEMBLY -Toe brake
BRACKET - Toe brake
ARM - Toe brake
ARM - Toe brake
-
ARM Toe brake
TEE - (MS20825-4D)
CLEVIS ASSEMBLY - Toe brake
SPACER - Toe pedal
BEARING - Brake pedal (PS10065-37)
PIN - Flat head (MS20392-2C17)
WASHER - (AN960-10)
COTTER PIN - (MS24665-132)
PIN - Flat head (MS20392-2C25)
WASHER - (AN960-10)
COTTER PIN - (MS24665-132)
PIN - Flat head (MS20392-2C31)
WASHER - (AN960-10)
-
COTTER PIN (MS24665-132)
PIN - Flat head (MS20392-2C39)
WASHER - (AN960-10)
COTTER PIN - (MS24665-132)
-
ELBOW (AN914-1D)
-
ELBOW (MS20882-4D)
-
ELBOW (MS20823-4D)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1F14
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 34. Toe Brake Master Cylinder Assembly

Reissued: December 1, 1989

1 F15
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 34

A - No longer available. Order Master Cylinder Assembly Part Number 455 968 (Cleveland 10-301 or 455 944 (Gar-Kenyon 17000) as a
replacement

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

CYLINDER ASSEMBLY - Master (10-27) Cleveland

PISTON ROD ASSEMBLY (182-01100) -
* ROLL PIN - (223-00600)
SPRING (082-02100) -
* O-RING - (AN6227-8)
' WASHER Seal (095-25200)-
PISTON (148-01200) -
-
0-ING (AN6227-7)
'O-RING - (AN6227-11 )
SPRING (82-9) -
WASHER (095-10100) -
* ROLL PIN - (223-00500)
* RETAINING RING - (155-01200)
-
' GLAND Packing (141-01200)
-
* WASHER Wiper (095-01300)
CYLINDER ASSEMBLY - Master (17000) Gar-Kenyon
PISTON ROD AND RING ASSEMBLY - (95404) includes
spring retaining ring
SPRING - (17005)
SPRING - (17006)
-
PISTON (17003)
SLEEVE (17007)-
* O-RING - (MS28775-113)
- O-RING - (MS28775-012)
' O-RING - (MS28775-110)
FITTING - (17002)
-
SEAL (110-3116)
' RING - Retaining (XRC-313)
CYLINDER ASSEMBLY - Master (10-30) Cleveland
' RING - Snap (155-47)
PISTON ROD ASSEMBLY (182-22) -
O-RING - (101-1)
ROLL PIN (223-00500) -
WASHER (095-10100) -
SPRING - (82-9)
-
' GLAND Packing (141-25)
-
* ' O-RING (101-01100)
-
' * O-RING (l(11-00800)
* WASHER - Wiper (095r01300)
-
SPRING (082-02100)
PISTON - (148-25)
BUSHING (145-58) -
' * RING - Snap (T5304-15)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1 F17
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

THE PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 35. Cockpit Finishing Installation

Reissued: December 1,1989

IF19
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 35

Used i f aft fresh air vent is no. ..,stalled.

Used i f aft fresh air vent is installed.
Used if overhead fresh air vent system is installed.
When ordering, specify color red, bluelgreen, gold, black, green or bark Specify color bark I when ordering for PA-28-151 with serial
numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716075. Specify color bark I1 for PA-28-161
with serial numbers 28-7716076 and up.
When ordering, specify color red, bluelgreen, gold, black, green or bark 11.

Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7515004 and up. and PA-28-161.
Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161.
When ordering for PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru
28-7716075, specify color bark I. When ordering for PA-28-161 with serial numbers 28-7716076 and up, specify color bark II or
black.
Used on PA-28-161 if air cond~tioningis installed.
When ordering, specify color bark 11 or black.
Used on PA-28-151 with serial numbers 28-7715001 and up,. - d PA-28-161 with seriabnumbers 28-7716001 thru 28-7716323.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916617.
Used if shoulder belts with inertia reel are installed.
Used if fixed shoulder hamesses are installed.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8016382.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8116213.
Used if Luxurious lnterior is not installed.
Used on serial numbers 28-8116214 and up. Also used on serial numbers 28-8016001 thru 28-8116213 if Luxurious lnterior is
installed.
Used on serial numbers 28-8116214 and up. Also used on serial numbers 28-8116001 thru 28-8116213 if Luxurious lnterior is
installed.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
Used on serial numbers 28-8116214 thru 28-8216236. Also used on serial numbers 28-8016001 thru 28-8116213 if Luxurious lnterior
is installed.
Used on serial numbers 28-8116214 thru 28-8216236. Also used on serial numbers 28-8116001 thru 28-8116213 if Luxurious Interior
is installed.
Used if air conditioning is not installed.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-151M 61 WARRIOR
AIRPLANE PARTS CATALOG
-igure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Cockpit Finishing Installation

H DRAWING - Cockpit Finishing Installation
DRAWING - Side Panel Installation
DRAWING - Sun Visor Installation

COVER ASSEMBLY - Flap handle

-
COVER Console
COVER - Console, white
COVER - Console
-
COVER ASSEMBLY Engine controls, red
COVER ASSEMBLY - Engine controls, tan
COVER ASSEMBLY - Engine controls, btadc
-
COVER ASSEMBLY Engine controls, green
COVER ASSEMBLY - Engine controls, white
COVER ASSEMBLY - Engine controls. bluelgreen
COVER ASSEMBLY - Engine controls
COVER ASSEMBLY - Engine controls
PLACARD - Engine controls
COVER ASSEMBLY - Shoulder harness. !eft
COVER ASSEMBLY - Shoulder harness, left
COVER ASSEMBLY - Shoulder hamess, right
COVER ASSEMBLY - ShouMer hamess. right
COVER ASSEMBLY - Trim, red
COVER ASSEMBLY - Trim, brown
COVER ASSEMBLY - Trirn, black
COVER ASSEMBLY - Trim, green
-
COVER ASSEMBLY Trim, bluelgreen
COVER ASSEMBLY - Trirn
COVER ASSEMBLY - Fuel selector
COVER ASSEMBLY - Fuel selector, white
COVER - Inboard
-
COVER Cowl
HEADLINER - Cockpit (464 385)
PANEL ASSEMBLY - Left front cockpit, red
PANEL ASSEMBLY - Left front cockpit, blueigreen
-
PANEL ASSEMBLY Left front cockpit, gold
PANEL ASSEMBLY - Left front cockpit. bkdc
-
PANEL ASSEMBLY Left front cockpit. white
-
PANEL ASSEMBLY Left front cockpit. green
PANEL ASSEMBLY - Left front cockpit. red
PANEL ASSEMBLY - Left front cockpit, bfuefgreen
-
PANEL ASSEMBLY Left front cockpit, gdd
-
PANEL ASSEMBLY Left front cockpit, black
-
PANEL ASSEMBLY Left front cockpit, white
-
PANEL ASSEMBLY Left front cockpit. g m
PANEL ASSEMBLY - Left front cockpit, mushroom/black
(with black carpet)
-
PANEL ASSEMBLY Left front cockpit, mushroomhlack
(with heather carpet)
PANEL ASSEMBLY - Left front cockpit, camellblack
(with black carpet)
PANEL ASSEMBLY - Left front cockpit, camehlack
(with heather carpet)
PANEL ASSEMBLY - Left front cockpit, camel/black
(with heather carpet)
-
PANEL ASSEMBLY Left front cockpit, cameVblack
(with black carpet)

When ordering, always specify Part Number. Description. and Serial Number of Aircraft

Revised: July 30, 1994

1F21
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

PANEL ASSEMBLY - Left front cockpit, firethorn red

(with heather carpet) 1
PANEL ASSEMBLY - Left front cockpit, firethom red
(with raspbeny carpet) 1
-
PANEL ASSEMBLY Left front cockpit, firethom red
(with firethorn red carpet)
PANEL ASSEMBLY - Left front cockpit, buckskin (with
brown carpet) 1
-
PANEL ASSEMBLY Left front cockpit, buckskin (with
medium saddle carpet)
-
PANEL ASSEMBLY Left front cockpit, dark blue
(with heather carpet) 1
PANEL ASSEMBLY - Left front cockpit, dark blue (with
dark blue carpet)
PANEL ASSEMBLY - Left front cockpit, light blue (velour)
(with light blue carpet) 1 28-8316001 and up
PANEL ASSEMBLY - Left front cockpit, dark cedar (with
dark cedar carpet) (knit)
PANEL ASSEMBLY - Left front cockpit, dark cedar (with dark
cedar carpet) (velour) 1 28-8216001 and up
PANEL ASSEMBLY - Left front cockpit, dark carmine (with dark
carmine carpet) (velour) 1 28-8216001 and up
PANEL ASSEMBLY - Left front cockpit, sandalwood (with dark
saddle carpet) (fabric) 1 28-8216001 and up
PANEL ASSEMBLY - Left front cockpit, dark saddle (fabric)
(w~thdark saddle carpet) 1 28-8316001 and up
-
PANEL ASSEMBLY Right front cockpit, red 1 28-7415001 t h 28-761
~ 5001
PANEL ASSEMBLY - Right front cockpit, bluetgreen 1 28-7415001 thrU 28-7615001
-
PANEL ASSEMBLY Right front cockpit, gold 1 28-7415001 t h r ~
28-7615001
-
PANEL ASSEMBLY Right front cockpit, black 1 28-7415001 t h 28-761
~ 5001
-
PANEL ASSEMBLY Right front cockpit, white 1 28-7415001 thm 28-7415713
PANEL ASSEMBLY - Right front cockpit, green 1 28-7615001
28-7415001 t h r ~
PANEL ASSEMBLY - Right front cockpit, red 1 28-7615002 t h 28-761
~ 5445
-
PANEL ASSEMBLY Right front cockpit, bluelgreen 1 28-7615002 t h 28-761
~ 5445
PANEL ASSEMBLY - Right front cockpit, gold 1 28-7615002 t h 28-761
~ 5445
-
PANEL ASSEMBLY Right front cockpit, black 1 28-7615002 t h 28-761
~ 5445
-
PANEL ASSEMBLY Right front cockpit, green 1 28-7615002 t h r ~
28-7615445
PANEL ASSEMBLY - Right front cockpit, red 1 28-7415001 t h r ~
28-7615001
-
PANEL ASSEMBLY Right front cockpit, bluelgreen 1 28-7415001 t h 28-7615001
~
-
PANEL ASSEMBLY Right front cockpit, gold 1 28-7415001 t h 28-7615001
~
PANEL ASSEMBLY - Right front cockpit, black 1 28-7415001 thrU 28-7615001
-
PANEL ASSEMBLY Right front cockpit, white 1 28-7415001 t h 28-741
~ 5713
-
PANEL ASSEMBLY Right front cockpit, green 1 28-7415001 t h 28-7615001
~
-
PANEL ASSEMBLY Right front cockpit, red 1 28-7615002 t h 28-761
~ 5445
-
PANEL ASSEMBLY Right front cockpit, bluelgreen 1 28-7615002 t h 28-761
~ 5445
-
PANEL ASSEMBLY Right front cockpit, gold 1 28-7615002 t h 28-7615445
~
-
PANEL ASSEMBLY Right front cockpit, black 1 28-7615002 t h r ~
28-7615445
-
PANEL ASSEMBLY Right front cockpit, green 1 28-7615002 t h 28-7615445
~
-
PANEL ASSEMBLY Right front cockpit. mushroom (with
black carpet)
-
PANEL ASSEMBLY Right front cockpit, mushroom (with
heather carpet)
PANEL ASSEMBLY - Right front cockpit, camel~black
(with black carpet)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1 F22
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Numbet Code Nomenclature Req. Affected
Number

35-11 -
PANEL ASSEMBLY Right front cockpit. camel/black (with
heather carpet) 1
-
PANEL ASSEMBLY Right front cockpit, firethom red (with
heather carpet) 1
-
PANEL ASSEMBLY Right front cockpit, firethom red (with
raspberry carpet) (luxurious) 1
-
PANEL ASSEMBLY Right front cockpit, firethom red (with
firethorn red carpet) 1
PANEL ASSEMBLY - Right front cockpit, buckskin (with
brown carpet)(luxurious) 1
-
PANEL ASSEMBLY Right front cockpit, buckskin (with
medium saddle carpet) 1
-
PANEL ASSEMBLY Right front cockpit, dark blue (with
heather carpet) 1
PANEL ASSEMBLY - Right front cockpit, dark blue, (with dark
blue carpet) 1
PANEL ASSEMBLY - Right front cockpit. light blue (velour)
(with light blue carpet) 1 28-8316001 and up
PANEL ASSEMBLY - Right front cockpit, dark cedar (with dark
cedar carpet) (knit) 1
-
PANEL ASSEMBLY Right front cockpit, dark cedar (with dark
cedar carpet) (velour) 1 28-8216001 and up
PANEL ASSE M BLY - Right front cockpit, dark canni ne (with
dark carmine carpet) (velour) 1 28-8216001 and up
-
PANEL ASSEMBLY Right front cockpit, sandalwood (with dark
saddle carpet) (fabric) 1 28-8216001 and up
PANEL ASSEMBLY - Right front cockpit, dark saddle (with
dark saddle carpet) 1 28-8316001 and up
-
* PLATE Placard attachment, left 1 28-7816001 t h 28-7916617
~
-
PANEL ASSEMBLY Left rear cockpit, red 1 28-7415001 t h f ~
28-7615445
PANEL ASSEMBLY - Left rear cockpit, bluelgreen 1 28-7415001 t h 28-761
~ 5445
-
PANEL ASSEMBLY Left rear cockpit, gold 1 28-7415001 t h 28-761
~ 5445
PANEL ASSEMBLY - Left rear cockpit, black 1 28-7415001 t h 28-7615445
~
-
PANEL ASSEMBLY Left rear cockpit, white 1 28-7415001 thN 28-7415713
-
PANEL ASSEMBLY Left rear cockpit, green 1 28-7415007 thN 28-7615445
-
PANEL ASSEMBLY Left rear cockpit, rnushroorn/black 1
-
PANEL ASSEMBLY Left rear cockpit, camelhlack 1
-
PANEL ASSEMBLY Left rear cockpit, white/camel/black 1
PANEL ASSEMBLY - Left rear cockpit, firethorn red 1
-
PANEL ASSEMBLY Left rear cockpit, firethom red (vinyl) 1
-
PANEL ASSEMBLY Left rear cockpit, firethom red (fabric) 1
PANEL ASSEMBLY - Left rear cockpit, red (vinyl) 1 28-8316001 and up
-
PANEL ASSEMBLY Left rear cockpit, buckskin (fabric) 1
-
PANEL ASSEMBLY Left rear cockpit, light buckskin (vinyl) 1 28-8316001 and up
PANEL ASSEMBLY - Left rear cockpit, dark blue 1 28-8116001 t h 28-8116213
~
-
PANEL ASSEMBLY Left rear cockpit, dark blue (vinyl) 1
-
PANEL ASSEMBLY Left rear cockpit, dark blue (fabric) 1
-
PANEL ASSEMBLY Left rear cockpit, light blue (velour) 1 28-8316001 and up
-
PANEL ASSEMBLY Left rear cockpit, blue (vinyl) 1 28-8316001 and up
-
PANEL ASSEMBLY Left rear cockpit, dark cedar (knit) 1
-
PANEL ASSEMBLY Left rear cockpit dark cedar (velour) 1 28-8216001 and up
PANEL ASSEMBLY - Left rear cockpit, dark carmine (velour) 1 28-821 6001 and up
PANEL ASSEMBLY - Left rear cockpit, sandalwood (fabric) 1 28-8216001 and up
-
PANEL ASSEMBLY Left rear cockpit, dark saddle (fabric) 1 28-8316001 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

1 F23
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

35-13 PANEL ASSEMBLY - Right rear cockpit, red

-
PANEL ASSEMBLY Right rear cockpit, bluekreen
-
PANEL ASSEMBLY Right rear cockpit, gold
PANEL ASSEMBLY - Right rear cockpit, black
PANEL ASSEMBLY - Right rear cockpit, white
-
PANEL ASSEMBLY Right rear cockpit, green
-
PANEL ASSEMBLY Right rear cockpit, mushroom/black
PANEL ASSEMBLY - Right rear cockpit, camelhlack
PANEL ASSEMBLY - Right rear cockpit, white/camelhlack
-
PANEL ASSEMBLY Right rear cockpit, firethorn red
-
PANEL ASSEMBLY Right rear cockpit, firethorn red
(luxurious)
PANEL ASSEMBLY - Right rear cockpit, firethorn red (vinyl)
PANEL ASSEMBLY - Right rear cockpit, firethorn red (fabric)
PANEL ASSEMBLY - Right rear cockpit, red (vinyl) 28-8316001 and up
PANEL ASSEMBLY - Right rear cockpit, buckskin (luxurious) 28-8016001 t h r ~28-8016382
PANEL ASSEMBLY - Right rear cockpit, buckskin (fabric)
-
PANEL ASSEMBLY Right rear cockpit, light buckskin (crinyl) 28-8316001 and up
-
PANEL ASSEMBLY Right rear cockpit, dark blue 28-8116001 t h 28-8116213
~
PANEL ASSEMBLY - Right rear cockpit, dark blue (vinyl)
PANEL ASSEMBLY - Right rear cockpit, dark blue (fabric)
PANEL ASSEMBLY - Right rear cockpit, light blue (velour) 28-8316001 and up
-
PANEL ASSEMBLY Right rear cockp~t,blue (vinyl) 28-8316001 and up
PANEL ASSEMBLY - Right rear cockpit, dark cedar (knit)
-
PANEL ASSEMBLY Right rear cockpit, dark cedar (velour) 28-8216001 and up
PANEL ASSEMBLY - Right rear cockpit, dark carmine (velour) 28-8216001 and up
-
PANEL ASSEMBLY Right rear cockpit, sandalwood (fabric) 28-8216001 and up
-
PANEL ASSEMBLY Right rear cockpit, dark saddle (fabric) 28-8316001 and up
HOUSING ASSEMBLY - Ash tray
-
BOX ASSEMBLY Ash tray (S-25-AR-C)
PAD - Armrest
PAD - Armrest, white
PAD - Armrest. mushroom
PAD - Armrest, camel
-
PAD Armrest, firethom red (vinyl) 28-8116001 thru 28-8216236
PAD - Armrest, firethom red (fabric) 28-8016001 and up
PAD - Armrest, firethom red (leather) 28-8316001 and up
PAD - Armrest, red (vinyl) 28-8316001 and up
-
PAD Armrest, buckskin (velour) 28-8016001 t h r ~
28-8216236
-
PAD Armrest, light buckskin (vinyl) 28-8316001 and up
PAD - Armrest, light buckskin (leather) 28-8316001 and up
PAD - Armrest, dark blue (vinyl) 28-8116001 t h 28-8216236
~
PAD - Armrest, dark blue (fabric) 28-801 6001 and up
-
PAD Armrest, dark blue (leather) 28-8316001 and up
PAD - Armrest, blue (vinyl) 28-8316001 and up
-
PAD Armrest, dark cedar (knit) 28-8116001 and up
-
PAD Armrest, dark cedar (velour) 28-8216001 t h 28-821
~ 6236
-
PAD Armrest, dark cedar (leather) 28-8316001 and up
-
PAD Armrest, dark carmine (velour) 28-8216001 thN 28-8216236
PAD - Armrest, sandalwood (fabric) 28-8216001 and up
-
PAD Armrest, patrician sandalwood (fabric) 28-8316001 and up
PAD - Armrest, dark saddle (knit) 28-8316001 and up
-
PAD Armrest, dark saddle (leather) 28-8316001 and up
BAR ASSEMBLY - TOW
-
GRILL ASSEMBLY Air exhaust

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1F24
 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

STRAP ASSEMBLY - Baggage tie down, black (tip end) 1

-
STRAP ASSEMBLY Baggage tie down, black (buckle end) 1
BULKHEAD ASSEMBLY Cabin, rear - 1
BULKHEAD ASSEMBLY - Cabin, rear 1
BULKHEAD ASSEMBLY - Cabin, rear 1 28-7816001 thtU 28-8016047
BULKHEAD ASSEMBLY Cabin, rear - 1 28-8016048 and up
* DOOR ASSEMBLY - Access cover 1
DOOR ASSEMBLY - Access cover 1 28-7816001 and up
-
HANDLE ASSEMBLY Fuel selector valve 1 28-7415001 thN 28-7515003
HANDLE ASSEMBLY - Fuel selector valve 1
BLADE - Sun visor 2
BLADE - Sun visor, copilot 1
BLADE - Sun visor, p~lot(with power setting table) 1 28-7715001 and up
BLADE - Sun visor, pilot (with power setting table) 1 28-7716001 t h 2816109
~
BLADE - Sun visor, p~lot(with power setting table) 1 2816110 and up
WINDLACING - Door seal 1
SILL - Door 1
SILL - Door 1
BLANKET - Firewall 1 28-7716001 t h 281
~ 6076
BLAtdKET - Firewall 1 2816077andup
' INSULATION - Firewall 1 2816077 and up
SHIELD - Flap handle cover 1
CUP - Air vent 4
CUP - Air vent, white 4
VENT ASSEMBLY - Air, forward, left (complete) 1
-
VENT ASSEMBLY Air, forward, right (complete) 1
VENT ASSEMBLY - Air, aft, left (complete) 1
VENT ASSEMBLY - Air, aft, right (complete) 1
GASKET Air vent assembly . 4
-
+

FLANGE Air vent 4

-
FLANGE Air vent, white 4
RETAINER - Sun visor 2
ROD - Sun visor 2
CLIP - Sun visor, upper left, lower right 2
CLIP - Sun visor, lower left, upper right 2
TRIM STRIP - Door frame, bottom, rear 1
TRIM STRIP - Door frame, bottom, rear 1
TRIM STRIP - Door frame, top. rear 1
TRIM STRIP - Door frame, top, rear 1
TRIM STRIP - Door frame, top, rear 1
-
TRIM STRIP Door frame, top, front 1
TRIM STRIP - Door frame, top, front 1
LOOP ASSEMBLY Assist - 1
-
DOUBLER Ash tray 2
-
CLIP Shoulder hamess retaining 1
CLIP - Shoulder hamess retaining 4
-
RETAINER Glare shield, left 1
RETAINER - Glare shield, right 1
ASH RECEIVER - (Complete) Chrome (2A20580) 2
-
BUTTON Plug 1
-
PLACARD Rudder trim 1
PLACARD - Operation limitations, mph 1
PLACARD - Operation limitations, knots 1
PLACARD - Operation limitations, knots 1
PLACARD - Operation limitations, knots 1 28-8016001 and up
BEARING - Sun visor 4

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1G I
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part NO. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

BOLT - (AN3-5A)
-
WASHER (AN960-10L)
BUSHING
STUD ASSEMBLY - Coat hanger (KM894-1A)
-
SCREW (MS51957-27)
-
WASHER (AN936-B6)
NUT - Dome (8061-NP)
-
SCREW Self tapping (4 x 114) (486 187)
-
BUTTON Plug (UCC-SS48179-K2215)
CAP - Assist strap
-
COVER Radio cooling trim
PLACARD - Cabin bulkhead
PLACARD - Stabilator trim
SCREW AND POST ASSEMBLY - Retainer
RIVET - Plastic (201-120751-00-0103)
SCREW - (AN530-10R36)

When ordering. always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1G2
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 36. Window Curtains Installation

(28-8016001and up)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR RGURE 36

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

36- 67955 DRAWING - Curtain and Rod Installation

CURTAIN ASSEMBLY -Window, center front, left

CURTAIN ASSEMBLY -Window, center front, right
CURTAIN ASSEMBLY - Window. center rear, left
CURTAIN ASSEMBLY -Window center rear, right
CURTAIN ASSEMBLY -Window, rear, left
-
CURTAIN ASSEMBLY Window, rear, right
CURTAIN ASSEMBLY - Window, rear, left
CURTAIN ASSEMBLY -Window, rear, right
ROD - Window curtain
BRACKET - Curtain rod attachment, front
BRACKET - Curtain rod attachment, center
BRACKET - Curtain rod attachment, rear
SCREW - (M535206-249)
NUT - (P510062-6-2)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
AIRPLANE PARTS CATALOG

Figure 37. Carpet Installation

Reissued: December 1,1989

1 G6
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 37

When ordering, specify color. For PA-28-151 with serial numbers 28-7415001 thru 28-7415713, specify color red, black, blue, fawn or
green. For PA-28-151with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 and up, specify color
heather, black, palm, raspberry, brown, dark blue, light blue, firethorn red, medium saddle, dark cedar, dark carmine, or dark saddle.
Used if sound reduction carpeting is installed.
>.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8016382.
Used on PA-28-151with serial numbers 28-7715001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8216236.

Used on PA-28-151with serial numbers 28-7515001 thru 28-7715314, and PA-28-161with serial numbers 28-7716001 thru
28-7816072.
Used on PA-28-151 with serial numbers 28-7715001 thru 28-7715314, and PA-28-161with serial numbers 28-7716001 thru
28-7816072.

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

37- 76 109 DRAWING - Cockpit Finishing Installation 28-7415001 thnt 28-7615445

79768 E -
DRAWING Cockpit Finishing Installation
66801 DRAWING - Baggage Compament Carpet hstallation

CARPET - Floor, front left, red 28-7415001 t h 28-7415713

~
CARPET - Floor, front left. black 28-7415001 thnt 28-7415713
CARPET - Floor, front left, blue 28-7415001 thnt 28-7415713
-
CARPET Floor, front left. fawn 28-7415001 t h 28-7415713
~
-
CARPET Floor, front left, green 28-7415001 thnt 28-7415713
CARPET - Floor, front left, red 28-7515001 thnt 28-7615445
CARPET - Floor, front left, black
-
CARPET Floor, front left, blue
-
CARPET Floor, front left, green
CARPET - Floor, front left, heather
CARPET - Floor, front left
-
CARPET Floor, front left, red 28-7515001 t h 28-7615445
~
CARPET - Floor, front left, black
CARPET - Floor, front left, blue 28-7515001 t h r ~28-7615445
-
CARPET Floor, front left, green 28-7515001 thnt 28-7615445
CARPET - Floor, front left, palm 28-8016001 thnt 28-8016382
CARPET - Floor, front left, raspberry 28-8016001 thnt 28-8016382
CARPET - Floor, front left, brown 28-8016001 thnt 28-8016382
CARPET - Floor, front left, dark blue 28-8016001 and up
CARPET - Floor, front left, light blue 268316001 and up
CARPET - Floor, front left, firethom red 28-8016001 and up
CARPET - Floor, front left, medium saddle 28-8016001 thnt 28-8216236
-
CARPET Floor, front left, dark cedar 28-8116001 and up
CARPET - Floor, front left, dark carmine 28-8216001 and up
-
CARPET Floor, front left, dark saddle 28-8216001 and up
CARPET ASSEMBLY - Floor, left front 2816093andup
CARPET - Floor, front right, red 28-7415001 thnt 28-7415713
-
CARPET Floor, fmnt right, black 28-7415001 thnt 28-7415713
CARPET - Floor, front right, blue 28-7415001 thrU 28-7415713
CARPET - Floor, front right, fawn 28-7415001 thnt 28-7415713
-
CARPET Floor, front right, green 28-7415001 thnt 28-7415713
CARPET - Floor, front right, red 28-7515001 thnt 28-7615445
CARPET - Floor, front right, black
-
CARPET Floor, fmnt right, blue 28-7515001 thnt 28-7615445
CARPET - Floor, front right, green 28-7515001 thnt 28-7615445
-
CARPET Floor, front right, heather
-
CARPET Floor, front right
-
CARPET Floor, front right, red
CARPET - Floor, front right, black
CARPET - Floor, front right, blue 28-7515001 thnt 28-7615445
CARPET - Floor, front right, green 28-7515001 t h 28-761
~ 5445
-
CARPET Floor, front right, palm 28-8016001 thnt 28-8016382
CARPET - Floor, front right. raspberry 28-8016001 t h 28-801
~ 6382
CARPET - Floor, front right, brown 28-8016001 t h 28-801
~ 6382
CARPET - Floor, front right, dark blue 288016001 and up
-
CARPET floor, front right, light blue 288316001 and up
-
CARPET Floor, front right, firethom red 28-8016001 and up
CARPET - Floor, front right, medium saddle 28-8016001 thnt 28-8216236
CARPET - Floor, front right, dark cedar 288116001 and up
-
CARPET Floor, front right, dark carmine 28-8216001 and up
-
CARPET Floor, front right, dark saddle 28-8216001 and up
CARPET ASSEMBLY - Floor, front left 2816093andup
CARPET - Floor, Sta. 74.00 thnt Sta. 105.00, outboard. red 28-7415001 thnt 28-7415713
CARPET - Floor, Sta. 74.00 thnt Sta. 105.00, outboard, black 28-7415001 thnt 28-7415713
CARPET - Floor, Sta. 74.00 thnt Sta. 105.00, outboard, blue 28-7415001 thnt 28-74157 13
CARPET - Floor, Sta. 74.00 thnt Sta. 105.00, outboard, fawn 28-7415001 thnt 28-7415713

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1G8
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

37-2 67905-06 -
CARPET Floor, Sta. 74.00 to Sta. 105.00, outboard, green 2
591 026 -
CARPET Floor, Sta. 74.00 to Sta. 105.00, outboard, red 2
591 027 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, black 2
591 028 -
CARPET Floor, Sta. 74.00 to Sta. 105.00, outboard, blue 2
591 030 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, green 2
591 501 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, heather 2
79236- 16 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard 2
591 275 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, red 2
591 276 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, black 2
591 277 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, blue 2 28-7515001 t h 28-761
~ 5445
591 279 -
CARPET Floor, Sta. 74.00 to Sta. 105.00, outboard, green 2 28-7515001 thN 28-7615445
591 620 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, palm 2 28-8016001 t h r ~28-8016382
591 622 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, raspberry 2 28-8016001 t h 28-801
~ 6382
591 623 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, brown 2 28-8016001 thN 28-8016382
591 806 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, dark blue 2 28-8016001 and up
592 078 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, light blue 2 28-8316001 and up
591 859 CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, firethorn
red 2 28-8016001 and up
CARPET - Floor. Sta. 74.00 to Sta. 105.00. outboard. medium
saddle 2
CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, dark
cMar 2 28-8116001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, dark
carmine 2 28-8216001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, outboard, dark
saddle 2 28-8216001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, red 2 28-7415001 t h r ~28-7415713
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, black 2 28-7415001 t h 28-7415713
~
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, blue 2 28-7415001 thrU 28-7415713
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, fawn 2 28-7415001 thN 28-7415713
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, green 2 28-7415001 thrU 28-7415713
CARPET - Floor, Sta: 74.00 to Sta. 105.00, center, red 2 28-7515001 t h 28-761
~ 5445
CARPET - Floor. Sta. 74.00 to Sta. 105.00. center, black 2
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, blue 2
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, green 2
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, heather 2
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center 2
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, red 2
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, black 2
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, blue 2 28-7515001 thN 28-7615445
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, green 2 28-7515001 t h 28-7615445
~
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, palm 2 28-8016001 thN 28-8016382
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, raspberry 2 28-8016001 thN 28-8016382
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, brown 2 28-8016001 thN 28-8016382
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, dark blue 2 28-8016001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, light blue 2 28-8316001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, firethorn
red 2 28-8016001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, medium
saddle 2 28-8016001 t h 28-821
~ 6236
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, dark cedar 2 28-8116001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, center, dark
carmine 2 28-8216001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, center, dark saddle 2 28-8216001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00. inboard, left, red 1 28-7415001 t h 28-7415713
~
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, black 1 28-7415001 t h 28-741
~ 5713
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, bl ue 1 28-7415001 thN 28-7415713
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, fawn 1 28-7415001 t h 28-7415713
~
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, green 1 28-7415001 t h 28-7415713
~
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, red 1 28-7515001 t h 28-7615445
~
D -
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, black 1
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, blue 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, green 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

37-4 591 549 E CARPET - Floor. Sta. 74.00 to Sta. 105.00, inboard, left,
heather 1
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, palm 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left,
raspberry 1
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, brown 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, dark
blue 1 28-8016001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, light
blue 1 28-8316001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left,
firethorn red 1 28-8016001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left,
medium saddle 1
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, left, dark
cedar 1 28-8116001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, dark
carmine 1 28-8216001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, left, dark
saddle 1 28-8216001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, red 1 28-7415001 thN 28-7415713
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right, black 1 28-7415001 t h 28-7415713
~
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, blue 1 28-7415001 t h 28-7415713
~
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, fawn 1 28-7415001 thN 28-7415713
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, green 1 28-7415001 t h 28-7415713
~
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, red 1 28-7515001 t h 28-761
~ 5445
D -
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right, black 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, blue 1
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right, green 1
E CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
heather 1
CARPET -Floor, Sta. 74.00 to Sta. 105.00, inboard, right, palm 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
raspberry 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
brown 1
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
dark blue 1 28-8016001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right, -
light blue 1 28-8316001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
firethorn red 1 28-8016001 and up
CARPET - Floor, Sta. 74.00 to Sta. 105.00, inboard, right.
medium saddle 1 28-8016001 t h 28-8216236
~
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
dark cedar 1 28-8116001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
dark carmine 1 28-8216001 and up
-
CARPET Floor, Sta. 74.00 to Sta. 105.00, inboard, right,
dark saddle 1 28-8216001 and up
CARPET - Tunnel, side, left, red 1 28-7415001 t h 28-7415713
~
-
CARPET Tunnel, side. left, black 1 28-7415001 thN 28-7415713
-
CARPET Tunnel, side, left, blue 1 28-7415001 thN 28-7415713
CARPET - Tunnel, side, left, fawn 1 28-7415001 t h 28-7415713
~
CARPET - Tunnel, side, left, green 1 28-7415001 thN 28-7415713
-
CARPET Tunnel, side, left, red 1 28-7515001 t h 28-7615445
~
D CARPET -Tunnel, side, left, black 1
CARPET -Tunnel, side, left, blue 1
CARPET - Tunnel, side, left, green 1
E CARPET - Tunnel. side. left. heather 1
CARPET - Tunnel, side, left, palm 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR

Figure
- AIRPLANE PARTS CATALOG

and Part No. Serial Numbers

Index Number Code Nomenclature Req, Affected
Number

-
CARPET Tunnel, side, left, raspberry 28-8016001 t h 28-8016382
~
CARPET -Tunnel, side, left, brown 28-8016001 @IN 28-8016382
-
CARPET Tunnel, side, left, dark blue 28-8016001 and up
-
CARPET Tunnel, side, left, light blue 28-8316001 and up
CARPET -Tunnel, side, left, firethom red 28-8016001 and up
CARPET - Tunnel, side, left, medium saddle 28-8016001 thN 28-8216236
-
CARPET Tunnel, side, left, dark cedar 28-8116001 and up
-
CARPET Tunnel, side, left, dark carmine 28-8216001 and up
-
CARPET Tunnel, side, left, dark saddle 28-8216001 and up
CARPET - Tunnel, side, right, red 28-7415001 thN 28-7415713
-
CARPET Tunnel, side, right, black 28-7415001 thN 28-7415713
CARPET -Tunnel, side, right, blue 28-7415001 thN 28-7415713
CARPET - Tunnel, side, right, fawn 28-7415001 t h 28-7415713
~
CARPET - Tunnel, side, right, green 28-7415001 thN 28-7415713
CARPET -Tunnel, side, right, red 28-7515001 thN 28-7615445
CARPET - Tunnel, side, right, black
CARPET -Tunnel, side, right, blue
-
CARPET Tunnel, side, right, green
-
CARPET Tunnel, side, right, heather
CARPET -Tunnel, side, right, palm 28-8016001 thN 28-8016382
.CARPET'- Tunnel, side, right, raspberry 28-8016001 thN 28-8016382
-
CARPET Tunnel, side, right, brown 28-8016001 thN 28-8016382
CARPET - Tunnel, side, right, dark blue 28-8016001 and up
CARPET -Tunnel, side, right, light blue 28-8316001 and up
-
CARPET Tunnel, side, right, firethorn red 28-8016001 and up
CARPET - Tunnel, side, right, medium saddle 28-8016001 t h 28-821
~ 6236
CARPET - Tunnel, side, right. dark cedar 28-8116001 and up
-
CARPET Tunnel, side, right, dark carmine 28-8216001 and up
CARPET - Tunnel, side, right, dark saddle 28-8216001 and up
-
CARPET Tunnel, top, red 28-7415001 t h 28-741
~ 5713
GARPET:- Tunnet, top, black 28-7415001 t h 28-741
~ 5713
-
CARPET Tunnel, top, blue 28-7415001 thN 28-7415713
-
CARPET Tunnel, top, fawn 28-7415001 t h 28-7415713
~
-
CARPET Tunnel, top, green 28-7415001 thN 28-7415713
-
CARPET Tunnel, top, red 28-7515001 thW 28-7615445
-
CARPET Tunnel, top, black
-
CARPET Tunnel, top, blue
-
CARPET Tunnel, top, green
-
CARPET Tunnel, top, heather
CARPET -Tunnel, top, palm 28-8016001 thN 28-8016382
-
CARPET Tunnel, top, raspberry 28-8016001 thN 28-8016382
-
CARPET Tunnel, top. brown 28-8016001 thW 28-8016382
CARPET -Tunnel, top, dark blue 28-8016001 and up
-
CARPET Tunnel, top, light blue 28-8316001 and up
CARPET -Tunnel, top, firethom red 28-8016001 and up
CARPET - Tunnel, top, medium saddle 28-8016001 t h 28-8216236
~
-
CARPET Tunnel, top, dark cedar 28-8116001 and up
CARPET - Tunnel, top, dark carmine 28-8216001 and up
-
CARPET Tunnel, top, dark saddle 28-8216001 and up
-
CARPET Spar box complete, red 28-7415001 thW 28-7415713
CARPET - Spar box complete, black 28-7415001 thW 28-7415713
-
CARPET Spar box complete, blue 28-7415001 thn! 28-7415713
CARPET - Spar box complete, fawn 28-7415001 thW 28-7415713
-
CARPET Spar box complete, green 28-7415001 t h 28-7415713
~
-
CARPET Spar box complete, red 28-7515001 th N 28-7615445
-
CARPET Spar box complete, black
CARPET - Spar box complete, blue
CARPET - Spar box complete. green
CARPET - Spar box complete, heather

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1G11
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index ~ Number Code Nomenclature Req- Affected
Number

-
CARPET Baggage cornpartment, red 28-7415001 t h 28-7415713
~
CARPET - Baggage compartment, black 28-7415001 thru 28-7415713
-
CARPET Baggage compartment, blue 28-7415061 thru 28-7415713
CARPET - Baggage compartment, fawn 28-7415001 thru 28-7415713
-
CARPET Baggage compartment, green 28-7415001 t h 28-741
~ 5713
CARPET - Baggage compartment, red 28-7515001 t h 28-7615445
~
CARPET - Baggage compartment, black
CARPET - Baggage compartment, blue
-
CARPET Baggage compartment, green
-
CARPET Baggage cornpartment, heather
-
CARPET Baggage compartment, palm 28-8016001 t h 28-8016382
~
-
CARPET Baggage compartment, raspberry 28-8016001 t h 28-801
~ 6382
CARPET - Baggage compartment, brown 28-8016001 t h 28-8016382
~
-
CARPET Baggage compartment, dark blue 28-8016001 and up
CARPET - Baggage compartment, light blue 28-8316001 and up
-
CARPET Baggage compartment, firethorn red 28-8016001 and up
-
CARPET Baggage compartment, medium saddle 28-8016001 t h 28-821
~ 6236
CARPET - Baggage compartment, dark cedar 28-8116001 and up
-
CARPET Baggage compartment, dark carmine 28-8216001 and up
CARPET - Baggage compartment, dark saddle 28-8216001 and up
PLATE - Heel
CLlP - Carpet, heat duct, left
CLlP - Carpet, heat duct, right
TRIM STRIP - Baggage compartment
PLATE - Striker, baggage door
COVER ASSEMBLY - Floor, left
COVER ASSEMBLY - Floor, right
-
PLACARD Seat reinstallationinstructions

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

1G12
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 38. Seats Installation

Reissued: December 1,1989

1G13
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 38

See Figure 38 for vertically adjustable front seat components.

When ordering this part, serial number of aircraft must be supplied. When ordering for PA-28-151 with serial numbers 28-7415001
thru 28-7615445, specify color red, bluelgreen, gold, black, white or green. When ordering for PA-28-151 with serial numbers
28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-7916113, specify color red (color code 7326), blue (color
code 7327). gold (color code 7328), black, green, navajo sepia, navajo cactus, yellowldark red or bluelgreen. When ordering for
PA-28-161 with serial numbers 28-7916114 thru 28-8216236, specify color red (color code 792). blue (color code 793), gold (color
code 794), navajo sepia, or navajo cactus. Also specify trim color black or camel, if applicable, for 1977 and up model aircraft.
Used on PA-28-151 with serial numbers 28-7415001 thru 28-7515413. If Seat Assembly incorporates a 'U' shaped handle for seat
track releasing mechanism, order part for PA-28-151 with serial numbers 28-7515414 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7415001 thru 28-7515413. Headrest Assembly incorporates a flat steel plate (8 inches
long) in center of headrest for attachment to seat back.
Used on PA-28-151 with serial numbers 28-7515414 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8216236.
Headrest assembly incorporates two round tubes (7 inches long) for attachment to seat back
When ordering, specify color red, bluelgreen, gold, black, white, green or bark. Specify color 'bark I' when ordering for PA-28-151 with
serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716075. Specify color 'bark 11' for
PA-28-161 with serial numbers 28-7716076 t h 28-8016382.
~
Used on PA-28-151 with serial numbers 28-7515414 and up. and PA-28-161.

Used on PA-28-151, and PA-28-161 with serial numbers 28-7716001 thru 28-7616072.'

When ordering, specify color firethom red, buckskin, dark blue, dark cedar, dark carmine, or sandalwood. Also specify material velour.
knit or cloth.
Before ordering, ascertain 0.D. at center of seat roller. If 0. D. of roller measures .42. (2) rollers PIN 18968-00 must be ordered. If
0. D. of roller measures .62, order (2) roller(s) PIN 87332-02 must be ordered.
Used on PA-28-151 with serial numbers 28-7415001 and up. and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
Used on PA-28-151 with serial numbers 28-7515414 and up. and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
When ordering, specify color madrid red, bahama blue, or buckskin.
When ordering, specify color firethom red, dark blue, dark cedar, dark saddle, sandalwood, or patrician sandalwood.
When ordering, specify color madrid red, bahama blue, dark blue, buckskin, light buckskin, firethorn red, dark firethorn, dark cedar,
dark saddle, sandalwood, or patrician sandalwood. Also specify material cloth. velour, knit, or leather.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part NO. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number
-
DRAWING Seat and Belts Installation

SEAT ASSEMBLY - Front, left

SEAT ASSEMBLY - Front, left 28-8316001 and up
-
SEAT ASSEMBLY Front, left (luxurious) 28-8016001 &IN 28-8216236
-
SEAT ASSEMBLY Front, left (luxurious) 28-8316001 and up
-
SEAT ASSEMBLY Front, right
SEAT ASSEMBLY - Front, right 28-8316001 and up
SEAT ASSEMBLY - Front, right (luxurious) 28-8016001 t h 28-8216236
~
-
SEAT ASSEMBLY Front, right (luxurious) 28-8316001 and up
CUSHION AND FRAME ASSEMBLY - Seat back, left
CUSHION AND FRAME ASSEMBLY - Seat back, right
'CUSHION AND FRAME ASSEMBLY Seat back, left -
CUSHION AND FRAME ASSEMBLY - Seat back, right
* CUSHION AND FRAME ASSEMBLY Seat back, left - 28-8316001 and up
CUSHION AND FRAME ASSEMBLY - Seat back, right 28-8316001 and up
' CUSHION AND FRAME ASSEMBLY - Seat back, left '
{fuiturious) - -.
CUSHION AND FRAME ASSEMBLY - Seat back, right
(luxurious)
CUSHION AND FRAME ASSEMBLY Seat back, left -
(luxurious) 28-8316001 and up
* CUSHION AND FRAME ASSEMBLY Seat back, right-
(luxurious) 28-8316001 and up
' FRAME ASSEMBLY - Seat back, left
' ' FRAME ASSEMBLY - Seat back, right
-
' FRAME ASSEMBLY Seat back, left
' FRAME ASSEMBLY - Seat back, right
' BUSHING - Seat back, right (PS10064-375-4)
-
COVER ASSEMBLY Seat back, right
' COVER ASSEMBLY - Seat back, right
-
' * COVER ASSEMBLY Seat back, right (luxurious)
' * PLACARD - Seat back release, left
-
' ' PLACARD Seat track release, right
' ' STOP ASSEMBLY - Seat latch, right
-
' ' STOP ASSEMBLY Seat latch, right
* BUTTON ASSEMBLY Seat back - 28-8016001 thtU 28-8216236
* ' BUTTON ASSEMBLY - Seat back 28-8316001 and up
' HANDLE - Seat release
-
' ' KNOB Seat back release
COVER ASSEMBLY - Seat back, left
-
COVER ASSEMBLY Seat back, left (luxurious)
CUSHION AND FRAME ASSEMBLY - Seat bottom, left
-
CUSHION AND FRAME ASSEMBLY Seat bottom, right
-
CUSHION AND FRAME ASSEMBLY Seat bottom, left
CUSHION AND FRAME ASSEMBLY - Seat bottom, right
-
CUSHION AND FRAME ASSEMBLY Seat bottom, left 28-8316001 and up
CUSHION AND FRAME ASSEMBLY - Seat bottom, right 28-8316001 and up
-
CUSHION AND FRAME ASSEMBLY Seat bottom, left
(luxurious)
-
CUSHION AND FRAME ASSEMBLY Seat bottom, right
(luxurious)
CUSHION AND FRAME ASSEMBLY - Seat bottom, left
(luxurious) 28-8316001 and up
-
CUSHION AND FRAME ASSEMBLY Seat bottom, right
(luxurious) 28-8316001 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1G15
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
'' FRAME ASSEMBLY Seat bottom. left
' FRAME ASSEMBLY - Seat bottom, right
-
'* FRAME ASSEMBLY Seat bottom, left
-
" FRAME ASSEMBLY Seat bottom, right
"' PLUNGER
" PLUNGER
" ' BUSHING Seat roller -
-
' * ROLLER Seat legs (.62 O.D.)
' ' ROLLER - Seat legs (.42 O.D.)
" BUSHING - Seat roller, aft legs

'' BUSHING - Seat roller, aft legs

* ROLLER - (NAS506-4)
'* ' SPRING - Seat plunger (LC438FbSS)
' ' KNOB - (PSI 0067-1-1)
* ' ' HANDLE ASSEMBLY - Front seat adjustment
^ ' BELLCRANK ASSEMBLY - Seat latch
-
' SPRING Seat back adjustment, inboard
' ' SPRING - Seat back adjustment, outboard
^ ' ' TUBE - Reclining mechanism, left
-
' ' TUBE Reclining mechanism, left
' ' TUBE - Reclining mechanism, right
' CAM - Reclining seat
' HANDLE - Seat back adjustment, cadmium plated
-
HANDLE Seat back adjustment, black
' PIN - Roll (59-028-125-0625)
" ' WASHER
' ' ' ARM ASSEMBLY - Seat latch, left
' ARM ASSEMBLY - Seat release, right
ROD - Seat release mechanism (8 69' L.)
ROD - Seat release mechanism (9.60' L.)
-
' SPACER Seat release, left
^ ^ ' BEARING SHAFT - Seat release, right
-
' ' ' BUSHING Seat back release, right
-
* BOLT (AN4-20A)
" ' WASHER
* NUT - (26C-048)
' ' PIN - Roll (59-028-187-0937)
-
' BOLT (AN24-26A)
WASHER - (AN960-416)
' NUT - (266-048)
CUSHION ASSEMBLY - Rear seat, back
CUSHION ASSEMBLY - Rear seat, back 2816001 and up
-
CUSHION ASSEMBLY Rear seat, back 2816001 andup
CARPET ASSEMBLY - Seat back 2816001 and up
CUSHION ASSEMBLY - Rear seat, back (luxurious) 28-8016001 to 28-8216236
-
CUSHION ASSEMBLY Rear seat, back (luxurious) 28-8316001 and up
FRAME ASSEMBLY - Rear seat, back
FRAME ASSEMBLY - Rear seat, back 28-8616001 and up
BRACKET ASSEMBLY - Rear seat
* GROMMET - (MS35489-6)
BOLT - (AN24-21A)
-
* WASHER (AN960-416)
CUSHION ASSEMBLY - Rear seat, bottom
CUSHION ASSEMBLY - Rear seat, bottom 28-7816073 to 28-8216236
CUSHION ASSEMBLY - Rear seat, bottom 28-8316001 and up
CUSHION ASSEMBLY - Rear seat, bottom (luxurious) 28-8016001 to 28-8216236.
CUSHION ASSEMBLY - Rear seat, bottom (luxurious) 28-8316001 and up
CUSHION ASSEMBLY - Rear seat, bottom 2816001 andup

When ordering, always specify Part Number. Description. and Serial Number of Aircraft

Reissued: December 1. 1989

1G16
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affect'ed
Number

-
FRAME ASSEMBLY Rear seat, bottom 1
FRAME ASSEMBLY - Rear seat, bottom 1 28-8616001 and up
-
SUPPORT BOARD Seat bottom 1
STOP - Seat track 8
-
BELT ASSEMBLY Safety front (PS50039-4-2A) 2
-
BELT ASSEMBLY Safety rear (PS50039-4-3) 2
-
BELT ASSEMBLY Shoulder, front (with inertia reel)
(PS50039-4-20) 2
-
BELT ASSEMBLY Shoulder, front (with inertia reel)
(PS50039-4-49) 2 2816110 and up
BELT ASSEMBLY - Shoulder. front (fixed)
(PS50039-4-23) 2 28-8116001 thrU 28-8216236
BELT ASSEMBLY - Shoulder, rear (with inertia reel)
(PS50039-4- 19) 2
-
BELT ASSEMBLY Shoulder, rear (with inertia reel)
(PS50039-4-48) 2
BELT ASSEMBLY - Shoulder, rear (fixed)
(PS50039-4-22) 2
BOOT - Seat belt attachment 4
CABLE-ASSEMBLY' Safety belt attachment, rear 4
B.D HEADREST ASSEMBLY - Complete, pilot 1
B,D -
HEADREST ASSEMBLY Complete, copilot 1
B.E HEADREST ASSEMBLY - Complete 2
L HEADREST ASSEMBLY - Complete (luxurious) 2 28-8016001 t h 28-8216236
~
S HEADREST ASSEMBLY Complete - 2 28-8316001 and up
RECEPTACLE - Headrest (1.88 L. x .62 W.) 2
RECEPTACLE - Headrest (1.00 Dia.) 2
SHACKLE - (MS20115-F5) 2
BUSHING - Rear seat; back 2
BUSHING - Front seat safety belt attachment (1.76" L.) 2
BUSHING - Front seat safety belt attachment. right ( 3 4 ' L.) 1
-
BUSHING Front seat safety belt attachment, left (.25' L.) 1
BUSHING - Rear seat safety belt attachment 4
BUSHING - Rear seat safety belt attachment 2
TRACK - Seat 4
-
BOLT (AN4-7A) 2
WASHER - (AN960-416) 2
-
NUT (MS20365-428C) 2
BOLT - (AN5-7A) -* 4
WASHER - (AN960-516) 4
NUT - (MS20364-524C) 4
-
BOLT (AN5-14A) 1
-
WASHER (AN960 516) 1
NUT - (MS20365-524C) 1
BOLT - (AN24-13A) 2
BOLT - (AN3-5A) 4
WASHER - (AN960-10) 4
-
NUT (MS20364-1032C) 4
STUD - (XX-10362-12) 7
-
BOLT (AN3-1OA) 2
BOLT - (AN23-1 1A) left
BOLT - (AN3-IOA) right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1G17
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 39. Vertically Adjustable Front Seat Assembly

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 39

When ordering this part, serial number of aircraft must be supplied. When ordering for PA-28-151 with serial numbers 28-7415001 t h ~
28-7615445: specify color red, bluelgreen, gold, black, white or green. When ordering for PA-28-151 with serial numbers 28-7715001
and up, and PA-28-161 with serial numbers 28-7716001 thw 28-7916113; specify color red (color code 7326), blue (color code 7327),
gold (color code 7328), black, green, navajo sepia, navajo cactus, yellowldark red or bluelgreen. When ordering for PA-28-161
with serial numbers 28-7916114 thru 28-8216236, specify color red (color code 792). blue (color code 793), gold (color code 794),
navajo sepia, or navajo cactus. Also specify trim color black or camel, if applicable, for 1977 and up model aircraft
Used on PA-28-151with serial numbers 28-7415001 thru 28-7515413. If Seat Assembly incorporates a 'U' shaped handle for seat
track releasing mechanism, order part for PA-28-151with serial numbers 28-7515414 and up, and PA-28-161.
Used if Seat Assembly incorporates a 'U' shaped handle for the seat track releasing mechanism.
Used if Seat Assembly incorporates a 'T' knob for the seat track releasing mechanism.
When ordering, specify color red, bluelgreen, gold, black, white, green or bark. Specify color 'bark I' when ordering for PA-28-151 with
serial numbers 28-7715001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-7716075. Specify color 'bark 11' for
PA-28-161 with serial numbers 28-7716076 t h 28-8016382.
~
Used on PA-28-151 with serial numbers 28-7515414 and up, and PA-28-161.
Used on PA-28-151 only and PA-28-161 with serial numbers 28-7716001 thru 28-7716073.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
Used if seat adjustment control assembly 76445-00 (P. L Porter Co. P/N SLlOlOO Rev. 8 )is installed.
Used if seat adjustment control assembly 587 404 (Gas Spring Corp. PIN 06-10-080-310-025) is installed.
Optional equipment.
Used on PA-28-151 with serial numbers 28-7415001 thru 28-7515413. Of Seat Assembly incorporates a 'Unshaped handle for seat
track releasing mechanism, order partyor PA-28-151'with serial numbers 28-7515414 and up, and PA-28-161 with serial numbers
28-7716001 t h 28-7716073.
~
Used on PA-28-151 with serial numbers 28-7515414 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716073. If
Seat Assembly incorporates a seat adjustment control assembly 587 404 (Gas Spring Cop. PIN 06-10-080-310-025),order part
number for PA-28-161with serial numbers 28-7716074 and up.
Used if a forged bellcrank assembly is installed.
When ordering, spec~fycolor firethom red, buckskin, dark blue, dark cedar, dark carmine, or sandalwood. Also specify material velour,
knrt, or cloth.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.
Used on PA-28-151 with serial numbars 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916113.
Before ordering, ascertain 0. D. at center of seat roller. If 0.D. of roller measures .42, (2) rollers PIN 87332-02 must be ordered. If
O.D. of roller measures .62, order roller(s) as required.
Ascertain part number stamped on control assembly. Reorder assembly of same part number.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.

When ordering, specify color madrid red, bahama blue, dark blue, buckskin, light buckskin. firethom red, dark firethom, dark cedar,
dark saddle, sandalwood, or patrician sandalwood. Also specify material cloth, velour, knit, or leather.
Used on PA-28-151 with serial numbers 28-7515414 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
Used if a welded bellcrank assembly is installed.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
SEAT ASSEMBLY Adjustable front, left
-
SEAT ASSEMBLY Adjustable front, left 28-8316001 and up
-
SEAT ASSEMBLY Adjustable front, left (luxurious) 28-8016001 t h r ~28-8216236
-
SEAT ASSEMBLY Adjustable front, left (luxurious) 28-8316001 and up
-
SEAT ASSEMBLY Adjustable front, right
-
SEAT ASSEMBLY Adjustable front, right 28-8316001 and up
-
SEAT ASSEMBLY Adjustable front, right (luxurious) 28-8016001 t h r ~28-8216236
SEAT ASSEMBLY - Adjustable front, right (luxurious) 28-8316001 and up
CUSHION ASSEMBLY - Back, left
' CUSHION ASSEMBLY Back, left -
CUSHION ASSEMBLY - Back, left 28-8316001 and up
CUSHION ASSEMBLY - Back, left (luxurious) 28-8016001 t h 28-8216236
~
' CUSHION ASSEMBLY - Back, left (luxurious) 28-8316001 and up
CUSHION ASSEMBLY Back, right -
CUSHION ASSEMBLY Back, right -
^ CUSHION ASSEMBLY - Back, right 28-8316001 and up
* CUSHION ASSEMBLY - Back, right (luxurious) 28-8016001 thN 28-8216236
* CUSHION ASSEMBLY - Back, right (luxurious) 28-8316001 and up
' FRAME ASSEMBLY - Seat back, left
* ' FRAME ASSEMBLY - Seat back, right
FRAME ASSEMBLY - Seat back, left
' ' FRAME ASSEMBLY- Seat back, right
' ' BUSHING - Seat back, right (PS10064-375-4)
' ' COVER ASSEMBLY - Seat back, right
' COVER ASSEMBLY Seat back, right -
' COVER ASSEMBLY - Seat back, right (luxurious)
' ' ' PLACARD - Seat back release, left
-
' ' PLACARD Seat track release, right
' ' HANDLE - Seat release, right
' KNOB - Seat back release, right
* ' BUTTON ASSEMBLY- Seat back 28-8016001 thrU 28-8216236
' ' BUTTON ASSEMBLY - Seat back 28-8316001 and up
-
' ' STOP ASSEMBLY Seat latch, right
CABLE ASSEMBLY - Seat back release (passenger
operated - length 27')
' ' CABLE ASSEMBLY - Seat track release (passenger
-
operated length 40' )
CABLE ASSEMBLY - Seat track release (crew operated -
length 27') (PS50146-8-1)
-
FRAME ASSEMBLY Seat bottom, left
-
'FRAME ASSEMBLY Seat bottom, right
-
* FRAME ASSEMBLY Seat bottom, left
FRAME ASSEMBLY - Seat bottom, right
-
FRAME ASSEMBLY Seat bottom, left 28-7716074 and up
FRAME ASSEMBLY - Seat bottom, right 28-7716074 and up
' * WASHER
' SPRING - Seat plunger (LC-038FbSS)
-
ROLLER (NAS506-4)
' PLUNGER
-
* ' TUBE Bellcrank
' ' BELLCRANK ASSEMBLY Forward -
' BELLCRANK ASSEMBLY Aft -
' LINK ASSEMBLY - Seat
' ' TUBE ASSEMBLY - Forward
' ' BUSHING - Seat
' ' BUSHING Seat -
'' TUBE ASSEMBLY Aft -
' ' TUBE ASSEMBLY - Aft
-
' ' BEARING SHAFT Seat release, right

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

IG20
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
,-7gure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
' ' TUBE Seat reclining
-
' ' BUSHING Seat back release, right
' ' COVER - Reclining seat
' ' LEVER - Seat
' WASHER -Teflon
* ' SPACER - Seat (.254 wide)
-
' SPACER Seat (.248 wide)
* SPACER
-
* ' PIN Roll (59-040-187-0937)
* BOLT - (AN4-20A)
* NUT - (MS20365-428C)
' NUT - (26C-048)
-
BOLT (AN4-5A)
-
' WASHER Nylon (1/4 I.D.)
* WASHER - (AN960-416L)
* NUT - (MS20365-428C)
-
' ' HANDLE Seat back adjustment, cadmium plated
-
' ' HANDLE Seat back adjustment, black
' PIN - Roll (59-028-125-0625)
-
* PIN (MS9048-172) (1.25 L.)
* PIN - (MS9048-173) (1.37 L.)
' PIN - (MS9048-100) .50 long
' * PIN - (MS9048-101) .56 long
* * PIN - (MS9048-170)
* PIN - (MS20392-1Cll)
* PIN - (MS20392-2Cll)
* WASHER - (AN960-4)
* * WASHER - (AN960-10)
COlTER PIN - (MS24665-132)
* PIN - (MS20392-3C17)
* PIN - (MS20392-3C15)
* WASHER - (AN960-416)
WASHER - (AN960-416L)
* COTTER PIN - (MS24665-132)
BOLT - (AN4-20A)
'' SPRING - Seat back adjustment, left
-
' ' SPRING Seat back adjustment, right
' ROLLER Seat-
' CAM - Reclining seat
' KNOB - (PS10067-1-1)
' HANDLE ASSEMBLY Seat release -
-
' ARM ASSEMBLY Seat release
-
' ' ARM ASSEMBLY Seat latch
CONTROL ASSEMBLY - Seat adjustment (P. L. Porter
Co. P/N SLlOlOO Rev. B)
-
CONTROL ASSEMBLY Seat adjustment (Gas Spring
Corp. PIN 06-10-080-310-025)
-
ADAPTER Seat control
-
ADAPTER Seat control
' BUSHING
* CONTROL ARM -Actuator
-
COVER ASSEMBLY Seat back, left
-
COVER ASSEMBLY Seat back, left (luxurious)
COVER ASSEMBLY - Seat bottom, red
-
COVER ASSEMBLY Seat bottom, bluelgreen
COVER ASSEMBLY - Seat bottom, gold
COVER ASSEMBLY - Seat bottom, green
-
COVER ASSEMBLY Seat bottom, black
'COVER ASSEMBLY - Seat bottom, white

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1 G21
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

COVER ASSEMBLY - Seat bottom, red (with black trim)

COVER ASSEMBLY - Seat bottom, blue (with black trirn)
COVER ASSEMBLY - Seat bottom, gold (with black trim)
COVER ASSEMBLY - Seat bottom, red (with black trim)
-
* COVER ASSEMBLY Seat bottom, blue (with black trim)
* COVER ASSEMBLY - Seat bottom, gold (with black trim)
* COVER ASSEMBLY - Seat bottom, green (with black
trim)
' COVER ASSEMBLY - Seat bottom, black (with black trim)
-
' COVER ASSEMBLY Seat bottom. navajo sepia (with
camel trim)
* COVER ASSEMBLY - Seat bottom, navajo cactus (with
carnel trim)
COVER ASSEMBLY - Seat bottom, yellowldark red (with
ca me1 trim)
-
COVER ASSEMBLY Seat bottom, bluetgreen (with
carnel trim)
* COVER ASSEMBLY - Seat bottom, navajo sepia (with
black trim)
'COVER ASSEMBLY - Seat bottorn, navajo cactus (with
black trirn)
COVER ASSEMBLY - Seat bottom, yellowldark red
(with black trirn)
COVER ASSEMBLY -Seat bottom, bluelgreen (with
black trim)
COVER ASSEMBLY - Seat bottom, firethom red (velour) 28-8016001 t h 28-8216236
~
* COVER ASSEMBLY - Seat bottom, firethom red (velour) 28-8316001and up
COVER ASSEMBLY - Seat bottom, dark firethom (leather) 28-8316001 and up
COVER ASSEMBLY - Seat bottorn, buckskin (velour) 28-8016001 t h 28-821
~ 6236
COVER ASSEMBLY - Seat bottom, buckskin (cloth) 28-8316001and up
COVER ASSEMBLY -Seat bottom, light buckskin (leather) 28-8316001and up
COVER ASSEMBLY - Seat bottom, dark blue (velour) 28-8016001t h 28-8216236
~
COVER ASSEMBLY - Seat bottom, dark blue (velour) 28-8316001 and up
COVER ASSEMBLY - Seat bottom, dark blue (leather) 28-8316001 and up
COVER ASSEMBLY - Seat bottom, dark cedar (knit) 28-8116001 t h 28-8216236
~
* COVER ASSEMBLY - Seat bottom, dark cedar (velour) 28-8216001 t h r ~28-8216236
-
COVER ASSEMBLY Seat bottom, dark cedar (knit) 28-8316001and up
-
* COVER ASSEMBLY Seat bottom. dark cedar (leather) 28-8316001 and up
COVER ASSEMBLY - Seat bottom, dark carmine (velour) 28-8216001 t h 28-821
~ 6236
-
COVER ASSEMBLY Seat bottom, sandalwood (fabric) 28-8216001thm 28-8216236
-
COVER ASSEMBLY Seat bottom, sandalwood (fabric) 28-8316001 and up
* COVER ASSEMBLY - Seat bottom, patrician sandalwood
(fabric) 28-8316001 and up
-
COVER ASSEMBLY Seat bottom, dark saddle (knit) 28-8316001and up
* COVER ASSEMBLY - Seat bottom, dark saddle (leather) 28-8316001 and up
-
COVER ASSEMBLY Seat bottom, red (with camel trim) 28-7816001t h 28-79161
~ 13
COVER ASSEMBLY - Seat bottom, blue (with camel trim) 28-7816001t h 28-7916113
~
'COVER ASSEMBLY -Seat bottom, gold (with carnel trim) 28-7816001WIN 28-7916113
-
' COVER ASSEMBLY Seat bottom, red (with camel trim) 28-7916114t h r ~
28-8016382
COVER ASSEMBLY -Seat bottom, blue (with carnel trim) 28-7916114 WIN 28-8016382
-
COVER ASSEMBLY Seat bottom, gold (with camel trim) 28-7916114 th~1.28-8216236
-
COVER ASSEMBLY Seat bottom, red (vinyl) 28-8116001 t h 28-8216236
~
-
' COVER ASSEMBLY Seat bottorn, blue (vinyl) 28-8116001 thN 28-8216236
-
COVER ASSEMBLY Seat bottom, madrid red (cloth) 28-8316001and up
-
COVER ASSEMBLY Seat bottom, bahama blue (cloth) 28-8316001 and up
BUSHING - Actuator
-
' KNOB Actuator (233)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1G22
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affectbd
Number

39-60 02585-04 L LUMBAR ASSEMBLY - Pilot seat

02585-05 L -
LUMBAR ASSEMBLY Copilot seat
02585-06 L 'PAD
686 083 L ' BLADDER
-61 453 024 L PUMP ASSEMBLY
454 935 L CLAMP

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1 G23
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 40. Instrument Panel Installation

(PA-28-151, and PA-28-161 thru serial number 2816109)

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 40

When ordering, specify color gold, blue, green, gray or bark. Specify color 'bark I' when ordering for PA-28-151with serial numbers
28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-7716075. Specify color 'bark II' or black for PA-28-161
with serial numbers 28-7716076 and up.
When ordering, specify color red, bluelgreen, gold, black, white, green or bark. Specify color 'bark I' when ordering for PA-28- 151
with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-7716075. Specify color 'bark 11' or
black for PA-28-161with serial numbers 28-7716076 and up.
See Figure 73 if AutoFlite II is installed.
See Figure 74 if Autocontrol Ill is installed.
Used if Cabin Overhead Air Vent System with blower is installed.
Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161. Also used on PA-28-151with serial numbers
28-7415001 thm 28-7515459 if Magnetic Compass Relocation Kit 760 795 has been installed per Service Letter 761.
See Figure 81 if phone jack is installed on PA-28-161.
When ordering, specify color red, bluehreen, gold, black, white, green, mushroom, camel or mocha..
Used on PA-28-161 only.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7515398 and up, and PA-28-161.
See Figure 75 if Century 21 Autopilot is installed.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with seriabnumbers 28-7716001 thm 28-7716323.
Used on PA-28-151 with serial numbers 28-7415001 and up. and PA-28-161 with serial numbers 28-7716001 thm 28-7716323.
Used if air conditioning is installed.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-7816171. Order
part for PA-28-161 with serial numbers 28-7816172 and up if the four position fan switch has been replaced with a three position fan
switch.
Order part for PA-28-161 with serial numbers 28-7816172 and up if the four position fan switch has been replaced with a three position
fan switch.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-7916428.
Currently, Halon fire extinguishers are not available, due to Federal mandate. As applicable per specific units, recharge, if available in
your local area. No fire extinguisher replacement has yet been identified.
lnstmment not approved IFR.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-7916617.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161with serial numbers 28-7716001 thm 28-7916617.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thm 28-7916617.
Used on PA-28-161 with serial numbers 28-8016299 and up. This part includes cable assembly.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-8116018. Also
used on PA-28-161 with serial numbers 28-8116019 and up if AutoFlite II is installed.
Used if Century 21 AutoPilot is installed.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-8116188.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8116268,
28-8216007,28-8216014,28-8216017,28-8216019,and 28-8216021.
Used on PA-28-161 with serial numbers 28-8116269 thm 28-8216006,28-8216008 thm 28-8216013,28-8216015,28-8216016,
28-821 6018,28-8216020,28-8216022 and up.
AH - Used if a push ontoff pitch trim switch is installed.
AJ - Used if a toggle pitch trim switch is installed.
AK - Located on right hand shin guard channel assembly only.
AL - Used if King KAP 1001150 Autopilot is installed.
AM- DISTRIBUTORS: Before replacing engine gauges and senders, see Piper Aircraft Service Spares Letter 406.
AN- Select the direct replacement for your clock from the list below.
548 083 - Clock, 8 day mechanical (Thomrnen 16-100)
-
550 544 Clock, 8 day mechanical (Wakmann W-33-7510-L)
-
599 295 Clock, 8 day mechanical with elapsed time hands (Thommen 16-101-1)
-
450 706 Clock, 8 day mechanical with elapsed time hands (Wakrnann W-33-7510-ET)
-
548 574 Clock, 8 day mechanical, lighted, 28 volt (Thommen 16-100L-2-28)
-
548 806 Clock, 8 day mechanical, lighted, 5 volt (Thomenn 16-100L-2-5)
548 868 - Clock, electric quartz analog, 14 volt or 28 volt (VDO MD88P)
-
548 516 Clock, digital, internal power, lighted, 28 volt (Astrotech LC-2)
548 755 - Clock, digital, aircraft power, lighted, 14 volt or 28 volt (Astrotech LC-2)
548 756 - Clock, digital, aircraft power, lighted, 14 volt or 28 volt (Astrotech LC-6)
Required for CAA certification.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affedted
Number
DRAWING - Instruments lnstallation
DRAWING - Instrumentslnstallation (Optional)
DRAWING - Instrument Panel Cover lnstallation
DRAWING - InstrumentPanel Cover lnstallation
DRAWING - Fire Extinguisher lnstallation 28-7916029 and up
DRAWING - Crew Cup Holder Installation 28-8316001 and up

-
INSTRUMENT Tachometer assembly (599 282)
PS50048-15-1 1
INSTRUMENT - Airspeed indicator (PS50049-16-2) (scale in
knots and mph) 1
-
INSTRUMENT Airspeed indicator (PS50049-25-2) (scale in
knots and mph) 1
INSTRUMENT - Airspeed indicator (PS50049-17-2) (scale in
knots) 1
INSTRUMENT - Airspeed indicator (PS50049-27-2) (scale in
knots) 1
INSTRUMENT - Airspeed indicator (PS50049-41 S) (stake in
knots) 1
INSTRUMENT - True airspeed indicator (PS50049-15-2) 1
INSTRUMENT - True airspeed indicator (PS50049-26-2) 1
INSTRUMENT - True airspeed indicator (PS50049-41T) 1
INSTRUMENT - Rate of climb (550 556) 1
INSTRUMENT - Directional gyro (3 inch) 1
INSTRUMENT - Gyro horizon (3 inch) 1
INSTRUMENT - Gyro horizon (EAM-520-266M) 1
INSTRUMENT - Altimeter, sensitive (scale in inches of mercury
to 20,000 feet) 1
-
INSTRUMENT Altimeter, sensitive (scale in inches of rnercury
to 20,000 feet) 1
INSTRUMENT - Altimeter, sensitive (scale in millibars
to 20,000 feet) 1
INSTRUMENT - Altimeter, sensitive (scale in inches of mercury
to 35,000 feet) 1
-
INSTRUMENT Altimeter, sensitive (scale in millibars
to 35,000 feet) 1
-
INSTRUMENT Altimeter, sensitive (scale in inches of mercury
and millibars to 20.000 feet) 1
INSTRUMENT - Altimeter, sensitive (scale in inches of mercury
and millibars to 35,000 feet) 1
INSTRUMENT - Altimeter, encoding (scale in inches of mercury
to 35,000 feet) 1
INSTRUMENT - Altirneter, encoding (scale in millibars
to 35,000 feet) 1
INSTRUMENT -Turn and bank (1234T100-5) electric 1
INSTRUMENT -Turn coordinator (1394T100) electric 1
-
INSTRUMENT Turn coordinator (PS50030-13-2) (with 1
internal lighting) 1
-
INSTRUMENT Clock 1
INSTRUMENT - Clock, electric (MD88P) 1 28-7615021 and up
-
COMPASS ASSEMBLY (C-2400-L4P-B) 1 28-7415001 thru 28-7515459
-
COMPASS 14V (C-2200-L4-B) 1
-
COMPASS 28V (C-2200-L4-1B) 1
-
HOLDER Compass card 1
-
INSTRUMENT Ammeter 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

AF,AM CLUSTER ASSEMBLY - lnstrument

AG,AM CLUSTER ASSEMBLY - Instrument
AF, AM INSTRUMENT - Fuel.gauge, left, main
AG,AM INSTRUMENT - Fuel gauge, left, main
AF,AM ' INSTRUMENT - Fuel gauge, right, main
AG,AM -
' INSTRUMENT Fuel gauge, right, main
AF,AM ' INSTRUMENT - Oil temperature
AG,AM ' INSTRUMENT - Oil temperature
AF,AM " INSTRUMENT - Fuel pressure
AG,AM INSTRUMENT - Fuel pressure
AF,AM ' INSTRUMENT - Oil pressure
AG,AM INSTRUMENT -Oil pressure
AM LENS - Cluster assembly
AM GAUGE - Cylinder head temperature (442800)
L INDICATOR - Engine hour meter
GAUGE - Suction (1G10-1)
GAUGE - Suction (AW1821AF03)
-
PLATE ASSEMBLY Instrument panel
-
COVER ASSEMBLY Radio opening, 6.44 x 1.78
COVER ASSEMBLY - Radio opening. 6.44 x 1.78
COVER ASSEMBLY - Radio opening, 6.56 x 2.90
COVER ASSEMBLY - Radio opening, 6.44 x 1.78
-
COVER ASSEMBLY Radio opening, 6.50 x 3.80
COVER ASSEMBLY - Radio opening, 6.50 x 1.25
-
COVER ASSEMBLY Radio opening, 6.56 x 3.24
COVER ASSEMBLY - Radio opening. 6.44 x 1.78
COVER ASSEMBLY - Radio opening, 6.56 x 2.90
-
COVER ASSEMBLY Upper instrument panel, left
-
COVER Upper instrument panel, left
-
COVER Upper instrument panel, left 28-7916429 and up
-
COVER Upper instrument panel, left 28-8116019 and up
-
COVER Upper instrument panel, left 28-8316001 and up
-
COVER Upper instrument panel, right
PLACARD - Maneuvering speed, mph
PLACARD - Maneuvering speed, knots
PLACARD - Maneuvering speed, knots
PLACARD - Maneuvering speed, knots 28-8016001 t h 28-821
~ 6236
-
PLACARD Manewering speed, knots 28-8316001 and up
PLACARD - Crosswind component, knots
-
PLACARD Crosswind component, mph
PLACARD - 'Press to Test'
-
COVER ASSEMBLY Instrument panel, left
-
PLACARD Landing checklist, mph
PLACARD - Landing checklist, knots
-
PLACARD Landing checklist, mph
-
PLACARD Landing checklist, knots
PLACARD - Landing checklist, knots
-
PLACARD Landing checklist, knots
PLACARD - Takeoff checklist
-
PLACARD Takeoff checklist

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1H4
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
lgure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

40-33 -
COVER ASSEMBLY lnstrument panel, right
COVER ASSEMBLY - lnstrument panel, right
-
COVER ASSEMBLY Instrument panel, right 28-7816172 and up
COVER ASSEMBLY - Instrument panel, right 28-7816001 t h 28-7816171
~
COVER ASSEMBLY - lnstrument panel, right 28-7816172 and up
-
PLACARD Heater and defrost
PLACARD - Heater and defrost (lift to actuate)
* PLACARD -Vent fan
PLACARD -Vent fan 28-7816172 and up
* PLACARD - Air condition control panel 28-7816001 t h 28-7816171
~
-
^ PLACARD Air condition control panel 28-7816172 and up
-
PLACARD Heater and defrost
PLACARD - Heater and defrost (lift to actuate)
COVER ASSEMBLY - Instrument panel, lower left
-
COVER ASSEMBLY lnstrument panel, lower left, white 28-7415001 thru 28-7415713
COVER ASSEMBLY - lnstrurnent panel, lower left 28-8116019 and up
COVER ASSEMBLY - lnstrument panel, lower right, red 28-7415001 t h 28-751
~ 5397
COVER ASSEMBLY - lnstrurnent panel, lower right,
bluelgreen
-
COVER ASSEMBLY lnstrument panel. lower right, tan
COVER ASSEMBLY - lnstrument panel, lower right, black
COVER ASSEMBLY - lnstrurnent panel, lower right, white
COVER ASSEMBLY - lnstrurnent panel, lower right, green
COVER ASSEMBLY - Instrument panel, lower right
PLACARD - Carburetor heat
PLACARD - Carburetor heat
CHANNEL ASSEMBLY - Shin guard, left
CHANNEL ASSEMBLY - Shin guard, left 28-81 16189 and up
CHANNEL ASSEMBLY - Shin guard, right
' FUSE - Spare (311005) 5 amp
COVER ASSEMBLY - Circuit breaker panel, red
-
COVER ASSEMBLY Circuit breaker panel, bluelgreen
-
COVER ASSEMBLY Circuit breaker panel, tan
-
COVER ASSEMBLY Circuit breaker panel, black
COVER ASSEMBLY - Circuit breaker panel, white
COVER ASSEMBLY - Circuit breaker panel, green
SHAFT - Tachometer (PS50044-2)
SHIELD ASSEMBLY - Glare, black
SUPPORT ASSEMBLY - Compass
-
CAP Trim, left
CAP -Trim, right
PLACARD - Alternate static source
PLACARD - Pitch trim
PLACARD - Pitch trim
PLACARD - On-off
-
SPRING Circuit breaker panel
WASHER - Tachometer shaft
-
PLACARD Oil cooler winterization
SPACER - Air temperature gauge, inner
SPACER - Air temperature gauge, outer
-
BUSTON Plug (SS-48189)
LIGHTER Cigar-
-
LIGHTER Cigar (28V)
CLAMP SHEEL (28V) -
ELEMENT - (28V)
HOUSING ASSEMBLY Compass -
GAUGE - Air temperature
GAUGE -Air temperature 28-771 6001 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30,1994

1 H5
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

GAUGE - Mixture control indicator (Alcor)

-
PROBE ASSEMBLY Mixture control (Alcor)
-
WIRE ASSEMBLY Mixture control (Alcor)
PLACARD - Fuel gauge waming 28-741 5001 thru 28-7715200
-
PLACARD Air condition door light 28-7816001 and up
SCREW - (PSI 0084-44-2)
WASHER - (AN960-6)
NUT - (MS20365632C)
W FIRE EXTINGUISHER (HA1014-01)- 28-791 6029 and up
-
BRACE Fire extinguisher support 28-7916029 and up
BRACE - Fire extinguisher support 28-7916029 and up
BRACKET ASSEMBLY - Fire extinguisher 28-7916029 and up
-
BRACKET ASSEMBLY Fire extinguisher 28-7916029 and up
BRACKET ASSEMBLY - Fire extinguisher 28-7916029 and up
-
TAB ASSEMBLY Fire extinguisher 28-7916029 and up
BRACKET ASSEMBLY - Fire extinguisher 28-7916029 and up
J PLATE ASSEMBLY - EGT
J COVER - EGT
J BRACKET - Fire extinguisher 28-7916029 and up
PLATE - Instrument retainer
PLATE - Instrument panel support
PLATE ASSEMBLY - Instrument panel
PLACARD - Radio power, ON-OFF 28-8016001 and up
PLACARD - Emergency bus switch 28-8016001 and up
PLACARD - Caution 28-8016076 and up
HOLDER - Crew cup 28-8316001 and up
AP LIGHT - Starter engage warning (134-3830-0333-201) 2816012andup
AP CAP - Red (134-0351-200) 2816012andup
AP BULB - (PS10008-330) 2816012andup

When ordering, always specify Part Number, Description. and Serial Number of Aircraft

Revised: July 30,1994

1H6
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 40A. lnstmrnent Panel Installation

(PA-28-161 serial numbers 2816110 and up)

Added: July 30,1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 40A

A - See Figure 65A, l n s t ~ m e nPanel

t Electrical Installation.
B - Part of Optional Avionics Package. See Optional Avionics Drawings, located in the Electronics Group, Section XII, of this catalog.
C - Optional equipment.

Added: July 30,1994

 PIPER AIRCRAFT
PA-28-1511161 WARRiOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

40A- 85433 -
DRAWING Instruments Installation 2816110 and up
85492 -
DRAWING Instrument Panel 2816110 and up

-
INDICATOR Vacuum gauge (599 537)
INDICATOR - Clock
INDICATOR Turn and bank -
INDICATOR - Airspeed
-
INDICATOR Directional gyro
INDICATOR - Gyro horizon
INDICATOR Rate of climb -
INDICATOR - Altimeter
PANEL ASSEMBLY - Annunciator
-
INDICATOR Compass assembly
INDICATOR - Compass
HOLDER - Compass card
INDICATOR - KI-204 VOR / LOC - Glideslope
INDICATOR - KI-203 VOR / LOC
-----
INDICATOR Ammeter -
INDICATOR - Engine hour meter (550 580)
-
PANEL ASSEMBLY Circuit breaker
PANEL ASSEMBLY Switch -
INDICATOR - Engine gauge (oil temperature, oil pressure.
cylinder head temperature)
INDICATOR - Tachometer
INDICATOR - Dual fuel quantity gauge
KNOB - Dimmer control
INDICATOR - Kl-227 ADF
-
SWITCH Ignition
SWITCH ASSEMBLY Primer -
PANEL - Instrument, left (IFR)
-
PANEL Instrument, left (VFR)
PANEL - Instrument. right (IFR)
PANEL - Instrument, right (VFR)
HOLDER - Crew cup, right
-
HOLDER Crew cup, left
-
SCREW (MS35207-262)
SPACER
WASHER Spring -
GLARESHIELD ASSEMBLY

When ordering, always specify Part Number. Description, and S e d Number of Aircraft

Added: July 30.1994

1H9
 PIPER AIRCRAFT
PA-28-151M 61 WARRIOR
+AIRPLANEPARTS CATALOG

Figure 41. Vacuum System Installation

(PA-28-151, and PA-28-161 thru serial number 2816109)

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 41

A -
B - Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161.
C - Used with Vacuum Pump PIN 26749-07 ( A i h m e 211CC) only.
D - Used with Vacuum Pump PIN 36535-02 (Edo-Aire 1U128-002) only.
E - See Figure 75A for PA-28-161 with serial numbers 28-8316001 and up if King KAP 1001150 Autopilot is installed.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomendature Req. Affected
Number

DRAWING - Vacuum System Installation

-
KIT Vacuum pump drive (69439)
-
PUMP Dry vacuum (Airborne 211CC)
PUMP - Dry vacuum (Edo-Aire 1U128-002)
'COUPLING ASSEMBLY KIT - Vacuum pump drive (No. 350)
-
' ' GASKET Vacuum pump mounting (83-1-2)
-
' GASKET Vacuum pump mounting (AN4045-1)
FILTER ASSEMBLY - Air (66673-00)
'CARTRIDGE - Air filter(D9-18-1)
VALVE - Suction regulating (133A4)
-
VALVE Suction regulating (2H3-19)
* SWITCH - (F7-16-1)
-
' FILTER Regulating (€33-5-1)
-
SPACER Air filter
HOSE - Directional gyro to air filter
HOSE - Regulating valve to vacuum pump
-
HOSE Gyro horizon to air filter
HOSE - Gyro horizon to regulating valve (11.50 L.)
HOSE - Gyro horizon to suction gauge
HOSE -Vacuum pump exhaust
HOSE - Vacuum pump exhaust
ELBOW - (1K1-6-10)
-
ELBOW (1 K8-6-8)
ELBOW - (1K1-6-10)
ELBOW - (1Kg-46)
ADAPTER - (1K1O-2-4)
ADAPTER - (1K10-4-6)
FllTING - (1K31-46-4)
CLAMP - (SAE TY F-8)
CLAMP - (SAETYE-11)
-
CLAMP (SAE PI E-13)
CLAMP - (SAE TY F-4)
CLAMP - (SAE TY F-6)
-
CLAMP (PS10017-8-8)
-
ELBOW (1K1-2-4)
-
CLAMP (NAS397-12)
NUT - (PS10024-420)
WASHER - (AN960-416)

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1H12
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

VIEW A-A

INSTRUMENT PANEL
Figure 41A. Vacuum System Installation
(PA-28-161 serial numbers 2816110 and up)

Added: July 30,1994

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 41A

A - Supplied as part of Vacuum Pump Drive Kit.

B - These fittings are used only when suction gauge is supplied without fittings.

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Added: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Pgure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING -Vacuum System Installation 2816110 and up

KIT - Vacuum pump drive

PUMP - Dry vacuum (211CC)
-
GASKET Vacuum pump mounting
CLAMP - (SAE TY F-8)
A -
NUT (114 - 20)
A -
WASHER (AN960-416)
NUT - (MS27151-12)
ELBOW
ELBOW
-
CLAMP (SAE r/ E-11)
HOSE - Vacuum pump exhaust
HOSE - Regulating valve to vacuum pump
WASHER - (AN960-1416L)
VALVE - Vacuum regulating (2H3-19)
CLAMP - Upper (SAE TY F-6)
-
CLAMP Lower (NAS397-12)
HOSE - Directional gyro to regulating valve
HOSE - Attitude gyro to regulating valve
CLAMP - (SAE TY F-6)
FITTING
FITTING - Lower
ADAPTER - Upper
HOSE - Vacuum source
HOSE - Vent
B FITTING
-
CLAMP (SAE TY F-4)
ADAPTER
ELBOW
CLAMP - (NAS397-12)
HOSE - Attitude gyro to air filter
HOSE - Directional gyro to air filter
-
FILTER ASSEMBLY Air (66673-00)
CARTRIDGE - Air filter
SPACER
-
WASHER (AN960-10)
-
NUT (MS 20365-1032C)

When ordering. always specify Part Number. Description, and Serial Nurnber of Aircraft

Added: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 41 8.Auxiliary Vacuum System Installation(1 of 2)

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 41 8.Auxiliary Vacuum System Installation (2 of 2)

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 5 1/I61 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 41B

A - Used on 14 volt system only.

B - Used on 28 volt system only.
C - Part of Kit 566 524.
D - Part of Kit 481 881.
E - Either circuit breaker may be used.
F - Not used on serial numbers 2816110 and up.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Auxiliary Vacuum Pump Installation

-
DRAWING Auxiliary Vacuum Pump Installation 2816110 and up

AUXILIARY AIR PUMP (4A3-1) -

AUXILIARY AIR PUMP (4A2-1) - 2816110 and up
CLAMP
-
RELAY (-44-2)
RELAY - (F7-64-1) 2816110 and up
FILTER ASSEMBLY - (F7-84-1)
BRACKET ASSEMBLY
BRACKET ASSEMBLY 2816110 and up
ELBOW - (1K1-6-lo)
HOSE
MANIFOLD ASSEMBLY - (1H5-24)
HOSE
HOSE
CLAMP - (SAE N F-8)
ELBOW - (1K1-6-8)
GASKET
GROMMET
CLAMP
SCREW - (MS35207-267)
SPACER
WASHER - (AN960-10L)
NUT - (MS20364-1032C)
HOSE
NIPPLE
NIPPLE
-
WASHER (AN970-3)
SCREW - (MS27039-1-22)
BOLT - (AN4-4A)
NUT - (MS20365-428C)
-
NUT (MS20364-632C)
VALVE - Suction regulating (2H3-19)
SWITCH - (R-16-3)
CIRCUIT BREAKER 20 Amp -
CIRCUIT BREAKER 20 Amp -
CIRCUIT BREAKER - 20 Amp 2816110 and up
ClRCUlT BREAKER 5 Amp -
CIRCUIT BREAKER - 5 Amp
C ~ R C U ~BREAKER
T - 5 Amp 2816110 and up
-
ETI ASSEMBLY (F7-97-1)
-
ETI ASSEMBLY (F7-97-2) 2816110 and up
SWITCH ASSEMBLY
SWITCH ASSEMBLY 2816110 and up
WlRE ASSEMBLY
WlRE ASSEMBLY 2816110 and up
WlRE ASSEMBLY
WlRE ASSEMBLY 2816110 and up
-
PLACARD Aux vac system circuit breakers
-
WASHER (AN-936-B10)
-
WASHER (AN-960-6)
-
WASHER (AN936-B6)
-
WASHER (AN960-416)
SCREW - (MS35206-230)
SCREW - (MS35207-261)
STRAP - (MS3367-5-9)
C,D -
PLACARD Caution....(B4-203-1)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 42. Pitot Static System installation

Reissued: December 1, 1989

1 H20
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 42

Used if encoding altimeter is installed.

Used if heated pitot head is installed.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.
Used on 28 volt system.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916092.
When ordering specify color red, bluetgreen, gold, black, green or 'bark 11'.
Used if Alternate Static System is installed.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216059.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Pitot Static System Installation

HEAD ASSEMBLY - Pitot (unheated) 1

HEAD ASSEMBLY - Pitot (heated) 1
HEATER CARTRIDGE 1
HEATER CARTRIDGE 1
HEAD ASSEMBLY - Pitot (heated) 1 28-8216060 and up
-
HEAD ASSEMBLY Pitot (heated) 1
-
HEAD ASSEMBLY Pitot (heated) 1 2816110and up
HEATER CARTRIDGE 1
HEATER CARTRIDGE 1
CONNECTOR - (1068 X 4) 2
' HOSE - Pitot 1
HOSE - Pitot 1
CLAMP - (SAE N F-4) 2
SUMP ASSEMBLY - Pitot Static 1
-
ELBOW Pitot static 2
-
VALVE (PS50036-2-2) 2
-
TEE (AN826-3D) 2
COUPLING (AN9lO-ID) - 2
VALVE ASSEMBLY - Static air vent 1
-
VALVE (CCA-7450) 1
SUMP ASSEMBLY - Pitot static 1 28-7816001 and up
ELBOW - Pitot static 2 28-7816001 and up
VALVE - (PS50036-2-2) 2 28-7816001 and up
-
TEE (AN826-3D) 2 28-7816001 and up
COUPLING - (AN910-1D) 2 28-7816001 and up
HOSE - Pitot Dressure 1
-
TUBE Pitot 1
TUBE ASSEMBLY Pitot static- 1
TUBE ASSEMBLY - Pitot static
TUBE ASSEMBLY - Pitot static
TUBE ASSEMBLY Pitot static-
TUBE ASSEMBLY - Pitot pressure 1
TUBE ASSEMBLY Pitot static- 1
TUBE ASSEMBLY - Pitot static 1
-
TUBE ASSEMBLY Pitot pressure 1
-
TUBE ASSEMBLY Pitot pressure 1
TUBE ASSEMBLY - Pitot static 1
TUBE ASSEMBLY Pitot static- 2
TUBE ASSEMBLY Pitot static- 1
TUBE ASSEMBLY - Pitot static 1
BUSHING 1
CLAMP - (PSI 0017-8-3) 1
-
ELBOW (AN821-3D) 2
-
ELBOW ( ~ ~ 8 2 2 - 3 ~ ) 4
TEE - (AN824-3D) 2
TEE - ( ~ ~ 8 2 5 - 3 ~ ) 1
UNION - (AN832-3D) 1
-
UNION (AN832-3D) 1
TUBE ASSEMBLY Pitot static- 1 28-7816001 ~ J I N 28-7916092
-
TUBE ASSEMBLY Pitot pressure 1 28-7816001 t h 28-791
~ 6092
TUBE ASSEMBLY Pitot static
-
CLAMP (PS10017-2-3)
- 2
6
28-7816001 and up

-
CLAMP (SAE N F-4) 6
GASKET 1Pitot head ' 1
GASKET Pitot head - 1
CLIP ASSEMBLY -Alternate static source 1
-
UNION (AN815-3D) 2
-
CLAMP (PS10017-2-4) 4
TUBE ASSEMBLY - Pitot static 1 28-7916093 and up
TUBE ASSEMBLY - Pitot pressure 1 28-7916093 and up
-
COVER ASSEMBLY Pitot static drain 1
PLACARD - Pitot drain 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1,1989

 PIPER AIRCRAFT
M y
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 43. Power Plant Installation

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
=? AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 43

A - Secure from Textron Lycorning, Williamsport, Pennsylvania..

B - See Figure 69 for component parts if a Prestolite alternator is installed. See Figure 70 for component parts if a Chrysler alternator is
installed. Component parts breakdown not yet available for 763 062 Alternator.
C - .". See Figure 61 if air conditioning is installed on PA-28-161. f
D - :Used on PA-28-151 with serial numbers 28-7415001,28-7415002,28-7415004 thru 28-7415421.
E -
F - ' Used on PA-28-161 only.
G -
H - ,Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 thru 2816109.
J - $ Used on PA-28-161 with serial numbers 28-7816001 and up if air conditioning is installed.
K - ;Used on PA-28-151 with serial numbers 28-7415001 thru 28-7715314 and on PA-28-161with serial numbers 28-7716001 thm
28-7816695.
L - Used only with carburetor air boxes that incorporate an aluminum flapper valve assembly.
M - Used if engine hour meter is installed.
N - Used on PA-28-161 with serial numbers 28-7916001 and up. When ordering for serial numbers28-7916001 thm 28-8116039.
ascertain if Part II of Service Letter 899 has been complied with (front spinner bulkhead is attached to spinner with eight screws) If
Part II has been complied with, order spinner only if Part ll has not been complied with, order one spinner PIN 36850-08, one front
spinner bulkhead PIN 87325-05. eight screws PIN 415 379 and eight washers PIN 494 227.
P - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA 28-161 with serialhumbers 28-7716001 thru 28-8116175,
28-8116177 t h 28-8216236.
~
Q - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA 28-161 with serial numbers 28-7716001 thru 28-8216236.
R - Used on PA-28-161 with serial numbers 28-7916001 and up When ordering for serial numbers 28-7916001 thru 28-8116039, ascertain
if Part ll of Service Letter 899 has been complied with (front spinner bulkhead is attached to spinner with eight screws). If Part II has
been complied with, order spinner bulkhead only i f Part II has not been complied with, order one front spinner bulkhead PIN 87325-05,
eight screws PIN 415 379, eight washers PIN 494 227 and modify existing spinner per Part II of Sewice Letter 899.

Revised: July 30. 1994

 PIPER AIRCRAFT
4:. . PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
~umbgr

43- 35106 -
DRAWING Power Plant Installation
35127 K -
DRAWING Propeller and Spinner Installation, Sensenich I
36851 -
DRAWING Propeller and Spinner Installation, Sensenich 28-7916001 and up
35483 DRAWING - Propeller and Spinner Installation, McCauley
35491 -
DRAWING Induction Air System Installation

ENGINE - Lycoming (0-320-E3D) 28-7415001 thr~28-7715314

ENGINE - Lycoming (0-320-D3G) with Slick magnetos 28-7716001 and up
-
ENGINE Lycoming (0-320-D2A) with Bendix magnetos 28-7716001 and up
-
ENGINE Lycoming (0-320-D3G) with Slick magnetos 2816110andup
SPINNER Propeller -
SPINNER - Propeller
SPINNER - Propeller
BULKHEAD ASSEMBLY - Spinner, front
BULKHEAD ASSEMBLY Spinner, front -
BULKHEAD ASSEMBLY Spinner, rear (PAC 35323-15) -
BULKHEAD ASSEMBLY - Spinner, rear (PAC 36757-07) 28-7916001 and up
PROPELLER - McCauley(lC160/EGM7653) b

-
PROPELLER Sensenich (74DM6-0-58)
PROPELLER - Sensenich (74DM6-0-60)
MOUNT ASSEMBLY - Engine and nose gear strut
SUPPORT ASSEMBLY Engine controls -
MOUNT - Engine (J9613-40) top left, bottom right
MOUNT - Engine (J9613-53) top right, bottom left
BOX ASSEMBLY - Carburetor air
BOX ASSEMBLY - Carburetor air
VALVE ASSEMBLY - Carburetor air box
MOUNT BOLTS - (AN74A-4)
..GROMMETS * (MS35489-41)
BEARINGS (PS10065-23) -
BOTTOM ASSEMBLY - Carburetor air box
BOX ASSEMBLY - Carburetor air filter
* FILTER ASSEMBLY - Carburetor air
' ' ELEMENT - Filter
' RETAINER Filter -
BOX ASSEMBLY Air filter, lower -
-
' SEAL Air filter box
RECEPTACLE - (PS10077-2-62)
RETAINER - Filter
RETAINER - Filter
BOX ASSEMBLY - Air filter, upper
-
' ' SEAL Air filter box
-
STUD (PS 10077-2-19)
-
. SPRING (PS10077-2-60)
WASHER - (PS10077-2-61)
RETAINER (PS10077-2-64) -
-
ALTERNATOR (Lycoming 32C19553, ElectroSystems
ALU 8421LS) 2816110 and up
-
BELT Alternator
VALVE ASSEMBLY Oil drain -
HOSE ASSEMBLY - Flexible, oil pressure
-
HOSE Engine breather
-
HOSE Carburetor air
-
UNION (AN815-4) Oil pressure
TUBE ASSEMBLY Oil pressure -
-
TUBE Engine breather
TUBE ASSEMBLY
TUBE - Engine breather
SLEEVE - (RES-R4522) (187 146)
CABLE TIES (MS3367-1-9) -

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
3 - AIRPLANE PARTS CATALOG
- --- -

Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

ELBOW - Oil pressure 1

ELBOW - Oil pressure 1
PLATE - Firewall grommet 4
GROMMET - Firewall seal 4
-
GASKET Firewall seal 2
-
GASKET Carburetor air box 1
-
BOLT (AN6-14) 1
WASHER - (STD 33) 1
SHIM - (76534) AR
-
WASHER (AN960-616L) AR
-
NUT (STD 872) 2
COTTER PIN - (STD 713) 2
SCREW - (MS90725-15) 2
WASHER (AN936-A416) - 2
WASHER - (AN960-416) 2
BOLT - Top, engine to mount (AN7-43A) 2
WASHER - Engine mount (AN960-716) 2
NUT - Engine mount (MS20365-720C) b 2
-
BOLT Bottom, engine to mount (AN7-44A) 2
WASHER - Engine mount (AN960-716) - 2
NUT - Engine mount (MS20365-720C) 2
CLAMP - Engine breather hose (SAE TY A-718) 2
CLAMP - (SAE TY A-3 3116) 4
BOLT - (AN6-13) 1
WASHER - (STD 33) 1
SHIM - (76534) AR
WASHER - (AN960-616L) AR
NUT - (STD 872) 1
COTTER PIN (STD 713) - 1
TUBE ASSEMBLY -Oil pressure, aft 1
TUBE ASSEMBLY -Oil pressure, forward 1
TEE - Bulkhead fitting 1
SWITCH - (M-4011-35) 1
WASHER - (AN960-716L) 1
NUT - (AN924-4) 1
TEE - (118 MMS-S) 1
SWITCH - (M-4006-4) 1
-
WIRE ASSEMBLY Starter to starter solenoid 1
-
DUCT Carburetor air intake 1
SCREW - (MS51958-63) 18
WASHER - (PS10063-2) 18
SWITCH -Oil pressure 1 2816110 and up
TEE - (118 MMS-S) 1 2816110 and up
-
SENDER Oil pressure 1 2816110 and up
-
CONNECTOR Bulkhead (4-WGTX-S) 1 2816110 and up
NUT - (AN924-4) 1 2816110 and up
TUBE ASSEMBLY 1 2816110 and up
WASHER - (AN960-716L) 2 2816110 and up

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Revised: July 30, 1994

114
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
a. *
w . AIRPLANE PARTS CATALOG

Figure 44. Engine Exhaust System Installation

Reissued: December 1.1989

115
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 44

A - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 7716323.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

44- 35 136 -
DRAWING Engine Exhaust System Installation
i

-1 35300-00 -
STACK ASSEMBLY Left front 1
-2 ' 35301-00 STACK ASSEMBLY - Left rear 1
-3 62230-00 A STACK ASSEMBLY - Right front 1
37922-02 -
STACK ASSEMBLY Right front 1 28-7816001 and up
-4 62232-00 STACK ASSEMBLY - Right rear 1
-5 35302-02 MUFFLER ASSEMBLY - Complete 1 28-7415001 thm 28-7715314
35302-03 MUFFLER ASSEMBLY - Complete 28-7716001 thw 28-8616057
I and2816001 andup
-6 66894-03 MUFFLER ASSEMBLY 2
-7 35303-02 SHROUD ASSEMBLY - Muffler, bottom 1
-8 35631-00 ' SHROUD ASSEMBLY - Muffler, takeoff 1
-9 3563 1-04 " ' SCREEN 1
-10 99568-02 SHROUD ASSEMBLY - Muffler, top 1 28-7415001 thru 28-7715314
99568-03 SHROUD ASSEMBLY - Muffler, top 5
28-7716001 t h 28-8616057
~
1 and 2816001 and up
-11 63243-02 CLAMP ASSEMBLY - Exhaust stack .A? 2
-12 400103 -
BOLT (AN4-6) 2
407 565 WASHER - (AN960-416) 4
404 101 NUT - (AN310-4) 2
424 051 COTTER PIN - (MS24665-132) 2

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

117
 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
.- AIRPLANE PARTS CATALOG

Figure 45. Engine Baffle Installation

Reissued: December 1, 1989

118
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
-
.&- i
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 45

A - Used on PA-28-151 with serial numbers 28-7415001,28-7415002,28-7415004 thru 28-7415421.

B - Used on PA-28-151 with serial numbers 28-7415003,28-7415422 and up, and PA-28-161 with serial numbers 28-7716001 thru
28-7716323.
C - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 fhru 28-7716323.
D - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8116175,
28-8116177 thru 28-8216236.

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
C - a -AIRPLANE PARTS CATALOG
Figure
and . Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Engine Baffle Installation

F
C BAFFLE ASSEMBLY - Left front
BAFFLE ASSEMBLY - Left front 28-7816001 and up
A BAFFLE ASSEMBLY - Right front
B BAFFLE ASSEMBLY - Right fron
C -
BAFFLE ASSEMBLY Right front 28-7816001 and up
BAFFLE ASSEMBLY - Left side, front
BAFFLE ASSEMBLY - Right side, front
D BAFFLE ASSEMBLY - Left side, rear
BAFFLE ASSEMBLY - Left side. rear 28-8116176 and
28-8316001 and up
BAFFLE ASSEMBLY - Right side, rear
D BAFFLE ASSEMBLY - Left, rear
BAFFLE ASSEMBLY - Left. rear 28-8116176 and
28-8316001 and up
BAFFLE ASSEMBLY - Right, rear
C BAFFLE ASSEMBLY - Right front
BAFFLE ASSEMBLY - Right front 28-7816001 and up
BRACKET - Rear baffle reinforcement
PLATE - Baffle magneto harness
TIE ROD - Baffle assembly
BUSHING - Baffle tie rod
BOLT - (AN4-5A)
WASHER - (AN960-416L)
NUT - (MS20364-428C)
BOLT - (AN4-1%)
-
WASHER (AN960-416)
NUT - (MS20365-428C)
SCREW - Cap (114 x 20 NC-3 x 112)
WASHER - Lock (AN936-A416)
WASHER - (AN960-416)
PLACARD - Oil spec

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1110
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
*A y?. AIRPLANE PARTS CATALOG

Figure 46. Oil Cooler Installation

Reissued: December 1, 1989

1111
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 46

Reissued: December 1. 1989

 PIPER AIRCRAFT
*.-? c
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
r?gure
and Part No. Serial Nunabers
Index Number Code Nomenclature R-4. Affected
Nurnbzr
-
DRAWING Oil Cooler Installation

COOLER ASSEMBLY -Oil

HOSE ASSEMBLY - Oil cooler inlet
HOSE ASSEMBLY - Oil cooler outlet
DEFLECTOR -Oil cooler
-
SEAL ASSEMBLY Oil cooler
-
TUBE Spacer
ELBOW - (AN823-8)
ELBOW - (AN822-8D)
NIPPLE - (AN816-8)
ADAPTER - (WIH 3200 X 6)
BOLT - (AN3-41A)
WASHER - (AN960-10L)
NUT - (MS20365-1032C)
WINTERIZATION KIT ASSEMBLY - Oil cooler

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1113
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 47.Engine Cowl Installation

Reissued: December 1, 1989

1114
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 47

A - - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-77'16001 thru 28-7716323.
B - Used on PA-28-161 with serial numbers 28-7816001 thru 28-8116175 and 28-8116177 thru 28-8216236.
'

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
.,
AIRPLANE PARTS CATALOG
Figure
and .. Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Cowl Installation
I

COWL ASSEMBLY - Engine top, complete

-
COWL ASSEMBLY Engine top, complete 28-7816001 and up
COWL ASSEMBLY - Engine top, center
-
' ' HINGE HALF Right
" HINGE HALF Left-
COWL ASSEMBLY - Engine side. left
COWL ASSEMBLY - Engine side, left 28-7816001 and up
COWL ASSEMBLY - Engine side, right
COWL ASSEMBLY - Engine side, right 28-7816001 and up
' ' HlNGE HALF - Left
-
' HINGE HALF Right
' FASTENER ASSEMBLY - Engine cowl
' ' RETAINER - (85-34-101-20)
" ' STUD - (5-W-18)
* ROD ASSEMBLY - Cowl support
' ' CLlP - Cowl rod support
' ' CLlP - Cowl rod catch (127002)
^ ' BOLT - (AN3-4A) .53 long
' BOLT - (AN3-5A) .65 long
. WASHER - (AN960-10L)
' NUT - (MS20365-1032C)
-
" PLATE Cowl
COWL ASSEMBLY - Engine bottom, complete
COWL ASSEMBLY - Engine bottom, complete
COWL ASSEMBLY - Engine bottom, complete 28-8116176 and
28-8316001 and up
PLATE ASSEMBLY - Lower cowl closure
RECEPTACLE - (5-295)
CUP - Cowl fastener
COWL ASSEMBLY - Nose, left
-
COWL ASSEMBLY Nose, left
* COWL ASSEMBLY - Nose, left 28-8116176 and
28-8316001 and up
COWL ASSEMBLY - Nose, right
-
COWL ASSEMBLY Nose, right
-
' COWL ASSEMBLY Nose, right 28-8116176 and
28-8316001 and up
' ' DOUBLER ASSEMBLY - Cowl, bottom
-
* LOUVER Bottom cowl 28-8116176 and
28-8316001 and up
COWL ASSEMBLY - Nose
COWL ASSEMBLY - Nose 28-7816001 and up
-
COWL ASSEMBLY Nose, upper
COWL ASSEMBLY - Nose, upper 28-7816001 and up
-
COWL ASSEMBLY Nose, lower
COWL ASSEMBLY - Nose, lower 28-7816001 and up
SUPPORT ASSEMBLY Lower cowl -
WASHER - (.62 O.D. x .062 thick)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1116
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 48. Engine Controls Installation

Reissued: December 1, 1989

1117
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
..- -
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 48

A - Used if a 2.72 L quadrant adjusting handle (PIN 66773-00) is installed

B - Used if a 2.94 L. quadrant adjusting handle (PIN 63039-04) is installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number.

48- 35129 -
DRAWING Engine Controls Installation

QUADRANT ASSEMBLY Control -

LEVER ASSEMBLY -Throttle
' * KNOB -Throttle lever
LEVER - Mixture control
KNOB - Mixture control (571 044)
A BOLT - (AN25-52)
B BOLT - (AN5-30)
^ BRACKET ASSEMBLY - Quadrant,
BRACKET ASSEMBLY -Quadrant,
HANDLE -Quadrant adjusting (2.72' L.)
HANDLE -Quadrant adjusting (2.94' L.)
PLATE - Quadrant friction
PLATE - Quadrant friction
CAM -Quadrant adjusting
PIN - Quadrant, friction plate
' SPACER - Quadrant
WASHER
' WASHER - (AN960-516L)
NUT - (AN320-5)
* COTTER PIN - (MS24665-13)
* WASHER - (3502-18-04)
' SCREW - (AN526-832R6)
' SCREW - (AN507-4R4)
' NUT - (A109-014-1)
CONTROL ASSEMBLY - Throttle (PS50146-13-6)
-
CONTROL ASSEMBLY Mixture (PS50146-13-4)
CABLE ASSEMBLY - Carburetor heat (PS50146-1-4)
CONTROL MOUNT - Caburetor heat
BEARING - (PSI 0020-16-2)
SUPPORT ASSEMBLY - Engine control
RETAINER Engine controls -
CLAMP - Control cable
FITTING -Swivel
CLEVIS - Carburetor heat control
TERMINAL (AN665-21R) -
WASHER - (MS35338-41)
NUT - (AN315-3R)
WASHER - (MS35338-43)
-
NUT (AN315-3R)
SCREW (AN23-12) -
WASHER - (AN960-10)
-
NUT (AN310-3)
COTTER PIN - (MS24665-132)
-
PIN (MS20392-2Cll )
WASHER - (AN960-10L)
COTTER PIN - (MS24665-132)
-
STUD Swivel fitting
WASHER (AN960-10) -
-
NUT (AN320-3)
COTTER PIN - (MS24665-132)
-
BUSHING Mixture control fitting

When ordering. always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
6 * AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-151f161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 49. Forward Fuel System Installation

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 49

A - Used on PA-28-151 with serial numbers 28-7517394 and up. and PA-28-161.
B - Used i f Engine Primer System is not installed.
C - Used if Engine Primer System is installed.
D - a Used with 118' I.D. hose. F
E - Used with 3/16, I.D. hose.
F - Used on PA-28-151 only.
G - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
H - Used on PA-28-161 only.
:
J - " Used if Electric Primer System is installed.
K -:On airplanes with Electric Primer System installed, see Figure 65A for Electric Primer Switch.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
AIRPLANE PARTS CATALOG
-- -
-

gure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
DRAWING Engine Primer Installation
-
DRAWING Forward Fuel System Installation F
-
DRAWING Electric Primer System Installation 2816110 and up

-
PUMP Primer (K2406-SAE-2)
PUMP ASSEMBLY - Electric fuel, 14 volt
PUMP ASSEMBLY - Electric fuel, 28 volt
-
PUMP Electric fuel, 14volt
PUMP - Electric fuel, 28 volt
' GASKET - Cover (479136)
' SCREEN - Filter (479135)
GASCOLATOR ASSEMBLY - Fuel
COVER - Fuel strainer
BOWL ASSEMBLY - Gascolator
' ELBOW - (AN915-1D) Drain
VALVE - (CCA-I 550) Drain (CCA-36150) b
' SCREEN - Fuel strainer
GASKET (44 PA) -
* WIRE - Bail (1 PAS)
* PLUG - (AN932-2)
NIPPLE - (AN816-6)
BRACKET - Primer tee
HOSE ASSEMBLY - Flexible, primer line (118' 1.D.)
HOSE ASSEMBLY - Flexible, primer (3116' I.D.)
HOSE ASSEMBLY - Flexible, to pressure gauge
HOSE ASSEMBLY - Flexible, dectric pump to engine pump
HOSE ASSEMBLY Flexible -
-
HOSE Flexible, engine fuel pump vent
TUBE ASSEMBLY - Fuel gascolator to electric pump
TUBE ASSEMBLY - Primer
TUBE ASSEMBLY - Primer
TUBE ASSEMBLY - Primer
TUBE ASSEMBLY - Primer
TUBE ASSEMBLY - Primer
TUBE ASSEMBLY - Primer
-
TUBE ASSEMBLY Fuel pressure to gauge
TUBE ASSEMBLY - Fuel pressure to gauge
JET ASSEMBLY - Primer
PLATE - Fire wail seal
-
PLATE Fire wall seal
DISC - Fire wall seal
-
DlSC Fire wall seal
GASKET - Fire wall seal
GASKET - Fire wall seal
GROMMET - Fire wall seal
SPACER - Fuel pump mounting
ELBOW - 45 degrees (restricted)
ELBOW - (MS20822-6)
-
ELBOW (AN823-6)
ELBOW - (AN833-6)
ELBOW - (RAC2000-6)
ELBOW - (AN837-6)
ELBOW - (RAC4500-6)
ELBOW - (1K1-2-4)
ADAPTER - (WM 3200 x 4 x 2)

When ordering, always specify Part Number, Description, and S e M l Number of Aircraft

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
-Y_. AIRPLANE PARTS CATALOG

Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number
- -

BUSHING - Reducer (AN912-IC)

CONNECTOR - (WIH 200 x 2)
BRACKET ASSEMBLY - Gascolator
-
NIPPLE (AN816-6-2)
-
NIPPLE ('23069 x 4)
REDUCER - (AN919-2)
-
TEE (AN824-2D)
-
TEE (MS20825-2D)
TEE - (C3709 X 4)
TEE - ( W N 702 X 2)
UNION - (AN81 5-2D)
-
REDUCER (AN919-OD)
NUT - (AN924-6)
O-RING - (MS29512-6)
CLAMP - Primer tee
CLAMP - Primer tee
CLAMP - Primer line I
CLAMP - Primer line
-
COUPLING (AN91O-ID)
NIPPLE - (AN816-3D)
TEE - (AN825-6) 2816110 and up
HOSE ASSEMBLY - Flexible 2816110 and up
BUSHING - (AN894-6-4) 2816110 and up
NIPPLE - (AN816-4) 2816110 and up
VALVE ASSEMBLY - Solenoid (28 volt) 2816110andup
VALVE - Solenoid (28 volt) 2816110 and up
CLAMP 2816110andup
CLAMP 2816110 and up
SCREW - (MS35206-245) 2816110 and up
NUT - (MS20364-832C) 2816110 and up
-
WASHER (AN960-10L) 2816110 and up
HOSE ASSEMBLY - Flexible 2816110andup
ADAPTER - (AN816-3) 2816110 and up
COUPLING - (3300 X 2) 2816110 and up
-
SENDER Pressure 2816110 and up
CLAMP 2816110andup
CLAMP 2816110 and up
-
SCREW (MS35206-245) 2816110 and up
-
NUT (MS20364-832C) 2816110 and up
-
WASHER (AN960-10L) 2816110andup

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1124
 PIPER AIRCRAFT
PA-28-1 51M61 WARRIOR
*s: -
AIRPLANE PARTS CATALOG

Figure 50. Aft Fud System Installation

(28-7415001 !ht~28-7515459)

Reissued: December 1, 1989

1J1
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
sI AIRPLANE PARTS CATALOG
----

CODE EXPLANATIONS FOR FIGURE 50

Reissued: December 1. 1989

 PIPER AIRCRAFT
2 L
PA-28-151M 61 WARRIOR
Z-
AIRPLANE PARTS CATALOG
lgure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

50- 35294 DRAWING - Aft Fuel System installation

i

-1 35532-00 MANIFOLD ASSEMBLY - F d 2

-2 67661-00 GUARD - Fuel line 1
-3 492 022 VALVE - (CCA-1550) 2
-4 491 947 VALVE - Fuel selector (6S122) 1
-5 99754-02 SUPPORT ASSEMBLY - Fuel selector cover 1
-6 97499-18 HOSE ASSEMBLY - Flexible, Fuel tank to fuel line, aft 2 28-7415001 t h 28-741
~ 5642
63901-75 HOSE ASSEMBLY - Flexible. fuel tank to fuel line, aft 2 28-7415643 t h 28-751
~ 5459
-7 63901-15 HOSE ASSEMBLY - Flexible, fuel line to manifold assembly,
left 1
-8 63901-75 HOSE ASSEMBLY - Flexibfe, fuel line to manifold assembly,
right 1
-9 63901-46 HOSE ASSEMBLY - Flexible, fuel tank to fuel line, forward 2 28-7415001 thm 28-7415642
63901-71 HOSE ASSEMBLY - Flexible, fuel tank to fuel line, forward 2 28-7415643 thm 28-75 15459
-10 67700-77 TUBE ASSEMBLY - Fuel tank to manifold assembly, aft 2 28-7415001 thru 28-74 15642
67700-91 TUBE ASSEMBLY - Fuel tank to manifold assembly, aft' 2 28-7415643 thw 28-7515459
-11 67700-78 TUBE ASSEMBLY - Fuel tank to manifold assembly, forwardw 2 28-7415001 thm 28-7415642
67700-92 TUBE ASSEMBLY - Fuel tank to manifold assembly, forward 2 28-7415643 t h 28-751
~ 5459
-12 62305-00 TUBE ASSEMBLY - Fuel line 1
-13 67700-79 TUBE ASSEMBLY - Fuel line 1
-14 67700-63 TUBE ASSEMBLY - Fuel line 1
-15 67700-64 TUBE ASSEMBLY - Fuel line 1
-16 458 895 ELBOW - (MS20822-6D) 1
-17 458 868 ELBOW - (MS20822-6) 6
-18 476662 NIPPLE - (AN816-6D) 5
-19 491 062 UNION - (AN832-6D) 4 18-7415001 thr~28-7415642
491 052 UNION - (AN8156D) 4 28-7415643 t h 28-751
~ 5459
-20 491 082 UNION - (6H12D) 1
-21 458 913 ELBOW - (AN837-6D) 1
-22 458 892 ELBOW - (AN823-6D) 1
-23 458 882 ELBOW - (AN821-6D) 1
-24 407 597 WASHER - (AN960-916L) 4 28-7415001 t h r ~28-7415642
477 620 NUT - (AN924-6D) 4 28-7415001 t h 28-741
~ 5642

When ordering, always specify Part Number. Description. and Serial Number of Aircraft

Reissued: December 1,1989

1J3
 PIPER AlRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 51. Aft Fuel System Installation

(28-761 5001 and up and 28-771 6001 and up)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 51

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
-
-

Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

51- 35645 -
DRAWING Aft Fuel System Installation

f
-1 491 947 VALVE - Fuel selector (68122) 1
-2 67661-00 GUARD - Fuel line 1
-3 99754-02 SUPPORT ASSEMBLY - Fuel selector cover 1
-3a 587 297 -
SPRING Fuel Selector Stop 1
-4 62305-00 TUBE ASSEMBLY - Fuel line 1
-5 67700-25 TUBE ASSEMBLY - Fuel line, left 1
-6 67700-56 TUBE ASSEMBLY - Fuel line, right 1
-7 67700-57 TUBE ASSEMBLY - Fuel line, left 1
-8 98044-70 TUBE ASSEMBLY - Fuel line, left 1
-9 98044-71 -
TUBE ASSEMBLY Fuel line 2
-10 98044-72 TUBE ASSEMBLY - Fuel line, right 1
-11 476 662 NIPPLE - (AN816-GD) 3
-12 458 895 -
ELBOW (MS20822-6D) 1
-13 458 892 ELBOW - (AN8236D) 1
-14 491082 UNION - (6H12D) 5
-15 477 670 NUT - (6B12D) 2
-16 460 464 FERRULE - (6T12D) 2

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued December 1,1989

1J6
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
9 .,=- AIRPLANE PARTS CATALOG

Figure 52. Fuel Tank Assembly

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
a I_ AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 52

Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161.

Used with fuel cap assembly PIN 66817-00 only. I

Used with Fuel Cap Assembly Kit PIN 39830-800 only.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with setial numbers 28-7716001 thru 28-8116268
and 28-8216007, 28-8216014, 28-8216017,28-8216019, and 28-8216021.
Used on PA-28-161 with serial numbers 28-8116269 thru 28-8216006,28-8216008 t h 28-8216013
~ and 28-8216015,28-8216016,
28-8216018,28-8216020,28-8216022 and up.
Kit includes (2) cap assemblies with matching locks.

Reissued: December 1,1989

 PIPER AIRCRAFT
e ' h
PA-28-1 51M 61 WARRIOR
't
AIRPLANE PARTS CATALOG
-lgure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
TANK ASSEMBLY Fuel, left
-
TANK ASSEMBLY Fuel, right
TANK ASSEMBLY - Fuel, left
TANK ASSEMBLY - Fuel, right
-
CAP ASSEMBLY Fuel tank (non-locking)
CAP ASSEMBLY - Fuel tank, (with locks) 28-7716001 and up
* CAP ASSEMBLY KIT - Fuel tank (with locks)
' GASKET - Fuel cap
' GASKET - Fuel cap
" VALVE - Fuel cap vent (VA3123)

' ' LOCK ASSEMBLY - Fuel cap

-
' GASKET Fuel gauge (15-423)
-
* ADAPTER (AN840-4D) with bead
-
ADAPTER (1068 x 6 x 2) without bead
-
STRAINER ASSEMBLY Fuel tank ouflet
STRAINER ASSEMBLY - Fuel tank outlet
OUTLET ASSEMBLY - Fuel tank, forward
OUTLET ASSEMBLY - Fuel tank, aft
OUTLET ASSEMBLY - Fuel tank. left
OUTLET ASSEMBLY - Fuel tank, right
FILLER NECK ASSEMBLY
' PLATE - Drain
VENT TUBE - Left (with bead)
VENT TUBE - Right (with bead)
^ VENT TUBE - Left (without bead)
VENT TUBE - Right (without bead)
* VENT TUBE - Fuel tank, left
VENT TUBE - Fuel tank, right
' HOSE - Connector
' HOSE - Connector
CLAMP - (SAE TY F-4)
SCREW - (AN502-10-10)
-
WASHER (AN935-10)
SAMPLER - Fuel
PLACARD Fuel -
PLACARD - Fuel
PLACARD - Fuel
-
SENDER Fuel
SENDER - Fuel (PS10013-11)
GASKET - Fuel sender (15-716)
-
VALVE Drain (CCA-1550)
WASHER - (AN960-10)
DECAL - Avgas only (000002)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1J9
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
.
24
AIRPLANE PARTS CATALOG

Figure 53. Control System Installation

Reissued: December 1, 1989

1J11
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
h : AIRPLANE PARTS CATALOG

CODE EXPLANATlONS FOR FIGURE 53

A - Used on PA-28-151 with serial numbers 28-7715254 and up, and PA-28-161.
B - Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161.

Reissued: December 1, 1989

 PIPER AIRCRAFT
45-
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Nvmbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING - Control System Installation

F

-
CABLE Forward aileron
-
CABLE Aileron, wing
CABLE - Aileron balance, left
CABLE - Aileron balance, right
-
CABLE Forward ~ d d e r
CABLE - Aft rudder
CABLE - Forward stabilator, left
-
CABLE Forward stabilator, right
CABLE - Aft stabilator, bottom
-
CABLE Aft stabilator, top
PULLEY - 2 314' diameter
PULLEY
PULLEY
-
PULLEY (MS20220-2)
BELLCRANK ASSEMBLY -Aileron, left
BELLCRANK ASSEMBLY - Aileron, right
-
BELLCRANK ASSEMBLY Aileron, left
-
BELLCRANK ASSEMBLY Aileron, right
A BELLCRANK ASSEMBLY - Aileron, left
A BELLCRANK ASSEMBLY - Aileron, right
ROD - A~leron
B ROD - Aileron
BEARING - Rod end (PS10020-21RX)
CLEVIS - Rod end (MS35812-2)
B BEARING - Rod end (PSI0020 2 1RX)
NUT - Lock (AN316 4R)
STOP - Aileron bellcrank
BRACKET - Pulley
FILLER BLOCK
FAIRLEAD
FAIRLEAD
SPACER - Bushing
SPACER - Bushing
-
SPACER Bushing
SPACER - Bushing
SPACER - Bushing
BEARING - lnner
BEARING Outer -
BEARING lnner -
BEARING lnner -
BEARING - Outer
-
BUSHING Aileron bellcrank
A -
BUSHING Aileron bellcrank
BUSHING
BUSHING - Stabilator pulley
BUSHING Rod end -
BUSHING - Aileron bellcrank
A -
BUSHING Aileron bellcrank
PIN - Cable guard
PIN - Cable guard
BARREL - Turnbuckle (MS21251-05s)
CLIP - (MS21256-1 )
BOLT - (AN3-5A)
-
WASHER (AN960-10)
NUT - (MS20365-1032C)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
BOLT (AN3-10)
-
BOLT (AN23-16)
WASHER - (AN960-10L)
-
WASHER (AN960-10)
WASHER - (AN960-10L)
-
NUT (AN310-3)
NUT - (AN320-3)
-
COTTER PIN (MS24665-132)
BOLT - (AN3-11A)
-
WASHER (AN960-10)
WASHER - (AN960-10L)
NUT - (MS20365-1032C)
-
BOLT (AN3-32A)
BOLT - (AN3-63A)
WASHER - (AN960-10)
NUT - (MS20365-1032C)
BOLT - (AN4-13A)
-
WASHER (AN960-416)
-
NUT (MS20365-428C)
BOLT - (AN5-IOA)
-
WASHER (AN960-516)
NUT - (MS20365-524C)
BOLT - (AN5-12A)
WASHER - (AN960-516)
NUT - (MS20365-524C)
BOLT - (AN5-13A)
-
WASHER (AN960-516)
-
NUT (MS20365-524C)
BOLT - (AN5-53A)
-
WASHER (AN960-516)
NUT - (MS20365-524C)
BOLT - (AN5-64A)
WASHER - (AN960-516)
NUT - (MS20365-524C)
BOLT -Clevis (AN23-12)
WASHER - (AN960-10)
NUT - (AN320-3)
-
PIN Cotter (MS24665-132)
BOLT - (NAS1103-7D)
WASHER - (AN960-10)
WASHER - (AN960-10L)
-
NUT (MS17826-3)
COTTER PIN - (MS24665-132)
BOLT - (AN5-lo)
-
WASHER (AN960-516)
-
NUT (AN310-5)
PIN - Cotter (MS24665-136)
SCREW - (MS35206-231)
-
NUT (AN315-3R)
WASHER - (AN960-516)
WASHER - (AN960-516L)
WASHER - (AN960-616)
PIN - Cotter (MS24665-132)
PIN - Cotter (MS24665-134)
-
PIN Cotter (MS24665-136)
-
PIN Cotter (MS24665-138)
-
PIN Cotter (MS24665-140)
WASHER - (97322)
PLATE - Aileron centering
SPRING - Aileron centering

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1J14
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
-5
AIRPLANE PARTS CATALOG
bl

Figure 54. Flap Control Installation

Revised: July 30, 1994

1515
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 54

A - Used if two or more toque shaft support shims, PIN 35402-04, are installed with each torque shaft support clamp assembly.
B - See latest revision of Piper Service Bulletin 965.

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
&!
AIRPLANE PARTS CATALOG
j,

--1gure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Control System Installation

FLAP TORQUE TUBE ASSEMBLY - Complete

' TORQUE TUBE - Flap
* SPROCKET ASSEMBLY -
Flap torque tube
BOLT - (AN4-16A)
WASHER - (AN960-416)
NUT - (MS20365-428)
LEVER ASSEMBLY - Flap control
BRACKET ASSEMBLY - Flap lever
BUSHING - Flap lever
' HANDLE ASSEMBLY - Flap lever
' ' TUBE ASSEMBLY - Flap lever
' ' PLUNGER ASSEMBLY Flap lever -
' ' TUBE - Plunger
* ^ ' PLUG - Plunger, upper
-
' ' ' PLUG Plunger, lower
" ' WASHER
' ' ' SPRING
' ^ ' PIN - Roll (59-022-094-0625)
* ' GRIP - Flap lever
' PIN - Roll
" ' PIN - Roll (59-012-062-0625)
BOLT - (AN3-15A)
WASHER - (AN960-10)
-
NUT (MS20365-1032C)
-
CLAMP ASSEMBLY Toque shaft support
ROD ASSEMBLY - Flap tube
^ BEARING - (F34-14 R.H. Thread)
BEARING - (FL34-14 L.H. Thread)
TUBE - Flap
' NUT - (AN316-4R R.H. Thread)
NUT - (AN316-4L L.H. Thread)
CHAIN - (65 Diamond 118 roller, 8.5' L.)
CHAIN - (65 Diamond 118 roller, 6 0' L.)
CABLE ASSEMBLY Flap -
SPRING - Flap return
-
SPRING Flap cable tension
PULLEY - Flap
BEARING - Outer
BEARING - Inner
FlITlNG ASSEMBLY - Left
FllTlNG ASSEMBLY - Right
TUBE ASSEMBLY - Flap toque tube, left
-
TUBE ASSEMBLY Flap toque tube, right
-
BUSHING Flap bellcrank
BUSHING - Flap rod end
BUSHING
FORK - (NAS645-22RS)
-
BARREL (MS21251-B5S)
-
CLIP (MS21256-1)
SHACKLE (ANI15-16) -
BOLT - (AN3-4A)
-
BOLT (AN3-12A)
WASHER (AN960-10)-

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30.1994

1517
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
I +
.
, AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number
- --

BOLT - (AN3-5A) 1
WASHER - (AN960-10) 1
NUT - (MS20365-1032C) 1 f
BOLT - (AN3-6A) 4
BOLT - (AN3-7A) 4
WASHER - (AN960-10) 4
WASHER - (AN960-10) 12
-
NUT (MS20365-1032C) 4
BOLT - (AN4-7A) 1
WASHER - (AN960-416L) 1
-
NUT (MS20365-428C) 1
-
BOLT (AN4-2OA) 4
-
WASHER (AN960-416) 4
-
NUT (MS20365-428C) 4
BOLT - (AN21-8) 1
WASHER (AN960-6)- 1
NUT - (AN320-1) 1
PIN - Cotter (MS24665-5) b
1
-
BOLT Clevis (AN21-9) 2
WASHER - (AN960-6) 4
NUT - (AN320-1) 2
PIN - Cotter (MS24665-5) 2
BOLT - (AN21-9) 1
NUT - (AN320-1) 1
PIN - Cotter (MS24665-5) 1
BOLT - (AN23-11) 1
WASHER - (AN960-10) 1
BUSHING 1
NUT - (AN320-3) 1
PIN - Cotter (MS24665-132) 1
BOLT - (AN23-18) 2
WASHER - (AN960-10) 2
NUT - (AN310-3) 2
PIN - Cotter (MS24665-132) 2
SCREW - (MS35207-269) 2
NUT - (AN315-3R) 2
-
PIN Cotter (MS24665-134) 1
PLACARD - Flap lever - 1 28-7716001 and up
-
SHIM Toque shaft support AR

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

1J18
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
>&-.
AIRPLANE PARTS CATALOG

Figure 55. Stabilator Trim Installation

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATlONS FOR FIGURE 55

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
',&
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Control System Installation
-
DRAWING Stabilator Trim Installation

CABLE - Stabilator trim, aft

-
CABLE Stabilator trim, foward
WHEEL ASSEMBLY - Trim tab
BRACKET ASSEMBLY Trim tab-
-
PLATE ASSEMBLY Trim wheel
CLlP - Stab~latortrim
BRACKET - Trim tab
BRACKET - Stabilator trim pulley
GUARD - Trim pulley
GUARD - Pin holder
GUARD - Cable
SHAFT - Stabilator trim
PLATE - Stabilator trim
CLlP - Stabilator trim
LINK - Stabilator trim
SNAP RING - (5108-75)
ARM ASSEMBLY - Stabilator trim
GUARD - Cable
BEARING -Thrust (T-1010)
BEARING - (F-838)
RIB - Stabilator trim
TAB - Stabilator trim
SHIM - Stab~latortrim
INDICATOR - Stabilator trim
BARREL - Stab~latortrim
RIB - Stabilator trim
BUSHING - Trim tab
BUSHING - Trim tab
BUSHING - Trim tab
BUSHING - Stabilator trim pulley
BUSHING - Stabilator trim pulley
BUSHING - Stabilator trim, inner
BUSHING - Stabilator trim, outer
BUSHING
-
BUSHING Stabilator trim link
BUSHING
SPACER - Stabilator trim pulley
SLEEVE - Stabilator trim link
-
PULLEY Trim tab
PULLEY - Stabilator trim
-
PULLEY (MS24566-1B)
PIN - Cable guard
-
PIN (MS20392-2C23)
PIN - Cotter (MS24665-132)
PIN - (MS20392-1C23)
PIN - Cotter (MS24665-132)
BARREL -Turnbuckle (MS21251-B2S)
CLIP - Turnbuckle safety (MS21256-1)
BOLT - Eye, stabilator trim
BOLT - (AN3-3A)
BOLT - (AN3-3A)
WASHER - (AN960-10L)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1J21
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
BOLT (AN3-4A)
WASHER - (AN960-10)
NUT - (MS20365-1032C)
BOLT - (AN3-5A)
-
WASHER (K19001-3)
-
NUT (H19000-3)
BOLT - (AN3-IOA)
WASHER - (AN960-10)
-
NUT (MS20365-1032C)
BOLT - (AN3-l6A)
-
WASHER (AN960-41-6L)
NUT - (MS20365-1032C)
BOLT - (AN3-17A)
WASHER - (AN960-10L)
-
WASHER (AN960-10)
-
WASHER (AN960-61-6L)
NUT - (MS20365-1032C)
BOLT - (AN3-25A)
WASHER - (AN960-10L)
-
NUT (MS20365-1032C)
NUT - (AN316-7R)
WASHER
WASHER - (AN960-10)
WASHER - (AN960-C1216L)
PIN - Cotter (MS24665-368)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1J22
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
;3 AIRPLANE PARTS CATALOG

Figure 56. Rudder Trim Mechanism Installation

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
a AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FlGURE 56

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
I-Ji.
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
DRAWING Control System Installation
-
DRAWING Rudder Trim Installation

ADJUSTMENT ASSEMBLY Rudder trim -

SHAFT ASSEMBLY - Rudder trim
HOUSING ASSEMBLY - Rudder trim
'WASHER
' WASHER
BUSHING ASSEMBLY Rudder trim-
-
* CLIP Rudder trim
-
BOLT (AN23-10)
WASHER - (AN960-10L)
-
NUT (AN320-3)
COTTER PIN - (MS24665-132)
-
PIN Flat head (MS20392-2-35)
-
COTTER PIN (MS24665-132)
SCREW - (AN515-8R7)
WASHER - (AN960-8L)
KNOB - Rudder trim
SCREW - Set (MS51964-132)
CHANNEL - Rudder trim

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30,1994

1K1
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
/ Serial numbers 28161 10 and up ?
I !

Figure 57. Control Wheel Installation

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
%
:"-

CODE EXPLANATIONS FOR FIGURE 57

A - Used on PA-28-161 if boom mike only is installed.

B - For serial numbers 2816110 and up, see Item 49.
C - Used if boom mike with electric trim and AutoFlite li is installed.
D - Control wheel assembly does not include switches. Order desired switches separately.
E - Used if remote transponder identification switch is installed on right grip of control wheel.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
. , AIRPLANE PARTS CATALOG
Figure
and- Part No. Serial Numbers
Index Number Code Nomenclature Rgl. ~ff&ted
Number

-
DRAWING Control System Installation

B,D WHEEL ASSEMBLY - Control (left grip cored)

B,D,E -
WHEEL ASSEMBLY Control (both grips cored)
MEDALLION - Control wheel
PLATE - Control wheel cover (standard)
KIT. Electric trim switch assembly
SWITCH ASSEMBLY - AutoFlite
CONTROL COLUMN ASSEMBLY
TEE BAR ASSEMBLY - Control column
* BEARING - (F-504-2)
-
BEARING (F-852-2)
BEARING - (F4DD)
' BUSHING - Control column pulley
' SPROCKET ASSEMBLY - Control column, right
SPROCKET ASSEMBLY - Control column, left
SPROCKET - Control column, center rear
SPROCKET - Control column, center front
* SHAFT - Control column, center
' SHAFT - Control column
* UNIVERSAL JOINT - Control column
PIN - (AN386-1-6A)
WASHER - (AN975-3)
NUT - (MS20364-1032C)
' PULLEY - Control column (MS20220-1)
* WASHER - (AN960-716)
' NUT - (AN310-7)
* COTTER PIN - (MS24665-285)
* BOLT - (AN4-35A)
WASHER - (AN960-416)
NUT - (MS20365-428C)
* BOLT - (AN3-IOA)
WASHER - (AN960-10)
WASHER - (AN960-10L)
-
* NUT (MS20365-1032C)
* SPACER - Control column
WASHER - Control column
' BUSHING - Control column
-
STOP Tee bar, left
-
CHAIN Control
EYE BOLT - Turnbuckle, right
EYE BOLT - Turnbuckle, left
BARREL - Turnbuckle (MS21251-05s)
BOLT - (AN4-1OA)
WASHER - (O.D. 1.50')
WASHER - (O.D. .75')
NUT - (MS20365-428C)
BOLT - Special
WASHER - (AN960-10L)
NUT - (MS20364-1032C)
BUSHING - Control chain
BOLT - (AN21-9)
NUT - (AN320-1)
COTTER PIN - (MS24665-5)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1K4
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
s
AIRPLANE PARTS CATALOG
gure
and Part No. Serial Numbers
Index Number Code Nomenclature Re% Affected
Number

BOLT - (AN3-11 ) 1
-
WASHER (AN960-10) 1
NUT - (AN310-3) 1
COTTER PIN - (M524665-132) 1
CLIP ASSEMBLY Map - 1
SWITCH - Boom mike (39-1) 1
BRACKET ASSEMBLY - Switch 1
-
PLACARD A/P INTR. 1
PLACARD - Mike 1
CLIP - Turnbuckle (MS21256-1) 2
-
SWITCH Remote transponder identifier (39-1) 1 28-8116001 t h 2816109
~
-
PLACARD Transponder ident 1 28-8116001 t h 2816109
~
CLOCK - Control wheel (AT4210 PO) 1 28-8116001 t h r ~
2816109
FUSEHOLDER - (155020) 1 28-8116001 t h 2816109
~
FUSE - (311005) 1 28-8116001 t h 2816109
~
PLATE - Control wheel cover, ri@t 1 28-7816001 t h 2816109
~
WHEEL ASSEMBLY - Control, pilot (with mic switch) , 1 2816110 and up
WHEEL ASSEMBLY - Control, copilot (with mic switch) 1 2816110 and up
* COVER ASSEMBLY - Contrd wheel ,-:&A, 1 2816110andup
' SWITCH - Microphone 1 2816110and up

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Revised: July 30, 1994

I K5
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 58. Rudder Pedal Installation

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
'* AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 58

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
-+ AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

DRAWING Control System Installation

RUDDER PEDAL ASSEMBLY - Complete

^PEDAL AND BAR ASSEMBLY
'PEDAL AND BAR ASSEMBLY
"PEDAL AND BAR ASSEMBLY
-
'ARM ASSEMBLY Connector
*BOLT - (AN174-13A)
'WASHER - (AN960-416)
'NUT - (MS20365-428C)
'PLUG - Rudder pedal assembly
'PLUG - Rudder pedal assembly
BLOCK - Rudder bar support, bottom
BLOCK - Rudder bar support, top
WASHER - Rudder bar support
-
BUSHING Rudder bar support
PLATE - Rudder bar support
SUPPORT ASSEMBLY - Rudder bar
BOLT - (AN3-4A)
BOLT - (AN23-10)
BOLT - (AN3-31A)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1 K8
 PIPER AIRCRAFT
PA-28-151M61 WARRlOR
.i(
AIRPLANE PARTS CATALOG

Figure 59. Cabin Heat and Defroster Installation

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 59

A - .
B - Used on PA-28-151 with serial numbers 28-7615067 and up, and PA-28-161.
C - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-7916461.
D - r
E - Black only.
F - .Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thw 28-8216236.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
DRAWING Cabin Heat System Installation
DRAWING - Defroster System Installation
DRAWING - Duct Assembly, Cabin Heat. Center

-
DUCT ASSEMBLY Cabin heat, front, left
-
DUCT ASSEMBLY Cabin heat, front, right
DUCT ASSEMBLY - Cabin heat, center. left
DUCT ASSEMBLY - Cabin heat, center, right
-
COVER Duct assembly, cabin heat, center, left
-
COVER Duct assembly. cabin heat, center, right
KNOB - Heat duct
DUCT ASSEMBLY - Cabin heat, rear, left
DUCT ASSEMBLY - Cabin heat, rear, right
BOX ASSEMBLY - Cabin heat distributor
VALVE ASSEMBLY -Cabin heat
BOX - Cabin heat distributor
BOX - Cabin heat distributor
HOSE - Defroster s

HOSE - Defroster 28-8316001 and up

HOSE - Defroster .
-
HOSE Defroster 28-7415001 thN 28-7615066
SLEEVE - Insulating 28-7716001 and up
HOSE - Defroster
-
HOSE Defroster 28-8316001 and up
HOSE - Air inlet
HOSE - Cabin heat inlet
CABLE ASSEMBLY - Cabin heat control (PS50146-4-3)
CABLE ASSEMBLY - Cabin heat control (PS50146-4-10) 28-8316001 and up
CABLE ASSEMBLY - Defroster control (PS50146-6-2)
-
CABLE ASSEMBLY Defroster valve (PS501468-1)
OUTLET - Defroster air
OUTLET ASSEMBLY - Defroster air
TAKE-OFF ASSEMBLY - Defroster air
LINK ASSEMBLY -Cabin heat box
LINK - Cabin heat box 28-7916462 and up
LINK - Cabin heat box 28-7916462 and up
-
LINK Cabin heat box
HOUSING - Defroster valve
GATE - Defrostervalve
KNOB - Cabin heat and defroster
TUBE - Defrostervalve
GASKET - Firewall seal
GASKET - Distributor box
-
SLEEVE Defroster cable
GROMMET Firewall seal -
-
STUD Swivel fitting
FITTING Swivel -
-
CLAMP Defroster cable
-
CLAMP (SAE TYA-1 112)
CLAMP - (SAE TYA-1)
-
CLAMP (SAE TYA-1)
CLAMP - (SAE TYA-2 9/16)
CLAMP - (SAE TYA-3 1116)
WASHER - Spring (35)

When ordering, always specify Part Number. Description, and Seriai Number of Aircraft

Revised: July 30, 1994

1K11
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

-
NUT (AN310-3)
WASHER - (AN960-10)
C O n E R PIN - (MS24665-132)
PACKING - O-ring (NAS1593-213)
WASHER
-
DUCT ASSEMBLY Defroster, left

-
PLATE Defroster valve
-
DUCT ASSEMBLY - Defroster.. riaht

PLATE - Firewall seal

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1K12
 PIPER AlRCRAFT
PA-28-151/161 WARRIOR
- w. AIRPLANE PARTS CATALOG

Figure 60. Cabin Overhead Air Vent Instdlakn

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 60

Used on PA-28-151 with serial numbers 28-7515255 thru 28-7615445. Also used on PA-28-151 with serial numbers 28-7415001 thru
28-7515254 if fresh air Flapper Valve Kit 760 901 has been installed per Service Letter 738A.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161.
Used on PA-28-161 28 volt system. f
Used on PA-28-151 with serial numbers 28-7515255 and up, and PA-28- 161. Also used on PA-28-151 with serial numbers
28-7415001 thru 28-7515254 if fresh air Flapper Valve Kit 760 901 has been installed per Sewice Letter738A.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716269.
Used on PA-28-161 with serial numbers 28-7716270 and up. Also used on PA-28-151 with serial numbers 28-7415001 and up, and
PA-28-161 with serial numbers 28-7716001 thru 28-7716269 if Blower Assembly Kit 761 150 has previously been installed.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7816171. Order
part for PA-28-161 with serial numbers 28-7816172 and up if the four position fan switch has been replaced with the three position fan
switch.
Used w~ththe four position fan switch only.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916617.
Used on PA-28-151 with serial numbers 28-7515255 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916617. Also
used on PA-28-151 with serial numbers 28-7415001 thru 28-7515254 if fresh air Flappervalve Kit760 901 has been installed per
Service Letter 73814.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8016081.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serialmumbers 28-7716001 thru 28-8016314.
Used on PA-28-151 only.
Used if air conditioning is not installed.
Used if air conditroning is installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
E- AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

60- 76304 DRAWING - Fresh Air Ventilation System Installation

79273 J DRAWING - Blower Ventilation Installation t
79278 J DRAWING - Ram Air Ventilation Installation
36983 DRAWING - Ram Air and Blower Air Ventilation Installation 28-8016001 and up

E BLOWER ASSEMBLY KIT - Fresh air

BLOWER ASSEMBLY - Fresh air 28-7716270 and up
-
BLOWER ASSEMBLY Partial, fresh air
-
BLOWER ASSEMBLY Complete, fresh air 28-7716270 and up
C BLOWER ASSEMBLY - Complete, fresh air
F MOTOR ASSEMBLY - Blower (475 210)
COVER - Blower motor
PLATE ASSEMBLY - Motor mounting
-
BLOWER (AE424-316-1)
DUCT ASSEMBLY - Fresh air, center
A DUCT ASSEMBLY - Fresh air, center
-
B
-
DUCT ASSEMBLY Fresh air, center
VENT ASSEMBLY - (10-0549-1C-C)
VENT ASSEMBLY - (PS10023-16)
B ' LOUVER - (136-1M), silver
B ' LOUVER - (336-IHS), black
B FRAME - (173M). silver
B ' FRAME - (173B), black
NUT - (C2733-040-1)
DUCT - Bulkhead interconnect
DUCT - Hose connect
-PANEL ASSEMBLY - Cabin light and fresh air
B "PANEL ASSEMBLY - Cabin light and fresh air (less
speaker hole)
B PANEL ASSEMBLY - Cabin light and fresh air (with
speaker hole)
PANEL ASSEMBLY - Cabin light (less speaker hole)
PANEL ASSEMBLY - Cabin light (less speaker hole)
PANEL ASSEMBLY - Cabin light (less speaker hole)
PANEL ASSEMBLY - Cabin light (less speaker hole)
COVER ASSEMBLY - Fresh air blower
J -
HOSE Air vent
HOSE - Air vent
-
HOSE Air vent
K HOSE - Air vent
J -
FllTlNG ASSEMBLY Air duct, upper
J -
FllTlNG ASSEMBLY Air duct, lower
TUBE 2816090 and up
PLATE 2816090 and up
INTERCOSTAL - Blower bracket support, left
INTERCOSTAL - Blower bracket support, right
HANGER ASSEMBLY - Blower, left
HANGER ASSEMBLY - Blower, right
RETAINER - Housing
BRACKET - Blower support
BRACKET - Blower support, aft
STRAP - Air hose support
-
FLANGE ASSEMBLY Bulkhead interconnect
BRACE Hanger -
GUSSET ASSEMBLY - Intercostal

When ordering. always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

1K15
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

-
VENT ASSEMBLY (10-0549-1C-D)
-
VENT ASSEMBLY (PS10023-17)
CHANNEL - Fresh air duct
PLACARD - Cabin air
SWITCH REPLACEMENT KIT - Fan (4 position)
-
SWITCH (MS35058-21) (3 position) 28-7816172 and up
-
KNOB (RB-67-1-SB-M)
TUBE - Drain
TUBE ASSEMBLY Drain -
-
CLAMP (SAE TY F-4)
-
CLAMP (SAE TY A-4 518)
SCREW - (PS10012-4)
WASHER (PS10016-6) -
FLAPPER VALVE ASSEMBLY - Fresh air Intake
* SHAFT ASSEMBLY
FLAPPER ASSEMBLY
CABLE ASSEMBLY - Fresh air flapper (PS50146-2-2)
FITTING - Swivel
STUD - Swivel fitting
WASHER - (AN960-10)
NUT - (AN320-3)
COTTER PIN - (MS24665-132)
HOSE - Air vent 28-8016001 and up
DUCT ASSEMBLY - Air vent (with filter) 28-8016001 and up
FILTER - Air vent 28-8016001 and up
LOUVER - Air vent 28-8016001 and up
-
CIRCUIT BREAKER (PS50120-1-9) 20 amp, Mech.
Products, Inc.
-
CIRCUIT BREAKER (PS50120-3-36) 20 amp, Wood
Electric Corp. 28-8016082 and up
CAPACITOR ASSEMBLY 28-8016001 t h 2816059
~
HOSE - Drain 28-8016001 and up
TUBE ASSEMBLY - Drain 28-8016001 and up
CLAMP - (SAE TY F-4) 28-8016001 and up
LOUVER - (136-IM), silver
LOUVER - (336-IHS), black
-
FRAME (173M), silver
FRAME - (173B), black
NUT - (C2733-040-1)
CABLE - Blower

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

1K16
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
ys
AIRPLANE PARTS CATALOG

Figure 61. Air Conditioning Compressor, Refrigerant tines and Alternator Installation
(28-7816001 and up)

Reissued: December 1, 1989

IK17
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 61

A - See Figure 69 for component parts.

B - If original one piece twisted brace has been replaced with a three piece bracket assembly, order individual parts for serial numbers
28-7916286 and up as desired.
C - Used if Refrigerant Line Fitting Replacement Kit 764 244 has not been installed. r
D - ' Order parts for serial numbers 28-8216075 and up if Refrigerant Line Fitting Replacement Kit764 244 has been installed per Service
Spares Letter 387.

Reissued: December 1.1989

 PIPER AIRCRAFT
w -
PA-28-1 511161 WARRIOR
r;.
AIRPLANE PARTS CATALOG
igure
and Part No. Serial Numbers
Index Number Code Req- Affected
Number

DRAWING - Air Conditioning Compressor and Alternator

lnstallatlon
DRAWING - Air Conditioning Refrigerant Lines Instailation

COMPRESSOR ASSEMBLY - (F2Q9-16764)

ALTERNATOR ASSEMBLY Prestolite (ALY-6422)-
CLUTCH ASSEMBLY (10616) -
RING GEAR ASSEMBLY - (LW11572)
BELT - (PSI 0069-1-4)
BELT - (PSI 0069-1-3)
BRACKET ASSEMBLY - Compressor upper
BRACKET ASSEMBLY - Compressor lower
* PULLEY ASSEMBLY - Alternator drive
BOLT - (NAS2906-20)
WASHER - Altemator pulley
' NUT - Altemator pulley
-
* BUSHING Altemator idler pulley
L

BOLT - (AN6-13A)
WASHER - (AN960-616)
NUT - (MS20365-624C)
BRACKET ASSEMBLY COMPLETE - Alternator support 28-7816001 t h r ~28-7916285
'CHANNEL ASSEMBLY Altemator support - 28-791 6286 and up
ARM ASSEMBLY - Alternator support 28-791 6286 and up
-
ARM ASSEMBLY Alternator support 28-791 6286 and up
' BOLT - (AN4-14A) 28-791 6286 and up
WASHER - (AN960-416L) 28-7916286 and up
. NUT - (MS20365-428C)
BOLT - (MS16997-81)
28-791 6286 and up
28-791 6286 and up
HOSE ASSEMBLY - Suction
HOSE - Suction
HOSE ASSEMBLY - Receiver dehydrator to condenser
HOSE ASSEMBLY - Pressure
-
HOSE Discharge (length 117 )
-
HOSE ASSEMBLY Discharge (length 25')
WASHER
CAPACITOR ASSEMBLY
CLIP ASSEMBLY - Left front baffie
IDLER PULLEY ASSEMBLY Compressor drive -
-
BOLT (MS20074-06-11)
WASHER - (AN960-616L)
-
BOLT (AN8H-7A)
-
WASHER (AN960-816)
BOLT - (MS20074-05-05)
WASHER - (AN960-516)
BOLT - (MS20074-06-06)
WASHER - (AN960416L)
BOLT - (AN6H-22A)
WASHER - (AN960-616)
WASHER - (AN960-616L)
-
WASHER (MS35339-46)
-
BOLT (MS20074-06-05)
WASHER - (AN960-616L)
-
ADAPTER (PSI 0022-6-4) 28-781 6001 th N 28-8216074
-
FITTING (FC9158-0808S) 28-8216075 and up
REDUCER - (661FHD-8-10) 28-8216075 and up

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1,1989

1K19
 PIPER AIRCRAFT
PA-28-1 5 1 M 6 1 WARRIOR
a* AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affectea
Number

-
ADAPTER (PS10022-6-13) 2 28-7816001 &IN 28-8216074
-
FITTING (FC9158-0606S) 2 28-8216075 and up
-
REDUCER (42F-8-6) 2 28-82160f5 and up
ADAPTER - (PS10022-6-14) 1 28-7816001 t h r ~28-8216074
FITTING - (FC9158-0808S) 1 28-8216075 and up
-
REDUCER (42F-10-8) 1 28-8216075 and up
BOLT - (MS20074-05-06) 1
WASHER - (AN960-516L) 2
CLAMP - (H-6) 4 28-7716001 t h r ~28-8216074

When ordering, always specify Part Number. Description,and Serial Number of Aircmft

Reissued: December 1, 1989

1K20
 PIPER AIRCRAFT
i
'
PA-28-151M 61 WARRIOR
":
AIRPLANE PARTS CATALOG

Figure 62. Air Conditioning Duct and Evaporator Installation

(28-781 6001 and up)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 62

A - Without radio speaker.

B - With radio speaker.
C - If interconnect duct assembly and aft cabin bulkhead duct are bonded (not riveted) to aft cabin bulkhead, order part listed for serial
numbers 28-8016048 and up. I

Reissued: December 1, 1989

 PIPER AIRCRAFT
3'
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial N m b e r s
Index Number Code Nomenclature Req- Affected
Number

DRAWING - Air Conditioning Duct Installation 28-7816001 t h 28-8016047

~
DRAWING - Air Conditioning Duct Installation 28-80?6048 and up
DRAWING - Evaporator Bulkhead Assembly 28-7816001 t h 28-801
~ 6047
DRAWING - Evaporator Bulkhead Assembly 28-8016048 and up

-
EVAPORATOR ASSEMBLY Air conditioning 1
* EVAPORATOR AND HOUSING ASSEMBLY -Air conditioning 1
BLOWER ASSEMBLY - Evaporator 1
' MOTOR ASSEMBLY - Evaporator blower (475 210) 1
COVER - Evaporator blower 1
-
' ' PLATE ASSEMBLY Motor mounting 1
BLOWER - (AE424-316-1) 1
-
DUCT Hose connect 1
SWITCH ASSEMBLY - Pressure 1
' TUBE ASSEMBLY - Evaporator inlet (37245-6-6s) 1
CLAMP - (SAE TY F-44) L
2
VALVE ASSEMBLY - Evaporatorexpansion 1
- BRACKET - Receiver dehydrator * a 1
' RECEIVER DEHYDRATOR - (1106) 1
* CLAMP - Bulb, expansion valve 1
CLAMP - (PS10017-23-6) 2
PANEL ASSEMBLY - Cabin light and air conditioning duct 1 28-7816001 thN 28-8016047
B PANEL ASSEMBLY - Cabin light and air conditioning duct 1 28-7716001 and up
A -
PANEL ASSEMBLY Cabin light and air conditioning duct 1 28-7716001 and up
LOUVER - (136-1 M), silver 2
LOUVER - (336-IHS), black 2
- FRAME - (173M), silver 2
FRAME - (173BJ, black 2
DUCT ASSEMBLY - Air conditioning 1 .28-7816001 t h 28-8016047
~
-
DUCT ASSEMBLY Air conditioning 1 28-8016048 and up
LOUVER - (136-1M), silver 2
' LOUVER - (336-IHS), black 2
' FRAME - (173M), silver 2
* FRAME - (173B), black 2
NUT - (C2733-040-1) 8
C DUCT ASSEMBLY - Aft cabin bulkhead 1 28-7816001 t h r ~28-8016047
-
DUCT ASSEMBLY Aft cabin bulkhead ,j 1 28-8016048 and up
C -
DUCT ASSEMBLY Interconnect 1 28-7816001 t h 28-8016047
~
DUCT ASSEMBLY - Interconnect 1 28-8016048 and up
-
CHANNEL Air conditioning 1 28-7816001 t h 28-801
~ 6047
-
CHANNEL Air conditioning 1 28-8016048 and up
SUPPORT ASSEMBLY - Evaporator box 1
COVER - Evaporator filter 1
FILTER - Evaporator 1
-
HOSE Air conditioning 1
HOSE - Evaporator drain 1
NUT - (C2733-040-1) 8

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1,1989

1 K23
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 63. Air Conditioning Condenser Installation

(28-7816001and up)

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRlOR
AIRPLANE PARTS CATALOG
-

CODE EXPLANATIONS FOR FlGURE 63

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51I161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and : Part No. Serial Numbers
Index Number Code Nomenclature Re% Affected
Number

DRAWING - Air Conditioning Condenser Installation

-
CONDENSER ASSEMBLY Air conditioning (complete)
or (99387-04)
* CONDENSER - (IE-1415C)
HINGE ASSEMBLY - Condenserdoor
HINGE Half -
-
BELLCRANK ASSEMBLY Condenser door mechanism
' BUSHING
BOLT - (AN3-14A)
' WASHER - (AN960-10L)
-
' NUT (MS20365-1032C)
DOOR ASSEMBLY Louver -
^ HINGE - Half
TRANSMISSION ASSEMBLY - Condenser door actuating
(complete)
-
MOTOR ASSEMBLY Transmission (C145-200)
UNIVERSAL ASSEMBLY (BlOO-06) -
' SWITCH - Limit (V3L-3-D9)
TUBE ASSEMBLY - Actuator
CLAMP - (AN741-8P)
BELLCRANK ASSEMBLY - Condenser
' BUSHING - Bronze (FF565-2)
BEARING - (AA225-1)
-
ROD ASSEMBLY Condenser push
* BEARING - Rod end (PS10020-5-1R)
' NUT - (AN315-3R)
-
BEARING ASSEMBLY Condenser door actuating
COVER ASSEMBLY - Forward
COVER ASSEMBLY Aft -
-
PIN Hinge
TUBE
BEARING - (AA304-20)
BOLT - (AN23-13A)
WASHER - (AN960-10)
WASHER (.56 O.D.) -
NUT - (MS20365-1032C)
-
BOLT (AN23-13A)
WASHER - (AN960-10)
WASHER ( 5 6 O.D.) -
NUT - (MS20365-1032C)
-
BOLT (AN23-13A)
WASHER (AN960-10) -
-
NUT (MS20365-1032C)
-
BOLT (AN3-7A)
WASHER - (AN960-10)
-
NUT (MS20365-1032C)
-
BOLT (AN4-36A)
WASHER (AN960-416) -
-
NUT (MS20365-428C)
-
BOLT (AN23-13A)
WASHER - (AN960-10)
NUT - (MS20365-1032C)
BOLT - (AN3-IOA)
WASHER (AN960-10) -
-
NUT (MS20365-1032C)
BOLT - (AN3-6A)
WASHER - (AN960-10)
NUT - (MS20365-1032C)

When ordering, always specify Part Number. Description, and Serial Number of Aircraft

Reissued: December 1, 1989

112
 PIPER A1RCRAm
PA-28-151M61 WARRIOR
m +-
AIRPLANE PARTS CATALOG

PAGES 1L3 THRU 1L24

INTENTIONALLY LEFT BLANK

Reissued: December 1,1989

This page intentionally left blank.
 WARRIOR

AIRPLANE PARTS CATALOG

CARD 2 OF 2

w PA-28-151 WARRIOR
PA-28-161 WARRIOR I1
PA-28-161 WARRIOR .ill

PIPER AIRCRAFT
r
CORPORATION
Courtesy of Bomar Flying Service
www.bomar.biz
[PART NUMBER 761 5381 REVISED: JULY 30,1994
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Published by
Technical Publications

Piper Aircraft Corporation

2926 Piper Drive
Vero Beach, Florida 32960
U.S.A.

Member of GAMA
Geneml Aviation
Manufacturers Association

Added: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

AEROFICHE EXPLANATION AND REVISION STATUS

I -
The Parts Catalog information in this set of Aerofiche cards is arranged in accordance with general specifications of Aerofiche adopted
by. the General Aviation Manufacturer's Association.

- Conversion of Aerofiche alpha/numeric code numbers:

First number is the Aerofiche card identifier.
I

Letter is the horizontal line reference per card.

Second number is the vertical line reference per card.
Example: 2J16 = Aerofiche card number two of given set. Grid location J16.

REVISIONS

The information compiled in this Aerofiche Parts Catalog is kept current by revisions distributed periodically. Each revision is a complete
Aerofiche card replacement and supersedes Aerofiche cards of the same number in the set.

Revisions to this PA-28-1511161 Parts Catalog (761 538) issued June 11. 1979 are as follows:

Aerof iche
Effectivity Publication Date Card Effectivity

CR891201 December 1, 1989 1 and 2

PR940730 July 30, 1994 1 and 2

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
.: . AIRPLANE PARTS CATALOG

INTRODUCTION
This illustrated Parts Catalog provides simple, positive identification of replacement parts for the Piper Model PA-28-1511161 manufactured
by the Piper Aircraft Corporation of Vero Beach, Florida.

il
NOTE: DO NOT USF THIS CATALOG FOR RIGGING AND INSTALI ATION PWPOSES.

1. The catalog is divided into thirteen major sections as follows:

a. Section I to XI1 inclusive contains all replacement parts for the complete airplane. Each section is subdivided and each
division includes an illustration and a parts lisbng.
b. Section Xlll is the Miscellaneous Group. This group includes an illustration and parts list for the Placards and Exterior
Stencils, a listing of the Optional Equipment Kits, Repair kits and Special Tools, and a listing of Miscellaneous Hardware and
Consumables.

2. The following is a brief explanation of the columns in the parts lists: (Refer to EXAMPLE below).
a. The FIGURE AND INDEX NUMBER column indicates the illustration figure number and its part index number.
: EXAMPLE: (2-I), the 2 is the figure number and the 1 is the index number. The figure number appears only at the top of each
parts list page.
b. The PART NUMBER column contains the identifying number of the replacement part and this number must be shown on all
parts orders.
c. The CODE column is for the purpose of indicating special uses of the part. An explanation of the letter code used is shown on
the grid (page) preceding each parts listing and pertains to that listing only.
d. The NOMENCLATURE column indicates the part name. This name must be shown on all parts orders.
e. The NO. REQ:(Number Required) column represents the total quantity of parts used per figure when the part is not indented
and the quantity of parts used per assembly when the part is indented. The symbol AR listed in this column means As
Required.
f. The SERIAL NUMBERS AFFECTED column indicates the part application by airplane serial number. Unless otherwise noted,
serial numbers listed w~ththe model year and up (ex. 28-7716001 and up) are ~ntendedto include the new style of senal
numbers that do not reference the model year (ex. 2816001 and up).

EXAMPLE
Figure --
and Part < , No. SERIAL NUMBERS
Index Number Code NOMENCLATURE Req- AFFECTED
Number

2-1 XXXXX-XX DOOR ASSEMBLY - Baggage compartment X

-2 XXXXX-XX ' TUBE ASSEMBLY - Baggage door latch X
-3 XXXXX-XX ' * CLEVIS - Door latch tube assembly X
-4 MXXX-XX ' * CLIP - Door latch tube assembly X

In the nomenclature column, the next higher assembly relationship of items covered is shown by the degree of indention of each
item and is indicated by an asterisk ('). One asterisk signifies one indention, two signifies two indentions, etc. The example listing
above is interpreted as follows:

If the DOOR ASSEMBLY (not indented) is ordered, it will include the three items indented under the DOOR ASSEMBLY.

If the TUBE ASSEMBLY (indented one space) is ordered, it will indude the two items indented under the TUBE ASSEMBLY.

If you want dnly a CLEVIS or CLIP, you order only that item.

Reissued: December 1 , 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
-. .
C. 3 )

AIRPLANE PARTS CATALOG

--
3. Piper Aircraft will supply all attaching parts to its customers in any quantity. When purchasingthe attaching parts such as nuts, bottq
washers, cotter pins, etc. from Piper Aircraft, the customeror service centerpeed only order the part(s) needed.
4. *All items of Optional Equipment are contained in the parts list in their proper sequence and sections. These items were not marked
optional, since they are fully identified by their descriptions.

HOW TO IDENTIFY A PART

IF YOU KNOW WHAT IT LOOKS LIKE
AND KNOW WHERE IT IS LOCATED

1. Refer to Figure 1 to determine the section number in which the part is used.

2. Refer to the Table of Contents and locate the section. Note the figure numbers that illustrate the various subgroups of this main section.
Select the figure title you think might contain the part you wish to identify and proceed to the grid (page) specified. If you don't find the
part on this illustration, try another figure in this group.

3. .Refer to Figure and Index Number in the parts listing for description of the part

-. HOW TO ORDER PARTS

When ordering parts forydur Piperairplanes, please observe the following instructions:
I . Place your order with your local distributor or service center.
2. Specify the model and serial number of your airplane.
3. Speclfy Part Number, Name, Type and Quantity Required.
4. Specify the method of shipment freight, express, parcel post, air express, air freight or air parcel post. Where the nature of the
shipment requires it or when no ~nstructionsare given, we reserve the right to ship the most suitable way.
5. Request price and delivery information pnor to order placement.

GENERAL INFORMATION
" .
I . Shortages
All orders are checked before leaving our Shipp~ngDepartment. A packing slip is enclosed with the shipment. Claims for errors or
shortages must be made wthin three days after receipt of orders.

2. Returned Goods
No material should be retumed without first secunng written permissioh Material sent in without notice will be held at the owner's risk
for thirty days and will then be disposed of as we see f i t

Transportation charges must be prepaid on retumed goods or the shipment will be refused.

3. Transportation Liabilities
The Piper Aircraft Corporation cannot be held liable for damages to parts in transit from the factory. If a shipment is received in a
damaged condition, have the delivery man or transportation company make a notation of the damage and file your dairn with the carrier.
In case of concealed damage, do not attempt to remove the part from the shipping container, or try to repair the damage, call the carrier
and have their claim agent inspect the damage before filing your claim with the canier.

Reissued: December 1, 1989

 PIPER'AIRCRAFT
PA-28-1 511161 WARRIOR
. .*' ,
+ AIRPLANE PARTS CATALOG .

MODEL SFRIAL lYyMBFR INFORMATION

The serial numbers of the aircraft covered b y this Parts Catalog are as folows:

Sen"al Numbers of the 1974 PA-28-151 WARRIOR Models are 28-7415001 thru 28-7415703.
Serial Numbers of the 1975 PA-28-151 WARRDR Models are 28-7515001 thru 28-7515449. F
Serial Numbers of the 1976 PA-28-151WARRIOR Models are28-7615002 thru 28-7615435.
Serial Numbers of the 1977 PA-28-151WARRIOR Models are 28-7715001 thru 28-7715314.
Serial Numbers of the 1977 PA-28-161WARRIOR II Models are 28-7716002 thru 28-77'16323.
Serial Numbers of the 1978 PA-28-161 WARRIOR II Models are 28-7816001 thru 28-7816680.
Serial Numbers of the 1979 PA-28-161 WARRIOR II Models are 28-7916001 thru 28-7916598.
Serial Numbers of the 1980 PA-28-161WARRIOR II Models are 28-8016001 thru 28-8016373.
Serial Numbers of the 1981 PA-28-161 WARRIOR II Models are 28-8116001 thru 28-8116322..
Serial Numbers of the 1982 PA-28-161WARRIOR IIModels are 28-8216001 thru 28-8216226.
Serial Numbers of the 1983 PA-28-161 WARRIOR II Models are 28-8316001 thru 28-8316112.
Serial Numbers of the 1984 PA-28-161 WARRIOR IIModels are 28-8416001 thru 28-6416131.
Serial Numbers of the 1985 PA-28-161 WARRIOR IIModels are 28-8516001 thru 28-8516099.
Serial Numbers of the 1986 PA-28-161 WARRIOR II Models are 28-8616001 thru 28-8616057,
2816001 thru 2816010 (less 2816002).
Serial Numbers of the 1987 PA-28-161 WARRIOR II Models are 2816002,281601 1 t h 2816036
~
(less 2816029 thru 2816033).
Serial Numbers of the 1988 PA-28-161WARRIOR 1I Models are 2816029 thm 2816033,
2816037 thhr 2816075 (less 2816066).
Serial Numbers of the 1989 PA-28-161WARRIOR II Models are 2816076 thru 2816094.
Serial Numbers of the 1990 PA-28-161 WARRIOR ll Models are 2816095 thru 2816099.
Serial Numbers of the 1992 PA-28-161 WARRIOR II Models are 2816100 thru 2816103.
Serial Numbers of the 1993 PA-28-161 WARRIOR II Models are 2816106 thm 2816109.
Serial Numbers of the 1994 PA-28-161 WARRIOR IIModels are 2816104 and 2816105.
Senal Numbers of the 1994 PA-28-161 WARRIOR Ill Models are 2816110 and up.

SFRIA1 NUMBFR EXPLANATION

The Serial Number on the Manufacturer's Identification Plate is based on either a 3- or 4-set numbering system. In the 4-set system, the
first set defines the Type Certificate Designation, the second set is the Model Year, the third set is the Model Code, while the fourth set is the
Model Sequence Number (within a model year).

The 3-set system omits the model year and begins a new sequence with 2816001. This new sequence continues without renumbering for
a new year.
-
EXAMPLE
28 74 16 001

Alk
TYPE CERTIFICATE DESIGNATION MODEL SEQUENCE NUMBER

-
(Within a Model Year)

"MODEL YEAR MODEL CODE

(1974 and subsequent) 16 = PA-28-161 WARRIOR

EXAMPLE
(late 1986 and subsequent)

TYPE CERTIFICATE DESIGNATION MODEL SEQUENCE NUMBER

(Without regard for Model Year)

LMODEL cow
16 = PA 28-161 WARRIOR

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
k
. AIRPLANE PARTS CATALOG

STANDARD PAINT CHART

MFG. PIPER PART NUMBER

NO. QUART GALLON
EXTERIOR

POLYURETHANE ENAMEL (Dupont Imron)

Baja Yellow
Juneau White
-
Ocala Orange
Madrid Red
Bahama Blue
Alvocado
Las Vegas Gold
Dakota Black
Denver Brown
Matador Red
Royal Blue
Hickory Brown
S~lver
time Green
Sage Green --
Firethom
Buckskin
Dark Blue
Platinum Gray
Sandalwood Tan
Dark Claret
Burnished Gold
bght Blue
Dark Saddle
Dark Green
+
. Saffron
tight Sandalwood
tight Platinum

Catalyst (Activator)
Reducer
' Retarder
Accelerator

POLYURETHANE PRIMER (Dupont Imron)

Wash Pnmer
Wash Primer Thinner
Acid Thinner

INSTRUMENT PANEL
Cadet Dark Grey
Grey II (Flat Tan)

Revised: July 30.1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
><
. I' AIRPLANE PARTS CATALOG

'
THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
vf . AIRPLANE PARTS CATALOG

TABLE OF CONTENTS
FIGURE NUMBER FIGURE TITLE GRID NUMBER

1 View of Complete Airplane......................................................................................................... .! ......1A13. 2A13

SECTION I
WING GROUP

Wing Installation.................................................................................................................................. lAl5

Wing Leading Edge Assembly ............................................................................................................ lA.20
Wing Trailing Edge Assembly ............................................................................................................. lA24
Aileron Assembly (28-7415001 thru 28-7515459) .............................................................................. 185
Aileron Assembly (28-7615001 and up, and 28-7716001 and up) .................................................... 109
Flap Assembly .................................................................................................................................... 1812

SECTION ll
FUSELAGE GROUP

Fuselage Assembly Complete ................................................................. .................................... 1815

Fuselage Upper Forward Cockpit Assembly ...................................................................................B 1 9
Fuselage Upper Center Cockpit Assembly......................................................................................... 1823
Fuselage Lower Forward Cockpit Assembly ....................................................................................... lC4
Fuselage Lower Aft Cockp~tAssembly ............................................................................................... lC8
Fuselage Aft Section........................................................................................................................... 1C l l
Fuselage Baggage Door Assembly .................................................................................................... l C l 5
Fuselage Cabln Door Assembly (28-7415001 thru 28-7615001) ................................................... C 1 8
Fuselage Cabln Door Assembly (28-7615002 and up. and 28-7716001 and up)...............................lC22
Fuselage Enclosure Installahon.........................................................................................................ID3

SECTION Ill
TAIL SURFACES GROUP

Tail Surfaces Installation ..................................................................................................................... ID9

Stabilator Assembly ............................................................................................................................ ID13
Fin Assembly ..................................................................................................................................... ID16
Rudder Assembly ................................................................................................................................ D l 9

SECTION IV
LANDING GEAR GROUP

Nose Gear Installation ........................................................................................................................ ID23

Nose Gear Stwt Assembly........................................................................................................... lE3
Nose Wheel Assembly (Cleveland) .................................................................................................... 1E?
Nose Wheel Assembly (McCauley) .................................................................................................... 1ElO
Main Gear Installation ......................................................................................................................... El3
Main Wheel Assembly ........................................................................................................................ lE17
Brake Assembly .................................................................................................................................. E 2 0
Main and Nose Wheel Fairing Installation (28-7415001 and up, and 28-7716001 thw 7716323) .....1E23
Main and Nose Wheel Fairing Installation (28-7816001 and up) ........................................................ IF2
Main Landing Gear Strut Fairing Installation.......................................................................................IF6
Hand Brake Installation....................................................................................................................... IF9
Toe Brake Installation.......................................................................................................................... IF12
Toe Brake Master Cylinder Assembly .......................................................................................... IF15

.
Revised: July 30 1994
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
;it
' AIRPLANE PARTS CATALOG

TABLEGOF CONTENTS
FIGURE NUMBER FIGURE TITLE GRID NUMBER

SECTION V
CABIN EQUIPMENT GROUP

35 Cockpit Finishing Installation .............................................................................................................. 1F19

, 36 Window Curtains Installation (sin 28-8016001 and up) ...................................................................... 1G3
. 37 Carpet Installation............................................................................................................................... 1G6
. 38 Seats Installation................................................................................................................................. 1GI3
Vertically Adjustable Front Seat Assembly ...................................................................................... 1G18
c .
: 39

SECTION VI
INSTRUMENTS GROUP

lnstryment Panel lnstallation (sln 28-7415001 and up, and 28-7716001 thru 2816109) .................... 1H1
Instrument Panel lnstallation (sln 2816110 and up) ......................................................................... 1H7
Vacuum, System lnstallation (sln 28-7415001 and up, and 28-7716001 thru 2816109) ..................... 1HI0
Vacuum. System lnstallation (sln 2fJ1,6110,and up) ............................... ,, .:,, ..................................... H I 3
1

Auxiliary Vacuum System lnstallation ....,..'..........................................................................................

' .
1H I 6
Pitot Static System Installation............................................................................................................ 1H20

SECTION VII
POWER PLANT GROUP

43 Power Plant Installation ...................................................................................................................... 1I1

44 Engine Exhaust System Ins.'nllation.............................................................................................. ......I I5
45 Engine Baffle Installation......:........................................... :.................................................................. 1I8
46 Oil Cooler Installation.......................................................................................................................... 1I11
47 Engine Cowl Installation...................................................................................................................... 1I14
48 Engine Controls Installation ............................................................................................................... 1117

SECTION Vlll
FUEL SYSTEM GROUP
-
49 Forward Fuel System Installation.., ,,.... ;.,.; ...... ........................ : .............. ;::......................................... 1I21
50 Aft Fuel System InstallationIsln 28-7415001 Z ~ N28-7515459)......................................................... 1J 1
51 Aft Fuel System Installation (sln 28-7615001 and up, and 28-7716001 and up) ................................ 1J4
52 Fuel Tank Assembly ............................................................................................................................ 1J7

SECTION IX
CONTROL SYSTEM GROUP
*
53 Control System Installation ................................................................................................................. 1Jll
54 Flap Control Installation .................................................................................................................... 1J15
55 Stabitator Trim Installation................................................................................................................... 1J19
56 Rudder Trim Mechanism Installation................................................................................................... 1J23
57 Control Wheel Installation................................................................................................................... 1K2
58 Rudder Pedal Installation.................................................................................................................... 1K6

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
Jr AIRPLANE PARTS CATALOG

TABLE OF CONTENTS
FIGURE NUMBER FIGURE TITLE GRID NUMBER

SECTION X
ENVIRONMENTAL GROUP

59 Cabin Heat and Defroster Installation................................................................................................. lK9

60 Cabin Overhead Air Vent Installation.................................................................................................. K 1 3
61 Air Conditioning Compressor. Refrigerant Lines and Alternator Installation(28-7816001 and up) ....1K17
62 Air Conditioning Duct and Evaporator Installation (sln 28-7816001 and up) ...................................... 1K21
63 Air Conditioning Condenser Installation(dn 28-7816001 and up) ..................................................... lK24

SECTION XI
ELECTRICAL SYSTEM GROUP

Electrical System Installation .............................................................................................................. 2A15

Instrument Panel Electrical Installation (sln 28-7415001 and up. 28-7716001 thru 2816109) ...........2 A M
Instrument Panel Electrical lnstallat~on(sin 2816110 and up) ............................................................2A24
Air Conditioning Electrical Installation (s/n 28-7816001 and up) ....................................................... 284
Battery Box Installation ....................................................................................................................... 287
External Power Supply Installation(sln 28-7415001 and up, 28-7716001 thru 28-8216236) ............2812
External Power Supply Installation(sin 28-8316001 thru 2816109) ................................................... 2815
Auxiliary Power Receptacle Installation (sin 2816110 and up) ...........................................................2618
Alternator Assembly (Prestolite) .........................................................................................................2921
Alternator Installation (Chrysler) .........................................................................................................2024
Strobe Light Installation .....................................................................................................................2C4

SECTION XI1
ELECTRONICS GROUP

Electric Trim Installation...................................................................................................................... 2 C l l

AutoFlite II Installation......................................................................................................................... 2C14
Autocontrol Ill and lllB Installation (sln 28-7415001 and up, 28-7716001 thru 28-8216236) ............2C17
Century 21 Autopilot Installation (dn 28-8116019 and up) ................................................................. 2C20
King KAP 100/150 Autopilot Installation (sin 28-8316001 and up)..................................................... 2C23
Piper Automatic Locator (ELT) Installation (Garret Mfg. Ltd.) ............................................................. 202
Pipee Awtomatic Locator (ELT) Installation (CommunicationsComponents.Cofp.) ............................205
Piper Automatic Locator (ELT 10) Installation(Narco Avionics) ......................................................... 208
Piper Automatic Locator (ELT 910) Installation (Narco Avionics) .......................................................2011
Radar Altimeter Installation................................................................................................................. 2D14
Encoder Installation (Narco .AR 500 and United - 5125-P3)............................................................. 2017
Piper PM-1 Marker Beacon Installation (sln 28-7415001 t h 28-7415713) ~ ....................................... 2020
Radio, Antenna System and Static Wicks Installation ........................................................................2023
Audio Selector Assembly .................................................................................................................... 2E3
Avionics Cooling Installation ............................................................................................................... 2E6
Avionics Installation Drawings............................................................................................................. 2E9

SECTION Xlll
MISCELLANEOUS GROUP

85 Placards and Exterior Stencils ............................................................................................................

2E13
Optional Equipment Kits and Repar Kits ............................................................................................ 2E19
Miscellaneous Hardware and Consumables....................................................................................... 2E22

NUMERICAL INDEX

All Part Numbers ................................................................................................................................. 2Fl

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
' ,'44
' AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Re~ssued:December 1, 1989
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
i AIRPLANE PARTS CATALOG

a&

.
i(

MISCELLANEOUS
XIll

ELECTRONICS

ELECTRICAL WING CABIN EQUIPMENT

XI I v

Figure 1. Complete Airplane

Revised: July 30. 1994

 PIPER AIRCRAFT
' PA-28-151/161 WARRIOR
9
1-
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 64. Electrical System Installation

Revised: July 30. 1994

 PIPER AIRCRAFT -
PA-28-15111 61 WARRIOR
.L.
,, ' AIRPLANE PARTS CATALOG

CODE EXPLANATIONSFOR FIGURE 64

7'

A - With light cutouts, but less radio speaker cutouts.

I3- With light and radio speaker cutouts.
C - See Figure 71 if strobe light is installed. I
D - See Figure 60 if Cabin Ovehead Air Vent System is installed or Figure 62 if Air Conditioning is installed.
C - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thnr 28-7716244
and 28-7716246.
F - Used on 28 volt svstem.
Used on PA-28-151 with serial numbers 28-7515001 and up. and PA-28-161 with serial numbers 28-7716001 thnr 28-8216236.
DISTRIBUTORS: Before replacing engine gauges and senders, see Piper Aircraft Senrice Spares Letter 406.
Used on PA-28-151 with serial numbers 28-7415001 and up. and PA-28-161 with serial numbers 28-7716001 thw 28-8116240.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thnr 28-8216023. Also
used on PA-28-161 with serial numbers 28-8216024 and up if aircraft complies with United Kingdom requirements.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thnr 28-8216059.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 thnr 28-8216059.
See Figure 67 for component parts.
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 and up.
Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thnr 28-8416028.
Used if recognition lights are installed.
This part is no longer available. Order Alternator Control Service Replacem V as a replacement.
"
Used if a Chrysler alternator i s installed.
Not used with 99220-03 Speaker Assembly.
Optional.

'I'

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
+:r AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Rw. Affected
Number
, ,

64- 35 130 DRAWING - Electrical System Installation 28-7415001 thw 28-7415713

35544 P -
DRAWING Electrical System Installation
85360 -
DRAWING Electrical System Installation 28161f0 and up

BATTERY INSTALLATION
KIT - Landing light ring installation
COVER - Terminal strip
COVER - Terminal strip
PANEL ASSEMBLY Cabin light -
PANEL ASSEMBLY Cabin light -
RING ASSEMBLY - Landing light
-
SCREW (MS35206-234)
HORN ASSEMBLY Stall warning -
-
* HORN (PS50178-3)
HORN ASSEMBLY
HORN - (PS50178-5)
SOLENOID - Starter (487 169)
SOLENOID - Starter (487 152)
-
LIGHT White (A2064-1073)
. BULB - (1073)
* LENS -White
LIGHT - Red (A1285-R12)
LIGHT - Red (A675-PR-14) 28-8116241 and up
BULB - (1512) 14 volt
' LENS - Red
. GASKET - (W1283)
LAMP - Navigation light assembly (A508) 14 volt
28-8116241 and up
28-8116241 and up
* SOCKET ASSEMBLY - Navigation light (A507) 28-81 16241 and up
' LENS - Navigation light (A615) 28-8116241 and up
' GASKET - Navigation light (A616) 28-8116241 and UP
' RETAINER - Navigation light (A674) 28-8116241 and up
LIGHT - Green (A1285-(3-12)
LIGHT - Green (A675-PG-14)
BULB - (1512) 14 volt
' LENS - Green
' GASKET (W1283) -
-
LAMP Navigation light assembly (A508) 14 volt
-
SOCKET ASSEMBLY Navigation light (A507)
* LENS - Navigation light (A615)
* GASKET - Navigation light (A616)
-
RETAINER Navigation light (A674)
LIGHT ASSEMBLY Cockpit overhead-
LIGHT ASSEMBLY - Panel (A300-W-14)
LIGHT ASSEMBLY Cockpit overhead-
LIGHT ASSEMBLY Panel (A300-W-28) -
LIGHT - Landing (PS10008-4509)
-
LIGHT Landing (PS10008-4594)
-
BEACON Rotating (Grimes)
-
BEACQN Rotating (Whelen WRML-12)
-
BULB Rotating beacon (GE-1940)
DETECTOR - Lift (C52207-4)
PLATE - Lift detector mounting (C52207-2)
DECAL - Lift detector (C52207-3)
POTENTIOMETER - D~mmerassembly
CAPACITOR
-
RELAY Microphone
RELAY - Overvoltage (PS50034-1)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
$4~ .
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature ' Req. Affected
Number
- -

REGULATOR ASSEMBLY Voltage -

REGULATOR ASSEMBLY Voltage - 28-8416029 t h 2816109
~
ALTERNATOR CONTROL (800371-1) - 28-8416029 t h 2816109
~
REGULATOR ASSEMBLY Voltage - 2816110 and up
ALTERNATOR CONTROL (6-00368-2) - 2816110 and up
-
STRIP Terminal (MS25123-1-12)
SENDER - Engine unit, oil temperature (362-EW)
-
BULB Oil temperature (MS28034-1) 2816110 and up
SENDER - Cylinder head temperature (333-8)
GASKET (AH-1522) -
CABIN LIGHT ASSEMBLY (With light switch) -
CABIN LIGHT ASSEMBLY (W~thlight switch) -
SPEAKER ASSEMBLY 28-7716001 t h 2816109
~
SPEAKER ASSEMBLY 2816110 and up
' SPEAKER - Radio, circular (6FU3211)
GASKET - Radio speaker
GRILL - Radio speaker
PLACARD - Dome light
-
PLACARD ASSEMBLY Alternate static correlation
KNOB - (PS10067-4-1)
-
LAMP 14 volt
-
LAMP 28 volt
-
LENS Light (12715-00)

NIPPLE - Electrical
NIPPLE Electrical -
-
NIPPLE Teiminal(476 695)
GASKET Firewall seal -
-
DISC Firewall seal
PLATE - Firewall seal
GROMMET Firewall seal -
PLATE - Firewall seal
BUTTON Plug (HS-50726) -
-
FILTER (NFIC-270-4)
DIODE AND COOLER ASSEMBLY
' INSULATOR Cooler (103) - .-
COVER - Diode assembly -.
DIODE AND COOLER ASSEMBLY
WASHER lnsulabng -
' INSULATOR Cooler (103) -
COVER ASSEMBLY Landing lght opening -
-
WlRE ASSEMBLY Altemator to ammeter (96.5' L.)
WlRE ASSEMBLY -Alternator to ammeter (95 0' L)
-
WlRE ASSEMBLY Alternator to shunt (47.0' L)
WlRE ASSEMBLY Ground (9.3' L.) -
WlRE ASSEMBLY - Ground (5.3' L.)
LIGHT ASSEMBLY - Recognition 28-8516001 and up
LAMP - Recognition light (14 volt) 28-8516001 and up
FUSE ASSEMBLY Altemator out switch - 2816110 and up
* FUSE HOLDER 2816110 and up
' FUSE 2816110 and up
SWITCH - Alternator out 2816110 and up
' SWITCH 2816110 and up
RELAY - Primer switch 2816110and up
FUSE ASSEMBLY 28161lOand up
' FUSE HOLDER 2816110 and up
FUSE 2816110 and up
-
SHUNT Ammeter (MS91586-6) 2816110 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
q: . AIRPLANE PARTS CATALOG

Serial Ntrmbers
, Number Code Nomenclature Affected

64%7 85299-05 F -
CONTROL ASSEMBLY Ammeter, dimmer, and voltage
monitor 1 2819110 and up
475 272 F ' LOW VOLTAGE MONITOR (6-00375-2) 1 2816110 and up
686 814 F ' RELAY 1 2816110 and up
85378-02 V PlTOT HEAT SENSOR ASSEMBLY 1 2816110 and up
-69 557 122 DIMMER CONTROL 3 2816110 and up

When ordenng, always spectfy Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

2A19
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
s .- AIRPLANE PARTS CATALOG

i.

Figure 65. Instrument Panel Electrical Installation

(PA-28-181, and PA-28-161 serial numbers 28-7716001 thm 2816109)

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
;.:, ' . AIRPLANEPARTSCATALOG
CODE EXPLANATIONS FOR flGURE 65

If matching Qain door lock, baggage door lock and ignition switch are desired, order Kit 470 728.
Used on PA-28-161 28 volt system.
Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161. f
Used on PA-28-151 with serial numbers 28-7515001 and up, and PA 28-161.
If matching cabin door lock, baggage door lock and ignition switch are desired. order Kit 87329-03.
Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28 7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916617.

Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-n16001 thru 28-8116252.
Used on PA 28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8116268,
28-8216007,28-8216014,28-8216017,28-8216019,and 28 8216021.
Used on PA-28-161 with serial numbers 28-8116269 thru 28-8216006,28-8216008thru 28-8216013,28-8216015,28-8216016,
28-8216018,28-8216020,28-8216022 and up.
See Figure 75A for PA-28-161 with serial numbers 28-8316001 and up if King KAP 1001150 Autopilot is installed.
Used if recognition lights are installed.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
E' AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

6 35 130 -
DRAWING Electrical Instailation 28-7415001 thru 28-7415713
35544 D -
DRAWING Electrical Installation F
39684 -
DRAWING Carburetor Ice Detector Installation 28-8016280 and up
36926 DRAWING - Radio Master Switch Installation 28-8016001 thru 28-8216216
39870 -
DRAWING Radii Master Switch Installation 28-8216217 and up

-
CIRCUIT BREAKER (PS50120-3-8) 5 amp,
Wood Electric Cop.
-
CIRCUIT BREAKER (PS50120-3-11) 7.5 amp,
Wood Electric Corp.
CIRCUIT BREAKER - (PS50120-3-13) 10 amp,
Wood Electric Cop.
-
CIRCUIT BREAKER (PS50120-3-15) 15 amp,
Wood Electric Cop.
CIRCUIT BREAKER - (PS50120-1-9) 20 amp,
Mech. Products Inc.
-
CIRCUIT BREAKER (PS50120-3-36) 20 amp, fP.
Wood Electric Co*. AR 28-8016082 and up
CIRCUIT BREAKER - (PS50120-1-13) 60 amp,
Mech. Products Inc.
PANEL ASSEMBLY - Switch
-
PANEL Circuit breaker
PLACARD - Circuit breaker panel
PLACARD -Circuit breaker panel
-
PLACARD Circuit breaker panel1
COVER - Terminal strip 1
PLATE - Switch cover 3
SWITCH - Ignition (10-357210-1) 1 28-7415001 thru 28-7615001
-
SWITCH Ignition (10-357200-1) 1
SWITCH Fuel pump- 1
SWITCH - Landing light 1
SWITCH Master - 1
SWITCH - Master 1 28-8116253 and up
-
SWITCH Strobe lights 1
POTENTIOMETERASSEMBLY Nav, radio lights - 1
POTENTIOMETER ASSEMBLY - Panet lights 1
-
STRIP Circuit breaker 1
SPACER - Circuit breaker 1
PLACARD Panel lights- 1
-
PLACARD Nav and radio lights 1
KNOB - Instrument lights 2
RESISTOR - (244E2R05) 2
RESISTOR (243E2R05) - 2
TRANSISTOR - (2N3055) 2
SOCKET - Transistor (8080-1G2) 2
-
STRIP Terminal (1076) 2
STRIP -Terminal (MS25123-1-4) 1
-
FILTER Lunar wh~te(1813-26) 16
LAMP - (PS10008-53) 16
LAMP - (PS10008-265) AR
HOLDER ASSEMBLY - Instrument lights (PS10082-1-1) 16
LIGHT ASSEMBLY - (572 660) AR
BULB - (PS10008-330) AR
BUTTON - Plug (SS48152) 15
FUSE - (311005) 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Rev~sed:July 30, 1994

2A22
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
>i
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

65-30 79333-00 D -
PANEL ASSEMBLY Annunciator 1
79333-801 B -
PANEL ASSEMBLY Annunciator 1 F
-31 67422-12 D -
' LIGHT Indicator (oil) 1
-32 67422-13 D -
LIGHT Indicator (vacuum) 1
-33 67422-14 D -
' LIGHT Indicator (alternator) 1
-34 487 904 D -
SWITCH (39-1) 1
-35 472 054 D -
* LAMP (PSl0008-330) 2
472 058 B -
LAMP (PS10008-387) 2
-36 453 695 D -
LAMP (PS10008-328) 1
472 054 LAMP - (PS20008-330) 14 volt 1
-37 35208-02 M -
STRIP Circuit breaker 1 28-8016001 and up
-38 35208-03 M -
STRIP Circuit breaker 1 28-8016001 t h 28-8216236
~
35208-10 STRIP - Electrical Bus 1 28-8316001 and up
-39 35208-04 M -
STRIP Circuit breaker 1 28-8016001 and up
-40 587 923 -
SWITCH Radio master (PS10095-1) 1 28-8016001 and up
-41 36935-02 -
SWITCH ASSEMBLY Emergency bus 1 28-8016001 and up
-42 484 209 -
RELAY (PS50053-2-2) 1 28-8016001 t h 28-8216216
~
-43 463 615 GUARD - (MS25224-1) 1 28-8016001 and up
-44 36934-02 .,*. I BRACKET- Emergency bus switch 1 288016001 and up
-45 548512 DETECTOR - Carburetor ice (107AP) 1 28-8016280 and up
-46 763 496 PROBE - Carburetor ice detector (107AP-P-P) 1 28-8016280 and up
-47 95261-00 K LIGHT ASSEMBLY - Cluster 1
86414-13 L HOLDER ASSEMBLY Lamp - 1
-48 472 056 K ' LAMP - (PS10008-53) 2
472 055 B LAMP - (PSI 0008-336) AR
-49 472 086 L LAMP - (PS10008-336) 6 volt 4
-50 584 279 RELAY - (6041H298) 1 28-8216217 and up
-51 23969-02 -
NIPPLE Electr~cal 2 28-8216217 and up
-52 23969-03 -
NIPPLE Electrical 2 28-8216217andup
-53 461 629 D FUSE - (311005) 2 28-8216217 and up
-54 99377-66 N SWITCH - Recognition and landing lights 1 28-8516001 and up
65 87369-53 N -
PLACARD Landing and recognition lights 1 28-8516001 and up
$6 584 265 B RESISTOR - (RWR80S1001FR) 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: Decernber 1, 1989

2A23
 PIPER'AIRCRAFT
PA-28-151/161 WARRIOR
r y IRPLANE PARTS CATALOG

(VIEW OF PANEL LOOKING AFT)

..

,
OFF

BATT
MASTR

27J
I
I
ALTR

28'
OFF

I
I
%
29
OFF

!; '
8
l L
LIGHT

30 J
I
- OFF

STROB
LIGHT
L
\
OFF

LOG
UGHT
. I
I
OFF

RECOG
LIGHT
I
I

I33
, rl I

134

!jj RADIO
31

Figure 65A. Instrument Panel Electrical installation

(PA-28-161serial numbers 2816110 and up)

Added: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
+ ;* , AIRPLANE PARTS CATALOG

CODE EXPLANATlONS FOR flGURE 65A

-
A Used when circuit breaker is not installed.

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Added: July 30. 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
4' 4;
AIRPLANE PARTS CATALOG
Figure
and Part _. No. Serial Numbers
Index Number Code' Nomenclature Req. Affected
Number

65A- 85360 -
DRAWING Electrical Installation 2816110 and up
85375 -
DRAWING Circuit Breaker Panel Assembly - Complete 2816fi0 and up
85372 -
DRAWING Annunciator Panel Assembly Complete - 2816110 and up

-1 85375-02 -
PANEL ASSEMBLY Circuit breaker (Complete) 1
-2 85374-02 PANEL ASSEMBLY - Circuit breaker 1
-3 454 736 ' CIRCUIT BREAKER 3 amp - AR
454 738 CIRCUIT BREAKER - 5 amp AR
454 739 ' CIRCUIT BREAKER 7.5 amp - AR
454 732 CIRCUIT BREAKER 10 amp - AR
687 800 * CIRCUIT BREAKER - 70 amp AR
581 657 A ' PLUG BUlTON AR
-4 89276- 11 ' BUS 1
-5 89276-15 ' BUS 1
-6 89276-13 ' BUS 1
-7 89276- 12 ' BUS 1
-8 89276- 14 ' BUS 1
-9 85372-02 -
PANEL ASSEMBLY Annunciator (Complete) 1
456 703 ' DIODE 20
-10 89452-04 -
LIGHT ASSEMBLY Indicator (599 553) 1
-11 89452-18 -
' CAP Low bus voltage, red (653 631) 1
-t2 89452-35 -
'' CAP Starter engage, red (654 508) 1
-13 89452-32 -
' CAP Vacuum inop, amber 1
-14 89452-33 -
'' CAP Alternator inop, red 1
-15 89452-21 -
' ' CAP Oil pressure, amber 1
-16 89452-26 -
' ' CAP Green w~thblack line 4
-17 472028 "LAMP 18
-18 514758 -
SCREW (MS24693C6B) 2
-19 688 175 SWITCH - Press to test (MPA-1O6F) 1
-20 653 588 -
CAP Switch (C-22) I
-21 487 877 -
SW;TCH Day / n~ght(MST-115D) 1
-22 572 625 LIGHT ASSEMBLY - Instrument post (75619-06) 21
472 028 LAMP 21
-23 85426-02 SWITCH ASSEMBLY Primer - 1
688 100 SWITCH 1
688 603 * CAP 1
561 027 ' FILTER 1
472 200 * LAMP 1
-24 688 178 SWITCH lgn~tion - 1
-25 571192 -
KNOB Dimmer control 3
-26 688 296 SWITCH 8
561 027 FILTER 16
472 200 LAMP 16
-27 84622-84 -
CAP Switch, Batt mastr (654 495) I
-28 84622-85 -
CAP Switch. Altr (654 496) 1
-29 84622-68 -
CAP Switch, Fuel pump (654 480) 1
-30 84622-13 -
CAP Switch. Nav light (653 512) 1
-31 84622-12 CAP - Switch. Stmb light (653 511) 1
-32 84622-10 -
CAP Switch. Ldg light (653 509) 1
-33 84622-52 CAP - Switch, Recog light (653 566) 1
-34 687 211 SPACER 1
-35 84622-17 -
CAP Switch, Radio mastr (653 516) 1
-36 588 464 TERMINAL STRIP - (MS27212-1-4) 1
-37 35207-00 BUS 1
-38 79151-00 WIRE ASSEMBLY - Ground 1
-39 548 885 AMMETER - (PM-349) 1
-40 85328-03 HARNESS ASSEMBLY - Ammeter 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Added: July 30. 1994

2B2
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
-
..
% AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Added: July 30.1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-- . ,
:*
,I . AIRPLANE PARTS CATALOG

Figure 66. Air Conditioning Electrical Instailation

(28-7816001and up)

Reissued: December 1, 1989

2B4
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
.? . + AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 66

A - Order part fot.serial numbers 28-7816172 and up if the four position fan switch has been replaced with a three position fan switch.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
.t'.
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
'Index Number Code Nomenclature Req. Affected
Number -
66- 99979 -
DRAWING Air Conditioning Electrical Installation
i

-1 99862-00 MOUNT ASSEMBLY Relay - 1

-2 99; '-00 THERMOSTAT - Air conditioning 1
-3 9917C-00 -
BRACKET Throttle limit switch support 1
-4 484 209 -
RELAY (PS50053-2-2) 3
-5 587 903 SWITCH - (MS35058-22) 1
-6 487 925 SWITCH (V3-1) - 1
7
; 763 815 A -
SWITCH REPLACEMENT KIT Fan (4 position) 1 28-7816001 thru 28-7816171
688 235 -
SWITCH (8946K942) (3 position) 1 28-7816172 and up
-8 454 709 -
CIRCUIT BREAKER (PS50120-1-9) 20 amp, 1
Mech Products Inc. 1 28-7816001 t h 28-801
~ 6081
454 743 -
CIRCUIT BREAKER (PS50120-3-36) 20 amp 1
Woad Electric C o p 1 28-8016082 and up
-9 571 162 KNOB - Control (RB-67-1-SB-M) AR
-10 99999-00 HOLDER ASSEMBLY Fuse - 1
-11 461 629 -
FUSE (311005) . 1
-12 465258 HOLDER,ASSEMBLY Fuse (155020) " 4
-13 461 629 FUSE - (311005) 4
-14 472 054 -
LAMP (PSI 0008-330) 1
-15 472 844 LIGHT - (MS25041-4) 1
-16 484 467 RESISTOR (4392) - 1

When ordering, always spec~fyPart Number. Description, and Serial Number of Aircraft

Reissued: December 1, 1989

286
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
s'' w AIRPLANE PARTS CATALOG

Figure 67. Battery Box Installation(1 of 2)

14 Volt System

Reissued: December 1. 1989

287
 . PIPER AIRCRAFT
PA-28-1511161 WARRIOR
s o . AIRPLANE PARTS CATALOG

- f

Figure 67. Battery Box Installation (2 of 2)

28 Volt System

Revised: July 30, 1994

2B8
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
.& AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 67

A Used on 28 volt system.

&-

B -, Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161.
C -
Used on PA-28-151 with serial numbers 28-7415001 thru 28-7715314, and PA-28-161 with serial numbers 28fl16001 thru
28-8216236.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
.F: AIRPLANE PARTS CATALOG

Figure
and Part No. SerialNumbers
Index Number Code ~omenclature + Reg Affected
Number

67- 35130 -
DRAWING Electrical System Installation 28-7415001 t h 28-741
~ 5713
35544 B -
DRAWING Electrical System Installation F
73989 A -
DRAWING Electrical System Installation

-1 450 030 -
BATTERY (S25) 25 AMP, Hour 1
450 035 BATTERY - (R35) 35 AMP, Hour 1
450 101 A BATTERY (G243) - 1
-2 35202-00 C BOX ASSEMBLY Battery - 1
-2a 484305 C RECEPTACLE - (2600-212-12) 4
-3 35201-00 C COVER ASSEMBLY - Battery box (with phenolic guard) 1
-3a 587 581 C -
STUD (2600-7W) 4
494 060 WASHER - (2600-LW) 4
-4 62279-00 DIODE ASSEMBLY Master relay - 1
89803-06 A DIODE ASSEMBLY 1
-4a 89803-05 A WIRE ASSEMBLY 1
-5 455 151 CONTACTOR - (6041H105A) 1
455 211 A CONTACTOR (6041H202A) - 1
-6 63904-06 C HOSE - Battery vent,.feft (19' long) 1
-7 63904-64 C HOSE - Battery vent, nght (14' long) 1
-8 454 161 VENT TUBE (1704-9-Y) - 1 28-7415001 t h 28-7715314
~
1 28-7716001 t h 28-8616049
~
-9 23969-02 NIPPLE - Electrical 2
-10 23969-05 NIPPLE - Electrical 2
-11 66580-02 NIPPLE - Termma1 (476 695) 1
-12 454 983 C CLAMP (SAE 8)- 4
-13 401306 C BOLT - (AN3-4A) 4
407 564 C -
WASHER (AN960-10) 4
-14 401 307 -
BOLT (AN4-4A) 2
407 801 C -
WASHER (AN970-4) 2
407 565 -
WASHER (AN960-416) 2 28-8316001 t h 2816109
~
404 836 C NUT - (MS20364-428C) 2
401 307 A -
BOLT (AN4-4A) 2
407 565 A -
WASHER (AN960-416) 2
404 888 A -
NUT (MS20365-428C) 2
-15 78140-33 C WIRE ASSEMBLY - Battery to ground 1
79653-121 WIRE ASSEMBLY - Battery to ground- 1 28-8316001 thru 2816109
73989-05 A WIRE ASSEMBLY Battery to ground - 1
-16 78140-39 A WIRE ASSEMBLY Battery to solenoid - 1
79653-97 WIRE ASSEMBLY Battery to solenoid - 1 28-8316001 thru 2816109
-17 79653-126 -
WIRE ASSEMBLY Battery solenoid to starter solenoid 1
79653-139 WIRE ASSEMBLY - Battery solenoid to starter solenoid 1 28-8316001 and up
-18 79595-19 -
FUSE ASSEMBLY Voltage spike supression 1 28-8116001 and up
79595-20 A FUSE ASSEMBLY -Voltage spike supression 1
-19 461 657 -
' FUSE (312001) 1 amp 1 28-8116001 and up
461 629 A ' FUSE - (311005) 5 amp
-20 35845-02 BOX ASSEMBLY Battery - 1 28-8316001 and up
-21 63977-00 COVER ASSEMBLY Battery - 1 28-8316001 and up
-22 63904-105 HOSE - Battery drain 1 28-8316001 and up
-23 63904-106 -
HOSE Battery vent 1 28-8316001 and up
-24 63904-107 -
HOSE Battery vent 1 28-8316001 and up
-25 66616-00 TERMINAL ASSEMBLY Battery box - 2 28-8316001 and up
-26 17555-00 PLATE - Battery ~nsulation 2 28-8316001 and up
-27 401 306 -
BOLT (AN3-4A) 6 28-8316001 and up
407 674 -
WASHER (AN960-C10) 6 28-8316001 and up
-28 23969-05 NIPPLE - Term~nal 2 28-8316001 and up

When ordenng, always spec~fyPart Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

2B10
 - PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
1$ AIRPLANE PARTS CATALOG
~igure
and Part No. Serial Numbers
Index Number Code Nomenclaturet Req. Affected
Number
1.

67-$9 554 861 -

CLAMP (SAE N F-4) 1 28-8316001 and up
-36' 454 983 CLAMP - (SAE PI E-8) 2 28-8316001 and up
-31 81342-56 -
WASHER Battery box 2 28-8316001 and up
-32 84316-02 A INSULATOR 2
400 496 A -
BOLT (AN3-73A) 2
407 800 A -
WASHER (AN970-3) 2
-33 488 722 A TY-RAP - (MS3367-4-9) 2
-34 559 031 A -
ELBOW (TBP3621) 1
-35 554 960 A -
CLAMP (PS10017-8-10) 2
-36 73989-03 A TUBE - Vent (35.0' long) 1
-37 73989-04 A TUBE - (1.Om long) 1
-38 488 503 A TERMINAL - Gmund 1
488 494 A TERMINAL - Positive 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
AIRPLANE PARTS CATALOG

.n

Figure 68. External Power Supply Installation

(28-7415001 and up and 28-7716001 thw 28-8216236)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
* 7 * AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 68

A ; Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-77'16001 thru 28-8216236.
B - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 207716323.

Reissued: December 1 , 1989

 :) PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
,."s
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature - Req- Affected
Number

68- 35298 -
DRAWING Auxiliary Power Receptade Installation
#

62226-00 -
SPACER Auxiliary power receptacle 1
-2 62227-00 -
PLATE Auxiliary power receptacle 1
3 69669- 173 -
PLACARD External power supply 1 28-7716001 and up
-4, 89097-02 PLUG ASSEMBLY Power connector - 1
-5 62355- 11 CONNECTOR ASSEMBLY Power connector - 1
-6 35297-00 B TUBE - Auxiliary power receptacle support 1
35298-07 -
TUBE Auxiliary power receptacle support 1 28-7816001 and up
-7 68 198-00 SUPPORT - Diode 1
-8 456 728 DIOOE - (lN3208) 1
-9 23969-02 NIPPLE Diode - 1
-10 484 373 -
RELAY Power (PS50053-5-2) 1 28-7716001 and up
-11 23969-05 -
NIPPLE Electrical terminal (476 683) 2
-12 400728 BOLT - (AN25-11A) 2
407 566 WASHER - (AN960-516) 2
407 106 WASHER (AN935-516) - = 2
404 323 -
NUT (AN316-5R) 2
-13 401 307 -
BOLT (AN4-4A) 2
407 565 WASHER - (AN960-416) 2
404 888 -
NUT (MS20365-428C) 2
-14 416794 -
SCREW (MS24693-5275) 4
494 087 WASHER (A3235-020-1) - 4
407 564 WASHER - (AN960-10) 4
404 835 NUT - (MS20364-1032C) 4

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2B14
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 68A. External Power Supply Installation

(28-8316001thru 2816109)

Reissued: December 1, 1989

 PIPER AIRCRAFT
*'
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPkANATIONS FOR.FIGURE 68A

Re~ssued:December 1, 1989
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
i:"
AIRPLANE PARTS CATALOG -4,

Figure
and Part -t . No. . Serial Numbers
Index Numher Code Nomenclature Req- Affected
Number

-
DRAWING Extemal Power Supply Installation

-
SPACER Auxiliary power receptacle 1
-
PLATE Auxiliary power receptacle 1
-
WIRE Ground 1
BRACKET ASSEMBLY - Auxiliary power relay 1
SOLENOID (24059) - 1
PLUG ASSEMBLY - Power connector 1
PLUG ASSEMBLY - Power Connector 1 2816038 and up
SOCKET ASSEMBLY Power connector - 1
SOCKET ASSEMBLY - Power Connector 1 2816038andup
PLACARD Extemal power - 1
SUPPORT - Diode mounting 1
-
DIODE (lN3208) 1
NUT - (AN316-4R) 1
NIPPLE 1
NIPPLE 3
PLATE - 2
GROMMET 2
GASKET 1
BOLT - (AN25-1 1A) 2
WASHER (AN960-516) - 2
WASHER (AN935-516) - 2
NUT - (AN316-5R) 2
BOLT - (AN4-4A) 2
WASHER - (AN960-416) 2
-
SCREW (M524693-5275) 4
-
WASHER Countersunk (A3235-020-1) 4
WASHER - (AN960-10) 4
NUT - (M520364-1032C) 4

When ordenng, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1. 1989

2817
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
+ 'AIRPLANE PARTS CATALOG

Figure 688.Auxiliary Power Receptacle Installation

(Serial numbers 2816110 and up)

Added: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
r + AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 688

Added: July 30, 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
< ,<
" AIRPLANE PARTS CATALOG
Figure
and -- Part No. Serial Numbers
Index Number- Code Nomenclature Req. Affected
Number

68B- 85421 -
DRAVJING Auxiliary Power Receptade Installation 2816110 and up
r
DOOR ASSEMBLY - Auxiliary power receptacle
RECEPTACLE - (MS3506-1)
BOOT - (MS25171-IS)
-
BOOT (MS25171-4s)
STRAP
BRACKET
BLOCK
BLOCK
-
BOLT (AN4-44)
WASHER (AN960-416) -
DECAL
WlRE ASSEMBLY
WlRE ASSEMBLY
WlRE ASSEMBLY
RELAY
DiODE ASSEMBLY
-
BOLT (AN3-4A)
WASHER (AN960-10) -
GROMMET
BOLT - (AN3-7A)
WASHER (AN960-10) -
-
NUT (MS20365-1032C)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Added: July 30, 1994

2B20
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
, - AIRPLANE PARTS CATALOG

Figure 69. Alternator Assembly (Prestolite)

Reissued: December 1, 1989

 -PIPERAIRCRAFT
PA-28-1 511161 WARRIOR
%r ". AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 69

. '

A - Used on PA-28-151 with serial pumbers 28-7415001,28-7415002,28-7415004thru 28-7415421.

B - Used on PA-28-161 with serial numbers 28-7816001 and up if air conditioning is installed.
C - Used with Alternator Assembly (ALY-6408) only. I
D, - Used with Alternator Assembly (ALY-6421) only.
E - Used with Alternator Assembly (ALY-6422) only.

<

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
..- AIRPLANE PARTS CATALOG

Figure
and Part No, Serial Numbers
Index Number Code Nomenclature Req- Affected
Number
-..
69-1. 551 984 A ALTERNATOR ASSEMBLY (ALY-6421) - 1
551 983 B ALTERNATOR ASSEMBLY (ALY-6422) - 1 I
-2 762 243 C ^ SLIP RING END HEAD AND ROTOR ASSEMBLY -
Package (90-2396) 1
-3 757 386 C ' ' PACKAGE - Bearing and seal S.R.E. (90-2014) 1
-4 757 387 C -
' ' PACKAGE Rectifier, negative (XA 944 JS) 1
-5 754 827 FAN ASSEMBLY - Ventilating (90-2241 ) 1
-6 757 391 C,D -
' PULLEY Drive (PU-6728) 1
757 392 E -
' PULLEY Drive (PU-692B) 1
-7 758 224 BRUSH HOLDER AND SPRING ASSEMBLY -
(ALE-1045BS) 1
-8 758 471 -
' ' BRUSH SET Alternator (ALE-1013AS) 1
-9 755 232 -
^ HEAD ASSEMBLY Drive end (ALE-1003K) 1
-10 758 225 ' ' BEARING - Ball, seal (X-3416) 1
-11 756 060 ' RECTIFIER AND PLATE ASSEMBLY - Positive
(ALE-1054A) 1
-12 761 903 TERMINAL STUD AND PARTS PACKAGE (90-2043) - 1
-13 756061 RETAINER - Drive end (GR-32) 1
-14 757 388 ACKAGE - Thw bolt (ALA-20JS) ,- 1
-15 757389 -
ACKAGE Eyelet (90-818) 1
-16 757 390 PACKAGE - Nut and washer (90-33) 1
-17 757 720 C,D ' SPACER - Rotor shaft (ALD-21 ) 1
757 721 E SPACER - Rotor shaft (ALD-21A) 1
-18 755271 D,E ' HEAD ASSEMBLY - Slip ring end (ALK-1132BS-I) 1
-19 757 387 D,E * PACKAGE - Rectifier, negative (XA944JS) 1
-20 762 509 D . -
ROTOR (ALE-21735-1) 1
.* 762 508 E -
ROTOR (ALE-2177s-1) I
-21 757 386 D,E, ' PACKAGE - Bearing and seal S.R.E. (90-2014) 1
-22 757 719 STATOR ASSEMBLY - (ALEQOO8AES) I

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1. 1989

2823
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
. & .
AIRPLANE PARTS CATALOG

Figure 70. Alternator Assembly (Chrysler)

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
...* .r -
*AIRPLANEPARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 70

A
B
.- Used on PA-28-151 with serial numbers 28-7415003,28-7415422 and up, and PA-28-161.
Used on PA-28-151 with serial numbers 28-7415003,28-7415422thru 28 7415713.
C - Used on PA-28-161 with serial numbers 28-7916241 thru 28-8216162. If AltematorICapacitor Mounting Kit 7 q 347 has been installed
per Service Spares Letter 366A order part for serial numbers 28-8216163 and up.
D - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916240. If
AltematorICapacitor Mounting Kit 764 347 has been installed per Service Spares Letter 366A order part for serial numbers
28-8216163 and up.
E - Used on PA-28-151 with serial numbers 28- 7415001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-7916507.
F - Used with Alternator Assembly PIN 69670-04 (Chrysler No. 4111810) only.
G - Used with Altemator Assemblies PIN 69670-00 and 69670-03 (Chrysler No. 3656624) only.
H - Used on PA-28-151 with serial numbers 28-7415003,28-7415422 thru 28-7515334.
J - Used on PA-28-151 with serial numbers 28-7515335 and up, and PA-28-161.
K - Used on PA-28-151 and PA-28-161 with serial numbers 28-7716001 thru 28-7716197 and 28-7716199 thru 28-8116014.
L - Used on PA-28-151 with serial numbers 28-7415001 and up. and PA-28-161 with serial numbers 28-7716001 thru 28-8116014.
M - Used on PA-28-151 with serial numbers 28-7415003,28-7415422thru 28-7515334; and PA-28-161 with serial numbers28-7716198,
28-8116015 and up.
N - Used on PA-28-151 with serial numbers 28-7515335 and up; and PA-28-161with serial numbers 28-7716001 thru 28-7716197, and
28-7716199 t h 28-8116014.
~
P - Used on PA-28-151 with serial numbers 28-7415422 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216162. If
Altemator/Capacitor Mowting Kit 764 347 has been installed per Service Spares LetterJMA, order parts for PA-28-161 wlth serial
numbers 28-8216163 and up.
Q - Also used on PA-28-151 with senal numbers 28-7415001 and up and PA-28-161 with serial numbers 28-7716001 thru 28-8216162 if
AlternatorICapacitor Mounting Kit 764 347 has been installed per Service Spares Letter 366A.
R - This alternator is no longer available. It is replaced by Piper Code Number 599 303 (ElectroSystems ES4020, 60 amp).

Revised: July 30, 1994

 PIPER AIRCRAFT
-t
PA-28-1 51/161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
' - and ,' Part , No. SerialNumbers
Index Number Code ~omenclature ' R-4- Affected
Number
70- 99937 K DRAWING - Alternator Installation
87323 -
DRAWING Alternator Installation 28-7#l6198, and
28-811601 5 thru 2816109

ALTERNATOR ASSEMBLY (Chrysler41118lO) -

-
SHIELD ASSEMBLY Drive end (2098634)
'SHIELD ASSEMBLY -Drive end (4111822)
-
' BEARING Drive end shield (20984-78)
-
BEARING Drive end shield (3656444)
PLATE - Bearing retainer (2095012)
* STATOR ASSEMBLY (3438768) -
.STATOR ASSEMBLY - (4111804)
ROTOR ASSEMBLY (3656632) -
ROTOR ASSEMBLY (4111817) -
-
SHIELD ASSEMBLY Rectifier end (3438712)
-
SHIELD ASSEMBLY Rectifier end (4091535)
BEARING - Rectifier end shield (2098512)
-$
-
BEARING Rectifier end shield (3755184)
PULLEY ASSEMBLY - (2642706)
KIT - (3) Frame screws (3656470)
' SCREW - Frame (4111814)
'WASHER -(4111887)
TERMINAL BLOCK (3438729) -
-
* BUSHING Altemator end shield (2098052)
BUSHING - Alternator end shield (2095052)
' BRUSH ASSEMBLY - Vertical (2095039)
' BRUSH HOLDER - Axial (3438159)
' BRUSH HOLDER - Radial (4091667)
-
BRUSH ASSEMBLY Horizontal (3420893)
' RECTIFIER ASSEMBLY Positive (3438727) -
" RECTIFIER ASSEMBLY Negative (3438721) -
HEAT SlNK - Negative (3755114)
CAPACITOR - (3438725)
' CAPACITOR, STUD, AND INSULATOR PACKAGE -
(3620793)
BATTEPY TERMINAL PACKAGE (3620794)- .J .
BATTERY TERMINAL AND POSITIVE HEAT SlNK
PACKAGE (4240488) - 1
RETAINER AND SLIP RING PACKAGE (3744889) - 1
TERMINAL (3438709) - 3
BRUSH AND WASHER PACKAGE (4176097) - 1

-
SCREW (6031272) 2
TERMINAL FIELD - (4111809) 1
-
BOLT (MS20074-05-06) 1
WASHER - (AN960-516) 2
-
WASHER (AN936-A516) 1
-
BOLT (MS20074-05-06) 1
WASHER 1
-
BOLT (MS20074-05-05) 1
-
BOLT (MS20074-05-07) 1 28-8216163 and up
-
WASHER (AN936B516) 1
-
WASHER (AN935 516) 1 28-8216163 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

2C2
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
- ", , AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

70-f7 401 971 M -

BOLT (MS20074-05-06) 2
401 970 N -
BOLT (M520074-05-05) 2 F
407 137 -
WASHER (AN936 A516) AR
407 586 -
WASHER (AN960 516L) AR
-28 401 970 -
BOLT (MS20074-05-05) 1
407 566 H WASHER - (AN960 516) 1
407 137 J -
WASHER (AN936 A516) 1
-29 764 092 L ALTERNATOR MOUNTING HARDWARE KIT 1
-30 401 424 BOLT - (AN6-44A) 1 28-8116015 and up
407 107 -
WASHER Lock (AN935-616) 2 28-8116015andup
407 567 -
WASHER (AN960-616) 3 28-8116015andup
407 587 -
WASHER (AN960-616L) 4 28-8116015 and up
404 838 NUT - (MS20364-624C) 1 28-8116015 and up
-31 86700-36 ' BUSHING 1 28-8116015 and up
-32 79238-00 G STRUT - Alternator 1
78483-00 F STRUT - Alternator 1
-33 582 172 PLATE - Lock (73383) 1
-34 63531-00 -
CHANNEL Alternator support 1
-35 63520-00 D ,p:.. BRACKET ASSEMBLY - Alternator support -+. 1
65199-00 C BRACKET - Alternator support 1
65199-05 Q BRACKET - Alternator support 1 28-8216163 and up
-36 564 852 BELT 1
-37 63897-06 CAPACITOR ASSEMBLY 1
-38 65199-04 Q BRACKET - Alternator support 1 28-8216163 and up
-39 401 971 Q BOLT - (MS20074-05-06) 2 28-8216163 and up
407 106 Q WASHER - (AN935-516) 2 28-8216163 and up
-40 69666-00 B RESISTOR ASSEMBLY 1
41 69668-00 B PLACARD - Alternator warning 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

2C3
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
-F, . AIRPLANE PARTS CATALOG

Figure 71. Strobe Light Installation

Reissued: December 1. 1989

2C4
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
T -. AIRPLANE PARTS CATALOG
..
CODE EXPLANATIONS FOR FIGURE 71

A - Used if whitestrobe wing tip lights are not installed.

0 - Used if white strobe wing tip lights are installed.
C - Used if unshieldedwing tip strobe lens is installed. f
D - Must be used when an A.D.F Radio Installation is installed.
E - Used on PA-28-161 with serial numbers 28-7816608 and up.
F - Used vith white wing tip strobe only.
G - Used with red wing tip strobe only.
H - Used on PA-28-151, and PA-28-161 with serial numbers 28-7716001 thm 28-7916204.
J - Used on 28 volt system.
K - Used on PA 28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8116240.
L - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thm 28-8116240, if red
wlng tip strobe is installed. Also used on PA-28-161 with serial numbers 28-8116241 and up.

Reissued: December I,1989

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part a , No. Serial Numbers
Index Number Code Nomenclature Req- Affected
-: Number

71- 99030 H -
DRAWING Strobe Lights Installation
38221 -
DRAWING Strobe Lights Installation 28-7716003 thw 28-7916204
79850 DRAWING - Wing Tip Strobe Lights Installation 28-7916205 t h 28-81
~ 16240
36789 -
DRAWING Wing Tip Strobe tights Installation 28-8116241 and up
79850 DRAWING - Fin 'lip Strobe tight Installation 28-7916205 thru 28-8216023
36789 -
DRAWING Fin 'lip Strobe tight Installation, 28-8216024 and up

481 214 A -
POWER SUPPLY Strobe light 1
763 469 B -
POWER SUPPLY Strobe light 1
481 247 POWER SUPPLY -Strobe light 1 2816110 and up
757 762 LIGHT ASSEMBLY - Strobe, fin (unshielded) 1
761 189 D -
LIGHT ASSEMBLY Strobe, fin (shielded) 1
-3 761 161 -
LENS Strobe light, red (unshielded) 1
761 190 -
LENS Strobe light, red (shielded) 1
-4 755 200 CLAMP ASSEMBLY - Ring 1
-5 751 312 ADAPTER - Mounting plate 1
-6 761 158 LIGHT ASSEMBLY - Red navigation and white strobe.
wing tip (unshielded) 1
472 896 D,K LIGHT ASSEMBLY - Red navigation and white strobe. -h
wing tip (shielded) 1
572 557 D LIGHT ASSEMBLY - Red navigation and white strobe.
wing tip (shielded) 1 28-8116241 and up
572 593 J LIGHT ASSEMBLY - Red navigation and white strobe.
wlng tip (90071-00) 2816110and up
472 988 D LIGHT ASSEMBLY -Red navigation and red strobe,
wing tip (shielded) 1 28-7916205 thw 28-8116240
572 558 D LIGHT ASSEMBLY - Red navigation and red strobe,
mng tip (shielded) 1 28-8116241 and up
761 159 -
LIGHT ASSEMBLY Green navigation and white strobe,
wing tip (unshielded) 1
472 895 D,K LIGHT ASSEMBLY - Green navigation and white strobe.
wing tip (shielded) 1
572 561 D -
LIGHT ASSEMBLY Green navigation and white strobe.
wing tip (shielded) 1 28-8 11624 1 and up
572 592 J LIGHT ASSEMBLY - Green navigation and white strobe.
wing tip (90071-01) 2816110and up
472 987 D LIGHT ASSEMBLY - Green navigation-andred strobe,
wing tip (shielded) i 1 28-7916205 thm 28-8116240
572 560 D LIGHT ASSEMBLY - Green navigation and red strobe.
wing tip (shielded) 1 28-8116241 and up
-7 756 037 C,F,K -
' RETAINER Light lens 1
762 581 C,G ' RETAINER - Light lens 1 28-7916205 thw 28-8116240
762 616 -
' RETAINER Light lens 1 28-8116241 and up
-8 761 156 F,K ' TUBE ASSEMBLY Flash tip - 1
762 003 G TUBE ASSEMBLY Flash tip - 1
-9 761 157 K -
LENS Wing tip strobe (unshielded) 1
761 224 LENS - Wing tip strobe (unshielded) 1 28-8116241 and up
-10 751 202 LENS - Navigation, red 1
751 201 ' LENS - Navigation, green 1
-11 751 381 -
LAMP (1512) 14 volt 1
553 494 J -
LAMP (W1290-28) 28 volt 1 2816110 and up
-12 761 162 F,K LENS AND RETAINER ASSEMBLY -Wing tip strobe
(shielded) 1
761 253 F ' LENS AND RETAINER ASSEMBLY -Wing tip strobe
(shielded) 1 28-8116241 and up
761 222 G,K ' LENS AND RETAINER ASSEMBLY -Wing tip strobe
(shielded) 1
761 254 G LENS AND RETAINER ASSEMBLY -Wing tip strobe
(shielded) 1 28-8116241 and up

When ordering, always spec~fyPart Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

2C6
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
r 7
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

71-13 755 075 ' GASKET - Navigationlight (W1283) 1

-14 755 076 ' GASKET - Wing strobe (A-427-4) 1 f
-15 761256 LAMP - Navigationlight assembly, 14 volt (A508) 1 28-8116241 t h 2816109
~
761 208 J -
LAMP Navigationlight assembly, 28 volt (A508) 1 2816110 and up
-16 762 426 -
SOCKET ASSEMBLY Navigation light (A507) 1 264116241 and up
-17 761 255 -
LENS Navigation light (A615) 1 28-8116241 and up
-18 755 096 -
' GASKET Navigation light (A616) 1 28-8116241 and up
-19 99377-06 A -
SWITCH Strobe lights, gray 1
99377-07 B -
SWITCH Strobe lights, gray 1
-20 99031-00 BRACKET ASSEMBLY - Power supply mounting 1
-21 35669-107 E -
PLACARD Strobe light outlet 1
-22 96602-00 H PLACARD Warning - 1
69669-175 PLACARD -Warning 1 28-7916205 thm 28-7916617

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

2C7
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
.%-F . AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Re~ssued:December 1, 1989
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
,n:i ,
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
,
AIRPLANE PARTS CATALOG
- 6

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
,- AIRPLANE PARTS CATALOG

Figure 72. Electric Trim Installation

Reissued: December 1,1989

2Cl I
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
. R i
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 72

A -
B - Used on PA-28-151 with serial numbers 28-7515213 and up, and PA-28-161with serial numbers 28-7716001 and up. Also used on
PA-28-151 with serial numbers 28-7415001 t h 28-7515212
~ if Electric Trim Servo Replacement Kit 763 850 has been installed.
C - Trim Servo Assembly is no longer available. Order Electric Trim Servo Replacement Kit 763 850 and electric trim switch, P/N 761 039.
D - Used if a push on-off switch is installed.
E - Used on PA-28-151with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8216109.
F - Used on PA-28-161 with serial numbers 28-8215110 and up. Also used on PA-28-151with serial numbers 28-7415001 and up and
PA-28-161 with serial numbers 28-7716001 thru 28-8216109if Pitch Trim Switch Replacement Kit 764 401 has been installed.

Re~ssued:December 1, 1989
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-4 AIRPLANE PARTS CATALOG

Figure
and Part - No. Serial Numbers
index Number Code Nomenclature Req. Affected
Number
DRAWING Electric Trim Installation

C SERVO ASSEMBLY Trim -

B SERVO ASSEMBLY Trim -
' WASHER - Servo friction (24696-00)
-
PLATE Servo clutch, outer (24695-00)
-
BRACKET Electric Trim
-
BUSHING Electric Trim
-
BRACKET ASSEMBLY Electric Trim
-
CABLE ASSEMBLY Front stabilator trim
-
PULLEY (MS24566-1B)
E FlTCH TRIM SWITCH REPLACEMENT KIT
F -
SWITCH Electric trim (PS10095-1)
F -
' PLACARD Electric trim
F ' PLACARD On-off -
D -
PLACARD Electric trim
BUSHING - Electric trim
-
BoLT (AN3-13A)
WASHER - (AN960-10)
-
NUT (MS20365-1032C)
-
BOLT (AN3-5A)
WASHER - (AN960-10)
NUT - (MS20365-1032C)
-
NIPPLE Electrical
-
BOLT (AN3-12A)
WASHER - (AN960-10)
NUT - (MS20365-1032C)
GROMMET - (AN931-3-5)
SPRING - Electric trim

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1. 1989

2C13
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
*.-
,
-<

. ' AIRPLANE PARTS CATALOG

-
Figure 73. AutoFlite II installation

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
.- . AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 73

A +Used if AutoRite II without tracker is installed.

B p Used if AutoFlite il with tracker is installed.
t

Reissued: December 1, 1989

 PIPER AIRCRAFT
'+I* r
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
ana Part No. Serial Numbers
Index Number Code . Nomenclature Req. Affected
Number

73- 99447 -
DRAWING AutoFlite 11 installation
I

INSTRUMENT - Turn and bank (52D75-3)

-
INSTRUMENT Turn and bank (52075-4)
-
'TRACKER BOARD Printed circuit (10628)
PLATE - Turn and bank mounting
CABLE - Bridle (308200)
CABLE ASSEMBLY - Roll SeNO (30C211-8R)
-
CABLE ASSEMBLY (30'379-1)
SWITCH - (8134-K21AlV-50)
BOX - Relay (1A526)
-
BRACKET AutoFlite 11
BRACKET - Servo mounting (7C511-3)
-
PLACARD AutoFlite 11
-
GUARD Cable (7A508-1)
CLAMP ASSEMBLY - Bridle cable (42A173-1)
SERVO - Roll (1C363-1-430R)
* SET SCREW - Capstan (3S326)
BLOCK - Rub (7A1373)
CIRCUIT PROTECTOR - (PS50120-3-7),5 amp

When ordering, always speclfy Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2C16
 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
C, . AIRPLANE PARTS CATALOG

Figure 74. Autocontrol Ill and lllB Installation

(28-7415001 and up and 28-7716001 thiu 28-8216236)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
.-w
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 74

- A - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8216236.
B - Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161 with serial numbers 28-7716001 hru 286116018.
28-8116276,28-8116252,28-8 116285 and 28-8116293. I
C - When ordering, specify color 'bark II' or black.
0 ,- Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916271.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
;,'
AIRPLANE PARTS CATALOG
h 1

".
Figure
and Part NQ. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number - r;,

74'-A 79221 DRAWING - AutoControl Ill and Ill B Installation

i

-
SERVO ASSEMBLY Roll (1'2363-1-430R) 1
-
' SET SCREW Capstan (35326) 1
CONSOLE AMPLIFIER ASSEMBLY AutoCantml Ill - 1
(1C338 S/N 1 thru 10000) 1 28-7415001 t h 28-7415713
~
-
CONSOLE AMPLIFIER ASSEMBLY AutoControl Ill B 1
(1C338 SIN 10001 and up) 1
KNOB - (36A98) 1
SWITCH - Engage (40A22-4) 2 28-7415001 t h 28-7415713
~
' BULB - Console (65328) 2 28-7415001 t h 28-7415713
~
-
CIRCUIT BOARD Face plate light (includes 4 bulbs) 1
(18686) 1
CABLE ASSEMBLY - Bridle (300200) 1
CLAMP ASSEMBLY - Bridle cable (42A173-1) 2
-
BRACKET Servo mounting (7C511-3) 1
-
HARNESS ASSEMBLY Amplifier (30C198) 1
COUPLER ASSEMBLY - Omni (25690-00) 1
KNOB - (36A98) 1
-
COVER Console amplifier 1
-
SPACER AutoControl console 2
ANGLE - AutoControl console support, left 1
-
ANGLE AutoControl console support, right 1
INSTRUMENT - Directional gyro (32168-00) (3 inch) 1
SWITCH - Omni coupler (MTG-206P) 1
CABLE ASSEMBLY - Roll servo extension (30C211 -156R) 1
PLACARD - Omni coupler switch 1
PLACARD - Omni coupler switch 1 28-7916272 and up
BRACKET - A/P filter mounting 1
FILTER - Roll signal (18440) 1 28-7415001 thru 28-7415713
FILTER - Roll signal (18440-2) 1
BLOCK - Rub (7A1373) 1
INSTRUMENT - Gyro horizon (32172-00) (3 inch) 1

When ordenng, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2C19
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
- ,- AIRPLANE PARTS CATALOG

Figure 75. Century 21 Autopilot Installation

(28-8116019 and up)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
."
AIRPLANE PARTS CATALOG

" - CODE EXPLANATIONS FOR FIGURE 75

.A -
'
This installation is relative only to associated Piper Aircraft Corporation parts that are used when installing Mitchell Century 21
Autopilot. All Mitchell equipment and components must be procured from an authorized Mitchell Service Center or from Edo-Aire
Mitchell, Post Office Box 610, Municipal Airport, Mineral Wells, Texas 76067. c

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
P,'.?,.

AIRPLANE PARTS CATALOG

Figure
and Part No. Serial Numbers
Index Number: Code , Nomenclature Req- Affected
Number

7% 39726 DRAWING - Centuty 21 Autopilot Installation

I

-
CIRCUIT BREAKER (PS50120-1-2) Mechanical Products
Inc, 5 amp 1
-
CIRCUIT BREAKER (PS50120-3-8) Wood Electric Co.,
5 amp 1
-
SWITCH (SF3GBX191) 1
-
PLACARD Nav 1 off Nav 2 1
BRACKET - Mounting (7C511-3) 1
-
SCREW (MS35206-250) 1
WASHER - (AN960-8) 1
NUT - (MS20365-832C) 1
-
BOLT (AN3-4A) 4
WASHER - (AN960-C10) 4
NUT - (MS20365-1032C) 4
-
SCREW (MS24693-S4) 6
-
CLAMP (PSl 0017-8-4) 1
-
CLAMP (PSI 0017-3-3-6F) &
SCREW - (MS35206-243) 1
-
NUT (MS20365-832C) 1
-
SCREW (MS35206-244) 1
-
NUT (AN936-88) 1
-
INSERT Autopilot 1

When ordering, always spec~fyPart Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2C22
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
- AIRPLANE PARTS CATALOG

\
'-\

\
\

\ I

F'
f

5
I
I
I

19

Figure 75A. King KAP 100f150 Autopilot Installation

(28-8316001and up)

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
- ? . AIRPLANE PARTS CATALOG

,CODE EXPLANATIONS FOR FIGURE 75A

A - This installat@ is relative only to associated Piper Ai,craft Corporation parts that are used when installing King KAP100/150 Autopilot.
All King equipment and components must be procured from King Radio Corporation, 400 N. Rogers Road, Olathe, Kansas 66061.
f

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
---

Figure
and Part - No. Serial Numbers
Index, Number. Code Nomenclature Req- Affected
Number

75A-! 39874 DRAWING - King KAP 100/150 Autopilot Installation

F

-
CIRCUIT BREAKER AutoPilot, 10 amp (PS50120-3-12) 1
-
CIRCUIT BREAKER Pitch trim, 5 amp (PS50120-3-6) 1
-
CIRCUIT BREAKER Compass system, 5 amp (PS50120-1-2) 1
-
STRIP Circuit breaker 1
-
STRIP Circuit breaker 1
-
STRIP Circuit breaker 1
PLACARD - Compass system 1
PLACARD - Nav 1INav 2 1
PLUG ASSEMBLY 1
-
ADAPTER (1~10-4-6) 2
ADAPTER - (1K10-2-4) 1
ELBOW - (1K31-4-6-4) 1
ELBOW - (1Kg-4-6) 1
UNION - (AN815-3D) 1
CROSS :(AN827-3D) * . 1
+ -
CLAMP (SAE TY E-7) 4
-
CLAMP (SAE TY F-6) 4
CLAMP - (SAE TY F-4) 4
CLAMP - (PS10017-23-4) 1
CLAMP - (NAS397-12) 2

When ordenng, always spec~fyPart Number, Descripbon, and Serial Number of Aircraft

Reissued: December 1, 1989

2D1
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
. c
AIRPLANE PARTS CATALOG

Figure 76. Piper Automatic Locator (ELT) Installation (Garnet Mfg. Ltd.)

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
,. .,.
AIRPLANE PARTS CATALOG

'.CODE EXPLANATIONS FOR.FIGURE76

B
C
..-
A -'' When ordenripspecify color red, bluelgreen, tan, black or avocado.

-
-
Used with Transmitter Assembly part number 761 939 (Model 627674-1).
-
Used with Transmitter Assembly part number 761 967 (Model 627810-1). f
D - No longer available Order ELT Replacement Kit 763 842v (Garrett ELT to Nara, ELT 10) as a replacement Refer to Sewice Letter
820.

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and ' Part No. Serial Nnmbers
Index Number Code Nomenclature Req. Affected
Number

-
DRAWING Piper Automatic Locator (ELT) Installation

-
TRANSMITTER ASSEMBLY Automatic locator (627674-1)
(includes magnesium battery pack)
-
TRANSMITTER ASSEMBLY Automatic locator (627810-1 )
(includes lithium battery pack)
-
BATTERY PACK Transmitter assembly (magnesium)
-
' BATTERY PACK Transmitter assembly (lithium)
ANTENNA ASSEMBLY Telexopic -
' CABLE AND BASE ASSEMBLY Whip, antenna -
-
ANTENNA ASSEMBLY Whip (less cable and base)
-
BRACKET Forward transmitter mounting
BRACKET ASSEMBLY - Aft transmitter mounting
(includes lock knob)
-
BRACKET ASSEMBLY Emergency locator transmitter
RING ASSEMBLY - Emergency locator transmitter
-
COVER ASSEMBLY Emergency locator transmitter ,
SWITCH AND COVER ASSEMBLY (ELT)
-
* PLACARD Warning (exposed switch)
PLACARD - Warning (recessed switch)
SWITCH - (SFILBX183-7)
SWITCH - (8ElOll)
PLACARD -Warning
-
COVER ELT switch
CONNECTOR (612129-3)-
-
SCREW (PS10015-88-12NA)
-
PLACARD E L I location

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2D4
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
AIRPLANE PARTS CATALOG

Figure 77. Piper Automatic Locator(ELT) Installation

(Communications Components Corp.)

Reissued: December 1. 1989

 PIPER AlRCRAFT
C
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

A - When orderipg, specify color red, bluelgreen, gold, green or bark Speafy color 'Bark I* when ordering for PA-28-151 with serial
numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716075. Specify cdor 'Bark II' or black for
' PA-28-161 with serial numbers 28-7716076 and up. f

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
',* .
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Eltrmbers
Index Number Code Nomenclature Reqd Affected
Number

-
DRAWING Piper Automatic Locator (ELT) Installation

-
TRANSMITTER ASSEMBLY Automatic locator (CIR-11-2) 1
(includes alkaline battery pack) 1
-
^ BATTERY PACK Transmitter assembly (alkaline) 1
ANTENNA ASSEMBLY - Portable (10-249) 1
-
ANTENNA ASSEMBLY Whip (10-234) 1
SWITCH AND HARNESS ASSEMBLY ELT 1
SWITCH - (8A205) 1
COVER - ELT switch 1
-
PLACARD Warning 1
-
BRACKET ASSEMBLY Emergency locator transmitter 1
RING ASSEMBLY - Emergency locator transmitter 1
-
COVER ASSEMBLY Emergency locator transmitter 1
SCREW - (P510015-88-12NA) 3
PLACARD - ELT location 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1. 1989

2D7
 PIPER AIRCRAFT
PA-28-151M 61 WARRIOR
I -
AIRPLANE PARTS CATALOG

Figure 78. Piper Automatic Locator (ELT 10) Installation (Narco Avionics)

Reissued: December 1, 1989

208
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
.*. .
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 78

A
B -- When ordering specify color ' h r k II' or black
Used on PA-28-161 with serial numbers 28-7716001 thm 28-8616057 and PA-28-161 with serial numbers 2816001 thm 2816093.
I

Reissued: December 1, 1989

 PIPER AIRCRAFT
..*. PA-28-1 511161 WARRIOR
* AIRPLANE PARTS CATALOG
Figure
-and - Part No. Serial Numbers
Index Number Code clature Req. Affected
Number

78- 36632 DRAWING - Piper Automatic Locator (ELT 10) Installation

I

-1 597 461 -
TRANSMITTER ASSEMBLY Automatic locator (ELT 10) I
(includes alkaline battery pack) 1
-2 758 452 -
* BATTERY PACK Transmitter assembly (57674-0001) 1
3 597 257 * ANTENNA ASSEMBLY ELT (01652-0101)- 1
-4 763 019 -
ANTENNA Blade, portable (57667-0001) 1
-5 758 453 BASE - Transmitter assembly (57666-0001) 1
-6 762 357 -
STRAP Transmitter assembly (57682-0101) 1
-7 99887-06 B -
BRACKET ASSEMBLY Emergency locator transmitter I
99887-07 -
BRACKET ASSEMBLY Emergency locator transmitter 1
-8 79463-00 A -
COVER ELT switch 1
-9 79599-00 SWITCH AND HARNESS ASSEMBLY ELT - 1
-10 588011 SWITCH - (8E1011) 1
-11 35669-132 PLACARD - Warning 1
-12 35669-105 -
PLACARD ELT location 1

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2D10
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
..-, AIRPLANE PARTS CATALOG

Figure 78A. Piper Automatic Locator (ELT 910) Installation

(Narco Avionics)

Added: July 30,1994

 PIPER AIRCRAFT
-.
L
PA-28-1 511161 >WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 78A

When ordering. always specify Part Number, Description, and Serial Number of Aircraft

Added: July r':, 1994

2D12
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-,
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code $ s Nomenclature i Rep Affected
Number

78A- 06292 DRAWING - Emergency Locator Transmitter Installation

(Narco E L I 910) I

-1 689 970 -
TRANSMITTER ASSEMBLY Emergency locator (ELT 910)
with battery pack and mounting tray (01475-0101) 1
-2 597 257 -
ANTENNA (01652-0101) 1
-3 99887-07 -
BRACKET ASSEMBLY Emergency locator transmitter 1
-4 35669-105 -
PLACARD ELT location 1
-5 688 404 -
SWITCH ASSEMBLY Remote (56988-0101) 1

When ordenng, always specify Part Number, Description, and Serial Number of Aircraft

Added: July 30,1994

2D13
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
t,
AIRPLANE PARTS CATALOG

Figure 79. Radar Altimeter Installation

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
,=. - AIRPLANE PARTS CATALOG

,GODE EXPLANATIONS FOR FIGURE 79

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
* '
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

79- 37693 -
DRAWING Radar Altimeter Installation ,,,
f

SUPPORT - Radar altimeter transmitter

HARNESS ASSEMBLY - Radar altimeter
-
LAMP ASSEMBLY (136-0020-00)
-
LAMP (PS10008-330)
-
SWITCH IPS10095-1)
CIRCUIT BREAKER- (i)ss0120-1-2)
MOULDING
PLACARD - Radar altimeter on-off
-
PLACARD Radar altimeter off for take-off
PLACARD - Radar altimeter

When ordering, always specify Part Number, Description. and Serial Number of Aircraft

Reissued: December 1, 1989

2D16
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

Figure 80.Encoder Installation (Narco-AR 500 and United-5125-P3)

Reissued: December 1, 1989

 PIPER AIRCRAFT -
PA-28-1 511161 WARRIOR
i
AIRPLANE PARTS CATALOG

. CODE EXPLANATIONS FOR FIGURE 80

A - Used on PA-28-151 with serial numbers 28-7715001 and up, $nd PA-28-161 with serial numbers28-n16001 and up.
-
8- Used if Alternate Static System is installed.
f
C :- Used if Alternate Static System is not installed.

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
'
AIRPLANE PARTS CATALOG
A%/

Figure
and Part No. Serial Mirmbers
Index Number Code Nomenclature Req- Affected
Number

80- 79658 - -
DRAWING Encoder Installation (Narco AR 500 and
-
United 5125-P3) f

-
ALTITUDE REPORTER Narco (PS50040-30-2)
ALTITUDE REPORTER -United (PS50040-30-4) 28-7916397 and up
TUBE ASSEMBLY Encoder -
CLAMP - (SAE TY F-4)
B -
HOSE Alternate static
-
HOSE Static
PLACARD - Altitude reporter installed
B -
CROSS (AN827-3D)
C -
TEE (AN824-3D)
UNION - (AN816-3D)

#
When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1. 1989

2D19
 PIPER AIRCRAFT
.!
"
a
PA-28-1 511161 WARRIOR
A

AIRPLANE PARTS CATALOG

Figure 81. P~perPM-1 Marker Beacon installation

(28-741 5001 thw 28-7415713)

Reissued: December 1, 1989

2D20
 PIPER AIRCRAFT
PA-28-1 51M 61 WARRIOR
.*- "
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR flGURE 81

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-151M 61 WARRIOR
"
"AIRPLANE PARTS CATALOG

No. Serial Numbers

Req. Affected
Number
81- 67454 -
DRAWING Piper PM-1 Marker Beacon Installation 1
f

-
RECElVER Marker beacon (1-950005)
-
PANEL ASSEMBLY Marker beacon lights
CONTROL PANEL - Marker beacon (1 -950019)
CIRCUIT BREAKER -White button (PS50120-1-2)
5 AMP
-
LIGHT ASSEMBLY Marker beacon (complete)
LIGHT ASSEMBLY - Blue (134-3830-0334-201)
-
LIGHT ASSEMBLY Amber (134-3830-0333-201)
-
LIGHT ASSEMBLY Clear (1 34-3830-0337-201)
-
BULB (PS10008-328)

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1,1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
42
., AIRPLANE PARTS CATALOG

Figure 82. Radio, Antenna System and Static Wicks Installation

Reissued: December 1. 7 989

2D23
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
'9
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS
'.2
FOR FlGURE 82

A - See Figure 83 for component parts.

B - With single VHF switch, ADF switch and marker beacon switches.
C, - With microphone switch, dual VHF switches and ADF switch. f
D, - With microphone switch, dual VHF switches, ADF switch and marker beacon switches.
E - Used if Bendii ADF-T-12C or ADF-T-120 receiver is installed.
F -
G - When ordering, specify color "Bark 11' or black.
H - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-n16001 t h 28-7716323.
~

Reissued: December 1. 1989

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
I
'I
I AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature % Rw. Affected
Number

82- 67440 DRAWING - Radio Systems lnstallation

79153 DRAWING - All Weather Antenna Installation I
99461 DRAWING - Radio Antenna Systems lnstallation
69667 DRAWING - Static Wick lnstallation
37869 DRAWING - Optional Phone Jack Installation
39737 DRAWING - Marker Beacon Antenna lnstallation 28-8116001 and up

HEADPHONE 1
HEADPHONE (With boom mike) - 1 28-7816001 and up
MICROPHONE - (Telex 60837-17) 1
MICROPHONE - (Telex 62800-001) 1
ANTENNAASSEMBLY Receiving - 1
ANTENNA ASSEMBLY Receiving - 1
ANTENNA ASSEMBLY - Omni-receiver (VRP-37) 1
ANTENNA ASSEMBLY - Transmitting (VTP-17) 2
-
ANTENNA Broadband. VHF Comm (PS50040-18-1)
(Communications Components) 2
-
ANTENNA Broadband, VHF Comm (PS50040-18-2)
(Dome & Margolin) 2
CABLE ASSEMBLY - Receiving 1
CABLE ASSEMBLY Transmitting - 1
CABLE ASSEMBLY - Receiving (90677-67) 1
CABLE ASSEMBLY - Transmitting 1
AUDIO SELECTOR ASSEMBLY 1
AUDIO SELECTOR ASSEMBLY 1
AUDIO SELECTOR ASSEMBLY 1
INSULATOR - Antenna (135-40) 1
STRIP ASSEMBLY -Terminal 1
STRIP ASSEMBLY - Terminal 1
-
HOLDER Microphone (64022-000) 1
SUPPORT - Microphone 1
JACK - Mike (S12B) 2
-
JACK Phone (11) 1
PLACARD Mike and phone - 1
PLACARD - Mike jack (with console mike jack) 1
-
COUPLER Dual Nav-Com (AVB-10) 1
-
'COUPLER Dual Nav-Com with glide slope (AV-571) 1 28-7816001 and up
COUPLER - Dual Nav-Cam with glide slope (C11125) 1 28-8116001 and up
COUPLER - Single Nav-Com with glide slope (AV-570) 1 28-7916355 and up
BUSHING - Snap (PS10064-500-6) 8
-
BUSHING Snap (PS10064-437-5) 8
GROMMET (MS35489-23) - 1
WICK - Static (SW 10-96) 9
-
SCREW (MS35206-230) 10
WASHER - (AN935-6L) 10
RIVNUT (S6K75) - 10
JUMPER ASSEMBLY Lightning protection -
(MS25083-3AA6) 7
MICROPHONE - (M700A) 1
MICROPHONE (M700B) - 1 28-7816001 and up
-
CLIP Microphone (9021136) 1
JACK - Phone (11) 3
-
PLATE Phone jack, right side 1
CUP - Phone jack 2

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1, 1989

2E1
 * PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
I" 'i r

AIRPLANE PARTS CATALOG

-
Fiaure
. and Part i l. No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

82-34 65269-02 DOUBLER Phone jack- 2

-35 67471-00 PLACARD - Phone iack 3 f
-
RELAY Boom mike (HE822C1210)
&

1 28-7816001 andup
-
SCREW (MS35206-231) 8
-
WASHER IAN935-6Ll R
-
RIVNUT ( ~ 6 ~ 7 5 ) .' "
-
ANTENNA ~ a r k ibeacon
r (PS50040-15-10) 1 28-8116001 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1. 1989

2E2
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
t"' AIRPLANE PARTS CATALOG

Figure 83. Audio Selector Assembly

Reissued: December 1, 1989

 PIPER AIRCRAFT
t
'PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG

GODE EXPLANATIONS FOR FIGURE 83 .P

A - With single VHF switch, ADF switch and marker beacon switches.
B - With microphone switch, dual VHF switches, and ADF switch.
C - With microphone switch, dual VHF switches. ADF switch and marker beacon switch. t

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number
-
8 99395-00 A AUDIO SELECTOR ASSEMBLY 1
99395-02 B AUDIO SELECTOR ASSEMBLY 1 t
99395-03 C AUDIO SELECTOR ASSEMBLY 1

-
SWITCH Microphone (JMT-223)
-
SWITCH VHF (JMT-221)
-
SWITCH ADF (JMT-221)
-
SWITCH Marker beacon, HiILo (JMT-221)
-
SWITCH Marker beacon, light test (JMT-126)
PLATE - Selector face
BUTTON - Plug (207-17021-00)
STRIP -Terminal (1076)
RECEPTACLE - (1055R48)
BULB - (PS10008-53)
FILTER - Lunar white (1813-26)
DIODE - (1N207-1)
-
RESISTOR (242E3RO5)

When ordering, always specify Part Number, Dexription, and Serial Number of Aircraft

Reissued: December 1,1989

2E5
 Figure 84. Avionics Cooling Installation

Revised: July 30, 1994

2E6
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
&
. t . AIRPLANE PARTS CATALOG
-, .
CODE EXPLANATlONS FOR FIGURE 84 -
A =_ Used on PA-28351 with serial nos. 28-7515002 and up, and PA-28-161 with serial nos. 28-7736001 and up.
B -
C .. Used with Bendii avionics cooling blower only.
Used with TRW avionics cooling blower only.
Hoses supplied by King Radio as part of KNS 80, KX 1551165. or KAP 150 kits.
f
D +-

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
XI. 4 AIRPLANE PARTS CATALOG

Figure
and - - Part No. Serial Numbers
-- . - - - - .-
Index , Number Code Nomenclature Req- Affected
Number

84- 67473 -
DRAWING Radio Coding Installation 28-74J5001 thru 28-7515001
79406 A DRAWING - Avionics Cooling Installation
39745 -
DRAWING Bendix Radio Cooling Blower Installation 28-8116001 thm 28-8216236
39857 DRAWING - Avionics Cooling Blower Installation 28-8516001 and up

79405-00 A BOX ASSEMBLY - Avionics'cooling

63633-136 A HOSE - Avionics cooling (60 long)
554 888 -
CLAMP (SAE TY F-6)
79487-00 REDUCER - Avionics cooling hose
63633-169 HOSE - Avionics cooling (4 long)
63633-186 A HOSE - Avionics cooling (73 long)
554 888 A -
CLAMP (SAE TY F-6)
454 921 CLAMP - (SAE TY F-10) 28-8116001 thm 28-8216236
554 892 -
CLAMP (SAE TY A-15/16) 28-8116001 t h 28-8216236
~
452 997 BLOWER - Avronics cooling, Bendi (3604529-0504) 28-8116001 t h 28-8216236
~
553 003 BLOWER - Avionics cooling, 14V (TRW 19A6009) 28-8316001 thw 2816109
460 105 BLOWER - Avionics cooling, 28V (TRW 19A2790) 2816110andup
63633-135 B -
HOSE Blower 28-8116001 thm 28-8216236
----- D HOSE - Blower 28-8316001 and up
86652-05 B FUSE ASSEMBLY - Blower 28-8116001 t h 28-8216236
~
461 629 B ' FUSE - (311005) 28-8116001 t h r ~28-8216236
86652-08 C -
FUSE ASSEMBLY Blower 28-8316001 and up
461 629 C ' FUSE - (311005) 28-8316001 and up
39745-10 B BRACKET - Blower mount 28-8116001 t h 28-8216236
~

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

2E8
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR AVIONICS INSTALLATION DRAWINGS

A - Part of standad VFR Package on Warrior Ill.

B - Used on PA-28-151 with serial numbers 28-7615001 and up, and PA-28-161 with serial numbers28-7716001thru 28-7916617.
-
-
C Used on PA-28-15 1 with serial numbers 28-7515001 and up, and PA-28-161. F
D - Part of optional IFR Package on Warrior Ill.
E - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-7716323.
F Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-7816057.
G - Used on PA-28-151 with serial numbers 28-7715001 and up, and PA 28-161 with serial numbers 28-7716001 and up.
H - Used on PA 28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7816695.
J - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-7916617.
K - Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28 161 with serial numbers 28-7716001 thru 28-7916617.
L - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28 161 with serial numbers 28-7716001 thru 28-8016382.
M - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161with serial numbers28-7716001 thru 28-8116342.
N - Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161with serial numbers 28-7716001 thru 28-8316112.

Revised: July 30, 1994

 PIPER AIRCRAFT
. . PA-28-151/161 WARRIOR
'3
. AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Re$& Affected
Number

67452 -
DRAWING Radio Installation, Narco UD1-4 DME
67456 -
DRAWING Radio Installation, Narco ADF-31A
67457 DRAWING - Radio Installation, Bendix ADF-T-12
79000 H -
DRAWING Radio Installation, King KX-170BIKX-1758
67452 DRAWING - Radio Installation, King KX-1758, KN-73,
KN-77 and KN1-520 28-7415001 t h 28-741
~ 5713
-
DRAWING Radio Installation. Narco Mark 12 and 16 28-741 5001 t h r ~28-7415713
-
DRAWING Radio Installation, Narco MK12D 28-8516019 and up
-
DRAWING Radio Installation, King KX-170 28-7415001 thm 28-7415713
-
DRAWING Radio Installation, King KN6OC DME 28-7415001 thW 28-7515459.
B -
DRAWING Radio Installation, King KN61 DME
DRAWING - Radio Installation, Narco Com-Nav 10111 or 12
L DRAWING - Radio Installation, King KR-85
DRAWING - King KR-87 ADF Radio lnstallation
-
DRAWING Transponder Installation, King KT-76 or KT-78
-
DRAWING King KT-76An8A Transponder lnstallation 28-7816058 and up
-
DRAWING Transponder Installation, Narco AT6-AIAT5-A 28-7415001 t h 28-741
~ 5713
-
DRAWING Transponder Installation, I.F.D. Starlight 28-7415001 t h 28-7415713
~
DRAWING - Transponder Installation, I.F.D. Starline 300. 28-7415001 t h 27-7415713
~
.
ORAWING Transponder lnstallation, AT50iATSOAI
'

AT1 50
DRAWING - Receiver Installation, Narco UGRQ Glideslope
L DRAWING - King KMA-20 Audio and Marker Beawn
lnstallation
DRAWING - King KMA-24 Audio and Marker Beawn
System Installation
E -
DRAWING Radio Installation, Narco CP258/125 and
MBT-1 2-R
DRAWING - Radio Installation, Narco CP-135/135M
E -
DRAWING Radio Installation, Narco Com-Nav 10/11 or 12
and Glideslope
DRAWING - Com 120/111, Nav 122/122A, 124A, Glide
Slope UGR-2A and Marker Beacon Radio lnstallation
C -
DRAWING Radio Installation, King KR-86
J -
DRAWING Radio Installation, King KN-65165A DME
-
DRAWING Radio Installation, King KN62/62A DME 28-8016001 and up
A -
DRAWING Radio Installation. King KN-74 Area Nav 28-7515001 t h r ~28-751 5459
A DRAWING - RNAVAnnunciatorPanel AssemMy 28-7515001 UIN 27-7515459
N -
DRAWING Radio Installation, Narco Single ADF-140/141
- .
,
-
DRAWINQ Radio Installation, Narco ADF-841
;tr
28-8416001 and up
L DRAWING - Radio Installation, Narco DME-1901190TSO
C DRAWING - Radio Installation, Narco Dual ADF-1401141
C -
DRAWING Radio Installation, King Dual KR-85 and KR-86
H -
DRAWING King KX 175B/B(E), KN-73, KN-77 and
KN 1-520 Radio lnstallation
DRAWING - Single ADFIHF Compatibility lnstallation
DRAWING - Narco DME-195 Radio lnstallation 28-7816001 t h 28-8216277
~
DRAWING - Narco DME-890 Radio lnstallation 28-8216218 and up
G DRAWING - Collins Com/NavlGS Radio Installation
G DRAWING - Collins TDR-950 Transponder Installation
G DRAWING - Collins RCRdSOA ADF Radio Installation
K -
DRAWING Narco DME-195 Radio Installation
-
DRAWING King KX-1708, KN-75, K1-209 Radio Installation 28-7916001 t h r ~28-8116342
M -
DRAWING Collins DCE 400 Distance Computing Equipment
-
DRAWING Collins DME-451 Radio lnstallation 28-8016001 and up
-
DRAWING King KY197/KY-196E and KN53 Dual-Corn/
Dual-Nav 28-8116001 and Up
-
DRAWING Bendix CN2013,lND2014, AS2015
S~ngleCorn-Nav 28-81 16001 t h 28-8216236
~

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Reissued: December 1.1989

2E10
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

39750 DRAWING - Bendix CN20llA, NSD360A, IN2014, AD2019A,

IU2016 Dual Corn-Nav 28-81X001 to 28-8216236
39739 -
DRAWING Bendix TPR2060 Transponder Installation 28-8 11600 1 to 28-82 16236
39749 -
DRAWING Bendix DME2030 28-8 11600 1 to 28-8216236
39746 -
DRAWING Bendix ADF2070 28-81 16001 to 28-8216236
79659 G -
DRAWING Collins AMR-350 System Installation
39833 DRAWING - King KX155, K1203/204/208/209 Single/Dual
Nav-Corn Installation 28-8216001 and up
39834 -
DRAWING King KX1551165, KN72, K12021203/208 Dual
Nav-Corn Installation 28-8216001 and up
39868 DRAWING - Narco 810/824/825 Single/Dual
Corn-NavAnd Installation 28-8216218 and up
39866 -
DRAWING Audio System Installation 28-8216218 and up
36979 DRAWING - King KNS-80, KY197, K1206 Area
Nav lnstallatron 28-8316001 and up
39857-09 A DRAWING - Avronics Cooling Blower Installation 2816110 and up
79036-00 A -
DRAWING Single Telex Mic and Holder (Center Console) 2816110 and up
79658-04 A DRAWING - Altitude Reporter (For Narco AR-850) 2816110 and up
85398-02 A - 3 DRAWING - Avronics Locator , 2816110 and up
85398-03 D DRAWING - Avionlcs Locator 2816110 and up
79814-27 A DRAWING - KT-76A Transponder with Narco AR-850 Provisions 2816110 and up
79814-26 D DRAWING - KT-71 Transponder with Narco AR-850 and GPS
Provis~ons 2816110 and up
39833-35 A DRAWING - Single NavICom 2816110
36656-13 ' WIRING 2816110
39833-39 A DRAWING - Single NavICorn 2816111 and up
83399-03 ' WIRING 2816111 and up
39833-36 D -
DRAWING Dual NavICorn 2816110
39833-40 D -
DRAWING Dual NavICom 2816111 and up
85392-03 A DRAWING - Procom 4 Intercom System 2816110
8539 1-02 ' WIRING 2816110
85392-04 A DRAWING - Procorn 4 Intercom System 2816111 and up
85176-02 ' WIRING 2816111 and up
I,
*
85392-02 D -
DRAWING Procom 4 Intercom System 2816110
85391-02 ' WIRING 2816110
39737-04 D DRAWING - Marker Beacon Antenna Installation 2816110 and up
99461-11 . A ' DRAWING - Single VHF Corn Broad Band Antenna 2816110andup
99461-13 D -
DRAWING Dual VHF Corn Broad Band - x 2816110andup
99461-14 D -
DRAWING Dual VHF Broad BandlNav Antenna 2816110 and up
99461-15 D -
DRAWING Dual VHF Broad BandlNav with GS Provisions
Antenna 2816110 and up
99461-21 D -
DRAWING Single Broad BandNav with GS Provisions
Antenna 2816110 and up
99461-25 D -
DRAWING Dual-VHF Broad BandNav Antenna with Dual GS
Provrstons 2816110andup
39770-07 D -
DRAWING KMA -24 Audio and Marker 2816110
39764-16 ' WIRING 2816110
39770-09 D DRAWING - KMA -24 Audio and Marker 2816111 and up
83398-02 ' WIRING 2816111 and up
39767 DRAWING - Single ADF 2816110andup
36968 DRAWING - DME for use with KX-155. -165 2816110 and up
83380-02 D DRAWING - KLN-9OA GPS RNAV 2816110and up
83379-02 WIRING 2816110 and up
83379-03 ' WIRING 2816110 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
AIRPLANE PARTS CATALOG

THIS PAGE INTENTIONALLY LEFT BLANK

Reissued: December 1, 1989

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

DENOTES INTERNAL
F
I DENOTES EXTERNAL

42

Figure 85. Placards and Exterior Stencils

(Sheet 1 of 2)

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
, $. c
AIRPLANE PARTS CATALOG

Serial numbers 2816110 and up

Figure 85. Placards and Exterior Stencils

(Sheet 2 of 2)

Added: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR FIGURE 85

A - Used on PA-28-151 with serial numbers 28-7515001 and up, and PA-28-161.
B "r'- Used on PA-28-161 with serial numbers 2816012 and up. British CAA requirement only.
-
C
D - Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-n16001 p d up.
Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161.
E 5 Used on PA-28-151 with serial numbers 28-7515255 and up, and PA-28-161.
F 'r Used on PA-28-151 with serial numbers 28-7615002 and up, and PA-28-161.
G - Used on PA-28-151 with serial numbers 28-7715001 thru 28-7715314, and PA-28-161 with serial numbers 28-7716001 thru
28-7716323.
H - Used on PA-28-161 with serial numbers 28-7816001 and up if air conditioning is installed.
J - Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.
K - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7716323.
L - Used on PA-28-161 with serial numbers 28-7816608 and up.
M - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916204.
N - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with setial numbers 28-7716001 thru 28-7916617.
P - Used on PA-28-151 with serial numbers 28-7715001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916617.
Q - Used if Cabin Overhead Air Vent System with blower is installed
R - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7816171.
Order part for PA-28-161 with serial numbers 28-7816172 and up if the four position fan switch has been replaced with a three position
fan swtch.
S - Used if air conditioning i~~installed. s
T ,- Order part for PA-28-161 With send numbers 28-7816172 and up if the four position fan sovitch has been replaced with a three
position fan switch.
U '- Used on PA-28-151 with send numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-7916271.
V . Used if Autocontrol Ill or lllB is installed.
X - Used if Century 21 Autopilot is installed.
Y - Used if Garrett Piper Automatic Locator is installed with Transmitter Assembly part number 761 939 (Model 627674-1).
Z - Used if Garrett Piper Automatic Locator is installed with Transmitter Assembly part number 761 967 (Model 627810-1).
AAt- Used if Communications Component Piper Automatic Locator (ELT) is installed
AD* Used if Narco Piper Automatic Locator IS installed.
AC- Used on PA-28-151 with senal numbers 28-7515001 and up and PA-28-161 with serial numbers28-7716001thru 28-8116342.
AD- Used if a push on-off trim switch is installed.
AE- Used if a toggle pitch trim swltch is installed.
AF - Used if recognition lights are ~nstalled.
AG- Used on PA-28-151~1th senal numbers 28-7415003.28-7415422 thru 28-7415713.
AH- These placards are supplied as part of Standby Vacuum System Kit, Piper code 566 528.
4,

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1510 61 WARRIOR
AIRPLANE PARTS CATALOG
Figure
".
and Part No. Serial Numbers
Index Number Code Nomenclature Req- Affected
Number

N -
DRAWING Placard Details Installation
-
DRAWING Placard Details Installation 28-8d6001 and up
-
DRAWING Exterior Finish 28-7415001 t h 28-741
~ 5713
DRAWING - Exterior Finish 28-7515001 thru 28-75 15459
-
DRAWING Exterior Finish 28-7615001 t h 28-761
~ 5445
G -
DRAWING Exterior Finish
-
DRAWING Exterior Finish 28-7816001 t h 28-7816695
~
DRAWING - Exterior Finish 28-7916001 t h 28-7916617
~
-
DRAWING Exterior Finish 28-8016001 thN 28-8016382
-
DRAWING Exterior Finish 28-8116001 t h r ~
28-8116342
-
DRAWING Exterior Finish 28-8216001 t h 28-821
~ 6236
-
DRAWING Exterior Finish 28-8316001 and up

N PLACARD - Oil cooler winterization

B PLACARD - Maneuvering speed, mph
B PLACARD - Maneuvering speed, knots
P PLACARD - Maneuvering speed, knots
C -
PLACARD Maneuvering speed, knots 28-8016001 t h 28-821
~ 6236
C PLACARD - krlaneuvenng speed, knots 28-8316001 and up
B PLACARD - Landing checklist, mph 28-7415001 thru 28-7615001
B -
PLACARD Landing checklist, knots 28-7415001 t h 28-7615001
~
PLACARD - Landing checklist, mph 28-7615002 t h 28-761
~ 5445
PLACARD - Landing checklist, knots 28-7615002 t h r ~28-7615445
J PLACARD - Landing checklist, knots
PLACARD - Landing checklist, knots
K -
PLACARD Takeoff checklist
PLACARD - Takeoff checklist 28-7816001 and up
-
PLACARD Heater and defrost
PLACARD - Heater and defrost (lift to actuate)
Q,R PLACARD - Vent fan
Q -
PLACARD Vent fan 28-7816172 and up
PLACARD - Carburetor heat
-
PLACARD Altemate static source
-
PLACARD Alternate static source 2816110 and up
-
PLACARD Crosswind component, mph
-
PLACARD Crosswind component, knots
A,D -
PLACARD Pitch trim
A,E -
PLACARD Pitch trim
-
PLACARD Baggage compartment
C -
PLACARD Baggage compartment
-
PLACARD Door lock, white
-
PLACARD Ruddertrim
-
PLACARD Seat back release, left
-
PLACARD Seat track release, right
-
PLACARD Nose gear oleo service instruction
PLACARD - Main gear oleo service instmction
PLACARD - Dome light
-
PLACARD ASSEMBLY Altemate static correlation
PLACARD - Circuit breaker panel
-
PLACARD Circuit breaker panel
PLACARD - Circu~tbreaker panel
PLACARD - External power supply
D PLACARD - External power supply
PLACARD - AutoFlite II
-
PLACARD Panel lights
-
PLACARD Nav and radio lights
U,V PLACARD - Omni coupler switch
V PLACARD - Omn~coupler switch

When ordering, always spec~fyPart Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 t

PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
T AIRPLANE PARTS CATALOG

Figure
and . Part , No. Serial Numbers
Index Number, Code Nomenclature Req. Affected
Number
'. .
85-26 6747 1-00 -
PLACARD Mike and phone 1
-27 66837-00 PLACARD - Mike jack (with console mike jack) 1
-28 69668115 -
PLACARD Pitot drain 1
-29 69669-32 -
PLACARD Operation limitations, mph 1
69669-76 -
PLACARD Operation limitations, knots 1
69669-143 P -
PLACARD Operation limitations, knots 1
35669-134 -
PLACARD Operation limitations, knots 1 28-8016001 and up
-30 450 741 DECAL - Lift detector (C52207-3) 1
-31 79275-00 -
MEDALLION Control wheel 1
-32 35526-00 -
NAMEPLATE Cherokee Warrior (white) 2 28-7415001 t h 28-7415713
~
35526-02 NAMEPLATE - Cherokee Warrior (black) 2 28-7515001 t h 28-751
~ 5459
79598-00 -
NAMEPLATE Cherokee Warrior (white) 2 28-7615001 and up
35682-02 -
NAMEPLATE Cherokee Warrior II 2 28-7716001 t h 28-771
~ 6323
37977-02 -
NAMEPLATE Cherokee Wamor 11 2 28-7816001 t h 28-781
~ 6695
-33 48629-00 A,C MEDALLION - Piper logo 1
.-34 69669-64 PLACARD - Fuel 2
69669-180 PLACARD Fuel- 2
35669-163 PLACARD - Fuel 2
-35 69669-39 -
A : , . PLACARD Press to test 'I, 1
-36 69669-15 Y -
PLACARD Warning (exposed switch) 1
69669-66 Y,A -
PLACARD Warning (recessed switch) 1
69669-107 Z PLACARD - Warning 1
35669-132 A.B PLACARD -Warning 1
-37 69669-77 E PLACARD - Cabin air 1
-38 66787-00 PLACARD - Cab~nbulkhead 1
-39 67786-00 PLACARD - Stab~latortrim 1
84967-173 DECAL - Stab~latortrim (Meyercord) 1
-40 69669-118 F PLACARD - Latch 1
-41 69669-117 F PLACARD - Open 1
-42 79688-00 G DECAL - Piper 2
-43 35664-02 PLACARD - Flap warning 1
-44 35669-04 PLACARD - Turn limit 1
-45 35669-05 PLACARD -Turn limit center mark 1
-46 67471-00 PLACARD - Phone jack 2
-47 35669-14 PLACARD - Fuel gauge warning 1 28-7415001 t h 28-771
~ 5200
-48 37974-02 NAMEPLATE - Piper 2 28-7816001 t h 28-781
~ 6695
78747-02 -
NAMEPLATE Piper Warrior II 2 28-7916001 and up
-49 79315-00 H " .
PLACARD - Piper Aire 1
-50 99921-00 H -
PLACARD Air condition door light 1
-51 35669-27 -
PLACARD Flap lever 1 28-7716001 and up
*52 35669-105 -
PLACARD ELT location 1
-53 35668107 L -
PLACARD Strobe light outlets 1
-54 96602-00 M PLACARD -Warning 1
69669-175 PLACARD -Warning 1 28-7916205 t h 28-7916617
~
-55 35669-125 PLACARD - Radio power ON-OFF 1 28-8016001 and up
-56 35669-130 -
PLACARD Emergency bus switch 1 28-8016001 and up
-57 35669-154 C PLACARD - Albtude reporter installed 1
-58 87369-27 -
PLACARD Caution 1 28-8016076 and up
-59 35669- 194 PLACARD - Seat reinstallation instructions 1
-60 65846-00 PLACARD - Engine controls 1
-61 8734 1-02 -
PLACARD Do not push 2
-62 87341-03 -
PLACARD Level point 2
-63 87341-04 PLACARD - No step 2
-64 87341-05 PLACARD - Max. baggage 1
-65 87334-02 PLACARD - Door release 1
-66 87338-02 PLACARD - Oil spec. 1
-67 35669-188 PLACARD - Transponder identifier 1 28-8116001 and up
-68 35669-44 PLACARD - Tre pressure 2

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

 PIPER AIRCRAFT
9; . PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

85-69 35669-23 PLACARD Gear - 2

-70 79112-00 S,T -
PLACARD Air condition control panel 1 28-78f6001 thw 28-7816171
79112-02 S -
PLACARD Air condition control panel 1 28-7816172 and up
-71 35669-188 -
PLACARD Transponder ident 1 28-8116001 and up
-72 87369-05 X PLACARD - Nav 1 off Nav 2 1 28-8116019 and up
-73 69669-97 PLACARD - Radar altimeter on-off 1
-74 69669-95 -
PLACARD Radar altimeter off for take-off 1
-75 69669-96 -
PLACARD Radar altimeter 1
-76 87369-39 A,E PLACARD - On-off 1
-77 456 682 -
DECAL Avgas only (000002) 2
-78 87369-53 A,F PLACARD - Landing and recognition lights 1 28-8516001 and up
-79 35669-16 -
PLACARD AIP INTR. 1 28-7816001 and up
-80 35669-17 PLACARD Mike - 1 28-7816001 and up
-81 69668-00 A,G -
PLACARD Alternator warning 1
-82 35669-110 PLACARD - Compass system 1 28-8316001 and up
-83 87369-40 PLACARD - Nav tlNav 2 1 28-8316001 and up
-84 87369-56 PLACARD - DME Nav 1/Nav 2 1 28-8516001 and up
-85 87369-55 , PLACARD - DME Audia odoff . . 1 28-8516001 and up
-86 87369-70 8 PLACARD - Starter engaged 1
-87 84967- 170 PLACARD - Atrspeed and crosswind 1 2816110 andup
-88 19099-00 -
PLATE Aircrai: registration number 1
-89 84967-130 PLACARD - Nic;nt - Day 1 2816110andup
-90 84967-133 -
PLACARD Press to test 1 2816110andup
-91 84967-145 PLACARD - Amp Altr 1 2816110 and up
-92 84967- 172 PLACARD - Circuit breaker 1 2816110and up
-93 84967-171 PLACARD - Cirur~tbreaker 1 2816110andup
-94 84967-168 PLACARD - Carburetor heat 1 2816110 and up
-95 84967-101 PLACARD Dimming - 1 2816110 and up
-96 84967-132 PLACARD Mike - 2 2816110 and up
-97 84967-131 PLACARD Phone - 2 2816110 and up
-98 AH -
PLACARD Aux vac (84-192-1) 1
AH PLACARD - Caution - Before using aux pump (84-203-1) 1
-99 84967-139 PLACARD - Heat Def - 1 2816110andup
400 85437-02 -
STENCIL Paint. 'flarrior 111 (687 686) 2 2816110 and up

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

2E18
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-. AIRPLANE PARTS CATALOG

CODE EXPLANATIONS FOR OPTIONAL EQUIPMENT KITS AND REPAIR KITS

A - Less Extemalprower Connector Plug Assembly, PIN 62355-02.

B r'" Used on PA-28-151 only. *

C - Used on PA-28-151 with serial numbers 28-7515001 t h 28-7715314,

~ and PA-28-161 with serial numbers 2817716001 thw
28-8216236.
D ':' Used on PA-28-161 only.
E - Used on PA-28-151 with serial numbers 28-7415001 and up, and PA-28-161 with serial numbers 28-7716001 thru 28-8016125.
F - Used to meet LBA (Germany) gross weight and noise reduction requirements.
G - Used on PA-28-161 28 volt system.
H - See Piper Sewice Bulletin 9168, or latest revision.

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
Ty *
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code Nomenclature Req. Affected
Number

OPTIONAL EQUIPMENT KITS AND REPAIR KITS

f

-
RECEPTACLE INSTALLATION Auxiliary power 28-7716001 and up
28-8316001 t h 28-8616016
~
-
CARD Passenger briefing
PLOTTER ASSEMBLY - Weight and balance 28-7716001 t h 28-8216236
~ * .
-
PLOTTER ASSEMBLY Weight and balance 28-8316001 t h 28-8616016
~
KING KAP100 AutoPilot Kit 8316001 and up
PLOTTER ASSEMBLY -Weight and balance
-
KIT ASSEMBLY EGT Indicator
-
VACUUM SYSTEM Standby, Electrically driven (374-10)
VACUUM SYSTEM - Standby, Electrically driven (374-10)
PIPER MIXTURE CONTROL INSTALLATION(E.G.T.)
ALTERNATE STATIC SYSTEM INSTALLATION
PlTOT COVER
CYLINDER HEAD TEMPERATURE GAUGE INSTALLATION
AILERON CENTERING INSTALLATION MODIFICATION;,
LANDING LIGHT INSTALLATIONMODIFICATION '

B BOTTOM COWL SUPPORT MODIFICATION

B ADF ANTENNA MODIFICATION
B OVERHEAD VENT SYSTEM VALVE INSTALLATION .
NOSE GEAR STEERING MODIFICATION
ELECTRIC PITCH TRIM
AUTOFLITE I1 (WITH AUTONAV TRACKER)
AUTOFLITE I1 (WITHOUT AUTONAV TRACKER)
HEATED PITOT SYSTEM INSTALLATION
AUTOCONTROL Ill B (WITH RADIO COUPLER)
AUTOCONTROL Ill 6 (WITHOUT RADIO COUPLER)
AUTOCONTROL Ill B (WITH RADIO COUPLER)
AUTOCONTROL Ill B (WITHOUT RADIO COUPLER)
RADIO COOLING INSTALLATION KIT
PIPER ELECTRIC TRlM SWITCH REPLACEMENT
AUXILIARY POWER RECEPTACLE INSTALLATION
VENT FAN SWITCH REPLACEMENT

D AIR CONDITION FAN SWITCH REPLACEMENT

ENGINE BREATHER TUBE WINTERIZATION KIT
ELT REPLACEMENT (Garrett or Communications Components
Corp. ELT to N a m ELT 10)
E IMPROVED CABIN HEAT CENTER DUCT
D FUEL TANK VENT MODIFICATION AND VENT HOSE
REPLACEMENT
D MAIN LANDING GEAR WHEEL AND STRUT FAIRING
REPLACEMENT (LEFT WHEEL ONLY)
D MAIN LANDING GEAR WHEEL AND STRUT FAIRING
REPLACEMENT (RIGHT WHEEL ONLY)
DOOR JAMB SNUBBER INSTALLATION
AFT SHOULDER HARNESS KIT 28-7415001 t h 28-7415314
~
28-7716001 and up
D INTAKE DUCT MODIFICATION 28-8016001 t h 28-8016168
~
D CARBURETOR ICE DETECTOR INSTALLATION

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and Part No. Serial Numbers
Index Number Code 4- Nomenclature Req. Affected
Number
OPTIONAL EQUIPMENT KlTS AND REPAIR KlTS (continued)
I
764 962 D EXTERNAL POWER SUPPLY RELOCATION 28-771 6001 t h 28-821
~ 6236
764 975 D NOSE GEAR STEERING MOOlFlCATlON 28-7716001 t h 28-8416095
~
764 981 INERTIA SAFETY SHOULDER BELT INSTALLATION 28-7415001 t h 28-7715314
~
765 122 AVIONICS COOLING BLOWER REPACEMENT
765 193 F MAXIMUM GROSS WEIGHT MODIFICATION(#2325) 28-8316001 and up
765 399 H -
STALL STRIP INSTALLATION (88164) 28-8016363 t h 28-8616057
~
and 2816001 thru 2816096

When ordering, always specify Part Number, Description, and Serial Number of Aircraft

Revised: July 30. 1994

2E21
 PIPER AIRCRAFT
?-
PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
.< "
CODE EXPLANATIONS FOR MlS$ELMEOUS
a
HARDWAREAND CONSUMABLES
3

A - commbn hardware to Piper part number cross reference available on Aerofiche. Contact your local Piper distributor for more
information.
B - Used on wing installation. Some items are also used in other places on aircraft. r
C - Location and quantity of items is found on applicable installation drawings.

Added: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-" 1
AIRPLANE PARTS CATALOG
Figure
and . Part No. Serial Numbers
Index Number Code Nomenclature ' Req. Affected
Number h

..
MISCELLANEOUS HARDWARE AND CONSUMABLES
i
...-
1766 005 A -
AEROFICHE Common hardware part number cross reference

ADHESIVE HYSOL 9309,l quart kit-

ADHESIVE HYSOL 9309,50 gram kit-
-
RIVET Cherry max, 4-2
RIVET - Cherry max, 4-3
RIVET - MS20470AD6-9
RIVET - MS20470AD5-7
-
RIVET MS20470AD5-8
RIVET - MS20470AD5-9
RIVET - HL18-6-6
RIVET - HL18-6-5
RIVET - HL18-6-4
RIVET - CR2245-4-3
RIVET - CR2245-4-4
RIVET - CR2245-4-5
RIVET - CR2245-4-6
RIVET - CR3245-4-2
RIVET - CR2249-4-2
RIVET - NAS1769D4-2
RIVET - NAS1769D4-3
RIVET - HL18-10-10
RIVET - HL19-6-10
RIVET - HL19-6-11
COLLAR - HL826AW
-
COLLAR HL70-10
RIVET - MS2047OAD3-3
RIVET - MS20470AD3-3.5
-
RIVET MS20470AD4-5
RIVET - CR3245-4-1
-
RIVET CR3245-4-2
RIVET - CR3245-4-3

ADHESIVE - RTV-157
ADHESIVE - RTV-133
ADHESIVE - Versalok 204, kit
ADHESIVE EC80l -
CEMENT A56B-
-
CEMENT EC1300L

CLEANER - M-0764

LUBRICANT OCR 404 -

SEALANT - PR142202
SEALANT - RTV-108
SEALANT 5674-7 -
SEALANT - PA14356
SEALANT - PR1403GB2
SEALANT - 1100FS, white

Added: July 30, 1994

 PIPER AIRCRAFT
2 PA-28-1511161 WARRIOR
AIRPLANE PARTS CATALOG
Figure
and, Part .I-I . No. Serial Numbers
Index Number Code Nom'enclature ' Req. Affected
Number

MISCELLANEOUS HARDWAREAND CONSUMABLES (continued) F

189 721 C -
TAPE Window, foam, gray, 1 inch wide, roll AR
189 750 C TAPE - Windshield, black vinyl. 1 12
1' inch wide, roll AR
289 791 C -
TAPE Storm window seal, 3/16 inch wide, roll AR

924 529 C WAX - Gary's cream, gallon

**,
Added: July 30,1994
 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
AIRPLANE PARTS CATALOG

NUMERIC
r
- Part Figure and Part Figure and I Part Part
Number Index No. Number Index No. Number Number
02385-04 39-60 23969-02 68A-11 35118-00 35164-04
02585-05 39-60 23969-02 72-15 35164-04
02585-06 39-60 23969-03 41B-22 35165-00
12761-02 14-4 23969-03 65-52 35165-01
12761-02 64-56 23969-05 67-10 35166-00
13071-00 22-39 23969-05 67-28 35 166-01
13074-02 23-26 23969-05 68-11 35167-02
14428-00 49-4 23969-05 68A-12 35167-03
14470-00 49- 13 24028-00 48-5 35 168-00
14627~03 15-12 26749-07 41-2 35168-01
14635-02 15-14 26898-03 64-8 35 168-02
14843-90 15-23 26898-05 68B-13 35 168-03
15086-00 35-53 31197-00 49-27 35168-04
15206-02 23-13 32380-00 38-20 35168-05
17555-00 67-26 32380-00 39-38 35 168-08
17766-06 49- 14 35113-04 2-1 35168-09
18078-00 49-55 35 114-00 2-12 35168-12
18219-02 48-27 35 114-00 5-1 35168-13
18321-00 49-28 35114-01 2-12 35169-00
18321-00 64-48 35114-01 5-1 35169-01
18457-00 2-5 35114-02 5-18 35 170-00
18622-00 46- 1 35 114-03 5-18 35 170-01
18968-00 38-11 35114-04 5-19 35171-00
19063-02 14-2 35114-05 2-1 35171-01
19063-02 15-47 35114-05 5-19 35172-00
1$~99-00 85-99 35114-06 5-20 35172-01
19336-00 38-17 35 114-07 5-20 35173-00
19336-00 39-46 35 114-08 5-21 35173-01
19336-01 38-17 35 114-09 5-21 35174-00
19336-01 39-46 35115-00 2-14 35174-01
19365-02 38-19 35115-01 2-14 35174-04
19365-02 39-48 35115-06 2-14a 35174-05
19392-15 38-18 35115-07 2-14a 35176-00
19807-00 64-24 35115-08 2-14b 35176-01
21176-00 15-52 35115-09 2-14b 35176-04
21230-00 49-56 35115-10 2-14 35 176-05
21843-00 15-25 35115-11 2-14 35182-00
21844-00 15-26 35 117-00 2-4 35182-01
22 105-02 49-32 35 117-00 4- 1 35192-00
22105-03 59-27 35117-01 2-4 35193-00
22482-00 13-45 35 117-01 4- I 35 193-03
23969-02 41B-21 35117-04 4-17 35193-03
23969-02 64-43 35 117-05 4-17 35199-00
23969-02 65-51 35 117-06 4-18 35 199-08
23969-02 67-9 35117-07 4-18 35201-00
23969-02 68-9 35 118-00 2-3 35202-00

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
,.
-'r r
c AIRPLANE PARTS CATALOG

' INDEX
NUMERICAL

1 B1E3
Part Part Figure and Part Figure and
Number Number Index No. Number Index No. pat
Num er
35207-00 44-2 35385-01 5-15 35421-04
35208-00 44-5 35386-00 5-22 35421-05
35208-02 44-5 35386-01 5-22 35422-00
35208-03 35303-02 44-7 35387-00 5-23 35422-04
35208-04 35307-00 59-5 35387-01 5-23 35425-00
35208-04 35307-11 59-5 35388-00 5-16 35426-00
I
35208-09 35321-00 52-6 35388-01 5-16 35426-01
35208-10 35322-04 2-11 35389-00 5-24 35426-02
35208-10 35322-04 52-1 35389-01 5-24 35426-03
35209-00 35322-05 2-11 35390-00 5-2 35427-00
35212-00 35322-05 52-1 35390-01 5-2 35427-01
35214-00 35323-05 43-2 35390-02 5-3 35428-00
35214-800 35323-05 43-4 35390-03 4" 35429-00
35220-00 35323-09 43-3 35392-00 5- 17 35431-00
35220-01 35323-12 43-3 35392-01 5-17 35431-01
35226-00 35323-13 33-2 35393-00 5-8 35432-00
35226-01 35328-800 49-2 35393-01 5-8 35433-00
35238-00 35328-803 49-2 35394-00 5-9 35435-00
35238-01 35335-00 59-6 35394-01 5-9 35435-01
35240-00 35335-03 59-6 35395-00 5-26 35448-00
35240-01 35341-00 45-1 35395-01 5-26 35449-00
35241-00 35341-02 45-1 35399-00 45-7 35453-00
35241-01 35342-00 45-2 35399-08 45-7 35454-00
35249-00 35342-04 45-2 35402-00 54-21 35457-00
35249-01 35342-06 45-2 35402-04 54-57 35461-00
35262-02 35343-00 45-3 35412-00 45-8 35461-04
35270-00 35344-00 45-4 35415-00 47-12 35461-05
35273-00 35345-03 45-5 35415-05 47'4 6 35462-00
35281-00 35345-04 45-5 35415-06 47- 17 35463-00
35282-03 35346-00 45-6 35415-07 47- 18 35464-00
35282-04 35362-00 4-16 35415-08 47-12 35467-00
35283-00 35375-00 64-44 35415-09 47-16 35467-00
35284-03 35378-00 4-29 35415-10 47- 17 35468-00
35297-00 35378-01 4-29 35415-13 47- 12 35470-00
35298-07 35379-00 43-7 35415-14 47- 16 35470-01
35299-00 35380-00 5-10 35415-15 47- 17 35473-00
35299-00 35380-01 5-10 35416-00 4-28 35473-01
35299-01 35381-00 5-11 35416-01 4-28 35473-02
35299-01 35381-01 5-11 35418-00 4-12 35473-03
35299-04 35382-00 5-12 35418-01 4-12 35473-10
35299-05 35382-01 5-12 35419-00 4-13 35473-11
35299-06 35383-00 5-13 35419-01 4-13 35476-00
35299-06 35383-01 5- 35420-00 4-14 35476-01
35299-07 35384-00 5- 35420-04 4- 14 35477-00
35299-07 35384-01 5-14 35421-00 4-15 35481-00
35300-00 35385-00 5-15 35421-01 4-15 3548 1-01

Revised: July 30, 1994

2F2
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
+ ,-%. AIRPLANE PARTS CATALOG

NUMERICAL INDEX ,

' Part
Number
Figure and
Index No.
I Part
Number
I
I
Figure and
lndex No.
1i Part
Number I Figure and
Index No. Number
Figure and
Index No.
35386-00 35594-02 2-9 35631-04 44-9 35640-22
' 35632-02 4-10
35490-00
35490-02 35632-03 4-10
35495-00 35632-04 4-46
I
35495-03 35632-05 4-46
I
35495-05 35633-02 2-11
35495-07 35633-02 52-1
35496-00 35633-03 2-11
35496-03 35633-03 52-1
35496-06 35634-00 4-18
35496-09 35634-01 4-18
35496-10 35634-04 4-18
35497-00 35634-05 4-19
35498-00 35634-10 4-54
35505-00 35634-11 4-54
35512-00 35634-14 4-56
35515-06 35634-15 4-56
35526-00 35636-00 4-48
35526-02 35637-00 4-21
35527-00 35637-01 4-21
35528-00 35638-00 52-7a
35532-00 35638-01 52-7a
35538-00 35640-00 2-12
35553-00 35640-00 6- 1
35555-00 35640-01 2-12
3$$55-03 35640-01 6-1
35555-03 35640-02 6-2
35555-04 35640-03 6-2
35555-04 35640-04 6-$
35557-00 35640-05 6-3
35557-04 35640-06 6-4
35558-00 35640-07 6-4
35558-03 35640-08 6-5
35573-00 35640-09 6-5
35573-00 35640-10 6-6
35574-00 35640-11 6-6
35575-00 35640-12 6-7
35591-02 35640-13 6-7
35591-03 35640-14 6-8
35591-04 35640-15 6-8
35592-00 35640-16 6-9
35592-01 35640-17 6-9
35593-02 35640-18 6-10
35593-0; 35640-19 6- 10
35593-04 35640-20 6-11
35593-05 35640-21 6-12
/
Revised: July 30, 1994
 PIPER AIRCRAFT
i
PA-28-1511161 WARRIOR
'AIRPLANE PARTS CATALOG

NUMERICAL INDEX
I Part
umber
Part
Number
Figure and
lndex No.
Part
Number
Figure and
Index No.
Part
Number
Figure and
lndex No.
57-41 35935-02 79-2 39745-10 84-17
85-80 36505-02 57-39 39769-02 9-24
57-44 36505-03 39-26 39769-0.) 9-24
85-67 36511-02 82-33 39800-02 75-12
85-71 36511-03 82-31 39829-02 52-2a
37-14 36535-02 82-32 39830-02 52-2
85-59 36558-02 37-13 39830-800 52-2
30-22 36558-03 37- 13 39856-02 52-2~
85-69 36558-06 40-62 39872-09 Misc
54-56 36565-02 40-63 39875-02 9-31
85-51 36565-03 40-64 39876-02 9-44
85-52 36567-03 40-65 39877-02 40-27
40-34 36567-05 " jb>g 39899-03 64-55
40-35b 36568-02 30-9 30-38 41001-10 53-11
85-5 36568-03 30-10 30-29 42513-04 68B-1
40-3 1 36572-03 16-47 30-29 45621-01 4-26
85-3 36588-04 35-59 30-2 48629-00 85-33
40-35 36589-02 35-20 30-14 49077-00 57-16
85-6 36590-02 16-40 30-3 50111-00 54-15
30-13a 36598-02 16-35 30-15 52586-02 73- 1
85-68 36612-02 60-45 30-5 56490-02 85-10
40-67 36615-05 60-43 30-6 56958-28 49-61
40-68 36616-03 60-44 30-7 61414-01 13-14
40-7 1 36625-02 52-11 4-16a 61715-02 55-29
40-66 36625-03 52- 11 39-54 61879-02 43-16
85-32 ' 36660-02 40-20 39-58 62002-02 18-20
42-7 36706-02 18-15 ~'. 39-54 62002-03 18-21
42-13 ' 36722-04 "6-57 ' , 3$55 62002-04 18-22
47-21 36733-02 Misc 44-3 62021-00 3-2
47-19 36739-02 2-14 , 30-9 62021-01 3-2
47-20 36739-03 2- 14 30-10 62033-00 52-9
49-3 36739-04 2-14 85-48 62049-00 3-26
2-6 36739-05 2-14 85-32 62049-01 3-26
4-49 , 36739-18 2- 14 42-12 62060-00 52-10
4-53 36739-19 2- 14 60-3 62060-01 52-10
4-49 36739-28 2-14c 62-5 62060-04 52-10
4-53 36739-29 2- 14c 3-7 62060-04 52-10
49-8 36739-62 2-14 3-8 62061-02 3-12
2-57 36739-63 2-14 2-48 62061-04 4-19
30-1 36805-02 47-18a 40- 17 62066-00 3-3
68A-4 36806-02 2-14d 64-62 62071-00 4-4
Misc 36806-03 2-14d 9-46 62071-01 4-4
67-20 36850-08 43-2. 9-46 62072-00 4-5
9-42 36934-02 65-34 Misc 62072-01 4-5
9-43 36938-013 38-42 Misc 62073-02 4-3
9-41 37693-013 79- 1 83-22 62073-03 4-3
***.
Revised: july 30,1994
2F4
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-
v.,
AIRPLANE PARTS CATALOG

NUMERICAL- INDEX
Part Figure and Part Figure and Part Figure and Part Figure and
.Number Index No. Number Index No. Number Index No. ~um6er Index No.
62079-00 4-6 62328-01 7-9 62443-00 13-15 62536-04 11-38
62086-00 3-11 62330-00 7-11 62444-05 13-17 62536-05 11-38
62086-01 3-11 62330-01 7-11 62445-00 13-22 62537-00 12-3
62086-02 3-llb 62331-00 7-12 62448-02 12-15 62539-00 11-22
62086-03 3-llb 62331-01 7-12 62448-03 12-15 62540-00 11-23
62086-05 3-lla 62332-00 7-10 62451-00 13-23 62541-00 8-15
62086-06 3-lla 62332-02 7-10 62452-00 13-24 62541-01 8-15
62086-08 3-11 62336-00 7-17 62452-01 13-24 62542-00 11-48
62086-09 3-11 62336-01 7-17 62453-00 13-20 62542-01 11-48
62086-14 3-11 62343-00 85-21 62455-00 13-25 62543-00 11-4
62086-15 3-11 62355-02 68A-6 62457-00 13-26 62543-02 11-4
62087-00 3-16 62355-03 68A-7 62457-01 13-26 62544-00 11-9
62091-00 3-6 62355-11 68-5 62463-00 I?@ 62544-01 11-9
6209 1-02 3-6 62371-08 4-47 62464-00 13-54 62546-00 11-26
62095-00 2-7 62400-02 14-7 62465-00 13-55 62549-00 8-16
62105-00 4-13b 62410-00 10-26 6247 1-00 13-32 62550-00 11-39
62 105-02 4-13a 62410-01 10-26 62473-00 9- 17 62550-01 11-39
62109-00 2-49 62411-02 12-14 62473-02 9-17 62551-00 11-17
62109-00 11-49a 624 12-02 10-25 62477-00 10-29 62551-01 11-17
62121-00 2-55 624 13-00 13-13 62477-0 1 10-29 62554-00 11-5
62129-03 4-34 62413-01 13-13 62485-00 9- 18 62554-00 11-11
62129-04 4-34 62414-00 13-14 62485-01 9-18 62557-04 38-50
62129-07 4-35 62419-11 10-60 62492-00 10-38 62558-00 11-10
62129-08 4-35 62420-08 10-24 62493-00 10-39 62558-01 11-10
62330-03 3-4 62420-10 10-24 62494-02 10-10 62563-01 12-16
62730-04 3-4 62420-11 8-26 62495-02 10-11 62563-02 12-16
62179-00 47-8 62420-23 10-24 62499-02 9-20 62571-00 10-58
62180-00 47-9 + .* I 62420-24 10-24 62501-00 1Q;rff3 62581-00 11-43
62226-00 68- 1 62420-25 10-24 62505-00 10-32 62581-01 11-43
62226-00 68A- 1 62420-26 10-24 62507-00 8-28 62582-00 11-18
62227-00 68-2 62421-00 11-40 62509-02 10-31 62601-03 11-30
62227-00 68A-2 62421-01 1140 62509-03 10-31 62603-00 11-33
62230-00 44-3 62423-00 10-33 62509-04 10-31 62603-01 11-33
62232-00 44-4 62425-00 9-15 62511-02 10-9 62618-00 12-10
62268-00 11-12 62425-01 9-15 62518-14 10-17 62618-01 12-10
62268-02 11-12 62426-05 10-6 62518-15 10-17 62619-00 12-9
62279-00 67-4 62426-06 10-6 62518-17 10-16 62620-00 11-35
62305-00 50-12 62427-00 10-7 62522-00 2-23 62630-00 13-12
62305-00 51-4 62427-02 10-7 62525-00 11-16 62632-00 10-66
62320-00 7-13 62428-00 11-24 62525-01 11-16 62633-00 10-67
62324-00 7-5 62428-01 11-24 62528-00 11-7 62634-00 10-57
62324-01 - 7-5 62429-00 10-8 62528-01 11-7 62635-00 10-56
62327-00 7-7 62430-00 10-27 62529-00 12-9 62636-00 10-55
62328-00 7-8 62438-00 ,, 9-3 .k 62531-00 12-6 62637-00 . 10-54
62328-00 7-9 6244 1-00 11-15 62531-00 12-7 62639-00 10-49
62328-01 7-8 62441-01 11-15 62534-00 12-4 62639-01 1049
-
Revised: July 30. 1994
2F5
 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
-,
ULI AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part Figure and Part Figure and Part Figure and Par) Figure and
:Number Index No. Number Index No. Number Index No. Number Index No.
62644-00 10-53 62712-03 53-30 62833-104 59-41 63036-03 16-42
62645-04 13-37 62712-04 57-11 62833-105 16-27 63036-04 16-42
62653-06 9-21 62713-02 54-32 62833-107 16-34 63037-00 10-23
62654-00 38-36 62713-03 53-31 62833-107 16-46 63038-02 10-12
62656-00 10-42 62714-02 55-27 62833-127 56-4 63039-00 15-38
62660-07 12-3 62714-03 53-33 62833-144 56-4 63039-00 15-40
62660-08 12-4 62714-04 55-28 62833-17 58-11 63039-00 16-48
62660-09 12-6 62715-02 53-34 62833-18 55-23 63039-04 48-8
62660-11 12-7 62716-07 57-17 62833-21 15-55 63042-02 15-33
62664100 11-60 62725-00 54-2 62833-21 16-49 63042-03 16-41
62665-02 13-8 , 62727-00 54-35 62833-27 26-3 63045-00 15-34
62674-01 9-22 62727-01 54-35 62833-37 55-57 63045-00 16-39
62674-03 9-22 62733-00 - 54-12 62833-39 - 1-471 63070-05 17-22
62677-00 10-51 62736-00 54- 14 62833-39 16-59 63070-07 17-25
62695-04 12-13 62740-00 54-7 62833-46 48-14 63070-11 17-22
6 2 h 7 -00 10-45 62743-02 53-25 62833-74 70-25 63070-41 17-2
62697-02 10-45 62743-02 54-13 62833-78 38-28 63070-42 17-1
62701-08 53-6 62743-03 53-26 62833-78 39-15 6307043 17-21
62701-100 53-5 62743-04 53-27 62833-82 61-10 63070-44 17-21
62701-101 54-28 62743-05 53-28 62833-83 61-25 63070-45 17-2
62701-104 55-2 62743-06 53-29 62833-85 57-32 63070-46 17-1
62701-111 72-7 62743-08 55-37 62833-86 57-32 63071-02 17-26
62701-113 53-7 62746-00 53-21 62834-02 57-18 63071-12 17-29
62701-114 53-8 62753-00 13-18 62838-00 56-10 63071-18 17-30
62701-12 53-9 62762-00 53-22 62839-00 57-13 63078-06 13-58
62701-122 53-2 62763-00 1146 62840-02 57-29 63142-02 35-37
62701-123 53-3 62764-00 54-22 62840-03 7-30 63142-39 35-38
62701-124 53-4 . ; 62764-02 -54-24 - 62845-02 %T2 6314247 35-39
62701-13 53-10 62768-00 53-23 62856-00 54-34 63142-48 35-40
62701-47 55-1 62769-00 53-24 62856-01 54-34 63142-51 35-40
62701-99 53-1 62778-00 57-14 62858-02 57-28 63142-55 35-39a
62703-03 57-6 62782-00 57-24 62858-03 54-26 63142-56 35-37
62703-33 57-7 62784-00 57-25 62858-04 54-27 6314-00 35-8
62705-00 54- 1 62789-02 54-3 62859-00 12-18 63149-16 17-20
62706-06 54-5 628 17-00 13-19 62867-02 33-7 63149-17 17-20
62709-00 55-10 62820-00 54-29 62875-00 11-36 63149-20 17-20
62710-02 53-40 62821-00 54-30 62924-02 52-16 63149-21 17-20
627 10-03 53-41 62829-03 56-2 62969-00 59-28 63149-24 17-20
6271053 55-42 6283 1-00 56-5 62980-00 43-22 63149-25 17-20
62711-02 53-12 62832-00 56-6 62980-04 43-22 63160-02 37-9
62711-02 54-31 62833-06 16-38 62980-05 43-22 63185-06 37-11
627 11-03 53-13 62833-07 30-35 62980-06 43-22 63186-02 18-18
62711-03 55-39 62833-101 22-27 63012-00 15-50 63186-04 31-2
627 11-04 13-7 62833-101 22-2& " 63020-02 i'5-72 63186-12 79-7
62711-04 55-40 62833-101 63-28 63020-02 16-60 63186-21 18-19
62712-02 54-33 62833-101 63-29 63036-00 15-30 63186-33 31-5
&*

Rev~sed:July 30, 1994

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
. . I AIRPLANE PARTS CATALOG

NUMERICAL INDEX
- .Part ' Part Part Figure and Figure and
'Number Number Number Index No. I ~ndexNO.
63207-00 63420-08 49-20
63211-00 63423-04
63243-02 63436-00
63264-00 63436-01
63287-00 63451-00
63288-00 63455-00
63292-02 63456-00
63293-02 63458-04
63307-00 63459-19
63308-00 63464-00
63310-00 63466-00
63311-00 63468-00
63311-03 63469-00
63312-00 63469-01
63312-02 63470-00
63314-00 63478-00
633 15-00 63479-00
63325-00 63484-00
63,332-03 63485-00
63332-05 63485-01
63338-00 63501-03
63341-00 63502-00
63342-00 63504-00
63354-00 63506-00
63355-09 63509-00
6%56-00 63510-00
63357-00 63513-00
63370-04 63515-00
63370-04 63520-00
63370-04 63530-00
63370-05 63531-00
63383-00 63543-00
63391-02 63544-00
63391-03 63545-00
63392-00 63546-00
63392-01 63550-00
63393-00 63560-02
63393-01 63560-02
63395-00 63560-03
63396-02 63561-05
63398-00 63562-00
63398-01 63563-00
63404-00 63564-00
63408-00 63565-02
63408-00 63566-02 '
63419-00 63566-02
-

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
i.
AIRPLANE PARTS CATALOG

'- NUMERICAL INDEX

Part
Number
Figure and
Index No. LJ
Number
Figure and
Index i o .

Revised: July 30, 1994

 'PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
<.a,
AIRPLANE PARTS CATALOG

(I NUMERICAL 'INDEX
Part Figure and Part Figure and Part Figure and Part Figure and
Number Index No. Number Index No. Number Index No. ~umder Index No.
65735-13 35-32 66598-00 4-31 66796-00 12-2 67135-03 32-30
65735-18 35-28 66598-01 4-31 66798-00 73-9 67137-00 9-36
65735-19 35-32 66599-00 4-32 66802-06 37-8 67138-03 9-38
65741-00 17-8 66599-01 4-32 66802-07 37-8 67139-00 9-39
65742-00 17-7 66609-00 8-20 66802-08 37-8 67168-00 30-24
65773-00 2-20 66614-00 53-20 66802-09 37-8 67193-07 57-27
65782-00 17-9 66616-00 67-25 66802-10 37-8 67206-02 48-25
65784-00 72-18 66620-00 3-17a 66804-00 35-18 67212-00 48-3
65797-07 42-1 66621-00 3-17 66805-00 35-19 67214-00 48-4
65798-03 17-4 66623-00 3-13 668 15-00 52-2a 67215-03 48-7
65798-04 17-4 66623-01 3-13 66817-00 52-2 67216-00 48-7
6582 1-02 72- 1 66641-00 15-24 66820-00 26-42 67218-02 48-9
6582 1-05 72-1 A : 66654-00 15-16, 66821-04 2946 67218-02 48-10
65826-05 17-3 66661-00 58-5 66821-04 30-23 67221-00 48-12
65826-06 17-3 66679-00 8-11 66821-05 30-23 67223-00 48-2
65836-00 56-3 66695-00 40-72 66822-09 18-9 67225-00 48-26
65837-02 56-1 66696-00 40- 12 66822-10 18-10 67228-04 40-30
65846-00 35-4 66703-12 43- 1 66835-00 48-23 67229-06 40-33
65846-00 85-60 66703-13 43- 1 66837-00 82-21 67232-12 35-3
65850-00 48-1 66703-14 43-1 66837-00 85-27 67232-13 35-3
65863-00 40-29a . 667 10-16 35-14 66843-02 23- 14 67232-15 35-3
65863-00 85-9 66710-17 15-7 66864-02 20-3 67232-21 35-3
65865-00 35-33 66710-17 16-3 66894-03 44-6 67232-22 35-3
65866-00 35-23 667 10-26 15-8a 669 13-03 15-3 67232-25 35-3
65866-00 35-23 667 10-26 35-15a 669 14-02 15-4 67232-40 35-3
65867-00 35-34 667 10-44 15-8a 66918-13 40-36 67232-47 35-4
65869-00 35-49 66710-44 16-5 66918-16 40-36 67241-00 40-34
65870-00 35-35 *,*: ; 6671044 35-15a 669 18-20 4436 67241-00 40-35b
65871-00 35-36 667 13-00 65-7 66955-00 13-21 67241-00 85-5
65889-00 47-15 66750-00 22- 17 66964-00 20-2 67249-00 13-16
65895-00 17-6 66761-02 3-14 66965-00 8-20 67258-00 9-30
65896-00 17-5 66761-03 3-14 66968-00 10-14 67259-02 9-29
65896-02 17-5 66762-00 4-9 66968-01 10-14 67259-12 9-29
65898-00 4-36 66768-00 49-36 66969-02 10-14 67262-02 10-30
65898-01 4-36 66769-00 13-34 66969-03 10-14 67262-03 10-30
65898-04 4-38 66773-00 48-8 66970-03 65- 17 67266-02 9-5
65898-07 4-40 66774-00 48-11 66970-03 85-23 67267-00 10-59
65899-00 7-6 66787-00 35-57 66972-00 20-8 67267-01 10-59
66219-00 49-35 66787-00 85-38 66975-03 18-2 67286-00 11-25
66541-00 9-24 66789-00 43-25 66975-03 20- 1 6729 1-00 10-50
66546-00 57-33 66789-00 49-29 66975-04 18-2 67291-01 10-50
66547-00 47-5 66789-00 64-50 66975-04 20-1 67325-03 35-9
66580-02 64-45 66789-00 68A-13 66980-00 59-3 67330-07 35-2
66580-02 67-11 66793-18 14--4%. 66980-00 59-25 67330-10 35-2
66597-00 4-30 66795-00 12-5 67120-17 9-7 67330-12 35-2
66597-01 4-30 66795-02 12-5 67125-00 9-13 67366-00 13-52
A .%

Revised: July 30, 1994

2F9
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
9 -,
AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part
' umber
Figure and
Index No.
Part
Number
Figure and
Index No. II Part
Number
I Figure and
Index No. lp,
Number
67367-00 13-51
67404-02 64-3
67404-03 64-4
67409-03 65-16
67422-12 65-31
67422-13 65-32
67422-14 65-33
67431-00 40-22
67432-04 40-74
67436-04 65-13
67436-05 65-14
67437-00 65-1
67462-06 40-1
67463-00 57-5
67466-00 40-70
67471-00 82-20
67471-00 82-35
67471-00 85-26
67471-00 85-46
67487-04 68B-14
67490-02 40-46
67490-02 72-11
67491-00 57-3
67491-03 57-48
67493-00 74- 15
6f494-00 74-16
67494-01 74-16
67556-02 17-23'
67556-04 17-23
67570-00 53-69
67661-00 50-2
6766 1-00 51-2
677P 1 50 80-4
6770i - i72 42-22
67700-183 42-38
67700-184 42-39
67700-25 51-5
67700-300 42-48
67700-301 42-47
67700-396 49-26
67700403 4240
6770042 43-21
67700-55 49-26
67700-56 5116
67700-57 51-7
67700-58 32-22
*:
Revised: July 30. 1994
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
-. , AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part Figure and Part Figure and Part Figure and
Number Number Index No. Number Index No. Number Index No.
IzizG- 64-30 69669-118 16-64 69669-36 40-32 7037 1-03 59-31
64-30 69669-118 85-40 69669-36 85-4 70371-05 48-35
8-29 69669-128 40-3 1 69669-37 40-29 7037 1-06 48-28
49-18 69669-128 85-3 69669-37 85-2 72091-00 52-5
42- 1 69669-I3 38-4 69669-39 40-29b 7209 1-00 52-5a
42-43 69669-13 39-6 69669-39 85-35 73290-02 68B-6
42-43 69669-13 85-14 69669-64 52-17 73451-07 43-28
40-69 69669-134 35-48 69669-64 85-34 73508-02 68B-5
17-42 69669-134 85-29 69669-66 76-12 73733-135 84-14
15-12 69669-14 38-4 69669-66 77-8 73909-00 11-47
59-18 69669-14 39-6 69669-66 85-36 73989-03 67-36
59-23 69669-14 85-14 69669-76 35-48 73989-04 67-37
59-33 4 69569-143 35-48, 69669-76 85729 74075-02 68B-7
59-17 69669-143 85-29 69669-77 60:1?28 74075-03 68B-7
59-26 69669-15 76-12 69669-77 85-37 74989-05 67-15
43-23 69669-15 85-36 69669-78 40-31 75619-09 65-27
56-12 69669-16 65-4 69669-78 85-3 76 112-04 11-2
64-58 69669- 16 85-19 69669-90 65-5 76112-05 11-6
64-58 69669-162 40-29 69669-90 85-20 76112-06 11-6
35-24 69669-162 85-2 69669-95 79-9 76114-00 11-3
30-25 69669-163 85-34 69669-95 85-74 76115-00 11-8
74-20 69669-17 65-18 69669-96 79-10 76115-01 11-8
85-25 69669-17 85-24 69669-96 85-75 76119-00 11-31
40-38 69669-171 14-8 69669-97 79-8 76119-01 11-31
40-38a 69669-171 85-11 69669-97 85-73 76120-00 11-19
85-7 69669-173 68-3 69669-205 68B-9 76120-01 11-19
40-40 69669-173 68A-8 69736-02 2-18 76121-00 11-62
40-40 . - 69669-173 85-21 69738-00 10-18 76123-04 11-54
40-40 69669-175 7 1-22 69740-00 1621 76123-05 11-54
40-40 69669-175 85-54 69740-02 10-21 76126-00 11-14
40-40 69669- 180 52-17 69785-01 52-8 76129-06 59-4
40-40 69669-180 85-34 69885-00 60-36 76129-07 59-4
18-17 69669-20 64-38 69885-02 60-37 76130-08 8-35
70-40 69669-20 85-17 69885-03 60-38 76130-12 10-2
70-41 69669-24 65-5 6989 1-02 10-24 76130-13 10-4
85-81 69669-24 85-20 6989 1-03 10-24 76130-14 10-3
76- 15 69669-25 40-35 69891-04 10-24 76130-15 8-33
85-36 69669-25 85-6 6989 1-05 10-24 76130-15 10-1
40-3 1 69669-27 22-5 69891-10 10-24 76131-00 10-13
85-3 69669-27 85-15 69891-11 10-24 76131-02 10-13
40-3 1 69669-30 40-31 69891-12 10-24 76131-03 10-13
85-3 69669-30 85-3 69891-13 10-24 76131-04 10-13
42-50 69669-31 40-29 69989-11 60-16 76132-00 10-5
85-28 69669-31 85-2, 70271-03 60-41 76132-03 10-5
16-63 69669-32 35-48 70371-02 59-32 76136-00 - 9-19
85-41 69669-32 85-29 7037 1-02 60-40 76137-02 9-25
.--
Revised: July 30. 1994
2Fl I
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
+*
'AIRPLANE PARTS CATALOG

"

:
Part
Number
Figure and
Index No.
Part
Number
Figure and
Index No. I "
Number
I ye;;: - - "P
Number
76138-00 10-44 76445-00
76139-00 10-37 76462-00
76139-02 10-40 76467-00
76143-00 17-27 76467-02
76145-00 15-2 76467-03
76150-02 15-6 76467-04
76150-04 15-6 76468-00
76158-00 15-42 76468-02
76158-02 15-42 76468-03
76158-03 15-42 76469-00
76159-00 15-42 76469-02
76 160-02 37-6 76469-04
76160-03 37-6 * 76469-904
76160-04 37-6 76469-904
76160-05 37-6 76469-907
76160-06 37-6 76469-907
76161-02 37-1 76469-907
76161-03 - 37-1 76469-946
76161-04 37-1 76469-947
76161-05 37-1 76469-948
76161-06 37- 1 76474-00
76161-07 37-1 76474-900
76161-08 37-1 76475-00
76161-09 37- 1 76475-900
76161-10 37-1 76476-00
76161-11 37-1 76476-01
76161-15 37-1 76476-900
76161-16 37-1 76476-901
76169-02 39-31 76489-02
7617240 38-16 76490-02
76 172-03 39-19 76490-03
76173-00 38-8a 76496-12
76173-01 38-8a 76496-13
76175-00 38-9 76497-02
76175-00 39-18 78033-00
76175-03 38-9 78041-00
76176-00 39-30 78041-00
76178-00 38-23 78041-00
76178-00 38-24 7804 1-00
76178-00 39-52 78041-08
76187-00 39-51 7804 1-08
76189-03 38-24a 78041-09
76191-00 35-25 78041-09
76191-02 35-25 78041-09
76192-00 38-25 78041-09
76197-00 17-28 78044-00
?A>.

Revwed: July 30,1994

 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
,v - AIRPLANE PARTS CATALOG

NUMERICAL INDEX
1

-I
Part""
Number
Part
Number
79171-29
r Number
I
I
Figure and
lndex No.
60-18
I Part
Number
79337-54
f Figure and

79171-30
79171-31
79171-32
79174-00
79 174-04
79205-00
79207-00
79207-00
79209-02
79209-10
79209- 14
79228-00
79228-00
79229-00
79230-00
79230-00
79230-00
79234-00
79235-00
79235-00
79236-05
79236-10
79236- 11
79238-00
79251-00
79251-00
79252;00
79252-00
79258-00
79258-01
79264-00
79266-00
79266-02
79267-00
79268-00
79270-00
79271-00
79275-00
79275-00
79276-00
79276-872
79277-00
79277-01
79280-00
79281-00

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
' c
'
AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part
Number
79563-901
Part
Number
Figure and
Index No. PE
Number

79563-905
79567-03
79569-00
79569-901

1
, ;::;:
79572-00
79573-02

79577-00
I
79577-900
79578-00
79578-900
79580-00
79580-01
79580-900
79580-901
79581-900
79582-02
79582-902
79584-08
79585-02
79585-902
79591-02
79591-03
79591-06
79591-07
79591.08
7959 1-09
79591-12
79591-13
79594-00
79595-19
79595-20
79595-22
79598-00
79599-00
79600-00
79639-02
79647-02
79650-02
79653-107
79653-121
79653-126
79653-127
79653-139

Revised: July 30, 1994

2F14
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
r*~ AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part Figure and Part Figure and Part Figure and Part Figure and
Number Index No. Number Index No. Number Index No. ~u&er Index No.
85375-02 65A-1 87369-27 85-58 89244-02 41B-5 96268-00 75A-9
85378-02 64-68 87369-38 40-46 89251-02 9-48 96352-03 2-33
85416-802 13-52 87369-38 72-1Oa 89258-08 64-64 96352-03 2-34
85417-02 13-51 87369-38 85-10 89268-02 35-17 96352-03 2-36
85421-03 68B-10 87369-39 40-46a 89269-02 38-31 96392-05 42-1
85421-04 68B-11 87369-39 72-lob 89276-11 65A-4 96392-805 42-1
85421-05 68B-12 87369-39 85-76 89276-12 65A-7 96392-810 42-1
85426-02 65A-23 873694 75A-8 89276-13 65A-6 96564-00 18-23
86062-94 46-6 87369-41 40-29 89276-14 65A-8 96602-00 71-22
86414113 65-47 87369-41 85-2 89276-15 65A-5 96602-00 85-54
86517-02 4-51 87369-53 65-55 89300-02 9-40 96610-00 82-10
86552-08 40-13 87369-53 85-78 89305-03 40A-28 96684-00 11-55
86652-05 84-143 , 87369-55 85-85, 89423-02 W 96806-08 38-8
86652-08 84-16 87369-56 85-84 89423-02 62-4 96806-09 38-8
86684-02 43-48 87369-60 41B-36 89452-04 65A-10 96806-12 38-2
86700-36 70-31 87369-70 85-86 89452-18 65A-11 96806-12 39-2
86875-04 49-64 87382-02 40-17 89452-21 65A-15 96806-17 38-42
86887-12 60-10 87389-02 40-14 89452-26 65A-16 96806-23 38-2
86887-13 60-10 87390-02 40-14 89452-32 65A-13 96806-23 39-2
87325-05 43-3 87391-02 40-16 89452-33 65A-14 96806-26 38-42
87327-02 43-9a ' 87392-02 45-12 89452-35 65A-12 96810-02 38-2a
87328-02 43-9 87438-02 38-35b 89803-05 67-4a 96810-02 39-3
87328-03 43-9 87451-02 40A-27 89803-06 67-4 96810-03 38-2a
87329-07 16-53 87451-03 40-78 93302-43 15-19 96810-03 39-3
87329-08 14-6 87451-03 40A-27 95061-106 38-10 96844-03 342
87332-02 38-11 87466-02 40A-27 95061-106 39-34 96863-00 15-5a
87332-02 39-47 87468-02 22-2 95061-108 2-24 96864-00 15-57
87334-02 15-732 . 87469-02
1 22-40 95061-118 22-8 96866-00 10-73
87334-02 16-61 87499-03 64-34 95061-151 61-11 96868-00 15-39b
87334-02 85-65 . 87499-06 64-34 95061-161 38-12 96869-00 15-39a
87338-02 45-17 87536-02 Misc 95061-161 39-33 96872-00 15-5
87338-02 85-66 87539-05 75-3 95061-180 38-47 96887-00 11-37
87341-02 18-41 87742-02 64-59 95061-186 38-47 96887-02 11-37
87341-02 85-61 87770-02 41B-5 95094-00 3-24 96890-00 11-45
87341-03 85-62 87777-02 41B-33 95153-101 42-30 96890-01 11-45
87341-04 2-54 87777-08 41B-33 95153-158 42-30 96908-00 38-41
87341-04 85-63 87777-13 41B-34 95228-00 64-26 96919-00 15-27
87341-05 14-9 87777-19 41B-35 95229-00 64-19 96926-00 2-25
87341-05 85-64 87777-36 41A-35 95229-04 64-19 96926-00 2-46
87349-03 43-llb 87777-37 41A-34 95241-17 40-13 96927-00 245
87349-04 43-llb 89038-04 38-31 95261-00 65-47 97499-18 50-6
87358-04 22-14 89039-04 38-35 95636-00 4-33 98044-70 51-8
87360-40 85-83 89097-02 68-4 95636-01 4-33 98044-71 51-9
87366-02 40-15 89097-02 688-6 95639-02 3-5 98044-72 51-10
87369-05 85-72 89097-03 6844-7 95639-03 3-5 99010-05 40-3
87369-27 40-77 89178-10 39-53 96143-00 42-10 99026-00 Misc
-
Revised: July 30, 1994
 PIPER AIRCRAFT
PA-28-1511161 WARRIOR
TI
' AIRPLANE PARTS CATALOG

NUME~ICALINDEX
1
Part
,Number
99031-00
Figure and
Index No.
71-20
part Figure and
lndex No.
71-19
Part
Number
99487-01
- .
Part
Number
99640-00
I Figure and
Index No.

99032-02 18-13 65-11 99488-00 99640-03

99045-00 11-29 65-54 99495-00 99641-00
99059-06 40-24 63-1 99496-00 99641-00
99059-06 40-26 8-32 99500-06 99642-03
99060-06 40-25 82-13 99500-06 99642-03
99061-06 40-24 83-1 99500-08 99642-04
99062-06 40-23 82-13 99500-15 99644-00
99062-06 40-24 83-1 99500-17 99646-02
99062-06 40-25 82-13 99507-00 99648-00
99064-06 40-24 83-1 . 99513-03 99650-00
- 99066-06 40-24 81-5 995 13-05 99661-00
99072-00 61-9 ' 81-2 ' 99539-00 99670-00
99080-00 6 1-28 11-34 99541-02 99672-08
99121-00 64-39 10-52 99545-00 99672-09
99121-00 85-18 37-10 99549-07 99672-10
99 123-00 11-27 37-10 99549-08 99672-11
99129-03 11-28 73- 11 99550-02 99672-12
99 130-02 64-8 85-22 99552-00 99672-13
99170-00 66-3 35-16 99552-02 99679-00
99181-00 35-22 35-46 99555-00 99680-08
99181-03 35-22 8-2 99557-00 99690-00
99198-00 64-37 13-1 99558-00 99690-01
99209-00 73-3 8-2 99559-00 99691-00
99214-00 40-73 13-1 99559-01 99691-01
99220-03 64-35 8-2 99561-00 99692-00
99222-12 64-5 . 13-1 99561-00 99692-01
99222-13 64-5 '13-2 i. 99568-02 99693-00
99263-00 63-3 13-2 99568-03 99699-00
99271-00 63-8 13-5 99569-00 99717-00
99272-00 13-50 13-5 99572-04 99718-01
99273-00 13-27 13-5 99580-00 99718-05
99275-02 63-4 13-3 99592-02 99718-05
99275-02 63-9 13-3 99592-04 99719-03
99275-04 63-25 13-3 99609-00 99719-16
99278-03 13-28 13-3 99610-02 99741-00
99280-00 13-46 13-3 99615-00 99741-01
99280-01 13-46 13-4 99615-01 99745-00
99295-13 35-7 13-4 996 19-04 99746-03
99344-00 83-7 13-4 99621-02 99754-02
9936 1-00 38-43 13-4 99624-00 99754-02
99377-02 6519 40-8 9963 1-00 99783-00
99377-03 65-10 40-54 99633-00 99801-02
99377-05 65-11 40-54' 99633-00 99801-03
99377-06 65-12 40-2 1 99634-00 99803-03
99377-06 71-19 13-41 99635-09 99805-03
at -
Rev~sed:July 30, 1994
 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
I AIRPLANE PARTS CATALOG

NUMERICAL, INDEX
' ' .part Figure and Part Figure and Part Figure and Part Figure and
'Number Index No. Number Index No. Number Index No. ~urnder Index No.
99"813-02 13-33 400 437 55-48 400 672 56-7
99818-00 35-26 179 872 2-19 400 437 44-49 400 672 56-7
99818-02 35-26 187 625 23-19 400 438 13-60 400 672 58-16
99841-04 82-5 189 139 14-2 400 438 21-11 400 673 54-52
99849-03 43-19 189 139 15-47 400 438 23-30 400 674 48-33
99853-00 63-14 189 139 16-2 400 438 47-11 400 674 53-54
99854-00 63-10 189 625 68B-16 400 438 54-43 400 678 53-45
99856-00 55-11 303 889 53-50 400 438 54-43 400 680 54-53
99862-00 66- 1 342 336 54-23 400 438 55-50 400 728 68-12
99867-00 63-16 354 836 82-24 400 438 58-15 400 728 68A-16
99868-00 18-15 400 002 22-41 400 438 68B-15 400 749 48-6
99886-02 40-32 400 002 39-37 400 438 75-6 400 861 63-28
99886-02 85-4 <$. 40OQQ2 45-14 , 400 440 2+33 400 861 63-29
99887-02 76-8 400 003 18-27 400 440 54-46 400 861 63-30
99887-04 77-9 400 003 18-28 400 440 63-35 400 861 63-33
99887-06 78-7 400 003 19-25 400 441 2-27 400 862 15-70
99887-07 78-7 400 003 26-45 400 441 54-46 400 862 16-56
99887-07 78A-3 400 003 26-46 400 441 63-3 1 400 863 38-58
99888-00 76-9 400 003 26-48 400 441 68B-17 400876 32-42
99888-00 77-10 400 003 29-7 400 443 54-44 400 883 10-69
99889-00 76-10 * 400004 19-26 400 443 72-16 400 903 38-54
99889-00 77-11 400 004 30-28 400 444 2-29 400 911 38-34
99921-00 40-59 400 004 38-51 400 444 2-30 400 916 38-30
99921-00 85-50 400 004 41-30 400 444 9-35 401 186 2-32
99931-05 59-5 400 004 54-47 400 444 22-27 401 187 38-52
99943-00 15-49 400 008 53-48 400 444 72- 13 401 188 53-49
99943-00 16-8 400 009 2-31 400 446 13-11 401 195 23-5
99943-00 17-39 ,-* 8 40QW9 61-17 400 446 5%$3 401 266 5-30
99943-00 17-41 400 011 54-4 400 450 18-26 401 266 11-41
99950-00 40-39 400 015 24- 13 400 450 55-54 401 266 15-66
99952-00 40-42 400 055 53-45 400 451 11-52 401 266 20-17
99959-05 40-28 400 056 18-25 400 456 58-17 401 266 35-50
99959-08 40-27 400 056 57-36 400 457 53-47 401 266 38-55
99967-00 35-44 400 058 22-32 400 461 22-28 401 266 47-11
99968-00 35-44 400 059 22-42 400 462 22-28 401 266 53-44
99997-00 15-48 400 103 44- 12 400 464 30-34 401 266 54-45
99997-00 16-33 400 113 16-21 400 464 46- 11 401 266 55-51
99997-00 17-43 400 113 32-41 400 496 67-32 401 266 72-14
99999-00 66-10 400 155 53-56 400 566 68-12 401 269 11-42
400 165 26-26 400 585 55-53 401 269 18-38
400 166 26-27 400 616 61-30 401 269 38-57
_ r 400 171 48-6 400 652 54-49 401 269 38-58
400 208 43-35 400 653 54-50 401 269 55-52
400 209 43-24) 400 653 54-5 i' 401 269 57-23
400 224 63-21 400 653 57-35 401 269 63-34
400 302 26-25 400 665 16-29 401 270 2-28

Revised: July 30, 1994

2F17
 PIPER AIRCRAFT
PA-28-151l161 WARRIOR
..
AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part Figure and pz- '
Part
-Number Index No. Number Number

Revised: July 30,1994

 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
-A?;,
AIRPLANE PARTS CATALOG

NUMERICAL INDEX' '

Part. Figure and Part Figure and Part Figure and Figure and
Number Index No. Number Index No. Number Index No. Number Index No.
404 887 53-47 404 888 67-14 407 104 52-15 407 564 18-25
404 887 54-20 404 888 68- 13 407 106 68-12 407 564 18-26
404 887 54-45 404 889 2-32 407 106 68A-16 407 564 18-38
404 887 54-46 404 889 23-5 407 106 70-26 407 564 22-27
404 887 55-50 404 889 23-6 407 106 70-39 407 564 22-42
404 887 55-52 404 889 23-31 407 107 70-30 407 564 23-28
404 887 55-54 404 889 23-32 407 120 75-11 407 564 23-30
404 887 55-55 404 889 27-15 407 122 82-27 407 564 32-45
404 887 57-23 404 889 38-53 407 122 82-37 407 564 33-17
404 887 63-7 404 889 53-49 407 122 82-37 407 564 33-18
404 887 63-28 404 889 53-51 407 124 32-43 407 564 33-19
404 887 63-29 404 889 53-52 407 128 41B-37 407564 38-55
404 887 : 63-30 is: 404889, 53-53,? . 407130 35-52 407 564 39-43
404 887 63-31 404 890 2-34 407 130 41B-38 407564 41A-28
404.887 63-33 404 890 23-33 407 136 22- 16 407 564 48-33
404 887 63-34 404 890 61-12 407 136 45- 16 407 564 48-36
404 887 68B-17 404 891 43-31 407 137 70-24 407 564 52-20
404 887 72-13 404 891 43-32 407 137 70-27 407 564 534
404 887 72-14 404 909 26-34 407 137 70-28 407 564 53-45
404 887 72-16 404 909 31-11 407 144 70-26 407 564 53-46
404 887 75-6 ' 404909 40-60 407 561 39-43 407 564 53-47
404 887 55-53 404 910 30-36 407 562 15-20 407 564 53-54
404 888 2-31 404 910 75-5 407 562 15-23 407 564 53-55
404 888 13-11 404 910 75-10 407 562 16-29 407 564 54-20
404 888 18-27 404 945 53-55 ~ 407 562 26-33 407 564 54-44
404'888 19-25 405 580 4 1A-5 407 562 31-11 407 564 54-45
404 888 23-29 406 345 48-19 407 562 40-60 407 564 54-46
404 888 24-12 <: 406373
~ ' e 31-10 407 562 4mr38 407 564 54-46
404 888 26-32 406 415 2-42 407 562 5449 407 564 54-52
404 888 26-3 1 406 418 2-43 407 562 5450 407 564 54-53
404 888 26-46 406 424 60-7~ 407 563 30-36 407 564 55-50
404 888 30-30 406 424 60-53 407 563 75-5 407 564 55-52
404 888 30-31 406 424 62-22a 407 564 2-27 407 564 55-54
404 888 38-5 1 406 424 62-31 407 564 2-28 407 564 55-58
404 888 39-36 406 551 55-51 407 564 2-29 407 564 57-23
404 888 39-37 406 585 28-21 407 564 2-30 407 564 59-39
404 888 41B-26 406 637 26-45 407 564 2-44 407 564 60-41
404 888 45-15 406 637 26-48 407 564 6- 14 407 564 63-28
404 888 53-48 406 823 17-51 407 564 9-35 407 564 63-29
404 888 54-47 406 927 2-26 407 564 11-41 407 564 63-30
404 888 54-48 406 942 2-25a 407 564 11-42 407 564 63-31
404 888 57-22 407 041 17-12 407 564 11-52 407 564 63-33
404 888 57-32 407 041 17-12a 407 564 13-39 407 564 63-34
404 888 58-6 407 041 48-M. 407 564 13-40 : 407 564 63-35
404 888 61-17 407 043 48-32 407 564 15-66 407 564 67-13
404 888 63-32 407 046 61-33 407 564 18-24 407 564 68-14

Revised: July 30, 1994

2F19
 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
1 AfRPLANE PARTS CATALOG

I. Part
Number
I
I
Figure and
index NO.
Part
Number
II part I Fisure and '
I
PY
Number
Figure and
lndex No.
IzZT- 68A- 18 407 566 407 585
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
407 566 407 586
-407 566 407 586
407 566 407 586
407 566 407 587
407 566 407 587
407 566 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 587
407 567 407 589
407 567 407 591
407 567 407 591
407 567 407 595
407 568 407 597
407 568 407 641
407 568 407 674
407 568 407 674
407 569 407 677
407 569 407 680
407 569 407 680
407 582 407 684
407 583 407 694
407 583 407 694
407 584 407 694
407 584 407 800
407 584 407 800
407 584 407 801
407 584 407 801
407 584 407 888

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-151/161 WARRIOR
'-in AIRPLANE PARTS CATALOG

NUMERICAL- INDEX
Part Figure and Part Figure and Part Figure and Part Figure and
Number Index No. Number Index No. Number Index No. Number Index No.
407 901 73-7 415 521 53-57 424 051 15-20 424 142 39-43
408 815 48-16 415 521 82-37 424 051 15-23 424 148 55-44
408 823 17-12 415 521 82-37 424 051 15-64 424 162 15-22
408 826 17-12a 415 533 2-41 424 051 16-21 424 163 15-20
408 836 40A-27 415 533 75-10 424 051 16-62 424 163 26-44
410 035 6-14 415 535 2-38 424 051 18-25 424 172 39-43
410 039 5-31 415 535 17-45 424 051 22-29 424 177 33-17
410 043 2-8 415 535 30-36 424 051 22-30 424 178 16-30
410 054 18-35 415 535 49-67 424 051 22-32 424 178 32-40
410 054 18-37 415 536 17-46 424 051 22-42 424 180 55-43
410 241 18-36 415 537 17-46 424 05 1 26-30 424 181 33-18
411 530 41B-41 415 539 36-9 424 051 32-40 424 184 33-19
411 531 40A-27e- 415 540 75-5 424 051 3&41 424 186 56-8
411 536 41B-16 415 544 17-4 424 051 33-17 424 189 33-20
411 538 54-54 415 544 75- 11 424 051 33-18 424 204 15-64
414 694 48- 18 415 753 56-9 424 051 33-19 424 204 16-62
414 695 75-7 416 209 52-15 424 051 33-20 424 204 39-44
414 736 15-65 416 346 26-32 424 051 39-43 424 205 39-44
414 762 30-8 416 633 30-27 424 051 39-44 424 226 22-29
414 762 30-32 416 794 68- 14 424 051 44-12 434 128 38-33
414 769 15-36 416 794 68A- 18 424 051 48- 15 434 136 72-17
414 793 30- 17 416 994 32-43 424 05 1 48-33 434 144 82-25
415 171 31-11 417 775 32-44 424 05 1 48-34 434 179 43-9a
415 179 15-39 418 420 45- 16 424 051 48-36 440 629 40-21
415 309 2-39 419 594 15-45 424 051 53-45 450 030 67-1
4 l+% 309 2-53 419 594 16-51 424 05 1 53-62 450 035 67-1
415 312 2-40 419 594 35-60 424 051 54-52 450 101 67- 1
415 312 2-52 --. 419 641 17-48 424 051 54-53 450 380 41-1
415 320 2-44 419 680 15-58 424 051 55-43 450 380 41A-1
415 322 11-56 419 681 15-61 424 05 1 55-44 450 397 64-29
415 323 11-57 419 681 17-49 424 051 56-8 450 741 64-25
415 332 41B-24 419 681 60-35 424 051 57-36 450 741 85-30
415 376 35-52 419 920 2-42 424 051 59-39 450 742 64-23
415 378 15-60 419 920 2-43 424 051 60-41 450 944 43-5
415 378 18-34 419 920 31-10 424 052 53-63 451 103 49- 1
415 379 43-45 419 929 15-62 424 052 54-55 45 1 272 82-7
415 448 48-17 419 929 17-47 424 053 53-55 451 273 82-6
415 449 294 419 933 15-63 424 053 53-56 45 1 728 23-35
415 449 31-9 419 967 16-14 424 053 53-64 451 735 26-37
415 495 17-50 419 967 56- 11 424 053 53-66 451 739 23-36
415 495 17-51 424 04 1 16-29 424 055 53-65 451 855 46-10
415 497 17-12 424 041 16-30 424 059 26-25 451 857 52-4
415 514 64-6 424 041 54-49 424 060 57-21 451 872 49-42
415 518 26-33 424 041 54-50 424 095 26-26 451 881 41-20
415 520 41B-40 424041 54-5 1 424 095 26-27 451 881 4lA-18
415 520 82-27 424 041 57-35 424 123 55-60 451 881 41A-21

Revised: July 30, 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
AtRPLANE PARTS CATALOG

NUMERICAL INDEX
Part Figure and Part Figure and P=Pt Figure and
Number Index No. Number Index No. Number Index No.
451 881 75A-11 452 935 60-5 454 709 65-1 455 968 33-1
451 906 61-35 452 935 62-7 454 709 66-8 455 968 34-28
451 907 61-36 452 997 84-10 454 711 65-1 456 015 22- 14
451 908 61-37 453 024 39-61 454 732 65A-3 456 682 52-21.
451 939 41-21 453 124 23-24 454 736 65A-3 456 682 85-77
451 939 41A-18 453 124 26- 15 454 738 41A-31 456 703 65A-9
45.1 939 41A-23 453 425 73-10 454 738 65A-3 456 703 83-13
451 939 75A-10 453 425 74-10 454 739 65A-3 456 728 68-8
452 332 22-13 453 425 75-4 454 743 41B-30 456 728 68A-10
452 334 22- 15 453 602 65-28 454 743 60-46 458 855 46-7
452 335 22-3 453 639 64-5 1 454 743 65-1 458 864 494
452 335 53-17 453 665 35-54. 454743 66-8 458 868 49-37
452 335 53-18 . 453-680 49-43- 454 797 * YIA-30 458 868 50-17
452 335 54-23 453 687 40-5 1 454 806 75A-16 458 871 49-38
452 341 22-3b 453 695 81-9 454 837 43-33 458 879 42-33
452 372 57-8 453 714 33-16 454 868 49-66 458 881 32-35
452 386 38-13 453 732 38-2b 454 868 49-73 458 882 50-23
452 386 39-17 453 732 39-4 454 887 15-5b 458 891 33-23
452 387 4-37 453 742 64-32 454 921 84-8 458 892 50-22
452 387 4-39 453 836 82-24 454 928 42-41 458 892 . 51-13
452 387 4-4 1 453 838 82-23 454 929 42-46 458 893 42-34
452 387 20-7 453 838 82-23 454 935 39-61 458 894 26-47
452 387 21-7 453 855 83-8 454 977 41B-15 458 894 32-36
452 388 57-10 453 856 15-69 454 983 67-12 458 894 33-22
452 389 57-9 453 856 16-58 454 983 67-30 458 895 50-16
452 394 13-38 453 966 2-51 454 985 59-35 458 895 51-12
452 410 64-21 453 991 43-9a 454 985 59-35a 458 898 46-8
452 413 55-20 454 053 23-25" - -
454 993 ,5937 458 904 33-21
452 418 55-19 454 053 26-14 455 035 40-52 458 910 32-37
452 419 22-12 454 161 67-8 455 124 23-23 458 910 32-39
452 465 64-21 454 656 73-17 455 124 26- 16 458 913 50-21
452 544 4-44 454 657 75A-1 455 151 67-5 458 936 49-39
'452 558 63-20 454 668 41B-31 455 173 42-9a 458 946 49-6
452 561 63-27 454 668 65-1 455 173 42-16 458 948 4 1-28
452 570 63-17 454 668 75- 1 455 173 49-58 458 948 49-41
452 571 63-18 454 669 65-1 455 174 49-70 458 958 41-17
452 584 5-25 454 670 65-1 455 211 67-5 458 958 41-18
452 605 22-3 454 678 65-1 455 350 48-20 458 9.58 41A-6
452 606 48-24 454 681 75A-2 455 352 48-21 458 958 41B-6
452 679 38-39 454 706 41B-31 455 417 75A-15 459441 15-43
452 680 38-39 454 706 75-1 455 417 80-7 459 849 40-61
452 766 23-3 454 706 75A-3 455 938 32- 1 460 105 84-11
452 766 23-11a 454 706 79-6 455 944 33-1 460 464 51-16
452 766 23-27 452 706 81-4" 455 944 34-16 460 594 64-52
452 823 61-6 454 709 41B-30 455 948 33-1 460 602 65-25
452 824 61-5 454 709 60-46 455 948 34- 1 460 602 83-12
- v .
--

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-15111 61 WARRIOR
.a. "
AIRPLANE PARTS CATALOG

NUMERICAL' INDEX
Part Figure and Part Figure and
Number Index No. ~um6er Index No.
460 651 49-44 464 357 42-1 472 823 81-6 477 640 30-8
460 652 49-5 1 464 362 82-1 472 824 81-8 477 670 51-15
460 691 26-5 464 412 16-50 472 844 66- 15 477 672 20- 16
460 691 26-20 464 440 42-1 472 895 71-6 477 674 29-4
460 836 4 1-22 464 441 42-1 472 8% 71-6 477 696 17-12
460 888 41-6 464 448 82-1 472 969 40-52 477 696 17-12a
460 888 41A-27 464 642 82-3 472 987 71-6 477 696 35-52
461 136 54-39 465 258 57-46 472 988 71-6 477 708 39-36
461 386 60-7b 465 258 64-61 473 187 60-7a 477 709 38-28
461 386 60-52 465 258 66-12 473 187 60-51 477 709 38;30
461 386 62-19 467 064 82-14 473 187 62-18 477 772 43-29
461 386 62-22 467 067 64-53a 473 187 62-21 477 772 43-35
461 391 60-7b .ax* 467.067 64-55a' 473 195 36@7a 477 778 36-9
461 391 60-52 468 002 82-18 473 195 60-5 1 477 816 30-21
461 391 62-19 468 006 82-19 473 195 62-18 477 850 41A-5
461 391 62-22 469 900 82-28 473 195 62-21 477 887 22-34
461 629 40-39a 470 565 38-34 474 652 82-2 477 887 22-35
461 629 57-47 47 1 084 39-59 474 655 82-29 480 592 39-41
461 629 65-29 472 010 14-5 474 659 82-29 480 694 15-21
461 629 65-53 472 017 30-4 474 727 32-8 480 696 54-16
461 629 66-11 472 017 30-16 475 124 43-8 480 698 54-19
461 629 66- 13 472 027 64-41 475 125 43-8 480 701 38-21
461 629 67-19 472 028 65A-17 475 272 64-67 480 701 39-39
461 629 84- 15 472 028 65A-22 476 647 49-59 480 730 57-19
461 629 84-16 472 034 64-41 476 647 80-9 480 732 38-29
46T 643 64-61 472 054 40-79 476 662 50-18 480 732 39-35
461 657 67- 19 472 054 65-27 476 662 51-11 480 776 43-29
461 659 64-65 ex.. 472054 65-36 476 673 -3 480 776 43-35
461 660 64-65 472 054 66-14 476 676 68B-4 480 777 39-41
461 740 49-2 472 054 79-4 476 678 49-12 480 789 39-42
461 907 41A-3 472 055 65-49 476 685 49-46 480 790 39-40
461 931 52-3 472 056 65-26 476 686 49-63 480 800 16-31
462 012 64-33 472 056 65-48 476 688 46-9 480 801 39-40
462 023 41-5 472 056 83-11 476 697 49-69 481 214 71-1
462 024 23-7 472 058 65-35 476 705 49-47 481 247 71-1
462 024 26- 11 472 071 64-20 477 618 32-26 481 625 53-14
462 049 49-9 472 086 65-49 477 620 50-24 481 640 55-41
462 050 23-21 472 200 65A-23 477 629 43-40 481 640 72-8
462 060 49-54 472 200 65A-26 477 629 43-50 481 651 57-20
462 080 60-7 472 330 64-42 477 631 49-53 481 666 49-2
462 111 61-4 472 416 40-79 477 640 2-38 481 772 8-37
462 736 64-9 472 661 64-20 477 640 18-33 481 881 Misc
463 380 32-31 472 665 64-12 477 640 18-34 482 065 41-8
463 615 65-43 472 666 a 64-25 477 640 18-36 484 083 , 62-14
464 046 15-41 472 822 40-79 477 640 18-37 484 125 68B-2
464 356 42- 1 472 822 81-7 477 640 30-17 484 198 30-17

Revised: July 30,i994

 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
*.
'AIRPLANE PARTS CATALOG

" NUMERICAL INDEX

' Part Figure and Part Figure and Part pap
Number Index No. Number Index No. Number Number
491 062 494224
491 082 494227
491 082 494411
491 947 494644
491 947 494678
492022 497564
492065 497564
492099 505 888
492 100 506902
492 153 506 902
492240 506902
492240 507 150
492241 510058
492241 514758
492312 515 710
492335 515 714
492338 519853
492339 519853
494001 524 145
494001 544861
494001 548039
494003 548040
494025 548082
494026 548094
4940% 548095
494037 548096
494037 548 153
494041 548 160
494060. 548 161
494066 548 190
494087 548330
494087 548 512
494093 548 517
494 101 548561
494 101 548671
494 101 548868
494 101 548 885
494 101 550275
494 101 550404
494 101 550405
494 103 550406
494 123 550483
494 133 550487
494 141 ' 550489
494 159 550491
494 in 550493

Revised: July 30. 1994

2F24
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
.*
AIRPLANE PARTS CATALOG

NUMERICALLINDEX
'.Part Figure and Part Figure and Part Figure and
Number Index No. Number Index No. Number Index No.
550 548 40- 19 554 678 61-39 555 457 63-2 556 773 39-57
550 549 64-32a 554 686 82-30 555 501 82-22 556 774 39-57
550 778 74- 17 554 687 53-18 555 563 39-57 556 794 17-19
550 780 74-24 554 714 63-15 555 564 39-57 556 923 39-57
550 805 40-9 554 753 47-10 555 565 39-57 556 932 39-57
550 949 43-5 554 757 48-29 555 566 39-57 556 933 39-57
550 972 43-5 554 761 61-3 555 567 39-57 556 939 17-19
551 114 74-12 554 793 41A-4 555 568 39-57 556 940 17-19
551 216 81-1 554 800 43-34 555 699 17-19 556 941 17-19
551 374 38-38 554 808 41-24 555 700 17-19 557 039 39-57
551 390 38-37 554 845 49-72 555 701 17-19 557 040 39-57
551 424 38-39 554 861 4 1-25 555 702 17-19 557 041 39-57
551 425 38-39 %C 554861 41A-22 555 703 1P49 557 057 17-19
551 705 26-35 554 861 42-5 555 704 17-19 557 058 17-19
559 705 28- 1 554 861 42-42 555 731 76-17 557 059 17-19
551 764 27- 1 554 861 60-33 555 884 39-57 557 122 64-69
551 772 23-34 554 861 60-50 555 885 39-57 557 198 17-19
551 772 25-1 554 861 62-16 555 886 39-57 557 199 17-19
551 792 23-34 554 861 67-29 555 887 39-57 557 200 17-19
551 792 24-1 554 861 75A-18 555 888 39-57 557 201 17-19
551 983 61-2 554 861 80-3 555 889 39-57 557 337 64-30
551 983 69- 1 554 871 32-34 555 890 39-57 557 580 43-49
551 984 69-1 554 882 59-36 555 891 39-57 558 830 49-39
553 003 84- 11 554 888 41-26 555 953 39-57 558 831 49-40
553 230 61-10 554 888 41A-13 555 954 39-57 558 900 41-18
553 266 13-37 554 888 41A-16 555 955 39-57 558 900 4 1A-7
553 266 18-32 554 888 75A-17 555 956 39-57 558 901 41B-12
553 494 71-11 i - 2 554 888 84-3 555 957 39757 558 912 41-19
553 599 43-4 554 888 84-7 555 985 17-19 558 913 4 1A-24
553 673 64-32a 554 892 84-9 556 105 42-2 558 913 75A-13
553 685 49-62 554 896 59-34 556 119 17-19 559 030 40-52
553 878 59-13 554 926 62- 11 556 315 17-19 559 031 67-34
554 093 48-22 554 941 49-65 556 342 39-57 559 700 39-57
554 142 59-13 554 953 42-32 556 343 39-57 559 707 39-57
554 143 59-14 554 954 75-8 556 344 39-57 559 714 39-57
554 144 59- 15 554 958 41-27 556 469 39-57 559 721 39-57
554 366 60-39 554 960 67-35 556 470 39-57 559 728 39-57
554 422 39-13 554 979 53-43 556 471 39-57 559 735 39-57
554 575 75A-19 554979 54-41 556 472 39-57 559 748 39-57
554 598 41-29 554 979 55-46 556 473 39-57 559 758 16-5
554 598 41A-13 554 979 57-42 556 474 39-57 559 758 35-15a
554 598 41A-24 554 985 41-24 556 693 17-19 559 759 17-19
554 598 75A-20 554 985 41A-8 556 694 17-19 559 760 39-57
554 640 60-34 555 412 , 61-?~-+- 556 713 17-19 . 559 770 16-5
554 659 4 1-23 555 421 82-22 556 753 82-22 559 770 35-15a
554 659 41B-11 555 422 82-22 556 760 39-57 559 771 17-19
-
Revised: July 30,1994
2G1
 PIPER AIRCRAW
PA-28-1 51/161 WARRIOR
, . I AIRPLANE PARTS CATALOG

NUMERICAL' INDEX
Part Figure and Part Figure and
;Number Index No. Number - '"6
Num er lndex No.
39-57 579 275 579 631 35-11
16-5 579 276 579 632 35-11
35-15a 579 277 579 633 35-11
17-19 579 280 579 634 35-11
39-57 579 281 579 639 35-11

1 ;;;:::
16-5 579 282 35-11
35- 15a 579 283 35-11
39-57 579 284 579 687 35-11
16-5 579 285 1 579 688 35-11
35-15a 579 286 579 690 35-11
17-19 579 295 , 579 691 35-11
39-57 579 316 579 692 35-11
39-57 ' - 579 317 579 693 35-11
39-57 579 338 579 694 35-11
41A-17 579 339 579 696 35-11
75A-12 579 340 579 734 35-11
52-4 579 341 579 735 35-11
61-35 579 346 579 736 35-11
61-37 579 347 579 737 35-11
61-36 579 356 579 739 35-11
65A-23 579 378 579 740 35-11
65A-26 579 379 579 741 35-11
71-6 579 410 579 742 35- 11
43-15 579 411 579 743 35-11
70-36 579 413 579 745 35-11
38-39 579 414 579 855 35-11
38-39 579 415 579 861 35-11
64-5 579 472 579 872 35-13
65-27 579 472 579 873 35-13
82-16 579 473 579 874 35-13
6 1-24 579 473 579 875 35-13
61-21 579 474 579 876 35-13
Misc 579 474 579 877 35-13
35-11 579 482 579 884 15-10
64-40 579 483 579 885 15-10
38-15 579 484 579 886 15-10
39-49 579 616 579 887 15-10
60-30 579 617 579 888 15-10
66-9 579 618 579 889 15-10
65A-25 579 619 579 891 35-11
71-6 579 620 579 908 35-12
71-6 579 626 579 909 35-12
64- 12 579 627 579 910 35-12
71-6 579 628 579 912 35-12
71-6 579 629 579 913 35-12
64-15 579 630 580 079 35-13
- - - - - -
*6.

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
,.<
c5
AIRPLANE PARTS CATALOG

NUMERICAL-INDEX
:Part ' Figure and Part Figure and Part Figure and Part Figure and
Number Index No. Number Index No. Number Index No. Numlder Index No.
580 711 35-12 587 299 39-16 591 023 37-5 591 471 37-8
580 714 35-11 587 320 43-13b 591 025 37-5 591 472 37-8
580 715 35-13 587 330 43-4 591 026 37-2 591 473 37-8
580 724 35-11 587 381 16-26 591 027 37-2 591 474 37-8
580 730 16-5 587 398 16-20 591 028 37-2 591 491 37-8
580 730 35-15a 587 505 43-13b 591 030 37-2 591 493 37-7
580 73 1 16-5 587 581 67-3a 591 031 37-3 591 497 37-5
580 731 35-15a 587 593 30-21 591 032 37-3 591 499 37-5
580 736 35-11 587 594 30-17 591 033 37-3 591 501 37-2
580 742 35-11 587 690 413-42 591 035 37-3 591 503 37-3
580 779 35-12 587 807 83-2 591 142 37-6 591 543 37-6
580 780 35-11 587 808 83-3 591 143 37-6 591 545 37-1
580 781 35-11 z.,> 587808 83-4 . 591 144 37& 591 547 37-1
580 784 35-13 587 808 83-5 591 146 37-6 591 549 37-4
580 793 35-11 587 809 83-6 591 147 37-1 591 551 37-4
580 794 35-11 587 857 64-62 591 148 37- 1 591 608 37-8
580 847 35- 11 587 903 66-5 591 149 37- 1 591 610 37-8
580 848 35-11 587 923 65-40 591 151 37-1 591 611 37-8
580 849 35-11 587 923 72-10 591 152 37-1 591 612 37-5
580 850 35-11 587 923 79-5 591 153 37-1 591 614 37-5
580 851 35-11 . 587 952 76- 13 591 154 37-1 591 615 37-5
580 887 49-11 587 961 43-39 591 156 37-1 591 616 37-5
581 126 72-3 587 990 43-42 591 157 37-4 591 618 37-5
581 330 58-7 588 01 1 76-14 591 158 37-4 591 619 37-5
581.332 58-8 588 011 78-10 591 159 37-4 591 620 37-2
581 489 15-44 588 030 77-6 591 161 37-4 591 622 37-2
581 657 65A-3 588 109 60-29 591 162 37-4 591 623 37-2
581 928 15-51 , $88 356 65-23 591 163 374 591 624 37-3
581 928 17-24 588 356 83-9 591 164 37T4 591 626 37-3
582 172 70-33 588 391 49-50 591 166 37-4 591 627 37-3
584 137 82-36 588 425 65-24 591 182 37-3 591 696 37-6
584 140 30-17 588 436 49-49 591 183 37-3 591 698 37-6
584 140 30-21 588 464 65A-36 591 184 37-3 591 699 37-6
584 256 61-36 588 469 43-41 591 186 37-3 591 700 37-1
584 257 61-37 588 469 43-47 591 216 37-1 591 702 37-1
584 258 61-35 589 688 62-10 591 217 37-1 591 703 37-1
584 265 65-56 591 006 37-7 591 218 37- 1 591 704 37-1
584 279 65-50 591 007 37-7 591 220 37-1 591 706 37-1
584 290 64-30 591 008 37-7 591 225 37-1 591 707 37-1
584 315 64-63 591 010 37-7 591 226 37- 1 591 708 37-4
585 015 64-35 591 016 37-5 591 227 37- 1 591 710 37-4
585 708 16-7 591 017 37-5 591 228 37- 1 591 711 37-4
585 798 16-7 591 018 37-5 591 275 37-2 591 712 37-4
587 221 15-54 591 020 37-5 1 591 276 37-2 591 714 37-4
587 297 51-3a 591 021 37-5 591 277 37-2 591 715 37-4
587 299 38-14 591 022 37-5 591 279 37-2 591 803 37-8
-
Revised: July 30, 1994
2G3
 PIPER AIRCRAFT
PA-28-151f161 WARRIOR
*%.

AIRPLANE PARTS CATALOG

NUMERICAL INDEX
Part
Number
Figure and
Index No. PT
Number
Figure and
lndex No.
Part
Number
680 001
l.2-
Number

680 002
680 002
680 003
680 003
680 047
680 048
680 049
680 050
680 055
680 056
680 057
680 066
680 076
680 077
680 078
680 094
680 117
680 118
680 121
680 122
680 125
680 131
680 131
680 459
686 083
686 814
687 211
687 800
688 100
688 153
688 164
688 175
688 178
688 178
688 235
688 289
688 2%
688 404
688 603
689 970
750 063
751 201
751 201
751 202
751 202

Revised: July 30, 1994

2G4
 PIPER AIRCRAFT
PA-28-1 5111 61 WARRIOR
AIRPLANE PARTS CATALOG

NUMERICAL' INDEX
Part Figure and Part Figure and Part Figure and
Number Index No. Number Index No. ~umder Index No.
753 850 28-10 756 016 34-37 757 391 69-6 758 366 70-17a
753 910 41-3 756 018 34-36 757 392 69-6 758 369 70-13a
753 920 28-2 756 019 34- 13 757 437 34-7 758 393 25-8
753 956 32-2 756 037 71-7 757 479 34-20 758 397 23-34a
753 980 73-4 756 060 69- 11 757 480 34-17 758 402 64-22
753 980 74-8 756 061 69-13 757 579 73-15 758 452 78-2
754 535 27-8 756 065 70-6 757 579 74-2 758 453 78-5
754 804 24-8 756 066 70- 15 757 580 34-4 758 457 34-41
754 806 74-22 756 067 70-16 757 580 34-39 758 471 69-8
754 827 69-5 756 117 32-14 757 581 74-5 758 528 77-2
754 848 34-25 756 118 32-16 757 597 65-8 758 573 70-18
754 856 25-6 756 118 34- 10 757 718 63-13 758 574 70-21
754 895 41B-4 756 118 34-34 757 719 69t22 758 575 70-3
755 028 34-14 756 159 70-2 757 720 69- 17 758 576 70-8
755 048 24-4 756 531 34-27 757 721 69- 17 758 580 70-13b
755 049 52-18a 756 616 40-57 757 745 70-5 760 210 ,Mist
755 075 64-14a 756 620 34-6 757 746 70-7 760 297 ~Misc
755 075 64-17a 756 621 34-15 757 762 71-2 760 458 Misc
755 075 71-13 756 621 34-38 757 768 73-14 760 847 Misc
755 076 71-14 756 622 34-11 757 768 74-1 760 854 64-2
755 082 34-35 756 622 34-33 757 790 41-8a 760 854 Misc
755 096 64-14e 756 665 27-5 757 831 24-3 760 856 ,Mist
755 096 64-18 756 666 27-2 757 831 24-6 760 857 Misc
755 096 71-18 756 667 24-2 757 863 73-13 760 901 Misc
755 200 71-4 756 668 24-5 757 863 74-9 760 934 Misc
755 232 69-9 756 685 25-9 757 899 41-7 760 993 Misc
755 271 69- 18 756 686 25-2 757 899 41A-27 760 995 Misc
755 340 70-16 756 757 70-10 757 913 73-6 760 996 Misc
755 427 40-4 757 052 74-4 758 001 73-5 761 000 Misc
755 428 40-5 757 052 74- 13 758 002 74-19 761 004 Misc
755 432 73-1 757 163 Misc 758 023 74-3 761 005 Misc
755 818 28-11 757 216 32-10 758 024 74-7 761 006 Misc
755 846 70-4 757 217 32-11 758 092 77-3 761 007 Misc
755 882 32-18 757 310 40-56 758 181 73-8 761 008 Misc
755 883 28-12 757 311 70-9 758 188 73-2 761 039 57-4
755 884 28-13 757 316 34-2 758 224 69-7 761 039 Misc
755 885 28- 16 757 317 34-3 758 225 69-10 761 077 8-37
755 886 28- 17 757 318 34-12 758 249 70-12 761 092 Misc
755 887 28-3 757 318 34-32 758 250 70-13 761 150 60-1
755 949 32-4 757 386 69-3 758 251 70-14 761 156 71-8
755 950 32-5 757 386 69-21 758 266 76-6 761 157 71-9
755 999 27-9 757 387 69-4 758 267 76-7 761 158 71-6
755 999 27-12 757 387 69-19 758 281 76-2 761 159 71-6
755 999 27-14 757 388 69-1; 758 296 73-16 761 161 71-3
756 007 24-7 757 389 69-15 758 296 74-23 761 162 71-12
756 008 24-9 757 390 69- 16 758 364 76-2 761 189 71-2

Revised: July 30. 1994

2G5
 PIPER AIRCRAFT
PA-28-1 51/161 WARRIOR
'AIRPLANE PARTS CATALOG

NUMERelCALINDEX
'
Part
Number
Figure and
Index No.
Part
Number
Figure and
Index No.
Part
Number
Figure and
Index No. pat
Num er
Figure and
Index No.
761 190 71-3 762 586 34-42 765 019 41A-32
761 198 79-3 762 587 34-29 765 122 MSC
761 208 71-15 762 616 71-7 765 193 Misc
761 222 71-12 762 628 70-6 765 399 Misc
761 224 71-9 762 629 70-19 765 496 41B-29
761 253 71-12 762 636 64-14f 765 551 41B-1
761 254 71-12 762 636 64-18a 765 553 41B-43
761 255 64-14d 762 669 41B-3 765 648 41B-1
761 255 64- 17d 762 68 1 4 1A-3 767 981 70-17
761 255 71-17 763 003 15-8
761 256 64-14b 763 003 16-4
761 256 74- 17b 763 003 35-15
761 256 71-15 763 004 77-4
761 279 64-60 763 019 783
761 519 63-11 763 062 43-14
761 821 41A-8 763 215 25-3
761 903 69-12 763 391 25-4
761 913 70- 11 763 395 70-17
761 939 76- 1 763 450 34-40
761 967 76- 1 763 45 1 34-30
761 970 26-36 763 469 71-1
761 974 23-35 763 496 65-46
761 994 26-36 763 781 70-10
762 003 71-8 763 814 60-29
762 030 77-1 763 814 Misc
762 049 70-20 763 815 66-7
762 050 70-23 763 815 Misc
762 243 69-2 ' 763 828 Misc
762 275 34-21 763 842 Mist
762 276 34-18 763 848 2-15
762 277 34-19 763 920 Mix
762 357 78-6 763 934 Misc
762 426 64-14c 763 956 Misc
762 426 64- 1 7 ~ 763 957 Misc
762 426 71-16 763 962 Mix
762 489 70-5 763 966 Misc
762 490 70-2 763 967 Misc
762 49 1 70-7 764 013 Misc
762 492 70-10 764 050 Misc
762 493 70-22 764 092 70-29
762 508 69-20 764 401 72-9
762 509 69-20 764 836 74-22
762 560 25-5 764 962 Misc
762 561 35-7 764 975 M isc
762 581 71-7 764 981 M isc
762 585 34-31 765 014 4lB-32

Revised: July 30. 1994

 PIPER AIRCRAFT
PA-28-1 511161 WARRIOR
p1 7" AIRPLANE PARTS CATALOG

PAGES 2G7 THRU 2L24

INTENTlONALLY LEFT BLANK

Revised: July 30. 1994

This page intentionally left blank.