VHF MARINE TRANSCEIVER

iC-m32

Downloaded from www.Manualslib.com manuals search engine

 INTRODUCTION
This service manual describes the latest service information
for the IC-M32 VHF MARINE TRANSCEIVER at the time of
publication.

To upgrade quality, all electrical or mechanical parts and

internal circuits are subject to change without notice or oblig-
ation.

Model Version Symbol AC adapter TX high power

U.S.A. [USA] BC-147A
IC-M32 S.E. Asia [SEA] BC-147E 5W
Australia [AUS] BM-95V

DANGER
NEVER connect the transceiver to an AC outlet or to a DC
power supply that uses more than 10 V. This will ruin the
transceiver.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when

connecting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100mW)

to the antenna connector. This could damage the transceiv-
er’s front end.

ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:

1. 10-digit order numbers

2. Component part number and name
3. Equipment model name and unit name
4. Quantity required

<SAMPLE ORDER>
1110003200 S.IC TA31136FN IC-M32 MAIN UNIT 1 piece
8930060730 2691 keyboard IC-M32 Chassis 5 pieces

Addresses are provided on the inside back cover for your con-
venience.

REPAIR NOTES
1. Make sure a problem is internal before disassembling the transceiver.
2. DO NOT open the transceiver until the transceiver is disconnected from its power source.
3. DO NOT force any of the variable components. Turn them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the transceiver is defective.
6. DO NOT transmit power into a signal generator or a sweep generator.
7. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using
such test equipment.
8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

Downloaded from www.Manualslib.com manuals search engine

 TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTIONS

SECTION 4 CIRCUIT DESCRIPTION

4-1 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
4-2 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
4-3 PLL CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
4-4 POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
4-5 CPU PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4

SECTION 5 ADJUSTMENT PROCEDURES

5-1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1
5-2 PLL AND TRANSMITTER ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-4
5-3 RECEIVER ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

CHASIS PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-1
CHARGER PARTS (BC-150) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-3

SECTION 8 SEMI-CONDUCTOR INFORMATION

SECTION 9 BOARD LAYOUTS

SECTION 10 BLOCK DIAGRAM

SECTION 11 VOLTAGE DIAGRAM

Downloaded from www.Manualslib.com manuals search engine

 SECTION 1 SPECIFICATIONS

‘ GENERAL
• Frequency coverage : 156.025–157.425 MHz
156.050–163.275 MHz
• Type of emission : 16K0G3E
• Antenna impedance : 50 Ω
• MIC impedance : 2 kΩ
• Audio impedance :8Ω
• Power supply requirement : 7.2 V DC (negative ground; supplied battery pack)
• Current drain (approx.) : Transmit at High (5.0 W) 1.5 A
at Low (1.0 W) 0.7 A
Receive max audio 200 mA
• Frequency stability : ±10 ppm
• Usable temperature range : –20˚C to +60˚C; –4˚F to +140˚F
• Dimensions (projections not included) : 61(W) × 135(H) × 41(D) mm; 2 13⁄32(W) × 5 5⁄16(H) × 1 5⁄8(D) in.
• Weight (approx.) : 360 g; 12.7 oz. (with BP-224)

‘ TRANSMITTER
• RF output power : 5 W / 1 W (High / Low)
(with supplied battery pack)
• Modulation system : Variable reactance frequency modulation
• Maximum frequency deviation : ±5.0 kHz
• Spurious emissions : 68 dB
• Adjacent channel power : 70 dB
• Transmitter audio distortion : Less than 10 % at 1 kHz, 60% deviation
• Residual modulation : 40 dB
• Audio frequency response : +1 dB to –3 dB of 6 dB octave from 300 Hz to 3000 Hz

‘ RECEIVER
• Receive system : Double conversion superheterodyne system
• Intermediate frequencies : 1st 21.7 MHz
2nd 450 kHz
• Sensitivity : 0.25 µV at 12 dB SINAD
• Squelch sensitivity : 0.35 µV at threshold
• Adjacent channel selectivity : 70 dB (typical)
• Spurious response rejection : 70 dB (typical)
• Intermodulation rejection ratio : 70 dB (typical)
• Hum and noise : 40 dB
• Audio output power : 350 mW typical at 10% distortion with an 8 Ω load
• Audio frequency response : +1 dB to –3 dB of –6 dB octave from 300 Hz to 3000 Hz

Specifications are measured in accordance with EIA/TIA-603.

All stated specifications are subject to change without notice or obligation.

1-1
Downloaded from www.Manualslib.com manuals search engine
 ‘ VHF MARINE CHANNEL LIST
Channel No. Frequency (MHz) Channel No. Frequency (MHz) Channel No. Frequency (MHz)
USA INT CAN Transmit Receive USA INT CAN Transmit Receive USA INT CAN Transmit Receive
01 01 156.050 160.650 21A 21A 157.050 157.050 73 73 73 156.675 156.675
01A 156.050 156.050 22 157.100 161.700 74 74 74 156.725 156.725
02 02 156.100 160.700 22A 22A 157.100 157.100 77* 77 77* 156.875 156.875
03 03 156.150 160.750 23 23 157.150 161.750 78 156.925 161.525
03A 156.150 156.150 23A 157.150 157.150 78A 78A 156.925 156.925
04 156.200 160.800 24 24 24 157.200 161.800 79 156.975 161.575
04A 156.200 156.200 25 25 25 157.250 161.850 79A 79A 156.975 156.975
05 156.250 160.850 26 26 26 157.300 161.900 80 157.025 161.625
05A 05A 156.250 156.250 27 27 27 157.350 161.950 80A 80A 157.025 157.025
06 06 06 156.300 156.300 28 28 28 157.400 162.000 81 157.075 161.675
07 156.350 160.950 60 60 156.025 160.625 81A 81A 157.075 157.075
07A 07A 156.350 156.350 61 156.075 160.675 82 157.125 161.725
08 08 08 156.400 156.400 61A 61A 156.075 156.075 82A 82A 157.125 157.125
09 09 09 156.450 156.450 62 156.125 160.725 83 83 157.175 161.775
10 10 10 156.500 156.500 62A 156.125 156.125 83A 83A 157.175 157.175
11 11 11 156.550 156.550 63 156.175 160.775 84 84 84 157.225 161.825
12 12 12 156.600 156.600 63A 156.175 156.175 84A 157.225 157.225
13* 13 13* 156.650 156.650 64 64 156.225 160.825 85 85 85 157.275 161.875
14 14 14 156.700 156.700 64A 64A 156.225 156.225 85A 157.275 157.275
15* 15* 15* 156.750 156.750 65 156.275 160.875 86 86 86 157.325 161.925
16* 16 16 156.800 156.800 65A 65A 65A 156.275 156.275 86A 157.325 157.325
17* 17 17* 156.850 156.850 66 156.325 160.925 87 87 87 157.375 161.975
18 156.900 161.500 66A 66A 66A* 156.325 156.325 87A 157.375 157.375
18A 18A 156.900 156.900 67* 67 67 156.375 156.375 88 88 88 157.425 162.025
19 156.950 161.550 68 68 68 156.425 156.425 88A 157.425 157.425
19A 19A 156.950 156.950 69 69 69 156.475 156.475
20 20 20* 157.000 161.600 70 70 70 Rx only 156.525
20A 157.000 157.000 71 71 71 156.575 156.575
21 21 157.050 161.650 72 72 72 156.625 156.625
* Low power only
NOTE: Channels 3, 21, 23, 61, 64, 81, 82 and 83 CANNOT be used by the general public in USA waters.

‘ WX CHANNEL LIST
Weather Frequency (MHz) Weather Frequency (MHz)
channel Transmit Receive channel Transmit Receive
WX01 Receive only 162.550 WX06 Receive only 162.500
WX02 Receive only 162.400 WX07 Receive only 162.525
WX03 Receive only 162.475 WX08 Receive only 161.650
WX04 Receive only 162.425 WX09 Receive only 161.775
WX05 Receive only 162.450 WX10 Receive only 163.275

1-2
Downloaded from www.Manualslib.com manuals search engine
 SECTION 2 INSIDE VIEWS

• MAIN UNIT

TOP VIEW BOTTOM VIEW

Antenna switching circuit

(D52: MA77)

Antenna switching circuit

(D90: 1SV307)
APC
(IC50: NJM2125F)
Power amplifier
(Q54: RD07MVS1)

1st mixer
(Q150: 3SK299)
IF amplifier
(Q151: 2SC2714 Y) IF detector IC
(IC170: TA31136FN)
TX/RX switch
(D50, D51: MA77) VCO circuit

PLL IC
(IC1: µPD3140GS)

Mic amplifier and

low-pass filter circuits
(IC200: NJM2902V)
D/A converter
(IC190: M62363FP-650C)

CPU
(IC360: M37560M8A-700GP)

EEPROM
(IC340: BR24L16FV)

2-1

Downloaded from www.Manualslib.com manuals search engine

 SECTION 3 DISASSEMBLY INSTRUCTIONS

¡Removing the Rear panel ¡Removing the Chassis unit

G
A
C B
Rear panel E

C
MP31
A
D B

Chassis unit

F (Speaker connector)

Rubber

Front panel
Front panel

q Unscrew 1 screw, A (2 × 10 mm), and remove 1 washer, B. q Unscrew 1 nut, D.

w Unscrew 3 screws, C (2 × 8 mm). w Unscrew 2 screws, E (2 × 6 mm).
e Remove the rear panel and rubber from the front panel. e Take off the chassis unit in the direction of the arrow.
r Unplug, F, to separate the front panel, J251, and the
chassis unit.
t Remove 1 washer, G.
NOTE:
A : For IC-M2A only.
¡Removing the MAIN unit
B : For IC-M32 only.
NOTE: The chassis panel MP31 is a
H common parts for IC-M2A and IC-M32.
H
Need to screw the MP42 (C) to the B
location for IC-M32.

MAIN unit

Chassis MP31

q Unscrew 7 screws, H (2 × 4 mm).

w Unsolder 3 points, I, and remove earth plate.
e Separate the MAIN unit and the chassis.

3-1

Downloaded from www.Manualslib.com manuals search engine

 SECTION 4 CIRCUIT DESCRIPTION

4-1 RECEIVER CIRCUITS 4-1-3 2ND IF AND DEMODULATOR CIRCUITS

4-1-1 ANTENNA SWITCHING CIRCUIT (MAIN UNIT)
(MAIN UNIT) The 2nd mixer circuit converts the 1st IF signal to a 2nd IF
The antenna switching circuit functions as a low-pass filter signal. A double conversion superheterodyne system (which
while receiving and as resonator circuit while transmitting. converts receive signal twice) improves the image rejection
The circuit does not allow transmit signals to enter receiver and obtain stable receiver gain.
circuits.
The 1st IF signal is applied to a 2nd mixer section of the FM
Received signals from the antenna connector pass through IF IC (IC170, pin 16). The signal is then mixed with a 2nd LO
the low-pass filter (L81, L82, C83–C86, C89) and antenna signal for conversion into a 450 kHz 2nd IF signal.
switching circuit (D52, D90). The filtered signals are then
applied to the RF amplifier circuit (Q90). IC170 contains the 2nd mixer, limiter amplifier, quadrature
detector and active filter circuits. A 21.25 MHz 2nd LO signal
is produced at the PLL circuit using the reference frequency.
4-1-2 RF AND 1ST MIXER CIRCUITS (MAIN UNIT)
The 2nd IF signal from the 2nd mixer (IC170, pin 3) passes
The 1st mixer circuit converts the received signals to a fixed
through ceramic filters (FI170) to remove unwanted hetero-
frequency of the 1st IF signal with a PLL output frequency.
dyne frequencies. It is then amplified at the limiter amplifier
By changing the PLL frequency, only the desired frequency
section (IC170, pin 5) and applied to the quadrature detec-
will be passed through a pair of crystal filters at the next
tor section (IC170, pins 10 and 11) to demodulate the 2nd IF
stage of the 1st mixer.
signal into AF signals.
The signals from the antenna switching circuit are passed
through the tunable bandpass filter (D92) and amplified at
the RF amplifier (Q90). The amplified signals are passed 4-1-4 AF CIRCUIT (MAIN UNIT)
through another tunable bandpass filter (D130), and then AF signals from the FM IF IC (IC170, pin 9) are fed to the
applied to the 1st mixer circuit (Q150). analog switch (IC260).

The filtered signals are mixed at the 1st mixer (Q150) with a The AF signals (detected signals) are passed through the
1st LO signal coming from the PLL circuit to produce a 21.7 analog switch (IC260, pins 2 and 1) and are then applied to
MHz 1st IF signal. The 1st IF signal is passed through two the active low-pass filter (IC200c, pin 9).
crystal filters (FI150, FI151) and is then amplified at the IF
amplifier (Q151). The filtered AF signals are applied to and adjusted audio
level at the D/A convertor (IC190, pin 24) to adjust ampli-
tude. The level controlled signals are passed through the AF
mute switch (Q280) which is controlled by “AFMS” signal
from the CPU (IC360, pin 47). The passed signals are
applied to the AF power amplifier (IC280, pin 4), and then
output to the internal speaker or [EXT SP] jack after being
passed through the de-emphasis circuit (R286, C285) to
obtain the –6 dB/octave frequency characteristics.

2ND IF AND DEMODULATOR CIRCUITS 2nd IF filter

450 kHz
C180 C179
17 16
R175 R176
8 R174 7 5 FI170 3 2 PLL IC
IC1
Noise
"SQLO" signal to the D/A Active detector 2nd
convertor IC (IC190, pin 15) filter Mixer
IF amp. X1
21.25 MHz
FM
"SQLI" signal to the D/A detector
Noise
convertor IC (IC190, pin 16) RSSI comp. IC170 TA31136FN(D)
C175 9 10 11 12 14 16
"IF" (1st IF signal: 21.7 MHz)
C171 from RF unit, Q151
AF signal "DET" R172
R171 "NOISV" signal to the CPU (pin 2)
C176 C174
R170 "RSSIV" signal to the CPU (pin 1)
R5V
X170
450 kHz

4-1
Downloaded from www.Manualslib.com manuals search engine
 4-1-5 SQUELCH CIRCUIT (MAIN UNIT) 4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS
The noise squelch circuit cuts out AF signals when no RF (MAIN UNIT)
signals are received. By detecting noise components in the The signal from the VCO circuit passes through the trans-
AF signals, the squelch circuit switches the AF mute switch. mit/receive switching circuit (D50, D51) and is applied to the
buffer-amplifier (Q50). The amplified signal is amplified by
A portion of the AF signals divided by C175 from the FM IF the pre-driver (Q53) and the power amplifier (Q54) to obtain
IC (IC170, pin 9) are applied to the D/A convertor (IC190, pin 5 W of RF power (at 7.2 V). The amplified signal passes
16) to adjust amplitude. The signals from the D/A convertor through the antenna switching circuit (D52), and low-pass fil-
(IC190, pin 15) are applied to the active filter section (IC170, ter (L81, L82, C83–C86, C89) and is then applied to the
pin 8). The active filter section amplifies and filters noise antenna connector.
components. The filtered signals are applied to the noise
detector section and output from IC170 (pin 14) as the The bias current of the pre-driver (Q53) and the power
“NOISV” signal. amplifier (Q54) is controlled by the APC circuit to stabilize
the output power.
The “NOISV” signal from IC170 (pin 14) is applied to the
CPU (IC360, pin 2). The CPU compares the set squelch
level voltage and “NOISV” signal voltage to control the 4-2-4 APC CIRCUIT (MAIN UNIT)
squelch output. The APC circuit provides stable output power from the
power amplifier even when the input voltage or temperature
changes, and, selects HIGH or LOW output power. The APC
circuit consists of a power detector and APC control circuits.
4-2 TRANSMITTER CIRCUITS
4-2-1 MICROPHONE AMPLIFIER CIRCUIT • POWER DETECTOR CIRCUIT (MAIN UNIT)
(MAIN UNIT) The power detector circuit (D80, C87) detects the transmit
The microphone amplifier circuit amplifies audio signals with output power level and converts it to DC voltage as the
+6 dB/octave pre-emphasis characteristics from the micro- “TDETV” signal. The detected signal is applied to the TX
phone to a level needed for the modulation circuit. control circuit.

The AF signals from the microphone are passed through the • APC CONTROL CIRCUIT (MAIN UNIT)
pre-emphasis circuit (R253, C254) and are then applied to The detected signal from the power detector circuit (D91,
the microphone amplifier (IC200b). The amplified AF signals R280) is applied to the CPU (IC360, pin 4) to control the
are applied to analog switch (IC260, pin 5). input voltage of the pre-driver (Q53) and the power amplifi-
er (Q54). When the output power changes, the CPU (IC360)
The AF signals are amplified again at the limiter-amplifier outputs APC control signal to the D/A converter (IC190). And
(IC200a) and then passed through the low-pass filter then “PCON” signal from the D/A converter controls the APC
(IC200d, pins 12 and 13). The filtered audio is applied to the controller (IC50) to provide stable output power.
RF unit as the “MOD” signal.

4-2-2 MODULATION CIRCUIT (MAIN UNIT)

The modulation circuit modulates the VCO oscillating signal
(RF signal) using the microphone audio signals.

The audio signals “MOD” change the reactance of D20 to

modulate an oscillated signal at the VCO circuit (Q21, Q22,
D22, D23). The oscillated signal is amplified at the buffer-
amplifiers (Q23, Q24).

APC CIRCUIT
PWR det.
"TDETV" signal to the CPU D80, C87 Ant
TX
IC360 (pin 4)

Pre-Drive PWR amp.

The amplified signal from the
Q53 Q54
buffer amplifier (Q50)
D52
APC ctrl
"PCON" signal +
from IC190 (pin 3) IC50 D91
RX
"TXMS" signal to the CPU
TX MUTE SW
IC360 (pin 11)
"T5V" Q351

D90
To the 1st IF circuit
Ant SW

4-2
Downloaded from www.Manualslib.com manuals search engine
 4-3 PLL CIRCUIT (MAIN UNIT) 4-4 POWER SUPPLY CIRCUITS
A PLL circuit provides stable oscillation of the transmit fre- VOLTAGE LINES
quency and receive 1st LO frequency. The PLL output com- LINE DESCRIPTION
pares the phase of the divided VCO frequency to the refer-
ence frequency. The PLL output frequency is controlled by VCC The voltage from the attached battery pack.
the divided ratio (N-data) of a programmable divider. Common 5 V converted from the VCC line by the
CPU5V regulator circuit (IC220).
The PLL circuit contains a VCO (Q21, Q22, D22, D23). The CPU5V
The output voltage is applied to the CPU
oscillated signal is amplified at the buffer-amplifiers (Q23, (IC360), REG5V regulator, etc.
Q25) and then applied to the PLL IC (IC1, pin 19).
Common 5V converted from the VCC line by the
The PLL IC contains the prescalers, programmable counter, 5V regulator circuit (Q223–Q225).
5V
programmable divider, phase selector and etc. The entered The output voltage is applied to the D/A convert-
signal is divided at the prescaler and programmable counter er (IC190) and PLL IC (IC1), etc.
sections by the N-data ratio from the CPU. The divided sig- Receive 5V converted from the 5V line by the R5
nal is detected on phase at the phase detector using the ref- regulator circuit (Q221).
erence frequency. R5V The regulated voltage is applied to the MOD
MUTE circuit (Q20, D20, D21) and receiver cir-
If the oscillated signal drifts, the phase of its frequency cuit.
changes from the reference frequency, causing a lock volt-
age changes to compensate for the drift in the oscillated fre- Common 5V converted from the 5V line by the
quency. V5 regulator circuit (Q220).
V5V
The regulated voltage is applied to the VCO cir-
A portion of the VCO signal is amplified at buffer-amplifiers cuit
(Q23, Q24) and is then applied to the receive 1st mixer Transmit 5V converted from the 5V line by the T5
(Q150) or transmit driver via the TX/RX switching diode regulator circuit (Q222).
(D50, D51). T5V
The regulated voltage is applied to the transmit-
ter circuit.

PLL CIRCUIT
D50
Buffer to transmitter circuit

Q24
Buffer to the 1st mixer circuit
VCO
Q23 D51
Buffer
Q21, Q22, D22, D23
Q25

Loop IC1 (PLL IC)

filter

13 Phase Programmable 19
Prescaler
detector counter
"2nd LO" signal (21.25 MHz) 3
to the FM IF IC (IC170) Programmable PLST
17 Shift register 4 SCK
divider 5 SDATA
X1 16
21.25 MHz

4-3
Downloaded from www.Manualslib.com manuals search engine
 4-5 PORT ALLOCATIONS
4-5-1 CPU (IC360)
Pin Port Pin Port
Description Description
number name number name
Input port for the RSSI signal to con- Input port for the [CH/WX] key.
43 CH/WX
1 RSSIV trol S-meter from the FM IF IC (IC170 Low : While [CH/WX] key is pushed.
pin 12).
Input port for the [Y] key.
44 UP
Input port for the NOIS signal to con- Low : While the [Y] key is pushed.
2 NOISV trol squelch circuit from the FM IF IC
(IC170 pin 14). Input port for the [Z] key.
45 DOWN
Low : While the [Z] key is pushed.
Input port for the battery voltage
3 BATTV Input port for the [16] key.
detection. 46 16
Low : While the [16] key is pushed.
4 TDETV Input port for the TX power detection.
Output the speaker mute switch con-
Input port for transceiver’s internal 47 AFMS trol signal.
5 TEMPV
temperature detection. High : While the AF output is muted.
6 SCK Outputs serial clock. Outputs RF bandpass filters control
signal.
7 SDATA Outputs serial data.
48 BPFS High : While receiving below
Outputs key pad and LCD back light 159.990 MHz.
10 LEDS control signal. Low : While receiving above
High : While lights ON. 160.000 MHz.
12 BEEP Outputs beep audio signals. Outputs the 5V regulator control sig-
49 V5VS
nal.
Outputs strobe signals to the PLL IC
13 PLST
(IC1, pin 3). Outputs the T5V regulator control sig-
50 T5VS
nal.
Outputs strobe signals to the D/A con-
14 DAST
vertor IC (IC190, pin 6). Outputs the R5V regulator control sig-
51 R5VS
nal.
Outputs the M5V regulator control sig-
15 5VS
nal. Outputs the AF regulator control sig-
52 AFVS
nal.
16 LCDS Outputs LCD contrast signal.
Outputs the MIC mute switch control
Outputs serial clock signal for the 53 MICM
18 ESCK signal.
EEPROM (IC340, pin 6).
Outputs the detector mute control sig-
19 CLIN Input port for the cloning data. 54 DETM nal.
20 CLOUT Outputs the cloning data. Low : While muting.
Input port for the power switch control Input port for the volume control sig-
22 PWSW 55 VOL UP
signal. nal.
Input port for the PLL unlock signal.
23 UNLK
High : PLL is unlocked. 4-5-2 D/A converter IC (IC190)
I/O port for the serial data signals to Pin Port
24 ESDA Description
the EEPROM (IC340, pin 5). number name
Outputs the decode monitor signal. Outputs the reference frequency
27 TDEC 2 FCON
High : While muting. adjusting signal.
Input port for the [PTT] switch. PCON Outputs the TX power adjusting sig-
30 PTT High : While the [PTT] switch is 3
nal.
pushed.
Outputs the transmit modulation
Input port for transceiver’s internal 10 MCON
31 WET adjusting signal.
inundation detection.
Outputs the beep tone level adjusting
Input port for the [SCN] key. 11 BEPO signal while “AUTO” is selected in set
39 SCAN Low : While the [SCN] key is mode.
pushed.
Outputs the beep tone level adjusting
Input port for the [H/L] key. 14 BEPST signal while 1–10 level is selected in
40 H/L
Low : While the [H/L] key is pushed. set mode.
VOL Input port for the volume control sig- Outputs the squelch level adjusting
41 15 SQLO
DOW nal. signal.
Input port for the [SQL] key.
42 SQL Low : While the [SQL] key is
pushed.

4-4
Downloaded from www.Manualslib.com manuals search engine
 SECTION 5 ADJUSTMENT PROCEDURES

5-1 PREPARATION
When adjusting IC-M32, the optional CS-M32 CLONING SOFTWARE (Rev. 1.0 or later), OPC-478 CLONING CABLE are required.

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Output voltage : 7.5 V DC Frequency range : 30–300 MHz
DC power supply FM deviation meter
Current capacity : 3 A or more Measuring range : 0 to ±10 kHz
Measuring range : 0.1–10 W Frequency range : 300–3000 Hz
Audio generator
RF power meter Frequency range : 100–300 MHz Measuring range : 1–500 mV
(terminated type) Impedance : 50 Ω
SWR : Less than 1.2 : 1 Frequency range : 100–300 MHz
Standard signal
Output level : 0.1 µV–32 mV
generator (SSG)
Frequency range : 0.1–300 MHz (–127 to –17 dBm)
Frequency counter Frequency accuracy : ±1 ppm or better
Sensitivity : 100 mV or better Power attenuation : 40 dB or more
Attenuator
Capacity : 10 W or more
Digital multimeter Input impedance : 10 MΩ/DC or better

■ BEFORE ENTERING THE ADJUSTMENT MODE

• Cloning the adjustment frequency 156.800 MHz on the programmable CH.
(No select POC function POC ON on the adjustment frequency. )

■ ENTERING THE ADJUSTMENT MODE

• Push and hold the [H/L] key and [PTT] switch, and then turn power ON.

■ OPERATING IN THE ADJUSTMENT MODE

• Change adjustment items: [16] key
• Change adjustment values: [Y] and [Z] keys

■ EXITING THE ADJUSTMENT MODE

When adjustment is finished, need to do follow operation to cancel the adjustment mode. Otherwise, the transceiver does not
work properly.
• Turn power OFF.
• Push and hold the [H/L] key and [PTT] switch, and then turn power ON.

• DC POWER CABLE CONNECTION

DC power supply

+ connect (soldering) line here

connect (soldering) + line here

Top view

5-1
Downloaded from www.Manualslib.com manuals search engine
 • CONNECTION

to the antenna connector Standard signal generator

CAUTION! 0.1 V to 32 mV
DO NOT transmit while ( 127 dBm to 17 dBm)
an SSG is connected to
the antenna connector.

to [MIC] jack Attenuator

Audio generator FM deviation meter
40 dB or 50 dB

to [SP] jack RF power meter

SINAD meter 0.1 10 W/50

Frequency
Speaker (8 ) counter

OPC-782
Optional plug adapter AD-98FSC
cable Optional STUD-BNC
adapter

DETACHING/ATTACHING THE TOP PANEL

CAUTION!
DO NOT detach the TOP PANEL
except for adjustment or cloning
to maintain the water resistance
capability.

Detach the TOP PANEL with a After adjustment, be sure to

sharp point such as tweezers for reattach the TOP PANEL to
adjustment. maintain the water resistance
BE CAREFUL cracking the TOP capability.
PANEL.

NOTE: If the tape on the back of the TOP PANEL has lost its
adhesion, replacement to a new one is necessary.

5-2
Downloaded from www.Manualslib.com manuals search engine
 5-2 PLL AND RX SENSITIVITY ADJUSTMENTS
ADJUSTMENT
MEASUREMENT POINT
ADJUSTMENT ADJUSTMENT CONDITION VALUE
UNIT LOCATION UNIT ADJUST
LOCK 1 • Operating frq. : 156.800 MHz MAIN Connect a digital 1.8 V Verify
VOLTAGE • Receiving multi-meter or oscil-
loscope to the
check point CP1.
2 • Operating frq. : 156.800 MHz 1.7 V
• Output power : Low
• Transmitting

RX 1 • Operating frq. : 156.800 MHz Top Connect an SSG to 0.35 µV (–116 dBm) Verify
SENSITIVITY • Set an SSG as: Panel the antenna con-
Frequency : 156.800 MHz nector and a SINAD
Level : 3.2 µV* meter with 8 Ω load
(–97 dBm) to the [SP] jack.
Modulation : 1 kHz
Deviation : ±3.5 kHz
• Receiving

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.

CP1
PLL lock voltage
check point

5-3
Downloaded from www.Manualslib.com manuals search engine
 5-3 ADJUSTMENT MODE ADJUSTMENTS
Select an operation using [16] key, then set specified value using [Y] / [Z] keys on the front panel of IC-M32.

MEASUREMENT
ADJUSTMENT ADJUSTMENT CONDITION VALUE
UNIT LOCATION
REFERENCE 1 • Operating frq. :156.800 MHz Top Loosely couple the frequency 156.8000 MHz
FREQUENCY • Output power : Low Panel counter to the antenna connec-
[Fr] • Connect an RF power meter or a 50 Ω tor.
dummy load to the antenna connector.
• Transmitting
OUTPUT 1 • Operating frq. : 156.800 MHz Top Connect an RF power meter to 5.0 W
POWER • Output power : Hi panel the antenna connector.
[Po H] (Hi) • Transmitting
[Po L] (Low) 2 • Output power : Low 0.8 W
• Transmitting
[Po ML] 3 • Output power : Extra-Low 0.45 W
(Extra-Low) • Transmitting
FM 1 • Operating frq. : 156.800 MHz Top Connect an FM deviation meter ±4.3 kHz
DEVIATION • Output power : Low panel to the antenna connector
[dE] • Connect an audio generator to the [MIC] through an attenuator.
jack and set as:
1 kHz/25 mV
• Set an FM deviation meter as:
HPF : OFF
LPF : 20 kHz
De-emphasis : OFF
Detector : (P–P)/2
• Transmitting
SQUELCH 1 • Operating frq. : 156.800 MHz Top Connect an SSG to the antenna More than 12 dB
LEVEL • Set an SSG as: panel connector and a SINAD meter SINAD
[nL] Frequency : 156.800 MHz with 8 Ω load to the [SP] jack.
Level : 0.63 µV*
(–111 dBm)
Modulation : 1 kHz
Deviation : ±3.5 kHz
• Receiving
2 • Receiving • Push [Z] key to
set squelch level
to “01” at the sub
channel readout.
• Then, push [Y]
key to set squelch
level to “00” at the
sub channel read-
out.

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
TX power Hi/Low is selectable on all adjustment items.

5-4
Downloaded from www.Manualslib.com manuals search engine
 SECTION 6 PARTS LIST

[MAIN UNIT] [MAIN UNIT]

REF ORDER REF ORDER
NO. NO. DESCRIPTION M. NO. NO. DESCRIPTION M.

IC1 1130007610 S.IC µPD3140GS-E1 (DS8) B L58 6200003710 S.COIL NL 252018T-2R7J T

IC50 1120002830 S.IC NJM2125F-TE1 T L80 6200008280 S.COIL 0.30-1.7-7TL 50N T
IC170 1110003200 S.IC TA31136FN (EL) B L81 6200009800 S.COIL 0.26-1.1-7TR 30N B
IC190 1190000350 S.IC M62363FP-650C B L82 6200008580 S.COIL 0.30-1.4-6TL 32N T
IC200 1110003780 S.IC NJM2902V-TE1 B L90 6200008280 S.COIL 0.30-1.7-7TL 50N B
IC220 1110005350 S.IC NJM2870F05-TE1 T L91 6200007760 S.COIL LQW2BHN82NJ01L B
IC260 1140003830 S.IC TC4W66F (TE12L) B L92 6200007760 S.COIL LQW2BHN82NJ01L B
IC280 1110001810 S.IC TA7368F (ER) T L93 6200008190 S.COIL 0.25-1.9-8TL 80N B
IC340 1130011540 S.IC BR24L16FV-WE2 B L94 6200008190 S.COIL 0.25-1.9-8TL 80N B
IC341 1110006210 S.IC BD5242FVE-TR B L95 6200006980 S.COIL ELJRE R10G-F B
IC360 1140011630 S.IC M37560M8A-700GP (FX-2691A) B L120 6200002430 S.COIL NL 252018T-082J T
L121 6200002410 S.COIL NL 252018T-056J T
L122 6200003550 S.COIL MLF1608A 4R7K-T B
Q20 1590000430 S.TRANSISTOR DTC144EUA T106 B L130 6200007760 S.COIL LQW2BHN82NJ01L B
Q21 1530002920 S.TRANSISTOR 2SC4226-T1 R25 B L131 6200007760 S.COIL LQW2BHN82NJ01L B
Q22 1530002920 S.TRANSISTOR 2SC4226-T1 R25 B L132 6200008190 S.COIL 0.25-1.9-8TL 80N B
Q23 1530002380 S.TRANSISTOR 2SC4215-Y (TE85R) B L133 6200008190 S.COIL 0.25-1.9-8TL 80N B
Q24 1530002380 S.TRANSISTOR 2SC4215-Y (TE85R) B L150 6200003680 S.COIL LQH31MNR82M01L B
Q25 1530002380 S.TRANSISTOR 2SC4215-Y (TE85R) B
Q50 1530002920 S.TRANSISTOR 2SC4226-T1 R25 T
Q53 1560001240 S.FET RD01MUS1 T R1 7510001660 S.THRMISTOR NTCG16 4LH 473KT B
Q54 1560001230 S.FET RD07MVS1 T R2 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ) B
Q90 1530002920 S.TRANSISTOR 2SC4226-T1 R25 B R3 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
Q150 1580000760 S.FET 3SK299-T1 U73 B R4 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B
Q151 1530002360 S.TRANSISTOR 2SC2714-Y (TE85R) T R5 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) B
Q220 1510000670 S.TRANSISTOR 2SA1588-GR (TE85R) T R6 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
Q221 1510000670 S.TRANSISTOR 2SA1588-GR (TE85R) T R7 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B
Q222 1510000670 S.TRANSISTOR 2SA1588-GR (TE85R) T R8 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
Q223 1590000430 S.TRANSISTOR DTC144EUA T106 B R9 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) B
Q224 1590001190 S.TRANSISTOR XP6501-(TX) .AB B R10 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) B
Q225 1520000450 S.TRANSISTOR 2SB1132 T100 Q B R20 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B
Q230 1520000450 S.TRANSISTOR 2SB1132 T100 Q T R22 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω) B
Q231 1590001190 S.TRANSISTOR XP6501-(TX) .AB T R23 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
Q240 1590000430 S.TRANSISTOR DTC144EUA T106 B R24 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B
Q250 1590002530 S.TRANSISTOR UN911H (TX) B R25 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B
Q280 1530003090 S.TRANSISTOR 2SC4213-B (TE85R) T R26 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) B
Q350 1590000660 S.TRANSISTOR DTC144TU T106 B R27 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) B
Q351 1590000720 S.TRANSISTOR DTA144EUA T106 T R28 7030003350 S.RESISTOR ERJ3GEYJ 181 V (180 Ω) B
R29 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) B
R30 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) B
D1 1750000770 S.VARICAP HVC376BTRF B R31 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B
D20 1790001260 S.DIODE MA2S077-(TX) B R32 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) B
D21 1790000620 S.DIODE MA77 (TX) B R33 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) B
D22 1720000780 S.VARICAP HVU350B TRF B R34 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B
D23 1720000780 S.VARICAP HVU350B TRF B R35 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) B
D50 1790000620 S.DIODE MA77 (TX) T R36 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
D51 1790000620 S.DIODE MA77 (TX) T R50 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
D52 1750000580 S.DIODE 1SV307 (TPH3) T R52 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) T
D80 1790001670 S.DIODE RB706F-40T106 T R53 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) T
D90 1750000580 S.DIODE 1SV307 (TPH3) B R54 7030003260 S.RESISTOR ERJ3GEYJ 330 V (33 Ω) T
D91 1790001670 S.DIODE RB706F-40T106 T R55 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) T
D92 1790000620 S.DIODE MA77 (TX) B R56 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) T
D93 1790000660 S.DIODE MA728 (TX) B R57 7030003310 S.RESISTOR ERJ3GEYJ 820 V (82 Ω) T
D130 1790000620 S.DIODE MA77 (TX) B R65 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) T
D350 1750000370 S.DIODE DA221 TL B R66 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) T
D353 1790000660 S.DIODE MA728 (TX) B R67 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T
R68 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) T
R69 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) T
FI150 2030000350 MONOLITH 21R15AB (FL-368) B R70 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) T
FI151 2030000270 MONOLITH FL-363 (21.7 MHz) B R71 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) T
FI170 2020001270 CERAMIC CFWLB450KE2A-B0 B R72 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) T
R73 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
R74 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T
X1 6050011740 S.XTAL CR-766 (21.250 MHz) B R75 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) T
X170 6070000190 S.DISCRIMINATOR CDBCB450KCAY24-R0 B R76 7030000280 S.RESISTOR MCR10EZHJ 150 Ω (151) T
X360 6060010290 S.XTAL CR-610 (7.9872 MHz) B R80 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) B
R81 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) T
R82 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T
L1 6200008070 S.COIL MLF1608E 6R8K 6.8U B R90 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
L20 6200007000 S.COIL ELJRE 82NG-F B R91 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
L21 6200003090 S.COIL NL 322522T-2R7J-3 B R93 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
L22 6200008190 S.COIL 0.25-1.9-8TL 80N B R94 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B
L23 6200006980 S.COIL ELJRE R10G-F B R95 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B
L24 6200006980 S.COIL ELJRE R10G-F B R96 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) B
L25 6200006980 S.COIL ELJRE R10G-F B R100 7030003860 S.RESISTOR ERJ3GE JPW V T
L50 6200006980 S.COIL ELJRE R10G-F T R120 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) T
L51 6200007000 S.COIL ELJRE 82NG-F T R121 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
L53 6200007690 S.COIL LQW2BHN18NJ01L T R130 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
L55 6200009240 S.COIL 0.20-1.0-7TL 31N T R131 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
L56 6200010640 S.COIL 0.26-1.0-3TL 8.5N T R132 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
L57 6200008230 S.COIL 0.30-1.3-5TL 22N T R133 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B

M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount

6-1
Downloaded from www.Manualslib.com manuals search engine
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION M. REF ORDER DESCRIPTION M.
NO. NO. NO. NO.
R134 7030003330 S.RESISTOR ERJ3GEYJ 121 V (120 Ω) B R351 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R150 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B R352 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) B
R151 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) B R353 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R152 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) B R360 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R153 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) T R361 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R154 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) T R362 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R155 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) T R363 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R156 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) T R364 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B
R170 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) T R366 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B
R171 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) B R367 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B
R172 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B R371 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R173 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) B R372 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R174 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) B R373 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B
R175 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B R374 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) B
R176 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) B R375 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) B
R192 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) B R376 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B
R193 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B R377 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) B
R194 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B R378 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) B
R201 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) B R379 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) B
R202 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B R380 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) T
R203 7030003810 S.RESISTOR ERJ3GEYJ 125 V (1.2 MΩ) B R381 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T
R204 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B R382 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) T
R205 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) B R383 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) T
R206 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) B R384 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) T
R207 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) B R385 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T
R212 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) B R386 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T
R213 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) B
R214 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) B
R220 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T C1 4030016930 S.CERAMIC ECJ0EB1A104K B
R221 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) T C2 4030016790 S.CERAMIC ECJ0EB1C103K B
R222 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T C3 4030007170 S.CERAMIC C1608 CH 1H 221J-T B
R223 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) T C4 4030007040 S.CERAMIC C1608 CH 1H 180J-T B
R224 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T C5 4030007030 S.CERAMIC C1608 CH 1H 150J-T B
R225 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) T C6 4030017460 S.CERAMIC ECJ0EB1E102K B
R226 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) B C7 4030016790 S.CERAMIC ECJ0EB1C103K B
R227 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B C8 4030009520 S.CERAMIC C1608 CH 1H 020B-T B
R228 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) B C9 4030009520 S.CERAMIC C1608 CH 1H 020B-T B
R230 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) T C10 4030008920 S.CERAMIC C1608 JB 1H 473K-T B
R231 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) T C11 4550006560 S.TANTALUM ECST1CY225R B
R232 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T C12 4030017460 S.CERAMIC ECJ0EB1E102K B
R233 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) T C20 4030017460 S.CERAMIC ECJ0EB1E102K B
R234 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) T C21 4030007000 S.CERAMIC C1608 CH 1H 090D-T B
R235 7030005930 S.RESISTOR ERJ3GEYF 334 V (330 kΩ) T C22 4030007000 S.CERAMIC C1608 CH 1H 090D-T B
R236 7030008090 S.RESISTOR ERJ3EKF 1503 V (150 kΩ) T C24 4030016930 S.CERAMIC ECJ0EB1A104K B
R240 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) B C25 4030017460 S.CERAMIC ECJ0EB1E102K B
R241 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B C26 4030007090 S.CERAMIC C1608 CH 1H 470J-T B
R242 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) B C27 4030007080 S.CERAMIC C1608 CH 1H 390J-T B
R245 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) T C28 4030017460 S.CERAMIC ECJ0EB1E102K B
R250 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C29 4030017460 S.CERAMIC ECJ0EB1E102K B
R251 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) B C30 4030017460 S.CERAMIC ECJ0EB1E102K B
R252 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B C31 4030017460 S.CERAMIC ECJ0EB1E102K B
R253 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) B C32 4030009540 S.CERAMIC C1608 CH 1H 1R5B-T B
R255 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) B C33 4030007170 S.CERAMIC C1608 CH 1H 221J-T B
R256 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) B C34 4030009540 S.CERAMIC C1608 CH 1H 1R5B-T B
R257 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B C35 4030017460 S.CERAMIC ECJ0EB1E102K B
R258 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) B C36 4030017460 S.CERAMIC ECJ0EB1E102K B
R260 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) B C37 4030009570 S.CERAMIC C1608 CH 1H 0R3B-T B
R261 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ) B C38 4030017460 S.CERAMIC ECJ0EB1E102K B
R262 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ) B C39 4030007020 S.CERAMIC C1608 CH 1H 120J-T B
R263 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C40 4030007030 S.CERAMIC C1608 CH 1H 150J-T B
R264 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C41 4030017460 S.CERAMIC ECJ0EB1E102K B
R265 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C42 4030009920 S.CERAMIC C1608 CH 1H 050B-T B
R271 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B C43 4030007050 S.CERAMIC C1608 CH 1H 220J-T B
R272 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) B C44 4030017460 S.CERAMIC ECJ0EB1E102K T
R273 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) B C50 4030017460 S.CERAMIC ECJ0EB1E102K T
R274 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ) B C51 4030007050 S.CERAMIC C1608 CH 1H 220J-T T
R275 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B C52 4030017460 S.CERAMIC ECJ0EB1E102K T
R276 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) B C53 4030017460 S.CERAMIC ECJ0EB1E102K T
R277 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C54 4030007030 S.CERAMIC C1608 CH 1H 150J-T T
R278 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) B C55 4030009650 S.CERAMIC C1608 CH 1H 240J-T T
R279 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) B C56 4030016790 S.CERAMIC ECJ0EB1C103K T
R281 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) T C57 4030016930 S.CERAMIC ECJ0EB1A104K T
R282 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T C58 4030016930 S.CERAMIC ECJ0EB1A104K T
R283 7030003260 S.RESISTOR ERJ3GEYJ 330 V (33 Ω) T C59 4030017730 S.CERAMIC ECJ0EB1E471K T
R284 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) B C60 4030017460 S.CERAMIC ECJ0EB1E102K T
R286 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) T C61 4510006970 S.ELECTROLYTIC ECEV1CA330WR B
R288 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) T C62 4030017460 S.CERAMIC ECJ0EB1E102K T
R289 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) T C63 4030017730 S.CERAMIC ECJ0EB1E471K T
R290 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) B C64 4030017460 S.CERAMIC ECJ0EB1E102K T
R300 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) B C65 4030007130 S.CERAMIC C1608 CH 1H 101J-T T
R304 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B C66 4030017460 S.CERAMIC ECJ0EB1E102K T
R305 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) B C67 4030017730 S.CERAMIC ECJ0EB1E471K T
R340 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B C68 4030007090 S.CERAMIC C1608 CH 1H 470J-T T
R341 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) B C70 4030018020 S.CERAMIC C1608 CH 1H 910J-T T
R343 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B C71 4030008560 S.CERAMIC C1608 CH 1H 300J-T T
R345 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) B C72 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
R346 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) T C73 4030006860 S.CERAMIC C1608 JB 1H 102K-T T
R350 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) B C74 4030006860 S.CERAMIC C1608 JB 1H 102K-T T

M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount

6-2
Downloaded from www.Manualslib.com manuals search engine
 [MAIN UNIT] [MAIN UNIT]
REF ORDER DESCRIPTION M. REF ORDER DESCRIPTION M.
NO. NO. NO. NO.
C75 4030007050 S.CERAMIC C1608 CH 1H 220J-T T C228 4030017460 S.CERAMIC ECJ0EB1E102K T
C80 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C229 4030017460 S.CERAMIC ECJ0EB1E102K B
C81 4030007040 S.CERAMIC C1608 CH 1H 180J-T T C230 4550006820 S.TANTALUM ECST1DX106R T
C82 4030007040 S.CERAMIC C1608 CH 1H 180J-T T C231 4030008680 S.CERAMIC C2012 JF 1C 105Z-T T
C83 4030007050 S.CERAMIC C1608 CH 1H 220J-T T C232 4030016930 S.CERAMIC ECJ0EB1A104K T
C84 4030011530 S.CERAMIC C1608 CH 1H 110J-T T C233 4030016790 S.CERAMIC ECJ0EB1C103K T
C85 4030009650 S.CERAMIC C1608 CH 1H 240J-T T C240 4030017460 S.CERAMIC ECJ0EB1E102K T
C86 4030007000 S.CERAMIC C1608 CH 1H 090D-T T C250 4030016790 S.CERAMIC ECJ0EB1C103K B
C87 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T T C251 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
C88 4030017460 S.CERAMIC ECJ0EB1E102K T C252 4030017460 S.CERAMIC ECJ0EB1E102K B
C89 4030006980 S.CERAMIC C1608 CH 1H 070D-T B C254 4030016790 S.CERAMIC ECJ0EB1C103K B
C90 4030007000 S.CERAMIC C1608 CH 1H 090D-T B C257 4030016790 S.CERAMIC ECJ0EB1C103K B
C91 4030007010 S.CERAMIC C1608 CH 1H 100D-T B C260 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
C92 4030007090 S.CERAMIC C1608 CH 1H 470J-T B C261 4030016930 S.CERAMIC ECJ0EB1A104K B
C93 4030009910 S.CERAMIC C1608 CH 1H 040B-T B C262 4030016790 S.CERAMIC ECJ0EB1C103K B
C94 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C263 4030016790 S.CERAMIC ECJ0EB1C103K B
C95 4030007070 S.CERAMIC C1608 CH 1H 330J-T B C264 4030017780 S.CERAMIC ECJ0EB1E472K B
C96 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C265 4030007150 S.CERAMIC C1608 CH 1H 151J-T B
C97 4030009510 S.CERAMIC C1608 CH 1H 010B-T B C266 4030017030 S.CERAMIC ECJ0EB1A273K B
C98 4030017460 S.CERAMIC ECJ0EB1E102K B C267 4030011810 S.CERAMIC C1608 JB 1A 224K-T B
C99 4030009520 S.CERAMIC C1608 CH 1H 020B-T B C268 4030016930 S.CERAMIC ECJ0EB1A104K B
C100 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C280 4030017480 S.CERAMIC C1608 JB 1A 474K-T T
C101 4030007070 S.CERAMIC C1608 CH 1H 330J-T B C281 4550006140 S.TANTALUM ECST1EY474R T
C102 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C282 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
C103 4030009920 S.CERAMIC C1608 CH 1H 050B-T B C283 4030016930 S.CERAMIC ECJ0EB1A104K T
C104 4030007090 S.CERAMIC C1608 CH 1H 470J-T B C284 4030017460 S.CERAMIC ECJ0EB1E102K T
C105 4030017460 S.CERAMIC ECJ0EB1E102K B C285 4030016930 S.CERAMIC ECJ0EB1A104K T
C106 4030017730 S.CERAMIC ECJ0EB1E471K B C286 4550006200 S.TANTALUM ECST0JY106R T
C107 4030016790 S.CERAMIC ECJ0EB1C103K B C287 4030007150 S.CERAMIC C1608 CH 1H 151J-T T
C108 4030007090 S.CERAMIC C1608 CH 1H 470J-T B C288 4030016950 S.CERAMIC ECJ0EB1A473K B
C109 4030017730 S.CERAMIC ECJ0EB1E471K B C289 4510005370 S.ELECTROLYTIC ECEV1AA221P B
C110 4030017460 S.CERAMIC ECJ0EB1E102K B C300 4030017770 S.CERAMIC ECJ0EB1E332K B
C120 4030016790 S.CERAMIC ECJ0EB1C103K T C340 4030016790 S.CERAMIC ECJ0EB1C103K B
C121 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C341 4030017030 S.CERAMIC ECJ0EB1A273K B
C122 4030007030 S.CERAMIC C1608 CH 1H 150J-T T C350 4030016790 S.CERAMIC ECJ0EB1C103K B
C123 4030007010 S.CERAMIC C1608 CH 1H 100D-T T C351 4030007090 S.CERAMIC C1608 CH 1H 470J-T B
C130 4030009920 S.CERAMIC C1608 CH 1H 050B-T B C352 4030007090 S.CERAMIC C1608 CH 1H 470J-T B
C131 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C360 4030016790 S.CERAMIC ECJ0EB1C103K B
C132 4030007070 S.CERAMIC C1608 CH 1H 330J-T B C361 4030016950 S.CERAMIC ECJ0EB1A473K B
C133 4030017990 S.CERAMIC MCH185A130JK B C363 4030016950 S.CERAMIC ECJ0EB1A473K B
C134 4030009510 S.CERAMIC C1608 CH 1H 010B-T B C364 4030016950 S.CERAMIC ECJ0EB1A473K B
C135 4030017460 S.CERAMIC ECJ0EB1E102K B C365 4030016950 S.CERAMIC ECJ0EB1A473K B
C136 4030017460 S.CERAMIC ECJ0EB1E102K B C366 4030016950 S.CERAMIC ECJ0EB1A473K B
C137 4030009520 S.CERAMIC C1608 CH 1H 020B-T B C367 4030017040 S.CERAMIC ECJ0EB1A333K B
C138 4030017990 S.CERAMIC MCH185A130JK B C368 4030016950 S.CERAMIC ECJ0EB1A473K B
C139 4030007070 S.CERAMIC C1608 CH 1H 330J-T B C370 4030007040 S.CERAMIC C1608 CH 1H 180J-T B
C140 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C371 4030007050 S.CERAMIC C1608 CH 1H 220J-T B
C141 4030009920 S.CERAMIC C1608 CH 1H 050B-T B C372 4030016930 S.CERAMIC ECJ0EB1A104K B
C142 4030007020 S.CERAMIC C1608 CH 1H 120J-T B C373 4030016930 S.CERAMIC ECJ0EB1A104K B
C143 4030017460 S.CERAMIC ECJ0EB1E102K B C374 4030016930 S.CERAMIC ECJ0EB1A104K B
C150 4030017460 S.CERAMIC ECJ0EB1E102K B C375 4030016930 S.CERAMIC ECJ0EB1A104K B
C151 4030007100 S.CERAMIC C1608 CH 1H 560J-T B C376 4030016930 S.CERAMIC ECJ0EB1A104K B
C152 4030016970 S.CERAMIC ECJ0EB1C223K B C377 4030009490 S.CERAMIC C1608 JB 1H 821K-T B
C153 4030017460 S.CERAMIC ECJ0EB1E102K B C378 4030017780 S.CERAMIC ECJ0EB1E472K B
C154 4030006860 S.CERAMIC C1608 JB 1H 102K-T B C379 4030007100 S.CERAMIC C1608 CH 1H 560J-T B
C155 4030011770 S.CERAMIC C1608 CH 1H 060B-T T C380 4030017460 S.CERAMIC ECJ0EB1E102K T
C156 4030006860 S.CERAMIC C1608 JB 1H 102K-T T C381 4030017460 S.CERAMIC ECJ0EB1E102K T
C157 4030016970 S.CERAMIC ECJ0EB1C223K T C382 4030017460 S.CERAMIC ECJ0EB1E102K B
C158 4030017460 S.CERAMIC ECJ0EB1E102K T
C159 4030016790 S.CERAMIC ECJ0EB1C103K T
C160 4030018240 S.CERAMIC ECJ0EB1E562K T J250 6450001910 CONNECTOR HSJ1594-010150 B
C170 4030017460 S.CERAMIC ECJ0EB1E102K B J251 6510021900 S.CONNECTOR BM02B-ASRS-TF T
C171 4030007120 S.CERAMIC C1608 CH 1H 820J-T B
C174 4030017460 S.CERAMIC ECJ0EB1E102K B
C175 4030017460 S.CERAMIC ECJ0EB1E102K B DS240 5040002660 S.LED FY1101F-TR (LED) T
C176 4030017460 S.CERAMIC ECJ0EB1E102K B DS241 5040002660 S.LED FY1101F-TR (LED) T
C177 4030016930 S.CERAMIC ECJ0EB1A104K B DS242 5040002310 S.LED SML-311YTT86 T
C178 4030011810 S.CERAMIC C1608 JB 1A 224K-T B DS243 5040002310 S.LED SML-311YTT86 T
C179 4030007140 S.CERAMIC C1608 CH 1H 121J-T B DS244 5040002310 S.LED SML-311YTT86 T
C180 4030007140 S.CERAMIC C1608 CH 1H 121J-T B DS245 5040002310 S.LED SML-311YTT86 T
C181 4030016930 S.CERAMIC ECJ0EB1A104K B DS246 5030002600 LCD L3-0018TAY-1 T
C191 4030016790 S.CERAMIC ECJ0EB1C103K B
C192 4510004630 S.ELECTROLYTIC ECEV1CA100SR B
C193 4030016790 S.CERAMIC ECJ0EB1C103K B MC250 7700002480 MICROPHONE SKB-2746 LPC T
C194 4030016790 S.CERAMIC ECJ0EB1C103K B
C200 4030016790 S.CERAMIC ECJ0EB1C103K B
C202 4030016930 S.CERAMIC ECJ0EB1A104K B S250 2260001900 SWITCH SW-149 (SKHLLD) B
C205 4030016960 S.CERAMIC ECJ0EB1C183K B S328 2260002710 S.SWITCH SKQLLCE012 B
C206 4030017460 S.CERAMIC ECJ0EB1E102K B
C207 4030016930 S.CERAMIC ECJ0EB1A104K B
C220 4510005430 S.ELECTROLYTIC ECEV0JA220SR B EP1 0910056712 PCB B 6031B
C221 4030016790 S.CERAMIC ECJ0EB1C103K T EP2 6910014690 S.BEAD MPZ1608S221A-T T
C222 4030016790 S.CERAMIC ECJ0EB1C103K T EP3 6910014690 S.BEAD MPZ1608S221A-T T
C223 4030016790 S.CERAMIC ECJ0EB1C103K T EP360 8930057100 LCD CONTACT SRCN-2497-SP-N-W T
C224 4510005430 S.ELECTROLYTIC ECEV0JA220SR B
C225 4030011810 S.CERAMIC C1608 JB 1A 224K-T B
C226 4030016790 S.CERAMIC ECJ0EB1C103K T
C227 4550006710 S.TANTALUM ECST1AX226R B

M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount

6-3
Downloaded from www.Manualslib.com manuals search engine
 [CHASSIS UNIT]
REF ORDER DESCRIPTION M.
NO. NO.
J31 6910014190 CONNECTOR 2497 ANT CONNECTOR

SP1 2510001092 SPEAKER 036D0801B <FG>

W1 8900010960 CABLE OPC-1129

M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount

6-4
Downloaded from www.Manualslib.com manuals search engine
 SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

[CHASSIS PARTS] [ACCESSORIES]

REF ORDER REF ORDER
DESCRIPTION QTY. DESCRIPTION QTY.
NO. NO. NO. NO.
J 31 6910014190 2497 ANT connector 1 EP1 3310002321 Antenna FA-SC55V-1 1
EP2 Optional products Charger BM-95V [AUS] 1
SP 1 2510001092 Speaker 036D0801B <FG> 1 Optional products Charger BC-147A [USA] 1
Optional products Charger BC-147E [SEA] 1
W 1 8900010960 Cable OPC-1129 1 EP4 Optional products Battery BP-224 ACC (700MAH) 1
EP5 Optional products Charger BC-150 1
MP 1 8210020090 2691 front panel assembly 1
MP 2 8310059690 2691 front panel (incl. MP1) 1 MP1 8010018080 Hand strap HK-009 1
MP 4 8930039000 1757 sheet 1 MP2 8930042041 1922 belt crip-1 1
MP 5 8930060730 2691 keyboard 1 MP3 8210028500 2497 top panel [AUS] 1
MP 6 8930058020 2497 PTT button 1 MP4 8930057260 2497 top sheet [AUS] 1
MP 7 8930056960 2497 PTT holder 1
MP 8 8610011151 Knob 2497 BATT lock-1 1
MP 9 8930056941 2497 lock plate-1 Y609A 1
MP 14 8850001950 Shieling washer (Y) 1
MP 15 8830001250 ANT connector-101 nut 1
MP 16 8210018500 2497 top panel 1
MP 17 8930057260 2497 top sheet 1
MP 21 8210018482 2497 rear panel-2 1
MP 22 8930056950 2497 main seal 1
MP 23 8810010120 Screw PH B0 M2x8 SUS ZK 3
MP 24 8810010150 Screw PH B0 2 x 10 SUS ZK 1 EP2 EP4
MP 25 8850001880 Shieling washer (W) 1
MP 31 8010019320 2691 chassis 1
MP 32 8930056980 2497 terminal holder 1
MP 33 8810009560 Screw PH BT M2x6 ZK 2
MP 34 8930060770 2691 A-terminal Y678 1
MP 35 8930056900 2497 B-terminal Y607 1 MP1 MP2
EP1 EP5
MP 36 8810008640 Screw FH BT No.0 M2x4 NI-ZU 2
MP 37 8930056910 2497 C-terminal Y608 1
MP 38 8810009510 Screw PH BT M2x4 NI-ZU 1
MP 39 8810009510 Screw PH BT M2x4 NI-ZU 7
MP 40 8510015970 2691 grounding plate 1
MP 42 8810009560 Screw PH BT M2x6 ZK 2
MP 43 8510015980 2691 main shield 1
MP 44 8930024961 891terminal rubber (A)-1 3
MP 46 8930060780 2691 PW button 1
MP 47 8930060790 2691 PW holder 1

[MAIN UNIT]
REF ORDER
DESCRIPTION QTY.
NO. NO.
J 250 6450001910 Connector HSJ1594-010150 1
J 251 6510021900 S. connector BM02B-ASRS-TF 1

S 250 2260001900 switch SW-149 (SKHLLD) 1

S 328 2260002710 S. switch SKQLLCE012 1

DS 246 5030002600 LCD L3-0018TAY-1 1

EP 360 8930057100 LCD contact SRCN-2497-SP-N-W 1

MC 250 7700002480 Microphone SKB-2746 LPC 1

MP 20 8510014330 2497 VCO case tip 1

MP 21 8510011101 1922 VCO cover-1 Y340A 1
MP 50 8410002370 2337 PA heatsink (tip) Y539 1
MP 360 8210019970 2691 reflector panel 1
MP 361 8930060800 2691 LCD holder 1
MP 362 8930061580 Sponge (HK) 1

Screw abbreviations B0, BT: Self-tapping, ZK: Black

NI-ZU: Nickel-zinc, SUS: Stainless
PH: Pan head, FH: Flat head

7-1

Downloaded from www.Manualslib.com manuals search engine

 MP25 (C) MP24 (C)
NOTE1
MP22 (C)
165 (6 1/2)

MP23 (C)

MP14 (C) MP34 (C) MP44 (C)

NOTE1
MP36 (C)
MP32 (C) MP21 (C)
J31 (C)
MP360 (M) NOTE1

DS246 (M)
136.1 (5 11/32)

136 (5 11/32)
135 (5 5/16)

MP35 (C) MP23 (C)

MP361 (M)
MP33 (C)

MP38 (C)
MP44 (C)
0.3 (1/32)

0.3 (1/32)

EP360 (M) MP37 (C)

56.2 (2 7/32) 36.1 (1 3/32) 4.7 (3/16) MP23 (C)
2.8 (1/8) 58.4 (2 5/16) 2.3 (3/32) 41 (1 5/8) 8.5 (11/32)
MP39 (C)
<A figure of measurement> SP1 (C)
NOTE2 MC250 (M)
UNIT : mm (inch) MP42 (C)
W1 (C) MP39 (C) NOTE4
MP46 (C) MP40 (C) MP9 (C)
NOTE1 A MP31 (C)
MP39 (C) B
MP15 (C) MP47 (C)
NOTE1
MP8 (C)
MP362 (M)
MP16 (C)
MP43 (C)
NOTE2 NOTE3
MP17 (C) MP21 (M) Once the 2497 PTT button (MP6 (C)) or
MP4 (C) The glue must be applied to the
MP39 (C) areas when the front panel is the 2497 PTT holder (MP7 (C)) is
MP42 (C)
replaced with new one, to ensure removed, the glue must be applied
water tightness. between the 2497 PTT button or the
Manufacture : Semedain Co. 2497 PTT holder and 2691 front panel.
Type : Super-X

MP6 (C)
MP7 (C) MP2 (C)
NOTE3 Front side Rear side
NOTE3 NOTE2
MAIN unit
MP39 (C)
Speaker MP6 (C)
MP7 (C)
MP5 (C)
NOTE2

Window
NOTE1 Plate
Once the following parts are removed, a O ring or sealing must be replaced
MP1 (C) with new one before reattachement.
NOTE4
MP42 (C)
Mother part . . . . . . . . . . . . . . . . . . Daughter part for relayted replacement
J31 (C) Antenna connector . . . . . . MP14 (C) Sealing washer 9-key A : For IC-M2A only
MP24 (C) Screw . . . . . . . . . . . . . . MP25 (C) Sealing washer B : For IC-M32 only

NOTE: The MP31 (C) is a common

parts for IC-M2A and IC-M32. Need to
screw the MP42 (C) to the B location
for IC-M32.
<Rear view of the front panel>

UNIT abbreviations (C): CHASSIS PARTS, (M): MAIN UNIT

7-2

Downloaded from www.Manualslib.com manuals search engine

 ¢ BC-150 CHARGER PARTS LIST
¡ELECTRICAL PARTS

[CHARGE UNIT]
REF. NO. ORDER NO. DESCRIPTION MP1(C)
R1 7070001130 RESISTOR 120 ERG2SJ
R2 7070001140 RESISTOR 150 ERG2SJ
R3 7010007100 RESISTOR 1K PSD1/4V

J1 6510023070 CONNECTOR HEC2305-01-250

DS1 5040001390 LED TLG124A

EP1 0910054642 PCB B-5787B

¡MECHANICAL PARTS
[CHASSIS]
REF. NO. ORDER NO. DESCRIPTION QTY. CHARGE unit
MP1 8510014350 2523 Case 1
MP2 8110007680 2523 Cover 1
MP1 (CH)
MP3 8810008660 Screw B0 3 x 8 NI-ZU (BT) 2
MP4 8930047830 Leg cushion (C) 2 MP2 (CH)

[CHARGE UNIT]
REF. NO. ORDER NO. DESCRIPTION QTY. MP2 (C)
MP1 8930057120 2523 Terminal 1
MP2 8930057120 2523 Terminal 1

[ACCESSORIES] MP4 (C)

REF. NO. ORDER NO. DESCRIPTION QTY.
MP4 (C)
MP1 8810001460 Screw A0 3.5 x 20 SUS 2
MP3 (C)
Screw abbreviations A0, B0, BT: Self-tapping
NI-ZU: Nickel-zinc
SUS: Stainless NOTE: (C): CHASSIS (CH): CHARGE UNIT

¢ BC-150 VOLTAGE DIAGRAM ¢ BC-150 BOARD LAYOUT

¡TOP VIEW
16.4V (No load) 16.4V (No load)
13.0V (Charge) 8.0V (Charge)

MP1
R3
J1 R1 120 VCC
HV DS1
GND
R2
GND
R2 150 MP2
MP1
+ R1 –

B5787B
R3 1 k J1
DS1 TLG124A
¡BOTTOM VIEW
9.9V (No load)
16.4V (Charge)
MP2
GND

7-3

Downloaded from www.Manualslib.com manuals search engine

 SECTION 8 SEMI-CONDUCTOR
PARTS LIST INFORMATION

• TRANSISTOR AND FET’S

2SA1588 GR 2SB1132 Q 2SC2714 Y 2SC4213 B 2SC4215 O
(Symbol: ZG) (Symbol: BAQ) (Symbol: QY) (Symbol: AB) (Symbol: QO)
B B B B B
C C C C
C
E E E E

2SC4226 R25 3SK299 U73 DTA144 EUA DTC144 TU UN911 H

(Symbol: R25) (Symbol: U73) (Symbol: 16) (Symbol: 06) (Symbol: 6P)
B G1 S B B B
C
C C C
E
G2 D E E E

XP6501 AB RD01MUS1 RD07MVS1

(Symbol: 5N) (Symbol: K2) (Symbol: RD07MVS1)
C1 D
E1 G
E2 B1 S D S G G
S
B2 C2 D S
(Bottom view)

• DIODES
1SS375 1SV307 DA221 TL HVC376B TRF HVU350 B
(Symbol: FH) (Symbol: TX) (Symbol: K) (Symbol: B9) (Symbol: B0)
A A

C A A C A C

C C

MA2S077 MA728 MA77 RB706F-40 T106

(Symbol: S) (Symbol: 2A) (Symbol: 4B) (Symbol: 3J)
A
C A A C A C

8-1

Downloaded from www.Manualslib.com manuals search engine

 SECTION 9 BOARD LAYOUTS

The combination of this page and the next page shows

MAIN UNIT the unit layout in the same configuration as the actual
• TOP VIEW P.C. Board.

SP1

Mic
TAG TAG 9 + –
16

GND

CLONE
MONI U/I/C DUAL
SQL CH/WX SCN
SPO

DS246 MIC
AFOUT

VOL VOL LOCK

– + H/L

9-1

Downloaded from www.Manualslib.com manuals search engine

 The combination of this page and the previous page
• BOTTOM VIEW
shows the unit layout in the same configuration as the
actual P.C. Board.

MIC
MC250

– +

GND
J250 CLONE

SPO

MIC AFOUT

ANT

9-2

Downloaded from www.Manualslib.com manuals search engine

 SECTION 10 BLOCK DIAGRAM

CHASSIS MAIN UNIT ANTENNA

J1

REF OSC D50, D51: D52, D90:

21.250 MHz Q21, Q22: 2SC4226 Q23: Q24: Q50: Q53: Q54:
VCC 2SC4215 2SC4215 MA77 2SC4226 RD01MUS1 RD07MVS1 1SV307
D22, D23: HVU350B

HV
X1 PLL IC LOOP BUFF BUFF TX/RX BUFF
PRE PWR ANT
LPF
CR-766 FIL SW DRIVE AMP SW
IC1: µPD3140GS

D80:
FCON

RB706F
UNLK

T5V
Q20: DTC144EUA
D20: MA2S077 MOD PWR
BTYPE MUTE R5V
D21: MA77 DET

D91: Q351:
Q25: 2SC4215 IC50: NJM2125F RB706F DAT144EUA
MODC

GND
PLLO
BUFF VCO BPF APC
CTRL PWR DET T5V
TX
MUTE SW

2ND LO 450 kHz FI170:

BPF CFWM450E
SP
FI150: FL-368 D92: MA77
Q151: FI151: FL-363 Q90:
2SC2714 Q150: D130: MA77 2SC4226 D93: MA728
3SK299
DET IF DET IC IF BPF BPF RF
BPF LPF
IC170: TA31136FN AMP AMP

21.7 MHz
BPFS

450kHz
POWER POWER SW RSSIV

NOISV
X170
CDBC450CX24 PCON

FCON
PCON
SQLO
SQLI

MODC

Q230: 2SB1132
PWSW

Q231: XP6501 VCC

TXMS
AFVS AF D/A IC
REG IC190: M62363FP
VOLO

VOLIN

BEEPO

BEEP

Q280: 2SC4213 VCC VCC

SPO IC280:
TA7368F Q223: DTC144EU
AF OUT AF AF Q224: XP6501
DE-ENPHA
EXT CLONE
AMP MUTE Q225: 2SB1132 IC220:
NJM2870F05
JACK 5V
CPU5V TDETV
MIC AFMS REG CPU
5V 5VS 5V
GND
BTYPE

IC200D: IC200C: DS246:

NJM2902V NJM2902V (7.9872MHz) L3-0018TAY-1
Q350: DTC144TU
D350: DA221 X361
LPF LPF Q221: IC341: CSTCR7M98G53
IC200A: 2SA1588 BD5242FVE
BUFF NJM2902V
J250 R5V CPU
LIMIT RESET

LCD
REG RESET IC360:
CLOUT/CLIN

AMP R5 R5VS
M37560M8A-700GP

WXTV
IC200B:
NJM2902V ATIS

MIC PRE
ENPHA AMP
Q220:
2SA1588
V5V LED
SW LED
REG
V5 V5VS
Q240: DS240, DS241: FY1101F
DTC144EUA DS242, DS243, DS244, DS245: SML-311YTT86
IC260: TC4W66F
MOD Q222:
2SA1588
PTT SW PTT
ANALOG SW IC T5V
CONT REG
DET T5 T5VS
PTT
PTT

Q250:
UN911H
KEY
DETM

MICM

BEEP
EEPROM

IC340:
PWSW BR24L16FV
CLOUT/CLIN NOTE: Explanatory notes
COMMON LINE TX LINE
PTT
RX LINE RX LINE

TX LINE COMMON LINE

10 -1

Downloaded from www.Manualslib.com manuals search engine

 SECTION 11 VOLTAGE DIAGRAM

MAIN UNIT

5V
5V
DET DET
MOD MOD
RSSIV RSSIV
C261 R203 R207 VOLIN VOLIN
R201
0.1 15 k 1.2 M 27 k BEPST BEPST
R377 R378 R379 NOISV
82 k 82 k 82 k NOISV
BEPO BEPO
5V C202 R206 BEEP
0.1 18 k BEEP
R251 R260 R261 1.90V C377 C378 C207 VOLO VOLO
470 12 k 3.9 k 820 P 0.0047 0.1 AFV AFV
R212 R213
1.5 k 68 k

R205 R204 R376 C205 R214 C206

8.2 k 4.7 k 100 k 0.018 15 k 0.001 C282 C283 C284
R263 10 0.1 0.001
R288
C251 C260 R262 100 k 220 k B
10 10 1.8 k C
CPU5V CPU5V
R289 IC280 CPU5V
150 k
TA7368F
1 NC POUT 10 DS246
R277 2 VCC PWGND 9 L3-0015TAY-1
100 k 3 8 R374 R373 R372 R371

SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
R256 R202 NC PREGND 68 k 100 k 100 k 100 k SEG0 1
18 k 100 k
IC200 4 VIN PHASE 7
2
SEG0
Q250 SEG1 SEG1
NJM2902V 5 RIPPLE NF 6
SEG2 3
UN911H SEG2
1 14 R284 R283 SEG3 4 SEG3
R274 10 33 SEG4 5
2 13 390 k SEG4
3 12 R276 SEG5 6 SEG5
C263
5V 4 11 180 k 0.01 C289 C288 C286 C287 SEG6 7 SEG6
PTT C373 C374 C375 SEG7 8
5 10 220 0.047 10 150 P SEG7
C376 0.1 0.1 0.1 SEG8 9
6 9 AFOUT COM0 SEG8
0.1 C379 COM1 SEG9 10
7 8

CPU5V
R275 SEG9
NOISV
RSSIV

56 P
10 k BEEP COM2 SEG10 11 SEG10
R367 SEG11 12 SEG11
C360 13
0.01 470 k SEG12 SEG12
C250 R250 R375 C257 C200 SEG13 14
0.01 100 k 6.8 k 0.01 0.01 VOLIN SEG13
SEG14 15 SEG14
C268 C267 SEG15 16 SEG15
R279 SEG16 17
820 0.1 0.22 SEG16
SEG17 18
RSSIV

SEG17
NOISV

TDETV

BATTV
BTYPE
TXMS

100
C254 R253 R255 SEG18 19 SEG18

99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
0.01 2.2 k 150 k C280 SEG19 20 SEG19
MIC R271 R272 R290 0.47 R286
33 k 33 k SEG20 21 SEG20
180 k 10 k

VL1
C1
C2
VL2
VL3
COM0
COM1
COM2
COM3
AVSS
VREF
VCC
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
WDECV SEG21 22 SEG21
CP250
MC250 C265
Q280 COM0 23 COM0
SKB-2746 LPC
IC260 150 P R281 2SC4213 B COM1 24 COM1
TC4W66F COM2 25 COM2

CPU5V
R273 33 k
LCDS

DETO 1 8 5V 18 k C367 C363 C365 C364

DETIN 2 7 DETM C262 0.033 0.047 0.047 0.047
0.01 R258
MICM 3 6 MICO
C252 R252 4.7 k R257 C264 C266 R282 C281 C285
4 5 MICIN R278 RSSIV 1 75 SEG13
0.001 33 k 4.7 k 0.0047 1k 0.027 10 k 0.47 0.1 P67/AN7 SEG13
NOISV 2 74 SEG14
P66/AN6 SEG14
BATTV 3 73 SEG15
P65/AN5 SEG15
PTTSW TDETV 4 72 SEG16
TEMPV P64/AN4 SEG16
TEMPV 5 71 SEG17
DETM P63/SCLK22/AN3 SEG17
C366 SCK 6 70 SEG18
P62/SCLK21/AN2 P30/SEG18
0.047 SDATA 7 69 SEG19
R300 WDECV P61/SOUT2/AN1 P31/SEG19
8 68 SEG20
ATIS 6.8 k P60/SIN2/AN0 P32/SEG20
ATIS 9 67 SEG21
P57/ADET/DA2 P33/SEG21
LEDS 10 66
P56/DA1 P34/SEG22
S250 TXMS 11 65
R264 P55/CNTR1 IC360 P35/SEG23
R265 C300 C361 WET BEEP 12 64
100 k 100 k P54/CNTR0 P36/SEG24
0.0033 0.047 PLST 13
P53/RTP1 M37560M8A-700GP P37/SEG25
63
DAST 14 62
5VS P52/RTP0 P00/SEG26
MICM 15 61
P51/PWM1 P01/SEG27
16 60 R366
C350 CP350 CP351 CP352 P50/PWM0 P02/SEG28
0.01 17 59 47 k
ESCK P47/SRDY1 P03/SEG29
18 58
CLOUT P46/SCLK1 P04/SEG30
19 57
CP253 CP255 CLIN TXD P05/SEG31
20 56
CHEXT RXD P06/SEG32 VOLUP
21 55
PWSW PWSW P43/TOUR P07/SEG33
R350 22 54 DETM
UNLK R360 1 k UNLK P42/INT2 P10/SEG34
470 k 23 53 MICM
J250 AFOUT ESDA P41/INT1 P11/SEG35
CP353 CP354 CP355 R361 1 k 24 52 AFVS
HSJ1594-010050 SCK P40 P12/SEG36
CLONE CLONE CLONE 25 51 R5VS
P77 P13/SEG37
SPO SPO SDATA R363 1 k
AFOUT AFOUT R346
MIC MIC 10 PLST R362 1 k CP361
CP252 BTYPE
GND GND
DAST R364 1 k
CPU5V
P15/SEG39
P14/SEG38
P70/INT0

CP251 D350 R352

XCOUT

CP254 ESCK
RESET

XOUT

DA221 15 k
XCIN

R345
VSS
P76
P75
P74
P73
P72
P71

P27
P26
P25
P24
P23
P22
P21
P20
P17
P16
XIN

470 k ESDA
J251
BM02B-ASRS-TF
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50

R353 WET
4 1 SPO SPO 1k
CPU5V CPU5V
TDEC

GND Q350
3 2
DTC144TU C372
SP1 R351 0.1 R305
036D0801B 1k 47 k
CP360
S320 S323 S329 C340 RESET X360
R340 R341 CSTCR7M98G53-RC
16 H/L 0.01 10 k 10 k
SCAN C351 C352 IC340
S328 47 P 47 P BR24L16FV-WE2 R304
47 k
1 8 R343
A0 VCC
S324 2 7 100 k C370 C371
S321 S325 A1 WP ESCK
3
A2 SCL
6 IC341 18 P 22 P
UP CH/WX VOLUP 4 5 ESDA BD5242FVE-TR
T5VS

VSS
BPFS

SDA C368
V5VS

0.047
1 5
VOUT VDD
S322 S327 S326 2
SUB 7.9872 MHz : 3.10 Vp-p
3 4
DOWN SQL VOLDOWN CT GND

C382 C341
0.001 0.027
VOLDOWN

CH/WX

DOWN
SCAN

Explanatory notes
CLOUT
PWSW

DETM

AFMS

SQL
MICM

PTT
CLIN

H/L

AFMS
UP

16

+B LINE
TX LINE
RX LINE
MAIN UNIT

11 - 1

Downloaded from www.Manualslib.com manuals search engine

 A
PLST
TEMPV

DAST
UNLK

SCK
SDATA

5V
DET
MOD
RSSIV TXMS
5V 5V
VOLIN
C191 VCO CIRCUIT VCC
BEPST
0.01 R1 R6 T5V T5V T5V
NOISV R8 R9 1k R7
47 k 3.58V 1k 10 47 k

VCC
BEPO

T5V
TEMPV MP20 V5V V5V R53 R54
BEEP 100 33
1
VOLO R32 R76
C1 R2 R10 2 R31
390
Q351
AFV 2.2 k 680 150
0.1 100 k 3
C52 R55 L50 DTA144EUA EP2 EP3
C50 T5V
0.001 0.001 3.3 k 0.1µH
CP1 C6
C10 C11 C29 C31 R29 R30 C36 L23 R33 L24
0.047 2.2 0.001 0.001 0.001 390 0.001 39 k
68 k 0.1µH 0.1µH
R22 L21 L22 C32
1.5 P R386 C381 C61 C62 R72 L53 C63 C67 C68
560 2.7µH 80 nH C38 C40 C73
10 k 0.001 33 0.001 47 18 nH 470 P 470 P 47 P L58
0.001 15 P 0.001 2.7 µH
B X1 Q23
R3 R4 C3 CR-766 C37 R52
C
FCON 10 k 47 k 220 P 0.3 P 2SC4215 Y 4.7 k
CPU5V Q20 R26 C39 Q50 L55
DTC144EUA 8.2 k 12 P 2SC4226 R25 31 nH
C4 R5 C5 C72 L80 C74 L81 L82
C2 D1 Q21 C54 L56 L57 C80
HVC376BTRF
18 P 330 15 P C24 C25 C26 Q54 8.5 nH 22 nH 0.001 50 nH 0.001 0.001 30 nH 32 nH CP80
0.01 2SC4226 R25 15 P
0.1 0.001 47 P R100 C51 RD07MVS1 ANT
5V
C33 R34 Q24 1 22 P
IC1 R23 D21 220 P R28 C35 470 2SC4215 Y L51 Q53 D52
C84 C89
1k MA77 1SV307
µPD3140GS 180 0.001
D50 R56
82 nH RD01MUS1 C65
11 P 7P
L20 MA77 100 P
1 20 82 nH 1.2 k R380
VCC1 GND1 D20 MP50
2 19 R27 15 k
IN1 IN2 MA2S077 C75 C71 C81 C82 C83 C85 C86 R80
PLST 3 18 8.2 k C41 R35 L25 R384 C70
ENB VCC2 5W TX : 3.02V 22 P 9P 82 k
SCK 4 CLK XB 17 R20 MOD Q22 0.001 68 k 0.1µH 2.2 k C58 1W TX : 2.33V
22 P 91 P 30 P 18 P 18 P 24 P
SDATA 5 16 100 2SC4226 R25 C53 R57 C55 0.1 R71
DATA XI L1 R50
6 15 R25 C34 1k 0.001 82 24 P 100
T1 XO 6.8µH R24
UNLK 7 14 100 k 100 k 1.5 P
LOK GND2 C43 R73
8 13 C42 R75
CP1 CP2 22 P R67 1k 100
9 FI1 FI2 12 5P 100 k
10 11 C7 C8 C9 C12 D51 T5V
FO1 FO2 C20 C21 C22 C27 C28 C30 D22 D23 R69
0.01 2P 2P 0.001 0.001 9P 9P 39 P 0.001 0.001 HVU350B MA77 R65 15 k D91
HVU350B
150 k
IC50 RB706F
Q25 5 R68
PCON 1 NJM2125F 100 R382
2SC4215 Y 4 2.7 k
2nd Lo 3
R66 C56 C57 C59 R70 C64 R74 C66 C380
2 C60
47 k 0.01 0.1 470 P 15 k 0.001 10 k 0.01 0.001 5W TX : 2.29V
0.001
1W TX : 0.65V
PCON PCON
MODC MODC RX 3.21V
MOD R381 R81
RSSIV RSSIV R96 10 k C99 C97 C96 L91 C94 C92 L90 C87 22 k
2P TDETV
NOISV NOISV R170 R5V 220 1P 12 P 82 nH 12 P 47 P 50 nH 0.5 P
390 RX : 3.57V R36 C44 R383
R5V 1k 0.001 12 k
C110 C109 C105 R94 D92 R115 C88 R82
C150 R120 C120 0.001 470 P L95 0.001 33 k MA77 47 0.001 10 k
R5V R150 D80
FI170 C170 0.001 2.2 k 0.01 0.1µH D353 [M31]
IC170 100 RB706F
CFWM450E R173 0.001 MA728
R90 L92 C95 C93 C115 D90 C91 C90
1 2 1.5 k TA31136FN C171 C160
R93 10 k 82 nH 33 P 4P 0.001 1SV307 10 P 9P
82 P 0.0056 C104 C102 L94 C100
1 16 R171 C108 1k 47 P 12 P 80 nH 12 P [M31] T5V
34 5 2 OSCIN MIXIN 15
OSCOUT GND 1.2 k 47 P
3 14 RX : 4.20V R91 C98
MIXOUT N-REC L121 L120 C121 1k 0.001
4
VCC N-DET
13
56 nH 82 nH 0.001 RX : 0.79V Q90
C181 5 12 1st Lo VCC VCC
0.1 6 IFIN RSSI 11
L130 C131 2SC4226 R25
DEC IFOUT 82 nH 12 P C103 C101 L93
7 10 D93 33 P 7.5 V
FILOUT QUAD 5P 80 nH
C179 8 9 MA728
R176 FILIN AFOUT C153 C152 R151 L150 C151 R121 L122 C123 C122 C130 C107 C106 R95 VCC
120 P X170 C133 C132
6.8 k 0.001 0.022 3.3 k 0.82µH 56 P 10 k 4.7µH 10 P 15 P 5P 0.01 470 P 100 CP241
R172 CDBC450CX24 13 P 33 P
SDATA

MODC
PCON

FCON
DAST

470 CH16 RX : 4.96V

SCK

DET CH88 RX : 0.00V GND

5V

C240
R174 0.001 CP240
220 k
C178 C177 C176 C175 C174
0.22 0.1 0.001 0.001 0.001 BPFS
T5V T5V
R175 C180
47 k 120 P Q150 5V 5V
3SK299 C142 C140 L133 C138 C137 C134
DET DET C154 2P R240 R241 R242
12 P 12 P 80 nH 13 P 1P
0.001 VCC 100 680 680
Power Save OFF : 5.00V Back-Light ON : Back-Light ON :
V5V
R5V

AF Mute OFF : 3.91V 3.82V

R5V 7.48V
BEPST BEPST Q225 Q230
D130
MA77 2SB1132 Q 2SB1132 Q
RX : 0.91V 5V VCC AFV DS240 DS242 DS244
SQLO C143 R134 R133 C141 C139 L132 R130 L131
82 nH Power Save OFF : 4.96V RX : 4.96V TX : 4.93V FY1101F-TR SML-311YT SML-311YT
0.001 120 10 k 5P 33 P 80 nH 10 k R385 1 k
VOLO
VOLIN C194 R227
0.01 10 k 4.98V DS241 DS243 DS245
5V 1 5 R233 R235
R155 CTRL VIN 2.2 k 330 k FY1101F-TR SML-311YT SML-311YT
1.5 k 2
GND
6

3 4
R193 IC190 NB VOUT R230 Q231
470 M62363FP-650C Q220 Q221 Q222 Q224 27 k XP6501 AB
2SA1588 GR 2SA1588 GR XP6501 AB IC220 Q240
2SA1588 GR
6

1 VIN1 VIN8 24
R152 C224 R228
C226 NJM2870F05 DTC144EUA CP245
FCON 2 VOUT1 23 C159 R156 R154 C158 C157 0.01
VOUT8 1.5 k 22 22 k
1

PCON 3 VPUT2 22 0.01 470 100 k 0.001 0.022 CPU5V

VOUT7 R220 R222 R224
4 VIN2 VIN7 21
5 VDD 20 10 k 10 k 10 k
GND R131
DAST 6 LD 19 R231 C231
1

RESET 1k R226 C225 C227 C228 C229 C230 R245

SCK 7 CLK 18 BPFS 1M 1 1k
VDAREF R221 R223 R225 2.2 k 0.22 22 0.001 0.001 10
SDATA 8 DI DO 17
4.7 k 4.7 k 4.7 k Q223 C233 R236
9 VIN3 VIN6 16 SQLI FI151 FI150 R232 C232 R234 150 k
R192 0.01
390 MCON 10 VOUT3 VOUT6 15 SQLO
RX : 1.45V
C156 R153 FL-363 21R15AB DTC144EU 1K 0.1 3.3 k
BEPO 11 14 BEPST 0.001 1.5 k
VOUT4 VOUT5
BEEP 12 VIN4 VIN5 13 BEEP
C220 C221
AFVS

C222 C223
+

C192 R194 C193 Q151 C135 R132 C136 22 0.01

100 k 0.01 0.01
0.001 10 k 0.001
R5VS
V5VS

0.01
T5VS

10 2SC2714 Y AFV
5VS

LEDS
C155
6P BPFS LEDS

BEPO 5V
BEEP BEEP

BTYPE

TDETV
BATTV

TXMS
AFV AFV AFV AFV
B
C
CPU5V CPU5V CPU5V CPU5V
Explanatory notes
+B LINE

MAIN UNIT TX LINE

RX LINE
COMMON LINE

11 - 2

Downloaded from www.Manualslib.com manuals search engine

Downloaded from www.Manualslib.com manuals search engine
 S-14008MZ-C2
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan © 2003 Icom Inc.
Downloaded from www.Manualslib.com manuals search engine