S A F E T Y D ATA S H E E T

METACAULK® C70
INDUSTRIAL CABLE COATING
Industrial strength coating for power cables

S ectio n 1 – P ro duct and C o m pa n y I nfor m atio n

Product Name HMIS Codes

Metacaulk® C70 Industrial Cable Coating Health 1
Flammability 1
Product Codes
50250, 50253 Reactivity 0
PPI B
Chemical Family
Organic/Inorganic

RectorSeal, LLC
2601 Spenwick Drive
Houston, Texas 77055 USA Emergency Telephone No.
Chemtrec 24 Hours
Date of Validation
(800)-424-9300 USA
January 23, 2020
(703)-527-3887 International
Date of Preparation
Technical Service Telephone No.
September 19, 2011
( 800)-231-3345 or (713)-263-8001

S ectio n 2 – H a z ar ds I den tificatio n

GHS CLASSIFICATION
Physical Hazards:
None
Health Hazards
Acute Toxicity:
Oral: Not Classified
Dermal: Not Classified
Inhalation: Not Classified
Skin Corrosion/Irritation: Not Classified
Serious Eye Damage/Eye Irritation: Not Classified
Respiratory or Skin Sensitization: Not Classified
Germ Cell Mutagenicity: Not Classified
Carcinogenicity: Not Classified
Reproductive Toxicology: Not Classified

Page 1
 METACAULK® C70 INDUSTRIAL
CABLE COATING

Target Organ Systemic Toxicity - Single Exposure: Not Classified

Target Organ Systemic Toxicity - Repeated Exposure: Not Classified
Aspiration Toxicity: Not Classified
ENVIRONMENTAL HAZARDS
Hazardous to the Aquatic Environment: Not Classified
Acute aquatic toxicity: Not Classified
Chronic aquatic toxicity: Not Classified
Bioaccumulation potential: Not Classified
Rapid degradability: Not Classified
GHS Label elements, including precautionary statements
Pictogram: None
Signal Word: None
Hazard Statements:
None
Precautionary Statements:
P102 - Keep out of reach of children.
P264 - Wash hands thoroughly after handling.
Summary Of Acute Hazards
May cause skin irritation.
Route Of Exposure, Signs And Symptoms
INHALATION
Spray applications of this material may create aerosols, which may be irritating to the upper respiratory tract,
nose, and throat.
EYE CONTACT
Contact may cause eye irritation.
SKIN CONTACT
Contact may cause skin irritation.
INGESTION
Possible irritation to mucous membranes of the mouth, throat, and stomach.
SUMMARY OF CHRONIC HAZARDS
None known.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
Persons with pre-existing skin conditions or chemical allergies may be more susceptible to contact effects of
the cured elastomer.

S ectio n 3 – C o m positio n /I nfor m atio n on I n gredien ts

Ingredient: Aluminum oxide

Percentage by weight: 10-25
CAS Number: 1344-28-1
EC#: 215-691-6

Page 2
 METACAULK® C70 INDUSTRIAL
CABLE COATING
Ingredient: Zinc borate
Percentage by weight: 1-5
CAS Number: 1332-07-6
EC#: 215-566-6

S ectio n 4 – F irst A id M e asures

If inhaled: Not a respiratory irritant.

If on skin: Wash with soap and water. If irritation occurs, seek medical attention.
If in eyes: Immediately flush with large amounts of water. If irritation occurs, seek medical attention.
If swallowed: If swallowed, call a physician immediately. Only induce vomiting at the instruction of
a physician. Never give anything by mouth to an unconscious person.

S ectio n 5 – F ire F ig h tin g M e asures

Extinguishing Media
Foam, dry chemical, carbon dioxide or water fog.
Special Fire Fighting Procedures: Wear self-contained breathing apparatus (SCBA) and other protective clothing.
Hazardous decomposition products possible (see Section 10).
Unusual Fire And Explosion Hazards: None known.

S ectio n 6 – A c ciden ta l R ele ase M e asures

Steps To Be Taken In Case Material Is Released Or Spilled: Wipe up spills to prevent footing hazard.
Avoid flushing into sewers, drains, waterways and soil. Wear protective clothing during clean up.

S ectio n 7 – H a n d lin g and S tor age

Precautions To Be Taken In Handling And Storing: Keep container closed and upright when not in use.
To prevent freezing and possible rupture of container, do not store below 35°F.
Other Precautions: Avoid prolonged or repeated contact with skin or clothing. Empty containers may contain
residues and vapors; treat as if full and observe all product precautions. Do not reuse empty containers.
KEEP OUT OF REACH OF CHILDREN.

Page 3
 METACAULK® C70 INDUSTRIAL
CABLE COATING

S ectio n 8 – E xposure C o n tro l s /P erso n a l P rotectio n

Ingredients Units
Aluminum oxide
ACGIH TLV 10 mg/m3 (TWA)
OSHA PEL 10 mg/m3 (TWA)
Zinc Borate
ACGIH TLV N/D
OSHA PEL N/D
Respiratory Protection (Specify Type): None required.
Ventilation − Local Exhaust: Acceptable.
Special: N/A
Mechanical (General): Preferable.
Other: N/A
Protective Gloves: Wear rubber gloves.
Eye Protection: Safety glasses (ANSI Z-87.1 or equivalent)
Other Protective Clothing Or Equipment: Coveralls recommended.
Work/Hygienic Practices: Where use can result in skin contact, wash exposed areas thoroughly before eating,
drinking, smoking, or leaving work area. Launder contaminated clothing before reuse.

S ectio n 9 – P h ysica l and C h emica l P ro perties

Boiling point: > 212°F (100°C)

pH: 8-10
Specific gravity (H20 = 1): N/D
Vapor pressure (mmHg): N/D
Melting point: N/D
Vapor Density (Air = 1): >1
Evaporation rate (Ethyl Acetate = 1): 1
Appearance/Odor: Liquid
Solubility in water: Soluble
Volatile Organic Compounds (VOC) Content
(theoretical percentage by weight): 6 g/L
Flash point: None
Lower explosion limit: N/D
Upper explosion limit: N/D

Page 4
 METACAULK® C70 INDUSTRIAL
CABLE COATING

S ectio n 10 – S ta bilit y and R e activit y

Stability: Stable
Conditions To Avoid: None.
Incompatibility (Materials To Avoid): None known.
Hazardous Decomposition Products: CO, CO2 and fragmented hydrocarbons.
Hazardous Polymerization: Will not occur.

S ectio n 11 – Toxic o lo gy I nfor m atio n

Chronic Health Hazards

No ingredient in this product is an IARC, NTP or OSHA listed carcinogen.
Toxicology Data
Ingredient Name
(No data availble unless listed below)

S ectio n 12 – E c o lo gica l I nfor m atio n

Ecological Data
Ingredient Name: (No data available unless listed below)
No data available for product.

S ectio n 13 – D isposa l C o n sider atio n s

Waste Classification: Non-regulated waste.

Disposal Method: Solidification and approved landfill.
Waste from this product is not considered hazardous as defined under the Resource Conservation and Recovery
Act (RCRA) 40 CFR 261. Dispose of in accordance with federal, state, and local regulation regarding pollution.

S ectio n 14 – Tr a n sportatio n I nfor m atio n

DOT: Non-regulated
Ocean (IMDG): Non-regulated
Air (IATA): Non-regulated
WHMIS (Canada): Non-regulated

Page 5
 METACAULK® C70 INDUSTRIAL
CABLE COATING

S ectio n 15 – R egu l atory I nfor m atio n

Regulatory Data
Ingredient Name: Aluminum oxide
SARA 313 Yes
TSCA Inventory Yes
CERCLA RQ N/A
RCRA Code N/A

Ingredient Name: Zinc borate

SARA 313 Yes
TSCA Inventory Yes
CERCLA RQ 1,000 lbs.

S ectio n 16 – O t h er I nfor m atio n

This document is prepared pursuant to the OSHA Hazard Communication Standard (29 CFR 1910.1200).
The information herein is given in good faith, but no warranty, expressed or implied is made.
Consult RectorSeal for further information: (713) 263-8001

Page 6