SCHEMATIC DIAGRAMS

CD RECEIVER
KD-R370K KD-R470K KD-R471E
KD-R471H2 KD-R471M KD-R471MM2
KD-R471R2 KD-R472E KD-R473MM2
KD-R474E KD-R476M KD-R477Q
KD-R670K KD-R671E KD-R671M

i
m
jo

(No.MA612<Rev.002>)1/26
■ PRECAUTIONS ON SCHEMATIC DIAGRAMS
z Due to the improvement in performance, some part numbers shown in the circuit diagrams
may not agree with those indicated in the Parts List.
z The parts numbers, values and rated voltage etc. in the Schematic Diagrams are for
reference only.
z Since the circuit diagrams are standard ones, the circuits and circuit constants may be
subject to change for improvement without any notice.

■ PRECAUTIONS ON PARTS LIST

z The parts identified by the symbol are critical for safety. Whenever replacing these parts, be sure to
use specified ones to secure the safety.
z The parts not indicated in this Parts List and those which are filled with lines --- in the Parts No.
columns will not be supplied.
z P.W. BOARD Ass'y will not be supplied, but those which are filled with the Parts No. in the Parts No.
columns will be supplied.
z When ordering chips, screws etc., place bulk orders (unit of tens) whenever possible to improve
shipping efficiency.

i
z There are cases where the actual implemented parts in the sets and the service parts are different.
When ordering parts, make sure to refer to the Parts List.
m
■ PRECAUTIONS ON SERVICE
Certain parts of the power circuits and the GNDs differ according to the models. Care must be
taken for the following points as the differences are indicated separately in the LIVE GND ( ) and
the ISOLATED (NEUTRAL) GND ( ).
jo
1. Do not touch the LIVE GND, or do not touch the LIVE GND and the ISOLATED (NEUTRAL)
GND at the same time. It may cause an electric shock.
Before pulling out the chassis or other parts, make sure to pull out the power cord from the
wall outlet first.
2. Do not short circuit between the LIVE GND and ISOLATED (NEUTRAL) GND, or never
measure the LIVE GND and ISOLATED (NEUTRAL) GND at the same time using measuring
instruments (oscilloscope, etc.). It may blow fuses or damage other parts.

■ DEVIATION TOLERANCE RANGE 

DEVIATION TOLERANCE RANGE
F G J K M N R H Z P
+30% +50% +80% +100%
± 1% ± 2% ± 5% ±10% ±20% ±30%
-10% -10% -20% -0%

(No.MA612<Rev.002>)2/26
BLOCK DIAGRAM (1/2) (SIGNAL BLOCK)
FUSE J471 BEEP J321
CN990 IC301 FLOUT RLOUT J600
FZB10BT-100 FROUT RROUT
MEM SXI PWIC_STBY
(10A)
JAC K PWIC_MUTE DC_ERR2 ANT
POWER AMP IC
FL+&FL - JACK
DC POWER CONNECTOR SXM_PWR
SXI_G
SXI_R FR+&FR- OFFSET
SXM_DA_SYS RL+&RL - FLOUT
SXI_L
RR+&RR- FROUT
RLOUT
ACC EXT ANT GND
RROUT
RL/SUBR
RR/SUBR

PWIC_MUTE ILLUMINATION TEL MUTE OE REMOTE

LINE OUT

SXM_DA_SXM
SXM_DA_SYS
CIRCUI T
REMOTE JUMPER
Q470 , Q471
ANT. AUTO
LEVEL MUTING
*FOR M ONLY TEL MUTE OE REMOTE
SHIFTER DIMME R
LINE_MUTE FLOUT
FROUT
IC901 SXM_DA_SYS RLOUT
RROUT
LINE MUTE DIM_I N TEL_MUTE OE_REMOTE RL/SUBR

MUTE
E_MUTE

RESET
RR/SUBR

FLAG_REG
EXT
1

IC601
ACC
6
OFFSET
IC161 TUNER
FLOUT
SXI_G FROUT
SXI_R RLOUT RL/SUBR
REGULATOR IC SXI_L RROUT RR/SUBR

E-VOLUME
E_MUTE

i
TU. R SCL_EE T SDA_EET
TU. R TU. L
TU. L

FLAG_REG

m
DC_ERR1 F-AUXL CD. R
F-AUXR SCL_EET SDA_EET CD. L
F-AUXG

SCL_REG
SDA_REG

IC861 FREQ_SEL

DC-DC SCL_EET SDA_EET

SDA_EET
FLAG_REG

TEL_MUTE
IC841
SDA_REG
SCL_REG

DC_ERR1

DC_ERR2

SCL_EET
DIM_IN

RESET
MUTE

EEPROM IC
SPBIO0
SPBIO1
IC891

HSS USB

/O C
PON_USB

IC411

IPOD IC
jo BEEP

PWIC_MUTE
PWIC_STBY

SXM_PWR
SXM_DA_SYS

SXM_DA_SXM

FREQ_SEL
PON_USB

SCL_IPOD

SDA_IPOD
IC701

MICON
SPBIO2
SPBIO3

SPBCLK
SPBSSL

NRST
MDATA
ML D
IC821

MCLK
FLASH IC

IC851

M_SRDATA_CD
LDO_1.25V
CD
PASSIVE
LPF

CD. R
CD. L

IC540
VT1
VT2
MD
VF1
VF2

LD
TVD
SPL

CD MECHA
CD LSI

CN502 (24PIN)
VREF

FFC CABLE
STAT BLKCK

CN1 (24PIN)
BCL K FOD
CD_SRDATA_ M
LRCK TRD
D+
D-
IC941
PON_CD
LDO_3.3V
ENC1 BU33TD3W G
ENC2
PON_PANEL OE_REMOTE
LCD_CE
LCD_CL K
PON_PANEL PAN_DET STAGE 1/STR_REMO1
Q701 LCD_DATA_LC D STAGE 2/STR_REMO2
SW1
LCD/RGB_DATA_SYS
PANEL3.3V SW2
PSW
SW
DRV_MUTE
DRV_LO_EJ
DRV_CNT

LCD/RGB_DATA_SYS
LCD_DATA_LC D
LCD_CL K
LCD_CE
ENC2 F-AUXL RESET
D+ ENC1 F-AUXR
D- REMO F-AUXG PAN_DET
*FOR OEM/DOP ONLY IC831
CN702
OEM/DOP RESET IC
PANEL CONNECTOR
RC

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)3/26
BLOCK DIAGRAM (2/2) (SUPPLY BLOCK)
CN990 FUSE J471 J321 J600
FZB10BT-100
MEM14.4V SXI
IC301
MEM
(10A)
JACK ANT
POWER AMP IC
JACK
DC POWER CONNECTOR
7 21
ACC EXT ANT GND

GND2 VCC1 VCC2

LINEOUT

JUMPER
CIRCUIT
REMOTE Q470 , Q471
ANT. AUTO
LEVEL
*FOR ASIA AREA(M) ONLY MUTING TEL MUTE OE REMOTE
SHIFTER DIMMER

IC901
GND
9

EXT
1
0.35A 200mA
15
SW3.3V IC601
0.45A VDDA_IFADC
ACC VDDA_RF
6
VDD
TUNER
AU9V/12V
IC161
VCC1 4
0.25A
8

REGULATOR VCC
24
5
CD8V
35mA E-VOLUME
IC 1.3A

i
GND2

VCC2
7
ILM10.5V
3 COMMENT:
0.3A
Lineout = 2.5V E'VOL VCC = 8.5V

m
Lineout = 4.0V E'VOL VCC =11.5V.

V6IN VDD3.3V
13 11
0.35A

IC861
VCC DC5.2V
VCC
2 DC-DC 3
2A 2mA

1
IC841
PVCC 60mA EEPROM IC
AVCC 4mA
AVREF 4mA

VIN
1
IC891

COMMENT:
HSS USB

HSW OCP ADJUSTED = 1.3A

3
VOUT
1A

IC411
IPOD IC
jo VCC

7.5mA
IC701

MICON VCC
PLLVCC
115mA
VOUT
IC821

FLASH IC

IC851
LDO_1.25V
VCC

25mA

VIN
200mA

STBY
CD
PASSIVE
LPF

AVDD1

IC540
CD3.3V

15mA
1

CD MECHA
CD LSI

FFC CABLE
106mA
IC941

CN1 (24PIN)
CN502 (24PIN)
VIN
LDO_3.3V VOUT RFVDD1
200mA RFVDD2
IOVDD1
IOVDD2

Q701 CD8V
1.3A
PANEL3.3V
CD8V
SW

VDD

USB5V ILM10.5 PANEL3.3V

*FOR OEM/DOP ONLY IC831
CN702
CN701 RESET IC
OEM/DOP
PANEL CONNECTOR
RC

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)4/26
 MAIN PWB ASSY(1/3) (XJ1-092x-xx) Except KD-R471R2
ANT

SW_R/RR_R
*J470

SW_L/RR_L
J600 TL56
(SXI.L) T1
QNZ0907-001
T3
QNB0356-001

RR_R

FR_R

RR_L

FR_L
TL472 T2 1 2 3 T6
TL57
(SXI.R) T4 T7
TL476 *J321
TL475 T5
4 5 6 7
T9
! IC301
JCV8034

PWGND1

PWGND2

PWGND3

PWGND4
T8 8 9 10 T10

ACGND
TL480

RSB6.8SM-X
RSB6.8SM-X
RSB6.8SM-X

RSB6.8SM-X

MUTE
VCC1

VCC2
STBY
TAB1

TAB2
*RA470

OFFDET

SVR
DZ2J068M
TL50 TL51 11 12

IN2

IN4
10

OUT2+

OUT1+

OUT3+

OUT4+
*R471

*R472
*C472

OUT2-

OUT1-

OUT3-

OUT4-
SGND
100

100
*D478

*D470
(TU.R) (TU.L) 1/16W 0.1u

IN1

IN3
*D477
*D479

*D480
*D481

CD

8
1 3 5 7 9 11 13 15 17 19 21 23 25 27

?R609
?R1011

?R610

0V
TU.R 2 4 6 8 10 12 14 16 18 20 22 24 26
RSB6.8SM-X
TU.L ?C1004 *R253
0

?C1003
14.4V

14.4V
3.3V

7.0V
3.3V
7.0V

7.0V

7.0V
7.0V
6.8V
6.9V

6.9V
6.9V
7.0V
7.0V

7.0V

7.0V
3.3V
7.0V

3.3V
10V

10V

10V
1u

1u

1u

220
F0K-0010-00

*R483
?D601 ?D602

0V

0V

0V

0V

0V

0V
TL625 GND3 TL340 ?C340 ?C350 TL320 ?C320 ?C330 TL260 ?C260 ?C250 TL250

VA600

4.7k
V

*R482
C1600

!
X600 R611
100

*C475

*C473

*C474
0.1u QAX0969-001Z SCL_EET

16V ?C305

?C306
*R476

F321
22k
5.0V TL350 TL330

3.3V

1.5V
1.5V
3.3V

3.0V
?R612
?R608 ?R607 9.216MHZ

82p

C1320
0.1u
C1604

C1605
0.1u
R260

180
*R250
180

180

180
*R340

180
*R320
C312

0.1u
180

*R350
0V

0V
0V

*R330
C1603 TL44 C368

1.0u
0V *Q471 (AC)

?C622
0.1u *Q470

?C623

?R606

XTAL_IN 32
VSS 31
DAC_L 30
DAC_R 29
GPIO_0 28
GPIO_1 27
GPIO_2 26
SCL 25
LTC043TEB-X

C303

C304
47u
GND6 LTC014EEBFS8
TL624 1u *R341 *R351 *R321 *R331 R261 *R251
C619 3.2V
0.1u 22k 22k 22k 22k 22k 22k
0V

?C307

?C308
?C621
C618

5.1
R601
0.1u 0V

R303
3.3V 3.0V 100 SDA_EET
TL58

17 18 19 20 21 22 23 24
1
(SIG) VDDA_IFADC SDA GND4
C617 0V 0V

R262
!

330

330

330

330

330

330
*R343

*R353

*R323

*R333

*R252
2
L607 0.22u VSSA_IFADC VSSD_IO C603

SXM_RX_M

M_TX_SXM
2.6V 3.3V

SXM_PWR

?C309

?C310

0V

0V

0V

0V

0V

0V

0V

0V

0V
3
1.2V VBGP IC601 VDDD

RR+
FR+

RL+
RR-
SXI_AG

FL+
SXI_AR

FR-
C615 0.15u 0V

RL-
SXI_AL

FL-
1.5V 0.1u

C611
1p
C612 TEF6657HN-X

L606
120n

4
33p C614 0.01u 1.2V FM_CAP VSSD
22p C616 1.5V 0V

4.7u

4.7u

4.7u

4.7u
4.7u

4.7u
5
L605 1000p 1.2V FM_IN_M I.C.

LTC043TEB-X
0.22u
0.22u

0.22u
0.22u

LTC043TEB-X
LTC043TEB-X
LTC043TEB-X

LTC043TEB-X

LTC043TEB-X
0V

!
0.22u 1.5V C369

6
FM_IN_P I2S_SD_1 MODEL LIST
4.7u 6.3V

OFFSET

SDA_EET

SCL_EET

E_MUTE

RLOUT
FLOUT
RR/SUBR
RL/SUBL

FROUT
RROUT
3.3V 0V

R304

47k
7
VDDA_RF I2S_BCK

R302

*C321

*C331
2.2k

22k

*C341

*C351

C261

*C251
R273
C609 0V MODEL NO. UNIT NO.

*Q320
*Q350

*Q330

*Q250
*Q340

Q260
AM_LNA_CAP
0V

DR_Q_DATA
8
R605 0.1u VSSA_RF I2S_WS

C316
C317

C319
C318
DR_I_DATA

0V

0V

0V
4.7 C610 C1601

DA2J101
I2S_SD_0
12p YJ1-0540-10

AM_IN_P
LTC043TEB-X

DR_BCK

D273
XJ1-0920-10 KD-R370K

PWIC_MUTE
DR_WS
YJ1-0540-11

DR_BL
XJ1-0920-11 KD-R470K 4.7K

GND
0.1u

1u
1u
1u
1u
1u

PWIC_STB
YJ1-0540-22

DC_ERR2
100

100

RR/SUBR
XJ1-0920-21 KD-R471M

RL/SUBL
C602 YJ1-0542-71

OFFSET
0
0

RROUT

RROUT
XJ1-0922-71 KD-R471E

FROUT

FROUT
RLOUT
RLOUT
FLOUT

FLOUT
L603 YJ1-0544-11

BEEP
XJ1-0920-21 KD-R471H2

?C172
C171
*C170
*C169
*C168
C167
0.1u YJ1-0540-23

33
10u YJ1-0542-72 XJ1-0920-22 KD-R471MM2

10
11
12
13
14
15
16
9
R602 YJ1-0540-24 XJ1-0922-71 KD-R472E

R170

R168
R169

*R167
C608 ! 0.85V C601 YJ1-0542-73 XJ1-0920-22 KD-R473MM2
R600

1V 0V

0V
0V
0V
0V
0V
0V
L604 1000p C607 82 0V XJ1-0922-71 KD-R474E
YJ1-0540-21 LTC024EEB-X

FLG_REG

RESET

E_MUTE

MUTE
YJ1-0543-81 XJ1-0920-21 KD-R476M
1k 1/8W 10u XJ1-0923-81 KD-R477Q 22K
1.0u L601 C605 YJ1-0580-10 XJ1-0920-12 KD-R570K

L602
1p YJ1-0580-21

0.47u

L600

4.7u
4.7u 1000p C1602 R271 XJ1-0920-23 KD-R571M 22K
YJ1-0582-71 XJ1-0922-72 KD-R571E
YJ1-0580-22

3.3V
R604

R603
C624 C606 XJ1-0920-24 KD-R571MM2

1M

1M
0.1u 9p C604 TL45 0.1u 330 YJ1-0583-81 XJ1-0923-82 KD-R577Q

*5.75V
*5.75V
*5.75V
*5.75V
*5.75V
*5.75V
*5.75V
*11.5V
?C1050 ?R1050 1500p (PIN10) ?C600 YJ1-0590-10 XJ1-0920-13 KD-R670K

3.3V
3.3V
3.0V
3.0V
8.5V
3.3V
4.0V
4.0V
4.0V
4.0V
4.0V
4.0V
4.0V
YJ1-0590-21 XJ1-0920-25 KD-R671M

0V

R1071
YJ1-0592-71

BAW56-TP-X
XJ1-0922-73 KD-R671E

0
LTA024EEB-X

100k

?D272
R270
YJ1-0690-10 XJ1-0920-14 KD-R775SK 22K

LINE MUTE
28 27 26 25 24 23 22 21 20 19 18 17 16 15 Q270 P.IC MUTE

D270
GND2 LTA024EEB-X

QD1L *WINTCL
SE3R *WINTCR
C100

WININ
DCERR
SDA
SCL
VCC
MUTE
WINTC
OUTLF
OUTLR
OUTRR
OUTRF

QD2G OUTSWL
QD2ROUTSWR
GND
22K
0.1u C103
AUX-G

3.3V
1u *IC161 3.3V
4700p

4700p
C101

C102

R100 0V
R103

R104
47k

47k

LTA024EEB-X
*MUTE
*QD2R
QD1G

QD2G
QD1R

CREF
SE1R

SE2R

QD2L
0V

SE1L

SE2L

SE3L
D101 470 C104 AUX-R 3.3V

BAW56-TP-X
3.3V

Q273
RSB6.8SM-X ?C1020 10K LTA014YEB-X
1u 1 2 3 4 5 6 7 8 9 10 11 12 13 14

D271
D100 C105 AUX-L Q272 47K

R171

10k

0V
RSB6.8SM-X R1070 LTC024EEB-X

3.3V
3.3V
3.3V
3.3V

3.3V
3.3V
3.3V

3.3V
3.3V
3.3V
3.3V

3.3V
3.3V
1u 3.3V
?C1021
1k Q271
22

GND1 LSAR523UBFS8

?R161

*R164 ?R163
?R1067

10u
16V
TL52

C177
1u
C161

C162
C163
4.7u

C164
4.7u
(AL)
20

1u

1u

35V

35V
F_AUXL TL60
(AG)
19

*R162
F_AUXG

0
TL53

i
(AR)

?C1053

C165
18

F_AUXR TL61
MAIN PWB:J7J-0020-**

DC_ERR1
(USBGND)

E_MUTE
17

SXI_AG
SXI_AR
GND

SXI_AL
AUX-G
AUX-R
TL07

AUX-L
CD.R
TU.R
(P33)

CD.L
TU.L
16

PANEL3.3V TL62 1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER

(ILM) WITHOUT INPUT SIGNAL
15

ILLUMINATION
TL63 LCD/RGB_DATA_SYS CONDITION---FM MODE. AM MODE ( )CD MODE.
14

LCD_DATA_SYS R709
TL64 3.3k LCD_CE 2. UNLESS OTHERWISE SPECIFIED.
13

LCD_CE
TL65 LCD_DATA_LCD ALL RESISTORS ARE 1/10W 5% METAL GLAZE RESISTOR.
12

LCD_DATA_LCD *R1043
TL66 RGB_CLK ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.

m
0
11

USB_GND 3.3V ALL RESISTANCE VALUES ARE IN OHM.

TL67 LCD_CLK

To SWITCH PWB ASSY

10

LCD_CLK TL24 PON_PANEL 0V 3. COMPONENTS WITH ? IN FRONT INDICATE NOT USE

?R1022

(GND1)
9

USB_GND

LCD_DATA_LCD

MUTE

DRV_MUTE

SPBIO3

SPBIO2
SPBIO1
SPBIO0
SPBSSL

SPBCLK

SPBIO2
SPBIO1
SPBSSL

SPBIO3
SPBCLK
SPBIO0
TL68 ENC2

(XJ6-055x-xx) Q701
8

ENC2
TL69 D+ LTA014YEB-X
3.3V
7

D+ DIM_IN 3.2V Q360

TL70 ENC1
Except KD-R471R2 LSCR523UBFS8
6

ENC1

TL716
TL71 D- R361 R362
5

D- TL15 ?R1007

R820
47k

47k
CN1
LCD_INH 0V

R822
47k
R821
47k
R421
(5V) 33k 22k
4

USB5V

C360

4.7k
REMO2
REMO1

R363
1u
TL72 TL360 0V
IPOD

3 GND

0.01u
3

USB5V

C361
R360

D360
22k
*R1006
TL73 REMO

DZ2J068M
0 *IC411
2

REMO TL18 L826

MFI337S3959-X

2
1

4.7k
PAN_DET ?CN702

R364
(PDET) LB73G0CK-001
1

PAN_DET
TL49 TL48 TL47
(IP4) (IP3)
4.7k

4.7k

4.7k

(IP2)
*R412
*R414

*R413

TL46
R717
100k

4700p

?C821
21

47k
47k

C820

?C822
(IP1)

NQR0713-001X
NQR0713-001X
NQR0713-001X
NQR0713-001X
RA701 !
CN701

LB73G0BK-006
0V NC4 47k

?R780
?R781
NQR0713-001X
5

R744
R743

F2
NC5 1/16W
QGZ2006J1-20

C1033
4700p
SCL_IPOD *R411 3.3V 0V

LB73G0BK-006
4700p
4700p
4700p

*C1035

R1045

NC3
*C1022
4700p

C1023
4700p

4700p

470p
*C723
*C724

*C722

2.2k
6

0V 3.3V

L827
R371 12k

L701
SCL VCC

LB73G0CA-002

(ASEMD) (TRST)

8
100 3.3V SDA 3.3V CS

TL38 TL37
TL36
(TCK)
7

RST 1.5V HOLD[IO3] 3.3V D370

L824
*R410

DEBUGGING

7
GND1 SDA_IPOD 3.3V 0V ?D701 C370 0.1u
1/4W
R719

GND DO[IO1] BAW56-TP-X

910

L825
8

1.5V 0V
R745

VCC CLK

(TMS)
0.1u
100

TL35

6
C713

C711
4700p
*C410 0V WP[IO2] 1.5V ?D702
0.1u DI[IO0] R370 68k

TL34

5
TL33 (TDI)
GND TL370 R372

L823
L822
L821
L820
?C780 TEL_MUTE (TMUTE) 10k

C712

(ASEBRK)
0.1u

TL39
?R1714

(TDO)
W25Q16DVSSIG
IC821 ?C781
0V(3.3V)

TL29
(WP)
TL23
TL31

(HOLD) TL26
TL22
TL30
(DO)
(CS)
FLASH ?R782
1.8V

TL907 (VCC2)
1.25V

1.25V
3.3V

3.3V

3.3V

3.3V

1.5V
1.5V
1.5V

3.3V

3.3V
3.3V
3.3V
1.2V
1.2V

TL09 (TU33)

TL04 (AUD)
0V

0V

0V

0V
0V
0V

0V

0V

TL05 (VDD)

TL11 (EXT)

TL10 (ANT)
TL17 (FLG)

TL02 (ILM)
TL03 (CD)
?R783 !

TL14 (V6)
(CLK)
(DI)
90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 IC901

?R784

?R785

TL901

TL902
LV5685PV-H
NC
LCD_DATA_LCD
NC
NC
Vcc
MUTE
Vss
NC
PVcc
DRV_MUTE/DEBUG_2C
MD_BOOT
MD_CLK
Vcc
SPBIO3
Vss
SPBIO2
SPBIO1
SPBIO0
SPBSSL
Vss
SPBCLK
PVcc
AUDIO_X1
AUDIO_X2
TCK
TMS
TD1
TD0
ASEBRKAK/ASEBRK
TRST
SW1
SW2 14.3V

1
SCL_EET EXT
PSW R746

jo 3.0V
91 E2P_SCL AVref 60
3.3V

2
SDA_EET 4.7k 3.0V 3.3V ANT
DRV_MUTE R747 92 E2P_SDA AVcc 59 C710 TL708 10.5V

3
SCL_IPOD 4.7k 3.3V 0V 0.1u *11.5V ILM
DRV_LO_EJ 93 IPOD_SCL AVss 58 8.5V

4
SDA_IPOD 3.3V 3.3V DC_ERR1 AUDIO
DRV_CNT R763 94 IPOD_SDA DC_ERR1 57 7.0V
*R735

5
SCL_REG 4.7k 3.3V 1.5V TEL_MUTE TL08 CD
BCLK R764 95 REG_SCL TEL_MUTE/LINE_MUTE 56 (SW33) 6.0V
*R734 ?R373

6
SDA_REG 4.7k 3.3V * SK34A-L-X ACC
LRCK R748 96 REG_SDA Stage1 55
*R733
SW3.3V D903 13.9V

7
PON_CD 4.7k (3.3V)0V * VCC2
CD_SRDATA_M ?R366 97 CD_DSP_SW Stage2 54 D902 14.1V
*R732

8
DIM_IN 3.2V VCC1
M_SRDATA_CD R365 98 DIM_IN NC 53 R731 ?Q931 SK34A-L-X 0V

9
FLG_REG 100k 3.3V 0V(3.3V) 47k PSW GND
NRST ?R765 99 FLG PSW 52 R730 ?R931 SCL_REG 3.3V

10
SCL

?R930

R1091
0V 3.3V 47k R729
BLKCK 100 Vss ASEMD 51 3.3V

0
C716 R728 15k

11
0.1u 3.3V 0V 22 D+ VDD
STAT 101 PVcc ! D+O 50 SDA_REG 3.3V

To MAIN PWB ASSY(2/3) R726

12
MLD (3.3V)0V 0V 22 D- SDA

?C931
MLD 102 MLD
IC701 D-O 49 5.1V

?Q930

13
BCLK R749 R750 100 (0V)0V 3.3V R727 V6IN
MDATA 47k 103 BCLK PVcc 48 C709 15k ?R932 FLG_REG R905 3.3V

(XJ1-092x-xx)
R761 0.1u

14
MCLK
LRCK 47k
R751 47k
R752 100 (0V)0V
104 LRCK R5S726A0D216FP Vss 47
0V C708
10p 100 3.3V
FLG

15
CD_SRDATA_M R754 10 (0V)0V 0V *C1051 TU3.3V
CD.R 105 CD_SRDA_M Vss 46

Except KD-R471R2 CD.L

M_SRDATA_CD R753 1k (0V)0V
106 M_SRDA_CD XTAL 45
1.6V
R725 12MHz
220p

R724
1M
R762 0V 1.6V 3.3k C707

100u 6.3V
PON_CD 107 Vss EXTAL 44 10p

0.1u 50V

?C1052
*C1054

470u 16V

0.1u 50V
0.022u
L709 X701

22u 16V
MCLK 47k R1064 (3.2V)0V 1.25V L7J-0060-00

1u 10V

1u 10V
1u 10V
1u 10V

1u 10V

0.22u
0.01u
AGND 10 C717 108 MCLK Vcc 43 C706 R722 R723
NQR0713-001X 47k PAN_DET *IC891
0.1u 1.25V 0V 0.1u 910 BD2242G-G
CD8V L710 109 Vcc PAN_DET 42 TL28
MDATA R1065 (2.0V)0V 1.25V (RST2)
HSS_USB
MGND 110 MDATA PLLVcc 41

*R1051
10 C705 L700 TL27

?C930
?C913

?C915

?R1052
C905
0
5.2V 5.1V

C390
C909
C911
C914
C904
0.1u

C908
NQR0713-001X

C903
NQR0713-001X 0V

C916

C907
C906
C912
(RST1) OUT

6
DCDC5V 111 NC Vss 40 R721 *C892 IN
47k RESET ?R1090 0V 0V
3.3V 3.3V 0.1u ILIM

5
CD_GND *3.2V 112 PVcc RESET 39

2.2k
0.1u
C718 GND
SXM_PWR 0.1u 0V 0V ?C1002 PON_USB 3.3V OC 3.3V

16k
_0.5%
3

4
113 SXM_PWR Vss 38 C1900

6.8k
6.8k

R901
47k
C704 EN

R903

1/4W
R902

1/4W
1/4W
0V 0.1u 0.01u

C1901
114 Vss NC 37

470p
DRV_CNT (0V)0V 3.3V ?R401
TL705 ? C1090
115 DRV_CNT PVcc 36
RGB_CLK/PCB_TEST_MODE_RX

MBRX130
*C891
R720

?C890
?R904

*R890

*R892
BEEP SW1 REMO

D390
0V 3.3V(3.3V) 47k *C893
116 BEEP SW1/DEBUG_2A 35 R756 *R894
DRV_LO_EJ NQR0713-001X STAT 0 10u R900
(0V)0V 0V(3.2V) R755 47k D400 47k
117 SERIAL_NO_MODE/DRV_Lo/Ej STAT 34 R716 *R402 RB521SM-30-X 1/4W

1k
R757 47k 3.3V 3.3V 2.2k 2.2M REMO
LCD/RGB_DATA_SYS

118 PCB_TEST_MODE REMO 33 *R403 TL01 L990

SW2 (3.3V)3.3V 3.3V
R714
1k 20k ENC1 DCDC R1080 D861 (MEM) QQR1927-001 REMOTE OUT *R381
0

D401
119 DEBUG_2B/FIELD TEST 2/SW2 ENC1 32
SXM_DATA_SXM
SXM_DATA_SYS

R758 47k R712 R715

DZ2J051M
BLKCK ENC2

R400
(0V)0V 3.3V 1k 2.2k

D990
120 BLKCK/FIELD_TEST_1 ENC2 31 R713 R850 0 DB22306 C990
PANEL_PON

PWIC_MUTE

M_CLK_LCD

TL06

1N5401-BPC04
DEBUG_1C

FREQ_SEL
M_CE_LCD

DEBUG_1A
DEBUG_1B

0
FREQ_SEL

2.2k 2200u
PWIC_STB
USB_PON

(V1.25)

MBR0530-X
DC_ERR2

1/4W
LCD_INH

16V
R760 TL717 TL43

0.22u
NRST

47k C852

?C392

C391
PVcc

PVcc

PVcc

C870

4.7k
(TM) C851 TL16 TL40

D391
R390
100u

1/4W
1.25V
Vss

Vss

Vcc

Vss

Vcc

Vss

IC861

4.7u
NC

NC

NC

NC

15p

10u
6.3V 0.47u MP9942AGJ (FB) (FB1)
R840

?R866

68k
_0.5%
R865
SDA_EET 100 3.0V 0V 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 R864
SDA GND
5

4 5 FB 0.792V 39k
R841
3.3V

3.3V
(3.3V)0V
0V
0V
3.3V
3.3V
0V
0V
2.0V
1.25V
0V
0V
3.3V
3.3V

0V

1.25V
3.3V
0V
*3.2V
0V
0V
0V
0V

3.3V
1.6V
0V

8
SCL_EET 3.0V 0V C868 PG

NC

VOUT
SCL

BU1CTD3WG
A2
6

10u

10u
14.0V 4.8V

0.1u L861
100 150u VCC
LDO_1.25V

L860

7
0V 0V

39k_0.5%
18k _0.5%
6.3V IN
C1000
4700p

WP A1
7

5.2V EN/SYNC 1.6V TL25

IC851
C869

6
3.3V 0V
?R1000
?R1001
?R1002

VCC A0 SW R861 0.22u (GND2)

8

0V

?C865

10u

10u
9.8V

C867
0.1u

C866
BST
0.047u

C700
0.1u

C701

C702
0.1u

C703
0.1u
C840

STBY

5
TL19

?R862
GND
GND

VIN
20 (A.ANT)

*C1010
470p
*C1011
470p
*C1012
470p
*C1013
470p
*C1014
470p
*C1015
470p
*C1016
470p
*C1017
470p
?C1001

C863 TL21

?D862
R1861

?R1860

C862
C860

C861
1/4W
3 2 1 0.22u (OE)

0
IC841

0V

R867
TL20

R868
C864
R707

0.1u
1.6k

3.3V

3.3V
BR24T02FJ-W-X
?R718

(REM)
100k
*R470

EEPROM C850
TL995
0.47u

RR+
FR+
RR-
FR-
RL-
FL-
RL+
FL+
18 17 16 1 15 2 14 3 13 4 12 5 11 6 10 7 9 8

C1034
*R705
10k

RESET
1.6k

2.2k
4.7k
1.6k

GND7
1.6k

?R708
R701

R711
R702
R703

R704

4700p
TL702

MEMORY
GND
DIMMER
ACC
TEL MUTE
*REMOTE/P-CON
OE REMOTE
*ANTENNA
REAR RIGHT (+)
FRONT RIGHT (+)
REAR RIGHT (-)
FRONT RIGHT (-)
REAR LEFT (-)
FRONT LEFT (-)
REAR LEFT (+)
FRONT LEFT (+)
F901
FUSE 10A
TL703
TL704

FZB10BT-100
IC831
GND7 R830
100
BU4228F CN990
TL42 TL41
QNZ0607-001
LCD/RGB_DATA_SYS

(RXM) (TXM)
0V 3.3V
1

GND RST
4

0.1u

0.1u
C832

C831

3.3V 1.7V * POWER CORD ASS'Y

PON_PANEL

PWIC_MUTE

VDD CT
SXM_RX_M
M_TX_SXM

FREQ_SEL
PWIC_STB

6800p
PON_USB
DC_ERR2

RGB_CLK

C830
LCD_CLK
LCD_INH

LCD_CE

RESET

2
NRST

S830
QSW0648-001Z

! Parts are safety assurance parts.

When replacing those parts make
sure to use the specified one.

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)5/26
 MAIN PWB ASSY(2/3) (XJ1-092x-xx) Except KD-R471R2

! Parts are safety assurance parts.

When replacing those parts make
sure to use the specified one.
R542
SPL 22k

C544
0.01u
R541
5.6k MAIN PWB:J7J-0020-**
R544 1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
TVD 18k
2. UNLESS OTHERWISE SPECIFIED.
C545 R543
0.01u 5.6k ALL RESISTORS ARE 1/10W 5% METAL GLAZE RESISTOR.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
R546
TRD 10k ALL RESISTANCE VALUES ARE IN OHM.
3. COMPONENTS WITH ? IN FRONT INDICATE NOT USE
C546
6800p
TL557 TL542 TL543
R548
FOD 12k

C547
TL545 6800p

CN502 ?C542
QGF1040F1-24 C548
4.7u C541
VF2 0.1u
24
C549
CD3.3 0.1u ?C543
23
VT2 C550
22 0.15u C540
?C582 PSW 0.1u M_SRDATA_CD
21
SW1 SW1
20

1.6V

1.5V
3.3V
1.6V
1.6V
1.8V
1.6V

1.5V
1.5V
SW2 SW2

0V
0V

0V
0V
0V
0V

0V
19
LD PSW
18 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
VT1 DRV_MUTE

CTRCRS
VREF
OSCIN
FOP
TRP
TRVP2
TRVP
SPOUT
PC
FG
DVSS1
DVDD1
IOVDD1
NC_7
NC_6
NC_5
SRVMON1
SRVMON0
PMCK
SMCK
17
MD DRV_LO_EJ
16 C552 ?C551
VF1 6800p DRV_CNT
15
0V 0V BCLK
14 R550 21 RFVSS1 DQSY 80 L777
CD8V VT2 2.2k 1.8V 0V NQR0713-001X BCLK LRCK
13 R551 22 E GIO2 79 L778
VT1 2.2k 1.8V 0V NQR0713-001X LRCK CD_SRDATA_M

i
12 23 F GIO1 78
To CD MECHA PWB ASSY 11
DRV_MUTE VF1 1.8V
24 D GIO0 77
0V
R567
100 CD_SRDATA_M M_SRDATA_CD

(LVA20106-01A) 10
?C581
FOD
TRD VF2
1.8V
1.8V
25 B NSRVMONON 76
3.3V
3.3V
C579
0.1u
?C580
NRST
BLKCK
TL544
CN1 9
8
VREF R554 1.8V
26 C
27 A
IOVDD2 75
X1 74
1.5V C577 X540 STAT To MAIN PWB ASSY(1/3)

R573
?C575 10p L7J-0093-00

1M
DRV_LO_EJ MD 2.2M
7 ?C554
0.1V
28 PD X2 73
1.6V R572
1k
C578
10p
16.9344
MLD
(XJ1-092x-xx)

m
TVD 2.3V ! 0V MDATA
6
5
TL504 SPL
C553
0.1u
C555
3.2V
29 LD
30 RFVDD1
IC540
MN6627553APA
DVSS2 72
NRST 71
3.3V
R571
10k
R570
100 NRST MCLK Except KD-R471R2
?C585 C576 R569
DRV_CNT 0.022u 1.9V 0V 0.1u 1k BLKCK CD.R
4 C556 31 CENV BLKCK 70 ?R568
MGND R556 3300p 1.7V 3.2V STAT CD.L
3 4.7k 32 RFENV STAT 69
MGND 1.2V 3.3V MLD PON_CD
2 C557 33 RFOUT MLD 68
1.8V

Q540 MDATA AGND

CD8V 2SA2188/E/-X TL546 0.33u 1.8V 2.0V
1 34 RFIN MDATA 67
1.0V 3.3V MCLK CD8V
C558 35 ARFDC MCLK 66
TL540 4.7u 1.2V RA580 MGND
36 ARFOUT TX 65
3V

C559 470 1/16W

TL547 0.1u 1.2V 0V DCDC5V
C560 37 ARFFB FLAG 64 TL553
C561 680p 1.6V 0V CD_GND
R557 TL503 10u 38 ARFIN TEST 63
4.7 3.3V
1/4W 39 NC_39 NTEST2 62 L574
0V 1.5V
40 RFVSS2 DVDD2 61
NQR0713-001X
C573 ?C574

RFVDD2
PLLFO2

LSPWM
AVDD1
0.1u

AVSS1
PLLFO
NC_41

NC_51
OUTR
VCOF

OUTL

CSEL
DSLF

EXT4
EXT3
EXT2
EXT1
EXT0
PLLF
IREF
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

0V
1.5V

0V
1.4V

0.5V

3.3V

0V
1.6V

1.6V
3.3V

0V

0V

0V
1.4V
0.8V
1.6V

2.7k
82k

820
R562

R558
R559

jo C510
470p
0.015u

0.082u
1000p

1000p
0.33u
C564

C568
C562
C563

C565
C567
0.1u

0.1u
C570
TL55

TL548
(CD.R)

TL54
(CD.L)
C571
0.1u
C572
10u
L540

TL549
NQR0713-001X
?C586

TL550
TL551
R589

820

R590

820

TL552
C583
820p
C584
820p
R579

2.2k

R580

2.2k
C588
680p
C589
680p
CD.R

CD.L

LDO3.3_CD
R1029
0

1/4W
C1028
4700p

R940

1/4W
10
TL13
(CD33)
IC941
BU33TD3WG
R587
22 3.3V 5.1V
VOUT VIN

1
0V
GND

2
(3.3V)
NC STBY

3
C942
10u

10u
C940
C941
1u
No.MA612 created date:2016-03-03
(No.MA612<Rev.002>)6/26
MAIN PWB ASSY(3/3) (XJ1-092x-xx) Except KD-R471R2
DIFFERENT TABLE
XJ1-092 0-13 2PRE 0-10 1PRE 0-11 1PRE 0-12 1PRE 0-14 3PRE 0-21 1PRE 0-22 2PRE 0-23 1PRE 0-24 2PRE 0-25 2PRE 2-71 1PRE 2-72 1PRE 2-73 2PRE 3-81 1PRE 3-82 1PRE
REFERENCE PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER PART NUMBER

SXI J470 - - - - QNZ0907-001 - - - - - - - - - -

C472 - - - - CK73GXR1H104K_9 - - - - - - - - - -

C473 - - - - CK73GXR1A105K_9 - - - - - - - - - -
C474 - - - - CK73GXR1A105K_9 - - - - - - - - - -

C475 - - - - CK73GXR1A105K_9 - - - - - - - - - -

D470 - - - - DZ2J068M_9 - - - - - - - - - -

D477 - - - - RSB6.8SM-X - - - - - - - - - -

D478 - - - - RSB6.8SM-X - - - - - - - - - -

D479 - - - - RSB6.8SM-X - - - - - - - - - -

D480 - - - - RSB6.8SM-X - - - - - - - - - -

D481 - - - - RSB6.8SM-X - - - - - - - - - -

Q470 - - - - LTC014EEBFS8_9 - - - - - - - - - -

Q471 - - - - LTC043TEB-X - - - - - - - - - -

R470 - - - - RK73GB2A104J_9 - - - - - - - - - -

R471 - - - - RK73GB2A101J_9 - - - - - - - - - -

R472 - - - - RK73GB2A101J_9 - - - - - - - - - -

R476 - - - - RK73GB2A223J_9 - - - - - - - - - -

R482 - - - - RK73GB2A472J_9 - - - - - - - - - -

R483 - - - - RK73GB2A221J_9 - - - - - - - - - -

RA470 - - - - RK74GB1J100J_9 - - - - - - - - - -

POWER IC C1010 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1011 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1012 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1013 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1014 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1015 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1016 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

C1017 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 - CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 CK73GBB1H471K_9 - - - - -

E-VOLUME IC161 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7720B-X TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9 TDA7718C_9

C168 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 - CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9

C169 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 - CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9 CK73GXR1A105K_9

C170 - - - - CK73GXR1A105K_9 - - - - - - - - - -

R162 - - - - RK73GB2A000J_9 - - - - - - - - - -

R164 - - - - RK73GB2A000J_9 - - - - - - - - - -

i
R167 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 - RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9

PREOUT J321 QNN0868-001 QNN0874-001 QNN0874-001 QNN0874-001 QNN0866-001 QNN0874-001 QNN0868-001 QNN0874-001 QNN0868-001 QNN0868-001 QNN0874-001 QNN0874-001 QNN0868-001 QNN0874-001 QNN0874-001
C251 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 - CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9 CK73EBB1C475K_9

Q250 LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X - LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X LTC043TEB-X

R250 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 - RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9 RK73GB2A181J_9

m
R251 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 - RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9 RK73GB2A223J_9

R252 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 - RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9 RK73GB2A331J_9

R253 - - - - RK73GB2A000J_9 - - - - - - - - - -

C321 CK73EBB1C475K_9 - - - CK73EBB1C475K_9 - CK73EBB1C475K_9 - CK73EBB1C475K_9 CK73EBB1C475K_9 - - CK73EBB1C475K_9 - -

C331 CK73EBB1C475K_9 - - - CK73EBB1C475K_9 - CK73EBB1C475K_9 - CK73EBB1C475K_9 CK73EBB1C475K_9 - - CK73EBB1C475K_9 - -

C341 - - - - CK73EBB1C475K_9 - - - - - - - - - -

C351 CK73EBB1C475K_9 - - - CK73EBB1C475K_9 - - - - - - - - - -

Q320 LTC043TEB-X - - - LTC043TEB-X - LTC043TEB-X - LTC043TEB-X LTC043TEB-X - - LTC043TEB-X - -

Q330 LTC043TEB-X - - - LTC043TEB-X - LTC043TEB-X - LTC043TEB-X LTC043TEB-X - - LTC043TEB-X - -

Q340 - - - - LTC043TEB-X - - - - - - - - - -

Q350 - - - - LTC043TEB-X - - - - - - - - - -

R320 RK73GB2A181J_9 - - - RK73GB2A181J_9 - RK73GB2A181J_9 - RK73GB2A181J_9 RK73GB2A181J_9 - - RK73GB2A181J_9 - -

R321 RK73GB2A223J_9 - - - RK73GB2A223J_9 - RK73GB2A223J_9 - RK73GB2A223J_9 RK73GB2A223J_9 - - RK73GB2A223J_9 - -

R323 RK73GB2A331J_9 - - - RK73GB2A331J_9 - RK73GB2A331J_9 - RK73GB2A331J_9 RK73GB2A331J_9 - - RK73GB2A331J_9 - -

R330 RK73GB2A181J_9 - - - RK73GB2A181J_9 - RK73GB2A181J_9 - RK73GB2A181J_9 RK73GB2A181J_9 - - RK73GB2A181J_9 - -

R331 RK73GB2A223J_9 - - - RK73GB2A223J_9 - RK73GB2A223J_9 - RK73GB2A223J_9 RK73GB2A223J_9 - - RK73GB2A223J_9 - -

R333 RK73GB2A331J_9 - - - RK73GB2A331J_9 - RK73GB2A331J_9 - RK73GB2A331J_9 RK73GB2A331J_9 - - RK73GB2A331J_9 - -

R340 - - - - RK73GB2A181J_9 - - - - - - - - - -
R341 - - - - RK73GB2A223J_9 - - - - - - - - - -

R343 - - - - RK73GB2A331J_9 - - - - - - - - - -
R350 - - - - RK73GB2A181J_9 - - - - - - - - - -

MICON

MICON
STAGE

AUTO ANT.

OE REMOTE

IPOD

HSS
R351

R353

C722

C723

C724

C1022

C1035

R705

R1006
R1043

R732

R733

R734
R735

R381

R402

R403

IC411

C410

R410

R411

R412

R413

R414
IC891

C891

C892

C893
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A273J_9

RK73GB2A223J_9

RK73GB2A473J_9
-

RK73GB2A225J_9

MFI337S3959-X

CK73GXR1H104K_9

RK73GB2A101J_9

RK73GB2A101J_9

RK73GB2A472J_9

RK73GB2A472J_9

RK73GB2A472J_9
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

-
-

RK73GB2A473J_9

RK73GB2A473J_9

RK73GB2A203J_9

-
-

-
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9
RK73GB2A000J_9

RK73GB2A000J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73GB2A473J_9
-

RK73GB2A225J_9
-

-
-

BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9
RK73GB2A000J_9

RK73GB2A000J_9

RK73GB2A333J_9

RK73GB2A153J_9

RK73GB2A473J_9

RK73GB2A225J_9

-
-

BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-
jo
RK73GB2A223J_9

RK73GB2A331J_9
CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A473J_9

RK73GB2A473J_9

RK73GB2A225J_9

MFI337S3959-X

CK73GXR1H104K_9

RK73GB2A101J_9

RK73GB2A101J_9

RK73GB2A472J_9

RK73GB2A472J_9

RK73GB2A472J_9
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9
CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A473J_9

RK73GB2A333J_9

RK73GB2A153J_9

RK73EB2E000J_9

RK73GB2A225J_9

-
-

BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

-
CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A473J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73EB2E000J_9

RK73GB2A225J_9

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9
CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73GB2A333J_9

RK73GB2A153J_9

RK73EB2E000J_9

RK73GB2A225J_9

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A273J_9

RK73GB2A223J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73EB2E000J_9

RK73GB2A225J_9

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A333J_9

RK73GB2A153J_9

RK73GB2A333J_9

RK73GB2A153J_9

RK73EB2E000J_9

RK73GB2A225J_9

MFI337S3959-X

CK73GXR1H104K_9

RK73GB2A101J_9

RK73GB2A101J_9
RK73GB2A472J_9

RK73GB2A472J_9

RK73GB2A472J_9
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A473J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73GB2A203J_9

-
-

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A273J_9

RK73GB2A223J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73GB2A203J_9

-
-

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9
RK73GB2A000J_9

RK73GB2A822J_9

RK73GB2A393J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73GB2A203J_9

MFI337S3959-X

CK73GXR1H104K_9

RK73GB2A101J_9

RK73GB2A101J_9

RK73GB2A472J_9

RK73GB2A472J_9

RK73GB2A472J_9
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9

RK73GB2A000J_9

RK73GB2A000J_9

RK73GB2A333J_9

RK73GB2A153J_9

RK73GB2A393J_9

RK73GB2A822J_9

RK73GB2A225J_9

-
-

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9
-

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

CK73GBB1H472K_9

RK73GB2A103J_9
RK73GB2A000J_9

RK73GB2A000J_9

RK73GB2A153J_9
RK73GB2A333J_9

RK73GB2A393J_9

RK73GB2A822J_9
-

RK73GB2A225J_9

-
-

-
BD2242G-G_9

CK73GXR1H104K_9

CK73GXR1H104K_9

CK73GXR0J106M_9

R890 RK73GH2A163D_9 - RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9 RK73GH2A163D_9

R892 RK73GB2A222J_9 - RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9 RK73GB2A222J_9
R894 RK73GB2A000J_9 - RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9

VDD3.3V C1051 - CK73GBB1H221K_9 - - CK73GBB1H221K_9 - - - - - CK73GBB1H221K_9 CK73GBB1H221K_9 CK73GBB1H221K_9 CK73GBB1H221K_9 CK73GBB1H221K_9

C1054 - CK73GBB1H223K_9 - - CK73GBB1H223K_9 - - - - - CK73GBB1H223K_9 CK73GBB1H223K_9 CK73GBB1H223K_9 CK73GBB1H223K_9 CK73GBB1H223K_9

R1051 - RK73GB2A000J_9 - - RK73GB2A000J_9 - - - - - RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9 RK73GB2A000J_9

XJ1-092 0-13 0-10 0-11 0-12 0-14 0-21 0-22 0-23 0-24 0-25 2-71 2-72 2-73 3-81 3-82
DC VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE VOLTAGE

IC701 pin 55
0V 0V 0V 0V 0V 1.03V 0.57V 1.03V 0.57V 1.03V 0.57V 0.57V 0.57V 0.57V 0.57V
STAGE 1

IC701 pin54
1.48V 0V 0.57V 1.03V 0V 0V 0V 0.57V 1.48V 1.03V 0V 1.48V 2.73V 1.03V 2.27V
STAGE 2

IC901 pin4
8.50V 8.50V 8.50V 8.50V 11.50V 8.50V 8.50V 8.50V 8.50V 8.50V 8.50V 8.50V 8.50V 8.50V 8.80V
AUDIO VOLTAGE

POWER CORD Y-NUMBER

QAM1329-001 YJ1-0540-10 YJ1-0540-21 YJ1-0540-22 YJ1-0540-24 YJ1-0580-10 YJ1-0580-22 YJ1-0690-10

YJ1-0540-11 YJ1-0590-21 YJ1-0540-23 YJ1-0544-11 YJ1-0580-21 YJ1-0590-10

QAM1345-003 YJ1-0542-71 YJ1-0542-72 YJ1-0542-73 YJ1-0543-81 YJ1-0582-71 YJ1-0583-81 YJ1-0592-71

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)7/26
 MAIN PWB ASSY(1/2) (XJ1-136R-00) KD-R471R2
ANT

SW_R/RR_R

SW_L/RR_L
?J470
J600 TL56

(RR_R)
T1 T3

(FR_R)

(RR_L)
(SXI.L)

(FR_L)
QNB0356-001 TL472 T2 1 2 3 T6 J321
TL57 TL476
(SXI.R) T4
4 5 6 7
T7
! IC301 QNN0874-001
TL475 T5 T9
JCV8034

PWGND1

PWGND2

PWGND3

PWGND4
T8 8 9 10 T10

ACGND
TL480

MUTE
VCC1

VCC2
STBY
TAB1

TAB2
?RA470

OFFDET

SVR
TL50 TL51 11 12

IN2

IN4
OUT2+

OUT1+

OUT3+

OUT4+
OUT2-

OUT1-

OUT3-

OUT4-
?R471

?R472

SGND
?C472

?D479

?D477

?D481

?D480

?D478

?D470
(TU.R) (TU.L)

IN1

IN3

CD

8
1 3 5 7 9 11 13 15 17 19 21 23 25 27

?R609
?R1011

?R610

0V
TU.R 2 4 6 8 10 12 14 16 18 20 22 24 26
TU.L ?C1004 ?R253

?C1003
14.4V

14.4V
3.3V

7.0V
3.3V
7.0V

7.0V

7.0V
7.0V
6.8V
6.9V

6.9V
6.9V
7.0V
7.0V

7.0V

7.0V
3.3V
7.0V

3.3V
?R483
F0K-0010-00

?R482
?D601 ?D602

0V

0V

0V

0V

0V

0V
TL625 GND3 TL340 ?C340 ?C350 TL320 ?C320 ?C330 TL260 ?C260 ?C250 TL250

VA600

!
V
C1600 X600 R611
100

?C475

?C473

?C474
0.1u QAX0969-001Z SCL_EET

?R476

16V ?C305

?C306

F321
TL350 TL330

3.3V

1.5V
1.5V
3.3V

3.0V
?R612
?R608 ?R607 9.216MHZ

82p

C1320
0.1u
C1604

C1605
0.1u
R260

180
?R340

?R320
?R350

180
C312

0.1u
?R330
0V

0V
0V
C1603 TL44

R250
C368

1.0u
?Q471 (AC)

?C622
?Q470

?C623
0.1u

?R606

XTAL_IN 32
VSS 31
DAC_L 30
DAC_R 29
GPIO_0 28
GPIO_1 27
GPIO_2 26
SCL 25

C303

C304
47u
GND6 TL624 1u ?R341 ?R351 ?R321 ?R331 R261 R251
C619
0.1u 22k 22k

?C307

?C308
?C621
C618

5.1
R601
0.1u

R303
3.3V 3.0V 100 SDA_EET
TL58

17 18 19 20 21 22 23 24
1
(SIG) VDDA_IFADC SDA GND4
C617 0V 0V

?R343

?R353

?R323

?R333

R262
330

330
2
VSSA_IFADC VSSD_IO

R252
L607 0.22u ! C603

SXM_RX_M

M_TX_SXM
2.6V 3.3V

SXM_PWR

?C309

?C310

0V

0V

0V
3
1.2V VBGP IC601 VDDD

RR+
FR+

RL+
RR-
SXI_AG

FL+
SXI_AR

FR-
C615 0.15u 0V

RL-
SXI_AL

FL-
1.5V 0.1u

C611
1p
TEF6657HN-X

L606
C612

0.12u

4
33p C614 0.01u 1.2V FM_CAP VSSD
22p C616 1.5V 0V

4.7u

4.7u
5
L605 1000p 1.2V FM_IN_M I.C.

0.22u
0.22u

0.22u
0.22u

LTC043TEB-X
LTC043TEB-X
0V

!
0.22u 1.5V C369

6
FM_IN_P I2S_SD_1
4.7u 6.3V

OFFSET

SDA_EET

SCL_EET

E_MUTE

RLOUT
FLOUT
RR/SUBR
RL/SUBL

FROUT
RROUT
3.3V 0V

R304

47k
7
VDDA_RF I2S_BCK

R302

?C321

?C331
2.2k

22k

?C341

?C351

C261

C251
R273

?Q320
?Q350

?Q330
?Q340
C609 0V

Q260
0V

Q250
10 AM_LNA_CAP
8
R605 0.1u VSSA_RF I2S_WS

C316
C317

C319
C318
14 DR_Q_DATA

0V
C610 C1601

15 DR_I_DATA
4.7

DA2J101
12p

16 I2S_SD_0

D273
LTC043TEB-X

AM_IN_P

PWIC_MUTE
13 DR_BCK
4.7K

12 DR_WS

GND
0.1u

1u

1u
1u
1u

PWIC_STB
11 DR_BL

DC_ERR2
100

100

RR/SUBR

RL/SUBL
C602

OFFSET
0
0

RROUT

RROUT
FROUT

FROUT
RLOUT
RLOUT
FLOUT

FLOUT
L603

BEEP
?C172
C171
?C170
C169
C168
C167
0.1u

33
10u

R167
R602

R170

R168
R169
C608 ! 0.85V C601
R600

1V 0V

0V
0V
0V
0V
0V
0V
L604 1000p C607 82 0V LTC024EEB-X

FLG_REG

RESET

E_MUTE

MUTE
1k 1/8W 10u 22K
1.0u 1p L601 C605

L602
0.47u

L600
1000p

4.7u
4.7u C1602 22K

3.3V
R604
C624

R603
C606

1M

1M
0.1u 9p C604 TL45 0.1u R271
?C1050 ?R1050 (PIN10) ?C600
1500p

3.3V
3.3V
3.0V
3.0V
8.5V
3.3V
4.0V
4.0V
4.0V
4.0V
4.0V
4.0V
4.0V
330

0V

R1071
BAW56-TP-X

?D272

0
LTA024EEB-X

100k
R270
22K

LINE MUTE
28 27 26 25 24 23 22 21 20 19 18 17 16 15 Q270 P.IC MUTE

D270
GND2 C100 LTA024EEB-X

WININ
DCERR
SDA
SCL
VCC
MUTE
WINTC
OUTLF
OUTLR
OUTRR
OUTRF

QD2G OUTSWL
QD2ROUTSWR
GND
22K
0.1u C103
AUX-G

3.3V
1u IC161 3.3V
4700p

4700p
C101

C102

R100 0V
R103

R104
47k

47k

LTA024EEB-X
TDA7718C

QD1G

QD2G
QD1R

CREF
SE1R

SE2R

SE3R
QD1L

QD2L
0V

SE1L

SE2L

SE3L
D101 470 C104 AUX-R 3.3V 3.3V

BAW56-TP-X

Q273
RSB6.8SM-X ?C1020 10K LTA014YEB-X
1u 1 2 3 4 5 6 7 8 9 10 11 12 13 14

D271
D100 C105 AUX-L Q272 47K

R171

10k

0V
RSB6.8SM-X R1070 LTC024EEB-X

3.3V
3.3V
3.3V
3.3V

3.3V
3.3V
3.3V

3.3V
3.3V
3.3V
3.3V

3.3V
3.3V
1u 3.3V
?C1021
1k Q271
22

GND1 LSAR523UBFS8

?R161

?R163

?R1067

10u
16V
TL52

C177
1u
C161

C162
C163
4.7u

C164
4.7u
(AL)
20

1u

1u

35V

35V
F_AUXL TL60
(AG)
19

?R164
?R162
F_AUXG TL53

i
(AR)

?C1053

C165
18

F_AUXR TL61
MAIN PWB:J7J-0020-**

DC_ERR1
(USBGND)

E_MUTE
17

SXI_AG
SXI_AR
GND

SXI_AL
AUX-G
AUX-R
TL07

AUX-L
CD.R
TU.R
(P33)

CD.L
TU.L
16

PANEL3.3V TL62 1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER

(ILM) WITHOUT INPUT SIGNAL
15

ILLUMINATION
TL63 LCD/RGB_DATA_SYS CONDITION---FM MODE. AM MODE ( )CD MODE.
14

LCD_DATA_SYS R709
TL64 3.3k LCD_CE 2. UNLESS OTHERWISE SPECIFIED.
13

LCD_CE
TL65 LCD_DATA_LCD ALL RESISTORS ARE 1/10W 5% METAL GLAZE RESISTOR.
12

LCD_DATA_LCD R1043
TL66 RGB_CLK ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.

m
0
11

USB_GND 3.3V ALL RESISTANCE VALUES ARE IN OHM.

TL67 LCD_CLK

To SWITCH PWB ASSY

10

LCD_CLK TL24 PON_PANEL 0V 3. COMPONENTS WITH ? IN FRONT INDICATE NOT USE

?R1022

(GND1)
9

USB_GND

LCD_DATA_LCD

MUTE

DRV_MUTE

SPBIO3

SPBIO2
SPBIO1
SPBIO0
SPBSSL

SPBCLK

SPBIO2
SPBIO1
SPBSSL

SPBIO3
SPBCLK
SPBIO0
TL68 ENC2
(XJ6-074R-00) Q701
8

ENC2
TL69 D+ LTA014YEB-X
3.3V
7

D+ DIM_IN 3.2V Q360

KD-R471R2 TL70 ENC1 LSCR523UBFS8
6

ENC1

TL716
TL71 D- 0V R361 R362
5

D-

CN1 TL15 ?R1007

R820
47k

47k
LCD_INH

R822
47k
R821
47k
R421
(5V) 33k 22k

REMO2
REMO1
4

USB5V

?C360

4.7k
R363
1u
TL72 0V

GND
TL360
IPOD

0.01u
3

USB5V

C361
R360

D360
22k
R1006
TL73 REMO

DZ2J068M
0
2

REMO TL18 L826

?IC411

3
2
1

4.7k
PAN_DET ?CN702

R364
(PDET) LB73G0CK-001
1

PAN_DET
TL49 TL48 TL47
(IP4) (IP3)
9
?R412
?R414

?R413

(IP2) TL46
R717
100k

4700p

?C821
21

47k
47k

C820

?C822
CN701
QGZ2006J1-20

(IP1)

NQR0713-001X
NQR0713-001X
NQR0713-001X
NQR0713-001X
RA701

LB73G0BK-006
47k

?R780
?R781
NQR0713-001X
NC5 NC4
5

R744
R743

F2
1/16W

C1033
4700p
SCL_IPOD ?R411

LB73G0BK-006
4700p
4700p
4700p

C1035

R1045
C1022
4700p

C1023
4700p

4700p

470p
C723
C724

C722

NC3
2.2k
6

SCL 0V 3.3V

L827
?R371

L701
VCC

LB73G0CA-002

(ASEMD) (TRST)

8
CS

TL38 TL37
SDA

TL36
(TCK)
7

RST 1.5V HOLD[IO3] 3.3V ?C370

L824
?R410

DEBUGGING

7
GND1 SDA_IPOD ?D701 ?D370
1/4W
R719

DO[IO1]
910

GND

L825
8

VCC 1.5V 0V
R745

CLK

(TMS)
0.1u

TL35

6
C713

C711
4700p
?C410 0V WP[IO2] 1.5V ?D702
DI[IO0] R370 68k

TL34

5
TL33 (TDI)
GND TL370 ?R372

L823
L822
L821
L820
?C780 TEL_MUTE (TMUTE)

C712

(ASEBRK)
0.1u

TL39
?R1714

(TDO)
W25Q16DVSSIG
?C781
! IC821
0V(3.3V)

TL29
(WP)
TL23
TL31

(HOLD) TL26
TL22
TL30
(DO)
(CS)
?R782
1.8V

TL907 (VCC2)
1.25V

1.25V
FLASH
3.3V

3.3V

3.3V

3.3V

1.5V
1.5V
1.5V

3.3V

3.3V
3.3V
3.3V
1.2V
1.2V

TL09 (TU33)

TL04 (AUD)
0V

0V

0V

0V
0V
0V

0V

0V

TL05 (VDD)

TL11 (EXT)

TL10 (ANT)
TL17 (FLG)

TL02 (ILM)
TL03 (CD)
?R783

TL14 (V6)
(CLK)
(DI)
90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 ! IC901

?R784

?R785

TL901

TL902
LV5685PV-H
NC
LCD_DATA_LCD
NC
NC
Vcc
MUTE
Vss
NC
PVcc
DRV_MUTE/DEBUG_2C
MD_BOOT
MD_CLK
Vcc
SPBIO3
Vss
SPBIO2
SPBIO1
SPBIO0
SPBSSL
Vss
SPBCLK
PVcc
AUDIO_X1
AUDIO_X2
TCK
TMS
TD1
TD0
ASEBRKAK/ASEBRK
TRST
?D703
SW1
SW2 14.3V

jo

1
SCL_EET 3.0V 3.3V EXT
PSW R746 91 E2P_SCL AVref 60

2
SDA_EET 4.7k 3.0V 3.3V ANT
DRV_MUTE R747 92 E2P_SDA AVcc 59 C710 TL708 10.5V

3
SCL_IPOD 4.7k 3.3V 0V 0.1u ILM
DRV_LO_EJ 93 IPOD_SCL AVss 58 8.5V

4
SDA_IPOD 3.3V 3.3V DC_ERR1 AUDIO
DRV_CNT R763 94 IPOD_SDA DC_ERR1 57 R735 7.0V

5
SCL_REG 4.7k 3.3V 1.5V 47k TEL_MUTE TL08 CD
BCLK R764 95 REG_SCL TEL_MUTE/LINE_MUTE 56 ?R734 (SW33) 6.0V
?R373

6
SDA_REG 4.7k 3.3V 0V SK34A-L-X ACC
LRCK R748 96 REG_SDA Stage1 55 R733 SW3.3V D903 13.9V

7
PON_CD 4.7k (3.3V)0V 1.82v 27k VCC2
CD_SRDATA_M ?R366 97 CD_DSP_SW Stage2 54 R732 D902 14.1V

8
DIM_IN 3.2V 22k VCC1
M_SRDATA_CD R365 98 DIM_IN NC 53 R731 ?Q931 SK34A-L-X 0V

9
FLG_REG 100k 3.3V 0V(3.3V) 47k PSW GND
NRST ?R765 99 FLG PSW 52 R730 ?R931 SCL_REG 3.3V

10
SCL

?R930

R1091
0V 3.3V 47k R729
BLKCK 100 Vss ASEMD 51 3.3V

0
C716 R728 15k

11
0.1u 3.3V 3.0V 22 D+ VDD
STAT 101 PVcc ! D+O 50 SDA_REG 3.3V
To MAIN PWB ASSY(2/2) R726

12
MLD (3.3V)0V 0V 22 D- SDA

?C931
MLD 102 MLD
IC701 D-O 49 5.1V

?Q930

13
BCLK R749 47k R750 100 (0V)0V 3.3V R727 V6IN
MDATA 103 BCLK PVcc 48 C709 ?R932 FLG_REG R905
(XJ1-136R-00) R761 0.1u 15k 3.3V

14
MCLK
LRCK 47k
R751 47k
R752 100 (0V)0V
104 LRCK R5S726A0D216FP Vss 47
0V C708
10p 100 3.3V
FLG

15
CD_SRDATA_M R754 10 (0V)0V 0V TU3.3V

KD-R471R2 CD.R
M_SRDATA_CD R753 1k (0V)0V
105 CD_SRDA_M Vss 46
1.6V

?C1051
CD.L 106 M_SRDA_CD XTAL 45 R725 12MHz

R724
1M
R762 0V 1.6V 3.3k C707

100u 6.3V
PON_CD 107 Vss EXTAL 44 10p

0.1u 50V

?C1052
470u 16V

0.1u 50V
L709 X701

?C1054

22u 16V
MCLK 47k R1064 (3.2V)0V 1.25V L7J-0060-00

1u 10V

1u 10V
1u 10V
1u 10V

1u 10V

0.22u
0.01u
AGND 10 C717 108 MCLK Vcc 43 C706 R722 R723
NQR0713-001X 47k PAN_DET IC891
0.1u 1.25V 0V 0.1u 910 BD2242G-G
CD8V L710 109 Vcc PAN_DET 42 TL28
MDATA R1065 (2.0V)0V 1.25V (RST2)
HSS_USB
MGND 110 MDATA PLLVcc 41 C705 L700

?R1051
10 TL27

?C930
?C913

?C915

?R1052
C905
5.2V 5.0V

C390
C909
C911
C914
C904
0.1u

C908
NQR0713-001X

C903
NQR0713-001X 0V

C916

C907
C906
C912
(RST1) OUT

6
DCDC5V 111 NC Vss 40 R721 C892 IN
47k RESET ?R1090 0V 0V
3.3V 3.3V 0.1u ILIM

5
CD_GND 112 PVcc RESET 39

2.2k
0.1u
C718 GND
SXM_PWR 0.1u 0V 0V ?C1002 PON_USB 3.3V OC 3.3V

16k
_0.5%
3

4
113 SXM_PWR Vss 38 C1900

6.8k
6.8k

R901
47k
C704 EN

R903

1/4W
R902

1/4W
1/4W
0V 0.1u 0.01u

C1901
114 Vss NC 37

470p
DRV_CNT (0V)0V 3.3V ?R401
TL705 ?C1090
115 DRV_CNT PVcc 36
RGB_CLK/PCB_TEST_MODE_RX

MBRX130
C891
R720

?C890
BEEP SW1 REMO ?R904

D390
0V 3.3V(3.3V)

R890

R892
47k R894 C893
116 BEEP SW1/DEBUG_2A 35 NQR0713-001X R756
DRV_LO_EJ STAT 0 10u D400 R900
(0V)0V 0V(3.2V) R755 47k 47k
117 SERIAL_NO_MODE/DRV_Lo/Ej STAT 34 R716 R402 RB521SM-30-X 1/4W

1k
R757 47k 3.3V 3.3V 2.2k 2.2M REMO
LCD/RGB_DATA_SYS

118 PCB_TEST_MODE REMO 33 ?R403 TL01 L990

SW2 (3.3V)3.3V 3.3V
R714
1k ENC1 DCDC R1080 D861 (MEM) QQR1927-001 REMOTE OUT
?R381

D401
119 DEBUG_2B/FIELD TEST 2/SW2 ENC1 32
SXM_DATA_SXM
SXM_DATA_SYS

R758 47k R712 R715

DZ2J051M
BLKCK ENC2

R400
(0V)0V 3.3V 1k 2.2k

D990
120 BLKCK/FIELD_TEST_1 ENC2 31 R713 R850 0 DB22306 C990
PANEL_PON

PWIC_MUTE

!
M_CLK_LCD

TL06

1N5401-BPC04
DEBUG_1C

FREQ_SEL
M_CE_LCD

DEBUG_1A
DEBUG_1B

0
FREQ_SEL

2.2k 2200u
PWIC_STB
USB_PON

(V1.25)

MBR0530-X
DC_ERR2

1/4W
LCD_INH

16V
R760 TL717 TL43

0.22u
NRST

47k C852

?C392

C391
PVcc

PVcc

PVcc

C870

4.7k
(TM) C851 TL16 TL40

D391
R390
100u

1/4W
1.25V
Vss

Vss

Vcc

Vss

Vcc

Vss

IC861

4.7u
NC

NC

NC

NC

15p

10u
6.3V 0.47u MP9942AGJ (FB) (FB1)
R840

?R866

68k
_0.5%
R865
SDA_EET 100 3.0V 0V 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 R864
SDA GND
5

4 5 FB 0.792V 39k
R841
3.3V

3.3V
(3.3)0V
0V
0V
3.3V
3.3V
0V
0V
2.0V
1.25V
0V
0V
3.3V
3.3V

0V

1.25V
3.3V
0V
0V
0V
0V
0V

3.3V
1.6V
0V

8
SCL_EET 3.0V 0V

BU1CTD3WG
C868 PG

NC

VOUT
SCL A2
6

10u
LDO_1.25V

10u
14.0V 4.8V

0.1u L861
100 150u VCC

L860

7
0V 0V

39k_0.5%
18k _0.5%
WP A1 6.3V IN
7

IC851
5.2V EN/SYNC 1.6V TL25
C869

6
3.3V 0V
?R1000
?R1001
?R1002

?C1001 C1000
4700p

SW R861 0.22u (GND2)

C700
0.1u

VCC A0
8

0V

?C865

10u

10u
9.8V

C867

C866
BST
0.047u
C840

STBY

5
TL19

?R862
0.1u

GND
GND
C701

C702
0.1u

C703
0.1u

VIN
20 (A.ANT)

470p

470p
470p
470p

470p
470p

C1014
470p

C1017
C1015
C1011

C1013

C1016
470p
C1010

C1012
C863 TL21

?D862
R1861

?R1860

C862
C860

C861
1/4W
3 2 1 0.22u (OE)

0
IC841

0V

R867
TL20

R868
C864
R707

0.1u
1.6k

3.3V

3.3V
BR24T02FJ-W-X
?R718

?R470

(REM)
EEPROM C850
TL995
0.47u

RR+
FR+
RR-
FR-
RL-
FL-
RL+
FL+
18 17 16 1 15 2 14 3 13 4 12 5 11 6 10 7 9 8

C1034
10k

RESET
1.6k

2.2k
4.7k
1.6k

R705

GND7
1.6k

?R708
R701

R711
R702
R703

R704

4700p
CN990
TL702

F901
FUSE 10A
FZB10BT-100

MEMORY
GND
DIMMER
ACC
?TEL MUTE
REMOTE/P-CON
OE REMOTE
NIL
REAR RIGHT (+)
FRONT RIGHT (+)
REAR RIGHT (-)
FRONT RIGHT (-)
REAR LEFT (-)
FRONT LEFT (-)
REAR LEFT (+)
FRONT LEFT (+)
TL703
TL704

!
IC831
GND7 R830
100
BU4228F QNZ0607-001
TL42 TL41
LCD/RGB_DATA_SYS

(RXM) (TXM)
0V 3.3V
1

GND RST
4

0.1u

0.1u
C832

C831

3.3V 1.7V
PON_PANEL

PWIC_MUTE

VDD CT
SXM_RX_M

POWER CORD ASS'Y

M_TX_SXM

FREQ_SEL
PWIC_STB

6800p
PON_USB
DC_ERR2

RGB_CLK

C830
LCD_CLK
LCD_INH

QAM1378-001
LCD_CE

RESET

2
NRST

S830
QSW0648-001Z

! Parts are safety assurance parts.

When replacing those parts make
sure to use the specified one.

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)8/26
 MAIN PWB ASSY(2/2) (XJ1-136R-00) KD-R471R2

! Parts are safety assurance parts.

When replacing those parts make
sure to use the specified one.
R542
SPL 22k

C544
0.01u
R541
5.6k MAIN PWB:J7J-0020-**
R544 1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
TVD 18k
2. UNLESS OTHERWISE SPECIFIED.
C545 R543
0.01u 5.6k ALL RESISTORS ARE 1/10W 5% METAL GLAZE RESISTOR.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
R546
TRD 10k ALL RESISTANCE VALUES ARE IN OHM.
3. COMPONENTS WITH ? IN FRONT INDICATE NOT USE
C546
6800p
TL557 TL542 TL543
R548
FOD 12k

C547
TL545 6800p

CN502 ?C542
QGF1040F1-24
C548 C541
VF2 4.7u
0.1u
24
C549
CD3.3 0.1u ?C543
23
VT2 C550
22 0.15u C540
?C582 PSW 0.1u M_SRDATA_CD
21
SW1 SW1
20

1.6V

1.5V
3.3V
1.6V
1.6V
1.8V
1.6V

1.5V
1.5V
SW2 SW2

0V
0V

0V
0V
0V
0V

0V
19
LD PSW
18 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
VT1 DRV_MUTE

CTRCRS
VREF
OSCIN
FOP
TRP
TRVP2
TRVP
SPOUT
PC
FG
DVSS1
DVDD1
IOVDD1
NC_7
NC_6
NC_5
SRVMON1
SRVMON0
PMCK
SMCK
17
MD DRV_LO_EJ
16 C552 ?C551
VF1 6800p DRV_CNT
15
0V 0V BCLK
14 R550 21 RFVSS1 DQSY 80 L777
CD8V VT2 2.2k 1.8V 0V NQR0713-001X BCLK LRCK
13 R551 22 E GIO2 79 L778
VT1 2.2k 1.8V 0V NQR0713-001X LRCK CD_SRDATA_M
To CD MECHA PWB ASSY 12
DRV_MUTE VF1 1.8V
23 F GIO1 78
0V
R567
100 CD_SRDATA_M M_SRDATA_CD

i
11 24 D GIO0 77
(LVA20106-01A) 10
?C581
FOD 1.8V
25 B NSRVMONON 76
3.3V
C579 ?C580
NRST
TRD VF2 BLKCK
CN1 9
VREF R554
1.8V
1.8V
26 C IOVDD2 75
3.3V
1.5V
0.1u TL544
C577 X540 STAT To MAIN PWB ASSY(1/2)
8 27 A X1 74

R573
?C575 10p L7J-0093-00
(XJ1-136R-00)

1M
DRV_LO_EJ MD 2.2M 0.1V 1.6V MLD
R572 C578 16.9344
7 ?C554 28 PD X2 73 1k 10p
TVD 2.3V ! 0V MDATA
6 C553 29 LD DVSS2 72 R571 R570 KD-R471R2

m
TL504 SPL 0.1u 3.2V IC540 3.3V 10k 100 NRST MCLK
5 ?C585 C555 30 RFVDD1 MN6627553APA NRST 71 C576 R569
DRV_CNT 0.022u 1.9V 0V 0.1u 1k BLKCK CD.R
4 C556 31 CENV BLKCK 70 ?R568
MGND R556 3300p 1.7V 3.2V STAT CD.L
3 4.7k 32 RFENV STAT 69
MGND 1.2V 3.3V MLD PON_CD
2 C557 33 RFOUT MLD 68
1.8V

Q540 MDATA AGND

CD8V 2SA2188/E/-X TL546 0.33u 1.8V 2.0V
1 34 RFIN MDATA 67
1.0V 3.3V MCLK CD8V
C558 35 ARFDC MCLK 66
TL540 4.7u 1.2V RA580 MGND
36 ARFOUT TX 65
3V

C559 470 1/16W

TL547 0.1u 1.2V 0V DCDC5V
C560 37 ARFFB FLAG 64 TL553
C561 680p 1.6V 0V CD_GND
R557 TL503 10u 38 ARFIN TEST 63
4.7 3.3V
1/4W 39 NC_39 NTEST2 62 L574
0V 1.5V
40 RFVSS2 DVDD2 61
NQR0713-001X
C573 ?C574

RFVDD2
PLLFO2

LSPWM
AVDD1
0.1u

AVSS1
PLLFO
NC_41

NC_51
OUTR
VCOF

OUTL

CSEL
DSLF

EXT4
EXT3
EXT2
EXT1
EXT0
PLLF
IREF
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

0V
1.5V

0V
1.4V

0.5V

1.6V

1.6V
3.3V

0V
3.3V

0V

0V

0V
1.4V
0.8V
1.6V

2.7k
82k

820
R562

R558
R559

TL548
TL549
TL550
TL551

TL552
jo C510
470p
0.015u

0.082u
1000p

1000p
0.33u
C564

C568
C562
C563

C565
C567
0.1u

C570
0.1u
TL55
(CD.R)

TL54
(CD.L)
C571
0.1u
C572
10u
L540
NQR0713-001X
?C586

R589

820

R590

820
C583
820p
C584
820p
R579

2.2k

R580

2.2k
C588
680p
C589
680p
CD.R

CD.L

LDO3.3_CD
R1029
0

1/4W
C1028
4700p

R940

1/4W
10
TL13
(CD33)
IC941
BU33TD3WG
R587
22 3.3V 5.1V
VOUT VIN

1
0V
GND

2
(3.3V)
NC STBY

3
C942
10u

10u
C940
C941
1u
No.MA612 created date:2016-03-03
(No.MA612<Rev.002>)9/26
SWITCH PWB ASSY (XJ6-055x-xx) Except KD-R471R2
0v
3 4
SWITCH PWB : J7J-0195-** J60
*IC90 QNS0279-001
PIC95603-X

VOUT
3

VCC
2 1
C61 C60 2
1
AUX
3.2v 3.2v
1000p 1000p

S1
S2
S3
S4
S5
S6
S7
S8
S9
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
S29
S30
S31
S32
S33
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
S48
S49
S50
S51
COM1
COM2
COM3
COM4
S20 ?D61 ?D60

*R1009
QSW1308-001

?R1007
*R91

0
6.2k

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 ?Q90

ED1 CN1

T1
T2
T3
T4
T5
T6
T7
T8
T9
T10
T11
T12
T13
T14
T15
T16
T17
T18
T19
T20
T21
T22
T23
T24
T25
T26
T27
T28
T29
T30
T31
T32
T33
T34
T35
T36
T37
T38
T39
T40
T41
T42
T43
T44
T45
T46
T47
T48
T49
T50
T51
T52
T53
T54
T55

*R1008

?R1010

1/8W
15k
?Q91

1/8W
1/8W
R61

R62

R60
QGZ2006K1-20X

100
4.7
100
*R1006
B3H-0029-00

*C91

?C90
1u

1
F_AUXL

2
F_AUXG

3
F_AUXR
R7

4
GND
1/4W

5
0 PANEL3.3V

6
ILM10.5
RA2 LCD_DATA_SYS

7
LCD_DATA_SYS
100 LCD_CE

KS2
KI4

8
1/16W LCD_CE
LCD_DATA_LCD

9
LCD_DATA_LCD

1/10W
S51

S50

COM4
COM3
COM2
COM1
KI5
KI4
KI3
KI2

KI1

KS6
KS4
KS3
KS2

S49
S48
S47
S46
S45
S44
S43
S42
S41
S40
S39
S38
S37

10
USB_GND
LCD_CLK
To MAIN PWB ASSY(1/3)

11
LCD_CLK

100
R1

12
USB_GND
(XJ1-092x-xx)

1/16W
RA1
R3

100
470

13
ENC2

Except KD-R471R2

14
D+

2.8V
2.8V

2.8V
2.8V
2.8V
2.8V

2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V

15
ENC1

CN701

16
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 D-

17
KI1/S62
KS6/S61
KS5/S60
KS4/S59
KS3/S58
KS2/S57
KS1/S56
S55
S54
S53
S52
S51
S50
S49
S48
S47
S46
S45
S44
S43
USB5V

MBRX130
D2
*D21

*D22

*D23

18
C6 ?C7 USB5V

19
10u REMO
TL11 S36
0V 2.4V

20
61 KI2/S63 S42 40 PAN_DET
0V 2.4V S35
62 KI3/S64 S41 39
0V 2.4V S34
TL11 63 KI4/S65 S40 38
0V S33

?D50
?D51
?D52
?D53
2.4V
64 KI5/S66 S39 37
2.5V 2.4V S32

1/8W
65 COM1 S38 36
1/8W

1/8W

1/8W
*R20

*R21

*R22

*R23

*R24

*R25

BACKLIGHT
1/8W

1/8W
2.5V S31

NHSW157B
2.4V

D49
66 COM2 S37 35
2.5V 2.4V S30
67 COM3 S36 34
2.5V 2.4V S29
68 COM4 S35 33

TL12
2.4V
4.9V
69 S67
70 VDD
IC1 S34 32
S33 31
2.4V
2.4V
S28
S27
2.4V 2.4V S26

BU97520AKV-M

i
71 S68 S32 30
TL12
C1 1u 1.7V
72 SDO S31 29
2.4V S25
*J80
0V 2.4V S24
R5 10.2V 73 VSS S30 28
4.9V RA3
74 OSC/S69 S29 27
2.4V S23 E5J-0069-00

1.1k

1.1k
R48

R49
330

1/8W

1/8W

LCD_DATA_LCD
4.9V 2.4V S22

Q1

7
4700p
1/4W

LSCR523UBFS8
75 INHB S28 26

470p
*C83

*C84
5.6V LCD_CE 0V 2.4V S21
76 SCE S27 25

1k
R6
LCD_CLK 1.6V 2.4V S20 *FL80

1
77 SCL S26 24 L7K-0030-00 VCC
LCD_DATA_SYS 0V 2.4V S19
R51

2
0.7V D-

m
0.1V 78 SDI S25 23 *C85 *C86
6.8k
100 P1 4.8V 2.4V S18 470p 4700p
USB

3
79 S1/P1/G1 S24 22 D+
1/16W P2 4.8V S17
2.4V

27p

27p

4
GND

*R80

0
0V 80 S2/P2/G2 S23 21

220

*C82
1/4W

10u
Q51

*R81
LSCR523EBFS8

S3/P3/G3
S4/P4/G4
S5/P5/G5
S6/P6/G6

*C80

*C81

DZ2J051M

DZ2J051M

5
C5

?C4
DZ2J056M

S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
D1

S7
S8
S9

6
1u

*D80

*D81
R50 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
0.1V
0.7V 4.3k

2.4V

2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
TL1
Q50
0V
KS2 S15A LSCR523EBFS8

S10
S11
S12
S13
S14
S15
S16
S1
S2
S3
S4
S5
S6
S7
S8
S9
S12 S13 S14 S15

6 5/USB MODE 4/REP BASS/EQ

TL2

KS3
S11A

S7 S8 S9

TL3 3/RDM 2/ 1/ SEARCH/RETURN

0-10 0-11 2-71 2-72 0-21 0-22 3-81 3-82
KS4
AUX
S6A
S3A reference RED W/OUT REMO RED WITH REMO RED W/OUT REMO BLUE W/OUT REMO AMBER WITH REMO WHITE WITH REMO GREEN WITH REMO GREEN W/OUT REMO

KS6
TL4
S3

DISPLAY/SETUP
S4

>>||
S5

||<<

S1

S1A
S6

PHONE

SOURCE/STDBY
S2A

S2

jo *C80

*C81

*C82
*C83

*C84

*C85

*C86

*C91
-

-
CC73GCH1H270J

CC73GCH1H270J

CK73EXR1C106K

CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

CK73GXR1A105K
CC73GCH1H270J

CC73GCH1H270J

CK73EXR1C106K

CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

-
CC73GCH1H270J

CC73GCH1H270J

CK73EXR1C106K
CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

-
CC73GCH1H270J

CC73GCH1H270J

CK73EXR1C106K
CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

RCK73GXR1A105K
CC73GCH1H270J
CC73GCH1H270J

CK73EXR1C106K
CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

CK73GXR1A105K
CC73GCH1H270J
CC73GCH1H270J

CK73EXR1C106K
CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

CK73GXR1A105K
CC73GCH1H270J
CC73GCH1H270J

CK73EXR1C106K
CK73GBB1H471K

CK73GBB1H472K

CK73GBB1H471K

CK73GBB1H472K

-
Model no
YJ1-0540-10
YJ1-0540-11
YJ1-0540-21
YJ1-0540-22
Unit no
XJ6-0550-10
XJ6-0550-11
XJ6-0550-21
XJ6-0550-11
Model name
KD-R370K
KD-R470K
KD-R476M
KD-R471M
TL6

EJECT
TL5

TL7

TL8

TL9

YJ1-0540-23 XJ6-0550-11 KD-R471MM2

*D21 LRT67DU1V211 LRT67DU1V211 LRT67DU1V211 ASMTUBB5ZT3Y2 QSMTUAJ1ZU4H2 ASMPCWH1ZCEB2 ASMTUGB5ZV7Y2 ASMTUGB5ZV7Y2 YJ1-0544-11 XJ6-0550-11 KD-R471H2
YJ1-0540-24 XJ6-0550-22 KD-R473MM2
YJ1-0542-71 XJ6-0552-71 KD-R471E
KI2

KI3

KI4

KI5

*D22 LRT67DU1V211 LRT67DU1V211 LRT67DU1V211 ASMTUBB5ZT3Y2 QSMTUAJ1ZU4H2 ASMPCWH1ZCEB2 ASMTUGB5ZV7Y2 ASMTUGB5ZV7Y2

KI1

YJ1-0542-72 XJ6-0552-72 KD-R472E

*D23 LRT67DU1V211 LRT67DU1V211 LRT67DU1V211 ASMTUBB5ZT3Y2 QSMTUAJ1ZU4H2 ASMPCWH1ZCEB2 ASMTUGB5ZV7Y2 ASMTUGB5ZV7Y2 YJ1-0542-73 XJ6-0552-71 KD-R474E
YJ1-0543-81 XJ6-0553-81 KD-R477Q
*D80 - DZ2J051M_9 DZ2J051M DZ2J051M DZ2J051M DZ2J051M DZ2J051M DZ2J051M YJ1-0540-12 XJ6-0550-11 KD-SR42K
YJ1-0590-10 XJ6-0550-11 KD-R670K
*D81 - DZ2J051M_9 DZ2J051M DZ2J051M DZ2J051M DZ2J051M DZ2J051M DZ2J051M YJ1-0590-21 XJ6-0550-11 KD-R671M
YJ1-0592-71 XJ6-0552-71 KD-R671E
*FL80 - L7K-0030-00 L7K-0030-00 L7K-0030-00 L7K-0030-00 L7K-0030-00 L7K-0030-00 L7K-0030-00 YJ1-0590-11 XJ6-0550-11 KD-SR62K
YJ1-0610-21 XJ6-0550-11 KD-X130M
*IC90 - PIC95603-X - - PIC95603-X PIC95603-X PIC95603-X - YJ1-0614-11 XJ6-0550-11 KD-X130H2
YJ1-0610-23 XJ6-0550-11 KD-X130MM2
NOTES *J80 - E5J-0069-00 E5J-0069-00 E5J-0069-00 E5J-0069-00 E5J-0069-00 E5J-0069-00 E5J-0069-00 YJ1-0612-71 XJ6-0552-71 KD-X130E
YJ1-0613-81 XJ6-0553-82 KD-X130Q
*R20 RK73FB2B751J RK73FB2B751J RK73FB2B751J RK73FB2B102J RK73FB2B122J RK73FB2B751J RK73FB2B681J RK73FB2B681J YJ1-0610-10 XJ6-0550-11 KD-X230K
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL YJ1-0610-22 XJ6-0550-11 KD-X230M
*R21 - - - RK73FB2B102J RK73FB2B122J - - - YJ1-0612-72 XJ6-0552-71 KD-X230E
2. UNLESS OTHERWISE SPECIFIED. YJ1-0632-70 XJ6-0552-71 KD-DB67E
*R22 RK73FB2B751J RK73FB2B751J RK73FB2B751J RK73FB2B102J RK73FB2B122J RK73FB2B751J RK73FB2B681J RK73FB2B681J
ALL RESISTORS ARE 1/10W +5% METAL GLAZE RESISTOR.
*R23 - - - RK73FB2B102J RK73FB2B122J - - -
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTANCE VALUES ARE IN OHM. *R24 RK73FB2B751J RK73FB2B751J RK73FB2B751J RK73FB2B102J RK73FB2B122J RK73FB2B751J RK73FB2B681J RK73FB2B681J
ALL CAPACITANCE VALUES ARE IN uF(P=pF) *R25 - - - RK73FB2B102J RK73FB2B122J - - -
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
*R80 - RK73EB2E221J RK73EB2E221J RK73EB2E221J RK73EB2E221J RK73EB2E221J RK73EB2E221J RK73EB2E221J
3. COMPONENTS WITH ? IN FRONT INDICATE NOT USE.
*R81 - RK73EB2E000J RK73EB2E000J RK73EB2E000J RK73EB2E000J RK73EB2E000J RK73EB2E000J RK73EB2E000J

*R91 - RK73GB2A622J - - RK73GB2A622J RK73GB2A622J RK73GB2A622J -

*R1006 - RK73GB2A000J - - RK73GB2A000J RK73GB2A000J RK73GB2A000J -

*R1008 - RK73GB2A153J - - RK73GB2A153J RK73GB2A153J RK73GB2A153J -

*R1009 - RK73GB2A000J - - RK73GB2A000J RK73GB2A000J RK73GB2A000J -

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)10/26
SWITCH PWB ASSY (XJ6-074R-00) KD-R471R2
0v
3 4
SWITCH PWB : J7J-0195-** J60
IC90 QNS0279-001
PIC95603-X

VOUT
3

VCC
3.2v
2 1
3.2v
C61 C60 2
1 AUX
1000p 1000p

S1
S2
S3
S4
S5
S6
S7
S8
S9
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
S23
S24
S25
S26
S27
S28
S29
S30
S31
S32
S33
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
S48
S49
S50
S51
COM1
COM2
COM3
COM4
S20 ? D61 ? D60

QSW1308-001

R1009
? R1007
R91

0
6.2k

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 ? Q90

? R1010
T1
T2
T3
T4
T5
T6
T7
T8
T9
T10
T11
T12
T13
T14
T15
T16
T17
T18
T19
T20
T21
T22
T23
T24
T25
T26
T27
T28
T29
T30
T31
T32
T33
T34
T35
T36
T37
T38
T39
T40
T41
T42
T43
T44
T45
T46
T47
T48
T49
T50
T51
T52
T53
T54
T55
ED1 CN1

R1008

1/8W
15k
?Q91

1/8W
1/8W
R61

R62

R60

100
4.7
100
R1006
B3H-0029-00 QGZ2006K1-20X

C91

? C90
1u

1
F_AUXL

2
F_AUXG

3
F_AUXR
R7

4
GND
1/4W

5
0 PANEL3.3V

6
ILM10.5
RA2 LCD_DATA_SYS

7
LCD_DATA_SYS
100 LCD_CE

KS2
KI4

8
1/16W LCD_CE
LCD_DATA_LCD

9
LCD_DATA_LCD

1/10W
S51

S50

COM4
COM3
COM2
COM1
KI5
KI4
KI3
KI2

KI1

KS6
KS4
KS3
KS2

S49
S48
S47
S46
S45
S44
S43
S42
S41
S40
S39
S38
S37

10
USB_GND

To MAIN PWB ASSY(1/2)

LCD_CLK

11
LCD_CLK

100
R1

12
USB_GND

1/16W
RA1
R3
(XJ1-136R-00)

100
470

13
ENC2

14
D+

KD-R471R2

2.8V
2.8V

2.8V
2.8V
2.8V
2.8V

2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
LRT67DU1V211

LRT67DU1V211

LRT67DU1V211

15
ENC1

16
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 D-
CN701

17
KI1/S62
KS6/S61
KS5/S60
KS4/S59
KS3/S58
KS2/S57
KS1/S56
S55
S54
S53
S52
S51
S50
S49
S48
S47
S46
S45
S44
S43
USB5V

MBRX130
D2
D21

D22

D23

18
C6 ? C7 USB5V

19
10u REMO
TL11 S36
0V 2.4V

20
61 KI2/S63 S42 40 PAN_DET
0V 2.4V S35
62 KI3/S64 S41 39
0V 2.4V S34
63 KI4/S65 S40 38
TL11 0V 2.4V S33

? D50
? D51
? D52
? D53
64 KI5/S66 S39 37
S32

1/8W

1/8W
2.5V 2.4V
1/8W
?R21

?R23

?R25
65 COM1 S38 36
R20

R22

R24

BACKLIGHT
2.5V 2.4V S31

NHSW157B
D49
66 COM2 S37 35

750

750
2.5V S30
750

2.4V
67 COM3 S36 34
2.5V 2.4V S29
68 COM4 S35 33

TL12
2.4V
4.9V
69 S67
70 VDD
IC1 S34 32
S33 31
2.4V
2.4V
S28
S27
2.4V 2.4V S26
71 S68
BU97520AKV-M S32 30

i
C1 1u 1.7V 2.4V S25
TL12
0V
72 SDO S31 29
2.4V S24
J80
R5 10.2V 4.9V 73 VSS S30 28
RA3
74 OSC/S69 S29 27
2.4V S23 E5J-0069-00

1.1k

1.1k
R48

R49
330

1/8W

1/8W

LCD_DATA_LCD
4.9V 2.4V S22

Q1

7
4700p
1/4W

LSCR523UBFS8
75 INHB S28 26

470p
C83

C84
5.6V LCD_CE 0V 2.4V S21
76 SCE S27 25 FL80

1k
R6
LCD_CLK 1.6V 2.4V S20 L7K-0030-00

1
77 SCL S26 24 VCC
LCD_DATA_SYS 0V 2.4V S19
R51

2
0.7V C85 D-
0.1V 78 SDI S25 23 C86
USB

m
6.8k P1 4.8V 2.4V S18 470p 4700p
100

3
79 S1/P1/G1 S24 22 D+
1/16W P2 4.8V S17
2.4V

27p

27p

4
GND

0
R80
0V 80 S2/P2/G2 S23 21

220

C82
1/4W

10u
Q51
LSCR523EBFS8

S3/P3/G3
S4/P4/G4
S5/P5/G5
S6/P6/G6

R81
C80

C81

DZ2J051M

DZ2J051M

5
C5

? C4
DZ2J056M

S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
D1

S7
S8
S9

6
1u

D80

D81
R50 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
0.1V
0.7V 4.3k

2.4V

2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
TL1
Q50
0V
KS2 S15A LSCR523EBFS8

S10
S11
S12
S13
S14
S15
S16
S1
S2
S3
S4
S5
S6
S7
S8
S9
S12 S13 S14 S15

6 5/USB MODE 4/REP BASS/EQ

TL2

KS3
S11A

S7 S8 S9

TL3 3/RDM 2/ 1/ SEARCH/RETURN

KS4

S3A
S6A NOTES

KS6
TL4
S3

DISPLAY/SETUP
S4

>>||
S5

||<<

S1

S1A
S6

PHONE

SOURCE/STDBY
S2A

S2

jo 1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
2. UNLESS OTHERWISE SPECIFIED.
ALL RESISTORS ARE 1/10W +5% METAL GLAZE RESISTOR.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTANCE VALUES ARE IN OHM.
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
3. COMPONENTS WITH ? IN FRONT INDICATE NOT USE.
TL6

EJECT
TL5

TL7

TL8

TL9
KI2

KI3

KI4

KI5
KI1

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)11/26
CD MECHA PWB ASSY (LVA20106-01A)
To MAIN PWB ASSY(2/3) To MAIN PWB ASSY(2/2)
(XJ1-092x-xx) (XJ1-136R-00)
Except KD-R471R2 KD-R471R2
CN502 CN502

14 DRV_MUTE
R47 R48

18 DRV_Lo/Ej
21 DRV_CNT

2 Vcc3.3V
0 1/4W 0 1/4W

10 B(VF1)

3 E(VT2)

1 A(VF2)
8 F(VT1)
23 MGND
22 MGND

13 DGND

4 PSW
11 GND

6 SW2
5 SW1
CN1

15 FOD
24 M8V

16 TRD

12 M8V
19 TVD
20 SPL

17 Vref
OPEN

9 PD

7 LD
QGF1044F2-24X C57

0.1u

VCC
VF2

VT2

VT1

VF1
MD
LD
TP40

TP45

TP42

TP37

TP41

TP36

TP39
i
TP43
GND

m DRV_MUTE
F- 15 F-
TP67

DGND
14 F+

M8V
FOD F+
TP90 TP66 13 T+
SW3
NSW0350-001X T+ 12 T-
1 4 TRD TP64

TP92

TP94
TP89 11 GND

TP3
8.2k

8.2k
T-

R18

R21
Lo/Ej TP65 10 VF1
TP91 R50
2 3 9 VR
TVD VR 130 PICK UP
EJECT

SLOUT
LOAD

TP87 TP125 8 MD
SLIN
PSW
GND

PSW OPEN
SP+

R38
SP-

C56
7 VC

2.7k
SPL VC
TP86 TP44 0

R24
R40

PRTOUT
0 0.1u 6 VT1
DRV_CNT
TP5 5 GND

DGND
TP6

TP8

jo
PSW
R30
R27

5.6k

R28

110k

R29

100
C54

0.1u

TP93
4 LD
3 VT2
2 VCC
TP16

SLIN/EJECT 1 VF2
TP7 100
SLOUT/LOAD CN2

0.1u

0.1u
24 23 22 21 20 19 18 17 16 15 14 13 QGF0522F6-15W
SW1 TP9
SP+
IN1
CNT
IN2-1
IN2-2
BIAS
IN3
IN4
MUTE
PREGND
PRTC
VREG
PRTOUT
NSW0349-001X
LOS SW

3 1 TP10
POWGND1

POWGND2
SP-

OPEN
C24

OPEN
C25
POWVCC1

POWVCC2
TP81

25
VO1+

VO2+

VO3+

VO4+
VO1-

VO2-

VO3-

VO4-
0.1u

0.1u

4 2

1 2 3 4 5 6 7 8 9 10 11 12
BD8266EFV-M-X
LOS_SW MGND IC1
TP1
OPEN
C23

OPEN
C22

M8V
TP2 OPEN OPEN
C58 C59 C26
0 1/4W

SW2 C55
R37

NSW0349-001X
R42

10u
12EJE SW

10u 0.1u 0.1u

3 1 16V 16V
TP85

4 2
R36

12EJE_SW

LVA20106-01A
Power rating of all unspecified resisters is 1/10w.
Voltage fating of all unspecified capacitors is 50V.

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)12/26
 MAIN PWB ASSY XJ1-092x-xx (J7J-0020-10) Except KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

C990

W11

W12
C1021
1

R1071
D272
Q272 R270 W8
D271 A

Q273
Q340 Q250 R1042
A
E
D270 IC301 C304
Q330 R252
C1024
R601
R611
C602
C603
J600
D1390

R262
C392
C391

G C310

Q270
GND C307 R333 Q260
J321

R1039
R1040
R1041
J470

W9

Q271
C308
C390

L990

D390 W3 W4 C309 R353

R323
R343
R250 X600
Q350

R251
R261

C250
C260
R253
R390

W10
R381
R472
R471
R476
C909

C916 C251

CN990
D391 D990 Q320
R260
R1070

R1036 1
W5

W6

W7

C907 R902

W13
W1

C604
C605
R330

R331
R351

C330
C350
C906

R602
R350

L601
C169
C168

W C
W2 G
C172

B
R170

C317
C316

C318
C319
C1051

C606

C331

C351
C261 R340 C619 C616

R341
R321

C340
C320
L602

C1600
C341

C321
R603 C618 C617
D478
D470
D477
D481
D480
D479

R320

C623
R610
R609
C622
R903
J7J-0020-10

C1054 C474 C

C607
L603
R900 C609

C608
R604
RA470

C473 B
E D601 IC601
R363

R904 C167 R1160 R608 R607

C475
R901
R1051

R171
C177

C171

C170

D602
L604
D

C610
R931

C912 R364
R169 C165 C615 R612
Q930
R362
IC901

R932 D360 R168

R606
C621
R361

C361 IC161 D
C1025

C905 Q931 Q360

R167
D400

R401

R1027 C360
R360

R164

C931 1 R605

C611
XJ1-092

L605

L606
L607
C903 C612
R161
1

R587

C510 C614
R930
D905

R162

R163
C565
C564

R1091
C567
C568

C572
L540
EXT3
EXT4

C571
C563
C562

R558
C904
R562
C560
C559

E3 C163
EXT2
EXT0

C586
R1024

R1

D540 PWM
C917 R559
C557
R569

FLAG
C553
C554
R1025

IC540

C575 C164
R554
RA580
R1023
C576
R571

C942
XJ1-046
R1076
R1074
R905

IC941

R568

C941
R570
XJ1-033
1 R572
C940 R551
C578 C552
R550
ULMARK

C577
R573

C551
R8
R7

X540

i
R567

R1021

C550
CN502

1
FE
TE

F
L778
L777

R542
R544
C545
R546
R548
C546
C547
VREF
C581

C548
R940 C549
R1020

R1860
D862 R565
R1019

R411
m R410

R762 C410
C850 F R413
R1018 R366 IC411 R412
C544 R414 R747 R840
R754 R751
R752 R749

C540 R541 R748 IC841 R766

1
R1861

1
R841
R746

R1017
R761

C543 R543 1 R767

IC851

R750

R719
R717
R1015
C840
R1064
R1065

R753
R745
L711
C862
C861

R1063
R1062
C860
IC861

R760
R1012
R1066

R744
R718

L710 R6 R765
R757
D861

R12
R11

R820
R701

L709 R5 R365
R1013
C852

E1 R867
R743

R868
L823
L822

IC701 L824
R1080

R13
L712
R702

1 L821 R10
1
R864
R865
R866
C870

L820 R9
R703
L861

R704

L825

L826
R14

R15

R708
R1081

1
C864
R861

R707
C869
C863

IC821
C702
L860

R705
C820
R470
R304

C868
R477
C1000
Q471
Q470

C711

L701
R478 R4
jo
R483
R482

R1090
C1001
RA701

R724 L827 R16

C710

R711 R722
R1054
C867
C866

R726
R728

R821 C821
R1000
R1001
R1002

C707

R734
R373
R731

R822 C822
R756
R755
R712
R714
R716

R713
R1007 R715
R1006 X701
R730

R732

R721 R729
R403
R720

C831
C708
R725

R723 R727
R103
C101

C830

R1717 C890 Q701

R709

1
R1715
E2
C832
R104
C102

CN701 IC831
R1022

R1009
C1023

C1022 R1008
D101

S830
C104
C103
C105
D100
R100

C100

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)13/26
 MAIN PWB ASSY XJ1-092x-xx (J7J-0020-10) Except KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

How to repair a fuse pattern.

Refer to "2.1 How to repair a fuse pattern".

R1086 J470
C472
D370 R370 D401 CN990

R372
C312
C1010

OE R400
R1011 R303

C369
C306
C990

C1605
C1004

FR C370 R371
MEM
AC BUP
C1032

C1604

C1012
TMUTE
SUBR

L990
C303 IC301 R302
RR J321 RL SUBL FL
C1320
C1003

D990

C1900
R1600

R1300
C1601 C304
C1031

PIN10 C1603

REM

C915
D1600

C305

R271
R600
C601

A.ANT
D273
R273
C368

C1020 TU33

X600 FLG
C907
J600
VA600

C913
C911
C1300

L600
C600

C1011
C1013
C1015
C1017
C1016
C1014

VCC1
C1602
SIG

C905 ACC
C624

C165

VCC2
D902 AUD
R1050 ANT

C161 OUTR D903 CD

TU.R OUTL
C1050 R1052
IC901 EXT

C583
TU.L

C584
C162 R589 L574 R2

C908

ILM
C1052

C588
DIMMER_IN
C163
R579 C903

C574

C914
C1028
C573

R1029
R590
C570 C1901
ARF CD33
R1030
C164

C558
R580
C589
C561

CD15
R557

RF

C556
C555
C580

IOP- PC
DB2B C579
Q540
C582
IOP+

i C585

R1083

C1053
C541
C542
MONO
m R556

CNT

SW33 R764
R763
PIN6 PIN2 R1049
CN502

PIN5 R850

C851
C718
PIN3
DB2C
C717

C852
SDA
R1082

TM

SCL
C716
R1714

R758
R421

FB1

C1033 FB
C700
C712

VDD LCLK
V125

R3 C701
RXM

CS DO WP DI
L700
C713

C703
C1034

HOLD
DB1A
R1047
TRST

CLK GND1 R862

TMS
TCK

TDI

C706 DB1B C892 C868

TXM
jo
DB1C
R780

R781

C1090
R1048

V6
TDO

C709 C705
ASEBRK C704
R735
R733

R402

C723
DB2A
R894

ASEMD 1
ERR1
D701

GND2 C893
D702

C725
C1002
C1035

R892
C891
D703

IC891
C724

RST2 RST1 C890 R890

R785

VOL2
R784

V10.5
PDET

REM2
5V

P33
R1043
R830

R1045
C722

LDI

AG

S830
AL
AR VOL1

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)14/26
 MAIN PWB ASSY XJ1-136R-00 (J7J-0020-10) KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

C990

W11

W12
C1021
1

R1071
D272
Q272 R270 W8
D271 A

Q273
Q340 Q250 R1042
A
E
D270 IC301 C304
Q330 R252
C1024
R601
R611
C602
C603
J600
D1390

R262
C392
C391

G C310

Q270
GND C307 R333 Q260
J321

R1039
R1040
R1041
J470

W9

Q271
C308
C390

L990

D390 W3 W4 C309 R353

R323
R343
R250 X600
Q350

R251
R261

C250
C260
R253
R390

W10
R381
R472
R471
R476
C909

C916 C251

CN990
D391 D990 Q320
R260
R1070

R1036 1
W5

W6

W7

C907 R902

W13
W1

C604
C605
R330

R331
R351

C330
C350
C906

R602
R350

L601
C169
C168

W C
W2 G
C172

B
R170

C317
C316

C318
C319
C1051

C606

C331

C351
C261 R340 C619 C616

R341
R321

C340
C320
L602

C1600
C341

C321
R603 C618 C617
D478
D470
D477
D481
D480
D479

R320

C623
R610
R609
C622
R903
J7J-0020-10

C1054 C474 C

C607
L603
R900 C609

C608
R604
RA470

C473 B
E D601 IC601
R363

R904 C167 R1160 R608 R607

C475
R901
R1051

R171
C177

C171

C170

D602
L604
D

C610
R931

C912 R364
R169 C165 C615 R612
Q930
R362
IC901

R932 D360 R168

R606
C621
R361

C361 IC161 D
C1025

C905 Q931 Q360

R167
D400

R401

R1027 C360
R360

R164

C931 1 R605

C611
XJ1-092

L605

L606
L607
C903 C612
R161
1

R587

C510 C614
R930
D905

R162

R163
C565
C564

R1091
C567
C568

C572
L540
EXT3
EXT4

C571
C563
C562

R558
C904
R562
C560
C559

E3 C163
EXT2
EXT0

C586
R1024

R1

D540 PWM
C917 R559
C557
R569

FLAG
C553
C554
R1025

IC540

C575 C164
R554
RA580
R1023
C576
R571

C942
XJ1-046
R1076
R1074
R905

IC941

R568

C941
R570
XJ1-033
1 R572
C940 R551
C578 C552
R550
ULMARK

C577
R573

C551
R8
R7

X540

i
R567

R1021

C550
CN502

1
FE
TE

F
L778
L777

R542
R544
C545
R546
R548
C546
C547
VREF
C581

C548
R940 C549
R1020

R1860
D862 R565
R1019

R411
m R410

R762 C410
C850 F R413
R1018 R366 IC411 R412
C544 R414 R747 R840
R754 R751
R752 R749

C540 R541 R748 IC841 R766

1
R1861

1
R841
R746

R1017
R761

C543 R543 1 R767

IC851

R750

R719
R717
R1015
C840
R1064
R1065

R753
R745
L711
C862
C861

R1063
R1062
C860
IC861

R760
R1012
R1066

R744
R718

L710 R6 R765
R757
D861

R12
R11

R820
R701

L709 R5 R365
R1013
C852

E1 R867
R743

R868
L823
L822

IC701 L824
R1080

R13
L712
R702

1 L821 R10
1
R864
R865
R866
C870

L820 R9
R703
L861

R704

L825

L826
R14

R15

R708
R1081

1
C864
R861

R707
C869
C863

IC821
C702
L860

R705
C820
R470
R304

C868
R477
C1000
Q471
Q470

C711

L701
R478 R4
jo
R483
R482

R1090
C1001
RA701

R724 L827 R16

C710

R711 R722
R1054
C867
C866

R726
R728

R821 C821
R1000
R1001
R1002

C707

R734
R373
R731

R822 C822
R756
R755
R712
R714
R716

R713
R1007 R715
R1006 X701
R730

R732

R721 R729
R403
R720

C831
C708
R725

R723 R727
R103
C101

C830

R1717 C890 Q701

R709

1
R1715
E2
C832
R104
C102

CN701 IC831
R1022

R1009
C1023

C1022 R1008
D101

S830
C104
C103
C105
D100
R100

C100

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)15/26
 MAIN PWB ASSY XJ1-136R-00 (J7J-0020-10) KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

How to repair a fuse pattern.

Refer to "2.1 How to repair a fuse pattern".

R1086 J470
C472
D370 R370 D401 CN990

R372
C312
C1010

OE R400
R1011 R303

C369
C306
C990

C1605
C1004

FR C370 R371
MEM
AC BUP
C1032

C1604

C1012
TMUTE
SUBR

L990
C303 IC301 R302
RR J321 RL SUBL FL
C1320
C1003

D990

C1900
R1600

R1300
C1601 C304
C1031

PIN10 C1603

REM

C915
D1600

C305

R271
R600
C601

A.ANT
D273
R273
C368

C1020 TU33

X600 FLG
C907
J600
VA600

C913
C911
C1300

L600
C600

C1011
C1013
C1015
C1017
C1016
C1014

VCC1
C1602
SIG

C905 ACC
C624

C165

VCC2
D902 AUD
R1050 ANT

C161 OUTR D903 CD

TU.R OUTL
C1050 R1052
IC901 EXT

C583
TU.L

C584
C162 R589 L574 R2

C908

ILM
C1052

C588
DIMMER_IN
C163
R579 C903

C574

C914
C1028
C573

R1029
R590
C570 C1901
ARF CD33
R1030
C164

C558
R580
C589
C561

CD15
R557

RF

C556
C555
C580

IOP- PC
DB2B C579
Q540
C582
IOP+

i C585

R1083

C1053
C541
C542
MONO
m R556

CNT

SW33 R764
R763
PIN6 PIN2 R1049
CN502

PIN5 R850

C851
C718
PIN3
DB2C
C717

C852
SDA
R1082

TM

SCL
C716
R1714

R758
R421

FB1

C1033 FB
C700
C712

VDD LCLK
V125

R3 C701
RXM

CS DO WP DI
L700
C713

C703
C1034

HOLD
DB1A
R1047
TRST

CLK GND1 R862

TMS
TCK

TDI

C706 DB1B C892 C868

TXM
jo
DB1C
R780

R781

C1090
R1048

V6
TDO

C709 C705
ASEBRK C704
R735
R733

R402

C723
DB2A
R894

ASEMD 1
ERR1
D701

GND2 C893
D702

C725
C1002
C1035

R892
C891
D703

IC891
C724

RST2 RST1 C890 R890

R785

VOL2
R784

V10.5
PDET

REM2
5V

P33
R1043
R830

R1045
C722

LDI

AG

S830
AL
AR VOL1

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)16/26
 SWITCH PWB ASSY(1/2) XJ6-055x-xx (J7J-0195-00) Except KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

S1A

S1

IC90
S15A

S11A
S15
S6

J80
S6A

i
D21

m
S3
S3A

S4
S5
S20
ED1 S2A S2
D23
S8 S7 S12
D22
S9 S14 S13

J60

jo
No.MA612 created date:2016-03-03
(No.MA612<Rev.002>)17/26
SWITCH PWB ASSY(1/2) XJ6-055x-xx (J7J-0195-00) Except KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

KS6 KI4
R91

XJ6-055 XJ6-065

R1008
R1010
R1009
R1007
J7J-0195-00 XJ6-056 XJ6-067 C91
KI5
C90
R1006

D50

D52
C84
D81
C83 R80

Q90
C86

C85

Q91
C82
J80

S20
R81

C81
C80

ULMARK

R7

i
FL80
R21
KS2 R49
CN1
C1000

R1005 R51

C7
D80 R48

R3
R50 R20

C6
R24 Q51

KS4
m
D51

RA2

R1

1
R25 R22
J60

Q50
RA3
KI2 R5 R23
D53 KI3
IC1

RA1
KS3
R61 C1
KI1
R62 C4

A/2 K

R6

D1

D2
Q1
C5
R60
D61 D60 W
C61 C60

jo
No.MA612 created date:2016-03-03
(No.MA612<Rev.002>)18/26
SWITCH PWB ASSY(2/2) XJ6-055x-xx (J7J-0195-00) Except KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

XJ6067

XJ6065
D49
i
m
jo

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)19/26
SWITCH PWB ASSY(2/2) XJ6-055x-xx (J7J-0195-00) Except KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

J7J-0195-00
ULMARK

B/2 XJ6055
XJ6056

i
m
jo

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)20/26
 SWITCH PWB ASSY(1/2) XJ6-074R-00 (J7J-0195-00) KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

S1A

S1

IC90
S15A

S11A
S15
S6

J80
S6A

i
D21

m
S3
S3A

S4
S5
S20
ED1 S2A S2
D23
S8 S7 S12
D22
S9 S14 S13

J60

jo
No.MA612 created date:2016-03-03
(No.MA612<Rev.002>)21/26
SWITCH PWB ASSY(1/2) XJ6-074R-00 (J7J-0195-00) KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

KS6 KI4
R91

XJ6-055 XJ6-065

R1008
R1010
R1009
R1007
J7J-0195-00 XJ6-056 XJ6-067 C91
KI5
C90
R1006

D50

D52
C84
D81
C83 R80

Q90
C86

C85

Q91
C82
J80

S20
R81

C81
C80

ULMARK

R7

i
FL80
R21
KS2 R49
CN1
C1000

R1005 R51

C7
D80 R48

R3
R50 R20

C6
R24 Q51

KS4
m
D51

RA2

R1

1
R25 R22
J60

Q50
RA3
KI2 R5 R23
D53 KI3
IC1

RA1
KS3
R61 C1
KI1
R62 C4

A/2 K

R6

D1

D2
Q1
C5
R60
D61 D60 W
C61 C60

jo
No.MA612 created date:2016-03-03
(No.MA612<Rev.002>)22/26
SWITCH PWB ASSY(2/2) XJ6-074R-00 (J7J-0195-00) KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
XJ6067

XJ6065
D49
i
m
jo

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)23/26
SWITCH PWB ASSY(2/2) XJ6-074R-00 (J7J-0195-00) KD-R471R2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

J7J-0195-00
ULMARK

B/2 XJ6055
XJ6056

i
m
jo

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)24/26
CD MECHA PWB ASSY LVA20106-01A (LVB20106-001B)
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

SW3

LVA20106-A2
B/2
N

PBF
F1A
S1B
R47

R48

CN2
VR

i 1
R50
R38
VC
LD

m T-
VT2

C57
VF2

VCC

F-

F+

T+
CN1

GND
1
VT1

LVB20106-001B
VF1

LVA20106-
MD
jo
M8V

A/2
DGND

C26
D-MUTE

PRTOUT A1
C59 C24
N
R18
R21

R29
C56

C25
R37 R36
TRD

C54

FOD
R40

D-CNT
S1B R28
R24

R42
R30

F1A
Lo/Ej
TVD

IC1
SPL

C58
R27

C55
MGND

BLK
M8V

SP-
RED
C22
OUT/Lo

SP+
YEL
IN/EJ

WHT
C23

PSW
ORG DGND
SW1
LOS SW
ORG
12EJE SW

SW2

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)25/26
CD MECHA PWB ASSY LVA20106-01A (LVB20106-001B)
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))

i
m
jo

No.MA612 created date:2016-03-03

(No.MA612<Rev.002>)26/26