CANADA : http//biz.lgservice.

com
USA : http//www.lgservice.com
: http//lgservice.com/techsup.html

PLASMA TV
SERVICE MANUAL
CHASSIS : AF-05FB

MODEL : 42PX5D 42PX5D-UB

CAUTION
BEFORE SERVICING THE CHASSIS,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.

Downloaded from www.Manualslib.com manuals search engine

 SAFETY PRECAUTIONS

IMPORTANT SAFETY NOTICE

Many electrical and mechanical parts in this chassis have special safety-related characteristics. These parts are identified by in
the Schematic Diagram and Replacement Parts List.
It is essential that these special safety parts should be replaced with the same components as recommended in this manual to
prevent X-RADIATION, Shock, Fire, or other Hazards.
Do not modify the original design without permission of manufacturer.

General Guidance Leakage Current Hot Check (See below Figure)

Plug the AC cord directly into the AC outlet.
An lsolation Transformer should always be used during Do not use a line Isolation Transformer during this check.
the servicing of a receiver whose chassis is not isolated from Connect 1.5K/10watt resistor in parallel with a 0.15uF capacitor
the AC power line. Use a transformer of adequate power rating between a known good earth ground (Water Pipe, Conduit, etc.)
as this protects the technician from accidents resulting in and the exposed metallic parts.
personal injury from electrical shocks. Measure the AC voltage across the resistor using AC
voltmeter with 1000 ohms/volt or more sensitivity.
It will also protect the receiver and it's components from being Reverse plug the AC cord into the AC outlet and repeat AC
damaged by accidental shorts of the circuitary that may be voltage measurements for each esposed metallic part. Any
inadvertently introduced during the service operation. voltage measured must not exceed 0.75 volt RMS which is
corresponds to 0.5mA.
If any fuse (or Fusible Resistor) in this monitor is blown, replace In case any measurement is out of the limits sepcified, there is
it with the same specified type. possibility of shock hazard and the set must be checked and
repaired before it is returned to the customer.
When replacing a high wattage resistor (Oxide Metal Film
Resistor, over 1W), keep the resistor 10mm away from PCB.

Keep wires away from high voltage or high temperature parts. Leakage Current Hot Check circuit
AC Volt-meter

Leakage Current Cold Check(Antenna Cold Check)

With the instrument AC plug removed from AC source,
connect an electrical jumper across the two AC plug prongs. Good Earth Ground
Place the AC switch in the on positioin, connect one lead of such as WATER PIPE,
ohm-meter to the AC plug prongs tied together and touch other To Instrument's CONDUIT etc.
ohm-meter lead in turn to each exposed metallic parts such as 0.15uF
exposed
antenna terminals, phone jacks, etc. METALLIC PARTS
If the exposed metallic part has a return path to the chassis, the
measured resistance should be between 1MΩ and 5.2MΩ.
When the exposed metal has no return path to the chassis the 1.5 Kohm/10W
reading must be infinite.
An other abnormality exists that must be corrected before the
receiver is returned to the customer.
CANADA: LG Electronics Canada, Inc. 550 Matheson
Boulevard East Mississauga, Ontario L4Z 4G3

USA : LG Customer Interactive Center

P.O.Box 240007, 201 James Record Road Huntsville,
AL 35824
Digital TV Hotline 1-800-243-0000

-2 -

Downloaded from www.Manualslib.com manuals search engine

 TABLE OF CONTENTS

DESCRIPTION OF CONTROLS ...........................................4

SPECIFICATIONS.................................................................8

ADJUSTMENT INSTRUCTIONS ..........................................9

PRINTED CIRCUIT BOARDS .............................................18

BLOCK DIAGRAM...............................................................23

EXPLODED VIEW...............................................................24

EXPLODED VIEW PARTS LIST .........................................25

REPLACEMENT PARTS LIST ............................................26

SCHEMATIC DIAGRAM..........................................................

-3 -

Downloaded from www.Manualslib.com manuals search engine

 DESCRIPTION OF CONTROLS

Controls

- This is a simplified representation of a front panel.

- Here shown may be somewhat different from your TV.
- Here shown may be somewhat different from index window position of 42PX5D model.

Front Panel Controls

INDEX
Switches
LED
Display on
TV GUIDE
or off.

TV GUIDE

CHANNEL (E, D) Buttons

VOLUME (F,G) Buttons Power Standby Indicator

Illuminates orange in
MENU Button
standby mode.
TV/VIDEO Button
When the TV is turned on,
TV GUIDE Button the indicator will blink
Remote Control
green for 3-4 seconds
Sensor
POWER Button before the picture is seen.

-4 -

Downloaded from www.Manualslib.com manuals search engine

 DESCRIPTION OF CONTROLS

Connection Options

Back Connection Panel

S-VIDEO Input
FRONT
A/V INPUT
A connection is available to provide
S-VIDEO better picture quality than the video
input.
VIDEO Input

VIDEO
Connects the video signal from a
video device.

L / MONO
AUDIO Input

R AUDIO
Connections are available for listening
stereo sound from an external device.

Memory Card Slots

RGB/AUDIO INPUT
IEEE1394 Connect the monitor output
Connect a DVHS, a Remote Control Port
from a PC to the appropriate Connect your wired
MicroMV Camcorder, or input port.
a set-top box to remote control here.
IEEE1394 Connector.
DVD/DTV Input
S-Video Input
RS-232C INPUT (CON- (Component 1-2)
Connect S-
G-LINK TM TROL/SERVICE) PORT Connect a component Antenna Input
Video out from
Connect an IR Connect to the RS-232C video/audio device to Connect over-the-
an S-VIDEO
controller to this port on a PC. these jacks. air signals to this
device to the S-
jack. VIDEO input. jack.

RS-232C INPUT
(CONTROL/SERVICE)

VIDEO AUDIO VIDEO AUDIO

OUTPUT
AC INPUT
Cable L R L R
HDMI 2 COMPONENT INPUT 2 MONITOR OUTPUT
COMPONENT2 DIGITAL AUDIO (OPTICAL)
IEEE-1394 INPUT DVD
REMOTE CABLE ANTENNA
/DTV
AUDIO INPUT CONTROL
HDMI1 /DVI RGB INPUT
INPUT (MONO)
DVI COMPONENT INPUT 1 A/V INPUT S-VIDEO
INPUT

CableCARD™ Digital Audio (DVI: Digital Monitor Output

Used for Visual Connect a second
CableCARD™ Interface/Component2) Audio/Video Input TV or Monitor.
received from Cable Input/ Connect audio/video
Service Provider. Digital Audio Output output from an CABLE Input
Connect digital audio from external device to Connect cable signals to this
HDMI1/DVI, HDMI 2 various types of equipment. jack, either directly or through
these jacks.
Connect a HDMI sig- Note: In standby mode, a cable box.
nal to HDMI1/DVI or these ports will not work.
HDMI2. Or connect a Power Cord Socket
DVI(Video) signal to This TV operates on an AC power. The voltage
HDMI1/DVI. is indicated on the Specifications page. Never
attempt to operate the TV on DC power.

Note: After removing the cover, you can insert the CableCARD™ or connect to the G-LINK jack.

-5 -

Downloaded from www.Manualslib.com manuals search engine

 DESCRIPTION OF CONTROLS

Remote Control Key Functions

- When using the remote control, aim it at the remote control sensor on the TV.

TV/VIDEO
External input modes rotate in regular
POWER sequence: Antenna, Cable, Video, Front
Turns your TV or any other programmed TV INPUT TV/VIDEO
Video, Component 1-2, RGB-DTV (or
equipment on or off, depending on mode. RGB-PC), HDMI1/DVI and HDMI2 input
sources.
MODE (Video, Front Video, Component 1-2 input
MODE

Selects the remote operating mode: TV, sources are linked automatically, only if
DVD, VCR, AUDIO, CABLE or STB. Select these are connected )
a mode other than TV, for the remote to
operate an external device.
DAY
DAY - +

TV GUIDE
MENU
Brings up the TV Guide On Screen sys-
Brings up the main menu to the screen.
tem to the screen.
Enters or exits a Panel Menu in the TV Guide
On Screen system.
INFO
EXIT
Channel information is displayed on top of
EXIT 1394 the screen. But not available in
Clears all on-screen displays and returns to Component 1-2, RGB, HDMI1/DVI and
HDMI2 mode.
TV viewing from any menu.

Mark
MUTE Selects a photo or music you want to
Switches the sound on or off. view or play in Xstudio mode.

TIMER FAV
Lets you select the amount of time before FLASHBK Scrolls the Favorite channels.
your TV turns itself off automatically.

FLASHBK
Tunes to the recent channels.
ADJUST APM

Adjusts screen position, size, and phase in

CC FREEZE AUTO DEMO M/C EJECT
PC mode. PIP
Switches to PIP, POP (Picture-out-of-
EZ PIC Picture) and Twin picture modes in regu-
lar sequence.
Selects a factory preset picture mode Switches the video window locking or
depending on the viewing environment. unlocking in the Listings Grid.
PIPCH-/PIPCH+
Changes to the next higher/lower PIP
channel.
FREEZE
Freezes the currently-viewed picture. Main PIP INPUT
picture is frozen in PIP/Twin picture mode. Selects the input source for the sub pic-
ture in PIP/Twin picture mode.
SWAP
AUTO DEMO Exchanges the main/sub images in
Starts the demonstration to explain the main PIP/Twin picture mode.
features of this TV.

LIGHT
Illuminates the remote control
buttons of selected mode.

-6 -

Downloaded from www.Manualslib.com manuals search engine

 DESCRIPTION OF CONTROLS

TV INPUT
• Rotates the input mode between Antenna
and Cable.
• Video, Front Video, Component 1-2,
RGB-DTV (or RGB-PC), HDMI1/DVI, VCR/DVD BUTTONS
HDMI2 TV INPUT TV/VIDEO • Controls some video cassette recorders
and IEEE1394 input sources, screen or DVD players. ("RECORD" button is not
returns to the last TV. available for DVD players.)
MODE < Only TV mode >
•In Photo mode of Xstudio, the view state
changes to the slide show state with the
Brings up the menu to select the Photo or “PLAY” button and the slide show state
Music mode of Xstudio for memory cards. changes to the view state with the
DAY
DAY - + “PAUSE” button.
• In Music mode of Xstudio, these controls
THUMBSTICK (Up/Down/Left/Right/ENTER) are functional “PAUSE”, “STOP”, ”PLAY”,
Allows you to navigate the on-screen menus ”(Left/Right) SKIP” buttons. Note that FF
and REW do not work in this mode.
and adjust the system settings to your pref-
•Controls the DVHS or Camcorder in IEEE
erence.
1394 mode.
EXIT
1394
1394 DAY+/DAY-
Moves the Listings Grid forward or back-
ward in 24 hour increments.

VOLUME UP/DOWN CHANNEL UP/DOWN

Increases/decreases the sound level.
Selects available channels found during
Manual scan.
PAGE UP/PAGE DOWN
NUMBER buttons Moves from one full set of screen infor-
mation to the next one.

FLASHBK
RATIO
SAP Changes the aspect ratio.
Selects MTS sound: Mono, Stereo, and
SAP in Analog mode. Change the audio lan-
guage in DTV mode. APM
EZ SOUND
CC FREEZE AUTO DEMO M/C EJECT
Selects the sound appropriate for the
program's character.
CC
Select a closed caption:
Off, CC1~4, Text1~4.
APM (Adaptive Picture Mode)
Concurrently, compare with the
Daylight, Normal, Night Time and
Custom on the screen.
M/C EJECT
Remove the Memory
Card.

-7 -

Downloaded from www.Manualslib.com manuals search engine

 SPECIFICATIONS

MODELS 42PX4D-UB / 42PX5D-UB

Width (inches / mm) 49.3 / 1252

Height (inches / mm) 27.8 / 705.5

Depth (inches / mm) 11.3 / 286.7

Weight (pounds / kg) 85.3 / 38.7

Resolution 1024x768 (Dot)

Power requirement AC100-240V ~ 50/60Hz

Television System NTSC-M, ATSC

Program Coverage VHF 2 ~ 13, UHF 14 ~ 69, DTV 2 ~ 69, CATV 1 ~ 135, CADTV 1 ~ 135.

External Antenna Impedance 75 Ω

Color 16,770,000 (256 steps of each R, G and B)

Operating Temperature Range 32 ~ 104°F (0 ~ 40°C)

Operating Humidity Range Less than 80%

Maximum Elevation 6561 feet (2000m)

• The specifications shown above may be changed without prior notice for quality improvement.

-8 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

1. Application Object 4. Gemstar VBI Micom Download

These instructions are applied to all of the PDP TV, AF-05FB.
4-1. Preparation for Adjustment
(1) As shown below, connect the MPLAB ICD2 equipment, PC
and Digital Connector.
2. Notes (2) Turn on the MPLAB ICD2 POWER Supply.
(1) Because this is not a hot chassis, it is not necessary to use (3) After turn on the PC and MONITOR, select the ‘MPLAB
an isolation transformer. However, the use of isolation IDE’ from the screen.
transformer will help protect test equipment.
(2) Adjustments must be done in the correct order.
(3) The adjustments must be performed in the circumstance of +13V

25±5°C of temperature and 65±10% of relative humidity if GND

there is no specific designation. Data

(4) The input voltage of the receiver be must kept 110V, 60Hz
when adjusting.
(5) The receiver must be operational for about 15 minutes Connect the RS-232 or USB Cable <Digital Board>

prior to the adjustments. Connect the MPLAB ICD2 and connector of Digital Board

1) After receiving 100% white pattern, the receiver must be

operated prior to adjustment. (Or 7. White Pattern
condition in EZ - Adjust) 4-2. Adjustment Sequence
2) Enter into White Pattern (1) When the program is executed, select the MPLAB ICD2
- Press POWER ON Key on the Service Remote from Programmer -> Select Programmer .
Control (S R/C)
- Enter the Ez - Adjust by pressing ADJ Key on the
Service Remote Control (S R/C).
- Select the 7. White Pattern using CH +/- Key and
press the Enter(Y) Key.
Display the 100% Full White Pattern.

[ Set is activated HEAT-RUN without signal generator in

this mode.

If you turn on a still screen more than 20 minutes (Especially (2) Select "Configure -> Select Device".
Digital pattern(13 CH), Cross Hatch Pattern), an afterimage
may occur in the black level part of the screen.

3. EPLD Download

VSC (3) When the "Select Device" window appears, select the
PC
B/D
PIC18F1220 from "Device" and press OK.

<Fig 1> Connection Diagram of EPLD Download

(1) Test Equipment: PC, Jig for download

(2) Connect the power of VSC B/D.
(3) Execute download program(iMPACK) of PC.
(4) After executing the hot key on the Programmer, click icon
(5) End after confirming

-9 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

(4) Select "Programmer -> Connect". (8) The execution of process (6) is convenient when using the
short-cut icon.

When connected with the Micom, the display message on

the Output window appears as below. 5. Gemstar IR Micom Download
Connecting to MPLAB ICD 2 5-1. Preparation for Adjustment
...Connected (1) As shown below, connect the MPLAB ICD2 equipment, PC
Setting Vdd source to MPLAB ICD 2 and Digital Connector.
(2) Turn on the MPLAB ICD2 POWER Supply.
Target Device PIC18F1220 found, revision = 0x4
(3) After turn on the PC and MONITOR, select the ‘MPLAB
...Reading ICD Product ID
IDE’ from the screen.
Running ICD Self Test
...Passed
MPLAB ICD 2 Ready +13V
+5V
GND
Data
(5) Select "File -> Import", select the Work HEX file and open. Clock

Connect the RS-232 or USB Cable <Digital Board>

Connect the MPLAB ICD2 and connector of Digital Board

5-2. Adjustment Sequence

(1) When the program is executed, select the MPLAB ICD2
from "Programmer -> Select Programmer" .

(6) Select "Programmer -> Program".

(2) Select "Configure -> Select Device".

(7) Download is executed and about 5 seconds later, the

"Programming succeeded" message is displayed on the
Output window and the Download process is ended.

- 10 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

(3) When the "Select Device" window appears, select the (6) Select "Programmer -> Program".
PIC18F242 from "Device" and press OK.

(7) Download is executed and about 3 seconds later, the

"Programming succeeded" message is displayed on the
Output window and the Download process is ended.

(8) The execution of process (6) is convenient when using the

short-cut icon.

(4) Select "Programmer -> Connect".

6. POD Certificate Download &

IEEE1394(DTCP) Download
When connect with the Micom, the display message on the
Output window appears as below.
6-1. Preparation for Adjustment
(1) Connect the MEMORY JIG and PC.
Connecting to MPLAB ICD 2 (2) Turn on the JIG MAIN POWER SWITCH.
(3) After turn on the PC and MONITOR, execute the
...Connected
‘Certificate Downloader v1.4’ from the screen.
Setting Vdd source to MPLAB ICD 2
Target Device PIC18F242 found, revision = 0x7 6-2. Adjustment Sequence
...Reading ICD Product ID (1) After open the ‘Certificate Downloader v1.4’, enter
Running ICD Self Test Connection set and set the as same below.
...Passed The port settings are determined by each PC's setup.
MPLAB ICD 2 Ready

(5) Select "File -> Import", select the Work HEX file and open.

- 11 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

(2) Select ‘Connection’ and SET connected to RS-232C. (6) When the Dialog window appears, click OK and the write
(3) After clicking "Enter", confirm that "Enter Password:" work will begin.
appears.

(7) When completed, click ‘CP Data Download: OK’

(4) Click the "OpenFile - Download" button from CP Data [ When ‘CP Data Download: OK’ does not appear, certificate
Download, ‘select the Private Key’ appears and click has not Download correctly.
ENTER. SET is rebooted and certificate Download work must be
repeated.

(5) After clicking ENTER, the ‘opens Private key' window

appears and select the Private key applied to the SET. (8) Now, you may begin IEEE1394 (DTCP) Download work.
The Private Key file name is on the Label of the Digital Select the “DTCP.dat” file by pressing the ‘DTCP File
Board. Open’ button.

- 12 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

(9) After opening the ‘DTCP.dat’ file, confirm the key list in the [ When process (11) malfunctions, it is not Download.
DTCP Key List window. DTCP Download process start again from (8).

7. Gemstar Operation Confirmation

7-1. Required Test Equipment
(1) PC with Factory Test Program
(2) G-LINK-To-PC Card (Serial GLINK(CN1202))
(3) VBI Inserter (Norpak TES3) - Guide Data Discharge
Equipment

[ In case of without the VBI Inserter(TES3), a VCR may be

used.

7-2. Preparation for Adjustments

(1) In case of with VBI Inserter(TES3): Signal uses Cable
(10) Select the desired item of DTCP key List. input and set as below.
When pressing ‘DTCP key writing’ button, the Progress
window will appear.

Input Signal

(2) In case of without VBI Inserter(TES3): VCR uses Cable

input and set as below.

(11) When completed, “DTCP key Download: OK" will display

in the Terminal window and the SET will reboot
automatically.
[ Factory Test S/W must be set to "GlinkTo PC Card" ON.

7-3. Adjustment Confirmation Work

(1) Turn on the TV and run Factory Test Program of PC.

[ Program only needs to run once, regardless of set quantity.

(2) Enter the EZ adjust menu by pressing Adjust on the

Service Remote Control (S R/C).
(3) Go to number 1 Gemstar and press Enter.
(4) TV set screen will appear as shown.

- 13 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

(5) Confrim that VBI Test, Glink Test and IR Test PASS from
the screen.

8. Cable Operation Confirmation

(1) Confirm that the Cable Card is inserted in the slot.
(2) Enter the EZ adjust menu by pressing Adjust on the
Service Remote Control (S R/C).
(3) Go to number 2 Cable Check and press the Right key (G) .
(4) Confirm items below..

Name Normal Defective

Descrambler OK Not OK

Check

CableCARD CableCARDTM CableCARDTM

is inserted. is removed.

OOB Path OK(Lock) Not OK(Unlock)

FDC_SNR OK(20dB above) Not OK(20dB under)

Video Signal Normal Screen Black Screen

(No Picture)

- 14 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

Each PCB Assy must be checked by Check JIG Set before 10. EDID(The Extended Display
assembly. (Especially, be careful Power PCB Assy which can Identification Data)/DDC
cause Damage to the PDP Module.)
(Display Data Channel) download
This is the function that enables “Plug and Play".

9. POWER PCB Assy Voltage 10-1. HDMI EDID Data Input

Adjustment (Va, Vs Voltage Adjustment)
(1) Required Test Equipment
9-1. Test Equipment : D.M.M 1EA 1) Jig for adjusting PC, DDC. (PC serial to D-sub.
Connection equipment)
9-2. Connection Diagram for Measuring 2) S/W for writing DDC(EDID data write & read)
Refer to Fig 1. 3) D-Sub cable
4) Jig for HDMI Cable connection

(2) Preparation for Adjustments &

Setting of Device
1) Set devices as below and turn on the PC and JIG.
2) Open S/W for writing DDC (EDID data write & read).
(operated in DOS mode)

PDP TV SET
(or Digital Board)

<Fig. 1> Connection Diagram of Power Adjustment for

Measuring (Power Board): 50” <Fig. 2>

9-3. Adjustment (50”) 10-2. EDID DATA for AF-05FB

(1) Va Adjustment
: EDID for HDMI 1 (DDC (Display Data Channel) Data)
EDID table =
1) Connect + terminal of D.M.M to Va pin of P805 and 0 1 2 3 4 5 6 7 8 9 A B C D E F
connect – terminal to GND pin of P805. _______________________________________________________
2) Adjust RV501 voltage to match that of the label on the 00 | 00 FF FF FF FF FF FF 00 1E 6D 01 00 01 01 01 01
Top/Right of the panel. (Deviation : ±0.5V) 10 | 00 0F 01 03 80 73 41 96 0A CF 74 A3 57 4C B0 23
20 | 09 48 4C 2F CE 00 31 40 45 40 61 40 01 01 01 01
(2) Vs Adjustment 30 | 01 01 01 01 01 01 01 1D 00 72 51 D0 1E 20 6E 28
1) Connect + terminal of D.M.M to Vs pin of P805 and 40 | 55 00 C4 8E 21 00 00 1E 01 1D 80 18 71 1C 16 20
connect – terminal to GND pin of P805. 50 | 58 2C 25 00 C4 8E 21 00 00 9E 00 00 00 FC 00 4C
2) Adjust RV401 voltage to match that of the label on the 60 | 47 2D 54 56 0A 20 20 20 20 20 20 20 00 00 00 FD
Top/Right of the panel. (Deviation : ±0.5V) 70 | 00 3B 3C 1F 2D 08 00 0A 20 20 20 20 20 20 01 77
80 | 02 03 15 F2 46 84 85 03 02 07 06 23 15 07 50 65
90 | 03 0C 00 10 00 8C 0A D0 8A 20 E0 2D 10 10 3E 96
A0 | 00 C4 8E 21 00 00 18 8C 0A D0 8A 20 E0 2D 10 10
B0 | 3E 96 00 13 8E 21 00 00 18 8C 0A A0 14 51 F0 16
C0 | 00 26 7C 43 00 C4 8E 21 00 00 98 8C 0A A0 14 51
D0 | F0 16 00 26 7C 43 00 13 8E 21 00 00 98 00 00 00
E0 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00
F0 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 88

- 15 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

: EDID for HDMI 1 (DDC (Display Data Channel) Data) 11-3. Adjustment
EDID table = (1) Select Component1 or Component2 as the input with
0 1 2 3 4 5 6 7 8 9 A B C D E F 100% Horizontal Color Bar Pattern(HozTV30Bar) in 720p
______________________________________________________ Mode and select ‘Normal’ in screen.
00 | 00 FF FF FF FF FF FF 00 1E 6D 01 00 01 01 01 01 (2) After receiving signal for at least 1 second, press the ADJ
10 | 00 0F 01 03 80 73 41 96 0A CF 74 A3 57 4C B0 23 Key on the Service R/C to enter the ‘Ez - Adjust’ and select
20 | 09 48 4C 2F CE 00 31 40 45 40 61 40 01 01 01 01 the ‘1. AD9883A-Set’.
30 | 01 01 01 01 01 01 01 1D 00 72 51 D0 1E 20 6E 28 Pressing the + Key to adjust with automatic movement.
40 | 55 00 C4 8E 21 00 00 1E 01 1D 80 18 71 1C 16 20 (3) When the adjustment is over, 'End Of AD9883A Adjust' is
50 | 58 2C 25 00 C4 8E 21 00 00 9E 00 00 00 FC 00 4C displayed. If the adjustment has errors, 'AD9883A
60 | 47 20 54 56 0A 20 20 20 20 20 20 20 00 00 00 FD Configuration Error’ is displayed.
70 | 00 3B 3C 1F 2D 08 00 0A 20 20 20 20 20 20 01 77 (4) Readjust after confirming the case Pattern or adjustment
80 | 02 03 15 F2 46 84 85 03 02 07 06 23 15 07 50 65 condition where the adjustment errors.
90 | 03 0C 00 20 00 8C 0A D0 8A 20 E0 2D 10 10 3E 96 (5) After adjustment is complete, exit the adjustment mode by
A0 | 00 C4 8E 21 00 00 18 8C 0A D0 8A 20 E0 2D 10 10 pressing the ADJ KEY.
B0 | 3E 96 00 13 8E 21 00 00 18 8C 0A A0 14 51 F0 16
C0 | 00 26 7C 43 00 C4 8E 21 00 00 98 8C 0A A0 14 51
D0 | F0 16 00 26 7C 43 00 13 8E 21 00 00 98 00 00 00
E0 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 12. Adjustment of White Balance
F0 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 78
12-1. Required Equipment
: EDID DATA for RGB (1) Color analyzer (CA-100 or similar product)
EDID table = (2) Automatic adjustor (with automatic adjustment hour
00 01 02 03 04 05 06 07 08 09 0A 0B 0C 0D 0E 0F necessity and the RS-232C communication being possible)
____________________________________________________ (3) Pattern Generator(MSPG-925FA): DVI Output
00 | 00 FF FF FF FF FF FF 00 1E 6D 01 01 01 01 01 01
10 | 06 0D 01 03 18 5C 34 96 08 CF 72 A3 57 4C B0 23 12-2. Connection Diagram of Equipment
20 | 09 45 5D EF CE 00 31 D9 31 59 45 59 01 01 01 01 for Measuring (Automatic Adjustment)
30 | 01 01 01 01 01 40 C3 1E 00 20 41 00 20 30 10 60
40 | 13 00 98 08 32 00 00 18 00 00 00 FC 00 4C 47 20 COLOR
50 | 54 56 0A 20 20 20 20 20 20 20 00 00 00 FD 00 30 ANALYZER
TYPE; CA-100
60 | 4C 1E 64 0F 00 0A 20 20 20 20 20 20 00 00 00 00
70 | 00 00 00 00 00 00 00 00 00 00 00 00 00 00 00 C5
High Light Adjustment Digital RGB
PDP MONITOR
Low Light Adjustment

11. AD9883A-Set Adjustment

11-1. Synopsis MSPG-925FA
AD9883A-Set adjustment to set the black level and the Gain
of optimum with an automatic movement from the analog =>
digital converter. <Fig. 4> Connection Diagram of Automatic Adjustment

11-2. Test Equipment

Service R/C, 801GF(802B, 802F, 802R) or MSPG925FA [ RS-232C Command (Automatic Adjustment)
Pattern Generator
CENTER
(720P The Horizontal 100% Color Bar Pattern output will be RS-232C Command
MIN (DEFAULT) MAX
possible and the output level will accurately have to be [CMD ID DATA]
50” 60”
revised with 0.7±0.1Vp-p)
R Gain kv00xx 00 7f 7f ff

G Gain kw00xx 00 87 87 ff

B Gain k$00xx 00 7f 7f ff

R Cut 00 3f 3f 7f

G Cut 00 32 32 7f

B Cut 00 49 49 7f
<Fig. 3> Adjustment Pattern : 720P/60Hz HozTV30Bar Pattern

- 16 -

Downloaded from www.Manualslib.com manuals search engine

 ADJUSTMENT INSTRUCTIONS

12-3. Adjustment of White Balance

O Operate the Zero-calibration of the CA-100, then attach
sensor to PDP module surface when you adjust.
O Manual adjustment is also possible by the following sequence.

(1) Enter ‘Ez - Adjust’ by pressing ADJ KEY on the Service

Remote Control.
(2) Select "7. WHITE PATTERN" using CH +/- Key and HEAT
RUN at least 30 minutes by pressing the ENTER Key.
(3) Receive the Window pattern signal from Digital Pattern
Generator. (AV Input: connect the ‘HDMI’)
(4) After attaching sensor to center of screen, select ‘5. White-
Balance’ of ‘Ez - Adjust’ by pressing the ADJ KEY on the
Service R/C. Then enter adjustment mode by pressing the
Right KEY (G) .
(5) Adjust the Hight Light using R Gain/B Gain/B Gain and
adjust the Low Light using R Cut/G Cut/B Cut.
(6) Adjust using Volume +/- KEY.

[DU-42PX41X]
(R-Gain: 127 R-Cut: 63 Fix.)

High Level: 150gray

Low Level: 60gray

High X; 0.285±0.003 Y; 0.285±0.002

Low X; 0.285±0.004 Y; 0.285±0.004

Color temperature: 9,800°K±500°K

[DU-50PX41]
(G-Gain: 127 R-Cut: 63 Fix.)

High Level: 150gray

Low Level: 60gray

High X; 0.285±0.003 Y; 0.285±0.002

Low X; 0.285±0.004 Y; 0.285±0.004

Color temperature: 9,800°K±500°K

- 17 -

Downloaded from www.Manualslib.com manuals search engine

 PRINTED CIRCUIT BOARD

MAIN DIGITAL(TOP)

- 18 -

Downloaded from www.Manualslib.com manuals search engine

 PRINTED CIRCUIT BOARD

MAIN DIGITAL(BOTTOM)

- 19 -

Downloaded from www.Manualslib.com manuals search engine

 PRINTED CIRCUIT BOARD

MAIN ANALOG(TOP)

- 20 -

Downloaded from www.Manualslib.com manuals search engine

 PRINTED CIRCUIT BOARD

MAIN ANALOG(BOTTOM)

- 21 -

Downloaded from www.Manualslib.com manuals search engine

 PRINTED CIRCUIT BOARD

SIDE A/V POWER LED(TOP)

INDEX(TOP)

INDEX(BOTTOM)

CONTROL

SPDIF(TOP) SPDIF(BOTTOM)

- 22 -

Downloaded from www.Manualslib.com manuals search engine

 BLOCK DIAGRAM

- 23 -

Downloaded from www.Manualslib.com manuals search engine

 EXPLODED VIEW

302

300
301

121

600 601
303

310 305

560
570
306
550

120
610

307 200

304

207

104 202 201

203 206

103

204
590
205
530 580

520
501

240

102
101

502

400

430

- 24 -

Downloaded from www.Manualslib.com manuals search engine

 EXPLODED VIEW PARTS LIST

No. Part No. Description

101 5900V04010A FAN,DC EFB0412LD-W147 DELTA 40*40*20 12V/0.05A 5000RPM 7.0-13.8VDC L=100MM
102 4980V00327B SUPPORTER,FAN EGI 40*40*20,50PY20 PRESS
103 5900V06008B FAN,DC G6015S12B2-RG DONGYANG 60*60*15 7V 1900RPM 6/12V L=500MM
104 4980V00D43B SUPPORTER,FAN SECC(EGI) MZ-42PM10 PRESS
120 6401VD0024A SPEAKER ASSEMBLY,FULL RANGE(R) NON RZ-42PX40 R
121 6401VD0025A SPEAKER ASSEMBLY,FULL RANGE(L) NON RZ-42PX40 L
200 6348Q-E074Z PDP,42 1024*768 PDP42X20022.AKLGG
6348Q-E091U PDP,42 1024*768 PDP42X20022.DDRSA C/SKD
201 6871QCH060B PCB ASSEMBLY,DISPLAY CTRL ASSY 42X2AI CTRL LGDP4024 MCM REV.
202 6871QYH042B PCB ASSEMBLY,DISPLAY YSUS ASSY 42HD 42X2A
203 6871QDH090B PCB ASSEMBLY,DISPLAY YDRV ASSY 42HD 42X2A YDRV TOP
204 6871QDH091B PCB ASSEMBLY,DISPLAY YDRV ASSY 42HD 42X2A YDRV BTM
205 6871QLH037A PCB ASSEMBLY,DISPLAY XRLT ASSY 42X2 X-LEFT(TCP)
206 6871QRH043A PCB ASSEMBLY,DISPLAY XRRT ASSY 42X2 X-RIGHT (TCP)
207 6871QZH047B PCB ASSEMBLY,DISPLAY ZSUS ASSY 42HD 4X2A
240 4980V00C84A SUPPORTER ASSY,AL RZ-42PX40
4980V00C84B SUPPORTER ASSY,AL 42PX40X C/SKD
300 3091V00775A CABINET ASSEMBLY,DU-42PX5 NON AF05FB 2PIECE
3091V00775H CABINET ASSEMBLY,42PX5D-UB NON NON 2PIECE C/SKD
301 3090V00660A CABINET,42PX5 (2PIECE) PDP NON
302 3211V00193A FRAME ASSEMBLY,FRONT 42PX5 NON
303 4980V01128B SUPPORTER ASSY,AL DU-42PX41XS 0.8T TOP
4980V01128C SUPPORTER ASSY,AL 42PX4D-UB 0.8T TOP C/SKD
304 4980V01130B SUPPORTER ASSY,AL DU-42PX41XS 0.8T BOTTOM
4980V01130C SUPPORTER ASSY,AL 42PX4D-UB 0.8T BOTTOM C/SKD
305 3790V00709C FILTER(MECH),LGM42-09 MITSUI 42”
3790V00709B FILTER(MECH),LGM42-01 MITSUI 42 ETCHING MESH GLASS FILTER *LGECI
306 4980V01134B SUPPORTER ASSY,AL 42PX4D-UB 0.8T LEFT
4980V01134C SUPPORTER ASSY,AL 42PX4D-UB 0.8T LEFT C/SKD
307 4980V01132B SUPPORTER ASSY,AL 42PX4D-UB 0.8T RIGHT
4980V01132C SUPPORTER ASSY,AL 42PX4D-UB 0.8T RIGHT C/SKD
310 5020V01022A BUTTON,CONTROL RZ-42PX40 ABS, AF-303S 8KEY NON
5020V01022B BUTTON,CONTROL DU-42PX51X ABS, AF-303S 8KEY TITAN GRAY
400 3809V00513D BACK COVER ASSEMBLY,DU-42PX41X NON DARK TITAN BLACK
3809V00513S BACK COVER ASSEMBLY,42PX4D-UB(DU-42PX41X) NON EPF,LGERS SKD
430 3501V00216A BOARD ASSEMBLY,AP-42DX41 NON WITHOUT PACKING
3501V00216B BOARD ASSEMBLY,AP-42DX41 NON C/SKD
501 3301V00055B PLATE ASSEMBLY,AV 3301V00053B 3301V00054A DU-42PX41X ASSY
502 3301V00066C PLATE ASSEMBLY,AV 3300V00496C 3300V00498A DI COVER
520 6871VMMZX8A PCB ASSEMBLY,MAIN AF-05FB 42PX5D-UB DIGITAL
530 6871VSMT91A PCB ASSEMBLY,SUB TUNER AF05FB DU-42PX41X ANALOG
550 6871VSMS59A PCB ASSEMBLY,SUB LED AF05FB DU-42PX51X LEDM/I
68719SF006A PCB ASSEMBLY,SUB PAKING AF05FB 42/50PX5D-UB SUSLLBR POWER LED
560 6871VSMS58A PCB ASSEMBLY,SUB CONT AF05FB DU-42PX51X CONTROLM/I
68719SF004A PCB ASSEMBLY,SUB PAKING AF05FB 42/50PX5D-UB SUSLLBR LOCAL KEY
570 6871VSMS53A PCB ASSEMBLY,SUB LED AF05FB DU-42PX51X INDEXM/I
68719SF005A PCB ASSEMBLY,SUB PAKING AF05FB 42/50PX5D-UB SUSLLBR INDEX
580 6709V00003A POWER SUPPLY ASSEMBLY,420W 1H255W SANKEN 42INCH DCR PSU
590 3141VSN422A CHASSIS ASSEMBLY,SUB MF056A AC INET ASSY
31419SF014A CHASSIS ASSEMBLY,SUB AF05FB 42PX5D-UB SKD AC INET
600 6871VSMT96A PCB ASSEMBLY,SUB A/V AF05FB DU-50PX41S SIDE A/V
601 4811V00173D BRACKET ASSEMBLY,SIDE AV DU-42PX40X RF052C ASSY SIDE AV
4811V00173J BRACKET ASSEMBLY,SIDE AV 42PX4D-UB RF052C NO JACK C/SKD
610 3141VSNJ20A CHASSIS ASSEMBLY,SUB AF05FB DU-42X41X EPF
31419SF016A CHASSIS ASSEMBLY,SUB AF05FB 42PX5D-UB SKD EPF

- 25 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST
For Capacitor & Resistors, the CC, CX, CK, CN : Ceramic RD : Carbon Film
charactors at 2nd and 3rd digit CQ : Polyestor RS : Metal Oxide Film
in the P/No. means as follows; CE : Electrolytic RN : Metal Film RUN DATE : 2005.3.14
RF : Fusible

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

IC301 0IMCRAL021A AT24C512W-10SI-2.7 8P

IC
IC302 0IMMRHY038C HY57V561620CT-H HYNIX 54PIN
IC100 0IPRPBM001B PPC405GPR-3JB266C CPU
IC302 0ITK118100B TK11840L 8P SOT23L
IC1000 0IMCRSJ001B SC1565IST-2.5TR 2.5V 1.5A 3P SOT-223
IC303 0IMMRHY038C HY57V561620CT-H 54PIN
IC1001 0ICTMLG017A LGDT3502B LG IC 208P/PBGA
IC304 0ICTM00006A LGDT3701 LG SYSTEM IC 128P
IC1002 0IMCRFA013A 74LCX244MTC 20P
IC305 0IMMRAM006B S29JL064H90TA100 AMD 48P
IC1003 0IMCRLT002A LCT1470CS8 8P
IC305 0IPRP00538A FSA1156P6X-NL 6P/MAA06A
IC101 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC306 0IMMRAM006B S29JL064H90TA100 AMD 48P
IC101 0ISO206900A CXA2069Q QFP64 BK I2C BUS AV S/W
IC307 0IMMRFU004A MBM29DL323TE90TN 48
IC101 0IMI623200B M62320FP 16P
IC308 0IMMRFU004A MBM29DL323TE90TN FUJITSU 48
IC102 0IMCRFA015A KA7805R 2P 500MA
IC400 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC1100 0IMCR02014A TSB43DA42AZHCR 196P/BGA
IC401 0ICTMLG009C LGDT1102C HD2.3 LG IC SBGA-432P
IC1101 0IPMG00028A AZ1117H-1.5TRE1 BCD 3P/SOT-223
IC402 0IMCRTI028C TAS5122DCAR 56P/TSSOP
IC112 0IMMRAL014B AT24C02N-10SI-2.7 8P
IC404 0ICTMMI057A M37151EFFP 42P MICOM
IC1200 0IMCRMP007A PIC18F242T-I/SO 18P
IC405 0IMCRAL006A AT24C16AN-10SI-2.7 8P
IC1201 0IMCRMT003A MM1108XFFE 8P
IC406 0IKE704200J KIA7042AF SOT-89 TP 4.2V
IC1202 0IMO744053B MC74HC4053DW 16SOP 3*2CH.MUX
IC500 0IMMRSS041F K4S641632H-UC60 54P
IC1203 0IPMGNS026A LM311MX 8P
IC501 0IMMRSS041F K4S641632H-UC60 54P
IC1204 0IMCRMP006A PIC18F1220T-I/SO 28P
IC502 0IMMRSS041F K4S641632H-UC60 54P
IC1301 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC503 0IMMRSS041F K4S641632H-UC60 54P
IC1302 0IMCRTH002A THC63LVD103 64P
IC504 0IMCRTI035A TL592B-8DR 8P
IC1305 0ICTMLG018B LGDP4411 IEP2 LG IC 176P
IC504 0IMCRCY001A CY2305SXC-1HT CYPRESS SOIC 8P
IC1500 0IMCR02015A SII3512ECTU128 128P/TQFP
IC505 0ICTMLG013A LGDT1901A LG IC 24P
IC1502 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC506 0IMCRFA004A KA2904DTF 8SOP R/TP OP-AMP
IC1700 0IMI623200B M62320FP 16P
IC508 0IMCRFA010A KA7809R, 2P
IC1701 0IPRPNS054A LM75CIMX-3 8P/SOP
IC600 0IMCRFA013A 74LCX244MTC 20P
IC1702 0IPMGKE032A KIA78R09F KEC 5PIN DPAK R/TP 1A,9V
IC601 0ICB533100A CS5331A-KSR 8SOIC TP ADC -
IC1703 0IPMGKE032A KIA78R09F KEC 5PIN DPAK R/TP 1A,9V
IC601 0IPRPNE008A UPD64011BGM-8ED-A 160
IC1705 0IPMGKE032A KIA78R09F KEC 5PIN DPAK R/TP 1A,9V
IC602 0ISS416162D K4S161622H-UC80 50P
IC1706 0IMCRSH001A PQ05DZ1U SHARP 5
IC602 0IMO330780B MC33078D 8/SOIC +-18V OP AMP
IC200 0IKE702900G KIA7029AF SOT-89 TP 2.9V
IC603 0ITO741570C TC74LCX157FT 16P
IC200 0IMCRMN027D MSP4440K MICRONAS 80P
IC603 0IPRPNE008A UPD64011BGM-8ED-A NEC 160
IC201 0ISTLPH026A 74LVC14APW PHILIPS 14PIN
IC604 0ICB841500B CS8415A-CZR 28P
IC201 0ILNR00015A NSP-2100A,LF NEOFIDELITY TQFP 64P
IC605 0IPMGKE032A KIA78R09F KEC 5PIN
IC202 0IMCRFA013A 74LCX244MTC 20P
IC606 0IPMGSG018C LD1086DT15TR 2P
IC203 0IMCRXL004A XC95288XL-10TQG144C 144P
IC607 0IPRPFA015A FMS6410CSX-NL(PB-FREE) SOIC 8P
IC203 0IMCRSH001A PQ05DZ1U SHARP 5
IC608 0IPRPFA015A FMS6410CSX-NL(PB-FREE) SOIC 8P
IC204 0IMCRCY001A CY2305SXC-1HT 8P
IC800 0IPRPS5006A SIL9021CTU(PB FREE) 144P
IC204 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC801 0IMCRAD002A AD9883AKST-110 80P
IC205 0IMCRCY002A CY2309SXC-1HT 16P R/TP 3.3V
IC802 0IPMGA0010A AZ1117H-3.3 AAC SOT-223 3P
IC205 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC804 0IMMRAL014B AT24C02N-10SI-2.7 8P
IC206 0IMCRFA010A KA7809R, 2P
IC805 0IPRPFA016A FMS6407MTC20X-NL(PB-FREE) 20P
IC207 0IMCRSH001A PQ05DZ1U SHARP 5
IC808 0IMMRAL014B AT24C02N-10SI-2.7 ATMEL 8P
IC208 0IMCRFA010A KA7809R, 2P
IC809 0IMCRSJ001A SC1565IST-1.8 3P SOT223
IC209 0IPMGA0010A AZ1117H-3.3 AAC SOT-223 3P R/TP 3.3V
IC900 0IMCRXL003B XC95144XL-10TQG144C 144P
IC300 0IMCRPH026B PA9516APW PHILIPS 16P
IC902 0IPRP00009A ICL3232CBNZ 16P/SOP
IC300 0IMCRSO025A CXA2181Q SONY 48P

- 26 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

IC903 0IMO744053B MC74HC4053DW 16SOP 3*2CH.MUX Q203 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q204 0TR150400BA CHIP 2SA1504S(ASY) KEC
TRANSISTOR
Q205 0TR387500AA CHIP 2SC3875S(ALY) KEC
IC407 0TR830009BA BSS83 Q206 0TR387500AA CHIP 2SC3875S(ALY) KEC
IC408 0TR830009BA BSS83 Q207 0TR102008AA KRA102S SOT23 CHIP TR
Q101 0TR387500AA CHIP 2SC3875S(ALY) KEC Q208 0TR387500AA CHIP 2SC3875S(ALY) KEC
Q101 0TR387500AA CHIP 2SC3875S(ALY) KEC Q209 0TR387500AA CHIP 2SC3875S(ALY) KEC
Q102 0TR387500AA CHIP 2SC3875S(ALY) KEC Q301 0TR387500AA CHIP 2SC3875S(ALY) KEC
Q102 0TR387500AA CHIP 2SC3875S(ALY) KEC Q302 0TR387500AA CHIP 2SC3875S(ALY) KEC
Q103 0TR387500AA CHIP 2SC3875S(ALY) KEC Q303 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q104 0TR387500AA CHIP 2SC3875S(ALY) KEC Q305 0TRKE80038A KTC3552T-RTK SOT-23F 50V 3A
Q105 0TR387500AA CHIP 2SC3875S(ALY) KEC Q503 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q106 0TR387500AA CHIP 2SC3875S(ALY) KEC Q504 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q119 0TR150400BA CHIP 2SA1504S(ASY) KEC Q601 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q120 0TR150400BA CHIP 2SA1504S(ASY) KEC Q602 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q1200 0TR387500AA CHIP 2SC3875S(ALY) KEC Q603 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q1201 0TR390609DC 2N3906S-RTK SOT23 Q604 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q1204 0TR390609DC 2N3906S-RTK SOT23 Q6603 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q1205 0TRKE80046A 2N3904S SOT23 60V 200MA Q6604 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q121 0TR150400BA CHIP 2SA1504S(ASY) KEC Q6607 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q122 0TR387500AA CHIP 2SC3875S(ALY) KEC Q6608 0TR150400BA CHIP 2SA1504S(ASY) KEC
Q123 0TR387500AA CHIP 2SC3875S(ALY) KEC Q6609 0TR387500AA CHIP 2SC3875S(ALY) KEC
Q124 0TR150400BA CHIP 2SA1504S(ASY) KEC Q800 0TR102009AG CHIP KRC102S SOT-23 NA NA
Q125 0TR150400BA CHIP 2SA1504S(ASY) KEC Q801 0TR102009AG CHIP KRC102S SOT-23 NA NA
Q126 0TR387500AA CHIP 2SC3875S(ALY) KEC Q803 0TR830009BA BSS83
Q127 0TR150400BA CHIP 2SA1504S(ASY) KEC Q804 0TR830009BA BSS83
Q148 0TR150400BA CHIP 2SA1504S(ASY) KEC Q805 0TR830009BA BSS83
Q151 0TR387500AA CHIP 2SC3875S(ALY) KEC Q806 0TR830009BA BSS83
Q152 0TR387500AA CHIP 2SC3875S(ALY) KEC Q807 0TR830009BA BSS83
Q153 0TR387500AA CHIP 2SC3875S(ALY) KEC Q808 0TR830009BA BSS83
Q154 0TR387500AA CHIP 2SC3875S(ALY) KEC
DIODE
Q155 0TR387500AA CHIP 2SC3875S(ALY) KEC
Q156 0TR150400BA CHIP 2SA1504S(ASY) KEC D1200 0DD184009AA KDS184 TP KEC - 85V 300MA
Q157 0TR150400BA CHIP 2SA1504S(ASY) KEC D1201 0DD184009AA KDS184 TP KEC - 85V 300MA
Q158 0TR150400BA CHIP 2SA1504S(ASY) KEC D1202 0DRSE00038A SDC15 TVS SOT23 12.8V
Q159 0TR387500AA CHIP 2SC3875S(ALY) KEC D1203 0DRSE00038A SDC15 TVS SOT23 12.8V
Q160 0TR387500AA CHIP 2SC3875S(ALY) KEC D1204 0DRSE00038A SDC15 TVS SOT23 12.8V
Q161 0TR387500AA CHIP 2SC3875S(ALY) KEC D200 0DD184009AA KDS184 TP KEC - 85V 300MA
Q162 0TR387500AA CHIP 2SC3875S(ALY) KEC D204 0DZRM00248A ZENERS,RLZ8.2B-TE11
Q163 0TR387500AA CHIP 2SC3875S(ALY) KEC D301 0DD184009AA KDS184 TP KEC - 85V 300MA
Q164 0TR387500AA CHIP 2SC3875S(ALY) KEC D505 0DD184009AA KDS184 TP KEC - 85V 300MA
Q165 0TR387500AA CHIP 2SC3875S(ALY) KEC D506 0DD184009AA KDS184 TP KEC - 85V 300MA
Q166 0TR387500AA CHIP 2SC3875S(ALY) KEC D800 0DD184009AA KDS184 TP KEC - 85V 300MA
Q167 0TR387500AA CHIP 2SC3875S(ALY) KEC D801 0DD184009AA KDS184 TP KEC - 85V 300MA
Q175 0TR387500AA CHIP 2SC3875S(ALY) KEC D900 0DRSE00038A SDC15 TVS SOT23 12.8V
Q176 0TR387500AA CHIP 2SC3875S(ALY) KEC D901 0DRSE00038A SDC15 TVS SOT23 12.8V
Q177 0TR387500AA CHIP 2SC3875S(ALY) KEC LD101 0DL200000CA LED,SAM5670(DL-2LRG)
Q201 0TR150400BA CHIP 2SA1504S(ASY) KEC LED150 0DL233309AC LED,SAM2333
Q202 0TR150400BA CHIP 2SA1504S(ASY) KEC LED170 0DL233309AC LED,SAM2333

- 27 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

LED301 0DL233309AC LED,SAM2333 C1218 0CE335SK6DC 3.3UF MVG 50V 20%

LED302 0DL233309AC LED,SAM2333 C1219 0CC101CK41A 100PF 1608 50V 5%
LED901 0DL233309AC LED,SAM2333 C1219 0CE476SF6DC 47UF MVG 16V 20%
C1220 0CC101CK41A 100PF 1608 50V 5%
CAPACITOR
C1221 0CC101CK41A 100PF 1608 50V 5%
C100 0CS335EFKDC 3.3UF 3216 16V 20%,-20% C1221 0CE476SF6DC 47UF MVG 16V 20%
C1003 0CE336SH6DC 33UF MVG 25V 20% C1224 0CC101CK41A 100PF 1608 50V 5%
C101 0CE225VK6DC 2.2UF MV 50V 20% C1225 0CK220CK4DA 22PF 1608 50V 5%
C1015 0CC200CK41A 20PF 1608 50V 5% C1226 0CK220CK4DA 22PF 1608 50V 5%
C1018 0CC200CK41A 20PF 1608 50V 5% C1227 0CC180CKH1A 18PF 1608 50V 5%
C102 0CK103CK56A 0.01UF 1608 50V 10% C1228 0CK220CK4DA 22PF 1608 50V 5%
C103 0CE106VF6DC 10UF MV 16V 20% C1229 0CC180CKH1A 18PF 1608 50V 5%
C103 0CE4763F618 47UF SRE 16V M FL TP5 C123 0CE106VF6DC 10UF MV 16V 20%
C104 0CE106VF6DC 10UF MV 16V 20% C1230 0CC330CK41A 33PF 1608 50V 5%
C104 0CE225VK6DC 2.2UF MV 50V 20% C1231 0CC330CK41A 33PF 1608 50V 5%
C104 0CE106SF6DC 10UF MVG 16V 20% C1232 0CC330CK41A 33PF 1608 50V 5%
C1041 0CE336SH6DC 33UF MVG 25V 20% C1242 0CE108DJ618 1000UF STD 35V 20%
C1042 0CE336SH6DC 33UF MVG 25V 20% C1255 0CE476SF6DC 47UF MVG 16V 20%
C106 0CE106SF6DC 10UF MVG 16V 20% C1258 0CE108DJ618 1000UF STD 35V 20%
C108 0CE106SF6DC 10UF MVG 16V 20% C126 0CE336SD6DC 33UF MVG 10V 20%
C1100 0CE106VF6DC 10UF MV 16V 20% C1264 0CE476SF6DC 47UF MVG 16V 20%
C1107 0CE106VF6DC 10UF MV 16V 20% C1266 0CE476SF6DC 47UF MVG 16V 20%
C1115 0CE106VF6DC 10UF MV 16V 20% C1269 0CE107SF6DC 100UF MVG 16V 20%
C1118 0CE106VF6DC 10UF MV 16V 20% C1273 0CE476SF6DC 47UF MVG 16V 20%
C1121 0CC180CKH1A 18PF 1608 50V 5% C1277 0CE477SF6DC 470UF MVG 16V 20%
C1122 0CC180CKH1A 18PF 1608 50V 5% C1279 0CE107SF6DC 100UF MVG 16V 20%
C1124 0CE476SF6DC 47UF MVG 16V 20% C1321 0CE476SF6DC 47UF MVG 16V 20%
C1125 0CE476SF6DC 47UF MVG 16V 20% C1322 0CE476SF6DC 47UF MVG 16V 20%
C1127 0CC221CK41A 220PF 1608 50V 5% C1324 0CK103CK56A 0.01UF 1608 50V 10%
C1128 0CC221CK41A 220PF 1608 50V 5% C1325 0CE476SF6DC 47UF MVG 16V 20%
C113 0CE106VF6DC 10UF MV 16V 20% C1327 0CE106VF6DC 10UF MV 16V 20%
C114 0CE106VF6DC 10UF MV 16V 20% C1331 0CK102CK56A 1000PF 1608 50V 0.1
C118 0CE105SK6DC 1UF MVG 50V 20% C1334 0CE106VF6DC 10UF MV 16V 20%
C1200 0CE226SF6DC 22UF MVG 16V 20% C1335 0CK102CK56A 1000PF 1608 50V 0.1
C1200 0CE475SK6DC 4.7UF MVG 50V 20% C1339 0CE106VF6DC 10UF MV 16V 20%
C1201 0CE475SK6DC 4.7UF MVG 50V 20% C1344 0CE476SF6DC 47UF MVG 16V 20%
C1202 0CC200CK41A 20PF 1608 50V 5% C1345 0CE476SF6DC 47UF MVG 16V 20%
C1203 0CK392CK56A 3900PF 1608 50V 10% C144 0CE105SK6DC 1UF MVG 50V 20%
C1203 0CE226SF6DC 22UF MVG 16V 20% C148 0CE226SF6DC 22UF MVG 16V 20%
C1205 0CC200CK41A 20PF 1608 50V 5% C149 0CE226SF6DC 22UF MVG 16V 20%
C1206 0CC561CK41A 560PF 1608 50V 5% C150 0CE476SF6DC 47UF MVG 16V 20%
C1208 0CC561CK41A 560PF 1608 50V 5% C1513 0CE106VF6DC 10UF MV 16V 20%
C1209 0CE475SK6DC 4.7UF MVG 50V 20% C1515 0CC270CK41A 27PF 1608 50V 5%
C1210 0CC471CK41A 470PF 1608 50V 5% C1516 0CC270CK41A 27PF 1608 50V 5%
C1211 0CK271CK46A 270PF 1608 50V 5% C1517 0CK103CK56A 0.01UF 1608 50V 10%
C1213 0CE476SF6DC 47UF MVG 16V 20% C1518 0CK103CK56A 0.01UF 1608 50V 10%
C1214 0CK105DF64A 1UF 2012 16V 20% C1519 0CK103CK56A 0.01UF 1608 50V 10%
C1216 0CK102CK56A 1000PF 1608 50V 0.1 C152 0CE107SF6DC 100UF MVG 16V 20%
C1216 0CE476SF6DC 47UF MVG 16V 20% C1520 0CK103CK56A 0.01UF 1608 50V 10%

- 28 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

C1529 0CE336SD6DC 33UF MVG 10V 20% C233 0CE476SF6DC 47UF MVG 16V 20%
C1534 0CE226SF6DC 22UF MVG 16V 20% C234 0CE107SF6DC 100UF MVG 16V 20%
C1537 0CE106VF6DC 10UF MV 16V 20% C235 0CE476SF6DC 47UF MVG 16V 20%
C1539 0CK103CK56A 0.01UF 1608 50V 10% C236 0CE476SF6DC 47UF MVG 16V 20%
C1540 0CK103CK56A 0.01UF 1608 50V 10% C244 0CE477SF6DC 470UF MVG 16V 20%
C1541 0CK103CK56A 0.01UF 1608 50V 10% C245 0CE477SF6DC 470UF MVG 16V 20%
C1542 0CK103CK56A 0.01UF 1608 50V 10% C251 0CE476SF6DC 47UF MVG 16V 20%
C158 0CE105SK6DC 1UF MVG 50V 20% C253 0CE476SF6DC 47UF MVG 16V 20%
C161 0CE105SK6DC 1UF MVG 50V 20% C254 0CE476SF6DC 47UF MVG 16V 20%
C162 0CE225VK6DC 2.2UF MV 50V 20% C255 0CE476SF6DC 47UF MVG 16V 20%
C163 0CE225VK6DC 2.2UF MV 50V 20% C260 0CE476SF6DC 47UF MVG 16V 20%
C168 0CK105DF64A 1UF 2012 16V 20% C266 0CE107SF6DC 100UF MVG 16V 20%
C1703 0CE477SF6DC 470UF MVG 16V 20% C269 0CE107SF6DC 100UF MVG 16V 20%
C1704 0CE477SF6DC 470UF MVG 16V 20% C274 0CE226SF6DC 22UF MVG 16V 20%
C1705 0CE477SF6DC 470UF MVG 16V 20% C280 0CE335SK6DC 3.3UF MVG 50V 20%
C1706 0CE477SF6DC 470UF MVG 16V 20% C295 0CE335SK6DC 3.3UF MVG 50V 20%
C1707 0CE477SF6DC 470UF MVG 16V 20% C297 0CE107SF6DC 100UF MVG 16V 20%
C1708 0CE477SF6DC 470UF MVG 16V 20% C298 0CE106SF6DC 10UF MVG 16V 20%
C171 0CK105DF64A 1UF 2012 16V 20% C299 0CE106SF6DC 10UF MVG 16V 20%
C1712 0CE476SF6DC 47UF MVG 16V 20% C309 0CE476SF6DC 47UF MVG 16V 20%
C1713 0CE476SF6DC 47UF MVG 16V 20% C310 0CE476SF6DC 47UF MVG 16V 20%
C1718 0CE476SF6DC 47UF MVG 16V 20% C319 0CE476SF6DC 47UF MVG 16V 20%
C1719 0CE476SF6DC 47UF MVG 16V 20% C324 0CE106SF6DC 10UF MVG 16V 20%
C172 0CE106SK6DC 10UF MVG 50V 20% C325 0CE476VK6DC 47UF MV 50V 20%
C1722 0CE477SF6DC 470UF MVG 16V 20% C326 0CE476SF6DC 47UF MVG 16V 20%
C1728 0CE476VH6DC 47UF MV 25V 20% C338 0CE476SF6DC 47UF MVG 16V 20%
C1729 0CE476SF6DC 47UF MVG 16V 20% C343 0CE335SK6DC 3.3UF MVG 50V 20%
C1731 0CE477SF6DC 470UF MVG 16V 20% C345 0CE225VK6DC 2.2UF MV 50V 20%
C1740 0CE476SF6DC 47UF MVG 16V 20% C358 0CE476SF6DC 47UF MVG 16V 20%
C1742 0CE476SF6DC 47UF MVG 16V 20% C360 0CE476SF6DC 47UF MVG 16V 20%
C175 0CE108DJ618 1000UF STD 35V 20% C364 0CE106SF6DC 10UF MVG 16V 20%
C186 0CF4741L438 0.47UF D 63V 5% TP 5 M/PE NI C370 0CK105DF64A 1UF 2012 16V 20%
C190 0CF4741L438 0.47UF D 63V 5% TP 5 M/PE NI C375 0CE106SK6DC 10UF MVG 50V 20%
C202 0CE106VF6DC 10UF MV 16V 20% C383 0CE476SF6DC 47UF MVG 16V 20%
C203 0CE106VF6DC 10UF MV 16V 20% C400 0CE226SF6DC 22UF MVG 16V 20%
C205 0CE476SF6DC 47UF MVG 16V 20% C403 0CE336SD6DC 33UF MVG 10V 20%
C207 0CE477DJ618 470UF STD 35V 20% C408 0CE476SF6DC 47UF MVG 16V 20%
C212 0CE477SF6DC 470UF MVG 16V 20% C412 0CE476SF6DC 47UF MVG 16V 20%
C213 0CE477SF6DC 470UF MVG 16V 20% C415 0CE476SF6DC 47UF MVG 16V 20%
C214 0CE477SF6DC 470UF MVG 16V 20% C419 0CK105DF64A 1UF 2012 16V 20%
C215 0CE477DJ618 470UF STD 35V 20% C422 0CE476SF6DC 47UF MVG 16V 20%
C216 0CE477SF6DC 470UF MVG 16V 20% C427 0CE476SF6DC 47UF MVG 16V 20%
C217 0CE477SF6DC 470UF MVG 16V 20% C433 0CE106SF6DC 10UF MVG 16V 20%
C219 0CE226SF6DC 22UF MVG 16V 20% C434 0CE106SF6DC 10UF MVG 16V 20%
C223 0CE477SF6DC 470UF MVG 16V 20% C436 0CE106SF6DC 10UF MVG 16V 20%
C224 0CE107SF6DC 100UF MVG 16V 20% C438 0CE106SF6DC 10UF MVG 16V 20%
C226 0CC100CK11A 10PF 1608 50V 0.5 PF C439 0CE106SF6DC 10UF MVG 16V 20%
C227 0CC100CK11A 10PF 1608 50V 0.5 PF C440 0CE106SF6DC 10UF MVG 16V 20%
C232 0CE476SF6DC 47UF MVG 16V 20% C441 0CE106SF6DC 10UF MVG 16V 20%

- 29 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

C443 0CE106SF6DC 10UF MVG 16V 20% C614 0CK103CK56A 0.01UF 1608 50V 10%
C444 0CE106SF6DC 10UF MVG 16V 20% C616 0CE476SF6DC 47UF MVG 16V 20%
C445 0CE106SF6DC 10UF MVG 16V 20% C618 0CE476SF6DC 47UF MVG 16V 20%
C446 0CE106SF6DC 10UF MVG 16V 20% C619 0CK472CK56A 4700PF 1608 50V 10%
C448 0CE106SF6DC 10UF MVG 16V 20% C620 0CE106VF6DC 10UF MV 16V 20%
C459 0CE106VF6DC 10UF MV 16V 20% C621 0CK103CK56A 0.01UF 1608 50V 10%
C460 0CK103CK56A 0.01UF 1608 50V 10% C624 0CK103CK56A 0.01UF 1608 50V 10%
C460 0CE107SF6DC 100UF MVG 16V 20% C625 0CK103CK56A 0.01UF 1608 50V 10%
C461 0CK103CK56A 0.01UF 1608 50V 10% C627 0CK103CK56A 0.01UF 1608 50V 10%
C462 0CK103CK56A 0.01UF 1608 50V 10% C6605 0CE226SF6DC 22UF MVG 16V 20%
C463 0CK103CK56A 0.01UF 1608 50V 10% C6608 0CE226SF6DC 22UF MVG 16V 20%
C468 0CE107SF6DC 100UF MVG 16V 20% C6609 0CE106SF6DC 10UF MVG 16V 20%
C472 0CE105SK6DC 1UF MVG 50V 20% C6609 0CE107SF6DC 100UF MVG 16V 20%
C477 0CE105SK6DC 1UF MVG 50V 20% C6611 0CE226SF6DC 22UF MVG 16V 20%
C483 0CE107SF6DC 100UF MVG 16V 20% C6613 0CE106SF6DC 10UF MVG 16V 20%
C486 0CE226SF6DC 22UF MVG 16V 20% C6615 0CE226SF6DC 22UF MVG 16V 20%
C488 0CE226SF6DC 22UF MVG 16V 20% C6617 0CE226SF6DC 22UF MVG 16V 20%
C490 0CE106SF6DC 10UF MVG 16V 20% C6634 0CE106SF6DC 10UF MVG 16V 20%
C492 0CE105SK6DC 1UF MVG 50V 20% C6634 0CE107SF6DC 100UF MVG 16V 20%
C504 0CE476VK6DC 47UF MV 50V 20% C6660 0CE476SF6DC 47UF MVG 16V 20%
C508 0CE476SF6DC 47UF MVG 16V 20% C6703 0CE476SF6DC 47UF MVG 16V 20%
C513 0CE226SF6DC 22UF MVG 16V 20% C6706 0CE106SK6DC 10UF MVG 50V 20%
C519 0CE106SF6DC 10UF MVG 16V 20% C6710 0CE106SK6DC 10UF MVG 50V 20%
C522 0CE226SF6DC 22UF MVG 16V 20% C8001 0CK102CK56A 1000PF 1608 50V 0.1
C535 0CE226SF6DC 22UF MVG 16V 20% C8002 0CK102CK56A 1000PF 1608 50V 0.1
C537 0CC100CK11A 10PF 1608 50V 0.5 PF C8003 0CK102CK56A 1000PF 1608 50V 0.1
C537 0CE477SF6DC 470UF MVG 16V 20% C8004 0CK102CK56A 1000PF 1608 50V 0.1
C538 0CE106VF6DC 10UF MV 16V 20% C8005 0CE106VF6DC 10UF MV 16V 20%
C539 0CC270CK41A 27PF 1608 50V 5% C8007 0CK103CK56A 0.01UF 1608 50V 10%
C539 0CE107SF6DC 100UF MVG 16V 20% C8008 0CC180CKH1A 18PF 1608 50V 5%
C541 0CE226SF6DC 22UF MVG 16V 20% C8009 0CC180CKH1A 18PF 1608 50V 5%
C554 0CE105SK6DC 1UF MVG 50V 20% C8010 0CK102CK56A 1000PF 1608 50V 0.1
C600 0CK103CK56A 0.01UF 1608 50V 10% C8013 0CK103CK56A 0.01UF 1608 50V 10%
C601 0CE226SF6DC 22UF MVG 16V 20% C8014 0CK102CK56A 1000PF 1608 50V 0.1
C6015 0CE476SF6DC 47UF MVG 16V 20% C8015 0CK102CK56A 1000PF 1608 50V 0.1
C6017 0CE106SF6DC 10UF MVG 16V 20% C8016 0CK102CK56A 1000PF 1608 50V 0.1
C602 0CE226SF6DC 22UF MVG 16V 20% C8017 0CK102CK56A 1000PF 1608 50V 0.1
C603 0CC470CK41A 47PF 1608 50V 5% C8018 0CK102CK56A 1000PF 1608 50V 0.1
C6034 0CE226SF6DC 22UF MVG 16V 20% C8019 0CK102CK56A 1000PF 1608 50V 0.1
C6036 0CE226SF6DC 22UF MVG 16V 20% C8024 0CE106VF6DC 10UF MV 16V 20%
C6038 0CE226SF6DC 22UF MVG 16V 20% C8025 0CE106VF6DC 10UF MV 16V 20%
C6040 0CE226SF6DC 22UF MVG 16V 20% C8026 0CK102CK56A 1000PF 1608 50V 0.1
C6049 0CE226SF6DC 22UF MVG 16V 20% C8028 0CK102CK56A 1000PF 1608 50V 0.1
C605 0CE107VF6DC 100UF MV 16V 20% C8029 0CK103CK56A 0.01UF 1608 50V 10%
C6054 0CE106SF6DC 10UF MVG 16V 20% C803 0CE106VF6DC 10UF MV 16V 20%
C610 0CE107VF6DC 100UF MV 16V 20% C8030 0CK103CK56A 0.01UF 1608 50V 10%
C611 0CC470CK41A 47PF 1608 50V 5% C8031 0CE106VF6DC 10UF MV 16V 20%
C612 0CE226SF6DC 22UF MVG 16V 20% C8034 0CE106VF6DC 10UF MV 16V 20%
C613 0CE226SF6DC 22UF MVG 16V 20% C8036 0CK102CK56A 1000PF 1608 50V 0.1

- 30 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

C8037 0CK102CK56A 1000PF 1608 50V 0.1 C928 0CK334CF56A 0.33UF 1608 16V 10%
C8038 0CK102CK56A 1000PF 1608 50V 0.1 C929 0CK473CH56A 0.047UF 1608 25V 10%
C8040 0CK102CK56A 1000PF 1608 50V 0.1
CONNECTOR
C8041 0CK102CK56A 1000PF 1608 50V 0.1
C8042 0CK102CK56A 1000PF 1608 50V 0.1 C10 6631V00045D CONNECTOR ASSEMBLY,10P 2.5MM 250MM
C8047 0CE106VF6DC 10UF MV 16V 20% C11 6631V10004A CONNECTOR ASSEMBLY,31P 1.0MM 80MM
C8052 0CK102CK56A 1000PF 1608 50V 0.1 C12 6631V10004Z CONNECTOR ASSEMBLY,31P 1.0MM 50MM
C8053 0CK102CK56A 1000PF 1608 50V 0.1 C13 6631V25032A CONNECTOR ASSEMBLY,3P 2.5MM 100MM
C8054 0CK102CK56A 1000PF 1608 50V 0.1 C14 6631V25083E CONNECTOR ASSEMBLY,7P 2.5MM 300MM
C8055 0CK102CK56A 1000PF 1608 50V 0.1 C15 6631V25084C CONNECTOR ASSEMBLY,12P 2.5MM 200MM
C8056 0CK102CK56A 1000PF 1608 50V 0.1 C16 6630CE00168 CONNECTOR,CARD BUS 68P 1.0MM
C8057 0CK102CK56A 1000PF 1608 50V 0.1 C17 387-G03M CONNECTOR ASSEMBLY,3P 2.5MM 800MM
C8058 0CK102CK56A 1000PF 1608 50V 0.1 C18 6631V25061D CONNECTOR ASSEMBLY,8P 2.5MM 250MM
C8059 0CK102CK56A 1000PF 1608 50V 0.1 C19 6631V39013Z CONNECTOR ASSEMBLY,8P 3.96MM 650MM
C806 0CK102CK56A 1000PF 1608 50V 0.1 C20 6631V39018B CONNECTOR ASSEMBLY,9P 3.96MM 300MM
C8060 0CK102CK56A 1000PF 1608 50V 0.1 C5 6631V00020J CONNECTOR ASSEMBLY,3P 3.96MM 400MM
C8061 0CK102CK56A 1000PF 1608 50V 0.1 C6 387-G04Q CONNECTOR ASSEMBLY,4P 2.5MM 1200MM
C8062 0CE106VF6DC 10UF MV 16V 20% C7 387-J06R CONNECTOR ASSEMBLY,6P 2.5MM 1400MM
C8063 0CK103CK56A 0.01UF 1608 50V 10% C8 387-J08Q CONNECTOR ASSEMBLY,8P 2.5MM 1200MM
C8064 0CK103CK56A 0.01UF 1608 50V 10% C9 387-J12K CONNECTOR ASSEMBLY,12P 2.5MM 600MM
C8068 0CE106VF6DC 10UF MV 16V 20% CN1101 6630SD01709 CONNECTOR,USB 4P 0.8MM
C8070 0CE226SF6DC 22UF MVG 16V 20% CN1102 6630SD01709 CONNECTOR,USB 4P 0.8MM
C8073 0CE336SD6DC 33UF MVG 10V 20% CN1501 6630U60039A CONNECTOR,TERMINAL 7P 1.27MM
C8075 0CE226SF6DC 22UF MVG 16V 20% CN900 6630G70017A CONNECTOR,D-SUB 9P 2.54MM
C814 0CE106VF6DC 10UF MV 16V 20% JK300 6630G70016A CONNECTOR,D-SUB 15P 2.29MM
C815 0CE106VF6DC 10UF MV 16V 20%
JACK
C818 0CK473CH56A 0.047UF 1608 25V 10%
C819 0CK473CH56A 0.047UF 1608 25V 10% ANT1 6612J00042G JACK,RCA UCT-EX-063
C820 0CK473CH56A 0.047UF 1608 25V 10% ANT2 6612J00042G JACK,RCA UCT-EX-063
C822 0CC221CK41A 220PF 1608 50V 5% CN1202 6612F00055B JACK,PHONE UEJ-CV-031
C824 0CE226SF6DC 22UF MVG 16V 20% CN800 6612B00015B JACK,DIN DC1R019WDH JAE 0.5MM
C825 0CE226SF6DC 22UF MVG 16V 20% CN801 6612B00015B JACK,DIN DC1R019WDH JAE 0.5MM
C843 0CK823CF56A 82NF 1608 16V 10% JK101 6613V00026A JACK ASSEMBLY,UJB-03-28A
C849 0CK822CK46A 8.2NF 1608 50V 5% JK402 6612F00087A JACK,PHONE UEJ-CV-032
C863 0CC470CK41A 47PF 1608 50V 5% JK407 6612J00040B JACK,RCA UJB-06-23B
C874 0CE226SF6DC 22UF MVG 16V 20% JK408 6612J10012A JACK,RCA UJB-05-02C
C883 0CE226SF6DC 22UF MVG 16V 20% JK409 6612J10012A JACK,RCA UJB-05-02C
C885 0CE106VF6DC 10UF MV 16V 20% JK410 6612F00087A JACK,PHONE UEJ-CV-032
C889 0CE106VF6DC 10UF MV 16V 20% JOPT101 6612BBBHN4A JACK,DIN TOTX179
C892 0CE106VF6DC 10UF MV 16V 20% JOPT102 6612BBBHN4B JACK,DIN TORX179
C893 0CE106VF6DC 10UF MV 16V 20% JOPT103 6612BBBHN4B JACK,DIN TORX179
C898 0CK102CK56A 1000PF 1608 50V 0.1
COIL
C899 0CK102CK56A 1000PF 1608 50V 0.1
C920 0CC221CK41A 220PF 1608 50V 5% F1100 6140VB0021A COIL,CHOKE 944CM-0004=P3
C921 0CC221CK41A 220PF 1608 50V 5% F1101 6140VB0021A COIL,CHOKE 944CM-0004=P3
C923 0CC331CK41A 330PF 1608 50V 5% L130 6140VB0032A COIL,CHOKE DBF-1015A 15.5UH
C925 0CK334CF56A 0.33UF 1608 16V 10% L131 6140VB0032A COIL,CHOKE DBF-1015A 15.5UH
C926 0CK334CF56A 0.33UF 1608 16V 10% L132 6140VB0032A COIL,CHOKE DBF-1015A 15.5UH
C927 0CK334CF56A 0.33UF 1608 16V 10% L133 6140VB0032A COIL,CHOKE DBF-1015A 15.5UH

- 31 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

L1700 6140VB0004B COIL,CHOKE 26UH

FILTER & CRYSTAL
L1701 6140VB0004B COIL,CHOKE 26UH
L201 6140VB0004B COIL,CHOKE 26UH B1000 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
L202 6140VB0004B COIL,CHOKE 26UH B1007 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
L203 6140VB0004B COIL,CHOKE 26UH B1100 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
L204 6140VB0004B COIL,CHOKE 26UH B1101 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
B1102 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
RESISTOR
B1103 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR110 0RRZVTA001C 4.7K OHM 1 / 16 W 1608 5% B1104 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR111 0RRZVTA001C 4.7K OHM 1 / 16 W 1608 5% B116 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1301 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1200 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1302 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1201 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1303 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1302 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1304 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1305 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1305 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1306 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1306 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1308 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1307 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1309 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1308 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1310 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1309 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1311 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1310 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1312 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1311 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1313 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1312 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1500 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR1313 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1501 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR6601 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1700 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR6602 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B1701 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR6603 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B200 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR6604 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B400 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR6605 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B401 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR6606 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B403 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR800 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B502 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR801 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B503 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR802 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B800 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR803 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B801 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR804 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B802 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
AR805 0RRZVTA001D 22 OHM 1 / 16 W 1608 5% B803 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
R1716 0RD0682H609 68 OHM 1/2 W 5.00% TA52 B804 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
R1754 0RD0332H609 33 OHM 1/2 W 5.00% TA52 B805 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
R675 0RN1002F409 10K OHM 1/6 W 1.00% TA52 B806 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
B807 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
SWITCH
B808 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
CN201 140-313A SWITCH,TACT 2LEAD 100G(TA) 5V B810 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
SW101 140-315A SWITCH,TACT SKHV17910B 12V B901 0LCML00003B FILTER,EMC MLB-201209-0120P-N2 5A
SW102 140-315A SWITCH,TACT SKHV17910B 12V F1200 6200QJ3001A FILTER,EMC BMS400 25V 200MA
SW103 140-315A SWITCH,TACT SKHV17910B 12V F1700 6200QJ3001A FILTER,EMC BMS400 25V 200MA
SW104 140-315A SWITCH,TACT SKHV17910B 12V F1701 6200QJ3001A FILTER,EMC BMS400 25V 200MA
SW105 140-315A SWITCH,TACT SKHV17910B 12V F1702 6200QJ3001A FILTER,EMC BMS400 25V 200MA
SW106 140-315A SWITCH,TACT SKHV17910B 12V F1703 6200QJ3001A FILTER,EMC BMS400 25V 200MA
SW107 140-315A SWITCH,TACT SKHV17910B 12V F1704 6200QJ3001A FILTER,EMC BMS400 25V 200MA
SW108 140-315A SWITCH,TACT SKHV17910B 12V F1705 6200QJ3001A FILTER,EMC BMS400 25V 200MA

- 32 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

F1706 6200QJ3001A FILTER,EMC BMS400 25V 200MA L208 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1707 6200QJ3001A FILTER,EMC BMS400 25V 200MA L209 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1708 6200QJ3001A FILTER,EMC BMS400 25V 200MA L210 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1709 6200QJ3001A FILTER,EMC BMS400 25V 200MA L211 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1710 6200QJ3001A FILTER,EMC BMS400 25V 200MA L212 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1711 6200QJ3001A FILTER,EMC BMS400 25V 200MA L213 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1712 6200QJ3001A FILTER,EMC BMS400 25V 200MA L214 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1713 6200QJ3001A FILTER,EMC BMS400 25V 200MA L215 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1714 6200QJ3001A FILTER,EMC BMS400 25V 200MA L220 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1715 6200QJ3001A FILTER,EMC BMS400 25V 200MA L227 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1716 6200QJ3001A FILTER,EMC BMS400 25V 200MA L228 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1717 6200QJ3001A FILTER,EMC BMS400 25V 200MA L229 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1718 6200QJ3001A FILTER,EMC BMS400 25V 200MA L230 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1719 6200QJ3001A FILTER,EMC BMS400 25V 200MA L231 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1720 6200QJ3001A FILTER,EMC BMS400 25V 200MA L232 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1721 6200QJ3001A FILTER,EMC BMS400 25V 200MA L234 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1722 6200QJ3001A FILTER,EMC BMS400 25V 200MA L235 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1725 6200QJ3001A FILTER,EMC BMS400 25V 200MA L302 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1726 6200QJ3001A FILTER,EMC BMS400 25V 200MA L312 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1727 6200QJ3001A FILTER,EMC BMS400 25V 200MA L320 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F1728 6200QJ3001A FILTER,EMC BMS400 25V 200MA L321 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F700 6200QJ3001A FILTER,EMC BMS400 25V 200MA L421 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F701 6200QJ3001A FILTER,EMC BMS400 25V 200MA L510 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F702 6200QJ3001A FILTER,EMC BMS400 25V 200MA L511 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F703 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6602 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F704 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6603 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F705 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6604 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F706 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6605 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F710 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6607 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F711 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6608 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F714 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6609 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F715 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6610 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F716 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6611 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F717 6200QJ3001A FILTER,EMC BMS400 25V 200MA L6615 6210VC0006A FILTER,EMC FBMH3216 HM501NT
F718 6200QJ3001A FILTER,EMC BMS400 25V 200MA X1000 6212AC2001D RESONATOR,CRYSTAL HC-49/SM 14MHZ
F719 6200QJ3001A FILTER,EMC BMS400 25V 200MA X103 6212BA2002C RESONATOR,CERAMIC CSALA2M69G4ZF01-B0
IC502 6200QL3002E FILTER,SAW X9650M 44MHZ 5PIN X104 6212AB2015A RESONATOR,CRYSTAL HC-49/SM4H 4MHZ
L101 6210VC0006A FILTER,EMC FBMH3216 HM501NT X1101 6212AB2806A RESONATOR,CRYSTAL SX-1 24.576MHZ
L102 6210VC0006A FILTER,EMC FBMH3216 HM501NT X1200 6212AB2015E RESONATOR,CRYSTAL HC-49/SM 10.0MHZ
L112 6210VC0006A FILTER,EMC FBMH3216 HM501NT X1202 6212AB2015A RESONATOR,CRYSTAL HC-49/SM4H 4MHZ
L115 6210VC0006A FILTER,EMC FBMH3216 HM501NT X1500 6212AB2015C RESONATOR,CRYSTAL HC-49/SM4H 25MHZ
L116 6210VC0005A FILTER,EMC BK2125 HS 750 X200 6202VDT002H RESONATOR,CRYSTAL SX-1 18.432000MHZ
L117 6210VC0006A FILTER,EMC FBMH3216 HM501NT X401 6202VDT002D RESONATOR,CRYSTAL SX-1SMD 8.0MHZ
L118 6210VC0006A FILTER,EMC FBMH3216 HM501NT X6601 6212AB2806A RESONATOR,CRYSTAL SX-1 24.576MHZ
L119 6210VC0006A FILTER,EMC FBMH3216 HM501NT X6602 6212AB2806A RESONATOR,CRYSTAL SX-1 24.576MHZ
L200 6210VC0006A FILTER,EMC FBMH3216 HM501NT X801 6212AB2845A RESONATOR,CRYSTAL ABLS-27.000MHZ
L205 6210VC0006A FILTER,EMC FBMH3216 HM501NT
MISCELLANEOUS
L206 6210VC0006A FILTER,EMC FBMH3216 HM501NT
L207 6210VC0006A FILTER,EMC FBMH3216 HM501NT C1 6850J00005A CABLE,DVI LVDS UL20276 AWG30 500MM

- 33 -

Downloaded from www.Manualslib.com manuals search engine

 REPLACEMENT PARTS LIST

LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION

C2 6851V00022B CABLE,COAXIAL(100MM),UL1365#26 VW-1

C3 6851V00022C CABLE,COAXIAL(150MM),UL1365#26 VW-1
C4 6850U00002B CABLE,USB SERIAL ATA UL2725 AWG26 800MM
J1 6871VSMQ67A PCB ASSEMBLY,SUB AUDIO
SW301 6634D00010B ADAPTER,RF TASA-H301P 75 OHM
TU301 6700AN0002C TUNER,TDVS-H702P
TU302 6700NF0019B TUNER,TAFM-H103P
TU500 6700NC0001B TUNER,TAEU-H018P
VA1100 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1101 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1102 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1103 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1104 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1105 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1106 6102W5V016A VARISTOR,AVRL161A1R1NT
VA1107 6102W5V016A VARISTOR,AVRL161A1R1NT
VX500 6204B60001B OSCILLATOR,27MHZ +/- 100 PPM 3.3V
X1100 6204B47985M OSCILLATOR,SCO-103 13.5MHZ
X200 6204B47985L OSCILLATOR,SCO-103 33.33HZ
X302 6204B47985K OSCILLATOR,BMS-873R 25MHZ
IC305 6927V1291AF SOFT WARE,3.08.1V 491E0FA1 PDP AF05FB
IC306 6927V1292AF SOFT WARE,3.08.1V 416ECC54 PDP AF05FB
IC307 6927V1288AA SOFT WARE,3.00V 288559F6 PDP AF05FB
IC308 6927V1289AA SOFT WARE,3.00V 2884B650 PDP AF05FB
IC404 6927V1211AQ SOFT WARE,3.02V 602D PDP AF05FA

ACCESSORIES
A1 3828VA0528B MANUAL,OWNERS
“ 3828VA0528J MANUAL,OWNERS *LGECI
A2 6710V00141B REMOTE CONTROLLER
A3 6410VUH005C POWER CORD,BP-301 2800MM V1625
A4 6850TD9007E CABLE,D-SUB UL20276-9C(5.8MM)
A5 6851V00019A CABLE ASSEMBLY,RF CONN 4AC208A0 3M
A6 6851V00023B CABLE ASSEMBLY,BIZLINK XX15563-88A 3000MM
A7 4972V00178A FIXER,WALL NON ASSY PDP SET

- 34 -

Downloaded from www.Manualslib.com manuals search engine

 March, 2005
P/NO : 3828VD0214G Printed in Korea

CANADA: LG Electronics Canada, Inc. 550 Matheson

Boulevard East Mississauga, Ontario L4Z 4G3

USA : LG Electronics Alabama Inc.

P.O.Box 240007, 201 James Record Road, Bldg. 3,
Huntsville, AL 35824

Downloaded from www.Manualslib.com manuals search engine

Downloaded from www.Manualslib.com manuals search engine
Downloaded from www.Manualslib.com manuals search engine
Downloaded from www.Manualslib.com manuals search engine
Downloaded from www.Manualslib.com manuals search engine
Downloaded from www.Manualslib.com manuals search engine
Downloaded from www.Manualslib.com manuals search engine