Scribd
Upload
193 views2 pages

Carrier Service Manual12

The document provides a maintenance schedule for a Carrier 250 with services to be performed at various hour intervals including initial service, service A, service B, and service C. The schedule outlines specific maintenance tasks such as replacing filters, checking for leaks, cleaning coils, and servicing electrical components.

Uploaded by

ahmed alamin
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as XLSX, PDF, TXT or read online on Scribd
193 views2 pages

Carrier Service Manual12

The document provides a maintenance schedule for a Carrier 250 with services to be performed at various hour intervals including initial service, service A, service B, and service C. The schedule outlines specific maintenance tasks such as replacing filters, checking for leaks, cleaning coils, and servicing electrical components.

Uploaded by

ahmed alamin
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as XLSX, PDF, TXT or read online on Scribd
You are on page 1/ 2

MAINTANENCE SCHEDULE

CARRIER 250
HOURS 250 750 1500 2250 3000 3750 4500 5250 6000 6750 7500 8250 9000 9750 10500 11250 12000 12750 13500
INITIAL ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___ ___
√
SERVICE
___
SERVICE A √ √ √ √ √ √ √ √ √ √ √ √ √ √ √ √ √ √

√ ___ √ ___ √ ___ √ ___ √ ___ √ ___ √ ___ √ ___ √ ___ √


SERVICE B
___ ___ ___ ___ √ ___ ___ ___ √ ___ ___ ___ √ ___ ___ ___ √ ___ ___
SERVICE C

Check the tightness of bolts, screws and that the unit is correctly fastened on to the box.
Drain the Engine oil
E
IC

Replace oil filter and by pass filter ( if so equipped)


RV

Tlghten all electrical connection in control box


SE
L

Check Refrigerant leaks


IA
IT

Clean up Condenser & Radiator coil


IN

Drain the Engine Oil.


Replace Oil, Oil filters and by pass filter ( if any )
Clean up Battery connection and clamps
Check Refrigerant leaks
Clean up the Cartridge of the dry air filter
Check functions parameters and configuration according to customer application
Check defrost ( timer setting and function, refrigerant control valves, fans stop defrost ends automatically)
Check Engine Coolent System
A

Check and adjust all the belts. Replace if needed


E
IC
RV

Pretrip inspection
SE

Check the tightness of bolts and screws and that the unit is correctly fastened onto the box.
Check Cap Command and Control panels ( display and switches)
Check relays, electrical connections
Check hoses and connections for leaks
Check fuel pump filter
Clean up condencer and radiator coil
Check drinage of defrost water
Check standby operation and test overload relay

OPERATION OF SERVICE A +
Replace the cartidge of the dry air filter
Check battery terminals & fluid levels ( if possible )
Clean up mechanical clutch with compressed air
Check thickness of the fiction material ( if possible ). If less than 1.5mm, replace the clutch
Check Refrigerant level
Check Compessor oil level
Check Alternator brushes. Replace if needed
Check Alternate voltage
Check engine thermostate
B

Repalce all the belts


E
IC
RV

Check fan motor brushes. Reolace if needed


SE

Calibrate defrost air switch


Drain water from fuel tank
Check operation of solenoids
Check starter condition
Grease diesel engine solenoid plungers
Check defrost klaxon cut out
Check motor speed in high and low speed
Check regulation operation
Check hardness and wires wear
Check skins ( hinges, cracks & screws )

OPERATION OF SERVICE A + B +
C

Replace bearings and brushes of 12 Vdc alternator


E
IC
RV

Check water pump bearing


SE

Replace capacitors ( if any )

FILTER DRIER, EXPANSION VALVE


O
S TW

Replace filter drier


A R RY
YE VE
E
Clean up the expansion valve
Replace orifice TXV expansion valve

You might also like