Wire Description

Wire Wire
RENR9858
Wire Color Description Wire Color Description August 2005
Number Number
Power Circuits Control Circuits (Continued)
101 RD BATTERY+ 727 GN SEC STR RELAY COIL+
102 BU RUNNING LAMP PWR 728 BU SEC STR INTER RELAY COIL+
104 YL PRODUCT LINK PWR (SWITCHED) 751 GN CLUTCH 1 REVERSE
106 WH LIFT/TILT POSITION SENSOR PWR 752 YL CLUTCH 2 FORWARD
109 OR ALTERNATOR PWR 754 BU CLUTCH 3 FOURTH
110 GN ENGINE ECM PWR (SWITCHED) 755 OR CLUTCH 4 THIRD
112 PU MAIN RELAY OUTPUT PWR 761 GY LIFT POS SENSOR
Component Identifiers (CID¹) 114 GN FORWARD HORN PWR 762 YL BUCKET/TILT POS SW
Module Identifier (MID²) 123 WH AXLE OIL COOLER CLUTCH POWER 779 WH QUICK COUPLER (ENGAGE SOL)
ADEM III ECM 129 BU START AID PWR A701 GY FUEL INJECTOR CYLINDER 1
(MID No. 036) 130 GN STOP LAMP/(BACKUP ALARM) PWR A702 PU FUEL INJECTOR CYLINDER 2
CID Component 136 GN SECONDARY STEERING PWR A703 BR FUEL INJECTOR CYLINDER 3 Component Location
0001 Fuel Injector Solenoid #1 138 GN PAYLOAD MONITOR SYSTEM PWR A704 GN FUEL INJECTOR CYLINDER 4 Schematic Machine Schematic Machine
Component Component
0002 Fuel Injector Solenoid #2 150 OR ENGINE ECM PWR (UNSWITCHED) A705 BU FUEL INJECOTR CYLINDER 5 Location Location Location Location
0003 Fuel Injector Solenoid #3 170 YL PRODUCT LINK PWR (UNSWITCHED) A706 GY FUEL INJECTOR CYLINDER 6 Alarm - Backup F-16 E-14, L-14 Sensor - Oil Pressure B-14 E-13, L-13
0004 Fuel Injector Solenoid #4 174 PK UNSWITCHED BUSS PWR A746 PK TURBO OUTLET PRESSURE Alternator C-18 D-13, L-13 Sensor - Trans. Lube Oil Temperature E-9 D-11, M-11
0005 Fuel Injector Solenoid #5 175 PK HOOD MOTOR PWR A747 GY ATMOSPHERIC PRESSURE Arc Suppressor D-18 D-13, L-13 Sensor - Trans. Output Speed F-9 D-10, M-10
0006 Fuel Injector Solenoid #6 177 OR MAIN CIRCUIT BREAKER PWR A751 YL AFTER COOLER TEMPERATURE Arc Suppressor 1 J-18 D-14, N-14 Sensor - Turbo Inlet Pressure C-10 E-11, L-11
0041 ECM 8V DC Supply 199 OR HOOD CONTROL PWR F713 OR TURBO INLET PRESS SENSOR Batteries A-18 C-14, K-14 Sensor - Turbo Outlet Pressure B-14 E-12, M-12
0091 Throttle Sensor Ground Circuits F762 GY START AID RELAY COIL+ Breaker - ADEM Engine Control K-18 D-14, N-14 Solenoid - A/C Clutch D-18 D-13, L-13
0094 Fuel Pressure Sensor 200 BK MAIN CHASSIS GND F766 WH DETENT ENABLE INTERLOCK Breaker - Alternator J-18 D-14, N-14 Solenoid - Axle Oil Cooler Clutch K-13 E-13, L-13
0100 Engine Oil Pressure 201 BK OPERATOR MONITOR GND G764 PK PARKING BRAKE SW (ON) Breaker - Hood Actuator K-18 D-14, N-14 Solenoids - Cylinder Head ( 1 - 6) E-15 E-13, L-13
0110 Engine Coolant Temperature Sensor 229 BK ENGINE ECM GND H702 PU REVERSING FAN RESET SWITCH (N.O.) Breaker - Main J-17 D-14, N-14 Solenoid - Ether Injection I-11 D-12, L-12
0168 Electrical Power Supply 251 BK PAYLOAD MONITOR SYSTEM GND H703 YL REVERSING FAN RESET SWITCH (N.C.) Breaker - Running Lamp K-18 D-14, N-14 Solenoid - Reversing Fan G-18 C-14, L-14
0172
0174
Inlet Air Temperature Sensor
Fuel Temperature Sensor
299
A274
BK
BK
M I PL ECM GROUND
PRODUCT LINK ECM GND
H704
H713
PK
PK
REVERSING FAN SOLENOID
LIFT PROPORTIONAL SOL
Breaker - Unswitched Bus (Cab)
Control - ADEM III Engine
K-18
A-10
D-14, N-14
C-12, L-12
Solenoid - Ride Control 1
Solenoid - Ride Control 2
K-2
K-2
D-7, M-7
D-7, M-7 980G Series ll
0253 Personality Module Basic Machine Circuits H714 OR LOWER PROPORTIONAL SOL Control - Product Link D-6 E-12, M-12 Solenoids - Trans. Clutch F-9 D-11, L-11
0254
0261
ADEM III ECM
Engine Timing Calibration Sensor
304
306
WH
GN
STARTER SOL START TERMINAL
START RELAY COIL+
H716
H717
WH
BR
I M PLEMENT ECM SOLENOID RETURN
PILOT SOLENOID
Ground - Engine
Ground - Left Frame
A-8
H-15
D-10, M-10
D-10, M-10
Solenoid - Variable Speed Fan
Switch - A/C Pressure
D-12
D-18
D-13, L-13
D-13, L-13
Wheel Loader
0262
0267
5V DC Power Supply Sensor
Engine Shutdown Switch
307
308
OR
YL
KEY SW(START)
MAIN POWER RELAY COIL+
H718
H746
GY
YL
BUCKET TILT POSITION SENS (SIG)
VARIABLE SPD FAN SOLENOID+
Ground - Right Frame
Motor - Fuel Priming Pump
A-17
E-18
D-10, K-10
E-13, L-13
Switch - Axle Oil Cooler Temperature
Switch - Brake Oil Pressure
K-13
C-6
C-11, L-11
D-9, K-9 Electrical System
0268 Check Programmable Parameters 317 YL START AID SOLENOID+ H747 BR VARIABLE SPD FAN SOLENOID- Motor - Starter C-18 C-12, L-12 Switch - Coolant Flow E-16 D-12, L-12
0273 Turbo Outlet Pressure Sensor 321 BR BACKUP ALARM H795 PK ENGINE ECM (SENSOR/SW RETURN) Motors - Front Washer B-7 D-9, K-9 Switch - Disconnect A-17 D-13, L-13 AXG1-UP
0274 Atmospheric Pressure Sensor 322 GY FORWARD HORN J700 BR ENGINE RETARDER SOL CYL 1 Relay - Ether Injection I-16 D-11, M-11 Switch - Engine Oil Level E-16 D-12, L-12
0291 Engine Cooling Fan Solenoid 326 PU FUEL PRIMING PUMP J701 GN ENGINE RETARDER SOL 3 Relay - Main J-18 D-14, N-14 Switch - Front Axle Temperature J-1 C-6, M-6
0296 Tranmission ECM 397 OR HOOD MOTOR LOWER J702 BK ENGINE RETARDER SOL COMMON Relay - Start I-18 D-14, N-14 Switch - Fuel Priming Pump D-18 E-13, L-13
0320 Speed/Timing Sensor 398 BU HOOD MOTOR RAISE A893 OR FUEL PRIMING PUMP MOTOR- Sender - Fuel Level L-7 D-9, N-9 Switch - Ground Level Shutdown L-14 C-14, N-14
0342 Secondary Engine Speed Sensor A300 GN HOOD CONTROL LOWER G828 WH SENSOR PRESSURE +5V Sensor - Atmospheric Pressure B-14 E-12, M-12 Switch - Hydraulic Oil Level A-6 B-9, J-9
0485 Engine Fan Reversing Solenoid A301 WH HOOD CONTROL RAISE G829 GN SENSOR PRESSURE COMMON Sensor - Cam Shaft Speed Timing A-15 E-13, L-13 Switch - Lift Kickout L-2 D-7, M-7
0545 Ether Start Relay A307 GY THROTTLE PEDAL POS SENS G833 PK ENGINE TEMP SENSOR COMMON Sensor - Coolant Temperature C-14 E-13, M-13 Switch - Park Brake Pressure C-6 D-9, K-9
0562 CAT Monitoring System Monitoring Circuits G850 BU AIR INLET HEATER RELAY COIL+ Sensor - Coolant Level F-18 C-14, L-14 Switch - Rear Axle Temp K-13 C-11, L-11
1582 Trans Lube Oil Temperature Sensor 403 GN ALTERNATOR (R) TERMINAL G856 WH TDC PROBE+ Sensor - Crank Shaft Speed Timing B-14 D-13, L-13 Switch - Supplemental Steering Pressure L-6 D-9, N-9
1589 Turbo Inlet Pressure Sensor 416 OR SEC STR PRESS SW (N/O) G857 YL TDC PROBE- Sensor - Fuel Pressure C-15 E-13, L-13 Switch - Tilt Kickout K-2 D-7, M-7
Product Link ECM 417 GY PRIMARY STR PRESS SW (N/O) J843 BK ENGINE ECM ANALOG SENSOR RTN Sensor - Fuel Temperature A-14 E-13, L-13 Switch - Trans Oil Level G-9 C-12, L-12
(MID No. 122) 419 YL PARKING BRAKE SW (OFF) J844 GY ENGINE ECM ANALOG SENS 5VOLTS Sensor - Hydraulic Oil Temperature A-6 D-9, K-9 Switch - Trans Filter Bypass F-8 E-11, L-11
CID Component 426 BR XMSN FILTER BYPASS SWITCH 900 PU CLUTCH 5 SECOND Sensor - Intake Manifold Air Temp B-14 E-12, M-12
0168 Electrical Power Supply 430 BU AIR FILTER RESTRICTED IND 901 WH CLUTCH 6 FIRST
0254 Electronic Control Module (Product Link) 432 PK BRAKE OIL PRES SWITCH (ON) 944 OR CAT DATA LINK+
0269 Sensor Power Supply 442 GY HYD TANK OIL TEMP SENSOR 945 BR CAT DATA LINK-
1251 Alternator R-Terminal Signal 443 YL TC OUTLET TEMP SENSOR 953 GY M I PLEMENT ECM SENSOR RTRN
447 PK FUEL LEVEL SENSOR 962 OR TRANSMISSION ECM SENSOR RTRN
¹ The CID is a diagnostic code that indicates which circuit is faulty.
450 YL ENGINE ECM (ENGINE SPD) 975 WH XMSN ECM SOLENOID/INDICATOR RTN
² The MID is a diagnostic code that indicates which electronic control module
453 PK SEC STR PRESS SW (N/O) 976 OR RIDE CONTROL ON SOLENOID
diagnosed the fault.
484 YL PRIMARY STR PRESS SW (N/C) 994 GY OIL PRESSURE (FILTERED)
496 WH HYD TANK OIL LEVEL SENS 995 BU COOLANT TEMPERATURE
E416 PU LIFT CYL HEAD END PRESS SENSOR A982 BR ENGINE ECM THROTTLE/IND 8VOLTS
E455 BR HYDRAULIC FILTER BYPASS SW C967 BU N I LET AIR TEMPERATURE
F421 YL FUEL TEMPERATURE C991 PK FUEL PRESS SENSOR
G454 PK PUMP DRIVE OIL TEMPERATURE E900 WH XMSN OUTPUT SPD SENS LEADING+
Volume 1: Chassis Wiring
G479 WH SERVICE ENGINE INDICATOR E901 GN XMSN OUTPUT SPD SENS LEADING-
© 2005 Caterpillar Printed in U.S.A.
G485 BU FRONT AXLE OIL TEMP SW E906 OR XMSN OUTPUT SPD SENS TRAILING+
G486 GN REAR AXLE OIL TEMP SW E907 GY XMSN OUTPUT SPD SENS TRAILING-
All Rights Reserved
Accessory Circuits E908 BR XMSN INPUT SPD SENSOR+
506 PU FRONT WASHER PUMP+ E909 WH XMSN INPUT SPD SENSOR-
507 WH REAR WASHER PUMP+ E919 YL AUX LIFT PROPORTIONAL SOL
513 OR A/C CLUTCH SOLENOID+ E920 BR AUX LOWER PROPORTIONAL SOL
521 YL A/C SELECT SW (A/C POSTION) E921 PK RACKBACK PROPORTIONAL SOL
522 WH A/C CLUTCH SOLENOID- E922 GN DUMP PROPORTIONAL SOL
C529 GY LIFT CYL HE PRESS SENS E963 BK CRANK RPM SENSOR-
C530 BU LIFT POSITION SENSOR E964 WH CRANK RPM SENSOR+ Harness And Wire Electrical Schematic Symbols
Lighting Circuits E965 BU CAM RPM SENSOR-
603 PK ROTARY BEACON E966 YL CAM RPM SENSOR+
604 OR STOP LAMP K933 GN OPERATOR MONITOR SENSOR PWR
Symbols
Failure Mode Identifiers (FMI)¹
FMI No. Failure Description
605 YL LH TURN LAMPS K977 PK XMSN OIL TEMP SENSOR 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
606 GY RH TURN LAMPS L983 WH FUEL INJECTOR RTN CYL 1-2
0 Data valid but above normal operational range. Connector Location T

608 GN REAR FLOOD LAMPS L984 OR FUEL INJECTOR RTN CYL 3-4 Pressure Temperature Level Flow Circuit Breaker
Schematic Machine
1 Data valid but below normal operational range.
611 PU HEAD LAMP (HIGH) L985 YL FUEL INJECTOR RTN CYL 5-6 Connector Number O O Symbol Symbol Symbol Symbol Symbol
2 Data erratic, intermittent, or incorrect. Location Location
612 GY BACKUP LAMP N939 GN RIDE CONTROL AUTO SOLENOID
3 Voltage above normal or shorted high. CONN 1 F-6 E-10, L-10
614 PU LICENSE PLATE/RH TAIL/DASH LAMPS P976 BR QUICK COUPLER RELEASE SOLENOID
4 Voltage below normal or shorted low. CONN 2 H-6 E-10, L-10 Symbols And Definitions
5 Current below normal or open circuit.
615 YL FORWARD CAB FLOOD LAMPS R971 YL XMSN LUBE OIL TEMP SENSOR
CONN 3 I-6 E-10, L-10 N N
617 BR LH TAIL/CLEARANCE LAMPS R974 OR START AID SWITCH Fuse - A component in an electrical circuit that will open the circuit if too much current flows
6 Current above normal or grounded circuit. CONN 4 J-6 E-10, L-10 through it.
619 GN FWD FLOOD/LO BEAM LAMPS X918 PU GND LEVEL SHUTDOWN SW (N/O)
7 Mechanical system not responding properly. CONN 5 G-6 E-10, L-10
Control Circuits

RENR9858 VOL 1
X919 WH GND LEVEL SHUTDOWN SW (N/C) Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
8 Abnormal frequency, pulse width, or period. CONN 6 D-17 D-12, L-12 M M circle indicates that the component has screw terminals and a wire can be disconnected from it.
709 OR XMSN ECM SENS/IND (+8VOLTS)
9 Abnormal update. CONN 7 Timing Cal Probe A-14 D-12, L-12
10 Abnormal rate of change. CONN 8 B-14 C-7, L-7 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
11 Failure mode not identifiable. CONN 9 C-14 C-11, L-11 L L No circle indicates that the wire cannot be disconnected from the component.
12 Bad device or component. CONN 10 D-14 E-12, L-12
13 Out of calibration. CONN 11 G-14 C-15, L-15 Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
CONN 12 K-13 C-10, L-10
14 Parameter failures.
Resistor, Sender and Solenoid Specifications CONN 13 K-14 C-10, L-10
K K
15 Parameter failures.
16 Parameter not available. Part No. Component Description Resistance (Ohms)¹ CONN 14 K-13 C-13, M-13 Ground (Case): This indicates that the component does not have a wire connected to ground.
118-9701 Solenoid: Reversing Fan 13.8 ± 0.4 CONN 15 H-12 E-10, L-10 It is grounded by being fastened to the machine.
17 Module not responding.
18 Sensor supply fault. 128-7991 Solenoids: Fuel Injectors 1.06 ± 0.05 CONN 16 G-8 D-13, L-13 J J
19 Condition not met. 141-9676 Solenoid: A/C Compressor Clutch 17.6 ± 0.6 CONN 17 A-6 C-9, K-9 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
147-5399 Solenoids: Transmission Clutch 8.15 ± 0.6 CONN 18 B-6 D-9, K-9 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
20 Parameter failures.
148-2350 Solenoid: Varible Speed Fan 5.0 ± 0.3 I I

30 Page
¹The FMI is a diagnostic code that indicates what type of failure has occurred. CONN 19 D-7 C-12, L-12
Empty: 95 ± 3.0 CONN 20 L-7 D-9, N-9 Sender: A component that is used with a temperature or pressure gauge. The sender
157-8858 Sender: Fuel Level
Full: 1.75 ± 1.75 CONN 21 K-4 D-7, L-7
measures the temperature or pressure. Its resistance changes to give an indication to
T
168-6452 Solenoid: Axle Oil Cooler Clutch 9.4 ± 5.0 the gauge of the temperature or pressure.
Ride Control 1
CONN 22 J-2 C-6, L-6 H H
174-4913 Solenoids: 8.7 ± 0.4 CONN 23 K-2 D-7, L-7
Ride Control 2 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
The connectors shown in this chart are for harness to harness connectors. It has a coil that makes an electromagnet when current flows through it. The
3E-6333 Solenoid: Ether Injection 6.0
Connectors that join a harness to a component are generally located at or near electromagnet can open or close the switch part of the relay.
¹ At room temperature unless otherwise noted. the component. See the Component Location Chart. G G
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
Event Codes F F
Off Machine Switch Specification
ADEM III ECM Part No. Function Actuate Deactuate Contact Position MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
Event Code Condition activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
275 to 1750 kPa¹
E015 High Engine Coolant Temperature Derate
114-5333 A/C (High / Low) Pressure
(39.9 to 253.8 psi)
Normally Open ² E E that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
E017 High Engine Coolant Temperature Warning 362 ± 2.9 mN 303 mN
134-6054 Coolant Flow Normally Open
E025 High Inlet Air Temperature Derate .141 ± .10 ozf 1.1 ozf
65 ± 3.0°C 58°C Min D D Harness And Wire Symbols
E027 High Inlet Air Temperature Warning 155-8998 Axle Oil Cooler Temperature Normally Open
(149 ± 5.4°F) (136.4°F Min)
E039 Low Engine Oil Pressure Derate 1 Deutsch connector: Typical representation 1 Sure-Seal connector: Typical representation
8270 kPa MAX 6890 ± 345 kPa A-B, Normally Open of a Deutsch connector. The plug contains all of a Sure-Seal connector. The plug and receptacle
E053 Low Fuel Pressure Warning 174-4312 Parking Brake Pressure 2 sockets and the receptacle contains all pins. 2 contain both pins and sockets.
(1200 psi MAX) (1000 ± 50 psi) A-C, Normally Closed C C
E096 High Fuel Pressure
175-3244 Brake Oil Pressure
10700 kPa MAX 8960 ± 537 kPa A-B, Normally Open Related Electrical Service Manuals Wire, Cable, or Harness Assembly Identification:
Harness Identification Letter(s):
(A, B, C, ..., AA, AB, AC, ...)
E100 Low Engine Oil Pressure Warning (1550 psi MAX) (1300 ± 79 psi) A-C, Normally Closed Includes Harness Identification Letters and Harness
Title Form Number Harness Connector Serialization Code: The "C" stands
Connector Serialization Codes
E190 Engine Overspeed Warning
177-2313 Front Axle Monitor Oil Temperature
100 ± 3.0°C 92°C Min
Normally Closed Alternator: 185-5294 SENR4130 B B for "Connector" and the number indicates which
connector in the harness. (C1, C2, C3, .....)
E272 Inlet Air Restriction Warning (212 ± 5.4°F) (197.6°F Min) Part Number for
Electric Starting Motor: 6V-0890 SENR3860 C-C4 AG-C3 Connector Plug AG-C4 L-C12 Part Number For
115 ± 3.0°C 106°C Min 111-7898 3E-5179
177-2314 Rear Axle Monitor Oil Temperature Normally Closed CAT Monitoring System: SENR1394 130-6795 130-6795 Connector Recepticle
(239 ± 5.4°F) (222.8°F Min)
1200 kPa MAX 700 ± 100 kPa A-C, Normally Closed
Transmission Control System: RENR6008 A A 325-AG135 PK-14 1 5A
230-5771 Supplemental Steering Pressure Pin Socket Fuse
(174 psi MAX) (101.5 ± 14.5 psi) B-C, Normally Open Product Link ECM: RENR5885 Receptacle
Pin or Socket (5 Amps)
¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained Single Wire 9X-1123
down to 170 kpa (25psi). 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 Connector Number
Component
Part Number
Plug
² Contact position at the contacts of the harness connector. Harness identification code: 2 200-L32 BK-14
This example indicates wire
135 in harness "AG".
Ground Circuit Identification Wire Gauge
Connection Number Wire Color
 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

TOOL BOX

GROUND LEVEL SHUTDOWN SW

CJ-C9 158-6634
1552272
X918-CJ93 PU-18 1 BK-18

L L
H795-CJ2 PK-18 2 RD-18
X919-CJ94 WH-18 3 WH-18
4

MACHINE LEFT SIDE

CJ-C17 CJ-C28 FRONT FRAME
1297164 1297163 FUEL LEVEL SENDER
397-CJ99 OR-14 1 CJ-C18 157-8858
1552269 AG-C12 LIFT KICKOUT PROXIMITY SWITCH
201-CJ60 BK-18 1 PK-18 1552267 3E-7844
447-CJ41 PK-18 2 BK-18 953-AG18 GY-18 A BK-18 GROUND
CJ-C20 CJ-C29 106-AG7 WH-18 B OR-18 + BATTERY
POWER DISTRIBUTION PANEL 1297163 1297164 C530-AG24 BU-18 C BU-18 SOLENOID
398-CJ98 BU-14 1 CAB
CJ-C19 CJ-C22 CK-C2 CK-C1 SUPPLEMENTAL STEERING PRESS SW
1552267 3E3370 3E3370 1552267 230-5771 AG-C11 AM-C1 AM-C2 TILT KICKOUT PROXIMITY SWITCH
CJ-C12 CJ-C30 201-CJ61 BK-18 A A 201-CK1 BK-18 A BK-16 3E3370 1552267 3E3370 176-5459
1552267 3E3370 417-CJ40 GY-18 B B 417-CK2 GY-18 B RD-16 106-AG6 WH-18 A 106-AM1 WH-18 A OR-18 + BATTERY
199-CJ47 RD-18 A 484-CJ16 YL-18 C C 484-CK3 YL-18 C BU-16 H718-AG34 GY-18 B H718-AM2 GY-18 B BU-18 SOLENOID
A301-CJ7 WH-18 B 953-AG17 GY-18 C 953-AM3 GY-18 C BK-18 GROUND
101-AH3 RD-14 1 1
175-CJ108 RD-14 A300-CJ96 GN-18 C CONN 20
20A
CJ-C2 CJ-C31 CONN 23
HOOD ACTUATOR BREAKER 1552273 3E3382
6T-3644 397-CJ99 OR-14 1 AG-C8
A300-CJ96 GN-18 2 CJ-C1 AG-C1 1552269
200-CJ85 BK-14 3 9X1343 9X0141 975-AG40 WH-18 1 GN-18
398-CJ98 BU-14 4 AXLE MONITOR 114-CJ21 RD-18 1 114-AG1 RD-18 976-AG42 OR-18 2 GN-18
175-CJ108 RD-14 5 138-CJ22 GN-18 2
A301-CJ7 WH-18 6 AXLE OIL COOLER TEMP SW 106-CJ20 WH-18 3 106-AG5 WH-18 RIDE CONT SOL 1
101-AH1 RD-14 110-CJ89 RD-10 CA-C2 CA-C4 CY-C1 CY-C2 200-CJ18 BK-14 N939-CJ44 GN-18 4 N939-AG8 GN-18 106-AG5 WH-18 106-AG7 WH-18 152-8340
1 1 3E3364 1552269 1552269 1552269 155-8998 FRAME GROUND
15A
200-CJ17 BK-14 201-CJ65 BK-18 5 201-AG44 BK-18 106-AG6 WH-18 AG-C16
ADEM ENGINE CONTROL BREAKER 1 1 200-CY1 BK-18 1 BK-18 106-CJ20 WH-18 G485-CJ35 BU-18 6 G485-AG43 BU-18 AG-C10 1552269
6T-3643 2 2 G454-CY2 PK-18 2 BK-18 114-CJ21 RD-18 200-CJ18 BK-14 7 200-AG9 BK-14 114-AG1 RD-18 114-AG3 RD-18 1552269 619-AG29 GN-14 1 LH FRONT FLOOD
K °T 138-CJ22 GN-18 200-CJ17 BK-14 8 200-AG12 BK-14 114-AG2 RD-18 975-AG41 WH-18 1 GN-18 200-AG14 BK-14 2 219-6485
K

200-CA2 BK-18
CONN 14

G454-CA1 PK-18
201-CJ65 BK-18 251-CJ23 BK-18 9 N939-AG8 GN-18 2 GN-18
REAR AXLE MONITOR OIL TEMP SW 251-CJ23 BK-18 953-CJ24 GY-18 10 953-AG16 GY-18 200-AG13 BK-14
CA-C3 322-CJ25 GY-18 322-CJ25 GY-18 11 322-AG19 GY-18 200-AG9 BK-14 200-AG10 BK-18 RIDE CONT SOL 2 AG-C14
1552269 177-2314 1552269
E416-CJ30 PU-18 E416-CJ30 PU-18 12 200-AG48 BK-14 152-8320
CJ-C5 1 BK-18 G485-CJ35 BU-18 C529-CJ28 GY-18 13 605-AG25 YL-18 1 RD-18 LH FRONT TURN LAMP
101-AH4 RD-14 102-CJ45 RD-14 3E3376 2 BK-18 C529-CJ28 GY-18 H718-CJ19 GY-18 14 H718-AG34 GY-18 200-AG14 BK-14 114-AG3 RD-18 200-AG11 BK-18 2 BK-18 3E-6466
1 15A 1
200-CJ103 BK-18 G486-CJ36 GN-18 1 G486-CA3 GN-18 °T C530-CJ29 BU-18 15 200-AG12 BK-14 200-AG11 BK-18 200-AG11 BK-18
RUNNING LAMP BREAKER 123-CJ3 WH-18 AXLE MONITOR 201-CJ63 BK-18 2 201-CA4 BK-18 605-CJ66 YL-18 16 200-AG47 BK-14 200-AG14 BK-14
3T-2662 201-CJ63 BK-18 200-CJ103 BK-18 3 606-CJ69 GY-18 17 322-AG21 GY-18 AG-C9
CAB 1552269
G486-CJ36 GN-18 4 611-CJ101 PU-14 C530-CJ29 BU-18 18 C530-AG24 BU-18 201-AG44 BK-18 605-AG25 YL-18
CA-C1 614-CJ70 PU-18 605-CJ66 YL-18 19 605-AG25 YL-18 619-AG29 GN-14 114-AG3 RD-18 1 LH FORWARD HORN
CONN 13 1552272 CJ-C23 CJ-C24 EW-C1 EW-C2 AXLE OIL COOLER CLUTCH 617-CJ72 BR-18 606-CJ69 GY-18 20 606-AG26 GY-18 322-AG21 GY-18 2 174-7875
1552269 3E3364 3E3364 1552269 168-6452 619-CJ102 GN-14 611-CJ101 PU-14 21 611-AG49 PU-14 322-AG19 GY-18 1 2

322-AG20 GY-18
200-CJ85 BK-14 G454-CJ104 PK-18 1 1 G454-EW2 PK-18 1 BK-18 H713-CJ37 PK-18 614-CJ70 PU-18 22 322-AG21 GY-18 AG-C19
101-AH2 RD-12 174-CJ4 RD-12 A300-CJ96 GN-18 201-CJ63 BK-18 123-CJ3 WH-18 2 2 123-EW1 WH-18 2 BK-18 H714-CJ38 OR-18 617-CJ72 BR-18 23 1552269
20A
A301-CJ7 WH-18 123-CJ3 WH-18 H716-CJ42 WH-14 24 G485-AG43 BU-18 611-AG45 PU-14 611-AG45 PU-14 1 LH BOTTOM FRONT FLOOD
UNSWITCHED FUSE BREAKER (CAB) 397-CJ99 OR-14 G486-CJ36 GN-18 CONN 12 H717-CJ43 BR-18 25 C530-AG24 BU-18 200-AG47 BK-14 200-AG47 BK-14 2 219-6485
6T-3644 398-CJ98 BU-14 102-CJ45 RD-14 CAB H718-CJ19 GY-18 26 605-AG25 YL-18 200-AG47 BK-14
175-CJ108 RD-14 112-CJ1 PU-4 E919-CJ31 YL-18 27 606-AG26 GY-18 611-AG49 PU-14 611-AG45 PU-14
WILL BE INSULATED AND 129-CJ46 RD-18 E920-CJ32 BR-18 619-CJ102 GN-14 28 619-AG27 GN-14 611-AG49 PU-14
ATTACHED ON THE HARNESS 175-CJ108 RD-14 174-CJ4 RD-12 E921-CJ33 PK-18 H713-CJ37 PK-18 29 611-AG46 PU-14 AG-C20
109-CJ88 RD-4 101-CJ97 RD-4 199-CJ47 RD-18 E922-CJ34 GN-18 H714-CJ38 OR-18 30 619-AG27 GN-14 1 2

619-AG28 GN-14 200-AG48 BK-14 1552269

102-CJ45 RD-14 200-CJ86 BK-18 N939-CJ44 GN-18 H716-CJ42 WH-14 31 619-AG29 GN-14 611-AG46 PU-14 611-AG46 PU-14 1 RH BOTTOM FRONT FLOOD
109-CJ88 RD-4 308-CJ110 YL-18 953-CJ24 GY-18 H717-CJ43 BR-18 32 200-AG48 BK-14 200-AG48 BK-14 2 219-6485
MAIN BREAKER 110-CJ89 RD-10 306-CJ48 GN-18 976-CJ27 OR-18 33 H718-AG34 GY-18
171-2210 112-CJ1 PU-4 975-CJ74 WH-18 975-CJ76 WH-18 E919-CJ31 YL-18 34 N939-AG8 GN-18 AG-C6
174-CJ4 RD-12 E920-CJ32 BR-18 35 1552269
101-AH3 RD-14 BUSS BAR 7V-9275 1 80A
177-CJ107 RD-4 200-CJ84 BK-18 36 953-AG16 GY-18 953-AG17 GY-18 114-AG2 RD-18 1 RH FORWARD HORN
101-AH2 RD-12 105A
200-CJ87 BK-18 E921-CJ33 PK-18 37 953-AG18 GY-18 114-AG2 RD-18 322-AG20 GY-18 2 163-1201
101-AH4 RD-14 304-CJ90 WH-8 E922-CJ34 GN-18 38 200-AG10 BK-18
101-AH1 RD-14 ALTERNATOR BREAKER CBL PP1 RD-2 306-CJ48 GN-18 X919-CJ94 WH-18 975-CJ76 WH-18 39 975-AG39 WH-18 975-AG39 WH-18 975-AG40 WH-18 200-AG13 BK-14
171-2212 308-CJ110 YL-18 H795-CJ2 PK-18 976-CJ27 OR-18 40 976-AG42 OR-18 975-AG41 WH-18 322-AG20 GY-18 AG-C3
975-CJ74 WH-18 X918-CJ93 PU-18 606-AG26 GY-18 1552269

J J
110-CJ89 RD-10 CONN 21 976-AG42 OR-18 619-AG28 GN-14 606-AG26 GY-18 1 RD-18 RH FRONT TURN LAMP
177-CJ107 RD-4 109-CJ88 RD-4 ENGINE DISCONNECT 200-AG10 BK-18 2 BK-18 3E-6466
101-CJ97 RD-4 129-CJ46 RD-18 304-CJ90 WH-8
229-CJ82 BK-18 317-CJ91 YL-18 G485-AG43 BU-18
317-CJ91 YL-18 F762-CJ92 GY-18 201-AG44 BK-18 AG-C5
F762-CJ92 GY-18 200-CJ80 BK-18 CH-C3 CH-C18 1552269
CJ-C25 200-CJ100 BK-18 3E5179 1552252 619-AG28 GN-14 1 RH FRONT FLOOD
1552269 229-CJ81 BK-10 1 326-CH60 RD-18 200-AG13 BK-14 2 219-6485
308-CJ106 YL-18 1 2 308-CH61 YL-18
200-CJ84 BK-18 2 3 G790-CH62 PK-18
ARC SUPPRESSOR 1 200-CJ80 BK-18 4 G791-CH63 PU-18
177-CJ107 RD-4

218-4935 200-CJ100 BK-18 5 X337-CH64 BU-18

229-CJ81 BK-10 6 200-CH65 BK-18 CJ-C11 FRONT AXLE MONITOR OIL TEMP SW
CJ-C26 200-CJ103 BK-18 7 H795-CH68 PK-18 8N1533 AG-C13 HA-C1 HA-C2 177-2313
3E3364 200-CJ86 BK-18 FRAME GROUND 8 112-CJ1 PU-4 1 3E3364 1552269 1552269
BK-16 1 200-CJ87 BK-18 200-CJ87 BK-18 9 2 CONN 5 G485-AG43 BU-18 1 G485-HA1 BU-18 1 BK-18
BK-16 2 308-CJ105 YL-18 308-CJ110 YL-18 200-CJ85 BK-14 10 611-CJ101 PU-14 3 CONNECTS TO C-C2 201-AG44 BK-18 2 201-HA2 BK-18 2 GN-18
200-CJ84 BK-18 11 4 ON CAB DIAGRAM °T
229-CJ82 BK-18 12 200-CJ86 BK-18 619-CJ102 GN-14 5 254-2138 CONN 22
BUSS BAR 186-3223 1 1
112-CJ1 PU-4 229-CJ83 BK-18 201-CJ64 BK-18 6 FRONT FRAME
229-CJ83 BK-18 419-CJ6 YL-18 174-CJ4 RD-12 7
MAIN RELAY 101-CJ97 RD-4 BATTERIES 432-CJ8 PK-18
167-0138 442-CJ9 GY-18 CJ-C4
E455-CJ13 BR-18 9X7147
RIGHT SIDE 496-CJ10 WH-18 1
CJ-C27 506-CJ11 PU-18 2
1552269 507-CJ12 WH-18 962-CJ5 OR-18 3
BK-18 1 306-CJ48 GN-18 G764-CJ14 PK-18 4
BK-18 2 975-CJ74 WH-18 ETHER INJECTION RELAY K933-CJ77 GN-18 419-CJ6 YL-18 5
CJ-C3 3E-5239 962-CJ5 OR-18 6
9X1054 432-CJ8 PK-18 7
30
1
304-CJ90 WH-8 129-CJ46 RD-18 1
86 106-CJ20 WH-18 442-CJ9 GY-18 8
F762-CJ92 GY-18 5 114-CJ21 RD-18 102-CJ45 RD-14 9
START RELAY 229-CJ82 BK-18 2
85 138-CJ22 GN-18 106-CJ20 WH-18 496-CJ10 WH-18 10
125-1302 317-CJ91 YL-18 201-CJ65 BK-18 112-CJ1 PU-4 506-CJ11 PU-18
I I
4 11
87
3
87a 251-CJ23 BK-18 114-CJ21 RD-18 507-CJ12 WH-18 12
322-CJ25 GY-18 123-CJ3 WH-18 E455-CJ13 BR-18 13
E416-CJ30 PU-18 129-CJ46 RD-18 G764-CJ14 PK-18 14
G485-CJ35 BU-18 138-CJ22 GN-18 K933-CJ15 GN-18 15
C529-CJ28 GY-18 174-CJ4 RD-12 484-CJ16 YL-18 16
C530-CJ29 BU-18 199-CJ47 RD-18 17
605-CJ66 YL-18 251-CJ23 BK-18 18
606-CJ69 GY-18 306-CJ48 GN-18 H718-CJ19 GY-18 19
CONN 4
611-CJ101 PU-14 321-CJ50 BR-18 106-CJ20 WH-18 20 CONNECTS TO C-C3
614-CJ70 PU-18 322-CJ25 GY-18 114-CJ21 RD-18 21 ON CAB DIAGRAM
617-CJ72 BR-18 E416-CJ30 PU-18 138-CJ22 GN-18 22 254-2138
FRONT FRAME 619-CJ102 GN-14 417-CJ40 GY-18 251-CJ23 BK-18 23

229-CJ83 BK-18
H713-CJ37 PK-18 419-CJ6 YL-18 953-CJ24 GY-18
200-CJ100 BK-18

200-CJ103 BK-18
24
200-CJ87 BK-18
200-CJ86 BK-18

200-CJ85 BK-14
200-CJ84 BK-18
229-CJ82 BK-18

229-CJ81 BK-10

200-CJ80 BK-18
H714-CJ38 OR-18 426-CJ58 BR-18 322-CJ25 GY-18 25
POWER DISTRIBUTION PANEL H716-CJ42 WH-14 432-CJ8 PK-18 26
H717-CJ43 BR-18 442-CJ9 GY-18 976-CJ27 OR-18 27
H718-CJ19 GY-18 447-CJ41 PK-18 C529-CJ28 GY-18 28
ALTERNATOR CJ-C15 CJ-C21 E919-CJ31 YL-18 E455-CJ13 BR-18 C530-CJ29 BU-18 29
1552269 3E3364 E920-CJ32 BR-18 484-CJ16 YL-18 E416-CJ30 PU-18 30
200-CJ80 BK-18 1 WH-18 E921-CJ33 PK-18 G485-CJ35 BU-18 E919-CJ31 YL-18 31
317-CJ91 YL-18 2 PU-18 E922-CJ34 GN-18 G486-CJ36 GN-18 E920-CJ32 BR-18 32
953-CJ24 GY-18 496-CJ10 WH-18 E921-CJ33 PK-18 33
START AID SOL N939-CJ44 GN-18 506-CJ11 PU-18 E922-CJ34 GN-18 34
3E-6333 976-CJ27 OR-18 507-CJ12 WH-18 G485-CJ35 BU-18 35
200-CJ17 BK-14 FRONT FRAME ENGINE 975-CJ76 WH-18 C529-CJ28 GY-18 G486-CJ36 GN-18 36
200-CJ18 BK-14 C530-CJ29 BU-18 H713-CJ37 PK-18 37
308-CH61 YL-18 201-CJ60 BK-18 604-CJ51 OR-18 H714-CJ38 OR-18 38
326-CH60 RD-18 LEFT SIDE 201-CJ61 BK-18 608-CJ54 GN-14 39
LEFT FRAME GROUND 200-CH65 BK-18 417-CJ40 GY-18 611-CJ101 PU-14 40
200-CJ26 BK-14 REAR H795-CH68 PK-18 447-CJ41 PK-18 619-CJ102 GN-14
200-CJ79 BK-14 G790-CH62 PK-18 484-CJ16 YL-18 H713-CJ37 PK-18 CJ-C6
X337-CH64 BU-18 H714-CJ38 OR-18 9X0141
G791-CH63 PU-18 102-CJ45 RD-14 H716-CJ42 WH-14 1
CJ-C7 CH-C4 112-CJ1 PU-4 H717-CJ43 BR-18 123-CJ3 WH-18 2

H 201-CJ62 BK-18
8N1518
304-CJ90 WH-8
K933-CJ78 GN-18
1
2
8N1517
304-CH34 WH-8
K933-CH54 GN-18
G791-CH63 PU-18
X337-CH64 BU-18
G790-CH62 PK-18 POWER PANEL
123-CJ3 WH-18
129-CJ46 RD-18
174-CJ4 RD-12
H718-CJ19 GY-18
G764-CJ14 PK-18
E919-CJ31 YL-18
201-CJ39 BK-18
417-CJ40 GY-18
447-CJ41 PK-18
3
4
5
H
308-CJ109 YL-18 201-CJ62 BK-18 3 201-CH53 BK-18 H795-CH68 PK-18 199-CJ47 RD-18 E920-CJ32 BR-18 H716-CJ42 WH-14 6
CAB K933-CJ78 GN-18 4 H795-CH8 PK-18 200-CJ86 BK-18 E921-CJ33 PK-18 H717-CJ43 BR-18 7
308-CJ109 YL-18 5 308-CH61 YL-18 X919-CH45 WH-18 ADEM 201-CJ63 BK-18 E922-CJ34 GN-18 N939-CJ44 GN-18 8
109-CJ88 RD-4 6 109-CH56 RD-4 X918-CH44 PU-18 306-CJ48 GN-18 N939-CJ44 GN-18 9
110-CJ89 RD-10 7 110-CH51 RD-10 110-CH51 RD-10 308-CJ110 YL-18 953-CJ24 GY-18 10
200-CJ100 BK-18 X918-CJ93 PU-18 8 X918-CH44 PU-18 200-CH55 BK-18 F762-CH46 GY-18 G486-CJ36 GN-18 962-CJ5 OR-18 11
200-CJ80 BK-18 9 201-CH53 BK-18 229-CH35 BK-10 975-CJ74 WH-18 201-CJ60 BK-18 102-CJ45 RD-14 12
229-CJ81 BK-10 X919-CJ94 WH-18 10 X919-CH45 WH-18 229-CH35 BK-10 H704-CH48 PK-18 13
304-CJ90 WH-8 11 304-CH34 WH-8 200-CH59 BK-4 321-CJ50 BR-18 201-CJ65 BK-18 129-CJ46 RD-18 14
POWER PANEL 317-CJ91 YL-18 F762-CJ92 GY-18 12 F762-CH46 GY-18 308-CH61 YL-18 443-CH57 YL-18 CH-C13 TORQUE CONVERTOR TEMP SENSOR 604-CJ51 OR-18 201-CJ61 BK-18 199-CJ47 RD-18 15
F762-CJ92 GY-18 13 F762-CH46 GY-18 1552267 118-7226 605-CJ67 YL-18 201-CJ64 BK-18 1 2

201-CJ39 BK-18 306-CJ48 GN-18 16

H795-CJ2 PK-18 14 H704-CH48 PK-18 443-CH57 YL-18 K933-CH54 GN-18 A OR-18 +8 VOLTS REAR LIGHTS 606-CJ68 GY-18 201-CJ59 BK-18 308-CJ49 YL-18 17
X918-CJ93 PU-18 15 H795-CH8 PK-18 K933-CH54 GN-18 201-CH53 BK-18 B BK-18 GROUND 608-CJ54 GN-14 201-CJ62 BK-18 18
CONN 3
LH REAR FLOODLAMP X919-CJ94 WH-18 200-CJ100 BK-18 16 200-CH55 BK-18 K933-CH54 GN-18 201-CH53 BK-18 443-CH57 YL-18 C WH-18 SIGNAL 614-CJ71 PU-18 201-CJ63 BK-18 19
219-6485 H704-CJ95 PK-18 H795-CJ2 PK-18 17 H795-CH8 PK-18 X918-CH44 PU-18 200-CH59 BK-4 617-CJ73 BR-18 605-CJ66 YL-18 20 CONNECTS TO C-C1
CF-C10 H704-CJ95 PK-18 18 H704-CH48 PK-18 X919-CH45 WH-18 109-CH56 RD-4 975-CJ75 WH-18 605-CJ67 YL-18 1 2

605-CJ52 YL-18 21 ON CAB DIAGRAM

1552269 109-CJ88 RD-4 19 109-CH56 RD-4 200-CH55 BK-18 MACHINE ENGINE 606-CJ69 GY-18 22 254-2138
1 608-CF19 GN-14 20 304-CH34 WH-8 ENGINE DISCONNECT 201-CJ62 BK-18 606-CJ68 GY-18 1 2

606-CJ53 GY-18 23
2 200-CF15 BK-14 21 200-CH65 BK-18 308-CJ109 YL-18 614-CJ70 PU-18 24
RADIATOR 110-CJ89 RD-10 22 110-CH51 RD-10 326-CH60 RD-18 K933-CJ78 GN-18 614-CJ71 PU-18 1 2

614-CJ55 PU-18 25
LH STOP TAIL PARK LAMP (LED) 23
XSMN OIL LVL SW 617-CJ72 BR-18 321-CJ50 BR-18 26
135-0426 229-CJ81 BK-10 24 229-CH35 BK-10 259-5415 AU-C4 426-CJ58 BR-18 617-CJ73 BR-18 1 2

617-CJ56 BR-18 604-CJ51 OR-18 27

CF-C9 200-CF15 BK-14 25 1464073 201-CJ59 BK-18 975-CJ74 WH-18 605-CJ52 YL-18 28
1552267 200-CF16 BK-18 200-CF13 BK-18 CAB CONNECTOR AT-C3 975-CJ75 WH-18 975-CJ57 WH-18 606-CJ53 GY-18 29
CONN 15 201-AU10 BK-18
1 2

BK-18 1
S RD-18 A 604-CF17 OR-18 200-CF14 BK-18 200-CF12 BK-14 BK-18 2 425-AU2 PK-18 975-CJ76 WH-18 608-CJ54 GN-14 30
T WH-18 C 617-CF9 BR-18 604-CF17 OR-18 200-CF14 BK-18 K933-CJ77 GN-18 614-CJ55 PU-18 31
BK-18 B 200-CF16 BK-18 605-CF5 YL-18 200-CF1 BK-14 K933-CJ78 GN-18 1 2

K933-CJ15 GN-18 617-CJ56 BR-18 32

608-CF19 GN-14 200-CF11 BK-18 200-CF2 BK-14 308-CJ109 YL-18 975-CJ57 WH-18 33
LH REAR TURN LAMP (LED) 617-CF9 BR-18 308-CJ110 YL-18 1 2

308-CJ49 YL-18 34
200-CF15 BK-14 CF-C3 CJ-C8 35
199-3368 CF-C7 3E5179 1552252
200-CF16 BK-18 XMSN REV 1 SOL XMSN FWD 2 SOL XMSN 4TH GEAR 3 SOL 36
1552269
G G
604-CF17 OR-18 200-CF1 BK-14 1 200-CJ79 BK-14 147-5399 147-5399 147-5399 37
RD-18 1 605-CF5 YL-18 200-CF2 BK-14 2 200-CJ26 BK-14 FRAME GROUND 38
BK-18 2 200-CF14 BK-18 604-CF18 OR-18 604-CF4 OR-18 321-CF3 BR-18 3 321-CJ50 BR-18 201-AU10 BK-18 39
608-CF19 GN-14 604-CF4 OR-18 4 604-CJ51 OR-18 201-AU7 BK-18 426-CJ58 BR-18 40
608-CF20 GN-14 605-CF5 YL-18 5 605-CJ67 YL-18
CAB 201-AU8 BK-18 AT-C3

WH-18
WH-18

WH-18
WH-18

WH-18
WH-18
608-CF7 GN-14 606-CF6 GY-18 6 606-CJ68 GY-18 7X6222
605-CF5 YL-18 608-CF7 GN-14 7 608-CJ54 GN-14 201-AU9 BK-18
606-CF6 GY-18 614-CF8 PU-18 8 614-CJ71 PU-18 201-AU1 BK-18 1

1
CJ-C13 CJ-C14 RH REAR TURN LAMP 614-CF8 PU-18 617-CF9 BR-18 617-CJ73 BR-18 975-AR8 WH-18 975-AR7 WH-18 425-AU2 PK-18

1
2

1
2

1
2
9 2
AR-C2 AR-C3 AR-C4

1
1 2

1552269 3E3364 199-3368 CF-C5 617-CF9 BR-18 975-CF10 WH-18 10 975-CJ75 WH-18 975-AR9 WH-18 AR-C1 AT-C2 E452-AU3 WH-18 3
3E3364 3E3364 3E3364

1
GN-18 1 H704-CJ95 PK-18 1552269 11 975-AR11 WH-18 1018107 6D5256 751-AT1 GN-18 4
GN-18 2 229-CJ83 BK-18 BK-18 1 606-CF6 GY-18 321-CF3 BR-18 12 975-AR10 WH-18 1 2

752-AR1 YL-18 A 752-AT2 YL-18 754-AT2 YL-18 5

BK-18 2 200-CF13 BK-18 754-AR4 BU-18 975-AR10 WH-18 B 6
REVERSING FAN SOL 200-CF12 BK-14 975-CF10 WH-18 CONN 11 975-AR8 WH-18 975-AR12 WH-18 751-AR2 GN-18 C 751-AT1 GN-18 E900-AT3 WH-18 7
118-9701 200-CF13 BK-18 752-AR1 YL-18 975-AR13 WH-18 D C468-AU4 BU-18 8

1
(CUSTOM) RH STOP TAIL PARK LAMP (LED) 200-CF11 BK-18 975-AR14 WH-18 975-AR14 WH-18 900-AR3 PU-18 E 900-AT7 PU-18 A497-AU5 GY-18 9

1
1 2

135-0426 604-CF18 OR-18 751-AR2 GN-18 975-AR15 WH-18 F TWISTED WIRES 10 CONN 2
CF-C4 606-CF6 GY-18 755-AR5 OR-18 751-AR2 GN-18 754-AR4 BU-18 G 754-AT4 BU-18 NOTE A 11
1552267 608-CF20 GN-14 975-AR12 WH-18 752-AR1 YL-18 H 754-AT4 BU-18 12 CONNECTS TO C-C26
S RD-18 A 604-CF18 OR-18 614-CF8 PU-18 900-AR3 PU-18 754-AR4 BU-18 755-AR5 OR-18 I 755-AT6 OR-18 E901-AT5 GN-18 13 ON CAB DIAGRAM
T WH-18 C 614-CF8 PU-18 975-AR13 WH-18 755-AR5 OR-18 J TRANSMISSION T800-AU6 OR-18 14 254-2138

1
BK-18 B 200-CF11 BK-18 901-AR6 WH-18 900-AR3 PU-18 901-AR6 WH-18 K 901-AT8 WH-18 15
975-AR15 WH-18 901-AR6 WH-18 L 16
RH REAR FLOODLAMP (LED) 975-AR7 WH-18 M 975-AT9 WH-18 17
219-6485 CF-C2 N 755-AT6 OR-18 18
BACKUP ALARM (ATCH) AR-C5 AR-C6 AR-C7
1552269 213-9100 CF-C11 CF-C1 19
1 608-CF20 GN-14 3E3364 1552269 3E3364 3E3364 3E3364 CONN 16 900-AT7 PU-18 20
200-CF12 BK-14 321-CF3 BR-18 901-AT8 WH-18

1
2

1
2

1
2
2 BK-18 1 21
TWISTED WIRES
BK-18 2 975-CF10 WH-18 XMSN OUTPUT SPEED SNSR AT-C1 975-AT9 WH-18 22
239-9957 AU-C1 189-5746 1552269 23

WH-18
WH-18

WH-18
WH-18

WH-18
WH-18
COOLANT LVL SENSOR 1552267 BK-18 1 E900-AT3 WH-18 24
VS RD-18 A T800-AU6 OR-18 CAB CONNECTOR AT-C3 WH-18 2 E901-AT5 GN-18
RENR9858 VOL 1

GROUND BK-18 B 201-AU7 BK-18 CH-C1

ALARM GN-18 C E452-AU3 WH-18 CJ-C16 1835784
3RD GEAR 4 SOL 2ND GEAR 5 SOL 1ST GEAR 6 SOL 1552269 1

F RADIATOR 147-5399 147-5399 147-5399

TRANSMISSION
BK-18
BK-18
1
2
426-CJ58 BR-18
201-CJ59 BK-18
201-AU10 BK-18
425-AU2 PK-18
TRANSMISSION
326-CH10 RD-18
2
3 F
201-AU7 BK-18 450-CH11 YL-18 4
RADIATOR 5
XMSN FILTER BYPASS SW E452-AU3 WH-18
201-AU10 BK-18 T800-AU6 OR-18 6
201-AU7 BK-18 164-7577 425-AU2 PK-18 403-CH7 GN-18 7
E452-AU3 WH-18 201-AU7 BK-18 201-AU8 BK-18 COOLANT FLOW SW 521-CH12 YL-18 8
T800-AU6 OR-18 E452-AU3 WH-18 A497-AU5 GY-18 522-CH18 WH-18 9
201-AU8 BK-18 201-AU8 BK-18 201-AU9 BK-18 ENGINE 10
A497-AU5 GY-18 T800-AU6 OR-18 C468-AU4 BU-18 11
CONN 1
201-AU9 BK-18 A497-AU5 GY-18 150-CH19 OR-18 12 CONNECTS TO C-C35
C468-AU4 BU-18 C468-AU4 BU-18 403-CH31 GN-18 403-CH7 GN-18
2 1

944-CH20 OR-18 13 ON CAB DIAGRAM

201-AU9 BK-18 403-CH5 GN-18 945-CH21 BR-18 14 254-2138
MACHINE ENGINE 326-CH10 RD-18 A307-CH22 GY-18 15
522-CH18 WH-18 A982-CH26 BR-18 16
521-CH12 YL-18 H795-CH27 PK-18 17
R974-CH28 OR-18 18
150-CH19 OR-18 H702-CH29 PU-18 19
A307-CH22 GY-18 H703-CH30 YL-18 20
430-CH13 BU-18 430-CH13 BU-18 21
443-CH57 YL-18 G479-CH15 WH-18 22
ADEM 450-CH11 YL-18 23
G479-CH15 WH-18 443-CH57 YL-18 24
H702-CH29 PU-18 25
POWER PANEL

H703-CH30 YL-18 26
COOLANT FLOW SW H795-CH27 PK-18 G850-CH14 BU-18 27 TWISTED WIRES
134-6054 AU-C2 G850-CH14 BU-18 104-CH2 YL-18 28
1552269 944-CH20 OR-18 170-CH1 RD-18 29
BK-18 1 201-AU8 BK-18 CAB CONNECTOR AT-C3 945-CH21 BR-18 A274-CH3 BK-18 30
BK-18 2 A497-AU5 GY-18 R974-CH28 OR-18 945-CH6 BR-18 31
A982-CH26 BR-18 944-CH4 OR-18 32
33
30 Page

101-CJ97 RD-4

34
229-CJ83 BK-18

ENGINE OIL LVL SW TWISTED WIRES 104-CH2 YL-18 35

E E
259-5415 AU-C3 CH-C5 170-CH1 RD-18 36
1464073 1552269 A274-CH3 BK-18 37
CAB CONNECTOR AT-C3 R971-CH32 YL-18
BK-18 1 201-AU9 BK-18 1 SIGNAL 403-CH5 GN-18 38 TWISTED WIRES
BK-18 2 C468-AU4 BU-18 J843-CH33 PU-18 2 GROUND 944-CH4 OR-18 39
945-CH6 BR-18 40
XSMN LUBE OIL TEMP SENSOR
130-9811

ENGINE

AX-C2
1552269
2 A893-AX3 OR-18
MOTOR CYL HEAD CYL HEAD CYL HEAD CYL HEAD CYL HEAD CYL HEAD
1 129-AX1 RD-18

FUEL PRIMING PUMP

SOL 1
128-7991
SOL 2
128-7991
SOL 3
128-7991
SOL 4
128-7991
SOL 5
128-7991
SOL 6
128-7991 VARIABLE SPEED FAN SOL CH-C6
VHF ANTENNA GPS ANTENNA WIRE GROUP COLOR DESCRIPTIONS
148-2350 1552269
162-2211
1 H746-CH43 YL-18
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.
FUEL PRIMING PUMP SW CX-C1 CX-C2 CX-C3 CX-C4 CX-C5 CX-C7 2 H747-CH41 BR-18
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
1 2 1 2 1 2 1 2 1 2

165-5970 AX-C1 CH-C15 7E6513 7E6513 7E6513 7E6513 7E6513 7E6513 GPS ANTENNA
AX-C3 3E3364 1552269
J702-CX1 BK-18
J702-CX2 BK-18
J702-CX3 BK-18

J700-CX4 BR-18

J701-CX609 GN-18
J700-CX5 BR-18

VOLTAGE CONVERTER OUTPUT CIRCUIT.

1803837
1552267
L984-CX402 OR-18

L985-CX702 YL-18
A701-CX601 GY-18

A702-CX602 PU-18

A703-CX603 BR-18

A704-CX604 GN-18

A705-CX605 BU-18

A706-CX606 GY-18
L983-CX102 WH-18

326-CH66 RD-18 326-CH10 RD-18

L984-CX302 OR-18

L985-CX502 YL-18

MOM 1 VHF ANTENNA

L983-CX202 WH-18

RD-18 B 200-AX2 BK-18 2 200-CH67 BK-18 CH-C17 CH-C14 MC-C1

WH-18 C 3E3382 1552273 1552273 STARTING CIRCUIT.
BK-18 A A893-AX3 OR-18 CONN 6 170-CH1 RD-18 1 1 170-MC1 RD-18 170-MC1 RD-18 1 + BATTERY
104-CH2 YL-18 2 2 104-MC2 YL-18 A274-MC3 BK-18 2 GROUND GROUND CIRCUIT.
A274-CH3 BK-18 3 3 A274-MC3 BK-18 3
403-CH5 GN-18 4 4 403-MC4 GN-18 403-MC4 GN-18 4 ALTERNATOR R TERM INPUT STARTING AID CIRCUIT.
200-CH65 BK-18 944-CH4 OR-18 5 5 944-MC5 OR-18 104-MC2 YL-18 5 KEYSWITCH INPUT
200-CH55 BK-18
326-CH60 RD-18
945-CH6 BR-18 6 6 945-MC6 BR-18 6
7
CAT DATA LINK
CONN 19 8
MONITOR CIRCUIT. (VIMS) / (CMS) / (EMS) / (OTHER)
J702-CX607 BK-18

J700-CX611 BR-18

CH-C8 CH-C7 CX-C6 K-C13

D D
L983-CX612 WH-18

AC PRESS SW
L984-CX610 OR-18

L985-CX608 YL-18

9
114-5333 3E3364 1552269 3E8969 1552252
NORMALLY
OPEN BEFORE 2 3 BK-18 1 513-CH24 OR-18 A701-CX601 GY-18 1 A701-K12 GY-18 944-MC5 OR-18
10
11 CAT DATA LINK + ENGINE CONTROL CIRCUIT (MASTER ).
REFRIGERANT 1 BK-18 2 521-CH12 YL-18 521-CH12 YL-18 A702-CX602 PU-18 2 A702-K13 PU-18 945-MC6 BR-18 12 CAT DATA LINK -
CHARGE A703-CX603 BR-18 3 A703-K14 BR-18 13 TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT.
A704-CX604 GN-18 4 A704-K15 GN-18 14
CH-C9 CH-C10 A705-CX605 BU-18 5 A705-K22 BU-18 15 HEATER AND AIR CONDITIONER CIRCUIT.
3E3364 1552269 A706-CX606 GY-18 6 A706-K23 GY-18 16
1 513-CH25 OR-18 J702-CX607 BK-18 7 17 TURN SIGNAL/WIPER/WASHER CIRCUIT.
2 522-CH16 WH-18 L985-CX608 YL-18 8 L985-K19 YL-18 18
ARC SUPPRESSOR J701-CX609 GN-18 9 TWISTED WIRES 19
218-4935 CAB ENGINE RETARDING WIRES: NOT USED L984-CX610 OR-18 10 L984-K18 OR-18 20
J700-CX611 BR-18 11 21
CH-C11 CH-C12 L983-CX612 WH-18 12 L983-K17 WH-18 22
3E3364 1552269 23
GN-16 1 513-CH23 OR-18 CONN 15 24
GN-16 2 522-CH17 WH-18 522-CH18 WH-18 HEUI MC-C2
CONNECTOR PRODUCT LINK ECM
7X6222 209-6417
AC COMPRESSOR (CLUTCH SOL) FUEL INJECTORS
141-9676 PRODUCT LINK ATTACHMENT

ALTERNATOR
197-8820 95A

POWER PANEL
CBL PP1 RD-2 + ALT R 403-CH31 GN-18 403-CH31 GN-18

1 CH-C16
CBL-RR1 BK-2 3E3370
+5V J844-CH50 GY-18 OR-18 A
GROUND J843-CH52 PU-18 YL-18 B MACHINE RIGHT SIDE
C WILL BE INSULATED AND
ATTACHED ON THE HARNESS
ENGINE GROUND ALT
SIGNAL
TURBO INLET PRESSURE SENSOR
194-6722
F713-CH47 OR-18 GN-18 C

CG-C4 PARK BRAKE PRESS SW

ABBREV COLOR IDENT PART NUMBER VER CHG LOC NOTE C
AX-C5 AX-C4 K-C11 1552267 174-4312 AG 257-6270 V 02 K-3 FRONT CHASSIS
3E3370 1552267 3E3370 962-CG3 OR-18 A BK-16
RD RED AM 259-5399 V 01 K-2 TILT POSITION SENSOR
AN 213-2226 - 01 A-6 HYDRAULIC TANK
+5V OR-18 A G828-AX111 WH-18 A G828-K28 WH-18 419-CG4 YL-18 B RD-16 SHOWN WITH WH WHITE AR 131-2150 - 01 G-8 TRANSMISSION
200-CH59 BK-4 200-CH59 BK-4 GROUND YL-18 B G829-AX112 GN-18 B G829-K31 GN-18 G764-CG11 PK-18 C BU-16 BRAKE ON
109-CH56 RD-4 109-CH56 RD-4 SIGNAL GN-18 C C991-AX116 PK-18 C C991-K4 PK-18 OR ORANGE AT 213-2213 - 01 G-7 MACHINE/TRANSMISSION INTERFACE
326-CH60 RD-18 TWISTED WIRES AU 259-1054 V 01 F-7 ENGINE SHUTOFF
FUEL PRESSURE SENSOR CONN 14 YL YELLOW
200-CH55 BK-18 194-6725 CG-C5 BRAKE OIL PRESS SW AX 200-2655 - 00 D-18 FUEL PRIMING
200-CH65 BK-18 ENGINE DISCONNECT 1552267 175-3244 CA 213-2209 - 01 K-14 REAR AXLE TEMP MONITORING
ENGINE DISCONNECT

K-C10 432-CG5 PK-18 A BK-16

PK PINK CF 256-7920 V 01 G-15 REAR CHASSIS
1552269 201-CG15 BK-18 B RD-16 SHOWN WITH BK BLACK CG 213-2225 - 04 B-6 BRAKE
SIGNAL 1 995-K9 BU-18 C BU-16 BRAKE OFF CH 231-4425 V 02 F-7 MACHINE/ENGINE INTERFACE
GY GRAY
CAB

GROUND 2 G833-K34 PK-18 CJ 213-2222 - 06 I-7 MAIN CHASSIS

304-CH34 WH-8 COOLANT TEMP SENSOR ADEM CK 183-9235 - 01 K-7 SUPPLEMENTAL STEERING PRESSURE (ATCH)
G S
130-9811 K-C9 HYD FILTER BYPASS SW PU PURPLE CX 122-1486 - 06 D-14 FUEL INJECTORS
3E3370 TWISTED WIRES 7X-8549
MTR BAT BR BROWN CY 205-3599 - 00 K-13 AXLE COOLER TEMP SW (ATCH)
+5V OR-18 A G828-K26 WH-18 EW 205-4316 - 00 K-13 AXLE COOLER CLUTCH (ATCH)
GROUND YL-18 B G829-K32 GN-18 E455-CG7 BR-18 GN GREEN HA 213-2210 - 01 J-2 FRONT AXLE TEMP MONITORING
F713-CH47 OR-18
J844-CH50 GY-18
J843-CH52 PU-18
J843-CH33 PU-18

H795-CH27 PK-18

STARTER 994-K8 GY-18

ENGINE

SIGNAL GN-18 C
MOTOR BU BLUE K 176-0274 - 04 A-11 ENGINE
6V-0890 OIL PRESSURE SENSOR MC 218-3235 - 00 D-7 PRODUCT LINK INTERFACE (ATCH)
110-CH51 RD-10

194-6725 TX 189-0852 - 02 B-14 CAMSHAFT TIMING

TX-C1 TX-C2 K-C8
1552269 3E3364 1552269
CBL-MM1 BK-00 SIG- E965-TX1 BK-18 1 1 E965-K25 BU-18 FRONT WASHER CABLE ASSEMBLIES
SIG+ E966-TX2 WH-18 2 2 E966-K24 YL-18 7T-8890 CG-C1 AA1 7P-6681 - 04 A-18 BATTERY +24VOLT TO POWER POST
SYMBOL DESCRIPTION
WH-18
WH-18
WH-18
WH-18
GN-18
GN-18
GN-18
GN-18
PK-18
PK-18
PK-18

A307-CH22 GY-18

G479-CH15 WH-18
H702-CH29 PU-18
H703-CH30 YL-18
G850-CH14 BU-18

R974-CH28 OR-18
A982-CH26 BR-18
150-CH19 OR-18

430-CH13 BU-18
450-CH11 YL-18

944-CH20 OR-18

7T5957 CG-C6 CJ-C10 CC1 122-0488 - 00 A-18 BATTERY +24VOLT TO POWER POST
945-CH21 BR-18

CAMSHAFT SPEED TIMING SNSR

H704-CH48 PK-18

F762-CH46 GY-18

X918-CH44 PU-18
X919-CH45 WH-18

H795-CH68 PK-18

CONN 13
229-CH35 BK-10

H795-CH8 PK-18

K-C7 1 506-CG8 PU-18 3E5179 1552252 EE1 118-1277 - 00 A-18 BATTERY + TO BATTERY -
188-7513
443-CH57 YL-18
X337-CH64 BU-18

2
1
G791-CH63 PU-18

3E3370 FF1 118-1277 - 00 A-18 BATTERY + TO BATTERY -

G828-K26
G828-K27
G828-K28
G828-K29
G829-K30
G829-K31
G829-K32
G829-K33
G833-K34
G833-K35
G833-K36

MOTOR 2 200-CG13 BK-18 200-CG1 BK-18 200-CG1 BK-18 1 200-CJ86 BK-18

BLADE, SPADE, RING,
2

2
1

+5V OR-18 A G828-K27 WH-18 201-CG2 BK-18 2 201-CJ64 BK-18 GG 115-5696 - 00 A-17 BATTERY - TO DISCONNECT SWITCH
CBL-JJ1 BK-00

H795-CH68 PK-18
1

443-CH57 YL-18
H795-CH8 PK-18

H795-CH9 PK-18

GROUND YL-18 B G829-K33 GN-18 962-CG3 OR-18 3 962-CJ5 OR-18 OR SCREW TERMINAL HH1 122-0489 - 00 A-17 DISCONNECT SWITCH TO FRAME GROUND
E963-K21 GY-18
E964-K20 WH-18
E965-K25 BU-18
E966-K24 YL-18
G856-K6 WH-18
G857-K7 YL-18

R971-CH32 YL-18
F421-K10 YL-18
A701-K12 GY-18
A702-K13 PU-18
A703-K14 BR-18
A704-K15 GN-18
A705-K22 BU-18
A706-K23 GY-18
A746-K16 PK-18

C967-K11 BU-18
L983-K17 WH-18
L984-K18 OR-18
L985-K19 YL-18
A747-K3 GY-18

C991-K4 PK-18

J843-CH49 PU-18

A746-K16 PK-18 419-CG4 YL-18 419-CJ6 YL-18 JJ1 7Y-3948 - 01 B-18 STARTER - TO FRAME GROUND
994-K8 GY-18
995-K9 BU-18

SIGNAL GN-18 C 4
H746-CH43 YL-18
H747-CH41 BR-18
CBL-LL1 RD-00

ENGINE GROUND 2 TURBO OUTLET PRESS SENSOR 432-CG5 PK-18 5 432-CJ8 PK-18 CAB SPLICE KK 2G-1830 - 03 A-17 AUX START (ATCH)
G790-CH62 PK-18

B B
110-CH42 RD-14
110-CH40 RD-14
110-CH39 RD-14

1 2
200-CH59 BK-4

194-6724 442-CG6 GY-18 6 442-CJ9 GY-18 LL1 188-3023 - 01 B-18 POWER POST TO STARTER "BAT" TERMINAL
1

E455-CG7 BR-18 7 E455-CJ13 BR-18 MM1 8Y-9603 - 01 B-18 STARTER - TO ENGINE GROUND
2

K-C6 CG-C2 506-CG8 PU-18 8 506-CJ11 PU-18 CIRCUIT NOT CONNECTED PP1 273-4877 V 00 F-18 ALTERNATOR BREAKER TO ALTERNATOR
1552269 7T5957 507-CG9 WH-18 9 507-CJ12 WH-18 RR1 179-8318 - 01 C-18 ALTERNATOR BAT - TO ENGINE GROUND
G828-K1 WH-18

G833-K5 PK-18
G829-K2 GN-18

SIGNAL 1 E963-K21 GY-18 1 507-CG9 WH-18 496-CG10 WH-18 10 496-CJ10 WH-18 ELECTRICAL CONNECTION
GROUND 2 E964-K20 WH-18 2 200-CG14 BK-18 G764-CG11 PK-18 11 G764-CJ14 PK-18 BUSS BAR
CRANKSHAFT SPEED TIMING SNSR K933-CG12 GN-18 12 K933-CJ77 GN-18 TO MACHINE STRUCTURE
7V-9275 - 02 J-18 ALTERNATOR BREAKER TO MAIN BREAKER
189-9266
K-C5 CONN 18 INTERNAL ELECTRICAL 186-3223 - 01 I-18 MAIN RELAY TO START RELAY
1552269 419-CG4 YL-18
SIGNAL 1 C967-K11 BU-18 432-CG5 PK-18 CONNECTION TO SURFACE ANTENNA
180-3837 - 03 E-6 ANTENNA-PRODUCT LINK (ATCH)
GROUND 2 G833-K35 PK-18 G764-CG11 PK-18 OF COMPONENT
J844-CH50 GY-18
J843-CH49 PU-18
A982-CH26 BR-18

H704-CH48 PK-18
X337-CH64 BU-18
G790-CH62 PK-18
G791-CH63 PU-18

F713-CH47 OR-18

F762-CH46 GY-18
R974-CH28 OR-18
X919-CH45 WH-18

R971-CH32 YL-18

G850-CH14 BU-18
G479-CH15 WH-18

X918-CH44 PU-18

H746-CH43 YL-18

H702-CH29 PU-18
H703-CH30 YL-18

H747-CH41 BR-18
H795-CH9 PK-18

944-CH20 OR-18
945-CH21 BR-18

430-CH13 BU-18

450-CH11 YL-18

110-CH42 RD-14

110-CH40 RD-14
110-CH39 RD-14

INTAKE MAN AIR TEMP SNSR 962-CG3 OR-18

A307-CH22 GY-18

150-CH19 OR-18

201-CG15 BK-18 CONNECTOR

229-CH38 BK-14

130-9811
229-CH37 BK-14
229-CH36 BK-14
F421-K10 YL-18

BU-18
GY-18
PU-18
BR-18
GN-18
PK-18

L983-K17 WH-18
L984-K18 OR-18
L985-K19 YL-18

E964-K20 WH-18
E963-K21 GY-18

A705-K22 BU-18
A706-K23 GY-18

E966-K24 YL-18
E965-K25 BU-18
G828-K1 WH-18
G829-K2 GN-18

A747-K3 GY-18

C991-K4 PK-18

G833-K5 PK-18

G856-K6 WH-18
G857-K7 YL-18
994-K8 GY-18

995-K9 BU-18

201-CG16 BK-18 201-CG2 BK-18

1 2

K-C4
CBL-JJ1 BK-00
3E3370
TWISTED WIRES 201-CG17 BK-18 ATCH WIRE, CABLE &
C967-K11
A701-K12
A702-K13
A703-K14
A704-K15
A746-K16

BLOCK AS 442-CG6 GY-18

8C-6358 +5V OR-18 A G828-K29 WH-18 496-CG10 WH-18 COMPONENT THIS DIAGRAM IS FOR THE:
BK-14
BK-14
BK-14

BK-10

G829-K30 GN-18 K933-CG12 GN-18

BK-4

GROUND YL-18 B
SIGNAL GN-18 C A747-K3 GY-18 K-C1 980GII UMA
CBL-KK2 RD-00 CH-C2
229-CH36
229-CH37
229-CH38

229-CH35
200-CH59

ATMOSPHERIC PRESS SENSOR 1607690

194-6724 J2 1607689 AN-C1 HYDRAULIC OIL TEMP SENSOR
1552267 134-2252 WHEEL LOADER CHASSIS AND
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

J1
1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9

K-C3
AIR FILTER RESTRICTED INDICATOR
CBL-AA1 RD-00

PRESS SENSOR SUPPLY +5V

AIH RELAY +24 VOLTS 2AMP

COOLANT TEMP SIG

PRESS SENSOR RETURN -

AIH RELAY -

ATMOSPHERIC PRESSURE SENSOR SIGNAL

FUEL PRESSURE

ANALOG TEMPERATURE SENSOR COMMON

FUEL TEMP SIG

INTAKE AIR TEMP

D OUT 9: ETHER RELAY COIL +24 VOLTS

+12V FAN SPEED SENSOR

ETHER SWITCH INPUT FROM CAB

PASSIVE SDP +3 TDC SERV PROBE
PASSIVE SDP -3 TDC SERV PROBE

INJECTOR 1 HI-SIDE
INJECTOR 2 HI-SIDE
INJECTOR 3 HI-SIDE
INJECTOR 4 HI-SIDE
ANALOG IN 13: TURBO OUTLET PRESSURE

INJECTOR 5 HI-SIDE
INJECTOR 6 HI-SIDE

ANALOG SENSOR POWER

ANALOG SENSOR RETURN
THROTTLE SENSOR POWER +8 VOLTS
THROTTLE SENSOR RETURN

CAT DATA LINK +

CAT DATA LINK -
REVERSING FAN
ANALOG IN 5: OIL PRESSURE SENSOR SIG

TURBO INLET PRESSURE SENSOR SIG

SW 2: GROUND LEVEL SHUTDOWN SW (N/C)

TRANS LUBE OIL TEMP SENSOR

AIR INLET HEATER INDICATOR

SERVICE INTERVAL INDICATOR

SW 3: GROUND LEVEL SHUTDOWN SW (N/0)

PWM OUT +3: VARIABLE SPD FAN CONTROL

+ BATTERY

PWM OUT -3: VARIABLE SPD FAN CONTROL

+ BATTERY
+ BATTERY

- BATTERY

- BATTERY

- BATTERY
PWM IN 1:THROTTLE PEDAL POSITION SIG
SW 10: REVERSING FAN RESET SW (N/C)
SW 9: REVERSING FAN RESET SW (N/O)

K933-AN5 GN-18
TACHO+ ENGINE SPD SIG TO PWRTRAIN

OR-18
ENGINE
PASSIVE SPD +1: CRANKSHAFT RPM
PASSIVE SPD -1: CRANKSHAFT RPM

A +8 VOLTS
PASSIVE SPD +2: CAMSHAFT RPM
PASSIVE SPD -2: CAMSHAFT RPM

SW 20: KEY ON +24 VOLTS

INJECTOR 1& 2 COMMON
INJECTOR 3& 4 COMMON
INJECTOR 5& 6 COMMON

1552269 CG-C3 AN-C3 201-AN1 BK-18 B BK-18 GROUND

SIGNAL 1 F421-K10 YL-18 1552273 3E3382 442-AN3 GY-18 C WH-18 SIGNAL
CBL-GG1 BK-00 CBL-HH1 BK-00 GROUND 2 G833-K36 PK-18 201-CG17 BK-18 1 201-AN1 BK-18
FUEL TEMP SENSOR 201-CG16 BK-18 2 201-AN2 BK-18 HYD OIL LEVEL SW
DISCONNECT SW 442-CG6 GY-18 3 442-AN3 GY-18 AN-C2
130-9811 172-8660
CBL-EE1 RD-00 7N-0718 K-C12 K-C2 496-CG10 WH-18 4 496-AN4 WH-18 1552269 WITH ELECTRONIC ENGINE CONTROL
229-CH58 BK-14

3E3364 1552269
CBL-CC1 RD-00

RIGHT FRAME GROUND K933-CG12 GN-18 5 K933-AN5 GN-18 201-AN2 BK-18 1 BK-18 ELECTRO-HYDRAULIC IMPLEMENT CONTROL
PSV ANALOG IN 10:

PSV ANALOG IN 12:

TIMING CAL 1 G856-K6 WH-18 ENGINE GROUND 3 6 496-AN4 WH-18 2 BK-18

PSV ANALOG IN 9:

AND COMMAND CONTROL STEERING

CBL-KK1 BK-00

POS NEG POS NEG

CBL-KK2 RD-00

PROBE G857-K7 YL-18

DIGITAL OUT 4:

2
CONN 17
CBL-GG2 BK-00

CONN 12 DESIGN CONTROL V187

A A
D OUT 5:

12V BATTERY 1 12V BATTERY 2

115-2422 115-2422 GROUND
SW 1:

STRAP AS. COMPONENTS ARE SHOWN INSTALLED ON A FULLY

OPERABLE MACHINE WITH THE KEY AND ENGINE OFF
CBL-FF1 RD-00 AND XMSN SHIFTER IN NEUTRAL
POS NEG POS NEG KK-C1 DASHED FONT INDICATES AN ATTACHMENT COMPONENT OR HARNESS
2G1830
ADEM III ENGINE CONTROL NOTE A: WIRES 201-AU1, 425-AU2, E452-AU3, C468-AU4, A497-AU5
AUXILARY START 178-3091
12V BATTERY 3 12V BATTERY 4
RECEPTACLE AND T800-AU6 ARE ADDED TO CONNECTOR AT-C3
115-2422 115-2422
ENGINE
FOR THE CAB DIAGRAM SEE:
254-2138

18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 Wire Description
Wire Wire RENR9858
Wire Color Description Wire Color Description
Number Number August 2005
Power Circuits Control Circuits (Continued)
101 RD BATTERY+ 727 GN SEC STR RELAY COIL+
102 BU RUNNING LAMP PWR 728 BU SEC STR INTER RELAY COIL+
104 YL PRODUCT LINK PWR (SWITCHED) 751 GN CLUTCH 1 REVERSE
106 WH LIFT/TILT POSITION SENSOR PWR 752 YL CLUTCH 2 FORWARD
Component Identifiers (CID¹) 109 OR ALTERNATOR PWR 754 BU CLUTCH 3 FOURTH
Module Identifier (MID²) Component Location
110 GN ENGINE ECM PWR (SWITCHED) 755 OR CLUTCH 4 THIRD
Schematic Machine Schematic Machine
Caterpillar Monitoring System 112 PU MAIN RELAY OUTPUT PWR 761 GY LIFT POS SENSOR Component
Location Location
Component
Location Location
(MID No. 030) 114 GN FORWARD HORN PWR 762 YL BUCKET/TILT POS SW
Alarm - Action E-15 D-10, L-10 Resistor 1 K-16 E-10, M-10
CID Component 123 WH AXLE OIL COOLER CLUTCH POWER 779 WH QUICK COUPLER (ENGAGE SOL)
Alarm - Engine Shutdown A-10 E-10, L-10 Resistor 2 L-16 E-10, M-10
0096 Fuel Level Sender 129 BU START AID PWR A701 GY FUEL INJECTOR CYLINDER 1
Breaker - HVAC Blower Motor A-15 D-10, L-10 Sensor - Left Hand Brake Pedal H-1 D-8, L-8
0100 Engine Oil Pressure Sensor 130 GN STOP LAMP/(BACKUP ALARM) PWR A702 PU FUEL INJECTOR CYLINDER 2
Breaker - Seat A-15 D-10, L-10 Sensor - Throttlle Position G-1 D-8, L-8
0110 Engine Coolant Temperature Sensor 136 GN SECONDARY STEERING PWR A703 BR FUEL INJECTOR CYLINDER 3
Compressor - Seat E-9 E-9, L-9 Suppressor - Arc E-15 D-10, L-10
0177 Torque Converter Oil Temperature Sensor 138 GN PAYLOAD MONITOR SYSTEM PWR A704 GN FUEL INJECTOR CYLINDER 4
Control - Dimmer D-15 D-10, L-10 Switch - A/C Selector E-7 E-8, M-8
0248 Data Link 150 OR ENGINE ECM PWR (UNSWITCHED) A705 BU FUEL INJECOTR CYLINDER 5
Control - Transmission Control System J-17 E-10, K-10 Switch - Auto/Manual Gear Select D-6 E-8, M-8
0263 Sensor Power Supply 170 YL PRODUCT LINK PWR (UNSWITCHED) A706 GY FUEL INJECTOR CYLINDER 6
Control - Data G-16 E-10, K-10 Switch - Dimmer H-1 E-8, M-8
0271 Action Alarm 174 PK UNSWITCHED BUSS PWR A746 PK TURBO OUTLET PRESSURE
Flasher F-15 D-10, L-10 Switch - EMS Mode Select C-8 G-8, K-8
0324 Action Lamp 175 PK HOOD MOTOR PWR A747 GY ATMOSPHERIC PRESSURE
Fuse - Block A-15 D-10, L-10 Switch - Forward Horn H-3 E-8, M-8
0427 Front Axle Oil Temperature Sensor 177 OR MAIN CIRCUIT BREAKER PWR A751 YL AFTER COOLER TEMPERATURE
Ground - Cab 1 C-13 D-10, L-10 Switch - Forward Horn 2 F-9 E-9, L-9
0428 Rear Axle Oil Temperature Sensor 199 OR HOOD CONTROL PWR F713 OR TURBO INLET PRESS SENSOR
Ground - Cab 2 B-13 D-10, L-10 Switch - Front Intermittent Wiper/Washer D-7 G-8, K-8
0600 Hydraulic Oil Temperature Sensor Ground Circuits F762 GY START AID RELAY COIL+
Ground - Cab 4 L-18 D-10, N-10 Switch - Hazard Lamp I-3 E-8, M-8
0819 Display Data Link 200 BK MAIN CHASSIS GND F766 WH DETENT ENABLE INTERLOCK
Ground - Dash J-5 E-8, M-8 Switch - Heat A/C Selector D-8 G-8, K-8
0821 Display Power Supply 201 BK OPERATOR MONITOR GND G764 PK PARKING BRAKE SW (ON)
Ground - Engine End Frame L-18 D-10, N-10 Switch - HVAC Blower Speed D-8 G-8, K-8
0826 Torque Converter Oil Temperature Sensor 229 BK ENGINE ECM GND H702 PU REVERSING FAN RESET SWITCH (N.O.)
Ground - Upper Cab A-5 G-8, K-8 Switch - Key Start G-3 E-8, M-8
0830 Brake Oil Temperature Sensor 251 BK PAYLOAD MONITOR SYSTEM GND H703 YL REVERSING FAN RESET SWITCH (N.C.)
Guage - Quad I-1 E-8, M-8 Switch - Kickout On/Off D-7 G-8, K-8
1791 Saw Pressure Sensor 299 BK M I PL ECM GROUND H704 PK REVERSING FAN SOLENOID
Electronic Transmission Control System A274 BK PRODUCT LINK ECM GND
Basic Machine Circuits
H713
H714
PK
OR
LIFT PROPORTIONAL SOL
LOWER PROPORTIONAL SOL
Indicator - Center Dash
Indicator - Left Hand Panel
K-1
K-1
E-8, M-8
E-8, M-8
Switch - Neutralizer Override
Switch - Ride Control
C-4
C-4
G-8, K-8
G-8, K-8 980G Series ll
(MID No. 081) Indicator - Right Hand Panel J-1 E-8, M-8 Switch - Running Lamp D-6 E-8, M-8
CID
0149 Ride Control Solenoid 2
Component 304
306
WH
GN
STARTER SOL START TERMINAL
START RELAY COIL+
H716
H717
WH
BR
I M PLEMENT ECM SOLENOID RETURN
PILOT SOLENOID
Motor - Blower
Motor - Front Wiper
J-16
I-1
E-10, M-10
E-8, M-8
Switch - Stop Lamp
Switch - Transmission Shifter Assembly
G-1
H-2
D-8, L-8
E-8, M-8
Wheel Loader
307 OR KEY SW(START) H718 GY BUCKET TILT POSITION SENS (SIG)
0168
0190
0363
Electrical System Voltage
Engine Speed Sensor
Ride Control Solenoid 1
308
317
YL
YL
MAIN POWER RELAY COIL+
START AID SOLENOID+
H746
H747
YL
BR
VARIABLE SPD FAN SOLENOID+
VARIABLE SPD FAN SOLENOID-
Relay - Forward Cab Floodlamp
Relay - Forward Horn
C-15
C-15
D-10, L-10
D-10, L-10
Switch - Turn Signal
Tach/Speedometer
H-2
I-1
E-8, M-8
E-8, M-8 Electrical System
Relay - Rear Cab Floodlamp D-15 D-10, L-10 Thermostat J-16 E-10, M-10
0367 Ride Control Switch 321 BR BACKUP ALARM H795 PK ENGINE ECM (SENSOR/SW RETURN)
0368 Transmission Auto/Manual Switch 322 GY FORWARD HORN J700 BR ENGINE RETARDER SOL CYL 1 AXG1-UP
0444 Starter Solenoid 326 PU FUEL PRIMING PUMP J701 GN ENGINE RETARDER SOL 3
0562 Caterpillar Monitoring System 397 OR HOOD MOTOR LOWER J702 BK ENGINE RETARDER SOL COMMON
0596 Implement ECM 398 BU HOOD MOTOR RAISE A893 OR FUEL PRIMING PUMP MOTOR-
0621 Downshift Push Button Switch A300 GN HOOD CONTROL LOWER G828 WH SENSOR PRESSURE +5V
0622 Upshift Push Button Switch A301 WH HOOD CONTROL RAISE G829 GN SENSOR PRESSURE COMMON
0623 Directional Switch A307 GY THROTTLE PEDAL POS SENS G833 PK ENGINE TEMP SENSOR COMMON
0627 Parking Brake Pressure Switch Monitoring Circuits G850 BU AIR INLET HEATER RELAY COIL+
0650 Harness Code 403 GN ALTERNATOR (R) TERMINAL G856 WH TDC PROBE+
0671 Transmission Speed Sensor 416 OR SEC STR PRESS SW (N/O) G857 YL TDC PROBE-
0793 Primary Steering Pressure Sensor 417 GY PRIMARY STR PRESS SW (N/O) J843 BK ENGINE ECM ANALOG SENSOR RTN
1327 Left Brake Pedal Sensor 419 YL PARKING BRAKE SW (OFF) J844 GY ENGINE ECM ANALOG SENS 5VOLTS
1401 Transmission Solenoid Valve (No.1) 426 BR XMSN FILTER BYPASS SWITCH 900 PU CLUTCH 5 SECOND
Resistor, Sender and Solenoid Specifications
1402 Transmission Solenoid Valve (No.2) 430 BU AIR FILTER RESTRICTED IND 901 WH CLUTCH 6 FIRST
Part No. Component Description Resistance (Ohms)¹
1403 Transmission Solenoid Valve (No.3) 432 PK BRAKE OIL PRES SWITCH (ON) 944 OR CAT DATA LINK+
Auxilliary Electro-Magnet
1404 Transmission Solenoid Valve (No.4) 442 GY HYD TANK OIL TEMP SENSOR 945 BR CAT DATA LINK-
Tilt Positioner Electro-Magnet
443 YL TC OUTLET TEMP SENSOR 953 GY M I PLEMENT ECM SENSOR RTRN 109-1739 Solenoid:
Lift Positioner Electro-Magnet
85.3 ± 5.0
1405 Transmission Solenoid Valve (No.5)
1406 Transmission Solenoid Valve (No.6) 447 PK FUEL LEVEL SENSOR 962 OR TRANSMISSION ECM SENSOR RTRN Float Electro-Magnet
1521 Variable Shift Selector Switch 450 YL ENGINE ECM (ENGINE SPD) 975 WH XMSN ECM SOLENOID/INDICATOR RTN A-C: 2 ± .05
1639 Machine Security System 453 PK SEC STR PRESS SW (N/O) 976 OR RIDE CONTROL ON SOLENOID 125-9740 Resistor: HVAC Blower Motor B-C: 1 ± .05
484 YL PRIMARY STR PRESS SW (N/C) 994 GY OIL PRESSURE (FILTERED) C-D: .36 ± .05
¹ The CID is a diagnostic code that indicates which circuit is faulty.
496 WH HYD TANK OIL LEVEL SENS 995 BU COOLANT TEMPERATURE ¹ At room temperature unless otherwise noted.
² The MID is a diagnostic code that indicates which electronic control module
E416 PU LIFT CYL HEAD END PRESS SENSOR A982 BR ENGINE ECM THROTTLE/IND 8VOLTS
diagnosed the fault.
E455 BR HYDRAULIC FILTER BYPASS SW C967 BU N I LET AIR TEMPERATURE
F421 YL FUEL TEMPERATURE C991 PK FUEL PRESS SENSOR
G454 PK PUMP DRIVE OIL TEMPERATURE E900 WH XMSN OUTPUT SPD SENS LEADING+ Volume 2: Cab Wiring
G479 WH SERVICE ENGINE INDICATOR E901 GN XMSN OUTPUT SPD SENS LEADING-
G485 BU FRONT AXLE OIL TEMP SW E906 OR XMSN OUTPUT SPD SENS TRAILING+ © 2005 Caterpillar Printed in U.S.A.
G486 GN REAR AXLE OIL TEMP SW E907 GY XMSN OUTPUT SPD SENS TRAILING- All Rights Reserved
Accessory Circuits E908 BR XMSN INPUT SPD SENSOR+
506 PU FRONT WASHER PUMP+ E909 WH XMSN INPUT SPD SENSOR-
507 WH REAR WASHER PUMP+ E919 YL AUX LIFT PROPORTIONAL SOL
513 OR A/C CLUTCH SOLENOID+ E920 BR AUX LOWER PROPORTIONAL SOL
521 YL A/C SELECT SW (A/C POSTION) E921 PK RACKBACK PROPORTIONAL SOL
522 WH A/C CLUTCH SOLENOID- E922 GN DUMP PROPORTIONAL SOL
C529 GY LIFT CYL HE PRESS SENS E963 BK CRANK RPM SENSOR-
C530 BU LIFT POSITION SENSOR
Lighting Circuits
E964
E965
WH
BU
CRANK RPM SENSOR+
CAM RPM SENSOR-
Harness And Wire Electrical Schematic Symbols
Component Identifiers (CID¹) 603 PK ROTARY BEACON E966 YL CAM RPM SENSOR+
Module Identifier (MID²) 604 OR STOP LAMP K933 GN OPERATOR MONITOR SENSOR PWR Symbols
VIMS 605 YL LH TURN LAMPS K977 PK XMSN OIL TEMP SENSOR 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
(MID No. 031) 606 GY RH TURN LAMPS L983 WH FUEL INJECTOR RTN CYL 1-2
T
CID Component 608 GN REAR FLOOD LAMPS L984 OR FUEL INJECTOR RTN CYL 3-4 Off Machine Switch Specification
0041 8 Volt Sensor Power Supply 611 PU HEAD LAMP (HIGH) L985 YL FUEL INJECTOR RTN CYL 5-6 O O Pressure Temperature Level Flow Circuit Breaker
Part No. Function Actuate Deactuate Contact Position Symbol Symbol Symbol Symbol Symbol
0075 Steering Oil Temperature Sensor 612 GY BACKUP LAMP N939 GN RIDE CONTROL AUTO SOLENOID
-1.1 ± 0.8°C 2.2 ± 0.8°C
0096 Fuel Level Sensor 614 PU LICENSE PLATE/RH TAIL/DASH LAMPS P976 BR QUICK COUPLER RELEASE SOLENOID 3E-5464 Thermostat Normally Closed
(30.0 ± 1.4°F) (35.9 ± 1.4°F)
0100 Engine Oil Pressure Sensor 615 YL FORWARD CAB FLOOD LAMPS R971 YL XMSN LUBE OIL TEMP SENSOR ¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained N N Symbols And Definitions
0110 Engine Coolant Temperature Sensor 617 BR LH TAIL/CLEARANCE LAMPS R974 OR START AID SWITCH down to 170 kpa (25psi).
Fuse - A component in an electrical circuit that will open the circuit if too much current flows
0127 Transmission Oil Pressure Sensor 619 GN FWD FLOOD/LO BEAM LAMPS X918 PU GND LEVEL SHUTDOWN SW (N/O) ² Contact position at the contacts of the harness connector. through it.
0171 Ambient Air Temperature Sensor Control Circuits X919 WH GND LEVEL SHUTDOWN SW (N/C)
M M

RENR9858 VOL 2
0177 Transmission Oil Temperature Sensor 709 OR XMSN ECM SENS/IND (+8VOLTS) Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
0190 Engine Speed Sensor
0248 CAT Data Link Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
0262 5 Volt Sensor Power Supply L L No circle indicates that the wire cannot be disconnected from the component.
0263 Sensor Power (8 or 12 Volt)
0267 Switch (Remote Engine Shutdown) Ground (Wired): This indicates that the component is connected to a grounded wire. The
K K grounded wire is fastened to the machine.
0271 Action Alarm
0272 Turbocharger Outlet Overboost Pressure Sensor (High)
0279 Aftercooler Coolant Temperature Sensor Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
0280 Gear Box Temperature Sensor
Connector Location J J
0295 HEX Electronic Control Module
Schematic Machine
0296 Transmission Electronic Control Module Connector Number Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
Location Location
0324 Action Lamp (Warning) contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
CONN 1 C-18 E-10, L-10 I I

30 Page
0341 Solenoid (Hydraulic Control Valve Warm Up) (No. 4)
CONN 2 D-18 E-10, L-10
0350 Lift Linkage Position Sensor Failure Mode Identifiers (FMI)¹ CONN 3 E-18 E-10, L-10
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
0364 Pressure Sensor (Lift Cylinder Head) FMI No. Failure Description CONN 4 F-18 E-10, L-10 T
H H the gauge of the temperature or pressure.
0371 Horn Solenoid (Forward) 0 Data valid but above normal operational range.
CONN 5 G-18 E-10, L-10
0379 Machine Autolube Pressure Sensor 1 Data valid but below normal operational range.
CONN 6 A-18 G-10, L-10 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
0425 Pressure Sensor (Front Brake Oil) 2 Data erratic, intermittent, or incorrect. It has a coil that makes an electromagnet when current flows through it. The
CONN 7 L-18 G-10, M-10
0426 Pressure Sensor (Rear Brake Oil) 3 Voltage above normal or shorted high.
CONN 8 K-18 D-9, K-9
G G electromagnet can open or close the switch part of the relay.
0427 Front Axle Oil Temperature Sensor 4 Voltage below normal or shorted low.
CONN 9 L-16 D-9, K-9
0428 Rear Axle Oil Temperature Sensor 5 Current below normal or open circuit. Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
CONN 10 Service Mode Plug E-15 E-10, C-10 coil that makes an electromagnet when current flows through it. The electromagnet
0429 Pressure Sensor (Steering Pump Oil) 6 Current above normal or grounded circuit.
CONN 11 G-15 G-9, L-9 F F can open or close a valve or move a piece of metal that can do work.
0430 Pressure Sensor (Steering Pilot) 7 Mechanical system not responding properly.
CONN 12 L-15 D-9, K-9
0434 Hydraulic Pilot Oil Pressure Sensor 8 Abnormal frequency, pulse width, or period. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
CONN 13 L-14 E-9, K-9
0436 Torque Converter Oil Pressure Sensor 9 Abnormal update. activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
0438 Solenoid (Hydraulic Control Valve Warm Up) (No. 1) 10 Abnormal rate of change.
CONN 14 L-13 E-9, K-9 E E that make electromagnet when current flows through them. It also has an internal switch that places
CONN 15 Service Tool Connector L-13 E-10, L-10
0439 Solenoid (Hydraulic Control Valve Warm Up) (No. 2) 11 Failure mode not identifiable. the latch coil circuit open at the time the coil latches.
CONN 16 Service Tool Connector E-10 G-10, K-10
0440 Solenoid (Hydraulic Control Valve Warm Up) (No. 3) 12 Bad device or component.
CONN 17 G-10 D-9, L-9
0533 Auto Retarder Control (ARC) 13 Out of calibration. D D Harness And Wire Symbols
CONN 18 G-10 D-9, L-9
0541 Pressure Sensor (Differential Oil)(Axle) 14 Parameter failures.
CONN 19 C-5 G-9, K-9
0558 Autolube Relay 15 Parameter failures. 1 Deutsch connector: Typical representation 1 Sure-Seal connector: Typical representation
CONN 20 A-3 G-8, L-8 of a Deutsch connector. The plug contains all of a Sure-Seal connector. The plug and receptacle
0562 Caterpillar Monitoring System 16 Parameter not available. C C 2 sockets and the receptacle contains all pins. 2 contain both pins and sockets.
CONN 21 G-4 E-8, L-8
0590 Engine Electronic Control Module 17 Module not responding.
CONN 22 Service Tool Connector G-3 E-8, L-8 Harness Identification Letter(s):
0596 Implement Electronic Control Module 18 Sensor supply fault. Wire, Cable, or Harness Assembly Identification: (A, B, C, ..., AA, AB, AC, ...)
CONN 23 H-3 E-8, L-8 Includes Harness Identification Letters and Harness
0600 Hydraulic Oil Temperature Sensor 19 Condition not met.
CONN 24 H-3 E-8, L-8 B B Connector Serialization Codes Harness Connector Serialization Code: The "C" stands
for "Connector" and the number indicates which
0650 Harness Code 20 Parameter failures. connector in the harness. (C1, C2, C3, .....)
CONN 25 L-3 G-8, M-8 Part Number for
0654 Trailer Right Brake Oil Temperature Sensor ¹The FMI is a diagnostic code that indicates what type of failure has occurred. C-C4 AG-C3 AG-C4 L-C12 Part Number For
CONN 26 G-2 D-8, M-8 Connector Plug
0655 Trailer Left Brake Oil Temperature Sensor 130-6795 130-6795 111-7898 3E-5179 Connector Recepticle

0656 Temperature Sensor (Trailer Brake Oil Cooler Inlet)

CONN 27 H-2 D-8, M-8 A A
The connectors shown in this chart are for harness to harness connectors. 325-AG135 PK-14 1 5A
0657 Temperature Sensor (Trailer Brake Oil Cooler) Connectors that join a harness to a component are generally located at or near Pin Socket Fuse
Receptacle
0658 Pressure Sensor (Trailer) (Right Suspension Cylinder) the component. See the Component Location Chart. (5 Amps)
0659 Pressure Sensor (Trailer) (Left Suspension Cylinder)
15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 Single Wire
Connector
Pin or Socket
Number
9X-1123
Component
0672 Torque Converter Output Speed Sensor Part Number
Plug
0767 Fixed Displacement Pump Oil Pressure Sensor Harness identification code: 2 200-L32 BK-14
This example indicates wire
0800 VIMS Main Module 135 in harness "AG".
Ground Circuit Identification Wire Gauge
0801 VIMS Interface Module (No. 1) Number Wire Color
Connection
0802 VIMS Interface Module (No. 2)
0803 VIMS Interface Module (No. 3)
0804 VIMS Interface Module (No. 4)
0805 VIMS Interface Module (No. 5)
0806 VIMS Interface Module (No. 6)
0807 VIMS Interface Module (No. 7)
0808 VIMS Interface Module (No. 8)
0809 Speedometer/Tachometer Display (No.1)
0810 Speedometer/Tachometer Display (No.2)
0811 Gauge (Quad Cluster) (No. 1)
0812 Gauge (Quad Cluster) (No. 2)
0813 Gauge (Quad Cluster) (No. 3)
0814 Gauge (Quad Cluster) (No. 4)
0815 Message Center (No. 1)
0816 Message Center (No. 2) Monitoring System Operator Modes
0817 ECM Internal Backup Battery Operator Mode Number Related Electrical Service Manuals
0819 Display Data Link Operator Mode 0 Title Form Number Monitoring System Service Modes
0820 Keypad Data Link Harness Code 1 Alternator: 185-5294 SENR4130 Service Mode Number
0821 Display Power Supply (9 Volt)
Numeric Readout 2 Electric Starting Motor: 6V-0890 SENR3860 Service Meter 0
0822 Power Supply (Display Lighting)
Service 3 CAT Monitoring System: SENR1394 Odometer 1
0823 Lamp (VIMS Service)
Digital Tattletale 4 Transmission Control System: RENR6008 Tachometer 2
0824 Green Truck Payload Lamp (No. 1)
0825 Red Truck Payload Lamp (No. 2) Units 5 Product Link ECM: RENR5885 Scrolling 3
0826 Torque Converter Oil Temperature Sensor Charging System Display 6 VIMS: SENR6059
 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
M-C1 M-C2 C-C97
1552269 1552272 1134630
1 608-M1 GN-14 1 608-C423 GN-14
2 200-M2 BK-14 2 200-C426 BK-14
3 K-C1
FLOOD LAMP REAR LH 4 1552269
219-6485 615-K6 YL-14 1 FLOOD LAMP FRONT LH 1
CONN 7 HVAC C-C8 200-K2 BK-14 2 219-6485
608-C423 GN-14 9W1951
200-C426 BK-14 AF-C1 E-C1 E-C2 AE-C6 A 147-C34 RD-18 C-C95 K-C4 K-C2
LH DOME LAMP 9G3670 9G3676 9G3670 9G3676 1134630 1552272 1552269
SERVICE B 200-C43 BK-18
C-C6 3E-6389 124-AF1 GN-14 1 124-E1 GN-14 1 124-AE1 GN-14 TOOL CONNECTOR C 615-C420 YL-14 1 615-K5 YL-14 1
2

615-K7 YL-14 1 FLOOD LAMP FRONT LH 2

1552267 200-AF9 BK-14 2 200-E2 BK-14 2 200-AE20 BK-14 D 944-C44 OR-18 200-C430 BK-14 1
2

200-C431 BK-14 2 200-K1 BK-14 1

2

200-K3 BK-14 2 219-6485

122-C240 RD-18 A RD-16 200-AF4 BK-14 3 A523-E3 PU-14 3 A523-AE9 PU-18 CAP AS. PART NUMBER E 945-C45 BR-18 X615-C436 YL-14 3 X615-K8 YL-14
A524-AF7 BR-14 4 A524-E4 BR-14 4 A524-AE5 BR-14 200-C432 BK-14 200-K4 BK-14 K-C3
L L
C WH-16 180-9900 F 4
200-C106 BK-18 B BK-16 135-AF10 BU-14 5 135-E8 BU-14 1
2

135-E9 BU-14 5 A525-AE8 GN-14 G 1552269

6 6 H CONN 25 1 FLOOD LAMP SIDE LH
STRAP AS. 7 7 J 2 219-6487
8X-5802 A273-C119 BK-18 INSERT AS
STRAP A273-C35 BK-18
CONN 9 PIN 10 CONN 12 CONN 15 TWISTED WIRES
ASSEMBLY A273-C15 BK-18 135-E10 BU-14
ENG END FRAME GND CAB GROUND 4 1
2

135-AF11 BU-14
ECM MOUNT BOLT 135-AF12 BU-14
C-C31 124-AF1 GN-14 1
2

124-AF2 GN-14 AE-C1 R-C2 R-C1 C-C21

1010205 124-AF3 GN-14 3E8969 1552252 1552252 3E8969
J1 124-AE1 GN-14 1 124-R1 GN-14 1 124-C440 GN-14
BATTERY 1 164-C281 WH-18 200-AF4 BK-14 1
2

200-AF6 BK-14 515-AE2 GY-14 2 515-R2 GY-14 2 515-C181 GY-14

GROUND 2 A273-C15 BK-18 306-C134 GN-18 200-AF5 BK-14 516-AE3 GN-14 3 516-R3 GN-14 3 516-C182 GN-14
RESISTOR AS. AF-C2
CAT DATA LINK (CDL-) 3 945-C108 BR-18 321-C148 BR-18 522-AE4 WH-14 4 522-R4 WH-18 4 522-C125 WH-18
239-9368 1552269
4 417-C146 GY-18 A524-AE5 BR-14 5 A524-R5 BR-18 5 A524-C188 BR-18
GROUND 5 A273-C35 BK-18 419-C283 YL-18 1 A524-AF7 BR-14 1
2

200-AE6 BK-14 6 200-R6 BK-14 6 200-C176 BK-14

BATTERY 6 164-C280 WH-18 450-C149 YL-18 2 A524-AF8 BR-14 200-AE19 BK-14 517-AE7 BU-14 7 517-R7 BU-14 7 517-C183 BU-14
SOLENOID AND INDICATOR RETURN 7 975-C46 WH-18 484-C142 YL-18 200-AE18 BK-14 A525-AE8 GN-14 8 A525-R8 GN-18 8 A525-C258 GN-18
GA-C1 AF-C4 DASH
START RELAY COIL+ 8 306-C134 GN-18 751-C61 GN-18 A523-AE9 PU-18 9 A523-R9 PU-18 9 A523-C186 PU-18
CAT DATA LINK (CDL+) 9 944-C282 OR-18 752-C52 YL-18 9G3670 9G3676 135-E10 BU-14 10 135-R10 BU-18 10 135-C171 BU-18 C-C46 LH INDICATOR PANEL

1
NEUTRALIZER DISABLE INDICATOR+ 10 910-C279 YL-18 754-C109 BU-18 VALVE AS. WATER GA-C2 1 C547-AE10 OR-14 11 C547-R11 OR-14 11 C547-C441 OR-14 1552252 202-9804
CLUTCH 2 SOLENOID (FORWARD) 11 752-C52 YL-18 755-C63 OR-18 241-5670 2470281 2 12 12 133-C343 OR-18 1 +24 VOLTS
RIDE CONTROL SOLENOID 2 12 N939-C135 GN-18 G764-C140 PK-18 +Vs A A523-GA1 PU-16 3 135-AF12 BU-14 200-C337 BK-18 2 GROUND
NEUTRAL SWITCH 13 G763-C150 PU-18 F766-C249 WH-18 B 4 A524-AF8 BR-14 CONN 13 CONN 14 3 DIMMER CONTROL
REVERSE SWITCH 14 G755-C151 GY-18 900-C110 PU-18 GROUND C A525-GA3 GN-16 5 200-AF6 BK-14 NOTE A 605-C89 YL-18 4 LH TURN SIGNAL
SENSOR/SWITCH RETURN 15 962-C58 OR-18 901-C66 WH-18 RS D A524-GA2 BR-16 6 5 NOT USED
SENSOR/SWITCH RETURN 16 962-C59 OR-18 E900-C114 WH-18 E 7 E702-C255 OR-18 6 RIDE CONTROL ON
CLUTCH 1 SOLENOID (REVERSE) 17 751-C61 GN-18 E901-C112 GN-18 615-C218 YL-18 7 FLOOD LAMPS
RIDE CONTROL SOLENOID 1 18 976-C139 OR-18 975-C70 WH-18 CONTROL GP AF-C3 CONN 8 910-C279 YL-18 8 NEUTRALIZER OVERRIDE
UPSHIFT SW 19 G768-C152 GN-18 975-C46 WH-18 205-4285 1552273 E701-C256 PK-18 9 RIDE CONTROL AUTO
VARIABLE SHIFT CONTROL (ECONOMY) 20 X974-C165 BR-18 976-C139 OR-18 +24V INPUT 1 124-AF2 GN-14 436-C47 OR-18 10 XMSN FILTER BYPASS
RIDE CONTROL SWITCH (AUTO) 21 G766-C154 GN-18 N939-C135 GN-18 KEY 2 124-AF3 GN-14 G480-C169 GN-18 11 FUEL LEVEL LOW
RIDE CONTROL SWITCH (ON) 22 G767-C155 WH-18 962-C59 OR-18 GROUND 3 200-AF9 BK-14 413-C33 BR-18 12 FUEL PRESSURE
UPSHIFT SW 23 G760-C156 WH-18 962-C58 OR-18 +12V UNSWITCHED 4

K VARIABLE SHIFT CONTROL (MID)

DOWNSHIFT SW
24
25
X973-C157 BU-18
G761-C158 YL-18
+12V SWITCHED
GROUND
5
6
135-AF11 BU-14
200-AF5 BK-14
CAB WALL

C-C63
K
DOWNSHIFT SW 26 G762-C159 BR-18 CENTER DASH IND
PARK BRAKE SWITCH (ON) 27 G764-C140 PK-18 1552273 202-9805
28 516-AE3 GN-14 132-C344 RD-18 1 BK +24 VOLTS
AUTO/MANUAL SWITCH (MAN) 29 973-C160 BR-18 C547-AE10 OR-14 200-C339 BK-18 2 BK GROUND
FORWARD SWITCH 30 G750-C161 BU-18 164-C280 WH-18 3 BK DIMMER CONTROL
AUTO/MAN SW (AUTO 4) 31 977-C162 YL-18 164-C281 WH-18 B
1 1
C 411-C243 PK-18 4 BK ACTION LAMP
AUTO/MAN SW (AUTO 2) 32 H729-C62 WH-18 307-C122 OR-18 A D 538-C363 BR-18 5 BK HAZARDS
AUTO/MAN SW (AUTO 3) 33 H728-C198 GN-18 A273-C119 BK-18 517-AE7 BU-14 611-C367 PU-18 6 BK HIGH BEAMS

1
NEUTRALIZER OVERRIDE SWITCH (M0M) 34 720-C164 PU-18 413-C33 BR-18
AUTO/MAN SWITCH (AUTO 1-4) 35 H730-C163 BR-18 436-C47 OR-18 TWISTED WIRES RESISTOR
PARK BRAKE SWITCH (OFF) 125-9740
36 419-C283 YL-18 G480-C169 GN-18
IMPLEMENT DETENT ENABLE 37 700-C24 PK-18 700-C24 PK-18
38 720-C164 PU-18 515-AE16 GY-14 1
2

C-C44 RH INDICATOR PANEL

VARIABLE SHIFT CONTROL (POWER) 39 X972-C153 GN-18 H728-C198 GN-18 1552253 202-9803
KEY SWITCH (START) 40 307-C122 OR-18 H729-C62 WH-18 200-AE18 BK-14 133-C285 OR-18 1 +24 VOLTS
H730-C163 BR-18
G746-C13 WH-18 1 1
522-AE4 WH-14 WIRE GROUP COLOR DESCRIPTIONS 200-C338 BK-18 2
3
GROUND
DIMMER CONTROL
CLUTCH 4 (3RD GEAR) 755-C63 OR-18 G750-C161 BU-18 430-C191 BU-18 AIR FILTER RESTRICTED
CLUTCH 6 (1ST GEAR)
1
2 901-C66 WH-18 G755-C151 GY-18 THERMOSTAT WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF. G850-C29 BU-18
4
5 AIR INLET HEATER ON
SOLENOID/INDICATOR RETURN 3 975-C70 WH-18 G760-C156 WH-18 3E-5464 G479-C192 WH-18 6 SERVICE INTERVAL
LH BRAKE PEDAL POSITION SENSOR 4 G746-C13 WH-18 G761-C158 YL-18
T°
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON. 7 NOT USED
BLOWER MOTOR
DOWNSHIFT SW 5 F781-C38 BR-18 G762-C159 BR-18 8 NOT USED
PRIMARY STEERING PRESS SWITCH (N/C) 6 484-C142 YL-18 G763-C150 PU-18
174-1494 AE-C11 VOLTAGE CONVERTER OUTPUT CIRCUIT. 118-C237 GY-18 9 NOT USED
CLUTCH 3 (4TH GEAR) 7 754-C109 BU-18 G766-C154 GN-18 1698668 130-C5 RD-18 606-C90 GY-18 10 RH TURN SIGNAL
CLUTCH 5 (2ND GEAR) 8 900-C110 PU-18 G767-C155 WH-18 MOTOR
WH/RD-14 1 515-AE17 GY-14 STARTING CIRCUIT. 132-C344 RD-18 11 NOT USED
9 G768-C152 GN-18 BK-14 2 200-AE19 BK-14 133-C285 OR-18 12 BUCKET TURN INDICATOR
PRIMARY STEERING PRESS SWITCH (N/O) 10 417-C146 GY-18 F781-C38 BR-18 GROUND CIRCUIT. 133-C343 OR-18
11 910-C15 YL-18 164-C231 WH-18

AUX/FLOAT IMPLEMENT DETENTS

12
G948-C265 BR-18
944-C282 OR-18
945-C108 BR-18
HVAC STARTING AID CIRCUIT. 200-C331 BK-18
200-C332 BK-18
13 157-2878
XMSN OUTPUT SPEED - 14
15
E901-C112 GN-18 G948-C265 BR-18
X972-C153 GN-18
CAT DATA LINK 200-C333 BK-18
200-C335 BK-18

J J
973-C160 BR-18 200-C189 BK-18 200-C336 BK-18
16
17 X973-C157 BU-18 MONITOR CIRCUIT. (VIMS) / (CMS) / (EMS) / (OTHER) 200-C228 BK-14 200-C327 BK-18 200-C337 BK-18
18 X974-C165 BR-18 200-C338 BK-18 TACH SPEEDOMETER
LIFT/TILT IMPLEMENT DETENTS 19 F766-C249 WH-18 977-C162 YL-18 ENGINE CONTROL CIRCUIT (MASTER ). 200-C331 BK-18 200-C339 BK-18
C-C14
1552273 190-3730
XMSN OUTPUT SPEED + 20 E900-C114 WH-18 201-C347 BK-18
21 TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT. 200-C332 BK-18 201-C348 BK-18
E707-C355 GN-18
201-C348 BK-18
1
2
OR-18
BK-18
+V DISPLAY
GROUND
FUEL PRESSURE INDICATOR 22 413-C33 BR-18 200-C336 BK-18 A307-C129 GY-18
23 HEATER AND AIR CONDITIONER CIRCUIT. 1
200-C333 BK-18 411-C243 PK-18
E708-C359 PK-18
C413-C351 YL-18
3
4
GN-18
WH-18
CLOCK
DATA
24 200-C335 BK-18 413-C33 BR-18
C414-C353 BU-18
25 TURN SIGNAL/WIPER/WASHER CIRCUIT. DASH GROUND
200-C337 BK-18 C413-C350 YL-18
5
6
YL-18
BU-18
LOAD
HARNESS CODE
26
1
200-C338 BK-18 C413-C351 YL-18
27 200-C339 BK-18 C414-C352 BU-18 PANEL LAMP 4 PANEL LAMP 3
XMSN FILTER INDICATOR 28 436-C47 OR-18 C414-C353 BU-18 7N-5876 7N-5876
1 2 1 2

29 430-C191 BU-18
C-C68 C-C69
30 436-C47 OR-18 3T3158 3T3158
31 G479-C192 WH-18
661-C233 GN-18
32 G480-C169 GN-18
200-C333 BK-18
33 500-C252 BR-18
662-C201 YL-18
34 501-C257 GN-18
200-C336 BK-18
35 611-C32 PU-14 1 2

611-C366 PU-14 502-C253 OR-18

36 611-C367 PU-18 604-C78 OR-18 C-C15 QUAD GAGE
BACKUP ALARM (+24 VOLTS) 37 321-C148 BR-18 135-C171 BU-18 610-C369 OR-14 1552273 166-6928
ENGINE SPEED (RPM) FROM ADEM 38 450-C149 YL-18 307-C122 OR-18 663-C197 GY-18 1 2

663-C346 GY-18 611-C366 PU-14

E707-C356 GN-18 1 OR-18 +V DISPLAY
39 308-C74 YL-18 663-C345 GY-18 611-C367 PU-18
201-C347 BK-18 2 BK-18 GROUND
FUEL LEVEL LOW INDICATOR 40 G480-C169 GN-18 320-C208 OR-18 615-C218 YL-18
E708-C354 PK-18 3 GN-18 CLOCK
C-C33 326-C199 PU-18 C413-C251 YL-18 1 2

C413-C350 YL-18 619-C40 GN-14

C413-C350 YL-18 4 WH-18 DATA
TRANSMISSION ECM 3E6287 413-C33 BR-18 C413-C351 YL-18 661-C233 GN-18
C414-C352 BU-18 5 YL-18 LOAD
172-9389 J2 430-C191 BU-18 662-C201 YL-18 6 BU-18 HARNESS CODE
436-C47 OR-18 C414-C244 BU-18 1 2

C414-C352 BU-18 663-C345 GY-18

604-C78 OR-18 C414-C353 BU-18 663-C346 GY-18 HAZARD LAMP SW PANEL LAMP 7 PANEL LAMP 6
605-C79 YL-18 E701-C256 PK-18 112--6167 7N-5876 7N-5876
1 2 1 2

606-C80 GY-18 E707-C250 GN-18 E707-C356 GN-18 E702-C255 OR-18

C-C70 C-C71
1 2

A
611-C32 PU-14 E707-C355 GN-18 E707-C355 GN-18 3T3158 3T3158
619-C40 GN-14 E707-C356 GN-18 1 B 663-C345 GY-18
CHASSIS, XMSN ECM 910-C15 YL-18 E708-C247 PK-18 E708-C354 PK-18 E708-C354 PK-18 691-C113 GY-18
I I
1 2

2 200-C331 BK-18
HVAC UNIT AND UPPER CAB 962-C368 OR-18 E708-C359 PK-18 E708-C359 PK-18 3 663-C346 GY-18
962-C31 OR-18 G746-C13 WH-18 691-C107 GY-18
200-C335 BK-18
A307-C129 GY-18 105-C195 RD-18 H795-C131 PK-18 4 5
A982-C130 BR-18 118-C237 GY-18 G850-C29 BU-18 200-C189 BK-18 6
G479-C192 WH-18 130-C5 RD-18 910-C279 YL-18 536-C415 WH-18 536-C415 WH-18
G480-C169 GN-18 132-C344 RD-18 962-C368 OR-18 537-C411 GN-18 C-C10 L
G746-C13 WH-18 133-C285 OR-18 A982-C130 BR-18 538-C414 BR-18 C-C79 1552273
GND
G750-C161 BU-18 133-C343 OR-18 691-C107 GY-18 3E7996 501-C257 GN-18 4 GN-16 MOTOR H
G755-C151 GY-18 135-C171 BU-18 538-C363 BR-18 614-C370 PU-18 1
T°
G760-C156 WH-18 147-C75 RD-18 605-C89 YL-18 614-C371 PU-18 538-C414 BR-18 200-C332 BK-18 2 BK-16
G761-C158 YL-18 164-C231 WH-18 606-C90 GY-18 537-C411 GN-18 118-C237 GY-18 6 GY-16
B+ P
G762-C159 BR-18 200-C373 BK-18 200-C189 BK-18 500-C252 BR-18 3 BR-16
G763-C150 PU-18 201-C347 BK-18 614-C370 PU-18 502-C253 OR-18 5 OR-16
G768-C152 GN-18 201-C348 BK-18 614-C371 PU-18 FRONT WIPER MOTOR
G850-C29 BU-18 307-C122 OR-18 135-0611
H795-C131 PK-18 A307-C129 GY-18
308-C74 YL-18
320-C208 OR-18
326-C199 PU-18 STEERING GROUP

536-C415 WH-18
538-C414 BR-18
411-C243 PK-18
413-C33 BR-18
430-C191 BU-18
436-C47 OR-18
G479-C192 WH-18 TURN SIGNAL SW
G480-C169 GN-18 605-C89 YL-18 128-6839
124-C440 GN-14 500-C252 BR-18 606-C90 GY-18 C-C94 P-C1 P-C2
135-C171 BU-18 501-C257 GN-18 538-C363 BR-18 1552272 3E3375 3E3372
1 DIMMER SW
200-C176 BK-14 502-C253 OR-18 536-C410 WH-18 536-C412 WH-18 1 536-P1 WH-16 1 536-WH
2H-1855
2
1

2
HVAC UNIT 517-C183 BU-14 536-C410 WH-18 105-C195 RD-18 538-C363 BR-18 1
2

538-C413 BR-18 2 538-P2 BR-16 2

3
695-OR
516-C182 GN-14 537-C411 GN-18 135-C171 BU-18 605-C79 YL-18 1
2

605-C87 YL-18 3 695-P3 OR-16 3 538-BR

4
515-C181 GY-14 604-C78 OR-18 147-C75 RD-18 606-C80 GY-18 1
2

606-C88 GY-18 4 696-P4 GN-16 4 538-BR

5
522-C125 WH-18 605-C79 YL-18 200-C189 BK-18 696-GN C-C88 W-C1
A523-C186 PU-18 606-C80 GY-18 200-C327 BK-18 605-C89 YL-18 CONN 24 536-WH
6 1552267 3E3370
A524-C188 BR-18 610-C369 OR-14 200-C373 BK-18 606-C90 GY-18 610-C369 OR-14 A 610-W2 OR-14

H A525-C258 GN-18
C547-C441 OR-14
105-C195 RD-18
614-C370 PU-18
614-C371 PU-18
615-C218 YL-18
307-C122 OR-18
308-C74 YL-18
320-C208 OR-18
619-C40 GN-14
611-C366 PU-14
B
C
619-W3 GN-14
611-W1 PU-14 H
164-C280 WH-18 118-C237 GY-18 619-C40 GN-14 326-C199 PU-18
CONN 27
164-C281 WH-18 130-C5 RD-18 661-C233 GN-18 536-C410 WH-18 SWITCH GP (205-3950)
307-C122 OR-18 132-C344 RD-18 662-C201 YL-18 537-C411 GN-18
A273-C119 BK-18 133-C285 OR-18 691-C107 GY-18 605-C79 YL-18
413-C33 BR-18 321-C148 BR-18 133-C343 OR-18 E701-C256 PK-18 606-C80 GY-18 FORWARD HORN SW
436-C47 OR-18 306-C134 GN-18 147-C75 RD-18 E702-C255 OR-18 614-C370 PU-18 C-C85 P-C3 2T-3360
G480-C169 GN-18 417-C146 GY-18 164-C231 WH-18 G746-C13 WH-18 614-C371 PU-18 1552252 3E5178
P-C4
700-C24 PK-18 419-C283 YL-18 FUSE PANEL/ELECTRICAL 200-C228 BK-14 G750-C161 BU-18 691-C107 GY-18 962-C31 OR-18 1 202-P5 BK-16 3E3384
720-C164 PU-18 450-C149 YL-18 INSTALLATION, CAB GROUND 200-C373 BK-18 G755-C151 GY-18 G750-C161 BU-18 320-C208 OR-18 2 322-P6 GY-16
H728-C198 GN-18 484-C142 YL-18 201-C347 BK-18 G760-C156 WH-18 G755-C151 GY-18 3 1 PU-20 NEUTRAL SW
H729-C62 WH-18 751-C61 GN-18 201-C348 BK-18 G761-C158 YL-18 G760-C156 WH-18 4 2 BK-20 GROUND
H730-C163 BR-18 752-C52 YL-18 536-C410 WH-18 G762-C159 BR-18 G761-C158 YL-18 G750-C161 BU-18 5 G750-P7 BU-16 3 BU-20 FORWARD SW
G746-C13 WH-18 754-C109 BU-18 537-C411 GN-18 G763-C150 PU-18 G762-C159 BR-18 G755-C151 GY-18 6 G755-P8 GY-16 4 GY-20 REVERSE SW
G750-C161 BU-18 755-C63 OR-18 615-C218 YL-18 G768-C152 GN-18 G763-C150 PU-18 G768-C152 GN-18 7 G768-P9 GN-16 5 GN-20 UPSHIFT (NC) C-C75 LH BRAKE PEDAL SENSOR
G755-C151 GY-18 900-C110 PU-18 TRANSMISSION ECM 661-C233 GN-18 H795-C131 PK-18 G768-C152 GN-18 G760-C156 WH-18 8 G760-P10 WH-16 6 WH-20 UPSHIFT (NO) 1552267 214-4863
G760-C156 WH-18 962-C58 OR-18 662-C201 YL-18 G850-C29 BU-18 944-C28 OR-18 G761-C158 YL-18 9 G761-P11 YL-16 7 YL-20 DOWNSHIFT (NC) 164-C231 WH-18 A RD-18 +V
TRANSMISSION ECM G761-C158 YL-18 962-C59 OR-18 IMPLEMENT POD 663-C197 GY-18 910-C15 YL-18 945-C17 BR-18 10 8 BR-20 DOWNSHIFT (NO) 962-C368 OR-18 B BK-18 RETURN
G762-C159 BR-18 G764-C140 PK-18 320-C96 OR-18 691-C107 GY-18 944-C28 OR-18 962-C31 OR-18 G762-C159 BR-18 11 G762-P12 BR-16 G746-C13 WH-18 C YL-18 SIGNAL
G763-C150 PU-18 F766-C249 WH-18 614-C98 PU-18 944-C28 OR-18 945-C17 BR-18 G763-C150 PU-18 12 G763-P13 PU-16 TRANSMISSION
G766-C154 GN-18 975-C46 WH-18 700-C24 PK-18 G-C3 G-C6 945-C17 BR-18 962-C31 OR-18 SHIFTER SW AS.
G767-C155 WH-18 975-C70 WH-18 761-C60 GY-18 1552273 3E3382 962-C368 OR-18 CONN 23 145-9994

1
G768-C152 GN-18 976-C139 OR-18 CHASSIS, XMSN ECM 762-C23 YL-18 962-G6 OR-18 1 A982-C130 BR-18 C-C76 T-C1

1
F781-C38 BR-18 E900-C114 WH-18 HVAC AND UPPER CAB F781-C38 BR-18 2 CABLE AS. 156-5537 3E3364 1552269
STOP LAMP SW
910-C15 YL-18 E901-C112 GN-18 G948-C25 BR-18 F781-G5 BR-18 3 130-C5 RD-18 1 130-T2 RD-18 105-6117
944-C282 OR-18 901-C66 WH-18 G948-C168 BR-18 4 604-C78 OR-18 2
945-C108 BR-18 N939-C135 GN-18 975-C22 WH-18 5 604-T1 OR-18
G948-C265 BR-18 975-C27 WH-18 6 411-C243 PK-18 CONN 26
X972-C153 GN-18 975-C53 WH-18 C413-C251 YL-18 LH BRAKE PEDAL(178-3186)
X973-C157 BU-18 135-C171 BU-18 975-C54 WH-18 C414-C244 BU-18
973-C160 BR-18 307-C122 OR-18 500-C252 BR-18
X974-C165 BR-18 308-C74 YL-18 C-C32 G-C1 501-C257 GN-18 C-C56 C-C77 THROTTLE POSITION SENSOR
1552253 1907612 PANEL B 1552272 R 1552267
G G
977-C162 YL-18 320-C208 OR-18 UPPER CAB 502-C253 OR-18 204-7949
326-C199 PU-18 FUSE PANEL/ELECTRICAL INSTALLATION 975-C22 WH-18 1 975-G1 WH-18 610-C369 OR-14 308-C74 YL-18 1 YL-16 A982-C130 BR-18 A RD-18 +V
C OFF KEY START SW
413-C33 BR-18 975-C27 WH-18 2 975-G2 WH-18 PILOT VALVE GROUP 614-C370 PU-18 326-C199 PU-18 2 PU-16
ON 110-7887 H795-C131 PK-18 B BK-18 RETURN
AUXILLARY S
430-C191 BU-18 DATA LOGGER ECM F-C2 762-C23 YL-18 3 961-G3 BR-18 152-6480 614-C371 PU-18 307-C122 OR-18 3 OR-16
ST A307-C129 GY-18 C YL-18 SIGNAL
C-C26 ELECTRO-MAGNET B
436-C47 OR-18 160-4891 1607689 4
TILT IMPLEMENT DETENTS E701-C256 PK-18 105-C195 RD-18 4 BR-16
9X0145 604-C78 OR-18 J1 F781-C38 BR-18 5 F781-G5 BR-18 E702-C255 OR-18
POSITIONER
1 201-C133 BK-18 605-C79 YL-18 BATTERY + 1 105-F26 RD-18 TWISTED WIRES 962-C320 OR-18 6 962-G6 OR-18 ELECTRO-MAGNET E707-C250 GN-18
2 425-C175 PK-18 606-C80 GY-18 GROUND 2 A275-F15 BK-18 F-C4 C-C27 7 G-C4 LIFT E708-C247 PK-18
3 E452-C166 WH-18 611-C32 PU-14 DASH 3 TWISTED WIRES 3E5179 1552252 8 1552264 POSITIONER
A-C1
4 751-C61 GN-18 619-C40 GN-14 4 1 9 975-G1 WH-18 4 RD ELECTRO-MAGNET 9W1951
5 752-C52 YL-18 910-C15 YL-18 5 A275-F12 BK-18 2 A275-C216 BK-18 G948-C25 BR-18 10 G948-G13 BR-18 G948-G13 BR-18 5 RD C-C47 A-C2
FLOAT
6 962-C31 OR-18 CAT DATA LINK - 6 945-F17 BR-18 3 108-C8 BU-14 G948-C168 BR-18 11 G948-G17 BR-18 961-G3 BR-18 3 RD 1552273 3E3382 A
ELECTRO-MAGNET
7 E900-C114 WH-18 962-C368 OR-18 CAT DATA LINK + 7 944-F19 OR-18 104-F21 YL-18 4 104-C260 YL-18 125-C14 OR-18 12 975-G2 WH-18 6 RD 147-C75 RD-18 1 147-A1 RD-18 B
CONN 2 8 C468-C172 BU-18 A307-C129 GY-18 8 945-F17 BR-18 5 945-C138 BR-18 142-C26 BU-18 975-G10 WH-18 2 RD 200-C327 BK-18 2 200-A2 BK-18 C SERVICE
CONNECT TO AT-C3 9 A497-C170 YL-18 A982-C130 BR-18 9 944-F19 OR-18 6 944-C145 OR-18 FUSE PANEL/ELECTRICAL 200-C97 BK-18 CONN 18 761-G11 GY-18 7 RD 944-C28 OR-18 3 944-A3 OR-18 D TOOL CONNECTOR
ON THE CHASSIS AND 10 G480-C169 GN-18 10 105-F26 RD-18 1 2

105-F23 RD-18 7 105-C246 RD-18 INSTALLATION, CAB GROUND 200-C99 BK-18 C-C36 G-C2 G948-G17 BR-18 1 RD 945-C17 BR-18 4 945-A4 BR-18 E
ENGINE DIAGRAM 11 G746-C13 WH-18 11 105-F24 RD-18 8 200-C11 BK-14 1552252 3E5179 975-G12 WH-18 8 RD 5 F CAP AS. PART NUMBER
FOR PART NUMBERS 12 754-C109 BU-18 G479-C192 WH-18 12 105-F25 RD-18 9 200-C21 BK-18 975-C53 WH-18 1 975-G10 WH-18 ELECTRO-MAGNET 109-1739 (4) 6 G 180-9900
SEE THE TITLE BLOCK 13 E901-C112 GN-18 G750-C161 BU-18 13 10 H766-C19 YL-18 761-C60 GY-18 2 761-G11 GY-18 H
14 T800-C173 OR-18 G755-C151 GY-18 BATTERY + 14 105-F24 RD-18 11 962-C320 OR-18 975-C54 WH-18 3 975-G12 WH-18
CONN 21 J
15 G760-C156 WH-18 GROUND 15 A275-F14 BK-18 12 H766-C19 YL-18 4 H766-G8 YL-16
16 G761-C158 YL-18 16 700-C24 PK-18 5 700-G14 PK-16 CONN 22
17 G762-C159 BR-18 17 CONN 11 320-C96 OR-18 6 320-G15 OR-18
18 755-C63 OR-18 G763-C150 PU-18 18 536-C410 WH-18 200-C97 BK-18 7 200-G16 BK-18 H766-G8 YL-16
19 G768-C152 GN-18 19 614-C98 PU-18 8
20 900-C110 PU-18 G850-C29 BU-18 20 FLASHER IMPL DETENT OVERRIDE LIMIT SW TWISTED
200-C99 BK-18 9 700-G14 PK-16
21 901-C66 WH-18 H795-C131 PK-18 21 108-0358 7X-1886 WIRES
142-C26 BU-18 10
22 975-C121 WH-18 22 11
23 23 12
24 320-C96 OR-18 24 G-C5 C-C90
1
614-C98 PU-18 25 CONN 17 1552269 7T5957
C-C2 FORWARD HORN SW 2 12 VOLT POWER PORT
700-C24 PK-18 26 537-C411 GN-18 320-G15 OR-18 1 BK-18 135-C171 BU-18 1
170-1821
RENR9858 VOL 2

8N1532 761-C60 GY-18 27 200-G16 BK-18 2 BK-18 200-C373 BK-18 2 117-2311

CONN 5 1 112-C1 PU-4 762-C23 YL-18 28
CONNECT TO CJ-C11 2 F781-C38 BR-18 IMPLEMENT POD 29

F ON THE CHASSIS AND

ENGINE DIAGRAM
3
4
611-C32 PU-14 G948-C25 BR-18
G948-C168 BR-18
30
31
24 VOLT CIGAR LIGHTER 9W-0335
F
FOR PART NUMBERS 5 619-C40 GN-14 975-C22 WH-18 32
SEE THE TITLE BLOCK 6 975-C27 WH-18 33
7 174-C2 RD-12 102-C69 BU-14 975-C53 WH-18 34 125-C14 OR-18 HEATER ELEMENT
104-C222 YL-18 975-C54 WH-18 35 200-C21 BK-18

1
112-C1 PU-4 36
C-C3 114-C41 RD-18 37
9X7148 123-C95 WH-18 38 945-C128 BR-18
1 124-C440 GN-14 39 945-C108 BR-18
2 129-C71 BU-18 40 945-C364 BR-18
3 962-C4 OR-18 130-C76 RD-18 102-C69 BU-14 41 945-C17 BR-18
4 135-C171 BU-18 201-C133 BK-18 42 945-C45 BR-18
5 419-C283 YL-18 138-C20 GN-18 403-C123 GN-18 43 1 2

945-C137 BR-18
6 150-C126 OR-18 425-C175 PK-18 44
7 432-C6 PK-18 164-C280 WH-18 426-C85 BR-18 45 945-C138 BR-18
8 442-C7 GY-18 164-C281 WH-18 432-C6 PK-18 KEY SWITCH INPUT 46 104-F21 YL-18
DASH
9 170-C86 RD-18 442-C7 GY-18 47
10 496-C9 WH-18 174-C2 RD-12 443-C18 YL-18 48 ACTION ALARM
11 506-C10 PU-18 200-C176 BK-14 447-C64 PK-18 49 3E-6328 C-C9
12 200-C418 BK-18 E452-C166 WH-18 50 1552269 944-C145 OR-18
13 E455-C12 BR-18 201-C65 BK-18 E455-C12 BR-18 51 BK-18 1 410-C242 WH-18 C-C7
14 G764-C140 PK-18 201-C133 BK-18 C468-C172 BU-18 52 BK-18 2 201-C224 BK-18 1 2

944-C143 OR-18 1552269 MOTOR

A275-F14 BK-18

15 K933-C226 GN-18 251-C67 BK-18 G485-C55 BU-18 53 944-C44 OR-18 108-C8 BU-14 1 OR-16
A275-F12 BK-18

16 484-C142 YL-18 A273-C119 BK-18 G486-C56 GN-18 54 944-C330 OR-18 200-C11 BK-14 2 BK-16
17 A274-C275 BK-18 496-C9 WH-18 55 944-C282 OR-18
18 306-C134 GN-18 A497-C170 YL-18 56 C-C4 C-C11 944-C127 OR-18 SEAT COMPRESSOR
CONN 4 19 762-C23 YL-18 307-C122 OR-18 506-C10 PU-18 57 1552272 1965330 944-C28 OR-18 XXX-XXXX
CONNECT TO CJ-C4 20 F766-C249 WH-18 A307-C129 GY-18 515-C181 GY-14 58 1 290-C16 BK-18 E735-C284 PU-18
ON THE CHASSIS AND 21 114-C41 RD-18 308-C74 YL-18 516-C182 GN-14 PANEL B 59 SERVICE 2 291-C100 BK-18 691-C107 GY-18
ENGINE DIAGRAM 22 138-C20 GN-18 320-C96 OR-18 517-C183 BU-14 AND UPPER CAB 60 MODE 3 E735-C284 PU-18 663-C197 GY-18 SEAT GP-SUSP-A (268-1202)
30 Page

FOR PART NUMBERS 23 251-C67 BK-18 1 2

320-C208 OR-18 521-C124 YL-18 61 PLUG 4 201-C102 BK-18 662-C201 YL-18

SEE THE TITLE BLOCK 24 200-C418 BK-18 320-C209 OR-18 A523-C186 PU-18 62 661-C233 GN-18
25 322-C39 GY-18 321-C148 BR-18 A524-C188 BR-18 63 CONN 10 647-C236 GN-18

E 26
27
28
976-C139 OR-18
322-C39 GY-18
326-C199 PU-18
403-C123 GN-18
A525-C258 GN-18
C547-C441 OR-14
614-C94 PU-18
64
65
66
646-C207 OR-18
X615-C433 YL-14
615-C218 YL-18
E
29 761-C60 GY-18 413-C33 BR-18 617-C83 BR-18 67 615-C217 YL-14
30 417-C146 GY-18 720-C164 PU-18 68 614-C92 PU-18
31 419-C283 YL-18 H728-C198 GN-18 GROUND 69 A275-F16 BK-18 608-C421 GN-14
32 425-C175 PK-18 H729-C62 WH-18 BATTERY + 70 105-F25 RD-18 608-C81 GN-14
33 426-C85 BR-18 H730-C163 BR-18 537-C411 GN-18
34 430-C191 BU-18 G766-C154 GN-18 1 536-C410 WH-18
35 G485-C55 BU-18 432-C6 PK-18 G767-C155 WH-18 2 410-C242 WH-18 PANEL B
36 G486-C56 GN-18 436-C47 OR-18 T800-C173 OR-18 3 322-C39 GY-18
37 442-C7 GY-18 962-C30 OR-18 4 320-C209 OR-18 147-C34 RD-18 HEAT A/C SELECTOR SW
38 443-C18 YL-18 K933-C226 GN-18 5 291-C100 BK-18 200-C43 BK-18 165-5963
39 447-C64 PK-18 X972-C153 GN-18 6 ARC SUPPRESSOR C-C12 290-C16 BK-18 944-C44 OR-18 614-C371 PU-18
1552269 A 1
40 450-C149 YL-18 973-C160 BR-18 7 189-3158 A275-C216 BK-18 945-C45 BR-18 614-C299 PU-18
E452-C166 WH-18 X973-C157 BU-18 8 1 691-C107 GY-18 201-C224 BK-18 F-C3 200-C301 BK-18 B HEAT 1 B1
E455-C12 BR-18 X974-C165 BR-18 9 2 131-C266 BR-18 201-C102 BK-18 FUSE PANEL/ 3E5136 567-C174 WH-14
C-C1 2
C468-C172 BU-18 977-C162 YL-18 10 200-C220 BK-18 ELECTRICAL A SERVICE 124-C234 GN-14 3 2
9X1343 G479-C192 WH-18 11 200-C214 BK-18 TWISTED WIRES INSTALLATION A276-F13 BK-18 B TOOL CONNECTOR 567-C174 WH-14 HVAC TEMPERATURE SELECT POT
1 G480-C169 GN-18 12 C-C16 200-C212 BK-18 876-F27 OR-18 C 124-C234 GN-14 567-C178 WH-14 C-C51 127-4540
5 4
2 123-C95 WH-18 484-C142 YL-18 13 1552273 200-C211 BK-18 104-C222 YL-18 875-F28 BU-18 D 124-C439 GN-14 1552267 C-C78 RUNNING LAMP SW
CAP AS. PART NUMBER 6
3 201-C65 BK-18 G485-C55 BU-18 14 GROUND 1 200-C214 BK-18 174-C2 RD-12 105-C195 RD-18 E 614-C298 PU-18 521-C124 YL-18 A525-C258 GN-18 A RD-14 1552264 108-3320
8D-9537 C A/C 3
4 417-C146 GY-18 496-C9 WH-18 104-C222 YL-18 15 LIGHTS 2 614-C92 PU-18 170-C86 RD-18 108-C8 BU-14 614-C299 PU-18 A524-C188 BR-18 B BK-14 131-C84 BR-18 1 OR-14
5 447-C64 PK-18 G486-C56 GN-18 112-C1 PU-4 16 + BATTERY 3 113-C262 OR-18 164-C281 WH-18 112-C1 PU-4 CONN 16 200-C301 BK-18 D
A523-C186 PU-18 C BR-14 102-C69 BU-14 2 BU-14
B2
6 A497-C170 YL-18 114-C41 RD-18 17 SPEEDOMETER LAMP 4 662-C201 YL-18 164-C280 WH-18 113-C245 OR-18 200-C302 BK-18 139-C277 OR-18 3 BR-14
TWISTED WIRES 4
7 506-C10 PU-18 123-C95 WH-18 18 TACHOMETER LAMP 5 661-C233 GN-18 164-C231 WH-18 114-C41 RD-18 105-C195 RD-18 C-C43 646-C207 OR-18 4 YL-14
8 N939-C135 GN-18 515-C181 GY-14 124-C440 GN-14 19 GAGE LAMP 6 663-C197 GY-18 118-C202 GY-14 108-C8 BU-14 3E7996 C-C52 617-C83 BR-18 5 GY-14 B3
9 516-C182 GN-14 129-C71 BU-18 20 DIMMER CONTROL 118-C237 GY-18 113-C245 OR-18 105-C195 RD-18 1552264 610-C369 OR-14 6 PK-14 KICKOUT ON/OFF SW
103-5526 219-9535
10 517-C183 BU-14 130-C76 RD-18 21 147-C73 RD-18 122-C225 RD-18 118-C202 GY-14 118-C237 GY-18 118-C322 GY-18 1 RD-16 WIPER B+ 647-C236 GN-18 7 GN-14
11 521-C124 YL-18 138-C20 GN-18 22 1 2

147-C75 RD-18 122-C240 RD-18 CHASSIS, XMSN 118-C237 GY-18 130-C5 RD-18 HVAC BLOWER SPEED SELECTOR SW 118-C357 GY-18 2 RD-16 WASHER B+ 614-C370 PU-18 8 PU-14 ROADING 614-C291 PU-18
PARK WORK1 A
12 102-C69 BU-14 A523-C186 PU-18 150-C126 OR-18 23 147-C34 RD-18 123-C95 WH-18 ECM HVAC UNIT 122-C225 RD-18 132-C344 RD-18 157-1361 200-C316 BK-18 3 BK-16 GROUND 614-C94 PU-18
C-C100 5
13 A524-C188 BR-18 164-C280 WH-18 24 REAR CAB MACH FLOODLAMPS RELAY 142-C26 BU-18 124-C439 GN-14 AND UPPER CAB 122-C240 RD-18 133-C343 OR-18 502-C253 OR-18 4 WH-16 HIGH OFF WORK2 B
200-C309 BK-18
14 129-C71 BU-18 A525-C258 GN-18 164-C281 WH-18 25 3E-5239 C-C29 138-C20 GN-18 124-C440 GN-14 124-C439 GN-14 133-C285 OR-18 1552273 501-C257 GN-18 5 YL-16 LOW 200-C313 BK-18
9X1054 1 1
15 C547-C441 OR-14 170-C86 RD-18 FUSE PANEL/ 26 133-C343 OR-18 125-C14 OR-18 125-C14 OR-18 147-C75 RD-18 567-C178 WH-14 1 BK-14 500-C252 BR-18 6 BU-16 PARK 962-C223 OR-18
30 2
306-C134 GN-18 604-C78 OR-18 174-C2 RD-12 ELECTRICAL INSTALLATION 134-C268 YL-14 133-C285 OR-18 126-C37 PK-18 126-C37 PK-18 164-C231 WH-18 506-C10 PU-18 962-C379 OR-18
D D
16 27 1 2 7 BR-16 WASH
86 C-C42 6 3
17 308-C74 YL-18 605-C79 YL-18 200-C176 BK-14 28 5 647-C236 GN-18 132-C344 RD-18 129-C71 BU-18 130-C5 RD-18 200-C228 BK-14 517-C183 BU-14 3 WH-14 8 UNUSED
8T9834 5 C-C54
18 606-C80 GY-18 200-C418 BK-18 29 2 200-C220 BK-18 131-C84 BR-18 130-C5 RD-18 131-C84 BR-18 200-C373 BK-18 113-C248 OR-18 C547-C441 OR-14 4 GY-14 C-C61
CONN 3 85 DASH 4 1552273
19 608-C81 GN-14 201-C65 BK-18 30 4 608-C185 GN-14 129-C71 BU-18 130-C76 RD-18 132-C344 RD-18 201-C348 BK-18 + BATTERY 1 113-C241 OR-18 113-C245 OR-18 516-C182 GN-14 5 GN-14 FRONT INTER WIPER WASHER SW 3E7996
87
2
1 1
2

3
CONNECT TO CJ-C6 20 611-C32 PU-14 251-C67 BK-18 31 124-C440 GN-14 131-C84 BR-18 133-C285 OR-18 201-C347 BK-18 GROUND 2 201-C103 BK-18 201-C104 BK-18 515-C181 GY-14 6 BU-14 110-7886 962-C380 OR-18 1 BK-16
87a
1 2

2
ON THE CHASSIS AND 614-C92 PU-18 A273-C119 BK-18 124-C439 GN-14 132-C344 RD-18 133-C343 OR-18 536-C410 WH-18 201-C48 BK-18 201-C115 BK-18 973-C160 BR-18
608-C421 GN-14

21 32 LOC 1 3 2 BK-16
608-C81 GN-14

2 3
ENGINE DIAGRAM 22 614-C82 PU-18 1 2

614-C94 PU-18 A274-C275 BK-18 33 114-C41 RD-18 133-C285 OR-18 139-C277 OR-18 537-C411 GN-18 ACTION ALARM 4 410-C242 WH-18 BR-14 977-C162 YL-18 3 BK-16
4 1
FOR PART NUMBERS 23 614-C98 PU-18 320-C209 OR-18 34 113-C245 OR-18 133-C343 OR-18 142-C26 BU-18 615-C218 YL-18 CAT DATA LINK + 5 944-C141 OR-18 1
2

944-C143 OR-18 113-C245 OR-18 H728-C198 GN-18 4 BK-16

5
322-C39 GY-18 112-C1 PU-4 138-C20 GN-18 147-C75 RD-18 661-C233 GN-18 201-C49 BK-18 944-C144 OR-18 290-C16 BK-18 H729-C62 WH-18

BK-18
PU-18
BK-18
PU-18
SEE THE TITLE BLOCK 24 35 LOC 5 6 5 BK-16
6
25 617-C83 BR-18 608-C81 GN-14 36 108-C8 BU-14 139-C277 OR-18 164-C231 WH-18 662-C201 YL-18 7 291-C100 BK-18 H730-C163 BR-18 6 BK-16
26 321-C148 BR-18 619-C40 GN-14 614-C92 PU-18 37 105-C195 RD-18 142-C26 BU-18 290-C16 BK-18 663-C197 GY-18 8 403-C123 GN-18
AUTO MANUAL GEAR SELECT SW ABBREV COLOR

200-C306
614-C294
200-C309
614-C291
27 604-C78 OR-18 700-C24 PK-18 944-C330 OR-18 38 104-C260 YL-18 147-C75 RD-18 291-C100 BK-18 691-C107 GY-18 FUEL LEVEL SENSOR 9 447-C64 PK-18 410-C242 WH-18
28 605-C79 YL-18 720-C164 PU-18 944-C127 OR-18 39 150-C126 OR-18 410-C242 WH-18 944-C28 OR-18 HYD TEMP SENSOR 10 442-C7 GY-18 411-C243 PK-18 201-7952
29 606-C80 GY-18 H728-C198 GN-18 944-C282 OR-18 VIMS SERVICE PORT TRANSMIT 40 875-F28 BU-18 164-C231 WH-18 536-C410 WH-18 945-C17 BR-18 11 C413-C251 YL-18 MANUAL RD RED
30 608-C81 GN-14 H729-C62 WH-18 945-C128 BR-18 VIMS SERVICE PORT RECEIVE 41 876-F27 OR-18 164-C280 WH-18 537-C411 GN-18 LOC 2 12 201-C50 BK-18 426-C85 BR-18 AUTO 4 WH WHITE
31 614-C82 PU-18 H730-C163 BR-18 945-C108 BR-18 42 164-C281 WH-18 608-C421 GN-14 ACTION LAMP 13 411-C243 PK-18 432-C6 PK-18
32 617-C83 BR-18 G746-C13 WH-18 945-C364 BR-18 43 170-C86 RD-18 615-C217 YL-14 CAT DATA LINK - 14 945-C101 BR-18 1 2

945-C137 BR-18 442-C7 GY-18 LAMP-MINIATURE OR ORANGE

AUTO 3 YL YELLOW
33 975-C167 WH-18 G750-C161 BU-18 44 TWISTED WIRES 174-C2 RD-12 615-C218 YL-18 MODULE LOAD 15 C414-C244 BU-18 945-C136 BR-18 443-C18 YL-18 7N-5876 614-C298 PU-18
34 751-C61 GN-18 45 200-C43 BK-18 X615-C433 YL-14 16 447-C64 PK-18 614-C296 PU-18 PK PINK
SIDE FLOODLAMPS SW AUTO 2 NEUTRALIZER OVERRIDE SW
35 752-C52 YL-18 46 FORWARD HORN RELAY 200-C176 BK-14 646-C207 OR-18 17 496-C9 WH-18 200-C302 BK-18 RIDE CONTROL SW

1
C-C13 3E-9319 BK BLACK
36 754-C109 BU-18 47 3E-5239 200-C211 BK-18 647-C236 GN-18 108-C8 BU-14 OPERATOR SW INPUT 18 E735-C287 PU-18 C414-C244 BU-18 LAMP AS. 200-C304 BK-18 AUTO 1-4 219-9531 219-9530
9X1054 7G-9730 GY GRAY
37 755-C63 OR-18 48 200-C212 BK-18 661-C233 GN-18 125-C14 OR-18 FRONT AXLE OIL TEMP SW 19 G485-C55 BU-18 E455-C12 BR-18 614-C294 PU-18
30 614-C437 PU-18 A A PU PURPLE
38 G755-C151 GY-18 49
86
1 322-C39 GY-18 200-C214 BK-18 662-C201 YL-18 142-C26 BU-18 BRK OIL PRESS 20 432-C6 PK-18 G485-C55 BU-18 A 614-C295 PU-18
614-C295 PU-18
39 G760-C156 WH-18 50 5 114-C42 RD-18 200-C220 BK-18 663-C197 GY-18 200-C11 BK-14 IMPLEMENT POD REAR AXLE OIL TEMP SW 21 G486-C56 GN-18 G486-C56 GN-18 200-C306 BK-18 B ON B BR BROWN
200-C305 BK-18 1 1
40 426-C85 BR-18 761-C60 GY-18 51
PANEL B AND
2 320-C209 OR-18 200-C418 BK-18 691-C107 GY-18 200-C21 BK-18 22 E707-C250 GN-18 EMS MODE SELECT SW B 200-C305 BK-18 GN GREEN
85 200-C438 BK-18 2 3
G761-C158 YL-18 52 4 200-C211 BK-18 201-C65 BK-18 E735-C284 PU-18 200-C97 BK-18 SERVICE 23 290-C16 BK-18 E708-C247 PK-18 220-8358 962-C278 OR-18 720-C164 PU-18
UPPER CAB 87 X615-C433 YL-14 3 2 MOM BU BLUE
762-C23 YL-18 53
87a 201-C102 BK-18 944-C28 OR-18 200-C99 BK-18 8 VOLT SENSOR SUPPLY 24 K933-C226 GN-18 K933-C226 GN-18 3 2 962-C325 OR-18 OFF 4
G762-C159 BR-18 54 201-C224 BK-18 944-C143 OR-18 H766-C19 YL-18 MODULE CLOCK 25 E708-C247 PK-18 944-C143 OR-18 A
614-C296 PU-18 5
C-C35 G763-C150 PU-18 55 251-C67 BK-18 945-C17 BR-18 962-C320 OR-18 26 945-C137 BR-18 614-C437 PU-18
1835785 C-C99 C-C57 6 C-C62
G764-C140 PK-18 56 FWD & SIDE CAB FLOODLAMPS RELAY A273-C119 BK-18 945-C137 BR-18 27 200-C304 BK-18 N-C1 962-C379 OR-18 3E7996
C-C5 B 3E7996 1552273 AUTO
SYMBOL DESCRIPTION
1 130-C76 RD-18 F766-C249 WH-18 57 3E-5239 A274-C275 BK-18 TORQUE CONV OUTLET TEMP 28 443-C18 YL-18 TWISTED 200-C438 BK-18 3E3382
9X1054

PK-18
WH-18
GN-18
OR-18
G766-C154 GN-18 A275-C216 BK-18 496-C9 WH-18 WIRES 201-C205 BK-18 E735-C284 PU-18 962-C278 OR-18 X962-N1 BK-18

962-C278 OR-18
962-C379 OR-18

H766-C19 YL-18

720-C164 PU-18
962-C379 OR-18
962-C223 OR-18
200-C313 BK-18
2 58 HYD OIL LEVEL 29 1

126-C37 PK-18

614-C94 PU-18
30 3 2 X615-C434 YL-14 BLADE, SPADE, RING,
3 326-C199 PU-18 G767-C155 WH-18 59
86
1 127-C267 OR-12 290-C16 BK-18 ALTERNATOR R-TERMINAL 30 403-C123 GN-18 201-C104 BK-18 E735-C287 PU-18 X972-C153 GN-18 2
C-C60
MOM
4 450-C149 YL-18 G768-C152 GN-18 60 5 646-C207 OR-18 291-C100 BK-18 201-C205 BK-18 31 X973-C157 BU-18 3
3E7996 OR SCREW TERMINAL
201-C104 BK-18

E701-C256
G767-C155
G766-C154
E702-C255
5 F781-C38 BR-18 61 2 200-C212 BK-18 320-C209 OR-18 201-C347 BK-18 XMSN FILTER BYPASS SW 32 426-C85 BR-18 C-C50 X974-C165 BR-18 4

C C
85 E735-C287 PU-18
1 2

CIRCUIT CONNECTED
6 H795-C131 PK-18 62 4 615-C219 YL-12 322-C39 GY-18 201-C348 BK-18 CLEAR 33 291-C100 BK-18 3E7996 5
87
2
1

7 403-C123 GN-18 T800-C173 OR-18 63

87a 104-C222 YL-18 410-C242 WH-18 CLUSTER +V 34 E707-C250 GN-18 6
CIRCUIT NOT CONNECTED
8 521-C124 YL-18 G850-C29 BU-18 64 104-C260 YL-18 536-C410 WH-18 201-C65 BK-18 MODULE DATA 35 C413-C251 YL-18
CONN 19 ELECTRICAL CONNECTION
X615-C433 YL-14

522-C125 WH-18 E900-C114 WH-18 118-C202 GY-14 537-C411 GN-18 201-C224 BK-18
615-C217 YL-14
615-C218 YL-18

9 65 36
10 E901-C112 GN-18 VIMS SERVICE PORT COMMON 66 A276-F13 BK-18 118-C237 GY-18 608-C81 GN-14 201-C102 BK-18 962-C320 OR-18 37 113-C248 OR-18 TO MACHINE STRUCTURE
11 900-C110 PU-18 67 122-C225 RD-18 608-C421 GN-14 H766-C19 YL-18 38 201-C115 BK-18
INTERNAL ELECTRICAL
12 150-C126 OR-18 901-C66 WH-18 TWISTED WIRES 68 122-C240 RD-18 614-C92 PU-18 A275-C216 BK-18 113-C245 OR-18 HYD FILTER BYPASS SW 39 E455-C12 BR-18 944-C144 OR-18
13 944-C127 OR-18 910-C15 YL-18 69 TWISTED WIRE 123-C95 WH-18 615-C217 YL-14 A274-C275 BK-18 118-C202 GY-14 40 945-C136 BR-18 CONNECTION TO SURFACE
CONN 1 14 945-C128 BR-18 K933-C226 GN-18 70 125-C14 OR-18 615-C218 YL-18 A273-C119 BK-18 122-C225 RD-18 OF COMPONENT
CONNECTS TO CH-C1 15 A307-C129 GY-18 N939-C135 GN-18 F-C1 126-C37 PK-18 X615-C433 YL-14 122-C240 RD-18 EMS III ECM TWISTED CONNECTOR
ON THE CHASSIS AND 16 A982-C130 BR-18 944-C127 OR-18 1471445 130-C5 RD-18 646-C207 OR-18 251-C67 BK-18 124-C439 GN-14 154-7443 WIRES
ENGINE DIAGRAM 17 H795-C131 PK-18 944-C282 OR-18 J2 130-C76 RD-18 647-C236 GN-18 126-C37 PK-18 ATCH WIRE, CABLE &
FOR PART NUMBERS 18 944-C330 OR-18 STRAP A275-F12 BK-18 139-C277 OR-18 661-C233 GN-18 131-C84 BR-18 COMPONENT
19 945-C108 BR-18 A275-F14 BK-18 150-C126 OR-18 662-C201 YL-18 139-C277 OR-18 PANEL B C-C41
SEE THE TITLE BLOCK
1

A523-C186 PU-18
A524-C188 BR-18
A525-C258 GN-18
118-C357 GY-18
118-C322 GY-18
200-C316 BK-18
500-C252 BR-18
501-C257 GN-18
502-C253 OR-18
8T9834 CIRCUIT GROUPING

A497-C170 YL-18
C468-C172 BU-18
E452-C166 WH-18
T800-C173 OR-18

C413-C251 YL-18
C414-C244 BU-18

E707-C250 GN-18
E708-C247 PK-18

K933-C226 GN-18

X615-C433 YL-14
X615-C434 YL-14

C547-C441 OR-14

E735-C284 PU-18

H728-C198 GN-18

H730-C163 BR-18

X972-C153 GN-18
X973-C157 BU-18
X974-C165 BR-18

E701-C256 PK-18
E702-C255 OR-18

G766-C154 GN-18

G767-C155 WH-18
506-C10 PU-18
945-C128 BR-18 A275-F16 BK-18 663-C197 GY-18 CAB GROUND 1 200-C313 BK-18 UPPER CAB H#

201-C133 BK-18
425-C175 PK-18

113-C245 OR-18

291-C100 BK-18
403-C123 GN-18
410-C242 WH-18
411-C243 PK-18

944-C143 OR-18
945-C137 BR-18

E455-C12 BR-18

G485-C55 BU-18
G486-C56 GN-18

124-C439 GN-14
201-C205 BK-18

515-C181 GY-14
516-C182 GN-14
517-C183 BU-14
521-C124 YL-18

614-C371 PU-18

139-C277 OR-18
610-C369 OR-14
614-C370 PU-18

646-C207 OR-18
647-C236 GN-18

962-C380 OR-18

H729-C62 WH-18

973-C160 BR-18
977-C162 YL-18

962-C278 OR-18

200-C313 BK-18

720-C164 PU-18

H766-C19 YL-18

962-C223 OR-18
20

131-C84 BR-18
290-C16 BK-18

426-C85 BR-18

443-C18 YL-18

447-C64 PK-18

102-C69 BU-14

617-C83 BR-18

126-C37 PK-18

614-C94 PU-18
432-C6 PK-18
442-C7 GY-18

496-C9 WH-18
21 430-C191 BU-18 945-C364 BR-18 691-C107 GY-18 200-C316 BK-18 + BATTERY 1 113-C248 OR-18 DESIGNATION
22 G479-C192 WH-18 973-C160 BR-18 A275-F15 BK-18 E735-C284 PU-18 201-C205 BK-18 GROUND 2 201-C116 BK-18
23 976-C139 OR-18 174-C2 RD-12 944-C28 OR-18 200-C313 BK-18 290-C16 BK-18 3
24 443-C18 YL-18 977-C162 YL-18 ECM MOUNT BOLT UNSWITCHED BUS 1 944-C127 OR-18 200-C316 BK-18 291-C100 BK-18 ACTION ALARM 4 A487-C147 PU-18
25 A982-C130 BR-18 944-C143 OR-18 410-C242 WH-18 CAT DATA LINK + 5 944-C144 OR-18
32 31
26 962-C30 OR-18 122-C240 RD-18 10A 10A 105-C246 RD-18 944-C282 OR-18 200-C97 BK-18 608-C421 GN-14 LOCATION CODE 3 6 201-C118 BK-18 1
2

201-C115 BK-18 HARNESS ASSEMBLIES

27 G850-C29 BU-18 962-C31 OR-18 122-C225 RD-18 DOME LAMPS KEY START SW/MSS 105-C195 RD-18 944-C330 OR-18 200-C99 BK-18 615-C217 YL-14 7 201-C117 BK-18 IDENT PART NUMBER VER CHG LOC NOTE
28 104-C222 YL-18 962-C4 OR-18 962-C368 OR-18 945-C17 BR-18 200-C373 BK-18 X615-C433 YL-14 COOLANT LVL SENSOR 8 E452-C166 WH-18
30 29
1 2

29 170-C86 RD-18 962-C58 OR-18 10A 10A 114-C42 RD-18 945-C108 BR-18 200-C21 BK-18 646-C207 OR-18 9
30 A274-C275 BK-18 962-C59 OR-18 SPARE HORN 114-C41 RD-18 945-C128 BR-18 200-C176 BK-14 647-C236 GN-18 10 A 197-4845 - 00 F-3 HARNESS AS. (SERVICE TOOL)
31 945-C364 BR-18 975-C22 WH-18 945-C137 BR-18 200-C418 BK-18 E735-C284 PU-18 11 TWISTED AE 157-2500 - 00 K15 HARNESS AS. (HVAC)
28 27
32 944-C330 OR-18 975-C27 WH-18 130-C76 RD-18 10A 10A 945-C364 BR-18 200-C211 BK-18 944-C143 OR-18 12 WIRES
33 975-C121 WH-18 975-C53 WH-18 130-C5 RD-18 STOP LAMPS/(ATTCH BACKUP ALARM/LAMPS) SPARE 200-C214 BK-18 945-C137 BR-18 13
AF 241-7692 - 00 K16 HARNESS AS. (HVAC)
975-C167 WH-18 975-C54 WH-18 200-C418 BK-18 200-C212 BK-18 945-C136 BR-18 C 256-3503 V 02 C-9 HARNESS AS. (MAIN CAB)
GY-18
GY-18

OR-18

OR-18
34 CAT DATA LINK - 14
26 25
1 2

35 975-C46 WH-18 139-C277 OR-18 10A 10A 147-C73 RD-18 200-C176 BK-14 15 E 256-3506 V 00 L-15 HARNESS AS. (HVAC)
36 TWISTED WIRES 975-C70 WH-18 LH TAIL AND CLEARANCE LAMPS ECAP 201-C65 BK-18 200-C220 BK-18 200-C228 BK-14 16
F 256-3504 V 00 E-16 HARNESS AS. (DATA LOGGER VIMS)
118-C322
118-C357

962-C223

962-C380
37 G948-C265 BR-18 G948-C25 BR-18 251-C67 BK-18 200-C43 BK-18 200-C11 BK-14 17
24 23
1 2

38 G948-C168 BR-18 20A 10A 170-C86 RD-18 A273-C119 BK-18 18 GA 241-7693 - 01 L-16 HARNESS AS. (HVAC)
C413-C251 YL-18
C414-C244 BU-18

C468-C172 BU-18

A497-C170 YL-18

A523-C186 PU-18
A524-C188 BR-18
A525-C258 GN-18
C547-C441 OR-14

X615-C433 YL-14
X615-C434 YL-14

E701-C256 PK-18
E702-C255 OR-18
E707-C250 GN-18
E708-C247 PK-18

H728-C198 GN-18

H730-C163 BR-18
E735-C284 PU-18
G766-C154 GN-18

G767-C155 WH-18

K933-C226 GN-18

X972-C153 GN-18

X973-C157 BU-18
X974-C165 BR-18
G 228-6087 - 00 L-15 HARNESS AS. (IMP CONTROLS HMU)

E452-C166 WH-18

T800-C173 OR-18
X972-C153 GN-18 A274-C275 BK-18 200-C418 BK-18 A497-C170 YL-18
113-C245 OR-18
124-C439 GN-14

139-C277 OR-18
200-C313 BK-18
200-C316 BK-18
201-C133 BK-18
201-C205 BK-18

291-C100 BK-18
403-C123 GN-18
410-C242 WH-18
411-C243 PK-18

425-C175 PK-18

E455-C12 BR-18

G485-C55 BU-18
G486-C56 GN-18

500-C252 BR-18
501-C257 GN-18
502-C253 OR-18

515-C181 GY-14
516-C182 GN-14
517-C183 BU-14
521-C124 YL-18

610-C369 OR-14

614-C370 PU-18
614-C371 PU-18

646-C207 OR-18
647-C236 GN-18

720-C164 PU-18

H729-C62 WH-18

H766-C19 YL-18

944-C143 OR-18
945-C137 BR-18

973-C160 BR-18

977-C162 YL-18
39 SPARE PRODUCT LINK COOLANT FLOW SW 19
102-C69 BU-14

126-C37 PK-18
131-C84 BR-18

290-C16 BK-18

426-C85 BR-18

443-C18 YL-18
447-C64 PK-18

506-C10 PU-18

614-C94 PU-18

617-C83 BR-18
432-C6 PK-18
442-C7 GY-18

496-C9 WH-18
B B
40 X973-C157 BU-18 200-C176 BK-14 ENGINE OIL LVL SW 20 C468-C172 BU-18
22 21 J 256-3507 V 01 A-3 HARNESS AS. (FLOODLAMPS FR RH)
X974-C165 BR-18 125-C14 OR-18 10A 10A 132-C344 RD-18 201-C65 BK-18 CAB GROUND 2 21
CIGAR LIGHTER CENTER DASH INDICATOR PANEL 251-C67 BK-18 LOCATION CODE 2 22 201-C120 BK-18 201-C133 BK-18 2 2 K 256-3507 V 01 L-3 HARNESS AS. (FLOODLAMPS FR LH)
A273-C119 BK-18 23 1 1

L 256-3508 V 01 A-18 HARNESS AS. (FLOODLAMPS RR RH)

A274-C275 BK-18 8V SENSOR SUPPLY 24 T800-C173 OR-18 M 256-3508 V 01 L-18 HARNESS AS. (FLOODLAMPS RR LH)
20 19
138-C20 GN-18
118-C202 GY-14

962-C320 OR-18
10A 10A 25

962-C30 OR-18
SPARE PAYLOAD CONTROL SYSTEM 26
N 256-3566 V 00 C-5 HARNESS AS. (VARIABLE SHIFT CONTROL JUMPER)
27 P 156-5537 - 00 H-3 CABLE AS. (WHEEL GP STEERING)
18 17
118-C237 GY-18 10A 10A 113-C245 OR-18 28 R 256-3505 V 00 L-14 HARNESS AS. (HVAC TO CAB)
118-C202 GY-14 FRONT WIPER/WASH EMS ECM/(QUAD GAGE/SPD/TACH BACKLIGHTS) 113-C262 OR-18 XSMN OIL LVL SW 29 425-C175 PK-18
T 146-1892 - 01 G-2 HARNESS AS. (LH PEDAL STOP LAMP SWITCH)
16 15 164-C231 WH-18 30
10A 10A 164-C281 WH-18 LOCATION CODE 1 31 201-C132 BK-18 W 121-8039 - 01 H-1 HARNESS AS. (DIMMER SWITCH)
SPARE TRANSMISSION ECM/LH BRAKE PEDAL SENSOR 164-C280 WH-18 32
33
14 13
10A 10A 133-C343 OR-18 34
SPARE LH/RH DASH INDICATOR PANELS 133-C285 OR-18 35 THIS DIAGRAM IS FOR THE:
36
12 11
104-C222 YL-18 10A 10A 131-C266 BR-18 37 980GII UMA
104-C260 YL-18 MSS/PRODUCT LINK TURN SIGNALS/(FWD/REAR FLOOD RELAYS) 131-C84 BR-18 38
39 200-C111 BK-12
10 9
1 2

10A
SPARE
20A
FWD & SIDE CAB FLOODLAMPS
127-C267 OR-12 40 200-C106 BK-18
200-C105 BK-18
WHEEL LOADER CAB
EMS III-II

X615-C433 YL-14
X615-C434 YL-14

E735-C284 PU-18

C413-C251 YL-18
C414-C244 BU-18

E701-C256 PK-18
E702-C255 OR-18
E707-C250 GN-18
E708-C247 PK-18
614-C371 PU-18
113-C245 OR-18
118-C202 GY-14
124-C439 GN-14

139-C277 OR-18
200-C316 BK-18
200-C313 BK-18
201-C205 BK-18

291-C100 BK-18
410-C242 WH-18

646-C207 OR-18
647-C236 GN-18

H766-C19 YL-18
944-C143 OR-18
945-C137 BR-18
962-C320 OR-18

411-C243 PK-18

500-C252 BR-18
501-C257 GN-18
502-C253 OR-18
610-C369 OR-14
614-C370 PU-18
126-C37 PK-18
131-C84 BR-18

290-C16 BK-18
8 7 154-7443
E452-C166 WH-18

C468-C172 BU-18

A497-C170 YL-18

A523-C186 PU-18
A524-C188 BR-18
A525-C258 GN-18
C547-C441 OR-14

H728-C198 GN-18

H730-C163 BR-18
G766-C154 GN-18
G767-C155 WH-18
T800-C173 OR-18
K933-C226 GN-18

X972-C153 GN-18
X973-C157 BU-18

X974-C165 BR-18

X615-C434 YL-14

X615-C434 YL-14
150-C126 OR-18
201-C133 BK-18
403-C123 GN-18
425-C175 PK-18

E455-C12 BR-18

G485-C55 BU-18
G486-C56 GN-18

515-C181 GY-14
516-C182 GN-14
517-C183 BU-14
521-C124 YL-18

720-C164 PU-18

H729-C62 WH-18

973-C160 BR-18

977-C162 YL-18

122-C225 RD-18
122-C240 RD-18
608-C421 GN-14
615-C217 YL-14

615-C217 YL-14

608-C421 GN-14
122-C240 RD-18
122-C225 RD-18

200-C424 BK-14
200-C106 BK-18
200-C105 BK-18

200-C427 BK-14
254-2138 CHG 02
10A 10A
102-C69 BU-14

426-C85 BR-18

443-C18 YL-18
447-C64 PK-18

506-C10 PU-18

614-C94 PU-18
617-C83 BR-18

962-C30 OR-18
432-C6 PK-18
442-C7 GY-18

496-C9 WH-18

ENGINE ECM ADEMIII SPARE

UPPER CAB GROUND
6 5
123-C95 WH-18 10A 15A 134-C268 YL-14
1
2

200-C426 BK-14 AXLE OIL COOLERS REAR CAB/REAR MACHINE FLOODLAMPS WITH PILOT CONTROLLED IMPLEMENTS
608-C423 GN-14 ENGINE SHUTDOWN ALARM
HMU STEERING AND
2
1

122-C240 RD-18 4 3 3E-6328 C-C40

10A 10A 129-C71 BU-18
200-C106 BK-18 SPARE ETHER INJECTION 1552269 ELECTRONIC ENGINE CONTROL
RH DOME LAMP
GN-14
BK-14
BK-14

GN-14

C-C18
PK 1 A487-C147 PU-18
3E-6389 2 1
1552267 126-C37 PK-18 10A 10A 142-C26 BU-18 BK 2 201-C117 BK-18 200-C430 BK-14
NEUTRAL OVERRIDE/GEAR SELECT 4TH FUNCTION/GRAPPLE 615-C420 YL-14
DESIGN CONTROL V187
608-C422
200-C425
200-C424

608-C421

122-C225 RD-18 A RD-16

X615-C436 YL-14
A 200-C105 BK-18
C
B
WH-16
BK-16
C-C30
1886253
SWITCHED BUS
112-C1 PU-4 J-C1
1552269
COMPONENTS ARE SHOWN INSTALLED ON A FULLY
A
FUSE PART NUMBERS 112-C270 PU-14 124-C239 GN-14 124-C439 GN-14 PANEL B 615-J6 YL-14 1 FLOOD LAMP FRONT RH 1
1

OPERABLE MACHINE WITH THE KEY AND ENGINE OFF

1

2
1

15A
10 AMP (9W-1442) 124-C440 GN-14 CHASSIS, TRANSMISSION ECM 200-J2 BK-14 2 219-6485
15 AMP (9W-1441) HVAC BREAKER HVAC UNIT, UPPER CAB AND XMSN SHIFTER IN NEUTRAL
20 AMP (9W-1446) 6T-3643 FUSE PANEL/ELECTRICAL CAB FORWARD AND 615-C217 YL-14 1
2

C-C96 J-C4 J-C2

INSTALLATION AND CAB GROUND SIDE FLOODLAMPS 1134630 1552272 1552269
112-C3 PU-14 108-C8 BU-14 200-C427 BK-14 615-C419 YL-14 1 615-J5 YL-14 615-J7 YL-14 1 FLOOD LAMP FRONT RH 2
DASHED FONT INDICATES AN ATTACHMENT COMPONENT OR HARNESS
1

NOTE A: WIRE 135-E10 IS ADDED TO CONNECTOR AE-C1

1

1 2 1 2

15A
DASH 200-C428 BK-14 2 200-J1 BK-14 1
2

200-J3 BK-14 2 219-6485

L-C1 L-C2 C-C98 SEAT BREAKER X615-C434 YL-14 1 2

3 X615-J8 YL-14
1552269 1552272 1134630 6T-3643 200-C429 BK-14 4 200-J4 BK-14
608-L1 GN-14 608-C422 GN-14
J-C3
FOR CHASSIS/ENGINE DIAGRAM SEE:
1 1
X615-C435 YL-14 CONN 20 1552269
2 200-L2 BK-14 2 200-C425 BK-14 FUSE PANEL/ELECTRICAL INSTALLATION CAB DOME LAMPS/ 1 FLOOD LAMP SIDE RH 257-0134
3
REAR FLOODLAMPS 2 219-6487
FLOOD LAMP REAR RH 4
219-6485
CONN 6

18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1