Cat Electronic Technician 2019A v1.

0
Product Status Report

18/06/2024 14:15

Product Status Report

Parameter Value
Engine Serial Number ZAP01240
Equipment ID MOTOR 07
Comments

3516B Engine - Genset #1 (ZAP01240)

Parameter Value
Equipment ID MOTOR 07
Engine Serial Number ZAP01240
ECM Serial Number 27386381JP
Personality Module Part Number 3489832-00
Personality Module Release Date JUN09
Personality Module Description GENSET

Logged Diagnostic Codes [Diagnostic Clock = 6249 hours] - 3516B Engine - Genset #1
(ZAP01240)
Code Description Occ. First Last
91- 8 Throttle Position Sensor : Abnormal Frequency, 1 6249 6249
Pulse Width, or Period
247- 9 SAE J1939 Data Link : Abnormal Update Rate 1 6249 6249

Logged Event Codes [Diagnostic Clock = 6249 hours] - 3516B Engine - Genset #1 (ZAP01240)
Code Description Occ. First Last
No Logged
Event Codes

Active Diagnostic Codes - 3516B Engine - Genset #1 (ZAP01240)

Code Description
247- 9 SAE J1939 Data Link : Abnormal Update Rate

Active Event Codes - 3516B Engine - Genset #1 (ZAP01240)

Code Description
No Active
Event Codes

Current Totals - 3516B Engine - Genset #1 (ZAP01240)

Description Value Unit
Total Time 6249 hours
Total Fuel 2205897 L
Configuration - 3516B Engine - Genset #1 (ZAP01240)
Description Value Unit
Equipment ID MOTOR 07
Engine Serial Number ZAP01240
ECM Serial Number 27386381JP
Personality Module Part Number 3489832-00
Personality Module Release Date JUN09
Rated Engine Speed 1800 rpm
Fuel Ratio Control Offset 0
Acceleration Delay Time 20 sec
Engine Acceleration Rate 130 rpm/s
Low Idle Speed 900 rpm
Cooldown Speed 900 rpm
Cooldown Duration 0 min
Engine Pre-Lube Duration 0 sec
Engine Pre-Lube System Configuration Automatic
Engine Continuous Pre-Lube Interval 0 min
Crank Duration 30 sec
Maximum Number of Crank Cycles 5
Crank Terminate RPM 400 rpm
Engine Speed Droop 4,0 %
Rated Fuel Position 20,800 mm
Fuel Correction Factor 0 %
Governor Gain Factor #1 26214
Governor Minimum Stability Factor #1 629
Governor Maximum Stability Factor #1 6248
FLS 0
FTS 0
Air Shutoff Enabled
Air Intake Shutoff Detection Installation Installed
Status
Ether Control Disabled
Engine Cooling System Config SCAC (Separate Circuit Aftercooled)
Cold Cylinder Cutout Disabled
Direct Fuel Control Mode Disabled
Desired Speed Input Configuration CAN Input
Throttle Air Pressure Sensor Installation Unavailable
Status
Throttle Input Low Idle Duty Cycle Setpoint Unavailable %
Throttle Input High Idle Duty Cycle Setpoint Unavailable %
Secondary Desired Speed Input Not Installed
Configuration
Fuel Enable Input Configuration CAN Input
Secondary Fuel Enable Input Enable Enabled
Status
Coolant Level Sensor Not Installed
Aftercooler Coolant Level Sensor Not Installed
Installation Status
Cat Data Link #2 Identifier Engine Control #1
Inlet Air Temperature Sensor Not Installed
Engine Oil Temperature Sensor Installation Installed
Status
Total Tattletale 31
Idle cyl cutout Off

Lifetime: Time vs Engine Speed - 3516B Engine - Genset #1 (ZAP01240)

Engine Speed( rpm ) hours %
<400,0 129229,80 1,04
400,0-499,0 1119940,25 9,05
500,0-599,0 128382,50 1,04
600,0-699,0 435112,44 3,52
700,0-799,0 364293,44 2,94
800,0-899,0 774252,38 6,26
900,0-999,0 1048172,38 8,47
1000,0-1099,0 483952,91 3,91
1100,0-1199,0 518458,81 4,19
1200,0-1299,0 1064409,38 8,60
1300,0-1399,0 1026104,38 8,29
1400,0-1499,0 949634,88 7,67
1500,0-1599,0 233148,41 1,88
1600,0-1699,0 276046,19 2,23
1700,0-1799,0 1193841,38 9,65
1800,0-1899,0 707392,63 5,72
1900,0-1999,0 1157135,50 9,35
>2000,0 767406,50 6,20

Lifetime: Time vs Engine Load Factor - 3516B Engine - Genset #1 (ZAP01240)

Engine Load Factor( % ) hours %
<5,0 677885,38 6,40
5,0-9,0 870401,38 8,22
10,0-14,0 1142560,25 10,79
15,0-19,0 726366,69 6,86
20,0-24,0 104708,95 0,99
25,0-29,0 33700,90 0,32
30,0-34,0 416395,41 3,93
35,0-39,0 212916,41 2,01
40,0-44,0 290502,34 2,74
45,0-49,0 189963,66 1,79
50,0-54,0 794356,88 7,50
55,0-59,0 914841,63 8,64
60,0-64,0 773402,56 7,30
65,0-69,0 638361,38 6,03
70,0-74,0 196666,25 1,86
75,0-79,0 759570,13 7,17
80,0-84,0 262041,25 2,47
85,0-89,0 221309,16 2,09
90,0-94,0 934403,00 8,82
95,0-99,0 415863,94 3,93
>100,0 16596,10 0,16

Lifetime: Time vs Right Exhaust Temperature - 3516B Engine - Genset #1 (ZAP01240)

Right Exhaust Temperature( hours %
Deg C )
<450,0 125135,30 0,86
450,0-464,0 998520,69 6,86
465,0-479,0 226751,00 1,56
480,0-494,0 676718,63 4,65
495,0-509,0 422775,66 2,91
510,0-524,0 927946,63 6,38
525,0-539,0 1023182,75 7,03
540,0-554,0 1014984,69 6,98
555,0-569,0 1064514,50 7,32
570,0-584,0 958346,38 6,59
585,0-599,0 484270,69 3,33
600,0-614,0 171211,25 1,18
615,0-629,0 521965,66 3,59
630,0-644,0 475990,56 3,27
645,0-659,0 1029798,38 7,08
660,0-674,0 1043413,81 7,17
675,0-689,0 909336,13 6,25
690,0-704,0 729694,63 5,02
705,0-719,0 315351,91 2,17
720,0-734,0 508907,34 3,50
735,0-749,0 511363,19 3,52
750,0-764,0 335619,75 2,31
>765,0 69393,55 0,48

Lifetime: Time vs Left Exhaust Temperature - 3516B Engine - Genset #1 (ZAP01240)

Left Exhaust Temperature( Deg hours %
C)
<450,0 1019858,13 6,83
450,0-464,0 464052,41 3,11
465,0-479,0 1120341,00 7,51
480,0-494,0 207977,34 1,39
495,0-509,0 962658,81 6,45
510,0-524,0 1148611,88 7,70
525,0-539,0 175309,16 1,17
540,0-554,0 910048,13 6,10
555,0-569,0 1118839,00 7,50
570,0-584,0 57031,90 0,38
585,0-599,0 1036619,13 6,95
600,0-614,0 437058,16 2,93
615,0-629,0 1104095,25 7,40
630,0-644,0 889159,38 5,96
645,0-659,0 303009,34 2,03
660,0-674,0 2185,90 0,01
675,0-689,0 395894,25 2,65
690,0-704,0 137619,55 0,92
705,0-719,0 652661,00 4,37
720,0-734,0 359737,34 2,41
735,0-749,0 865660,00 5,80
750,0-764,0 943845,88 6,32
>765,0 612464,19 4,10

Histogram - 3516B Engine - Genset #1 (ZAP01240)

Error retrieving Histogram data

Monitoring System - 3516B Engine - Genset #1 (ZAP01240)

Description State Trip Point Delay Time
Altitude (atmospheric
pressure)
Moderate Severity (2) On 92,5 kPa 0 sec
Engine Overspeed
Least Severe (1) On 2070 rpm 0 sec
Most Severe (3) On 2070 rpm 0 sec
High Aftercooler
Coolant Temperature
Least Severe (1) On 102 Deg C 5 sec
Moderate Severity (2) On 107 Deg C 5 sec
Most Severe (3) On 107 Deg C 5 sec
High Air Filter
Restriction Pressure
Least Severe (1) On 7,0 kPa 5 sec
Moderate Severity (2) On 7,0 kPa 5 sec
High Boost Pressure
Least Severe (1) Off 400,0 kPa 0 sec
Moderate Severity (2) Off 400,0 kPa 0 sec
High Crankcase
Pressure
Least Severe (1) On 2,0 kPa 3 sec
Moderate Severity (2) On 6,0 kPa 10 sec
Most Severe (3) On 3,5 kPa 3 sec
High Engine Coolant
Temperature
Least Severe (1) On 102 Deg C 5 sec
Moderate Severity (2) On 107 Deg C 30 sec
Most Severe (3) On 107 Deg C 5 sec
High Engine Oil Filter
Restriction Pressure
Least Severe (1) On 105 kPa 5 sec
High Exhaust
Temperature
Least Severe (1) On 600 Deg C 5 sec
Moderate Severity (2) On 750 Deg C 5 sec
High Fuel Filter
Restriction Pressure
Least Severe (1) On 105 kPa 5 sec
Low Aftercooler
Coolant Level
Least Severe (1) On None 30 sec
Most Severe (3) Off None 30 sec
Low Coolant Level
Least Severe (1) On None 30 sec
Most Severe (3) Off None 30 sec
Low Engine Coolant
Temperature
Least Severe (1) On 80 Deg C 5 sec
Low Engine Oil
Pressure
Least Severe (1) On None 4 sec
Most Severe (3) On None 9 sec
Low Fuel Pressure
Most Severe (3) On 220 kPa 20 sec
Low System Voltage
Least Severe (1) On 20 Volts 10 sec

Injector Codes Calibration - 3516B Engine - Genset #1 (ZAP01240)

Injector Code
Injector 1 2645
Injector 2 7620
Injector 3 5617
Injector 4 7512
Injector 5 5401
Injector 6 3752
Injector 7 5942
Injector 8 2655
Injector 9 2871
Injector 10 6302
Injector 11 7841
Injector 12 6506
Injector 13 2456
Injector 14 2785
Injector 15 1221
Injector 16 1219