WIRING DIAGRAM 290-4722 INTERCONNECT WIRING DIAGRAM 290-4722 INTERCONNECT FLEX06 WIRING DIAGRAM 290-4722 GOVERNOR CONNECTIONS WIRING

722 INTERCONNECT FLEX06 WIRING DIAGRAM 290-4722 GOVERNOR CONNECTIONS WIRING DIAGRAM 290-4722 REMOTE PANEL/PM3000 INTERCONNECT
EMTB MMS II/GMS EMTB MMS II/GMS REMOTE RELAY PANEL #1,
1 16 AWG 1 REMOTE I/O ADAPTER CONNECTIONS
24VDC 1 300 16 AWG 0 C 28 0 A D E M G OV E RN O R FO R MA RI N E P R O P U L S IO N (OUTPUTS 1-32)
CH 0-RTDH
2 2 EXAMPLE ONLY DIP SWITCHES 1794-ASB KENR6320
16 AWG LUBE OIL 3 301 16 AWG 17 MMS II CUSTOMER
BATTERY COM TEMPERATURE CH 0-RTN 1 2 3 4 5 6 7 8
E MTB C IP / G M S C O N N E C TI ON S
1A 16 AWG 1A (TO) 2 302 16 AWG 1 O July 2007
CH 0-RTDL (24V POWER) 1 C3, PIN A 1 (REQUIRED 14GWA) SINGLE REMOTE RELAY SWITCH 1 N
1B 16 AWG 1B SH (24V POWER RETURN) 2 C3, PIN B 2 (REQUIRED 14GWA) PANEL (179-8813) L1 SH L2
REMOTE SHUTDOWN TBX28 C1, PIN 36 150A 24VDC
AIR SHUTOFF OUT 85 C1, PIN 11 85 POWER SUPPLY 1 2 3 4 5 6 7 8
1D 16 AWG 1D 1 303 16 AWG 2 RIO ADAPTER
INLET AIR CH 1-RTDH J1939 DATA + TBX13 C1, PIN 17 604 O
MANIFOLD J1939 DATA - TBX14 C1, PIN 18 605 1794-ASB SWITCH 2
SH G 3 304 16 AWG 19 N
16 AWG BOOST CH 1-RTN GENERAL ALARM COMMON 1B C1, PIN 13 18 IF REMOTE RELAY PANEL(S) OR
IPSV TEMPERATURE 2 305 16 AWG 3 GENERAL ALARM N/O 219 C1, PIN 15 219 PM3000 IS USED, THE
73 16 AWG 73 RTD (TBST) CH 1-RTDL KEY SWITCH INPUT 80 C1, PIN 30 80 RESISTOR IS TO BE MOVED
LOCAL SPEED POT 1 TBX37 C1, PIN 33 606 FROM TERMINALS 500 AND 502
2 1 306 16 AWG LOCAL SPEED POT 2 TBX39 C1, PIN 34 607 IN THE MMSII PANEL TO THE
4 LOCAL SPEED POT 3 TBX38 C1, PIN 35 608
CH 2-RTDH LAST DEVICE. REMOTE RELAY PANEL #2,
ASSV FUEL TO REMOTE/LOCAL SWITCH TBX16 C1, PIN 31 601 (OUTPUTS 33-64)
3 307 16 AWG 21
75 16 AWG 75 ENGINE CH 2-RTN BACKUP ACTIVE LAMP TBX45 C1, PIN 27 610 500 DIP SWITCHES 1794-ASB
TEMPERATURE BACKUP READY LAMP TBX46 OR C1, PIN 28 609
2 308 16 AWG 5 1 2 3 4 5 6 7 8
2 RTD (TF) CH 2-RTDL PRIMARY THROTTLE (PWM) TBX12 C1, PIN 10 (REQUIRED)
THROTTLE 4-20mA- TBX40 501 O
C1, PIN 39 (OPTIONAL) MMSII
ASOS SH THROTTLE 4-20mA+ TBX41 C1, PIN 40 (OPTIONAL)
SWITCH 1 N
PANEL
82 16 AWG 82 DIAGNOSTIC LAMP - PRI TBX06 C1, PIN 24 (OPTIONAL)
1 309 16 AWG 6 502
DIAGNOSTIC LAMP - SEC TBX18 C1, PIN 23 (OPTIONAL)
JACKET WATER CH 3-RTDH LOAD FEEDBACK + TBX36 C1, PIN 26 (OPTIONAL) 1 2 3 4 5 6 7 8
2
OUTLET 3 310 16 AWG 23 LOAD FEEDBACK - TBX35 C1, PIN 25 (OPTIONAL)
CH 3-RTN O
FSOS TEMPERATURE SHUTDOWN NOTIFY RELAY COMMON TBX31 C1, PIN 19 (OPTIONAL) SWITCH 2 N
85 ALARM RTD 2 311 16 AWG 7
CH 3-RTDL SHUTDOWN NOTIFY RELAY N/O TBX32 C1, PIN 20 (OPTIONAL)
(TJWO) SHUTDOWN NOTIFY RELAY N/C TBX33 C1, PIN 21 (OPTIONAL)
2 GLOBAL THROTTLE SELECT TBX26 C1, PIN 37 (OPTIONAL)
1 312 16 AWG 8 DUAL DYNAMIC SELECT TBX27 C1, PIN 38 (OPTIONAL)
COMP. BYPASS CH 4-RTDH GLOBAL (PWM) THROTTLE TBX21 C1, PIN 29 (OPTIONAL) DUAL REMOTE RELAY PANEL (179-8813) WIRING DIAGRAM 290-4722 - TABLE OF
452 16 AWG 452 AC/OC WATER 3 313 16 AWG 25
INLET CH 4-RTN TERMINAL BOARD NUMBERS AND LINE NUMBERS
IF REMOTE RELAY PANEL(S)
TEMPERATURE 2 314 16 AWG 9 L1 SH L2 OR PM3000 IS USED, THE L1 SH L2
SEE THE OTHER SIDE OF THIS SHEET
2 RTD (TAIO) CH 4-RTDL
C 28 0 A D E M G OV E R NO R FO R M A R I N E A U X IL IA RY RESISTOR IS TO BE MOVED TB # LINE # TB # LINE # TB # LINE # TB # LINE #
SH FROM TERMINALS 500 AND
OPLS2 92 MMS II CUSTOMER 502 IN THE MMSII PANEL TO G 313 101 508 164B 1172 251 817
1 3 92 16 AWG EMTB CIP THE LAST DEVICE.
1 315 16 AWG 10 / G M S C O N N E C TI ON S GND 300 102 508 164C 1170 253 810
2 JACKET WATER CH 5-RTDH
101 16 AWG 101 (24V POWER) 1 C3, PIN A 1 SH 344 102A 1161 165 648 254 862
OUTLET 3 316 16 AWG 27
TEMPERATURE CH 5-RTN (24V POWER RETURN) 2 C3, PIN B 2 1 300 102B 1165 167 720 255 856
93 16 AWG 93 SHUTDOWN RTD 2 317 16 AWG 11 START/STOP INPUT TBX34 C1, PIN 36 150B COM 2 300 102C 1163 168 726 256 870
CH 5-RTDL AIR SHUTOFF OUT 85 C1, PIN 11 85 500
(TJWO2) 3 320 103 514 169 720 257 873
OPLS1 J1939 DATA + TBX13 C1, PIN 17 604
1 3 103 16 AWG 103 J1939 DATA - TBX14 C1, PIN 18 605 1A 306 104 520 173 430 257A 1175
318 16 AWG 12 OR 501 1B 520 257B
2 CH 6-RTDH GENERAL ALARM COMMON 1B C1, PIN 13 1B MMSII 310 105 174 436 1179
104 16 AWG 104 AUXILIARY #1 319 16 AWG 29 GENERAL ALARM N/O 219 C1, PIN 15 219 PANEL 1C 341 105A 1161 175 430 257C 1177
TEMPERATURE CH 6-RTN LOW IDLE TBX22 C1, PIN 28 250 24V 502 1D 323 105B 1165 200 400 258A 1168
91 16 AWG 91 CUSTOMER 320 16 AWG 13 KEY SWITCH INPUT 80 C1, PIN 30 80 1E 315 105C 1163 201 400 258B 1172
SUPPLIED CH 6-RTDL THROTTLE (PWM) TBX12 C1, PIN 10 (REQUIRED)
DROOP INPUT (PWM) TBX21 C1, PIN 27 (OPTIONAL) 14A 1188 106 507 202 602 258C 1170
CPHSS SH ECM DIAGNOSTIC LAMP TBX18 C1, PIN 24 (OPTIONAL) 14B 1192 107 529 203 741 259 834
1 3 110 16 AWG 110 F
LOAD FEEDBACK + TBX36 C1, PIN 26 (OPTIONAL) 14C 1190 107A 1168 204 705 260 837
2 321 16 AWG 14 LOAD FEEDBACK - TBX35 C1, PIN 25 (OPTIONAL) 30A 1151 107B 1172 205 708 262 865
111 16 AWG 111 CH 7-RTDH SHUTDOWN NOTIFY RELAY COMMON TBX31 C1, PIN 19 (OPTIONAL)
AUXILIARY #2 322 16 AWG 31 PM3000 30C 1151 107C 1170 205A 1194 452 746
TEMPERATURE CH 7-RTN SHUTDOWN NOTIFY RELAY N/O TBX32 C1, PIN 20 (OPTIONAL) D E G
90 16 AWG 90 SHUTDOWN NOTIFY RELAY N/C TBX33 C1, PIN 21 (OPTIONAL) 55A 1181 108 529 205B 1199 500 329
CUSTOMER 323 16 AWG L1 SH L2
15 DIRECT RACK + (0-200mA) TBJ1 C1, PIN39 55B 1186 109 538 205C 1196 501 328
SUPPLIED CH 7-RTDL
ASPLA DIRECT RACK - (0-200mA) TBJ2 C1, PIN40 55C 1183 109A 1154 208 980 502 326
1 3 211 16 AWG 211 56A 1175 109B 1158 209 983 511 1040
BL CL
1B
FLEX05
MMS II/GMS
C280 56B 1179 109C 1156 210 952 512 1036
1 330 16 AWG 0 SHIELD 56C 1177 110 538 210A 1194 513 1039
GENERATOR CH 0-RTDH IF REMOTE RELAY PANEL(S) OR 57A 1181 111 543 210B 1199 514 1041
JWPLA NON DRIVE-END 3 331 16 AWG 17 PM3000 IS USED, THE
1 3 212 16 AWG 212 BEARING CH 0-RTN 57B 1186 113 449 210C 1196 515 1044
RESISTOR IS TO BE MOVED Marine Monitoring System II 944
TEMPERATURE 2 332 16 AWG 1 57C 1183 114 211 955
CH 0-RTDL FROM TERMINALS 500 AND 502
1B RTD (TGNDEB) IN THE MMSII PANEL TO THE 67 617 115 845 211A 1154
SH CONNECTION TO CONNECTION TO 500 LAST DEVICE. 68 620 116 846 211B 1158
AWPLA 69 625 140 1013 211C 1156
1 3 213 16 AWG 213
1 333 16 AWG 2 Electrical System 70 635 141 1016 212 957
GENERATOR CH 1-RTDH LINE 1 BLUE D COMMON INPUT 501
1B MMSII 71 632 142 1019 212A 1161
DRIVE-END 3 334 16 AWG 19
BEARING CH 1-RTN PANEL 72 632 146 607 212B 1165
SHIELD SHIELD E 24 VDC IN
1 OLLA 3 210 16 AWG 210 TEMPERATURE 2 335 16 AWG 3 502 73 714 147 611 212C 1163
RTD (TGDEB) CH 1-RTDL LINE 2 CLEAR F COMMON OUT 74 620 148 607 213 960
2
G 24 VDC OUT
PKA1-UP 75 620 149 614 214 963
1B 1 336 16 AWG 4 80 511 150 607 215 966
CH 2-RTDH
PDA GENERATOR 3 81 438 150A 1188 216 969
214 214 STATOR A 337 16 AWG 21 MMS PANEL GROUP 264-9888 - DOOR, BACK PLATE & MATERIAL LIST NKB1-UP
16 AWG CH 2-RTN 82 723 150B 1192 217 971
TEMPERATURE 2 338 5
RTD (TGSA) 16 AWG 82A 720 150C 1190 218 974
1B CH 2-RTDL SCB1-UP 82B 726 151 620 219 977
ASPSU SH 83 441 151A 824 220 841
84 444 151B 827 221 840
1 339 16 AWG 6 17
TSJ1-UP
2 CH 3-RTDH 5 7 8 15 85 438 151C 824 222 1222
GENERATOR 27 14 24 25 86 444 152 626 223 1223
3 340 16 AWG 23 6 1 1 4 1
203 16 AWG 203 STATOR B CH 3-RTN 1 DOOR FRONT VIEW 1 29 24 25 DOOR REAR VIEW 1 1 86A 1175 153 626 230 1214
TEMPERATURE 2 341 16 AWG 7 264-9888 MATERIAL LIST LDL1-UP
1 1 1 86B 1179 153A 1154 231 1216
RTD (TGSB) CH 3-RTDL N
202 16 AWG 202 O MEAS 86C 1177 153B 1158 233 1205
T PART NO. NAME 87 547 153C 1156 234 1207
JWDS ITEM QTY UNIT RDW1-UP
1 342 16 AWG 8 E
CH 4-RTDH 88 549 161 638 235 991
2 S - 3 2 GENERATOR PARTS LIST
3 343 16 AWG 25 28 90 501 162 642 236 994
STATOR C CH 4-RTN 1 4 PC 1H-4393 LOCKWASHER-#8 NDT1-UP
TEMPERATURE 91 517 163 642 248 807
1 + T 4 2 344 16 AWG 9 1 2 4 PC 4B-4863 WASHER
RTD (TGSC) CH 4-RTDL G G 92 501 164 645 249 818
90 90 12 26 3 1 PC 4W-5972 KNOB 93 505 164A 1168 250 807
16 AWG SH TDX1-UP
BACKUP OK BACKUP BERL BEAL 4 4 PC 5M-6668 SCREW-MACHINE
ECM READY ECM ACTIVE 1 1
72 16 AWG 72 5 6 PC 8T-8730 SOCKET-CONNECTOR
SOS FLEX00 6 1 PC 127-9069 POTENTIOMETER
2 EMTB MMS II/GMS 7 1 PC 155-2259 WEDGE-PLUG LOCK
SUMMARY 8 1 PC 155-2264 PLUG AS-CONN
17 400 K TYPE + 0 CH0 ENGINE SPEED SHUTDOWN
+ TEMLR 9 2 PC 162-0568 SWITCH
OR 18 401 K TYPE -1 R
70 70 TEMLF SSL
10 2 PC 162-0575 LATCH-MOUNTING
16 AWG SUMMARY
RPM ALARM 11 2 PC 162-0577 BLOCK-CONTACT
CUST. SHUTDOWN SH A 12 1 PC 168-4672 MODULE
108 16 AWG 108 SAL 13 1 PC 194-7775 PLATE
CONTROL TM
+2 FAILURE 14 1 PC 228-7424 DISPLAY GP-ELEK
21 402 K TYPE CH1 STARTING
90 TESLR AIR PRESSURE A 15 8 PC 250-6853 NUT-CLINCH
CONNECT TO OR 22 403 K TYPE -3 160 PLCFL
80 250 16 1 PC 285-4092 FILM-CTRL PANEL
0 10 350
TESLF 5 15
20 SPEED SWITCH
0 BAR 25
TB-91 FOR FAILURE
OR 17 1 PC 264-3571 DOOR AS-CUTOUT
91 TIME DELAY 1 404 K TYPE A ASPG
+ 4 CH2 18 2 PC 9X-9675 BRACKET-END
SFL
TEP1 -5 ENGINE HOURS ENGINE 19 1 PC 134-2540 RECEPTACLE AS
OVR 2 405 K TYPE 6T7337
PRELUBE
20 3 PC 144-0436 MARKER-TERMNAL
(CUST. SUPPLIED) SERVICE METER
G 16
204 16 AWG 204 HOURS 1/
10
000000
SOL 21 1 PC 252-4943 COVER-END
SH 22 9 PC 252-4949 TERMINAL-BLOCK
1
1A HM A 23 1 PC 264-9887 WIRING GP
1 406 K TYPE + 6 CH3 24 2 PC 162-0600 LENS-GREEN
BARRING DEVICE 25 2 PC 162-0601 LIGHT AS
69 69 TEP2 2 407 K TYPE -7
16 AWG
LOCAL GOVERNOR 26 1 PC 281-4819 SOFTWARE GP
RUN
OFF/ REMOTE IDLE RATED
EMERGENCY STOP RESET PRELUBE START 27 1 PC 204-5628 FILM-CTRL PANEL
(OPTIONAL) 3 408 K TYPE + 8 CH4 SPEED CONTROL
2 28 1 PC 204-5629 FILM-CTRL PANEL
9 10 11
TEP3 4 409 -9 DECREASE INCREASE IRS PSS ECS 29 1 PC 285-4093 FILM-LAMP
K TYPE FUEL GOVERNOR
CONTROL CONTROL 1 1 1
AIR DOOR CLOSED HORN LAMP LOCAL REMOTE
OFF ON SILENCE TEST SCS
114 16 AWG 114 ES
MISC REF
SH © 2007 Caterpillar Printed in U.S.A.
(OPTIONAL) LRS SLS FCS
B - 1 PC 281-5769 SOFTWARE GP
1B 3 410 K TYPE + 10 3 6 All Rights Reserved
80 TEP4 4 411 K TYPE - 11 CH5 1 1
80 16 AWG

85 16 AWG 85 5 412 K TYPE + 12 CH6

GAR 9 10 11
219 16 AWG 219 TEP5 6 413 K TYPE - 13
1 1 1
1B 1 2
SH
4 4

(OPTIONAL) 5 414 K TYPE + 14 CH7 4 13 15

TEP6 6 415 K TYPE - 15 4 1 4
EGBBM
F G 254 16 AWG 254
FLEX01 HINGE SIDE
255 16 AWG 253 EMTB MMS II/GMS
7 416 K TYPE + 0 CH0
1A 1A
TEP7 8 417 K TYPE -1 MMS PANEL GROUP 264-9888 - GOVERNOR SCHEMATIC
MODE 400 1A 2 80
BBMS SH
256 16 AWG 256 401

7 418 K TYPE 402 RMARX

257 257
+ 2 CH1 249 248 250
16 AWG 11 12 R13 IRS R14
TEP8 8 419 K TYPE -3 403 IDLE/RATED
IDLE RATED
(OPTIONAL) 404
A 1A 9 420 K TYPE + 4 CH2
405 REMOTE
MPU (A) 200 200 TEP9 10 421 K TYPE -5
C 16 AWG (CUSTOMER SUPPLIED)
ESS 406 R13 LRS R14 601 RMARX
ENGINE MPU LOCAL/REMOTE 253
B 201 16 AWG 201 SH 407 11 14 R13 IRS R14 250
SPEED SWITCH
SH 408
9 422 K TYPE + 6 CH3
MPU (B) 409
TEP10 10 423 K TYPE -7 151C FCRX 151A
222 16 AWG 222 410 21 24 ENERGIZED FOR
S
PLC 11 424 K TYPE FUEL OFF
+ 8 CH4 411
ENGINE 223 223
SPEED C 16 AWG TEP11 12 425 K TYPE -9 412
FCRX 151B
SH 413 21 22 ENERGIZED FOR
SH
OPTIONAL FOR 414 4 5 FUEL ON
NAPIER TURBO 603
1B 11 426 K TYPE + 10 415 3 6
604
MPU (E) TEP12 - 11 CH5 2 7 J1939 DATA LINK
12 427 K TYPE 416 247 150 150A
605 2 R11 R14 REMOTE
TURBO 230 16 AWG 230 1 8
S 417 SHUTDOWN
SPEED 17 428 K TYPE + 12 CH6
LEFT TEMRR
231 16 AWG 231 OR 18 429 K TYPE - 13 418
(INLINE) C
(OPTIONAL) TEMRF
419 150B
SH SH R11 R12
420
OPTIONAL FOR
NAPIER TURBO + 14 421
1B 21 430 K TYPE
TESRR
MPU (F) OR - 15 CH7 422
22 431 K TYPE
TESRF A
TURBO 233 16 AWG 233 423
S
SPEED
RIGHT FLEX02 424 TERMINATING
(VEE ONLY) 234 16 AWG 234 EMTB MMS II/GMS RESISTOR
C 425
(OPTIONAL) 13 432 K TYPE +0 B
SH 426
TEP13 14 433 K TYPE - 1 CH0
427
OMDR
5 4 235 16 AWG 235 SH 428
429
13 434 K TYPE + 2 CH1
430
OMDS TEP14 14 435 K TYPE -3
8 7 236 16 AWG 236 ENCLOSURE BACK PLATE 431
15 436 K TYPE + 4 CH2
432 606
OIL MIST
DETECTOR TEP15 16 437 K TYPE -5 1
433

+
- 2 AMCI 2 K OHM 2 607
1 2 434 LOCAL THROTTLE TRIM POT
SH POTENTIOMETER
(OPTIONAL) 80 435
FLEX07 3 608
15 438 K TYPE + 6 CH3 436
1 1D 35
LUBE OIL P +24 VDC TEP16 16 439 K TYPE -7 437
PRESSURE TO 2 361 16 AWG 0
I +I IN 0 438
ENGINE (POE)
ECP
SH CUSTOMER SUPPLIED MMS II/GMS 439
(Dimensions: 39 inches x 28 inches)

ES (REMOTE) 440
16 AWG 84 BERL
INLET AIR 1 1D 37 441
MANIFOLD P +24 VDC - + 609
16 AWG 113 442 BACKUP ECM READY LAMP
(BOOST) 2 362 2
I +I IN 1
PRESSURE 1 443
(PIAM) 16 AWG
363 16 AWG
444
WLLA 16 AWG 215
KENR6320

445
FUEL 1 1D 39
P +24 VDC 16 AWG 1B 446
PRESSURE 4
TO ENGINE I 2 365 16 AWG +I IN 2 447 BEAL
(PFE) SWPLA 16 AWG 216
448 - + 610
BACKUP ECM ACTIVE LAMP
SH
16 AWG 1B 449

41 IRS
1 1D 16 AWG 250
LUBE OIL P +24 VDC
PRESSURE TO 2 367 16 AWG 6 REMOTE
FILTER (POF) I +I IN 3 16 AWG 249

1D 43 AUX. ALARM 1 217

1 16 AWG
FUEL P +24 VDC
PRESSURE TO 2 369 16 AWG 8
I +I IN 4 16 AWG 1B
FILTER (PFF)

SH AUX. ALARM 2 218

16 AWG
30 Page, B&W

16 AWG 1B
CUSTOMER SUPPLIED 1D 47 +24 VDC
4-20 mA INPUT OR AUX. SHUTDOWN 1 208
1-10 VDC INPUT 373 16 AWG 12 +I IN 6 16 AWG
AUXILIARY #1(AAI1)
16 AWG 13 16 AWG 1B
SH +V
16 AWG 30 -V AUX. SHUTDOWN 2 209
16 AWG
CUSTOMER SUPPLIED 1D 49 +24 VDC 16 AWG 1B
4-20 mA INPUT OR
1-10 VDC INPUT 375 16 AWG 14 +I IN 7 HB
AUXILIARY #2(AAI2)
16 AWG 15 +V 16 AWG 2
CONNECT TO TERMINALS 32
12 OR 14 16 AWG -V
FOR 4-20 mA CURRENT (OPTIONAL)
CONNECT TO TERMINALS FLEX03 16 AWG 205
13, 30 OR 15, 32 MMS II/GMS
FOR 2-10 VDC
FLEX04
1 1D 35 CUSTOMER SUPPLIED MMS II/GMS
RAW/SEA WATER +24 VDC SEE LOCAL NOTE
P LINE 1456 TO
PRESSURE (PSW) 16 AWG 0 PROGRAMMABLE ANALOG OUTPUT 1
I 2 381 +I IN 0 LINE 1447
(OPTIONAL) (FOR CUSTOMER USE) 2 (V)
SH
16 AWG
1 1D 37 + - 0 (I)
AC/OC PUMP P +24 VDC CH0
PRESSURE (PAOP) 2 383 16 AWG 2
I +I IN 1 16 AWG 1 (C) MMS PANEL GROUP 264-9888
(OPTIONAL)
1 1D 39 18 20 21 SWITCH CONTACT STATUS
AIR START P +24 VDC PROGRAMMABLE ANALOG OUTPUT 2 2 3 1
PRESSURE (PSA) 2 385 16 AWG 4 (FOR CUSTOMER USE) 6 (V)
I +I IN 2 SWITCH CONTACT STATUS
(OPTIONAL) 16 AWG 22 23
SH IDLE/RATED SWITCH (IRS) NOTES
+ - 4 (I) CH1 9 1
1 1D 41 NOTE A: FOR TERMINATING RESISTOR INSTALLATION.
P +24 VDC CONTACT CONTACTS IDLE RATED LINE
JW PRESSURE 6 16 AWG 5 (C)
(PJW) (OPTIONAL) I 2 387 16 AWG BLOCKS NO. NOTE B: SOFTWARE FOR REMOTE DISPLAY.
+I IN 3 19
8 R13 R14
RIGHT X O 402
1 UNLESS OTHERWISE SPECIFIED, RECOMMENDED STANDARD
PROGRAMMABLE ANALOG OUTPUT 3 B A 601 601
(FOR CUSTOMER USE) 10 (V) SCHEMATIC INDICATES STATES OF IRS CONTACTS IN WIRE SIZE IS 16 AWG ENGINE, 18 AWG MMS PANEL.
602 602
16 AWG 603 603 THE IDLE POSITION.
+ - 8 (I) CH2 C 604 604 SHIELD TWISTED PAIR WIRE SIZE IS 18 AWG MINIMUM.
605 605 LOCAL/REMOTE SWITCH (LRS)
ABREVIATION & SYMBOLS ARE DEFINED ON THE OTHER SIDE
16 AWG 9 (C) SH SH OF THIS SHEET.
606 606 CONTACT CONTACTS LOCAL REMOTE LINE
607 607 BLOCKS NO.
PROGRAMMABLE ANALOG OUTPUT 4 608 608 R13 R14
(FOR CUSTOMER USE) 14 (V) RIGHT X O 406
16 AWG SCHEMATIC INDICATES STATES OF LRS CONTACTS IN
+ - 12 (I) CH3 THE LOCAL POSITION.

16 AWG 13 (C) X INDICATES A CLOSED CONTACT

O INDICATES AN OPEN CONTACT

LEFT AND RIGHT SIDE OF SWITCH ARE

VIEWED FROM FRONT OF PANEL.
 KENR6320
30 Page, B&W, (Dimensions: 39 inches x 28 inches)

CIRCUIT SCHEMATIC TB-1A TB-2 1150 CB4 CB3 CB2 CB1 1400
(FOR USE WITH C280 ADEM GOVERNOR) 30A 30C 1401 TB-1D TB-3
800 LINE LINE 1151 11 14 14 11 11 14 14 11 1402 LINE LINE FLEX03
ENGINE CONTROL SWITCH (ECS) CIRCUIT BREAKERS STATUS 1399 1399
1 24 VDC 2 GND 750 750 1403
(12 AWG) 801 1152 1404 16 COM IN
300 CONTACT CONTACTS OFF/ LOCAL REMOTE LINE NO. IPR 153A SOSRX 211A
BLOCKS RESET 802 1153 11 14 21 24 1405 34 24V IN
CPHSR 109A
301 21 24
L11 L12 803 FCRX 1154 1406
O X X 510 150 150A
302 LBVAR 2 247 R11 R14 REMOTE SHUTDOWN
1 2 LOW BATTERY 804 1155 CRANKCASE 153C 211C ENGINE 1407
+ - VOLTAGE ALARM (MAR.PROP) 109C HIGH INTERMITTENT 1D 35
303 LEFT L23 L24 X O O 607 PRELUBED
RELAY 985 PRELUBING 1408 RAW/SEA WATER P +24 VDC
805 1156 PRESSURE 0
304 PRESSURE (PSW) I 381
L31 L32
SHUTDOWN IPR SOSRX 1409 (OPTIONAL) +I IN 0
O X X 620 806 FCRX 1157 153B 211B
305 150B CPHSR 109B 11 12 21 22
CB 1 CB1 R11 R12 START/STOP 1410
LINE LOAD 1A LINE 935 807 1158 21 22 SH
306 R11 R12 (MAR.AUX)
5A PLC02 IN 12 X X O 620
808 1159 1411
307 RIGHT 255 OPLS2R 102A PSCR1 212A
REMOVE JUMPER IF SEPARATE L11 IRS L12 ECM 1412 1 1D 37
R23 R24 O O X 606 809 1160 OPLS1R 21 24 11 14 +24 VDC
308 POWER SOURCE IS REQUIRED IDLE/RATED 105A AFTER COOLER/OIL COOLER P
21 24 1413 PUMP PRESSURE (PAOP) 2 383 2
CB2 SCHEMATIC INDICATES STATES OF ECS CONTACTS IN THE 810 1161 I +I IN 1
309 CB 2 1B (OPTIONAL)
LINE LOAD OFF POSITION. 102C LOW OIL 212C PROGRAMABLE 1414
24 VDC 24V COM 811 1162 PRESSURE SPEED CONTROL
310 5A 105C LOW OIL SHUTDOWN RELAY #1 1415
812 1163 PRESSURE
311 REMOVE JUMPER IF PLCPS PRELUBE / START SWITCH (PSS) SHUTDOWN (HIGH SPEED)
SEPARATE POWER 813 1164 (LOW SPEED) OPLS2R 102B PSCR1 212B 1416
POWER SUPPLY CONTACT CONTACTS PRELUBE 1D 39
312 SOURCE IS REQUIRED START LINE NO. OPLS1R 21 22 11 12 1
G BLOCKS RMARX 253 IRS 105B 1417 P +24 VDC
CHASSIS GND 814 R13 R14 250 1165 21 22 AIR START PRESSURE 4
313 11 14 I 2 385
LEFT L13 L14 X O O 629 1418 (PSA) (OPTIONAL) +I IN 2
815 REMOTE 1166
314 CB4 CSDR SFAR 258A
CB 4 (CUSTOMER SUPPLIED) 107A 1419
LINE LOAD 1E 816 1167 21 24 11 14 SH
315 24 VDC IN 24V COM IN RIGHT R13 R14 O O X 620 PLCFAR 164A
5A 11 14 1420
817 1168
316 SCHEMATIC INDICATES STATES OF PSS CONTACTS IN SPEED
POWER SUPPLY RMARX IRS 107C 258C FAILURE 1421 1 1D 41
THE CENTER POSITION. 818 1A 248 1169 CUSTOMER +24 VDC
11 12 R13 R14 250 ALARM JACKET WATER P
317 IDLE/RATED 164C PLC FAILURE SHUTDOWN 1422 PRESSURE (PJW) 2 387 6
819 1170 ALARM RELAY I
318 24 VDC OUT 24V COM OUT 249 IDLE RATED (OPTIONAL) +I IN 3
SILENCE/LAMP TEST SWITCH (SLS) CSDR SFAR 258B 1423
820 1171 107B
319 21 22 11 12
CONTACT CONTACTS SILENCE TEST LINE NO. PLCFAR 164B 1424
BLOCKS 821 1172 11 12
320 3
24 VDC FLEXASB0 24V COM 822 1173 1425
L13 L14 SSRX RMAR 257A 43
321 LEFT X O O 1025 86A
CTRX 21 24 11 14 1426 +24 VDC
(1794-ASB) 823 1174 56A 8
322 FCRX 11 14
1D RIGHT R13 R14 O O X 1028 1427 +I IN 4
824 151C 7 1175
323 L1 SH L2 249 21 24 151A 257C REMOTE
ENERGIZED FOR FUEL OFF 86C MODE 1428
825 1176 SUMMARY
324 RIGHT R23 R24 O O X 642 56C SHUTDOWN ACTIVE
ENGINE 1429
826 1177 RUNNING RELAY
325 SEE SHEET 25 SCHEMATIC INDICATES STATES OF ARS CONTACTS IN FCRX SSRX RMAR
21 22 151B 86B 257B 1430 45
FOR OPTIONAL THE CENTER POSITION. 827 1178 21 22 11 12 +24 VDC
326 502 REMOTE I/O ENERGIZED FOR FUEL ON CTRX 56B
11 12 1431 10 +I IN 5
828 1179
327 CONNECT TO
501 IDLE/RATED SWITCH (IRS) (OPTIONAL) CUSTOMER SIGNAL REQUIREMENT SAR 55A 1432
829 1180
328 (OPTIONAL) CTRX 11 14
CONTACT LINE 57A 1433
500 CONTACTS IDLE RATED 830 1181 21 24
329 BLOCKS NO.
150 OHM 1434
BELDEN 9463 831
606 1182 55C SUMMARY
330 REMOVE JUMPER IF RIGHT R13 R14 X O 807 ALARM
SEPARATE POWER 832 2K OHM POTENTIOMETER 1183 57C 1435
331 (C280 MARINE PROPULSION) ENGINE
SOURCE IS REQUIRED SCHEMATIC INDICATES STATES OF IRS CONTACTS IN RUNNING 1436
PLC01 THE IDLE POSITION. 833 (LOAD SPEED CONTROL) 1 1184 SAR
332 55B
RI/O 2 607 CTRX 11 12 1437
834 10K OHM POTENTIOMETER SPEED TRIM 1185 57B
333 (1747-SN) (C280 MARINE AUXILIARY) 21 22
L1 EMERGENCY STOP SWITCH (ES) 835 1186 1438
(FOR WOODWARD FCRX 150A
334 LOAD SHARE MODULE) 3 11 14
CONTACT LINE 836 1187 PSCR2 1439
SH CONTACTS DEACTIVATED ACTIVATED 14A (OPTIONAL)
335 BELDEN 9463 BLOCKS NO. 608 11 14
837 1188 1440 ADD IF TRANSDUCER(S)
336 150C ARE USED
L2 LEFT L13 L14 O X 445 838 FUEL 1441
1189
337 14C PROGRAMMAB CONTROL
LE SPEED 1442
150 OHM RIGHT R13 R14 O X 446 839 1190 CONTROL
338 FCRX 1443
RELAY 2 150B 1444
SCHEMATIC INDICATES STATES OF ES CONTACTS IN 840 1191 11 12
339 DIP SWITCHES 1747-SN PSCR2 14B 1445 TB-1D
THE DEACTIVATED POSITION. 1446 51 24V OUT
841 1192 11 12
340 1 2 1447
CB3 1C 33 COM OUT
CB3 O 842 1193 RLR 1448
LINE LOAD 210A 1449
341 24 VDC 24V COM FUEL CONTROL SWITCH (FCS) N HBR 11 14
5A 843 205A 1452 FLEX 04
1194
342 CONTACT CONTACTS 21 24 1453
OFF ON LINE NO. 1454
BLOCKS 844 1195
343 1 2 HORN 210C
REDUCE LOAD 1455
DH + COM G SH L11 L12 ON ON 56K 845 1196 205C AND
344 DH + COM CHASSIS GND LEFT X O 611 24V IN 34
(CH 0) ON OFF 115.2K BEACON 1456
846 1197 (REMOTE)
345 MONITOR OFF ON 230.4K 1198 RLR 210B TB-3
RIGHT R13 R14 O X 1005 11 12 1457 COM IN 16 CONNECT TO TERMINAL 0 FOR
OFF OFF 230.4K 847 1199 HBR TB-1B TB-2 4-20 mA CURRENT
346 1200 205B
SCHEMATIC INDICATES STATES OF FCS 21 22 LINE LINE 1458 CONNECT TO TERMINAL 2 FOR
SERIAL PORT 848 1201 (V) 2
347 CONTACTS IN THE OFF POSITION. DIP SWITCHES 1794-ASB PLC06 1149 1149 2-10 VDC
(CH 1) 849 LRS 1202 1459
1 2 3 4 5 6 7 8 LOCAL/REMOTE
348 X INDICATES A CLOSED CONTACT 2 601 THROTTLE (I) 0
O 850 OPTIONAL FOR 1460 + - PROGRAMMABLE ANALOG
O INDICATES AN OPEN CONTACT SWITCH 1 - N (C280 MARINE 1203 CH0
349 NAPIER TURBO TBL1 OUTPUT 1
RACK 0 PROPUSTION ONLY) 1461
LEFT AND RIGHT SIDE OF SWITCH ARE 851 1204 1B (C) 1 (FOR CUSTOMER USE)
350 PLC00 6
AS VIEWED FROM FRONT OF PANEL. MPU (F) 1462
5/04 CPU 1 2 3 4 5 6 7 8 852 1205
CONNECT TO TERMINAL 4 FOR
O 233 233 1463 4-20 mA CURRENT
853 1206 TURBO SPEED S 5
SWITCH 2 - N CONNECT TO TERMINAL 6 FOR
RACK 0 RIGHT 1464
854 1207 (VEE ONLY) 234 234 2-10 VDC
(OPTIONAL) C (V) 6
855 1208 1465
TB-80 4 5
80 SH
856 3 6 603 1209 1466 CH1 (I) 4 + -
PROGRAMMABLE
200 200 C ESS RATED SPEED SETTINGS 2 J1939 DATA LINK ANALOG OUTPUT 2
2 7 604 1467
201 201 857 1A 1010
400 B
MPU (A) RATED CRANK OIL OIL STEP OVER- (C) 5 (FOR CUSTOMER USE) THE PLC OUTPUT
1A 1A A SPEED TERM. STEP TIME SPEED 1 8 605 1468 PROVIDES THE
I/7 I/8 I/9 (RPM) SPEED SPEED DELAY (RPM) 858 1211 OPTIONAL FOR REMOVE JUMPER(S) 4
401 IF USED CONNECT TO TERMINAL 8 SOURCE POWER
G SH NAPIER TURBO 1469 8 FOR THE OPTIONAL
(RPM) (RPM) (SEC.) 859 1212 FOR 4-20 mA CURRENT
402 TM 604 1B CONNECT TO TERMINAL 10 GAUGE
1 SIG(+) SIG(-) 1470 CONNECTION
1 2 O O O 1000 170 750 750+9 1130 860 A 1213 MPU (E) (V)10 FOR 2-10 VDC
403
861 TERMINATING 1214 230 230 1471
404 LINE 607 OFF/RESET TURBO SPEED S 3
X O O 930 170 698 698+9 1051 RESISTOR 1472 (I) 8 + -
862 1215 LEFT CH2 PROGRAMMABLE
405 SEE ESS RATED
75% VERIFY MODE SPEED & CRANK B (INLINE)
C
231 231
1473
ANALOG OUTPUT 3
863 605 1216 (OPTIONAL) (FOR CUSTOMER USE)
406 1A TERMINATE TIME O X O 900 170 675 675+9 1017 (C) 9
DELAY SETTINGS 864 1217 SH 1474
407 TABLES CONNECT TO TERMINAL 12
X X O 750 170 563 563+9 848 BERL 1475 FOR 4-20 mA CURRENT
865 2 BACKUP ECM 1218
408 - + 609 CONNECT TO TERMINAL 14
866 READY LAMP 1219 2 1476 FOR 2-10 VDC
409 O O X 720 170 540 540+9 814 (MARINE PROP) (V)14
867 1220 1477
410 NOT NOT DC DC 1050 170 BEAL MPU (B)
I/3 I/6 I/9
USED USED COM I/0 I/1 I/2 COM I/4 I/5 I/7 I/8 X X X 788 788+9 1187
868 2 BACKUP ECM 1221 1478 CH3 (I)12 + -
PROGRAMMABLE
411 - + 610 222 222
ACTIVE LAMP S 1 1479 ANALOG OUTPUT 4
O X X 1020 170 765 765+9 1153 869 (MARINE PROP) 1222 PLC (C)13 (FOR CUSTOMER USE)
412
ESS OIL STEP RATED SPEED 870 1223
ENGINE
C
223 223 1480
413 SPEED
DELAY ESS CRANK TERMINATE 1481
TIME DELAY SETTINGS 871 1224 TBL2
414 163 163 SH
VAC VAC VAC VAC VAC 5 1482
VDC O/0 VDC O/1 VDC O/2 VDC O/3 VDC O/4 O/5 DELAY 872 1225
415 I/5 I/6 SEC.
1226 1483
416 DC IN GOVERNOR SCHEMATIC 4 33
+ 24V - O O 9 1227 1484 COM OUT OPTIONAL MODULE
417 1D SFAR 2 TB-1B 3 FOR USE WITH
+ - SPEED FAILURE ALARM LINE 1485 51
2 900 1228 GENSET VERSION
418 RELAY 648, 1181, 1185 X O 15 750 PLC02 1486 24V OUT
901 1229 2 1487
419 103 0 IN 0 1488
1A O X 18 I:2.0/0 1489
EOSTR 902 LOW OIL PRESSURE SHUTDOWN 1 N.O. LINE 513 1230
420 1 1490 FLEX05
+ - ENGINE OILSTEP 1500
2 903 1231
421 75% RELAY 505, 930 1501
VERIFY SEE ESS RATED 904 1232 1502 TB-3 16 COM IN
422 INDICATOR ECTTDR ENGINE CRANK 105 I:2.0/1 1 IN 1 1503
SPEED & CRANK LOW OIL PRESSURE SHUTDOWN 1 N.C. LINE 516 1233
+ - TERMINATE TIME 905 1234 1504 TB-1D 34 24V IN
2 TERMINATE TIME TB-1D TB-3
423 DELAY RELAY 517, DELAY SETTINGS 1235
927 906 1250 LINE LINE 1505
424 ECTR TABLES 450 450
1251
+ - ENGINE CRANK 907 2 IN 2 1252 1506 330 0
2 92 I:2.0/2 FLEX00 1
CH 0-RTDH
425 TERMINATE LOW OIL PRESSURE SHUTDOWN 2 N.O. LINE 502
RELAY 426, 924 16 COM IN 1507 GENERATOR NON
908 1253 DRIVE-END BEARING 3 331 17
426 EOSSR CH 0-RTN
909 1254 34 24V IN 1508 TEMPERATURE RTD 332 1
+ - 2
427 2 ENGINE OVERSPEED (TGNDEB) CH 0-RTDL
RELAY 430, 931 910 102 I:2.0/3 3 IN 3 1255 1509
428 LOW OIL PRESSURE SHUTDOWN 2 N.C. LINE 504 +0 SH
400 1510
911 1256 EXHAUST MANIFOLD
429 3 TEMPERATURE (LEFT) + CH0 1 333 2
912 1257 [(REAR) OR (FRONT)] 1511 CH 1-RTDH
430 - 401 -1 GENERATOR
109 4 IN 4 (TEMLR) OR TEMLF) DRIVE-END 3 334 19
913 I:2.0/4 1258 1512 CH 1-RTN
ECTR CTR CRANKCASE PRESSURE N.O. LINE 541 BEARING
431 2 335 3
11 14 173 175 + - SH 1513 TEMPERATURE RTD CH 1-RTDL
2 CRANK TERMINATE 914 1259
432 36 C (TGDEB)
RELAY 620, 720 1514
915 1260 402 +2
433 CTRX 111 5 IN 5 EXHAUST STACK
I:2.0/5 TEMPERATURE (LEFT) + CH1 1515
CRANK TERMINATE 916 CRANKCASE PRESSURE N.C. LINE 544 1261 1 336 4
434 + - [(REAR) OR (FRONT)] 37 J CH 2-RTDH
2 AUXILIARY RELAY 403 -3 GENERATOR
1175, 1179, 1181, 1186 917 1262 (TESLR) OR TESLF) - 1516 3 337 21
435 STATOR A CH 2-RTN
PCTR 1517 TEMPERATURE RTD
11 14 174 175 + HM - 918 6 IN 6 1263 38 C 2 338 5
436 HOUR METER 107 I:2.0/6 (TGSA) CH 2-RTDL
CUSTOMER SHUTDOWN N.O. LINE 525 1518
919 1264
437 +4 SH
404 1519
EOSSR ASOS 2 920 1265
438 81 85 85 2 EXHAUST PORT 1 + CH2 339 6
11 14 SOSRX 1520
1
CH 3-RTDH
AIR SHUTOFF SOLENOID 921 7 IN 7 1266 TEMPERATURE -5
439 11 14 I:2.0/7 (TEP1) - 405 GENERATOR STATOR
B TEMPERATURE 3 340 23
922 1267 1521 CH 3-RTN
440 RTD (TGSB) 2 341 7
SH 1522 CH 3-RTDL
PASOR 923 1268
441 1B 83 85 2 ECTR
11 14 8 IN 8 1523
924 21 24 I:2.0/8 1269 406 +6
442
925 1270 EXHAUST PORT 2 + CH3 1524 1 342 8
443 TEMPERATURE CH 4-RTDH
- 407 -7 1525 GENERATOR
ES (LOCAL) 926 1271 (TEP2) 3 343 25
444 1 ECTTDR STATOR C CH 4-RTN
L13 L14 84 85 86 21 24 I:2.0/9 9 IN 9 1526 TEMPERATURE RTD
927 1272 2 344 9
445 (TGSC) CH 4-RTDL
R13 R14 928 1273 FOR USE WITH 1527
446 SH
TB-3 408 +8 C280-6, C280-8,
929 EOSTR 1274 C280-12 & C280-16 1528
447 LINE EXHAUST PORT 3 + CH4
ES (REMOTE) 1250 21 24 I:2.0/10 10 IN 10 ENGINES 10
1 84 LINE 1002 930 1275 TEMPERATURE 1529 CH 5-RTDH
448 PLC04 - 409 -9
(TEP3) 27
1B IN 00 931 1276 1530 CH 5-RTN
449 11
113 EOSSR SH 1531 CH 5-RTDL
932 11 IN 11 1277
450 21 24 I:2.0/11
LINE 941 933 1278 + 10 1532
113 410
PLC02
IN 14 TB-1D 934 1279 EXHAUST PORT 4 + CH5 1533 12
500 LINE LINE 907 TEMPERATURE CH 6-RTDH
92 - 411 - 11 1534
1250 PLC02 935 1A 12 IN 12 1280 (TEP4) 29
501 POSTR I:2.0/12 CH 6-RTN
IN 02 RELAY POWER AVAILABLE LINE 306
11 14 936 1281 1535 13
502 CH 6-RTDL
937 1282 1536
503
938 149 I:2.0/13 13 IN 13 1283 412 + 12 1537
FCR EOSTR OPLS2 LINE 910 SUMMARY SHUTDOWN RELAY LINE 616
504 1A 90 93 93 92 EXHAUST PORT 5 + 14
21 22 11 14 1 3 PLC02 CH6 1538 CH 7-RTDH
939 1284 TEMPERATURE
505 2 IN 03 - 413 - 13 31
(TEP5) 1539 CH 7-RTN
940 1285 47 C
506 14 IN 14 15
113 I:2.0/14 1540 CH 7-RTDL
941 EMERGENCY STOP LINE 450 1286 SH
507 106
101 101 102 1541
942 1287 48 J
508 414 + 14 TB-1D
TB-80 1542 51 24V OUT
943 AIR DOOR CLOSED 1288 EXHAUST PORT 6 + CH7
509 1B 1B 114 114 15 IN 15 1543
I:2.0/15 TEMPERATURE 49 C 1544 33 COM OUT
ECS 944 1289 - 415 - 15
510 80 OPLS2R OPLS2R 2 (TEP6) 1545
L11 L12 OIL PRESSURE LOW 1546
11 14 + - SHUTDOWN RELAY #2 945 1290
511 2 1547
511,1161,1165 946
947 1291 1548
512 16 COM 17 1549
948 TB-1D
949 1292 51 24V OUT 1550
513 PCTTDR 103 1551 FLEX06
LINE 902 950 PLC03 1293
11 14 951 1294 33 COM OUT 1552
PLC02 OLLA
514 IN 00 1B 1B 210 210 I:3.0/0 0 IN 0 1295
952 1300 1553 TB-3 16 COM IN
515 BK WH 1301
953 1302 1554
ECTTDR OPLS1 LINE 904 34 24V IN
516 91 91 103 FLEX01
11 14 1 3 PLC02 ASPLA 1555
954 1303
517 2 IN 01 1B 1 3 211 211 I:3.0/1 1 IN 1
955 1304 1556 1 300 0
BK WH TB-3 16 COM IN CH 0-RTDH
518
956 1305 1557 LUBE OIL 3 301 17
CONTACTORS 34 24V IN CH 0-RTN
519 ARE NOT JWPLA TEMPERATURE (TO)
104 104 105 106 1558 2 302 1
957 PRESENT IF 1B 1 3 212 212 I:3.0/2 2 IN 2 1306
520 CH 0-RTDL
OPTIONAL 416 +0 1559
958 TRANSDUCERS BK WH 1307 SH
521 EXHAUST PORT 7 + CH0
959 ARE USED. 1308 1560
OPLS1R OPLS1R TEMPERATURE -1
522 OIL PRESSURE LOW AWPLA (TEP7) - 417 1 303 2
11 14 + - 1561 CH 1-RTDH
2 SHUTDOWN RELAY #1 960 1B 1 3 213 213 I:3.0/3 3 IN 3 1309
INLET AIR MANIFOLD
523 523,1161,1165 3 304 19
961 BK WH 1310 SH 1562 BOOST TEMPERATURE CH 1-RTN
524 RTD (TBST) 2 305 3
36 C 1563 CH 1-RTDL
962 1311 +2
525 PDA 418
LINE 918 963 1B 214 214 I:3.0/4 4 IN 4
1312 EXHAUST PORT 8 + CH1
1564
526 PLC02 BK WH TEMPERATURE 37 J
IN 06 964 1313 - 419 -3 1565 1 306 4
(TEP8) CH 2-RTDH
527
965 1314 1566 FUEL TO ENGINE 3 307 21
528 CUST. SHUTDOWN WLLA 38 C CH 2-RTN
108 108 107 106 1B 215 I:3.0/5 5 IN 5
1567 TEMPERATURE RTD (TF) 2 308 5
OR 966 1315
529 REMOVE JUMPER IF CONTACTOR CH 2-RTDL
967 IS INSTALLED 420 +4 1568
1316 FOR USE WITH SH
530 EXHAUST PORT 9 + CH2
968 1317 C280-8, C280-12 1569
CSDR CSDR SWPLA (CUSTOMER SUPPLIED) TEMPERATURE
531 11 14 + - CUATOMER SHUTDOWN 1B 216 I:3.0/6 6 IN 6
(TEP9) - 421 -5 & C280-16 1 309 6
2 969 1318 ENGINES 1570 CH 3-RTDH
RELAY 532,1168,1172 REMOVE JUMPER IF CONTACTOR JACKET WATER OUTLET
532 IS INSTALLED 3 310 23
970 1319 SH 1571 TEMPERATURE ALARM CH 3-RTN
533 RTD (TJWO) 2 311 7
971 AUX ALARM 1 1320 1572 CH 3-RTDL
534 CPHSR CPHSR 1B 217 I:3.0/7 7 IN 7 422 +6 24
11 14 + - CRANKCASE PRESSURE 972 REMOVE JUMPER IF CONTACTOR 1321 1573 CH 3-SHLD
2 EXHAUST PORT 10 + CH3
535 HIGH SHUTDOWN RELAY IS INSTALLED TEMPERATURE
535,1154,1158 973 1322 - 423 -7 1574 1 312 8
(TEP10) CH 4-RTDH
536 AUX ALARM 2
974 1B 218 I:3.0/8 8 IN 8 1323 1575 AC/OC WATER INLET 3 313 25
537 OVR TEMPERATURE RTD CH 4-RTN
110 109 106 86 REMOVE JUMPER IF CONTACTOR 1576
11 12 975 1324 (TAOI) 2 314 9
538 IS INSTALLED CH 4-RTDL
976 424 +8 1577
AUX ALARM 3 1325 SH
539 EXHAUST PORT 11 + CH4
977 1B 219 I:3.0/9 9 IN 9
1326 TEMPERATURE
1578
540 CPHSS - 425 -9 1 315 10
90 90 1 3 110 LINE 913 (TEP11) 1579 CH 5-RTDH
PLC02 978 1327 JACKET WATER OUTLET
541 2 TEMPERATURE 3 316 27
IN 04 SH 1580 CH 5-RTN
979 AUX SHUTDOWN 1 1328 SHUTDOWN RTD
542 317 11
I:3.0/10 10 IN 10
1B 208 2
1581 (TJWO2) CH 5-RTDL
980 1329 + 10
543 111 111 LINE 916 426
PLC02 981 1330 EXHAUST PORT 12 + 1582
CH5
544 IN 05 TEMPERATURE
982 AUX SHUTDOWN 2 1331 - 427 - 11 1583 318 12
(TEP12) CH 6-RTDH
545 1B 209 I:3.0/11 11 IN 11
983 1332 1584 AUXILIARY #1 319 29
SSR SSR REMOVE JUMPER IF CONTACTOR CH 6-RTN
546 80 87 86 IS INSTALLED TEMPERATURE
11 14 + - SUMMARY SHUTDOWN 984 1585 320 13
2 1333 CUSTOMER SUPPLIED CH 6-RTDL
547 RELAY 546,614 LBVAR (AT1)
985 428 + 12 1586
COM NC I:3.0/12 12 IN 12 1334 EXHAUST MANIFOLD SH
548 TEMPERATURE (RIGHT) + CH6
986 1335 1587
SSRX [(REAR) OR (FRONT)] - 13 321 14
549 LINE 1123 88 SUMMARY SHUTDOWN - 429
+ - (TEMRR) OR TEMRF) 1588 CH 7-RTDH
PLC05 2 AUXILIARY RELAY 987 1336 47 C AUXILIARY #2
550 620,1175,1179 JWDAR 322 31
OUT 08 1589 TEMPERATURE CH 7-RTN
988 11 12 I:3.0/13 13 IN 13 1337 SH
CUSTOMER SUPPLIED
600 323 15
48 J 1590 (AT2) CH 7-RTDL
JWDS 989 1338 + 14
601 JWDAR 430
90 202 202 2 JACKET WATER EXHAUST STACK 1591
+ - 2 S - 3 990 1339 TEMPERATURE (RIGHT) + CH7
602 2 DETECTOR ALARM OMDR TB-1D 51 24V OUT
RELAY 988 991 80 80 5 4 235 235 I:3.0/14 14 IN 14 1340
[(REAR) OR (FRONT)] - 431 - 15 49 C 1592
603 90 1 + T (TESRR) OR TESRF)
4 33 COM OUT
992 1341 1593
604 TB-80 1594
993 OMDS 1342 1595
ECS RMAR 1596
605
R23 R24 + - 2 REMOTE MODE ACTIVE 8 7 236 236 I:3.0/15 15 IN 15 1597
2 994 1343 TB-1D
606 RELAY 1011,1175,1179 51 24V OUT 1598
LINE 407 995 OIL MIST 1344 1599
607 L23 ECS L24 146 ESS IN 02 148 150 DETECTOR 33 COM OUT 1600
LINE 1103
PLC05 RMARX 996 (OPTIONAL) 1345 1601 FLEX07
608 2 REMOTE MODE 2 16 COM 17 1602
+

LINE 1022 OUT 00 + - - TB-2 1346

2 ACTIVE(AUX.) RELAY 1603 TB-3
PLC04 815, 819 997 1 2 1350
1351 16 COM IN
609 IN 07 998 1347
999 1352 1604
1000 1348 FLEX02
610 1001 PLC04 1353 1605 34 24V IN
TB-2 1349
FCS FCR 84 16 COM IN 1606
611 L11 L12 147 147 150
FUEL CONTROL
2 RELAY
1002 I:4.0/0 0 IN 0 1354 TB-3
+ - EMERGENCY STOP LINE 448 1D 35
2 1355 34 24V IN 1607 1
505, 720, 726 1003 P +24 VDC
612 LUBE OIL PRESSURE 0
1608 TO ENGINE (POE) I 2 361
1004 FCS 1356 +I IN 0
613 SSR FCRX +0
432
149 FUEL CONTROL 1005 1B R14 R13 I:4.0/1 1 IN 1 1357 1609
614 21 24 + - EXHAUST PORT 13 + CH0 SH
2 AUXILIARY RELAY 1610
1006 1358 TEMPERATURE -1
615 REMOVE JUMPER IF 825, 827,1188,1192 (TEP13) - 433
START INTERLOCK IS 1007 1359 1611
OVR 1 1D 37
616 LINE 938 USED
PLC02 1008 21 24 I:4.0/2 2 IN 2
1360 SH 1612 INLET AIR MANIFOLD P +24 VDC
ASR (BOOST) PRESSURE 2 362
617 67 IN 13 75 2 36 C I
11 14 1613 (PIAM)
1009 1361 434 +2
618 363 2
1010 RMAR 1362 EXHAUST PORT 14 + CH1 1614 +I IN 1
619 CTR SSRX ECS ECS PSS 151 SOSR ASSV 21 24 I:4.0/3 3 IN 3 TEMPERATURE
435 -3
37 J
1615
21 22 11 12 L31 L32 R11 R12 R13 R14 11 14 68 74 75 75 2 1011 1363 (TEP14) -
620 AIR START SOLENOID 39
1616 1 1D
VALVE 1012 1364 38 C P +24 VDC
621 FUEL PRESSURE TO 4
REMOTE PRELUBE 1617 ENGINE (PFE) I 2 365
1013 140 1365 +I IN 2
622 I:4.0/4 4 IN 4
+4
436 1618
FCTDR 1014 1366
623 + - 2 EXHAUST PORT 15 + CH2 SH
2 FUEL CONTROL 1015 1367 TEMPERATURE 1619
624 TIME DELAY 730 - 437 -5
MOMENTARY REMOTE START 141 (TEP15)
69 1620
625
1016 I:4.0/5 5 IN 5 1368 1 1D 41
152 153 SH 1621 P +24 VDC
LINE 1105 1017 1369 LUBE OIL PRESSURE 6
626 PLC05 TO FILTER (POF) I 2 367
1622 +I IN 3
OUT 01 1018 1370 438 +6
627 MOMENTARY REMOTE STOP 142
PSS I:4.0/6 6 IN 6 EXHAUST PORT 16 + CH3 1623
IPR 1019 1371 FOR USE WITH
628 69 L14 L13 153 + - 2 INTERMITTENT TEMPERATURE
439 -7 C280-16 1624
2 PRELUBING RELAY 1020 1372 (TEP16) -
714,1154,1158 ENGINE ONLY
629 43
REMOVE JUMPER IF PRELUBE 1625 1 1D
1021 1373 P +24 VDC
630 INTERLOCK IS USED 146 FUEL PRESSURE TO
SOSR 1022 I:4.0/7 7 IN 7
1374 1626 FILTER (PFF) I 2 369 8
SOS OFF/RESET LINE 609 +I IN 4
631 ELECTRIC BARRING DEVICE + - 71 72 72 2 STARTING OIL
2 SENSOR RELAY +8 1627
CONNECTION 1023 1375
632 (OPTIONAL) 620,639 CH4 SH
+ 1024 SLS 1376 1628
-9
633 L13 L14 I:4.0/8 8 IN 8
1629
1025 1377 45
634 70 70 +24 VDC
1026 1378 1630
5 370 10 +I IN 5
635 IF CONTINUOUS PRELUBE IS SLS
SELECTED, TERMINATE (+) 1027 1379 1631 RACK AMPLIFIER
+ 10
636 TERMINAL TO TERMINAL 70.
R13 R14 I:4.0/9 9 IN 9
(OPTIONAL)(RPT) SH
1028 1380 CH5 1632
JACKET WATER HEATER,
637 CONTINUOUS PRELUBE PUMP - 11 1633
SOSR SOSRX STARTING OIL SENSOR 1029 1381
638 161 47
21 24 + - AUXILIARY RELAY 256 1634 CUSTOMER SUPPLIED 1D +24 VDC
2 1030 I:4.0/10 10 IN 10 1382
639 921,1154,1158 BBMS LINE 871 4-20 mA INPUT OR
1635 1-10 VDC INPUT 374 12 +I IN 6
1031 1383
640 + 12 AUXILIARY #1(AAI1)
1032 1384 1636 13
641 SLS SOL BBMAR SH +V
CH6
R23 R24 163 163 162 X1
G
X2 1033 21 24 I:4.0/11 11 IN 11 1385 - 13
1637 30 -V
642 STARTING OIL LIGHT
1034 1386 47 C 1638
CUSTOMER SUPPLIED 1D 49 +24 VDC
643
1035 1387 1639 4-20 mA INPUT OR
1-10 VDC INPUT 375 14 +I IN 7
644 PLCFAR PLCFL
1036
512 I:4.0/12 12 IN 12 1388 48 J 1640 AUXILIARY #2(AAI2)
21 22 164 X1 X2 + 14 15
645 A CONTROL FAILURE +V
LIGHT 1037 1389 CH7 1641
646 49 C 32
- 15 1642 -V
1038 1390
647 SFAR SFL 513 I:4.0/13 13 IN 13 1643 51 24V OUT
21 22 165 X1 X2 1039 1391 1644 CONNECT TO TERMINALS 12 OR 14 FOR
648 A SPEED FAILURE LIGHT 511 1645 4-20 mA CURRENT 33 COM OUT
1040 1392 51 24V OUT 1646 CONNECT TO TERMINALS 13, 30 OR 15, 32
649 1393
650 1394 1647 FOR 2-10 VDC
1041 33 COM OUT
700 514 I:4.0/14 14 IN 14 1395 1648
701 1396 1649
1042 TB-1D TB-3
702 1397 LINE
703 1043 1398 LINE SYMBOLS/ABBREVIATIONS
704 1403 1403
OVR OVR
705
1A 1A 204 204 + -
2
OVERRIDE RELAY
1044 515 I:4.0/15 15 IN 15 SYMBOLS
2 537,1008 1045 INTERNAL WIRING
706 CUSTOMER DIODE
SUPPLIED EMERGENCY STOP
HB 1046 RESISTOR
707
HBR CONNECT JUMPER(S) 16 COM 17 FACTORY WIRING
2 HORN AND 1047 AS PER THE ENGINE TB-2
708 11 14 205 1048 STANDARD RELAY COIL/SOLENIOD METER
BEACON CONFIGURATION CHART ENGINE CONFIGURATION CHART POTENTIOMETER
1049 CUSTOMER PROVIDED WIRING
709 (OPTIONAL)
1100 INPUTS DESCRIPTION NORMALLY CLOSED SWITCH
710 (OPTIONAL) INTERCONNECT WIRING OPEN RELAY
12 13 14 15 THERMOCOUPLE
1101 PLC05 CONTACTS NORMALLY OPEN SWITCH
711
1102 0 0 0 0 C280-16, GMS W/TRANSDUCER MODULE ENGINE MOUNTED TERMINAL BOX
712 TERMINAL BOARD POINT CLOSED RELAY JWDS
OUT 0 148 0 0 0 1 C280-16, GMS W/0 TRANSDUCER MODULE -
1103 O:05.0/0 FUEL SHUTOFF SIGNAL CONTACTS RESISTIVE TEMPERATURE S
713 LINE 607 0 0 1 0 C280-16, MMS W/TRANSDUCER MODULE JACKET WATER DETECTION SWITCH
VDC MMS PANEL TERMINAL BOARD POINT DEVICE (RTD) + T
IPR IPSV 1104 0 0 1 1 C280-16, MMS W/O TRANSDUCER MODULE
714 21 24 73 73 2 INTERMITTENT 0 1 0 0 C280-12, GMS W/TRANSDUCER MODULE
PRELUBE 1105 152 GOVERNOR PANEL PRESSURE SWITCH +
715 SOLENOID VALVE OUT 1 O:05.0/1 0 1 0 1 C280-12, GMS W/O TRANSDUCER MODULE
PRELUBE SIGNAL TERMINAL BOARD POINT F FREQUENCY TRANSDUCER
1106 LINE 623 0 1 1 0 C280-12, MMS W/TRANSDUCER MODULE I - MPU MAGNETIC PICKUP
716 0 1 1 1 C280-12, MMS W/O TRANSDUCER MODULE
1107 1 0 0 0 C280-08, GMS W/TRANSDUCER MODULE TD TIME DELAY TEMPERATURE SWITCH
717 RLR +
OUT 2 O:05.0/2 + - 1 0 0 1 C280-08, GMS W/O TRANSDUCER MODULE P PRESSURE TRANSDUCER GROUND CONNECTION
1108 2 REDUCE LOAD RELAY I -
718 1195,1199 1 0 1 0 C280-08, MMS W/TRANSDUCER MODULE + -
1109 1 0 1 1 C280-08, MMS W/O TRANSDUCER MODULE BATTERY
719 ENGINE SOLENOID
CTR FCR ASR 1 1 0 0 C280-06, GMS W/TRANSDUCER MODULE PARTICLE DETECTOR
167 169 1110 OUT 3 SOS
720 11 14 11 14 82A (ETS) O:05.0/3 + - AUTO START RELAY 1 1 0 1 C280-06, GMS W/O TRANSDUCER MODULE LIQUID LEVEL SWITCH
1111 2 1 1 1 0 C280-06, MMS W/TRANSDUCER MODULE STARTING OIL SENSOR SWITCH
721 617
1 1 1 1 C280-06, MMS W/O TRANSDUCER MODULE LAMP
FOR ENERGIZE TO SHUTDOWN 1112 +
722 HBR PLUG ASSEMBLY
5
6
7
8

CONNECT TERMINAL 82A TO OUT 4 CIRCUIT BREAKER

4
3
2
1

FSOS 2 FUEL 1113 O:05.0/4 + - HORN AND BEACON RELAY INPUT MMS TERM. # ENGINE CONFIGURATION
723 TERMINAL 82. 82 82 2 2 708,1195,1199
FOR ENERGIZE TO RUN OR SHUTOFF 12 512 Ø = VEE, 1 = INLINE
1114
724 CONNECT TERMINAL 82B TO SOLENOID 13 513 # OF CYLINDERS/BANK 0 = 8, 1 = 6 ABBREVIATIONS
TERMINAL 82. 1115 SAR
725 OUT 5 14 514 Ø = GMS, 1 = MMS DESCRIPTION
O:05.0/5 +
2
- SUMMARY ALARM RELAY ABR. LINE# ABR. DESCRIPTION LINE# ABR. DESCRIPTION LINE#
1B 168 TD FCR 1116 1181,1186 15 515 Ø = OPTIONS INSTALLED, 1 = NO CARD
726 169 15 18 11 12 82B (ETR) AAI1 AUXILIARY ANALOG INPUT #1 1634 GND GROUND 300 RPT RACK POSITION TRANSDUCER 1631
1117 AAI2 AUXILIARY ANALOG INPUT #2 1638 HB HORN AND BEACON 708 RTD RESISTIVE TEMPERATURE DETECTOR 1508
727 SAL
1118
OUT 6 O:05.0/6 X1 X2 WIRING DIAGRAM 290-4722 CIRCUIT SCHEMATICS ACOC AFTER COOLER/OIL COOLER 1575 HBR HORN AND BEACON RELAY 1113 SAL SUMMARY ALARM LAMP 1117
728 A SUMMARY ALARM LAMP ASOS AIR SHUTOFF SOLENIOD VALVE 439 HM HOUR METER 432 SAR SUMMARY ALARM RELAY 1115
30 SECONDS
1119 NOTES: ASPG AIR STARTING PRESSURE GAUGE 733 IPR INTERMITTENT PRELUBING RELAY 626 SCS SPEED CONTROL RELAY 817
729 ASPLA AIR STARTING PRESSURE LOW ALARM 954 IPSV INTERMITTENT PRELUBE START SOLENOID VALVE 714 SEC SECONDS 3
1120 SSL UNLESS OTHERWISE SPECIFIED, RECOMMENDED STANDARD
730 OUT 7 O:05.0/7 X1 X2 ASPSU AIR STARTING PRESSURE SENDING UNIT 736 IRS IDLE/RATED SWITCH 807 SFAR SPEED FAILURE (SENSOR) ALARM RELAY 411
R
WIRE SIZE IS 16 AWG ENGINE, 18 AWG MMS PANEL.
FCTDR 1121 SUMMARY SHUTDOWN LAMP ASR AUTOMATIC START RELAY 1110 JWDAR JACKET WATER DETECTOR ALARM RELAY 602 SFL SPEED FAILURE (SENSOR) LIGHT 648
731 2 FUEL 620
11 14 B1 A2 ASSV AIR START SOLENOID VALVE JWDS JACKET WATER DETECTOR SWITCH 602 SG 02A SENSOR ROTARY POSITION
TD CONTROL 1122 SHIELDED TWISTED PAIR WIRE SIZE IS 18 AWG MINIMUM.
AT1 AUXILIARY TEMPERATURE #1 RTD 1583 JWPLA JACKET WATER PRESSURE LOW ALARM 957 SG 03VR AMPLIFIER ROTARY POSITION
732 TIME DELAY 88
A1 OUT 8 O:05.0/8 AT2 AUXILIARY TEMPERATURE #2 RTD 1588 LBVAR LOW BATTERY VOLTAGE ALARM RELAY 303 SLS ACKNOWLEDGE/LAMP TEST SWITCH 1024
1123 SUMMARY SHUTDOWN USE K-TYPE THERMOCOUPLE WIRE FOR THERMOCOUPLE
733 LINE 549 AUX AUXILIARY 971 LRS LOCAL/REMOTE SWITCH SOL STARTING OIL PRESSURE LIGHT 642
CONNECTIONS. AWG AMERICAN WIRE GAUGE 40 MMS MARINE MONITORING SYSTEM SOS STARTING OIL SENSOR SWITCH 629
1124
734 AWPLA AC/OC WATER PRESSURE LOW ALARM 960 MPU MAGNETIC PICK UP 401 SOSR STARTING OIL SENSOR RELAY 629
1125 PSCR1 DRY CONTATS ARE RATED FOR 5 AMPS AT 30 VDC & 120 VAC.
735 OUT 9 O:05.0/9 + - PROGRAMMABLE SPEED BEAL BACKUP ECM ACTIVE LIGHT NC NORMALLY CLOSED 905 SOSRX STARTING OIL PRESSURE AUXILIARY RELAY 638
1126 2 CONTROL RELAY 1 BERL BACKUP ECM READY LIGHT NO NORMALLY OPEN 902 SSL SUMMARY SHUTDOWN LAMP 1120
736 746,1161,1165 ALL PRESSURE SWITCHES SHOWN WITHOUT PRESSURE 877
BBMAR BALL HEAD BACKUP MODE ALARM RELAY OLLA OIL LEVEL LOW ALARM 952 SSR SUMMARY SHUTDOWN RELAY 546
1127 PRESENT. BBMS BALL HEAD BACKUP MODE SWITCH 871 OMDR OIL MIST DETECTOR RELAY 991 SSRX SUMMARY SHUTDOWN AUXILIARY RELAY 550
737 PCTR
OUT 10 O:05.0/10 CB# CIRCUIT BREAKER NUMBER 305 OMDS OIL MIST DETECTOR SHUTDOWN 994 SWPLA SEAWATER PRESSURE LOW ALARM 968
1128 + - PLC CRANK TERMINATE
738 2 ALL LEVEL SWITCHES SHOWN WITHOUT FLUID PRESENT. CHL CHANNEL 344 OPLS1 OIL PRESSURE LOW SHUTDOWN (>170 RPM) 516 TAOI AC/OC INLET TEMPERATURE 1575
ASPG RELAY 436 COM BATTERY COMMON 309 OPLS1R OIL PRESSURE LOW SHUTDOWN RELAY #1 522 TB TERMINAL BLOCK 350
STARTING AIR 1129
739 + - ALL RELAY CONTACTS SHOWN IN THE DE-ENERGIZED MODE. CPHSR CRANK PRESSURE HIGH SHUTDOWN RELAY 535 OPLS2 OIL PRESSURE LOW SHUTDOWN (>75% OF RPM) 504 TBST INLET AIR MANIFOLD (BOOST) TEMPERATURE RTD 1562
PRESSURE 1130 PCTTDR
740 GUAGE OUT 11 CPHSS CRANK PRESSURE HIGH SHUTDOWN SWITCH 540 OPLS2R OIL PRESSURE LOW SHUTDOWN RELAY #2 511 TD TIME DELAY 732
O:05.0/11 + -
G 2 PLC CRANK TERMINATE TIME INTERCONNECT WIRING, UNLESS OTHERWISE SPECIFIED, CSDR CUSTOMER SHUTDOWN RELAY 531 OVR OVERRIDE RELAY 705 TEMF TEMP EXHAUST MANIFOLD (FRONT) 1334
1131 DELAY RELAY 514
741 ASPSU RECOMMENDED STANDARD WIRE SIZE IS 16 AWG. FACTORY CTR CRANK TERMINATE RELAY 426 PAOP AC/OC PUMP PRESSURE TRANSDUCER 1412 TEMLF TEMP EXHAUST MANIFOLD LEFT (FRONT) 1256
203 203 2 STARTING AIR 1132 PROVIDED FOR ACCESSORY MODULE MOUNTED GMS OR CTRX CRANK TERMINATE RELAY AUXILIARY 429 PASOR PLC AIR SHUTOFF RELAY 1135 TEMLR TEMP EXHAUST MANIFOLD LEFT (REAR) 1256
742 PRESSURE POSTR
SENDING UNIT OUT 12 MMS II, CUSTOMER PROVIDED IF SHIP LOOSE. DC DIRECT CURRENT 409 PCTR PLC CRANK TERMINATE RELAY 1128 TEMR TEMP EXHAUST MANIFOLD (REAR) 1334
1133 O:05.0/12 + -
743 2 PLC OIL STEP RELAY ECP ENGINE CONTROL PANEL 1700 PCTTDR PLC CRANK TERMINATE TIME DELAY RELAY 1131 TEMRF TEMP EXHAUST MANIFOLE RIGHT (FRONT) 1334
502 ECS ENGINE CONTROL SWITCH 511 PDA PARTICLE DETECTOR ALARM 963 TEMRR TEMP EXHAUST MANIFOLD RIGHT (REAR) 1334
1134 ALL COMMON TERMINALS FOR ENGINE WIRING ARE JUMPERED
744 ECTR ENGINE CRANK TERMINATE RELAY 421 PFCR PLC FUEL CONTROL RELAY 1103 TEP# EXHAUST PORT NUMBER 1266
1135 PASOR IN ENGINE TERMINAL BOX FOR INTERCONNECT WIRING TO
OUT 13 ECTTDR ENGINE CRANK TERMINATE TIME DELAY 418 PFE FUEL TO ENGINE PRESSURE TRANSDUCER 1616 TESF TEMP EXHAUST STACK (FRONT) 1339
745 O:05.0/13 + - GMS OR MMS II PANELS.
PSCR1 2 PLC AIR SHUTOFF RELAY EGBBM ELECTRONIC GOV. BALL HEAD BACKUP MOTOR 858 PFF FUEL TO FILTER PRESSURE TRANSDUCER 1626 TESLF TEMP EXHAUST STACK LEFT (FRONT) 1260
COMP. BYPASS SOL. 1136 442
746 21 24 452 452 2 COMPRESSOR EMTB ENGINE MOUNTED TERMINAL BOX 1700 PIAM INLET AIR MANIFOLD PRESSURE TRANSDUCER 1612 TESLR TEMP EXHAUST STACK LEFT (REAR) 1260
A TABLE SHOWING LINE NUMBERS CROSS REFERENCED TO EOSSR ENGINE OVERSPEED RELAY 423 TESR
BYPASS SOLENOID 1137 PJW JACKET WATER PRESSURE TRANSDUCER 1422 TEMP EXHAUST STACK (REAR) 1339
747 PLCFAR TERMINAL BOARD NUMBERS IS ON THE OTHER SIDE OF THIS SHEET. 414
OUT 14 PLC FUNCTIONING EOSTR ENGINE OIL PRESSURE STEP RELAY PLC PROGRAMMABLE LOGIC CONTROLLER 448 TESRF TEMP EXHAUST STACK RIGHT (FRONT) 1339
1138 O:05.0/14 + -
748 2 ALARM RELAY ES EMERGENCY STOP 444 PLCFAR PLC FALIURE ALARM RELAY 1138 TESRR TEMP EXHAUST STACK RIGHT (REAR) 1339
1139 645,1168,1172 ESS ELECTRONIC SPEED SWITCH 411 PLCFL PLC FAILURE ALARM LAMP 645 TF FUEL TO ENGINE TEMPERATURE RTD 1566
TB-2
749 LINE ETR ENERGIZED TO RUN 727 PLCPS PLC POWER SUPPLY 310 TGDEB GENERATOR DRIVE END BEARING TEMP RTD 1511
TB-1A TB-1B PSCR2
750 LINE LINE 800 1140 OUT 15 SYMBOL DESCRIPTION ETS ENERGIZED TO SHUTDOWN 720 POE OIL TO ENGINE PRESSURE TRANSDUCER 1607 TGNDEB GENERATOR NON DR END BEARING TEMP RTD 1506
O:05.0/15 + - PROGRAMMABLE SPEED
800 900 2 CONTROL RELAY 2 FCR FUEL CONTROL RELAY 611 POF OIL TO FILTER PRESSURE TRANSDUCER 1621 TGSA GENERATOR STATOR A TEMPERATURE RTD 1516
TB-2 1141
1188,1192 CIRCUIT CONNECTED FCRX FUEL CONTROL AUXILIARY RELAY 614 POSTR PLC OIL PRESSURE STEP RELAY 1133 TGSB GENERATOR STATOR B TEMPERATURE RTD 1520
1142 FCS FUEL CONTROL SWITCH 611 PSA STARTING AIR PRESSURE TRANSDUCER 1417 TGSC GENERATOR STATOR C TEMPERATURE RTD 1525
DC COM FCTDR FUEL CONTROL TIME DELAY RELAY 624 PSCR1 PROGRAMMABLE SPEED CONTROL RELAY 1 1125 TJWO JACKET WATER TEMPERATURE RTD 1570
1143 CIRCUIT NOT CONNECTED
FLEX# FLEX I/O MODULE NUMBER 1251 PSCR2 PROGRAMMABLE SPEED CONTROL RELAY 2 1140 TJWO2 REDUNDANT JACKET WATER TEMP RTD 1579
1144 ELECTRICAL CONNECTION TO FLEXASB FLEX REMOTE I/O ADAPTER 320 PSS PRELUBE START SWITCH 620 TM TACHOMETER 402
1145 FSOS FUEL SHUTOFF SOLENOID 723 PSW SEAWATER PRESSURE TRANSDUCER 1408 TO OIL TEMPERATURE RTD 1557
MACHINE STRUCTURE
1146 GAR GENERAL ALARM RELAY PWM PULSE WIDTH MODULATION VDC VOLTAGE DIRECT CURRENT 414
1147 TB-1B TB-2
LINE CONNECTOR GMS GENERATOR MONITORING SYSTEM RLR REDUCE LOAD RELAY 1108 WLLA WATER LEVEL LOW ALARM 966
1148 LINE
1149 1200 1200 RMAR REMOTE ACTIVE RELAY 606