Installation instructions, accessories

Volvo Car Corporation Gothenburg, Sweden

Instruction No Version Part. No.

30730121 1.1

Subwoofer, cargo compartment

M3905136

Equipment

A0000162

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 1 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

M3905137

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 2 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

IMG-213320

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 3 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

INTRODUCTION

Read through all of the instructions before starting installation.

Notifications and warning texts are for your safety and to

minimise the risk of something breaking during installation.

Ensure that all tools stated in the instructions are available

before starting installation.

Certain steps in the instructions are only presented in the form

of images. Explanatory text is also given for more complicated
steps.

In the event of any problems with the instructions or the

accessory, contact your local Volvo dealer.

Preparations

1 Preparations

Turn the ignition key to position 0.

Wait at least five minutes before disassembling the connectors

or removing other electrical equipment.

Remove both floor hatches by folding them up and pulling them

towards the rear.

M8502718

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 4 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

Detach the storage box under the rear floor hatch by turning the
clips on the right-hand and left-hand sides 90°. Lift out the box.

M8503121

Cut out the insulation panel as illustrated.

M8503122

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 5 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

Slacken off the screw (1) a few turns and remove the nut (2)
from the battery holder.

Remove the holder.

Detach the ground lead from the battery.

M3100213

Unscrew the holder for the spare wheel, jack and tool bag.

Remove the jack and the tool bag from the holder (they will no
longer be used). A new holder and mounting fixture for the jack,
tool bag and spare wheel are included in the kit.

M7700278

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 6 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

Secure the spare wheel with the new mounting fixture from the
kit.

M7700279

Remove the rubber washer (1) from the rear crossmember

behind the spare wheel. The hole is used for securing the rear
edge of the subwoofer.

M8901651

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 7 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

Remove the folding panels on the right-hand and left-hand sides

of the cargo compartment.

M8503006

Remove the rear insulation panels on the left-hand and right-

hand sides.

M8503007

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 8 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

10

Remove the left side panel. Remove the cover and the screw
from the front edge.

Pull the top edge of the panel out until the clips release.

Fold the panel inwards. Lift the panel out.

M8503130

11

Fold the left-hand rear seat cushion forward (1).

Fold the backrest (2) forward.

M8502805

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 9 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

12

Remove the left-hand side cushion by pulling the upper edge

towards the rear and lifting it up.

A8500151

13

Remove the panel for the D-post loudspeaker. Carefully pry off
the lower edge of the panel using a plastic weatherstrip tool.

Place the panel to one side.

Repeat the operation on the other side.

M8502927

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 10 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

14

Remove the loudspeaker by pulling out the red locking

mechanism (1) and pushing in the catch (2). Lower the speaker
forwards and lift it out.

Unplug the connector from the loudspeaker and move it aside.

Repeat the operation on the other side.

M3902958

15

Remove the 4 x screws in the tailgate sill panel.

M8503123

Cable routing

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 11 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

16 Cable routing

Position the kit wiring harness along the tailgate sill panel and
the floor supports on the right-hand and left-hand sides as
illustrated.

Make sure the wiring harness is positioned so that the connector

(1) can be plugged into the subwoofer, the ground lead can be
secured behind the battery and that the loose cable ends are
positioned on the left-hand side of the car.

M3703526

17

Lift the panel and insert the wiring harness (1) with the ground
lead in the gap between the floor support (2) and the panel.

Insert the cable as far under the panel as possible. Ensure that
the cable is not trapped.

Press the panel into place.

Repeat the operation on the other side.

Reinstall the screws in the panel. Tighten.

M3702217

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 12 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

18

Insert a thick cable (1) or something similar through the

loudspeaker cutout behind the D-post panel and out into the
cargo compartment.

Attach the routed wiring harness (2) to the cable with tape and
pull the harness up through the loudspeaker cutout.

Repeat the operation on the other side.

M3702200

Connecting the cable harness

19 Connecting the cable harness

Plug in the existing loudspeaker connector (1) to the

corresponding connector (2) in the new wiring harness.

The remaining connector (3) will be plugged into the

loudspeaker.

Wrap foam tape from the kit around the connectors to prevent
rattling.

Repeat the operation on the other side.

M3903047

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 13 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

20

Reinstall the loudspeakers on the right-hand and left-hand sides

by positioning the guide pins in the corresponding D-post holes.

Raise the loudspeakers until the catches engage.

Push in the red locking mechanism (1).

M3902915

21
Applies to the left-hand loudspeaker.

Pull out the existing wiring harness (1) from the D-post panel
and press it firmly into the loudspeaker clamp (2).

Reinstall both loudspeaker grilles.

Secure the loudspeaker cables to the existing wiring harnesses

at the D-post panel with four tie straps from the kit (two on each
side).

M3903048

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 14 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

22

Connect the routed ground lead to the grounding point (1)

behind the battery and tighten the grounding screw securely.

M3100209

23

Secure the wiring harness to the existing wiring harness at the

rear crossmember with four tie straps (1) from the kit.

M3702201

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 15 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

24

Remove the Rear Electronic Module (REM) by opening the lock

(1) on the top of the unit. Tip the unit forward and lift it out of the
mountings (2).

M3703523

25

Press in the catch on the rear brown connector in the cargo

compartment fuse holder. Turn up the lock arm as far as
possible and pull out the connector.

M3904943

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 16 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

26

Carefully prise apart the sides of the connector holder in the

ends so that the connector can pass by the retaining hooks.

Pull out the connector.

D3703496

27

Plug the two red (R) cables into positions 17 and 18. The cables
can be plugged into either position.

Reinstall the connector in the holder

Reinstall the connector in the fuse holder.

M3703524

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 17 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

28

Press in the catch on the black connector on the reverse side of

the cargo compartment fuse holder. Turn up the lock arm as far
as possible and pull out the connector.

M3904942

29

Carefully prise apart the sides of the connector holder in the

ends so that the connector can pass by the retaining hooks.

Pull out the connector.

M3703366

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 18 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

30

Note!

Make a note of the position number of the connector. The

position numbers are located on the ends of the connector and
in the bottom of the fuse holder.

Plug the violet (VO) cable into position 7 in the connector.

Reinstall the connector in the holder

Reinstall the connector in the fuse holder.

Reinstall the rear electronic module.

M3703525

31

Fold the insulation panel back into place.

Reconnect the battery ground lead.

Reinstall the left-hand side panel.

Reinstall the rear insulation panels.

Reinstall the side cushion.

Fold the seat cushion and backrest back into place.

Reinstall the folding side panels.

32

Insert the strap (1) in the new jack and tool bag holder (2) from
the kit.

Place the tool bag and jack in the holder and secure them with
the strap.

M8901652

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 19 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

33

Place the jack and tool bag holder on top of the spare wheel and
push it towards the front edge of the spare wheel well and the
cable duct (1) as illustrated.

M8901653

Installing the subwoofer

34 Installing the subwoofer

Position the subwoofer in the three anchor points:

the hole in the rear crossmember (1)

the right-hand anchor point (2) for the removed storage box

the two studs (3)

If necessary: Loosen the knob (4) to align the mounting on the

studs.

M3903049

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 20 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

35

Press the subwoofer firmly into place on the right-hand side of

the cargo compartment by turning the clip (1) 90°.

Secure the subwoofer with the knob (2).

Reinstall the battery holder over the subwoofer mounting and

secure it with the nut and bolt.

Install the new nut and tighten the mounting to the subwoofer on
the remaining stud.

M3903050

36

Plug in the routed cable (1) connector to the subwoofer.

Press the cable firmly into place in the cable duct (2).

M3905138

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 21 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

37

Place the carpet from the kit over the subwoofer.

Reinstall both floor hatches.

M8901654

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 22 / 23
 Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden

38

Programme the software in accordance with the service

information in VIDA.

Note!

The software download is carried out in the following order

depending on whether the accessories HU radio, amplifier and
subwoofer have been installed at the same time, whether
amplifier and subwoofer have been installed at the same time,
or if just the subwoofer has been installed.

Applies if HU radio (AUM), amplifier and subwoofer have

been installed:

First download ADD AMPLIFIER.

Then download ADD SUBWOOFER.

Finally, download ADD AUM.

Applies if amplifier and subwoofer have been installed

(existing HU radio):

First download ADD AMPLIFIER.

Then download ADD SUBWOOFER.

Finally, download RELOAD AUM / UPGRADE AUM. This is so

that the radio shall also obtain the correct software in
combination with the new amplifier and subwoofer.

Applies if only subwoofer has been installed (existing HU

radio and amplifier):

First download ADD SUBWOOFER.

Then download RELOAD AUM / UPGRADE AUM. This is so

that the radio shall also obtain the correct software in
combination with the new subwoofer.

Hint

If the downloads are made in the wrong order then repeat

RELOAD / UPGRADE AUM.

© Volvo Car Corporation Subwoofer, cargo compartment- 30730121 - V1.1

Side 23 / 23