SAFETY DATA SHEET

According to Regulation (EC) No. 1907/2006

Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY

1. 1 Product Identifier

Product Name : CEMENT REMOVER

Product Code : SP-KS-050

1.2 Relevant Identified Uses Of The Substance or Mixture and Uses Advised Against

Product Type : CEMENT REMOVER

Uses Advised Against : This product is not recommended for any industrial, professional or consumer use
other than the Intended Uses above.

1.3 Details Of The Supplier Of The Safety Data Sheet

Producer : Ertek Kimya Tic. ve San. A.Ş.

Address : Aydınlı-KOSB Mah. Organik Cad. KOSB Sitesi No:1 Tuzla İSTANBUL / TURKEY
Telephone : 90 0216 499 50 00 – 90 0216 499 50 01
Fax : 90 0216 499 50 02
E-mail & Web Site : [email protected] – www.ertekchemicals.com

1.4 Emergency Telephone Number

Tel. No : 0 216 499 50 00 (08:30-18:00)

NATIONAL POISON : 114
INFORMATION CENTRE

 2. HAZARDS IDENTIFICATION
2.1 Classification of the mixture
Classification according to Regulation (EC) No 1272/2008
Corrosive to metals (Category 1), H290
Skin corrosion (Category 1B), H314
Specific target organ toxicity - single exposure (Category 3), Respiratory system, H335
For the full text of the H-Statements mentioned in this Section, see Section 16
2.2 Label Elements
Labelling according Regulation (EC) No 1272/2008
Hazard Pictograms

Signal word DANGER

Page No: 1 Version 5.2 Revision Date 05.02.2021
 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

Hazard statement(s)
H290 May be corrosive to metals.
H314 Causes severe skin burns and eye damage.
H335 May cause respiratory irritation.
Precautionary statement(s)
P260 Do not breathe dust/ fume/ gas/ mist/ vapours/ spray.
P280 Wear protective gloves/ protective clothing/ eye protection/ face protection.
P303 + P361 + P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower.
P304 + P340 + P310 IF INHALED: Remove person to fresh air and keep comfortable for breathing. Immediately call a POISON
CENTER or doctor/ physician.
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy
to do. Continue rinsing.
Supplemental Hazard none
Statements

2.3 Other Hazards

This substance/mixture contains no components considered to be either persistent, bioaccumulative and toxic (PBT), or very
persistent and very bioaccumulative (vPvB) at levels of 0.1% or higher.Rapidly absorbed through skin.

 3. COMPOSITION/INFORMATION ON INGREDIENTS
3.1 Chemical Composition:
Hazardous ingredients according to Regulation (EC) No 1272/2008

No Ingredients name CAS-NO EC NO Cons.(weight%) Classification

Met. Corr. 1; Skin Corr. 1B;
STOT SE 3; H290, H314,
H335
Concentration limits:
>= 25 %: Skin Corr. 1B,
H314; 10 - < 25 %: Skin
231-595-7 Endeks-No. Irrit.
1 Hydrochloric acid 7647-01-0 20-40
017-002-01-X 2, H315; 10 - < 25 %: Eye
Irrit.
2, H319; >= 10 %: STOT
SE
3, H335; >= 0,1 %: Met.
Corr.
1, H290;
Ingredients that do not contribute to the
2 classification of the product (not 60-80 -
classified)

For the full text of the H-Statements and R-Phrases mentioned in this Section, see Section 16

 4. FIRST AID MEASURE

4.1 Description of first aid measures
If inhaled : If breathed in, move person into fresh air. If not breathing, give artificial respiration.
Consult a physician.
Page No: 2 Version 5.2 Revision Date 05.02.2021
 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

In case of skin contact : Take off contaminated clothing and shoes immediately. Wash off with soap and
plenty of water. Consult a physician.
In case of eye contact : Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician.
If swallowed : Do NOT induce vomiting. Never give anything by mouth to an unconscious person.
Rinse mouth with water. Consult a physician.

4.2 Most Important Symptoms And Effects, Both Acute And Delayed
The most important known symptoms and effects are described in the labelling (see section 2.2) and/or in section 11

4.3 Indication Of Any Immediate Medical Attention And Special Treatment Needed
No data available

 5. FIRE FIGHT MEASURE

5.1 Extinguishing Media
Use water spray, alcohol-resistant foam, dry chemical or carbon dioxide.
5.2 Special Hazards Arising From The Substance or Mixture
Hydrogen chloride gas
5.3 Advice for Firefighters
Wear self contained breathing apparatus for fire fighting if necessary.
5.4 Further Information
No data available.

 6. ACCIDENTAL RELEASE MEASURES

6.1 Personal Precautions, Protective Equipment and Emergency Procedures
Wear respiratory protection. Avoid breathing vapours, mist or gas. Ensure adequate ventilation. Evacuate personnel to safe
areas. Avoid breathing dust.For personal protection see section 8.
6.2 Environmental Precautions
Prevent further leakage or spillage if safe to do so. Do not let product enter drains.
6.3 Methods and Materials for Containment and Cleaning Up
Soak up with inert absorbent material and dispose of as hazardous waste. Keep in suitable, closed
containers for disposal.
6.4 Reference to Other Sections
For disposal see section 13.

 7. HANDLING AND STORAGE

7.1 Precautions for safe handling
Avoid contact with skin and eyes. Avoid formation of dust and aerosols.Provide appropriate exhaust ventilation at places
where dust is formed.For precautions see section 2.2.

7.2 Conditions for Safe Storage, Including Any Incompatibilities

Store in cool place. Keep container tightly closed in a dry and well-ventilated place. Containers which are
opened must be carefully resealed and kept upright to prevent leakage.
Metal containers must be lined. Corrodes metal.

Page No: 3 Version 5.2 Revision Date 05.02.2021

 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

Storage class (TRGS 510): Non-combustible, corrosive hazardous materials

7.3 Specific and Use(s)

Apart from the uses mentioned in section 1.2 no other specific uses are stipulated.

 8. EXPOSURE CONTROLS/PERSONAL PROTECTION

8.1 CONTROL PARAMETERS
Components with workplace control parameters
8.2 Exposure Controls
Appropriate engineering controls
Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end
of workday.
Personal protective equipment
Eye/face protection
Use equipment for eye protection tested and approved under appropriate government standards
such as NIOSH (US) or EN 166(EU).
Skin protection
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without
touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after
use in accordance with applicable laws and good laboratory practices. Wash and dry hands.The selected
protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374
derived from it.
Full contact
Material: Nitrile rubber
Minimum layer thickness: 0,4 mm
Break through time: 480 min
Material tested: Camatril® (KCL 730)
Splash contact
Material: Nitrile rubber
Minimum layer thickness: 0,11 mm
Break through time: 69 min
Material tested: Dermatril® (KCL 740)
data source: KCL GmbH, D-36124 Eichenzell, test method: EN374
If used in solution, or mixed with other substances, and under conditions which differ from EN 374, contact
the supplier of the CE approved gloves. This recommendation is advisory only and must be evaluated by an
industrial hygienist and safety officer familiar with the specific situation of anticipated use by our
customers. It should not be construed as offering an approval for any specific use scenario.
Body Protection
Impervious clothing, The type of protective equipment must be selected according to the concentration and amount of the
dangerous substance at the specific workplace.
Respiratory protection
Respiratory protection not required. For nuisance exposures use type OV/AG (US) or type ABEK (EU EN 14387)
respirator cartridges. Use respirators and components tested and approved under appropriate government
standards such as NIOSH (US) or CEN (EU).
Control of environmental exposure
Do not let product enter drains..

Page No: 4 Version 5.2 Revision Date 05.02.2021

 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

 9. PYHSICAL AND CHEMICAL PROPERTIES

9.1 Information On Basic Physical and Chemical Properties

Form: Fuming liquid Specific Gravity: -1.16 gr/cm3 (at Colour: Yellowish
15°C)
Rel. vapour density: Not applicable Odor : Pungent odor of hydrogen Ignition temp: -
chloride.
Solubility in Water: Infinite in water Density: 1.10 – 1.20 gram / cm3 Expl.limit: Not established
with slight evolution of heat
MeltingPoint/range: -25ºC VapourDensity(Air=1):No Vapour pressure: 190 25ºC(77ºF)
information found
Boiling Point: 53ºC(127ºF) Saturaction conc : Not applicable Decomposition temp.: Not
Azeotrope(20.2 %) boils at applicable
109ºC(228ºF)
Viscosity: 1.9 mPa.s (at 150 °C) Flash Point: Not applicable pH: < 1.0

9.2 Other safety information

No data available

 10. STABILITY AND REACTIVITY

10.1 Reactivity
Corrosive in contact with metals
10.2 Chemical Stability
Stable under recommended storage conditions.
10.3 Possibility of Hazardous Reactions
Exothermic reaction with:, Amines, Aldehydes, permanganates, e.g. potassium permanganate, Risk of
ignition or formation of inflammable gases or vapours with:, Aluminium, Carbides, Fluorine, Metals, Bases, Sulphides, Risk of
explosion with:, Alkali metals, Sulphuric acid, Gives off hydrogen by reaction with metals.
10.4 Conditions to Avoid
No data available
10.5 Incompatible Materials
Metals

10.6 Hazardous Decomposition Products

Other decomposition products - No data available
In the event of fire: see section 5
 11. TOXICOLOGICAL INFORMATION
Page No: 5 Version 5.2 Revision Date 05.02.2021
 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

11.1 Information on Toxicological Effects

EXPOSURE LIMITS
Acute toxicity
No data available
Inhalation: Inhalation may provoke the following symptoms: Respiratory irritation Cough Difficulty in breathing Pneumonia
(Hydrochloric acid)
Skin corrosion/irritation
Skin - Rabbit (Hydrochloric acid)
Result: Causes burns.
Serious eye damage/eye irritation
Eyes - Rabbit (Hydrochloric acid)
Result: Corrosive to eyes
Respiratory or skin sensitisation
Did not cause sensitisation on laboratory animals. (Hydrochloric acid)
Germ cell mutagenicity
No data available
Carcinogenicity
This product is or contains a component that is not classifiable as to its carcinogenicity based on its IARC,
ACGIH, NTP, or EPA classification. (Hydrochloric acid)
(Hydrochloric acid)
IARC: 3 - Group 3: Not classifiable as to its carcinogenicity to humans (Hydrochloric acid)
Reproductive toxicity
No data available
Specific target organ toxicity - single exposure
The substance or mixture is classified as specific target organ toxicant, single exposure, category 3 with
respiratory tract irritation. (Hydrochloric acid)
Specific target organ toxicity - repeated exposure
The substance or mixture is not classified as specific target organ toxicant, repeated exposure.
Aspiration hazard
No aspiration toxicity classification (Hydrochloric acid)
Additional Information
RTECS: MW4025000
Inhalation of vapors may cause:, burning sensation, Cough, wheezing, Shortness of breath, spasm, inflammation and edema
of the larynx, spasm, inflammation and edema of the bronchi, pneumonitis, pulmonary edema (Hydrochloric acid)

 12. ECOLOGICAL INFORMATION

12.1 Toxicity
Toxicity to fish LC50 - Lepomis macrochirus (Bluegill) - 24,6 mg/l - 96 h (Hydrochloric acid)
Toxicity to daphnia and EC50 - Daphnia magna (Water flea) - 4,91 mg/l - 48 h (Hydrochloric acid)
other aquatic
invertebrates

12.2 Persistence and Degradability

No data available
12.3 Bioaccumulative Potential
No data available
Page No: 6 Version 5.2 Revision Date 05.02.2021
 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

12.4 Mobility in Soil

No data available
12.5 Results of PBT and vPvB Assessment
This substance/mixture contains no components considered to be either persistent, bioaccumulative and toxic (PBT), or very
persistent and very bioaccumulative (vPvB) at levels of 0.1% or higher
12.6 Other Adverse Effects
May be harmful to aquatic organisms due to pH change. Do not empty into drains.

 13. DISPOSAL CONSIDERATIONS

13.1 Waste Treatment
Methods
Product
Offer surplus and non-recyclable solutions to a licensed disposal company.
Contaminated Packaging
Dispose of as unused product.

 14. TRANSPORT INFORMATION

14.1 UN Number
ADR/RID: 3264
IMDG: 3264
IATA: 3264

14.2 Proper Shipping Name

ADR/RID: CORROSIVE LIQUID,ACIDIC,INORGANIC,N.O.S(Hydrochloric acid)
IMDG: CORROSIVE LIQUID,ACIDIC,INORGANIC,N.O.S (Hydrochloric acid)
IATA: CORROSIVE LIQUID,ACIDIC,INORGANIC,N.O.S (Hydrochloric acid)

14.3 Transport Hazard Class(es)

ADR/RID:8
IMDG: 8
IATA: 8

14.4 Packaging Group

ADR/RID: III
IMDG: III
IATA: III

14.5 Environmental Hazards

ADR/RID: no
IMDG Marine pollutant: no
IATA: no

14.6 Special Precautions For User

no data available
Page No: 7 Version 5.2 Revision Date 05.02.2021
 SAFETY DATA SHEET
According to Regulation (EC) No. 1907/2006
Regulation on the Safety Data Sheet Relating to Hazardous
Substances and mixtures (12/13/2014 Date and Official Gazette No. 29204)
Version 5.2 Revision Date 05.02.2021
Print Date 05.02.2021

 15. REGULATORY INFORMATION

This safety datasheet complies with the requirements of Regulation (EC) No. 1907/2006.

15.1 Safety, Health and Environmental Regulations/Legislation Specific for the Substance or Mixture
No data available

15.2 Chemical Safety Assessment

No data available

 16. OTHER INFO

H290 May be corrosive to metals.
H314 Causes severe skin burns and eye damage.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
H335 May cause respiratory irritation.
This safety data sheet has been prepared on the basis of information given by our suppliers and our present knowledge.
Information given is intended to present guidelines for safe handling, use, processing, storage, transport, disposal and
discharge; it is not intended to be a guarantee or quality specification. The intent of this safety data sheet is to give a
description of the product with regard to safe storage, handling and use. Information given applies only to the product itself,
and not in combination with other products or in any processed form, unless this is specified in the text. We believe that all
information in this safety data sheet (which replaces all previous versions) was correct at the date of issue. It is the
responsibility of the recipient of this safety data sheet to ensure that information given here is read and understood by all
who use, handle, dispose of or in any way come in contact with the product.

Page No: 8 Version 5.2 Revision Date 05.02.2021