TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-...

Page 1 of 11

search

TASK 05-10-01-200-001-C00 Group A Parts Lives

(V2522-A5, V2524-A5, V2527-A5, and V2527M-A5)
DMC: V2500-A5-05-10-0100-01A-288A-D | Issue No: 001 | Issue Date: 2013-11-01

Export Control
EAR Export Classification: Not subject to the EAR per 15 C.F.R. Chapter 1, Part 734.3(b)
(3), except for the following Service Bulletins which are currently published as EAR Export
Classification 9E991:
SBE70-0992, SBE72-0483, SBE72-0580, SBE72-0588, SBE72-0640, SBE73-0209,
SBE80-0024 and SBE80-0025.

Copyright
© IAE International Aero Engines AG (2001, 2014 - 2015)
The information contained in this document is the property of © IAE International Aero
Engines AG and may not be copied or used for any purpose other than that for which it is
supplied without the express written authority of © IAE International Aero Engines AG.
(This does not preclude use by engine and aircraft operators for normal instructional,
maintenance or overhaul purposes.).

Applicability
V2500-A5

Description
1. TASK 05-10-01-200-001-C00 Group A Parts Lives
(V2522-A5, V2524-A5, V2527-A5, and V2527M-A5)
A.

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 2 of 11

General

CAUTION
THE FOLLOWING AIRWORTHINESS
LIMITATIONS HAVE BEEN SUBSTANTIATED
BASED ON ENGINEERING ANALYSIS THAT
ASSUMES THIS PRODUCT WILL BE OPERATED
AND MAINTAINED USING THE PROCEDURES
AND INSPECTIONS PROVIDED IN THE
INSTRUCTIONS FOR CONTINUED
AIRWORTHINESS SUPPLIED WITH THIS
PRODUCT BY THE TYPE CERTIFICATE
HOLDER, OR ITS LICENSEES. FOR ENGINE
CRITICAL PARTS AND PARTS THAT INFLUENCE
ENGINE CRITICAL PARTS, ANY REPAIR,
MODIFICATION OR MAINTENANCE
PROCEDURES NOT APPROVED BY THE TYPE
CERTIFICATE HOLDER, OR ITS LICENSEES, OR
ANY SUBSTITUTION OF SUCH PARTS NOT
SUPPLIED BY THE TYPE CERTIFICATE
HOLDER, OR ITS LICENSEES, MAY
MATERIALLY AFFECT THESE LIMITS. IN SUCH
CIRCUMSTANCES, APPROPRIATE
AIRWORTHINESS LIMITATION SHOULD BE
OBTAINED FROM THE APPLICANT
RESPONSIBLE FOR THE REPAIR,
MODIFICATION OR SUBSTITUTE PARTS.

(1) The information below is not intended as authority for interchangeability.

Refer to the applicable Service Bulletins for interchangeability information.

(2) For definition of an Engine Cycle refer to Chapter/Section 05-10-00 of this

manual.

B. Group A Parts Lives

APPROVED LIFE (FLIGHT

LOW PRESSURE COMPRESSOR (LPC) - GROUP A PART LIVES: CYCLES)

5A0338 - LPC Stage 1 Fan Disk 20,000

(72-31-12,01-310)

(Part of 5A0337 - LPC Stage 1 Fan Disk Assembly

(72-31-12,01-200))

5A1758 - LPC Stage 1 Fan Disk (SBE 70-0712) 20,000

(72-31-12,01-310)

(Part of 5A1757 - LPC Stage 1 Fan Disk Assembly

(72-31-12,01-200))

5A1949 - LPC Stage 1 Fan Disk (SBE 70-1001) 20,000

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 3 of 11

(72-31-12,01-310)

(Part of 5A1948 - LPC Stage 1 Fan Disk Assembly

(72-31-12,01-200))

5A0896 - Stub Shaft 20,000

(72-32-51,01-400)

(Part of 5A0895 - Stub Shaft Assembly (72-32-51,01-

350))

5R0161 - LPC Stage 1.5 To 2.5 Disk 20,000

(72-32-81,02-205)

(Part of 5R0159 - LPC Stage 1.5 To 2.5 Disk

Assembly (72-32-81,02-200))

APPROVED LIFE
HIGH PRESSURE COMPRESSOR (HPC) - GROUP A PART LIVES: (FLIGHT CYCLES)

6A4929 - HPC Stage 3 To 8 Disk 10,000

(72-41-11,01-245)

(Part of 6A4900, 6A7383 (SBE 72-0304), 6B1387 (SBE 72-

0606) - HPC Stage 3 To 8 Disk Assembly (72-41-11,01-200))

NOTE
Do not start at zero flight cycles when the HPC Stage 3 To
8 Disk has been reworked to SBE 72-0304 and SBE 72-
0606. Continue to add to existing flight cycles.

6A5468 - HPC Stage 3 To 8 Disk (SBE 72-0178) 15,000

(72-41-11,01-245)

(Part of 6A5467, 6A7384 (SBE 72-0304), 6B1379 (SBE 72-

0606) - HPC Stage 3 To 8 Disk Assembly (72-41-11,01-200))

NOTE
Do not start at zero flight cycles when the HPC Stage 3 To
8 Disk has been reworked to SBE 72-0304 and SBE 72-
0606. Continue to add to existing flight cycles.

6A6474 - HPC Stage 3 To 8 Disk (SBE 72-0254) 16,000

(72-41-11,01-245)

(Part of 6A6473, 6A7385 (SBE 72-0304), 6B1380 (SBE 72-

0606) - HPC Stage 3 To 8 Disk Assembly (72-41-11,01-200))

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 4 of 11

NOTE
Do not start at zero flight cycles when the HPC Stage 3 To
8 Disk has been reworked to SBE 72-0304 and SBE 72-
0606. Continue to add to existing flight cycles.

6A7402 - HPC Stage 3 To 8 Disk (SBE 72-0300) 16,000

(72-41-11,01-245)

(Part of 6A7401 (SBE 72-0300), 6B1384 (SBE 72-0606) -

HPC Stage 3 To 8 Disk Assembly (72-41-11,01-200))

NOTE
Do not start at zero flight cycles when the HPC Stage 3 To
8 Disk has been reworked to SBE 72-0606. Continue to add
to existing flight cycles.

6A7706 - HPC Stage 3 To 8 Disk (SBE 72-0376) 20,000

(72-41-11,01-245)

(Part of 6A7705 (SBE 72-0376), 6B1385 (SBE 72-0606) -

HPC Stage 3 To 8 Disk Assembly (72-41-11,01-200))

NOTE
Do not start at zero flight cycles when the HPC Stage 3 To
8 Disk has been reworked to SBE 72-0606. Continue to add
to existing flight cycles.

6A8317 - HPC Stage 3 To 8 Disk (SBE 72-0470) 20,000

(72-41-11,01-245)

(Part of 6A8316 (SBE 72-0470), 6B1386, 6B1404 (SBE 72-

0606) - HPC Stage 3 To 8 Disk Assembly (72-41-11,01-200))

NOTE
Do not start at zero flight cycles when the HPC Stage 3 To
8 Disk has been reworked to SBE 72-0606. Continue to add
to existing flight cycles.

6A4156 - HPC Stage 9 To 12 Disk Assembly 14,300

(72-41-12,01-600)

6A6546 - HPC Stage 9 To 12 Disk Assembly (SBE 72-0273) 20,000

(72-41-12,01-600)

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 5 of 11

6A7546 - HPC Stage 9 To 12 Disk Assembly (SBE 72-0347) 20,000

(72-41-12,01-600)

6A7547 - HPC Stage 9 To 12 Disk Assembly (SBE 72-0347) 14,300

(72-41-12,01-600)

6A4158 - HPC Rear Shaft 10,000

(72-41-13,01-900)

(Part of 6A4157 - HPC Rear Shaft Assembly (72-41-13,01-

850))

6A7714 - HPC Rear Shaft (SBE 72-0403) 10,000

(72-41-13,01-900)

(Part of 6A7713, 6B1426 (SBE 72-0614) - HPC Rear Shaft

Assembly (72-41-13,01-850))

NOTE
For engines not incorporating SBE 72-0202.

6A5868 - HPC Rear Shaft (SBE 72-0202) 20,000

(72-41-13,01-900)

(Part of 6A5867 - HPC Rear Shaft Assembly (72-41-13,01-

850))

6A7712 - HPC Rear Shaft (SBE 72-0403) 20,000

(72-41-13,01-900)

(Part of 6A7711, 6B1419 (SBE 72-0614) - HPC Rear Shaft

Assembly (72-41-13,01-850))

NOTE
For engines not incorporating SBE 72-0202.

6A4392 - HPC Rear Rotating Seal 15,000

(72-41-14,01-800)

6A5869 - HPC Rear Rotating Seal (SBE 72-0202) 20,000

(72-41-14,01-800)

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 6 of 11

APPROVED LIFE
HIGH PRESSURE TURBINE (HPT) - GROUP A PART LIVES: (FLIGHT CYCLES)

2A2201 - HPT Stage 1 Hub 15,000

(72-45-11,01-011)

2A2801 - HPT Stage 1 Hub (SBE 72-0238) 15,000

(72-45-11,01-011)

(Part of 2A3301 - HPT Stage 1 Rotor Assembly (72-45-

10,01-010))

2A5001 - HPT Stage 1 Hub (SBE 72-0327) 20,000

(72-45-11,01-011)

2A1350 - HPT Stage 1 Rotating Outer Air Seal 15,000

(72-45-12,01-040)

2A3423 - HPT Stage 1 Rotating Outer Air Seal (SBE 72- 20,000
0327)

(72-45-12,01-040)

2A1352 - HPT Stage 1 Rotating Inner Air Seal 8,000

(72-45-13,01-020)

2A3032 - HPT Stage 1 Rotating Inner Air Seal (SBE 72- 15,000
0180)

(72-45-13,01-020)

NOTE
If 2A1352 air seal is reworked to SBE 72-0180 before
5,500 cycles and identified to 2A3032, the approved life
limit is a total of 15,000 cycles.

2A3032 - HPT Stage 1 Rotating Inner Air Seal (SBE 72- 8,000
0180)

(72-45-13,01-020)

NOTE
If 2A1352 air seal is not reworked to SBE 72-0180 before
5,500 cycles and identified to 2A3032, the approved life
limit is a total of 8,000 cycles.

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 7 of 11

2A3069 - HPT Stage 1 Rotating Inner Air Seal (SBE 72- 15,000
0190)

(72-45-13,01-020)

NOTE
If 2A1352 air seal is reworked to SBE 72-0190 before
5,500 cycles and identified to PN 2A3069, the approved
life limit is a total of 15,000 cycles.

2A3069 - HPT Stage 1 Rotating Inner Air Seal (SBE 72- 8,000
0190)

(72-45-13,01-020)

NOTE
If 2A1352 air seal is not reworked to SBE 72-0190 before
5,500 cycles and identified to PN 2A3069, the approved
life limit is a total of 8,000 cycles.

2A3086 - HPT Stage 1 Rotating Inner Air Seal ( SBE 72- 15,000
0194)

(72-45-13,01-020)

2A3424 - HPT Stage 1 Rotating Inner Air Seal ( SBE 72- 20,000
0327)

(72-45-13,01-020)

2A3923 - HPT Stage 1 Rotating Inner Air Seal ( SBE 72- 20,000
0511)

(72-45-13,01-020)

2A1161 - HPT Stage 2 Rotating Air Seal 15,000

(72-45-00,01-080)

(Part of 2A1160 - HPT Stage 2 Air Seal Assembly (72-45-

00,01-080))

2A3107 - HPT Stage 2 Air Seal (SBE 72-0207) 15,000

(72-45-00,01-080)

(Part of 2A3108 - HPT Stage 2 Air Seal Assembly (72-45-

00,01-080))

2A3179 - HPT Stage 2 Rotating Air Seal (SBE 72-0240) 15,000

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 8 of 11

(72-45-00,01-080)

2A3425 - HPT Stage 2 Rotating Air Seal (SBE 72-0327) 20,000

(72-45-00,01-080)

2A3596 - HPT Stage 2 Rotating Air Seal (SBE 72-0412) 20,000

(72-45-00,01-080)

2A4157 - HPT Stage 2 Rotating Air Seal (SBE 72-0534) 20,000

(72-45-00,01-080)

2A2302 - HPT Stage 2 Hub 15,000

(72-45-31,01-011)

2A3002 - HPT Stage 2 Hub (SBE 72-0145) 15,000

(72-45-31,01-011)

(Part of 2A2822 HPT Stage 2 Rotor Assembly (72-45-30,01-

010))

2A4802 - HPT Stage 2 Hub (SBE 72-0327) 20,000

(72-45-31,01-011)

2A2097 - HPT Stage 2 Blade Retaining Plate 15,000

(72-45-33,01-020)

2A3426 - HPT Stage 2 Blade Retaining Plate (SBE 72- 15,000

0327)

(72-45-33,01-020)

2A3437 - HPT Stage 2 Blade Retaining Plate (SBE 72- 20,000

0328)

(72-45-33,01-020)

APPROVED LIFE (FLIGHT

LOW PRESSURE TURBINE (LPT) - GROUP A PART LIVES: CYCLES)

3A2151 - LPT Stage 3 Disk 20,000

(72-50-31,01-200)

3A2428 - LPT Stage 3 Disk (SBE 70-0522) 20,000

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V2527-... Page 9 of 11

(72-50-31,01-200)

3A2508 - LPT Stage 3 Disk (SBE 72-0307) 20,000

(72-50-31,01-200)

3A2513 - LPT Stage 3 Disk (SBE 70-0705) 20,000

(72-50-31,01-200)

3A1984 - LPT Stage 4 Disk 20,000

(72-50-31,01-150)

3A2153 - LPT Stage 5 Disk 20,000

(72-50-31,01-100)

3A2430 - LPT Stage 5 Disk (SBE 70-0522) 20,000

(72-50-31,01-100)

3A1986 - LPT Stage 6 Disk 20,000

(72-50-31,01-050)

3A2996 - LPT Stage 6 Disk (SBE 70-0942) 20,000

(72-50-31,01-050)

3A1987 - LPT Stage 7 Disk 20,000

(72-50-31,01-010)

3A2424 - LPT Stage 7 Disk (SBE 70-0522) 20,000

(72-50-31,01-010)

3A2512 - LPT Stage 7 Disk (SBE 72-0307) 20,000

(72-50-31,01-010)

3A2514 - LPT Stage 7 Disk (SBE 70-0705) 20,000

(72-50-31,01-010)

3A0963 - LPT Stage 3 Rotating Air Seal 20,000

(72-50-33,01-200)

3A1983 - LPT Stage 4 Rotating Air Seal 20,000

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V252... Page 10 of 11

(72-50-33,01-150)

3A2422 - LPT Stage 4 Rotating Air Seal (SBE 70- 20,000

0522)

(72-50-33,01-150)

3A1985 - LPT Stage 5 Rotating Air Seal 20,000

(72-50-33,01-100)

3A2423 - LPT Stage 5 Rotating Air Seal (SBE 70- 20,000

0522)

(72-50-33,01-100)

3A0078 - LPT Stage 6 Rotating Inner Air Seal 20,000

(72-50-00,01-240)

3A3063 - LPT Stage 6 Rotating Inner Air Seal 20,000

(SBE 72-0567)

(72-50-00,01-240)

3A3047 - LPT Stage 6 Rotating Inner Air Seal 20,000

(SBE 72-0626)

(72-50-00,01-240)

3A1988 - LPT Stage 6 Rotating Air Seal 20,000

(72-50-33,01-050)

3A1741 - LPT Stage 7 Rotating Air Seal 20,000

(72-50-33,01-010)

3A2522 - LPT Stage 7 Rotating Air Seal (SBE 70- 20,000

0707)

(72-50-33,01-010)

5A0864 - LPT Shaft 20,000

(72-50-41,01-200)

5A1732 - LPT Shaft (SBE 70-0488) 20,000

(72-50-41,01-200)

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016
TASK 05-10-01-200-001-C00 Group A Parts Lives (V2522-A5, V2524-A5, V252... Page 11 of 11

5A1762 - LPT Shaft (SBE 70-0605) 20,000

(72-50-41,01-200)

International Aero Engines Proprietary Information © 2014 - 2015.EAR Export Classification:

Not subject to the EAR per 15 C.F.R. Chapter 1, Part 734.3(b)(3).

http://127.0.0.1:8000/V2500-77445-A4406-00/V2500-A5-05-10-0100-01A-288A-D.... 09.05.2016