Service Manual

Portable Radio Cassette

DAEWOO ELECTRONICS EUROPE.GmbH

with CD/MP3/USB/Card Slot Player

TP-605GUC

DAT H.K. LIMITED

CONTENTS :

# MODEL SPECIFICATION P.1-7

# SCHEMATIC DIAGRAM P.8-9

# PCB LAYER DIAGRAM P.10-13

# WIRING DIAGRAM P.14

# BLOCK DIAGRAM P.15

# EXPLODE DIAGRAM P.16

# PART LIST P.17-24

 PAGE:1 OF 7

MODEL NUMBER: UC966DR(2W)

CUSTOMERS MODEL NUMBER: TP-605GUC
BRAND:
TYPE OF SET: PORTABLE RADIO CASSETTE WITH CD/MP3/USB/CARD SLOT PLAYER
DATE: 15/4/2006

STANDARD TEST CONDITIONS

SUPPLY VOLTAGE: DC: V, AC: 230 V, 50 Hz
REFERENCE OUTPUT POWER: 50 MW INTO 4 OHM LOAD
AM ANTENNA: IRE
LOOP ANT.
AM STANDARD SIGNAL: 400 Hz , 30% MODULATION
FM ANTENNA: 75 OHMS , UN BALANCED
FM STANDARD SIGNAL MONO: 1 KHz , 22.5 KHz DEVIATION
FM STANDARD SIGNAL (STEREO): 1 KHz , 75 KHz DEVIATION

1 UV=1 UV= 0 dB FOR RADIO FREQUENCY

1 V = 1 V = 0 dB FOR AUDIO FREQUENCY

ELEC ENCR: APPROVER: MANAGER: .

 PAGE: 2 OF 7

AM PERFORMANCE SPECIFICATIONS (MW)

No. Test Items Unit Nominal Limit Remark1

1 Intermediate frequency KHz 465 +/-3
2 Tuning range KHz 520-1630
3 Dial calibration 612KHz KHz
1404KHz KHz
612KHZ dB/M
4 MAX SENS 999KHz dB/M
1404KHz dB/M
20 dB quieting 612KHz dB/M 58 66
5 999KHz dB/M 58 64
sensitivity 1404KHz dB/M 58 64
6 IF rejection 612KHz dB 45 35
7 Image rejection 1404KHz dB 35 30
8 S/N ratio 5mV/M input dB 35 30
9 AGC figure of merit 100mV/M dB 45 35
10 A.C.A at 20dB S/N +/-10KHz dB 20 14
11 -6dB band width at 20 dB S/N KHz 8 5-10
12 T.H.D 5mV/M 30% mod % 1 3
100m/V/M 80% mod % 3 5
13 Modulation hum 100mV/M dB 40 35
14 Frequency response -6dB low Hz 60 100
400 Hz=0dB, 5mV/M high Hz 2200 1800
15 Output power %mod, 5mV/M W
16 10% THD power 80% mod, 5mV/M W 2 1.8
17 Hum & Noise level VR min mV 3 5
18 Whistle at 5mV/M IFX2, FIX3 %
19 Spurious response at 1400 KHz
2.5 MHz - 10MHz dB
20 AM signal meter 5mV/M %
21 Record beat 5mV/M %
22 FAIL OUT VOLTAGE (DC) V
23 SEEK SENSITIVITY db/M
 PAGE: 3 OF 7

FM PERFORMANCE SPECIFICATIONS

No. Test Items Unit Nominal Limit Remark1

1 Intermediate frequency MHz 10.7 +/-0.1
2 Tuning range MHz 87.35-108.25 +/-0.15 '+/-0.25
3 Dial calibration 90MHz KHz
106MHz KHz
90KHZ uV
4 MAX SENS 98MHz uV
106MHz uV
30 dB quieting 90MHz uV 10 20
5 98MHz uV 10 20
sensitivity 106MHz uV 10 20
6 IF rejection 90MHz dB 50 45
7 Image rejection 106MHz dB 25 20
8 S/N ratio1mV input 22.5 KHz dev dB 40 35
9 3 dB limiting sensitivity uV 10 20
10 T.H.D 22.5 KHz dev % 0.65 1.5
11 AM suppression dB 32 26
12 Modulation hum100mv 22.5KHz dev dB 40 35
13 AFC hold rang - 3 dB l mV KHz 300 200~400
14 Frequency response -3dB Hz 60 100
KHz 5 3.5
15 Overload break mV
16 Output power 32 KHz dev 1mV W
17 10% THD power 75KHz dev. 1mV W 2 1.8
18 Hum & Noise level mV 3 5
19 Spurious response dB
20 Muting on level uV
21 Muting bandwidth KHz
22 Alternate channel selectivity 0.1 mV
input +/- KHz dB
23 Capture ration 1mV dB
24 FAIL OUTPUT VOLTAGE (DC) V
SEEK SENSITIVITY db
 PAGE: 4 OF 7

FM PERFORMANCE SPECIFICATIONS

NO. Test items Unit Norminal Limit Remark1

25 MPX indicator sens. uV 10 20
100Hz dB W/Z 19KHz
26 MPX separation 1k Hz dB 26 22 FILTER
10K Hz dB
27 MPX T.H.D. Main 400 Hz % 2 4 W/Z 19KHz
L. or R. 1K Hz % 2 4 FILTER
4 MAX 50dB quieting
28 Sensitivity 98MHz dB
28 MPX S/N ratio dB 35 28 W/Z 19KHz
FILTER
30 FM signal meter %
31 SCA Signanl Suppression dB
 PAGE: 5 OF 7
CASSTETTE ( MAGNET ERASE )

NO. Test items Unit Nominal Limit Remark1

1 Tape speed B-111N % 3000 Hz +3,-2
2 Wow & Flutter WRMS JIS B-111N % 0.1 0.35
3 Distortion B-118N % 1 3
4 S/N ratio B-112S dB 45 40
5 Cross talk B-121N dB 35 28
6 Separation B-141N dB 30 25
7 Hum & noise VR Max mV 40 70
8 Hum & noise VR min mV 3 5
Frequency response 125 Hz dB 0 +/-4
9 1000 Hz dB 0 0
Play Back (B-257) 6300 Hz dB 0 +/-4
10 Output level mV
11 10% THD power B-112BN W 2 1.8
12 Max power B-112BN W
S/N Recording/P.B. Normal dB 30 25
13 at -62 dbv, 1k Hz Cro2 dB
CD PLAY, SONY 3 - 16 Matal dB N
Erase ratio Normal dB 30 25
14 at -59 dbv, 1k Hz Cro2 dB
CD PLAY, SONY 3 - 16 Matal dB
Rec/P.B. Level Normal dB 0 +/-3 REF:B-212
15 at -66 dbv, 1k Hz Cro2 dB
CD PLAY, SONY 3 - 18 Matal dB
16 Line input sensitivity dB
17 Mic input sensitivity dB
18 Peak level 1 dB
Peak level 2 dB
Frequency response Rec./P. 125 Hz dB 0 +/-6
19 Recording level (B-257) 1000Hz dB 0 0
CD PLAY, SONY3 7000Hz dB 0 +/-6
Rec./ P.B. distorion Normal % 5 8
20 -66 dBV, 1K Hz Cr02 %
CD PLAY, SONY 3-18 Metal %
21 AlC Rec. /P.B. distortion -56 dbv %
input 1K Hz CD PLAY, SONY 3-14
22 FAIL OUTPUT VOLTAGE (DC) V
(AC) %
 PAGE: 6 OF 7

(CD BUIDE IN) (TEST AT SPKD OUTPUT)

NO. Test items Unit Nominal Limit Remark1
1 LEVEL 0dB TRACK 1.3,11 dB 0.5 +/-3.5
FREQUENCY RESPONSE 40 - 15KHz dB
2 LEVEL 0dB TRACK 30,34 dB 40 35 JIS A NET IN
CHANNEL SEPARATION 1KHz
3 LEVEL 0dB TRACK 14 % 1 3 JIS A NET IN
TOTAL HARMONNIC DISTORTION
4 LEVEL 0dB TRACK 1, 23 dB 55 50 JIS A NET IN
S/N RATIO
5 Hum & Noise VR Max 8 12
Hum & Noise VR min mV 3 5

6 CD SAME VOL dB

PLAYABILITY
NO TEST ITEMS TEST
DISC
1 DEFECT DISC INTERRUPTION PHILIPS PLAYABLE WITHOUT ANY
444A AUDIBLE ERROR
INFORMATION LAYER 600um
2 PHILIPS PLAYABLE WITHOUT ANY
BLACK DOT AT READ OUT SIDE 444A AUDIBLE ERROR
600um
3 PHILIPS
SIMULATED FINGERPRINT 444A PLAYABLE WITHOUT ANY
TRACK AUDIBLE ERROR
18/19
1 Test Items Unit Norminal Limit Remark1

TEST DISC TYPE 3 (SONY YEDS - )

 PAGE: 7 OF 7

AUDIO LEVEL BALANCE

No. Unit Norminal Limit Remark0
FM 1000uV 22.5K DEV. dB 0 0
FM FUNC.1mV AM 5mV/M30%MOD dB 0 +/-3
22.5KHz DEV TAPE - 10dB 1KHz MTT-118 dB 0 +/-3
(FM LEVEL 0dB) CD-10 dB RECORDING LEVEL dB +3 +/-3
 PAGE:1/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

1 158-966001-00 1 966DR PM1 ASSʼY 主板组合件
2 133-208227-14 1 I.C TA8227P 集成电路 IC5
3 133-102111-67 1 I.C SA2111 集成电路 IC3
4 133-207312-11 1 I.C AN7312 集成电路 IC4
5 133-507805-61 1 I.C KA7805 集成块 U3
6 133-008020-00 1 I.C S5L8020 集成电路 U9
7 133-0TMC51-61 1 IC TMC51F 集成电路 U8
8 133-004004-8A 1 I.C EN29LV040A-70PC 集成电路 U10
9 133-006392-18 1 I.C BA6392FP 集成电路 U7
10 133-501117-06 1 I.C AZ1117H-3.3V 集成电路 U1
11 137-169344-30 1 CRYSTAL 16.9344MHZ 金属外壳 晶振 Y2
12 137-120000-30 1 CRYSTAL 12.0000MHZ 金属外壳 晶振 Y1
13 131-240882-67 1 TRANSISTOR PS D882P 三极管 Q22
14 131-449018-07 2 TRANSISTOR S9018 三极管 Q3.12
15 131-448050-03 1 TRANSISTOR 2SD8050 三极管 Q19
16 130-134148-00 9 DIODE 1N4148 （带式） 二级管 D2.4.5.6.7.9.10.13.15.
17 130-410039-00 2 ZENER DIODE 3.9V（带式） 稳压二极管 ZD3.4
18 130-410043-00 1 ZENER DIODE 4.3V（带式） 稳压二极管 D1
19 130-410082-00 1 ZENER DIODE 8.2V（带式） 稳压二极管 ZD1
20 130-314002-00 4 DIODE 1N4002 （带式） 二极管 D3.11.12.14
21 182-222000-00 1 FUSE T2AL 250V(5*20MM) 保险丝 F1
22 733-005020-00 2 FUSE HOLDER (5*20 MM) 保险丝支架 F1
23 107-300465-14 1 CERAMIC FILTER 465KHZ TDK 滤波器 CF1
24 107-310700-14 1 CERAMIC FILTER 10.7 MHz(TDK-3P) 滤波器 CF2
25 102-111083-07 1 AM IFT 083B YELLOW 黄周 T1
26 102-219128-07 1 FM DET 9128 PINK 粉周 T2
27 102-819812-07 1 AM OSC 9812 RED 红周 T3
28 104-035045-08 1 FM COIL 4.5x3.5Tx0.8MM 线圈 L2
29 104-025050-08 1 FM COIL 5.0x2.5Tx0.8MM 线圈 L6
30 104-045045-08 1 FM COIL 4.5x4.5Tx0.8MM 线圈 L8
31 303-101010-00 2 SPONGE 10*10*10MM 低密度海棉
32 120-110401-04 1 PVC AM126PF FM20PF KG2220T28 （NCE） 可变电容 PVC 1
DF443DF01-A04
33 183-220080-02 1 FERRITE BAR 10 x 80MM Q2M 磁棒
34 103-412015-13 1 AM ANT. COIL 120:15 130MMx4 ＡＭ线圈
35 105-220101-05 13 CHOKE COIL 22UH （带式） 电感 L5.7.9.10.11.12.13.17.19.21.24.25.27.
36 184-090503-00 1 FERRITE BEAD 9*5*3mm+26UH CHOKE COIL 磁环线圈 T101
37 141-043111-11 2 SLIDE SWITCH SK43D03M11 功能开关
38 144-062040-05 1 REC SW 6P2T PS62D04 NON-SHORTING 录放开关 SW 201 ( 非短路型)
39 102-819908-01 1 BIAS COIL 21364-230 偏压线圈 T5
OR 102-819908-02 0 BIAS COIL 1A1630R 偏压线圈 T5
40 161-103513-20 1 3.5JACK 5PIN TC-38-020-03 耳机插座 JACK1
41 111-36706-01 1 VOLUME F-122KGP A50K L15FX5 电位器 与CDC367同一款
42 126-102071-01 1 MYLAR CAP 0.001UF +/-20% 50V 聚脂电容 C102
43 126-152071-01 3 MYLAR CAP 0.0015UF +/-20% 50V 聚脂电容 C81.82.103.
44 126-392071-01 1 MYLAR CAP 0.0039UF +/-20% 50V 聚脂电容 C101
45 126-332071-01 2 MYLAR CAP 0.0033UF +/-20% 50V 聚脂电容 C94.96
46 126-223071-01 2 MYLAR CAP 0.022UF +/-20% 50V 聚脂电容 C93.97.
47 126-224071-01 2 MYLAR CAP 0.22UF 50V 绦纶电容 C45.46.
48 127-105078-01 3 ELE.CAP 1UF/50V +/-20% 电解电容 C6.8.90.
49 127-225078-01 3 ELE.CAP 2.2UF/50V +/-20% 电解电容 C50.122.161.
50 127-475078-01 16 ELE.CAP 4.7UF/50V +/-20% 电解电容 C7.9.25.26.52.78.79.84.86.95.98.104.105.
C118.119.120.
 PAGE:2/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

51 127-105078-01 3 ELE.CAP 10UF/50V +/-20% 电解电容 C22.87.301.
52 127-226048-01 5 ELE.CAP 22UF/16V +80/-20% 电解电容 C3.83.85.129.173.
53 127-476048-01 9 ELE.CAP 47UF/16V +80/-20% 电解电容 C1.39.124.134.140.145.146.151.170.
54 127-107048-01 16 ELE.CAP 100UF/16V +80/-20% 电解电容 C18.28.80.91.108.109.110.111.112.127.
C137.130.131.179.187. 64
55 127-107058-01 1 ELE.CAP 100UF/25V +80/-20% 电解电容 C115
56 127-227048-01 2 ELE.CAP 220UF/16V +80/-20% 电解电容 C138.152
57 127-477048-01 3 ELE.CAP 470UF/16V +80/-20% 电解电容 C40.106.107.
58 127-228058-01 2 ELE.CAP 2200UF/25V +80/-20% 电解电容 C29.58

59 160-102205-01 1 PIN SOCKET 2PIN 2.0MM 直扦扦座 CN31

60 160-102255-01 2 PIN SOCKET 2PIN 2.5MM 直扦扦座 CN8.32
61 160-102254-01 1 PIN SOCKET 2PIN 2.5MM(RIGHT ANGLE) 弯脚插座 CN3
62 160-103205-01 1 PIN SOCKET 3PIN 2.0MM 直扦扦座 CN7
63 160-104255-01 1 PIN SOCKET 4PIN 2.5MM 直扦扦座 CN21
64 160-104204-01 1 PIN SOCKET 4PIN 2.0MM(RIGHT ANGLE) 弯脚插座 CN26.
65 160-104254-01 1 PIN SOCKET 4PIN 2.5MM(RIGHT ANGLE) 弯脚插座 CN25
66 160-105205-01 1 PIN SOCKET 5PIN 2.0MM 插座 CN28
67 160-106205-01 1 PIN SOCKET 6PIN 2.0MM 插座 CN5
68 160-107205-01 1 PIN SOCKET 7PIN 2.0MM 插座 CN30
69 160-110205-01 1 PIN SOCKET 10PIN 2.0MM 插座 CN27
70 160-216106-02 1 Connector-FFC R/A type 16PIN 1.0mm 双排脚插座 CN4
71 160-211106-02 1 Connector-FFC R/A type 11PIN 1.0mm 双排脚插座 CN6
72 718-020040-00 6 BRASS EYELET DIA 2*4mm 铜鸡眼
73 C16-005000-00 100 JUMPER WIRE 40*0.5MM 铁线
74 113-000005-63 3 CAR. RESISTOR 0 OHM 0603 贴片电阻 R116.127.132.
75 113-100005-63 1 CAR RESISTOR 10 OHM 0603 贴片电阻 R63.
76 113-220005-63 11 CAR RESISTOR 22 OHM 0603 贴片电阻 R8.84.160.164.165.168.170.172.175.176.177.
77 113-330005-63 8 CAR RESISTOR 33 OHM 0603 贴片电阻 R76.81.148.149.150.151.153.154.
78 113-470005-63 14 CAR RESISTOR 47 OHM 0603 贴片电阻 R2.59.69.139.140.141.142.144.145.179.180.
R169.171.173.
79 113-101005-63 11 CAR. RESISTOR 100 OHM 0603 贴片电阻 R01.82.114.122.166.167.182.183.185.187.188.
80 113-121005-63 2 CAR. RESISTOR 120 OHM 0603 贴片电阻 R94.95.
81 113-221005-63 1 CAR. RESISTOR 220 OHM 0603 贴片电阻 R86.
82 113-331005-63 4 CAR. RESISTOR 330 OHM 0603 贴片电阻 R7.11.40.50.
83 113-391005-63 1 CAR. RESISTOR 390 OHM 0603 贴片电阻 R121
84 113-471005-63 3 CAR. RESISTOR 470 OHM 0603 贴片电阻 R1.10.93.
85 113-561005-63 1 CAR. RESISTOR 560 OHM 0603 贴片电阻 R28.
86 113-681005-63 1 CAR. RESISTOR 680 OHM 0603 贴片电阻 R128
87 113-102005-63 7 CAR. RESISTOR 1K 0603 贴片电阻 R3.73.85.184.186.189.209
88 113-222005-63 8 CAR. RESISTOR 2.2K 0603 贴片电阻 R6.19.27.112.115.126.192.300.
89 113-332005-63 7 CAR. RESISTOR 3.3K 0603 贴片电阻 R4.17.42.43.57.61.62.
90 113-472005-63 10 CAR. RESISTOR 4.7K 0603 贴片电阻 R48.60.65.90.91.92.96.97.99.174.
91 113-562005-63 6 CAR. RESISTOR 5.6K 0603 贴片电阻 R12.13.67.80.66.79.
92 113-822005-63 2 CAR. RESISTOR 8.2K 0603 贴片电阻 R71.102.
93 113-103005-63 26 CAR. RESISTOR 10K 0603 贴片电阻 R14.15.18.21.39.41.72.77.98.123.
R125.193.201.203.146.147.206.208.211.129.
R130.133.136.147.178.301.
94 113-153005-63 3 CAR. RESISTOR 15K 0603 贴片电阻 R68.100.161.
95 113-223005-63 2 CAR. RESISTOR 22K 0603 贴片电阻 R107.163.
96 113-273005-63 1 CAR. RESISTOR 27K 0603 贴片电阻 R89.
 PAGE:3/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

97 113-333005-63 4 CAR. RESISTOR 33K 0603 贴片电阻 R156.157.158.159.
98 113-473005-63 18 CAR. RESISTOR 47K 0603 贴片电阻 R9.20.74.75.87.101.103.124.137.138.
R106.108.111.117.118.119.120.210.
99 113-563005-63 1 CAR. RESISTOR 56K 0603 贴片电阻 R16
100 113-683005-63 1 CAR. RESISTOR 68K 0603 贴片电阻 R143.
101 113-823005-63 2 CAR. RESISTOR 82K 0603 贴片电阻 R152.155.
102 113-154005-63 1 CAR. RESISTOR 150K 0603 贴片电阻 R135.
103 113-224005-63 1 CAR. RESISTOR 220K 0603 贴片电阻 R5
104 113-105005-63 3 CAR. RESISTOR 1M 0603 贴片电阻 R64.131.162.

105 123-509340-63 2 C.CAP 5PF NPO 50V 0603 贴片电容 C5.19

106 123-100340-63 2 C.CAP 10PF NPO 50V 0603 贴片电容 C21.44.
107 123-220340-63 4 C.CAP 22PF NPO 50V 0603 贴片电容 C142.143.176.180.
108 123-240340-63 2 C.CAP 24PF NPO 50V 0603 贴片电容 C11.14.
109 123-300340-63 4 C.CAP 30PF NPO 50V 0603 贴片电容 C15.16.17.20.
110 123-101340-63 3 C.CAP 100PF NPO 50V 0603 贴片电容 C12.163.165.
111 123-141340-63 1 C.CAP 130PF NPO 50V 0603 贴片电容 C48.
112 123-501340-63 2 C.CAP 500PF NPO 50V 0603 贴片电容 C113.114.
113 123-821340-63 1 C.CAP 820PF NPO 50V 0603 贴片电容 C150.
114 123-102350-63 11 C.CAP 0.001UF 50V 0603 贴片电容 C10.42.36.41.47.49.51.121.171.174.181.
115 123-182350-63 4 C.CAP 0.0018UF 50V 0603 贴片电容 C166.167.168.169.
116 123-502350-63 1 C.CAP 0.005UF 50V 0603 贴片电容 C63
117 123-103350-63 4 C.CAP 0.01UF 50V 0603 贴片电容 C2.4.164.177.
118 123-333350-63 2 C.CAP 0.033UF 50V 0603 贴片电容 C160.175
119 123-683350-63 1 C.CAP 0.068UF 50V 0603 贴片电容 C149
120 123-104350-63 52 C.CAP 0.1UF 50V 0603 贴片电容 C13.23.24.27.30.31.32.34.35.37.38.43.
C55.56.62.92.123.125.126.128.132.133.
C135.136.139.141.144.147.156.157.158.178
C162.182.183.184.189.190.191.192.193.195.
C197.198.199.194.196.185.186.188.200.300.

121 123-224350-63 3 C.CAP 0.22UF 50V 0603 贴片电容 C159.148.155

122 131-459014-1A 5 TRANSISTOR C9014 SMT 贴片三极管 Q5.6.11.17.21.
123 131-448050-1A 4 TRANSISTOR JE8050C SMT 贴片三极管 Q7.9.13.16
124 131-448550-1A 5 TRANSISTOR 8550 SMT 贴片三极管 Q1.4.8.15.18.
125 190-966001-00 1 966DR PM1 PCB (94V0) 主板

126 158-966008-00 1 966DR USB PCB ASS'Y USB 板组件

127 113-330005-63 1 CAR RESISTOR 33 OHM 0603 碳膜电阻 R29
128 160-004100-02 1 USB A TYPE FEMALE CONNECTOR （贴板式） USB插座 USB1
129 004-130408-01 1 5-130408-004 FOR SD/MS CARD SD CARD 座 与USB801同一款
130 130-520523-00 1 LED EL204 HD RED 3MM 红色发光二极管 LED1
131 190-966008-00 1 966DR USB PCB USB 板

132 158-966080-01 1 966DR DISPLAYER PCB ASSʼY 显示板组件

113-100105-12 1 CAR RESISTOR 10 OHM 1/4W +/-5% 碳膜电阻 R2
133 113-105105-12 1 CAR RESISTOR 1M1/4W +/-5% 碳膜电阻 R1
134 130-520523-00 1 LED EL204HD RED 3MM 红色发光二极管 LED2.
135 130-520523-30 1 LED EL204HD GREEN 3MM 红色发光二极管 LED3.
136 133-003610-67 1 IC SC3610 集成电路 IC1
137 305-096600-00 2 斑马导电胶条 SIZE：2X6X26mm
138 135-096600-01 1 LCD DISPLAY ACD-781571-01-T2NSO（天山供货） 液晶显示器
 PAGE:4/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

139 187-000966-00 1 FH0185B1-DSP (BLUE BACKLIGHT) 显示背光源
140 136-316038-00 1 OPTIC R/C REC MORULE FM-6038LM-5A（E3标记） 红外线接收头
127-476048-01 1 ELE.CAP 47UF/16V +80/-20% 电解电容 C7
141 127-107038-01 1 ELE.CAP 100UF/10V +80/-20% 电解电容 C1
142 123-104350-16 3 C.CAP 0.1UF+/-20% 50v 瓷片电容 C2.5.6
143 137-327680-30 1 CRYSTAL32.768KHz（SIZE：3X8mm）,+/-10PPM晶振 X1
144 123-150340-13 2 N.P.O CERAMIC CAP 15 PF +/-5%50V 瓷介电容 C3.4.
123-501340-13 1 N.P.O CERAMIC CAP 500 PF +/-5%50V 瓷介电容 C8
145 160-412205-12 1 PCB CONNECTION 12PIN 2.0MM 排针 特采物料、塑胶在中间位置
146 160-405205-12 1 PCB CONNECTION 5PIN 2.0MM 排针 特采物料、塑胶在中间位置
147 160-211106-02 1 Connector-FFC R/A type 11PIN 1.0mm 双排脚插座 CN2
148 190-966080-01 1 966DR DISPLAYER PCB 显示板

149 158-966060-01 1 DISPLAY DRIVE IC PCB ASS'Y 显示IC板组件

150 133-201621-13 1 I.C HT1621 集成电路
151 113-472005-63 1 CAR. RESISTOR 4.7K 0603 贴片电阻 R2
152 123-104350-63 1 C.CAP 0.1UF 50V 0603 贴片电容 C2
153 190-966060-01 1 DISPLAY DRIVE IC PCB 显示IC板

154 158-966002-00 1 966DR KEY PCB ASSʼY 按键板组件

155 113-221005-12 1 CAR. RESISTOR 220 OHM 1/16W +/-5% 碳膜电阻 R4
156 113-561005-12 1 CAR. RESISTOR 560 OHM 1/16W +/-5% 碳膜电阻 R6
157 113-391005-12 1 CAR. RESISTOR 390 OHM 1/16W +/-5% 碳膜电阻 R5
158 113-332005-12 1 CAR. RESISTOR 3.3K OHM 1/16W +/-5% 碳膜电阻 R8
159 113-912005-12 1 CAR. RESISTOR 9.1K OHM 1/16W +/-5% 碳膜电阻 R3
160 113-392005-12 1 CAR. RESISTOR 3.9K OHM 1/16W +/-5% 碳膜电阻 R7
161 147-110143-00 7 TACT SWITCH H:4.3MM/4 TERMINAL 轻触开关 SW1.2.3.4.5.6.7.
162 190-966002-00 1 966DR KEY PCB 按键板

163 158-966003-00 1 966DR SET PCB ASSʼY 按键板组件

164 147-110143-00 3 TACT SWITCH H:4.3MM/4 TERMINAL 轻触开关 SW8.9.10.
165 190-966003-00 1 966DR SET PCB 按键板

166 158-008020-03 1 REM MP3 USB SD PCB ASS'Y 遥控器

167 133-806121-67 1 I.C SC6121-001 集成块
168 107-300455-29 1 CERAMIC RESONATOR ZTB 455KHz(2PIN) 陶瓷谐振器 X1
169 130-600012-04 1 INFRARED DIODE KL-IL2 (KODENSHI) 发射管 LED1
170 131-449014-03 1 TRANSISTOR JE 9014C 三极管 Q1
171 123-101340-13 2 CERAMIC CAP 100 PF +/-5% 50V 磁片电容 C2.3
172 127-476048-01 1 ELE.CAP 47UF/16V +80/-20% 电解电容 C1
173 C16-005000-00 2 JUMPER WIRE 40*0.5MM 铁线
174 190-008020-03 1 REM MP3 USB SD PCB 遥控板

175 444-009350-03 1 CD DECK 新江海光头 GM9350HTR (有珠仔) CD机芯

176 443-P93800-10 1 WS-21 V-PT938 (H) 9V (EG-530AD-9B) 半自停磁石抹音卡式机芯 (与
与PCD938同
同一款）
177 127-335078-01 1 ELE. CAP 3.3UF/50V +/-10% 电解电容
178 147-110102-01 1 LEAF SWITCH QAS-1229-4 叶片开关

179 161-938001-01 1 AC SOCKET AS-208 电源插座 供应: 进佳 （按生产细则）

R1 161-938001-02 0 AC SOCKET AS-209 电源插座 有极性 (UL认证用）按生产细则
180 C01-030040-03 2 UL 4.0MM SHRINK TUBE( L=24MM) AC/DC电源插座用热缩管
 PAGE:5/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

181 101-480661-35H 1 TRANSFORMER EI-48 230V 50Hz 变压器 ( 按生产细则 ）
R1 101-480661-25H 1 TRANSFORMER EI-48 220V 50Hz 变压器 ( 按生产细则 ）
R2 101-480661-1AH 1 TRANSFORMER EI-48 110/220V 60/50Hz 变压器 ( 按生产细则 ）
R3 101-480661-85H 1 TRANSFORMER EI-48 240V 50Hz 变压器 ( 按生产细则 ）
R4 101-480661-15H 1 TRANSFORMER EI-48 110V 60Hz 变压器 ( 按生产细则 ）
R5 101-480661-18H 1 TRANSFORMER EI-48 120V 60Hz 变压器 ( 按生产细则 ）

182 171-662072-40 1 VDE APPROVAL KEMA-KEUR HO3VVH2-F VDE电源线 有头有尾 ( 按生产细则订料 ）

0.75mm 2*0.75 6 ' W/END
R1 171-442059-70 1 BS APP. 1.5M W/END & CABLE TIE BSI电源线 有头有尾 ( 按生产细则订料）
R2 171-213059-70 1 UL#ISPT-118AWG*2 60c APPROVAL NON- UL无极性电源线 有头有尾 ( 按生产细则订料）
POLARIZED W/END 1.5M
R3 171-711072-90 1 UL/CSA#NISPT-2 60c APPROVAL 6' W/END UL有极性电源线 有头有尾 ( 按生产细则订料）
R4 171-552059-70 1 AC LINE CORD SAA APP. 1.5m W/END SAA电源线有头有尾 ( 按生产细则订料）
R5 171-999472-70 1 AC LINE CORD BRASIL APP.1.83M W/END 巴西电源线 有头有尾 ( 按生产细则订料）

110/220V机
机增加材料
183 147-120328-00 VOLTAGE SELECTOR SWITCH 电压选择开关
184 C01-030100-01 UL 10MM SHRINK TURE (L=25MM) 热缩套管
185 C01-030200-00 UL 20MM SHRINK TUBE <L=50MM> 热缩套管
186 172-422015-52 UL1672#22AWG RED 150MM 线材

CE认
认证标准需加磁环、 看市场部生产细则要求
187 184-350613-00 5 FERRITE BEAD 3T 3.5*6.0*1.3mm +CHOKE COI 磁环线圈 L1.3.4.
188 184-162807-01 1 FERRITE BEAD 18*10*6MM 磁环 FOR USB WIRE
189 184-251512-00 3 FERRITE BEAD 25*12*15MM 磁环 FOR AC CORD
190 C08-000020-03 8 CABLE TIE 3" 3'扎线
191 C01-010010-00 8 UL PVC TUBING 1.0*10mm 胶管
192 C01-010030-00 1 UL PVC TUBING 35*3MM 胶管 FOR AM ANT.
193 166-240530-11 2 3" 4 OHM 5W 圆形 SPEAKER 32 磁 喇叭

线 材
194 172-126009-50 1 UL1007#26AWG 90mm BLACK 线材 PM1 TO FM ANT.
195 172-126018-50 1 UL1007#26AWG 180mm BLACK 线材 BATTERY - TO MAIN POWER GND.
196 172-126008-52 1 UL1007#26AWG 80mm RED 线材 BATTERY"+" TO AC SOCKET
197 172-126018-52 1 UL1007#26AWG 180mm RED 线材 AC SOCKET TO MAIN PCB VDD
198 172-126018-55 1 UL1007#26AWG 180mm GREEN 线材 MAIN PCB B+ TO AC SOCKET
199 172-122012-50 1 UL1007#22AWG 120mm BLACK 线材 MAIN PCB GND TO GND
172-122016-50 1 UL1007#22AWG 160mm BLACK 线材 MAIN PCB G3 TO G4
200 172-122008-50 1 UL1007#22AWG 80mm BLACK 线材 MAIN PCN GND TO GND
201 177-612151-02 1 UL2468#26AWG 150mm 2P1H P=2.5mm 线材 KEY PCB CN3 TO MAIN PCB CN32
202 177-602151-02 1 UL2468#26AWG 150mm 2P1H P=2.0mm 线材 CD DOOR SW. TO MAIN PCB CN31
203 177-602151-07 1 UL2468#26AWG 150mm 7P1H P=2.0mm 线材 DISPLAYER PCB CN1 TO MAIN PCB CN30
204 177-602151-03 1 UL2468#26AWG 150mm 3P1H P=2.0mm 线材 SET PCB TO MAIN PCB CN7
205 191-040440-00 1 UL1007#22AWG 440 & 240mm 4P1H P=2.5mm 线材 MAIN PCB CN25 TO SPK.
206 191-040180-00 1 UL1007#22AWG 180 & 120mm 4P1H P=2.5mm 线材 MAIN PCB CN21 TO MOTOR
207 176-112014-10 1 UL1365#30 75 OHM CABLE 140mm 2P1H P=2.5mm 线材 DISPLAY PCB CN8 TO MAIN PCB CN8
208 181-303200-30 1 UL2854#30T/S 200mm 4P1H P=2.0mm 线材 R/P HEAD TO MAIN PCB CN26
210 177-289614-11 1 11PIN AWM 2896 SUPER FLEX 140mm 线材 MAIN PCB CN6 TO DISPLAY PCB CN2
211 177-289610-16 1 16PIN AWM 2896 SUPER FLEX 100mm 线材 CD DECK TO MAIN PCB CN4
212 177-600121-06 1 UL20080#26AWG 120mm 6P2H P=2.0mm 线材 CD DECK TO MAIN PCB CN5
213 177-602221-10 1 UL2468#26AWG 220mm 10P1H P=2.0mm 线材 USB CN2 TO MAIN PCB CN27
 PAGE:6/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

214 191-020280-02 1 UL1007#26AWG 280mm 2P1H P=2.5mm 线材 MAIN PCB CN3 TO BATTERY
非CE认
认证用料
209 174-833150-20 1 UL2547#28D/S 150mm 3PINS 线材 MAIN PCB TO HEAD PHONE JACK
215 177-602221-05 1 UL2468#26AWG 220mm 5P1H P=2.0mm 线材 USB PCB CN9 TO MAIN PCB CN28
CE认
认证穿磁环用料
209 174-833300-20 1 UL2547#28D/S 300mm 3PINS 线材 MAIN PCB TO HEAD PHONE JACK
216 177-602321-05 1 UL2468#26AWG 320mm 5P1H P=2.0mm 线材 USB PCB CN9 TO MAIN PCB CN28
217 177-622170-08 1 普通灰排线 170mm 8PIN PITCH=2.0mm 线材 MAIN PCB CN1 TO CN11

结构
1 PS-096601 1 FRONT PANEL 面壳
2 PS-096602 1 UPPER CABINET 顶壳
3 PS-096603 1 LOWER CABINET 底座
4 PS-096605 1 CASS KNOB ASSM 卡钮组合
5 PS-096606 1 CD DOOR CD门
6 PS-096607 1 CASS DOOR 卡门
7 PS-096608 1 HANDLE 手挽
8 PS-096609 1 BATTERY DOOR 电池门
9 PS-096610 1 PLATED RING L 左装饰圈
10 PS-096611 1 PLATED RING R 右装饰圈
11 PS-096612 1 CASS DOOR LENS 卡门镜
12 PS-096613 1 DISPLAY LENS 显示镜
13 PS-096615 1 VOLUME KNOB 音量钮
14 PS-096616 2 FUNCTION KNOB 功能钮
15 PS-096617 1 KEY KNOB R-4D 右四按钮
16 PS-096618 6 KEY KNOB L-4D 左四按钮
17 PS-096619 1 KEY KNOB L-1D 左单按钮
18 PS-096620 1 KEY KNOB L-3D 左三按钮
19 PS-096621 1 TUNING KNOB 选台钮
20 PS-096622 1 TUNNING SHAFT 选台轴
21 PS-096623 1 GEAR HOLDER 齿轮支架
22 PS-096625 1 PVC GEAR PVC 齿轮
23 PS-096627 1 2D LCD HOLDER 两位LCD支架
24 PS-096628 1 LED HOLDER LED支架
25 PS-096629 1 RECORD ROCKER 录音摇杆
26 PS-096630 1 ROCKER HOLDER 摇杆支架
27 PS-096632 2 SPEAKER HOLDER A 喇叭支架 A
28 PS-096633 2 SPEAKER HOLDER B 喇叭支架 B
29 PS-096634 1 DR MODEL SMALL PANEL DR机型小面
30 PS-KS77006 2 DAMPER GEAR GROUP 阻尼轮组
31 PS-990850 1 CD DUST COVER CD防尘盖
32 PS-990852 1 CD DUST COVER CD防尘盖 三洋和青雅CD机芯选用

根据生产细则或有关资料加入以下物料(要求加入CD磁环时)
33 PS-0938236631 1 M AGNET HOLDER 磁石支架
34 PS-CDK70832 1 CD CHUEK PLATE CD鼓盖
35 700-410001-00 1 CD DRUM BRACKET 圆铁片
36 728-410001-00 1 CD MAGNET 30*16*5 CD磁环
37 501-020502-00 1 2*5BM MAGNET*1
38 500-030606-00 3 3*6KA MAGNET HOLDER*3
39 503-170300-05 1 PAPER WASHER 17*30*0.5 CD DOOR*1
 PAGE:7/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

40 715-096601-00 1 METAL GRILL-L 左铁网
41 715-096602-00 1 METAL GRILL-R 右铁网
42 308-003106-00 4 CD RUBBER CUSHION 25 度 避震胶 25度(绿色)
43 560-093801-00 1 ANTENNA 天线
44 720-325003-00 1 ANTENNA CONNECTD3.2*50*0.3 天线焊片
45 740-093801-00 1 CD DOOR SPRING CD门弹簧
46 721-093802-00 1 CASS DOOR SPRING 卡门弹簧
47 303-096601-00 4 REAR FOOT 直径14.0*高5.0 MM 胶脚(EVA)
48 714-060601-00 1 HEAT SINK 散热片(A)
49 714-038801-00 2 HEAT SINK 散热片
714-096601-00 1 HEAT SINK 散热片
50 PS-093801-00 2 FERRITER BAR HOLDER 磁棒支架
51 707-091301-01 1 BATTERY CONTACT(+) 电池片正极
52 707-091302-01 1 BATTERY CONTACT(-) 电池片负极
53 707-091303-01 1 BATTERY COMBINE-A 电池组件-A
54 707-091304-01 1 BATTERY COMBINE-B 电池组件-B
55 707-096601-00 1 BATTERY COMBINE(+/-) 电池组件正负

SCREW & WASHER

56 500-021202-00 1 2*12PA FOR CD LEAF SWTH*1
57 500-260802-00 3 2.6*8PA DISPLAY PCB TO PANEL*2
MAIN PCB TO RECORD ROCKER HOLDER*1
58 509-261001-10 8 2.6*10PWA(W=10) CD DECK*4
DAMPER GEAR HOLDER TO CD BASE*1
DAMPER GEAR HOLDER TO FRONT PANEL*1
CASS SRING*1,TUNNING KNOB*1
59 509-261001-08 2 2.6*10PWA(W=8) USB PCB TO UPPER CABINET*2
根据生产细则要求加入此物料
60 500-031002-00 34 3*10PA SPEAKER TO FRONT PANEL*4
PLATED RING TO PANEL*6
CASS DECK TO FRONT PANEL*4
SAMELL PANEL TO UPPER CABINET*9
GEAR HOLDER TO MAIN PCB*3
MAIN PCB TO CABINET*8
61 500-031402-00 6 3*14 PA FRONT PANEL TO BACL CABINET*6
62 509-031001-10 4 3*10PWA(W=10) TRANSFORMER *2
AC JACK*2
63 501-030802-00 1 3*8BM ANTENNA TO BACK CABINET*1
64 501-260602-00 1 2.6*6BM TUNING SHAFT TO PVC*1
65 501-260403-00 2 2.6*4KM PVC TO PCB*2
66 501-030805-00 2 3*8BTB HEAT SINK TO *2
67 500-020802-00 4 2*8PA LCD HOLDER TO PCB*4

REMOTE CONTROLLER
68 RMT-6KEY 1 REMOTE HANDSET 遥控器
69 311-410001-01 1 REMOTE RUBBER (8 KEYS) A675 导电橡胶
70 707-077001-00 1 HANDSET BATTERY PLATE (- ) 负极弹片
71 707-077002-00 1 HANDSET BATTERY PLATE (- ) 正极弹片
72 707-077003-00 1 HANDSET BATTERY PLATE（+/-） 正负极弹片
73 PS-RM701 1 REMOTE FRONT CABINET 遥控面
74 PS-RM702 1 REMOTE REAR CABINET 遥控底
75 PS-RM703 1 REMOTE BATTERY DOOR 遥控电池门
76 PS-RM705 1 REMOTE INLAY 遥控片
 PAGE:8/8 DAT H.K. LTD.
TP-605GUC

NO PART NO QTY DESCRIPTION 中文名

77 303-050505-00 3 PAD CORD 5*5*5MM 高密度海棉 FOR BATTERY PLATE*2
FOR REMOTE PCB*1

PAPER LABEL
78 642-096601-00 1 INSTRUCTION MANUAL 说明书
79 664-053211-02 1 DATE CODE LABEL 日期贴纸
80 664-053211-25 1 THERMAL FUSE LABEL 火牛贴纸
81 664-053211-07 1 LASER BEAM LABEL 激光柱（太阳）贴纸
82 664-053211-08 1 LASER CAUTION LABEL 激光（镭射）警告贴纸
83 664-053211-23 1 SERIAL LABEL 流水号贴纸
84 664-099100-05 1 CAUTION & SAFETY LABEL 警告安全贴纸
85 664-099100-06 1 CLASS 1 LASER LABEL 一级镭射贴纸
86 622-091000-01 1 CD PAPER DISC 纸碟
87 622-091000-01 1 CD PAPER DISC CD纸碟片 机芯不是波仔头时选用
88 622-011000-01 1 CD PAPER DISC CD纸碟片 中间孔径略小,是
是波仔头机芯时选用
89 664-096600-08 1 MODEL LABEL 产品型号贴纸

SPACKING
90 800-096601-00 1 MAIN POLYFOAM(R) 左发泡胶
91 801-096602-00 1 MAIN POLYFOAM(L) 右发泡胶
92 612-096601-00 1 CARTON 卡通纸箱
93 811-150180-73 1 POLY BAG 15"*18"*0.03MM 主机胶袋
94 811-065100-73 1 POLY BAG 6.5"*10"*0.03MM 说明书胶袋 生产细则中如要求说明书为A4纸大小时则要用9"*15"胶袋

95 811-040090-73 1 POLY BAG 4"*9"*0.03MM 遥控器胶袋

96 811-040090-73 1 POLY BAG 4"*9"*0.03MM 普通电源线胶袋 根据生产细则要求选用不同规格的胶袋

97 811-040210-73 1 POLY BAG 4"*21"*0.03MM 电源线胶袋 （BS&SAA插头用）

根据生产细则要求选用不同的包装方式
98 612-096602-00 4 CARTON 卡通纸箱 四台一箱包装内容
99 613-096601-00 1 CARTON 卡通纸箱
100 612-096602-00 6 CARTON 内卡通纸箱 根据生产细则要求选用.
101 613-096602-00 1 CARTON 外卡通纸箱 六台1箱包装
******ENG*******