EXPLODED VIEW DRAWINGS & PARTS LISTS

WESTWOOD MULCH S1400 & S1600

TRACTOR PARTS LIST INDEX 2006

1. FRONT AXLE ASSEMBLY

2. BONNET ASSEMBLY
3. BRIGGS & STRATTON ENGINE & EXHAUST ASSEMBLY
4. TRANSMISSION DRIVE ASSEMBLY
5. MULCH TRANSAXLE ASSEMBLY
6. HYDROSTATIC TRANSAXLE
7.A MAIN WIRING LOOM
7.B DIAL HEIGHT WIRING LOOM
8. STEERING CONSOL ASSEMBLY
9. HYDROSTATIC REAR BODY ASSEMBLY
10.A I.B.S. CUTTER DECK
10.B 38” MULCHING DECK
11.A DECALS 2002/03
11.B DECALS 2004/05
 Westwood
WESTWOOD MULCH S1400 & S1600 2006

SERVICE DRAWINGS & PARTS LIST INDEX

Westwood Tractors

Admail 3376,
Plymouth,
Devon
PL7 5ZY(0) 800 0720127
Tel: +44
Fax: +44 (0) 800 0720132
[email protected]
www.westwoodtractors.com
 9
WESTWOOD TRACTOR 52
FRONT AXLE ASSY 27 29 11 50
27 32
17
29 17 2
53 19 10
27
46 5
42 21 19
25 47
48 49
60 43 51 32 5
49 49
32 32
29 50
24 15
59
27 50 32 55
14 52 5 32
61 19
39 40 45 49 56
44 58
27 14
14 8 62 28 38
22 63 54
12 37
6 5
32 36
23 19 57 33
24
25
38 18
30
32 27 16
34 29 7
27 4 41
21 20 5

13 35
26
5
27 32
28 1 11
49
32
31 DRWG No: T1640503
ISSUE No: 3
SECTION 1
 WESTWOOD MULCH TRACTOR
FRONT AXLE PARTS LIST
PART DESCRIPTION PART NUMBER
1 Nyloc Nut 12mm `T’ Fine 04836100
2 Hub Cap Washer Front Wheel 30128100
3 Washer M12 x 24 x 1.6 088003600
4 Tractor Front Tyre 15 x 6 19802800
Wheel Valve 14889200
5 Front Wheel Bearing 10802200
6 Stub Axle R/H 327015200
7 Stub Axle L/H 327015100
8 Axle Beam 327014700
9 Steering Arm 32702500
10 Chassis 2004 32702403
11 Hub Cap (Moulded) 14811800
12 Tractor Chassis Front 27115500
13 Deck Tension Cradle 328956900
14 Bolt M10 X 85mm 018001900
15 Deck Tension Rod 31805600
16 M10 Track Rod 31318300
17 19mm External Circlip 07921200
18 Deck Lift Pin (Front) 31336800
19 Galvanised Washer 32 x 19.5 30127900
20 Washer 19mm 08829900
21 M10 x 60mm Coachbolt 018005000
22 Rose Joint Boss 31302400
23 Rose Joint Shoulder Boss (Long) 31337100
24 10mm Rod End 10872600
25 M10 Locknut 04872100
26 Trunnion (Deck Cradle) 18805500
27 Washer 10.8 i.d x 20.7 o.d x 2mm Thk 088002400
28 Rue Clip 11836700
29 M10 Nyloc Nut 04886100
30 Track Rod End Spacer 183016900
31 Spacer 31302700
32 M8 Washer 08819501
33 Deck Push Rod Pin 31338200
34 Bolt M8 x 25mm 01902300
35 Front Wheel Rim 32701100
36 Deck Lift Pin 31339400
37 Split Pin 1/8” x 1” 07823300

SEPT 2006 SECTION 1

 WESTWOOD TRACTOR
FRONT AXLE PARTS LIST

PART DESCRIPTION PART NUMBER

38 M12 x 24 x 1.6mm Washer 088003600
39 Steering Link Plate 27102400
40 Steering Support Boss 31337500
41 Deck Carrying Cradle ( Front ) 32703701
42 Track Rod End Spacer 183016900
43 Rose Joint Shoulder Support Boss (Short) 31339600
44 Steering Rack Pivot 31337400
45 Steering Quadrant 327015800
46 Steering Gear 213112100
47 Washer 5/8” T3 LP 08822700
48 Steering Rod Spacer 18401500
49 M8 Nut Nyloc 04920100
50 Bolt M8 x 20mm 02825900
51 Column Lower Bearing 10801700
52 Circlip 5/8” 07823800
53 Steering Column 31328400
54 Front Deck Cradle Adjuster 327029200
55 Deck Tension Lever 32700600
56 Bolt M8 X 50mm 018001800
57 Deck Tension Bar 36” IBS 29203900
Deck Tension Bar 38” IBS 29202400
Dec Tension Bar 38” Mulcher / 42” IBS 29203700
58 Plastic Lever Cap 14946200
59 Pivot (Deck Overlock) 18833700
60 Steering Link Rod 313007800
61 Grease Nipple 11808600
62 Deck Level Adjuster Nut 189501800
63 M/Screw M10 x 60mm 018006600

SEPT 2006 SECTION 1

 WESTWOOD MULCH
TRACTOR 1/1a
BONNET ASSEMBLY
11 20 32
7 33 29
27/28
33
AIR INTAKE
COWL 18 36
LOCATION
UNDER
BONNET
36
25/26
6
33
2 30/31
19 33
32
Air Vents 4 5 35 8
Located 38
Under L.H. & R.H. 3
Sides of the Bonnet 38
34
20
22 13 9

16 6
11
21 23 4
3 5 7
2
11
14
12 23

37a 13

10
23
37 13

23
15 DRWG No:T2000403
23 14 ISSUE: 3
24
12a/b 23 SECTION 2B
13
 WESTWOOD MULCH TRACTOR
BONNET ASSEMBLY PARTS LIST

PART DESCRIPTION PART NUMBER

1 Bonnet Assembly Complete ( includes items 1a, 2, 3,
4, 5, 6, 7, 9, 11, 16, 18, 19 & 20)
Models S1300 & S1400 408020200
Model S1600 408020300
Models T1600 & T1800 408020400
1a Plastic Bonnet Main Body 148012100
2 L/H Westwood Headlamp 148011400
R/H Westwood Headlamp 148011500
3 L/H Westwood Light Lens 148011200
R/H Westwood Light Lens 148011300
4 12V Pole Bulb 44816200
5 Bulb Holder 44816100
6 Light Loom 3894 44813900
7 Westwood Bonnet L/H Fixing Panel 148011700
Westwood Bonnet R/H Fixing Panel 148011800
8 Westwood Bonnet L/H Engine Side Panel 148011900
Westwood Bonnet R/H Engine Side Panel 148012000
9 Westwood Bonnet Front Fixing Panel 148011600
10 Spring 25805200
11 Bolt Flanged Button Head M5 x 25mm 018003700
12 Bonnet Hinge Cross Plate Assembly 327181400
12a L/H Tractor Universal Bonnet Stop 301135901
12b R/H Tractor Universal Bonnet Stop 301135801
13 M8 Nyloc Nut 04920100
14 Bolt M8 x 25mm 01902300
15 M5 Jacknut 048001400
16 Bonnet Pivot Boss (Not Illustrated) 31306100
17 Decal Westwood Badge 358026100
18 New Style Beading 4832
19 Fir Tree Fixing 148012300
20 M8 Washer 08819501
21 Bolt M8 x 25mm 02826000

SEPT 2006 SECTION 2B

 WESTWOOD TRACTOR 2004
BONNET ASSEMBLY PARTS LIST

PART DESCRIPTION PART NUMBER

22 Engine Side Panels Forward Fixing Bracket L/H 307185600
23 Engine Side Panels Forward Fixing Bracket R/H 307185700
24 Engine Side Panels Rear Fixing Bracket L/H 307185800
25 Engine Side Panels Rear Fixing Bracket R/H 307185900
26 Consol Side Panel Mounting Plate 307186000
27 L/H Bracket (Front) – Side Panel 301135500
28 R/H Bracket (Rear) – Side Panel 301135600
29 Bolt M8 x 20mm 02825900
30 Washer M8 x 21 x 1.6mm 088003700
31 Nut Nyloc M6 04920500
32 M/Screw M6 x 16mm 028001000
33 Captive Nut M8 04852800
37 2003 R/H Exhaust Welded 328956300 use
327007301
38 M6 Washer 089422200

SEPT 2006 SECTION 2B

WESTWOOD MULCH TRACTOR
BRIGGS & STRATTON 2
ENGINE & EXHAUST
ASSEMBLY 1

S1400 S1600 TWIN EXHAUST

SINGLE EXHAUST SINGLE EXHAUST ASSEMBLY
ASSEMBLY ASSEMBLY 7
12
12 5
14 14 12
6

14

16 10
19**
17
10
19a
8
3
11

4
15 15A
9

13 DRWG No: T1660302

20 ISSUE No: 2
**No Longer Used
from May 2002 SECTION 3
 WESTWOOD MULCH TRACTOR
ENGINE & EXHAUST
PARTS LIST

PART DESCRIPTION PART NUMBER

1 Engine - Not Available From Westwood N/A
2 Oil Drain Valve 52851200
3 M8 Washer 08819501
4 Clutch Plate 302007000
5 Engine Pulley Spacer 31854000
6 Key 1/4” Square x 1.1/4” 09853400
7 Chassis 04 32702403
8 Engine Pulley 31330502
9 Mag Stop Electric Clutch 44936100
10 Bolt M10 x 30mm 018002100
11 Bolt M8 x 40mm 018003200
12 Exhaust Gasket ( Supplied by Briggs & Stratton) N/A
13 Clutch Spacer 31330300
14 Exhaust Pipe (S1400/1600) 327360400
Exhaust Pipe (T1600 & Twin Cylinder) 327360500
15 Exhaust Box (S1300/1600) 32851800
Exhaust Box (T1600 & Twin Cylinder) 529469200
15a R/H Exhaust Box 328956300 use
327007301
16 Nut M8 04822300
17 Washer M8 x 25 x 3mm Unplated 089418600
19 Exhaust Cover (** No Longer Used from May 2002) 307176000 use
30122900
19a Heat Shield 301136200
20 Bolt 7/16” UNF x 4.1/2” 01831000

SEPT 2006 SECTION 3

 WESTWOOD MULCH TRACTOR
TRANSMISSION
DRIVE ASSEMBLY
1
2
10
1
2 3
11 10 4
2
3
23 20
24 4
2 9
6
22 9 7
21 5 14
25 28
2 36
2
24
29 3
8 13
6
7
24

19
2
26
2
11 6

34
33 27
37
1
2 6

15 30
7
16 11

1
2 12
32

31
2
17
38
35 32
2 12
18
DRWG No: T1680505
ISSUE No: 5

SECTION 4
 WESTWOOD TRACTOR
P.T.O. & TRANSMISSION DRIVE.
ASSEMBLY PARTS LIST

PART DESCRIPTION PART NUMBER

1 M8 Nyloc Nut 04920100
2 M8 Washer 08819501
3 Spacer Jockey Wheel 18831600
4 Tx PTO Jockey Pulley 20811500
5 Transmission Pulley Plate 327020500
6 M10 Nyloc Nut 04886100
7 Washer 10.8 i.d x 20.7 o.d x 2mm Thk 088002400
8 Bolt M8 x 50mm 018001800
9 Jockey Cap 31351100
10 Belt Retaining Bracket 27105800
11 Split Pin 1” x 1/8” 06823300
12 Pedal Spacer 189500200
13 Deck Tension / P.T.O Engage Rod. 318958000
14 Trunnion (PTO Engage) 18806100
15 Clutch Retaining Bracket 302007000
16 Chassis 04 32702403
17 Bolt M8 x 45mm 02941000
18 Bolt M8 x 20mm 02825900
19 Magstop Engine Pulley 31330502
20 A79 Super II Belt 229503400
21 Clutch Link Arm 301046800
22 Trunnion 18806100
23 Clutch Link Rod 313009500
24 Belt
19mm External Circlip 2281110A
07921200
25 Clutch Link Arm 301069700
26 Brake Pedal Plate 307174000
27 Clutch Pedal Shaft 327020300
28 Safety Switch Spring 25813801
29 Pull Safety Switch 44813400
30 Transmission Cassette 409429501
31 Reverse Pedal 328958900
32 Bolt M8 x 25mm 01902300
33 LH Rubber Pedal Pad 149496800
34 Forward / Reverse Trunnion 183017300
35 Forward Pedal 327362800
36 Switch Mounting Plate 302005400
37 Forward / Reverse Rod 327362500
38 Forward Pedal Rubber 148013700

SEPT 2006 SECTION:4

 WESTWOOD TRACTOR
MULCH TRANSAXLE ASSY

1 14
2 55
56
54

2 56
12 34
33 35 12 55
32 36
22 2
31 13 59
38 12
31 37
38 2
22 59

33
30 29
28
27
25
53 26
60 15
44 2 16
49 42
50 17
18
46 41
43 12
58

40 19
48
46
47 39
50 24 2
51 10
12

52 20

4 22
38 2
21
8 6
23
7

11

3
DRWG No: T1690503
ISSUE No: 3

SECTION 5 4
9 5
 WESTWOOD TRACTOR
MULCH TRANSAXLE
PARTS LIST

PART DESCRIPTION PART NUMBER

1 Set Screw 5/16”UNF x 3/4” 02827600
2 Washer 5/16” T4 HP 08819700
3 Hub Cap 14811800
4 Washer 46mm x 19.5mm 30127800
5 E - Clip 3/4” 07823200
6 20” Rear Wheel 19802800
7 Rear Wheel Rim 198001100
Grease Nipple 45 Degrees 11898800
`O’ Ring 24898700
Starlock Washer 5/16” x 5/8” 08823500
8 Wheel Hub ( for 20” Wheel) with Studs & Nuts 198002000
9 Valve 14889200
10 Transaxle Spacer 189498700
11 Wheel Nut 048000800
12 Nyloc Nut 5/16” UNF 04827500
13 Bolt 5/16” UNF x 2 1/2” HT Z/P 01821100
14 Chassis 04 32702403
15 Pulley 7” 20870700
16 Engine / Transmission Belt (Manual) A82 2281110A
17 Woodruff Key 606 09823900
18 Circlip 5/8” 07823800
19 Key 3/16” x 2” 09830700
20 Transaxle Support Bracket 292005600
21 Screw 5/16” Taptite Tri - Lock 02822100
22 Spacer 5/16” x 7mm 31302800
23 Wheel Spacer 17mm 31324900
24 Brake Rod (Manual) 32711500
25 Locknut 3/8” UNF 04821400

SEPT 2006 SECTION 5

 WESTWOOD TRACTOR
MANUAL TRANSAXLE
PARTS LIST

PART DESCRIPTION PART NUMBER

26 Brake Rod Trunnion 18849900
27 Brake Rod Spring 25808300
28 Washer 3/8” T3 HP 08820100
29 Nut 3/8” UNF Nyloc 04820200
30 Bolt 5/16” UNF x 1 3/4” 01820800
31 Rod End M8 x M8 ( R/H thread female) 10896200
32 Gear Select Plate 32702300
33 Washer 5/16” T3 LP 08819500
34 Bolt 1/4” UNF x 3/4” 01827700
35 Shakeproof Washer ¼” 08825700 use
08824200
36 Washer 9/16” 08824200
37 Gear Select Adjustment Rod 31301600
38 Locknut M8 04822300
39 Tecumseh Manual 6 Speed Transaxle N/A
40 Park Brake Spring 25805000
41 Park Brake Rod 31305900
42 Lever Knob 14804800
43 Oillite Bush Flange 52826500
44 Foot Pedal 327173900
45 Pull Safety Switch 44813400
46 Safety Switch Bracket 307174400
47 Spring Brake Pedal 25808300
48 Spring Safety Switch 25813801
49 Screw 5/16” UNF x ¾” 02827600
50 Washer 5/16” T4 HP 08819700
51 Nut 5/16” UNF Nyloc 04827500
52 Jockey Pulley Plate 327361900
53 R/H Rubber Pedal Pad 149496900
54 Tow Bracket 29200101
55 Bolt M10 01915300
56 Washer M10 088002400
57 Nut M10 04872100
58 R. Clip 06849100
59 Hydro Transaxle Gearbox Mounting Bracket 30131600
60 Brake Extension Bracket 30138500

SEPT 2006 SECTION 5

 37
WESTWOOD MULCH TRACTOR 32
HYDROSTATIC TRANSAXLE 38 39
2
5

29

44
31

6
8 9 30
24
36
2
28 5
7
10 3 9
16
2 43
4
40
42

BRAKE & FORWARD

PEDALS SEE SECTION 4
13 14 11
12

41 15
2 5 2
2

5 5
2 2 5
1 33 2
34
35 5

28
27
26
22

21

23 DRWG No: T1700402

ISSUE: 2
19
20 17 SECTION 6
25
18
 WESTWOOD MULCH TRACTOR
HYDROSTATIC TRANSAXLE
PARTS LIST

PART DESCRIPTION PART NUMBER

1 Roofing Bolt M8 x 20mm 018001500
2 M8 Washer 08819501
3 M10 Locknut 04872100
4 Vent Valve Breather Tuff Torq Pt No
19848592452
5 M8 Nyloc Nut 04920100
6 Park Brake Pin Rod 31305900
7 M8 x 10mm Grubscrew 018000900
8 Chassis 04 32702403
9 Split Pin 1/8” x 1” 06823300
10 Transaxle Bracket 307025900
11 14 mm Circlip 07906600
12 9/16” T4 LP Washer 08917800
13 K46 Input Pulley 200811600
14 Tuff Torq Plastic Transaxle Fan 148007000
15 Bolt M8 x 70mm 01850700
16 Bolt M8 x 75mm 018005600
17 Hub Cap 14811800
18 19 mm External Circlip 07921200
19 K46 Transaxle Thrust Washer 307191800
20 20” Rear Tyre 198001200
21 Rear Wheel Rim 198001100
Grease Nipple 11898800
22 Hub with Studs & Nuts 198002000
23 Wheel Nut 048000800
24 Brake Rod Spring 25808300
25 Wheel Valve 14889200
26 Washer 19mm 08829900
27 K46 Transaxle Spacer 189498700
28 Brake Rod - Hydro 327174100
29 Bolt M10 x 30mm 018002100
30 Brake Rod Trunnion 183017400
31 Lever Knob 14804800
32 Flat Head Rivet ¼” x ½” B/Z 12855800
33 Transaxle Support Bracket 313009400
34 K46 Hydrostatic Transaxle 478000300
35 Bolt M8 x 50mm 018001800
36 Deck Spring Stop Locking Collar 31320400
37 Dump Valve Rod 321123301

SEPT 2006 SECTION 6

 WESTWOOD TRACTOR
HYDROSTATIC TRANSAXLE
PARTS LIST

PART DESCRIPTION PART NUMBER

38 Dump Rod Bracket 303071400
39 Starlock Washer ¼” 08868700
40 Reservoir Hose 148014800
41 Belt Dayco A79 229503400
42 Key Rear Wheel 2” x 3/16” 09830700
43 Reservoir Tank 148014600
44 Tow bracket 29200101

SEPT 2006 SECTION 6

WESTWOOD MULCH TRACTOR
MAIN WIRING LOOM
29
24
34 1
23

P.C.B.
30 22
2 20

21

19

3
18
25

31 11
13
RELAY

15
STARTER

33

5
4
14
16
9

35
6 7

34 8
7
BATTERY CHARGER 32 DRWG No: T1710402
8 ISSUE: 2
SECTION 7A
 WESTWOOD MULCH TRACTOR
MAIN WIRING LOOM
PARTS LIST

PART DESCRIPTION PART NUMBER

1 Printed Circuit Board - please see reference table on the next page
2 Cutter Switch (With Symbols) 8161
3 Light Switch (With Symbols) 8160
4 Pull Safety Switch for Transmission 44813400
5 Safety Switch Spring 25813801
6 Light Loom 3894 44946600 use
44813900
7 Bulb Holder 44816100
8 12 Volt Pole Bulb 44816200
9 Electric Clutch Magstop 44936100
10 Clutch Loom Magstop Modular (not illustrated) 44946800
11 Lead Battery to Solenoid 44812600
12 B&S Engine Loom Block Connector (not illustrated) 448015500
13 Battery Solenoid Lead (+) 448006200
14 Battery Earth Lead 448006301
15 Starter Solenoid 44814801
16 12V 34AH Battery (Gel Type) 458141200
17 Ignition Light (not illustrated) 8841
18 Seat Switch 44949500
19 Fuse Holder FHA40 6.3mm 8176
20 Fuse Spade 10 Amp 44889500
21 Fuse Spade 20 Amp 44835000
22 Fuse Spade 1Amp 449559300
23 Ignition Switch Steel Lock Nut M16 048001300
24 Bezel 52813100
25 Main Loom 448006101
Main Loom (c/w clutch loom & light loom) 448006100 use
448006101
26 Tie Wrap (Not Illustrated) 52825400
27 Tie Wrap Mount (Not Illustrated) 52816800
28 Tie Wrap Self Adhesive (Not Illustrated) 52816700
29 Ignition Key 528006900
30 Ignition Switch 4488010700
31 Electric Relay 12v / 30amp 449559100
32 Intek Adaptor Loom for 448006101 448006900
33 Chassis to Engine Earth Loom 448007000
34 Westwood Battery Charger 449562800
35 Battery Charger Decal SEE SECTION
13B
36 Battery Charger Instructions (not illustrated) 36919400

SEPT 2006 SECTION 07A

 WESTWOOD MULCH TRACTOR 2 22a
DIAL HEIGHT WIRING LOOM
14
30
24 23
29/29a 1 17
3

22
32

31
BATTERY CHARGER
13

15
3
25

12

19

11

5
4
16
10
9

6
8

18
DRWG No: T171(B)0501
8 ISSUE 1.
SECTION 07B
 WESTWOOD MULCH TRACTOR
DIAL HEIGHT LOOM
PARTS LIST

PART DESCRIPTION PART NUMBER

1 Main Control PCB 449561700
2 Fuse Box Holder 301139400
3 Waterproof Monentary Switch (on / off / on) 448016100
4 Brake Switch 44945001
5 Safety Switch Spring 25813801
6 Headlight Loom 449562400
7 Electric Relay 12v / 30amp 449559100
8 Bulb Hella 21W 448008500
9 Electric Magstop Clutch 44936100
10 Clutch Loom Magstop 44946800
11 Lead Battery to Solenoid 44812602
12 Earth Lead 44812402
13 Start Lead (Briggs & Stratton Engines only) 44812500
14 Collet Knob Cap 148011001
15 Starter Solenoid 44814801
16 U1-34 12v Battery (Gel Type) 458141200
17 Ignition Washer 23 x 16 x 2mm 089418900
18 Seat Switch 44949500
19 Hiwin Actuator 1200N 448015700
20 10A Fuse (not illustrated) 44889500
21 Fuse Spade 20A (not illustrated) 44835000
22 Ignition Switch 448010700
22a Ignition Key 528006900
23 Ignition Switch Steel Lock Nut M16 048001300
24 Ignition Cap Bezel 52813100
25 Loom with Dial Height 449562000
26 Tie Wrap (Not Illustrated) 52825400
27 Tie Wrap Mount (Not Illustrated) 52816800
28 Tie Wrap Self Adhesive (Not Illustrated) 52816700
29 Deck Control PCB - from serial no. 21001…to 21104… 449559600
Dial Height Deck Control PCB – from serial no. 21211… 448009200
29a Dial Height Loom & Fuel Sender ( not illustrated) 448015200
30 Collet Knob 148010600
31 Westwood Battery Charger 449562800
32 Battery Charger Decal SEE SECTION
13B
33 Battery Charger Instructions (not illustrated) 36919500

SEPT 2006 SECTION 07B

WESTWOOD MULCH TRACTOR 1
STEERING CONSOL 4 3 2
ASSEMBLY 31 11

13 17/17a
35 32
12 5
14
7 6
31
9 8
34

15
16
37 28
22 & 27
38 29
27
21 PCB &
PCB COVER
20 18 30

DASHBOARD DECALS 29
24 SEE SECTION 13
30 39
23

26 25
19 O

8
9
10
01
9 8 66
77 88
CHOKE

9
9
5
7
5
7
& THROTTLE

10
6
6

4
4

10
5
5

33
4

1
1
2
4 22

CONTROL
3 2 3 11

12.5 25 50 100 100 100 100

10
n/min n/min

36 DRWG No: T1720503

ISSUE: 3

SECTION 8
FUSE BOX HOLDER
 WESTWOOD MULCH TRACTOR
STEERING CONSOL 2004
PARTS LIST

PART DESCRIPTION PART NUMBER

1. Steering Wheel Cap 14938700
2. Screw 8mm x 25mm 02826000
3. M8 Washer 08819501
4. Steering Wheel 14928200
5. Gaiter 9426
6. Circlip 5/8” 07823800
7. Column Spacer 183025200
8. Washer M8 x 40 x 3 08925400
9. Column Upper Bush 14801800
10. Dashboard Decals SEE SECTION 13B
11. Consul Top 148016800
12. Consul 321125200
13. Cap, Fuel Tank 3963
14. Fuel Tank 148015400
15. Battery Dry charge 458141200
16. Battery Strap 149499500
17. Fuel Tank Sensor 448010600
17a Fuel Level Sensor Seal Kit 149510900
18. Throttle Cable Single Cylinder 528004501
19. LH Manual Tractor Foot Mat 148009800
20. RH Front Running Board Mat 148010000
21. Centre Running Board Mat - Manual 148010100
22. RH Rear Running Board Mat 148010300
23. LH Rear Running Board Mat 148010400
24. RH Running Board 327174600
25. LH Running Board 327174500
26. Chassis 04 32702403
27. Screw M4 x 12mm Pozi Pan S/Screw 02826300
28. Control Knob (Throttle Cable) 14810400
29. M4 Form A Washer BZP 08826200
30. Nut Nyloc M4 04826400
31. Jubilee Clip ( Fuel Tank Hose) 11856900
32. Carry Plate 307202400
34. Fuel Tank Bracket 307199800
35. Pipe, Fuel Black Rubber 3859
36. Fuse Box Holder 301139400
37. Main PCB 449561700
38 PCB Case 148016700
39 Choke Control – Twin Cylinder RCL290058-00
SEPT 2006 SECTION 08
 WESTWOOD TRACTOR
STEERING CONSOL 2004
PARTS LIST

PART DESCRIPTION PART NUMBER

40 Actuator 1200N Hiwin 448015700
41 M10 x 55mm Hex Head Bolt 018002400
42 Washer 10.8 i.d. x 20.7o.d. x 2mm thk 088002400
43 M10 Nyloc Nut 04886100
44 Deck Actuator Cover 307188100
45 Hiwin Actuator Plate 328960500
46 M8 x 35mm Bolt 01935700
47 M8 Washer 08819501
48 Full Nut Hex M8 Z/P 04822300
49 Actuator Adjuster 188719000
50 M12 Nut 049381200
51 Deck Lift Actuator Screw 187189000
52 Universal Deck Lift Arm 307192400

SEPT 2006 SECTION 08

WESTWOOD MUCLH TRACTOR
HYDROSTATIC
REAR BODY ASSEMBLY

3
32
2
28 36 6
35 5
31
33 9 1
34 4
37
9
38 7
10 11
12

13
14
15
16
8
17
9

18
29 25
30 19
26
36
22
23 35
27
9
24 21

19
32
9 20

DRWG No: T1750102

ISSUE: 2
SECTION 9B
 WESTWOOD MULCH TRACTOR HYDROSTATIC
REAR BODY ASSEMBLY PARTS LIST

PART DESCRIPTION PART NUMBER

1 Seat 14947200
2 Compression Spring Universal 25831100
3 Seat Plate Adjuster R/H 30117900
4 ¼” x ½” Flat Head Solid Rivet 12855800
5 Starlock Washer ¼” 08868700
6 Seat Handle 30203100
7 Seat Plate Adjuster L/H 30118000
8 Bolt M8 x 20mm 02825900
9 Washer M8 08819501
10 R/H Seat Runner Upper 327173700
11 Tool Tray 149496700
12 L/H Seat Runner Upper 327173600
13 Washer 40 X 10mm HG 08118200
14 10mm Starlock Washer 08104400
15 M10 x 20mm Bolt 02800300
16 Bolt M10 x 40mm 019479100
17 Seat Spring (Adjustable Seat) 25845600
18 Spring Retaining Washer (Seat) 27835400
19 Rear Seat Box 327173000
20 Chassis 04 32702403
21 Seat Pivot Rod 31301800
22 ‘R’ Clip 2mm 06849100
23 Decal “IBS Deck” 35931400
24 Deck Size Decal “92cm/36in” 35931500
Deck Size Decal “97cm/38in” 35931600
Deck Size Decal “122cm/48in” 35931800
25 Washer 10.8 i.d. x 20.7 o.d. x 2mm Thk 088002400
26 Tractor Seat Channel 30114900
27 Rear Body Panel 301129800
28 Lever Knob 14804800
29 Decal Cutter Height Adjustment / PTO Engage 358005600
30 PTO Engage Plate 32708601
31 M8 Nyloc Nut 04920100
32 Tractor Deck Adjustment Lever 327003300
33 Deck Height Adjustment Yoke 32703300
34 Deck Height Trunnion 18805400
35 Clevis Pin 3/8” 31340800
36 Circlip 3/8’’ External 07846800
37 Deck Height Pivot Boss 18317400
38 Bolt M8 x 50mm 018001800

SEPT 2006 SECTION 9B

 3
4
WESTWOOD MULCH TRACTOR 3
I.B.S. CUTTER DECK
3
8
9
11
10

21
1

5 2
35

13
14
13
12 14
8 20
19 14
15 9
15 15
17
37
15
16 19 36 29
18 6 28
17 15 39
24 31 41
17
14 27 40 13
28 14
22 23 7 28 47
42 13 48
26 6
51 45
25 14 43

61 7 55 14 50
44 49
53 6 74 26
62
51

57 7
7 54
74 58
46 59
73
71 35
67 68 72
71 75 60/60a
70 46 46 13
79 6
84 83
69 74 6
68 13 81/82 20
80
67 78 6
14 8
77 DRWG No: T1740506
76
ISSUE No: 6
9 9
SECTION 10A
8 8
 WESTWOOD MULCH TRACTOR
IBS CUTTER DECK
(COVERED MODEL)
PART DESCRIPTION PART NUMBER
1 Deck Lid Cover 36” 148002200
Deck Lid Cover 38” 148002300
Deck Lid Cover 42” 148002402
Deck Lid Cover 48” 148002501
2 Rivet 4.8 x 6mm 12949400
3 Fir Tree Fastener 4958
4 Universal Deck Pulley Cover 2001 149497400
5 6 x 8 Pozi S/S S/Tap 02913100
6 Washer M8 x 25 x 3 unplated 089418600
7 M8 X 16mm M/Screw 028001000
8 Bolt 10 x 30mm 018002100
9 Washer Dome 3/8”id X1 3/4” X 1/8” 08819900
10 Deck Drive Pulley c/w 31328301 Spacer 20870202
11 Belt B54 - 36” Deck 22949800
Belt B55 – 38” Deck 22940200
Belt B57 – 42” Deck 22871200
Belt B59 – 48” Deck 22949900
12 Steel Deck Pulley c/w Bearing 20869600
13 M8 Nyloc Nut 04920100
14 M8 Washer 08819501
15 Spacer Jockey Wheel 18831600
16 Belt AA 105 – 36” Deck 22869800
Belt AA 112 – 38” Deck 22869901
Belt AA 120 – 42” Deck 22870000
Gates Belt BB 136 – 48” Deck 22928800
17 5” Deck Pulley 20869502
18 Tx PTO Jockey Pulley Plastic 20811500
19 Belt Retaining Bracket 27105800
20 S/Screw M8 x 70mm 01850700
21 Deck Pulley Cover (Driven) 327180100
22 Bolt M8 x 50mm 018001800

NOTE: MAG STOP CLUTCH STANDARD AFTER SERIAL No. 60929...

WARNER AND OGURA DECK DRIVE CLUTCHES NO LONGER AVAILABLE FROM
PARTS DEPARMENT

SEPT 2006 SECTION 10A

 WESTWOOD MULCH TRACTOR
IBS CUTTER DECK
(COVERED MODEL)

PART DESCRIPTION PART NUMBER

23 Belt Tension Plate Spacer 31328900
24 Belt Tension Plate 32731000
25 Deck Belt Tension Spring 25906200
26 Bolt M8 x 20mm 02825900
27 M10 x 55 Hex Head Bolt 018002400
28 Washer 10.8 i.d. x 20.7 o.d x 2mm Thk 088002400
29 M10 Nut Nyloc 04886100
31 Lift Arm (20” Wheel Model) 301122401
Deck Danger Decal 35803300
35
36 Key ¼” x ¼” x 22mm Square 098450100
37 Deck Drive Pulley Spacer (39mm) 31328301
39 Deck Hanging Bracket (Rear) 27102001
40 Deck Hanging Bar (Rear) 327361700
Rear Deck Lift Cradle (H.E.) 328954100
41 Sweeper Lift Assist Spring 25908801
42 Spacer 9mm X 8.3mm id 31302700
43 M8 x 30mm Hx Hd Bolt Zinc Plt & Clear Passivated 018005700
44 Deck Lift Cradle Rear 328961100
45 Deck Lift Pin Rear 31337200
46 Washer M12 x 24 x 1.6 088003600
47 Rear Deck Level Bracket 301143700
48 Rear Deck Cradle Adjuster 327029300
49 Washer 19mm 08829900
50 M12 ‘E’ Clip Plated 078000800
51 Rear Deck Hanging Bracket 27102001
53 Rubber Flap 14868900
54 Rubber Flap Plate 30145100
55 Pop Rivet 4.8 X 16mm 12860100
57 Deck Bearing Housing (Short Shaft With Studs) 40503604
58 Deck Bearing Housing (Short Shaft) 40503704 use
40503604
59 Deck Bearing Housing (Long Shaft) 40503504
60 36” Deck Shell 32726700
38” Deck Shell 32726601
42” Deck Shell 32726500

SEPT 2006 SECTION 10A

 WESTWOOD MULCH TRACTOR
IBS CUTTER DECK
(COVERED MODEL)

PART DESCRIPTION PART NUMBER

60 48” Deck Shell 32732500
60a Complete Cutter Deck SALES DEPT.
61 2002 Tractor Deck Level Trunnion 189497500
62 Height Adjuster Rod 18805900
63 Decal (36”) 92cm IBS Deck (not illustrated) 358008901
64 Deck Decal (38”) 97cm IBS Deck (not illustrated) 358009200
65 Decal (42”) 107cm IBS Deck (not illustrated) 358009001
66 Decal (48”) 122cm IBS (not illustrated) 358009301
67 Deck Lift Pin 31339400
68 Split Pin 1/8” x 1” 07823300
69 Deck Adjustment Plate 27115100
70 Deck Carrying (Front) 32703701
71 Deck Lift pin (Front) 31336800
72 Deck Push Rod Pin 31338200
73 Deck Bar 36” & 42” 29203900
Deck Tension Arm 38” 29202400
Deck Bar 48” 29203800
74 Rue Clip 11836700
75 15” R/H Blade 16869201
75 17.5” L/H Blade 16929000
76 12” L/H Blade (36” & 38 “) 16869001
15” L/H Blade (42”) 16869101
17.5” L/H Blade (48”) 16928900
77 15” L/H Blade 16869101
17.5 L/H Blade (48”) 16928900
36” & 38” Blade Kit 40505200
42” Deck Blade Kit 40505300
48” Deck Blade Set 40505500
78 10mm Internal Shakeproof Washer 088004000
79 Deck Pan Tab Washer 27111200
80 Scuff Wheel Hub 31337600
81 Anti Scalp Wheel 19905500
82 Anti Scalp Wheel – March 2002 149495800
83 Deck Level Adjuster Nut 189501801
84 M/Screw M10 x 60mm 018006600

SEPT 2006 SECTION 10A

 IBS DECK BLADE QUICK REFFERENCE

92cm (36”) & 97cm (38”)

1 12” L/H BLADE CLOCKWISE 16869001
1 15” L/H BLADE CLOCKWISE 16869101
1 15” R/H BLADE ANTI - CLOCKWISE 16869201
36” & 38” BLADE KIT 40505200

107cm (42”)
1 15” L/H BLADE CLOCKWISE 16869101
1 15” L/H BLADE CLOCKWISE 16869101
1 15” R/H BLADE ANTI - CLOCKWISE 16869201
42” BLADE KIT 40505300

123cm (48”)
1 17.5” L/H BLADE - ANTICLOCKWISE 16928900
1 17.5” L/H BLADE ANTI - CLOCKWISE 16928900
1 17.5” R/H BLADE ANTI - CLOCKWISE 16929000
48”BLADE KIT 40505500

IBS BELT PATH

SEPT 2006 SECTION 10A
 3
27
4
2 3
3 8
7 9
12
8
9 12
14 10 28
8 13 18
11 9
5 19
12
17
15 12
16
13
14
WESTWOOD MULCH TRACTOR
22 38"MULCHING DECK
21
14 14
20
23 25
13
14
29
30
14
24
24
14 5
37 26
36

35 34
13
14
38 40 1
14

24
32 14 6
14
13
26 31 24
39 24 14
9 24 33
8 14
32 32 14
13
39 14
13 39 DRWG No: T1760202
ISSUE: 2
9
9 SECTION 10B
8
8
 WESTWOOD MULCH TRACTOR
38’’ MULCHING DECK
PARTS LIST

P PART NUMBER
1 M8 x 70mm Hex Bolt Zinc & Clear Passivated 028663200
2 Self Tapping Screw Hex Head 4.8 x 16mm 028001500
3 Fir Tree Fastener 4958
4 Universal Deck Pulley Cover 149497400
5 `Deck Danger’ Decal 35803300
6 Mulcher Deck Liner Inner 148002600
7 B55 Belt Dayco Super 2 22940200
8 M10 x 30mm Bolt 018002100
9 Washer Dome 3/8” id x 1.3/4” x 1/8” 08819900
10 Deck Drive Pulley Spacer 31328301
11 Belt A72 Super 2 Mulcher Application 228000500
12 5” Deck Pulley - Internal 20869502
13 M8 Nyloc Nut 04920100
14 Washer M8 x 25 x 3mm Unplated 089418600
15 Spacer Jockey Wheel 18831600
16 PTO Jockey Pulley Plastic 20811500
17 Belt Retaining Bracket 27105800
18 Key 1/4” x 1” 09830600
19 Mulcher Deck Drive Pulley Guard 327180000
20 M8 x 40mm Bolt BZP 018003200
21 Belt Tension Plate Spacer 31328900
22 Mulcher Deck Belt Tension Plate 32734600
23 Deck Tension Spring 25906200
24 Screw 8mm x 25mm 02826000
25 Bolt M8 x 45mm 02941000
26 M8 Washer 08819501
27 Deck Lid Cover 38” Mulcher 148002701
28 Rivet Pop 4.8 x 6mm 12949400
29 Rear Hanging Bracket ( R/H ) 30121300
30 Rear Hanging Bracket ( L/H ) 30121400
31 Rivet for Mulcher Deck Liner 128000100
32 Short Shaft Bearing Housing 40503604
33 Deck Bearing Housing Long Shaft 40503504
34 Mulch 38” Deck Shell 327000101
35 Deck Push Rod Pin 31338200
36 Deck Tension Bar (38” Mulcher) 29203700
37 Rue Clip 11836700
38 Anti Scalp Wheel 149495800
39 15” L/H Mulching Blade 16937900
40 Scuff Wheel Hub 31337600

SEPT 2006 SECTION 10B

 WESTWOOD MULCH TRACTOR
38’’ MULCHING DECK
PARTS LIST

SEPT 2006 SECTION 10B

 1. WESTWOOD TRACTOR
DECALS 2002/3
MULCHER
2.
11. DASHBOARD DECALS

3.
Westwood O

10
4. 9 O

8 6.
Westwood
l
7 7.
6 O
5 O
4
3
5. 97 CM / 38"-
2
1 8.
S1400
S1600
9.

Westwood
IMPORTANT - READ SAFETY INSTRUCTIONS BEFORE OPERATING THIS MACHINE

MULCHING
For Best results;
- Do not reduce the height of the grass by more than 1/3 in a single pass
- Mow often - short clippings of 25mm (1") or less decompose more quickly
- If possible, avoid cutting in the wet
- Always cut with the engine at full running speed
15 MAX 15 MAX
O
- If an unsightly residue is present - increase cutting height O

- Vary mowing pattern from cut to cut

SERVICE DRWG:
- Always keep the underside of the deck clean to permit good grass flow
- Always ensure that blades are sharp and in good condition

VIBRATION TESTED TO THE FOLLOWING STANDARDS

EXERCISE CAUTION WHEN CUTTING
ON SLOPES
ISSUE:
BS 6842:1987, DD ENV 25349:1993, SI 1992:3073, BS6841:1987

10. SECTION 11A

 WESTWOOD MULCH TRACTOR DECALS PRE 2003/4
PARTS LIST

PART DESCRIPTION PART NUMBER

1. LH Bonnet Side Stripe RCL766181-00
RH Bonnet Side Stripe RCL766180-00
2. Decal Westwood Badge 358026100
3. Side Bonnet Decal `Westwood’ 9370
4. Front Bonnet Decal `Westwood’ 358010200
5. Decal - 92cm Deck Size 35931500
Decal - 97cm Deck Size 35931600
Decal - 107cm Deck Size 35931701
Decal - 122cm Deck Size 35931800
6. DK Height / PTO Engage Rear Body Decal 358005602
7. Dashboard Decal 358010500
8. Decal Front Upper Bonnet S1300M RCL76614100
Decal Front Upper Bonnet S1400H RCL76614200
Decal Front Upper Bonnet S1600H RCL76614600
Decal Front Upper Bonnet T1600H RCL76614800
Decal Front Upper Bonnet T1800H RCL76615200
Decal Front Upper Bonnet T2000H RCL76633000
9. Decal S1300 Consul 358011400
Decal S1600 Consul 358011600
Decal T1600 Consul 358011800
Decal T1800 Consul 358012000
Decal T2000 Consul 358012200
10. Instruction Decal 359506300
11. Mulcher Decal 35945901

SEPT 2006 SECTION 11A

 1. WESTWOOD TRACTOR
DECALS 2004/5
8.
MULCHER 97 CM / 38"-

Westwood 9. 10.
2.
DASHBOARD DECALS

11. 12.

7.

77 88
9 8 66

10
01

9
10

9
5
7
5

10
6
4
9

10
9

5
O

33
4

1
8
2
22 11
9 9 8 66
77 88 3

8
8 10

6.
01

9
9
5
7
5
7
14.

10
6
6
7

4
4

10
13.

5
5

33
7
4

1
1
2
4 22 11
3 2 3

6 6
12.5 25 50 100 100 100 100

5
S n/min n/min

4 5
3. 4
S1600 3 5.
2 3 O

1 2
1
12.5 25 50 100 100 100 100 500 7 8
9 8 6
9
8 10 01

9
7
5
S

10
6
4
6
n/min n/min

5
3
5
4

1
16.
2
2 1

1
4
2 3
3

4. 18. 15. 17.

IMPORTANT - READ SAFETY INSTRUCTIONS BEFORE OPERATING THIS MACHINE

MULCHING
O

For Best Results;

15 MAX 15 MAX
O
O

- Do not reduce the height of the grass by more than 1/3 in a single pass
- Mow often - short clippings of 25mm (1") or less decompose more quickly ATTENTION - Important Information is contained in the Battery Charger
- If possible, avoid cutting in wet Manual - Please read this carefully before using this
- Always cut with the engine at full running speed
EXERCISE CAUTION WHEN CUTTING RED
ON SLOPES charger. Only use this charger with the Countax Tractor
- If unsightly residue is present - increase cutting height Charging
- Vary mowing pattern from cut to cut Sealed Battery.Do not use in a sealed container or cover
- Always keep the underside of the deck clean to permit good grass flow the ventilation slots. Place the charger on a solid surface
- Always ensure that blades are sharp and in good condition with the indicator lights uppermost. Disconnect the charger from the
mains before connecting or disconnecting the battery.
Instructions -

SERVICE DRWG:
VIBRATION TESTED TO THE FOLLOWING STANDARDS
BS 6842:1987, DD ENV 25349:1993, SI 1992:3073, BS6841:1987 1. Disconnect the Tractor battery leads from the battery
2. Connect the charger to the battery with the red clip to the GREEN
red terminal ( + ) and the black clip to the black terminal ( - ) Maintenance

ISSUE:
3. Plug in and switch on the mains supply. The red light will illuminate
4. The battery will be sufficiently charged once the green light comes on
but you can not overcharge your battery with this charger so it can
be left connected until you next need to use your Tractor.
! IMPORTANT - THIS SIDE UP ! PART No 44-95628-00

SECTION 11B
 WESTWOOD MULCH DECALS 2004/5
PARTS LIST

PART DESCRIPTION PART NUMBER

1. Decal Westwood Badge 358026100
2. Side Bonnet Decal `Westwood’ 9370
3. Decal S1300 Consul 358011400
Decal S1600 Consul 358011600
Decal T1600 Consul 358011800
Decal T1800 Consul 358012000
Decal T2000 Consul 358012200
4. Instruction Decal 359506300
5. Deck Height PTO Disengage Manual Decal 358034200
6. DK Height / PTO Engage Rear Body Decal 358005602
7. Sweeper Height Decal 35937601
8. Mulcher Decal 35945901
9. Decal - 92cm Deck Size 35931500
Decal - 97cm Deck Size 35931600
Decal - 107cm Deck Size 35931701
Decal - 122cm Deck Size 35931800
10. Handbrake Handle Badge 359505100
11. Centre Clutch Switch Decal 358036000
12. Headlight Switch Decal 358035900
13. Throttle Choke Combined Decal 358035600
14. Ignition Deck Height Decal 358035400
15. Throttle & Choke Decal 358035500
16. Display Decal 358035200
17. Ignition Switch Decal 358035300
18. Westwood Battery Charger Decal 359509400

SEPT 2006 SECTION 11B