COROLLA ALTIS

Electrical Wiring Diagram

Pub. No. EM11B2EV

 FOREWORD
This wiring diagram manual has been prepared to provide
information on the electrical system of the COROLLA ALTIS.

This manual applies to the models listed below. It covers all

information in the previously issued Pub. No. EM11B1EV, and
includes all production changes effective Sep. 2010 or later.

Applicable models: ZZE142 Series

ZRE142, 143 Series

Refer to the following manuals for additional service

specifications and repair procedures for these models:

Manual Name Pub. No.

COROLLA ALTIS Repair Manual RM11B2EV

All information in this manual is based on the latest product

information at the time of publication. However, specifications
and procedures are subject to change without notice.

NOTICE
Always follow the directions given in the above repair manuals when handling
supplemental restraint system components (such as removal, installation,
inspection, etc.) in order to prevent accidents and supplemental restraint
system malfunction.

©2010
All rights reserved. This book may not be
reproduced or copied, in whole or in part, without
the written permission of Toyota Motor
Corporation.
 COROLLA ALTIS
ELECTRICAL WIRING DIAGRAM
Section Code Page

INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2

HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . . . . B . . . . 3

TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . C . . . . 12

ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17

GLOSSARY OF TERMS AND SYMBOLS . . . . . . E . . . . 18

RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20

ELECTRICAL WIRING ROUTING . . . . . . . . . . . . . . G . . . . 52

SYSTEM CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . H . . . . 74

GROUND POINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I . . . . 288

POWER SOURCE (Current Flow Chart) . . . . . . . J . . . . 296

CONNECTOR LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . K . . . . 304

PART NUMBER OF CONNECTORS . . . . . . . . . . . L . . . . 322

OVERALL ELECTRICAL WIRING DIAGRAM . . M . . . . 326

COROLLA ALTIS (EM11B2EV)

A INTRODUCTION
This manual consists of the following 13 sections:

No. Section Description

INDEX Index of the contents of this manual.

A
INTRODUCTION Brief explanation of each section.

HOW TO USE THIS

B Instructions on how to use this manual.
MANUAL

TROUBLE–
C Describes the basic inspection procedures for electrical circuits.
SHOOTING

D ABBREVIATIONS Defines the abbreviations used in this manual.

GLOSSARY OF
E TERMS AND Defines the symbols and functions of major parts.
SYMBOLS

Shows position of the Electronic Control Unit, Relays, Relay Block, etc.
F RELAY LOCATIONS
This section is closely related to the system circuit.

ELECTRICAL Describes position of Parts Connectors, Splice points, Ground points, etc.
G
WIRING ROUTING This section is closely related to the system circuit.

INDEX Index of the system circuits.

Electrical circuits of each system are shown from the power supply through ground
H points. Wiring connections and their positions are shown and classified by code
according to the connection method. (Refer to the section, ”How to use this manual”).
SYSTEM CIRCUITS
The ”System Outline” and ”Service Hints” useful for troubleshooting are also contained
in this section.
(Only wiring information for complete circuits is included.)

I GROUND POINT Shows ground positions of all parts described in this manual.

POWER SOURCE
J Describes power distribution from the power supply to various electrical loads.
(Current Flow Chart)

Describes the form of the connectors for the parts appeared in this book.
K CONNECTOR LIST
This section is closely related to the system circuit.

PART NUMBER OF
L Indicates the part number of the connectors used in this manual.
CONNECTORS

OVERALL
Provides circuit diagrams showing the circuit connections.
M ELECTRICAL
(Only wiring information for complete circuits is included.)
WIRING DIAGRAM

COROLLA ALTIS (EM11B2EV)

 HOW TO USE THIS MANUAL B

This manual provides information on the electrical circuits installed on vehicles by

dividing them into a circuit for each system.

The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)

When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section).

When the circuit operation is understood, begin troubleshooting of the problem

circuit to isolate the cause. Use Relay Location and Electrical Wiring Routing
sections to find each part, junction block and wiring harness connectors, wiring
harness and wiring harness connectors and ground points of each system circuit.
Internal wiring for each junction block is also provided for better understanding of
connection within a junction block.
Wiring related to each system is indicated in each system circuit by arrows
(from__, to__). When overall connections are required, see the Overall Electrical
Wiring Diagram at the end of this manual.

Example:
*The information in this manual is Front right door When inspecting or repairing,
refer to the Repair Manual.
about the wire harnesses.
Information about component and
assembly parts is for reference,
but in some cases this reference
information might not be included or
might differ from the actual vehicle.
When inspecting or repairing a vehicle,
refer to the relevant Repair Manual.
Wire harness
Component parts
Assembly parts

COROLLA ALTIS (EM11B2EV)

B HOW TO USE THIS MANUAL
* The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
[A]

Stop Light
[M]
(BAT) (IG)

15A 7.5A
STOP GAUGE

[B] 1 3 IB 4 IB

R–L
W–R

(S/D)
7 3C

L
[C] [G]
H6
Stop Light Switch
Assembly 14 CH1 15 3C

R–L
(W/G)

(S/D)
R

L
G–W

Combination Meter
4
Skid Control ECU

15 CH1 [E]

Lights
Rear
G–W
[D]
Assembly

H7
13
(S/D)
L
G–W

[F] [O]

Y–G
H4
7 8 Light Failure Sensor 4

2 1 11

[I]
G–R

1
G–R
HJ1 [N]
[H]
W–B
G–B
G–R

(Shielded)
G–R
Rear Combination Light

Rear Combination Light

4 3
Assembly RH

Assembly LH

2
H17
[J]
Stop

Stop

Center Stop
Light Assembly
1
H9
J7

3 6
W–B

W–B

W–B

1
W–B
HJ1
W–B

H1 [K] H2

50 [L]

COROLLA ALTIS (EM11B2EV)

 B
[A] : System Title [I] : Indicates the wiring color.
[B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code.
only the Relay Block No. is shown to distinguish it
B = Black W = White BR = Brown
from the J/B
Example: Indicates Relay Block No.1 L = Blue V = Violet SB = Sky Blue
R = Red G = Green LG = Light Green
[C] : ( ) is used to indicate different wiring and
connector, etc. when the vehicle model, engine P = Pink Y = Yellow GR = Gray
type, or specification is different. O = Orange BE = Beige
[D] : Indicates related system. The first letter indicates the basic wire color and the
[E] : Indicates the code for the (male and female) second letter indicates the color of the stripe.
connectors which are used to join two wire
harnesses. The connector code consists of two Example: L–Y
alphabetical and one numerical characters.

L Y
(Blue) (Yellow)

[J] : Indicates the pin number of the connector.

The numbering system is different for female and
Female Male ( ) male connectors.
The first character of the connector code indicates Example: Numbered in order Numbered in order
the alphabetical code allocated to the wire harness from upper left to from upper right to
which has the female connector, and the second lower right lower left
shows that of the wire harness which has the male
connector.
The third character indicates a serial number used
to distinguish between the wire harness
combinations in cases when more than one of the Female Male
same combination of wire harnesses exist
(e.g. CH1 and CH2). [K] : Indicates the ground point. The code consists of the
two characters: A letter and number.
The first character of the code indicates the
Symbol ( ) indicates the male terminal connector. alphabetical code allocated to the wire harness.
Numbers outside connector codes indicate the pin The second character indicates a serial number
numbers of both male and female connectors. used to distinguish between the ground points in
[F] : Represents a part (all parts are shown in sky blue). cases when more than one ground point exist on the
The code is the same as the code used in parts same wire harness.
position. [L] : Page No.
[G] : Junction Block (The number in the circle is the J/B [M] : Indicates the ignition key position(s) when the
No. and the connector code is shown beside it). power is supplied to the fuse(s).
Junction Blocks are shaded to clearly separate
them from other parts. [N] : Indicates a wiring Splice Point.

Example:
Example:

3C indicates that
it is inside
Junction Block
No.3
[O] : Wire Harness Code
Each wire harness is represented by a code.
Wire harness codes are used in the parts codes,
connector joining wire harness and wire harness
[H] : Indicates a shielded cable.
codes, and ground point codes. For example,
H7 (combination meter), CH1 (male, connector
joining wire harness and wire harness), and H2
(ground point) indicate that they are the parts
belonging to the same wire harness "H".

COROLLA ALTIS (EM11B2EV)

 ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.

A/C = Air Conditioner

A/T = Automatic Transaxle
ABS = Anti-Lock Brake System
ACIS = Acoustic Control Induction System
CAN = Controller Area Network
CPU = Central Processing Unit
CVT = Continuously Variable Transmission (Transaxle)
DLC3 = Data Link Connector 3
E.F.I. = Electronic Fuel Injection
ECM = Engine Control Module
ECT = Electronic Control Transmission
ECU = Electronic Control Unit
EPS = Electric Motor Power Steering
FL = Fusible Link
HID = High Intensity Discharge
IC = Integrated Circuit
J/B = Junction Block
LED = Light Emitting Diode
LH = Left-Hand
M/T = Manual Transaxle
R/B = Relay Block
RH = Right-Hand
SRS = Supplemental Restraint System
VSV = Vacuum Switching Valve
VVT = Variable Valve Timing
w/ = With
w/o = Without

* The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.

17

COROLLA ALTIS (EM11B2EV)

E GLOSSARY OF TERMS AND SYMBOLS
BATTERY GROUND
Stores chemical energy and The point at which wiring attaches to
converts it into electrical energy. the Body, thereby providing a return
Provides DC current for the auto’s path for an electrical circuit; without a
various electrical circuits. ground, current cannot flow.

CAPACITOR (Condenser) HEADLIGHTS

A small holding unit for temporary Current flow causes a headlight
1. SINGLE
storage of electrical voltage. FILAMENT filament to heat up and emit light. A
headlight may have either a single
(1) filament or a double (2) filament

CIGARETTE LIGHTER
An electric resistance heating 2. DOUBLE
FILAMENT
element.

CIRCUIT BREAKER HORN

Basically a reusable fuse, a circuit An electric device which sounds a
breaker will heat and open if too loud audible signal.
much current flows through it.
Some units automatically reset when
cool, others must be manually reset.
DIODE IGNITION COIL
A semiconductor which allows Converts low–voltage DC current
current flow in only one direction. into high–voltage ignition current for
firing the spark plugs.

DIODE, ZENER LIGHT

A diode which allows current flow in one Current flow through a filament
direction but blocks reverse flow only up causes the filament to heat up and
to a specific voltage. Above that potential,
emit light.
it passes the excess voltage. This acts as
a simple voltage regulator.

PHOTODIODE LED (LIGHT EMITTING DIODE)

The photodiode is a semiconductor Upon current flow, these diodes emit
which controls the current flow light without producing the heat of a
according to the amount of light. comparable light.

DISTRIBUTOR, IIA METER, ANALOG

Channels high–voltage current from Current flow activates a magnetic
the ignition coil to the individual coil which causes a needle to move,
spark plugs. thereby providing a relative display
against a background calibration.

FUSE METER, DIGITAL

A thin metal strip which burns through Current flow activates one or many
when too much current flows through it, FUEL
LED’s, LCD’s, or fluorescent
thereby stopping current flow and displays, which provide a relative or
protecting a circuit from damage. digital display.
FUSIBLE LINK
(for Medium Current Fuse) A heavy–gauge wire placed in high
MOTOR
amperage circuits which burns through on
overloads, thereby protecting the circuit.
A power unit which converts
The numbers indicate the crosssection M electrical energy into mechanical
surface area of the wires. energy, especially rotary motion.
(for High Current Fuse or
Fusible Link)

18

COROLLA ALTIS (EM11B2EV)

 E
RELAY SPEAKER
Basically, an electrically operated An electromechanical device which
1. NORMALLYswitch which may be normally creates sound waves from current
CLOSED closed (1) or open (2). flow.
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY SWITCH, MANUAL
OPEN Opens and closes
circuits, thereby
1. NORMALLY
OPEN stopping (1) or
allowing (2) current
flow.
RELAY, DOUBLE THROW
A relay which passes current 2. NORMALLY
through one set of contacts or the CLOSED
other.

RESISTOR SWITCH, DOUBLE THROW

An electrical component with a fixed A switch which continuously passes
resistance, placed in a circuit to current through one set of contacts
reduce voltage to a specific value. or the other.

RESISTOR, TAPPED SWITCH, IGNITION

A resistor which supplies two or A key operated switch with several
more different non adjustable positions which allows various
resistance values. circuits, particularly the primary
ignition circuit, to become
operational.
RESISTOR, VARIABLE or RHEOSTAT
A controllable resistor with a variable
rate of resistance.
Also called a potentiometer or
rheostat.

SENSOR (Thermistor) SWITCH, WIPER PARK

A resistor which varies its resistance Automatically returns wipers to the
with temperature. stop position when the wiper switch
is turned off.

SENSOR, SPEED TRANSISTOR

Uses magnetic impulses to open A solidstate device typically used as
and close a switch to create a signal an electronic relay; stops or passes
for activation of other components. current depending on the voltage
(Reed Switch Type)
applied at ”base”.

SHORT PIN
WIRES
Used to provide an unbroken
Wires are always drawn as
connection within a junction block. (1) NOT straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction are
SOLENOID not joined;
An electromagnetic coil which forms crossed wires (2) with a
a magnetic field when current flows, (2) SPLICED black dot or octagonal ( )
to move a plunger, etc. mark at the junction are
spliced (joined)
connections.

19

COROLLA ALTIS (EM11B2EV)

F RELAY LOCATIONS
[Engine Compartment]

ECM

Engine Room R/B

Engine Room J/B

Brake Actuator
Assembly Cooling Fan ECU

[Instrument Panel]
Stop Light Control R/B No.5 R/B No.6 J/B No.4 J/B No.3
Relay Assembly

Power Steering
ECU Assembly

Steering Lock
Actuator Assembly Theft Warning
ECU Assembly

Main Body ECU Clearance Warning

Instrument Panel ECU Assembly
J/B
A/C Amplifier Assembly
Center Airbag
Sensor Assembly
Shift Lock Control
ECU Sub-Assembly

*1
* 1:Refer to the Service Bulletin
for the installation position
of the parts. Certification
ID Code Box ECU Assembly

20

COROLLA ALTIS (EM11B2EV)

 F
[Body]

* 1:w/ Smart Entry & Start System No.3 Door Control Receiver (*1)
* 2:w/o Smart Entry & Start System No.2 Door Control Receiver (*2)

21

COROLLA ALTIS (EM11B2EV)

F RELAY LOCATIONS
1 : Engine Room R/B
Engine Compartment Left (See Page 20)
: Engine Room J/B

Fuse Holder

*1 STRG LOCK DOME

2 2 20A 1 1 10A 2
1 *2 AM2 RAD NO.1
2 2 30A 1 1 15A 2
*3 AM2 NO.2 ECU-B
2 2 7.5A 1 1 10A 2
1 *4 ALT-S D.C.C
2 2 7.5A 1 1 2
*5 TURN-HAZ ECU-B2
2 2 10A 1 1 10A 2
1 *6 ETCS IG2 NO.2 FAN NO.1 Relay
2 2 10A 1 1 7.5A 2
1 1
5 3 5 3 MG CLT Relay
2 2

2 2
3 5 3 5 4 FAN NO.2 Relay
*7 1 1

*8 *11 FAN NO.3 Relay

*9 *12

*15

*10
5

2 1
DIMMER Relay
3

*13

*14 5

2 1 H-LP Relay
3

* 1:15A H-LP LH LO (HID Type)

10A H-LP LH LO (Except HID Type)
* 2:15A H-LP RH LO (HID Type)
10A H-LP RH LO (Except HID Type)
* 3:10A H-LP LH HI
* 4:10A H-LP RH HI
* 5:10A EFI NO.1
* 6:10A EFI NO.2
1F 1Q * 7:50A HTR (for High Current)
1 1 * 8:50A ABS NO.1 (for High Current)
Unit B * 9:30A ABS NO.3 (for High Current)
(from Engine (from Engine Wire) * 10:30A RDI FAN (1ZZ-FE)
Unit A Room Main Wire) Wire Color: B-R (for High Current)
Wire Color: W * 11:50A H-LP MAIN (for High Current)
* 12:50A P/I (for High Current)
* 13:60A EPS (for High Current)
* 14:120A ALT (for High Current)
* 15:40A RDI FAN (2ZR-FE, 3ZR-FE)
(for High Current)

22

COROLLA ALTIS (EM11B2EV)

 F

Unit A
1 2 1 2
3 4 3 4

(from Engine Room (from Engine Room

Main Wire) Main Wire)
1C 1D

3 4 3 4
1 2 1 2 Back View

1J
1

(from Engine 1I
Room Main 1
Wire)
Wire Color : W (from Engine
Room Main
Wire)
Wire Color : L

Side View

1P Top View
1

(from Engine
Wire)
Wire Color : B-L

Side View
To Fuse
Holder
1G
1

(from Engine
Room Main
1H Wire)
1
Wire Color : W
(from Engine
Room Main
Wire)
Wire Color : L

23

COROLLA ALTIS (EM11B2EV)

F RELAY LOCATIONS
[Engine Room R/B and Engine Room J/B Inner Circuit]

* 1:1ZZ-FE
* 2:2ZR-FE, 3ZR-FE Unit A
* 3:HID Type 1 1P
* 4:Except HID Type 120A ALT

1 1H 1 1J
60A EPS

1 1C
30A RDI FAN (*1)

2 1C
40A RDI FAN (*2)

3 1D 1 1D
50A P/I 30A ABS NO.3

4 1D 2 1D
50A H-LP MAIN 50A ABS NO.1

1 1G 1 1I
50A HTR

Fuse Holder

2 1 1 2
1 1
10A DOME 30A AM2
2 1 1 2
1 1
15A RAD NO.1 10A ETCS
2 1 1 2
1 1
10A ECU-B 10A TURN-HAZ
2 1 2
1
D.C.C

7.5A ALT-S

1
2 1
1
10A ECU-B2
1 2
1 1
15A H-LP LH LO (*3)
10A H-LP LH LO (*4)
1 2
1
15A H-LP RH LO (*3)
10A H-LP RH LO (*4)
1 2
1 1
10A H-LP LH HI
1 2
1
10A H-LP RH HI
1 2
1 1
10A EFI NO.1
1 2
1
10A EFI NO.2
1 2
1 1
7.5A IG2 NO.2

24

COROLLA ALTIS (EM11B2EV)

F RELAY LOCATIONS
1 : Engine Room R/B
Engine Compartment Left (See Page 20)
: Engine Room J/B

Unit B

Top View Back View

IG2
1 15A 2 1 1
2 2
3 3
1A
4 4

5 5
6 6
7 7
8 8

HORN (from Engine Room Main Wire)

1 10A 2

1 1
2 2
3 3
4 1B 4

EFI MAIN 5 5

1 2 6 6
20A
7 7
8 8

(from Engine Room Main Wire)

1E
1 1

(from Engine Room Main Wire)

26

COROLLA ALTIS (EM11B2EV)

 F
[Engine Room R/B and Engine Room J/B Inner Circuit]

Unit B
1 1A
IG2 Relay
1 2
4 1A
15A IG2
3 1A

2 1A

5 1A
HORN Relay
1 2
8 1A
10A HORN

7 1A

6 1A

1 1B
EFI MAIN Relay
1 2
4 1B
20A EFI MAIN
3 1B

2 1B

5 1B

1 1E 8 1B

7 1B

6 1B

27

COROLLA ALTIS (EM11B2EV)

F RELAY LOCATIONS

: Instrument Panel J/B Cowl Side Left (See Page 20)

16151413121110 9
1413121110 9 8 8 7 6 5 4 3 2 1
7 6 5 4 3 2 1

19 1
20 2 (from Instrument (from Instrument
21 3
22 4
2B Panel Wire) Panel Wire)
23 5
24 6
25 7 9 18
26 8
8 17
2D 2C 7 16
27 9 6 15
28 10 5 14
29 11 4 13
30 12 3 12
2 11
31 13 1 10
32 14
33 15 (from Instrument
1 16 1 19
34 16
2 17 2 20 7654321 Panel Wire)
35 17 3 21 87654321
36 18 3 18 14 1312 1110 9 8
4 19 4 22 16 15 14 1312 1110 9
5 20 5 23 2H
6 21 6 24
7 25
(from Engine Room 7 22 8 26
Main Wire) 1 17
8 23 9 27 18 9
9 24 10 28 17 8 2 18 17 1
16 7 3 19 18 2
10 25 11 29 4 20 19 3
16 1 15 6
2A 11 26 12 30
14 5
5 21 20 4
17 2 6 22 21 5
18 3 13 4 7 23 22 6
19 4 12 27 13 31 12 3 8 24 23 7
20 5 13 28 14 32 11 2 24 8
21 6 14 29 15 33 10 1 9 25
22 7 15 30 16 34
2E
10 26 25 9
17 35 11 27 26 10
23 8 18 36 12 28 27 11
24 9 4 28 12
25 10 3
26 11 2 13 29
1 3 29 13
1 14 30
4 15 31 30 14
5 1
27 12 2 16 32 31 15
28 13 2 6 32 16
2
29 14 1
30 15
2 (from Instrument
3 2 1 Panel Wire)
(from Floor Wire) 1 1
1 8 7 6 5 4

2J 4
3
3 1
4
2K 1 1
2
8 7 6 5 4 1
5
6 2 5 3 5 4 3 3 2 1
(from Instrument
(from Roof Wire) Panel Wire)
2 2

30A POWER
(for High Current) 2F 1 2 3
4 5 6 7 8

30A DEF
(for High Current) (from Instrument
Panel Wire)

IG1 Relay HTR Relay FLASHER Relay

2L 2G
30A PWR SEAT
(for High Current)
1 1

(from Engine Room

Main Wire) (from Engine Room
Main Wire)

28

COROLLA ALTIS (EM11B2EV)

 F

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
Main Body ECU 16
17
18
19
20
21
22
23
24
25
26

2M 10 11 12 13 14 15 16 17 18 6 7 8 9 10
2Q
7 8 9 10 11 12 6 7 8 9 10 11 12 13 13121110 9 8 7 6
12 11 10 9 8 7 1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 1 2 3 4 5 1 2 3 4 5 54 321
6 5 4 3 2 1

(from Instrument
(from Instrument Panel Wire)
Panel Wire)

2S 2P

1 2 3 4 5 6 7 8 9 1 2 3 4 5
10 11 12 13 14 15 16 17 18 6 7 8 9 10

(from Instrument (from Instrument

Panel Wire) Panel Wire)

29

COROLLA ALTIS (EM11B2EV)

 30
METER
7.5A AM1
IGN 7.5A
7.5A FR FOG
15A

ACC-B
25A
F RELAY LOCATIONS

DOOR
: Instrument Panel J/B

MIR HTR 25A

10A

STOP
ACC 10A
7.5A OBD
CIG 7.5A
15A ECU-IG NO.2
10A
ECU-IG NO.1
RR DOOR 10A
20A WASHER
RL DOOR 15A
20A
FR DOOR
20A WIPER
25A
HTR-IG

COROLLA ALTIS (EM11B2EV)

PANEL 10A
7.5A
TAIL
Cowl Side Left (See Page 20)

10A
F RELAY LOCATIONS
5 : R/B No.5 Instrument Panel Center (See Page 20)

1
ST Relay 5 3
2

1
ACC Relay 5 3
2

50

COROLLA ALTIS (EM11B2EV)

 F
6 : R/B No.6 Instrument Panel Center (See Page 20)

1
FR FOG Relay 5 3
2

2
3 5 ST CUT Relay
1

51

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[2ZR-FE]
A93 A50 A12 A11 A28

A27

A66

A16

A18

A64 A7

A19 A65

A8

A38

A22 A17 A37 A21 A82 A94 A24 A23 A41 A10 A25

A7 Front Turn Signal Light LH (Headlight Assembly LH) A25 Fog Light Assembly LH
A8 Front Clearance Light LH (Headlight Assembly LH) A27 Front Speed Sensor RH
A10 Front Airbag Sensor LH A28 Front Speed Sensor LH
A11 Windshield Wiper Motor Assembly A37 Headlight Assembly RH (High)
A12 Brake Fluid Level Warning Switch A38 Headlight Assembly LH (High)
(Brake Master Cylinder Reservoir Sub-Assembly) A41 Cooling Fan ECU
A16 A/C Pressure Sensor A50 ECM
A17 Windshield Washer Motor and Pump Assembly A64 Headlight Assembly RH (Low)
A18 Front Turn Signal Light RH (Headlight Assembly RH) A65 Headlight Assembly LH (Low)
A19 Front Clearance Light RH (Headlight Assembly RH) A66 Brake Actuator Assembly
A21 Front Airbag Sensor RH A82 High Pitched Horn Assembly
A22 Fog Light Assembly RH A93 Security Horn Assembly
A23 Ambient Temperature Sensor A94 Hood Lock Assembly
A24 Low Pitched Horn Assembly

52

COROLLA ALTIS (EM11B2EV)

 G
Position of Parts in Engine Compartment
[2ZR-FE]
B108 B26 B27 B28 B29 B89 B119 B106 B19 B107 B97 B2

B23

B10

B9 B31

B113 B117

B6 B115

B111

B3 B14 C2 B112 B98 B11 B4 B8 B12 B25 B88 B110 B118 B114 B116

B2 Intake Air Flow Meter Sub-Assembly B88 Park/Neutral Position Switch Assembly
B3 Generator Assembly B89 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
B4 Starter Assembly B97 E.F.I. Engine Coolant Temperature Sensor
B6 Engine Oil Pressure Switch Assembly B98 Cooler Compressor Assembly
B8 Starter Assembly B106 VVT Sensor (Exhaust Side)
B9 Fuel Injector Assembly No.1 B107 VVT Sensor (Intake Side)
B10 Fuel Injector Assembly No.2 B108 Camshaft Timing Oil Control Valve Assembly
B11 Fuel Injector Assembly No.3 (Exhaust Side)
B12 Fuel Injector Assembly No.4 B110 Back Up Light Switch Assembly
B14 Generator Assembly B111 Crank Position Sensor
B19 Purge VSV B112 Cooler Compressor Assembly
B23 Camshaft Timing Oil Control Valve Assembly B113 VSV (ACIS)
(Intake Side) B114 CVT Solenoid
B25 Throttle with Motor Body Assembly B115 Oil Pressure Sensor
B26 Ignition Coil Assembly No.1 B116 Transmission Revolution Sensor (NIN)
B27 Ignition Coil Assembly No.2 B117 Transmission Revolution Sensor (NOUT)
B28 Ignition Coil Assembly No.3 B118 Transmission Revolution Sensor (NT)
B29 Ignition Coil Assembly No.4 B119 Noise Filter (Ignition)
B31 ECM
C2 Knock Control Sensor (Bank 1)

53

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[3ZR-FE]
A93 A50 A12 A11 A28 A42
* 1:Before Sep. 2010 Production
* 2:From Sep. 2010 Production

A27

A66

A16 A7

(*2)
A18 A40

(*2) (*1)
A39 A65

(*1)
A64 A8

A19 A9

A20 A38

A22 A17 A37 A21 A82 A94 A24 A23 A41 A10 A25

A7 Front Turn Signal Light LH (Headlight Assembly LH) A27 Front Speed Sensor RH
A8 Front Clearance Light LH (Headlight Assembly LH) A28 Front Speed Sensor LH
A9 Headlight Leveling Motor LH (Headlight Assembly LH) A37 Headlight Assembly RH (High)
A10 Front Airbag Sensor LH A38 Headlight Assembly LH (High)
A11 Windshield Wiper Motor Assembly A39 Headlight Assembly RH (Low)
A12 Brake Fluid Level Warning Switch A40 Headlight Assembly LH (Low)
(Brake Master Cylinder Reservoir Sub-Assembly) A41 Cooling Fan ECU
A16 A/C Pressure Sensor A42 Wireless Door Lock Buzzer
A17 Windshield Washer Motor and Pump Assembly A50 ECM
A18 Front Turn Signal Light RH (Headlight Assembly RH) A64 Headlight Assembly RH (Low)
A19 Front Clearance Light RH (Headlight Assembly RH) A65 Headlight Assembly LH (Low)
A20 Headlight Leveling Motor RH A66 Brake Actuator Assembly
(Headlight Assembly RH) A82 High Pitched Horn Assembly
A21 Front Airbag Sensor RH A93 Security Horn Assembly
A22 Fog Light Assembly RH A94 Hood Lock Assembly
A23 Ambient Temperature Sensor
A24 Low Pitched Horn Assembly
A25 Fog Light Assembly LH

54

COROLLA ALTIS (EM11B2EV)

 G
Position of Parts in Engine Compartment
[3ZR-FE]
(*1) (*2)

B108 B26 B27 B28 B29 B89 B30 B119 B106 B19 B107 B97 B117 B2 B118 B31

B23

B10

B9

B113 B116

B6 B115

(*1)
B105 B109

(*2)
B111 B96

B88

* 1:Before Sep. 2010 Production

* 2:From Sep. 2010 Production
B3 B14 C2 B112 B98 B11 B4 B8 B12 B25 B90 B114

(*1) (*2)

B2 Intake Air Flow Meter Sub-Assembly B89 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
B3 Generator Assembly B90 Electronically Controlled Transmission Solenoid
B4 Starter Assembly B96 Transmission Revolution Sensor (Turbine)
B6 Engine Oil Pressure Switch Assembly B97 E.F.I. Engine Coolant Temperature Sensor
B8 Starter Assembly B98 Cooler Compressor Assembly
B9 Fuel Injector Assembly No.1 B105 Crank Position Sensor
B10 Fuel Injector Assembly No.2 B106 VVT Sensor (Exhaust Side)
B11 Fuel Injector Assembly No.3 B107 VVT Sensor (Intake Side)
B12 Fuel Injector Assembly No.4 B108 Camshaft Timing Oil Control Valve Assembly
B14 Generator Assembly (Exhaust Side)
B19 Purge VSV B109 Transmission Revolution Sensor (Counter Gear)
B23 Camshaft Timing Oil Control Valve Assembly B111 Crank Position Sensor
(Intake Side) B112 Cooler Compressor Assembly
B25 Throttle with Motor Body Assembly B113 VSV (ACIS)
B26 Ignition Coil Assembly No.1 B114 CVT Solenoid
B27 Ignition Coil Assembly No.2 B115 Oil Pressure Sensor
B28 Ignition Coil Assembly No.3 B116 Transmission Revolution Sensor (NIN)
B29 Ignition Coil Assembly No.4 B117 Transmission Revolution Sensor (NOUT)
B30 Noise Filter (Ignition) B118 Transmission Revolution Sensor (NT)
B31 ECM B119 Noise Filter (Ignition)
B88 Park/Neutral Position Switch Assembly
C2 Knock Control Sensor (Bank 1)

55

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[1ZZ-FE]
A93 A50 A12 A28 A11

A27

A66

A88

A18

A64 A7

A19 A65

A37 A8

A38

A22 A17 A21 A82 A94 A24 A58 A10 A92 A25

A7 Front Turn Signal Light LH (Headlight Assembly LH) A28 Front Speed Sensor LH
A8 Front Clearance Light LH (Headlight Assembly LH) A37 Headlight Assembly RH (High)
A10 Front Airbag Sensor LH A38 Headlight Assembly LH (High)
A11 Windshield Wiper Motor Assembly A50 ECM
A12 Brake Fluid Level Warning Switch A58 Cooling Fan Motor
(Brake Master Cylinder Reservoir Sub-Assembly) A64 Headlight Assembly RH (Low)
A17 Windshield Washer Motor and Pump Assembly A65 Headlight Assembly LH (Low)
A18 Front Turn Signal Light RH (Headlight Assembly RH) A66 Brake Actuator Assembly
A19 Front Clearance Light RH (Headlight Assembly RH) A82 High Pitched Horn Assembly
A21 Front Airbag Sensor RH A88 Pressure Switch
A22 Fog Light Assembly RH A92 Cooling Fan Resistor
A24 Low Pitched Horn Assembly A93 Security Horn Assembly
A25 Fog Light Assembly LH A94 Hood Lock Assembly
A27 Front Speed Sensor RH

56

COROLLA ALTIS (EM11B2EV)

 G
Position of Parts in Engine Compartment
[1ZZ-FE]
B9 B10 B26 B11 B27 B12 B28 B29 B89 B30 B58 B60 B19

B23

B31
B65

B2
B1

B96
B14

B90
B7

B88

B6 B4 B8 C2 B68 B25

B1 Generator Assembly B27 Ignition Coil Assembly No.2

B2 Intake Air Flow Meter Sub-Assembly B28 Ignition Coil Assembly No.3
B4 Starter Assembly B29 Ignition Coil Assembly No.4
B6 Engine Oil Pressure Switch Assembly B30 Noise Filter (Ignition)
B7 With Pulley Compressor Assembly B31 ECM
B8 Starter Assembly B58 E.F.I. Engine Coolant Temperature Sensor
B9 Fuel Injector Assembly No.1 B60 Back Up Light Switch Assembly
B10 Fuel Injector Assembly No.2 B65 Crank Position Sensor
B11 Fuel Injector Assembly No.3 B68 Cam Position Sensor
B12 Fuel Injector Assembly No.4 B88 Park/Neutral Position Switch Assembly
B14 Generator Assembly B89 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
B19 Purge VSV B90 Electronically Controlled Transmission Solenoid
B23 Camshaft Timing Oil Control Valve Assembly B96 Transmission Revolution Sensor (Turbine)
(Intake Side)
B25 Throttle with Motor Body Assembly C2 Knock Control Sensor (Bank 1)
B26 Ignition Coil Assembly No.1

57

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel

E4 E5 E9 E25 E3 E26 E2 E1 E23 E20

* 3:Automatic A/C
* 7:Refer to the Service Bulletin
for the installation position of the parts.

*7

E22 E11 E17 E7 E6 E10 E30 E14 E18 E16 E12

(*3)

E1 Radio Receiver Assembly E14 Center Airbag Sensor Assembly

E2 Radio Receiver Assembly E16 Heater or Boost Ventilator Control Assembly
E3 Amplifier Antenna Assembly E17 Outer Mirror Switch Assembly
E4 Ignition or Starter Switch Assembly E18 Cigarette Lighter Assembly
E5 Un-Lock Warning Switch Assembly E20 Glove Box Light Assembly
E6 Spiral Cable Sub-Assembly E22 ID Code Box
E7 Spiral Cable Sub-Assembly E23 Blower with Fan Motor Sub-Assembly
E9 Windshield Wiper Switch Assembly E25 Room Temperature Sensor
E10 Windshield Wiper Switch Assembly E26 Radio Receiver Assembly
E11 DLC3 E30 A/C Amplifier Assembly
E12 Parking Brake Switch Assembly

58

COROLLA ALTIS (EM11B2EV)

 G
Position of Parts in Instrument Panel

* 5:w/ Smart Entry & Start System E32 E59 E39 E46 E38 E58 E41 E53 E57 E56
* 7:Refer to the Service Bulletin
for the installation position of the parts.

E55

E54

E37

*7

E36 E52 E51 E50 E44 E60

(*5)

E32 Power Steering ECU Assembly E52 Main Body ECU

E36 Certification ECU Assembly E53 Junction Connector
E37 Front Electrical Key Oscillator E54 Junction Connector
E38 Power Switch E55 Junction Connector
E39 Steering Lock Actuator Assembly E56 Junction Connector
E41 Hazard Warning Signal Switch Assembly E57 Junction Connector
E44 Headlight Leveling Switch E58 Junction Connector
E46 Combination Meter Assembly E59 Junction Connector
E50 Main Body ECU E60 Headlight Dimmer Switch Assembly
E51 Main Body ECU

59

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel

* 1:3ZR-FE Before Sep. 2010 Production E94 E96 E69 E70 E68 E66 E64
* 2:1ZZ-FE, 2ZR-FE, 3ZR-FE From Sep. 2010 Production
* 4:Manual A/C
* 6:w/o Smart Entry & Start System

E98

(*6)
E61 E75

E87 E93

E99 E65

E95

E92 E82 E62 E63 E86 E67 E83 E81

(*1 *4) (*2 *4)

E61 Main Body ECU E82 Key Inter Lock Solenoid

E62 A/C Amplifier Assembly E83 Transmission Control Switch
E63 A/C Amplifier Assembly E86 Oxygen Sensor (Bank 1 Sensor 2)
E64 Blower with Fan Motor Sub-Assembly E87 Security Indicator Light Assembly
E65 No.3 Heater Control Sub-Assembly E92 Ignition Key Cylinder Light Assembly
E66 Blower Resistor E93 Clearance Warning ECU Assembly
E67 No.1 Cooler Thermistor E94 No.1 Clearance Warning Buzzer
E68 Recirculation Damper Servo Sub-Assembly E95 Telltale Light Assembly
E69 Heater Control Base Sub-Assembly E96 Stop Light Control Relay Assembly
E70 Heater Control Sub-Assembly E98 Diode
E75 Theft Warning ECU Assembly (Front Door Courtesy Light Switch Assembly RH)
E81 Shift Lock Control ECU Sub-Assembly E99 Diode
(Front Door Courtesy Light Switch Assembly LH)

60

COROLLA ALTIS (EM11B2EV)

 G
Position of Parts in Instrument Panel

A75 a2 a1 Y1 f1 U1

A49

A48

A46 A47

A45

A95

A1

A3

Y3 X1 L16 M8

A1 Stop Light Switch Assembly L16 Center Airbag Sensor Assembly

A3 Accelerator Pedal Sensor Assembly
A45 Junction Connector M8 Center Airbag Sensor Assembly
A46 Junction Connector
A47 Junction Connector U1 Front Passenger Side Squib Circuit
A48 Junction Connector
A49 Junction Connector X1 A/C Blower Assembly
A75 Power Steering ECU Assembly A/C Amplifier Assembly
A95 Clutch Start Switch Assembly
Y1 Spiral Cable Sub-Assembly
Steering Pad Switch Assembly
Y3 Driver Side Squib Circuit
Spiral Cable Sub-Assembly

a1 Power Steering ECU Assembly

Steering Column Assembly
a2 Power Steering ECU Assembly
Steering Column Assembly

f1 Solar Sensor

61

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Body

H1 H8 H2 H4 H7 H9 H6 J1 J2 J3

I4

I2

I6
L1

I3
L2

I1
L9

I5

I9

L3 L4 K1 K2 K3 L5 L7

H1 Front No.1 Speaker Assembly RH J1 Rear Power Window Regulator Switch Assembly RH
H2 Outer Rear View Mirror Assembly RH J2 Rear Door Window Regulator Sub-Assembly RH
H4 Front No.2 Speaker Assembly RH J3 Rear Door Lock Assembly RH
H6 Front Door Lock Assembly RH
H7 Front Power Window Regulator Switch Assembly RH K1 Rear Power Window Regulator Switch Assembly LH
H8 Front Power Window Regulator Motor Assembly RH K2 Rear Door Window Regulator Sub-Assembly LH
H9 Front Door Courtesy Light Assembly RH K3 Rear Door Lock Assembly LH

I1 Front No.1 Speaker Assembly LH L1 Rear Speaker Assembly RH

I2 Outer Rear View Mirror Assembly LH L2 Rear Speaker Assembly LH
I3 Power Window Regulator Master Switch Assembly L3 Front Door Courtesy Light Switch Assembly LH
I4 Front No.2 Speaker Assembly LH L4 Front Seat Outer Belt Assembly LH
I5 Front Door Lock Assembly LH L5 Rear Door Courtesy Light Switch Assembly LH
I6 Front Power Window Regulator Motor Assembly LH L7 Rear Combination Light Assembly LH
I9 Front Door Courtesy Light Assembly LH L9 License Plate Light Assembly RH

62

COROLLA ALTIS (EM11B2EV)

 G
Position of Parts in Body

(*2) (*1)

T1 T2 L24 L20 L46 O10 L17 O1 L30 M1 M2 L31 e1 M3 M12 M14

* 1:w/ Smart Entry & Start System
* 2:w/o Smart Entry & Start System

P1

M16

L27

L29

L28

L18

b3

L22 L25 L34 V1 L33 L32 L19 L35 L10 b4 W1 L26 M13

L10 License Plate Light Assembly LH M1 Front Door Courtesy Light Switch Assembly RH
L17 Fuel Pump M2 Front Seat Outer Belt Assembly RH
Fuel Sender Gage Assembly M3 Rear Door Courtesy Light Switch Assembly RH
L18 Luggage Compartment Door Lock Assembly M12 No.2 Door Control Receiver
L19 No.1 Luggage Compartment Light Assembly M13 Outside Luggage Electrical Key Antenna
L20 Noise Filter (Rear Window Defogger and Stop Light) M14 No.3 Door Control Receiver
L22 Front Seat Inner Belt Assembly LH M16 Indoor Luggage Compartment Electrical Key Oscillator
L24 Diode (No.1 Luggage Compartment Light Assembly)
L25 Rear Electrical Key Oscillator O1 No.1 Room Light Assembly
L26 Luggage Compartment Door Opener Switch Assembly O10 Map Light Assembly
L27 Luggage Compartment Door Lock Cylinder Assembly
L28 Back Up Light Socket RH P1 Rear Window Defogger (Back Window Glass)
L29 Rear Combination Light Assembly RH
L30 Junction Connector T1 Front Door Handle Assembly Outside LH
L31 Junction Connector T2 Front Door Electrical Key Oscillator LH
L32 Junction Connector
L33 Junction Connector V1 Rear Speed Sensor LH
L34 Junction Connector
L35 Back Up Light Socket LH W1 Rear Speed Sensor RH
L46 Rear Window Defogger (Back Window Glass)
b3 Rear RH No.1 Ultrasonic Sensor Center
b4 Rear LH No.1 Ultrasonic Sensor Center

e1 Center Stop Light Assembly

63

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
Position of Parts in Seat

c2

c6
d2

c1
d1

L48 c7 c3 c4 c5

L48 Junction Connector d1 Front Power Seat Reclining Position Motor Assembly
LH
c1 Front Power Seat Slide Position Motor Assembly LH d2 Front Lumbar Support Adjuster Motor Assembly LH
c2 Front Power Seat Lift Position Motor Assembly LH
c3 Front Power Seat Vertical Position Motor Assembly LH
c4 Front Power Seat Switch
c5 Power Lumbar Support Adjuster Switch
(Power Seat Switch Assembly)
c6 Front Seat Inner Belt Assembly LH
c7 Junction Connector

64

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[2ZR-FE]

B4 B3

Engine Room BA2

Main Wire
BA4
Engine Wire
BA1

A2
A4
A1
A3

CB2 Engine No.4 Wire

66

COROLLA ALTIS (EM11B2EV)

 G
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[3ZR-FE]

B4 B3

Engine Room BA2

Main Wire
BA4
Engine Wire
BA1

A2
A4
A1
A3

CB2 Engine No.4 Wire

67

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[1ZZ-FE]

B3 B4

Engine Room BA2

Main Wire
BA4
Engine Wire
BA1

A2
A4
A1
A3

CB1 Engine No.4 Wire

68

COROLLA ALTIS (EM11B2EV)

 G
: Location of Connector Joining Wire Harness and Wire Harness

AE11 AE3 AE2 Ef1 EU1 AE7 AE12 AE8 AE6 AM1
(*1) (*2)

AE5
AE1
AE4
HE2
(*1)
AL1
EM1
(*2)
AL2 EM3
EL5
EL1

* 1:Before Sep. 2010 Production (*1) (*2) (*1) (*2)

* 2:From Sep. 2010 Production
EL4 IE1 IE4 IE3 IE2 HE1 HE3

: Location of Ground Points

E2 Air Conditioner E5 E3 Instrument Panel
Wiring Harness Wire Assembly
Sub-Assembly
Engine Room
Main Wire
Engine Room
Main Wire

Roof Wire Front Door

RH Wire

A5 E4

Front Door
LH Wire Floor No.2 Wire

E1

Floor Wire Instrument Panel Wire Floor Wire Floor No.2 Wire

69

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points

L1 Front Door M2 JM1 Rear Door M1 P1

RH Wire No.1 Wire

Roof Wire

Front Door
LH Wire
Rear Window
KL1 No.2 Wire

IT1
Floor No.2 Wire
Electrical Key
Wire Harness LH WM1

L2
bM1

Floor Wire Floor No.5 Wire

Rear Door No.2 Wire

Skid Control L3 Skid Control

VL1 Sensor LH Wire Le1 Cord Assembly Sensor RH Wire

70

COROLLA ALTIS (EM11B2EV)

 G
: Location of Connector Joining Wire Harness and Wire Harness

Front Seat LH No.2 Wire

Front Seat LH Wire Floor Wire dc1

71

COROLLA ALTIS (EM11B2EV)

G ELECTRICAL WIRING ROUTING
[Antenna]

Antenna Cord Sub Assembly

Amplifier Antenna Assembly

72

COROLLA ALTIS (EM11B2EV)

H SYSTEM CIRCUITS

COROLLA ALTIS
ELECTRICAL WIRING DIAGRAM
SYSTEM CIRCUITS
Page
ABS ...................................................................................................................... 196
Air Conditioner (Automatic A/C) ....................................................................... 276
Air Conditioner (Manual A/C) ............................................................................ 282
Audio System ..................................................................................................... 250
Back-Up Light ..................................................................................................... 146
Charging .............................................................................................................. 100
Cigarette Lighter ................................................................................................. 248
Combination Meter ............................................................................................. 258
Cooling Fan (1ZZ-FE) ......................................................................................... 272
Cooling Fan (2ZR-FE, 3ZR-FE) .......................................................................... 268
CVT and Shift Indicator ...................................................................................... 188
DLC3 .................................................................................................................... 130
Door Lock Control .............................................................................................. 212
ECT and A/T Indicator ........................................................................................ 180
Engine Control (1ZZ-FE) .................................................................................... 120
Engine Control (2ZR-FE, 3ZR-FE) ..................................................................... 108
EPS ...................................................................................................................... 232
Front Fog Light ................................................................................................... 160
Front Wiper and Washer .................................................................................... 176
Headlight ............................................................................................................. 136
Headlight Beam Level Control .......................................................................... 164
Horn ..................................................................................................................... 246
Ignition ................................................................................................................ 104
Illumination ......................................................................................................... 148
Interior Light ....................................................................................................... 154
Key Reminder (w/o Smart Entry & Start System) ............................................ 168
Light Reminder ................................................................................................... 172
Multiplex Communication System (CAN) ........................................................ 132
Parking Assist (TOYOTA Parking Assist-Sensor) .......................................... 254
Power Seat .......................................................................................................... 240
Power Source ..................................................................................................... 76
Power Window .................................................................................................... 228
Rear Window Defogger ...................................................................................... 244
Remote Control Mirror ....................................................................................... 236
Seat Belt Warning ............................................................................................... 208
Shift Lock ............................................................................................................ 206
Smart Entry & Start System .............................................................................. 82
* Engine Immobiliser
* Push-Button Start
* Steering Lock
* Wireless Door Lock Control
SRS ...................................................................................................................... 201

74

COROLLA ALTIS (EM11B2EV)

 H

Page
Starting (w/o Smart Entry & Start System) ...................................................... 98
Stop Light ............................................................................................................ 144
Taillight ................................................................................................................ 148
Theft Deterrent .................................................................................................... 222
Turn Signal and Hazard Warning Light ............................................................ 140
Wireless Door Lock Control (w/o Smart Entry & Start System) .................... 218

75

COROLLA ALTIS (EM11B2EV)

Power Source

30A AM2 W

1 (∗1)
1 2 W W
1 AE1
(∗2)

7. 5A AM2 NO. 2
16
1 2 W W
1 AE3
(∗1) (∗1)

40A RDI FAN (∗6)

30A RDI FAN (∗5)

∗ 1 : w/ Smart Entry & Start System

10A ETCS 50A HTR ∗ 2 : w/o Smart Entry & Start System
1 2 ∗ 3 : HID Type
∗ 4 : Except HID Type
∗ 5 : 1ZZ–FE
∗ 6 : 2ZR–FE, 3ZR–FE
50A ABS NO. 1

10A TURN–HAZ

1 2
30A ABS NO. 3

120A ALT
1 1
W
1G 1J
GR
W

IG2 Relay
4
R
1A

2 3
1 1F GR W–B
1A 1A

50A P/I 20A EFI MAIN

EFI MAIN Relay
3 1 4
B 1 2 B
1D 1E 1B
1 1Q

15A IG2

1 2
B–R
(∗5)

(∗6)
W

10A HORN

1 2
7. 5A ALT–S

FL MAIN 1 2
3. 0W
10A ECU–B
D. C. C
1 2 1 2
60A EPS
R

10A ECU–B2 10A DOME

Battery
1 2 1 2

20A STRG LOCK 15A RAD NO. 1

1 2 1 2

50A H–LP MAIN

4
R–B
1D

76

COROLLA ALTIS (EM11B2EV)

 ACC 3
W
(∗2) Y 2 AM1 IG1 4 W
(∗2) (∗2) B
ST1 (∗2)
51 88
W Y
4A 4A
(∗1) (∗1)
W 7 AM2 IG2 6 GR GR

89 (∗2) (∗2) (∗2)

W ST2
4A
(∗1)
W
E4 (∗2)
Ignition or Starter
Switch Assembly
Y
(∗2)

Y 1 4 GR(∗1)
B AM1 ACCD A
(∗1)

W 6 6 W(∗1)
A AM2 IG1D B
(∗1)
W

GR 5 GR
IG2D B
(∗1)
7. 5A IGN
10 W(∗1)
SSW1 B
1 4 7. 5A METER
R R
AE3 2F
9 B(∗1)
W–B SSW2 B

10A EFI NO. 1 E50(A), E51(B)

Main Body ECU
B 1 2
1 GR

10A EFI NO. 2

1 2

10A H–LP LH HI

1 2
DIMMER Relay
W–B

R 2 1
1
10A H–LP RH HI

R 3 5 R–B 1 2 1 B
1 1 1 A45(A), A46(B)
Junction
Connector
15A H–LP LH LO (∗3)
10A H–LP LH LO (∗4) 6 A

1 2
W–B

H–LP Relay
1 2
1 15A H–LP RH LO (∗3)
10A H–LP RH LO (∗4)
R–B

5 3 R 1 2
1 1 1
R–B
A1

77

COROLLA ALTIS (EM11B2EV)

Power Source

ACC Relay
5
L 3 5 W
5 5 2F

B B 1 2
5 5
(∗2) (∗2)

W–B
(∗1)
GR
GR
9 25A ACC–B
(∗2) L
2M

3
W W(∗2)
2F
(∗2)
W(∗1)

1 7. 5A AM1
Y Y
2F
(∗2) (∗2)
1
W W
2G

GR(∗1)

W(∗1)
(∗2)
GR

GR
(∗1)

W(∗1) 17 AE3
GR

B(∗1)

GR 2 7 1
SS2 SS1
7. 5A
IG2
NO. 2
Power Switch

COM GND
E38

1
4 5
32 92
BR W–B
4A 4A
(∗1) (∗1)

33
BR
4A
(∗1)
GR

E5

78

COROLLA ALTIS (EM11B2EV)

 15A CIG

7. 5A ACC

Noise Filter

IG1 Relay
5 3 25A WIPER

2 1 10A ECU–IG NO. 1

T–LP Relay 10A ECU–IG NO. 2

7. 5A OBD 7. 5A PANEL

10A HTR–IG
10A STOP 10A TAIL

15A WASHER
15A FR FOG
30A POWER
PWR Relay
1 2
20A FR DOOR

25A DOOR 20A RL DOOR

20A RR DOOR

30A DEF
DEF Relay
1 2 10A MIR HTR

30A PWR SEAT

1 2

7 2M 17 2E 2 2E 18 2E
W–B

W–B

32 4C (∗9)
45 4C (∗10)

∗ 1 : w/ Smart Entry & Start System

21 4B (∗9)
∗ 2 : w/o Smart Entry & Start System
58 4B (∗10)
∗ 9 : Before Sep. 2010 Production
∗10 : From Sep. 2010 Production
W–B

W–B

W–B

W–B

E1 E2

79

COROLLA ALTIS (EM11B2EV)

Power Source
: Parts Location
Code See Page Code See Page Code See Page
A45 A 61 E4 58 E50 A 59
A46 B 61 E38 59 E51 B 59

: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B (Engine Compartment Left)
5 50 R/B No.5 (Instrument Panel Center)

: Junction Block and Wire Harness Connector

Code See Page Junction Block and Wire Harness (Connector Location)
1A
26
1B
1D 23
1E 26 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1F 22
1G
23
1J
1Q 22 Engine Wire and Engine Room J/B (Engine Compartment Left)
2E
28 Instrument Panel Wire and Instrument Panel J/B (Cowl Side Left)
2F
2G 28 Engine Room Main Wire and Instrument Panel J/B (Cowl Side Left)
2M 29 Instrument Panel Wire and Instrument Panel J/B (Cowl Side Left)
4A
4B 40 Instrument Panel Wire and J/B No.4 (Instrument Panel Brace RH)
4C

: Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AE1
69 Engine Room Main Wire and Instrument Panel Wire (Left Side of the Instrument Panel)
AE3

: Ground Points
Code See Page Ground Points Location
66 (2ZR-FE)
A1 67 (3ZR-FE) Front Fender Apron LH
68 (1ZZ-FE)
E1 69 Left Kick Panel
E2 69 Left Side of the Instrument Panel
E5 69 Instrument Panel Brace LH

80

COROLLA ALTIS (EM11B2EV)

Starting (w/o Smart Entry & Start System)

(BAT) (BAT)
∗ 1 : Before Sep. 2010 Production
∗ 2 : From Sep. 2010 Production
30A 7. 5A ∗ 3 : 1ZZ–FE
AM2 AM1 ∗ 4 : 2ZR–FE, 3ZR–FE
∗ 5 : A/T, CVT

1 1 2F

ACC
W

Y 2 AM1 IG1

11 6
ST1 1 W W
AE3 B
1 AE1
5 2
W 7 AM2 IG2 B A

A45(A), A46(B)
ST2 8 Junction
Connector

E4
Ignition or Starter
LG
W

Switch Assembly

(A/T)

(∗4)
LG

W
5 5

5 1 1 BA2 22 AE3
ST Relay

(∗5)
W
3 2
4 A (A/T)

Park/Neutral Position
4 B (CVT)

(M/T)
5 5

(A/T)
LG

W
Switch Assembly
L B L
B88(A), (B)
P
W–B

W–B
(∗1)

(∗2)

N
12 AE3 14 AE3
4 AE1 70 4A 58 4A 5 A (A/T)
9 B (CVT)

(A/T)
(∗5)
LG

LG

W
L

45 4A 92 4A

8 BA2 2 BA2 10 BA2

W–B

W–B
(∗1)

(∗2)

B–L
(A/T)
L

LG

(∗4)

1 B 1 2S
B–R 1
52 B 25 A
A50(A), B31(B)

A
(∗3) STAR NSW
Starter Assembly

LG
B4(A), B8(B)

ECM

17 2E STA
M
48 A

Battery
W–B
(∗1)

E1 E5

98

COROLLA ALTIS (EM11B2EV)

 : Parts Location
Code See Page Code See Page Code See Page
A45 A 61 55 (3ZR-FE) B31 B 57 (1ZZ-FE)
B4 A
A46 B 61 57 (1ZZ-FE) 55 (3ZR-FE)
A
52 (2ZR-FE) 53 (2ZR-FE) 57 (1ZZ-FE)
B88
A50 A 54 (3ZR-FE) B8 B 55 (3ZR-FE) 53 (2ZR-FE)
B
56 (1ZZ-FE) 57 (1ZZ-FE) 55 (3ZR-FE)
B4 A 53 (2ZR-FE) B31 B 55 (3ZR-FE) E4 58

: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B (Engine Compartment Left)
5 50 R/B No.5 (Instrument Panel Center)

: Junction Block and Wire Harness Connector

Code See Page Junction Block and Wire Harness (Connector Location)
2E
28
2F Instrument Panel Wire and Instrument Panel J/B (Cowl Side Left)
2S 29
4A 40 Instrument Panel Wire and J/B No.4 (Instrument Panel Brace RH)

: Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AE1
69 Engine Room Main Wire and Instrument Panel Wire (Left Side of the Instrument Panel)
AE3
66 (2ZR-FE)
BA2 67 (3ZR-FE) Engine Wire and Engine Room Main Wire (Inside of the Engine Room R/B and Engine Room J/B)
68 (1ZZ-FE)

: Ground Points
Code See Page Ground Points Location
E1 69 Left Kick Panel
E5 69 Instrument Panel Brace LH

99

COROLLA ALTIS (EM11B2EV)

Charging

(IG)

10A
ECU–IG
NO. 2
W

1 1G 19 2B

G
120A 7. 5A
ALT ALT–S

5 BA2
2

1 1P 1

G
W
B–L
7 BA1

W
B1(A), B3(C), B14(B) 1 C (∗2)
Generator Assembly 1 A (∗1) 1 B 2 B
B S IG

IC Regulator
W

1 1F

1 1Q
M L
3 B 4 B
B–R

(∗2)
L

FL MAIN 52 B
3. 0W ALT

B31(B)
ECM
Y

Battery

100

COROLLA ALTIS (EM11B2EV)

 (BAT) (IG)
∗ 1 : 1ZZ–FE
∗ 2 : 2ZR–FE, 3ZR–FE
10A 7. 5A ∗ 3 : Before Sep. 2010 Production
ECU–B METER ∗ 4 : From Sep. 2010 Production

1 1 2M

(∗3)
W

P
12 2H 1 4C (∗3) 29 4C
3 4C (∗4)

(∗4)
P
30 2B 4 4B
2 4B (∗3)
15 4C (∗4)

(∗3)
W

E46
Combination Meter Assembly 32 33
B IG+
Master
Charge

Display

LED Information
Driver 5V IC

CPU

I/F I/F

Buzzer
CHG– ET
39 30
BR
Y

11 4B (∗3)
2 AE5 18 4C (∗4)
Y

21 4B (∗3)
92 4A (∗4)
6 BA1

Y
W–B

W–B
(∗4)

(∗3)

E5 E2

101

COROLLA ALTIS (EM11B2EV)

Charging
: Parts Location
Code See Page Code See Page Code See Page
B1 A 57 (1ZZ-FE) 53 (2ZR-FE) 53 (2ZR-FE)
B31 B
53 (2ZR-FE) B14 B 55 (3ZR-FE) 55 (3ZR-FE)
B3 C
55 (3ZR-FE) 57 (1ZZ-FE) E46 59

: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B (Engine Compartment Left)

: Junction Block and Wire Harness Connector

Code See Page Junction Block and Wire Harness (Connector Location)
1F 22
Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1G 23
1P 23
Engine Wire and Engine Room J/B (Engine Compartment Left)
1Q 22
2B 28 Engine Room Main Wire and Instrument Panel J/B (Cowl Side Left)
2H 28
Instrument Panel Wire and Instrument Panel J/B (Cowl Side Left)
2M 29
4A
4B 40 Instrument Panel Wire and J/B No.4 (Instrument Panel Brace RH)
4C

: Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AE5 69 Engine Room Main Wire and Instrument Panel Wire (Left Side of the Instrument Panel)
66 (2ZR-FE)
BA1 67 (3ZR-FE)
68 (1ZZ-FE)
Engine Wire and Engine Room Main Wire (Inside of the Engine Room R/B and Engine Room J/B)
66 (2ZR-FE)
BA2 67 (3ZR-FE)
68 (1ZZ-FE)

: Ground Points
Code See Page Ground Points Location
E2 69 Left Side of the Instrument Panel
E5 69 Instrument Panel Brace LH

102

COROLLA ALTIS (EM11B2EV)

Ignition

(IG) (BAT)
∗ 1 : 1ZZ–FE
∗ 2 : 2ZR–FE, 3ZR–FE
7. 5A 15A ∗ 3 : Before Sep. 2010 Production
IG2
NO. 2
IG2 ∗ 4 : From Sep. 2010 Production

2 2

1
GR

2 1A
IG2 Relay

3 1A 4 1A B31(A), (B)
ECM
W–B

IGT1 IGT2
85 A 84 A (∗1)
109 B 108 B (∗2)
4 BA1
W–L
R

R R B R
R

1 A (∗3)
1 B (∗4) 1 3 1 3

B30(A), B119(B) +B IGT1 +B IGT2

Assembly No. 1

Assembly No. 2

Noise Filter
(Ignition)
Ignition Coil

Ignition Coil

IGF GND IGF GND

B26

B27

2 4 2 4

1 B
A45(A), A46(B)
W–B

W–B

Junction
Y

Connector

6 A
Y Y

W–B W–B
W–B

W–B

A1 B3

104

COROLLA ALTIS (EM11B2EV)

 B31(A), (B)
ECM

IGT3 IGT4 IGF1

83 A 82 A 81 A (∗1)
107 B 106 B 82 B (∗2)
V–G(∗1)

Y(∗2)
L–B

R
R

1 3 1 3
+B IGT3 +B IGT4
Assembly No. 3

Assembly No. 4
Ignition Coil

Ignition Coil

IGF GND IGF GND

B28

B29

2 4 2 4
W–B

W–B
Y

Y Y

W–B W–B

Y
(∗2)

105

COROLLA ALTIS (EM11B2EV)

Ignition
: Parts Location
Code See Page Code See Page Code See Page
A45 A 61 B27 57 (1ZZ-FE) 55 (3ZR-FE)
B30 A
A46 B 61 53 (2ZR-FE) 57 (1ZZ-FE)
53 (2ZR-FE) B28 55 (3ZR-FE) A 57 (1ZZ-FE)
B26 55 (3ZR-FE) 57 (1ZZ-FE) B31 53 (2ZR-FE)
B
57 (1ZZ-FE) 53 (2ZR-FE) 55 (3ZR-FE)
53 (2ZR-FE) B29 55 (3ZR-FE) 53 (2ZR-FE)
B27 B119 B
55 (3ZR-FE) 57 (1ZZ-FE) 55 (3ZR-FE)

: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B (Engine Compartment Left)

: Junction Block and Wire Harness Connector

Code See Page Junction Block and Wire Harness (Connector Location)
1A 26 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)

: Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
66 (2ZR-FE)
BA1 67 (3ZR-FE) Engine Wire and Engine Room Main Wire (Inside of the Engine Room R/B and Engine Room J/B)
68 (1ZZ-FE)

: Ground Points
Code See Page Ground Points Location
66 (2ZR-FE)
A1 67 (3ZR-FE) Front Fender Apron LH
68 (1ZZ-FE)
66 (2ZR-FE)
B3 67 (3ZR-FE) Engine Block Left
68 (1ZZ-FE)

106

COROLLA ALTIS (EM11B2EV)

Engine Control (1ZZ-FE)

(IG) (BAT) (BAT) (IG)

7. 5A 15A 20A 7. 5A
IG2 NO. 2 IG2 EFI MAIN IGN

2 2 2

1
GR

2 1A

EFI MAIN C/OPN

IG2 Relay Relay
Relay

3 1A 4 1A 3 1B 4 1B 2 1B 1 1B 11 2B 9 2B 10 2B 8 2A

BE

LG
B

B
L
W–B

W–B
R

Pump
8 BA1

Junction Connector
M

Fuel Pump
4 A 3 A

A45(A), A46(B)
1 1

L17
5
10A 10A
EFI EFI 4 B
R

NO. 2 NO. 1

W–B
B

2 2

1 1 B

P
B

B B
B

BE
16 AE11 9 BA1 12 BA1
B

L
B

R
1 B
A45(A), A46(B) B
Junction
Connector
6 A

W–B B

B
W–B

W–B

A1 L2

120

COROLLA ALTIS (EM11B2EV)

 (BAT) (BAT)

10A 10A
STOP ETCS

18 2B 1

W
B

3 2
Switch Assembly
Stop Light
A1

4 1
L

A45(A), A46(B)

12 A
Connector
Junction

8 B
R

35 A 36 A 3 A
ST1– STP +BM

A50(A), B31(B)
ECM

BATT +B FC IGSW MREL # 10 # 20 # 30 # 40

20 A 2 A 7 A 28 A 44 A 108 B 107 B 106 B 105 B
BE

LG
G
B

Y
L

B
Fuel Injector Assembly No. 1

Fuel Injector Assembly No. 2

Fuel Injector Assembly No. 3

Fuel Injector Assembly No. 4

P

2 2 2 2
B
B10

B11

B12
B9

1 1 1 1

BE
R

R R R R

B B

B B

B B

121

COROLLA ALTIS (EM11B2EV)

Engine Control (1ZZ-FE)

B25
Throttle with Motor Body Assembly
Control Valve Assembly
Camshaft Timing Oil

2
(Intake Side)

E2 VC VTA VTA2 M+ M–
3 5 6 4 2 1
B23

R–G
P–B

(∗1)
BR
B

BR
100 B 123 B 91 B 67 B 115 B 114 B 42 B 41 B 63 B
OC1+ OC1– ETA VCTA VTA1 VTA2 M+ M– GE01

A50(A), B31(B)
ECM

PRG VG E2G THA ETHA A1A– A1A+ HA1A

49 B 118 B 116 B 65 B 88 B 113 B 112 B 109 B

(∗1)
(∗1)
W

R
V

Y
L

Air Fuel Ratio Sensor

Meter Sub–Assembly

(Bank 1 Sensor 1)

1 5 4 1 4 3 1
Intake Air Flow

VG E2G THA A1A– A1A+ HA1A

Purge VSV

+B E2 +B
B19

B89
B2

2 3 2 2
B

B B

B B

122

COROLLA ALTIS (EM11B2EV)

 ∗ 1 : Shielded

A3
Accelerator Pedal Sensor Assembly
E. F. I. Engine Coolant
Temperature Sensor

VCP2 VPA2 EPA2 VCPA VPA EPA

1 3 2 4 6 5
B58

2
BR

BE

R
B

97 B 96 B 58 A 56 A 60 A 57 A 55 A 59 A
THW ETHW VCP2 VPA2 EPA2 VCPA VPA EPA

A50(A), B31(B)
ECM

HT1B OX1B EX1B E1 G2 NE– NE+

47 B 64 B 87 B 104 B 99 B 121 B 122 B

(∗1) BR (∗1)
W
BR
LG
(∗1)
P

BR

5 BA4 8 BA4 7 BA4 10 BA4

(∗1)

B
(∗1)

LG
P

(∗1)
BR

W
B

15 AE11 12 AE11 13 AE11 14 AE11

(∗1)

LG
P

Crank Position Sensor

Cam Position Sensor

2 4 3
HT1B OX1B E2 2 2

+B
B68

B65

1 E86
Oxygen Sensor 1 1
(Bank 1 Sensor 2)
B

B4

123

COROLLA ALTIS (EM11B2EV)

Engine Control (1ZZ-FE)

(IG) (BAT) (BAT)

10A 30A 120A

ECU–IG DEF ALT
NO. 2

1 1J

DEF
Relay

W
10A 1 2G 15 2B
MIR HTR

FAN NO. 2 Relay

G

Junction Connector
T–LP Relay

A48(A), A49(B)
11 2M 9 A
10A
TAIL
B

12 B

13 AE3

R
B

33 A 31 A 22 A
ELS2 ELS1 FANH

A50(A), B31(B)
ECM

KNK1 EKNK IGT1 IGT2 IGT3 IGT4 IGF1

110 B 111 B 85 B 84 B 83 B 82 B 81 B

(∗1)
(∗1)

W
B

W–L

V–G
L–B
B

1 CB1 2 CB1 Y Y
W

3 2 3 2 3 2 3 2
IGT1 IGF IGT2 IGF IGT3 IGF IGT4 IGF

2
Sensor (Bank 1)
Knock Control

B26 B27 B28 B29

Ignition Coil Ignition Coil Ignition Coil Ignition Coil
Assembly No. 1 Assembly No. 2 Assembly No. 3 Assembly No. 4
C2

124

COROLLA ALTIS (EM11B2EV)

 ∗ 1 : Shielded
(BAT)

7. 5A
AM1

2 BA2

1 2F

(A/T)
LG
E63
A/C Amplifier Assembly 5

Park/Neutral Position
B L ACC

Switch Assembly

(M/T)
LG
ACT AC1 P Y 2 AM1 IG1
19 17 N ST1 1 W
B88

(A/T)
W
E4
P

Ignition or Starter
Switch Assembly

1 BA2 11 AE3
6 AE2 5 AE2

W
W

W
LG
P

18 A 30 A 48 A 5 B 6 B

A45(A), A46(B)
ACT AC1 STA

Connector
Junction
A50(A), B31(B)
ECM
2 A

EC E04 E03 E02 ME01 E01 TC TACH SPD W CANL CANH STAR

W
32 A 46 B 86 B 44 B 43 B 45 B 27 A 15 A 8 A 24 A 49 A 41 A 52 B
GR

W
R
P

23 2B 25 2B 4 AE2 10 BA2 22 AE3

W

4 2C 10 2E

14 AE3
W–B

W–B

W–B

W–B

W–B

W–B

GR

W
P

23 4B

Y
42 4A
W
P

13 9 R
TC TAC
E11 V
DLC3

CANL CANH
14 6

LG

A1 B3 B4

125

COROLLA ALTIS (EM11B2EV)

Engine Control (1ZZ-FE)

E58
Junction Connector

10 21 7 18 2 13
W
B

2 AE7 1 AE7

LG

W
G
W
B

9 20
A47
Junction
Connector

10 21 8 19 Speed Sensors
BR
LG

LG
W

W
R
Y

25 14 19 18 7 6
CANH CANL FL+ FL– FR+ FR–
A66
Brake Actuator Assembly
SP1 RL+ RL– RR+ RR–
22 5 4 17 16
W

G
R
V

Y
2 BA4
W W
Speed Sensors
G
V

R R

V V

LG

126

COROLLA ALTIS (EM11B2EV)

 (BAT) (IG)

10A 7. 5A
ECU–B METER

1 1 2M

P
12 2H 1 4C 29 4C

30 2B 2 4B 4 4B

P
E46
Combination Meter Assembly 32 33
B IG+
Check Engine

Buzzer

Master
Display

Information
I/F

LED Driver 5V IC

CPU
CAN Controller

5V +B

I/F CAN I/F

I/F I/F

EFI CANL CANH ET +S SI

20 28 27 30 36 35
BR
W

G
P

4 AE5 11 4B 7 4B 6 AE5
V

21 4B 19 4A

6 BA4
W
W–B

E2

127

COROLLA ALTIS (EM11B2EV)

Engine Control (1ZZ-FE)
: Parts Location
Code See Page Code See Page Code See Page
A1 61 B11 57 (1ZZ-FE) B68 57 (1ZZ-FE)
A3 61 B12 57 (1ZZ-FE) B88 57 (1ZZ-FE)
A45 A 61 B19 57 (1ZZ-FE) B89 57 (1ZZ-FE)
A46 B 61 B23 57 (1ZZ-FE) C2 57 (1ZZ-FE)
A47 61 B25 57 (1ZZ-FE) E4 58
A48 A 61 B26 57 (1ZZ-FE) E11 58
A49 B 61 B27 57 (1ZZ-FE) E46 59
A50 A 56 (1ZZ-FE) B28 57 (1ZZ-FE) E58 59
A66 56 (1ZZ-FE) B29 57 (1ZZ-FE) E63 60
B2 57 (1ZZ-FE) B31 B 57 (1ZZ-FE) E86 60
B9 57 (1ZZ-FE) B58 57 (1ZZ-FE) L17 63
B10 57 (1ZZ-FE) B65 57 (1ZZ-FE)

: Relay Blocks
Code See Page Relay Blocks (Relay Block Location)
1 22 Engine Room R/B (Engine Compartment Left)

: Junction Block and Wire Harness Connector

Code See Page Junction Block and Wire Harness (Connector Location)
1A
26
1B Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1J 23
2A 28 Floor Wire and Instrument Panel J/B (Cowl Side Left)
2B 28 Engine Room Main Wire and Instrument Panel J/B (Cowl Side Left)
2C
2E 28 Instrument Panel Wire and Instrument Panel J/B (Cowl Side Left)
2F
2G 28 Engine Room Main Wire and Instrument Panel J/B (Cowl Side Left)
2H 28
Instrument Panel Wire and Instrument Panel J/B (Cowl Side Left)
2M 29
4A
4B 40 Instrument Panel Wire and J/B No.4 (Instrument Panel Brace RH)
4C

: Connector Joining Wire Harness and Wire Harness

Code See Page Joining Wire Harness and Wire Harness (Connector Location)
AE2
AE3 69 Engine Room Main Wire and Instrument Panel Wire (Left Side of the Instrument Panel)
AE5
AE7 69 Engine Room Main Wire and Instrument Panel Wire (Cowl Side Panel RH)
AE11 69 Engine Room Main Wire and Instrument Panel Wire (Left Side of the Instrument Panel)
BA1
BA2 68 (1ZZ-FE) Engine Wire and Engine Room Main Wire (Inside of the Engine Room R/B and Engine Room J/B)
BA4
CB1 68 (1ZZ-FE) Engine No.4 Wire and Engine Wire (Engine Block Center)

: Ground Points
Code See Page Ground Points Location
A1 68 (1ZZ-FE) Front Fender Apron LH
B3
68 (1ZZ-FE) Engine Block Left
B4
E2 69 Left Side of the Instrument Panel
L2 70 Left Center Pillar

128

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
A1 A3 A7 A8 A9
Black Gray Black Black

1 2 1 2 3 4 5 6
1 2 1 2 1 2
3 4 3

A10 A11 A12 A16 A17

Yellow Gray Black

1 2 1 2 3 1 2 1 2 3 1 2
4 5

A18 A19 A20 A21 A22

Gray Black Black Yellow Black

1 2 1 2
1 2 1 2 1 2
3

A23 A24 A25 A27 A28

Black Black Black Black Black
1

1 2 1 2 1 2
1 2

A37 A38 A39 A40 A41

Black Black Gray Gray Black

1 2 1 2
1 2 1 2
1 2 3

A42 A45 A46

Black

1 2

1 2 3 4 5 6 1 2 3 4 5 6
7 8 9 10 11 12 7 8 9 10 11 12

304

COROLLA ALTIS (EM11B2EV)

 K
A47 A48

1 2 3 4 5 6 7 8 9 10 11 1 2 3 4 5 6
12 13 14 15 16 17 18 19 20 21 22 7 8 9 10 11 12

A49 A50
Black

1 2 3 4 5 6 7 8 9 10 11
1 2 3 4 5 6 12 13 14 15 16 17 18 19
7 8 9 10 11 12 20 21 22 23 24 25 26 27 28 29 30

31 32 33 34 35 36 37 38 39 40 41
42 43 44 45 46 47 48 49
50 51 52 53 54 55 56 57 58 59 60

A58 A64 A65

Gray Brown Brown

1 2 1 2

1 2

A66 A75 A82

Gray Gray Black
1

2
1 2 3 4 5 6 7 8 9 10 11 12

13 14 15 16 17 18 19 20 21 22 23 24
25 26 27 28 29 30 31 32 33 34

305

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
A88 A92 A93 A94 A95 B1
Gray Black Black
1
1
1 1 2
2 3 1 2
4 1 2

B2 B3 B4 B6 B7
Black Gray Gray

1 1
1
1 2 3 4 5
1

B8 B9 B10 B11 B12

Black Black Gray Black Gray

1 2 1 2 1 2 1 2
1

B14 B19 B23 B25 B26

Black Blue Gray Black Black

1 2 1 2 1 2 3 4
1 2 3 4 5 6
1 2
3 4

B27 B28 B29 B30

Gray Black Gray Gray

1 2 3 4 1 2 3 4 1 2 3 4
1 2

B31 B58
Black Gray

1 2

X X X X X X X X X X X X X X X X X X X X X X X
X X X X X X X X X X X X X X 38 39 40
47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 41 42 43 44 45 46

64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86
87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103
110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 104 105 106 107 108 109

306

COROLLA ALTIS (EM11B2EV)

 K
B60 B65 B68 B88 B89
Gray Gray Gray Gray Gray

1 2
1 2 1 2
1 2 1 2 3 4 3 4
5 6 7 8 9

B90 B96 B97 B98 B105

Gray Black Gray Black Black

1 2

1 2 3 4 5 1 2 1 2 1 2
6 7 8 9 10

B106 B107 B108 B109 B110

Black Gray Black Black Gray

1 2 3 1 2 3 1 2
1 2 1 2

B111 B112 B113 B114

Black Gray Black Gray

1 2 3
1 2 1 2 1 2 3 4 5
6 7 8 9 10

B115 B116 B117 B118 B119

Black Gray Gray Black Gray

1 2 3 1 2 1 2 1 2 1

C2 E1 E2 E3 E4
Black

1 2 1 2 3 4 1 2
1
5 6 7 8 9 10 3 4 5 6
1 2 3 4
5 6 7 8

307

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
E5 E6 E7 E9 E10
Black Yellow

1 2
1 2 3 1 2 3 4
1 2 3 4 5 6 1 2 3 4

7 8 9 10 11 12 4 7 5 10
5 6 6 7 8 9

E11 E12 E14 E16

Yellow

1 2 3 4 5 6 7 8 9 10
1
1 2 3 4 5

11 12 13 14 15 16 17 18 19 20
16 15 14 13 12 11 10 9

8 7 6 5 4 3 2 1 21 22 23 24 25 26 27 28 29 30

E17 E18 E20 E22 E23

Black Black

1 2
1 2
1 2 3 4 5 6 7 8 1 2 3
1 2 3 4 5 6 7 8 9 10 3 4

E25 E26 E30

Black

1 2

1 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

E32 E36 E37

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
1 2 3 4 5 6
18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1 2 3
7 8 9 10 11 12

308

COROLLA ALTIS (EM11B2EV)

 K
E38 E39 E41 E44
Black Black Gray Black

1 2 3 4

1 2 3 4 5 6 7 1 2 3 4 5 6 7 1 2 3 4
8 9 10 11 12 13 14

E46 E50 E51

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 2 3 4 5 6
1 4
2 3
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
7 8 9 10 11 12 13 14 15 16 17 5 6 7 8 9 10

18 19 20 21 22 23 24 25 26 11 12 13 14 15 16

E52 E53 E54

1 2 3 4 5 6 7
1 2 3
8 9 10 11 12 13 14 1 2 3 4 5 6
4 5 6 7 8
15 16 17 18 19 7 8 9 10 11 12

E55 E56

1 2 3 4 5 6 1 2 3 4 5 6
7 8 9 10 11 12 7 8 9 10 11 12

E57 E58
Gray

1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 10 11

7 8 9 10 11 12 12 13 14 15 16 17 18 19 20 21 22

309

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
E59 E60

1 2 3 4

5 6 7 8 9 10 11 12 13

1 2 3 4 5 6 7 8 9 10 11

12 13 14 15 16 17 18 19 20 21 22

E61 E62 E63

1 2 3 4 5 6 7 8
1 2 3 10 11 12 1 2 3 4 5 6 7 8 9 10 11 12 13 14
4 5 6 7 8 9 9 10 11 12 13 14 15 16
15 16 17 18 19 20 21 22 23 24 25 26 27 28
13 14 15 16 17 18 19 20 21 22 23 24 25 26

E64 E65 E66 E67 E68

Black Black Black Black

1 2
1 2 1 2 3 4 5
1 2
1 2 3 4 5 6 7 8
3 4

E69 E70 E75

Gray Gray

1 5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
2 3 4
1 2 3 4 5 6 7 8 6 7 8 9 10 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

E81 E82 E83 E86 E87 E92

Black Gray Gray

1 2 1 2
1 2 2 1
1 2 3 4 1 2 3 4 5 6 7
4 3
5 6 7 8 8 9 10 11 12 13 14

310

COROLLA ALTIS (EM11B2EV)

 K
E93 E94 E95 E96 E98
Black Black Black

1 2 3
1 2
4 5 6 7 8
1 2 3 4 5 6 7 8 9 1 2
1 2 3 4 5 6
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 7 8 9 10 11 12

E99 H1 H2 H4 H6
Black

1 2 1 2 3 4
2 1
1 1 2 3 4
3 7 6 5 4
2 5 6 7 8 9 10

H7 H8 H9 I1 I2
Black Gray

1 2 1 2
1 2 3 4 5 2 1
1
3 4 5 6 3
2 7 6 5 4

I3 I4 I5 I6

1 2 3 4
1 2 3 4
1 2 3 4 5 6 7 8 9 1 2
5 6 7 8 9 10
10 11 12 13 14 15 16 17 18
3 4 5 6
7 8 9 10

I9 J1 J2 J3 K1
Gray Black

1 2 1 2
1 2 3 4 5 1 2 3 4 1 2 3 4 5
3 4 5 6
5 6 7 8 9 10

K2 K3 L1 L2 L3
Black Black

1 2 1
1 2 3 4 2 1 2 1
3 4 5 6
5 6 7 8 9 10

311

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
L4 L5 L7 L9 L10 L16
Yellow Black Black Black Yellow

1 2 3 4 5
1 2 1 1 2 1 2
1 2
6 7 8 9 10
3 4

11 12 13 14 15

L17 L18 L19 L20 L22 L24

Black Gray Black

1 2 3 1 2 1 2
1 2 3 1 2 1 2
4 5

L25 L26 L27 L28 L29

Gray Gray

1 2
2 1 1 2
1 2 3 2 1 3 4

L30 L31

1 2 3 4 5 6 1 2 3 4 5 6
7 8 9 10 11 12 7 8 9 10 11 12

L32 L33

1 2 3 4 5 6 1 2 3 4 5 6
7 8 9 10 11 12 7 8 9 10 11 12

312

COROLLA ALTIS (EM11B2EV)

 K
L34 L35 L46
Blue Gray Black

1
1 2

1 2 3 4 5
6 7 8 9 10 11 12

L48 M1 M2 M3
Black Yellow Black

1 1 2 1

1 2 3 4 5

6 7 8 9

10 11 12 13 14 15 16 17

M8 M12 M13 M14 M16

Yellow

1 2 3 4 5
1 2 3
2 1
1 2 3 4 5 4 5 6 7
6 7 8 9 10 4 3
1 2 3
6 5

11 12 13 14 15

O1 O10 P1 T1 T2
Gray Gray Black Black
1 2 3 1
1 2
1 2 3 4 5
1 2 6 7 8 9 10
3 4
5 6

U1 V1 W1 X1 Y1
Orange Black Black

1 2
1 2 1 2
1 2 3 4 1 2 3 4 5
5 6 7 8 6 7 8 9 10

313

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
Y3 a1 a2 b3 b4
Orange Black Black

1 2
1 2 3 4 5 6 1 2 3 4 5 6
1 2 3 4 1
5 6 7 8

c1 c2 c3 c4 c5 c6
Blue Orange

1 2 3 4

1 2 1 2 1 2 5 6 7 8 9 10 1 2 3 4 5 1 2

c7 d1 d2 e1 f1
Black

1 2
1 2 1 2 1 2

1 2 3 4 5

6 7 8 9

10 11 12 13 14 15 16 17

314

COROLLA ALTIS (EM11B2EV)

 Memo

315

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
AE1 AE2 Gray

1 2 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
3 4 2 1
18 17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17 18
4 3

AE3 AE4 Yellow

2 1
9 8 7 6 5 4 3 2 1
1 9 1 2
2 3 4 5 6 7 8
25 16 15 14 13 12 11 10 17
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18
18 19 20 21 22 23 24

AE5

1 10
10 1
11 2 3 4 5 6 7 8 9 20
12 13 14 15 16 17 18 19 20 9 8 7 6 5 4 3 2 11
19 18 17 16 15 14 13 12

AE6

11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22

316

COROLLA ALTIS (EM11B2EV)

 K
AE7 Blue AE8 Yellow

1 2 3 4 5 2 1
6 7 8 9 10 11 12 13
5 4 3 2 1 1 2
13 12 11 10 9 8 7 6

AE11

1 2 8 9
9 8 2 1
10 11 3 4 5 6 7 17 18
12 13 14 15 16 18 17 7 6 5 4 3 11 10
16 15 14 13 12

AE12

1 2 3 4 5
6 7 8 9 10 11 12 13
5 4 3 2 1
13 12 11 10 9 8 7 6

AL1 AL2

1 2
11 10 9 8 7 6 5 4 3 2 1 3 4 5 6
1 2 3 4 5 6 7 8 9 10 11 2 1
22 21 20 19 18 17 16 15 14 13 12
12 13 14 15 16 17 18 19 20 21 22 6 5 4 3

AM1 BA1

1 2
11 10 9 8 7 6 5 4 3 2 1 3 4 5 6 7
2 1
1 2 3 4 5 6 7 8 9 10 11 8 9 10 11 12
22 21 20 19 18 17 16 15 14 13 12 7 6 5 4 3
12 13 14 15 16 17 18 19 20 21 22
12 11 10 9 8

317

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
BA2 BA4 Gray

1 2 3 4
5 6 7 8 9 10 4 3 2 1 1 2 3 4 5 5 4 3 2 1
10 9 8 7 6 5 6 7 8 9 10 10 9 8 7 6

CB1 Gray CB2 Gray

2 1 2 1
1 2
1 2

EL1 EL4 Gray

1 2 3 4 5 1 2 3 4
6 7 8 9 10 11 12 13 5 6 7 8 9 10 4 3 2 1
5 4 3 2 1
13 12 11 10 9 8 7 6 10 9 8 7 6 5

EL5 Gray

9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
25 16 15 14 13 12 11 10 17
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18
18 19 20 21 22 23 24

EM1 Gray EM3

1 2 3 4 5
9 8 7 6 5 4 3 2 1
6 7 8 9 10 11 12 13
1 9 5 4 3 2 1
2 3 4 5 6 7 8
25 16 15 14 13 12 11 10 17 13 12 11 10 9 8 7 6
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18
18 19 20 21 22 23 24

318

COROLLA ALTIS (EM11B2EV)

 K
EU1 Yellow Ef1

1 2 5 4 3 2 1
1 2 3 4 5
2 1
6 7 8 9 10 10 9 8 7 6

HE1 Blue HE2

1 2 1 2 8 9
3 4 5 6 7 9 8 2 1
2 1 3 4 5 6 7
8 9 10 11 12 10 11 17 18
7 6 5 4 3 18 17 7 6 5 4 3 11 10
12 13 14 15 16
12 11 10 9 8 16 15 14 13 12

HE3 IE1 Blue

1 2 1 2
3 4 5 6 7 3 4 5 6 7
2 1 2 1
8 9 10 11 12 8 9 10 11 12
7 6 5 4 3 7 6 5 4 3
12 11 10 9 8 12 11 10 9 8

IE2

1 2 8 9
9 8 2 1
10 11 3 4 5 6 7 17 18
12 13 14 15 16 18 17 7 6 5 4 3 11 10
16 15 14 13 12

319

COROLLA ALTIS (EM11B2EV)

K CONNECTOR LIST
IE3 IE4

1 2
9 8 7 6 5 4 3 2 1 3 4 5 6 7
2 1
1 2 3 4 5 6 7 8 9 8 9 10 11 12
25 16 15 14 13 12 11 10 17 7 6 5 4 3
17 10 11 12 13 14 15 16 25 24 23 22 21 20 19 18 12 11 10 9 8
18 19 20 21 22 23 24

IT1 Gray

1 2 3 4 4 3 2 1
5 6 7 8 8 7 6 5

JM1

6 5 4 3 2 1

1 2 3 4 5 6 21 20 19 11 10 9 8 7 13 12
7 8 9 10 11 19 18 17 16 15 14
12 13 20 21
14 15 16 17 18

KL1

6 5 4 3 2 1

1 2 3 4 5 6 21 20 19 11 10 9 8 7 13 12
7 8 9 10 11 19 18 17 16 15 14
12 13 20 21
14 15 16 17 18

320

COROLLA ALTIS (EM11B2EV)

 K
Le1 VL1 WM1
Gray

1 2 2 1 1 2 2 1 1 2 2 1

bM1 Gray dc1

1 2
1 2 3 4 4 3 2 1
3 4 5 6 7
5 6 7 8 8 7 6 5 2 1
8 9 10 11 12
7 6 5 4 3
12 11 10 9 8

321

COROLLA ALTIS (EM11B2EV)