SB-2ST-000 R1

SB-912-000UL R1
SB-912 i-000iS R1
SB-914-000UL R1 This SB revises SB-2ST-000/SB-912-000UL/SB-912 i-000iS/SB-914-000UL Initial Issue
dated 20. June 2016

SERVICE BULLETIN
Publication Index for ROTAX Aircraft Engines
ATA System: 00-00-00 GENERAL NOTE

MANDATORY

1) Planning information
To obtain satisfactory results, procedures specified in this publication must be accomplished with
accepted methods in accordance with prevailing legal regulations.
BRP-Rotax GmbH & Co KG cannot accept any responsibility for the quality of work performed in
accomplishing the requirements of this publication.
1.1) Applicability
All versions of ROTAX® engines types:
Engine type Serial number
2-stroke UL aircraft engines (Series / Pre-series)
912 UL (Series / pre-series)
912 ULS (Series / pre-series)
912 iS (Series / pre-series)
912 iS Sport (Series / pre-series)
914 UL (Series / pre-series)

For complete instructions and compliance with this Service Bulletin refer to Service Bulletin SB-
505-000/SB-535-000/SB-912-000/SB-912 i-000/SB-914-000, latest edition, section 1.2 onward.
NOTE: Section 1.6) Approval: Is not required for engines of the type UL, iS (Series).

Translation into other languages might be performed in the course of language localization but
does not lie within ROTAX® scope of responsibility.
In any case the original text in English language and the metric units are authoritative.

Symbols used For meaning of the symbols used in this document, see chapter >Safety< of the latest Operators
Manual for the respective engine type.
d06387.fm

24 February 2017 Current valid documentation see: 00-00-00

Revision 1 www.FLYROTAX.com Page 1 of 1

Copyright - BRP-Rotax GmbH & CO KG. All rights reserved.

 SB -912 i-000R9
SB-912-000R21
SB-914-000R21
SB-505-000R1 This SB revises SB-505-000/SB-535-000/SB-912 i-000R8
SB-535-000R1 SB-912-000R20/SB-914-000R20- dated 20 June 2016

SERVICE BULLETIN

Publication Index for ROTAX® Aircraft Engines

ATA System: 00-00-00 GENERAL NOTE

MANDATORY

1) Planning information
To obtain satisfactory results, procedures specified in this publication must be accomplished with
accepted methods and prevailing legal regulations.
BRP-Rotax GmbH & Co KG. cannot accept any responsibility for the quality of work performed in
accomplishing the requirements of this publication.
1.1) Applicability
All engines of type:
Engine type Serial number
912 A (Series / Pre-series)
912 F (Series / Pre-series)
912 S (Series / Pre-series)
912 iSc Sport (Series / Pre-series)
914 F (Series / Pre-series)
505 (Series / Pre-series)
505 A (Series / Pre-series)
535 A (Series / Pre-series)
535 B (Series / Pre-series)
535 C (Series / Pre-series)
1.2) Concurrent ASB/SB/SI and SL
none
1.3) Reason
List of valid documentation in accordance with Part 21A.57 "Instruction for continued airworthi-
ness".
1.4) Subject
Publication Index for ROTAX® Aircraft Engines.
d06386.fm

24 February 2017 Current valid documentation see: 00-00-00

www.FLYROTAX.com Page 1 of 2

Copyright - BRP-Rotax GmbH & CO KG. All rights reserved.

SB -912 i-000R9
SB-912-000R21
SB-914-000R21
SB-505-000R1
SB-535-000R1

SERVICE BULLETIN
1.5) Compliance
MANDATORY
For continued airworthiness keep the documentation to the latest valid revision level in accor-
dance with the list attached and the information on the ROTAX® AIRCRAFT ENGINES home-
page.

Non-compliance with these instructions could result in engine dama-

mWARNUNG
m WARNING ges, personal injuries or death!

1.6) Approval
The technical content of this document is approved under the authority of DOA ref.
EASA.21J.048.
2) Material Information
none
3) Accomplishment / Instructions
Incorporation / exchange of relevant documentation.
3.1) Enquiries
The following table (list of effective documentation, issue 2017.02.17, page 1-19) includes all the
valid documentation for the engine types described in section 1.1).
NOTE: Because of the multitude of documentation a continual updating of the ta-
bles is not possible. This Service Bulletin, however, will be updated/revised
twice a year. The current documentation (current issue) or relevant revisions
(replacement pages) are available at any ROTAX® authorized distributor or
their independent Service Centers in printed version or on the ROTAX®
AIRCRAFT ENGINES homepage
www.FLYROTAX.com
(in subsection >Services >Technical Documentation) in electronic
and current version.
Symbols used For meaning of the symbols used in this document, see chapter >Safety< in latest Operators
Manual of the respective engine type.

Translation into other languages might be performed in the course of language localization but
does not lie within ROTAX® scope of responsibility.
In any case the original text in English language and the metric units are authoritative.
d06386.fm

24 February 2017 00-00-00

Page 2 of 2

Copyright - BRP-Rotax GmbH & CO KG. All rights reserved.

 Publication Index for
ROTAX 2-stroke aircraft engines and
all versions of ROTAX aircraft
engines type 912 / 912 i / 914

Revision
Issue
Document
Engine Type Date Title
Type

ASB-2ST-
003,ASB-914- 582 UL,914 UL,912 Exchange of floats on ROTAX Engine Type 912, 914 and 2-
0 1 22.07.2016
051UL,ASB-912- ULS,912 UL stroke (Series)
069UL
Replacement of fuel pump for Rotax engine type 912 (Series)
ASB-912-053 912 S,912 F,912 A 0 0 20.02.2007
- replaced by SB-912-053, latest edition
ASB-912-053- Replacement of fuel pump for Rotax engine type 912 (Series)
912 ULS,912 UL 0 0 20.02.2007
UL - replaced by SB-912-053 UL, latest edition
Replacement of the pressure side fuel hose at fuel pump part
ASB-912-061 912 S,912 F,912 A 0 1 31.05.2012
no. 893114 for ROTAX engine type 912 (Series)
ASB-912-061- Replacement of the pressure side fuel hose at fuel pump part
912 ULS,912 UL 0 1 31.05.2012
UL no. 893114 for ROTAX engine type 912 (Series)
ASB-912i-005- The use of lithium-ion batteries in combination with the
912 iS SPORT,912 iS 0 0 29.05.2015
iS ROTAX engine type 912 i Series
ASB-914- CANCELLED - Checking of magnetic plug on Rotax engine
034,ASB-912- 914 F,912 S,912 F,912 A 0 0 13.10.2006 type 912/914 (Series), replaced by SB-912-051/SB-914-034,
051 latest edition
ASB-914-034- CANCELLED - Checking of magnetic plug on Rotax engine
914 UL,912 ULS,912
UL,ASB-912- 0 0 13.10.2006 type 912/914 (Series), replaced by SB-912-051/SB-914-034,
ULSFR,912 UL
051-UL latest edition
ASB-914- CANCELLED - Checking of the crankshaft journal (power
042,ASB-912- 914 F,912 S,912 F,912 A 0 0 01.01.2012 take off side) for ROTAX engine type 912 and 914 (Series),
059 replaced by SB-912-059/SB-914-042 latest edition

ASB-914-042- CANCELLED - Checking of the crankshaft journal (power

914 UL,912 ULS,912
UL,ASB-912- 0 0 01.01.2012 take off side) for ROTAX engine type 912 and 914 (Series),
ULSFR,912 UL
059-UL replaced by SB-912-059UL/SB-914-042UL latest edition
ASB-914-
Checking of the oil pump fixing bolts for correct torque for
043,ASB-912- 914 F,912 S 0 0 26.01.2012
ROTAX engine type 912 and 914 (Series)
060
ASB-914-043-
Checking of the oil pump fixing bolts for correct torque for
UL,ASB-912- 914 UL,912 ULS,912 UL 0 0 26.01.2012
ROTAX engine type 912 and 914 (Series)
060-UL
ASB-914-
Checking of the cylinder head assy. 2/3 for ROTAX engine
044,ASB-912- 914 F,912 S,912 F,912 A 0 2 29.05.2013
type 912 and 914 (Series)
062
ASB-914-044-
Checking of the cylinder head assy. 2/3 for ROTAX engine
UL,ASB-912- 914 UL,912 ULS,912 UL 0 2 29.05.2013
type 912 and 914 (Series)
062-UL
ASB-914-
Exchange of floats on ROTAX Engine Type 912 and 914
051,ASB-912- 914 F,912 S,912 F,912 A 0 1 22.07.2016
(Series)
069
912 iS SPORT,912 iS,912 B.U.D.S. Log Viewer (Windows) (only available for authorized
DIV-912 i - - 23.06.2016
iSc SPORT distributors and overhaul facilities)
912 iS SPORT,912 iSc B.U.D.S. Log Viewer (Linux) (only available for authorized
DIV-912 i - - 23.06.2016
SPORT,912 iS distributors and overhaul facilities)
912 iS SPORT,912 iSc B.U.D.S. Log Viewer (MacOs) (only available for authorized
DIV-912 i - - 23.06.2016
SPORT,912 iS distributors and overhaul facilities)
BRP Utility and Dignostic Software B.U.D.S. Aircraft V2.4
912 iS SPORT,912 iSc
DIV-912 i 0 3 20.01.2014 ((Requires
q ROTAX USB-to-CAN activation dongle. g See SI-
SPORT,912
SPORT 912 iSc
iSc,912
912 iS
912i-002.)

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 1 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

DIV-914 914 UL,914 F 0 0 01.01.2001 Monitoring-Programm TLR 4.6a

DIV-914 914 UL,914 F 0 0 01.01.2001 Monitoring-Programm TLR 4.3a
DIV-914 914 UL,914 F 0 0 01.01.2001 Monitoring-Programm TLR 4.5a
914 UL,914 F,912
ULSFR,912 ULS,912
UL,912 S,912 F,912
A,642,618 UL,582 UL,535
DIV-914,DIV-
C,535 B,535 A,532 0 2 13.02.2017 Customer Service Information Report
912,DIV-2ST
UL,508 UL,505 A,505,503
UL,501,463,462 UL,447
UL,377 UL,277
UL,275,185

914 UL,914 F,912

ULSFR,912 ULS,912
UL,912 S,912 iSc
SPORT,912 iS
DIV-914,DIV- SPORT,912 iS,912 F,912
912,DIV- A,642,618 UL,582 UL,535 4 0 24.02.2017 ROTAX Aircraft Engine Registration Card
912i,DIV-2ST C,535 B,535 A,532
UL,508 UL,505 A,505,503
UL,501,463,462 UL,447
UL,377 UL,277
UL,275,185
HB-505 505 A 2 0 29.01.1992 Operators manual 505 A without decompressor
I t ll ti Manual
Installation M l 501/505 S i ((nott available
Series il bl - use
IM-505 505 A 1 1 01.07.1988
german version)
Installation Manual 535 (Series) - (not available - use german
IM-535 535 C,535 B,535 A 1 1 01.12.1982
version)
IM-582,IM- Installation Manual 447 UL SCDI-503 UL DCDI-582 UL DCDI-
582 UL,503 UL,447 UL 0 0 01.05.1999
503,IM-447 582 UL DCDI mod.99
912 ULSFR,912 ULS,912
IM-912 2 1 01.02.2015 Installation Manual ROTAX 912 Series
UL,912 S,912 F,912 A

912 ULSFR,912 ULS,912 Revision Pages for Installation Manual ROTAX 912 Series,
IM-912 2 1 01.02.2015
UL,912 S,912 F,912 A Issue 2, Revision 1
912 iSc SPORT,912 iS
IM-912i 1 3 01.08.2015 Installation Manual ROTAX 912 i Series, Rev. 3
SPORT,912 iS
912 iSc SPORT,912 iS Revision pages for Installation Manual ROTAX 912 i Series,
IM-912i 1 3 01.08.2015
SPORT,912 iS Rev. 3
IM-914 914 UL,914 F 2 1 01.02.2015 Installation Manual 914 Series
IM-914 914 UL,914 F 2 1 01.02.2015 Revision Pages for Installation Manual 914 Series
IPC-277 277 UL 0 2 01.07.1993 Spare Parts List for Engine 277 UL (Nr. 491)
IPC-505 505 A 1 1 01.07.1993 Spare parts list for Engine Type 505A (Nr. 805)
IPC-505 505 A,505 0 0 01.09.1990 Spare Parts List for Engine Type 505/505A (Nr. 744)
IPC-535 535 C 0 0 01.04.1988 Illustrated Parts Catalog 535 C (Nr. 645)
IPC-535 535 B,535 A 0 0 01.07.1983 Illustrated Parts Catalog 535 A and 535 B (No. 448)
IPC-618,IPC-
618 UL,582 UL,503 Illustrated parts catalog for ROTAX 447 SCDI, 503 DCDI, 582
582,IPC- 3 1 01.04.2011
UL,447 UL DCDI mod. 90, 582 DCDI mod. 99, 618 DCDI
503,IPC-447
IPC-912 912 UL 0 1 01.11.1994 Illustrated Parts Catalog 912 UL (No. 825)
IPC-912 912 A,912 UL 0 3 01.07.1992 Illustrated parts catalog 912A/912 UL (No. 825)
912 iSc SPORT,912 iS
IPC-912i 3 0 27.01.2017 Illustrated Parts Catalog for ROTAX Engine Type 912 i Series
SPORT 912 iS
SPORT,912

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 2 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

914 UL,914 F,912

IPC-914,IPC- Illustrated parts catalog ROTAX 912 A/F/S/UL/ULS/ULSFR
ULSFR,912 ULS,912 3 2 01.02.2016
912 and 914 F/UL
UL,912 S,912 F,912 A
914 UL,914 F,912
IPC-914,IPC- Exchange pages for Illustrated parts catalog ROTAX 912
ULSFR,912 ULS,912 3 2 01.02.2016
912 A/F/S/UL/ULS/ULSFR and 914 F/UL, Edition 3, Revision 2
UL,912 S,912 F,912 A
MM-582,MM- Maintenance Manual 447 UL SCDI-503 UL DCDI-582 UL
582 UL,503 UL,447 UL 0 0 01.05.1999
503,MM-447 DCDI-582 UL DCDI mod.99
912 F,912 A,914 UL,914
MMH-912,MMH- Revision Pages for Maintenance Manual (Heavy) for ROTAX
F,912 ULSFR,912 1 4 01.02.2015
914 912 and 914 Series, Rev. 4
ULS,912 UL,912 S
912 F,912 A,914 UL,914
MMH-912,MMH-
F,912 ULSFR,912 1 4 01.02.2015 Maintenance Manual (Heavy) for ROTAX 912 and 914 Series
914
ULS,912 UL,912 S
912 iSc SPORT,912 iS Revision pages for Maintenance Manual Heavy for ROTAX
MMH-912i 1 2 01.09.2014
SPORT,912 iS 912 i Series
912 iSc SPORT,912 iS
MMH-912i 1 2 01.09.2014 Maintenance Manual (Heavy) for ROTAX 912 i Series
SPORT,912 iS
912 ULSFR,912 ULS,912 Revision Pages for Maintenance Manual 912 Series (Line
MML-912 3 2 01.02.2015
UL,912 S,912 F,912 A Maintenance), Revision 2

912 ULSFR,912 ULS,912

MML-912 3 2 01.02.2015 Maintenance Manual 912 Series (Line Maintenance)
UL,912 S,912 F,912 A
912 iSc SPORT,912 iS Revision pages for Maintenance Manual (Line) for ROTAX
MML-912i 0 2 01.06.2014
SPORT,912 iS 912 i Series, Rev. 2
912 iSc SPORT,912 iS
MML-912i 1 2 01 06 2014 Maintenance Manual (Line) ROTAX 912 i Series
01.06.2014
SPORT,912 iS
MML-914 914 UL,914 F 2 2 01.02.2015 Revision Pages for Maintenance Manual (Line) for 914 Series
MML-914 914 UL,914 F 2 2 01.02.2015 Maintenance Manual (Line) for ROTAX 914 Series
912 iS SPORT,912 iSc Overhaul Manual 912 i Series (only available for authorized
OHM-912i 1 0 01.04.2014
SPORT,912 iSc,912 iS distributors and overhaul facilities)
914 UL,914 F,912
OHM-914,OHM- Overhaul Manual 912 and 914 Series (only available for
ULS,912 UL,912 F,912 2 3 01.04.2015
912 authorized distributors and overhaul facilities)
A,912 S
912 iS SPORT,912 iSc Appendix to Overhaul Manual 912 i Series (only available for
OHMA-912i 1 1 01.04.2014
SPORT,912 iSc,912 iS authorized distributors and overhaul facilities)
914 UL,914 F,912
OHMA- Appendix to Overhaul Manual 912 and 914 Series (only
ULSFR,912 ULS,912 1 5 01.03.2016
914,OHMA-912 available for authorized distributors and overhaul facilities)
UL,912 S,912 F,912 A
OM-277 277 UL 0 4 01.03.1988 Operators manual 277 UL
OM-503,OM-
503 UL,447 UL 19 0 01.06.1994 Operators Manual 377-447-503 UL CB
447
OM-505 505 2 0 30.04.1992 Operators manual 505 with decompressor
OM-505 505 A 2 0 30.04.1992 Operators manual 505 A with decompressor
OM-505 505 2 0 30.04.1992 Operators manual 505 without decompressor
Operators Manual 535 A (dual carburetor horizontal)
OM-535 535 B,535 A 2 0 01.01.1992
Operators Manual 535 B (dual carburetor vertical)
OM-535 535 C 2 0 01.01.1992 Operators manual 535 C (single carburetor)
OM-582,OM- Operators Manual for engine types 447 UL SCDI, 503 UL
582 UL,503 UL,447 UL 2 0 01.09.2010
503,OM-447 DCDI, 582 UL DCDI mod. 90 and 582 UL DCDI mod. 99
OM-618 618 UL 1 0 01.06.1994 Operators manual ROTAX 618 UL (preliminary)
912 ULSFR,912 ULS,912
OM-912 4 0 27.01.2017 Operators Manual 912 Series
UL,912 S,912 F,912 A
912 iSc SPORT,912 iS
OM 912i
OM-912i 1 3 01 08 2015 Operators
01.08.2015 O t Manual
M l ROTAX 912 i Series,
S i Rev.
R 2
SPORT,912 iS

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 3 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

912 iSc SPORT,912 iS Revision pages for Operators Manual ROTAX 912 i Series,
OM-912i 1 3 01.08.2015
SPORT,912 iS Rev.3
OM-914 914 UL,914 F 2 2 01.02.2015 Revision Pages for Operators Manual 914 Series, Revision 2
OM-914 914 UL,914 F 2 2 01.02.2015 Operators Manual 914 Series
RM-277 277 UL 0 2 01.01.1993 Repair manual 277 UL
RM-503,RM-
503 UL,447 UL 0 1 01.12.1989 Repair manual engine types 377-447-503 UL CB
447
RM-505 505 A,505 1 3 01.01.1993 Repair Manual 501/505 (Serie)
RM-582 582 UL 0 1 01.04.1995 Repair manual 462-532-582 UL
Checking or replacement of tension spring on exhaust
SB-2ST-001 582 UL 0 0 01.12.2001
system for ROTAX engine type 582 UL
SB-2ST-002 582 UL 0 0 01.03.2002 Modified rotary valve cover for ROTAX engine type 582 UL
Studs 840 585 (M8x177) connecting cylinders to crankcase
SB-505-001 505 0 0 26.02.1986
(8x)
Conversion of engine types 505 into 505 A (type certificate
SB-505-002 505 0 0 20.09.1988
data sheet TW 3/78, issue no. 5
SB-505-003 505 A,505 0 0 20.09.1988 Check of ignition timing after exchange of an electronic box
SB-505-004 505 A,505 0 0 13.04.1989 Examination of the starter gear for cracks.
Piston pin bearing, conversion to reinforced design **(for 501
SB-505-005 505 A,505,501 0 0 01.08.1989
see SB-505-005)
Introduction of a new electronic box with a modified wiring on
SB-505-006 505 A,505 0 0 29.01.1992
the stator plate.
TBO of ROTAX engine type 501, 505 and 505 A. **(for 501
SB-505-007
SB 505 007 505 A,505,501 0 0 02.12.1997
SB 505 007)
see SB-505-007)
SB-505-008 505 A,505 0 0 22.01.1999 Magneto housing for ROTAX engine type 505 (series)
New charging coil assy. with support for Rotax engine type
SB-505-009 505 A,505 0 1 01.03.2003
505
SB-535-001 535 B,535 A 0 0 31.01.1984 Flywheel on drive side
Coil brace 866 780 connecting charging coil with lighting coil
SB-535-002 535 B,535 A 0 0 05.12.1985
on armature plate assy.
SB-535-003 535 B,535 C,535 A 0 0 20.09.1988 Check of ignition timing after exchange of an electronic box.
Fixation of charging coil and lighting coil on armature plate
SB-535-004 535 C,535 B,535 A 0 0 21.03.1989
assy.
SB-535-005 535 C,535 B,535 A 0 0 13.04.1989 Examination of the starter gear for cracks.
Introduction of a new electronic box with a modified wiring on
SB-535-006 535 C,535 B,535 A 0 0 05.06.1992
the stator plate.
SB-535-007 535 B,535 A 0 1 01.02.1999 Magneto housing for ROTAX engine type 535 (Series)
New charging coil assy. with support for Rotax engine type
SB-535-008 535 C,535 B,535 A 0 1 28.01.2005
535
SB-535-009,SB-
535 C,535 B,535 A,505 New maintenance schedule, checklist and engine
505-010,SB- 0 1 04.05.2007
A,505,501,275 preservation for ROTAX engine type 275, 501, 505 and 535
501,SB-275

SB-912-000, SB-
914-000, SB- 535 C,535 B,535 A,505
912i-000, SB- A,505,914 F,912 S,912 0 - 24.02.2017 Publication Index for ROTAX Aircraft Engines
535-000,SB- F,912 A,912 iSc SPORT
505-000
SB-912-
912 iS,912 ULS,914
000UL,SB-914-
UL,447 UL,503 UL,618
000UL,SB-912i- 0 1 24.02.2017 Publication Index for ROTAX Aircraft Engines
UL,912 UL,912 iS
000iS SB
000iS, SB-2ST-
2ST
SPORT,582 UL,277 UL
000
Edition: 2017.02.24 For current valid documentation see:
File: d06386.xlsx www.flyrotax.com page 4 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SB-912-001 912 A 0 0 13.08.1992 Engine type 912 A, Ignition unit with resistor spark plug
SB-912-002 912 A 0 1 29.11.1993 Ignition for ROTAX 912 A
CANCELLED - Operators manual for ROTAX 912 A -
SB-912-003 912 A 0 0 28.09.1993
superseded by Operators manual 912 Series, current edition
Extension of time between overhauls (TBO) for ROTAX
SB-912-004 912 A 0 2 14.12.2009
engine type 912 A (Series)
Extension of time between overhauls (TBO) for ROTAX
SB-912-004-UL 912 UL 0 2 14.12.2009
engine type 912 UL (Series)
Special inspection to increase the TBO for ROTAX engine
SB-912-005 912 A 0 3 14.12.2009
type 912 A (Series)
Special inspection to increase the TBO for engine 912 A
SB-912-005 912 A 0 2 29.07.1996
Serie
Special inspection to increase the TBO for ROTAX engine
SB-912-005-UL 912 UL 0 0 14.12.2009
type 912 UL (Series)
Grounding cable for electronic module of ROTAX Engine
SB-912-006 912 A 0 0 28.11.1994
series Type 912 A
Ground connection for pick up wiring, ROTAX Engine Series
SB-912-007 912 A 0 0 01.02.1995
Type 912 A
Ground connection for pick-up wiring for ROTAX engine type
SB-912-007-UL 912 UL 0 0 20.12.2007
912 (Series)
SB-912-008 912 A 0 0 24.08.1995 Electronic module with pi-filter, ROTAX Engine Series 912 A
SB-912-009 912 A 0 0 12.09.1995 Contamination of carburetors, ROTAX 912 A (series)
SB-912-010 912 F,912 A 0 0 08.02.1996 Fitting of a carburetor support, ROTAX 912 A/F (series)
Fitting of a carburetor support for ROTAX engine type 912
SB-912-010-UL 912 UL 0 0 20.12.2007
(Series)
CANCELLED - Use of an adapted propeller governor on
SB-912-011 912 F,912 A 0 1 01.11.1999 Rotax engine type 912 A3 and 912 F3, superseded by SB-
912-052/SB-914-035, latest edition
SB-912-012 912 A 0 0 13.08.1996 Modification on ROTAX 912 A4
912 ULS,912 UL,912 CANCELLED - Motor oil for ROTAX 912 Series - superseded
SB-912-013 0 0 29.07.1996
S,912 F,912 A by SI-18-1997 latest edition
Extension of time between overhauls (TBO) for ROTAX
SB-912-014 912 F,912 A 0 2 14.12.2009
engine type 912 A and 912 F (Series)
SB-912-015 912 F,912 A 0 0 29.07.1996 Replacement of rocker arms on ROTAX 912 A/F (series)
Replacement of rocker arms for ROTAX engine type 912
SB-912-015-UL 912 UL 0 0 20.12.2007
(Series)
SB-912-016 912 A 0 0 13.08.1996 External alternator for engine type 912, model A2, A3 and A4

SB-912-017,SB- Checking or replacement of oil filter for ROTAX engine type

912 F,912 A,914 F 0 - 20.12.2007
914-037 912 and 914 (Series)
SB-912-017-
Checking or replacement of oil filter for ROTAX engine type
UL,SB-914-037- 912 UL,914 UL 0 - 20.12.2007
912 and 914 (Series)
UL
SB-912-018 912 A 0 1 18.03.1997 Cam shaft check engine type ROTAX 912 A (series)
SB-912-019 912 A 0 0 09.07.1997 Propeller gear box for ROTAX 912 A3
SB-912-020 912 F,912 A 0 1 10.02.1998 Fuel pump for Engine type ROTAX 912 F and 912 A (series)
Replacement of the fuel pump part no. 996592 for ROTAX
SB-912-020-UL 912 UL 0 0 20.12.2007
engine type 912 (Series)
CANCELLED - Operator's manual for ROTAX 912 F -
SB-912-021 912 F 0 0 17.12.1997
superseded by Operator's manual 912 Series, latest edition

SB-912-022,SB- Replacement of valve spring retainer on single valve spring

912 S
S,912
912 F
F,912
912 A
A,914
914 F 0 0 01 03 2001
01.03.2001
914-011 configuration of ROTAX engine type 912 und 914 (series)

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 5 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SB-912-022-
912 ULSFR,912 ULS,912 Replacement of valve spring retainer on single valve spring
UL,SB-914-011- 0 1 13.03.2001
UL,914 UL configuration of ROTAX engine type 912 und 914 (Series)
UL
SB-912-023 912 F,912 A 0 0 25.05.1998 Inspection of the fuel pump kit, part no. 996.594
CANCELLED - Installation of propeller governor McCauley
SB-912-024 912 F,912 A 0 0 22.10.1998 DCFU290D17B/T1, superseded by SB-912-052/SB-914-035,
latest edition
CANCELLED - Installation of propeller governor McCauley
SB-912-025 912 F,912 A 0 0 22.10.1998 DCFU290D17B/T2, superseded by SB-912-052/SB-914-035,
latest edition
SB-912-026,SB-
912 F,912 A,914 F 0 3 01.12.1999 Checking and replacement of stator assy.
914-014
SB-912-026-
UL,SB-914-014- 912 ULS,912 UL,914 UL 0 3 01.12.1999 Checking and replacement of stator assy.
UL
SB-912-027,SB- Checking or replacement of the propeller gearbox for all
912 F,912 A,914 F 0 1 01.02.2000
914-010 versions of the Rotax engine type 912 and 914
SB-912-027-
Checking or replacement of the propeller gearbox for all
UL,SB-914-010- 912 UL,914 UL 0 1 01.02.2000
versions of the Rotax engine type 912 and 914
UL
SB-912-028,SB- Checking or replacement of engine suspension frame part
912 S,912 F,912 A,914 F 0 1 01.11.2002
914-016 no. 886 567 on ROTAX engine type 912 and 914 (Series)
SB-912-028-
912 ULSFR,912 ULS,912 Checking or replacement of engine suspension frame part
UL,SB-914-016-
, 0 1 01.11.2002
UL 914 UL
UL,914 no 886 567 on ROTAX engine type 912 and 914 (series)
no.
UL
SB-912-029,SB- Checking of crankcase on ROTAX engine type 912 and 914
912 S,912 F,912 A,914 F 0 3 11.07.2006
914-018 (Series)
SB-912-029-
912 ULS,912 ULSFR,912 Checking of the crankcase on ROTAX engine type 912 and
UL,SB-914-018- 0 3 11.07.2006
UL,914 UL 914 (Series)
UL
SB-912-030,SB- Cracks, wear and distortion on the carburetor flange on Rotax
912 S,912 F,912 A,914 F 0 1 01.02.2004
914-019 engine type 912 and 914 (series)
SB-912-030-
912 ULS,912 ULSFR,912 Cracks, wear and distortion on the carburetor flange on Rotax
UL,SB-914-019- 0 1 01.02.2004
UL,914 UL engine type 912 and 914 (series)
UL
Checking or replacement of the fuel pump assembly part no.
SB-912-031 912 S,912 F,912 A 0 0 01.10.2001
996 596 on ROTAX engine tpye 912 (series)
912 ULSFR,912 ULS,912 Checking or replacement of the fuel pump assembly part no.
SB-912-031-UL 0 0 01.10.2001
UL 996 596 on ROTAX engine tpye 912 (series)
Replacement of oil pump assy. or oil pump shaft assy. on
SB-912-032 912 A 0 0 01.10.2001
ROTAX engine type 912 A (series)
Replacement of oil pump assy. or oil pump shaft assy. on
SB-912-032-UL 912 UL 0 0 01.10.2001
ROTAX engine type 912 UL
SB-912-033,SB- Inspection of the propeller gearbox when using leaded fuel
912 S,912 F,912 A,914 F 0 0 01.08.2002
914-020 for ROTAX engine 912/914
SB-912-033-
912 ULSFR,912 ULS,912 Inspection of the propeller gearbox when using leaded fuel
UL,SB-914-020- 0 0 01.08.2002
UL,914 UL for ROTAX engine 912/914
UL
Checking of oil pump attachment screw for ROTAX engine
SB-912-034 912 A 0 0 01.03.2002
type 912 A (Series)
Checking of oil pump attachment screw for ROTAX engine
SB-912-034-UL 912 UL 0 0 01.03.2002
type
yp 912 UL ((Series))

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 6 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SB-912-035,SB- Inspection or replacement of the rocker arms and valve push-

912 S,912 F,912 A,914 F 0 1 01.09.2002
914-021 rods for Rotax engine type 912 and 914 (Series)
SB-912-035-
912 ULSFR,912 ULS,912 Inspection or replacement of the rocker arms and valve push-
UL,SB-914-021- 0 1 01.09.2002
UL,914 UL rods for Rotax engine type 912 and 914 (Series)
UL
CANCELLED - Inspection for correct venting of the oil system
SB-912-036,SB-
912 S,912 F,912 A,914 F 0 1 23.01.2007 for Rotax engine type 912 and 914 (Series), superseded by
914-022
SB-912-040/SB-914-026, latest edition
SB-912-036- CANCELLED - Inspection for correct venting of the oil system
912 ULSFR,912 ULS,912
UL,SB-914-022- 0 1 23.01.2007 for Rotax engine type 912 and 914 (Series), superseded by
UL,914 UL
UL SB-912-040UL/SB-914-026UL, latest edition

SB-912-037,SB- Installation of an electric starter with enhanced power for

912 S,912 F,912 A,914 F 0 1 01.10.2003
914-023 Rotax Motor Type 912 und 914 (Serie)
SB-912-037-
912 ULS,912 UL,912 Installation of an electric starter with enhanced power for
UL,SB-914-023- 0 0 01.10.2002
ULSFR,914 UL Rotax Motor Type 912 und 914 (Serie)
UL
SB-912-038,SB- CANCELLED - Revision of Operators Manual for ROTAX
912 S,912 F,912 A,914 F 0 0 01.11.2002
914-024 engine type 912 and 914 (Series)
Checking of the engine in case of excessive propeller
SB-912-042 912 S 0 1 01.04.2004
backlash for Rotax engine type 912 S
Checking of the engine in case of excessive propeller
SB-912-042-UL 912 ULSFR,912 ULS 0 1 01.04.2004
backlash for Rotax engine type 912 S
Use of the Rotax supplied airbox for all Rotax engine types
SB-912-044 912 F 912 A
F,912 0 1 28 05 2010
28.05.2010
912 A/F (Series)
Use of the Rotax supplied airbox for all Rotax engine types
SB-912-044-UL 912 UL 0 1 28.05.2010
912 UL (Series)
Checking eccenters and fuel pump plungers for Rotax engine
SB-912-049 912 S,912 F,912 A 0 0 24.05.2006
type 912 (series)
912 ULS,912 ULSFR,912 Checking eccenters and fuel pump plungers for Rotax engine
SB-912-049-UL 0 0 24.05.2006
UL type 912 (series)
CANCELLED - Checking or replacement of fuel pump part
SB-912-050 912 S,912 F,912 A 0 0 24.05.2006 no. 892230/892235 on Rotax engine type 912 (series),
superseded by ASB-912-053 latest edition
CANCELLED - Checking or replacement of fuel pump part
912 ULS,912 ULSFR,912
SB-912-050-UL 0 0 24.05.2006 no. 892230/892235 on Rotax engine type 912 (series),
UL
superseded by ASB-912-053 latest edition
SB-912-053 912 S,912 F,912 A 0 0 13.04.2007 Replacement of fuel pump for Rotax engine type 912 (Series)
912 ULSFR,912 ULS,912
SB-912-053-UL 0 0 13.04.2007 Replacement of fuel pump for Rotax engine type 912 (Series)
UL
Checking or replacement of flexible fuel line for Rotax engine
SB-912-054 912 S,912 F,912 A 0 0 29.05.2007
type 912 (Series)
912 ULSFR,912 ULS,912 Checking or replacement of flexible fuel line for Rotax engine
SB-912-054-UL 0 0 29.05.2007
UL type 912 (Series)
Extension of Time Between Overhauls (TBO) for ROTAX
SB-912-057 912 S,912 F,912 A 0 1 24.05.2016
Engine Type 912 (Series)
912 ULSFR,912 ULS,912 Extension of time between overhauls (TBO) for ROTAX
SB-912-057-UL 0 0 14.12.2009
UL engine type 912 (Series)
Replacement of Fuel Pumps for Rotax Engine Type 912
SB-912-063 912 S,912 F,912 A 0 1 24.06.2013
(Series)
912 ULS,912 UL,912 Replacement of Fuel Pumps for Rotax Engine Type 912
SB-912-063-UL 0 2 21.08.2013
ULSFR (Series)
SB-912-064,SB- Periodic checking of the crankshaft journal (power take off
912 S,912 F,912 A,914 F 0 1 11.11.2013
914 045
914-045 side) for ROTAX Engine Type 912 and 914 (Series)

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 7 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SB-912-064-
912 ULS,912 ULSFR,912 Periodic checking of the crankshaft journal (power take off
UL,SB-914-045- 0 1 11.11.2013
UL,914 UL side) for ROTAX Engine Type 912 and 914 (Serie)
UL
SB-912-065
Periodic inspection of the float buoyancy for ROTAX Engine
UL,SB-914-046 912 UL,914 UL,912 ULS 0 3 26.03.2015
Type 912 and 914 (Series)
UL
SB-912-065,SB- Periodic inspection of the float buoyancy for ROTAX Engine
912 S,912 F,912 A,914 F 0 3 26.03.2015
914-046 Type 912 and 914 (Series)
Change of Measurement Method from Cylinder Head
SB-912-066,SB-
912 S,912 F,912 A,914 F 0 1 23.04.2015 Temperature to Coolant Temperature for ROTAX® Engine
914-047
Type 912 and 914 (Series)
SB-912-066- Change of Measurement Method from Cylinder Head
912 ULSFR,912 ULS,912
UL,SB-914-047- 0 1 23.04.2015 Temperature to Coolant Temperature for ROTAX® Engine
UL,914 UL
UL Type 912 and 914 (Series)
SB-912-067,SB- Exchange of floats on ROTAX Engine Type 912 and 914
912 S,912 F,912 A,914 F 0 1 26.03.2015
914-048 (Series)
SB-912-067-
912 ULSFR,912 ULS,912 Exchange of floats on ROTAX Engine Type 912 and 914
UL,SB-914-048- 0 1 26.03.2015
UL,914 UL (Series)
UL
SB-912-068,SB- Specification/Change of Engine Configuration and/or Type
912 S,912 F,912 A,914 F 0 1 09.09.2015
914-049 Plate for ROTAX Engine Type 912 and 914 (Series)
SB-912-068-
912 ULSFR,912 ULS,912 Specification/Change of Engine Configuration and/or Type
UL,SB-914-049- 0 2 09.09.2015
UL,914 UL Plate for ROTAX Engine Type 912 and 914 (Series)
UL
SB-912i-001,SB-
912 iSc SPORT,914 F,912 Installation / Use of governors for Rotax engine type 912i,
914-035,SB- 0 - 13.06.2014
S,912 F,912 A 912 and 914
912-052
SB-912i-
912 iS,914 UL,912
001iS,SB-914- Installation / Use of governors for Rotax engine type 912i,
ULSFR,912 ULS,912 0 - 13.06.2014
035-UL,SB-912- 912 and 914 (Series)
UL,912 iS SPORT
052-UL
Flashing of a new Software on the Engine Control Unit 912 iS
SB-912i-002iS 912 iS 0 0 18.12.2013
(ECU) for ROTAX Engine Type 912 i (Series)
Installation instructions for upgrade kit 912 iS Sport for
SB-912i-003iS 912 iS 0 1 03.06.2014
ROTAX engine type 912 i (Series)
Replacement of Regulator A and Regulator B for ROTAX
SB-912i-004iS 912 iS 0 0 03.09.2014
Engine Type 912 i (Series)
Exchange of stator assy. of ROTAX Engine Type 912 i
SB-912i-006 912 iSc SPORT 0 0 26.05.2016
(Series)
Exchange of stator assy. of ROTAX Engine Type 912 i
SB-912i-006iS 912 iS SPORT,912 iS 0 0 26.05.2016
(Series)
CANCELLED - Use of an adapted propeller governor on
SB-914-001 914 F 0 0 06.02.1997 engine type ROTAX 914 F3, superseded by SB-912-052/SB-
914-035, latest edition
SB-914-002 914 F 0 0 24.02.1997 Modification of engine type ROTAX 914 F3
Calibration of the mixture enrichment jet of engine type
SB-914-003 914 F 0 0 09.07.1997
ROTAX 914 F (series)
Calibration of the mixture enrichment jet for ROTAX engine
SB-914-003-UL 914 UL 0 0 20.12.2007
type 914 (Series)
Checking of the banjo bolt in the pressure oil line of turbo
SB-914-004 914 F 0 0 27.08.1997
charger for ROTAX 914 (series)
Checking of the banjo bolt in the pressure oil line of
SB-914-004-UL 914 UL 0 0 20.12.2007
turbocharger for ROTAX engine type 914 (Series)
Introduction of a turbo charger
g with a modified wastegate
g on
SB 914 005
SB-914-005 914 F 0 0 29 07 1998
29.07.1998
Rotax 914

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 8 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

Introduction of a turbocharger with modified waste-gate for

SB-914-005-UL 914 UL 0 0 20.12.2007
ROTAX engine type 914 (Series)
Employment of a muffler of reduced noise emission on
SB-914-006 914 F 0 1 01.10.2002
ROTAX engine Type 914 F (series).
Employment of a muffler of reduced noise emission on
SB-914-006-UL 914 UL 0 0 01.10.2002
ROTAX engine Type 914 F (series).
ROTAX engine type 914 F (series), check / replacement of
SB-914-007 914 F 0 0 05.06.1998
the turbo oil pressure line and pipe clamps
Check/replacement of the turbo oil pressure line and pipe
SB-914-007-UL 914 UL 0 0 20.12.2007
clamps for ROTAX engine type 914 (Series)
ROTAX engine type 914 F (series) check / replacement of
SB-914-008 914 F 0 0 05.06.1998
the wastegate servo cable
Check/replacement of the waste-gate servo cable for ROTAX
SB-914-008-UL 914 UL 0 0 20.12.2007
engine type 914 (Series)
CANCELLED - Installation of propeller governor McCauley
SB-914-009 914 F 0 0 22.10.1998 DCFU290D17B/T2, superseded by SB-912-052/SB-914-035,
latest edition
ROTAX engine series type 914 F, verification of the wiring
SB-914-012 914 F 0 0 29.09.1998
harness
Verification of the wiring harness for ROTAX engine type 914
SB-914-012-UL 914 UL 0 0 20.12.2007
(Series)
Turbocharge control unit (TCU) with software level according
SB-914-013 914 F 0 0 31.03.1999
to RTCA DO 178 B, for engine Type 914 F (series)
Turbocharge control unit (TCU) with software level D
SB-914-013-UL 914 UL 0 0 20.12.2007 according to RTCA DO 178 B for ROTAX engine type 914
(Series)
Checking or replacement of the exhaust muffler of reduced
SB-914-015 914 F 0 0 01.01.2001 noise emission part no. 979405 for ROTAX engine type 914
F
Checking or replacement of exhaust bend on ROTAX engine
SB-914-017 914 F 0 1 01.07.2002
type 914 (Series)
Checking or replacement of the exhaust bend on ROTAX
SB-914-017-UL 914 UL 0 1 01.07.2002
engine type 914 (series)
SB-914-024-
914 UL,912 ULSFR,912 CANCELLED - Revision of Operators Manual for ROTAX
UL,SB-912-038- 0 0 01.11.2002
ULS,912 UL engine type 912 and 914 (Series)
UL
SB-914-025,SB- Modifications of the overflow bottle for ROTAX engine type
914 F,912 S,912 F,912 A 0 0 01.12.2002
912-039 912 and 914 (Series)
SB-914-025-
914 UL,912 ULSFR,912 Modifications of the overflow bottle for ROTAX engine type
UL,SB-912-039- 0 0 01.12.2002
ULS,912 UL 912 and 914 (Series)
UL
SB-914-026,SB- Introduction of a new oil dipstick for ROTAX engine type 912
914 F,912 S,912 F,912 A 0 1 01.08.2003
912-040 and 914 (Series)
SB-914-026-
914 UL,912 ULSFR,912 Introduction of a new oil dipstick for ROTAX engine tpye 912
UL,SB-912-040- 0 0 01.04.2003
ULS,912 UL and 914 (Series)
UL
SB-914-027,SB- Extension of Time Between Overhaul (TBO) for ROTAX
914 F,912 S,912 F,912 A 0 2 25.03.2010
912-041 engine type 912 and 914 (Series)
SB-914-027-
914 UL,912 ULSFR,912 Extension of Time Between Overhaul (TBO) for ROTAX
UL,SB-912-041- 0 2 25.03.2010
ULS,912 UL engine type 912 and 914 (Series)
UL
Inspection of exhaust muffler part no. 979402 / 979404 for
SB-914-028 914 F 0 1 08.11.2004
Rotax engine type 914 (Series)
Inspection of exhaust muffler part no. 979402 / 979404 for
SB 914 028 UL 914 UL
SB-914-028-UL 0 1 08 11 2004
08.11.2004
Rotax engine type 914 (Series)

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 9 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SB-914-029,SB- Change of coolant specification on ROTAX engine type 912

914 F,912 S,912 F,912 A 0 2 10.11.2006
912-043 and 914 (Series)
SB-914-029-
914 UL,912 ULSFR,912 Change of coolant specification on ROTAX engine type 912
UL,SB-912-043- 0 1 28.08.2006
ULS,912 UL and 914 (Series)
UL
SB-914-030,SB- Inspection of the oil filter part no. 825701 for Rotax engine
914 F,912 S,912 F,912 A 0 0 19.11.2004
912-045 type 912 and 914 (Series)
SB-914-030-
914 UL,912 ULS,912 Inspection of the oil filter part no. 825701 for Rotax engine
UL,SB-912-045- 0 0 19.11.2004
ULSFR,912 UL type 912 and 914 (Series)
UL
Check of the support bearing on the crankshaft and of the
SB-914-031,SB-
914 F,912 S 0 0 26.07.2005 bearing bushing in the propeller gearbox on Rotax engine
912-046
type 912/914 (Series)
SB-914-031- Check of support bearing on the crankshaft and of the
914 UL,912 ULS,912
UL,SB-912-046- 0 0 26.07.2005 bearing bushing in the propeller gearbox on Rotax engine
ULSFR,912 UL
UL type 912/914 (Series)
SB-914-032,SB- Check of Allen screw M8x100 in the crankcase on Rotax
914 F,912 S 0 0 29.07.2005
912-047 engine type 912/914 (Series)
SB-914-032-
914 UL,912 ULS,912 Check of Allen screw M8x100 in the crankcase on Rotax
UL,SB-912-047- 0 0 29.07.2005
ULSFR,912 UL engine type 912/914 (Series)
UL
SB-914-033,SB- Replacement of pin part no. 929700 in carburetor for Rotax
914 F,912 S,912 F,912 A 0 0 23.09.2005
912-048 engine type 912 and 914 (series)
SB-914-033-
914 UL,912 ULS,912 Replacement of pin part no. 929700 in carburetor for Rotax
UL,SB-912-048- 0 0 23.09.2005
ULSFR,912 UL engine type 912 and 914 (series)
UL
SB-914-034,SB- Checking of magnetic plug on Rotax engine type 912/914
914 F,912 S,912 F,912 A 0 0 30.01.2008
912-051 (Series)
SB-914-034-
914 UL,912 ULS,912 Checking of magnetic plug on Rotax engine type 912/914
UL,SB-912-051- 0 0 30.01.2008
ULSFR,912 UL (Series)
UL
SB-914-036,SB- Inspect for tight fit of oil filter for Rotax engine type 912 and
914 F,912 S,912 F,912 A 0 0 31.08.2007
912-055 914 (Series)
SB-914-036-
914 UL,912 ULSFR,912 Inspect for tight fit of oil filter for Rotax engine type 912 and
UL,SB-912-055- 0 0 31.08.2007
ULS,912 UL 914 (Series)
UL
SB-914-038,SB- Replacement of the propeller gearbox for some Rotax
914 F,912 S 0 1 05.08.2008
912-056 engines type 912/914 (Series)
SB-914-038-
914 UL,912 ULSFR,912 Replacement of the propeller gearbox for some ROTAX
UL,SB-912-056- 0 1 05.08.2008
ULS engines type 912/914 (Series)
UL
Extension of time between overhauls (TBO) for ROTAX
SB-914-039 914 F 0 0 25.03.2010
engine type 914 (Series)
Extension of time between overhauls (TBO) for ROTAX
SB-914-039-UL 914 UL 0 0 25.03.2010
engine type 914 (Series)
Replacement of fuel pressure regulator part no. 887130 for
SB-914-040 914 F 0 0 10.03.2011
ROTAX engine type 914 (Series)
Replacement of fuel pressure regulator assy. part no. 887130
SB-914-040-UL 914 UL 0 0 10.03.2011
for ROTAX engine type 914 (Series)
SB-914-041,SB- Replacement of washer part no. 944072 (flywheel hub) for
914 F,912 S,912 F,912 A 0 0 15.04.2011
912 058
912-058 ROTAX engine type 912 and 914 (Series)

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 10 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SB-914-041-
914 UL,912 ULS,912 Replacement of washer part no. 944072 (flywheel hub) for
UL,SB-912-058- 0 0 15.04.2011
ULSFR,912 UL ROTAX engine type 912 and 914 (Series)
UL
SB-914-042,SB- Checking of the crankshaft journal (power take off side) for
914 F,912 S,912 F,912 A 0 0 01.01.2012
912-059 ROTAX engine type 912 and 914 (Series)
SB-914-042-
914 UL,912 ULS,912 Checking of the crankshaft journal (power take off side) for
UL,SB-912-059- 0 0 01.01.2012
ULSFR,912 UL ROTAX engine type 912 and 914 (Series)
UL
Replacement of the overload clutch of ROTAX® Engine Type
SB-914-050 914 F 0 0 13.05.2015
914 (Series)
Replacement of the overload clutch of ROTAX® Engine Type
SB-914-050-UL 914 UL 0 0 13.05.2015
914 (Series)
532 UL,503 UL,462
SI-01-1985 0 0 01.04.1985 UL-Propeller-Gear
UL,447 UL,377 UL
532 UL,503 UL,462
SI-01-1988 0 0 01.01.1988 Function test of rectifier regulator
UL,447 UL,377 UL,277 UL
SI-01-1989 503 UL 0 0 01.03.1989 Fan drive of engine Type 503
SI-01-1991 582 UL,532 UL 0 0 01.02.1991 Rotary valve shaft sealing for ROTAX 532 UL and 582 UL
SI-01-1992 912 UL 0 0 01.07.1992 Engine type 912 UL, ignition unit with resitor spark plug
SI-01-1993 582 UL 0 0 01.01.1993 ROTAX 582 UL DCDI - making of pick-up
SI-01-1994 912 A,912 UL 0 0 01.01.1994 Electronic-box for ROTAX 912 A + UL
CANCELLED - Ground connection for pick-up wiring, ROTAX
SI-01-1995 912 UL 0 1 01.04.1995 engine Series Type 912 UL, superseded by SB-912-007 UL,
latest edition
CANCELLED - Fuel pump 996592 (pump with screw fittings)
SI-01-1998 912 UL 0 1 01.02.1998
912 (series), superseded by SB-912-020 UL, latest edition
SI-02-1984 277 UL 0 0 25.01.1984 UL-Propeller-Gear 277
532 UL,503 UL,462
SI-02-1985 0 0 01.05.1985 Increase of ignition voltage on BOSCH contact ignition
UL,447 UL,377 UL,277 UL

SI-02-1991 618 UL,582 UL,503 UL 0 0 01.02.1991 Tightening torque increase on ´C´ gearboxes for UL-engines.
SI-02-1992 912 A,912 UL 0 0 01.12.1992 Coolant expansion tank ROTAX 912
912 A,912 ULSFR,912
SI-02-1995 2 0 01.08.1995 Contamination of carburetors, ROTAX-series 912
ULS,912 UL,912 S,912 F
SI-02-1996 912 UL,912 A 0 0 01.02.1996 Rectifier regulator, Rotax Series 912
SI-02-1997 912 UL 0 0 01.02.1997 Camshaft check on ROTAX engine Type 912 UL (series)
CANCELLED - ROTAX engine type 914, check / replacement
SI-02-1998 914 F,914 UL 0 0 01.06.1998 of the turbo oil pressure line and pipe clamps, superseded by
SB-914-007 UL, latest edition
SI-03-1985 277 UL 0 0 01.09.1985 UL-Propeller-Gear 277
SI-03-1985 277 UL 0 0 01.09.1985 UL-Propeller Gear 277
532 UL,503 UL,447
SI-03-1989 0 0 01.06.1989 Matching a propeller to ROTAX UL-Engines.
UL,377 UL
618 UL,582 UL,532
Daily and Pre-Flight-Check - Maintenance plan for all ROTAX
SI-03-1991 UL,508 UL,503 UL,462 0 0 01.04.1991
engines
UL,447 UL,377 UL,277 UL
SI-03-1993 912 UL 0 0 01.02.1993 Ignition unit of ROTAX 912 UL
SI-03-1994 912 UL,912 A 0 0 01.12.1994 Sensor and gauge for oil pressure indication-ROTAX 912
618 UL,582 UL,532 Rotary valve shaft seal leakage at Rotax engine type 462 UL /
SI-03-1996 0 1 01.09.1999
UL 462 UL
UL,462 532 UL / 582 UL and 618 UL

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 11 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

914 UL,914 F,912 CANCELLED - Coolant (antifreeze) mixtures for ROTAX

SI-03-1997 ULS,912 UL,912 S,912 0 1 01.01.1999 engine type 912/914 (Series) - superseded by relevant
F,912 A Operators Manual, latest edition
914 UL,914 F,912 UL,912 Engine start at low temperatures at Rotax engine type 912
SI-03-1998 0 1 01.02.2004
S,912 F,912 A and 914 (Series)
914 UL,914 F,912
Standardization of the crankcase for ROTAX engines 912
SI-03-1999 ULS,912 UL,912 S,912 0 0 01.02.1999
and 914
F,912 A
532 UL,508 UL,503
SI-04-1986 UL,462 UL,447 UL,377 0 0 01.09.1986 Possible causes for piston seizures or holes in pistons
UL,277 UL
582 UL,532 UL,508
SI-04-1987 UL,503 UL,462 UL,447 1 0 01.05.1990 Ultralight engines-unexpected engine stops
UL,377 UL,277 UL
582 UL,532 UL,508
SI-04-1989 UL,503 UL,462 UL,447 0 0 01.01.1989 Use of tool for cageless piston pin needle bearing
UL,377 UL,277 UL
Starter gear - electric starter, magneto side, on engine 582
SI-04-1990 582 UL 0 0 01.09.1990
UL
SI-04-1993 582 UL 0 0 01.09.1993 Crankcase modifications - ROTAX 582 DCDI
532 UL,914 UL,912
UL,618 UL,582 UL,508
SI-04-1994 0 0 01.02.1994 Carburetor icing on UL-engines
UL,503 UL,462 UL,447
UL,377 UL,277 UL
SI-04-1995 912 F,912 A,912 UL 0 0 01.05.1995 Floats with a new shape, engine Series Type 912
914 UL,914 F,912 CANCELLED - Venting of lubrication system for Rotax engine
SI-04-1997
SI 04 1997 ULS,912 UL,912 S,912 0 3 23.01.2007 type 912 and 914 (Series), superseded by SI-912-018/SI-914-
SI 912 018/SI 914
F,912 A 020, latest edition
CANCELLED - ROTAX engine type 914 F (series)
SI-04-1998 914 F,914 UL 0 1 01.06.1998 Replacement of the waste gate servo cable, superseded by
SB-914-008 UL, latest edition
447 UL,532 UL,503
SI-05-1988 0 0 01.04.1990 Gearbox fixation on UL-engines type 377 to 532 UL
UL,462 UL,377 UL
Disturbance of tachometer 966 072 for 503 UL C.D.I. and 582
SI-05-1990 582 UL,503 UL 0 1 01.12.1990
UL with DUCATI ignition unit
618 UL,582 UL,532
SI-05-1991 UL,508 UL,503 UL,462 0 0 01.12.1991 Piston for ROTAX UL engines (2-stroke)
UL,447 UL,377 UL,277 UL
SI-05-1994 912 UL,912 A 0 0 01.03.1994 Banjo Bolt ROTAX 912
SI-05-1995 912 UL 0 2 01.07.1996 External alternator for engine series type 912 UL, Mod. 94
SI-05-1996 503 UL,447 UL 0 0 01.03.1997 Cracks in the carburetor socket, ROTAX 447 and 503 UL
914 UL,914 F,912 UL,912
SI-05-1997 0 1 01.04.1997 Exhaust flange of ROTAX engines 912/914 (series)
F,912 A
Acceptable cracks in the turbine housing of the turbo charger
SI-05-1998 914 UL,914 F 0 0 01.06.1998
for engine 914
CANCELLED - Turbocharge control unit (TCU) with software
SI-05-1999 914 UL 0 0 01.10.1999 level according to RTCA DO 178 B, for ROTAX engine Type
914 F (series), superseded by SB-914-013 UL, latest edition
377 UL,277 UL,532
SI-06-1986 UL,508 UL,503 UL,462 0 0 01.12.1986 UL-Reduction gear box
UL,447 UL
582 UL,532 UL,508
SI-06-1987 UL,503 UL,462 UL,447 0 0 01.07.1987 Engine-Instruments
UL,377 UL,277 UL
SI-06-1993 582 UL 0 0 01.09.1993 ROTAX 582 UL carb adapter

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 12 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

618 UL,582 UL,532

Incorrect Model fuel pumps without bleed hole, ROTAX 2-
SI-06-1994 UL,508 UL,503 UL,462 0 0 01.07.1994
cycle engines
UL,447 UL,377 UL,277 UL
External alternator for engine series type 912 UL, Mod. 89
SI-06-1995 912 UL 0 2 01.07.1996
and 91
SI-06-1996 618 UL,582 UL,503 UL 0 0 01.03.1997 Modifications on reduction gearbox ´C´ and ´E´
914 UL,914 F,912 UL,912 Friction torque check of propeller gear with overload clutch on
SI-06-1997 0 1 18.02.2005
F,912 A Rotax engine type 912 and 914 (Series)
618 UL,582 UL,532 Amendment on reduction gearbox type ´C´ and type ´E´ for 2-
SI-06-1998 0 1 01.07.2001
UL,503 UL,447 UL stroke UL aircraft engines
SI-06-1999 912 ULS,912 S 0 0 01.01.1998 ROTAX engine Type 912 ULS/S, Oil consumption
582 UL,532 UL,508
SI-07-1987 UL,503 UL,462 UL,447 1 0 01.04.1990 Fuel consumption, 2-stroke UL-Engine
UL,377 UL,277 UL
Wiring diagr. for 447 UL SCDI and 508 UL SCDI in conj. with
SI-07-1991 508 UL,447 UL 0 0 01.05.1991
electr. tachometer
SI-07-1993 447 UL 0 0 01.09.1993 Revolution counter for ROTAX 447 SCDI
SI-07-1994 582 UL 0 0 01.07.1994 ROTAX 582 UL crankshaft
914 UL,914 F,912
ULS,912 UL,912 S,912
SI-07-1995 F,912 A,618 UL,582 0 1 01.02.1999 New airfilter with securing tab
UL,532 UL,503 UL,447
UL,377 UL,277 UL
CANCELLED - Replacement of rocker arms on ROTAX 912
SI-07-1996 912 UL 0 0 01.09.1996
UL ((series),
), superseded
p byy SB-912-015 UL,, latest edition
CANCELLED - Calibration of the mixture enrichment jet of
SI-07-1997 914 UL 0 0 01.07.1997 ROTAX 914 UL (series), superseded by SB-914-003 UL,
latest edition
´B´ type gearbox installation, ROTAX 503 UL DCDI (all
SI-07-1998 503 UL 0 0 12.10.1998
versions)
582 UL,532 UL,508
Influence of ambient air temperature and barometric pressure
SI-08-1987 UL,503 UL,462 UL,447 0 0 01.06.1990
on engine performance and carb calibration
UL,377 UL,277 UL
618 UL,582 UL,532
Safety-check of the BING-carburetors used in all ROTAX UL-
SI-08-1991 UL,508 UL,503 UL,462 0 0 01.06.1991
engines
UL,447 UL,377 UL,277 UL
CANCELLED - General overhaul of ROTAX 912 A/UL,
SI-08-1993 912 UL,912 A 0 0 01.10.1993
superseded by SB for TBO Extension, latest edition
SI-08-1994 582 UL 0 0 01.05.1994 Attaching of water pump housing on ROTAX 582 UL
CANCELLED - Fitting of a carburetor support, Rotax Series
SI-08-1995 912 UL 0 1 01.12.1995
912, superseded by SB-912-010 UL, latest edition
SI-08-1996 618 UL 0 0 01.03.1997 Installation of oversize pistons, ROTAX 618 UL
CANCELLED - ROTAX engine series type 914 UL,
SI-08-1998 914 UL 0 1 01.02.1999 verification of the wiring harness, superseded by SB-914-012
UL, latest edition
CANCELLED - Documentations for 447 - 503 - 582 - 582
SI-08-1999 582 UL,503 UL,447 UL 0 0 01.02.1999
Mod. 99, superseded by SL-2ST-002, latest edition
618 UL,582 UL,532
SI-09-1991 UL,508 UL,503 UL,462 0 0 01.11.1991 Installation Instructions for ROTAX UL-engines
UL,447 UL,377 UL,277 UL
SI-09-1993 618 UL 0 0 01.11.1993 Assembly instructions for ROTAX 618 water pump cover
618 UL,582 UL,532 Installation Instruction of UL reduction gearbox type 'C'
C and
SI 09 1994
SI-09-1994 0 2 01 01 2004
01.01.2004
UL,503 UL 'CL'

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 13 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

SI-09-1996 914 UL 0 0 01.03.1998 ROTAX 914 UL exchange of the oilpump housing

SI-09-1997 503 UL 0 0 01.07.1997 Exchange of piston pins, ROTAX 503 UL
SI-10-1987 503 UL 0 0 01.11.1987 503 UL- FREE AIR Version
SI-10-1991 912 A,912 UL 0 0 01.09.1991 Water distributor for ROTAX 912 A and 912 UL
618 UL,582 UL,532 Installation Instruction of UL reduction gearbox type 'E' and
SI-10-1994 0 2 01.01.2004
UL,503 UL 'EL'
618 UL,582 UL,532
SI-10-1996 UL,503 UL,447 UL,377 0 0 01.05.1997 Piston pin circlip installation (2-stroke UL-engines)
UL,277 UL
914 UL,914 F,912
Illustrated Parts Catalog (IPC) for ROTAX engines 912 / 914
SI-10-1999 ULS,912 UL,912 S,912 0 0 01.03.1999
(series)
F,912 A
532 UL,503 UL,447
SI-11-1987 0 0 01.11.1987 Exhaust systems for 377/447/462/503/532
UL,377 UL
914 UL,914 F,912
ULSFR,912 ULS,912
UL,912 S,912 F,912 A,618
SI-11-1991 0 0 01.12.1992 Propeller mass moment of inertia
UL,582 UL,532 UL,508
UL,503 UL,462 UL,447
UL,377 UL,277 UL
Subsequent install. or retrofit of an oil-Pump for separate oil
SI-11-1994 503 UL 1 0 01.06.1994
Lubrication
618 UL,582 UL,532
SI-11-1996 UL,503 UL,447 UL,377 0 0 01.01.1998 Engine preservation for 2-stroke- UL- engines
UL,277 UL
Adjustment or verification of the wastegate position on
SI-11-1997 914 UL,914 F 0 0 01.12.1997
ROTAX 914
SI-12-1991 508 UL 0 0 01.12.1992 508 UL-Valve Cover Attachment
462 UL,447 UL,377
SI-12-1994 UL,277 UL,582 UL,532 0 2 01.01.2004 Installation Instruction of UL reduction gearbox Type 'B'
UL,508 UL,503 UL
914 F,914 UL,912 F,912 CANCELLED - Oil filter ROTAX 912 / 914 engine,
SI-12-1996 0 0 01.12.1996
A,912 UL superseded by SB-912-017/SB-914-037 UL, latest edition

CANCELLED - Checking of the banjo bolt in the pressure oil

SI-12-1997 914 F,914 UL 0 0 01.07.1997 line of turbo charger for ROTAX engine Type 914 (series),
superseded by SB-914-004 UL, latest edition

618 UL,582 UL,532

SI-13-1994 UL,508 UL,503 UL,462 0 0 01.07.1994 Using auto fuel in ROTAX two cycle aircraft engine
UL,447 UL,377 UL,277 UL
914 UL,914 F,912 UL,912 Installation instructions of rev-counter part no. 966403 and
SI-13-1996 0 2 23.06.2009
F,912 A 966408 for Rotax engine type 912 and 914 (Series)
CANCELLED - Introduction of a turbo charger with a modified
SI-13-1997 914 F,914 UL 0 0 01.12.1997 wastegate on Rotax 914, superseded by SB-914-005 UL,
latest edition
618 UL,582 UL,532
ROTAX two-cycle aircraft engines crankshaft failures, piston
SI-14-1994 UL,508 UL,503 UL,462 0 0 01.07.1994
seizures
UL,447 UL,377 UL,277 UL
912 UL,914 F,914 UL,912 Introduction of the single valve spring arrangement on Rotax
SI-14-1997 0 1 01.03.1998
F,912 A engine type 912 and 914 (series)
618 UL,582 UL,532
SI-15-1994 0 0 01.11.1995 Rev. counter for DUCATI ignition unit
UL,508 UL,503 UL,447 UL

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 14 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

914 UL,914 F,912 CANCELLED - Spark plugs for ROTAX engines 912/914
SI-15-1997 ULSFR,912 ULS,912 0 2 24.11.2010 (Series), superseded by Maintenance Manual Line, latest
UL,912 S,912 F,912 A edition
914 F,914 UL,912 F,912
SI-16-1997 0 1 01.12.1997 Introduction of a modified oil pressure sensor 912/914
A,912 UL
618 UL,582 UL,532
Weight, centre of gravity and moments of inertia of ROTAX
SI-17-1994 UL,508 UL,503 UL,462 0 0 01.06.1994
UL-engines
UL,447 UL,377 UL,277 UL
532 UL,618 UL,582
Introduction of resistance spark plugs for Rotax 2-stroke
SI-17-1997 UL,503 UL,447 UL,377 0 0 01.11.1997
engines
UL,277 UL
SI-18-1994 912 UL 1 0 01.11.1994 Grounding cable for electronic module for ROTAX 912
914 UL,914 F,912 CANCELLED - Selection of Motor Oil and General Operating
SI-18-1997 ULS,912 UL,912 S,912 0 5 28.08.2006 Tips for Rotax engines Type 912 and 914 (series),
F,912 A superseded by SI-912-016/SI-914-019 latest edition
SI-19-1994 582 UL 0 0 01.06.1994 Cylinder and Piston for ROTAX 582 DCDI
SI-19-1997 618 UL 0 0 01.12.1997 Version without intake silencer 618 UL
SI-20-1994 912 UL,912 A 0 3 01.10.1996 Lubrication system for all ROTAX 912
377 UL,277 UL,914
UL,914 F,912 ULS,912
SI-20-1997 UL,912 S,912 F,912 A,618 0 0 01.11.1997 New flydat configuration for Rotax UL and aircraft engines
UL,582 UL,532 UL,503
UL,447 UL
912 ULS,912 UL,912 CANCELLED - 912 carburetor fixation, superseded by SB-
SI-21-1994 0 0 01.07.1994
S 912 F
S,912 912 A
F,912 912 030/SB 914 019 (+UL)
912-030/SB-914-019 (+UL), latest edition
914 F,914 UL,912 F,912 Introduction of the mono hook circlip at ROTAX 912 and 914
SI-21-1997 0 1 01.11.1998
A,912 UL series
CANCELLED - Overload clutch for Rotax engine 912 UL,
SI-2-1993 912 UL 0 0 01.01.1993
superseded by relevant Maintenance Manual, latest edition

582 UL,532 UL,618

SI-22-1994 UL,508 UL,503 UL,462 0 0 01.12.1994 supply scope of ROTAX crankshafts
UL,447 UL,377 UL,277 UL
914 UL,914 F,912
SI-22-1997 ULS,912 UL,912 S,912 0 0 01.11.1997 Pressure oil line for hydraulic governor 912/914
F,912 A
Ensuring of a ground connection between screening box part
SI-25-1994 912 UL 0 0 01.11.1994
no. 996 611 and engine
CANCELLED - Running modifications on Rotax engine type
914 UL,912 UL,912 S,912
SI-25-1997 0 11 18.07.2007 912 and 914 (series), superseded by SI-912-020/SI-914-022,
F,912 A,912 ULS,914 F
latest edition
SI-26-1994 912 UL 0 0 01.11.1994 TBO for ROTAX engine type 912 UL-series
Supplementing the Maintenance Manual in regard to
SI-26-1997 914 UL,912 UL 0 0 01.09.1998
propeller gearbox without overload clutch
Special inspection to increase the TBO for engine type 912
SI-27-1994 912 UL 1 0 01.03.1995
UL
914 UL,914 F,912 CANCELLED - Oil level check for ROTAX engine type 912
SI-27-1997 ULS,912 UL,912 S,912 0 1 17.07.2012 and 914 (Series), superseded by relevant Maintenance
F,912 A Manual, latest edition
Installation instructions for the new design piston for 582 UL
SI-2ST-001 618 UL,582 UL 0 0 01.04.1999
with mono hook piston pin circlip grooves
Change of the exhaust gasket on engine type 582 UL mod.
SI-2ST-002 618 UL,582 UL 0 0 01.05.2000
90/99 und type 618 UL
618 UL,447 UL,582 Running modifications on ROTAX 2-stroke UL aircraft
SI-2ST-004 0 1 11 07 2006
11.07.2006
UL,503 UL engines

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 15 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

Modified rotary valve cover for ROTAX engine type 582 UL

SI-2ST-005 582 UL 0 0 01.12.2001
(replaced by SB-2ST-002)
618 UL,582 UL,532 Amendment on reduction gearbox type C and type E for
SI-2ST-007 0 2 20.05.2008
UL,503 UL,447 UL ROTAX 2-stroke UL aircraft engines
618 UL,582 UL,503 Selection of suitable operating fluids for ROTAX 2-stroke UL
SI-2ST-008 0 0 08.04.2009
UL,447 UL engines
CANCELLED - Cracks in the carburetor flange, engine series
SI-3-1995 912 UL,912 A 0 0 01.02.1995 type 912, superseded by SB-912-030/SB-914-019 (+UL),
latest edition
912 ULS,912 UL,912
SI-912-001,SI- Installation of rotary water pump seal and water pump
S,912 F,912 A,914 UL,914 0 0 01.04.1999
914-001 impeller
F
SI-912-002,SI- 912 S,912 ULS,912 F,912 Verification of the Lubrication system and replacement of the
0 0 01.06.1999
914-004 A,912 UL,914 F,914 UL oil pressure spring for engine type 912 and 914
912 ULS,912 UL,912
SI-912-003,SI- Oil line connections with UNF-threads (AN-8) for ROTAX
S,912 F,912 A,914 UL,914 0 2 19.03.2009
914-005 engine types 912 and 914 (series)
F
912 ULS,912 UL,912 CANCELLED - Modified carburetor flange for Rotax engine
SI-912-004,SI-
S,912 F,912 A,914 UL,914 0 0 01.08.1999 type 912 (series) and Rotax engine type 914 (series),
914-006
F superseded by SB-912-030/SB-914-019 (+UL), latest edition
912 ULS,912 UL,912
SI-912-005,SI- Lubrication system for all ROTAX engine type 912 (series)
S,912 F,912 A,914 UL,914 0 0 01.02.2000
914-007 and 914 (series)
F
912 S,912 ULSFR,912
SI-912-006,SI- Replacement of the circlip in the sprag clutch housing on
ULS,912 F,912 A,912 0 1 03.02.2009
914-008 ROTAX engine type 912 and 914 (series)
UL,914 F,914 UL
912 ULSFR,912 ULS,912
UL,912 S,912 F,912 A,618
SI-912-007,SI- Check of the fuel pressure gauge kit part no. 874 230 for
UL,582 UL,532 UL,508
2ST-003,SI-914- 0 0 01.08.2001 ROTAX engine type 912 and 914 (Series) and 2-stroke UL
UL,503 UL,462 UL,447
009 aircraft engines
UL,377 UL,277 UL,914
UL,914 F

912 S,912 ULSFR,912 Fuel pressure indication problems on ROTAX engine type
SI-912-008 0 1 01.02.2002
ULS,912 F,912 A,912 UL 912 (series)
912 S,912 ULSFR,912
SI-912-009,SI- Introduction of a new rocker arm bushing for ROTAX engine
ULS,912 F,912 A,912 0 0 01.10.2001
914-010 type 912 and 914 (series)
UL,914 F,914 UL
SI-912-010,SI- 912 ULS,912 F,912
912i-005,SI-914- UL,912 S,912 A,912 0 - 02.10.2012 Oil change on Rotax engine type 912i, 912 and 914 (Series)
011 iS,914 UL,914 F
912 S,912 ULSFR,912
SI-912-011,SI- Replacement of the gasket rings on the adaptor of the oil
ULS,912 F,912 A,912 0 0 01.03.2003
914-012 radiator for Rotax engine type 912 and 914 (series)
UL,914 F,914 UL
912 ULS,912 UL,912
SI-912-012,SI- Routine Modifications of the Bing constant depression
S,912 F,912 A,914 UL,914 0 1 01.03.2004
914-014 carburetor on ROTAX engine type 912 and 914 (Series)
F
912 ULS,912 S,912
SI-912-013,SI- Standardization of the ignition unit for ROTAX engine type
ULSFR,912 F,912 A,912 0 0 01.04.2004
914-016 912 and 914 (Series)
UL,914 F,914 UL
912 ULSFR,912 ULS,912
SI-912-014,SI- Optimizing of piston ring position for ROTAX engine type 912
UL,912 S,912 F,912 A,914 0 0 01.06.2004
914-017 and 914 (Series)
UL,914 F
912 S,912 ULSFR,912
SI-912-015,SI- Increase of disk spring pre-tension in the gearbox on ROTAX
ULS,912 F,912 A,912 0 0 01.06.2004
914 018
914-018 engine type 912 and 914 (Series)
UL,914 F,914 UL

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 16 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

912 UL,912 S,912 F,912

SI-912-016,SI- A,912 ULSFR,912
Selection of suitable operating fluids for Rotax engine type
912i-001,SI-914- ULS,912 iSc SPORT,912 0 - 16.04.2015
912 i, 912 and 914 (Series)
019 iS SPORT,912 iS,914
UL,914 F

912 ULSFR,912 ULS,912

SI-912-017,SI- Airfilter for Rotax engine type 912 (Series) and 2-stroke UL
UL,912 S,912 F,912 A,618 0 0 22.12.2006
2ST-006 aircraft engines
UL,582 UL,503 UL,447 UL

SI-912-018,SI- 912 ULSFR,912 ULS,912

Purging of lubrication system for Rotax engine type 912i, 912
912i-004,SI-914- UL,912 S,912 F,912 A,912 0 - 02.10.2012
and 914 (Series)
020 iS,914 UL,914 F
912 ULS,912 S,912
SI-912-019,SI- ULSFR,912 F,912 A,912
Oil leakages in the area of the cylinder barrel for Rotax
912i-006,SI-914- UL,912 iSc SPORT,912 iS 0 - 13.06.2014
engine type 912i, 912 and 914 (Series)
021 SPORT,912 iS,914
UL,914 F
SI-912-020,SI- 912 S,912 A,914 F,912 Running Modifications on ROTAX Engine Type 912/914
0 9 30.12.2016
914-022 F,912 UL,914 UL,912 ULS (Series)
912 F,912 A,914 UL,914
F,912 ULSFR,912
SI-912-021,SI-
ULS,912 UL,912 S,535 Inspection of carburetors for ROTAX engine type 912 and
914-023,SI-2ST- 0 0 09.11.2009
B,503 UL,618 UL,505 914 (Series) and 2-stroke UL aircraft engines
009
A,505,535 A,277 UL,535
C,582 UL,447 UL
912 ULSFR,912 ULS,912 Cancelation of the 5-years change interval for fuel hoses
SI-912-022 0 0 20.01.2014
S,912 F,912 A,912 UL (teflon hoses) for ROTAX Engine Type 912 (Series)

912 F,914 UL,912 S,912

SI-912-025,SI- Change of Tightening Torque Procedure for the Installation of
iSc SPORT,912 ULS,914
914-026,SI-912 0 0 30.12.2016 Cylinder Heads on ROTAX Engine Type 912 i, 912 and 914
F,912 A,912 iS,912
i-010 Series
UL,912 iS SPORT
912 iSc SPORT,912 iS B.U.D.S. Aircraft Installation Instructions for ROTAX Engine
SI-912i-002 0 1 13.06.2014
SPORT,912 iS Type 912 i Series
912 iSc SPORT,912 iS B.U.D.S. Aircraft Update for ROTAX Engine Type 912 i
SI-912i-003 0 4 13.06.2014
SPORT,912 iS Series
SI-912i-007,SI- 912 iSc SPORT,912 iS Introduction of a radiator retrofit kit part no. 881535 for the
914-024,SI-912- SPORT,912 iS,914 F,912 0 0 04.11.2015 new radiator part no. 997083 on ROTAX engine type 912i,
023 S,912 F,912 A 912 and 914 (Series)
SI-912i-008,SI- 912 iSc SPORT,912 iS
Introduction of new oil radiator/-sets on ROTAX Engine Type
914-025,SI-912- SPORT,912 iS,914 F,912 0 0 19.11.2015
912 i, 912 und 914 (Series)
024 S,912 F,912 A
912 iSc SPORT,912 iS Introduction of a new fuel filter part no. 874060 for ROTAX
SI-912i-009 0 0 21.01.2016
SPORT,912 iS Engine Type 912 iS and 912 iS Sport
SI-914-002 914 F,914 UL 0 0 01.04.1999 Optimizing of mixture distribution
Inspection and lubrication of Wastegate for ROTAX engine
SI-914-003 914 UL,914 F 0 1 15.04.2008
type 914 (Series)
Introduction of a new airbox for Rotax engine type 914
SI-914-013 914 F,914 UL 0 0 01.04.2003
(series)
Introduction of a new airbox part no. 667167 for Rotax engine
SI-914-015 914 F,914 UL 0 0 01.12.2003
type 914 (Series)

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 17 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

447 UL,377 UL,277

UL,582 UL,535 C,535
Documentations for ROTAX 2-stroke UL engines and
SL-2ST-002 B,535 A,532 UL,505 0 1 12.01.2005
certified 2-stroke aircraft engines
A,505,618 UL,503
UL,501,462 UL
503 UL,618 UL,582 Running modifications on carburetors for ROTAX 2-stroke UL
SL-2ST-005 0 0 01.07.2001
UL,447 UL aircraft engines
SL-912-007 912 ULSFR 0 1 15.03.2011 ROTAX engine type 912 ULSFR - version for France
CANCELLED - Operators and Maintenance Manual for
912 ULS,912 UL,912
SL-912-008 0 0 20.07.2000 ROTAX 912 Series - superseded by SB-2ST-000/SB-912-
S,912 F,912 A
000/SB-914-000, current edition
912 ULSFR,912 ULS,912 Identifying abnormal vibrations on aircrafts equipped with
SL-912-010 0 0 01.02.2003
S Rotax engine type 912 S/ULS/ULSFR
Essential information regarding engine behavior,
SL-912-016,SL- 912 A,912 F,914 F,912
0 1 30.12.2016 performance and manifold pressure data for ROTAX Engine
914-014 ULS,912 S,914 UL,912 UL
Type 912 and 914 (Series)
912 iSc SPORT,912 iS
SL-912i-003 0 2 07.07.2016 Warranty conditions for ROTAX Engine Type 912 i Series
SPORT,912 iS
914 UL,914 F,447 UL,377
UL,277 UL,582 UL,535
Change of desig. of Tech. Bulletins and Service Information
SL-914-001,SL- C,535 B,535 A,532
in acc. with the new ROTAX standard for ROTAX 2-stroke UL
2ST-001,SL- UL,508 UL,505 A,505,912 0 1 01.07.1999
aircraft engines, ROTAX 912 (series) and ROTAX 914
912-001 ULS,912 UL,912 S,912
(series)
F,912 A,618 UL,503
UL,501,463,462 UL
914 UL,914
, F,912
,
SL 914 002 SL
SL-914-002,SL- Standardization of the crankshaft/piston pin and of the
ULS,912 UL,912 S,912 0 2 28.05.2010
912-002 gearbox for ROTAX engine type 912/914 (Series)
F,912 A

914 UL,914 F,447 UL,377

UL,277 UL,275,185,582
CANCELLED - List of documentation for ROTAX 2-Stroke
SL-914-003,SL- UL,532 UL,535 C,535
Aircraft engines and all versions of engine Type 912 / 914 -
2ST-003,SL- B,535 A,912 ULS,912 0 2 01.07.2000
superseded by SB-2ST-000/SB-912-000/SB-914-000, current
912-003 UL,912 S,912 F,912 A,508
edition
UL,505 A,505,503 UL,618
UL,501,463,462 UL

914 UL,914 F,912

SL-914-004,SL-
ULS,912 UL,912 S,912 0 2 15.04.2008 Documentation for ROTAX engine type 912 and 914 (Series)
912-004
F,912 A
914 UL,914 F,912
ULS,912 UL,912 S,912
SL-914-005,SL- F,912 A,377 UL,582 Change of layout for: Alert Service Bulletin (ASB), Service
912-005,SL- UL,535 C,535 B,535 0 0 01.12.1999 Bulletins (SB), Service Instructions (SI) and Service Letters
2ST-004 A,532 UL,505 A,505,503 (SL)
UL,618 UL,501,462
UL,447 UL
914 UL,914 F,912
SL-914-006,SL- ULS,912 UL,912 S,912
Use of third party after-market piston kits in Rotax engines
912-006,SL- iSc SPORT,912 iS 0 - 23.07.2014
type 912 (series) and 914 (series)
912i-006 SPORT,912 iS,912 F,912
A
CANCELLED - Operators and Maintenance Manual for
SL-914-007 914 UL,914 F 0 0 01.07.2000 ROTAX 914 Series - superseded by SB-2ST-000/SB-912-
000/SB-914-000, current edition
914 UL,914 F,912 CANCELLED - Coolant for ROTAX engine type 912 and 914
SL-914-008,SL-
ULSFR,912 ULS,912 0 1 01.12.2003 (Series), superseded by SB-912-043/SB-914-029,
SB 912 043/SB 914 029, latest
912 009
912-009
UL,912 S,912 F,912 A edition

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 18 of 19
 Revision
Issue
Document
Engine Type Date Title
Type

914 UL,914 F,912

SL-914-009,SL-
ULSFR,912 ULS,912 Use of an oil thermostat for Rotax engine type 912i, 912 and
912-011,SL- 0 - 02.10.2012
UL,912 S,912 F,912 A,912 914 (Series)
912i-002
iS
914 F,912 ULSFR,912
SL-914-010,SL-
ULS,912 UL,912 S,912 Warranty conditions for ROTAX engine types 912 and 914
912-012,SL- 0 3 07.07.2016
F,912 A,582 UL,914 (Series) and 2-stroke aircraft engines
2ST-006
UL,503 UL,447 UL
914 UL,914 F,912
ULSFR,912 ULS,912
SL-914-011,SL-
UL,912 S,912 F,912 A,618 List of stolen ROTAX engines type 912 and 914 (Series) and
912-013,SL- 0 10 24.02.2017
UL,582 UL,505,503 2-stroke aircraft engines
2ST-007
UL,463,462 UL,447
UL,377 UL
914 UL,914 F,912
ULSFR,912 ULS,912
SL-914-012,SL- UL,912 S,912 F,912 A,912
Non-approved modifications or use of ROTAX unapproved
912-014,SL- iSc SPORT,912 iS
0 - 01.09.2014 engine components or accessories for ROTAX aircraft
912i-005,SL- SPORT,912 iS,618
engines
2ST-008 UL,535 C,503 UL,505,447
UL,505 A,535 B,277
UL,535 A,582 UL
914 UL,914 F,912
ULSFR,912 ULS,912
SL-914-013,SL- UL,912 S,912 F,912 A,447
Definition for propeller strike or accidental engine stoppage
912-015,SL- UL,582 UL,912 iS,618
0 - 08 03 2012 on ROTAX engine type 912 ii, 912 and 914 (Series) and 2-
08.03.2012
2ST-009,SL- UL,503 UL,535 C,535
stroke aircraft engines
912i-001 B,535 A,505,912 iSc
SPORT,912 iS
SPORT,505 A
SL-914-015,SL- 914 UL,912 ULS,912
Conditions relating to the Limited Extended Warranty for
912-017,SL- UL,912 S,912 F,912 A,912 0 1 07.07.2016
ROTAX Engine Types 912/914 Series and 912 i Series
912i-004 iS,914 F,912 ULSFR
914 UL,535 A,503 UL,912
SL-914-016,SL- S,535 C,277 UL,505
2ST-010,SL- A,912 iS,912 F,535 B,618 Language Standardization in Technical Documentation for
0 0 08.09.2016
912-018,SL-912 UL,505,912 iS ROTAX® Aircraft Engines
i-007 SPORT,912 A,447 UL,914
F,582 UL

Edition: 2017.02.24 For current valid documentation see:

File: d06386.xlsx www.flyrotax.com page 19 of 19