COMPONENT LOCATION CHART

Machine Schematic Machine Schematic SENR8332

Location Component Location Location Component Location
November 1995
C Alarm - Action D-7 18 Sender - Hydraulic (Gauge) A-7
1 Alarm - Backup F-9 19 Sender - Powertrain Oil (Gauge) A-3 1

2 Alternator A-1 16 Solenoid - Air Conditioner Clutch A-2 10 8

3 Batteries - 12 Volt F-6 20 Solenoid - Diverter Valve E-8

E Breaker - Alternator (60A) E-8 12 Solenoid - Prelube Timer D-2 A
E Breaker - Blower Motor (20A) F-7 20 Solenoid - Ripper Pin Puller C-9
E Breaker - Remote Condenser (20A) F-7 21 Solenoid - Start Aid B-2
4 Bus Bar F-2 16 Suppressor - Arc A-2 17 23
D B
C
5 Converter - Voltage F-5 16 Switch - A/C Refrigerant Pressure B-2 3
5 E 11
B Filter - Alternator B-5 C Switch - Backup Alarm D-7
18 9
E Fuses E-7,E-8 7 Switch - Blower D-6 4 15
7 13 27
B Gauge - Coolant Temp A-6 22 Switch - Coolant Temperature B-2 3
B Gauge - Fuel Level A-5 14 Switch - Disconnect F-5 14 22 6
1
B Gauge - Hydraulic Oil Temp B-5 23 Switch - Diverter Valve A-7 4 2
16
B Gauge - Powertrain Temp B-6 24 Switch - Engine Coolant Flow (EMS) B-2 25
26
6 Horn - Forward E-1 22 Switch - Engine Coolant Temperature (EMS) B-2
20 2
B Lamp - Action C-5 25 Switch - Engine Oil Pressure (EMS) B-2
D Lighter - Cigar B-7 B Switch - Flood Lamp C-5 24
12 21
B Meter - Service B-6 D Switch - Forward Horn A-7
B Monitor - Operator C-6 A Switch - Front Wiper B-7 19
7 Motor - Blower D-4,C-4 26 Switch - Fuel Pressure (EMS) B-2
7 Motor - Condenser B-9 18 Switch - Hydraulic Oil Temp (EMS) A-7
8 Motor - Front Wiper B-4 27 Switch - Hydraulic Oil Filter Press (EMS) A-9
9 Motor - Left Wiper F-5 27 Switch - Hydraulic Oil Filter Temp (EMS) A-9
10 Motor - Rear Wiper D-8 B Switch - Key Start D-5
11
12
Motor - Right Wiper
Motor - Starter (Prelube Atch)
A-6
E-2
A
C
Switch - Left Wiper
Switch - Neutral/Start
B-7
D-7 D8R Tractor
13
14
Motor - Washer Pump
Outlet - Power
A-8
B-7
12
B
Switch - Oil Pressure (Atch)
Switch - Operator Monitor Test
D-2
C-5 Electrical System
A Radio A-5 27 Switch - Powertrain Oil Filter Press (EMS) A-8
15 Receptacle - Aux Start F-2 19 Switch - Powertrain Oil Temp (EMS) A-3
7 Relay B-9 27 Switch - Powertrain Oil Filter Temp (EMS) A-8
E Relay - Main F-8 A Switch - Rear Wiper B-8 7XM1-UP
E Relay - Start F-7 A Switch - Right Wiper B-8
7 Resistor - Blower Motor Speed C-4 D Switch - Ripper Pin Puller A-8 9EM1-UP
12 Resistor - Starter Diagnostic F-1 B Switch - Running Lamp C-5
16 Sender - Coolant Temperature (Gauge) A-2 B Switch - Start Aid C-5
17 Sender - Fuel (Gauge) B-9 7 Switch - Thermostat (A/C) E-6 13
3
Machine locations are repeated for components located close together.
A = Components located in operator's compartment. 14
B = Components located in dash.
C = Components located in operator's left console. E 4
3
D = Components located in operator's right console. 9
5 4
E = Components located on relay panel. C 26
10 15 12 21
6
2
8
A 19
17 B 22 16

20 25
RESISTOR AND SOLENOID SPECIFICATIONS D
23
Component Part No. Resistance (Ohms) ¹
1 2 24
Resistor - Blower Motor Speed 9G-1950 Overall 2.0 ± .1; Tap 1.0 ± .05 11
Resistor - Starter/Diagnostic 6T-2217 150.0± 7.5
Solenoid - Air Conditioner Clutch 102-0347 14.4± 0.6
Solenoid - Diverter Valve 127-0574 31.0 ± 3.0
27
Solenoid - Ripper Pin Puller 9G-9988 24.9 1
18
Solenoid - Start Aid 3E-6332 6 7
¹At room temperature.

D39055 © 1995 Caterpillar Printed in U.S.A.

Machine Harness Connector And Component Locations All Rights Reserved

HARNESS CONNECTOR LOCATION CHART

Machine Schematic Machine Schematic Electrical Schematic Symbols And Definitions Harness And Wire Electrical Schematic Symbols
Connectors Location Harness And/Or Components Location Connectors Location Harness And/Or Components Location
A - 6Y-4522 K - 120-6547
E Diagnostic Connector F-8 6 Contacts * Prelube Timer/Solenoid D-2
RELATED ELECTRICAL SERVICE MANUALS 20 Contacts A AA 1 1
A - 6Y-4522 A - 6Y-4522
Title Form No. * Operator Monitor (EMS) C-6 D E - 6Y-4523 A-7 1 2 2
5 Contacts
Alternator (100-5047): A - 6Y-4522 A - 6Y-4522
Consist No.100-5045 SENR4130 B B - 127-5121 E-4 B M - 61-8611 A-5 Typical representation of a Typical representation of a
Consist No.100-5046 SENR2082
9 Contacts A - 6Y-4522 A - 6Y-4522 Deutsch connector. The Sure-Seal connector. The
T Receptacle
Electronic Monitoring System (EMS) SENR2945 B UU - 129-6268 E-4 B B - 127-5121 C-5 Plug plug contains all sockets plugand receptacle contain
Starting And Charging Systems SENR2947 B - 127-5121 A - 6Y-4522 Pressure Temperature Level Flow and the receptacle contains both pins and sockets.
Starting Motor: (6V-0890) B UU - 129-6268 E-5 4 H - 9N-4596 E-7 Symbol Symbol Symbol Symbol 2 all pins.
Consist No. 6V-0890 SENR3860 MM - 127-5120 A - 6Y-4522
1 NN - 9U-9463 C-7 B N - 9W-1816 E-4
8 Contacts MM - 127-5120 A - 6Y-4522
NN - 9U-9463 MM - 127-5120
Pin or Socket
1 C-8 B E-4
MM - 127-5120 A - 6Y-4522
Number
4 Contacts
* Radio A-5 * Ripper Pin Puller Solenoid C-9
A - 6Y-4522 MM - 127-5120 Wire, Cable, or Harness Component
7 Contacts 2 C - 8E-0599 C-2 * Left Wiper Motor E-5 Normally open switch that will close with an increase of a specific condition (temp-press-etc.). Assembly Identification Part Number
A - 6Y-4522 MM - 127-5120 Single Wire
2 C - 8E-0599 C-2 * Front Wiper Motor B-4 Connector
WIRE DESCRIPTION CHART A - 6Y -4522 MM - 127-5120
Wire Wire Wire Wire
3 A - 6Y-4522 F-4 * Right Wiper Motor B-6
Normally open switch that is closed due to an applied condition, and will open again with a C A A AA 9X-1123
6 Contacts
Number Color Description Number Color Description
A - 6Y-4522 NN - 9U-9463 specific decrease in that condition. 325-PK-14 1 325-PK-14
Power Distribution Circuits Monitoring Circuits (cont'd) * Voltage Converter F-4 * Rear Wiper Motor D-8
101 RD BAT 415 GN OPR MON TEST SW Machine locations are repeated for connectors located close together. Pin Socket Wire
102 BU HD LMP 424 GY OPR MON POWER TRAIN TEMP Color
* = Connector is located at the component.
105 BR KEY SW 426 BR OPR MON POWER TRAIN OIL FILTER B = Components located in dash Normally closed switch that will open with an increase of a specific condition.
108 BU AUX CKT 441 OR ENG COOLANT TEMP GAGE D = Components located in operator's right console
109 OR ALT OUTPUT (+) TERM. 442 GY HYD SYSTEM TEMP GAGE 2 200-BK-14
E = Components located on relay panel
112 PU MAIN POWER RELAY OUTPUT 443 YL POWER TRAIN TEMP GAGE
113 OR OPR MON PANEL VMIS B+ SWITCHED 449 BU SPDOM SENDER (SIGNAL NO.1) Normally closed switch that is open due to an applied condition, and will close again Circuit Number Wire
114 GN WARNING HORN (FORWARD) 499 GY OPR MON IMPLEMENT OIL FILTER with a specific decrease in that condition. Identification Gauge
116 BR AUX CKT A447 PK PRELUBE OIL PRESS
OFF MACHINE SWITCH SPECIFICATIONS
121 YL BACKUP ALARM TO LAMP Accessory Circuits
Normal
123 WH AUX CKT 500 BR WIPER - FRONT (PARK) Part No. Function Actuate Deactuate Condition The circle indicates that the component has screw terminals and a wire can be disconnected Electrical Schematic Symbols And Definitions
124 GN A/C 501 GN WIPER - FRONT (LO) 362 ± 29 mN 303 mN MIN Normally from it.
Ground Circuits 502 OR WIPER - FRONT (HI) 3E-2030 Engine Coolant Flow (EMS) (1.3 ± 0.1 oz) (1.1 oz MIN) Open
FUSE - A component in an electrical circuit that will open the circuit if too much current flows
200 BK MAIN CHASSIS 503 BR WIPER - REAR (PARK) 129.4 ± 2.8°C 118.3°C Normally
through it.
201 BK OPR MON PANEL VMIS CMS 504 YL WIPER - REAR (LO) 3T-5825 Power Train Oil Temp (EMS) (265.0 ± 5.0°F) (245.0°F) Closed
203 BK CHASSIS DIAGNOSTIC 505 BU WIPER - REAR (HI) 93.0 ± 21.0 kPa 69.0 ± 21.0 kPa Normally
6T-4949 Engine Oil Pressure (EMS) (13.5 ± 3.0 psi) (10.0 ± 3.0 psi) Open
No circle indicates that the wire cannot be disconnected from the component. REED SWITCH - A switch whose contacts are controlled by a magnet. A magnet closes the
207 BK STARTER DIAGNOSTIC 510 YL WASHER - PRIMER contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
107.2 ± 2.8°C 91.0°C MIN Normally
Basic Machine Circuits 513 OR A/C COMPRESSOR/REFRIGERANT PRESS. SW
7N-9785 Engine Coolant Temp (EMS) (225.0 ± 5.0°F) (196.0°F MIN) Closed
301 BU STARTER NO.1 SOL 515 GY BLOWER MOTOR (HI)
37.8 ± 2.8°C 26.7°C MIN Normally
302 OR STARTER NO.1 RESISTOR TO DIAGNOSTIC 516 GN BLOWER MOTOR (MEDIUM) 8C-3569 Hydraulic Oil Filter Temp (EMS) (100.0 ± 5.0°F) (81.0°F) Closed SENDER - A component that is used with a temperature or pressure gauge. The sender
304 WH STARTER RELAY NO.1 OUTPUT 517 BU BLOWER MOTOR (LO) 37.8 ± 2.8°C 26.7°C MIN Normally measures the temperature or pressure. Its resistance changes to give an indication to the
306 GN STARTER RELAY COIL TO NEUT START SW OR KEY SW 521 YL A/C SW TO REFRIGERANT SW 8N-1693 Engine Coolant Temp (St Aid) (100.0± 5.0°F) (80.0°F) Closed This indicates that the component has a wire connected to it that is connected to ground. T gauge of the temperature or pressure.
307 OR KEY SW TO NEUT START SW OR VMIS SENSOR MODULE 522 WH A/C CLUTCH TO THERMOSTAT SW 101.7 ± 2.8°C 93.3°C MIN Normally
308 YL MAIN POWER RELAY COIL 523 BR WIPER - LEFT (PARK) 8N-2248 Hydraulic Oil Temp (EMS) (215.0 ± 5.0°F) (200.0°F MIN) Closed
310 PU START AID SW TO START AID SOL 524 BU WIPER - LEFT (LO) 51.7±2.8°C 43.0°C MIN Normally RELAY (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
311 WH START AID SOL TO TEMP SW 525 GY WIPER. LEFT (HI) 9G-3341 Power Train Oil Filter Temp (EMS) (125.0± 5.0°F) (110.0°F MIN) Closed It has a coil that makes an electromagnet when current flows through it. The electromagnet
321 BR BCKP ALARM LAMP TRAVEL ALARM 526 YL WIPER - RIGHT (PARK) 93.0 ± 21.0 kPa 69.0 ± 21.0 kPa Normally This indicates that the component does not have a wire connected to ground. It is grounded can open or close the switch part of the relay.
322 GY WARNING HORN (FORWARD) 527 GN WIPER. RIGHT (LO) 9W-3187 Fuel Pressure (EMS) (13.5 ± 3.0 psi) (10.0± 3.0 psi) Closed by being fastened to the machine.
528 PK WIPER - RIGHT (HI)
Hydraulic Oil Filter/ 210 ± 70 kPa _ Normally
Monitoring Circuits CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will open the circuit if too
9X-7781 Power Train Filter Pressure (EMS) (30± 10 psi) -- Open
403 GN ALTERNATOR (R)TERM. 600 BR DASH LAMP BASIC much current flows through it. This does not destroy the circuit breaker and it can be reset to
30 ± 7 kPa 30± 7 kPa Normally
404 YL OPR MON HYD OIL TEMP 608 GN FLOOD LAMP - REAR
105-9152 Oil Pressure (Atch) (4.3± 1.0 psi) (4.3 ± 1.0 psi) Closed become part of the circuit again.
405 GY OPR MON OIL PRESS. (LO SETTING) 609 YL FLOOD LAMP - SIDE
275 to 1750 kPa¹ _ Normally
406 PU OPR MON COOLANT TEMP 610 OR HEAD LAMP BASIC (40 to 255 psi) -- Open ² SOLENOID - A solenoid is an electrical component that is activated by electricity. It has a coil
114-5334 Refrigerant Pressure (AC)
410 WH OPR MON FAULT ALARM 779 WH COUPLER ENGAGE SOL ¹ A hysteresis band exists: with increasing pressure the closed condition can be maintained up to 2800 kPa (405 psi), with decreasing pressure the closed that makes an electromagnet when current flows through it. The electromagnet can open or
411 PK OPR MON MASTER FAULT LAMP 780 PU COUPLER DISENGAGE SOL condition can be maintained down to 170 kPa (25psi). close a valve or move a piece of metal that can do work.
412 BU OPR MON COOLANT FLOW 978 GN CST AUTOSHIFT - SLOW MODE SW 1 ² Contact postion at the contacts of the harness connector.
413 BR OPR MON FUEL PRESS. 987 WH DIVERTER SOL MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
activated by electricity and held latch by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
 9 8 7 6 5 4 3 2 1

FLOOD LAMP FLOOD LAMP MAIN RELAY RD-00 RD-00 RD-00

FLOOD LAMP 106-8964 106-8964 3T-0376 BK-00 BK-00
107-6689 TT
112-PU 112-PU-14 3 200-BK
RR RR NOTE: PLUG REQUIRED ONLY WIRES THAT HAVE BATTERY VOLTAGE
112-PU-14 AA BB BB CC 6 200-BK
W A WITH 24V RADIOS. REMOVE WHEN THE KEY SWITCH IS OFF.
POS NEG POS NEG 201-BK 1 102-RD
A CC A PLUG AND INSTALL CONVERTER
109-RD-4 2 116-BR WIRES THAT HAVE BATTERY VOLTAGE
FOR 12V RADIOS. WHEN THE KEY SWITCH IS ON.

RD-00

BK-00
109-RD-4 4 A513-PK-18
TT SS 12V BATTERY 12V BATTERY L11
FRONT FACING FLOODS A 112-PU-14 158-BR-14 DISCONNECT SW 5 592-BU-18 STARTING CIRCUIT.
A 3T-5760 3T-5760

608-GN-14
20A

200-BK-14
MAY BE 107-6689 OR 308-YL 7N-0718
A A
9X-7164 DEPENDING ON GUAGE CIRCUIT.

608-GN-14
200-BK-14
REMOTE CONDENSER BK-00 203-BK
LIGHTING ARRANGEMENT AA CC
BREAKER 3T-8728 Z Z 203-BK EMS CIRCUIT.
308-YL POS NEG POS NEG 12V BATTERY GROUND 3 200-BK FLOOD
12V BATTERY

BK-00
RR S L42 LAMP PANEL LAMP CIRCUIT.
L42
12 112-PU 3T-5760 3T-5760 GROUND 6 109-RD-4
W 24V TO 12V A R 112-9378 WIPER/WASHER CIRCUIT.
8 308-YL 304-WH 109-RD-4 +24 V BATTERY IN 1 302-OR R
DD CONVERTER
2 302-OR 308-YL +24 V SWITCHED IN 2 207-BK 1 609-YL-14 1 WH-18 HEATER AND AIR CONDITIONER CIRCUIT.
FLOOD LAMP FLOOD LAMP A A 119-1733
F 3 203-BK
L42
112-PU-14
20A
124-GN-14 203-BK
NOTE D
+12 V MEMORY OUT 4 304-WH-8 200-BK 2 200-BK-14 2 BK-18
GROUND CIRCUIT.
F
FLOOD LAMP 106-8964 106-8964 FRAME

200-BK
7 207-BK 311-WH +12 V SWITCHED OUT 5 101-RD-4

608-GN-14
200-BK-14
A A L42 L42
106-8964 10 310-PU 109-RD-4 304-WH-8 BLOWER MOTOR 310-PU 410-WH-18 START AID CIRCUIT.
A
608-GN-14

BREAKER

112-PU
112-PU
112-PU
112-PU
112-PU
200-BK-14

608-GN-14 11 311-WH 302-OR 311-WH L11

L38 L38 START 3T-8728 L11
200-BK-14 4 304-WH A 207-BK 158-BR-14 310-PU

DIAGNOSTIC CONNECTOR
L20 L20 L10 L10 ALL DASHED LINES ARE ATTACHMENTS.
13 2 BK-18 RELAY 124-GN-14 521-YL-14 124-GN-14

RD-00
AUX START
14 1 BK-18 118-3534 304-WH-8 201-BK-18
L39 L39 RECEPTACLE
15 200-BK 123-WH
L41 HH AA BUS BAR

609-YL-14
6 306-GN 306-GN 200-BK-14 114-RD
L37

L37 9W-0742

200-BK
16 200-BK-14 200-BK-14 121-RD RD-00
17 200-BK-14 200-BK 321-BR

BK-00
FF
5 105-RD 200-BK 200-BK 113-OR
K
18 200-BK 200-BK OPERATOR STATION 200-BK-14
L38 L41 D
KK KK A 19 200-BK 105-RD HARNESS B AND HARNESS A. 129-BU 200-BK-14
BK-14 2 20 105-RD 200-BK 102-RD L 200-BK
BK/PK-14 1 1 105-RD 102-RD MM 200-BK 101-RD-4
KK RESISTOR
9 102-RD 101-RD-4 200-BK-18 BK MOTOR H 116-BR 610-OR-14
BACKUP ALARM KEY A LEFT 6T-2217
102-RD 116-BR UU UU 102-RD
A
3T-1815 FUSE WIPER

121-RD
T STARTER HEAD

321-BR
101-RD-4 113-OR 524-BU-18 1 GN 9 609-YL-14 9 102-RD

RD-00
L19 L19 L10

10A
3K-8782 7X-6112 6V-0890 STD LAMP
200-BK 123-WH 108-BU 3 GY 7 310-PU 7 102-RD
124-9780 106-8964
109-RD-4 116-BR 523-BR-18 4 BR 5 608-GN-14 5 116-BR

101-RD-4
A L12 ATCH PRELUBE

102-RD
102-RD
101-RD 20A SPARE 108-BU 525-GY-18 2 OR 4 610-OR-14 4 105-RD

2
1
FRONT D
129-BU MM 3 308-YL 3 308-YL LL 200-BK-14
DASH A A A
GN 112-PU 15A SIDE & REAR FLOOD LAMPS 116-BR 114-RD 2 105-RD 2 307-OR 304-WH-8
A

410-WH-18
DOME

302-OR
124-GN-14

301-BU
201-BK-18

200-BK-14
101-RD

304-WH-8
GN RADIO 116-BR 121-RD 515-GY-14 1 102-RD 1 108-BU

109-RD-4

101-RD-4
FUSE A A G S

311-WH

123-WH
A

113-OR

302-OR
109-RD

101-RD

121-RD
114-RD
310-PU

321-BR

129-BU
200-BK

207-BK
ALT 112-PU 10A OPERATOR MONITOR 113-OR 410-WH-18 L45 515-GY-14 8 116-BR 116-BR 8 200-BK 610-OR-14
DIVERTER 3K-8782 STD L43 L45
201-BK-18 516-GN-14 6 307-OR 337-WH 6 200-BK-14 FORWARD
BREAKER 8M-8948 ATCH L16 L16 L20

10A
VALVE SOL L41 A A L20 A MTR BAT FF HORN HEAD
2
1

9S-0173 112-PU 10A GAGES & SERVICE METER 123-WH 321-BR 517-BU-14 337-WH L8 101-RD-4 301-BU
X 127-0574 L44 L49 L49 7T-0970 LAMP
A A 307-OR 521-YL-14 116-BR 301-BU-4 301-BU-4 A
A A 106-8964
101-RD 112-PU 15A WIPER MOTORS 108-BU 124-GN-14 307-OR 200-BK K
60A MOTOR TIE UNUSED
A MM A

L9
101-RD-4 522-WH-14
A A WIRES BACK

L11
112-PU 15A CIGAR LIGHTER 129-BU 200-BK-14 592-BU-18 2 592-BU-18 L11 TO HARNESS

322-GY-14
200-BK-14
U 109-RD-4 L22 A513-PK-18 3 A513-PK-18
A A L22 K
987-WH

JJ
201-BK

109-RD-4 109-RD 10A FORWARD HORN 114-RD 102-RD-18 1 102-RD UU K 200-BK

E 109-RD 108-BU 4 108-BU L49 A 116-BR L7 BK-00 FORWARD E
A A L7 EE A D
109-RD 109-RD 10A BACK-UP ALARM 121-RD TO GAGE B 307-OR HORN
X B PANEL

2
1
L12
200-BK 102-RD-14 1 102-RD C 337-WH 7T-0969
U FUSE HOLDER FUSE MOUNTING L12 LL
2
1

105-RD 2 105-RD

101-RD-4
A PANEL LL

522-WH-14
BOLT

610-OR-14
4K-5122 NOTE C

200-BK-14
RIPPER

200-BK-14

207-BK
308-YL 3 308-YL
LAMP

BK-6
L37

L38

L39

FLOOD RELAY PANEL 307-OR 6 307-OR

L21
LAMP
OPERATOR STATION B B 7N-9967 L21
116-BR-14 8 116-BR
107-6689 BASE A EE JJ
610-OR-14 4 610-OR-14 310-PU 200-BK-4
L43 N N 7G-9730 608-GN-14 5 608-GN-14 610-OR-14
987-WH
121-RD

ENG
321-BR

600-BR
200-BK

200-BK
L43
310-PU 7 310-PU 609-YL-14
608-GN-14

608-GN-14

608-GN-14

FRAME BLOCK
200-BK-14

200-BK-14

200-BK-14

509-WH-18 - H A T 609-YL-14 9 609-YL-14 608-GN-14

508-PU-18 + 1 200-BK
L45 B A
608-GN-14

NN THERMOSTAT
200-BK-14

2 306-GN
L44 SW
3 307-OR
LEFT L44 3E-5465
4 321-BR OPERATOR STATION 304-WH-8

L15
410-WH-18
SPEAKER

201-BK-18
N A L9 207-BK
U 6T-7695 L9
W RR 124-GN-14 1 124-GN-14 124-GN-14 101-RD-4
S L15

516-GN-14

124-GN-14
515-GY-14
515-GY-14
517-BU-14

521-YL-14
DOME LAMP
2
1

307-OR 521-YL-14 2 521-YL-14 522-WH-14 302-OR

A 8C-9678
1
2

1
2

1
2

A 321-BR L16 522-WH-14 4 522-WH-14 521-YL-14 109-RD-4

A
608-GN-14
200-BK-14
608-GN-14

608-GN-14

608-GN-14
200-BK-14

200-BK-14

200-BK 200-BK-14 3 200-BK-14

1
2
608-GN-14

200-BK
200-BK-14

521-YL-14
3 WH-18 306-GN H 517-BU-14

610-OR-14
200-BK-14
987-WH
121-RD

A C
321-BR
200-BK

102-RD-18 1 RD-18 516-GN-14

L27 N 1 KEY START L8
200-BK-18 2 BK-18 515-GY-14 109-RD-4 109-RD-4

RD
BK
H N 2 SW
MM 515-GY-14 L8
SS RED 9G-7641
987-WH BACK UP
L35

L34

200-BK-14
BLK
L36

L35 N

522-WH-14

410-WH-18
608-GN-14
610-OR-14
200-BK-14

200-BK-12

200-BK-12

201-BK-18

200-BK-14
521-YL-14

609-YL-14
321-BR ALARM SW 515-GY-14

OFF
L27 BLU L21

ST
L36 L27 N 5

311-WH

123-WH
ON
306-GN

307-OR

610-OR-14
113-OR

322-GY-14
114-RD

121-RD
310-PU

321-BR

129-BU

200-BK-14
200-BK

200-BK
121-RD 9N-1750 515-GY-14
N 4 GRN

L1
608-GN-14 L19 516-GN-14 200-BK
3 OR L17

C
N

S
B

301-BU-4
517-BU-14

101-RD-4
L33 H H B B
200-BK-12 B 200-BK-14

200-BK
L LL
FOR ATCH FLOOD 200-BK ACTION 200-BK-14
NN

608-GN-14

610-OR-14
ALARM

102-RD-14
116-BR-14
LAMPS REPLACE

3
1
2
609-YL-14
200-BK BK MOTOR H
9G-9813 C

307-OR

307-OR
105-RD

105-RD
HARNESS S BLOWER SW BLOWER

310-PU
308-YL
308-YL

308-YL
200-BK NEUTRAL/ MOTOR
6P-3236 9G-8697 L20 L20

525-GY-18
524-BU-18
523-BR-18
WITH HARNESS RR T REAR

200-BK-18

610-OR-14
START SW

200-BK-14
447-PK-18
OR HARNESS W WIPER

108-BU
9N-1750

322-GY
779-WH
9X-3392 K
D
509-WH-18
200-BK

508-PU-18

780-PU K

200-BK-14
200-BK-14
200-BK

L17 307-OR 3
337-WH 5

BK-14
L49
A
779-WH

L7

WH/RD-14
780-PU
200-BK
200-BK

108-BU 108-BU 116-BR 1

GN

OR
GY
BR
2
1
3

L27
200-BK-18 A447-PK 4
QQ

L46
L27 START K
102-RD-18 200-BK 2
1
3
4
2

L22 L22 AID SW A A

200-BK-18
447-PK-18

108-BU 108-BU 200-BK-12 200-BK-12 6

L2
D NN 108-BU 592-BU-18
3T-3453 A A
200-BK 200-BK K
L24 L26 L26 A A

1
2
108-BU A513-PK-18 200-BK-4 200-BK-4 PRELUBE TIMER/SOL 200-BK 2 BK-18

101-RD-4
B L49 SS
108-BU N 200-BK-14 125-6539 A447-PK 1 BK-18
B

515-GY-14
503-BR-18
505-BU-18

200-BK-14
504-YL-18

108-BU
108-BU

200-BK
201-BK
OIL PRESS
L46 L46 MODULE SW
105-9152
L40

L18

ABBREV COLOR
200-BK-14
200-BK-18 200-BK 515-GY-14 515-GY-14 RD RED
OPERATOR N
200-BK-18 515-GY-14 WH WHITE
L26 MONITOR L17
592-BU-18 A B 516-GN-14 516-GN-14 OR ORANGE
L26 3T-9100

L20
A513-PK-18 1 200-BK 517-BU-14 YL YELLOW

410-WH-18

522-WH-14
L24

608-GN-14

610-OR-14
201-BK-18

200-BK-12

200-BK-14
521-YL-14

609-YL-14

609-YL-14
415-GN-18

OPERATOR STATION
108-BU TEST 15 415-GN-18 201-BK-18 4 201-BK 200-BK-14 PK PINK
L24 N
779-WH

123-WH

311-WH
113-OR

114-RD

121-RD
780-PU

129-BU

321-BR

310-PU
200-BK
200-BK

200-BK
200-BK
108-BU LAMP 11 411-PK-18 411-PK-18 411-PK-18 3 411-PK 517-BU-14 BK BLACK
512-GN-18 ALARM 10 410-WH-18 415-GN-18 2 415-GN RESISTOR GY GRAY
L25 L25 L13 9G-1950
511-BR-18 +BATTERY 1 113-OR PU PURPLE

200-BK-18
200-BK-18

200-BK-18
200-BK-18
A

521-YL-14
158-BR-14
A C

200-BK-14
509-WH-18 COOL FLOW 12 412-BU-18 BR BROWN
1
4
3
2

508-PU-18 PWR TN FLTR 19 426-BR-18 OPERATOR 6 200-BK-14 610-OR-14 GN GREEN

L2
L2
MONITOR

415-GN

515-GY-14
201-BK-18

200-BK-14
411-PK

201-BK
500-BR-18 ALTERNATOR 3 403-GN-18

L5
1 521-YL-14 322-GY BU BLUE
GN-18

GN-18

TEST SW
BK-18
BK-18

501-GN-18 ENG OIL PR 5 405-GY-18 2 311-WH 200-BK-14

7N8001 ACTION
502-OR-18 FUEL PR 13 413-BR-18 L15 3 310-PU 200-BK
L14 B LAMP SYMBOL DESCRIPTION

L6
200-BK-18 COOL TEMP 6 406-PU-18 7N-1996 4 522-WH-14 521-YL-14
C PWR TN TEMP 7 424-GY-18
B B B N 7 610-OR-14 522-WH-14 BLADE, SPADE, RING, C

L1
BASE L1

1
2
HYD TEMP 4 404-YL-18 201-BK 5 322-GY 310-PU OR SCREW TERMINAL
3T-0304 L6
HYD FILTER 17 499-GY 311-WH
CIRCUIT CONNECTED

WH/RD-14
14
RIPPER FLOOD

200-BK-18
L25

9
L46

PIN PULLER LAMP SW

200-BK

BK-14
GROUND 2 123-WH CIRCUIT NOT CONNECTED
SOLENOID 3T-1730
8 113-OR 406-PU-18 2 406-PU 406-PU
9G-9988
18 201-BK-18 441-OR-18 3 441-OR 441-OR ELECTRICAL CONNECTION
B B L3 L3
MM 20 116-BR-14 609-YL-14 410-WH-18 403-GN-18 5 403-GN 403-GN TO VEHICLE STRUCTURE

L4
L36 L49
16 116-BR-14 608-GN-14 403-GN-18 412-BU-18 7 412-BU 412-BU
527-GN-18

B B INTERNAL ELECTRICAL
509-WH-18

528-PK-18

L35
526-YL-18
527-GN-18

512-GN-18

501-GN-18
502-OR-18
525-GY-18
511-BR-18

508-PU-18

523-BR-18
524-BU-18

500-BR-18

ROOF BLOWER
528-PK-18
510-YL-18
526-YL-18

200-BK-18

A 412-BU-18 201-BK-18 6 201-BK 201-BK

L34 MOTOR CONNECTION TO SURFACE
108-BU

610-OR-14
9G-8693
108-BU

201-BK-18
201-BK-18
201-BK-18
201-BK-18
201-BK-18
201-BK-18
201-BK-18
201-BK-18
L40

116-BR-14 441-OR-18 413-BR-18 1 413-BR 201-BK

109-RD-4
L4
L40 L4 OF COMPONENT
CONDENSOR

201-BK-18

200-BK
102-RD-14 406-PU-18 405-GY-18 4 405-GY
MOTOR CONNECTOR
VV 106-2721 PANEL 201-BK-18 A C
593-GN-14 2 WH/RD-14 MM MM LAMP 405-GY-18
5
7
8
3
2
1
4
6

2
7
6
5
4
1
3
8

RUNNING 7N-9967 ATCH WIRE, CABLE,

405-GY
413-BR
201-BK
201-BK
200-BK-14 1 BK-14 413-BR-18 START AID
NN NN LAMP SW BASE L18 COMPONENT
404-YL-18 SOLENOID
L23

7N-8005 L5
200-BK

7G-9730 3E-6332 CIRCUIT GROUPING

OPERATOR STATION

B 442-GY-18 L#
CONDENSOR 600-BR 201-BK-18 DESIGNATION
MOTOR B 2 1 B B
VV 106-2721 200-BK 511-BR-18 102-RD-14 426-BR-18 IDENT PART NO. CHG LOC NOTE
593-GN-14 2 WH/RD-14 508-PU-18 512-GN-18 499-GY
4 B

410-WH-18

403-GN-18
403-GN-18
441-OR-18
405-GY-18

424-GY-18

442-GY-18
426-BR-18
412-BU-18

413-BR-18
406-PU-18
HARNESS AS.

201-BK-18
201-BK-18

201-BK-18

201-BK-18
201-BK-18
201-BK-18
201-BK-18

447-PK-18
404-YL-18

443-YL-18
200-BK-14 1 BK-14 509-WH-18 200-BK 610-OR-14 447-PK-18
L13 L13 B5

123-WH
113-OR

499-GY
A 6Y-4522 16 C-6 STD

201-BK
511-BR-18 508-PU-18 102-RD-14 201-BK-18
A 1Q-3512 04 C-6 ATCH

WH-18
200-BK-14 512-GN-18 509-WH-18 FRONT 443-YL-18

PU-18
L23 L23

610-OR
200-BK-14 WIPER 424-GY-18 B 127-5121 00 C-5
RELAY VV VV POWER 9X-3392 C 8E-0599 07 C-2
600-BR
OUTLET L15 L15 D 1Q-3237 01 B-1/E-1 ATCH
3E-5239 200-BK
VV L
A 102-9235 L14 L14 D 1Q-3275 02 B-1/E-1 ATCH
593-GN-14

2
1
L48
VV C E 6Y-4523 03 A-7
MOTOR H

L18
593-GN-14 200-BK 2 201-BK 403-GN-18
L28
501-GN-18
502-OR-18
525-GY-18
523-BR-18
524-BU-18

500-BR-18

311-WH
527-GN-18

310-PU
526-YL-18
158-BR-14

F 9W-9873 00 A-3
521-YL-14

528-PK-18
200-BK-14

510-YL-18
512-GN-18
511-BR-18

129-BU 129-BU 1 403-GN-18 201-BK FUEL

L1
SERVICE L18 L48

405-GY
ALTERNATOR T PRESSURE H 9N-4596 01 E-7
108-BU

413-BR
201-BK

201-BK
A 200-BK 200-BK L3
METER FILTER SWITCH
129-BU COOLANT K 120-6547 03 D-2 ATCH
108-8357 100-5052 L5 9W-3187 TEMPERATURE SW L 6Y-4207 02 B-8 ATCH
510-YL-18

200-BK
VV C 8N-1693
503-BR-18

505-BU-18

FUEL M 6I-8611 00 A-5

504-YL-18

GR-18 SIGNAL GR-18 3 403-GN-18 LH SPEAKER (-) WH/BK, GN/BK-18 1 509-WH-18 C

L28 L28 C C

522-WH-14
C
A
B

SENDER CIGAR N 9W-1816 03 D-4 ATCH

108-BU

B B

2
1

521-YL-14
S BK-18 GROUND BK-18 1 200-BK LH SPEAKER (+) WH/GN-18 2 508-PU-18 311-WH
NN

BK
SS

311-WH
GN

OR
C

GY

610-OR-14
LIGHTER

441-OR
403-GN
BR
118-0690 R 116-6774 01 A-2/F-2

310-PU

406-PU

412-BU

200-BK-14
200-BK

201-BK
201-BK
- - BR-18 +BATTERY BR-18 2 123-WH B +24 VOLT RD-18 4 108-BU T 311-WH
MM 9W-0335
158-BR-14

BK-18
BK-18
200-BK-14

+
521-YL-14

QQ + S 8E-1631 01 E-9
A 5 A513-PK-18
1
2

L40 L23 MM
Q

608-GN-14
442-GY-18

426-BR-18
U 8E-3560 01 E-9 ATCH

447-PK-18

201-BK-18

200-BK-12
404-YL-18

609-YL-14
1

4
3

2
447-PK-18 1 PK-18 6 592-BU-18
Y

610-OR-18

499-GY

121-RD

114-RD

322-GY
RIGHT W 126-9200 00 E-9 NOTE E

129-BU

321-BR
200-BK
200-BK

200-BK
200-BK
200-BK-18 2 BK-18 GROUND BK-18 3 200-BK-18 MM LL
SPEAKER NN NN NN NN Y 6Y-1200 00 B-8 ATCH
200-BK
523-BR-18

RH SPEAKER (+) GY/VI-18 8 511-BR-18

501-GN-18

502-OR-18
500-BR-18
6T-7695
L

LL 6Y-2510 01 D-1

1
2
123-WH-18 123-WH-18 RH SPEAKER (-) GY/BK, VI/BK-18 7 512-GN-18 521-YL-14

108-BU
L34 D MM 127-5120 00 B-7 ATCH
123-WH-18 123-WH-18 ANTENNA MM 522-WH-14
L34

200-BK-18
NN 9U-9463 01 B-7 ATCH
510-YL-14

610-OR-18 406-PU
527-GN-18
200-BK-18

528-PK-18
526-YL-18

L6 L6 ENGINE COOLANT QQ 6I-8612 01 D-9

P W

B B

P W

B B

P W

B B

P W

B B
L33

610-OR-18

L32
NN L6
108-BU

L35 NN NN NN NN POWER TRAIN L6 ENGINE TEMPERATURE SW

24 VOLT RADIO RR 1Q-3121 02 E-9 ATCH
L36

L35 L33 TEMP HYDRAULIC OIL OIL PRESS 7N-9785

NOTE D A/C REFRIGERANT SWITCH SS 117-8314 00 B-9 ATCH
Y 4W-0485 TEMP
608-GN-14

610-OR-18
PRESSURE SWITCH TT 110-2982 00 F-7 ATCH
610-OR-18
200-BK-14

MM 6T-4949 201-BK
1
2

4W-1129 NOTE A C C
REAR WIPER SW RIGHT WIPER SW LEFT WIPER SW FRONT WIPER SW MM 123-WH-18 123-WH-18 UU 129-6268 00 E-3 ATCH

BK-18
T
1
3
4
2

L M M 114-5334

610-OR-18
3T-6655 3T-6655 3T-6655 3T-6655 LH SPEAKER (-) WH/BK, GN/BK-18 1 509-WH-18 C ENGINE VV 123-8329 00 B-9 ATCH
608-GN-14

IGN IGN COOLANT

200-BK-14

108-BU 108-BU 108-BU LH SPEAKER (+) WH/GN-18 2 508-PU-18 BK-18 1 521-YL-14

GN

OR
GY
BR

BK-18
BK

S M Q M Q 2 3
608-GN-14

FLOW SW WIRE AS.

447-PK-18
200-BK-12

4 108-BU 1 BK-18 2 513-OR-14 C

SEND SEND TIE UNUSED
779-WH
987-WH

3E-2030
121-RD

G 4D-6565 A-1 STD

321-BR

780-PU
200-BK
200-BK

200-BK

510-YL-18 510-YL-18 510-YL-18 +12 VOLT MEMORY YL-18 5 A513-PK-18 2 201-BK 01

DIVERTER WIRES BACK G 1Q-2807 01 A-1 ATCH
510-YL-18 +12 VOLT RD-18 6 592-BU-18 1 412-BU
510-YL-14

RR GRD GRD TO HARNESS

FLOOD LAMP 108-BU 108-BU VALVE RIGHT LAMP GROUND BK-18 3 200-BK-18 ANTENNA P 6Y-9377 01 A-9
443-YL-18

109-RD-4
106-8964 L28 L28 SWITCH AS. WIPER M LAMP M 8E-1118 Q 6I-8609 B-4
7X-2058 RH SPEAKER (+) GY/VI-18 8 511-BR-18 COOLANT 00
7X-1751 D
610-OR-18

7X-2058
442-GY-18

200-BK 3E-0306 MOTOR RH SPEAKER (-) GY/BK, VI/BK-18 7 512-GN-18 C TEMPERATURE 441-OR 610-OR-14 T 3T-1480 03 A-8
A A
200-BK-18
A 1 2 A
200-BK-18

424-GY-18
FLOOD LAMP RIPPER PIN FORWARD SENDER C X 8E-4863 E-9

2
1
201-BK-18
443-YL-18
00
L31

L L H ANTENNA MM
L30

MOTOR PULLER SW A 3 HORN SW L29 L48 6N-5926 T

106-8964 200-BK-14 987-WH 2 BK-18 T JJ 9F-4337 07 E-2
L 6T-6970 3T-2357 L FUEL LEVEL KK 9G-6259 02 E-9
WASHER 114-RD 1 BK-18 403-GN 200-BK-14
608-GN-14

9X-3496
114-RD

114-RD

322-GY

12 VOLT RADIO ARC SUPRESSOR HEAD

200-BK-14

PUMP A PP PP A
123-WH-18 123-WH-18 NOTE D 3E-9169 ALT LAMP CABLE AS.
7T-8891 C
M LAMP M POWERTRAIN 106-8964 Z 8E-5909 F-6

2
3
1
123-WH R + 00
IGN 7X-2058 IGN F OIL TEMP SW C AA 8E-5907 F-6
00
L36

OPERATOR STATION

A513-PK-18
RR RR M M Q 3T-5825

509-WH-18
D

512-GN-18

501-GN-18
502-OR-18
592-BU-18

511-BR-18

508-PU-18

500-BR-18
ALTERNATOR 100-5047 BB 3P-2179 F-6

2
1
200-BK-18
200-BK-18
200-BK-18

200-BK-18

200-BK-18
200-BK 610-OR-18 M A G 610-OR-14 03
L28

L28 SEND Q SEND F ATCH 3E-7577 G

CC 8E-5908 F-5

108-BU

108-BU
780-PU 129-BU 123-WH-18 4 123-WH 201-BK 00
L30 L30

L48

GN-14
GN-14
779-WH 322-GY 442-GY-18 1 442-GY-18 F AIR DD 6T-9661 00 F-5
L29 GRD GRD L48 T G
FLOOD LAMP FLOOD LAMP CONDITIONER EE 2V-6166 F-2
441-OR-18

01
443-YL-18

200-BK 114-RD LAMP 443-YL-18 2 443-YL-18 BK-6 200-BK-14

608-GN-14

M M
200-BK-14

106-8964 106-8964 L29 7X-2058 CLUTCH SOL HEAD FF 9W-2531 00 E-2

987-WH 114-RD 200-BK 441-OR-18 3 441-OR-18 424-GY
102-0347 LAMP HH 6I-9412 00 F-2
A 114-RD 114-RD 608-GN-14 COOLANT 447-PK-18 5 447-PK-18 G BK-4 A
L6 L6 L31 L31 POWERTRAIN 106-8964 PP 9U-8746 01 A-3 ATCH

L13
321-BR TEMP 447-PK-18
OIL SENDER
121-RD 4W-0483 442-GY-18 200-BK-18
W L32 L32 8N-3844 R
BK 1 499-GY 499-GY 447-PK-18 200-BK-18 609-YL-14 1 609-YL-14 1 WH-18 FLOOD
M LAMP
BK 2 201-BK 200-BK-12 441-OR-18 443-YL 200-BK 2 200-BK-14 2 BK-18
POWERTRAIN F 112-9378
T E BK 2 426-BR HYDRAULIC E 443-YL-18 A R
OIL FILTER T T
FLOOD LAMP HYDRAULIC OIL BK 1 201-BK 200-BK GAGE THIS DIAGRAM IS FOR THE D8R TRACTOR (105-9792 CHG 00)
TEMP SW SENDER
106-8964 FILTER TEMP SW 9G-3341 T MTG BOLT NOTE D: 24 TO 12 VOLT CONVERTER NOT REQUIRED WITH SEPARATE IMPLEMENT & STEERING PUMPS.
T T E 8N-3844 T L13 L13
FRONT FACING 8C-3569 499-GY 2 499-GY WITH 24 VOLT RADIO
FLOODS MAY BE RADIO OPTIONS COMPONENTS ARE SHOWN INSTALLED ON A FULLY
608-GN-14

POWERTRAIN 442-GY 1 442-GY-18 442-GY-18

200-BK-14

107-6689 OR P P T T E OPERABLE MACHINE WITH THE KEY AND ENGINE OFF

OIL FILTER 12 VOLT RADIOS 24 VOLT RADIOS
201-BK
201-BK

9X-7164 DEPENDING BK 1 499-GY BK 1 201-BK HYDRAULIC 404-YL 5 404-YL-18 404-YL-18 OPERATOR STATION
3E-7140 FIXED U.S. 9X-6810 FIXED U.S. AND XMSN SHIFTER IN NEUTRAL

L32
ON LIGHTING BK 2 201-BK PRESS SW BK 2 426-BR OIL TEMP SW 201-BK 4 201-BK-18 201-BK-18
ARRANGEMENT 8N-2248 T L32 3E-7141 REMOVEABLE U.S. 9X-6778 REMOVEABLE U.S. UNLESS OTHERWISE SPECIFIED: ALL WIRE IS 16 GAGE
NOTE B
P E T E 426-BR 3 426-BR-18 426-BR-18 L32 3E-6107 FIXED EUROPE 3E-7890 FIXED EUROPE
W 9X-7781 NOTE A: NORMALLY OPEN BEFORE REFRIGERANT CHARGE
E A 3E-6106 REMOVEABLE EUROPE 9X-5288 REMOVEABLE EUROPE NOTE B: NORMALLY OPEN BEFORE INSTALLATION
HYDRAULIC OIL 426-BR
FILTER PRESS SW NOTE E: BOTH ARE ATTACHMENT HARNESSES. 1Q-2996 IS FOR NOTE C: FUSES 10A - 3K-8782, 15A - 8M-8948,
201-BK 20A - 8M-0456
FLOOD LAMP 9X-7781 201-BK 201-BK TWO FLOODS IN FENDER, AND TWO ON ROPS STRUCTURE.
L6 L6 126-9200 IS FOR BOTH FLOODS ON ROPS STRUCTURE.
107-6689 L6 D39000
9 8 7 6 5 4 3 2 1