PIPER AZTEC SERVICE MANUAL

TABLE II-II. CONSUMABLE MATERIALS (cont.)

Material Specification Product Manufacturer

Thread Lubricant, MIL-PRF-907E Kopr-Kote Jet Lube, Inc.
Oleo Stru, Air Valve P.O. Box 21258
Houston, TX 77226-1258
1-800-538-5823
www.jetlube.com
Wax, Simonize * See Note 1
Wire, Safety MS20995-C32 * See Note 1
MS20995-F32
MS20995-F20
MS20995-C20
MS-20995-C41
MS-20995-NC32

NOTES: 1. Purchase locally.

2. Available in small quantities.

2-6. ACCESS AND INSPECTION PROVISIONS.

The access and inspection provisions for the airplane are shown in Figures 2-6a, 2-7 and 2-8. The
component to be serviced or inspected through each opening is assigned an index number to identify it
in illustration. All access plates and panels are secured by either metal fasteners or screws. To enter the
aft section of the fuselage, remove the rear baggage compartment upholstery panel by removing the
attaching screws.

II - HANDLING AND SERVICING 01/01/09

1B24
 PIPER AZTEC SERVICE MANUAL

C169

20370 ACCESS HOLE 17318 ACCESS HOLE

COVER PLATE COVER l=lt..ATE
AN 426 A03-4

,
/-----r------, . . ♦
00 REQl

,
/ '' ' ,,----- ----=;_,,,,.~--------~~-
,, ' , -o,
I
/
I I

~
,.,, .. --....
..., ,..

'..,
' \
\
\

I
I ., "' '' \
I I
I
/ ' '\~ \

,;,~::L~·_,-\! -~. . \1
I
I '
I

.
I ' I
J I I I I
I 0 ~ 'Z, 0 I I
----~·- 1....,
I
____ I

I
I 1101 ,
1
' , , .. / I I1 I +-~--"---~ -
I I , ... " ' , I
,
I
I
___...
_._ _, ... _ _.1,_ _ _ _
I
I I
I
'
I

0 I 0 J I I
I
I
I I I I
I I
I I
I I
I I
I '
I I
\ ;
\ /

'' AN 507-8-32RIO '

'
__ \ ___ _,~;N426-A03·3
(12 REQl
17317 ACCESS HOLE_7',
... .,. ____ --
HOLE IN BOTTOM
REINFORCEMENT WING SKIN
PLATE OIAM£TER 4~

1n16 ACCESS HOLE

COVER PLATE
"11\Jl '
-,..,-
'
I 0 ,,~ I
I !
I '"' I

', ,_ ,' : ...

'' 1
I,,,., , I

0
I •• I
I
I

I
~AN426-AOJ-4
: (22 REQJ
I
0

I
AN 507-8-32RI0
o I o o , o o : a :
---: - -- ----- -- - -- -- - - - - -r-- - 6~ - -- - - --- -- --~r- _J

,I i6 I
-----~-------7----------
Figure 2-6a. Typical Access Plates and Panels

01/01/09 II - HANDLING AND SERVICING

1C1
 PIPER AZTEC SERVICE MANUAL

2101

A & B = SHEET2
C & D = SHEET3
E & F = SHEET 4

Figure 2-7. Access Plates and Panels PA-23-235 and PA-23-250 (Sheet 1 of 4)

II - HANDLING AND SERVICING 01/01/09

1C2
 PIPER AZTEC SERVICE MANUAL

SKETCH A 2121

' 4
3
----a----

- -
ID

•
-r- -
II 12 IJ 14 15 16 16 15 14 13 12 II

1. FUEL FILLER I 0. NACELLE f A IR ING

2. FUEL flLLEH 11. WING TIP
3. ENGINE ACCESS, TOP 12. FUEL SENOER AHO CELL
4. 01 L f ILLER 13. fUEL SENOER AHO CELL
5. OIL FILLER 14. NACELLE FAIRING
6. ENGll◄ E ACCESS, OUTBOARD 15. ENGINE SUPPORT
1. PROPELLER 16. ELECTRIC fUEL PUMP, VACUUM REGULATOR
8. ENGINE ACCESS, INBOARO
9, WIRING, CONTROL CABLES, LINE FITTINGS,
WING ATTACHMENTS

2120
SKETCH B
3 4 2

L --

• T
16

13 14 15 17 15 14 13

1.WIHGTIP 10. DEICER LINES

2. FUEL VENT LINE 11. FUEL LINES, FUEL CONTROL CABLES
3. FUEL CELL OUTLET LINE 12. PROPELLER
4. FUEL SELECTOR, FUEL STRAINER 13. FUEL VENT LINE, TIP HINGE
5. WIRING, CONTROL CABLES, LINE FITTINGS, 14. AILERON BELLCRAHK
WING ATTACHMENTS IS. A I LERON CONTROL CABLES
6. INSPECTION 16. PITOT LINE lLEf'T WING ONLY), INSPECTION
7. f'UEL STRAINER 17. ENGINE ACCESS, BOTTOM
8. FUEL STRAINER 18. LANDING GEAR
9. fUEL LINES, FUEL CONTROL CABLES, 19 LANDING GEAR
Al LE RON CAB LES

Figure 2-7. Access Plates and Panels PA-23-235 and PA-23-250 (Sheet 2 of 4)

01/01/09 II - HANDLING AND SERVICING

1C3
 PIPER AZTEC SERVICE MANUAL

2123
SKETCH C 2 3 4

I. TRIM INDICATOR WIRE, ANTENNA CONNECTOR 7. BRAKE RESERVOIR

2. FIN RIB 8. POWERPAK FILLER TUBE
3. STABILATOR TORQUE TUBE 9. CONTROL CABLES ANO PULLEYS
4. ROTATING BEACON 1 O. RUDDER HORN
5. LANDING LIGHT I:. STABILATOR TRIM MECHANISM
6. HEATER, WIRING, MISC. FLUID AND AIR LINES 12. STABILATOR TRIM ROD

2124
I 2 3 4
SKETCH D

GOD

5 & 7 I 9
• 10 II 12 13

I. ROTATING BEACON e. RUDDER TRIM ROD

2. STABILATOR TORQUE TUBE 9. RUDDER TRIM DRUM
3. FIN RIB Io. BAGGAGE AREA
4. TRIM INDICATOR WIRE, ANTENNA CONNECTOR 11. RUDDER PEDALS, CONTROL CABLES,
5. STABILATOR TRIM ROD HYDRAULIC LINES, WIRING
6. STABILATOR TRIM MECHANISM 12. BATTERY
7. RUDDER NORN 13. LANDING LIGHT

Figure 2-7. Access Plates and Panels PA-23-235 and PA-23-250 (Sheet 3 of 4)

II - HANDLING AND SERVICING 01/01/09

1C4
 PIPER AZTEC SERVICE MANUAL

SKETCH E
2 l

-
I

5 6 7

1. LANDING GEAR
2. WING ATTACHMENT
3. FLAP MECHANISM
4. LANDING GEAR
5. CONTROL CABLES, LINE FITTINGS, WIRING, WING ATTACHMENT
6. WING ATTACHMENT
7. FLAP MECHANISM

(\J

~ ----------------------------------------1 SKETCH F
2 l 4 5

I
I T
& 1 • 9 ID 11

1. AILERON PULLEY AND CABLE

2. TRIM SENSOR, ALTIMATIC II
3. INSPECTION
4. FLAP SENDER
5. RUDDER CABLES
6. AILERON PULLEY AND CABLE
7. MAIN SPAR
8. RUDDER CABLE AND PULLEY
9. STABILATOR CABLES AND PULLEYS
10. STABILATOR CABLES AND PULLEYS
11. RUDDER CABLE AND PULLEY

Figure 2-7. Access Plates and Panels PA-23-235 and PA-23-250 (Sheet 4 of 4)

01/01/09 II - HANDLING AND SERVICING

1C5
 PIPER AZTEC SERVICE MANUAL

A & B -- SHEET
SHEET 2
3 (AZTECC
(AZTE ti~D LATER)
C & D = SHEET 4
E & F = SHEETS

Figure 2-8. Access Plates and Panels PA-23-250 (six place) (Sheet 1 of 5)

II - HANDLING AND SERVICING 01/01/09

1C6
 PIPER AZTEC SERVICE MANUAL

SKETCH A 2\05
(AZTEC 8-D)

1 I 9 11 12 13 14 15 16 16 15
f=-
14 13 12 II 10
- --1---!-J

9 I 7

27-2000 TO 27-2504 27-2505 TO27-4425 INCL.AND

_ _l_ _ _ _ _ _ 27-4427 TO 27-4573 INCL.

1. PROPELLER RECHARGE VALVE 11. FUEL SENDER AND CELL

2. PROPELLER 12. NACELLE FAIRING
3. ENGINE ACCESS, OUTBOARD 13. ELECTRIC FUEL PUMP , VACUUM REGULATOR,
4. OIL FILLER AILERON CONTROL CABLES, LANDING GEAR
5. ENGINE ACCESS, INBOARD ACTUATING CYLINDER AND ROLL SERVO
6. ENGINE ACCESS, TOP (LEFT NACELLE ONLY)
7. WING TIP 14. ENGINE SUPPORT
8. FUEL FILLER 15. NACELLE FAIRING
9. FUEL SENDER AND CELL 16. WIRING,CONTROL CABLES, LINE FITTINGS
10. FUEL FILLER AND WING ATTACHMENTS

SKETCH B 2 34557176543 2 2104

(AZTEC 8-D) I
I
I
• I
I
I
I
161
II 12 13 14 13 12 II

27-2000 TO 27-2504 I 27-2505 TO 27-4425 INCL AND

_j_ _ _ _ _ _ 27-4427 TO 27-4573 INCL

1. WING TIP
2. FUEL VENT
3. FUEL CELL OUTLET LINE 11. WING TIP HINGE
4. FUEL SELECTOR, FUEL STRAINER AND 12. AILERON BELLCRANK
FUEL DRAINS 13. AILERON CONTROL CABLES
5. FUEL STRAINER AND FUEL DRAINS 14. PITOT LI NE (LEFT WING ONLY), INSPECTION
6. INSPECTION 15. ENGINE CONTROL CABLES, MISC. LINES
7. WIRING, CONTROL CABLES, LINE FITTINGS 16. DEICER LINES
AND WING ATTACHMENTS 17. ENGINE ACCESS, BOTTOM
8. LANDING GEAR 18. PROPELLER
9. LANDING GEAR 19. PROPELLER RECHARGE VALVE
10. FUEL LINES, FUEL CONTROL CABLES AND 20. LANDING GEAR
AILERON CABLES

Figure 2-8. Access Plates and Panels PA-23-250 (six place) (Sheet 2 of 5)

01/01/09 II - HANDLING AND SERVICING

1C6A
 PIPER AZTEC SERVICE MANUAL

A433
SKETCH A

i
(AZTEC E & UP) 16 • I

15
1° 0
SERIAL NOS. 27-7654001 AND UP
I
I 1. PROPELLER RECHARGE VALVE
2. PROPELLER
3. ENGINE ACCESS, OUTBOARD
4. ENGINE ACCESS, TOP
5. ENGINE ACCESS, INBOARD
6. OIL FILTER
7. NACELLE FAIRING
8. WI RfNG, CONTROL CABLES, LINE
FITTINGS, WING ATTACHMENTS

i_
9. NACELLE FAIRING
10. ELECTRIC FUEL PUMP, VACUUM
REGULATOR, AILERON CONTROL
•
~~
CABLES, LANDING GEAR
ACTUATING CYLINDER, AND ROLL
SERVO (LEFT NACELLE ONLY)
12 13 14 11. ENGINESUPPORT
12. FUEL SENDER AND CELL
13. FUEL FILLER
14. WING TIP
15. FUEL FILLER OR ACCESS COVER
16. FUEL SENDER OR.ACCESS COVER
17. OIL COOLER VENT

27-4426 AND 27-4574 AND UP

SKETCH B
(AZTEC E & UP) 1. WI RING, CONTROL CABLES, LINE
FITTINGS, WING ATTACHMENTS
2. INSPECTION
3. FUEL SELECTOR, FUEL STRAINER,
FUEL DRAINS
4. FUEL VENT
5. WING TIP
6. LANDING GEAR
7. FUEL CELL OUTLET LINE
8. LANDING GEAR
9. LANDING GEAR
10. FUEL STRAINER
11. DEICER LINES
12. FUEL LINES, FUEL CONTROL
CABLES, Al LERON CABLES
13. ENGINE CONTROL CABLES, MISC.
LINES
14. ENGINE
19 20 21 15. ENGINE ACCESS, BOTTOM
16. PROPELLER RECHARGE VALVE
1 7. PROPELLER
18. PITOT LINE (LEFT WING ONLY),
INSPECTION
19. AILERON CONTROL CABLES
20. AILERON BELLCRANK
21. WING TIP HINGE

5 SERIAL NOS. 27-7654001 AND UP

A434

Figure 2-8. Access Plates and Panels PA-23-250 (six place) (Sheet 3 of 5)

II - HANDLING AND SERVICING 01/01/09

1C6B
 PIPER AZTEC SERVICE MANUAL

2 102

SKETCH C 2 3 4 5

I 9 10 II 12

1. OXYGEN FILLER 8. CONTROLCABLESANDPULLEYS

2. TRIM INDICATOR WIRE 9. FLUX SENSOR , SERIAL NOS. 27-7505446,
3. FIN RIB 27-7505456 AND UP
4. STABILATOR TORQUE TUBE 10. RUDDER HORN
5. ROTATING BEACON 11 . STABILATOR TRIM MECHANISM
6. HEATER 12. STABILATOR TRIM ROD
7. BRAKE RESERVOIR AND POWER
PACK FILLER TUBE

2103
I 2
SKETCH D

. _[I__ ·\(
- -- -
·:
)
---------· -
6 19 10 II 17 ll 11

1. ROTATING BEACON 10. BAGGAGE DOOR, SERIAL NOS. 27-2000

2. STABILATOR TORQUE TUBE THAU 27-3050, 27-3052 THAU 27-3153
3. FIN RIB 11. BAGGAGE DOOR, SERIAL NOS. 27-3154 AND UP
4. RUDDER TRIM DRUM 12. RUDDER PEDALS, CONTROL CABLES
5. TRIM INDICATOR WIRE AND HYDRAULIC LINES
6. STABILATOR TRIM ROD 13. BATTERY
7. STABILATOR TRIM MECHANISM 14. BAGGAGE AREA, ELECTRONICS
8. RUDDER TRIM ROD
9. RUDDER HORN

Figure 2-8. Access Plates and Panels PA-23-250 (six place) (Sheet 4 of 5)

01/01/09 II - HANDLING AND SERVICING

1C6C
 PIPER AZTEC SERVICE MANUAL

SKETCH E
2 3 4 5

--J

& 1 I 9 1. LANDING GEAR

2. AILERON PULLEY
3. CONTROL CABLES, LINE FITTINGS,
WIRING AND WING ATTACHMENT
4. WING ATTACHMENT
5. FLAP MECHANISM
6. LANDING GEAR
7. HEATER DUCTS
8. WING ATTACHMENT
9. FLAP MECHANISM

,--------------------------------------- 8
SKETCH F '"
t 2 l 4 12 5

~--:1:-----.r--r--r-1-+--------

& 7 I 9 10 11

1. AILERON PULLEY AND CABLE

2. TRIM SENSOR, ALTIMATIC II
3. INSPECTION
4. FLAP SENDER
5. RUDDER CABLES
6. AILERON PULLEY AND CABLE
7. MAIN SPAR
8. RUDDER CABLE AND PULLEY
9. STABILATOR CABLES AND PULLEYS
10. STABILATOR CABLES AND PULLEYS
11. RUDDER CABLE AND PULLEY
12. STABILATOR TRIM & FLAP INTERCONNECT CABLES & PULLEYS, SERIAL NOS. 27-7654001 AND UP

Figure 2-8. Access Plates and Panels PA-23-250 (six place) (Sheet 5 of 5)

II - HANDLING AND SERVICING 01/01/09

1C6D
 PIPER AZTEC SERVICE MANUAL

THIS PAGE INTENTIONALLY BLANK

01/01/09 II - HANDLING AND SERVICING

1C7